THE WORK SHEET IS FOR DESIGN OF RCC DRAIN , TRENCH,OR CULVERT,ETC. THE WORKSHEET IS USER FRIENDLY FOR VARIOUS SIZE OF DRAIN/TRENCH/CULVERT
Spark Plug Temperatures
16−50 COOLING
−
COOLANT (1KD−FTV)
COOLANT (1KD−FTV) 160HI−01
REPLACEMENT
Vinyl Hose
Tape A70279
Radiator Cap
Engine Drain Plug
1. DRAI DRAIN N ENGI ENGINE NE COOL COOLAN ANT T CAUTION: To avoid the ris risk k of burn burn injury injury, do not remove remove the radiato radiatorr cap while the engine and radiator are on heat. It is a probable able resu result lt that that heat heated ed flui fluid d and and stea steam m are are spew spewed ed by pres pres-sure inside the radiator. radiator. (a) Remove Remove the radiat radiator or cap. cap. (b) (b) Remo Remove ve the the serv servic ice e hole hole cove coverr for for the the engi engine ne unde underr cove coverr No. 1. (c) Instal Installl a vinyl vinyl hose hose to th the e drain drain tthe he radia radiator tor side side.. (d) (d) Loos Loosen en the the radi radiat ator or drai drain n plug plug and and engi engine ne drai drain n plug plug,, and and drain the coolant from the radiator. (e) Drain Drain the coolan coolantt from from the the rese reserve rve tan tank. k. (f) (f) Clos Close e the the drai drain n plug plugs. s. Torque: 8 Nm (82 kgfcm, 71 in.lbf) (g) Remove Remove the vinyl hose from the radiator radiator..
Radiator Drain Plug A72428
2. ADD ADD ENGI ENGINE NE COOL COOLAN ANT T (a) Fill the radiator radiator with a coola coolant nt carefully carefully.. HINT: S Use Toyota oyota Lon Long g Life Life Coolan Coolantt (LLC) (LLC) or equ equiva ivalen lentt one one.. Accord Accordanc ance e with with an instru instructi ction on by the man manufa ufaccture, mix it with demineralized water. S It is recommended recommended tha thatt use of a coolant contains contains ethylen ethylene e glycol. glycol. Preferred Preferred its content content ratio is 50 % and more, up to 60 %. Beyond that, 70 % and more would deteriorate its cooling effectiveness of the coolant. For your information, a freezing point depression in a mixture to 50 % ethylene glycol is − 35 _C (−31 _F), and it will down to − 50 _C (−58 _F) with 60 % ethylene glycol mixture. NOTICE: Do not not use use an alco alcoho holi lic c cool coolan antt and and plai plain n (non (non−demin deminer erali alize zed) d) water water alone. alone. Other Otherwis wise, e, it may may cause cause damage to engine cooling system.
(b) (c) (d) (e)
w/ Viscous heater
w/o Viscous heater
A/T
10.8 liters (11.4 (11.4 US qts, 9.5 lmp. qts)
11.0 liters (11.6 US qts, 9.7 lmp. qts)
M/T
11.1 liters (11.8 US qts, 9.9 lmp. qts)
11.3 liters (11.9 US qts, 9.9 lmp. qts)
Reset Reset the radiat radiator or cap. cap. Fill the radiator radiator reserv reservoir oir with with the coola coolant nt until until it reache reaches s to the FULL FULL line. line. Start Sta rt the the engin engine e to circul circulate ate the coolan coolant. t. Wait Wa it until the the coolant coolant gets cold, cold, then then remove the the radiator radiator cap again, again, and so check check the coolant coolant level level inside the radiator.
HINT: S S
Refill the radiator with the coolant if the coolant coolant level level is low. low. Refill the radiator reservoir reservoir with the coolant if it is lower lower than the FULL line. line.
