Cat.dcs.Sis.controller 320D

Cylinder #1 Injector Cylinder #2 Injector Cylinder #3 Injector Cylinder #4 Injector Cylinder #5 Injector Cylinder #6 Injector 8 Volt DC Supply Fuel Filter Differrential Pressure Sensor Engine Oil Pressure Sensor Engine Coolant Temperature Sensor Electrical System Voltage Intake Manifold Air Temperature Sensor Fuel Temperature Sensor Engine Speed Sensor Personality Module Engine Timing Calibration 5 Volt Sensor DC Power Supply Programmed Parameter Fault Secondary Engine Speed Sensor Fuel Pressure Sensor After Fuel Filter Inlet Air Heater Relay Fuel Rail #1 Pressure Valve Solenoid Intake Manifold Pressure Sensor Fuel Rail Pressure Sensor Ignition Key Switch Start Aid Current

Machine Control (MID No. 039) CID

Component

0041 0096 0127

8v Sensor Supply Fuel Level Sensor Transmission Pressure Sensor

0191

Transmission Output Speed Sensor

0262 0268 0298 0370 0374 0444 0590 0600 0726 0727 0735 0882 1130 1326 1401 1402 1482 1530 1558 1615 1617 1621 1622 1628 1629 1630 1657 1658 1960 2110 2104 2210 2129 2142 2149 2184 2185 2213 2214 2256 2447 2543 2544 2545 2546 2547 2592 2593 2594 2599 2600 2649 2665 2666 2667 2668

5v Sensor Supply Programmed Parameter Brake Ped Lim Sw Boom Float Solenoid Swing Brake Solenoid Start Relay Engine Control Hydraulic Oil Temperature Sensor Right Steering Solenoid Left Steering Solenoid Heavy Lift Solenoid Implement Lockout Solenoid Left Attachment Pedal Position Sensor ECM Location Code Transmission Solenoid 1 Transmission Solenoid 2 10v Sensor Supply Quick Coupler Solenoid Electronic Implement Control #2 One Way / Two Way Valve Solenoid Oscillating Axle Solenoid Generator Valve Solenoid Travel Lock Magnet Arm Rest Switch Main Pump Power Shift Pres Solenoid Swing Pump Sol Left Joystick Thumbwheel Right Joystick Thumbwheel Ignition Key Reader Machine Pitch Sensor Travel Motor Swash Plate Angle Limit Solenoid Right Joystick Thumbwheel Ride Control Solenoid Straight Travel Pedal Position Sensor Travel Pilot Pressure Solenoid Medium Pressure Hydraulic Circuit Port B Solenoid Medium Pressure Hydraulic Circuit Port A Solenoid Auxiliary Valve #2 Port B Solenoid Auxiliary Valve #2 Port A Solenoid Hydraulic Modulation Solenoid Travel Motor Bypass Solenoid Joystick Steering Enable Switch Offset Boom Offset Left Solenoid Offset Boom Offset Right Solenoid Hydraulic Cab Riser Raise Solenoid Hydraulic Cab Riser Lower Solenoid Auxiliary Valve Port A Flow Solenoid Auxiliary Valve Port B Flow Solenoid Hammer Solenoid Auxiliary Valve Port A Line Relief Solenoid Auxiliary Valve Port B Line Relief Solenoid Auxiliary Valve Load Sensing Solenoid Boom Float Down Solenoid Offset Boom Enable Switch Limp Home Sw Hydraulic Cab Riser Enable Switch

200 210 229 235 A209 A250

¹ The CID is a diagnostic code that indicates which circuit is faulty. ² The MID is a diagnostic code that indicates which electronic control module diagnosed the fault.

Failure Mode Identifiers (FMI)¹ FMI No.

Failure Description

0

Data valid but above normal operational range.

1

Data valid but below normal operational range.

2

Data erratic, intermittent, or incorrect.

3

Voltage above normal or shorted high.

4

Voltage below normal or shorted low.

5

Current below normal or open circuit.

6

Current above normal or grounded circuit.

7

Mechanical system not responding properly.

8

Abnormal frequency, pulse width, or period.

9

Abnormal update.

10

Abnormal rate of change.

11

Failure mode not identifiable.

12

Bad device or component.

13

Out of calibration.

14

Parameter failures.

15

Parameter failures.

16

Parameter not available.

17

Module not responding.

18

Sensor supply fault.

19

Condition not met.

20

Parameter failures.

Description Power Circuits Bat (+) Aux Ckt Key Sw Heater Relay Alt Output (+) Term. Main Power Rly Output Radio Warning Horn (forward) Cab Lamp Relay 12V Power Converter Wiper Control Alternator Diode 12V 7A Converter 1 Seat Heater A/C Air Suspension Cigar Lighter Engine Control Converter 12V Memory Out Converter 24V Switched In Unused Unused Caution Lamp Relay Switch Power Boom Lamp Relay Under Window Limit Switch Neutral Start Relay to Neutral Start Limit Sw Chassis Lamp Relay Caution Lamp Relay Refueling System Power Backup EPR Valve Sw Heater Relay / Product Link Radio and ECM A/C Unit Main Brkr 12V 7A Converter 2 Boom Float Disable Relay Machine ECM Radio Hydraulic Lock Action Alarm / Beacon Relay Ground Circuits Main Chassis Converter Output (24/12 Volt) 12V 7A Socket B Machine Control Ground Machine ECM Analog Return Engine Control Ground Basic Machine Circuits Starter Relay to Starter Motor Start Relay Coil to Neutral Start Relay Key Sw To Neutral Start Relay Main Power Relay Coil Alternator Regulator Term. Engine Control to Heater Relay Horn Relay Coil To Sw Travel Alarm Warning Horn (forward) Fuel Pump Power Fuel Pump Relay Cut-out Key Sw 'C' Term. Refueling Pwr Rly to Refueling Stop Rly Start Relay to Start Control Relay Travel Alarm Relay Refueling Stop Sw to Refueling Stop Relay Monitoring Circuits CAN 1 Data Link (+) CAN 2 Data Link (+) CAN 1 Data Link (-) CAN 2 Data Link (-) Alternator (R) Term. Engine Oil Pressure Action Alarm Coolant Level Air Cleaner Sw Hyd Oil Filter Sw Hyd Oil Temp Sender Fuel Level Signal Hyd Oil Level Engine Oil Level Boom Cylinder Rod End Pressure Boom Angle Sensor Stick Angle Sensor Machine ECM 8v Sensor Supply RH Thumb Wheel LH Thumb Wheel Overload Warning Switch Overload Warning Pressure Sensor Travel Straight Pressure Switch Travel Right Pressure Switch Travel Left Pressure Switch Joystick Pressure Switch Accessory Circuits Wiper - Front (low) Washer - Front Radio Speaker - Left Radio Speaker - Left (commom) Radio Speaker - Right Radio Speaker - Right (common) Washer Right Sw To Wiper Sw Wiper - Aux (Park) Wiper - Aux (Low) Washer - Aux Wiper Sw To Intermittent Module DC/DC Converter Power Output DC/DC Converter Memory Output Seat Heater Backup Resistor to Diode 1 Wiper Motor + Wiper Motor Wiper Motor Reverse Wiper Motor Stop Front Window Limit Sw To Wiper Cont Wiper Sw To Wiper Cont Hyd Lock Sw to Hyd Lock Solenoid Left Rear Speaker Left Rear Speaker (common) Converter 2 12V Switched Out A/C Controller To A/C Compressor Clutch Quick Coupler Sw

RD RD RD RD RD PU OR RD RD RD GY PK YL WH GN OR BU RD BU OR RD RD BR PU RD BU RD PU YL RD PK RD RD RD BU GN RD WH RD OR BK BK BK BK BK BK

304 306 307 308 309 310 320 321 322 323 325 326 329 330 331 365

WH GN OR YL GY PU RD BR GY WH PK RD YL YL OR YL

251 252 261 262 403 405 410 412 430 487 491 495 496 C468 E411 E441 E442 E472 E473 E474 E480 H446 H473 H474 H475 H476

YL YL GN GN GN GY WH BU BU OR PK GN WH BU YL GN GN GN GY OR PK PK BR GN BU WH

501 506 508 509 511 512 530 535 575 576 578 590 592 A513 A537 A549 A579 A580 A581 A582 A584 A586 A588 C560 C566 C569 E554 E562

GN PU PU WH BR GN OR BU YL PK BU GY BU RD PK BU OR BR GN PU BU OR GN OR PK YL PK PU

E564 E565

PK BU

603 607 615 616 638 645 646 684 A623

PK PK YL BU WH RD RD RD BU

763 779 780 788 789 A755 A756 A757 A758 A760 A762 A768 A769 A770 E787 F716 F772 F773 F774 G723 H746 H747 H792 K776 M736 M737 M739 M740 M743 M744 M745 M746 M747 M748 M749 M751 M755 N789 N793 N794 N795 R725 T725 X738 X794 877 892 893 F889 G834 K843 K844 K847 K848 K849 K850 K851 K852 K856 K857 K858 K859 K860 K861 K862 K863 K864 K865 K866 K868 K869 K871 K872 K876 K877 K879 L885 L886 936 998 E997 G973 G976 K904 K906 K907 K931 K950 K952 L968 L969 L972 L973 L976 L978 M906 N957 N959 N960 N963 N970 N973 N979 N981 T901 T902 T967

BU WH PU YL RD PK BU GY BR GY PU BU GY PK PK WH WH OR WH YL YL BR BR GN BU WH YL PK GN WH GY YL BU BR PK YL OR BU GN GY WH WH WH PK BU YL BR GN WH PU GN GY PU WH YL BR BU GN PU WH YL BR BU GN GY OR PK PU WH BR BU WH OR BR BU GN BU BU PU BR RD OR BU GN GN BU GN YL BR OR WH BU GN GN GY BU PK PK OR OR YL BR GN GN YL PK YL

Component Location Schematic Location

Machine Location

A/C Unit

K-9

C-1

Air Heater

F-18

A-1

Description

Component

Accessory Circuits (Continued) Quick Coupler Relays QC Sw to QC Relay 2 Lighting Circuits Rotary Beacon Flood Lamp - Front Cab Flood Lamp/ROPS Bucket Flood Lamp/Boom Flood Lamp Rotary Beacon Headlamp Relay Light Sw To Front Flood Relay Cab Flood Lamp Right Cab Flood Lamp Sw To Relay Control Circuits Travel Speed Solenoid Universal Quick Coupler Solenoid (Low) Universal Quick Coupler Solenoid (High) Engine Speed (-) Hydraulic Lock Throttle Sw #1 Throttle Sw #2 Throttle Sw #3 Throttle Sw #4 Machine Control +5v Supply Engine Speed (+) Backup EPR Valve Sw to Power Shift Pressure Solenoid Backup EPR Valve Sw to Power Shift Pressure Solenoid Backup EPR Valve Sw to Backup Resistor Bucket Lock Solenoid Secondary Shutdown Sw Crane Backup Sw Backup Governor Accel Backup Governor Decel Heavy Lift Solenoid Viscous Clutch Solenoid (+) Viscous Clutch Solenoid (-) Smart Boom Up/Down Relay to Boom Up/Down Pressure Sw Alternator L Terminal to Start Control Relay Governor Command Flow Limit Solenoid Flow Limit Solenoid Travel Straight Solenoid Boom Float Disable Relay Smart Boom Select Sw Boom Check Solenoid 1 / Boom Down Pressure Sw Smart Boom Select Sw Smart Boom Select Sw Boom Bown Pressure Sw / Boom Down Line Cutoff Solenoid Boom Check Solenoid 2 / Boom Up/Down Pressure Sw Crane Cancel Sw Bucket Extend Pressure Sw Viscous Clutch Temp Sensor Foot Pedal Sw Aux Pedal-LH Aux Pedal-RH Not Used Not Used Hammer Return Filter Sw Stick Out Stop Solenoid Heater Relay Cat Data Link (-) Cat Data Link (+) Engine Speed Command Viscous Clutch Fan Speed + RH Joystick Upper Sw LH Joystick Upper Sw RH Joystick Smart Boom Sw LH Joystick Fore Sw Att Stem 1 Att Stem 2 Att Stem 3 Att Stem 4 Stem 1 Control Valve A Stem 2 Control Valve A Stem 3 Control Valve A Stem 4 Control Valve A Stem 1 Control Valve B Stem 2 Control Valve B Stem 3 Control Valve B Stem 4 Control Valve B Relief Solenoid 1 Relief Solenoid 2 Att 1-way / 2-way Control Valve Stem 1/2 Extend/Retract Solenoids Stem 3 Extend/Retract Solenoids 1P / 2P Change Solenoids Single Action Solenoids 1 / 2 Relief 1 Check Solenoid Relief 2 Check Solenoid Double Action Solenoid Not Used Not Used Backup Resistor to Diode 3 Backup Governor Sw Hydraulic Lock Diode Boom Raise Pressure Sw Water Separator Level Sensor Pump 1 Pressure Sensor Swing Brake Solenoid Backup EPR Valve Sw Backup Resistor to Diode 2 Boom Up Limit PRV Boom Up Solenoid to Backup Crane Sw Bachup EPR Valve Sw PS Pressure One Touch Low Idle Sw Fine Swing Cont Sw to Fine Swing Solenoid Refueling Start Switch (N.O.) Level Sw to Leveling Solenoid Squeze Pressure Sensor Product Link RS232 Rxd - Comm #1 Product Link RS232 Rxd - Comm #3 Product Link RS232 Txd - Comm #1 Product Link RS232 Txd - Comm #3 Product Link RS232 Dtr - Comm #1 Product Link RS232 Dcd - Comm #1 Product Link RS232 Signal Gnd - Comm #1 Product Link RS232 Signal Gnd - Comm #3 MSS Exciter Coil In MSS Exciter Coil Out Pump Pressure Sensor 2

Alarm - Action

Connector Location Schematic Location

Machine Location

Sensor - Atch Viscus Clutch Temp

L-14

B-40

Sensor - Atch Wtr Separator Lvl 2

K-14

B-41

Component

F-1

C-2

Sensor - Eng Speed Pickup

E-18

A-4

Alarm - Atch Travel

A-16

B-2

Sensor - Fuel Level

A-15

B-15

Alternator

D-18

B-1

Sensor - Pump 1 Press.

A-18

B-16

L-4

C-7

Sensor - Pump 2 Press.

A-18

B-17

Atch Air Suspension Battery - Atch Front

F-17

D-1

Solenoid - A/C Clutch

D-18

B-20

Battery - Atch Rear

F-18

D-2

Solenoid - Atch 1p 2p Change 1 (Sol 2)

B-18

B-21

Battery - Front

F-17

D-4

Solenoid - Atch 1p 2p Change 2 (Sol 3)

B-18

B-22

Battery - Rear

H-18

D-5

Solenoid - Atch 1way/2way Change

B-9

B-49

Block - As

G-12

D-6

Solenoid - Atch Boom Up

L-9

C-54

Block - Gp

F-18

D-7

Solenoid - Atch Bucket Lock

L-9

C-53

Breaker - Alt

H-11

D-8

Solenoid - Atch Double Action (Sol 3)

B-18

B-23

Breaker - Heater

H-11

D-9

Solenoid - Atch Fine Swing

A-9

A-12

Breaker - Main

H-11

D-10

Solenoid - Atch Flow Limit

A-18

B-24

Bus Bar

H-11

D-3

Solenoid - Atch Heavy Lift

A-12

A-11

J-1

C-12

Solenoid - Atch Quick Coupler

J-15

B-25

Control - Engine

K-18

A-19

Solenoid - Atch Relief 1

B-11

B-48

Control - Machine

G-11

D-14

Solenoid - Atch Relief 1 Check

B-11

B-47

Control - PLJ

K-18

D-17

Solenoid - Atch Relief 2

B-9

B-50

Control - Product Link

L-17

D-12

Solenoid - Atch Relief 2 Check

B-9

B-51

Control - Wiper

D-2

C-88

Solenoid - Atch Single Action (1)

B-9

B-18 B-19

Coil - Atch Exciter

Converter - Atch 12V 7A (1)

K-4

C-4

Solenoid - Atch Single Action (2)

B-9

Converter - Atch 12V 7A (2)

K-4

C-3

Solenoid - Atch Stem 1 Extend

A-17

B-42

Converter - Radio

C-8

C-38

Solenoid - Atch Stem 1 Retract

A-17

B-43

Diode - ACC

J-5

C-22

Solenoid - Atch Stem 2 Extend

A-17

B-44

Diode - Alternator

G-6

C-31

Solenoid - Atch Stem 2 Retract

B-17

B-45

Diode - Heater

F-18

A-2

Solenoid - Atch Stem 3 Extend

D-16

B-52

Diode - Hyd Lock

J-5

C-23

Solenoid - Atch Stem 3 Retract

D-16

B-53

Diode - Lamp

G-9

C-24

Solenoid - Atch Stick Out Stop

L-9

C-55 B-39

Diode - Main Relay

D-9

C-25

Solenoid - Atch Viscus Clutch

L-13

Diode - Start Relay

H-12

D-13

Solenoid - Hyd Lock

A-12

A-13

Diode-1

K-9

C-26

Solenoid - Power Shift Press.

A-18

B-26

Diode-2

K-9

C-27

Solenoid - Swing Brake

A-12

A-14

Diode-3

K-9

C-28

Solenoid - Travel Speed

A-12

A-15

Fuse Base

G-8

C-30

Solenoid - Travel Straight

A-12

B-27

Indicator Unit

I-1

C-32

Switch - Air Cleaner

K-14

A-16

Joystick - Atch LH

L-3

C-13

Switch - Atch Aux Pump Press. (Stem 4)

L-1

C-58

Joystick - Atch RH

J-1

C-15

Switch - Atch Boom Raise Press.

B-12

B-29

Joystick - Atch RH (3 Sw)

J-1

C-16

Switch - Atch Bucket Ex Press.

B-12

B-28

Joystick- Atch LH (3 Sw)

L-3

C-14

Switch - Atch Buckup Crane

I-1

C-59

Keyreader - Atch Mss

J-2

C-17

Switch - Atch Crane Cancel

B-5

C-60

Meter - Atch Boom Potentio

B-9

B-7

Switch - Atch Fine Swing Cont

B-2

C-61

Meter - Atch Stick Potentio

C-9

A-6

Switch - Atch Foot

L-1

C-62

Meter - Service

E-1

C-33

Switch - Atch Hammer Return Filter

I-15

D-22

Monitor

G-1

C-34

Switch - Atch High Press. (Stem 1)

K-1

C-63

Motor - Atch Lower Washer

G-11

D-15

Switch - Atch Leveling

B-1

L-1

C-36

Switch - Atch Lower Washer

B-3

C-65

Motor - Starter

E-18

B-8

Switch - Atch Lower Wiper

B-2

C-66

Motor - Washer

G-11

D-16

Switch - Atch Medium Press. (Stem 3)

L-1

C-67

E-2

C-37

Switch - Atch Over Load Warning

B-4

C-68

Motor - Atch Lower Wiper

Motor - Wiper Pedal - Atch Aux LH

L-1

C-8

Switch - Atch Quick Coupler

B-1

C-69

Radio - Prod Link 2nd Generation

J-16

D-11

Switch - Atch Radio Mute

B-3

C-70

Relay - Atch Beacon

E-9

C-47

Switch - Atch Refueling Start

A-6

B-37

Relay - Atch Caution Lamp

F-10

C-40

Switch - Atch Refueling Stop

A-6

B-36

Relay - Atch Single

G-10

C-41

Switch - Atch Seat Heater

B-4

C-71 C-72

Relay - Boom Lamp

G-9

C-42

Switch - Atch Smart Boom Select

B-4

Relay - Cab Lamp

F-9

C-44

Switch - Atch Travel Straight Press.

K-1

C-73

Relay - Chas Lamp

F-9

C-43

Switch - Atch Under Window Limit

E-2

C-74

Relay - Heater

F-18

A-20

Switch - Backup EPR Valve

I-3

C-75

Relay - Horn

F-9

C-45

Switch - Backup Gov

I-3

C-76

Relay - Main

C-10

C-46

Switch - Coolant Level

L-13

A-17

A = See Area A

F-9

C-50

Switch - Disconnect

G-12

D-23

B = See Area B

Relay - Start

H-12

D-19

Switch - Eng Oil Level

D-18

B-32

C = See Area C

Relay - Start Cont

G-8

C-48

Switch - Horn

L-3

C-77

D = See Area D

Relay - Travel Alarm

E-9

C-39

Switch - Hyd Oil Filter

A-16

B-34

Resistor

C-3

C-51

Switch - Hyd Oil Level

A-16

B-35

Resistor - 2

D-6

C-52

Switch - Implement Press.

K-4

C-78

Resistor - Atch Backup

F-10

C-9

Switch - Key

I-1

C-79

Resistor - Backup

G-8

C-20

Switch - Neutral Start Limit

L-3

C-80

Resistor - Can 1

C-11

D-20

Switch - One Touch Low Idle

J-2

C-81

Resistor - Can 1 PLJ

C-10

D-18

Switch - Panel

E-2

C-82

Resistor - Can 2

C-11

D-21

Switch - Secondary Shutdown

H-9

C-83

Sender- Hyd Temp

A-16

B-13

Switch - Throttle Position

I-1

C-84

Sensor - Atch Boom Cyl Head Press.

C-9

A-8

Switch - Travel L Press.

K-1

C-85

Sensor - Atch Boom Cyl Rod Press.

C-9

A-9

Switch - Travel R Press.

K-1

C-86

Sensor - Atch O.L.W.D. Press.

A-9

A-10

Timer - Atch Lamp Delay

D-10

C-87

Sensor - Atch Squeeze Press.

B-11

B-46

Relay - Neutral Start

Machine Location

L-15, L-16, L-18 C-14, C-15, C-16 K-15, L-15, J-16, L-16 J-15, K-16 L-15 E-15 D-15 C-15, D-15 C-15 C-15 A-15 I-14 J-14 L-14 A-12, A-13 L-11 K-11 J-11 J-11 I-11 I-11 I-11 H-11 C-11 A-10 C-10 D-10 H-9 A-8 A-8 B-8 B-8, C-8 G-8 H-8 H-8 H-7 F-7 F-7 C-6, C-7 A-6 A-6 D-6 H-6 H-6 H-5 H-5 L-5 L-5 J-4, J-5 B-5 H-4 I-4, J-5, J-6 I-4 J-4 J-4 C-2 I-2 C-1 L-16 G-17 F-18 J-7 E-7 E-7 G-17

12D 7B 26D 23D 25D 9B 1B 36B 47B 6B 22B 14D 16D 43B 9A 2D 4D 1C 5D 13D 11D 128C 7D 22D 4A 19B 70C 14C 16B 14B 6A 13B 97C 3C 18C 19C 80C 96C 91C 40B 41B 68C 24C 20C 2C 99C 26C 17C 29C 54C 105C 23C 35C 30C 21C 127C 117C 90C 26D 19A 9A 19C 80C 96C 2B

Connector Number CONN 1 CONN 2 CONN 3 CONN 4 CONN 5 Serial Service Connector CONN 6 CONN 7 CONN 8 CONN 9 CONN 10 CONN 11 CONN 12 CONN 13 CONN 14 CONN 15 CONN 16 CONN 17 CONN 18 CONN 19 CONN 20 CONN 21 CONN 22 CONN 23 CONN 24 CONN 25 CONN 26 CONN 27 CONN 28 CONN 29 CONN 30 CONN 31 CONN 32 CONN 33 CONN 34 CONN 35 CONN 36 CONN 37 CONN 38 CONN 39 CONN 40 CONN 41 CONN 42 ET Connector CONN 43 CONN 44 CONN 45 CONN 46 CONN 47 CONN 48 CONN 49 CONN 50 CONN 51 CONN 52 CONN 53 CONN 54 CONN 55 CONN 56 CONN 57 CONN 58 CONN 59 CONN 60 CONN 61 CONN 62 CONN 63 CONN 64 CONN 65

C-64

Schematic Location

KENR6118-03 November 2009

Resistor, Sender and Solenoid Specifications Part No.

Component Description

102-8016

Resistor:

111-9916

Solenoid:

121-1491

Solenoid:

126-2941

Resistor:

163-6700

Sender:

11.7 ± 1.2

320D Excavator Electrical System

32 ± 3.2

Positions 1,2,3,4 = 25 ± 5% 0% - 83.5 ± 1.5 50% - 33.8 ± 2.0 100% - 8.0 +1.0 -0.5

120 ± 10%

34 ± 0.5

174-3016

Resistor:

234-4460

Solenoid:

Fine Swing

244-8506

Solenoid:

Relief 1

260-3877

Solenoid:

Quick Coupler

Sender:

47 ± 5%

Fuel Level CAN 1 CAN 2 CAN 1 PLJ Resistor Resistor 2

4I-5394

Resistance (Ohms)¹

Backup Flow Limit Power Shift Pressure Stem 1 Extend Stem 1 Retract Stem 2 Extend Stem 2 Retract Stem 3 Extend Stem 3 Retract Bucket Lock 1P / 2P Change 1 1P / 2P Change 2 Double Action Travel Straight Travel Speed Swing Brake Hydraulic Lock Universal Quick Coupler High Universal Quick Coupler Low Backup

A6F1-UP A8F1-UP A9F1-UP KGF1-UP KTF1-UP MGG1-UP

MCH1-UP FAL1-UP PCM1-UP BZP1-UP PHX1-UP JFZ1-UP

19.5 ± 2 26.96 ± 1.6

Hydraulic Oil Temperature

6134 to 7496

¹ At room temperature unless otherwise noted.

© 2009 Caterpillar, All Rights Reserved

Printed in U.S.A.

Harness And Wire Electrical Schematic Symbols Symbols

T

A = See Area A

Pressure Symbol

B = See Area B C = See Area C

Temperature Symbol

D = See Area D

Level Symbol

Circuit Breaker Symbol

Flow Symbol

Symbols and Definitions Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component.

Event Codes Engine Control Event Code

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

Off Machine Switch Specification Part No.

Condition

E096

High Fuel Pressure

E198

Low Fuel Pressure

E265

User Defined Shutdown

E360

Low Engine Oil Pressure

E361

High Engine Coolant Temperature

E362

Engine Overspeed

E363

High Fuel Temperature

E390

Fuel Filter Restriction

E396

High Fuel Rail Pressure

E398

Low Fuel Rail Pressure

E539

High Intake Manifold Air Temperature

E1044

High Intake Manifold Pressure

E1045

Low Intake Manifold Pressure

Related Electrical Service Manuals Title Alternator Engine Control: Machine Control:

Function

106-0179

Bucket Extend Pressure

154-0498

Air Cleaner Aux Pump Pressure Medium Pressure Travel Left Pressure Travel Right Pressure High Pressure Travel Straight Pressure Implement Pressure Boom Raise Pressure Boom Down Pressure

Form Number 212-8561

SENR2143 KENR5442 167-3466

RENR9848

202-9002

Actuate

Deactuate

Contact Position

1520 ± 98 kPa (220 ± 14 psi)

1127 kPa MIN (163 psi)

Normally Open

635 ± 58 mm H2O

-

Normally Open

490 ± 49 kPa (71.07 ± 7.11 psi)

290 kPa MIN (42.06 psi)

Normally Open

13780 kPa MAX (1998.6 psi MAX)

Boom Up/Down Pressure

10335 ± 689 kPa (1499 ± 100 psi)

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch. Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

T

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

Normally Closed

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness and Wire Symbols Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

1 2

Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...)

Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes

C-C4 130-6795

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)

Part Number for Connector Plug

AG-C3 130-6795

L-C12 3E-5179

AG-C4 111-7898

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

Socket

Part Number For Connector Recepticle

1

325-AG135 PK-14 Pin

Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

1 2

5A

Receptacle Pin or Socket Number

Single Wire Connector

9X-1123

Component Part Number

Plug

2

Harness identification code: This example indicates wire 135 in harness "AG".

Fuse (5 Amps)

Ground Connection

200-L32 BK-14 Circuit Identification Number

Wire Color

Wire Gauge

19

4 57

56 17

2

2 11

12

15 14

9

16

9

13

5 3

8 10

89

49

3

97

102 48

4

6

7

90

9

1

18

40

20

41

6

22 21

5 52

6 38 71 38

20

127 95

4

72 61 64

74

76

79

21 47

13

48

32 17

81

51 34

50

16

49

18

22 30

19

24 42 30 43 44 45 31 47 50

22 11 91 92 93 94

12 14 26

17 19

23

128

105

10

23

15

1

18

75

12 19

1

19

18

84

46

96 25 80

3

70 46

39

90

51

82

88

87

29

24

91

68 65 66 60

54

11

69

20

2

99 68

96

70

59

16 14

12

21 29

117

16

30 35

21

7

15

78 14 27 12 29

77 28

41

16 14

35

55 54

41 37 40 10 11 36

13

39

26

14 14 83

5 2 74

7

7 47 16 6 36 1

9

43

2

53

54

6 8

35 24

13 21

1 2

4

4

5 4 5

22

52 53

20

7

25

2

11 13

37

23

23

55 3

18 22 20

9

10 17

80

33

3

25 17

1

9

15

2

40

19

7

6

26 27 28 63

AREA A

13 21 22 23 31 33 42 43 44 45

AREA B

AREA C

86 36 85

73

67 8

58 62

32

8 26

AREA D

(Dimensions: 48 inches x 35 inches)

0001 0002 0003 0004 0005 0006 0041 0095 0100 0110 0168 0172 0174 0190 0253 0261 0262 0268 0342 0460 0617 1779 1785 1797 1834 2417

101 103 105 108 109 112 113 114 115 117 118 119 120 123 124 127 129 130 135 139 141 142 143 147 149 152 154 160 165 168 169 172 175 177 179 180 184 188 189 199

Component

Wire Wire Number Color

36 Page,

CID

Wire Description Wire Wire Number Color

KENR6118-03

Component Identifiers (CID¹) Module Identifier (MID²) Engine Control (MID No. 036)

12

11

10

9

8

7

6

5

4

3

BK-18

147-GJ6 PU-16 F772-GJ17 WH-16 K952-GJ25 BR-18 M739-GJ7 YL-18 235-GJ4 BK-18 603-GJ22 PK-18 936-GJ20 PU-16 A549-GJ24 BU-16 F772-GJ18 WH-16 K931-GJ19 GN-16 M751-GJ23 YL-18 235-GJ5 BK-18

A

A768-C64 A769-C65

M737-C77 M739-C135

(NOTE F,G,H,K,L,M,N,P)

18

WH-18 YL-18

147-GC5 K871-GC8 K866-GC3

OR-18

WH-18 BK-18

321-C40 487-C19 491-C20 496-C23 235-C173 235-C172 235-C172 235-C173 235-C176 235-C177 235-C175

GN-18 BK-18

K861-GF4 K868-GF13

K857-GF3 K868-GF14

(NOTE K,N,P

K856-GF1 K868-GF16

308-C126 308-C126 308-C182 308-C181 A768-C64 A769-C65 K904-C117 M737-C77 M739-C135 T967-C118 A209-C122 A209-C188 A209-C188 A209-C122 A209-C154 A209-C123

YL-16 YL-16 YL-16 YL-16 BU-18 GY-18 GN-18 WH-18 YL-18 YL-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

BR-18 OR-18 PK-18 WH-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

252-C101 262-C102

YL-18 GN-18

251-C103 261-C104

YL-18 GN-18

E997-C84

RD-18

184-C105 235-C106

RD-14 BK-14

N789-C192 E441-C153 E442-C161 K852-C38 A760-C180 H476-C30 A755-C24 A758-C27 L972-C33 184-C109 235-C110

BU-18 GN-18 GN-18 GN-18 GY-18 WH-18 PK-18 BR-18 BU-18 RD-14 BK-14

M906-C111

BU-18

A209-C112 A756-C25 A757-C26 K848-C54 K844-C53 308-C113

BK-18 BU-18 GY-18 WH-18 GY-18 YL-16

N794-C58 N795-C59

GN-18 YL-18 GN-18 YL-18

321-C40 235-C177

BR-18 BK-18

496-C23 235-C176

WH-18 BK-18

235-C178 487-C19

17

603-F133 200-F134 199-F69 199-F135 638-F91

PK-18 BK-18 OR-18 OR-16 WH-16

147-F58 331-F187 147-F58 147-F83 321-F44

PU-18 OR-18 PU-18 PU-16 BR-18

GY-16

GY-18 BR-18

PK-18

L978-A30

309-A153 321-A122

A770-A141

YL-16

YL-16 308-A108

330-A55

BU-16

GY-16 YL-16 RD-18 BU-16 WH-16 RD-16 PK-18

616-A13

607-A21 154-A23 127-A124 306-A20 124-A86 307-A24 175-A87 320-A14 184-A11

322-A15 120-A1 172-A9 179-A64 638-A19 105-A10 169-A5

RD-14

PK-16 RD-18 OR-16 GN-16 GN-14 OR-16 RD-14 RD-18 RD-14

130-A125

GN-18

CONN 63

RD-16 RD-16 RD-16 OR-16 PU-16 PU-16 RD-18 OR-18 GN-16 OR-16 RD-18 BR-18 GY-16 OR-18 PK-18 PK-18 PK-16 YL-16 BU-16 WH-16 RD-18 RD-18 BK-18 BK-18

200-F136 200-F134 200-F203 200-F68 200-F138 200-F139 200-F140

BK-18 BK-18 BK-18 BK-14 BK-16 BK-16 BK-16

CONN 27

308-F144 308-F104 308-F141

GY-18 WH-18

177-A71 177-FA1 603-GW22 200-GW28

YL-18 YL-16 YL-18 RD-6 RD-4

PK-18 BK-18

105-F137 200-F138 308-F141

RD-16 BK-16 YL-18

308-F141 308-F104 308-F144

YL-18 YL-16 YL-18

308-F145

YL-18

200-F146 308-F145

BK-18 YL-18

308-F145 200-F140

YL-18 BK-16

112-FC1

PU-4

177-FA1

RD-4

RD-18 RD-18

OR-18 OR-18

684-F130 646-F32

RD-18

139-AJ9 113-AJ1

684-WH1

BK-18

PK-18

235-C175 235-C178

BK-18

BK-18 OR-18

235-F112 893-F142 892-F143 105-F40

ET CONN

OR-18 BK-18 WH-18 GN-18 PK-16 RD-16 PU-18 BR-18

113-AJ1 200-AJ3 509-AJ4 512-AJ5

OR-18 BK-18 WH-18 GN-18

103-AJ6 508-AJ7 511-AJ8

F772-GM1 147-GM2 235-GM3 M739-GM4 K952-GM5

309-F99 120-F55 124-F65 127-F60 130-F75 154-F93 168-F73 168-F123 169-F18 172-F10 175-F72 179-F56 184-F74 306-F92 307-F94 320-F85 321-F44 322-F86 330-F71 607-F87 616-F84 638-F91 A770-F66 K776-F205 L978-F199 308-F104 105-F102 403-F201 200-F68

GY-18 YL-16 GN-14 OR-16 RD-14 RD-18 RD-10 RD-14 PK-18 RD-18 RD-14 BU-16 RD-14 GN-16 OR-16 RD-18 BR-18 GY-16 YL-16 PK-16 BU-16 WH-16 PK-18 GN-18 GY-16 YL-16 RD-16 GN-18 BK-14

118-F90 152-F59 615-F129

GY-16 BU-16 YL-16

200-G35 A537-G9

BK-18 PK-18

998-G14

BR-18

F774-G28 F773-G29

CONN 39

1113-F185 139-F186

OR-18 OR-18

PK-18 BU-16 YL-18 BK-18

H475-A146 235-A148

BU-18 BK-18

H474-A147 235-A149

GN-18 BK-18

K849-A150 235-A151

YL-18 BK-18

H473-A38 235-A118

BR-18 BK-18

K

K906-G5

GN-18

A768-G6

BU-18

RD-16 PU-18 BR-18

BK-18

A769-G7

GY-18

WH-16 PU-16 BK-18 YL-18 BR-18

235-G38 235-G37 L968-G13 F889-G16 M736-G11 A770-G15 L969-G12 169-G31 K907-G10

BK-18 BK-18 OR-18 WH-18 BU-18 PK-18 WH-18 PK-18 BU-18

YL-16 BK-18 YL-18 GN-18 YL-18 PK-18

CONN 57

T902-M12 T901-M11 607-M1 200-M2 235-M3 A755-M4 A756-M5 A757-M6 A758-M7 308-M8 326-M23 307-M9 105-M10 113-M13 200-M14 509-M15 512-M16 607-M17 103-M18 508-M19 511-M20

PK-18 YL-18 PK-16 BK-18 BK-18 PK-18 BU-18 GY-18 BR-18 YL-16 RD-16 OR-16 RD-16 OR-18 BK-18 WH-18 GN-18 PK-16 RD-16 PU-18 BR-18

113-M13 200-M14 509-M15 C566-M22 512-M16 607-M17 103-M18 508-M19 C560-M21 511-M20

OR-18 BK-18 WH-18 PK-18 GN-18 PK-16 RD-16 PU-18 OR-18 BR-18

C560-M21

OR-18

C566-M22

PK-18

I

F772-GM1 K952-GM5 M739-GM4 235-GM3 147-GM2

WH-16 BR-18 YL-18 BK-18 PU-16

H

CAB

511-F118 512-F119

PU-16 PK-18 BU-16 GN-16 WH-16 YL-18 BR-18 BR-18 YL-18 BK-18 YL-18

508-F120 509-F121

200-F116 200-F116 200-F149 200-F149 200-F155 200-F161 615-F129 615-F129 615-F163 615-F164

BR-18 GN-18

615-F163

YL-16

615-R1

YL-16

615-R1

YL-16

200-F161

BK-16

200-R2

BK-16

200-R2

BK-16

615-F164

YL-16

615-T1

YL-16

615-T1

YL-16

200-F155

BK-16

200-T2

BK-16

(24V,70W)

PU-18 WH-18

(24V,70W) BK-16

103-F96 RD-16 A584-F169 BU-18 200-F157 BK-18 200-F162 BK-16

YL-16

200-U2

BK-16

616-V1

YL-16

200-V2

BK-16

G

(NOTE S)

200-F157

BK-18 BU-18

403-F4 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18 495-F1 GN-18 496-F5 WH-18 C468-F9 BU-18 200-F160 BK-16 251-F189 YL-18 251-F23 YL-18 251-F147 YL-18 251-F147 YL-18 261-F152 GN-18 261-F52 GN-18 261-F51 GN-18 261-F51 GN-18 308-F144 YL-18 892-F12 BR-18 893-F11 GN-18 103-F7 RD-18 103-F7 RD-18 103-F24 RD-18 200-F8 BK-18 200-F8 BK-18 103-F27 RD-18

495-F1

GN-18

491-F3 403-F4

PK-18 GN-18

405-F62 C468-F9 412-F2 496-F5

GY-18 BU-18 BU-18 WH-18

152-F59 BU-16 403-F76 GN-18 535-F117 BU-16 535-F124 BU-16 535-F151 BU-16 200-F166 BK-18 199-F165 OR-18 118-F90 GY-16 506-F103 PU-18 A584-F169 BU-18

251-F147 261-F51

YL-18 GN-18

410-F89

WH-18

410-F89

WH-18

199-F165 410-F89

OR-18 GN-18 OR-18 GY-18 OR-18 BK-18

OR-18 WH-18

410-F89

WH-18

103-F27

RD-18

200-F166

BK-18

403-F76

GN-18

152-F59

BU-16

535-F151 535-F124 535-F117 129-F57

OR-16 OR-16 YL-18

F

103-F24 RD-18 308-F144 YL-18 893-F11 GN-18 892-F12 BR-18 200-F8 BK-18

200-F166 BK-18 200-F8 BK-18 200-F160 BK-16 200-F168 BK-16 200-F180 BK-18

YL-18 GN-18

165-GX8

616-U1

103-F96 RD-16 200-F162 BK-16

BK-18 GN-18 BR-18 RD-16

YL-18 YL-18 BK-18

200-T2

BK-14 BK-14 BK-16 BK-16 BK-16 BK-16 YL-16 YL-16 YL-16 YL-16

A584-F169

165-GX8 M751-GX4 235-GX5

J

BU-18

T902-G53 PK-18 T901-G52 YL-18 607-G30 PK-16 200-G33 BK-18 235-G39 BK-18 A755-G23 PK-18 A756-G24 BU-18 A757-G25 GY-18 A758-G26 BR-18 308-G18 YL-16 326-G54 RD-16 307-G20 OR-16 105-G8 RD-16 113-G44 OR-18 200-G45 BK-18 509-G46 WH-18 512-G47 GN-18 607-G48 PK-16 103-G49 RD-16 508-G50 PU-18 511-G51 BR-18

WH-18 OR-18

235-G38

262-F150 GN-18 252-F153 YL-18

252-F20 262-F19

BU-18 BK-18

BU-16 BU-16 BU-16

535-F148

BU-16

535-F148

BU-16

E

BU-16

200-F122

BK-16

113-F81 331-F187 430-F33 487-F34 501-F28 530-F29 590-F67 645-F88 646-F32 780-F30 A586-F26 G976-F36 X738-F35 251-F100 251-F109 251-F189 251-F189 261-F52 261-F52 261-F50 261-F48 200-F25 200-F181 199-F165

OR-18 OR-18 BU-18 OR-18 GN-18 OR-18 GY-18 RD-18 RD-18 PU-18 OR-18 BU-18 PK-18 YL-18 YL-18 YL-18 YL-18 GN-18 GN-18 GN-18 GN-18 BK-18 BK-18 OR-18

199-F165 200-F181 E480-F43 L973-F110

OR-18 BK-18 PK-18 GN-18

L886-F13

BU-18

L885-F39

BU-18

R725-F38

WH-18

T725-F37

WH-18

165-F196

YL-18

113-F81 200-F25 251-F109 261-F50

OR-18 BK-18 YL-18 GN-18

430-F33 487-F34 X738-F35 G976-F36 T725-F37

BU-18 OR-18 PK-18 BU-18 WH-18

A579-F176 A580-F177 A581-F178 A582-F179 200-F168 200-F168

R725-F38 WH-18 E480-F43 PK-18 L886-F13 BU-18 L973-F110 GN-18 780-F30 L885-F39 530-F29 590-F67 A586-F26 501-F28 646-F32 645-F88 331-F187 165-F196

PU-18 BU-18 OR-18 GY-18 OR-18 GN-18 RD-18 RD-18 OR-18 YL-18

261-F48 251-F100

GN-18 YL-18

OR-16 BR-16 GN-16 PU-16 BK-16 BK-16

A579-F176 OR-16 A580-F177 BR-16 A581-F178 GN-16 A582-F179 PU-16 A586-F26 OR-18 590-F67 GY-18 501-F28 GN-18 530-F29 OR-18 200-F180 BK-18

D

506-F103 PU-18 118-F90 GY-16 A584-F169 BU-18

200-F168

BK-16

CONN 58

CONN 56 251-F100 261-F48

YL-18 GN-18

CONN 58

CAB

CONN 10

C

308-GF24 A209-GF19 M906-GF12 K876-GF7 K864-GF10

YL-18 BK-18 BU-18 BR-18 PK-18

M739-GF22 235-GF23 235-GF20

YL-18 BK-18 BK-18

235-GF18 235-GF17

BK-18 BK-18

K866-GF9 K877-GF8 K865-GF11 K856-GF1 K857-GF3 K860-GF2 K861-GF4

WH-18 BU-18 PU-18 PU-18 WH-18 BU-18 GN-18

K868-GF5 K868-GF15 K868-GF16

BR-18 BR-18 BR-18

M755-GW15 235-GW24

G973-GC1 235-GC2

251-EL7 261-EL10

K864-GF10 M739-GF22

PK-18 YL-18

K876-GF7 235-GF20

BR-18 BK-18

308-GF24 A209-GF19 M906-GF12

OR-18 BK-18

YL-18 GN-18

K866-GF9 235-GF18

YL-18 BK-18 BU-18

K865-GF11 M739-GF21

K877-GF8 235-GF17

K872-GC12 200-GC19

GY-18 GN-18 BK-18

616-C9 200-C98

WH-18 BK-18

BU-16 BK-16

616-AR1 200-AR2

CONN 32

M740-C74 235-C185

168-X16 329-X17

BU-16 BU-16 BK-16 BK-16

RD-18 YL-18

325-C174

GN-18 BK-18

763-C75 BU-18 A588-C167 GN-18 G723-C92 YL-18 K906-C62 GN-18 M740-C74 200-C171 235-C170 235-C170 235-C93 235-C86 235-C85 235-C185

PK-18

BK-18 BK-18 325-WJ1

PK-18

325-WJ1

PK-18

PK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

763-C75 235-C86

K906-C62 235-C93

PU-18 YL-18

616-AV1 200-AV2

BU-16 BK-16

(NOTE C)

BU-18 BK-18

322-E2 200-E4

GY-16 BK-16

OR-18 BK-18

322-C6 200-C97

607-C7 200-C96

GY-16 BK-16

322-E1 200-E3

322-E2 322-E1 200-E3 200-E4

GY-16 BK-16

GY-16 GY-16 BK-16 BK-16

PK-16 BK-16

168-X15 168-X14 168-X14 168-X13 168-X1 323-X12 329-X18

RD-18 RD-18 RD-18 RD-18 RD-10 WH-10 YL-18

NOTE A: USE WITH COLD WEATHER. NOTE B: USE WITH JUMP START. L976-X9 365-X6 200-X4

GN-18 YL-18 BK-18

329-X18

YL-18

NOTE C: USE WITH LONG BOOM.

W RE GROUP COLOR DESCR PT ONS

NOTE D: USE WITH SHORT BOOM. NOTE E: USE WITH LAMP DELAY TIMER.

GROUND C RCU T

NOTE F: USE WITH CONFIG.1,3'.

W RES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SW TCH S OFF

NOTE G: USE WITH CONFIG.2.

W RES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SW TCH S ON

NOTE H: USE WITH CONFIG.11.

VOLTAGE CONVERTER OUTPUT C RCU T

NOTE J: USE WITH SHOVEL CRANE.

START NG C RCU T

L976-X19 L976-X10

A588-C167 200-C171

GN-18 BK-18

PILOT MANIFOLD CONTROL VALVE

CONN 15

15

14

13

12

200-C98 200-C97 200-C96 200-C95 200-C169

11

168-C51 200-C95

BK-16 BK-16 BK-16 BK-10 BK-18

168-C51 RD-10 322-C6 GY-16 325-C174 PK-18 607-C7 PK-16 616-C9 BU-16 200-C169 BK-18 200-C169 BK-18 L973-C80 GN-16

325-C174

L973-C80 200-C169

GN-16 BK-18

CONN 25

10

PK-18 PK-18

GY-16 PU-16 BK-18 BK-18

PK-18 GN-16 607-F154 L973-F14

607-F154 607-F200

PK-18 PK-18 BU-16 YL-18 PK-18 BK-18 BK-18 607-F159 607-F200 535-F151 575-F106 576-F107 200-F158 200-F156

L978-F199 147-F198 200-F197 200-F156

OR-16 OR-16 BK-18 BK-18

147-F188 PU-16 200-F181 BK-18 200-F197 BK-18

PK-18 PK-18

139-F186 113-F185 200-F170 200-F158

CAB

START A D C RCU T

L976-X19 GN-18 365-X7 YL-18 168-X15 RD-18

PK-18 BK-18

GN-18 BK-18

PK-18 PK-18 BU-18 YL-18 WH-18 BK-18 BK-18

CONN 50

OPERATOR STATION

YL-18 BK-18

BU-18 BK-18

607-F193 607-F159

WH-10 BK-10

BU-16 BK-18 BK-18

BU-16 BK-16

616-AV1 616-AR1 200-AR2 200-AV2

BU-16 BK-16

CONN 31

BR-18 BR-18

616-AE1 200-AE2

323-X12 200-X5

(NOTE D)

K872-GC11 OR-18 200-GC9 BK-18

G723-C92 235-C85

BU-16 BU-16 BK-16 BK-16

535-F124 200-F194 200-F170

CONN 32

616-AE1 616-AC1 200-AC2 200-AE2

PK-18 PK-18 BU-16

YL-16 BK-18 PK-18

BU-16 BK-16

607-F171 607-F193 578-F105

308-GW3 A209-GW6 H446-GW7

616-AC1 200-AC2

607-F172 607-F171 M747-F42 M746-F192 M744-F195 200-F167 200-F194

YL-16 BK-18 YL-18

A760-GW13 E441-GW10 235-GW26

K872-GC11 OR-18 K872-GC12 OR-18 200-GC9 BK-18 200-GC19 BK-18 200-GC10 BK-18

OR-18 BK-18

308-GW2 A209-GW5 E411-GW8

PK-18 BK-18 BK-18

YL-18 GN-18

GY-18 GN-18 BK-18

E480-F43 200-F183 200-F167

251-EL8 261-EL11

CONN 24

A760-GY3 E442-GY2 235-GY1

PK-18 PK-18 BK-18

YL-18 GN-18

GY-18 GN-18 BK-18

607-F184 607-F172 235-F46

251-C133 261-C132

CONN 26 A760-GW14 E442-GW11 235-GW27

WH-18 BK-18 BK-18

YL-18 GN-18

123-F64 200-F173 200-F183

308-GW2 YL-16 308-GW3 YL-16 A209-GW5 BK-18 A209-GW6 BK-18 A760-GW13 GY-18 A760-GW14 GY-18 E411-GW8 YL-18 E441-GW10 GN-18 E442-GW11 GN-18 H446-GW7 PK-18 235-GW26 BK-18 235-GW27 BK-18 M755-GW15 OR-18 235-GW24 BK-18

252-C131 262-C130

PK-18 PK-18 OR-18 OR-18 PK-18 BK-18

YL-16 YL-16 YL-16 YL-16 BK-18 BK-18 BK-18 BK-18 GY-18 GY-18 GY-18 GY-18 YL-18 GN-18 GN-18 PK-18 OR-18 BK-18 BK-18 BK-18 BK-18 BK-18

PK-18 PK-18 PK-18

GN-18 GN-18 GY-18 OR-18 YL-18 YL-18 YL-18 BU-18 PK-18 WH-18

308-GW1 308-GW1 308-GW3 308-GW2 A209-GW4 A209-GW4 A209-GW6 A209-GW5 A760-GW12 A760-GW12 A760-GW13 A760-GW14 E411-GW8 E441-GW10 E442-GW11 H446-GW7 M755-GW15 235-GW24 235-GW25 235-GW25 235-GW26 235-GW27

607-F174 607-F184 A537-F108

E441-C153 E442-C161 A760-C186 M755-C179 M751-C168 K950-C44 M739-C183 X794-C150 E787-C152 F772-C83

147-GW9 PU-16 E787-GW20 PK-16 F772-GW21 WH-16 K950-GW17 YL-18 M739-GW18 YL-18 M751-GW16 YL-18 X794-GW19 BU-16 200-GW28 BK-18 235-GW23 BK-18 308-GW1 YL-16 A209-GW4 BK-18 A760-GW12 GY-18 E411-GW8 YL-18 E441-GW10 GN-18 E442-GW11 GN-18 H446-GW7 PK-18 M755-GW15 OR-18 235-GW23 BK-18 200-GW28 BK-18 200-GW28 BK-18 235-GW23 BK-18 235-GW25 BK-18 235-GW24 BK-18

607-F49 607-F174 199-F69 199-F165 603-F133 200-F173

CONN 2

YL-16 BK-18 PK-18 YL-18 PU-16

BK-18 PK-18

308-C128 A209-C125 H446-C119 E411-C162 147-C184

CONN 15

16

113-G44 200-G45 509-G46 512-G47 607-G48 103-G49 508-G50 511-G51

BK-18

199-F165 501-F28 530-F29 590-F67 A586-F26 200-F166

CONN 42

113-AJ1 139-AJ9

PK-18 BK-16 BK-18

235-G43

308-G19 200-G34 252-G21 262-G22 T901-G52 T902-G53

200-G33 BK-18 200-G32 BK-16 200-G35 BK-18

PK-18 GY-18 GY-18

105-F102 RD-16 308-F104 YL-16 L978-F199 GY-16 103-F6 RD-16 105-F77 RD-16 113-F61 OR-18 123-F64 WH-18 129-F57 BU-16 147-F63 PU-16 147-F83 PU-16 199-F69 OR-18 331-F187 OR-18 603-F133 PK-18 607-F49 PK-18 645-F88 RD-18 684-F130 RD-18 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 200-F138 BK-16 200-F139 BK-16 200-F140 BK-16

103-AJ6 RD-16 508-AJ7 PU-18 509-AJ4 WH-18 511-AJ8 BR-18 512-AJ5 GN-18 200-AJ3 BK-18 113-AJ1 OR-18

K851-A142 235-A144

CONSOLE(RH)

210-F47 BK-14 135-F95 BU-14 229-F45 BK-14 C569-F97 YL-14 105-F40 RD-16 252-F190 YL-18 252-F190 YL-18 252-F20 YL-18 252-F153 YL-18 262-F191 GN-18 262-F191 GN-18 262-F19 GN-18 262-F150 GN-18 892-F12 BR-18 892-F98 BR-18 892-F143 BR-18 892-F143 BR-18 893-F11 GN-18 893-F111 GN-18 893-F142 GN-18 893-F142 GN-18 235-F114 BK-18 235-F114 BK-18 235-F112 BK-18 235-F46 BK-18 123-F64 WH-18 147-F22 PU-16 147-F63 PU-16 147-F83 PU-16 147-F188 PU-16 147-F198 PU-16 147-F17 PU-16 147-F17 PU-16 147-F198 PU-16 147-F188 PU-16 199-F69 OR-18 535-F124 BU-16 535-F151 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 603-F133 PK-18 607-F49 PK-18 A537-F108 PK-18 L973-F82 GN-16 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 L978-F199 GY-16 780-F21 PU-16 780-F21 PU-16 780-F31 PU-16 780-F30 PU-18 113-F81 OR-18 129-F57 BU-16 251-F189 YL-18 261-F52 GN-18 331-F187 OR-18 430-F33 BU-18 487-F34 OR-18 646-F32 RD-18 645-F88 RD-18 G976-F36 BU-18 X738-F35 PK-18 200-F139 BK-16 200-F113 BK-14 199-F165 OR-18 501-F28 GN-18 530-F29 OR-18 590-F67 GY-18 A586-F26 OR-18 200-F113 BK-14 200-F139 BK-16 200-F25 BK-18 200-F181 BK-18 200-F182 BK-18 200-F182 BK-18 200-F122 BK-16

CONN 64

149-F80 115-F78 114-F79 199-F135 160-F53 147-F83 154-F93 199-F69 306-F92 307-F94 320-F85 321-F44 322-F86 331-F187 603-F133 607-F49 607-F87 615-F129 616-F84 638-F91 645-F88 684-F130 200-F134 200-F136

169-G31 200-G32 235-G36

GN-18 BK-18 GY-18 BK-18 GN-18 PU-18

L972-G27

200-F160 200-F160 200-F116 200-F149 200-F157 200-F162

PK-18 OR-18 GY-16 PK-18 YL-16 WH-18 GN-14 OR-16 BU-16 PU-16 BU-16 BU-16 PU-16 OR-16

PK-18 BU-18 GY-18 BR-18 BU-18 WH-18 OR-18 PK-16

BU-16 BU-16 GN-18 PU-18 BU-16 GY-16 BU-16 YL-16

GN-16

CONN 52

TRANSM SS ON ENG NE PUMP CONTROL C RCU T MON TOR C RCU T

GN-18 GN-18

MACH NE SECUR TY CONTROL C RCU T ENG NE CONTROL C RCU T

CONN 11

235-C178

306-F92

169-F175 113-F61 118-F90 119-F202 120-F55 123-F64 124-F65 127-F60 129-F57 147-F63 152-F59 179-F56 160-F53 199-F135

GN-18 BK-18

200-GX7 607-GX6

YL-16 BK-18 PK-18 YL-18 PU-16

BU-18 YL-18 BU-18 BR-18 BR-18 WH-18 PU-18 PK-18 GN-18 BU-18 WH-18 PU-18 BK-18 YL-18 BK-18

495-C22 235-C173

491-C20

RD-18 BK-18 OR-16

175-F72 RD-14 172-F10 RD-18 149-F80 RD-16 115-F78 RD-16 103-F6 RD-16 105-F77 RD-16 114-F79 RD-16 184-F74 RD-14 130-F75 RD-14 141-F16 RD-16 142-F15 RD-16 168-F123 RD-14 168-F73 RD-10

OR-18 BK-18 WH-18 GN-18 PK-16 RD-16 PU-18 BR-18

A755-G23 A756-G24 A757-G25 A758-G26 L972-G27 F774-G28 F773-G29 607-G30

CONN 51

M751-GX4 YL-18 200-GX7 BK-18

308-GW1 A209-GW4 H446-GW7 E411-GW8 147-GW9

K868-GF13 K868-GF14

PU-18 BR-18

235-C175

154-F93 200-F136 307-F94

PK-18 PK-18 WH-18 YL-18 BU-18 PK-18

K852-A105 235-A104

OPERATOR STATION

WH-18 BR-18

BU-18 BR-18

WH-16

PU-16 GN-16 BU-16

WH-18

CONN 9

M906-GF12 M739-GF6 K877-GF8 K876-GF7 K868-GF5 K866-GF9 K865-GF11 K864-GF10 K861-GF4 K860-GF2 K857-GF3 K856-GF1 A209-GF19 308-GF24 235-GF23

GN-18 BR-18

F772-GX12

936-GX13 K931-GX2 A549-GX3

PK-18 BK-16 BK-18

YL-16 RD-16 OR-16 YL-18 GN-18

535-F151 535-F124 403-F76 506-F103 535-F117 118-F90 152-F59 615-F129

BU-18 PK-18 YL-18

WH-16 WH-16

CONN 38

RD-18 RD-18 RD-18 RD-16 GY-16

CONN 53

308-G17 326-G54 307-G20 252-G21 262-G22

YL-18 GN-18 OR-18 RD-16 BU-14 PU-16 YL-18 GN-18 BU-18 OR-18 YL-18 PK-18 BU-16 PU-16 BR-18 GN-18 PK-18 YL-14 BU-18 GN-16 PK-18 BK-14 BK-14 BK-14 BK-18 BU-16 BU-16

X794-C150 E787-C152 M739-C94

F772-GX10 F772-GX11

143-GX9

GN-18 PU-18 BR-18 BU-18 YL-18

CONN 37

PU-4

A588-C88 K865-C89 K876-C90 K877-C91 G723-C92

114-F126 320-F85 114-F126 114-F79 322-F86

112-FC1

OR-18 BR-18 BU-18 PU-18 PU-18

E472-C114 GN-18 F889-C115 WH-18 K847-C57 PU-18 K843-C56 GN-18 H475-C35 BU-18 K849-C36 YL-18 893-C116 GN-18 K904-C117 GN-18 T967-C118 YL-18 E411-C162 YL-18 H446-C119 PK-18 E474-C52 OR-18 H473-C31 BR-18 H474-C34 GN-18 K850-C120 BR-18 K851-C37 BU-18 892-C121 BR-18 E473-C55 GY-18 M751-C168 YL-18 M755-C179 OR-18 N793-C1 GN-18 G973-C12 OR-18

262-C61 GN-18 262-C61 GN-18 262-C102 GN-18 262-C204 GN-18 262-C130 252-C131 261-C132 251-C133

L968-C67

BR-18 YL-18 BR-18 BR-18 PK-18

RD-18 BU-18 BK-18 BK-18 RD-16 OR-18

K871-C78 WH-18 K876-C90 BR-18 K877-C91 BU-18 K904-C117 GN-18 K907-C63 BU-18 K950-C44 YL-18 L968-C67 OR-18 L969-C66 WH-18 L972-C33 BU-18 F889-C71 WH-18-GXL F889-C68 WH-18 F889-C100 WH-18 F889-C115 WH-18 F889-C115 WH-18 F889-C100 WH-18 M737-C77 WH-18 M739-C94 YL-18 M740-C74 PK-18 M751-C168 YL-18 M755-C179 OR-18 M906-C111 BU-18 N789-C192 BU-18 N793-C1 GN-18 N794-C58 GY-18 N795-C59 WH-18 T967-C118 YL-18 X794-C150 BU-18 251-C49 YL-18 251-C49 YL-18 251-C103 YL-18 261-C50 GN-18 261-C50 GN-18 261-C104 GN-18 252-C60 YL-18 252-C60 YL-18 252-C101 YL-18 252-C203 YL-18

PK-18

H747-C191 K907-C63 G834-C189 A762-C87

F889-C100

PK-18 PU-18 WH-18

143-GX14 165-GX8 143-GX14 143-GX9 603-GX1

A513-AJ10 592-AJ11 200-AJ2 200-AJ3 103-AJ6 139-AJ9

PK-18

K864-C82

(NOTE J)

YL-18

RD-18 RD-18 RD-18 RD-16 YL-16

112-FC1 PU-4 177-FA1 RD-4

147-C73 PU-16 308-C113 YL-16 308-C127 YL-16 308-C76 YL-16 308-C126 YL-16 308-C128 YL-16 308-C128 YL-16 763-C75 BU-18 788-C81 YL-18 A762-C87 PU-18 G723-C92 YL-18 K904-C117 GN-18 M737-C77 WH-18 M739-C135 YL-18 M740-C74 PK-18 T967-C118 YL-18 A209-C122 BK-18 A209-C188 BK-18 235-C166 BK-14 235-C193 BK-18

A250-C15 BK-18 308-C70 YL-18-GXL 308-C4 YL-16 308-C140 YL-16 147-C73 PU-16

147-C73 PU-16 K871-C78 WH-18 K866-C79 WH-18 K864-C82 PK-18 M739-C134 YL-18 K876-C90 BR-18 K865-C89 PU-18 K877-C91 BU-18 G973-C12 OR-18 K850-C120 BR-18 E472-C41 GN-18 N795-C59 WH-18

CONN 9 G973-GC1

YL-16 BK-18 BU-18

788-C81

115-F127 684-F128 115-F127 115-F78 615-F129

169-F18 A770-F66 M744-F195 M746-F192 M747-F42 169-F175

103-F6 RD-16 105-F77 RD-16 130-F75 RD-14 168-F73 RD-10 168-F123 RD-14 172-F10 RD-18 175-F72 RD-14 184-F74 RD-14 114-F79 RD-16 115-F78 RD-16 149-F80 RD-16

BR-18

BU-18 OR-18 WH-18 BU-18 GN-18 GY-18 K907-C63 L968-C67 L969-C66 L972-C33 N793-C1 N794-C58

262-C206 GN-18-GXL 262-C206 GN-18-GXL 262-C204 GN-18 262-C130 GN-18 252-C205 YL-18-GXL 252-C205 YL-18-GXL 252-C203 YL-18 252-C131 YL-18 F889-C71 WH-18-GXL 147-C184 PU-16 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 892-C121 BR-18 893-C116 GN-18 A588-C88 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E997-C84 RD-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18

BK-18 BK-18 BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18 BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18 BK-18 BK-18 BK-16

308-C127 A209-C124 M906-C111

PU-16 WH-18 WH-18

CONN 8

WH-18 PK-18 YL-18 BR-18 PU-18 BU-18

CONN 8

WH-18 WH-18 WH-18 YL-18

K866-GA1 WH-18 200-GA2 BK-18 147-GA3 PU-16 K879-GA4 GN-18 K872-GA5 OR-18

PK-18 PK-18 PK-18

124-F65 GN-14 169-F175 PK-18 160-F53 PU-16 129-F57 BU-16 179-F56 BU-16 113-F61 OR-18 147-F63 PU-16 123-F64 WH-18 152-F59 BU-16 118-F90 GY-16 127-F60 OR-16 120-F55 YL-16 199-F135 OR-16 180-F54 GN-16 143-F41 BR-18 119-F202 PK-18

160-F132 PU-18 A623-F131 BU-18 160-F132 PU-18 160-F53 PU-16 607-F87 PK-16 607-F49 PK-18

A513-AJ10 RD-18 592-AJ11 BU-18 512-AJ5 GN-18 511-AJ8 BR-18

BR-18

YL-16 YL-18 PU-16 BK-18 GY-18 YL-18 GN-18 GN-18 PK-18 WH-18 PK-18 YL-18 YL-18 OR-18 BU-18

WH-18 YL-18

M737-C77 K871-C78 K866-C79 K950-C44

A770-F66 169-F18 169-F175

119-F202 309-F204 309-F99

607-GX6 PK-18 235-GX5 BK-18

K866-GF9 K864-GF10 M739-GF6 K876-GF7 K865-GF11 K877-GF8

PU-18 BU-18 WH-18 GN-18 BR-18 YL-18 BK-18 BU-18

K868-GE3

308-C128 M739-C183 147-C184 A209-C125 A760-C186 E411-C162 E441-C153 E442-C161 E787-C152 F772-C83 H446-C119 K950-C44 M751-C168 M755-C179 X794-C150

F772-C83 H746-C190

WH-18 BK-18

YL-16 BK-18 YL-18

BU-18 GY-18

K856-GF1 K860-GF2 K857-GF3 K861-GF4 K868-GF5 308-GF24 A209-GF19 M906-GF12

WH-18

E441-GW10 GN-18 E442-GW11 GN-18 A760-GW12 GY-18 M755-GW15 OR-18 M751-GW16 YL-18 K950-GW17 YL-18 M739-GW18 YL-18 X794-GW19 BU-16 E787-GW20 PK-16 F772-GW21 WH-16

K860-GF2 K868-GF15 308-C181 A209-C123 T967-C118

OR-18 OR-18

BR-18 BR-18

CONN 2

(NOTE N,P) YL-16 BK-18 GN-18

K872-GC11 K872-GC12

K868-GE3 K868-GE3

K857-GE2

M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18

RD-18 RD-18 RD-18 RD-16 BU-16

CONN 54

K906-G5 GN-18 A768-G6 BU-18 A769-G7 GY-18 105-G8 RD-16 A537-G9 PK-18 K907-G10 BU-18 M736-G11 BU-18 L969-G12 WH-18 L968-G13 OR-18 998-G14 BR-18 A770-G15 PK-18 F889-G16 WH-18

E472-G1 235-G42 E473-G2 235-G41 K843-G3 K847-G4

CONN 46

BR-18

309-F204 GY-18 330-F71 YL-16 403-F201 GN-18 K776-F205 GN-18 200-F203 BK-18

GN-18

BK-10

BK-18 BK-18

PU-16 WH-18 WH-18 OR-18 OR-18 BK-18

PU-18 BR-18

WH-18 BR-18 BU-18 BU-18 WH-18

BU-18 WH-18

200-C95

235-AK2 200-GW28

147-GC5 K866-GC3 K871-GC8 G973-GC1 G973-GC1 235-GC2

K856-GE1 K868-GE4

PU-18

K871-C78 K876-C90 K877-C91 M906-C111 N795-C59

763-C75 L969-C66

BK-16 BK-16

BK-18 BK-18 BK-18 BK-18

K856-GE1

BK-18

BK-18

BK-18

200-AL2 200-GC15 200-GC4 235-GC2 235-GC18

BK-18 BK-18 BK-18

BK-18

BK-16 BK-18

BK-18 BK-18

GN-18 GY-18

WH-18 BR-18

PK-18 PU-18 WH-18

PK-18

OR-16 YL-18 GN-18

F772-GJ17 WH-16 147-GJ6 PU-16 235-GJ4 BK-18 M739-GJ7 YL-18 K952-GJ25 BR-18

936-GX13 603-GX1 A549-GX3 K931-GX2 F772-GX10 165-GX8 143-GX9 143-GX9 165-GX8 235-GX5 M751-GX4

200-X5 BK-10 168-X1 RD-10 168-X13 RD-18 168-X15 RD-18 365-X6 YL-18 L976-X9 GN-18 200-X4 BK-18

(NOTE M)

BK-6

K776-C13 309-C129

K857-GE2 K868-GE5

K864-C82 K865-C89 K866-C79

M740-C74

149-F125 645-F88 149-F125 149-F80 616-F84

509-AJ4 WH-18 508-AJ7 PU-18 200-AJ2 BK-18

(NOTE M)

(CONFIG. 2,11)

308-C182 A209-C154 K904-C117

K864-C82 K865-C89 K866-C79

BK-18 BU-16

200-C97 200-C96

K879-GC7 200-GC15

BK-18 BK-18 GY-18 PU-18 YL-18 BR-18 BU-18

200-C164 578-C46

BK-18

K871-GC13 235-GC16

235-C193 A209-C188 A760-C187 G834-C189 H746-C190 H747-C191 N789-C192

RD-14 RD-14 RD-14 RD-14 BK-14 BK-14 BK-14 BK-14 YL-16 BU-18 YL-18 BR-18 GN-18 BK-18 BK-18 BK-18 BK-18 BK-18 GN-18 PK-18 BU-18 GY-18 BR-18 GY-18 GY-18 GY-18 GY-18 PU-18 YL-18 GN-18 GN-18 GN-18 GN-18 GN-18 GN-18 GY-18 OR-18 PK-18 RD-18 WH-18 YL-18 PU-18 OR-18 PK-18 BR-18 GN-18 BU-18 WH-18 YL-18 BR-18 GN-18 GY-18 PU-18 WH-18 YL-18 BR-18 BU-18 GN-18

BK-18 PU-18

200-GC10

B

GN-18

235-GF23

235-C99 235-C166 235-C170 235-C172 235-C42 235-C43 K871-GC14 235-GC17

GY-18 BK-18 PU-18 YL-18 BR-18 BU-18 BK-18

RD-6

200-C108

235-C160 235-C193

BK-18 BK-14 BK-18 BK-18 BK-18 BK-18

BK-18 BK-18 BK-18

BK-6 200-C108

200-C171 200-C163 200-C107

BK-18

200-GC15 BK-18 200-GC4 BK-18 A250-C15 BK-18

200-AL2

200-GW28

BK-18

403-C151

CONN 6

308-C113 YL-16 763-C75 BU-18 788-C81 YL-18 A209-C122 BK-18 A762-C87 PU-18 G723-C92 YL-18 K904-C117 GN-18 M737-C77 WH-18 M740-C74 PK-18 T967-C118 YL-18 235-C166 BK-14 M739-C94 YL-18 M739-C94 YL-18 M739-C135 YL-18 308-C128 YL-16 147-C73 PU-16 308-C127 YL-16 A209-C188 BK-18 235-C193 BK-18

CONN 7

PK-18 BK-18

109-C138

A760-C187 A209-C188 G834-C189 H746-C190 H747-C191 N789-C192 235-C193

BU-18 OR-18 WH-18 BU-18 GN-18 GY-18 PU-16

308-C127 YL-16 147-C73 PU-16 M739-C134 YL-18 A209-C124 BK-18 E472-C41 GN-18 G973-C12 OR-18 K850-C120 BR-18

235-GW23 235-GW24 235-GW25

D

GY-18 BK-18 PU-18 YL-18 BR-18 BU-18 BK-18

184-C5 184-C5 184-C105 184-C109 235-C166 235-C166 235-C106 235-C110 308-C113 763-C75 788-C81 892-C121 893-C116 A209-C112 A209-C112 A209-C122 A209-C124 A209-C125 A588-C88 A755-C24 A756-C25 A757-C26 A758-C27 A760-C180 A760-C180 A760-C186 A760-C187 A762-C87 E411-C162 E441-C153 E442-C161 E472-C114 E472-C114 E472-C29 E472-C41 E473-C55 E474-C52 E787-C152 E997-C84 F772-C83 G723-C92 G834-C189 G973-C12 H446-C119 H473-C31 H474-C34 H475-C35 H476-C30 H746-C190 H747-C191 K843-C56 K844-C53 K847-C57 K848-C54 K849-C36 K850-C120 K851-C37 K852-C38

200-C165 506-C45

BK-18 BK-16

E554-C11 200-C107

A760-AU1 A209-AU2 G834-AU3 H746-AU4 H747-AU5 N789-AU6 235-AU7

BK-18 BK-18

BU-18 BK-18

K907-C63 L968-C67 L969-C66 L972-C33 N793-C1 N794-C58 147-C184

BK-18 BK-18 BK-18

PU-18 BU-16 BK-18 BK-18 BK-18 BK-18

200-C169 200-C98

C468-C28 235-C99

A209-C122 A209-C188 A250-C15

BK-18 BK-18 BK-16 BK-14 BK-18 BK-18 BK-18

200-AL2 235-AK2

RD-00 RD-00 RD-00

235-GF23

101-CP1 101-CF1 101-CA1

235-AK2

E

YL-16 BK-18 BK-18 BU-18 GY-18 GN-18 WH-18 YL-18 YL-18

403-F201

RD-6

101-C139 RD-4 101-CA1 RD-00 101-CF1 RD-00 101-CP1 RD-00

BK-18

BU-18 RD-18 RD-18

177-A71

WH-8

A250-C15 308-C126 A209-C122 A209-C188 A768-C64 A769-C65 K904-C117 M737-C77 M739-C135 T967-C118

235-C42 235-C43 235-C160 235-C166 235-C170 235-C172 235-C193

M740-C74

304-C137

BK-18 BK-18 BK-16 BK-14 BK-18 BK-18 BK-18

200-C171 BK-18 235-C170 BK-18 763-C75 BU-18 A588-C167 GN-18 G723-C92 YL-18 K906-C62 GN-18

YL-18 PU-18

235-C42 235-C43 235-C160 235-C166 235-C170 235-C172 235-C193

325-C174 PK-18 168-C51 RD-10 322-C6 GY-16 607-C7 PK-16 616-C9 BU-16 L973-C80 GN-16

788-C81 A762-C87

A250-C15 A250-C196 A250-C198 A250-C197 A250-C197 A250-C198 A250-C196 A250-C200 A250-C199 A250-C199 A250-C200 200-C163 235-C42 235-C43 235-C160

BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 GN-18 WH-18 WH-18 WH-18 BK-18 PU-16 WH-18 OR-18 OR-18 OR-18 OR-18 200-GC4 235-GC2 200-GC15 235-GC18 235-GC16 235-GC17 200-GC15 K879-GC7 K871-GC14 K871-GC13 K871-GC8 235-GC2 147-GC5 K866-GC3 K872-GC6 K872-GC6 K872-GC12 K872-GC11

RD-4

BK-18 GN-18 PK-18

108-C136

235-C99 BK-18 200-C107 BK-18 200-C108 BK-6 200-C163 BK-18 200-C171 BK-18

235-C173 495-C22 325-C174

101-CA1 RD-00 101-CF1 RD-00 101-CP1 RD-00

(NOTE B)

BK-18 BK-18 BR-18 OR-18 PK-18 WH-18 BK-18

CONN 61

RD-18 PU-18-GXL

235-C172 235-C172 321-C40 487-C19 491-C20 496-C23 235-C173

172-C195 310-C209

101-C139 RD-4 109-C138 RD-6 172-C195 RD-18 304-C137 WH-8 308-C126 YL-16 309-C129 GY-18 310-C209 PU-18-GXL 403-C151 GN-18 788-C81 YL-18 108-C136 RD-4 A762-C87 PU-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E554-C11 PK-18 K776-C13 GN-18 K904-C117 GN-18 M739-C135 YL-18 M737-C77 WH-18 T967-C118 YL-18 200-C163 BK-18 200-C171 BK-18

BK-18 BK-18 BK-18 BK-16

RD-00

F

C

101-C139 RD-4 109-C138 RD-6 172-C195 RD-18 304-C137 WH-8 309-C129 GY-18 310-C209 PU-18-GXL 403-C151 GN-18 788-C81 YL-18 108-C136 RD-4 A762-C87 PU-18 C468-C28 BU-18 E554-C11 PK-18 K776-C13 GN-18 200-C108 BK-6 200-C107 BK-18 235-C99 BK-18

RD-00

330-F71 YL-16 K776-F205 GN-18 309-F204 GY-18 200-F203 BK-18

CONN 33

184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 252-C131 YL-18 252-C203 YL-18 261-C50 GN-18 262-C61 GN-18 262-C130 GN-18 262-C204 GN-18 892-C121 BR-18 893-C116 GN-18 A588-C88 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E997-C84 RD-18 F889-C68 WH-18 F889-C71 WH-18-GXL H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18

BK-00

200-C163 235-C42 235-C43 235-C160

200-CH1

143-GX9

BK-00 BK-00 A623-F131 684-F130 684-F128

506-C45 578-C46 200-C165 200-C164 200-C163 200-C163

BK-18 BK-18 BK-18 BK-18 BK-18

RD-00

BK-00

A209-C122 A209-C188 A250-C15 235-C170 200-C171

101-CP1

101-CG1

200-CE1

101-C139 RD-4 109-C138 RD-6 168-C51 RD-10 172-C195 RD-18 304-C137 WH-8 309-C129 GY-18 310-C209 PU-18-GXL 321-C40 BR-18 322-C6 GY-16 403-C151 GN-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 108-C136 RD-4 A588-C167 GN-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E554-C11 PK-18 K776-C13 GN-18 K906-C62 GN-18 L973-C80 GN-16

101-CR1

RD-00 RD-00

RD-00

200-CE1 200-CH1

101-C139 RD-4 109-C138 RD-6 172-C195 RD-18 304-C137 WH-8 308-C126 YL-16 309-C129 GY-18 310-C209 PU-18-GXL 403-C151 GN-18 788-C81 YL-18 108-C136 RD-4 A762-C87 PU-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E554-C11 PK-18 K776-C13 GN-18 K904-C117 GN-18 M737-C77 WH-18 M739-C135 YL-18 T967-C118 YL-18 200-C163 BK-18 235-C42 BK-18 235-C43 BK-18 235-C160 BK-16 235-C166 BK-14 235-C193 BK-18

101-CF1 101-CR1

101-CC1

BK-18 BK-18

RD-00

200-AL2 235-AK2

CONN 60

101-C139 RD-4 109-C138 RD-6 147-C73 PU-16 168-C51 RD-10 172-C195 RD-18 304-C137 WH-8 308-C4 YL-16 308-C70 YL-18-GXL 308-C140 YL-16 309-C129 GY-18 310-C209 PU-18-GXL 321-C40 BR-18 322-C6 GY-16 403-C151 GN-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 108-C136 RD-4 A588-C167 GN-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E554-C11 PK-18 K776-C13 GN-18 K906-C62 GN-18 L973-C80 GN-16

CONN 65

101-CA1

K776-F205

RD-10

RD-4

177-A71

101-CJ1

PK-18

RD-6

YL-16

177-WE1

330-F71

RD-8 RD-4 RD-4

A770-F66

109-WA1 109-CL1 101-CJ1

GY-16

RD-4

GY-18 BR-18

RD-6

101-C139

309-F99 321-F44

109-C138

RD-6

RD-4

L978-F199

WH-8

YL-16

304-WC1

308-F104

WH-8

BU-16 RD-14 GY-16 YL-16 RD-18 BU-16 WH-16 RD-16 PK-18

304-C137

616-F84 168-F123 322-F86 120-F55 172-F10 179-F56 638-F91 105-F102 169-F18

RD-4

PK-16 RD-18 OR-16 GN-16 GN-14 OR-16 RD-14 RD-18 RD-14

108-CM1

RD-14

RD-4

177-A71

108-CM1

WH-8

108-C136

CONN 45

CONN 44

CONN 43

607-F87 154-F93 127-F60 306-F92 124-F65 307-F94 175-F72 320-F85 184-F74

304-WC1

RD-6

YL-16

307-A24 252-A126 262-A127

GN-18 GY-18 GN-18 PU-18

251-F23 261-F152 113-F101 103-F70 135-F95 147-F22 252-F190 262-F191 430-F33 487-F34 575-F106 576-F107 578-F105 780-F21 892-F98 893-F111 A537-F108 C569-F97 G976-F36 L973-F82 X738-F35 200-F113 210-F47 229-F45 235-F114 535-F124 535-F151

BK-00 BK-00

306-A20 GN-16 330-A55 YL-16 177-A71 RD-6

177-WE1

168-F73

GN-16 GN-16

CONN 36

CONN 35

CONN 55

CONN 52

RD-6

306-A2 306-A3

RD-10

CONN 34

130-F75

RD-4

168-A70

RD-6 177-A71

BU-16 PU-18 BK-18

RD-4 RD-6 WH-8 RD-4 101-C139 109-C138 304-C137 108-C136

578-C46 506-C45 200-C163

GN-18 GY-18 BK-18 BK-18 PU-18 BU-16 N793-C1 N794-C58 235-C42 235-C43 506-C45 578-C46

GN-18 BU-18 OR-18 WH-18 BU-18 GN-16 K906-C62 K907-C63 L968-C67 L969-C66 L972-C33 L973-C80

F716-C208 WH-18-GXL 998-C207 BR-18-GXL 405-C148 GY-18-GXL F773-C21 OR-18-GXL F774-C69 WH-18-GXL 130-C149 RD-14 147-C184 PU-16 147-C73 PU-16 168-C51 RD-10 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 309-C129 GY-18 321-C40 BR-18 322-C6 GY-16 172-C195 RD-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 A588-C167 GN-18 A588-C88 GN-18 A588-C3 GN-18 A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C84 RD-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K776-C13 GN-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18

YL-16 BR-18 GN-18 GN-18 BK-16 308-C140 892-C121 403-C151 893-C116 235-C160

130-C145 RD-18-GXL 130-C144 RD-18-GXL 130-C144 RD-18-GXL 130-C145 RD-18-GXL 130-C147 RD-14 130-C16 RD-18-GXL 130-C146 RD-18-GXL 130-C146 RD-18-GXL 130-C16 RD-18-GXL 130-C147 RD-14 130-C149 RD-14 F774-C69 WH-18-GXL F773-C21 OR-18-GXL 405-C148 GY-18-GXL 998-C207 BR-18-GXL F716-C208 WH-18-GXL

308-C70 F889-C71 252-C205 262-C206 310-C209 A250-C197 A250-C198 A250-C200 A250-C199

200-AL2 235-AK2

YL-18-GXL WH-18-GXL YL-18-GXL GN-18-GXL PU-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL

BK-18 BK-18

306-A3 GN-16 330-A59 YL-16

109-CL1

308-A139

113-A155 200-A102 509-A69 512-A67 607-A103 103-A63 508-A68 511-A66

WH-18

GN-16 YL-16 YL-16

GN-18 BU-18 GY-18 RD-16 PK-18 BU-18

169-A5 200-A94 235-A88

DISC BOX

306-A2 330-A92 330-A55

K906-A73 A768-A77 A769-A78 105-A10 A537-A41 K907-A74

E472-G1 E473-G2 K843-G3 K847-G4

A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 L972-A96 BU-18 F774-A107 WH-18 F773-A106 OR-18 607-A95 PK-16

CONN 23

G

CONN 52

CONN 28

F716-AG2

GN-18 GY-18 GN-18 PU-18

L969-A89 WH-18 L968-A90 OR-18 998-A6 BR-18 A770-A141 PK-18 F889-A101 WH-18

CONN 52

CAB

235-AG1

103-G49 RD-16 105-G8 RD-16 113-G44 OR-18 252-G21 YL-18 262-G22 GN-18 307-G20 OR-16 308-G17 YL-16 308-G17 YL-16 308-G18 YL-16 308-G19 YL-16 326-G54 RD-16 508-G50 PU-18 509-G46 WH-18 511-G51 BR-18 512-G47 GN-18 607-G30 PK-16 607-G48 PK-16 A755-G23 PK-18 A756-G24 BU-18 A757-G25 GY-18 A758-G26 BR-18 E472-G1 GN-18 E473-G2 GY-18 K843-G3 GN-18 K847-G4 PU-18 L972-G27 BU-18 200-G45 BK-18 235-G41 BK-18 235-G42 BK-18 235-G43 BK-18 235-G40 BK-18 235-G36 BK-18 235-G36 BK-18 235-G40 BK-18 235-G39 BK-18 200-G33 BK-18

615-F129 YL-16 103-F96 RD-16 A584-F169 BU-18

BK-16 BK-16 BK-18 BK-18 BK-16 BK-16

200-A93 BK-14 200-A53 BK-16 200-A8 BK-14 200-A29 BK-14 200-A7 BK-14 200-A51 BK-14

200-A82 200-A94 200-A102 200-A110 200-A111 200-A112

CONN 62

F716-A115 WH-18 235-A37 BK-18

K866-GA1 WH-18 200-GA2 BK-18 147-GA3 PU-16 K872-GA5 OR-18 K879-GA4 GN-18

CONN 22

200-CE1 200-CH1

RD-18 RD-18 OR-18

E472-A84 E473-A50 K843-A57 K847-A22

603-GJ22 PK-18 F772-GJ18 WH-16 K931-GJ19 GN-16 A549-GJ24 BU-16 936-GJ20 PU-16 M751-GJ23 YL-18 235-GJ5 BK-18

BK-18

WH-18 BK-18 PU-16 OR-18 GN-18

BU-16 YL-18 PK-18 GN-18 BR-18 GN-18 BU-18 YL-18 BU-18 GN-18 GN-18 GY-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

BK-16 BK-16 BK-14 BK-16 BK-18 BK-16

CONN 21

I

H

CONN 49

PK-18 K866-GC3 200-GC4 147-GC5 K872-GC6 K879-GC7

WH-18 BK-18

603-GX1 PK-18 WH-16 F772-GX10 K931-GX2 GN-16 A549-GX3 BU-16 936-GX13 PU-16 M751-GX4 YL-18 235-GX5 BK-18

X738-C39

CONN 12

789-A123 E997-A154 113-A117

YL-18 GN-18

235-AK2

PK-18

OR-18 OR-18

252-A49 262-A128

X738-AK1

535-A65 575-A39 576-A40 E472-A133 H473-A38 H474-A147 H475-A146 K849-A150 K851-A142 K852-A105 N793-A85 N794-A129 200-A110 235-A104 235-A144 235-A149 235-A130 235-A130 235-A118 235-A148 235-A135 235-A135 235-A151 235-A143 235-A143 235-A136 235-A152 235-A37 235-A132 235-A132 235-A37

200-F122 BK-16 200-F182 BK-18 200-F139 BK-16 200-F113 BK-14 200-F160 BK-16 200-F168 BK-16 200-F180 BK-18 200-F8 BK-18 200-F166 BK-18

CONN 20

235-A37 BK-18 F716-A115 WH-18

GN-18 BK-18 GY-18

576-A40 535-A65 575-A39 200-A110

PU-18 WH-18 BR-18 GN-18 BK-14

BK-18

235-GJ1 BK-18 147-GJ6 PU-16 M739-GJ7 YL-18 K950-GJ8 YL-16 X794-GJ13 BU-16 E787-GJ14 PK-16 F772-GJ21 WH-16 603-GJ22 PK-18 M751-GJ23 YL-18

BK-18

508-F120 509-F121 511-F118 512-F119 200-F116

235-GW23 BK-18 147-GW9 PU-16 M739-GW18 YL-18 K950-GW17 YL-18 X794-GW19 BU-16 E787-GW20 PK-16 F772-GW21 WH-16 603-GW22 PK-18 M751-GW16 YL-18

PU-16

113-A140 113-A140

YL-18 GN-18

780-C8

CONN 13

RD-18

200-H9

CONN 49

252-F190 262-F191

200-AL2

PU-16

E472-A133 235-A136 N794-A129

CONSOLE(RH)

CONN 49

200-F68 BK-14 403-F201 GN-18 103-F70 RD-16 113-F101 OR-18 135-F95 BU-14 147-F22 PU-16 251-F23 YL-18 252-F190 YL-18 261-F152 GN-18 262-F191 GN-18 430-F33 BU-18 487-F34 OR-18 506-F103 PU-18 535-F117 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 780-F21 PU-16 892-F98 BR-18 893-F111 GN-18 A537-F108 PK-18 C569-F97 YL-14 G976-F36 BU-18 L973-F82 GN-16 X738-F35 PK-18 200-F113 BK-14 210-F47 BK-14 229-F45 BK-14 235-F114 BK-18 403-F115 GN-18 403-F115 GN-18 403-F76 GN-18 403-F4 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18 495-F1 GN-18 496-F5 WH-18 C468-F9 BU-18

780-AL1

320-H8

YL-16 RD-18 BK-16 BK-16 RD-16 RD-16 RD-16 RD-16 RD-16 RD-18 YL-18 YL-18 RD-18 RD-16 WH-18 BU-16 PU-16 PU-16 OR-18 OR-18 PK-18 PK-18 RD-18 GY-16 WH-18 YL-18 BU-18 BK-16 OR-18 OR-18 OR-18 RD-16 RD-18 YL-18 YL-18 GN-18 BR-18 GN-18 GN-18 YL-18

PU-18-GXL GY-18-GXL

RD-18-GXL RD-18-GXL RD-18-GXL RD-18-GXL YL-18-GXL GN-18-GXL YL-18-GXL PU-18-GXL GY-18-GXL BR-18-GXL WH-18-GXL OR-18-GXL WH-18-GXL WH-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL BK-18-GXL

RD-6 GN-16 YL-16

GN-18 BK-18 OR-18 BK-18 GY-18 WH-18

308-F104 684-F130 200-F138 200-F140 105-F137 105-F137 105-F77 105-F102 105-F40 646-F32 308-F144 308-F144 646-F32 105-F40 123-F64 129-F57 147-F63 147-F83 199-F69 331-F187 603-F133 607-F49 645-F88 L978-F199 M744-F195 M746-F192 M747-F42 200-F139 113-F81 113-F81 113-F61 103-F6 103-F7 308-F144 251-F189 261-F52 892-F12 893-F11 261-F152 251-F23

310-C209 405-C148

130-C144 130-C145 130-C146 130-C16 252-C205 262-C206 308-C70 310-C209 405-C148 998-C207 F716-C208 F773-C21 F774-C69 F889-C71 A250-C197 A250-C198 A250-C199 A250-C200

177-A71 306-A20 330-A55

ATCH-BEACON LAMP

RD-18 OR-18

WH-18 BU-18 GN-18 PU-18 WH-18 BR-18 GN-18 BK-14 YL-18 GN-18

WH-18-GXL

BR-18-GXL GN-18-GXL

PK-16 PK-16 YL-16 YL-16 BU-16 BU-16 BK-18 BK-18 BR-18 GN-16 BU-16 PU-16 PU-16 BU-16 GN-16 BR-18 PU-16 PK-18 WH-16 WH-16 YL-18 YL-18 BK-18 BK-18

789-A138 113-A140

496-A61 C468-A62 495-A54 508-A68 509-A69 511-A66 512-A67 200-A51 251-A47 261-A48

F889-C71

892-C201 893-C202

E787-GJ15 E787-GJ16 K950-GJ9 K950-GJ10 X794-GJ11 X794-GJ12 235-GJ2 235-GJ3 K952-GJ25 K931-GJ19 A549-GJ24 936-GJ20 936-GJ20 A549-GJ24 K931-GJ19 K952-GJ25 147-GJ6 603-GJ22 F772-GJ17 F772-GJ18 M739-GJ7 M751-GJ23 235-GJ4 235-GJ5

E472-H1 235-H6 E474-H2 235-H7 K844-H3 K848-H4

YL-16 BK-16 BK-16 BU-16 BU-16 BU-16 BU-16

H476-A145 235-A137

PU-18 WH-18 BR-18 GN-18 BK-14 YL-18 GN-18

WH-18-GXL

F889-C68 WH-18 F773-C21 OR-18-GXL F774-C69 WH-18-GXL 998-C207 BR-18-GXL

147-GJ6 PU-16 603-GJ22 PK-18 E787-GJ14 PK-16 E787-GJ14 PK-16 E787-GJ15 PK-16 E787-GJ16 PK-16 F772-GJ21 WH-16 F772-GJ21 WH-16 F772-GJ17 WH-16 F772-GJ18 WH-16 K950-GJ8 YL-16 K950-GJ8 YL-16 K950-GJ9 YL-16 K950-GJ10 YL-16 M739-GJ7 YL-18 M751-GJ23 YL-18 X794-GJ13 BU-16 X794-GJ13 BU-16 X794-GJ11 BU-16 X794-GJ12 BU-16 235-GJ1 BK-18 235-GJ1 BK-18 235-GJ4 BK-18 235-GJ5 BK-18 235-GJ2 BK-18 235-GJ3 BK-18

RD-18 RD-18 RD-18 RD-18

508-F120 509-F121 511-F118 512-F119 200-F116 251-F23 261-F152

F716-C208

K906-A73 GN-18 K907-A74 BU-18 A768-A77 BU-18 A769-A78 GY-18 L969-A89 WH-18 L968-A90 OR-18 F889-A101 WH-18 F773-A106 OR-18 F774-A107 WH-18 998-A6 BR-18

GN-18 BU-18 BU-18 GY-18 WH-18

789-A134 E997-A154 E997-A154 789-A123

GN-18 WH-18 BU-18

WH-18-GXL OR-18-GXL

K906-C62 K907-C63 A768-C64 A769-C65 L969-C66

780-C8 PU-16 X738-C39 PK-18

YL-18-GXL

F774-C69 F773-C21

CONN 19

OR-18

495-F1 496-F5 C468-F9

BK-18

YL-18 GN-18

RD-18 GN-18 RD-18

123-F64 WH-18 147-F17 PU-16 147-F188 PU-16 147-F198 PU-16 199-F69 OR-18 535-F124 BU-16 535-F151 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 603-F133 PK-18 607-F49 PK-18 780-F31 PU-16 A537-F108 PK-18 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 L978-F199 GY-16 235-F46 BK-18 L973-F82 GN-16 L973-F110 GN-18 L973-F14 GN-16 L973-F14 GN-16 199-F165 OR-18 200-F181 BK-18 E480-F43 PK-18

308-C70

235-GN23

CONN 3

252-A120 262-A121

BK-16 GN-18 RD-18 RD-18 RD-18 GN-18 OR-18 GY-18 WH-18 BK-18 BK-18 BK-18 BK-18 BK-16 BK-16 BK-16 BK-18

C569-A27 229-A28 200-A112 179-A17 179-A16 179-A64 179-A64

PU-16 GN-16 BK-18 BK-14 GN-18 GY-18 BU-18 PK-18

BR-18-GXL

YL-16

YL-18 GN-18

200-H14 A588-H11 154-H10 189-H12 320-H8 E472-H1 E474-H2 K844-H3 K848-H4 235-H5 235-H5 235-H6 235-H7 200-H13 200-H13 200-H14 200-H9

154-H10 A588-H11 189-H12

L 320-H8 RD-18 200-H13 BK-16 154-H10 RD-18 189-H12 RD-18 A588-H11 GN-18 127-H15 OR-16

147-A58 L973-A114 235-A33 200-A29 403-A52 405-A75 412-A60 491-A56

998-C207

308-GN9

OR-18 PK-18 GN-18 YL-18 BR-18

252-C60 262-C61

113-A117

147-F22 PU-16 L973-F82 GN-16 235-F114 BK-18 200-F113 BK-14 403-F115 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18

N960-GN17 N957-GN15 N979-GN21 N970-GN19 N973-GN20

CONN TO GK-C2

OR-18 GY-18 WH-18 GY-18 GN-18 PU-18 GN-18 GY-18

RD-16 RD-16 OR-18 YL-16 OR-16 BU-16 RD-18 PK-18 BU-16 YL-18 GN-18 OR-16 YL-16 RD-18 PU-18 WH-18 BR-18 GN-18 BU-16 YL-18 PK-18 PK-16 PK-16 PK-18 PK-18 YL-16 BK-16 BK-16

OR-16 BK-16

135-A25 BU-16 210-A26 BK-16 200-A111 BK-16 120-A119 YL-16 120-A109 YL-16 120-A1 YL-16 120-A1 YL-16

OR-16 OR-16

J

BK-18

GN-18 GY-18 PK-18 BK-18 BK-18

E474-A79 K844-A46 K848-A36 E473-A50 K843-A57 K847-A22 N793-A85 N794-A129

103-A63 105-A10 113-A117 120-A1 127-A124 135-A25 154-A23 169-A5 179-A64 252-A126 262-A127 307-A24 308-A139 320-A14 508-A68 509-A69 511-A66 512-A67 535-A65 575-A39 576-A40 607-A95 607-A103 A537-A41 A770-A141 C569-A27 210-A26 229-A28

127-H15 200-H14

GN-18 BK-18

CONSOLE(LH)

139-F186 113-F185

235-GN14

N793-C1 N794-C58 X738-C39 235-C42 235-C43

OR-18 GY-18 WH-18 GY-18 GN-18 PU-18 GN-18 GY-18

BU-16 PU-16

RD-16 RD-16 YL-16 BU-16 PK-18 BU-16 YL-18 GN-18 OR-16 YL-16 PU-18 WH-18 BR-18 GN-18 PK-16 PK-16 BR-18 PK-18 PK-18 BU-18 GY-18 BR-18 BU-18 GY-18 PK-18 YL-16 GN-18 GY-18 OR-18 WH-18 WH-18 WH-18 GN-18 PU-18 GN-18 BU-18 OR-18 WH-18 BU-18 BK-16 BK-18 BK-16 BK-16 BK-16 BK-16 BK-18 BK-18 OR-18 OR-18 RD-18 RD-18 OR-18

RD-18 BK-16 RD-18 RD-18 GN-18 OR-16

GN-18 OR-18 GY-18 WH-18 BK-18

CONN 48

BK-14

OR-18 PK-18 GN-18 BK-18

N793-C1 GN-18 N794-C58 GY-18 998-C207 BR-18-GXL F716-C208 WH-18-GXL L968-C67 OR-18 L968-C67 OR-18

WH-18 BU-18 GN-16

E474-C52 K844-C53 K848-C54 E473-C55 K843-C56 K847-C57 N793-C1 N794-C58

X794-GJ11 936-GJ20

103-A63 105-A10 120-A1 135-A25 169-A5 179-A64 252-A126 262-A127 307-A24 308-A139 508-A68 509-A69 511-A66 512-A67 607-A95 607-A103 998-A6 A537-A41 A755-A100 A756-A99 A757-A98 A758-A97 A768-A77 A769-A78 A770-A141 C569-A27 E472-A84 E473-A50 F773-A106 F774-A107 F889-A101 H476-A145 K843-A57 K847-A22 K906-A73 K907-A74 L968-A90 L969-A89 L972-A96 200-A94 200-A102 200-A111 200-A112 210-A26 229-A28 235-A88 235-A137 113-A155 113-A155 789-A123 E997-A154 113-A117

320-A14 200-A82 154-A23 789-A123 A588-A12 127-A124

E472-H1 E474-H2 K844-H3 K848-H4 235-H5

N793-A85 235-A152

CONN 47

210-F47

N963-GN18 N959-GN16 N981-GN22 235-GN13

CONN 4

308-C140 YL-16 403-C151 GN-18 892-C121 BR-18 893-C116 GN-18 235-C160 BK-16 892-C201 BR-18-GXL 893-C202 GN-18-GXL

L969-C66 L972-C33 L973-C80

RD-10

PK-16 GN-16

C569-F97 YL-14 229-F45 BK-14 135-F95 BU-14

CONN TO GK-C1

RD-18 YL-16 GN-18

BR-18 GN-18 BU-18

168-A70

CONN 18

RD-14 PU-16 RD-10 RD-18 RD-6 RD-14 YL-18 YL-18 GN-18 GN-18 GN-16 YL-16 GY-18 BR-18 GN-18 YL-16 GY-16 GY-18 BU-18 BU-18 OR-18 PK-18 GN-18 WH-18 PU-18 BU-16 PK-16 BU-16 PU-16 BR-18 GN-18 BU-18 PK-18 BU-18 GN-18 GN-16 GY-16 PK-18 BK-14 BK-14 BK-14 BK-14 BK-14 BK-16 BK-18

E787-GJ15 K931-GJ19

BK-16 BK-16

172-GN8 308-GN10 403-GN12

892-C48 893-C47 G976-C32

CONN 17

GN-14 BK-14 RD-14 PK-18 PK-16 BK-14

YL-16 BU-16

200-F140 200-F139

CONN TO GL-C1 (NOTE V) GN-C4 (NOTE W)

PU-16 RD-18 GN-18 BU-18 BU-18

RD-10

124-A86 200-A8 175-A87 E554-A4 607-A91 200-A93

K950-GJ9 A549-GJ24

GN-18 OR-18 GY-18 WH-18 BK-18

BK-14 BR-18 GN-18 RD-16 OR-18 BU-18 OR-18 PU-18 PU-16 PK-18 BU-16 BU-16 YL-18 PK-18 BU-18 PK-18 BU-16 BK-16 YL-16 BK-16

CONN 3

147-C72 172-C194 403-C14 412-C17 430-C18

168-C51

130-A125 147-A58 168-A70 172-A9 177-A71 184-A11 251-A47 252-A120 261-A48 262-A121 306-A20 308-A80 309-A153 321-A122 403-A52 330-A55 322-A15 405-A75 412-A60 430-A42 487-A43 491-A56 495-A54 496-A61 506-A35 578-A34 607-A81 616-A13 780-A83 892-A31 893-A32 C468-A62 E554-A4 G976-A45 K776-A131 L973-A114 L978-A30 X738-A44 200-A7 200-A8 200-A29 200-A93 200-A51 200-A53 235-A33

VALVE GP

BU-16 YL-18 PK-18 GN-18 BR-18 GN-18 BU-18 YL-18 BU-18 GN-18 GN-18 GY-18 BK-18 BK-18 BK-18 BK-18

E472-A72 E474-A79 K844-A46 K848-A36 235-A76

200-A7 892-A31 893-A32 103-A63 113-A117 430-A42 487-A43 506-A35 780-A83 A537-A41 578-A34 535-A65 575-A39 576-A40 G976-A45 X738-A44 135-A25 210-A26 C569-A27 229-A28

OR-18 PK-18 GN-18 YL-18 BR-18

147-C72 PU-16 172-C194 RD-18 308-C140 YL-16 235-C160 BK-16 403-C151 GN-18 403-C14 GN-18 403-C141 GN-18 403-C141 GN-18 412-C17 BU-18 430-C18 BU-18 892-C143 BR-18 892-C143 BR-18 892-C48 BR-18 892-C201 BR-18-GXL 892-C121 BR-18 893-C142 GN-18 893-C142 GN-18 893-C47 GN-18 893-C202 GN-18-GXL 893-C116 GN-18 G976-C32 BU-18

506-A35 PU-18 578-A34 BU-16 893-A32 GN-18 892-A31 BR-18 251-A47 YL-18 261-A48 GN-18

X794-GJ12 BU-16 235-GJ3 BK-18

535-A65 575-A39 576-A40 E472-A133 H473-A38 H474-A147 H475-A146 K849-A150 K851-A142 K852-A105 N793-A85 N794-A129 200-A110 235-A37 235-A132 235-A143

BK-14 BR-18 GN-18 RD-16 OR-18 BU-18 OR-18 PU-18 PU-16 PK-18 BU-16 BU-16 YL-18 PK-18 BU-18 PK-18 BU-14 BK-14 YL-14 BK-14

GN-18-GXL BR-18-GXL

GN-18

CONN TO C-C18 (NOTE V) GN-C3 (NOTE W)

PU-18 BU-16 GN-18 BR-18 YL-18 GN-18

RD-14 PU-16 RD-10 RD-18 RD-6 RD-14 YL-18 YL-18 GN-18 GN-18 GN-16 YL-16 GY-18 BR-18 GY-16 YL-16 GN-18 GY-18 BU-18 BU-18 OR-18 PK-18 GN-18 WH-18 PU-18 BU-16 PK-16 BU-16 PU-16 BR-18 GN-18 BR-18 GN-18 PK-18 BU-18 GY-18 BR-18 BU-18 GY-18 BU-18 GN-18 GN-18 GN-18 GN-18 GN-18 GY-18 OR-18 PK-18 RD-18 WH-18 OR-18 WH-18 WH-18 BU-18 BR-18 GN-18 BU-18 WH-18 GN-18 GN-18 GY-18 PU-18 WH-18 YL-18 BU-18 GN-18 GN-18 BU-18 OR-18 WH-18 BU-18 GN-16 GY-16 GN-18 GY-18 PK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

1

CONSOLE(LH)

200-F68 892-F98 893-F111 103-F70 113-F101 430-F33 487-F34 506-F103 780-F21 A537-F108 578-F105 535-F117 575-F106 576-F107 G976-F36 X738-F35 135-F95 210-F47 C569-F97 229-F45

893-C202 892-C201

403-GN11

N960-GK6 N957-GK5 N979-GK9 N970-GK7 N973-GK8

CONN 4

BK-18 BK-18

506-C45 578-C46 893-C47 892-C48 251-C49 261-C50

130-A125 147-A58 168-A70 172-A9 177-A71 184-A11 251-A47 252-A120 261-A48 262-A121 306-A20 308-A80 309-A153 321-A122 322-A15 330-A55 403-A52 405-A75 412-A60 430-A42 487-A43 491-A56 495-A54 496-A61 506-A35 578-A34 607-A81 616-A13 780-A83 892-A31 893-A32 998-A6 A588-A12 A755-A100 A756-A99 A757-A98 A758-A97 A768-A77 A769-A78 C468-A62 E472-A72 E472-A84 E472-A133 E472-A116 E472-A116 E473-A50 E474-A79 E554-A4 E997-A154 F716-A115 F773-A106 F774-A107 F889-A101 G976-A45 H473-A38 H474-A147 H475-A146 H476-A145 K776-A131 K843-A57 K844-A46 K847-A22 K848-A36 K849-A150 K851-A142 K852-A105 K906-A73 K907-A74 L968-A90 L969-A89 L972-A96 L973-A114 L978-A30 N793-A85 N794-A129 X738-A44 235-A33 235-A88 235-A137 235-A18 235-A18 235-A76 235-A132 235-A113 235-A113 235-A143

YL-16 BR-18

BK-18 BK-18 BK-16 BK-18 BK-14

YL-18-GXL GN-18-GXL

RD-18

BK-18

BK-18

GN-18 GY-18 BU-18 BU-18 OR-18 PK-18 WH-18 GN-18 WH-18 PK-18 BU-18 GY-18 BR-18 BU-18 GN-18 WH-18 BR-18 BU-18 BU-18 GN-18 BU-18 YL-18 RD-18 BU-18 GN-18 PK-18 BR-18 GY-16 BK-18 BK-18

K950-GJ10 K952-GJ25

YL-18

252-C205 262-C206

172-GN7

235-GK2

235-C158

235-C42 235-C43

K776-A131 405-A75 412-A60 430-A42 487-A43 491-A56 F716-A115 495-A54 496-A61 A755-A100 A756-A99 A757-A98 A758-A97 C468-A62 E472-A116 H476-A145 H473-A38 G976-A45 L972-A96 H474-A147 H475-A146 K849-A150 E997-A154 K851-A142 K852-A105 X738-A44 321-A122 L978-A30 235-A113 235-A143

K776-C13 GN-18 405-C148 GY-18-GXL 412-C17 BU-18 430-C18 BU-18 487-C19 OR-18 491-C20 PK-18 F716-C208 WH-18-GXL 495-C22 GN-18 496-C23 WH-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 C468-C28 BU-18 E472-C29 GN-18 H476-C30 WH-18 H473-C31 BR-18 G976-C32 BU-18 L972-C33 BU-18 H474-C34 GN-18 H475-C35 BU-18 K849-C36 YL-18 E997-C84 RD-18 K851-C37 BU-18 K852-C38 GN-18 X738-C39 PK-18 321-C40 BR-18

BK-14 BK-14 BK-14 BK-14 BK-16 BK-14

OR-16 RD-18 RD-18 GN-18 GN-18 OR-18 GY-18 WH-18 BK-16 BK-18 RD-18

329-X18

RD-18-GXL RD-18-GXL

RD-18 YL-16 GN-18

BU-18

BR-18 GN-18 PK-18 BU-18 GY-18 BR-18 BU-18 GY-18 GN-18 GN-18 GN-18 GY-18 OR-18 RD-18 OR-18 WH-18 WH-18 BR-18 GN-18 BU-18 WH-18 GN-18 GY-18 PU-18 WH-18 YL-18 BU-18 GN-18 GN-18 BK-18 OR-18 WH-18 BU-18 GN-18 GY-18 BK-18 BK-18 BK-18 BU-18 BK-18 BK-18

127-A124 154-A23 320-A14 A588-A12 E472-A72 E474-A79 K844-A46 K848-A36 200-A82 235-A76 789-A123

BK-10 WH-10

130-C146 130-C16

172-GK1 308-GK3 403-GK4

430-C18

998-A6 A588-A12 A755-A100 A756-A99 A757-A98 A758-A97 A768-A77 A769-A78 E472-A72 E472-A84 E472-A133 E473-A50 E474-A79 E997-A154 F773-A106 F774-A107 F889-A101 H473-A38 H474-A147 H475-A146 H476-A145 K843-A57 K844-A46 K847-A22 K848-A36 K849-A150 K851-A142 K852-A105 K906-A73 235-A132 L968-A90 L969-A89 K907-A74 N793-A85 N794-A129 235-A37 235-A76 235-A88 L972-A96 235-A137 235-A143

200-F134 200-F136 200-F138 200-F203 200-F68

RD-18-GXL RD-18-GXL BK-18-GXL BK-18-GXL

CONN 3

PU-16 BK-18 BU-18

GN-18

998-A6 BR-18 A588-A12 GN-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 A768-A77 BU-18 A769-A78 GY-18 E472-A72 GN-18 E472-A84 GN-18 E472-A133 GN-18 E473-A50 GY-18 E474-A79 OR-18 E997-A154 RD-18 F773-A106 OR-18 F774-A107 WH-18 H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 H476-A145 WH-18 K843-A57 GN-18 K844-A46 GY-18 K847-A22 PU-18 K848-A36 WH-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 K906-A73 GN-18 K907-A74 BU-18 L968-A90 OR-18 L969-A89 WH-18 L972-A96 BU-18 235-A137 BK-18 N793-A85 GN-18 N794-A129 GY-18 235-A76 BK-18 235-A88 BK-18 235-A132 BK-18 F889-A101 WH-18 235-A143 BK-18 235-A37 BK-18

200-X5 323-X12

130-C144 130-C145 A250-C199 A250-C200

147-C72 235-C155 G976-C32

403-A52

200-A7 200-A8 200-A29 200-A51 200-A53 200-A93

E787-GJ16 PK-16 235-GJ2 BK-18

GN-18

BK-18-GXL BK-18-GXL

CONN TO GL-C1 (NOTE W)

YL-16 RD-14 GY-16 PK-16 PU-16 BU-16 PU-16 PK-18 GY-18

K776-A131

A250-C197 A250-C198

BR-18 GN-18

OR-18 PK-18 GN-18

BU-18 BK-18

GN-18

308-A80 184-A11 322-A15 607-A81 780-A83 616-A13 147-A58 E554-A4 309-A153

BK-16

K

N973-GN20 N979-GN21

CONN TO C-C18 (NOTE W)

403-C14

BK-16 BK-16 BK-18 BK-18 BK-16 BK-16

200-A53

GN-18 BR-18 YL-18 GN-18

OR-18 YL-18

CONN 1

YL-16 RD-14 GY-16 PK-16 PU-16 BU-16 PU-16 PK-18 GY-18

WH-16

893-EL4 892-EL5 251-EL6 261-EL9

N960-GN17 N970-GN19

N963-GN18 N959-GN16 N981-GN22

172-C195 RD-18 147-C73 PU-16 147-C184 PU-16 130-C149 RD-14 168-C51 RD-10 184-C5 RD-14 235-C42 BK-18 235-C43 BK-18 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 309-C129 GY-18 321-C40 BR-18 322-C6 GY-16 405-C148 GY-18-GXL 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 506-C45 PU-18 578-C46 BU-16 607-C7 PK-16 616-C9 BU-16 A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C84 RD-18 F773-C21 OR-18-GXL F774-C69 WH-18-GXL F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K776-C13 GN-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K906-C62 GN-18 K907-C63 BU-18 L969-C66 WH-18 L972-C33 BU-18 L973-C80 GN-16

GY-18 BK-18 BU-18

412-C17 235-C156

RD-18

308-C4 184-C5 322-C6 607-C7 780-C8 616-C9 147-C10 E554-C11 309-C129

638-A19

RD-18 BK-18 YL-16

RD-18 YL-16 GN-18 BR-18 GN-18 BK-18

PU-16 PU-16 PU-16 RD-18

200-A82 200-A94 200-A102 200-A110 200-A111 200-A112

130-A125 RD-14 172-A9 RD-18 L973-A114 GN-16 A588-A12 GN-18

638-A19 WH-16 200-A53 BK-16

172-EL1 235-EL2 308-EL3

PK-18

172-GN1 308-GN3 403-GN4 892-GN5 893-GN6 235-GN2

A760-AU9 235-AU7 N789-AU6

130-C149 RD-14 147-C10 PU-16 168-C51 RD-10 172-C2 RD-18 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 309-C129 GY-18 321-C40 BR-18 322-C6 GY-16 403-C14 GN-18 405-C148 GY-18-GXL 412-C17 BU-18 430-C18 BU-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 506-C45 PU-18 578-C46 BU-16 607-C7 PK-16 616-C9 BU-16 780-C8 PU-16 892-C48 BR-18 893-C47 GN-18 998-C207 BR-18-GXL A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C84 RD-18 F716-C208 WH-18-GXL F773-C21 OR-18-GXL F774-C69 WH-18-GXL F889-C68 WH-18 G976-C32 BU-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K776-C13 GN-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K906-C62 GN-18 K907-C63 BU-18

CONN 16

RD-16 RD-16 OR-18 YL-16 OR-16 BU-16 RD-18 PK-18 BU-16 YL-18 GN-18 OR-16 YL-16 RD-18 PU-18 WH-18 BR-18 GN-18 BU-16 YL-18 PK-18 PK-16 PK-16 PK-18 PK-18 YL-16 BK-16 BK-16

N957-GN15

172-C194 892-GN5 BR-18 893-GN6 GN-18 N959-GN16 PK-18 N963-GN18 OR-18 N981-GN22 GN-18 172-GN1 RD-18 172-GN8 RD-18 172-GN7 RD-18 172-GN7 RD-18 308-GN3 YL-16 308-GN10 YL-16 308-GN9 YL-16 308-GN9 YL-16 403-GN4 GN-18 403-GN12 GN-18 403-GN11 GN-18 403-GN11 GN-18 235-GN2 BK-18 235-GN14 BK-18 235-GN23 BK-18 235-GN13 BK-18 235-GN13 BK-18 235-GN23 BK-18 235-GN14 BK-18 403-GN12 GN-18 308-GN10 YL-16 172-GN8 RD-18 172-GN8 RD-18 308-GN10 YL-16 403-GN12 GN-18 235-GN14 BK-18 N957-GN15 PK-18 N960-GN17 OR-18 N970-GN19 YL-18 N973-GN20 BR-18 N979-GN21 GN-18

GN-18 BR-18

BR-18 GN-18 BU-18

147-C10 147-C10 147-C72 172-C2

CONN 3

893-GN6 892-GN5

892-C48 893-C47 G976-C32

130-C149 RD-14 172-C2 RD-18 L973-C80 GN-16 A588-C3 GN-18

103-A63 105-A10 113-A117 120-A1 127-A124 135-A25 154-A23 169-A5 179-A64 252-A126 262-A127 307-A24 308-A139 320-A14 508-A68 509-A69 511-A66 512-A67 535-A65 575-A39 576-A40 607-A95 607-A103 A537-A41 A770-A141 C569-A27 210-A26 229-A28

GY-18 GY-18 GY-18

GN-18 BU-18 BU-18

BK-14 BK-14 PK-18 GN-14 RD-14 PK-16

CONN 14

403-C14 412-C17 430-C18

200-A93 200-A8 E554-A4 124-A86 175-A87 607-A91

PU-18 BK-18 BR-18 YL-18 GY-18

RD-14 PU-16 RD-10 RD-18 RD-6 RD-14 YL-18 YL-18 GN-18 GN-18 GN-16 YL-16 GY-18 BR-18 GY-16 YL-16 GN-18 GY-18 BU-18 BU-18 OR-18 PK-18 GN-18 WH-18 PU-18 BU-16 PK-16 BU-16 PU-16 BR-18 GN-18 BU-18 BU-18 GN-18 GN-16 GY-16 PK-18 BK-14 BK-14 BK-14 BK-16 BK-18 PK-18 BK-14 BK-14

A760-AU8 A760-AU1 A760-AU9

CONN 5

G834-AT1 A209-AT2 H747-AT3 H746-AT4 A760-AT5

PU-18 BK-18 BR-18 YL-18 GY-18

130-A125 147-A58 168-A70 172-A9 177-A71 184-A11 251-A47 252-A120 261-A48 262-A121 306-A20 308-A80 309-A153 321-A122 322-A15 330-A55 403-A52 405-A75 412-A60 430-A42 487-A43 491-A56 495-A54 496-A61 506-A35 578-A34 607-A81 616-A13 780-A83 892-A31 893-A32 C468-A62 G976-A45 K776-A131 L973-A114 L978-A30 X738-A44 200-A7 200-A29 200-A51 200-A53 235-A33 E554-A4 200-A8 200-A93

YL-18 YL-18 YL-18 YL-18 GN-18 GN-18 GN-18 GN-18

G834-AU3 A209-AU2 H747-AU5 H746-AU4 A760-AU8

103-A63 RD-16 105-A10 RD-16 113-A117 OR-18 120-A1 YL-16 124-A86 GN-14 127-A124 OR-16 130-A125 RD-14 135-A25 BU-16 147-A58 PU-16 154-A23 RD-18 168-A70 RD-10 169-A5 PK-18 172-A9 RD-18 175-A87 RD-14 177-A71 RD-6 179-A64 BU-16 184-A11 RD-14 251-A47 YL-18 252-A120 YL-18 252-A126 YL-18 252-A49 YL-18 252-A49 YL-18 261-A48 GN-18 262-A121 GN-18 262-A127 GN-18 262-A128 GN-18 262-A128 GN-18 306-A20 GN-16 307-A24 OR-16 308-A80 YL-16 308-A139 YL-16 308-A108 YL-16 308-A108 YL-16 309-A153 GY-18 320-A14 RD-18 321-A122 BR-18 322-A15 GY-16 330-A55 YL-16 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 495-A54 GN-18 496-A61 WH-18 506-A35 PU-18 508-A68 PU-18 509-A69 WH-18 511-A66 BR-18 512-A67 GN-18 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 578-A34 BU-16 607-A81 PK-16 607-A95 PK-16 607-A103 PK-16 607-A91 PK-16 607-A21 PK-16 607-A21 PK-16 616-A13 BU-16 780-A83 PU-16 892-A31 BR-18 893-A32 GN-18 A537-A41 PK-18 A770-A141 PK-18 C468-A62 BU-18 C569-A27 YL-16 G976-A45 BU-18 K776-A131 GN-18 L973-A114 GN-16 L978-A30 GY-16 X738-A44 PK-18 200-A7 BK-14 200-A29 BK-14 200-A51 BK-14 210-A26 BK-16 229-A28 BK-16 235-A33 BK-18

L

CONN TO C-C18 (NOTE X)

RD-18 YL-16 GN-18 BR-18 GN-18 BK-18

172-C194 RD-18 308-C140 YL-16 403-C141 GN-18 892-C143 BR-18 893-C142 GN-18 235-C159 BK-18 235-C159 BK-18 235-C160 BK-16 235-C160 BK-16 235-C159 BK-18 235-C158 BK-18 235-C157 BK-18 235-C157 BK-18 235-C155 BK-18 235-C156 BK-18 147-C72 PU-16 412-C17 BU-18 430-C18 BU-18 G976-C32 BU-18

251-EL6 251-EL6 251-EL7 251-EL8 261-EL9 261-EL9 261-EL10 261-EL11

CONN 59

CONN 1

OR-18 GN-18 YL-18 BR-18

BR-18 GN-18 BK-18

N960-GK6 N979-GK9 N970-GK7 N973-GK8

892-EL5 893-EL4 235-EL2

172-C194 308-C140 403-C141 892-C143 893-C142 235-C159

RD-18 BK-18 YL-16 GN-18 PK-18

RD-18 YL-16

172-GK1 235-GK2 308-GK3 403-GK4 N957-GK5

172-EL1 308-EL3

2

OPERATOR STATION

PU-16 PU-16

13

147-F17 780-F31

14

BK-16

15

200-F168

16

OPERATOR STATION

235-GC2 235-GC18

(Dimensions: 48 inches x 35 inches)

17

36 Page,

KENR6118-03

18

L973-AM1 200-AM2

RD-10 BK-10

PK-18

168-X1 200-X2

CONN 30

325-X3

CONN 29

RD-10 BK-10

PK-18

168-X1 325-X3 365-X6 365-X8 365-X7 L976-X9 L976-X10 L976-X11 200-X2 200-X2 200-X4 200-X5

RD-10 PK-18 YL-18 YL-18 YL-18 GN-18 GN-18 GN-18 BK-10 BK-10 BK-18 BK-10

168-X1 365-X6 L976-X9 200-X4 200-X5 168-X13 168-X15

RD-10 YL-18 GN-18 BK-18 BK-10 RD-18 RD-18

HEATER AND A R COND T ONER C RCU T TURN S GNAL W PER WASHER C RCU T 365-X8 325-X3

YL-18 PK-18

YL-18 PK-18

CONN 41

168-X15 RD-18 365-X7 YL-18 L976-X10 GN-18 168-X13 RD-18 325-X3 PK-18 365-X8 YL-18 L976-X11 GN-18

365-AA1 325-AA2

CAT DATA L NK CAN DATA L NK RS 232 RS 485 DATA L NK CAN DATA L NK A

168-X13 L976-X11

RD-18 GN-18

168-Y1 L976-Y2

CONN 40

RD-18 GN-18

OTHER COLOR DESCR PT ONS H GHWAYS

GN-16 BK-18

9

8

7

6

5

4

IDENT PART NO. HARNESS AS.

LOC

A C E F G H J K M R T U V X Y AA AC AE AG AJ AK AL AM AR AT AU AV AW EL EN EM GA GC GE GF GG GH GJ GK GL GM GN GT GU GV GW GX GY ZZ

L-11 L-11 B-8 H-5 J-4 L-5 G-8 A-10 I-2 G-1 G-1 G-1 G-1 A-6 A-6 A-6 C-8 B-7 H-9 D-8 J-14 J-14 A-9 B-7 L-14 L-14 B-7 B-1 L-18 F-18 J-5 F-10 C-15 D-15 B-10 D-15 D-7 H-4 K-16 K-15 H-4 L-15 C-1 A-10 D-2 C-10 H-5 C-9 H-11

275-7004 306-8610 267-8073 259-5296 259-4877 251-0580 251-0614 275-7196 251-0543 167-3456 167-3456 167-3456 167-3456 238-1579 238-1595 238-1597 267-7628 267-7626 251-0299 234-1124 259-5344 267-7590 259-5129 259-5326 275-6846 275-6803 259-5327 238-2479 275-6784 306-8691 283-2914 251-0598 267-7636 275-7198 275-7197 275-7202 259-5254 267-7923 275-6979 259-4940 267-7955 259-4887 267-7644 275-7195 267-7672 267-7922 267-7930 267-7925 319-1348

3

B

WIRE PAIRS OF 892-BR & 893-GN,251-YL & 261-GN, 252-YL & 262-GN MUST BE TWISTED AT LEAST 1 TURN PER 25mm.

COLOR ABBREV AT ONS IDENT

PART NO.

LOC

CABLE AS.

(NOTE S) (NOTE S)

(NOTE D) (NOTE D)

CA CC CE CF CG CH CJ CL CM CP CR FA FC

267-8016 170-6929 231-1827 267-8034 170-6929 259-5229 251-0303 251-0304 234-1035 267-8044 259-5097 238-2390 238-2391

G-18 G-18 G-17 F-18 F-17 F-17 H-11 H-11 H-12 F-18 F-18 C-10 C-9

IDENT

PART NO.

LOC

(NOTE A) (NOTE A) (NOTE A)

(NOTE B) (NOTE B)

(NOTE C) (NOTE C)

WIRE AS.

(NOTE X) (NOTE (NOTE (NOTE (NOTE (NOTE (NOTE

AA) G,H) G,H) M) K,L,N,P) R)

(NOTE (NOTE (NOTE (NOTE (NOTE

J) V,W) V,W) J) W)

(NOTE J) (NOTE J) (NOTE J)

W WA WC WE WH WJ

299-2767 234-1037 234-1038 238-2280 163-6758 238-1593

H-17 H-12 H-12 H-12 D-10 A-15

ABBREV

COLOR

RD WH OR YL PK BK GY PU BR GN BU

RED WH TE ORANGE YELLOW P NK BLACK GRAY PURPLE BROWN GREEN BLUE

SYMBOL

DESCR PT ON C RCU T CONNECTED C RCU T NOT CONNECTED E ECTR CA CONNECT ON TO MACH NE STRUCTURE NTERNA E ECTR CA CONNECT ON TO SURFACE OF COMPONENT CONNECTOR

H

C RCU T GROUP NG DES GNAT ON ATCH W RE CAB E COMPONENT C RCU T CONNECTED SP CE B ADE SPADE R NG OR SCREW TERM NA

THIS SCHEMATIC IS FOR THE 320D EXCAVATOR PART NUMBER: 267-7999, CHANGE: 04, VERSION: HE Components are shown installed on a fully operable machine. Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.

2

1

A