WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte
Atlas Copco Stationary Air Compressors GA 75 VSD, GA 90 VSD Aircooled GA 75 VSD, GA 90 VSD Watercooled
Parts list
•
•
Copyright 2006, Atlas Copco Airpower n.v., Antwerp, Belgium. Any unauthorized use or copying of the contents or any part thereof is prohibited. This applies in particular to trademarks, model denominations, part numbers and drawings. Use only authorized parts. Any damage or malfunction malfunction caused by the use of unauthorized parts is not covered by Warranty or Product Liabili ty.
No. 2930 1431 01 Registration code : APC G 75-90 VSD / 39
Replaces No. 2930 1431 00 2006-07
www.atlascopco.com
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
Contents Inhoud Innehåll Inhaltsverzeichnis Table des matières Indice
Compressor element and drive gear Compressorelement en aandrijving Kompressorelement och drivning Kompressorelement und Antrieb Elément compresseur et entraînement Elemento compresor y accionamiento Elemento compressore e ingranaggi di azionamento Kompressorelement og drivhjul Elemento compressor e accionamento Kompressorelement og drivgir Kompressorielementit ja voimansiirto ............................... Air inlet Luchtinlaat Luftintag Lufteinlaß Admission d’air Entrada de aire Presa d’aria Luftindsug Admissão de ar Luftinnløp Tuloilma.............................................................................. Air receiver Luchtketel Luftbehållare Luftbehälter Réservoir d’air Depósito de aire Serbatoio dell’aria Oliebeholder Reservatório de ar Luftbeholder Ilmasäiliö ............................................................................
Indice Innholdsfortegnelse Índice Indholdsfortegnelse Sisällysluettelo
1
Air flow and cooling system Luchtstroming en koelsysteem Luftflöde och kylsystem Luftstrom und Kühlsystem Flux d’air et circuit de refroidissement Flujo de aire y sistema de refrigeración Flusso d’aria e sistema di raffreddamento Luftflow og kølesystem Fluxo de ar e sistema de arrefecimento Luftstrøm og kjølesystem Ilman virtaus ja jäähdytysjärjestelmä
4 - GA (W) ...... ............ ............ ........... ........... ............ ............ ............ ............ ............ ............ ............ .......... 5 Oil system -
2
3
Oliesysteem Oljesystem Ölsystem Système d’huile Sistema de aceite Sistema dell’olio Oliesystem Sistema de óleo Oljesystem Voitelujärjestelmä ...............................................................
6
Air outlet Luchtuitlaat Luftutlopp Luftauslaß Sortie d’air Salida de aire Mandata dell’aria Luftafgang Saida de ar Luftutløp Paineilmaputki -
2
GA (A) ...... ............ ............ ........... ........... ............ ............ ........... ........... ............ ............ ............ .......... ....
7 Pack - GA (W) ...... ........... ........... ............ ............ ........... ........... ............ ............ ............ .......... .... 8 Full Feature Feature - GA (A) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ... 9 Full Feature Feature - GA (W) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ..... 10 Pack - GA (A) ...... ............ ............ ............ ............ ............ ........... ........... ............ ........... .......... .....
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
Contents Inhoud Innehåll Inhaltsverzeichnis Table des matières Indice
Air dryer Luchtdroger Lufttorkare Lufttrockner Sécheur d’air Secador de aire Essiccatore d’aria Lufttørrer Secador de ar Lufttørker Kuivain ...........................................................................
Indice Innholdsfortegnelse Índice Indholdsfortegnelse Sisällysluettelo
11
Drain system Aftapsysteem Avtappningssystem Ablaßsystem Système de vidange Sistema de drenaje Sistema di scarico Drænsystem Sistema de drenagem de condensados Avtappingssystem Lauhteenpoistojärjestelmä -
12 Pack - GA (W) ...... ............ ........... ........... ............ ........... ........... ............ ........... ........... ........ 13 Full Feature Feature - GA (A) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ....... 14 Full Feature Feature - GA (W) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ..... 15 Pack - GA (A) ...... ............ ........... ........... ............ ............ ........... ........... ............ ........... .........
2930 1431 01
Convertor cubicle Converterkast Omvandlarens skåp Konvertersschrank Armoire du convertisseur Armario de convertidor Quadro del convertitore Regulator elskab Quadro do conversor Omformerskap Invertterikotelo Start cubicle -
16 CSA/UL CSA/ UL ..... ........... ............ ............ ........... ........... ............ ............ ........... ........... ............ ........... ..... 17 IEC ...... ............ ........... ........... ............ ............ ........... ........... ............ ............ ........... ........... ............ ........
Bodywork Carrosserie Karosseri Karosserie Capotage Carrocería Cappottatura Karosseri Carroceria Kabinett Kotelo GA (A/W) (A/W) - Common Common parts parts ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... .......
18
Service kits Service kits Service Kits Service kits Service kits Kit per la manutenzione Service kits Conjuntos de reparação Servicesett Huoltotarvikesarjat .........................................................
19
-
3
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
1
63429_01
4
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
1
Compressor element and drive gear
Ref.
Part number
Qty Name
1 010 1 015 1 030 1 040 1 050 1 060 1 100 1 110 1 120 1 130 2 010
1616 7146 93 0101 1951 40 0147 1365 03 0663 2111 46 0663 2109 78 1619 6032 00 1622 4633 00 0337 2293 23 1622 3668 00 0211 1963 16
1 2 10 1 1 4 1 1 1 1 1
2 020 2 030 2 040 2 050 2 060 2 100 2 110 2 120 2 130 2 510 3 001
1080 4238 51 1080 4238 51 1080 4238 61 1080 4238 61 1622 3666 00 1616 5517 00 1622 3665 00 0335 2178 00 0147 1477 03 1619 6032 00 0508 1100 98 1622 3645 00 1622 3740 00 1088 1001 04 1622 3667 00
2930 1431 01
1 1 1 1 4 2 1 1 1 1 1
Remarks
Service stage Pi n Hexagon bolt O-ring O-ring Nipple Spacer Parallel key Washer Hex sock. screw Motor GA 75 VSD (A/W) 400V/50Hz GA 75 VSD (A/W) 460V/60Hz GA 90 VSD (A/W) 400V/50Hz GA 90 VSD (A/W) 460V/60Hz Gearbox housing Lip seal Bushing Int.circlip Hexagon bolt Nipple(spm) Bearing Key Drain nipple Warning mark Spacer
Ref.
Part number
Qty Name
3 002 3 003 3 005 3 010 3 020 3 030 3 040 3 050 3 060 3 070 3 080 3 090 3 100 3 101 3 102 3 103 3 104 3 110 3 120
1622 3668 00 0211 1963 16 1622 3793 00 1613 6752 19 1613 9598 01 0147 1493 03 0211 1400 03 0301 2358 00 0333 3237 00 1622 3622 00 0147 1400 03 0301 2358 00 0333 3237 00 1613 6752 18 0211 1400 03 0333 3237 00 0301 2358 00 0147 1479 03 0301 2378 00
1 1 1 1 1 1 2 2 2 1 5 5 5 2 4 4 4 2 2
Washer Screw Oil nozzle Antivibr.pad Spacer Hex.bolt Cap screw Washer Lock washer Support Hexagon bolt Washer Lock washer Antivibr.pad Cap screw Lock washer Washer Hexagon bolt Washer
3 170 1622 3698 80
1
Plug assembly
0663 2107 89 1622 3699 00
4 010 1622 3692 41 4 020 1622 3692 42
• • •
1 1 1 1 1
Remarks
O-ring ø20x2 Magnet Plug Gear Gear
5
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
2
63430_02
6
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
2
Air inlet
Ref.
Part number
Qty Name
1 020 1 025 1 030 1 040 1 045 1 050 1 070 1 075 1 080 1 085 1 090 1 095 1 100 1 105 1 110 1 115 1 120 2 005 2 020 2 030 2 040 2 060 2 070 2 080
1622 0795 00 1622 0796 00 1622 9639 00 0211 1964 75 0686 3716 01 0661 1000 38 1613 8907 00 1613 2357 00 1622 0958 00 0661 1000 44 1622 1041 00 0686 3716 07 0661 1000 44 1079 5840 19 0661 1000 39 1622 0977 01 1089 0574 55 1613 7690 00 0663 2107 37 0147 1363 03 0301 2344 00 0347 6120 00 1622 3631 00 0147 1963 08
1 1 1 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 4 4 2 1 2
Valve housing Spring Check valve Cap screw Hexagon plug Seal washer Valve body Compr.spring Nipple Seal washer Piston Hexagon plug Seal washer Nipple Seal washer Gasket Temp.sensor Nipple O-ring Hexagon bolt Washer Hose clip Filter plate Hexagon bolt
1
Air filter
2 100 1613 9502 00
1613 9503 00 2 110 0301 2344 00 2 120 0147 1363 03 2 130 0575 1205 10
2930 1431 01
•
1 2 2 1
Filter element Washer Hexagon bolt Hose
Remarks
Ref.
Part number
Qty Name
2 140 2 150 2 200 2 205 2 210 2 215
1079 5840 03 0661 1000 40 1089 0574 12 0989 4220 15 1622 5683 00 0661 1000 40
1 1 1 1 1 1
Nipple Seal washer Temp.sensor Grommet Nozzle Seal washer
1
Inlet valve assembly
1
Hose assembly
3020 30255 302 30300 303 30355 303 30400 304 30455 304 30500 305 30511 305 30555 305 30655 306 30700 307 4010 40200 402 5 010 5 020 5 030 5 040 5 050 5 060 5 070
1622 07 0759 80
1613 72 1613 7214 14 00 1613 16 13 72 7216 16 00 1613 16 13 72 7217 17 00 1613 16 13 72 7218 18 00 1613 16 13 79 7980 80 00 0147 01 47 12 1247 47 02 1613 16 13 89 8933 33 00 1613 16 13 89 8923 23 00 0500 05 00 45 4510 10 31 1613 16 13 72 7220 20 00
• • • • • • • • • • •
1622 0965 80
1613 79 1613 7912 12 01 1622 3619 00 0663 7138 00 0147 1363 03 0301 2344 00 0663 7138 00 0147 1363 03 0301 2344 00
• •
1 1 1 1 1 1 1 1 1 2 1
1 1 1 1 2 2 1 2 2
Remarks
Valve housing Valve Bushing Bushing Spring Valve spindle Hexagon bolt Washer Bracket Plain bearing Dowel pin
Hose Indicator Pipe O-ring Hexagon bolt Washer O-ring Hexagon bolt Washer
7
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
3
63431_03
8
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
3
Air receiver
Ref.
1 010 2 020 2 030 2 04 040 2 050 2 060 2 080 2 090 2 100 2 110 2 120
2 200 2 205 2 210 2 215 2 230 2 240 2 250 2 260 2 270 2 280 2 290 2 310 2 320 2 330 2 340 2 350 2 360 2 370 2 380
Part number
Qty Name
1
1202 5401 00 1613 7810 00 1622 3657 00 1613 8103 00 1622 3656 00 1622 3659 00 0147 1365 03 0663 7139 00 0663 3120 00 1622 3654 80 1079 5840 18
1622 1622 1622 1622 1622
3658 3658 3658 3658 3658
99 82 85 95 86
30100 16 301 1622 22 36 3658 58 00
2930 1431 01
1 3 3 3 3 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 4 1 4 1
Safety valve 13 bar(e) 175 psig Shield Bushing Oil separator element Oil level gauge Hexagon bolt O-ring O-ring Scavenge line Nipple Seal washer CE/ASME LL/DIR MOL MOM SQL Cover Parallel pin Seal washer O-ring Nipple Retaining ring Non return valve O-ring Spring Piston Spring Piston valve Washer Washer Hexagon bolt Hexagon bolt Hexagon nipple Washer O-ring
1
Vessel
1 1 1 1 4 1 1 1 1
0661 1000 38 0661 1000 38 0661 1000 38 0661 1000 38 0661 1000 38 1622 3661 00 0101 2465 00 0661 1000 40 0663 2101 01 1622 3693 00 0335 3111 00 1613 9005 01 0663 2108 11 1622 3664 00 1622 3663 00 1622 3662 00 1613 3221 00 1613 3223 01 1613 3222 00 0147 1244 03 0147 1249 03 0571 0035 85 0301 2321 00 0663 2113 24
•
Remarks
1
CE/ASME LL/DIR MOL MOM SQL Vessel
Ref.
Part number
3020
1622 3655 00 1622 3655 00 1622 3655 00 1622 3655 00 1622 5087 00 30300 01 303 0147 47 19 1961 61 17 30400 06 304 0663 63 21 2107 07 49 3050 1622 0003 00 1622 0003 01 1622 0003 01 1622 0003 00 1613 9349 00 30600 02 306 0244 44 41 4184 84 00 30700 12 307 1202 02 89 8992 92 00 30800 06 308 0663 63 21 2102 02 15 30900 16 309 1622 22 36 3660 60 00 31000 06 310 0663 63 21 21111 17 17 3110 31 10 06 0686 86 42 4206 06 00 4030 4030 4040 40500 405 40600 406 40700 407 40900 409 4110 41 10 41200 412 41400 414 41500 415 5 010 5 020 5 030 5 040 5 060 5 090 5 100 5 110 5 120 5 130 5 140 5 150
Qty Name •
• • •
• • • • • •
1622 3650 80
0335 03 35 21 2131 31 00 0661 10 0661 1000 00 44 1622 16 22 36 3653 53 00 1622 16 22 46 4614 14 00 0686 06 86 64 6448 48 00 0663 06 63 21 2106 06 16 0147 01 47 13 1325 25 03 0301 03 01 23 2335 35 00 0603 06 03 41 4100 00 42 0392 1100 28 0301 2335 00 0291 1110 00 1613 8967 12 0147 1963 08 1089 0575 43 0147 1322 03 0301 2344 00 0575 1205 11 0603 4100 42 0852 0010 22 0687 3103 00
1
8 2 1
4 1 1 1 1 1 1
• • • • • • • • • •
1 1 1 1 1 1 1 3 3 1 4 4 4 1 1 1 2 2 1 1 1 1
Remarks
Valve housing CE/ASME LL/DIR MOL MOM SQL Hexagon bolt O-ring Dataplate vessel CE/ASME LL/DIR MOL MOM SQL Drive screw Plug O-ring Plug O-ring Hex. plug Oil filter pipe
Circlip Filter pipe Seal washer Bypass valve Cover Plug O-ring 94,5x3 Hexagon bolt Washer Nipple Vibration damper Washer Lock nut Cable Hexagon bolt Dp transducer Hexagon bolt Washer Hose assembly Nipple Ball valve Pipe cap
9
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
4
63432_04
10
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
4
Air flow and cooling system - GA (A)
Ref.
Part number
Qty Name
1 010
1 1622 3646 01 1622 3646 11 1622 3646 11 1622 3646 01 1622 3646 04 1622 3646 11 1622 3646 12 1622 3646 22 1622 3646 31 1622 3646 31 1622 3646 22 1622 3646 31 1622 3646 24 1622 3646 32
1080 4004 71 1080 4004 81 1080 4004 81 1080 4004 71 1080 4004 74 1080 4004 81 1080 4004 82 1080 4024 52 1080 4025 51 1080 4025 51 1080 4024 52 1080 4025 51 1080 4024 54 1080 4025 52 1 025 0147 1963 08 2 010 1622 3625 00 2 020 0147 1963 08
•
4 1 4
2 030 1622 3628 80
1079 9901 18
2930 1431 01
1
2 •
1
Fan ass’y
Remarks
GA 75 VSD 230V/50Hz GA 75 VSD 230V/60Hz GA 75 VSD 380V/60Hz GA 75 VSD 400V/50Hz GA 75 VSD 440V/50Hz GA 75 VSD 440V/60Hz GA 75 VSD 575V/60Hz GA 90 VSD 230V/50Hz GA 90 VSD 230V/60Hz GA 90 VSD 380V/60Hz GA 90 VSD 400V/50Hz GA 90 VSD 440V/60Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Motor GA 75 VSD 230V/50Hz GA 75 VSD 230V/60Hz GA 75 VSD 380V/60Hz GA 75 VSD 400V/50Hz GA 75 VSD 440V/50Hz GA 75 VSD 440V/60Hz GA 75 VSD 575V/60Hz GA 90 VSD 230V/50Hz GA 90 VSD 230V/60Hz GA 90 VSD 380V/60Hz GA 90 VSD 400V/50Hz GA 90 VSD 460V/60Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Hexagon bolt Fan support Hexagon bolt Fan protection 1) Decal
Ref.
Part number
Qty Name
2 040 0147 1963 08 3 010 1622 3780 00 1622 3781 00 3 020 0147 1963 08 3 025 0348 0102 11 3 045 0574 9918 14 3 050 0147 1323 03 3 055 0300 0274 34
4 1 4 6 2 4 4
Hexagon bolt Cooler plate GA 75 VSD GA 90 VSD Hexagon bolt Cable tie Hose assembly Hexagon bolt Washer
3 060
1
Aftercooler
1622 3769 00 1622 3771 00
3 070 3 080 3 090 3 100 3 110 3 120 3 130 3 140 3 150
1622 3797 00 0147 1323 03 0300 0274 34 1622 3787 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1363 03
•
4 030 1622 3768 00 1622 3770 00
2250 4983 00 0661 1000 44 4500 16 4500 1622 22 37 3797 97 00 1)
• • •
1 4 4 1 1 2 2 1 2 2
GA 75 VSD GA 90 VSD Decal Hexagon bolt Washer Pipe O-ring Washer Hexagon bolt O-ring Washer Hexagon bolt
1
Oil cooler
2 2 1
Remarks
GA 75 VSD GA 90 VSD Nipple Seal washer Decal
Line Li nedd wi with th / Bekl Beklee eedd me mett / Be Bekl kläd äddd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650
11
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
5
63433_04
12
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
5
Air flow and cooling system - GA (W)
Ref.
Part number
Qty Name
1 010 1 020 1 030 1 040 1 050 1 060 1 070 1 080 1 085 1 090 1 100 1 110 1 120 1 130 1 140 1 150 1 151 1 152 1 153 1 154 1 155 1 156 1 158 1 160 1 165 1 166 1 170 1 171 1 172 1 173 1 180 1 190 1 200 1 205 1 210
1622 4640 81 0147 1962 72 0301 2335 00 1622 4652 80 1622 4642 00 0147 1962 72 0301 2335 00 1622 4653 80 0574 9918 15 1622 4642 02 0147 1962 72 0301 2335 00 1622 4649 80 0147 1326 03 0301 2335 00 1089 9556 28 0160 6039 00 0661 1000 46 0301 2315 00 0605 8700 24 0261 2106 00 0661 1000 44 2250 4983 00 1622 4646 80 0147 1321 03 0301 2335 00 1622 4645 81 0291 1110 00 0661 1000 38 0686 3716 01 0147 1962 72 0301 2335 00 0663 7138 00 0686 3716 02 0661 1000 39
1 4 4 1 1 2 2 1 2 1 2 2 1 4 4 1 4 1 4 1 8 1 1 1 1 1 1 1 3 3 2 2 1 1 1
2930 1431 01
Remarks
Cooler plate Hexagon bolt Washer Aftercooler Support Hexagon bolt Washer Oilcooler Hose assembly Support Hexagon bolt Washer Duct 1) Hexagon bolt Washer Fan Screw Seal washer Washer Bushing Nut Seal washer Nipple Pipe Hexagon bolt Washer Pipe Lock nut Seal washer Hexagon plug Hexagon bolt Washer O-ring Hexagon plug Seal washer
Ref.
Part number
Qty Name
1 215 1613 9370 83
1 220 1 230 1 240 1 250 1 255 1 257 1 260 1 270 1 300 1 330 1 340 1 360 1 370 1 372 1 374 1 376 1 378 1 380 1 460 1 470 1 480 1 500 1 510 1 520 1 530
0663 6147 00 0663 6136 00 0663 2111 27 0663 7138 00 0147 1475 00 0301 2378 00 1622 4641 80 0147 1364 03 0301 2344 00 0663 7138 00 0147 1476 03 0301 2344 00 1622 4643 80 0663 7138 00 1622 4644 00 0663 7138 00 0661 1000 46 0605 8700 24 0661 1000 44 2250 4983 00 0574 9874 02 1622 4650 80 0147 1962 72 0301 2335 00 1900 0710 41 1622 0661 01 1088 0031 04 1622 0663 03
• • •
1900 2325 01
20055 10 200 1089 89 94 9436 36 46 1)
•
Remarks
1
WSD 250
1
Option Module cubicle
1 1 1 1 4 4 1 2 2 1 2 2 1 2 1 1 1 1 1 1 1 1 4 4 1 1 1 2 1
O-ring 114,5x3 O-ring 59,5x3 O-ring 31,5x3 O-ring Hexagon bolt Washer Pipe Hexagon bolt Washer O-ring Hexagon bolt Washer Pipe O-ring Pipe O-ring Seal washer Bushing Seal washer Nipple Hose assembly Plate Hexagon bolt Washer AIE1 Exp. Module Cable Connector Cable temp.sensor Transformer
Line Li nedd wi with th / Bekl Beklee eedd me mett / Be Bekl kläd äddd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 66(AR) 25 x 2040 x 1650 13
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
6
Oil system
63434_05
Ref.
Part number
1 080 0575 1244 50 1 140 0574 9919 01 2 030 1622 3652 80 1622 4601 80 0663 2113 23 14
Qty Name
1 1 1 •
1
Remarks
Hose assembly Hose assembly Oil filter element 4000 Hrs 8000 Hrs O-ring
Ref.
2 500
Part number
Qty Name
1079 9909 57 1079 9920 76
1 1 1
Label 4000 Hrs 8000 Hrs
1
Thermostat assembly
1622 37 3759 81 81
30100 16 301 1622 22 37 3759 59 01
•
1
Remarks
Plug
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
7
Air outlet - Pack GA (A)
63435_06
Ref.
Part number
Qty Name
1 010 1 020 1 030 1 040 1 050 1 060 2 010 2 030 2 050 2 055
1622 3786 00 0663 7138 00 0301 2344 00 0147 1363 03 0147 1963 08 1089 0575 54 0852 0010 20 0070 6002 05 0581 0000 35
1 1 2 2 2 1 1 AR 2 1
1614 5941 00 2 060 0661 1000 38 2 065 0653 1331 00
2930 1431 01
2 1
Remarks
Pipe O-ring Washer Hexagon bolt Hexagon bolt Pressure transducer Ball valve Tube Coupling Adaptor NPT Seal washer Flat gasket NPT
Ref.
Part number
Qty Name
2 070 3 010 3 021 3 050 3 060 3 070 3 080 3 090
0852 0010 45 1622 3629 80 0147 1963 08 1622 3796 00 1622 3795 00 0160 6040 00 1622 3626 81 0147 1963 08
1 1 6 1 AR 4 1 4
Ball valve Plate ass’y Hexagon bolt Cover Seal Screw Plate Hexagon bolt
Remarks
1)
2)
Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido Rivestido de / Allineato Allineato con / Foret med / Revestido Revestido com / Kledd med / Vuorattu : 1) Foam Fo am:: 039 03955 600 60011 67( 67(AR AR)) 30 30 x 20 2040 40 x 165 16500 2) Foam Fo am:: 039 03955 600 60011 66( 66(AR AR)) 25 25 x 20 2040 40 x 165 16500 15
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
8
Air outlet - Pack GA (W)
Ref.
Part number
Qty Name
1 010 1 020 1 030 1 040 1 050 1 060 2 010 2 030 2 050 2 055
1622 3786 00 0663 7138 00 0301 2344 00 0147 1363 03 0147 1963 08 1089 0575 54 0852 0010 20 0070 6002 05 0581 0000 35
1 1 2 2 2 1 1 AR 2 1
1614 5941 00 2 060 0661 1000 38 2 065 0653 1331 00 16
2 1
Remarks
Pipe O-ring Washer Hexagon bolt Hexagon bolt Pressure transducer Ball valve Tube Coupling Adaptor NPT Seal washer Flat gasket NPT
Ref.
Part number
Qty Name
2 070 3 010 3 021 3 050 3 060 3 070 3 080 3 090
0852 0010 45 1622 3629 80 0147 1963 08 1622 3796 00 1622 3795 00 0160 6040 00 1622 3626 81 0147 1963 08
1 1 6 1 AR 4 1 4
Ball valve Plate ass’y Hexagon bolt Cover Seal Screw Plate Hexagon bolt
Remarks
1)
2)
Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido Rivestido de / Allineato Allineato con / Foret med / Revestido Revestido com / Kledd med / Vuorattu : 1) Foam Fo am:: 039 03955 600 60011 67( 67(AR AR)) 30 30 x 20 2040 40 x 165 16500 2) Foam Fo am:: 039 03955 600 60011 66( 66(AR AR)) 25 25 x 20 2040 40 x 165 16500
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
9
Air outlet - Full Feature - GA (A)
63437_06
Ref.
Part number
Qty Name
1 010 1 020 1 030 1 040 1 050 1 060 1 070 2 010 2 030 2 050 2 055
1622 3785 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1364 03 0852 0010 20 0070 6002 05 0581 0000 35
1 1 2 2 1 2 2 1 AR 2 1
1614 5941 00 2 060 0661 1000 38 2 065 0653 1331 00
2930 1431 01
2 1
Pipe O-ring Washer Hexagon bolt O-ring Washer Hexagon bolt Ball valve Tube Coupling Adaptor NPT Seal washer Flat gasket NPT
Remarks
Ref.
Part number
Qty Name
2 070 3 010 3 040 3 050 3 060 4 010 4 020 4 050 4 060
0852 0010 45 1622 4626 01 0663 2104 98 0147 1364 03 0301 2344 00 0147 1963 08 0160 6040 00 1622 3626 80 0147 1963 08
1 1 1 2 2 6 4 1 4
1)
Line Li nedd wi with th / Bekl Beklee eedd me mett / Be Bekl kläd äddd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 66(AR) 25 x 2040 x 1650
Ball valve Outlet pipe O-ring Hexagon bolt Washer Hexagon bolt Screw Plate Hexagon bolt
Remarks
1)
17
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
10
63438_06
18
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
10
Air outlet - Full Feature - GA (W)
Ref.
Part number
Qty Name
1 010 1 020 1 030 1 040 1 050 1 060 1 070 2 010 2 030 2 050 2 055
1622 3785 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1364 03 0852 0010 20 0070 6002 05 0581 0000 35
1 1 2 2 1 2 2 1 AR 2 1
1614 5941 00 2 060 0661 1000 38 2 065 0653 1331 00
2930 1431 01
2 1
Pipe O-ring Washer Hexagon bolt O-ring Washer Hexagon bolt Ball valve Tube Coupling Adaptor NPT Seal washer Flat gasket NPT
Remarks
Ref.
Part number
Qty Name
2 070 3 010 3 040 3 050 3 060 4 010 4 020 4 050 4 060
0852 0010 45 1622 4626 01 0663 2104 98 0147 1364 03 0301 2344 00 0147 1963 08 0160 6040 00 1622 3626 80 0147 1963 08
1 1 1 2 2 6 4 1 4
1)
Linedd wit Line withh / Bek Bekle leed ed me mett / Bek Beklä lädd dd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 66(AR) 25 x 2040 x 1650
Ball valve Outlet pipe O-ring Hexagon bolt Washer Hexagon bolt Screw Plate Hexagon bolt
Remarks
1)
19
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
11
63439_17
Ref.
Part number 8092 2651 42 8092 2651 59 8092 2651 83 8092 2652 17 8092 2651 75 8092 2651 59 8092 2651 83 8092 2652 17
20
Qty Name
Remarks
GA 75 VSD -ID 245 400V/ 50Hz IEC GA 75 VSD -ID 245 460V/ 60Hz CSA/UL GA 75 VSD -ID 285 500V/ 50Hz IEC GA 75 VSD -ID 285 575V/ 60Hz CSA/UL GA 90 VSD -ID 285 400V/ 50Hz IEC GA 90 VSD -ID 285 460V/ 60Hz CSA/UL GA 90 VSD -ID 285 500V/ 50Hz IEC GA 90 VSD -ID 285 575V/ 60Hz CSA/UL
Ref.
Part number
1010 101 0 16 1624 24 23 2306 06 80
1088 0803 08 0348 0102 11 0348 0111 06 1020 16 1020 1624 24 23 2307 07 00 10300 16 103 1624 24 23 2308 08 00 1060 106 0 16 1624 24 23 2310 10 80
1624 2312 00 0147 1325 03 1080 108 0 16 1624 24 23 2309 09 80
1090 1090 11000 110 1110 11 10 11200 112
0129 32 0129 3270 70 40 0147 01 47 12 1247 47 03 0333 03 33 32 3220 20 00 0300 03 00 02 0274 74 64
Qty Name 1
•
1 1 4 1 1 1
Frame assy
•
1
Plate assy
••
1 1 2
•
1
Support assy
• •• •• •• •• •
•• ••
•• • • • •
1 5 4 4 4
Remarks
Frame Grommet Cable tie Connector Support Support Plate Bracket Screw
Support Blind rivet Hex.bolt Ser.washer Washer
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
11
Air dryer Ref.
Part number
1130 1130 11400 114 11600 116 11700 117 15000 150 21200 212 21500 215 21511 215
0147 13 0147 1323 23 03 0300 03 00 02 0276 76 47 01111 168 01 16866 12 12 1079 10 79 22 2263 63 02 1624 16 24 23 2314 14 00 1624 16 24 24 2451 51 00 1617 16 17 03 0315 15 00 1617 16 17 00 0092 92 03
3001 3002
Qty Name
•
4 4 8 2 2 2 1 1
Hex.bolt Washer Plug Tapping screw Plate Insulation Ring Ring
•
1
Heat exchanger
• • • • • • •
1624 2275 80 1624 2276 80
1624 2414 00 1624 2415 00 30155 05 301 0581 81 00 0000 00 71 30500 06 305 0661 61 10 1000 00 39 3350 1624 2390 02 1624 2390 01 34800 10 348 1089 89 05 0575 75 54 40055 16 400 1624 24 26 2668 68 00 4010 1624 2674 00 1624 2672 00 40155 16 401 1624 24 26 2670 70 00 4020 1624 2671 00 1624 2671 00 4025 1624 2673 00 1624 2669 00 50100 16 501 1617 17 12 1269 69 00 50122 10 501 1079 79 99 9903 03 48 50300 03 503 0346 46 10 1000 00 41 50500 10 505 1079 79 22 2263 63 01 50700 03 507 0346 46 10 1000 00 37 50900 01 509 0147 47 12 1247 47 03 51000 03 510 0301 01 23 2327 27 00 51200 03 512 0333 33 32 3220 20 00 5130 1624 2291 00 1624 2292 00 51400 01 514 0147 47 12 1247 47 03 51500 03 515 0333 33 32 3220 20 00 51622 03 516 0348 48 01 0101 01 13 51700 03 517 0300 00 02 0274 74 64 51900 16 519 1624 24 22 2293 93 00 52500 03 525 0348 48 01 0110 10 03 52600 02 526 0226 26 33 3343 43 07 53000 03 530 0348 48 01 0101 01 13 53200 16 532 1617 17 24 2428 28 00 53300 06 533 0697 97 98 9809 09 10 53600 03 536 0301 01 23 2335 35 00 53700 03 537 0333 33 32 3227 27 00 54011 03 540 0395 95 60 6005 05 96 6100 1619 5563 02 1617 0314 00 1617 0107 00 1617 1524 04 1617 0207 00 1617 2750 00 6110 1617 0092 01 1617 0674 00
2930 1431 01
Remarks
•• ••
• • •
• • •
• •
•
• • • • • • • • •
• • • • • • • • • • • • • • •• •• •• •• •• •• •• •• •• •• •• •• • •• ••
ID 245 ID 285 1 Heat exchanger 1 Label ID 245 ID 285 1 Pipe coupling 1 Seal washer 1 Label ID 245 ID 285 1 Pressure transducer 1 Insulation 1 Insulation ID 245 ID 285 1 Insulation Insulation 1 ID 245 2 ID 285 1 Insulation ID 245 ID 285 AR Freon gas 1 Label 2 Pipe clamp 2 Screw 1 Pipe clamp 1 Hex.bolt 1 Washer 1 Ser.washer 1 Condenser ID 245 ID 285 6 Hex.bolt 6 Ser.washer 2 Cable tie 6 Washer 1 Filter dryer 1 Anchor 1 Tapping screw 1 Cable tie 1 Liquid separator 1 Locknut 1 Washer 1 Ser.washer 1 Foam 1 Pipe assy 1 Schrädervalve 1 Nut 1 Sleeve 1 HGB valve 1 Insulation 1 Non return valve 1 Pipe assy 1 Nut 1 Sleeve
Ref.
Part number
1624 2297 09 6120 1624 6120 1624 23 2383 83 00 6140 1617 0477 00 1617 0476 00 70100 16 701 1624 24 23 2386 86 00 70200 16 702 1617 17 23 2361 61 00 7030 1617 2499 11 1617 2499 12 1617 2499 10 1617 2499 10 7040 704 0 16 1617 17 25 2501 01 80
1617 1808 03 71600 16 716 1624 24 24 2453 53 00 8010 1624 2296 02 1624 2295 08 1614 7168 20 1614 7168 19 8020 0147 1331 03 0147 1331 03 0147 1331 03 1619 5337 03 80300 03 803 0300 00 80 8019 19 00 80400 03 804 0333 33 32 3214 14 00 80500 03 805 0301 01 23 2315 15 00 80600 10 806 1088 88 10 1001 01 01 8070 1617 1617 1617 1617
8080 8080 80900 809 81000 810 8110 81 10 81233 812 81700 817 81800 818 82000 820 82500 825 82600 826 82700 827 82800 828
2057 2581 2582 2582
Qty Name
•
1 1 1 1 1 1 1 1
Tem empe pera ratu ture re Ex Expa pant ntio ionn Val alve ve Pipe Pipe assy Sleeve Nut Insulation Insulation Insulation 400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz
•
1
Insulation assy
•• • • •• •• • •
•
4 4 4 3 4 1 1 3
Insulation pl plate Insulation Insulation Refr.compressor 400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz Hexagon bolt 400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz Washer Ser.washer Washer Warning mark
•
1
Fan assy
••
1
•• •• • •
•
• • •
9030
•
1 1 4 4 4 10 2 1 1 3 1 2 2
•
1
Cran ankc kca ase heat ateer assemb mbly ly
•• • • • • • • • • • • •
••
1 1 1 2
ID 245 ID 285 Crankcase heater Connector plug Clamp Pin contact
•
1
Wiring
••
1
1624 2313 80 1624 2365 80
1088 0015 02 1624 2389 00 1088 0015 14 9200 1624 1624 1624 1624
2360 2362 2362 2362
•• •• ••
80 80 80 80
1624 2361 00
1 1 1 1
400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz Fan+motor 400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz Grating Rotation arrow Hex.bolt Ser.washer Washer Cable tie Tapping screw Sensor Fan switch Screw HP sensor Ser.washer Washer
80 80 80 80
1617 2057 00 1617 2581 00 1617 2582 00 1617 2582 00 1617 2059 00 1503 15 03 07 0786 86 00 0147 01 47 13 1326 26 03 0333 03 33 32 3227 27 00 0300 03 00 80 8019 19 00 0348 03 48 01 0101 01 13 0226 02 26 33 3343 43 07 1617 16 17 30 3077 77 85 1089 10 89 91 9139 39 04 1619 16 19 53 5337 37 03 1619 16 19 57 5703 03 00 0333 03 33 32 3214 14 00 0301 03 01 23 2315 15 00
Remarks
400V/50HZ 460V/60HZ 500V/50Hz 575V/60Hz Plate 21
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
12
Drain System - Pack - GA (A)
63440_06
Ref.
Part number
Qty Name
1 010 1 050 1 060 1 100 1 110 1 120
1622 3798 81 0147 1963 08 0581 0000 87 0581 0000 35 0661 1000 38 0070 6002 03
1 2 2 3 3 AR
22
Drain assembly Hexagon bolt Pipe coupling Coupling Seal washer Plastic tube
Remarks
Ref.
Part number
Qty Name
1 130 1 140 1 150 1 160 1 170
0070 6002 13 0581 0000 71 0661 1000 39 0581 0000 73 1079 9926 02
AR 1 2 2 1
Remarks
Plastic tube Pipe coupling Seal washer Pipe coupling Label
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
13
Drain System - Pack - GA (W)
63441_06
Ref.
Part number
Qty Name
1 010 1 015 1 020 1 030 1 060 1 100
1622 3798 81 0147 1963 08 0661 1000 39 0581 0000 71 1613 8084 00 0581 0000 35
1 2 2 1 1 3
2930 1431 01
Drain assembly Hexagon bolt Seal washer Coupling Pipe coupling Coupling
Remarks
Ref.
Part number
Qty Name
1 110 1 120 1 130 1 160 1 170 1 180
0661 1000 38 0070 6002 03 0070 6002 13 0581 0000 73 0581 0000 87 1079 9926 02
3 AR AR 2 2 1
Remarks
Seal washer Plastic tube Plastic tube Pipe coupling Pipe coupling Label
23
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
14
Drain System - Full Feature - GA (A)
63442_06
Ref.
Part number
Qty Name
1 010 1 050 1 060 1 100 1 110
1622 3798 81 0147 1963 08 0581 0000 87 0581 0000 35 0661 1000 38
2 4 2 6 6
24
Drain assembly Hexagon bolt Pipe coupling Coupling Seal washer
Remarks
Ref.
Part number
Qty Name
1 120 1 130 1 140 1 150 1 160 1 170
0070 6002 03 0070 6002 13 0581 0000 71 0661 1000 39 0581 0000 73 1079 9926 02
AR AR 4 5 2 1
Remarks
Plastic tube Plastic tube Pipe coupling Seal washer Pipe coupling Label
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
15
Drain System - Full Feature - GA (W)
63443_06
Ref.
Part number
Qty Name
1 010 1 015 1 020 1 030 1 060 1 100
1622 3798 81 0147 1963 08 0661 1000 39 0581 0000 71 1613 8084 00 0581 0000 35
2 4 6 2 1 5
2930 1431 01
Drain assembly Hexagon bolt Seal washer Coupling Pipe coupling Coupling
Remarks
Ref.
Part number
Qty Name
1 110 1 12 120 1 13 130 1 150 1 160 1 170 1 180
0661 1000 38 0070 6002 03 0070 6002 13 0581 0001 45 0581 0000 73 0581 0000 87 1079 9926 02
8 AR AR 1 2 2 1
Remarks
Seal washer Plastic tube Plastic tube Pipe coupling Pipe coupling Pipe coupling Label 25
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
16
63444_12
Ref.
Part number
1 020 0147 1963 08 1 040 1089 0580 03 1 050 1088 1001 01 1900 1900 1900 1900 1900
26
2515 2515 2515 2515 2515
01 01 02 02 21
Qty Name
8 1 1
Hexagon bolt Solenoid valve Warning mark
1
Cubicle
Remarks
GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz
Ref.
2015
Part number
Qty Name
1900 2515 21 1900 2515 22 1900 2515 22
1622 3697 50 1622 3697 50 1622 3697 00 1622 3697 00
•
1
Remarks
GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Wire harness 380V/50Hz 460V/50Hz 500V/50Hz 575V/60Hz
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
16
Convertor cubicle - IEC Ref.
2020
2030 2030 20355 203 20455 204 20500 205 2051 2055 2055 20600 206 20655 206 20700 207 20755 207 20800 208 20855 208 20900 209 20955 209 21000 210 21055 210 2110 21 10 2115 21 15 21200 212 21255 212 21300 213 2135
2140
Part number
9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 06 9820 3138 06 1079 10 79 99 9901 01 61 1079 10 79 99 9925 25 69 1079 10 79 99 99111 01 01 1079 10 79 99 9924 24 26 1079 9925 48 1079 9925 48 1088 10 88 00 0037 37 30 1088 10 88 00 0037 37 31 1088 10 88 00 0037 37 33 1088 10 88 00 0037 37 34 1088 10 88 00 0031 31 13 1088 10 88 00 0031 31 18 1088 10 88 00 0031 31 29 1088 10 88 00 0031 31 49 1088 10 88 00 0037 37 66 1088 10 88 00 0031 31 86 1088 10 88 00 0031 31 87 1088 10 88 00 0037 37 06 1088 10 88 00 0037 37 07 1089 10 89 03 0362 62 50 1089 10 89 03 0362 62 51 1089 10 89 03 0362 62 58 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30
1089 0506 52 1089 0506 52 1089 0506 52 1089 0506 52 1089 0506 52 21455 10 214 1089 89 05 0506 06 75 21500 10 215 1089 89 06 0612 12 01 21555 10 215 1089 89 91 9168 68 26 2160 1089 9338 42 1089 9338 37 2165 1089 9339 47 1089 9339 47 1089 9339 48 1089 9339 48 1089 9339 48 1089 9339 48 1089 9339 47 1089 9339 47 2167 1089 9342 47 1089 9342 17 21700 10 217 1089 89 93 9345 45 02 2175 1089 9415 14
2930 1431 01
Qty Name •
• • • • •
• • • • • • • • • • • • • • • • •
•
• • • •
•
•
• •
1
1 1 1 1 1 2 1 1 1 1 4 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 2 1 1 1 1 2 2 1 1
1 2 1
Remarks
Service diagram GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Decal Label Label Label Label 500V/50Hz 575V/60Hz Connector Connector Connector Connector Connector Adaptor Connector Connector Connector Connector Connector Connector Connector Contact block Push button Contact block End bracket GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD Terminal switch GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD Terminal Fuse holder Fuse link Freq. Converter GA 75 VSD GA 90 VSD Line filter GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Inductor GA 75 VSD GA 90 VSD Hf-screen Contactor 380V/50Hz
Ref.
2180
Part number
Qty Name
1089 9415 14 1089 9415 24 1089 9415 24
460V/50Hz 500V/50Hz 575V/60Hz 1 Contactor GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz 1 Aux.contact block 1 Circuit breaker GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz 1 Connection block 1 Transformer 1 Label 1 Data plate 1 Control panel 1 Support 1 Cubicle VSD 1) 1 Cubicle 1 Decal AR Seal 2 Bolt 2 Lock washer 2 Bolt 2 Nut 2 Lock washer 1 Regulator 4 Hexagon bolt 4 Washer
1089 9415 81 1089 9415 81 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 21855 10 218 1089 89 94 9416 16 01 2190 1089 9416 67 1089 9416 67 1089 9416 66 1089 9416 66 1089 9416 68 1089 9416 68 1089 9416 68 1089 9416 68 21955 10 219 1089 89 94 9416 16 75 22000 10 220 1089 89 94 9436 36 45 22055 16 220 1613 13 34 3431 31 00 22100 16 221 1614 14 89 8949 49 23 22155 29 221 2908 08 00 0094 94 00 22200 16 222 1622 22 02 0239 39 00 3010 30200 302 30400 304 30800 308 30900 309 31000 310 3110 31 10 31200 312 40100 401 40200 402 40300 403 5000 5000 50055 500 50100 501 50155 501 50200 502 50255 502 50300 503 50355 503 50400 504 50455 504 50500 505 50600 506 50655 506 50700 507 50755 507 50800 508 50855 508 50900 509 55000 550 1)
1622 3601 80
1622 37 1622 3783 83 00 1202 12 02 65 6584 84 01 0160 01 60 09 0996 96 83 0333 03 33 31 3120 20 00 0147 01 47 13 1325 25 03 0266 02 66 21 2110 10 00 0333 03 33 31 3127 27 00 1900 19 00 07 0710 10 12 0147 01 47 116 1699 03 03 0301 03 01 23 2315 15 00
•
• •
• • • • • • • •• •• •• •• •• •• •• •• • • •
1900 2600 68
0090 14 0090 1400 00 02 1088 10 88 00 0029 29 17 1088 10 88 00 0029 29 58 1088 10 88 00 0029 29 63 1088 10 88 00 0029 29 82 1088 10 88 00 0029 29 86 1088 10 88 00 0029 29 88 1088 10 88 00 0037 37 62 1088 10 88 00 0037 37 63 1088 10 88 00 0037 37 65 1088 10 88 00 0036 36 12 1089 10 89 05 0506 06 30 1089 10 89 06 0612 12 01 1089 10 89 06 0612 12 24 1089 10 89 06 0612 12 28 1089 10 89 94 9415 15 14 1089 10 89 94 9415 15 24 0694 06 94 52 5285 85 26 9820 98 20 35 3549 49 02
1 • • • • • • • • • • • • • • • • • • •
AR 1 6 8 1 3 2 1 1 1 1 2 6 3 3 1 1 3 1
Remarks
Dryer rail
Rail Housing fo for co connector Crimp contact Crimp contact Crimp terminal Crimp contact Crimp terminal Connector Connector Connector Frame for connection End bracket Fuse holder Fuse Fuse Contactor Contactor Faston Dryer se service di diagram
Line Li nedd wi with th / Bekl Beklee eedd me mett / Be Bekl kläd äddd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 64(AR) 20 x 2040 x 1650 27
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
17
63445_12
Ref.
Part number
1 020 0147 1963 08 1 040 1089 0580 03 1 050 1088 1001 01 1900 1900 1900 1900
28
2515 2515 2515 2515
01 01 02 02
Qty Name
8 1 1
Hexagon bolt Solenoid valve Warning mark
1
Cubicle
Remarks
GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz
Ref.
2015
Part number 1900 1900 1900 1900
2515 2515 2515 2515
Qty Name
21 21 22 22
1622 3697 50 1622 3697 50 1622 3697 00 1622 3697 00
•
1
Remarks
GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Wire harness 380V/50Hz 460V/50Hz 500V/50Hz 575V/60Hz
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
17
Convertor cubicle - CSA/UL Ref.
2020
2030 2030 20355 203 20455 204 20500 205 2051 2055 2055 20600 206 20655 206 20700 207 20755 207 20800 208 20855 208 20900 209 20955 209 21000 210 21055 210 2110 21 10 2115 21 15 21200 212 21255 212 21300 213 2135
2140
Part number
9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 01 9820 3138 06 9820 3138 06 1079 10 79 99 9901 01 61 1079 10 79 99 9925 25 69 1079 10 79 99 99111 01 01 1079 10 79 99 9924 24 26 1079 9925 48 1079 9925 48 1088 10 88 00 0037 37 30 1088 10 88 00 0037 37 31 1088 10 88 00 0037 37 33 1088 10 88 00 0037 37 34 1088 10 88 00 0031 31 13 1088 10 88 00 0031 31 18 1088 10 88 00 0031 31 29 1088 10 88 00 0031 31 49 1088 10 88 00 0037 37 66 1088 10 88 00 0031 31 86 1088 10 88 00 0031 31 87 1088 10 88 00 0037 37 06 1088 10 88 00 0037 37 07 1089 10 89 03 0362 62 50 1089 10 89 03 0362 62 51 1089 10 89 03 0362 62 58 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30
1089 0506 52 1089 0506 52 1089 0506 52 1089 0506 52 1089 0506 52 21455 10 214 1089 89 05 0506 06 75 21500 10 215 1089 89 06 0612 12 01 21555 10 215 1089 89 91 9168 68 26 2160 1089 9338 42 1089 9338 37 2165 1089 9339 47 1089 9339 47 1089 9339 48 1089 9339 48 1089 9339 48 1089 9339 48 1089 9339 47 1089 9339 47 2167 1089 9342 47 1089 9342 17 21700 10 217 1089 89 93 9345 45 02 2175 1089 9415 14 1089 9415 14 2930 1431 01
Qty Name •
• • • • •
• • • • • • • • • • • • • • • • •
•
• • • •
•
•
• •
1
1 1 1 1 1 2 1 1 1 1 4 1 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 2 1 1 1 1 2 2 1 1
1 2 1
Remarks
Service diagram GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Decal Label Label Label Label 500V/50Hz 575V/60Hz Connector Connector Connector Connector Connector Adaptor Connector Connector Connector Connector Connector Connector Connector Contact block Push button Contact block End bracket GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD Terminal switch GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD Terminal Fuse holder Fuse link Freq. Converter GA 75 VSD GA 90 VSD Line filter GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz Inductor GA 75 VSD GA 90 VSD Hf-screen Contactor 380V/50Hz 460V/50Hz
Ref.
2180
Part number
Qty Name
1089 9415 24 1089 9415 24
500V/50Hz 575V/60Hz 1 Contactor GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz 1 Aux.contact block 1 Circuit breaker GA 75 VSD 380V/50Hz GA 75 VSD 460V/50Hz GA 75 VSD 500V/50Hz GA 75 VSD 575V/60Hz GA 90 VSD 380V/50Hz GA 90 VSD 460V/50Hz GA 90 VSD 500V/50Hz GA 90 VSD 575V/60Hz 1 Connection block 1 Transformer 1 Label 1 Data plate 1 Control panel 1 Support 1 Cubicle VSD 1) 1 Cubicle 1 Decal AR Seal 2 Bolt 2 Lock washer 2 Bolt 2 Nut 2 Lock washer 1 Regulator 4 Hexagon bolt 4 Washer
1089 9415 81 1089 9415 81 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 1089 9415 82 21855 10 218 1089 89 94 9416 16 01 2190 1089 9416 67 1089 9416 67 1089 9416 66 1089 9416 66 1089 9416 68 1089 9416 68 1089 9416 68 1089 9416 68 21955 10 219 1089 89 94 9416 16 75 22000 10 220 1089 89 94 9436 36 45 22055 16 220 1613 13 34 3431 31 00 22100 16 221 1614 14 89 8949 49 23 22155 29 221 2908 08 00 0094 94 00 22200 16 222 1622 22 02 0239 39 00 3010 30200 302 30400 304 30800 308 30900 309 31000 310 3110 31 10 31200 312 40100 401 40200 402 40300 403 5000 5000 50100 501 50155 501 50200 502 50255 502 50300 503 50355 503 50400 504 50455 504 50500 505 50555 505 50600 506 50655 506 50700 507 50755 507 50800 508 50855 508 50900 509 50955 509 55000 550 1)
1622 3601 80
1622 37 1622 3783 83 00 1202 12 02 65 6584 84 01 0160 01 60 09 0996 96 83 0333 03 33 31 3120 20 00 0147 01 47 13 1325 25 03 0266 02 66 21 2110 10 00 0333 03 33 31 3127 27 00 1900 19 00 07 0710 10 12 0147 01 47 116 1699 03 03 0301 03 01 23 2315 15 00
•
• •
• • • • • • • •• •• •• •• •• •• •• •• • • •
1900 2600 69
0090 14 0090 1400 00 02 1079 10 79 99 9924 24 96 1088 10 88 00 0029 29 17 1088 10 88 00 0029 29 58 1088 10 88 00 0029 29 63 1088 10 88 00 0029 29 82 1088 10 88 00 0029 29 86 1088 10 88 00 0029 29 88 1088 10 88 00 0037 37 62 1088 10 88 00 0037 37 63 1088 10 88 00 0037 37 65 1088 10 88 00 0036 36 12 1089 10 89 05 0506 06 30 1089 10 89 06 0612 12 01 1089 10 89 91 9168 68 02 1089 10 89 91 9168 68 62 1089 10 89 94 9415 15 14 1089 10 89 94 9415 15 25 0694 06 94 52 5285 85 26 9820 98 20 35 3549 49 02
1 • • • • • • • • • • • • • • • • • • • •
AR 1 1 6 8 1 3 2 1 1 1 1 2 6 3 3 1 1 3 1
Remarks
Dryer rail
Rail Label fuse values Housing fo for co connector Crimp contact Crimp contact Crimp terminal Crimp contact Crimp terminal Connector Connector Connector Frame for connector End bracket Fuse holder Fuse link Fuse link Contactor Contactor Faston Dryer se service di diagram
Line Li nedd wi with th / Bekl Beklee eedd me mett / Be Bekl kläd äddd me medd / Au Ausg sgek ekle leid idet et mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 64(AR) 20 x 2040 x 1650
29
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
18
63446_10
30
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
18
Bodywork - GA (A/W) - Common parts
Ref.
Part number
Qty Name
Remarks
Ref.
1 010 1 020 1 030 1 040 1 045 1 046
1622 5577 80 0147 1963 08 1622 5578 80 0147 1963 08 1622 5676 80 0147 1963 08
2 4 1 2 1 2
1)
1 380 1622 5531 80
1 050 1622 3637 80
1
Door assemby 2)
1
Door assembly 2)
1
Door assembly 2)
1
Door assembly 2)
1622 3633 80 0690 1132 01
• •
1 060 1622 3636 80
1622 3633 80
•
1 065 1622 3636 81
1622 3633 80
•
1 070 1622 3638 80
1 100 1 110 1 114 1 115
1622 3633 80 0690 1132 01 1622 3616 00 0147 1963 08 0226 3343 59 1622 6605 00
• •
1 120 1622 3617 80
1 121 1 122 1 123 1 124 1 125 1 126 1 280 1 290 1 291 1 292 1 300 1 310 1 360 1 370
1613 9846 01 0301 2335 00 0291 1110 00 0147 1247 03 0333 3220 00 0147 1247 03 0333 3220 00 1622 3615 80 0147 1963 08 0147 1963 08 0147 1963 08 1622 3782 00 0147 1963 08 1622 0533 81 0211 1249 03
2930 1431 01
1 1 1 1
1 1 1 4 2 1 1
•
1 1 1 1 1 1 1 1 2 4 2 1 4 1 4
Beam Hexagon bolt Beam Hexagon bolt Beam Hexagon bolt
2) 2)
Lock Decal Lock Lock
Lock Decal Panel inlet Hexagon bolt Tapping screw Drain plate
Panel
Decal Washer Lock nut Hexagon bolt Washer Hexagon bolt Washer Roof assembly 2) Hexagon bolt Hexagon bolt Hexagon bolt Z-plate Hexagon bolt Baffle 3) Cap screw
Part number
1622 3633 81
2020 20600 206 20700 207 3 010 3 020 3 030 3 040 3 045 3 050 3 060 3 070 3 090 3 100 3 200
Qty Name
•
1622 3600 80
1079 99 1079 9922 22 39 1079 10 79 99 9903 03 48 1622 3618 00 0301 2335 00 0291 1110 00 1621 0606 00 1621 0607 00 0211 1249 03 0333 3220 00 1622 5500 00 0147 1963 08 0301 2335 00 1622 3639 20
• • •
3 210 1622 3784 80
1049 9903 87 3 220 0147 1964 06 4 010 1622 4631 07 1622 4631 08 1622 4631 09 1622 4631 10 4 020 1079 9922 37 4 030 1079 9905 38 1-3)
• •
Remarks
1
Door cubicle assembly
1
Frame assembly
1
Screen assembly
2
1 2 4 1 1 1 4 4 8 8 1 4 4 1 1 1 4 1
1 1
Lock
Frame Warning label Warning label Panel Washer Lock nut Hinge Hinge Cap screw Washer Cover Hexagon bolt Washer Filter element
Screen Decal Hexagon bolt Label GA75 VSD GA75 FF VSD GA90 VSD GA90 FF VSD Label Decal
Linedd with Line with / Bekle Bekleed ed met / Beklä Beklädd dd med / Ausg Ausgekle ekleidet idet mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : 1) Foam: 0395 6001 66(AR) 25 x 2040 x 1650 2) Foam: 0395 6001 67(AR) 30 x 2040 x 1650 3) Foam: 0395 6001 69(AR) 50 x 2040 x 1650
31
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte Parts list
19 Ref.
Service kits
Part number
Qty Name
2901 0245 01
1
2901 0522 00
1
2901 0045 01
1
2901 14 1453 00 00
0663 7139 00 1613 3223 01 1622 3662 00 0663 2101 01 1622 3664 00 0335 3111 00 0633 3120 00
1
• • • • • • •
2901 14 1460 00 00
0663 2109 78 0337 2293 23 0663 2111 46 1622 0977 00 0663 2107 37
1 1 1 1 1 1 1
1
• • • • •
1 1 1 1 1
Remarks
Oil can
ROTO-INJECTFLUID 5 l
Ref.
Part number 2901 1452 00
ROTO-INJECTFLUID 20 l
1622 3654 80 0663 2108 11 1613 9005 01 0661 1000 38
Oil barrel
2901 1454 00
Oil can
ROTO-INJECTFLUID 5 l
Qty Name
1622 3759 80 0663 7137 00
1 • • • •
• •
1622 0977 00 0661 1000 44 0661 1000 44 0661 1000 38 0661 1000 39 1622 0796 00 1622 9639 00 0663 7138 00 1613 2357 00 1613 8907 00
1
• • • • • • • • • •
2901 1462 00
0335 2178 00 0508 1100 98 1616 5517 00 1622 3665 00 1622 3740 00 0663 2107 89 0502 1092 55
1
• • • • • • •
2901 1463 00
1622 3686 00 1622 3694 80 1622 3690 00 1622 3689 00 1622 3691 00 0663 7154 00 1622 3182 00 1622 3183 00 1622 3184 00 1622 3185 00 0301 2318 00 0160 0996 86 0663 2111 55 0663 2107 37 0211 1957 79 0661 1000 40 32
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
• • • • • • • • • • • • • • • •
1 1 1 1 1 1 1 1 1 1 2 2 1 1 2 1
Scavenge line kit
1 1 1 1
Scavenge line O-ring Non return valve Seal washer
1
Thermostat kit 40°C
1 1
Thermostat ass’y O-ring
Minimum Pressure Valve kit
O-ring washer spring O-ring spring circlip O-ring
2901 1464 00
1622 3759 81 0663 7137 00
1 • •
2901 1455 00
1622 3759 82 0663 7137 00
• •
Thermostat kit 60°C
1 1
Thermostat ass’y O-ring
1
Tropical thermostat kit (75°C)
1 1
Thermostat ass’y O-ring
Element mounting kit
O-ring Parallel key O-ring gasket O-ring
2901 05 0566 12 12
1613 9503 00 1622 3652 80 0663 2106 16
1 • • •
2901 10 1096 00 2901 1084 00
Remarks
Check and Oil stop valve kit
Gasket Seal washer Seal washer Seal washer Seal washer Spring Check valve O-ring Spring Valve body
1622 4601 80 0663 2106 16 1613 9503 00
• • •
2901 0566 22
1622 3656 00 0663 2111 16
•
2901 14 1465 00
1622 3798 81 9820 9583 00
1 1 1
Air filter element Oil filter element O-ring
1
Air/ Oil long life filter kit (8000 Hrs)
1 1 2 1
•
1 2
1 • •
Unloader
Valve Blow off valve Bushing Guidance tape Quadring O-ring Guide Seal Bushing Spring Washer Screw O-ring O-ring Screw Seal washer
2901 1453 80
2901 1453 00 2901 1084 00 2901 0302 00 2901 1463 00 2901 0566 12 2901 0566 22 2901 1464 00
• • • • • • •
Oil filter element O-ring Air filter element
Oil separator kit
Oil separator O-ring
Electronic drain kit
1 1
Drain assembly Maintenance & operating manual CDi16
1
Preventative maintenance kit GA 75-90 VSD
Motor overhaul kit
Circlip Bearing Lipseal kit Bushing Drain nipple O-ring Bearing
Air/ Oil filter kit (4000 Hrs)
1 1 1 1 1 1 1
MPV kit Check & Oil st stop va valve kit Inlet valve kit VSD Unloader kit Air/Oil filter kit Oil separator kit Thermostat ki kit 60 60°C
2930 1431 01
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte
Atlas Copco Stationary Air Compressors GA 75 VSD, GA 90 VSD Aircooled GA 75 VSD, GA 90 VSD Watercooled
Parts list
WMV-Dresden, Ersatzteilservice für Elektrower Elektrower kzeuge, kzeuge, Motor- und Gartengeräte
What sets Atlas Copco apart as a company is our conviction that we can only excel in what we do if we provide the best possible know-how and technology to really help our customers produce, grow and succeed.
There is a unique way of achieving that - we simply call it the Atlas Copco way. It builds on interaction , on long-term relationships and involvement in the customers’ process, needs and a nd objectives. It means me ans having the flexibility to adapt to the diverse demands of the people we cater for.
It’s the commitment to our customers’ business that drives our effort towards increasing their productivity through better solutions. It starts with fully supporting existing products and continuously doing things better, but it goes much further, creating advances in technology through innovation . Not for the sake of technology, but for the sake of our customer’s bottom line and peace-ofmind.
That is how Atlas Copco will strive to remain the first choice, to succeed in attracting new business and to maintain our position as the industry leader. 7 0 . 6 0 0 2 C D / 1 0 1 3 4 1 0 3 9 2 . o N
*2930143101*