10959 Chassis KCT57A

COLOR TELEVISION RECEIVER Chassis : M od odel:

KCT57 KCT57A A CT566BVX/ ST STR CT566BVX/XAP CT566BWX/STR CT567BWX/STR CT567BWX/XAP CT766DWX/STR CT766DWX/XAP

Precautions

1. Prec Precautions autions Follow these safety, servicing and ESD precautions to prevent damage and protect against potential hazards such as electrical shock and X-rays.

1-1 Safety Precautions Preca utions 1. Be sure sure that that all all of the the built built-in -in pro protec tectiv tivee devices are replaced. Restore any missing missing protective shields. 2. When When reins reinstall talling ing the cha chassi ssiss and and its its assemblies, be sure to restore all protective devices, including: nonmetallic control knobs and compartment covers. 3. Make Make sure sure that ther theree are no no cabine cabinett opening openingss through which peopleÑparticularly childrenÑmight insert fingers and contact dangerous voltages. voltages. Such openings include the spacing between the picture tube and the cabinet mask, excessively wide cabinet ventilation slots, and improperly fitted back covers. If the measured resistance is less than 1.0

LEAKAGE CURRENT TESTER

DEVICE UNDER TEST

(READING SHOULD NOT BE ABOVE 0.5mA)

TEST ALL EXPOSED EXPOSED M ETAL SURFACES 2-WIRE CORD ALSO TEST WITH PLUG REVERSED (USING AC ADAPTER PLUG AS REQUIRED)

EARTH GROUND

Fig. 1-1 AC Leakage Test

6. Ante Antenn nnaa Col Cold d Che Check ck:: With the unitÕs AC plug disconnected from the AC source, connect an electrical jumper across the two AC prongs. Connect one lead of the ohmmeter to an AC prong. Connect the other

Precautions

1-1 Safety Precautions (Continued) 9. High voltage is maintained within specified limits by close-tolerance, safety-related components and adjustments. If the high voltage exceeds the specified limits, check each of the special components. 10. Design Alteration Warning: Never alter or add to the mechanical or electrical design of this unit. Example: Do not add auxiliary audio or video connectors. Such alterations might create a safety hazard. Also, any design changes or additions will void the manufacturerÕs warranty. 11. Hot Chassis Warning: Some TV receiver chassis are electrically connected directly to one conductor of the AC power cord. If an isolation transformer is not used, these units may be safely serviced only if the AC power plug is inserted so that the chassis is connected to the ground side of the AC source. To confirm that the AC power plug is inserted correctly, do the following: Using an AC voltmeter, measure the voltage between the chassis and a known earth ground. If the

15. Observe the original lead dress, especially near the following areas: Antenna wiring, sharp edges, and especially the AC and high voltage power supplies. Always inspect for pinched, out-of-place, or frayed wiring. Do not change the spacing between components and the printed circuit board. Check the AC power cord for damage. Make sure that leads and components do not touch thermally hot parts. 16. Picture Tube Implosion Warning: The picture tube in this receiver employs Òintegral implosionÓ protection. To ensure continued implosion protection, make sure that the replacement picture tube is the same as the original. 17. Do not remove, install or handle the picture tube without first putting on shatterproof goggles equipped with side shields. Never handle the picture tube by its neck. Some Òin-lineÓ picture tubes are equipped with a permanently attached deflection yoke; do not try to remove such Òpermanently attachedÓ yokes from the picture tube.

Precautions

1-2 Servicing Precautions Warning1: First read the “ Safety Precautions” section of this manual. If some unforeseen circumstance creates a confli ct betw een the servicing and safety precautions, always foll ow t he safet y precautions. Warning2: An electrolytic capacitor installed wi th the wrong polarity might explode.

1. Servicing precautions are printed on the cabinet. Follow them. 2. Always unplug the unitÕs AC power cord from the AC power source before attempting to: (a) Remove or reinstall any component or assembly, (b) Disconnect an electrical plug or connector, (c) Connect a test component in parallel with an electrolytic capacitor. 3. Some components are raised above the printed circuit board for safety. An insulation tube or tape is sometimes used. The internal wiring is sometimes clamped to prevent contact with thermally hot components. Reinstall all such elements to their original position. 4. After servicing, always check that the screws, components and wiring have been correctly reinstalled. Make sure that the portion around the serviced part has not been damaged.

5. Check the insulation between the blades of the AC plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). 6. Insulation Checking Procedure: Disconnect the power cord from the AC source and turn the power switch ON. Connect an insulation resistance meter (500V) to the blades of the AC plug. The insulation resistance between each blade of the AC plug and accessible conductive parts (see above) should be greater than 1 megohm. 7. Never defeat any of the B+ voltage interlocks. Do not apply AC power to the unit (or any of its assemblies) unless all solid-state heat sinks are correctly installed. 8. Always connect a test instrumentÕs ground lead to the instrument chassis ground before

Precautions

1-3 Precautions for Electrostatically Sensitive Devices (ESDs) 1. Some semiconductor (Òsolid stateÓ) devices are easily damaged by static electricity. Such components are called Electrostatically Sensitive Devices (ESDs); examples include integrated circuits and some field-effect transistors. The following techniques will reduce the occurrence of component damage caused by static electricity. 2. Immediately before handling any semicon ductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. Alternatively, wear a discharging wrist-strap device. (Be sure to remove it prior to applying powerÑ this is an electric shock precaution.) 3. After removing an ESD-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of electrostatic charge. 4. Do not use freon-propelled chemicals. These can generate electrical charges that damage ESDs.

5. Use only a grounded-tip soldering iron when soldering or unsoldering ESDs. 6. Use only an anti-static solder removal device. Many solder removal devices are not rated as Òanti-staticÓ; these can accumulate sufficient electrical charge to damage ESDs. 7. Do not remove a replacement ESD from its protective package until you are ready to install it. Most replacement ESDs are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. 8. Immediately before removing the protective material from the leads of a replacement ESD, touch the protective material to the chassis or circuit assembly into which the device will be installed. 9. Minimize body motions when handling unpackaged replacement ESDs. Motions such as brushing clothes together, or lifting a foot from a carpeted floor can generate enough static electricity to damage an ESD.

Specifications and IC Data

2. Specifications and IC Data 2-1 Specifica tions

Model

CT566BV

CT566BW /567BW /568BW

Television System :

NTSC-M

Channels :

VHF : CH 2 ~ CH 13 UHF : CH 14 ~ CH 69 CATV : CH 1, CH 14 ~ CH 125

Intermediate Frequencies :

Picture IF Carrier : 45.75 MHz Sound IF Carrier : 41.25 MHz Color Sub Carrier : 42.17 MHz

Sound System

M ONO

Picture Tube :

CT633BW

CT683BW

CT766DW

M TS A53QCX89X01

Power Requirements :

AC100~240V, 50/60Hz

Antenna Input Impedance :

75 ohm unbalanced type

A63AFW32X

A68A DT25X01 A70QBZ791X


2-2 IC Line Up

Table 2 - 1 IC Line - Up Loc No

No

SF101

1

M3951M

SAW FILTER (VIF)

SF102

2

M9260M

SAW FILTER (SIF)

TDA8377

ONECHIP TV PROCESSOR

CT566BV/ CT567BW / CT568BW/ CT766DW

TDA8373

ONECHIP TV PROCESSOR

CT633BW/CT683BW

IC201

Specification

Description

Remarks

3

IC202

4

LA7510

AUDIO IF AMP/4.5M DETECT

IC301

5

TDA8350Q

VERTICAL AM P IC

IC603

6

TDA7057AQ

SOUND AM P IC

IC602

7

mPC 1460HA

VOLUM E CONTROL IC

STEREO M ODEL ONLY

IC701

8

TDA4053

SWITCHING IC

STEREO M ODEL ONLY

S6709 IC801

9

CT633BW/ CT683BW/ CT766DW POWER IC


2-3 Semiconductor Base Di agrams ELECTROLYTICCONDENSER

IC

DIODE

XLS24C02P (PIN 8) TDA8375 (PIN 56) RM168E (PIN 42) TDA9850 (PIN 22) TDA4053 (PIN 16)

TRANSISTOR

TRANSISTOR

KSC2073 KSA940 2SD1887 2SD1880 KSD5072

SAW-FILTER

M3951M M9260M KSC815Y KSA539-Y

1


2-4 One Chip TV-processor

SOUND IF INPUT

1

56

DECOUPLING SOUND DEMODULATOR

EXT AUDIO INPUT

2

55

AUDIO DEEMPHASSIS/ M PX OUT

VCO REF FILTER

3

54

TUNER AGC OUTPUT

VCO REF FILTER

4

53

AGC DECOUPLING CAPACITOR

PLL LOOP FILTER

5

52

REREFERENCE CURRENT INPUT

IF VIDEO OUTPUT

6

51

VERT, SAWTOOTH CAPACITOR

BUSINPUT : SCL

7

50

EHT/OVERVOLTAGE PROTECTION INP (X-RAY PROTECTION)

BUSINPUT : SDA

8

49

IF INPUT

BANDGAP DECOUPLING

9

48

IF INPUT

CHROMA INPUT

10

47

VERT. DRIVE NEG

Y/CVBS INPUT

11

46

VERT. DRIVE POS

M AIN POSITIVE SUPPLY

12

45

EAST-WEST DRIVE

INT CVBS INPUT

13

44

GROUND

GROUND

14

43

PHI1 FILTER

AUDIO OUT

15

42

PHI2 FILTER / FLASH PROT

DECOUPLING FILTER TUNING

16

41

SAND CASTLE OUTPUT/ FLYBACK INP

Alignment and Adjustments

3. Alignment and Adjustments 3-1 Preadj ustment 1. Since there are no VRs in the KCT52A chassis, all adjustments after parts replacement must be done in the Service Mode. 2. The Factory Mode adjustments are necessary when either the EEPROM (IC902) or the CRT is replaced. 3. Do not tamper with the Ò AdjustmentÓ screen of the Factory Mode menu. This screen is intended only for factory use.

4. WHEN EEPROM (IC902) IS REPLACED (1) When IC902 is replaced, all adjustment data revert to their initial values. It is necessary to re-program this data. (2) After IC902 is replaced, warm up the TV for 10 seconds. Make the following adjustments AFTER setting up purity and convergence: White Balance Sub-Brightness Vertical Center Vertical Size Horizontal Size (No use in 21Ó and 25Ó models)

3-2 Factory (“SERVICE”) M ode


3-2-1 Adjustment 1. Selection sequence : STAND-BY ® MUTE ® 1 ® 8 ® 2 ® POWER ON 2. Example : Sub-bright Adjustment * FACTORY M ODE* Adjustment Mpx Adjust Test Pattern Set Option Byte Factory Reset ¯ Press VOL w

AGC VCO SBT SCT SCR STT RG GG BG SCO VSL

15 62 7 11 8 8 32 32 32 20 26

VS VA HS EWA EWP EWC EWT VZM MAT VOL PLA

32 27 46 52 31 32 31 25 off 0 6


M EMORY SPECIFICATION

Table 3 - 1 M emory Specification No

MODE (OSD)

CT566BV

CT566BW/567BW/568BW

CT766DW

CT633BW

CT683BW

1

AGC

15

15

15

15

15

2

VCO

62

62

62

62

62

3

SBT

7

7

7

7

7

4

SCT

7

7

7

7

7

A

5

SCR

8

8

8

8

8

D

6

STT

8

8

8

8

8

J

7

RG

32

32

32

32

32

U

8

GG

32

32

32

32

32

S

9

BG

32

32

32

32

32

T

10

SCO

20

20

20

20

20

M

11

VSC

30

30

35

38

26

E

12

VS

32

32

32

32

32

N

13

VA

7

7

15

45

27

T

14

HS

42

42

48

46

46

15

EWA

38

38

38

52

52

16

EWP

0

0

49

31

31

17

EWC

0

0

32

32

FUNCTION


3-2-2 Test Pattern (Aging M ode) 1. This mode can be used to confirm that the convergence and purity adjustments are correct. 2. Access the Test Pattern parameters by pressing the CHANNEL keys (v ,w) while the Service Mode is on. The cursor will move to the test pattern. Press the VOLUME keys. On-screen display: RED GREEN BLUE

3-2-3 V2 Tri-Norma Option Table 3-2-3(A) OPTION BYTE 0

Table 3-2 Option Byte 0 DATA D0

D1

FUNCTION

REM ARK

0 = AIR/ STD/HRC/ IRC 1 = A IR/ STD/HRC/ AFN

OPTION

0 = NORMAL

FIX = “ 0”


3-2-3(B) OPTION BYTE 1 Table 3-3 Option Byte 1 DATA D0

FUNCTION

REM ARK

00 = TV/VIDEO 01 = TV/VIDEO/S-VIDEO 11 = NO ASSIGNED

OPTION

D2

0 = VID : 0 1 = VID : 1

FIX = “ 0”

D3

0 = RB 10 STEP UP 1 = RB 5 STEP UP

FIX = “ 0”

D4

0 = NO COM BFILTER 1 = COM BFILTER

OPTION

D5

0 = 4 : 3 CRT 1 = 12.8 : 9 CRT (Q M ODEL)

OPTION

D6

0 = INTERNAL A/ V SWITCH 1 = EXTERNAL A/ V SWITCH

OPTION (M ONO = 0) OPTION (STEREO = 1)

D7

NOT USED NOT USED

D1

OPTION BYTE 1


3-2-4 Factory Reset When Ò Factory ResetÓ is selected, the User-Control data reverts to the initial values. The User-Control data is available at MENU (picture, sound and the other functions). Note : When Ò Factory ResetÓ is selected, the Factory Mode Data does not change. Selection sequence : Stand-By ® MUTE ® 1 ® 8 ® 2 ® POWER ON

¯

* FACTORY M ODE * Adjustment Mpx Adjust Test Pattern Set Option Byte Factory Reset ¯ Press CH

Adjustment Mpx Adjust Test Pattern Set Option Byte Factory Reset

w


3-3-2 Automatic De gaussing A degaussing coil is mounted around the picture tube, so external degaussing after moving the TV should be unnecessary. However, the receiver must be properly degaussed upon installation. The degaussing coil operates for about 1 second after the power is switched ON. If the set has been moved or turned in a different direction, disconnect its AC power for at least 10 Minutes. If the chassis or parts of the cabinet become magnetized, poor color purity will result. If this happens, use an external degaussing coil. Slowly move the degaussing coil around the faceplate of the picture tube and the sides and front of the receiver. Slowly withdraw the coil to a distance of about 6 feet before removing power.

3-3-3 High Voltage Check CAUTION : There is no high voltage adjustment on this chassis. The B+ power supply must be set to either +135V or +125V (for 20Ó screen). Conditions : Full color bar input and

3-3-4 FOCUS Adjustment 1. Input a black and white signal. 2. Adjust the tuning control for the clearest picture. 3. Adjust the FOCUS control for well defined scanning lines in the center area of the screen.

3-3-5 B+ Line Check There are 3 power modes : 1. ÒAÓ : When AC power supply is connected ; Ò Stand-ByÓ mode. 2. ÒBÓ : When Ò Set Power-ONÓ button is pressed. 3. ÒCÓ : Driven by FBT. Each voltage is marked on its lead-in wire. ( )

3-3-6 F/S (Fail Sa fe) Circuit Check


3-3-7 Color Purity Adjustment 1. Warm up the receiver. Operate it for 20 minutes, with the Brightness control set to maximum. 2. Fully degauss the receiver. Use an external degaussing coil. 3. Roughly adjust convergence by rotating the Convergence Magnet. 4.

6. Loosen the Purity Magnet clamp. Adjust the purity magnet so that the vertical green raster is precisely at the center of the screen. Then tighten the clamp. 7. Slowly move the Deflection Yoke forward, and adjust it for the best overall green screen. 8. Tighten the Deflection Yoke clamp screw.

Input a black and white signal.

5. Loosen the Deflection Yoke clamp screw, and move the Deflection Yoke as close to the purity magnet as possible.

DEFLECTION YOKE

CRT

RUBBER WEDGES

PURITY AND CONVERGENCE M AGNET ASS'Y RUBBER WEDGE 30

30


3-3-8 Center Convergence Adjustment Note: Before attempting any convergence adjustment, make sure that the receiver has been powered ON for at least twenty minutes. 1.

Input a crosshatch pattern from a color bar generator.

2. Adjust the Brightness and Contrast controls for a well defined pattern. 3. Adjust the two tabs of the 5-pole magnets. Change the angle between the tabs, and superimpose red and blue vertical lines in the center area of the picture screen.

BLUE

4. Next, turn both tabs at the same time. Keep the angle between the tabs constant, and superimpose the red and blue horizontal lines at the center of the screen. 5. Adjust the two tabs of the 6-pole magnets. Superimpose the red/blue lines on the green. Adjusting the angle affects the horizontal lines. 6. Repeat adjustments 3, 4 and 5. The dot movement is complex because the 4-pole and 6pole magnets interact.

RED/ BLUE

RED

BLUE

RED/ BLUE

RED

GREEN

4-Pole M agnet M ovement

GREEN

6-Pole M agnet M ovement


3-3-11 White Balance Adjustment

3-3-11 (D) SUB-BRIGHTNESS ADJUSTMENT

3-3-11 (A) SCREEN ADJUSTMENTS

1. Input a TOSHIBA pattern.

1. Input a TOSHIBA pattern.

2. Set SBT so that the brightness level in lowlight is 1.0 F/L.

2. Check R506 ÒGÓ pin on the CRT PCB with an oscilloscope.

3. Enter the Horizontal Line Mode.

High-Light

4. Adjust the Screen Control on the FBT so that the waveform of the 21st line is DC 2.0 _ (+0.5)V. SIZE

29”

26”

22”

DC

2.0

2.4

2.4

Low-Light

3-3-11 (B) HIGH-LIGHT ADJUSTM ENT 3-3-11 (E) SUB-COLOR ADJ USTMENT 1. NOTE : If a color analyzer is not available, then approximate the following color adjustments Òby eyeÓ. 2. Input a TOSHIBA pattern.

Set ÒSCRÓ in the Service Mode to step 0.

3-3-11 (F) SUB-TINT ADJUSTMENT

Troubleshooting

4. Troubleshooting 4-1 No Raster and No Sound

No Raster and No Sound

No Voltage

M easure the B+ Voltage at the Cathode of D812 (D811)

Abnormal

Normal Check +12.5 Line

Check/Replace IC801 Q801

Check/Replace AVR Circuit, Horiz O

M ore than 130V

Normal

Normal

Measure the B+

Check the hori z output signal at TR collector.

Troubleshooting

4-2 N o Raster (Sound OK)

No Raster (Sound Ok)

Check that CRT Heater is Lighting Yes

Abnormal

Check/Replace FBT Abnormal

Check I2C Data

Check H.V of CRT

Normal

Check/Replace IC201

Normal

No

Check Heater pl us

Abnormal

Check/Replace FBT

Normal

Check/Replace CRT Drive Circuit

Troubleshooting

4-3 No Vert Scan (Horizontal Line)

No Vertical Scan (Horizontal Line)

Check D812 (D811)

Abnormal

Check./Replace Vertical Output Circuit

Normal

Check IC301 Pin 4

Abnormal

Check/Replace DZ306,DZ305,R410,T444

Normal

Check IC201 Pin 46 , 47 Normal

Abnormal

Check/Replace IC201

Troubleshooting

4-4 No Sound No Sound

Normal

Check Speaker

Check IC603 Pin 8 , 13

Abnormal

Abnormal



Normal

Check/Replace IC602 Abnormal

Check IC701 Pin 21 , 27 Normal

Normal

Check/Replace IC603

Troubleshooting

4-3 No Color

No Color

Push "Display" Button on the Remocon

OSD " PAL-M" PAL-M " or "PAL-N" or " NTSC" appear?

No

It's not normal normal signal

Yes

Check ICH01

Normal Check IC901 8 , 16

Abnormal

Check B+ (5V), Replace ICH01

Exploded Ex ploded View & Parts List

5. Exploded Exploded View & Parts List List 5-1 CT566BVX/STR, CT566BVX/XAP, CT566BWX/STR No

Code N o

De sc ri pti on

AA64 AA 64-3 -311 1110 10C C

CAB ABIN INE ET-F -FR RONT

-,C -, CT56 566B 6BW, W,B BK-7 -708 08P P EGN, N,H HIP IPS, S,HB HB,,

1 CT56 566B 6BWX WX/ST /STR R

AA64AA6 4-31 3111 110B 0B

CAB ABINE INET-F -FR RONT

-,C -, CT5 T566 66BV BV,B ,BKK-70 708P 8P EGN,H N,HIP IPS, S,HB HB,,

1 CT5 T566 66BV BVX/S X/STR TR

AA64AA6 4-31 3111 110B 0B

CAB ABINE INET-F -FR RONT

-,C -, CT5 T566 66BV BV,B ,BKK-70 708P 8P EGN,H N,HIP IPS, S,HB HB,,

1 CT5 T566 66BV BVX/X X/XAP AP

A A6 A64- 60 60278P

IN LA LAY- AV AV

KCT57A,S/ T GOLD,PS,T0.3,BLK,-,

1 CT566BW X/ X/ ST STR

A A6 A64- 60 60 27 278 Q

I NL NLAY- AV AV

KCT57 A, A, M / N GOLD, PS, T0 T0 .3 .3, BL BLK,- ,

1 CT566 BV BVX/ ST STR

A A6 A64- 60 60 27 278 Q

I NL NLAY- AV AV

KCT57 A, A, M / N GOLD, PS, T0 T0 .3 .3, BL BLK,- ,

1 CT566 BV BVX/ XA XA P

1- 2

AA64-70010D

BADGE-BRAN D

AL,SS R2000 25,GOLD,L50,-,-,-

1

1- 3

AA64-10712B

KNOB-POW ER KN

-,Q21,TS,ABS,HB,BLK

1

1- 4

AA61-60003T

SPRIN GG-CS

-,SUS304,0.5,OD7,H13.5,N5,-,-,

1

1- 5

A A6 A65- 30 30105A

CLAM PP- WI WIRE

N YL YLON 66N ,V ,V0,N TR TR,15M M ,A ,A LL LL M OD ODE

2

1- 6

A A6 A61- 40 40053A

STOPPER- PCB

A LL LL M OD ODEL,HIPS HB,W HT HT,HB,-,-

1

1 -7 -7

A A6 A64- 40 40 46 461 A

I ND NDICATOR- LE LED

- ,2 ,2 26 26 B, B,LG TR5 58 58- 02 02 39 39 ,A ,A BS BS, HB HB, CL CL

1

1- 8

A A6 A64- 40 40460A

W IN IN DO DOW -R -REM OC OCON

- ,2 ,226B,LG-41338,A BS BS,HB,- ,-,-

1

1 -9 -9

60 02 02 -0 -00 05 05 14 14

SCREW -T -TA PP PPIN G

RH, +, +, 2, 2, M 4, 4, L1 L1 5, 5, ZP ZPC(BLK), SW SW RC RCH1 8

1

1-10

3001-000190

SPEAKER

5W,8ohm,89dB,150Hz

2

1-11 111

6002 60 02-0 -000 0051 5144

SCREWW-T TAP APP PIN ING G

RH, H,++,2 ,2,M4 ,M4,L ,L15 15,Z ,ZP PC(BLK) K),S ,SWR WRC CH1 H188

4

1-12

3722-001031

JACK-RCA

3P,3.6mm,#18,AU

1

1-13

A A6 A60-10002A

SCREW -T -TA PPIN G

RH,+,M 4, 4,L12,ZPC(YEL),- ,O ,OD14

2

1-14

AA64-10713A

KNOB-CONTROL

-,226B,-,ABS,HB,BLK

1

1-15 115

6002 60 02-0 -000 0051 5144

SCREWW-T TAP APP PIN ING G

RH, H,++,2 ,2,M4 ,M4,L ,L15 15,Z ,ZP PC(BLK) K),S ,SWR WRC CH1 H188

1

1

1- 1

Q’ty

2

AA03-10028Z

CRT-COLOR

-,A53QCA891X(B),0mG,21,90deg,

1

2- 1

A A6 A65- 30 30019A

CLAM PP- D, D,COIL

N YL YLON -6 -66,V0,N TR TR,DA DH DH-460 20,-

4

2 -2 -2

A A6 A60- 10 10 05 050 D

SCREW -A -A SS SSY

W C, C,HH, +, +, M5 M5 ,L ,L33 ,S ,SW RC RCH18 ,Z ,ZPC(YEL

4

2- 3

AA94-50017T

ASSY-CRT

A53QCA891X(B),0M G, G,22,BARE,CT5

1

R e ma r k Re

3

AA64-31111B

CABIN ET-BACK

-,566B,-,HIPS,HB,BLK,-,-

1

3 -1 -1

60 02 02 -0 -00 05 05 16 16

SCREW -T -TA PP PPIN G

RH, +, +, 2, 2, M 4, 4, L2 L2 0, 0, ZP ZPC(BLK), SW SW RC RCH1 8

4

3 -2 -2

A A6 A64- 60 60 05 052 P

I NL NLAY- BA BA CK CK

KCT57 A, A,N T S/ T, T, PS SHEET,T0. 5, 5, BL BL

1 CT56 6B 6BW X/ X/ ST STR

AA64 AA 64-6 -600 0052 52K K

INLLAY-B IN -BAC ACK K

KCT57 57A, A,NT NT MO MONO NO,P ,PS S SHE HEE ET,T ,T0. 0.5, 5,B B

1 CT56 566B 6BV VX/ST /STR R

AA64 AA 64-6 -600 0052 52K K

INLLAY-B IN -BAC ACK K

KCT57 57A, A,NT NT MO MONO NO,P ,PS S SHE HEE ET,T ,T0. 0.5, 5,B B

1 CT56 566B 6BV VX/XA /XAP P

A A3 A39- 10 10006X

POW ER ER-CORD

- ,K ,KKP419C,KLCE- 2F 2F,2.286M T, T,3P,V

1

4

Samsung El ect roni cs

Spe c i fi c a ti on

5-1

Exploded View & Parts List

5-2 CT567BW X/STR, CT567BWX/ XAP

No

5-2

Code No

Description

1

A A6 4- 311 15 A

" CA BI NET- FRON T

- ,CT567 BW ,BK- 708 P,HI PS,HB, BLK,

Specification

Q’ty 1

1- 1

A A63- 50334A

GRILLE-W OOFER,L

-,567B,PA110,SECC,T0.5,- ,-

1

A A6 3- 503 35 A

GRI LLE- WOOFER, R

- ,5 67B, PA 110 ,SECC, T0 .5 ,- ,-

1

1-2

AA64-70010D

BADGE-BRAND

AL,SS R2000 25,GOLD,L50,-,-,-

1

1-3

AA64-60278S

IN LAY-AV

KCT57A,S/ T GOLD,PS,T0.3,KSP213

1

1- 4

A A64- 40431A

W IN DOW -REM OCON

- ,503E,-,ABS,HB,LG41338,-

1

1-5

AA64-10716B

KNOB-POW ER

-,Q21,TS,ABS,HB,M ET BROW N

1

1-6

AA61-60003T

SPRING-CS

-,SUS304,0.5,OD7,H13.5,N 5,-,-,

1

1-7

AA64-40462A

DECORATION-FRONT

-,CT567BW,KSP213,HIPS,VO,L/GRA

1

1-8

AA64-40432A

INDICATOR-LED

-,503E,-,PM MA,HB,CLR,-

1

1- 9

A A65- 30105A

CLA MP-W IRE

N YLON 66N ,V0,N TR,15M M ,A LL M ODE

2

1- 10

A A61- 40053A

STOPPER- PCB

A LL M ODEL,HIPS HB,W HT,HB,-,-

1

1-11

AA64-10717A

KNOB-CONTROL

-,-,-,ABS,HB,M ET BROW N

1

1-12

6002-000514

SCREW-TAPPING

RH,+,2,M4,L15,ZPC(BLK),SWRCH18

1

2

AA03-10028Z

CRT-COLOR

-,A53QCA891X(B),0mG,21,90deg,

1

2- 1

A A6 0- 100 50 D

SCREW -A SSY

W C, HH,+,M 5, L33 ,SW RCH18, ZPC(YEL

4

2-2

AA94-50017T

ASSY-CRT

A53QCA891X(B),0M G,22,BARE,CT5

1

2-3

3001-000190

SPEAKER

5W,8ohm,89dB,150Hz

2

2-4

AA91-60289A

ASSY-HOLDER,SPK

567BW ,-,PP,HB,BLK,8ohm,6W,600

1

2- 5

60 02- 00 051 6

SCREW -TA PPI NG

RH, +, 2, M4 ,L2 0, ZPC(BLK), SW RCH18

4

3

AA64-31111B

CABINET-BACK

-,566B,-,HIPS,HB,BLK,-,-

1

3- 1

60 02- 00 051 6

SCREW -TA PPI NG

RH, +, 2, M4 ,L2 0, ZPC(BLK), SW RCH18

4

3- 2

A A64- 60052P

IN LAY-BACK

KCT57A ,N T S/ T,PS SHEET,T0.5,BL

1

4

A A39- 10006X

POW ER- CORD

-,KKP419C,KLCE- 2F,2.286M T,3P,V

1

Samsung Electronics

Exploded View & Parts List

5-3 CT766DW X/STR, CT766DWX/ XAP

No

Samsung Electronics

Code No

Description

1

A A64- 31 178 A

CA BIN ET- FRON T

- ,CT76 6DW ,DG- 70 3P EGB,HI PS, HB,

Specification

Q’ty 1

1 -1

A A63- 50 341 A

GRILLE- WOOFER

- ,7 66 DW ,- ,SECC PI 0.6 ,T0. 6, DG- 7

2

1-2

A A64-70117C

BADGE-BRAND

AL,SS,GOLD,L65,FLAT,-,-

1

1 -3

A A64- 40 479 A

W IN DOW -REM OCON

- ,7 65 D, -,A BS, HB, -, CLR LG41 33 8

1

1-4

A A64- 10740A

KN OB- POW ER

- ,765D,G3119,HIPS,HB,HI-GREY

1

1-5

AA61-60003N

SPRING-CS

-,SUS304,0.6,OD11.2,H27,N9,H27

1

1-6

A A64- 60423E

IN LAY- AV.SIDE

766D,KCT57A ,PS,T0.3,S/ GRAY,- ,-

1

1-7

AA95-90028W

ASSY-PCB,A/V SIDE

-,CT766DWX/XAP,KCT57A,NTSC,100

1

1 -8

60 02 -00 05 14

SCREW -TA PPIN G

RH, +, 2, M 4, L1 5, ZPC(BLK), SW RCH1 8

2

1-9

A A61- 40053A

STOPPER- PCB

A LL M ODEL,HIPS HB,W HT,HB,-,-

1

1-10

A A65- 30105A

CLAM P- WIRE

N YLON 66N ,V0,N TR,15M M ,A LL M ODE

2

1-11

AA64-40480A

INDICATOR-LED

-,765D,-,ABS,-,CLR,-

1

1 -12

A A 64- 10 74 1A

KN OB- CON TROL

- ,7 65 D, G31 19 ,HI PS, HB, HI -GREY

1

1-13

6002-000514

SCREW-TAPPING

RH,+,2,M4,L15,ZPC(BLK),SWRCH18

1

1-14

AA61-40010A

BOSS-WING

-,HIPS,HB,NTR,-,-

1

2

AA03-10029G

CRT-COLOR

-,A70QBZ791X001(B),0mG,29,100

2-1

3001-000274

SPEAKER

5W,8ohm,90dB,160Hz

1

2 -2

60 02 -00 05 14

SCREW -TA PPIN G


4

2-3

AA95-20009W

ASSY-PCB,CRT

-,KCT57A,29,JUNGNAM MI,-

1

2

3

AA64-31179A

CABINET-BACK

-,766D,-,HIPS,HB,GRAY,-,-

1

3 -1

60 02 -00 05 16

SCREW -TA PPIN G


4

3-2

A A64- 60052P

IN LAY- BA CK

KCT57A ,N T S/ T,PS SHEET,T0.5,BL

1

4

A A39- 10006X

POW ER-CORD

- ,KKP419C,KLCE- 2F,2.286M T,3P,V

1

5-3

6. Electric Parts List

6-1 Dissimila r Pow er Parts List .............................................................................................. 6-1 6-2 Part Description (P/D) Acc ording to Screen Size ....................................................... 6-4 6-3 CRT PCB PART (TDA6101Q IC) .......................................................................................... 6-8 6-4 COM B FILTER OPTION ....................................................................................................... 6-10 6-5 AUDIO OUT OPTI ON ........................................................................................................... 6-10 6-6 VIDEO OUT OPTION ............................................................................................................ 6-11 6-7 M ONO STEREO OPTION .................................................................................................... 6-11 6-8 SOUND OUTPUT OPTI ON .................................................................................................. 6-14 6-9 JACK ...................................................................................................................................... 6-14 6-10 CT566BVX/STR (CT566BWX/STR AND CT566BVX/STR Dissimil ar Parts) ............. 6-15

Electri c Parts List

6-1 Dissimilar Pow er Parts List

S T L O V E E R F H C N I 0 3 , 9 2

V 0 2 1 C A H C N I 8 2 , 7 2

V 0 2 1 C A H C N I 7 2 , 5

M E T S L Y E S 9 D 0 O 7 M 6 S Q

M E T S Y L S E 9 D 0 O 7 M 6 S Q

P M E M A S P P S / E E / A S S S W / / / D D W D D 6 5 D 5 5 6 6 6 6 6 7 7 6 7 7 - - 7 T T T T T C C C C C

M E S / W 9 D 9 7 5 6 8 6 8 2 2 7 - H H T X X C T T

M E M M M M M S / E E E E E S C S S T / S / / B / S C C W Y 5 7 8 5 6 W W 6 V V S 4 4 4 4 4 2 6 6 5 B B 3 5 5 7 7 0 4 4 7 3 7 5 8 0 2 2 2 2 2 2 3 8 2 3 6 7 G G G G G 7 6 6 H 6 5 X X X X X T T T X T T

) 6 2 ) 4 9 1 ) 1 0 7 2 0 0 - 8 0 1 0 0 1 0 4 0 2 0 2 1 ( F 4 8 u 0 3 ( 0 4 7 ( 1 E R E E 4 T m E P T E V h M L 0 o L E U E 0 4 7 D J D

) 5 0 1 ) ) ) 1 9 0 ) K 2 H 1 0 4 - 7 0 2 2 0 0 0 0 8 0 0 0 4 1 0 2 - 2 0 - 0 1 0 3 2 ( 3 0 - 1 1 1 1 V A 8 S 1 A A 3 ( 4 0 A 0 ( 9 ( R 0 2 - ( 0 N E 3 7 5 P 4 5 7 6 3 M B 2 R 1 U R / T E J E 1 S S

) 6 8 ) 3 9 1 ) 1 0 8 2 0 0 - 0 0 1 2 0 0 0 4 0 2 0 2 1 ( F 4 8 u 0 3 ( 0 4 R 7 1 E ( E E 4 T P T m E V h E M L 0 o L E U E 5 2 7 D J D

) 6 8 ) 3 9 1 ) 1 0 8 2 0 0 - 0 0 2 1 0 0 0 4 0 2 2 1 ( 0 F 4 8 u 0 3 ( 0 4 R E 7 1 E ( E 4 T P T m E V h E M L 0 o L E U E 5

) ) 9 ) ) 3 ) 1 5 1 1 8 2 9 0 4 8 0 2 1 1 0 0 0 0 1 0 1 0 0 - 0 0 0 2 0 0 9 1 1 6 0 0 1 8 0 0 0 0 3 2 2 ( 0 ( ( 0 R 2 8 K 2 ( E ( 1 . 3 . K P 1 1 0 4 1 M U W W 2 / 2 / J 5 5 1 1

) E 4 0 ) ) 0 ) 2 2 0 8 0 0 2 1 1 6 1 2 2 2 0 0 0 A 1 0 0 - 0 - A 0 3 3 ( 2 0 0 ë ¿ 0 0 0 T 2 ( 2 L 4 0 ( ( K K O 6 E 8 8 V 0 6 6 E 6 T E E V L W W R B E 2 2 F R D

) ) 0 0 9 9 0 0 1 1 0 0 0 - 0 3 3 0 0 0 0 2 ( 2 ( K K 0 0 1 1 W W 2 2

) 5 0 1 ) ) ) 1 9 0 ) K 2 H 1 0 4 - 7 0 2 2 0 0 0 0 8 0 0 0 4 1 0 2 0 - 2 - 0 1 0 3 2 ( 3 0 - 1 1 1 1 V A 8 S 1 A A 3 ( 4 0 A 0 ( 9 ( R 0 2 - ( 0 N E 3 5 7 P 4 7 6 5 3 M B 2 R 1 U R / T E J E 1 S S

) ) 9 ) ) 3 ) 1 5 1 1 8 2 9 0 4 8 0 2 1 1 0 0 0 0 1 0 1 0 0 - 0 0 0 2 0 0 9 1 1 6 0 0 1 8 0 0 0 0 3 2 2 ( 0 ( ( 0 R 2 8 K 2 ( E ( 1 . 3 . K P 1 1 0 4 1 M U W W 2 / 2 / J 5 5 1 1

) E 4 0 ) ) 0 ) 2 2 0 2 0 0 2 1 1 6 8 0 2 2 2 1 0 0 A 0 0 0 - - A 0 3 3 ( 2 0 0 ë 0 ¿ 0 0 T 4 2 ( 2 L 0 ( ( K K O 6 E 8 8 V - 0 6 6 E 4 T E E V L W W R B E 2 2 F R D

) ) 0 0 9 9 0 0 1 1 0 0 0 - 0 3 3 0 0 0 0 2 ( 2 ( K K 0 0 1 1 W W 2 2

) 5 0 1 1 ) ) 0 7 V 4 0 0 0 2 0 1 0 1 0 4 0 2 0 ( 0 - 3 1 1 1 V 0 A S 0 A ( 4 2 ( 7 - 0 0 E E 0 7 T T 3 2 4 2 5 E E L B 2 R L E R / T E

) 0 1 0 ) 9 ) 1 1 5 0 2 9 0 0 2 9 0 0 0 0 - 0 0 2 2 0 - ( 1 6 . 8 0 2 3 ( 0 0 R 2 W E E E ( 5 T P 1 1 C T E E M P L L U W E E

) ) 2 9 8 1 0 2 1 0 0 0 0 0 - 2 M 2 7 0 1 0 4 8 3 0 0 ( 0 ( 6 R E E 2 - 0 E T T 6 E E 2 4 P L L V M E E A B U

) 0 9 0 1 0 0 3 0 0 2 ( K E 0 T 1 E L W E


S ) ) ) T 6 9 L 0 5 1 O 9 6 2 0 V 1 0 0 E 0 0 0 0 E 0 0 - 2 - 3 R 3 F 0 0 4 1 8 H 0 0 3 ( C 2 ( ( N K C R I E - 0 5 P 0 1 1 Z 3 M , T 9 W U 2 2 M J

) 7 ) 1 3 1 5 1 1 0 0 0 1 0 0 0 0 3 2 ( 0 5 K ( 2 0 E E 2 E T T T E E E W 0 1 L L L 2 / P I E E E 1 T D D D

) ) ) 9 0 6 5 1 V 9 2 6 0 0 1 0 0 2 0 0 0 1 0 0 0 - C - 3 A 3 0 2 0 4 1 H 0 0 8 3 ( C 2 ( ( R N K C I E 5 - 0 P 8 1 1 Z 2 M , T 7 W U 2 2 M J

) 7 ) 1 3 1 5 1 1 0 0 0 1 0 0 0 0 3 2 0 ( 5 K ( 2 0 E E 2 E T T T E E E W 0 1 L L L 2 / P I E E E 1 T D D D

) ) 7 5 9 0 6 0 0 0 0 0 0 - 0 3 1 0 0 4 4 0 0 ( ( E E E A 8 T T T 0 4 E E E 1 1 L L L P 4 E E E Z N D D D T 1

) 0 V 9 0 0 2 1 1 0 C 0 A 3 0 H 0 2 C ( N K I E - 0 E T 7 1 T E E 2 L L , 5 W E E 2 2 D D

) ) ) 9 9 9 1 1 1 2 2 2 0 0 0 0 0 0 0 - 0 - 0 2 2 2 1 1 1 8 8 8 3 ( 3 ( 3 ( R R R E E E E E T T P P P E E L L M M M E E U U U D D J J J

) ) ) 9 9 9 1 1 1 2 2 2 0 0 0 0 0 0 0 - 0 - 0 2 2 2 1 1 1 8 8 8 3 ( 3 ( 3 ( R R R E E E E E P P P T T E E M M M L L U U U E E J J J D D

) 5 1 4 1 0 0 1 0 4 2 ( F u 0 E E E E 7 T T T T 4 E E E E L L L V L 5 E E E E 3 D D D D

) ) )

) 5

) ) )

) 7 ) 0 ) ) ) 9 4 9 6 9 9 0 1 5 1 2 0 2 6 0 2 0 0 0 0 5 0 0 0 0 0 - 0 0 - 0 - 0 3 3 2 2 3 2 0 ( 1 1 4 F 0 8 8 0 n 4 3 ( 3 ( 0 0 ( C 7 ( C R R 5 E . 4 5 E 7 V 1 P P Z 0 Z M M T 0 T U U M 1 M J J

) ) ) 7 ) 9 9 1 2 1 1 1 3 2 2 1 0 0 0 0 1 0 0 0 0 0 - 0 - 1 0 2 2 0 4 1 1 0 0 8 8 2 6 3 ( 3 ( ( K 0 R R E E E 2 ( 7 P P T 1 E 8 M M L W 2 U U E / V J J D 1 T L

) E 9 4 1 0 ) ) ) 5 - 6 4 4 6 6 4 2 6 3 9 5 0 A 0 0 0 0 0 A 0 ( - 0 - 0 S 2 2 / 0 0 1 H 4 5 0 5 + 0 0 ( 0 ( ( G 0 E S Y 6 T 2 0 4 0 E G 1 9 3 L R A 3 E M V S 2 D F T K C

E E E E E T T T T T E E E E E L L L L L E E E E E D D D D D

) 4 9 2 0 0 0 8 0 0 2 ( 3 3 E E E E T T W T T E E 2 E E L L L L E E F E E D D R D D

) 0 4 5 0 0 0 2 0 4 0 ( E E E A E T T T 0 T E E E 2 E L L L L U E E E E R D D D D

) ) 7 5 9 0 6 0 0 0 0 0 0 - 0 3 1 0 0 4 4 0 0 ( ( E E E A 8 T T T 0 4 E E E 1 1 L L L P 4 E E E Z N D D D T 1

) 7 ) 0 ) ) ) 9 4 9 6 9 9 0 1 5 1 2 0 2 6 0 2 0 0 - 0 0 0 0 5 0 0 0 0 0 - 0 0 - - 2 3 3 3 2 0 2 1 ( 0 4 F 4 8 1 8 0 n 0 ( 3 ( 3 ( 0 C 7 ( C R R 5 E . 4 5 E 7 V 1 P P Z 0 Z M M T 0 T U U M 1 M J J

) ) ) 9 1 ) 4 9 ) 6 7 3 5 3 7 4 1 0 0 9 2 1 0 0 4 0 1 0 0 - 0 0 0 - 1 - 0 1 0 1 0 0 0 0 1 0 2 2 4 0 2 ( 2 0 2 ( F 4 ( 0 2 K p 0 F ( ( u K 7 1 . 0 0 2 4 6 4 2 5 U 2 G W V V W 0 5 5 2 / 8 / 0 R 3 1 1 5 1

T

) ) ) 7 ) 9 9 1 2 1 1 1 3 2 2 1 0 0 0 0 1 0 0 0 0 0 - 0 - 1 0 2 2 0 4 1 1 0 0 8 8 2 3 ( 3 ( 6 ( K 0 R R E E E 2 ( 7 P P T 1 E 8 M M L W 2 E U U / V L J J D 1 T

) E 9 4 1 0 ) ) ) 5 - 6 4 4 6 6 4 2 6 3 9 5 0 A 0 0 0 0 0 A 0 ( - 0 - 0 S 2 2 / 0 0 1 H 4 5 0 5 + 0 0 ( 0 ( ( G 0 Y E S 6 T 2 0 4 0 E G 1 9 3 L R A 3 E M V S 2 D F T K C

) ) ) 9 1 ) 4 9 ) 6 7 3 5 3 7 4 1 0 0 9 2 1 0 0 4 0 1 0 0 - 0 0 0 - 1 - 0 1 0 1 0 0 - 0 2 2 0 1 0 4 0 2 ( 2 0 2 0 ( F 4 ( F 2 K p 0 ( u ( 7 1 . 0 0 K 6 4 2 2 4 5 U 2 G W V V W 0 5 5 2 / 8 / 0 R 3 1 1 5 1

) 4


) ) 1 S ) ) 4 6 0 T 1 9 L 6 2 0 9 1 O 6 0 5 0 V 3 0 0 0 E 0 0 E 0 1 1 0 0 R - - 0 0 F 1 3 0 4 ( 0 2 ( 2 H 0 K F C 5 0 0 u 2 ( ( 6 2 N I 2 5 2 E - Y 0 0 3 2 W V T E 3 , 3 2 0 L 9 2 W / 6 E 2 C 2 1 1 D

) ) ) E 4 1 4 0 ) 6 0 0 2 1 9 0 V 0 9 1 0 0 0 2 - 5 0 2 6 0 0 1 2 0 1 1 C A 0 0 0 A A 3 0 4 2 2 ( H ( T 0 0 ( K F C L u 2 ( 6 O 2 N I 2 5 2 E - V 8 E 2 W V T E 2 0 L , E / 6 E 7 R W 2 2 F 2 1 1 D

V 0 2 1 C A H C N E E E I - E E T T T T 7 T E E E E E 2 L L L L L , 5 E E E E E 2 D D D D D

T

) ) 9 1 5 6 1 4 0 2 0 0 0 0 - 6 1 0 0 3 4 2 ( 2 4 ( F 2 u 2 0 V 2 0 2 5 V 2 5 C 3 A

) ) ) ) ) 9 9 9 8 1 1 8 H 1 2 2 0 2 2 0 0 1 0 0 0 0 0 0 0 0 0 - 0 - 0 - 0 3 2 2 1 - 2 1 1 1 9 8 8 8 0 0 2 3 3 3 2 A ( ( ( ( R R K A ( R E E E 1 H P P P u 0 M M M W 0 U U U 2 / 8 J J J 1

) F 2 0 0 0 3 9 2 1 4 E A E E U T ( A T T G E H E E L L 5 L E R m E E 1 D 6 D D

) 9 1 2 0 0 0 2 1 8 3 ( R E E T P E L M E U D J

) F 2 0 0 0 3 9 2 1 4 E A E E U T ( A T T E E G E 5 L H L L R E m E E 1 D 6 D D

) ) 9 5 1 ) 6 1 9 4 0 1 2 0 2 0 0 E 0 6 0 T 0 0 0 E 1 0 3 2 L 4 2 ( 1 E 8 D 2 ( 4 F 2 3 ( u 2 R V E E E 0 2 T P T 2 0 5 E E L M L V 2 E U E 5 C D J D 3 A

) ) 9 9 1 1 2 2 0 0 0 0 0 - 0 2 2 1 1 8 8 3 ( 3 ( R R E E E E E P P T T T E E E M M L L L U U E E E J J D D D

) ) ) ) ) 9 9 9 8 1 1 8 H 1 2 2 0 2 2 0 0 1 0 0 0 0 0 0 0 0 0 - 0 - 0 - 0 3 2 2 1 - 1 2 1 1 9 8 8 8 0 0 2 3 3 3 2 A ( ( ( ( R R K A ( R E E E 1 H P P P u M M M W 0 0 U U U 2 / 8 J J J 1

) 9 9 2 ) ) ) ) 0 6 3 8 8 0 9 3 8 8 0 2 2 1 1 1 0 0 0 0 0 0 0 0 0 9 0 - 0 2 - 0 - 0 - ( 3 2 5 0 0 0 5 0 D 4 4 4 4 A 0 ( 0 1 ( ( 1 ( E B S D D B 6 2 1 1 E . 3 3 L 5 1 B G 4 Z L C 4 C U T M N N O M F E E D

) F 2 0 0 0 3 9 2 1 4 E A E E U T A T T G E ( E E 5 L H L L R E m E E 1 D 6 D D

) ) ) 5 5 9 5 ) 8 1 1 9 0 4 0 1 0 1 0 2 0 0 0 0 0 0 1 0 - 6 0 0 1 - 0 3 2 0 0 4 2 ( 1 2 ( 2 8 K ( 4 3 0 F 2 ( 2 R 0 u V E E 1 0 7 0 T P 4 5 E L M W V 2 E U 2 / 5 C D J 1 3 A


) H 2 0 0 0 3 9 2 A A ( E E E E H T T T T E E u E E L L L 0 L 0 E E E E 8 D D D D

) ) ) ) 2 3 8 8 6 9 8 8 5 4 1 1 0 0 0 0 0 0 0 0 0 - 0 - 0 - 0 3 2 5 0 0 5 0 0 4 4 4 4 0 0 1 ( ( 1 ( B ( 1 D D 5 4 1 1 E . 3 7 U 3 4 4 T Z G C C E L T 5 R N N E M 1 E E D

) ) ) 9 5 5 ) 8 5 1


) 9 9 2 ) ) ) ) 0 6 3 2 2 0 9 3 5 5 0 2 2 1 1 1 0 0 0 0 0 0 0 0 0 9 0 - 0 - 0 - 0 - 2 3 2 5 5 ( 0 0 0 0 D 4 4 4 4 A 0 ( 0 ( 1 ( 1 E ( B S D D B 6 1 1 E . 2 6 6 L 5 1 B G 5 Z L C 5 C U T M N N O M F E E D

) )

) )

) ) ) ) 2 3 2 2

S a m s u n g E l e c t r o n i c s

6-2 Part Description (P/D) According to Screen Size (CONTIN UED) NO. 88 89 90

LOC. NO. RX02 DY-CONN. J414

91 92 93 94 95

21Q (AC120V ) 1/8W 62K(2004-001990) DELETE 1/2 0.39(2001-003019)

21Q (FREE VOLT) 1/8W 62K(2004-001990) DELETE 1/2 0.39(2001-003019)

25-INCH 1R(AC 120V) 1/8W 62K(2004-001990) DELETE JUMPER (3812-000219)

27-INCH 1R(AC 120V) 1/8W 62K(2004-001990) NEW DELETE JUMPER (3812-000219)

28-INCH Q(AC 120V) 1.5R 1/8W 62K(2004-001990) DELETE JUMPER (3812-000219)

28-INCH Q(FREE VOLT) 1/8W 62K(2004-001990)

R419 RF 1/ 2W 0.47(2008-000252) L204 10 Uh(2701-000114) J413(R420)JUMPER (3812-000219) C208 DELETE L402(03 lot)DELETE

RF 1/ 2W 0.47(2008-000252) 10 Uh(2701-000114) JUMPER (3812-000219) DELETE DELETE

RF 2W 1.5(2008-000257) 10 Uh(2701-000114) JUMPER (3812-000219) DELETE BEAD AXIAL(3301-000287)

RF 2W 0.68(2008-000254) 10 Uh(2701-000114) RF 1/2W 0.47 AX(2008-000252) DELETE BEAD AXIAL(3301-000287)

RF 2W 1.2 10 Uh(2701-000114) RF 1/2W 0.47 AX(2008-000252) P 50V 103(2301-000380) DELETE

RF 2W 1.2 10 Uh(2701-000114) RF1/2W 0.47 AX(2008-000252) P 50V 103(2301-000380) DELETE

96 97 98 99 100

J417 J418 C244 C405 R415

JUM PER (3812-000219) JUM PER (3812-000219) 50V 2.2 UF(2401-000660) P 250V 224(2301-000213) 2W 4.7K(2003-002007)


DELETE DELETE 50V 4.7 UF(2401-001271) P 250V 104(2305-000704) 1W 3.9K(2003-000993)

DELETE DELETE 50V 4.7 UF(2401-001271) P 250V 104(2305-000704) 1W 3.9K(2003-000993)



101

L203

JUMPER (3812-000219)

JUMPER (3812-000219)

BEAD AXIAL(3301-000287)

BEAD AXIAL(3301-000287)

BEAD AXIAL(3301-000287)

BEAD AXIAL(3301-000287)

JUMPER (3812-000219)

E l e c t r i c P a r t

6 - 8

6-3 CRT PCB PART (TDA6101Q IC) NO.

LOC. NO. TXG2045 TXG2046 CT5346BVC/ SEM CT5377BVC/ SEM

1 2 3 4 5

S a m s u n g E l e c t r

PCB-ASSY CN501B CN502B CN501B CN502B

19-INCH/ 20-INCH/ 21-INCH CT5072BVC/ GE CT566BV/ SAM CT5372BVC/ GE CT566BV/ SEP CT5399BVC/ M ABY CT566BW/ SEP CT5072BVC/ RCL CT566BW/ SEP CT5377BVC/ SAM CT566BV/ GE CT5372BVC/ SEP CT566BW/ SEM CN5372

25-INCH TXG2545 TXG2547 TXG2548 CT6346VC/ SEM TXH2555 TXH2556 CT6346VC/ GE CT6346VC/ SEP

23-INCH CT6202BVC/ M ABY

AT M AIN DIRECT(AA39-20053A) DIRECT(AA39-20053A) DIRECT DIRECT 1/ 2W 61.9K(2004-001-899) 1/ 2W 61.9K(2004-001-899) 1/ 2W 61.9K(2004-001-899) RF 2W 1.5(2008-000257) RF 2W 0.18(2008-001011) NOT USED

TXG2745 TXG2746 TXH2756 CT6846VC/ SEM CT6846VC/ GE CT6846VC/ SEP

CT7251VC/ IRT CT7202BVC/ MABY CT7202BVC/ SEM CT766W/ SEM TXH2869 TXH2879 CT7202W BC/SEM

SUB ASSY L-CON(AA39-20020J) L-CON(AA39-20029K) POSTHEADER(3711-001011) POSTHEADER(3711-001097)

6 7 8 9 10

R511 R512 R513 R525 J512

11 12 13 14 15

J513 CRT-SOCKET C504 C505 C506

16 17 18 19 20

Q501 C520 D505 D506 D507

DELETE DELETE DELETE DELETE DELETE

C815Y(0501-000389) 50V 104 P(2306-000122) 1N4148(0401-000005) 1N4148(0401-000005) 1N4148(0401-000005)

21

C501

63V 474(2305-000412)

DELETE

NOT USED DHE-A93-700(3704-000109) C-C 15P(2202-000162) C-C 15P(2202-000162) C-C 15P(2202-000162)

27-INCH/ 28-INCH CT766DW/ SEP

1/ 2W 100K(2004-001373) 1/ 2W 100K(2004-001373) 1/ 2W 100K(2004-001373) RF 2W 3.9(2008-001049) JUM PER(3812-000219) DELETE JUM PER(3812-000220)

DELETE

1/ 2W 110K(2004-002011) 1/ 2W 110K(2004-002011) 1/ 2W 110K(2004-002011) RF 2W 1(2008-000266) JUM PER(3812-000219) DELETE JUM PER(3812-000219) DHE-A90-700(3704-000111) C-C 5.6P(2202-002005) C-C 5.6P(2202-002005) C-C 5.6P(2202-002005)

DELETE

E l e c t r i c P a r t s L i s t

S a m s u n g E l e c t r o n i c s

6-3 CRT PCB PART (TDA6101Q IC) (CONTINUED) NO.

LOC. NO.

19-INCH/ 20-INCH/ 21-INCH

23 24 25

DZ503 DZ504 R524

DELETE DELETE 1/ 2W RC4.7K(2002-000330)

M TZ13A(0403-000655) M TZ13A(0403-000655) 1/ 2W RC4.7K(2002-000330)

26 27 28 29 30

IC501-H/ S IC502-H/ S IC503-H/ S C511 C512


AA61-10060A AA61-10060A AA61-10060A AC250V474(2305-000410) AC250V474(2305-000410)

AT M AIN

AA41-10459A

31

CRT-PCB

25-INCH

23-INCH

27-INCH/ 28-INCH

E l e c t r i c P a r t


6-4 COM B FILTER OPTION STEREO NO.

REM ARK

LOC. NO.

COM B

COM B

S-VHS

1 2 3 4 5

C209 R241 R242 R243 C206


(P)474(2305-000411) 820K(2004-001284) 430K(2001-000755) 1M (2001-000435) (P)102(2301-000192)

(P)474(2305-000411) 820K(2004-001284) 430K(2001-000755) 1M (2001-000435) (P)102(2301-000192)

Y-IN Y-IN Y-IN Y-IN C-IN

6 7 8 9 10

JF01 JF02 JF03 JF04 J713

DELETE DELETE DELETE DELETE JUMPER (3812-000219)

JUM PER (3812-000219) JUM PER (3812-000219) JUM PER (3812-000219) JUM PER (3812-000219) JUMPER (3812-000219)

DELETE JUM PER (3812-000219) DELETE JUM PER (3812-000219) DELETE

COM B-C

11 12 13

CF01 JC01 R819

DELETE JUM PER (3812-000219) 2W 27 AF(2003-001035)

UGL-352KN T(AA29-10002A) JUM PER (3812-000219) 2W 22 AF(2003-000592)

U GL-352KN T(AA29-10002A) DELETE 2W 22 AF(2003-000592)

COM B FILTER CAPTION LINE B+ SETTING

6-5 AUDIO OUT OPTION NO.

LOC. NO.

NO OUT(M ONO)

NO OUT(ST)

VAO

M ONITOR OUT

COM B-Y


6-6 VIDEO OUT OPTION NO.

LOC. NO.

VIDEO OUT USED

VIDEO OUT NOT USED

1 2 3 4 5

RA06 RA07 RA08 RA09 RA10

47K(2001-000786) 18K(2001-000411) 470(2001-000780) 150(2001-000362) 150(2001-000362)


6 7 8 9 10

RA11 CA01 CA02 QA01 QA02

1/ 2W 75(2001-001187) 25V 470uF(2401-001397) 25V 47uF(2401-001530) C815Y(0501-000389) A539Y(0501-000283)


11

JA701

3P OR 5P

6P(OR +SVHS PIN)

6-7 M ONO STEREO OPTION N O. 1 2 3 4 5

LOC. N O. C201 C214 C231 C243 C622

STEREO(CT566BW )

M ON O(CT566BV)

REM ARK

AX 25V 103(2202-000127) P 50V 104(2305-000665) P 50V 104(2305-000665) 50V 33 (CH)(2201-000487) 25V 470 UF(2401-001397)

DELETE DELETE DELETE P 50V 472(2301-000264) DELETE

1 CHIP PART 1 CHIP PART 1 CHIP PART 1 CHIP PART CONTROL IC PART


6-7 M ONO STEREO OPTION (CONTIN UED) NO. 29 30

LOC. NO. CM 01 CN701

STEREO(CT566BW) DELETE 3711-002648

MONO(CT566BV) AX 473(2202-000819) DELETE

REM ARK M TS PART AV SW,JACK PART

31 32 33 34 35

CN702 CU01 CUD01 CUD02 CUD03

DELETE DELETE P 63V 473(2301-000285) 50V 4.7 UF(2401-001271) 50V 4.7 UF(2401-001271)

3711-002645 p 63v 224(2305-000289) DELETE DELETE DELETE

AV SW,JACK PART M TS PART M TS PART M TS PART M TS PART

36 37 38 39 40

CUD04 CUD05 CUD06 CUD07 CUD08

P 63V 474(2305-000412) p 63v 224(2305-000289) 50V 4.7 UF(2401-001271) 50V 4.7 UF(2401-001271) 50V 2.2 Uf(2401-000660)


M TS PART M TS PART M TS PART M TS PART M TS PART

41 42 43 44 45

CUD09 CUD10 CUD11 CUD12 CUD13

P 50V 153(2301-000175) 16V 100uF(2401-001840) 50V 2.2 Uf(2401-000660) 50V 10 UF(2401-000480) 50V 10 UF(2401-000480)


M TS PART M TS PART M TS PART M TS PART M TS PART

46 47 48 49 50

CUD14 D602 DZ701 IC602 IC701

50V 1 UF(2401-000603) 1N4148(0401-000005) M TZ 9.1B(0403-000563) upc1406(1204-000395) TC4053(0801-000961)


M TS PART CONTROL IC PART AV SW,JACK PART CONTROL IC PART AV SW,JACK PART

03 LOT


6-7 M ONO STEREO OPTION (CONTIN UED) NO. 73 74 75

LOC. NO. JM 06 JM 07 JM 07

STEREO(CT566BW) DELETE DELETE DELETE

MONO(CT566BV) JUM PER (3812-000219) p 63v 224(2305-000289) JUM PER (3812-000219)

REM ARK AV SW,JACK PART M TS PART M TS PART

76 77 78 79 80

JM C2 JM V02 JUD01 JUD02 JUD03

DELETE DELETE JUM PER (3812-000219) JUM PER (3812-000219) JUM PER (3812-000219)

JUM PER (3812-000219) JUM PER (3812-000219) DELETE DELETE DELETE

1 CHIP PART M TS PART M TS PART M TS PART M TS PART

81 82 83 84 85

JUD04 JUD07 JUD09 JV01 Q602

JUM PER (3812-000219) JUD07 JUM PER (3812-000219) DELETE A539Y(0501-000283)

DELETE DELETE DELETE JUM PER (3812-000219) DELETE

M TS PART M TS PART M TS PART AV SW,JACK PART CONTROL IC PART

86 87 88 89 90

Q701 Q702 R245 R606 R610

KSR1010(0504-000123) C815Y(0501-000389) DELETE 1/8W 2.2K(2001-000449) 1/ 2W 47(2001-001153)

DELETE DELETE 1/ 8W 100 K(2001-000273) 1/8W 15 K(2001-000008) DELETE

AV SW,JACK PART AV SW,JACK PART 1 CHIP PART MTS PART CONTROL IC PART

91 92 93 94

R611 R614 R616 R620 R

1/ 8W 1/ 8W 1/ 8W 1/ 8W / 8W


CONTROL IC PART CONTROL IC PART CONTROL IC PART CONTROL IC PART CONTROL IC PART

100 K(2001-000273) 10 K(2001-000290) 4.7K(2001-000734) 100(2001-000281) ( )

02 LOT 03 LOT


6-8 SOUND OUTPUT OPTION N O.

LOC. N O.

CT566BV

CT566BW / 567BW / 568BW

CT633BW / 683BW

CT766DW

CN 765

1 2 3 4 5

R617 R618 R622 R623 R632

10K 10K(2001-000290) 5.6K(2001-000812) 5.6K(2001-000812) 10K 10K(2001-000290) 5.6K(2001-000812) 5.6K(2001-000812) 270K(2001-000548) 270K(2001-000548)

10K(2001-000290) 10K(2001-000290) 10K(2001-000290) 5.6K(2001-000812) 5.6K(2001-000812) 8.2K(2001-000977) 10K(2001-000290) 10K(2001-000290) 10K(2001-000290) 5.6K(2001-000812) 5.6K(2001-000812) 8.2K(2001-000977) 270K(2001-000548) 270K(2001-000548) 240K(2001-000531)

6

R606

100(2001-000281)

100(2001-000281)

2.2K(2001-000449)

6-9 JACK

CODE NO

SPEC

FUNCTION

BACK

3722-001104 3722-001215 3722-001261

3P 6P 5P+SVHS

VIDEO 1 INPUT 1 INPUT+M ONITOR OUT 1 INPUT+VAO+SVHS

FRONT

3722-001031 3722-001282

3P 2P

ST M ONO

2.2K(2001-000449)

2.2K(2001-000449)


6-10 CT566BVX/STR (CT566BW X/STR AND CT566BVX/STR Dissimilar Parts) Loc . N o.

Code N o.

De sc ri pt ion ; Spe ci fi ca ti on

Re ma rk

Loc . N o.

Code N o.

ASSY-CABINET * AA90-70091C AA64-60052K

De sc ri pti on ; S pe ci fi ca ti on

Re ma rk

ASSY-CABINET,FRONT

ASSY-CABINET;566B,CT566BVX/STR

* AA91-10329C

INLAY-BACK;KCT57A,NT MONO,PS SHEET,T0.5,B

ASSY-CABINET,FRONT;-,CT566BV,PA100,HB,BLK

AA64-31110B

CABINET-FRONT;-,CT566BV,BK-708P EGN,HIPS,HB,

AA64-60278Q

INLAY-AV;KCT57A,M/ N GOLD,PS,T0.3,BLK,-,

6-11 CT566BVX/XAP (CT566BW X/STR AND CT566BVX/XAP Dissimilar Parts) Loc . N o.

Code N o.


Re ma rk

ASSY-PCB,MAIN * AA94-10122L

ASSY-PCB,MAIN(OPT);CT566BVX/XAP,KCT57A,PANAMA,-

C243

2301-000264 C-FILM,PEF;4.7nF,5%,50V,TP,6.5X5.5X3.0X5,

C650

2202-000222 C-CERAMIC,MLC-AXIAL;3.3nF,20%,16V,Y5P,TP,-,7.5

Loc . N o.

Code N o.


REM OCON AA59- 10095R REM OCON;-,TM 59,RM3 22,24,L/ GRY EX,SS

ASSY-CABINET

Re ma rk


6-12 CT567BWX/STR (CT566BWX/STR AND CT567BWX/STR Dissimilar Parts) Loc . N o.

Code N o.


Re ma rk

Loc . N o.

Code N o.

ASSY-PCB,MAIN

Re ma rk

ASSY-HOLDER,SPK

*

AA94-10127NASSY-PCB,MAIN(OPT);CT567BWX/STR,KCT57A,PERU,-

DIODE

0403-000704 DIODE-ZENER;TZP7.5B,7.5V,7.5-8.4V,1W,DO-41

WIRE1

AA65-30002ACLAMP-FBT;NYLON-66,V0,BLK,-,-,-

WIRE2

AA65-30009ACLAMP-FBT;ABS,V0,BLK,-,-,-

*

AA91-60289AASSY-HOLDER,SPK;567BW ,-,PP,HB,BLK,8ohm,6W,600

ASSY-CABINET,FRONT *

AA91-10331AASSY-CABINET,FRONT;-,567B,PA100,HB,BLK AA63- 50334A GRILLE-W OOFER,L;-,567B,PA110,SECC,T0.5,-,-

ASSY-CABINET *


AA63- 50335A GRILLE-W OOFER,R;-,567B,PA110,SECC,T0.5,-,AA64- 10716B KNOB-POWER;-,Q21,TS,ABS,HB,MET BROWN

AA90-70095BASSY-CABINET;567B,CT567BWX/STR

AA64-10717AKNOB-CONTROL;-,-,-,ABS,HB,MET BROWN AA64- 31115A CABINET-FRONT;-,CT567BW,BK-708P,HIPS,HB,BLK,

6002-0 00516 SCREW-TAPPING;RH,+,2,M 4,L20,ZPC(BLK),SWRCH18

AA64- 40431A WIN DOW-REMOCON;-,50 3E,-,ABS,HB,LG41338,-

AA60- 10002A SCREW-TAPPING;RH,+,M4, L12,ZPC(YEL),-,OD14

AA64- 40432A INDICATOR-LED;-,503E,-,PM M A,HB,CLR,AA64- 40462A DECORATION-FRONT;-,CT567BW,KSP213,HIPS,VO,L/GRA AA64- 60278S INLAY-AV;KCT57A,S/T GOLD,PS,T0.3,KSP213

6-13 CT567BW X/XAP (CT566BWX/STR AND CT567BWX/XAP Dissimilar Parts) Loc . N o.

Code N o.


Re ma rk

Loc . N o.

Code N o.


Re ma rk


6-14 CT766DW X/STR (CT566BW X/STR AND CT766DW X/STR Dissimilar Parts) Loc . N o.

Code N o.


Re ma rk

Loc . N o.

ASSY-PCB,MAIN * *

C208

2301-000192 C-FILM,PEF;1nF,5%,50V,TP,5.3x10mm,5mm

C209

!

!

!

!


C228

2401-000660 C-AL;2.2uF,20%,50V,GP,TP,5x11mm,5mm

C237


C307

2401-003140 C-AL;47uF,20%,50V,WT/NP,TP,10x20,5

C402

2306-000204 C-FILM,M PPF;430nF,5%,400V,TP,26x20.5x12.5,

C417

2305-000178 C-FILM,M PEF;10nF,5%,100V,TP,-,5mm

C419

2301-000224 C-FILM,PEF;22nF,5%,50V,TP,7.4x3.9x13mm,5m

C801

2401-001426 C-AL;470uF,20%,400V,GP,-,35x45mm,10

C820

2401-003141 C-AL;2200uF,20%,25V,WT,TP,13x25,5mm

C822

2201-000963 C-CERAMIC,DISC;1nF,20%,400V,Y5U,TP,11x8mm,10m

C852

2401-002461 C-AL;220uF,20%,35V,GP,TP,10x12,5

C854


C856

2401-000903 C-AL;22uF,20%,160V,WT,TP,10x20mm,5m

CB01 CB19

2306-000318 C-FILM,M PPF;220nF,20%,250V,TP,-,22.5mm 2303-001026 C-FILM,PPF;33nF,10%,400V,TP,20x15x8,7.5

Q803

0501-000366 TR-SMALL SIGNAL;KSC2330-Y,NPN,1W,TO-92L,-,70-1

R217

2004-001301 R-METAL;82Kohm,5%,1/8W,AA,TP,1.8x3.2mm

R241

2004-001284 R-METAL;820Kohm,5%,1/8W,AA,TP,1.8x3.2m

R243

2001-000435 R-CARBON;1Mohm,5%,1/8W,AA,TP,1.8x3.2mm

R247


R250

2001-000052 R-CARBON(S);3.3Kohm,5%,1/2W,AA,TP,2.4x6.4m

R301

2001-000006 R-CARBON;2.4Kohm,5%,1/8W,AA,TP,1.8x3.2m

R306

2003-002009 R-METAL OXIDE(S);390ohm,5%,2W,AF,TP,3.9x10mm

R309

2003-002009 R-METAL OXIDE(S);390ohm,5%,2W,AF,TP,3.9x10mm

R310

2008-001011 R-FUSIBLE(S);0.18ohm,10%,2W,AF,TP,3.9x10mm

R311

2003-002069 R-METAL OXIDE;470ohm,5%,2W,AF,TP,3.9x10mm

R404

2001-000117 R-CARBON(S);68ohm,5%,1/2W,AA,TP,2.4x6.4mm

R406

2003-002008 R-METAL OXIDE(S);18Kohm,5%,2W,AF,TP,3.9x10mm

R407


!

R409


!

R411

2004-002022 R-METAL(S);51Kohm,1%,1/2W,AA,TP,2.4x6.4mm

!

R412

2004-001967 R-METAL(S);68Kohm,1%,1/2W,AA,TP,6.5x2.5mm

R413

2001-003019 R-CARBON(S);0.39ohm,10%,1/2W,AA,TP,2.4x6.4

R419


R420

2008-000221 R-FUSIBLE;0.47ohm,10%,1/2W,AA,TP,4.7x11m

R801

2009-001011 R-METAL PLATE;0.18ohm,10%,5W,CL,TP,5x14x18mm

R802

2001-001117 R-CARBON(S);2Kohm,5%,1/2W,AA,TP,2.4x6.4mm

R803


2306-000329 C-FILM,M PPF;7nF,3%,1.6KV,TP,28.5x18.5x11mm

C621

0502-000244 TR-POWER;KSA940,PNP,1.5W,TO-220,-,40-14 0501-000366 TR-SMALL SIGNAL;KSC2330-Y,NPN,1W,TO-92L,-,70-1

2306-000237 C-FILM,M PPF;6.3nF,5%,1.6KV,TP,28.5x18x11.5

C404

Q802


2305-000411 C-FILM,M PEF;470nF,5%,50V,TP,7.3x4.8x5.5mm,

C214

Re ma rk

R211

AA94-10126XASSY-PCB,MAIN(OPT);CT766DWX/XAP,KCT57A,PANAMA,-



Q804

AA94-10128PASSY-PCB,MAIN(OPT);CT766DWX/STR,KCT57A,PERU,-

C206

Code N o.


Lo c. N o.

Co de N o.

D esc ri pt io n ; S pe ci fi ca ti on

Re ma rk

Lo c. N o.

ASSY-CRT ! !

* *

AA03-10029GCRT-COLOR;-,A70QBZ791X001(B),0mG,29,100 AA03-10029CCRT-COLOR;-,A70QBZ791X001(B),+200mG,29,

PERU PANAMA

ASSY-PCB,CRT !

Co de N o.


Re ma rk

R516

2001-000490 R-CARBON;200ohm,5%,1/8W,AA,TP,1.8x3.2mm

R517*

2002-001009 R-COMPOSITION;2.7Kohm,10%,1/2W,AA,TP,3.7X9.0

R518*


R519*


R522


R525

2008-000266 R-FUSIBLE(S);1ohm,5%,2W,AF,TP,3.9x10mm

R526


V999

3704-000114 SOCKET-CRT;14P,29.1,35.5,SN,ISH09S/BK

*

AA95-20009WASSY-PCB,CRT;-,KCT57A,29,JUNGNAMMI,-

C502


C503

2401-000832 C-AL;220uF,20%,25V,GP,TP,8x11.5,5mm

C504

2202-000162 C-CERAM IC,MLC-AXIAL;15pF,5%,50V,SL,TP,3.5x19,-

C505


C506


C507

2201-000556 C-CERAM IC,DISC;470pF,10%,500V,Y5P,TP,7x4,5

C508


C509


C510

2401-001232 C-AL;4.7uF,20%,250V,GP,TP,10x12.5mm

C511

2305-000011 C-FILM,M PEF;470nF,5%,250V,TP,21.5X13.0X7.9

C512


C514

2201-000379 C-CERAM IC,DISC;22nF,+80-20%,50V,Y5V,TP,8.0X4.

C515

2401-000430 C-AL;10uF,20%,250V,GP,TP,10x16mm,5m

C516


*

AA90-70103BASSY-CABINET;766D,CT766DWX/STR

C517

2201-000158 C-CERAM IC,DISC;10nF,+80-20%,3KV,Y5V,BK,-,10mm

*

AA90-70103AASSY-CABINET;766D,CT766DWX/XAP

C519

2401-000832 C-AL;220uF,20%,25V,GP,TP,8x11.5,5mm

C520

2306-000122 C-FILM,M PPF;100nF,5%,50V,TP,7.3x4.0x5.0mm,

C555

2201-000144 C-CERAM IC,DISC;100pF,5%,50V,CH,TP,8x3,5

AV+CF

6002-000514 SCREW-TAPPING;RH,+,2,M4,L15,ZPC(BLK),SWRCH18

CN501

AA39-20020CLEAD-CONNECTOR,ASSY;-,67096-005,S,5P,500,1007#26

CB+RCA

6002-0 00516 SCREW-TAPPING;RH,+,2,M 4,L20,ZPC(BLK),SWRCH18

CN501B

3711-0 02644 CONNECTOR-HEADER;BOX,5P,1R,2.5mm,STRAIGHT,SN

ASSY-SPEAKER 3001-000274 SPEAKER;5W,8ohm,90dB,160Hz

ASSY-PCB,A/V SIDE *

AA95-90028WASSY-PCB,A/V SIDE;-,CT766DWX/XAP,KCT57A,NTSC,100

CN701B

AA39-20112F LEAD CONNECTOR-ASSY;-,YBNH025-09,67096-9,9P,700mm

ASSY-CABINET

AA63- 10050A BAND-TIE,DCOIL;2955,PA,V0,-,-,W HT,-,-

PANAMA


6-15 CT566BWX/STR Parts List Loc . N o.

Code N o.


Re ma rk

Loc . N o.

ASSY-PCB,MAIN *

AA94-10122J ASSY-PCB,MAIN(OPT);CT566BWX/STR,KCT57A,PERU,!

C101

2401-000962 C-AL;22uF,20%,50V,GP,TP,5x11,5

C102

2401-001363 C-AL;470uF,20%,16V,GP,TP,10x12.5mm,

C104

2202-000127 C-CERAMIC,MLC-AXIAL;10nF,+80-20%,25V,Y5V,TP,-,7.5

C105

2401-001333 C-AL;470nF,20%,50V,GP,TP,5x11,5

C106


C107

2401-001333 C-AL;470nF,20%,50V,GP,TP,5x11,5

C108

2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5

C110

2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5mm

C111

2202-000286 C-CERAMIC,MLC-AXIAL;56pF,5%,50V,SL,TP,1.9x3.5,-

C112


C113


C116


C117


C201


C202


C203


C204


C205

2301-000223 C-FILM,PEF;22nF,5%,100V,TP,7.2x4.5x9.0mm,

C210

2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5mm

C211


C212

2202-000819 C-CERAMIC,MLC-AXIAL;47nF,+80-20%,50V,Y5V,TP,3.5x19

C213


!

Code N o.


Re ma rk

C308

2201-000108 C-CERAM IC,DISC;1.5nF,10%,1KV,Y5P,TP,11x5,5

C309

2202-000796 C-CERAM IC,MLC-AXIAL;1nF,10%,50V,Y5P,TP,3.5x19,-

C401


C402

2306-000329 C-FILM,M PPF;7nF,3%,1.6KV,TP,28.5x18.5x11mm

C404

2306-000187 C-FILM,MPPF;330nF,5%,400V,BK,26x20.5x13.5,

C405

2301-000213 C-FILM,PEF;220nF,5%,250V,TP,21.5x11,7.5

C406


C407

2401-001397 C-AL;470uF,20%,25V,GP,TP,10x16mm,5m

C408

2201-000551 C-CERAM IC,DISC;470pF,10%,1KV,Y5P,TP,8x5,5

C409

2401-001661 C-AL;68uF,20%,100V,GP,TP,10x16mm,5m

C410

2401-002268 C-AL;2.2uF,20%,250V,LZ,TP,8X11,5

C411


C412

2401-000927 C-AL;22uF,20%,250V,GP,TP,13x20mm,5m

C413

2401-000302 C-AL;100uF,20%,25V,GP,TP,6.3x11,5mm

C414

2201-000984 C-CERAM IC,DISC;680pF,10%,2KV,Y5P,TP,11x6,7.5m

C415

2303-000331 C-FILM,PPF;4.7nF,5%,630V,TP,19.5x12x7,7.5

C417


C418

2401-001571 C-AL;47uF,+20%-0%,50V,GP,TP,8x12,5

C501

2305-000704 C-FILM,M PEF;100nF,5%,250V,TP,16.5x10.3x5.7

C503

2401-001232 C-AL;4.7uF,20%,250V,GP,TP,10x12.5mm

C504

2202-000862 C-CERAM IC,MLC-AXIAL;390pF,10%,50V,Y5P,TP,3.5x1.9,-

C505


C506


C510

2401-000430 C-AL;10uF,20%,250V,GP,TP,10x16mm,5m

C517

2201-000969 C-CERAM IC,DISC;10nF,+80-20%,3KV,Y5V,TP,-,10mm

C520


C622

2401-001397 C-AL;470uF,20%,25V,GP,TP,10x16mm,5m


Lo c. N o.

!

!

Co de N o.


Re ma rk

Lo c. N o.

Co de N o.


C809

2401-000302 C-AL;100uF,20%,25V,GP,TP,6.3x11,5mm

CUD01

2301-000285 C-FILM,PEF;47nF,5%,50V,TP,7.5x4.0x6.5,5mm

C810

2401-000603 C-AL;1uF,20%,50V,GP,TP,5x11mm,5mm

CUD02


C811

2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5mm

CUD03


C812

2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5mm

CUD04


C813


CUD05


C814

2306-000318 C-FILM,M PPF;220nF,20%,250V,TP,-,22.5mm

CUD06


C815

2401-000293 C-AL;100uF,+30-10%,200V,HR,TP,16x25

CUD07


C816

2401-000166 C-AL;1000uF,20%,25V,WT,TP,13x20mm,5

CUD08


C817

2306-000323 C-FILM,M PPF;2.2nF,5%,1.6KV,TP,28.5x15.5x8.

CUD09

2301-000175 C-FILM,PEF;15nF,5%,50V,TP,7.1x3.5x13mm,5m

C818

2401-000493 C-AL;10uF,20%,50V,LZ,TP,5x11mm,5mm

CUD10

2401-001840 C-AL;100uF,20%,16V,GP,TP,6.3x11,5mm

C820

2401-001998 C-AL;1000uF,20%,25V,GP,TP,10x20,5mm

CUD11


C821


CUD12

2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5

C823

2201-002002 C-CERAM IC,DISC;4700pF,20%,400V,+20%~-55%,TP,2

CUD13

2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5

C825

2201-000292 C-CERAM IC,DISC;1nF,10%,50V,Y5P,TP,5x4,5mm

CUD14


C826


!

CX01

2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5

C850


!

D-COIL

AA27-20003T COIL-DEGAUSSING;-,22,16.7ohm,60T,2600mm,E

C851

2401-002289 C-AL;470uF,20%,35V,WT,TP,10x20,5

DIODE


C852

2401-001415 C-AL;470uF,20%,35V,GP,TP,10x20mm,5m

D201

0401-000005 DIODE-SWITCHING;1N4148,75V,300mA,DO-35,TP

C853

2401-000395 C-AL;10uF,20%,160V,GP,TP,10x12.5mm,

D202

0402-000132 DIODE-RECTIFIER;1N4004,400V,1A,DO-41,TP

C861

2401-000242 C-AL;100uF,20%,10V,GP,TP,6x11,5mm

D203


C862

2401-000480 C-AL;10uF,20%,50V,GP,TP,5x11,5

D204


C901


D205


C902


D206


C903


D207


C904


D208


C905

2401-001333 C-AL;470nF,20%,50V,GP,TP,5x11,5

D210


C906


D301


C907


D302


C908

2201-000573 C-CERAM IC,DISC;47pF,5%,50V,CH,TP,6.5x3.0,5

D401

0402-000493 DIODE-RECTIFIER;1R5GU41,400V,1.5A,DO-15L,TP

C909

2201-000193 C-CERAM IC,DISC;10pF,0.3pF,50V,CH,TP,5x3,5

D402


Re ma rk


Loc . N o.

!

!

Code N o.


Re ma rk

Loc . N o.

Code N o.


Re ma rk

DX01

0402-000546 DIODE-RECTIFIER;TVR10G,400V,1.0A,DO-41

L401

AA27-30003L COIL-LINERITY;-,73uH,DR12x15,0.55mm,-,BK,15%

DZ101

0403-000700 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,TP

L403

AA27-10001DCOIL-CHOKE;-,6.8mH,K,50,150mA,ST,6.8MH-K(

DZ302

0403-001039 DIODE-ZENER;MA 2560,56V,52-60V,1W,DO-41,TP

L404

3301-000287 CORE-FERRITE BEAD;AA,3.5x1.0x6.0mm,1500,2400G

DZ303


L405

2701-000114 INDUCTOR-AXIAL;10uH,10%,2.5x3.4mm

DZ305

0403-000660 DIODE-ZENER;MTZ22A,22V,20.15-21.2V,500mW,D

L406

2901-000296 FILTER-EMI ON BOARD;-,4.4/4.4mH,-

DZ306

0403-000700 DIODE-ZENER;TZP33A,33V,31-35V,1W,DO-41,TP

L602


DZ401

0403-000300 DIODE-ZENER;MTZ8.2B,7.78-8.19V,500mW,DO-34

L802

AA29-30002FFILTER-LINE NOISE;-,6mH,2.45A,-,-

DZ402

0403-000295 DIODE-ZENER;MTZ5.1B,5.1V,4.94-5.20V,500mW,

L804


DZ601


L807


DZ650

0403-000656 DIODE-ZENER;MTZ15C,15V,14.35-15.09V,500mW,

L808


DZ651


L809

AA27-10002YCOIL-CHOKE;-,100uH,K,10,700mA,T,100UH-K(S

DZ701


L810

AA27-10002YCOIL-CHOKE;-,100uH,K,10,700mA,T,100UH-K(S

DZ702


L811


DZ704


L812


DZ801

1405-000188 VARISTOR;430V,1250A,14x7.5mm,TP

L813

2901-000299 FILTER-EM I ON BOARD;-,6A,UL/CSA,-,9x7.5,TP,-

DZ802

1405-000188 VARISTOR;430V,1250A,14x7.5mm,TP

L862


DZ804


L863


DZ805


L864


DZ807


L901


DZ808


L902


DZ815


LA01

AA27-10002X COIL-CHOKE;-,43uH,K,10,1A,T,43UH-K(SPT050

DZ901


LD302

AA27-10001E COIL-CHOKE;-,1.0uH,K,25,2100A,T,SP0408-1R

DZ902


LD303

AA27-10001E COIL-CHOKE;-,1.0uH,K,25,2100A,T,SP0408-1R

DZ903


LD901

AA96-30001B ASSY-LED,GUIDE;-,AA61-50055A,DL-G5RGA,-

DZ905


LE01

AA27-40001FCOIL-HORIZ.WIDTH;-,1mH,DR1520,PI0.4,-

DZ906


NT801

1404-001045 THERMISTOR-NTC;4.7ohm,15%,2900K,35.0mW,TP

DZ907


P801

1404-001087 THERMISTOR-PTC;7ohm,30%,220V,270V,19A,-,ST

DZ908


Q101

0501-000436 TR-SMALL SIGNAL;KTC3197,NPN,625mW,TO-92,TP,20-

DZ910


Q201

0501-000389 TR-SMALL SIGNAL;KSC815,NPN,400mW,TO-92,TP,120-

DZE01

0403-001039 DIODE-ZENER;MA 2560,56V,52-60V,1W,DO-41,TP

Q204

0501-000283 TR-SMALL SIGNAL;KSA539,PNP,400mW,TO-92,TP,120-

!

!

!

!


Lo c. N o.

Co de N o.


Re ma rk

Lo c. N o.

Co de N o.


Re ma rk

R204


R505

2001-000429 R-CARBON;1Kohm,5%,1/8W,AA,TP,1.8x3.2mm

R205


R506


R206


R517

2002-001008 R-COMPOSITION;1.8Kohm,5%,1/2W,AA,TP,3.7x9mm

R207


R518


R209


R519


R210


R520

2001-000096 R-CARBON(S);1Mohm,5%,1/2W,AA,TP,2.4x6.4mm

R211


R523

2008-000299 R-FUSIBLE(S);47ohm,5%,2W,AF,TP,3.9x10mm

R212


R524


R213


R525


R214


R606


R215


R607


R216


R608


R217


R610


R219


R611

2001-000273 R-CARBON;100Kohm,5%,1/8W,AA,TP,1.8x3.2m

R222


R614


R223


R616


R224


R617


R226


R618


R227

2001-000745 R-CARBON;4.7ohm,5%,1/8W,AA,TP,1.8x3.2mm

R620


R228


R621


R229

2004-001205 R-METAL;68ohm,5%,1/8W,AA,TP,1.8x3.2mm

R622


R230


R623


R231


R627


R232


R628


R233


R629


R234


R630


R235


R631


R237


R632


R239


R636


R247


R703



Loc . N o.

Code N o.


Re ma rk

Loc . N o.

Code N o.


Re ma rk

R827


RU06


R828

2001-001093 R-CARBON(S);2.2Kohm,5%,1/2W,AA,TP,2.4x6.4m

RU07


R832


RU08


R901


RU09


R902


RU10


R903


RU12


R904


RU13


R906


RU14


R907


RU15


R908


RU16


R909


RU17


R911


RU18


R912


RU19


R914


RU20


R915


RU21


R920


RU22


R921


RUD01

2004-001256 R-METAL;8.2Kohm,2%,1/8W,AA,TP,1.8x3.5m

R922


RUD02


R923


RUD03


R924


RUD04


R925


!

RX01


R926


!

RX02


R927


!

RX03


R928


!

RX04


R930


!

RX05


R931


!

RX06

2008-000206 R-FUSIBLE(S);1ohm,5%,1/2W ,AF,TP,2.5x6.5mm

R932


SF101

2904-000287 FILTER-SAW AV;45.75MHz,SIP5P,ST,12.5dB,NTSC-

R935


SF102

2904-000289 FILTER-SAW AV;45.75MHz,SIP5P,ST,14.4dB,NTSC-

R951


SW901

3404-000244 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SPST

R952


SW902

3404-000244 SWITCH-TACT;15V,20mA,90-170gf,7.5x7mm,SPST


Lo c. N o.

Co de N o.


Re ma rk

AA63- 60028A SPACER-DY;NEOPRENE,-,BLK,V0 W1 2,-,-

ASSY-PCB,A/V *

AA95-90026WASSY-PCB,A/V;-,CT567BWX/XAP,KCT57A,NTSC,100

JB01

3722-001031 JACK-RCA;3P,3.6mm,#18,AU

CN701B

AA39-20112DLEAD-CONNECTOR,ASSY;-,YBNH025-09,67096-009,9P,500,

ASSY-POWER,CORD AA39- 10006X POWER-CORD;-,KKP419C,KLCE-2F,2.286M T,3P,V

!

AA61-20284A HOLDER;-,P-CORD,PP,VO,BLK,KE-002

REM OCON AA59- 10095P REM OCON;-,TM 59,RM 168,27,L/ GRY EX,SS

ASSY-CABINET *

AA90-70091BASSY-CABINET;566B,CT566BWX/STR

CB+JCK


CB+CF


CF+AVJCK

AA60- 10002A SCREW-TAPPING;RH,+,M4 ,L12,ZPC(YEL),-,OD14

CRT+CF

AA60-10050DSCREW-ASSY;WC,HH,+,M5,L33,SWRCH18,ZPC(YEL AA64- 31111B CABINET-BACK;-,566B,-,HIPS,HB,BLK,-,AA64- 60052P INLAY-BACK;KCT57A,N T S/ T,PS SHEET,T0.5,BL AA65- 30008A CLAM P-CORD;PE,HB,BLK,-,-,AA65- 30019A CLAM P-D,COIL;NYLON-66 ,V0,NTR,DADH-460 20,-

Lo c. N o.

Co de N o.


Re ma rk

Block Diagram

7. Block Diagram 7-1 KCT57A Block Diagram IN1 SF102 TU01

SAW M9260M

TUNER TECC1070PG26A

IN2

IC202 SIF IC LA7510 4.5M Hz DETECTOR IC

A/V SWITCH 4053B

SAW M3951M

IC201 I2C BUS

1 CHIP TDA8375

IC902 E2PROM XL24C02P

VOLUME-CONTROL

I2C BUS M TS TDA9850

IC901* MICOM SZM322

IC602

IC701

Q401* H-OUT TR D1887/D1880 IC301*

UPC1406 IC601 TDA7056Q

IC501 RGB AMP TDA6101Q TDA6107Q

CRT

MEMO

PCB Layout

8-2 PW B-CRT V/M

8-3 ASSY-PCB-F/AV

8-4 ASSY-PCB, A/V SIDE

8-2

Samsung Electronics

Wi ring Diagram

9. Wiring Diagram 9-1 KCT57A W iring Diagram

ASSY FRONT A/V SPEAKER

ASSY-SIDE A/V ASSY PWB M AIN

CN601

CT766DW

Schematic Diagrams

10. Schematic Diagrams 10-1 M AIN 1/4 TP1

TP2

TP1

TP3,4

TP4

TP5,6

TP3

TP5 TP2

Samsung Electronics

TP6

10-1

Schematic Diagrams

10-2 M AIN 2/4

TP7

TP8

TP14

TP12 TP9 TP7

TP9,10

TP10

TP11

TP8

TP12

TP13

TP14

TP15

TP15

TP13

TP11

10-2

Samsung Electronics

Schematic Diagrams

10-3 M AIN 3/4 TP16

TP18

TP17

TP16

TP18

TP17

Samsung Electronics

10-3

Schematic Diagrams

10-4 M AIN 4/4

10-4

Samsung Electronics

Schematic Diagrams

10-5 CT766DW ( M AIN 1/4)

TP1

TP2

TP1

TP3,4

TP5,6 TP4 TP3

TP5 TP2

Samsung Electronics

TP6

10-5

Schematic Diagrams

10-6 CT766DW ( M AIN 2/4)

TP7

TP8

TP14

TP12 TP9

TP9,10

TP11

TP10

TP7

TP8

TP12

TP13

TP14

TP15

TP15

TP13

TP11

10-6

Samsung Electronics

Schematic Diagrams

10-7 CT766DW ( M AIN 3/4) TP16

TP18

TP17

TP16

TP18

TP17

Samsung Electronics

10-7

10959 Chassis KCT57A

Recommend Documents