FORWARD CONTROL 6x4 26000 kg GVM
PF6TA 235 kW {320 PS} For Cargo Truck Right-hand drive
CWB450PHNA CWB450PPNA
Left-hand drive
CWB450PHLA CWB450PPLA
(for full trailer)
(for full trailer)
For Dump Truck Right-hand drive
CWB450HDNA
Left-hand drive
CWB450HDLA
For Concrete Mixer Truck Left-hand drive
CWB450HMLA
CWB450 SERIES TRUCK CHASSIS SPECIFICATIONS DIMENSIONS Wheelbase Overall Length Overall Width Overall Height Front Tread Rear Tread Rear Overhang to Frame End Cab to Rear Axle Center Ground Clearance Recommended BodyLength Width Ideal Body Offset
mm
CWB450HD
CWB450HM
CWB450PH
CWB450PP
(WB) (OL) (OW) (OH) (FT) (RT) (ROF) (CA) (GC)
3850 7365 2490 2855 2045 1860 1995 3140 270
3850 7365 2490 2855 2045 1860 1995 3140 270
5265 10055 2490 2855 2045 1860 3270 4555 270
5265 10055 2490 2855 2045 1860 3270 4555 270
4800 2200 250
Max. loading capacity 6.0 m3
7700 2330 470
7700 2330 470
MASSES
kg
Chassis with Cab On front wheels On rear wheels Payload, Body and Crew Allowance Permissible Gross Vehicle Mass Front Axle Capacity Rear Axle Capacity Permissible Gross Combination Vehicle Mass
CWB450HD
CWB450HM
CWB450PH
CWB450PP
7260 3760 3500 18740 26000 6500 26000 —
7330 3790 3540 18670 26000 6500 26000 —
7510 3790 3720 18490 26000 6500 26000 —
7620 3760 3860 18380 26000 6500 26000 55000
Note: These dimensions and masses are calculated for standard trucks fitted with 10.00R20-16 PR tires. When mounting body, the GVM should be less than the permissible tire load indicated in JIS, TRA, DIN, ETRTO or local regulations. The masses include oil, coolant and fuel, but not standard tools and spare wheel. Fuel System Fuel injection pump Governor
PERFORMANCE CWB450H
CWB450P
6.9 m
8.8 m
Minimum Turning Radius Max. speed and Gradeability
At 26000 kg GVM with 10.00R20 tires At 55000 kg GCM with 10.00R20 tires (CWB450PP only)
CWB450
CWB450PP
Max. speed km/h
Gradeability (tanθ)
Transmission
Final Ratio
— — — — — — — STD OPT □ OPT □ OPT □ OPT □ OPT □ OPT □
87 97 92 106 95 91 86 97 108 92 88 106 95 85
0.443 0.392 0.417 0.643 0.750 0.818 0.893 0.338 0.301 0.360 0.381 0.308 0.352 0.399
MTS60A MTS60A MTS60A RTX11710B RTX11710B RTX11710B RTX11710B RTX11609B RTX11609B RTX11609B RTX11609B RT14915 RT14915 RT14915
6.833 6.166 6.500 5.571 6.166 6.500 6.833 6.166 5.571 6.500 6.833 4.111 4.625 5.143
STD OPT □ OPT □ OPT □ OPT □ OPT □ OPT □ OPT □ OPT □ — — — — —
Available combinations of transmissions and final gear ratios are shown in the above table. Except for CWB450PP
ENGINE Make and Model Type Number of Cylinders Bore × Stroke Total Piston Displacement Max. Gross Output (JIS) Max. Gross Torque (JIS) Max. Engine Speed Compression Ratio Lubrication System Cooling System
NISSAN DIESEL MOTOR, PF6TA DIESEL ENGINE 4-cycle, direct-injection, water-cooled, in-line, turbocharged with intercooler, diesel engine 6 133 × 150 mm 12503 cm3 235 kW {320 PS} at 2100 rpm 1294 N·m {132 kgf·m} at 1200 rpm 2300 rpm 16.5 Forced feed by gear pump Forced circulation by centrifugal water pump
Bosch P-type in-line plunger RFD, mechanical type (STD) Limiting-speed use (except CWB450HM) All-speed use (CWB450HM only) (OPT) □ All-speed use (except CWB450HM) Air Cleaner (STD) Donaldson FTG13L (paper-element) (OPT) □ Donaldson FTG13L (metallic-element) (OPT) □ Donaldson FTG15S (paper-element) (OPT) □ Donaldson FTG15S (metallic-element) Electrical Equipment 24-volt system, negative earth Generator (STD) 24-volt-40 amp. alternator (OPT) □ 24-volt-50 amp. alternator Rear Power Takeoff (STD for Concrete Mixer Truck) Allowable max. torque 343 N·m {35 kgf·m}
CHASSIS Clutch
Dry single (twin for CWB450PP only) plate, hydraulically operated clutch release mechanism with air-assisted booster Reverse Elliot “I” beam
Front Axle Rear Axle Type
Full-floating, in-line tandem type with inter-axle differential
Final reduction gear
Single reduction, hypoid gear
Final reduction ratio CWB450 CWB450PP
6.833
6.500
6.166
5.571
5.143
4.625
4.111
STD OPT □
OPT □ OPT □
OPT □ STD
OPT □ OPT □
— OPT □
— OPT □
— OPT □
Except for CWB450PP
Steering Service Brake (foot brake) Parking Brake
(STD)
(OPT) □
Recirculating ball screw type with hydraulic power assistance Full air brake on all wheels, dual air line system, internal expanding leading and trailing shoe type Hand brake Mechanically operated by hand brake lever, internal expanding duo-servo shoe type acting on drum at rear of transmission Spring brake (also be used as emergency brake) Pneumatically controlled spring brake operated by gradual type control valve, acting on all rear axles (STD for CWB450PP)
Transmission
Make and model
Type
Gear ratios
1st 2nd 3rd 4th 5th 6th Rev.
OPT □
NISSAN DIESEL MOTOR, MTS60A Six forward speeds and one reverse, synchromesh on 2nd, 3rd, 4th, 5th and 6th gears, constantmesh on 1st and reverse gears 6.736 4.164 2.545 1.576 1.000 0.732 6.911
FULLER RTX11710B
FULLER RTX11609B
Ten forward speeds and two reverse, constantmesh on each shift and synchromesh on range shift
Nine forward speeds and two reverse, constantmesh on each shift and synchromesh on range shift
1st 2nd 3rd 4th 5th 6th
FULLER RT14915
(HIGH) — 5th 1.952 6th 1.379 7th 1.000 8th 0.730 3.434
(LOW) LO 12.565 1st 7.468 2nd 5.276 3rd 3.825 4th 2.793 Rev. 13.136
(HIGH) 7th 1.832 8th 1.360 9th 1.000 10th 0.743 Rev. (L)11.227 Rev. (H) 2.515
(LOW) 10.956 8.179 6.072 4.463 3.319 2.454
Fifteen forward speeds and three reverse, constantmesh on each shift and synchromesh on range shift
(DEEP) 1st 16.939 2nd 12.977 3rd 10.026 4th 7.725 5th 6.070 Rev. 16.725
(LOW) 1st 9.964 2nd 7.634 3rd 5.897 4th 4.544 5th 3.570 9.838
(HIGH) 6th 2.790 7th 2.137 8th 1.651 9th 1.272 10th 1.000 2.755
Mechanical remote control Attached on the left side of gearbox
2
P.T.O. (OPT) □ Reduction ratio
Attached on the bottom of gearbox
1.214
Capacity
0.632
0.750
294 N·m {30 kgf·m}
Clockwise as seen from rear
1 STD for CWB450PP
2 STD for CWB450HD
Front Springs Width × Span Rear Springs
Semielliptic leaf springs 90 × 1550 mm Trunnion-mounted semielliptic leaf springs with torque rods Width × Span 90 × 1300 mm Shock Absorbers Telescopic type on front axle Wheels and Tires Front: Single, Rear: Dual Tires (STD) 10.00R20-16PR (OPT) □ 11R22.5-14PR, □ 11R22.5-16PR, □ 12R22.5-14PR, □ 12R22.5-16PR, □ 10.00R20-14PR □ 11.00R20-14PR Note: When these tires are selected, the axle load must be within the tire capacity. Rim and wheel (STD) 7.50V × 20, 10 studs (SAE) disc wheel (OPT) □ 7.00T × 20, 10 studs (SAE) disc wheel □ 7.50V × 20, 10 studs (ISO) disc wheel □ 7.50 × 22.5, 10 studs (SAE) disc wheel □ 8.25 × 22.5, 10 studs (SAE or □ ISO) disc wheel □ 7.50 × 20, TRILEX rim Spare wheel One spare wheel and tire with wind-up wheel carrier Available combinations of wheels and tires Tire Wheel 7.00T × 20 7.50V × 20 7.50 × 22.5 7.50 × 20 (TRILEX) 8.25 × 22.5
0.849
304 N·m {31 kgf·m}
Direction of rotation
Frame
OPT □
OPT □
Gearshift
○ : Available
1
STD
10.00R20
11.00R20
11R22.5
12R22.5
○ ○ × × ×
× ○ × ○ ×
× × ○ × ○
× × × × ○
× : Not available (STD)
Ladder type, channel section side member
Dimensions Dimensions Fuel Tank Capacity
Electrical Equipment Battery Headlights Others
300 × 90 × 8 mm (OPT) □ Double-channel ladder type main 300 × 90 × 8 mm inner 284 × 80 × 6 mm (STD) (OPT) □ □ □
200 liters 300 liters 200 liters × 2 (Except HD, HM) 300 liters × 2 (Except HD, HM)
(STD) 115 A·h, 12-volt × 2 (OPT) □ 145 A·h, 12-volt × 2 2 lamps, halogen 75/70 W × 2 Taillight, stoplight, licence light, side clearance light, turn signal, air horn
CAB Type Windshield Instruments Meters
Forward control, all steel welded construction tilting cab Laminated glass Speedometer with odometer, fuel gauge, water temperature gauge, voltmeter, air pressure gauge, oil pressure gauge Low oil and air pressure warning lights, hand brake, direction and headlight beam indicators, low air pressure warning buzzer
Warning lights and buzzers
ATTACHMENTS Tools
NISSAN DIESEL standard tools (1 set)
OTHERS ITEM Air conditioner Air dam skirt Air pressure gauge
STD × × One needle
Beacon lamp
×
Brake auto adjuster (With spring brake)
×
Cab suspension system
○
Car heater
□ □ □ □ □ □
Center console
×
□
Center seat
○
□
Cigarette lighter
○
Coolant level warning buzzer
○
Curtain rail Driver’s seat
○ Air suspension type
○ ○ Two needle
－
Passing lights
○
－
Power window
○
○ ○
□
Radio
Convex
□
Combination
Reverse warning buzzer
×
□
○
○ (Without)
Revotachograph
×
□
○
Roof ventilator
×
□ ○ Driver’s seat & passenger’s seat
Seat belts
×
－ Rail & curtain
Exhaust brake
○
－
Fan clutch
×
□
○
× Yellow
□ □
○ White
Front stabilizer
×
□
○
UD mark
○
Meters illuminate control Multi-use console (Without center seat) Oil mist separator Overhead tray
－
○
－
○ × × ○ ○
3 point ELR □ 3 point NR □ Center seat □
Seat upholstery
Intermittent wiper
－ □ □
－ AM radio AM-FM radio AM-FM radio & cassette tape player
Rearview mirrors
－
Hazard warning lamp
□ □ □
○ Loop type cloth
○
Fog lights
×
－ □
OPT
○
Engine overrunning warning buzzer
Fire extinguisher
STD
Overheating warning buzzer
－
× Vinyl resin
Carpet
ITEM
OPT
○ ○ － －
2 point NR
Vinyl resin
□
Cloth
Side deflector
×
□
○
Sleeper
×
□
○ Driver’s side only
□
○ (Without)
Tachograph
×
□
Tachometer
○
Tilt/telescopic steering
○
Tire inflator
×
□
○
Toolbox (except HD, HM)
×
□
○
Wheel step (SAE type wheel only)
×
□
○
Spare wheel Sun visor
□
Driver’s side & passenger’s side ○ － －
○ : Available × : Not available
Please contact an authorized distributor of Nissan Diesel Motor Co., Ltd.
Note: In order that product improvements may be introduced at any time, specifications are subject to change without notice.
Pub. No. SCWB450AE11
