Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets.
Receptacle
Plug
7
1 2
1 2 Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.
L-C12 * 3E-5179
Switch - Air Inlet Pressure
E-9
9
Switch - Key Start
C-4
A
E-9
9
Switch - LH Console
D-4
16
Motor - Wiper
B-2
10
Switch - Oil Pressure
E-9
7
Relay - Boom Lower
B-5
5
Switch - Speed Select
D-2
14
Relay - Hydraulic Disable
C-7
5
19
Switch - Travel
D-2
Relay - Lamp
C-7
5
Switch - Wiper/Washer
E-4
B
Relay - Main Power
D-3
5
Switch 2 - Travel
D-2
19
* C-C4* AG-C3 130-6795 130-6795
Pin
L-C12* 3E-5179
AG-C4* 111-7898 325-A135 PK-14
1
4 1 K P 5 2 L 5 2 3
Harness identification code This example indicates wire 32 in harness "L'.
Socket
Single Wire Connector * Harness identification letter(s) and a serializing code. The "C" stands for connector and the number indicates which connector in the harness.
2
200-L32 BK-14 Circuit Number Identification
Wire Color
Wire Gauge
Electrical Schematic Symbols And Definitions FUSE - A - A component in an electrical circuit that will open the circuit if too much current flows through it. REED SWITCH - A - A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
Machinelocationsarerepeatedforcomponentslocatedclosetogether. A= Locatedinoron therightconsole. B= Locatedinoron theleftconsole. T
SENDER - A - A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its r esistance changes to give an indication to the gauge of the temperature or pressure. RELAY (Magnetic Switch) - A - A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.
Machine Harness Connector And Component Locations
CIRCUIT BREAKER (C/B) - A component in an electrical circuit that will openthe circuit if too much current flows through it. This does not destroy the circuit breaker and it can be reset to become part of the circuit again. SOLENOID - A - A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The
1 0 9 3 5 3 R N E R
9
8
7
6
5
4
3
2
CA-C1 3E5179 1 2 3 4 5 6 7 8 9 10 11 12
F
1
BEACON2 128-6985 607-CA18 PK-18 L E F TC A B F L O O D L A M P 2 146-6366