Dynaudio installation in Passat 3C Based on Roy’s descriptions (http://petzold.serveftp.net/Partycentral/Forum/foru (http://petzold.serveftp.net/Partycentral/Forum/forum3/viewforum.ph m3/viewforum.php?f=6) p?f=6) I’ve now also completed my installation of the Dynaudio system in my Passat. I’m very pleased with both the great sound and the fact that it has only cost me approx. €800 (amplifier and speakers purchased on eBay) compared to the €4000 it cost on the Danish Danish Passat extras list list . Thanks Thanks Roy. Roy. The entire project has lasted me about 30 hours or so, and I find the result well worth it. But I don’t think this is a one day project to anybody, so be prepared to spend some hours pulling your car apart if you start on this. My initial Car configuration was as follows: Passat 2006 2.0 TDI Variant Comfortline. RCD300 radio and 8 VW speakers (standard in Denmark) Antenna and 4 speaker wires (one signal for each door) As head unit I’ve built in a MFD2 DVD instead of the RCD300, and while at it, I also built in a Nokia CK7W hands-free unit. Since my car already had the antenna built in, I didn’t need to dismantle the C-column C-column or the rear inside of the car. I did however have to dismantle the following: -
All 4 door covers. Lower B column cover. Lower and middle A column cover. Side entry covers. Foot well side and top covers.
Installation of antenna If you don’t have the antenna installed you have install the two antenna amplifiers (3C9 (3C9 035 552 A = right & 3C9 035 552 D = left) in the C-column and fit the antenna cables (2x 000 098 657) along the sides of the under the side entry covers. I didn’t have to do this, as I had the antenna amplifiers and cables fitted from the factory.
To fit the wires in the door-connector, you have to disconnect the wire coming from the A or B column and retract the plug into the door and out through the hole where the speakers were removed. When inserting the needed connectors into the plug make sure to make a note of which positions in the plug you have used.
Once the wires are in place make sure to tape them up with isolating tape, both to protect them from water in the doors and keep the wires from getting in the way of the windows when lowering them. One thing to remember: Don’t install the new speakers until you have all the new wiring in the door ready. You need the access to the interior of the door when installing the new wires.
Finally connect the plugs in the loudspeakers and fit door covers in the reverse order of the removal.
If you are looking to install a MFD2 at the same time, I positioned the GPS under the topside left dashboard using the access to the underside of the dashboard from the removed storage drawer below the headlights switch. This keeps the antenna hidden and the reception has been perfect so far. The 4 signals from the head unit (Front left, Front right, Rear left, Rear right), CAN High and CAN low I took from the radio connector behind the radio, and routed the wires through the left foot well to the amplifier. From the CAN signals I used shielded LIYCY 2x0,34 wire (shielding not connected). In Roys installation, he has routed the cabling under the seats and across the middle column. Choose what suit you best.
Once all the wires were inside the amplifier bracket, I connected the wires to the multi-connectors according to the pin-out below, plugged in the multi-pin connectors and turned on the funky music!! No further work is needed, and in particular no reprogramming using VAG-COM is required. And just to repeat Roys warning: If you decide to try this installation, it is at own risk. This is not a project that is completed in an afternoon, and there is a chance of breaking car interiors, cables, plugs and other essentials. A Picture of my car completed:
A Picture of Roys car completed:
Parts list 1. Dynaudio System - 1x 3C0 035 456 A = Amplifier - 2x 3C0 035 454 B = Midrange- /Bass speaker front - 2x 3C0 035 453 B = Bass speaker rear - 2x 3C0 035 411 D = Treble speaker front (without the triangle housing) - 2x 3C0 035 411 E = Treble speaker rear (without the door handle housing) - 1x 1K0 035 883 = Amplifier bracket 2. Radio accessories if no radio from factory - 2x 000 098 657 = Antenna cable - 1x 3C9 035 552 A = Antenna amplifier right - 1x 3C9 035 552 D = Antenna amplifier left - 2x N 013 969 21 = Bolt for fixing antenna amplifiers - 1x 3B7 035 447 = Speaker connector for Quadlock Connector 3. Connectors if no speakers from factory - 4x 1J0 972 704 = Connector housing for Midrange- / Bass front & rear - 2x 3B0 972 712 = Connector housing for Treble front - 2x 1J0 972 723 = Connector housing for Treble rear 3. Connector s - 1x 1J0 962 624 A = Connector 24pol. at amplifier (grey) - 1x 1Jo 962 623 B = Connector 23pol. at amplifier (green) - 60x N 103 358 07 = Connector elements for Connector - 25x N 103 381 05 = Connector elements for Connector - 50x N 906 844 05 = Connector elements for Connector
Connector pin-outs 1. Amplifier
5 = unused 6 = Treble speaker front left, minus 7 = unused 8 = unused 9 = Treble speaker front left, plus 10 = unused 11 = Bass speaker front right, plus 12 = Bass speaker front right, minus 13 = unused 14 = unused 15 = Treble speaker front right, plus 16 = Voltage, Ground 17 = unused 18 = Treble speaker front right, minus 19 = Voltage, Ground 20 = Voltage, plus 12V 21 = Voltage, plus 12V 22 = Voltage, Ground 23 = Voltage, plus 12V
2. Radio
6 = Speaker front right, minus 7 = Speaker front left, minus 8 = Speaker rear left, minus M u l t i - p i n h a r n e s s co n n e c t o r 2 , 8 - p i n / V o l t a g e , CA N - B u s, Te l e p h o n e m u t e 9 = Can High 10 = Can Low 11 = Telephone mute 12 = Ground 13 = unused 14 = unused 15 = 12V Plus 16 = SAFE 3. Speakers M i d r an g e - / B as s sp e a k er f r o n t 1 = Bass minus 3 = Bass plus 2 = Midrange minus 4 = Midrange plus T r e b l e sp e a k e r f r o n t 1 = Treble plus 2 = Treble minus Bass speaker r ear 1 = Bass plus 3 = Bass minus
Overview: Connecting the amplifier
Passat
Wiring Diagram
No. 73 /
Radio - Premium Sound System, Radio/Navigation System RNS MFD2-DVD, Dynaudio, Satellite Radio, CD Changer from May 2005 Note: Information for ♦ Relay and fuse arrangements ♦ Connector arrangements ♦ Control Modules and Relays ♦ Ground connections → Component Locations Information for ♦ Troubleshooting Procedures → Guided Fault Finding using VAS 5051 / 5052
Passat
No. 73 /
Wiring Diagram
Power Supply for Radio/Radio/Navigation Display Control Module, CD Changer, Antenna Connection GPS J412 J503 J519 R R1 R36 R41 SB19 T8s T12f T12i T12j T12l T54
519
T12i /12
SB19
36 412 T54/16
1,5 ro/ge
1,0 gr
B340
36
0,5 ws/ro
412
36
0,35 ws
412
0,35 bl
62
65
HF
B151
Operating Electronics and Telephone Control Module Radio/Navigation Display Control Module Vehicle Electrical System Control Module Radio Antenna Connection Telephone Transceiver CD Changer Fuse 19 (on fuse panel B) 8-Pin Connector, black 12-Pin Connector, near CD changer 12-Pin Connector 12-Pin Connector 12-Pin Connector 54-Pin Connector
✱✱ 1,0 gr
1,5 ro/ge
1,0 ro/ge
T8s /15
T8s /16
T12j /4
T12j /6
T12l /6
T8s /11
T12l /12
R1
GPS
AM/FM
R1
370
Ground Connection 5 (in main wiring harness)
610
Ground Connection (Audio) (under center console, front)
B151 Plus Connection 3 (30a) (in interior wiring harness) T12j /11
T12j /12
T12j /9
T12j /10
T12j /2
T12j /8
T8s /12
503
B340 Connection 1 (58d) (in main wiring harness)
2,5 br
B341 Connection 2 (58d) (in main wiring harness)
370 0,5 ✱ gr
0,35 0,5 ✱ ✱ bl ro/ws
12f /12
12f
0,35 ✱ gn
12f
/1
0,35 ✱ ge
12f
/6
0,35 ✱ bl
12f
/4
0,5 ✱ ws/ge
12f
/2
0,35 ✱ sw
12f
/7
12f
/8
/9
0,35 ✱ gr
0,35 ✱ sw
12f /10
12f
2,5 br
*
0,5 br
**
18
/3
41
610 1
2
3
4
5
6
7
8 97-94414
ws sw ro br gn bl gr li ge or rs
= = = = = = = = = = =
white black red brown green blue grey lilac yellow orange pink
Only vehicles with CD changer preparation or external CD changer Only models with Navigation System
Passat
No. 73 /
Wiring Diagram
Power Supply Amplifier, Radio/ Radio/Navigation Display Control Module, Digital Satellite Radio, Antenna Connection
519
J503 J519 J533 R R1 R12 R190 SB18 SB21 T8k T8m T8p T8s T12j T20e T23 T24
59 533 533 T20e/10 T20e/20
SB 21 190
R1
SAT
T8p /1
T8p /2 0,35 or/br
0,35 or/li T8m/1
8p/6
0,35 or/br
0,35 or/li
B415 B421
0,5 ro/sw
0,5 br
0,35 li
12
T12j /1
T8k/
503
0,35 bl
T8k/
T8k/
0,35 ws
T12j /3
0,35 or/li
T12j /7
T8k/
T8k/
0,35 or/br
T8s/9 can-h
T8k/
T8k/
T8s/10 can-l
T8k/
SB18
0,5 br
0,5 sw
0,5 sw
0,5 gn
0,5 sw
0,5 ws
0,5 sw
0,5 ge
0,35 or/br
T23 /20
T23 16 1,0 br
2,5 ro
T23 /21
T23 /19 1,0 br
T23 /23
T23 /22
T24 /14
T24 /15
T24 /17
T24 /18
T24 /20
T24 /21
T24 /23
T24 /24
T23 /1
T23 /4
12
2,5 br
366
610
Ground Connection 1 (in main wiring harness)
610
Ground Connection (Audio) (under center console, front)
B415
Infotainment CAN-Bus High Connection 1 (in main wiring harness)
B421
Infotainment CAN-Bus Low Connection 1 (in main wiring harness)
0,35 or/li
B219
1,0 ro
366
B219 Plus Connection 4 (30a) (in interior wiring harness)
4,0 ro
1,0 ro
Radio/Navigation Display Control Module Vehicle Electrical System Control Module Data Bus On Board Diagnostic Interface Radio Antenna Connection Amplifier Digital Satellite Radio Fuse 18 (on fuse panel B) Fuse 21 (on fuse panel B) 8-Pin Connector, brown 8-Pin Connector 8-Pin Connector 8-Pin Connector, black 12-Pin Connector 20-Pin Connector 23-Pin Connector 24-Pin Connector
6,0 br
97-94415
ws sw ro br gn bl gr li ge or rs
= = = = = = = = = = =
white black red brown green blue grey lilac yellow orange pink
Passat
No. 73 /
Wiring Diagram
Treble Speaker, Midrange Speaker and Left and Right Front Bass Speaker, Amplifier J519 R12 R20 R21 R22 R23 R103 R104 T2dv T2dw T4as T4at T23 T24 T28 T28c
519
103
21
T4as/2
1,0 br/bl
T4as/4
1,0 bl
28c /26
1,0 br/bl
T23/2
1,5 br/bl
28c /25
1,0 bl
T4as/1
T23/3
T4as/3
1,5 ro/bl
28c /24
1,5 br/bl
20
T24/8
1,0 br/gr
28c /23
1,5 ro/bl
T2dv/2
T24/9
T2dv/1
1,0 ro/gr
28c /28
1,0 br/gr
104
1,0 br/sw
28c /27
1,0 ro/gr
T23/6
T4at/2
T23/9
T4at/4
1,0 bl/sw
28 /26
1,0 br/sw
23
1,5 br/gn
28 /25
1,0 bl/sw
T24/11
T4at/1
T24/12
T4at/3
1,5 ro/gn
28 /24
1,5 br/gn
22
1,0 br/sw
28 /23
1,5 ro/gn
T23/12
T2dw/2
1,0 ro/sw
28 /28
1,0 br/sw
T23/11
T2dw/1
28 /27
1,0 ro/sw
T23/18
T23/15
12
97-94410
ws sw ro br gn bl gr li ge or rs
= = = = = = = = = = =
white black red brown green blue grey lilac yellow orange pink
Vehicle Electrical System Control Module Amplifier Left Front Treble Speaker Left Front Bass Speaker Right Front Treble Speaker Right Front Bass Speaker Left Front Midrange Speaker Right Front Midrange Speaker Double Connector Double Connector 4-Pin Connector 4-Pin Connector 23-Pin Connector 24-Pin Connector 28-Pin Connector, connector station A-pillar, right 28-Pin Connector, connector station A-pillar, left
Passat
No. 73 /
Wiring Diagram
Bass Speaker and Left and Right Rear Treble Speaker, Amplifier J519 R12 R14 R15 R16 R17 T2dk T2do T4ai T4am T6bx T6by T24 T28a T28b
519
15
T4ai/1
14
T4ai/3
T2dk/1
1,0 bl/li
16
T2dk/2
1,0 ws/li
6bx /1
1,5 br/ws
1,5 ro/ws
28a /24
1,5 br/ws
28a /23
1,5 ro/ws
T24/10
T24/4
1,0 bl/li
1,0 bl/li
6bx
1,0 bl/gr
28a /28
1,0 bl/gr
T24/7
6by /2
1,0 ws/gr
28b /27
1,0 ws/li
T4am/1- T4am/3
1,0 ws/li
/1
1,0 ws/li
T24/1
T2do/2
6by
/2
28a /27
1,0 bl/li
T2do/1
17
28b /28
1,0 ws/gr
T24/6
T24/5
1,5 br/li
1,5 ro/li
28b /24
1,5 br/li
T24/2
28b /23
1,5 ro/li
T24/3
12
97-94411
ws sw ro br gn bl gr li ge or rs
= = = = = = = = = = =
white black red brown green blue grey lilac yellow orange pink
Vehicle Electrical System Control Module Amplifier Left Rear Treble Speaker Left Rear Bass Speaker Right Rear Treble Speaker Right Rear Bass Speaker Double Connector Double Connector 4-Pin Connector 4-Pin Connector 6-Pin Connector (In LR Door) 6-Pin Connector, (In RR Door) 24-Pin Connector 28-Pin Connector, connector station B-pillar, left 28-Pin Connector, connector station B-pillar, right
Passat
No. 73 /
Wiring Diagram
Antenna, Antenna Amplifier, FM Frequency Filter J9 J519 R11 R24 R50 R93 R111 R112 R172 R178 R179 T10s Z1
519
T10s /1 2,5 sw
172 178
SAT
24
111
GPS
AM/FM
1,5 sw
HF
18
660
Ground Connection 1 (left, near rear window)
660
Ground Connection 2 (right, near rear window)
*
1,5 sw
112
657
B569 Connection 36 (in main wiring harness)
B569
179
657
97-94817
Rear Window Defogger Relay Vehicle Electrical System Control Module A nt en na Antenna Ampli fier Navigation System Antenna Radio Antenna 2 Antenna Ampli fier 2 Antenna Ampli fier 3 Satellite Tuner Antenna FM Frequency Filter (in negative wire) FM Frequency Filter (in positive wire) 10-Pin Connector, black Heated Rear Window
ws sw ro br gn bl gr li ge or rs
= = = = = = = = = = =
white black red brown green blue grey lilac yellow orange pink
Only models with Navigation System
