Chemical Compatibility Guide LEGEND
A B C D E F G H
I
J K L M
N O P Q R S T U V W X Y Z The material contained in this guide is based upon technical data and tests made available by various chemical manufacturers and users.
Factors that may affect the material or elastomer composition in a pump using liquid chemical(s) are: chemical concentration aeration ● impurities ● duty cycle ● temperature ● viscosity ● mixing of chemicals ● pH rating ● pump RPM ● vapor point ● ●
The purpose of this information is to provide a GENERAL GUIDE regarding the use of various chemicals with CAT PUMPS products. This guide is not intended as an absolute materials recommendation.
The only reliable means of making a final selection is actual field testing under the conditions of intended use. CAT PUMPS assumes no liability for results obtained or damage incurred through the application of the data presented in this guide.
Kalrez®, Teflon® and Viton® are registered trademarks of DuPont Dow Elastomers. Chemraz® is a registered trademark of Greene, Tweed and Co. HASTELLOY ‘C’® is a registered trademark of Haynes International, Inc.
1681-94th Lane N.E., Mpls, MN 55449-4324 Ph: 763 ● 780 ● 5440 FAX: 763 ● 780 ● 2958 e-mail:
[email protected] PN 990331 Rev A 6720
LEGEND A
Elastomer/material shows little or no effect after exposure to the chemical.
B
Elastomer/material may be affected after exposure chemical. Swelling and/or a loss of physical properties is possible.
C
Elastomer/material is effected after exposure to the chemical. Moderate or severe swelling and loss of physical properties will limit life of the elastomer/material.
U
Elastomer/material is unsuitable when exposed to the chemical.
*
For fluid to remain in liquid state, pressure or temperature may exceed inlet seal specifications.
^
A special compound may be required. Contact CAT PUMPS for recommendations.
A C A A
A
C A
A B A A A A C A
U U
A
U A A A A A A A A A A A
C A A A A A A A A A A A
C A A U A A A C C A A C
C C B
C C C
U U
C C C
C
U
A
U
U
U
C C A A A A A A A A
A A A A A A A
A A
A U
A A A
C U U U U U U U U U C U U U U U U C
U U U U U U U U U
U U U U A A A C U C U
C U
A A
C C
U
A
U
U U C
C U
B U
U U C C C
A A A A C
U
A
A B B A A
B U
U U A C C C A A B C C B B A U A A A A A A A C C C C
A A
U C A
C
C
C C
C C
U
B A A
A A
C C C
C C A
A A
U C A B A B B A A A B B A A A C A A A A A
C A A
A B A
A U
C
C
A A
C U C
C A A
A
C
A A A A
C A A A A A A A A A A A
A A
U
A A A A
A A A A A A A A A A A
C A
A
A A A A
C A A A A A A A A A A A
A A C C C C A A A A A
U
C C
A A A A
A A A A
A A
A A B A A A A A A A A
A A A A A A A A A A A A
U
A A A A B A A A C A A
C C B A A A
C C B
A A
U A
U B
A A
A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A
U U C U U
U C U U U
U A
A A A
A A B A A A U A
U A U A C B A B B A B A
C U A A A C A A A U A A A A B B U
U U A B A A C A A A C A
A A A C A A A A U U U
A A
C A B A A A A A
A
B A B A
A A
A A A A A A A A A A A
C U
A A
A A
A A
C C
U
A
A
A
C
C C C U
A A A A A A
A A A A
A C C A
A
A
A A A
A A A
B
A A A
C
A
A
C U U U U U U U
A A
C C
C C A A A A
B
A A A B B
C
A
C C C U U U C U U B
B U B B
A A A A A A A A A A A A A A A A A A A A
A A
A
A A A A A A A A
A A A C B A A A A U A B B U A A A A A A A A A B A U C A A U U A
U U
A
A A A A A A A
Kalrez®, Chemraz® (KPFE)
A A U A
A B
Ethylene Propylene Diene Monomer (EPDM)
U U B A A
A A
Viton® (FPM)
A U C A
A
BUNA-N (NBR)
A C U A
A
ELASTOMERS
Teflon® (PTFE)
A A
Polyvinylidene Fluoride (PVDF)
A B
ACETAL (D)
C C
CERAMIC (ALUMINA) (CC)
C U
TITANIUM (TI)
316 STAINLESS STEEL (SS)
A U
HASTELLOY 'C'® (HC)
304 STAINLESS STEEL (S)
A
PLASTICS
304SS CHROME PLATED (SCP)
CARBON STEEL (CBST)
CHEMICAL ACETALDEHYDE ACETAMIDE ACETANILIDE ACETATE SOLVENTS (PURE) ACETIC ACID (GLACIAL) ACETIC ANHYDRIDE ACETONE ACETONITRILE ACETOPHENONE ACETYL CHLORIDE *ACETYLENE ACETYLENE TETRABROMIDE ACETYLENE TETRACHLORIDE ACRYLONITRILE ALCOHOL,AMYL ALCOHOL,BENZYL ALCOHOL,BUTYL ALCOHOL,DIACETONE ALCOHOL,ETHYL ALCOHOL,HEXYL ALCOHOL,ISOBUTYL ALCOHOL,ISOPROPYL ALCOHOL,METHYL ALCOHOL,OCTYL ALCOHOL,PROPYL ALKYL BENZENE ALKYL CHLORIDE ALUM 10% ALUM 100% ALUMINUM ACETATE ALUMINUM BROMIDE ALUMINUM CHLORIDE ALUMINUM FLUORIDE ALUMINUM HYDROXIDE ALUMINUM NITRATE ALUMINUM OXIDE-ABRASIVE ALUMINUM POTASSIUM SULFATE 10% ALUMINUM POTASSIUM SULFATE 100% ALUMINUM SULFATE AMINES *AMMONIA ANHYDROUS LIQUID AMMONIA LIQOURS AMMONIA NITRATE AMMONIUM BICARBONATE AMMONIUM BIFLUORIDE AMMONIUM CARBONATE AMMONIUM CHLORIDE AMMONIUM DIPHOSPHATE AMMONIUM HYDROXIDE (10%) AMMONIUM HYDROXIDE (46.5%) AMMONIUM MONOPHOSPHATE AMMONIUM NITRATE AMMONIUM NITRITE AMMONIUM OXALATE AMMONIUM PERSULFATE AMMONIUM PHOSPHATE (MONOBASIC) AMMONIUM PHOSPHATE (TRIBASIC) AMMONIUM SULFATE AMMONIUM SULFIDE AMMONIUM THIOPHOSPHATE AMMONIUM TRIPHOSPHATE AMMONIUM THIOSULFATE AMYL ACETATE AMYL ALCOHOL AMYL BORATE AMYL CHLORIDE AMYL CHLORONAPHTHALENE AMYL NAPHTHALENE AMYL NITRATE ANHYDROUS HYDROGEN FLUORIDE ANHYDROUS HYDRAZINE ANILINE ANILINE DYES
CAST IRON (F)
(See Legend Page for Detail)
BRASS (BB)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
NICKEL ALUM. BRNZ. (NAB)
LEGEND
DUPLEX STAINLESS (SSD)
MATERIALS
A^ A^ A^ A^ A A A A A A A A A^ A A A A A A A A A A A A A A A A A A A A
A A A^
A B A
A A
A A^ A A
A B
A A
A
A
A A
A A A U
A A A A
U B A C B A
C A U U U U
C B
A A A A
A A A A A
A A A A A A
A A
C C U
A C
A
C
A B C C A U C U A A U A
A B C
A A
A B A
A U A
U
U
U
U U A A A A A C A U C U B B U A
C C A B A A A C
A A A
A
C A A A B A A C
A C A U U A
C A C C U A B B
A U
B A C A C C U A C
A U U
C A A
C C A A
A A A A A A A A A C C A A U A
A A A A A A A A A C C A A C A
A A A
A A A
A A U A U U
C C U U A
C
U
C C
A
A B A A U
A U A B A C
C A A A A A A U
A
A
A
A
U
B
B A
B
A A A A A
A A A A
A
A A A
A
B A
U A A A A A
A A U
A A B
U U
A U
A
A A
A A
B A A A A A A A
A A C C A A A A
A A B U A A A B B A A
A
A C A
B A
C C U C A C A
A U
C C A
A A A C
A A A A A
U
A
A
A U A A A C
A U A
C
A A
A
A A
A
B A
A
C C C A C A B
U
U C
C A C U A C A A
A C A A A A A C
B C
B B
A A
C A A
U
C
A A B
A B C
A A A
C U A
A
A A B
U U
A A
A A A C A A U
A A A A A A A A A A A A A A A A A A A A A A A
A A
U
A A A A A
U A U A A A A
A A A A
A C A A A A A
A
U C
B U
A A A A A A
C
A
A
A U C
Polyvinylidene Fluoride (PVDF)
ACETAL (D)
CERAMIC (ALUMINA) (CC)
TITANIUM (TI)
DUPLEX STAINLESS (SSD)
304SS CHROME PLATED (SCP)
A
A
A
A A
A
U
A A
U
Kalrez®, Chemaz® (KPFE)
U
A U U
U
Ethylene Propylene Diene Monomer (EPDM)
C
U B
Viton® (FPM)
B
U A A
BUNA-N (NBR)
B
U A
316 STAINLESS STEEL (SS)
A A
ELASTOMERS
Teflon® (PTFE)
B
U A A
PLASTICS
HASTELLOY 'C'® (HC)
U A
304 STAINLESS STEEL (S)
CHEMICAL ANILINE HYDROCHLORIDE ANILINE OIL ANISE OIL ANSUL ETHER ANSUL OIL ANTI-FREEZE ANTIMONY TRICHLORIDE AQUA REGIA *ARGON GAS AROCHLOR *AROMATIC HYDROCARBONS ARSENIC ACID ARSENIC COMPOUNDS ASKAREL ASPHALT ASPHALT TOPPING ASTM OILS NO.1,NO.2,NO.3 AVIATION GASOLINE BARIUM CARBONATE BARIUM CHLORIDE BARIUM CYANIDE *BARIUM HYDROXIDE BARIUM NITRATE BARIUM SULFATE BARIUM SULFIDE BEER BEET SUGAR LIQUORS *BENZALDEHYDE BENZENE BENZENESULFONIC ACID BENZINE (GASOLINE) BENZOIC ACID BENZOL BENZYL BENZOATE BENZYL CHLORIDE BICHLORIDE OF MERCURY BLACK SULFATE LIQUID BLEACH LIQOUR BOILER FEED WATER BONE OIL BORAX (SODIUM BORATE) BORIC ACID BRAKE FLUID BRINE ---- ABRASIVE BROMINE BROMINE TRIFLUORIDE BROMINE WATER BROMOBENZENE BUNKER 'C' FUEL OIL *BUTADIENE RHITEMP *BUTANE BUTTER BUTTERMILK BUTYL ACETATE ROOM TEMP. BUTYL ACRYLATE BUTYL AMINE BUTYL BENZOATE BUTYL CARBITOL BUTYL CELLOSOLVE BUTYLENE BUTYL OLEATE BUTYL PHTHALATE BUTYL STEARATE BUTYRALDEHYDE BUTYRIC ACID CALCIUM ACETATE CALCIUM BISULFATE CALCIUM BISULFIDE CALCIUM BISULFITE CALCIUM CARBONATE SLURRY CALCIUM CHLORATE (DILUTE) CALCIUM CHLORIDE CALCIUM HYDROXIDE 10% CALCIUM HYDROXIDE 50%
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
C
A
A
U
U C A
A A A A A A A
A A A
A A A A
A A
A A
A A A
C
U U A U U U
A A A A A A A A A A A A A A A A
U A U U A A B C C A A A A C A A A A U A U U A C U U U A A U C A B A U A U U U U A U A A A U C U A C A U B U C B A A U A A A
A A A
A A A A A A A A A A A U A A A A A A A A A U A A A A A U A A A A A A A U U U A A U A A A U B U A A A A A A A
A A A A A A A A A A U
A A A A A A A A
U C B B U
A A^
A
A^
A A
A
A A
A U U B U U C U A
A A A^ A
C U B B A A U B A C B B A U U U
A
A A
A A A
A^ A A A A A^ A A A A
A A A
A
A
A
A A
U U A U U C A U
C
U
B A A A A A A A A
U A
A
B
A
A
U
A A A A A
A
A
A
A
A
U A A A B A B A
A A A A A A A A A
B A A A A A A C B U C A U B A C A A U U A U A
A B A A B A A A A A
C
A
A
A C
A A A A A
A B B
A A
A A
U A A C A A A A A
ACETAL (D)
C A A
TITANIUM (TI)
BUNA-N (NBR)
A C A
C B A C A C A A C
Teflon® (PTFE)
C
A
A
A A
A
U
A
U
A
A
C
C U U A U U
C U U U U U
A
A
A
U U U
U U
A U
C C C C A U C A C
A A U A C
A A U A C C
C U
C U A A A A
C
A
A
C
A
U
C
A
U
U
A U U
U U U
C
U A A C U
U U
U
U
A U A
U U
A C
C C U C
U U U
U A A U C A C
U A A U C A C
A A C C C A A A A A A
A A A
A A
U
A
A
A A
A A
U
A U
A
A
A
A
A
A
A
B
A U
A B
A
C
U
A A C C U A A A A A A
A
A A C U U A A C A
U A B C U B U B B
A A B
A A A
U
A
A
A
A
A A A A
U A U A
U A U A
C
A A A A A A A
A A A A A A A C
A A A
A B
A A
A A
C
A A B A
B
A
B B B U
C
A
A
A
U
A
A
A
B A B A
B A A
A A A A A
B A U U U
A
A
C A
U U U U U U U U U
A A
A A A A B A A A A A A A A A C U
A A B B B U B U A A U B C B B
A A
A C
A A A B A U A C A A A A
C
C B A U B U U U U
A
U U U
A A A A
U
A A A A A A A A A A A A
A A
A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A
U U C A U U U A A A A A A A A A A A B A A A B A A A A A A C A U
A
U A C A A A A A A A A A A A A
U U B
Kalrez®, Chemraz® (KPFE)
A
B B
C
Ethylene Propylene Diene Monomer (EPDM)
A
ELASTOMERS
Viton® (FPM)
A
Polyvinylidene Fluoride (PVDF)
A
CERAMIC (ALUMINA) (CC)
C C
HASTELLOY 'C'® (HC)
C
PLASTICS
304SS CHROME PLATED (SCP)
U
316 STAINLESS STEEL (SS)
C
304 STAINLESS STEEL (S)
C
CARBON STEEL (CBST)
CHEMICAL CALCIUM HYPOCHLORITE CALCIUM NITRATE CALCIUM PHOSPHATE CALCIUM SALTS ---- ABRASIVE CALCIUM SULFATE CALCIUM SULFIDE CANE SUGAR LIQOURS CARBAMATE CARBITOL CARBOLIC ACID (PHENOL) CARBON BISULFIDE *CARBON DIOXIDE CARBON DISULFIDE CARBONIC ACID *CARBON MONOXIDE *CARBON TETRACHLORIDE CASTOR OIL CATSUP CELLOSOLVE CELLOSOLVE ACETATE CELLULOSE CELLULUBE CHINA WOOD OIL (TUNG OIL) CHLORIC ACID CHLORINATED LIME CHLORINATED SALT BRINE --- ABRASIVE CHLORINATED SOLVENTS CHLORINATED BIPHENYL CHLORINE (ANHYROUS LIQUID) CHLOROACETIC ACID CHLOROACETONE CHLOROBENZENE CHLORO BROMOMETHANE CHLOROBUTADIENE CHLORODECANE *CHLOROFORM CHLORONAPTHALENE CHLOROPHENOL 5% CHLOROSULFONIC ACID CHLOROTOLUENE CHLOROX (BLEACH) CHOCOLATE SYRUP CHROMIC ACID 5% CHROMIC ACID 30% CHROMIC ACID 50% CIDER CINNAMON OIL CITRIC ACID CITRIC OILS CITRUS PECTIN LIQOUR CLOVE OIL COAL TAR COBALT CHLORIDE COCOA BUTTER COCONUT OIL COD LIVER OIL COFFEE COPPER ACETATE COPPER AMMONIUM ACETATE COPPER CHLORIDE COPPER CYANIDE COPPER FLUOBORATE COPPER NITRATE COPPER SALTS --- ABRASIVE COPPER SULFATE (5% SOLUTION) CORN OIL COTTON SEED OIL CREAM CREOSOLS CREOSOTE OIL CRESYLIC ACID CRUDE OIL CUMENE CUPROUS AMMONIA ACETATE
CAST IRON (F)
(See Legend Page for Detail)
NICKEL ALUM. BRNZ. (NAB)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
DUPLEX STAINLESS (SSD)
MATERIALS
A A A A A A A A A A A A A A A A A A
A A A A A B A A A A A A A A A
C C C
A A A
A
A
U A
A A
A A A U
C A
A A
A
A A A A
A A
A A A A
A A A A B A B A A
A
A A A
B
A
U U
A A A
U
A A
A
A
A
A
A
A
A
U
U
A
U
U
A
A
A
A
A
A
A
A
C
C
C
C
A
A
A
C
A A A A A A
A
A
A
A
A
B
B U
A
A A A
A
B
A
A
A
A
C C A
A
A A
A A A A A A A A
A
A A A A
A
A
A A
A A
A A
A A A
A A A
A
A
A A A A A A A A A A A A A
A
A A
A A A A
B
C
B
A A A A
A B
A
A
U
C C
A A
A B U A U A A A A A U U U U U U U U U U C C U C A A C
Viton® (FPM)
ACETAL (D)
A
A A
Polyvinylidene Fluoride (PVDF)
CERAMIC (ALUMINA) (CC)
TITANIUM (TI)
HASTELLOY 'C'® (HC)
A
A A A A A A A
C A C A
A A
A
A
A
U
B
A C
A
A A A
A A
A A U
A A A A A A A U U U B B U C C B A A A U C A A U
U
U
B A B U A
B
B
A A A U U A U B A U B B U
A U U U C U A
A A
A
A
U C U U U B
A A U C
A
U
U C A B U
Kalrez®, Chemraz® (KPFE)
A A A
A A
Ethylene Propylene Diene Monomer (EPDM)
A
A A
BUNA-N (NBR)
A
A A A
ELASTOMERS
Teflon® (PTFE)
U
A A A
PLASTICS
304SS CHROME PLATED (SCP)
A A U
DUPLEX STAINLESS (SSD)
A A U
316 STAINLESS STEEL (SS)
A A
304 STAINLESS STEEL (S)
CHEMICAL CUTTING OIL (WATER SOLUBLE) CUTTING OIL (SULFUR BASE) CYANIC ACID CYANIC COMPOUNDS CYANOGEN CYCLEHEXAMONE CYCLOHEXANE CYCLOHEXANOL CYCLOHEXANONE CYCLOHEXYLAMINE CYMENE DECALIN DECANE DEIONIZED WATER DENATURED ALCOHOL DETERGENT WATER SOLUTIONS DEVELOPING FLUIDS DIACETONE DIACETONE ALCOHOL DIAMYLAMINE DIBENZYL ETHER DIBENZYL SEBACATE DIBROMOETHYL BENZENE DIBUTYL AMINE DIBUTYL ETHER DIBUTYL PHTHALATE DIBUTYL SEBECATE DICHLOROBENZENE DICHLOROBUTANE DICHLOROETHANE DICHLOROHEXYLAMINE DICHLOROISOPROPYL ETHER DICHLOROPENTANE DIESEL FUEL DIETHANOLAMINE DIETHYLAMINE DIETHYL ANILINE DIETHYL BENZENE DIETHYL CARBONATE *DIETHYL ETHER DIETHYL FORMALDEHYDE DIETHYL HYDRAZINE DIETHYL MALEATE DIETHYL SEBACATE DIETHYL SULFATE DIETHYLAMINE DIETHYLBENZENE DIETHYLENE GLYCOL DIETHYLENE TRIAMINE DI-ISOBUTYL KETONE DI-ISOBUTYLENE DI-ISOOCTYL SEBECATE DI-ISOPROPYL BENZENE DI-ISOPROPYL KETONE DIMETHYL ANILINE DIMETHYL ETHER DIMETHYL-FORMAMIDE DIMETHYL PHTHALATE DINITROCHLORO BENZENE DINITROTOLUENE DIOCTYL PHTHALATE DIOCTYL SEBECATE DIOXANE DIOXOLANE DIPENTENE DIPHENYC,CHLORINATED DIPHENYC,OXIDES --- ABRASIVE DIPHENYL DIPHENYL OXIDE DOWTHERM® FLUIDS DRY CLEANING FLUIDS DYES,ABRASIVE DYES,WATER BASED EMBALMING FLUID
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
U A A
A A A A A A A B A
A A B A A A B B U C C B B U
U C
A^ A
A A A^ A A A A^ A A A A A A A^ A
U A B A
A A^
A U A A A B
A A
B U A A A U
A B U B B U B B B B U
U U U U
A A A^ A A A^ A A
A A A A A A A A A A A
A A A A
*FREON® 11 NOTE: INLET SEALS WILL *FREON® 12 (WET) HAVE LIMITED LIFE *FREON® 13 WHEN COMPRESSED *FREON® 13B1 GASES ARE PUMPED *FREON® 21 *FREON® 22 *FREON® 31 *FREON® 32 *FREON® 112 *FREON® 113 *FREON® 114 *FREON® 114B2 *FREON® 115 *FREON® 142b *FREON® 152a *FREON® 218 *FREON® 502
C
U
A
C
A
C A A
C A A
A A U
C U
C U U
C U
U C C
U U U
U U C C C
C A C U U
U
U
U
U
A C B B
U C U C B
B
C
B
A
A
A
A
U
C
U A A
C
C C
U
U
A U B
A
A
B
A
U
A
A
A
A
C
A
B
C
A
A
A
A A C
A A A
C A
B A
C A A
B B
A U A U C U A U
A U A U C U A U
A A A
A A A
A U U
A B A
A A A
A A A U U B A U
A
U C C C
U U U
Polyvinylidene Fluoride (PVDF)
A
ACETAL (D)
A
CERAMIC (ALUMINA) (CC)
B A A
Kalrez®, Chemraz® (KPFE)
A
B B B
B
Ethylene Propylene Diene Monomer (EPDM)
A
A A
A A A A A
Viton® (FPM)
C
A
BUNA-N (NBR)
A
B
A
A
A
A
A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A
U A A B U U U U C
U A A U U U U U C
B U U B A B B B A
A^ A A A^ A A A A A
U U
A A
U A
U B A U U U C U A U U U
U U A A A A U A
U B C B B C C B
A A A A A A A A
B A A
C A U
A A A
A A A
A
U U
B A
A A A A A A A A A A
A A A
A A A U A U A A A A A A C
A
A
A B
B A B A
A C U C A A
A U A C A A
U U U A B A A B A A A A B
U U U C A C B B B U U A B
U A U U A B A A
A C A
U
U
A
U
C
C
A
U
U
C A C C U
U A C C U
B A A A A
U B C B B
A A A A A
A U U B
A A A A A
A
A
A
A
A
A
A
A
C
A
A
A
A C U
ELASTOMERS
Teflon® (PTFE)
U
C
TITANIUM (TI)
B
C
A A A A A A
HASTELLOY 'C'® (HC)
C A
A A A A A
DUPLEX STAINLESS (SSD)
B
PLASTICS 304SS CHROME PLATED (SCP)
A A
A
A A A A A
316 STAINLESS STEEL (SS)
A
304 STAINLESS STEEL (S)
CHEMICAL EPICHLOROHYDRIN EPSOM SALTS (MAGNESIUM SULFATE) *ETHANE GAS ETHANOLAMINE ETHER COMPOUNDS ETHYL ACETATE ETHYL ACETOACETATE ETHYL ACRYLATE ETHYL ALCOHOL ETHYL AMINE ETHYL BENZENE ETHYL BENZOATE ETHYL BROMIDE ETHYL CELLOSOLVE ETHYL CELLULOSE ETHYL CHLORIDE ETHYL CHLOROCARBONATE ETHYL CHLOROFORMATE ETHYL DICHLORIDE *ETHYL ETHER ETHYL FORMATE ETHYL HEXANOL ETHYL MERCAPTAN ETHYL OXALATE ETHYL PENTACHLOROBENZENE ETHYL PYRIDRINE ETHYL SILICATE ETHYL SULFATE *ETHYLENE GAS ETHYLENE BROMIDE ETHYLENE CHLORIDE ETHYLENE CHLOROHYDRIN ETHYLENE DIAMINE ETHYLENE DIBROMIDE ETHYLENE DICHLORIDE ETHYLENE GLYCOL - ANTIFREEZE ETHYLENE OXIDE ETHYLENE TRICHLORIDE ETHYLENEDIAMINE FATTY ACIDS FERRIC CHLORIDE FERRIC NITRATE FERRIC OXIDE --- ABRASIVE FERRIC SULFATE FERROUS CHLORIDE FERROUS SULFATE FIBERGLASS RESIN-UNKOWN VARIABLES FISH OIL FLUORINATED CYCLIC ETHER FLUORINE FLUORO BENZENE FLUOROLUBE® FLUOROBORIC ACIDS FLUOROCARBON OILS FLUOROSILICIC ACID *FORMALDEHYDE (FORMALINE) FORMIC ACID
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
A
A A^ A A A A A A
B A C B A
A
C A C C A C A A
A A A^ A B^ A A A
A
A A A
A
A A
A A A A A B A A U B A U A A A U U A U A A A A
B^ A^ A A^
A^
FRUIT JUICES FUEL OIL FUMARIC ACID FURAN,FURFURAN FUFURAL GALLIC ACID GASOLINE 'HEAT' (LOW LUBRICITY) GELATIN GINGER OIL GLACIAL ACETIC ACID GLUCOSE GLUE SIZING GLYCERIN (GLYCEROL) GLCOLIC ACID GLYCOLS GOLD MONOCYANIDE GRAPEFRUIT OIL GRAPE JUICE GREEN SULFATE LIQUORS HEPTANE HEXACHLORO ACETONE N-HEXALDEHYDE HEXAMINE HEXANE HEXONE HEXYL ALCOHOL HONEY HYDRAULIC FLUIDS HYDRAZINE (WATER BASED) HYDRAZINE (ALCOHOL BASED) HYDROBROMIC ACID *HYDROCARBONS,LIGHT HYDROCHLORIC ACID (MURATIC ACID) HYDROCHLORIC ACID (30-37%) HYDROCYANIC ACID HYDROFLUORIC ACID (50% OR LESS) HYDROFLUORIC ACID (50% OR MORE) HYDROFLUOSILICIC ACID
U
A
C A
U A
U
C
A A C A A U
A
A A A
A A U A U U U B A B
U U C
U U U
A
A
A C A C
A A A
A
A
A
A A A U U U A U U U U U U A
*HYDROGEN CHLORIDE
C
C
*HYDROGEN PEROXIDE
C
C
U
*HYDROGEN SULFIDE
U
U
U
U
B
C
U
*HYDROGEN GAS
A
A
A
C A U U U U U
U U
B A B
B
B
U U U U U U B
U
C
B
C
U
A
B
C
A
U
A A
A A
C
A A
A A
A A
A B
A B C A A A
A B C A A A
A B A A A
A A B A
A
U U
A A A
B A A
U A A A A A A A
A A A
A A A A
A
A A A A A
A U A B
A A A
A A A A
A A A
A A A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A A
A
A A A U
A A A A U
C U A U U U A
C U A U U U A
C
C
C
C
C
C
A
B
C
C
C
C
A
A
C
B
A
A
A
A
A A
C A U U U U U A
A A
A
A
A
B B B U
A B A B B C A
C C A U U B A
C U A U C A
C C B U U B
INK (MAY BE ABRASIVE)
C
U
A
A
A A A A A A A A A C C A A A A A C A A A
U
U
U
U
A
U
A
B
A
A
A
U A A A
A A A B A A A
A A A C C A A
A C B B U A C C B U U C A
A
A
Kalrez®, Chemraz® (KPFE)
A A A A A A A A A A A A A
B
C
A
U
U
A
A^
A
U
B
B
A
A
A
A
U
U
A
A
A
B
A
U
U
U
B
A A A B
A A
A
B
A
ISO-BUTYRALDEHYDE
A
A A
A
A
A
A
A
A A A
A
A
A
A
A
A
U
U
A
A
B
A
A
ISOPHORONE
A
A
A
*ISO-BUTYLENE
A
A A A^
B
A
A
A
A
A
A
A A A A
A
ISO-BUTYL METHYL KETONE
A
A U A A A U A C
A A
U
ISO-BUTYL N-BUTYRATE
ISO-OCTANE
A A A A A A
A A A
C
A A
Ethylene Propylene Diene Monomer(EPDM)
A A A A A U U A
U B C B B U A
A
C
*ISO-BUTANE
Viton® (FPM)
BUNA-N (NBR)
A
A B U B A B
A
IODOFORM
ISOPROPANOL
U
A A A
A A
A
IRON SULFATE
ISO-PENTANE
U
A
IODINE PENTAFLUORIDE
ISO-BUTYL ALCOHOL
C A C A A A A A A A U A A A A C A A A A A A
A
A
INSECTICIDES (MAY BE ABRASIVE) IODINE
A U A A
A A B A A A C B A B A A A U U B C A A C A A A A A A U C B A
A
HYDROQUINONE HYDROXYACETIC ACID
A A A A
ELASTOMERS
A
*HYDROGEN BROMIDE U
Teflon® (PTFE)
C
A A A C C U
Polyvinylidene Fluoride (PVDF)
ACETAL (D)
CERAMIC (ALUMINA) (CC)
TITANIUM (TI)
HASTELLOY 'C'® (HC)
PLASTICS 304SS CHROME PLATED (SCP)
DUPLEX STAINLESS (SSD)
316 STAINLESS STEEL (SS)
304 STAINLESS STEEL (S)
CHEMICAL *FREON® C316 *FREON® C318 *FREON® BF *FREON® MF *FREON® TA *FREON® TC *FREON® TF *FREON® TMC *FREON® T-P35 *FREON® T-WD602
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
U
A A A
Ethylene Propylene Diene Monomer (EPDM)
A
U
U
B
A
B
A
A
A
ISO-PROPYL BENZENE A
A
A
A
A
A
A
A
A
U
A
U
A
U
A
B
U
U
A
ISOPROPYL CHLORIDE ISO-PROPYL ETHER
Kalrez®, Chemraz® (KPFE)
Viton® (FPM)
ELASTOMERS
BUNA-N (NBR)
U
A
Teflon® (PTFE)
ACETAL (D)
A A
Polyvinylidene Fluoride (PVDF)
CERAMIC (ALUMINA) (CC)
A
TITANIUM (TI)
B
A
HASTELLOY 'C'® (HC)
B
A
DUPLEX STAINLESS (SSD)
C
A
CHEMICAL
CARBON STEEL (CBST)
B
ISO-PROPYL ALCOHOL
(See Legend Page for Detail)
CAST IRON (F)
ISOPROPYL ACTEATE
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
316 STAINLESS STEEL (SS)
304SS CHROME PLATED (SCP)
PLASTICS
304 STAINLESS STEEL (S)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
A
A
A
JET FUEL (JP-1 THRU JP-6)
A
A
A
A
A
A
A
A
A
A
A A
A
A
A
U
A
KEROSENE
A
A
A
B
A
A
A
A
A
A
A
A
A
A
U
A
A
A
A
A
A
A
A
C
U
A
U
U
U
C
B
B
A
A
ISOTANE
KETONES LACQUERS
C
LACQUER THINNERS
A
C
A
C
C
A
A
A
C
LACTIC ACID (COLD)
C
C
U
U
A
A
C
A
A
A
LACTIC ACID (HOT)
C
C
U
U
A
A
C
A
A
A
A
LANOLIN A
LARD (ANIMAL FAT) LATEX --- ABRASIVE
A
A
C
A
A
A
A
A
A
A
B
A
B
U
A
U
U
U
U
A
U
U
U
B
A
B
A
A
A
A
C
A
U
A A
A A
A
A
B
A
A
A
B
A
C
A
A
A
A
B
A
U
A
U
A
B
U
A
A
A
B
LAVENDER OIL A
LEAD ACETATE
A
U
A
LEAD NITRATE C
C
LEMON OIL
A
A
A
LIGNIN LIQOUR
A
A
A
LIGROIN
A
LIME
A
LEAD SULFAMATE
A
U
A A
A
A
A A
A
U
A
A
U
A A
U
A
A
U
LIME BLEACH
A
A
A
LIME SULFUR
U
A
A
A
B
A A
A
A
A
A
A
B
A
B
A
B
B
U
LINDOL LINOLEIC ACID A
A
A
C
A
*LIQUID PETROLEUM GAS (LOW SEAL LIFE)
A
A
A
U
A
LIQUOR-PULP MILL
A
A
LINSEED OIL
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
C
C
A
A
A
LIQUOR SULFATE LITHIUM BROMIDE
A
A
LITHIUM CHLORIDE
C
C
A
LITHIUM HYDROXIDE
U
U
LUBRICATING OILS
A
A
A
A
A
A
A
A
LYE A
A
A
A A A
A
A
U
B
B
A A
A
A
A
A
A
A
A
A
A
MAGNESIUM ACETATE MAGNESIUM CARBONATE
A
A
MAGNESIUM CHLORIDE
A
A
U
C
B
B
C
A
A
A
A
A
A
A
A
A
MAGNESIUM HYDROXIDE
B
C
B
B
A
A
A
A
A
A
A
A
B
A
A
A
MAGNESIUM NITRATE
U
U
A
A
A
A
A
MAGNESIUM OXIDE --- ABRASIVE
A
A
A
A
A
A
A
A
MAGNESIUM SULFATE
A
B
A
B
A
A
A
A
A
A
A
A
A
A
C
A
A
A
A
A
A
U
A
MAGNESIUM SULFITE MALEIC ACID
C
C
C
B
C
C
A
A
A
MALEIC ANHYDRIDE
A
A
A
U
A
B
A
A
U
A
U
U
B
A
A
A
A
MALEIC HYDRAXIDE MALT LIQUORS A
MANGANESE CHLORIDE MANGANESE NITRATE MAYONNAISE
U
U
C
A
C
C
U
U
B
A
A
A
MELAMINE RESINS
U
U
U
MERCURIC CHLORIDE (DILUTE SOLUTION)
U
U
U
U
U
MERCURIC CYANIDE
A A U
MERCURY
U
U
MERCURY SALTS --- ABRASIVE
U
U
A
U
U
B
A
A
A
A
A
A
C
C
A
A
A
A
C
A
A
A
A
A
A
A
A
A A
B
A
A
A
A
A A
A
A
A
A
A
A
A
A
A
A
A
A
A
MERCURIOUS NITRATE
U
A
A
A
MESITYL OXIDE
U
U
B
METHACRYLIC ACID
U
U
METHANOL
A
A
A
B
A
A
METHYL ACETATE
A
A
A
METHYL ACETONE
B
A
A
A
A
A
A
B
A
A
U
A
A
A
B
A
METHYL ACRYLATE METHYL ALCOHOL METHYLAMINE
A
A
A
A
B
A A
B
A
A
A
A
A
B
A
A
B
A
A
B
A
U
U
A
U
A
U
U
A
B
C
U
U
B
A
A
A
A
A
B
A
A
B
C
ELASTOMERS
U
A
C
B
B
A
C
C
A
U
A
U
B
C
METHYL CHLORIDE
BRASS (BB)
C
C
A
C
A
A
A
METHYL CHLOROSILANCES A
METHYL CYCLOPENTANE
A
METHYL DICHLORIDE
A
U
A
B
*METHYL ETHER A
METHYL ETHYL KETONE
A
A
A
A
A
A U
B
U
A
U
A
A
A
U
A
U
U
A
A
A A
U
METHYL ISOPROPYL KETONE
A
A
A
A
A
A
A
A
A
METHYL METHACRYLATE
METHYLENE CHLORIDE
U
A
A
U
U
C
A
A
U
A
U
U
B
A
A
U
A
U
U
U
A
A
U
B
B
A
A
A
C
C
U
A
B
A
A
METHYLENE DICHLORIDE MILK
C
C
MINE WATER (HARDNESS AFFECTS WEAR)
A
A
MINERAL OIL
A
A
MINERAL SPIRITS
A
MOLASSES
A
A
U A A
U B A
A
U
B
A
A
B
A
U
A
A
U
B
C
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A A
A A
A A
A A
A
U
METHYL SALICYLATE A
A B
A
METHYL OLEATE METHYLENE BROMIDE
A
A
METHYL ETHYL KETONE PEROXIDE C
A A
U
METHYL FORMATE METHYL ISOBUTYL KETONE
Kalrez®, Chemraz® (KPFE)
A
BUNA-N (NBR)
A
Teflon® (PTFE)
A
Polyvinylidene Fluoride (PVDF)
A
A
ACETAL (D)
A
METHYL CELLUSOLVE
CERAMIC (ALUMINA) (CC)
U
TITANIUM (TI)
U
U
HASTELLOY 'C'® (HC)
A
A
304SS CHROME PLATED (SCP)
C
U
DUPLEX STAINLESS (SSD)
A
A
316 STAINLESS STEEL (SS)
U
A
CHEMICAL METHYL BROMIDE
304 STAINLESS STEEL (S)
A
A
(See Legend Page for Detail)
CARBON STEEL (CBST)
A
A
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
CAST IRON (F)
A
METHYL BUTYL KETONE
LEGEND
NICKEL ALUM. BRNZ. (NAB)
Ethylene Propylene Diene Monomer(EPDM)
PLASTICS
Viton® (FPM)
MATERIALS
A
A
A
A
A
A
A
A
A
A A
A
A
C
A
A
A
A
A
MONO BROMOBENZENE
A
MONO CHLOROBENZENE
A
U
C
U
MONO ETHANOLAMINE
A
U
U
A
A
A
A
A
A
A
A
A
A
A
A
A
MONOMETHYL ANILINE MONO METHYLETHER MONOVINYL ACETYLENE U
U B
C
B
A
A
A
A
A
C
B
A
NAPTHA
C
C
B
B
A
A
A
A
A
U
A
B
A
U
A
NAPTHALENE
C
C
B
A
A
A
A
A
A
U
A
U
A
U
A
NAPTHENIC ACID
C
C
A
A
A
A
A
U
*NATURAL GAS
A
A
A
A
U
A
A
B B
MURIATIC ACID (30%) MUSTARD
U
U
U
B
A
NEATSFOOT OIL NEVILLE ACID NICKEL ACETATE
A
U
C
A
A
C
C
A
C
C
NICKEL CHLORIDE --- ABRASIVE
A
U
U
NICKEL SULFATE
C
C
U
U
U
A
NICKEL NITRATE
A
A
A
A
C
A
B
U
A
A
A
A
A
A
A
A
B
A^
U
A A
B
A
A
A
A
A
A
A
B
A
B
A
A
A
A
U
A
NITRIC ACID,DILUTE
U
U
U
U
C
C
U
A
A
U
A
NITRIC ACID (5-10% SOLUTION)
U
U
U
C
C
U
A
A
C
U
A
U
A
NITRIC ACID (50% SOLUTION)
U
U
U
C
C
U
A
A
C
U
A
U
C
NITRIC ACID,RED & WHITE FUMING
U
U
U
U
U
U
A
U
A
U
C
NITROBENZENE
C
C
B
A
A
B
A
A
A
U
B
A
C
C
B
A
U
A
A
U
A
C
NITROBENZINE
B
B
NITROETHANE
A
U
U
B
NITROMETHANE
A
U
U
B
U
U
C
U
U
B
*NITROGEN GAS
A
A
A
A
NITROGEN TETRAOXIDE A
NITRO METHANE
A
A
NITROUS ACID
A
A
A
A
A
A
NITROPROPANE
A
U
U
A A
A
A
OCTACHLOROTOLUENE
U
A
U
A
OCTADECANE
A
A
U
A
N-OCTANE
B
A
U
A A
OLEIC ACID
C
B
OLEAM
C
C
OLIVE OIL
A
ORANGE OIL
A
C A
C
A
A
A
B
A
C
A
C
B
U
B
B
A
B
U
A
U
A
C
A
U
B
A
A
A
A
A
A
A
A
A
A
B
A
A
A
A
A
ORTHO-DICHLORO BENZENE
A
ORTHOCHLORO ETHYL BENZENE
A
A A
ORTHOCIDE
A
ORTHOCRYL
A
A
*OZONE PAINT (WITH XYLENE)
A
A
A
A
A
PAINT THINNER
A
PALM OIL
A
A
A
A
A
A
A
B
A
A
A
A
A
U
A
A
C
B
A
A
A^
C
U
A
A
A^
A
C
C
A A
A
U
B
A
A
A
A
A
A
A
B
A
U
A
A
PARAFORMALDEHYDE A
A
A
A
A
A
A
U
PECTIN LIQOUR A
PENTANE
B
B
C
C
B
A
B
A
A
A
A
A
A
A
A
PENTACHLORO PHENOC PERCHLORIC ACID
U
U
PERCHLOROETHYLENE
A
A
B
B
A
C
C
PETROLATUM
U
U
A
A
U A
A
A
A
PHATHALIC ANHYDRIDE
B
C
PHENOL
C
U
C
A
A
B
A
A
A
A A
A
U
A A^
A
A
U
A
B
A
A
C
A
U
A
B
A
A
A
A
A
B
C
A
A
*PETROLEUM ETHER
U
A
A
A
PARA-DICHLOROBENZENE PEANUT OIL
A A
PALMITIC ACID PARAFFIN (MOLTEN)
Kalrez®, Chemraz® (KPFE)
B
Ethylene Propylene Diene Monomer (EPDM)
B
Viton® (FPM)
ACETAL (D)
U
ELASTOMERS
BUNA-N (NBR)
CERAMIC (ALUMINA) (CC)
U
A
Teflon® (PTFE)
TITANIUM (TI)
C
C
Polyvinylidene Fluoride (PVDF)
HASTELLOY 'C'® (HC)
A
A
*OXYGEN (LIQUID)
DUPLEX STAINLESS (SSD)
C
A
316 STAINLESS STEEL (SS)
A
A
304 STAINLESS STEEL (S)
C
A
CARBON STEEL (CBST)
CHEMICAL OXALIC ACID
CAST IRON (F)
(See Legend Page for Detail)
NICKEL ALUM. BRNZ. (NAB)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
PLASTICS 304SS CHROME PLATED (SCP)
MATERIALS
A
A
A
C
A
U
A
B
A
PHENYL BENZENE
A
U
A
U
A
*PHENYL ETHYL ETHER
A
U
U
U
A
PHENYL HYDRAZINE
A
U
A
B
A
U
U
C
A
U
A
U
A
B
A
A
A
U
PHORONE PHOSPHORIC ACID,CRUDE
U
U
PHOSPHORIC ACID (50%)
U
C
PHOSPHORIC ACID,PURE
U
U
PHOSPHORIC ANHYDRIDE
U
U
U
U
U
U
A
U
C
C
U
U
C
C
U
A
A
PICRIC ACID
U
C
C
A
A
C
U
A
U
A
A
A
A
B
U
U
A
U
A
A
A
A
U
U A
A
A
U
U
C
A
A
A
U
A
A
A
A
A
PHOSPHOROUS TRICHLORIDE PHOTOGRAPHIC DEVELOPER
A
A
U
A
A
A
A
A
A
B
A
A
B
A
B
A
A
B
A
U
A
B
A
U
PINENE PINE OIL
U
C
A
A
PIPELINE CLEANER
A
A
A
A
A
B
A
A
A
A
U A
PIPERIDINE
U
A
U
U
PLATING SOLUTIONS ACID FLUOBORATE BATH
U
A
U
B
A
ACID SULFATE BATH
U
A
A
A
A
ANTIMONY BATH
A
A
A
A
A
A
A
A
A
A
A
ARSENIC BATH
A
A
A
A
A
A
C
A
A
A
A
BARREL CHROME BATH
U
C
U
C
C
A
U
A
U
A
A
A
A
A
A
U
C
A
A
U
A
U
C
A
A
A
C
A
A
A
A A
BARREL COPPER BATH BLACK CHROME BATH
C
A
BRASS BATH-REGULAR
A
A
BRASS BATH-HIGH SPEED
A
A
A
A
A
U
A
A
CHROMIC-SULFURIC BATH
C
A
U
U
A
A
U
U
A
COPPER-CADMIUM BRONZE BATH
A
A
A
A
A
A
C
A
A
A
A
COPPER FLUOBORATE BATH
U
U
A
U
A
U
U
C
A
B
A
A
A
A
C
A
A
A
A A
A
A
COPPER STRIKE BATH COPPER SULFATE BATH
U
A
U
A
A
A
A
A
A
COPPER-TIN BRONZE BATH
A
A
A
A
A
A
U
B
A
A
A
COPPER-ZINC BRONZE BATH
A
A
A
A
A
A
C
A
A
A
A
CYANIDE BATH
A
A
A
A
A
C
A
U
A
A
A
FERROUS AMMONIUM SULFATE BATH
A
A
A
A
A
U
U
C
C
U
U
C
B
U
C
U
C
U
A
U
A
A
A
FERROUS SULFATE BATH FLUOBORATE BATH
A
U
FLUORIDE BATH
U
FLUOSILICATE BATH
C
GOLD PLATE BATH
A
A
A
A
A
A
A
A
A
B
A
A
U
A
A
U
A
A
A
A
LEAD FLUOBORATE BATH
U
A
U
NICKEL FLUOBORATE BATH
U
A
U
ROCHELLE & POTASSIUM SALT BATH
A
A
A
U
B
A
A
A
A
A
U
B
A
A
A
A
A
A
A
A
B
A
ROCHELLE & SODIUM SALT BATH
U
RHODIUM BATH
U
U
U
A
SILVER PLATE BATH
A
A
A
B
SULFATE-CHLORIDE BATH
U
U
A
B
A
B
A
U
B
A
Kalrez®, Chemraz® (KPFE)
Viton® (FPM)
A
Ethylene Propylene Diene Monomer (EPDM)
BUNA-N (NBR)
U
ELASTOMERS
Teflon® (PTFE)
U
Polyvinylidene Fluoride (PVDF)
CERAMIC (ALUMINA) (CC)
A
ACETAL (D)
TITANIUM (TI)
U
TIN FLUOBORATE BATH
HASTELLOY 'C'® (HC)
PLASTICS 304SS CHROME PLATED (SCP)
DUPLEX STAINLESS (SSD)
316 STAINLESS STEEL (SS)
304 STAINLESS STEEL (S)
CHEMICAL
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
END OF PLATING SOLUTIONS POLYVINYL ACETATE
A
POLYVINYL ACETATE EMULSION
A
POTASH
C
B
A
A
A
U
U
A
A
B
A
C
A
C
POTASSIUM ACETATE POTASSIUM BICARBONATE
B
A A A
A
A
B
U
A
A
A
POTASSIUM BORATE
A
A
B
A
A
A
POTASSIUM BROMATE
A
A
A
A
A
A
C
U
POTASSIUM CARBONATE
U
U
A
POTASSIUM CHLORIDE
C
C
B
A
A
POTASSIUM BROMIDE
POTASSIUM CHROMATE POTASSIUM CUPRO CYANIDE
U
U
A
POTASSIUM CYANIDE
U
U
A
POTASSIUM DICHROMATE
U
U
A
POTASSIUM FERROCYANIDE
A
POTASSIUM HYDROXIDE
U
POTASSIUM NITRATE
A
U B
A
A
B
A
A
A
A
A
A
A
B
A
A
B
A
A
A
A
A
A
A
A
A
A
A
A
A
A
U
C
A
A
A
A
A
A
C
A
A
A
A
U
A
B
B
U
B
A
A
C
A
A
B
A
A
U
A
A
A
C
A
A
A
A
A
U
B
A
B
C
A
A
A
A
A
A
A
A
A
A
A
A
A
A
B
A
U
A
B
U
A
A
A
B
A
A
B
A
A
A
A
A
A
A
A
A
A
C
A
A
A
A
A
A
A
A
A
A
A
C
C
A
A
A
POTASSIUM PHOSPHATE
C
C
U
A
A
POTASSIUM SILICATE C
B
B
POTASSIUM SULFITE A
PRESTONE
A
B
B
A
A
A
A
A
U
B
A
A
B
A
PRODUCER GAS *PROPANE (NEEDS HIGH INLET PRESSURE)
A
PROPIONIC ACID
C
A
A
B
A
B
POTASSIUM PERFLUOROACETATE
C
A
A
POTASSIUM PERMANGANATE
POTASSIUM SULFATE
A A
A
A
C
A
A
A
B
A
A
B
A
A A A A
A
A
A
A
A
A
A
C
A
A
U
A
A
U
A
U
A A
PROPION --- ALDEHYDE
A
PROPYL ACETATE
A
U
U
B
N-PROPYL ACETONE
A
U
U
A
A
A
A
A
A
A
PROPYL NITRATE
A
U
U
B
A
PROPYLENE
A
U
A
U
PROPYLENE DICHLORIDE
A
U
A
PROPYL ALCOHOL
A
A
A
PROPYLENE GLYCOL
A
B
B
B
A
A
A
PROPYLENE OXIDE PYDAUIS
A
A
PYRIDINE
U
A
PYROGALLIC ACID
B
PYROLIGNEOUS ACID
C
C
B
B
A
A
A
B
A
B
A
A
U
A
C
U
RAPESEED OIL
A
A
RED OIL
C
C
A
B
A
U
U
U
C
B
A
A
A
A
A
A
U
A
C
A
A
A
A
A A
A A
U
C
B
A
A
A
A
A
C
C
A
A
B
A
A
A
A
A
C
A
B
SESAME OIL
A
A
SEWAGE
A
A
SHAVE CREAM
A A
SILICA GEL
A
A
U
A
A
A
A A
A
A
A
A
B
A
A
A
C
A
B
A
U
A A
A
A
C
A
A
A
C
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
U
A
A
A
A
A
A
A
A
B
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A
A A
A
A
A
U
B
A
A
A
B
A
A
U
U
A
A
B
A
U
A
A
A
A
A
A
A U
A
A
SILICONE TETRACHLORIDE SILVER BROMIDE
A
A
SILICATE ESTERS
SILVER NITRATE
U
A
A
A
A
SILICONE OIL, GREASE
A
U
A
SALT SOLUTION
SHELLAC
A
A
SESAME SEED OIL SEA WATER
B
A
A
SAL AMMONIAC SALICYLIC ACID
A^
C
RUM RUST INHIBITORS
U
A B
A
ROSE OIL ROSIN
U
A A
A
C
PYRROLE U
A U
A A
PYRANOL QUATERNARY AMMONIUM GERMICIDE
A U
A
A
A
C
A
A
A
A
A A
B
A
A
A
Kalrez®, Chemraz® (KPFE)
Ethylene Propylene Diene Monomer (EPDM)
A
Viton® (FPM)
BUNA-N (NBR)
A A
SIZING STARCH
ELASTOMERS
Teflon® (PTFE)
U
Polyvinylidene Fluoride (PVDF)
ACETAL (D)
CERAMIC (ALUMINA) (CC)
TITANIUM (TI)
HASTELLOY 'C'® (HC)
A
PLASTICS 304SS CHROME PLATED (SCP)
A
DUPLEX STAINLESS (SS)
U
316 STAINLESS STEEL (SS)
U
304 STAINLESS STEEL (S)
CHEMICAL SILVER SALTS
CARBON STEEL (CPST)
(See Legend Page for Detail)
NICKEL ALUM. BRNZ. (NAB)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
CAST IRON (F)
MATERIALS
A
SKYDROL® 500
A
A
A
U
U
A
A
SKYDROL® 7000
A
A
A
U
B
A
A
SOAP SOLUTIONS
A
B
A
SODA ASH (SODIUM CARBONATE)
A
A
A
SODA,CAUSTIC (20%)
C
C
SODA,CAUSTIC (50%)
U
U
SODIUM ACETATE
B
SODIUM ALUMINATE
A
C
A
A
A
A
B
A
A
A
A
A
A
A
A
B
A
B
A
A
A
A
A
A
A
A
A
A
A
U
U
A
A
C
C
A
A
U
C
C
C
A
A
A
B
A
B
U
A
A
C
A
A
B
B
A
B
A
A
A
A
A
A
B
A
A
A
A
A
A
A
A
U
U
A
A
C
C
C
C
A
A
A
A
SODIUM BISULFATE (HYPO)
C
C
U
U
A
A
A
B
B
A
B
A
A
A
A
A
SODIUM BISULFITE SODIUM BORATE SODIUM CARBONATE --- ABRASIVE SODIUM CHLORATE SODIUM CHLORIDE SODIUM CHROMATE SODIUM CITRATE SODIUM CYANIDE SODIUM FLUORIDE SODIUM HYDROSULFITE SODIUM HYDROXIDE (20%) SODIUM HYDROXIDE (50%) SODIUM HYPOCHLORITE >20% SODIUM HYPOCHLORITE SODIUM HYPOSULFATE SODIUM METAPHOSPHATE SODIUM METASILICATE SODIUM NITRATE SODIUM NITRITE SODIUM ORTHOPHENYLPHENATE SODIUM PERBORATE SODIUM PEROXIDE SODIUM PHOSPHATE-MONO SODIUM PHOSPHATE-DI SODIUM PHOSPHATE-TRI SODIUM POLYPHOSPHATE SODIUM SILICATE --- ABRASIVE SODIUM SULFATE SODIUM SULFIDE SODIUM SULFITE SODIUM TETRABORATE SODIUM THIOSULFATE SODIUM TRIPOLYPHOSPHATE SOLUBLE OIL SORGHUM SOY BEAN OIL SOY SAUCE SPERM OIL STANNIC CHLORIDE STANNIC FLUOBORATE STANNOUS CHLORIDE STARCH STEARIC ACID STEMRIC ACID STODDARD SOLVENTS STYRENE SUGAR SOLUTIONS SULFATE LIQOURS SULFITE LIQOURS SULFUR,MOLTEN SULFUR BASED CUTTING OIL SULFUR CHLORIDE *SULFUR DIOXIDE GAS SULFUR HEXAFLUORIDE SULFUR TRIOXIDE SULFURIC ACID (10%) SULFURIC ACID (75%) SULFURIC ACID-FUMING
C
C A A A B A
U C B
B
A A A A
A A A U
A A A A A A
A A A A A
A A A
B U
A C
A A A B B A U
A A
A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A
C A A B A A
B U
B A B A A B A A A A A A A A
A A A A A
U C C U C U U U C B B C
A A B A A A A A C
A
B B
A A A A A A
A
C B C C B
A U A A U C B
A C A A A A U
A
A
A A C A U B C A A A A A A A A A B A A A A A A A A A A C A A U A
A A A A
A A A
A
A A A A A A A A A A A A
A A A A A A A A A A
A A A A A
SODIUM ARSENITE SODIUM BICARBONATE
A
A
SODIUM BICHROMATE
A C A U
U U U
C C
C A C U A C C C U A
A U
A B U U
A A C
B C B
U C A C U C A C C C
C U U A A A A A A A
B C
U U A U A A A U U U A A
C U A A U A U U U C C
A C A A A A U
A A A U
A C C
U A C C
A U
A U U U
A C U C
B U U U
A B U
B B B
U U C C A A B
B
A C A U
U A A A A A A C A A U C
A A U C
U A C C
B C
U A
C A
U B
C C U U
C C U U
A U U U
B A B C
U A C
A C U
U U U
A A A A A A C A C A A A A A A A A B A A A A A U
A A
A A
A A C A A A A A A A C A C A A A A A A B A A A A A A A A U A C A A A A A A C
U
B C A A
A
A A A C
A A
A C A
A
A
A A C C
B B A A A A A B B A
A A A A A A A A
C
A
A
A A A A A A A A A A A A
C A C
A C U U B U A
B U
B C B B B C
A
A U
A C A A A A C
A
A
B
A A
A
A
B
A
A U A A
A
A A A A U A
A U A U C C
A A
A A
A A A A
A A A U
A
A
B U A U U B U C U U
A
A A A A A A A A B A A A B A
A A B
A A
A A A
A
A
A A A A A A
C
A
A A
A
B
A
U U
A A^
A A
B A
A A
A A B A A A A
U A B B U C
A A B^ A A A
A
A
C
A A C A A A C
A A C A A A C
A A A A
B A
A A
A A
B
A
A A A A A A
A
A
A
A
A
A
A
C
C
U
U
C
C
A
A
A U
A U
A A
A A
U
U
A
A
A
A
A
A
A
A
A
A A A A
C A
C
A A A A
A A A A
A
A
A A
A A
A
U
C A A A A A
C C A A
B
U
U
C A
A A A A A
A
A
A
A B
C A A
C A A
A C C
C
C
C
A A A A
A U C A A A
B
A
A
A
B A
A A B
A A A
B
A A A
A C U
A
C
A A
A
U
A
A
C
A
U
A A
A A
A A A
A A A A A A
C
A B
A A A
A A A A A A
A
A A
A A A
U U U
A A
A A
A
A B A A A
B
A
A A
A
A A
B
B
U
A
U
A
A B B U
A A A
A
A B
A
A A A
A A A A A A A
B
A
B
A
A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A A
A A
U A
A A A
A A A
A A A
A A A A
A
B
A
A A A A
Kalrez®, Chemraz® (KPFE)
B
Ethylene Propylene Diene Monomer (EPDM)
U
Viton® (FPM)
C
BUNA-N (NBR)
C
A A
A A
C A
A
A
A
ELASTOMERS
Teflon® (PTFE)
U
Polyvinylidene Fluoride (PVDF)
ACETAL (D)
C
CERAMIC (ALUMINA) (CC)
A A
TITANIUM (TI)
C A B A A A A
HASTELLOY 'C'® (HC)
C A A A
304SS CHROME PLATED (SCP)
U
DUPLEX STAINLESS (SSD)
U
316 STAINLESS STEEL (SS)
U
304 STAINLESS STEEL (S)
CHEMICAL SULFUROUS ACID SULFONATED FATTY ALCOHOLS SULFONATED VEGETABLE OILS SYNTHETIC DETERGENT TALLOW-HOT TANNIC ACID TANNING LIQOURS TANNING OIL TAR TARTARIC ACID TERPINEOL TERTIARY BUTYL ALCOHOL TERTIARY BUTYL CATECHOL TERTIARY BUTYL MERCAPTAN TETRA BROMOMETHANE TETRABUTYL TITANATE TETRACHLOROETHANE TETRACHLOROETHYLENE TETRAETHYL LEAD TETRAHYDROFURAN TETRALIN® THIONYL CHLORIDE TITANIUM TETRACHLORIDE TOLUENE (TOLUOL) TOLUENE DI-ISOCYANIDE TOMATO PULP TRANSFORMER OIL TRANSFORMER PYRANOL TRANSMISSION FLUID TYPE A TRIACETIN TRI-ARYL PHOSPHATE TRIBUTOXY ETHYL PHOSPHATE TRIBUTYL MERCAPTAN TRIBUTYL PHOSPHATE TRICHLOROACETIC ACID TRICHLOROBENZENE TRICHLOROETHANE TRICHLOROETHYLENE TRICHLOROPANE TRICHLOROPROPANE TRICRESYL PHOSPHATE TRIETHANOLAMINE TRIETHYLALUMINUM TRIETHYLBORANE TRIETHYLPHOSPHATE TRI-FLUORO-VINYL CHLORIDE TRINITROTOLUENE TRI-NORMAL-BUTYL PHOSPHATE TRIOCTYL PHOSPHATE TRIPOLY PHOSPHATE TRISODIUM PHOSPHATE TRICRESYL PHOSPHATE TRIPHENYL PHOSPHATE TUNG OIL TURBINE OIL TURPENTINE UNSYMMETRICAL DIMETHYL HYDRAZINE UREA FORMALDEHYDE URINE VARNISH VEGETABLE OIL VERSILUBE VINEGAR VINYL CHLORIDE VINYL PYRIDINE VINYLIDENE CHLORIDE VISCOSE VITRIOL OIL WATER,BOILER-TREATED WATER,DEIONIZED WATER,DISTILLED WATER,SALT WATER BASED SOLUBLE OIL WHISKEY & WINES
CAST IRON (F)
(See Legend Page for Detail)
NICKEL ALUM. BRNZ. (NAB)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
PLASTICS
CARBON STEEL (CBST)
MATERIALS
A A A A A A A A A A
A A A A C A B C B B U U U B U U B U U U B U U A A U A B U U U U B U U U A U B U U
A A A A A A A A A A A A A A A A U A B B C U A A A A U A A A U C A C A A A A U U A
A
C B C B B U U A U U C U C U U B
U A A A U B B
A A
A A A A A A A
A A A B^ A A
A
U U
A A A A A^ A A A
U A C C
A A A^ A A
U A U
A B
U
A
B
A
A
A U
C
U
A A
A A A U
C U U A
A B A B A A B A A C
A A A A C A
A A A
U C A A B A A
A A
A A
A
A
A A
A A
A C
U
A A A A
A A A A
A
A
C
C
U
C
U B
U C
C
A
C
U
C
C
U
A A
A A
A
A
A
A
A
C
C
B
A
A
C C
B
A
A A
B
A
A
C
A A A A A A A A A A A A
A A A U A
U U U
U
A
Kalrez®, Chemraz® (KPFE)
A
A B U C U A A B
Ethylene Propylene Diene Monomer (EPDM)
A A
Viton® (FPM)
U
ELASTOMERS
BUNA-N (NBR)
A
Teflon® (PTFE)
A A
A
Polyvinylidene Fluoride (PVDF)
A
A
ACETAL (D)
A
A
TITANIUM (TI)
A
C
CERAMIC (ALUMINA) (CC)
B
HASTELLOY 'C'® (HC)
A
A
PLASTICS 304SS CHROME PLATED (SCP)
A
A
DUPLEX STAINLESS (SSD)
C
316 STAINLESS STEEL (SS)
A
U
304 STAINLESS STEEL (S)
CHEMICAL WHITE GAS WHITE LIQOUR WHITE PINE OIL XYLENE XYLIDENES XYLOL YEAST ZEOLITE ZINC ACETATE ZINC AMMONIUM CHLORIDE ZINC CHLORIDE ZINC CYANIDE ZINC HYDROSULFITE ZINC NITRATE ZINC PHOSPHATE SOLUTION ZINC SALTS ZINC SULFATE
CARBON STEEL (CBST)
(See Legend Page for Detail)
CAST IRON (F)
A-GOOD B-FAIR C-QUESTIONABLE U-UNSATISFACTORY
BRASS (BB)
LEGEND
NICKEL ALUM. BRNZ. (NAB)
MATERIALS
A A
A A A A
A
A
A
A A
A
A
A
A A A A A A A A
