WARRANTY Manufacturer (Roadtec, Inc.) warrants, commencing with the date of shipment to first end-user and for a period of 12 months thereafter or 1,000 hours of operation, whichever occurs first, all machinery and parts manufactured by Roadtec, Inc. to be free from defects in workmanship and material. Warranty remains in force for the above time period only if all Manufacturer’s operational procedures are followed and recommended maintenance is performed. performed. If, within such warranty period, any machinery or parts shall be proved to Manufacturer’s satisfaction to be defective, it shall be repaired or replaced, at the Manufacturer’s option, F.O.B. Manufacturer’s warehouse. All failed parts or components must be returned to Manufacturer prepaid for inspection before credit will be issued for new parts or components. Manufacturer’s obligation hereunder shall be confined to such repair or replacement and does not include any charges, direct or indirect, for removing or replacing defective machinery or parts. Wear parts such as: conveyor lines, screed plates, cutter teeth, tooth holders, scraper blades, track pads, tires and conveyor belts are warranted only if found to be defective at time of shipment, but are not warranted for the warranty period as far as wear or abuse.
HOW TO ORDER PARTS THE ROADTEC PARTS DEPARTMENT INFORMATION TO PROCESS YOUR ACCURA ACCURATEL TELY. Y.
NEEDS ORDER
THE FOLLOWING PROPERLY AND
1. YOUR COMPANY’S NAME AND PURCHASE ORDER NUMBER. 2. NAME AND ADDRESS OF PERSON OR PLACE TO WHOM PARTS PARTS ARE TO BE SHIPPED. 3. METHOD OF SHIPMENT. ( MOTOR FREIGHT, UPS, AIR, ETC... ) 4. MODEL AND SERIAL NUMBER OF THE THE MACHINE FOR WHICH PARTS ARE BEING ORDERED. 5. PART NUMBER, DESCRIPTION, AND QUANTITY OF PARTS. 6. THE LOCATION OF PART(S) IN THE ROADTEC PARTS MANUAL. ONCE THE ABOVE INFORMATION HAS BEEN OBTAINED, CONTACT THE ROADTEC PARTS DEPARTMENT AT : ROADTEC INC. / PARTS DEPARTMENT 2909 RIVERSIDE DRIVE CHATTANOOG CHATTANOOGA, A, TN. 37406
GENERAL INFORMATION This parts manual contains a listing of all parts of the ROADTEC RX-900 (4-Track) Milling Machine. A Sectional index immediately follows follows this introduction. This catalog is divided into numerical sections, each section has an alphabetical table of contents of its assemblies. the pages within each section are numbered with the section number and the number of the page within the section such as 1.1 ( Sect. 1, page 1 etc... ) The page numbers are located bottom center of each page. The parts shown in the illustrations are numbered and correspond to the number appearing in the REF. REF. NO. column of the parts list immediately immediately following the illustration. DO NOT ORDER PARTS BY THE REFERENCE NUMBERS. Each Ref. No. is followed by the ROADTEC part number for that particular part. When ordering parts, be sure to provide the serial number of the machine for which the parts are being ordered. Specify how parts shipment is to be forwarded. (See “How To Order Parts.” On the inside of this catalog.) Record the serial number of your machine, it’s engine, and any other equipment in the space provided below. Our Service Department will need this information to provide you with prompt, ef ficient service when you order parts or optional equipment.
RX-900 TECHNICAL SPECIFICATIONS
MILLING WIDTH WIDTHS S MAXIMUM MILLING WIDTH MAXIMUM MILL ING DEPTH
7’-2” , 12’ 6” 12’ 6” 14 IN
2184mm/3810mm 3810mm 356mm
MILL ING DRUM SP SPACING ACING MILLING DRUM NO. OF TEETH (7’ 2” DRUM w/ wip ers) MILLING DRUM NO. OF TEETH (12’-6” DRUM w/ wip ers) MILL ING DRUM DIAMETER (TIP TO TIP) DRUM TOOTH INCLINATION
5/8 IN 169 271 48 IN 7 DEGREES
16mm 169 271 1219mm 7 DEGREES
ENGINE MAKE ENGINE ENGINE TYPE ENGINE NO. OF CYLINDERS ENGINE OUTPUT ENGINE SPEED ENGINE DISPLA CEMENT FUEL CONSU CONSUMPTIO MPTION N (at fu ll lo ad) FUEL CONSU CONSUMPTIO MPTION N (at 2/3 load )
CATERPILLAR CATERPILLAR 3412E 12 860 HP 2,100 RPM 1648 CU IN 43 GA/HR 28.7 GA/HR
CATERPILLAR CATERPILLAR 3412E 12 641 KW 2,100 RPM 27 LITERS 163 L/HR 109 L/HR
OPERATING SPEED LOW OPERATING SPEED HIGH OPERATING SPEED LOW OPERATING SPEED HIGH
(3-TRACK ) (3-TRACK)) (3-TRACK (4-TRACK ) (4-TRACK)) (4-TRACK
0000-
0000-
TRAVEL SPEED
(3-TRACK )
0 3.2 MPH
83 FPM 156 FPM 83 FPM 128 FPM
25.3 MPM 47.5 MPM 25.3 MPM 39 MPM
0 5.14 KM/HR
MACHINE SAFETY PRECAUTIONS YOU WILL OBSERVE THE “ATTENTION” SYMBOLS SHOWN BELOW THROUGHOUT THE OPERATION & SERVICE MANUAL PROVIDED WITH YOUR MACHINE. THESE SYMBOLS ARE MEANT TO DRAW YOUR ATTENTION TO IMPORTANT INFORMATION THAT COULD AFFECT SAFE UNIT OPERATION AND THE SAFETY OF PEOPLE. WHEN YOU SEE THESE SYMBOLS THEY MEAN :
ATTENTION!
BECOME ALERT!
YOUR SAFETY IS INVOLVED!
THESE SYMBOLS WILL BE ACCOMPANIED BY THE FOLLOWING:
!
DANGER
THIS WORD DENOTES THE MOST SERIOUS HAZARD.
!
WARNING
THIS WORD DENOTES AN INTERMEDIATE HAZARD.
!
CAUTION
THIS WORD DENOTES THE LEAST SERIOUS HAZARD AND IS USUALLY USED IN CONJUNCTION WITH OPERATING AND MAINTENANCE INSTRUCTIONS THAT AFFECT SAFE PRACTICE.
OPERATIONAL CHECKS: 1. PRETEST STEERING, BRAKES AND ALL OTHER CONTROLS. 2. BEFORE STARTING THE MACHINE CHECK ALL FLUID LEVELS (HYDRAULIC FLUID, ENGINE OIL, WATER LEVEL, ALL PLANETARIES, ENGINE COOLANT, ETC.) 3. BE SURE THAT THE AREA YOU PLAN TO MILL IS ON A SLOPE OF LESS THAN 10 DEGREES. ALWAYS USE CAUTION WHEN OPERATING ON UNEVEN SURFACES AND ROUGH TERRAIN. 4. NEVER CLIMB ON OR OFF THE UNIT WHEN THE UNIT IS MOVING AND ALWAYS USE PROPER STEPS AND RAILS WHEN CLIMBING ON OR OFF THE UNIT. 5. LOOK IN ALL DIRECTIONS BEFORE REVERSING THE UNIT. 6. BE AWARE OF ALL POTENTIAL CLEARANCE AND GROUND OBSTACLES.
MAINTENANCE 1. ALWAYS SHUT OFF THE ENGINE, RAISE THE MOLDBOARD WITH THE POWER PACK, BLOCK THE TRACKS AND SET THE ELEVATION SAFETY BARS WHEN WORKING ON THE CUTTER DRUM, CONVEYOR OR OTHERWISE SERVICING THE MACHINE. 2. KEEP CONTROL PLATES ON CONSOLE CLEAN AND REPLACE LOST OR DAMAGED DECALS IMMEDIATELY.
SECTION 1 : ENGINE
ASSEMBLY
PART NO.
ENGINE C27 950 HP TIER II ENGINE C27 950 HP TIER II BELT TENSIONER BELT TENSIONER EXHAUST AIR FILTER ENGINE COOLING RADIATOR SUB-A SSY. SURGE TANK ENGINE PUMPS AIR COMPRESSOR ENGINE HARNESS (CAT)
221722-01 221377-01 221723-01 221287-01 221293-01 220538-01 221394-01 220564-01 220637-01 221372-01 220476-01 208698-01
S/N 182 & UP 181 & UP 179-181
PAGE NO. 1.1 1.5 1.9 1.11 1.12 1.13 1.15 1.19 1.22 1.23 1.29 1.35
RX-900 C27 4-TRACK ENGINE ASSY. TIER II ( 221722-01 )
22 23 30
21 25 24
1
NEXT PAGE
PREVIOUS PAGE
RX-900 C27 4-TRACK ENGINE ASSY. TIER II ( 221722-01 ) 2 1
16 13 14
27 44 45
43,42,41 43,42,41
40 35
RX-900-C27 4 TRACK ENGINE ASS'Y (221722-01) ITEM #
PART # -
DESCRIPTION ~ -
-
-
-
-
-
-
-
~
-
QTY
-
x
4
~ at was er -
. -
~ ~ ~
- x
.
RX-900 C27 4-TRACK ENGINE ASSY. TIER II ( 221377-01 )
22 23 30 1 21 25 24
NEXT PAGE
PREVIOUS PAGE
RX-900 C27 4-TRACK ENGINE ASSY. TIER II ( 221377-01 )
2 1
40 43,42,41 43,42,41
35 34 36
33 34 36 37 47 40 43 16 13
27
RX-900 C27 4-TRACK ENGINE ASSY. TIER II ( 221377-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
218303-01 221372-01 221394-01 221287-01 220538-01 221293-01 220476-01 209476-01 220672-01 216444-01 206921-04 93723 83752-04 95937 84071-04 93189 89252 84717 O1702 O1203 93106
DESCRIPTION
ENGINE - CAT C27 950 HP TIER 2 PUMP ASSY. COOLING PACKAGE ASSY. BELT TENSIONER ASSY. AIR FILTER ASSY. EXHAUST ASSY. AIR COMPRESSOR ASSY. RAD SIDE ENG REAR SUPPORT BRACKET CONSOLE SIDE ENG REAR SUPPORT FUEL TANK ASSY. BELT - DRIVE 6-5V2240 HEX BOLT - 3/4-10 X 2 1/2” LOCK WASHER - 5/8” SPRING STEEL FLAT WASHER - 3/4” HARD HEX NUT - 3/4-10 ASTM 563 A GR8 HEX BOLT - 3/4-10 X 2 1/4” HEX BOLT - 5/8-11 X 2 1/2” LOCK WASHER - 5/8” SPRING STEEL LOCK WASHER - 16 7980 SPRING STEEL HEX BOLT - M16-2 X 50 10.9 933 HOSE BARB - 1” NPT X 1 1/4”
NO. REQ’D 1 1 1 1 1 1 1 1 1 1 2 4 8 10 2 4 8 8 8 8 1
ASSY - BELT TENSIONER (221723-01) ITEM #
PART # -
QTY
- BELT TENSI NER BEARING H USING WLD'T A HININ . . - mm mm
-
-
DESCRIPTION
~
-
x
. -
. -
.
.
.
1
ENGINE COOLING ASSEMBLY ( 221394-01 )
23
28 16 3 23 23
4 5
23,22
22 17 28 22
NEXT PAGE
29
20
23
22 23
22
28 22 21 23
23
ENGINE COOLING ASSEMBLY ( 221394-01 )
PREVIOUS PAGE
27 26 11 25 2
5
15
19
24
3 4
28 19 24 29
3
4 5 1
ENGINE COOLING ASSEMBLY ( 221394-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
220564-01 220637-01 84332 83056 83757 93723 95937 83752-04 84071-04 221394-01-1 45228 220624-03 221301-03 220636-03 221298-01 221300-01 221296-01 221394-01-2 133591 221299-01 221297-01
DESCRIPTION ( 145386-01 ) RX-900-C27 RADIATOR SUB-ASSY. ASSY. - RX-900-C27 REMOTE SURGE TANK HEX BOLT - 3/8-16 X 1” LOCK WASHER - 3/8” SPRING STEEL FLAT WASHER - 3/8” STEEL HEX BOLT - 3/4-10 X 2 1/2” FLAT WASHER - 3/4” HARD LOCK WASHER - 3/4” SPRING STEEL HEX NUT - 3/4-10 ASTM 563 A GR8 HOSE - 3/8” FUEL / WATER X 43” LG CLAMP - 3/8”-1/2” WORM RADIATOR WATER SUCTION PIPE ENGINE WATER SUCTION PIPE RADIATOR RETURN WATER PIPE ENGINE RETURN WATER PIPE CONSOLE TURBO CHARGE AIR LINE RADIATOR TURBO CHARGE AIR LINE HOSE - RADIATOR 4 X 5” LG CLAMP - 3 5/8” TO 4 5/8” FRONT TOP CHARGE AIR LINE BACK TOP CHARGE AIR LINE
NO. REQ’D 1 1 6 6 6 4 6 4 2 1 4 1 1 1 1 1 1 3 12 1 1
RX-900 C27 RADIATOR SUB-ASSEMBLY ( 220564-01 )
1
6 7 9 17 10 11 12
18 19 7 6 7
8
NEXT PAGE
PREVIOUS PAGE
RX-900 C27 RADIATOR SUB-ASSEMBLY ( 220564-01 )
1
10 14
15 16
9
13
16 9
RX-900 C27 RADIATOR SUB-ASSEMBLY ( 220564-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
219359-01 80167 87588-04 83468-04 83988 28G05 84632-04 90939-04 98118 140632-04 145666-04 204334-04 96578 207809-04 89610 96765 83459-04 215934-04 136028-04 98247 45228
DESCRIPTION
RX-900 CAT C27 COOLING PACKAGE NIPPLE - PIPE 1/2” X 2 NPT BMI VALVE - 1/2” APOLLO HAND TYPE FIT - CONNECTOR 8 JIC - 1/2” NPT MALE FIT - CAP 8 JIC STEEL FIT - ST. ADAPTER 24 SAE M X 20 SAE F FIT - CONNECTOR 16 JIC - 20 SAE F FIT - BRANCH TEE 16 JIC SWIVEL FIT - SWIVEL RUN TEE 16 JIC FIT - 16 JIC FS X 16 SAE MALE O-RING FIT - 20 SAE MALE X 16 SAE FM. STR. VALVE - CHECK 20 SAE FEMALE FIT - 16 JIC - 20 FLG 90 DEG. CODE 62 VALVE - CHECK 1” 5# SAE FEMALE FIT - 16 JIC X 16 SAE ST MALE KIT - FLANGE #20 CODE 62 FIT - CONNECTOR 8 JIC X 8 SAE MALE CONNECTOR - 8 JIC F X 1/2” NPT F SW HOSE BARB - 1/2” NPT - 1/2” BARB PLUG - 1/4” NPT CSK SOC. HD. BRASS CLAMP - 3/8-1/2” WORM
NO. REQ’D 1 1 1 1 1 2 3 1 3 2 1 1 2 1 1 2 2 2 2 1 2
ENGINE PUMPS ASSEMBLY ( 221372-01 )
NEXT PAGE
PREVIOUS PAGE
ENGINE PUMPS ASSEMBLY ( 221372-01 )
NEXT PAGE
PREVIOUS PAGE
ENGINE PUMPS ASSEMBLY ( 221372-01 )
NEXT PAGE
PREVIOUS PAGE
ENGINE PUMPS ASSEMBLY ( 221372-01 )
ENGINE PUMPS ASSEMBLY ( 221372-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
205753-03 206439-04 206438-04 206441-04 208434-04 93144 208398-04 83317 86164 O5707 O1190 213331-04 89610 84654-04 90729 96648 90939-04 89596-04 83734-04 93587-04S 91665-04 83735-04
DESCRIPTION ( 145386-01 )
NO. REQ’D
CLUTCH/PUMP DRIVE ASSY. CONVEYOR PUMP TRAVEL PUMP AUX. PUMP FAN PUMP KIT HEX BOLT - 1/2-13 X 1 1/2” LG SOC. HD. CS BOLT - 5/8-11 X 3” LG LOCK WASHER - 1/2” SPRING STEEL GR8 BOLT - 1/2-13UNC X 1 1/4” LG CONICAL WASHER - HS12 6796 STEEL HEX BOLT - M12- 1.75 X 40 8.8 933 O-RING 250 BN CONNECTOR - 16 JIC - 16 SAE MALE STRAIGHT FIT - 16 JIC FEMALE SWIVEL KIT - FLANGE #16 CODE 62 FIT - 16 FLANGE X 16 JIC MALE ST CODE 62 FIT - BRANCH TEE 16 JIC SWIVEL REDUCER - 16 JIC FEMALE - 12 JIC MALE FIT - ELBOW 6 JIC MALE - 6 SAE MALE 90 DEG. HOSE #27 - 1/2”-84” - 8X8 ST - 8X8 ST FIT - RUN TEE 6 JIC - 6 SAE MALE ADAPTER - 6 JIC - 6 SAE MALE
1 2 1 1 1 16 6 20 4 12 16 3 2 1 6 2 2 4 5 1* 2 2
ENGINE PUMPS ASSEMBLY ( 221372-01 ) REF NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68
PART NO.
134771 134771 208392S 208392S 208392S 134523 132354 99703 127058 130213 134013 129829 97568 96584 209459-04 O1188 211110-01 84632-04
DESCRIPTION ( 145386-01 ) HOSE #158 - 1/4-52” - 6X4 ST - 6X4 ST HOSE #159 - 1/4-52” - 6X4 ST - 6X4 ST HOSE #147 - 1/4-220” - 6X4 ST - 4X4 ST HOSE #148 - 1/4-220” - 6X4 ST - 4X4 ST HOSE #149 - 1/4-220” - 6X4 ST - 4X4 ST HOSE #131 - 3/4-85” - 12X12 ST - 12X12 ST HOSE #157 - 3/4-26” - 12X12 ST - 12X12 ST HOSE #162 - 3/4-20” - 12X12 ST - 12X12 ST HOSE #122 - 3/4-55” - 12X12 ST - 12X12 ST HOSE #130 - 1/2-220” - 8X8 ST - 8X8 90 DEG. HOSE #153 - 3/8-80” - 6X4 ST - 6X4 90 DEG. HOSE #124 - 1” - 26’ - 16X16 ST - 16X16 ST FIT - 12 JIC - 16 FLG. ST CODE 62 FIT - 16 JIC X 24 JIC REDUCER FIT - BRANCH TEE 24 JIC HEX BOLT - M8-1.25 X 35MM LG PULLEY ARRANGE. 16” ENGINE PULLEY 93 RPM DRUM SPEED FIT - CONNECTOR 16 JIC X 20 SAE MALE
NO. REQ’D 1* 1* 1* 1* 1* 1* 1* 1* 1* 1* 1* 1* 2 1 1 12 1 1
AIR COMPRESSOR ASSEMBLY ( 220476-01 )
NEXT PAGE
PREVIOUS PAGE
AIR COMPRESSOR ASSEMBLY ( 220476-01 )
NEXT PAGE
PREVIOUS PAGE
AIR COMPRESSOR ASSEMBLY ( 220476-01 )
NEXT PAGE
PREVIOUS PAGE
AIR COMPRESSOR ASSEMBLY ( 220476-01 )
AIR COMPRESSOR ASSEMBLY ( 220476-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
DESCRIPTION
NO. REQ’D
220468-01 220464-03 123831
AIR COMPRESSOR & DRIVE MOTOR MOUNT WLDMT. AIR COMPRESSOR DRIVE MOTOR MOUNT PLATE FIT - 8 JIC M X 10 SAE 90 DEG.
1 1 2
209039-04 205783-04 137747-04 83735-04 80132-04 90869 84385-04 87328-04 84402-04 122168 83459-04 83460-04 83767-04 134229-04 83924 83056 83757
FLOW REGULATION VALVE FLOW REGULATION VALVE COUPLING - L100 SPIDER FIT - ADAPTER 6 SAE - 6 JIC ST HOSE - 3/4” WATER HEX BOLT - 5/16-18 X 2 3/4” LG PIPE PLUG - 1/8” NPT (CSK) LOCK WASHER - 5/16” FIT - SWIVEL RUN TEE 12 JIC FIT - 8 SAE M - 8 JIC F SW FIT - 8 SAE M - 8 JIC M ST FIT - 8 SAE M - 8 JIC M SW 90 DEG. FIT - 8 SAE PLUG MOTOR - HYD 1.03 CID HEX BOLT - 3/8-16 X 1 1/2” LG LOCK WASHER - 3/8” FLAT WASHER - 3/8”
1 1 1 1 72” 2 4 2 1 1 2 2 1 1 4 10 8
AIR COMPRESSOR ASSEMBLY ( 220476-01 ) REF NO.
PART NO.
51 52 53 54 55 56 57 58 59
209212 96950 209214 93621-04 209207 130211 132115 93402-04 95553
DESCRIPTION
HOSE ASSY. - 1/2”-144” 8X8 JIC ST - 8X8 JIC SW 90 DEG. HOSE ASSY. - 3/8-11” 8X6 ST - 8X6 ST HOSE ASSY. - 1/4-144” 4X4 SW 90 DEG. - 4X4 ST HOSE ASSY. - 1/2-48” 8X8 ST - 8X8 90 DEG. HOSE ASSY. - 3/8-87” 6X8 - 8X6 90 DEG. HOSE ASSY. - 1/2-142” 8X8 ST - 8X8 ST HOSE ASSY. - 3/8-144” 6X6 ST - 8X6 90 DEG. HOSE ASSY. - 3/8-14” 8X6 ST - 8X6 90 DEG. FIT - 1/4” FEMALE QUICK DISCONNECT
NO. REQ’D REF REF REF REF REF REF REF REF 1
ENGINE WIRING HARNESS (CAT.) ( 208698-01 )
ENGINE WIRING HARNESS (CAT.) ( 208698-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
PART NO.
207993-04 133746-04 133741-04 93253 93843-03-C2 143149 143148 143146 143150 143147 86624-03 98298 35Z65 123097 95020 95021 207994-04
DESCRIPTION ( 145386-01 ) DEUTSCH 23 PIN RECEPTACLE SOCKET CONTACT , DEUTSCH SEALS PLUG, DEUTSCH RING TERMINAL 4 PIN PACKARD 4 PIN PACKARD FEMALE WIRE SEAL MALE TERMINAL 4 PIN PACKARD MALE FEMALE TERMINAL WIRE - 25 CONDUCTOR 16 AWG SPLIT LOOM - 1” SPLIT LOOM - 3/4” SPLIT LOOM - 5/8” SPLIT LOOM - 1/2” SPLIT LOOM - 1/4” DEUTSCH BACKSHELL SIZ2 24
NO. REQ’D 1 21 2 2 3 1 8 4 1 4 265” 148” 39 80” 116” 76” 1
SECTION 2 : FRAME
ASSEMBLY
PART NO.
S/N
AIR TANK HANDRAIL, FLOORPLATE, & BELTGUARD FUEL TANK FUEL TANK FITTINGS MAINFRAME PANEL S ( CAT. ENGINE ) HOOD SUPPORT DECALS
211019-02
116 & UP
2.1
213679-01 216444-01 208415-03 221438-01 220546-01 209273-01 219197-01
138 & UP
2.3 2.7 2.9 2.11 2.15 2.21 2.23
102 & UP 179 & UP 175 & UP 171 & UP
PAGE NO.
AIR TANK ASSEMBLY ( 211019-02 )
AIR TANK ASSEMBLY ( 211019-02 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO. 149597 84332 83757 83056 83055 91232-04 89575-04 200479 92236 80245 45228 80187 80132-04 92780 201399 136925 80345 91321-04 80105 207642-04 80132-04
DESCRIPTION ( 145386-01 ) AIR TANK - 9 1/2” X 46 1/8 (13 GAL.) HEX BOLT - 3/8-16 X 1” FLAT WASHER - 3/8” STEEL LOCKWASHER - 3/8” SPRING STEEL HEX NUT - 3/8-16 GR8 VALVE - POP OFF 1/4” NPT X 120 PSI VALVE - 1/8” NPT DRAIN COCK AIR CSK PIPE PLUG 3/8” NPT CSK PIPE PLUG 3/4” NPT BUSHING - HEX 1/8” TO 3/8” NPT CLAMP - 3/8”-1/2” WORM HOSE BARB - 3/8” NPT X 3/8” BARB HOSE - 3/8” FUEL/WATER X 96” PLUMB - 3/8” NPT FEMALE 90 DEG. NIPPLE - 3/8 X 2” FIT - 3/4” NPT X 3/4” HOSE NO FERRULE ELBOW - 3/4” NPT 90 DEG. FEMALE HOSE - 3/4” WATER (BLACK) X 60” LG. CLAMP - HOSE 3/4” NIPPLE - PIPE 3/4” SCH. 40 X 6” LG. HOSE - 3/8” FUEL/WATER X 14 3/4” LG
NO. REQ’D 2 8 8 8 8 2 2 3 3 2 3 3 1 3 2 1 1 1 2 1 1
NEXT PAGE
PREVIOUS PAGE
ASSY- HANDRAIL FLOOR & BELTGUARD (213679-01) ITEM #
PART #
DESCRIPTION
-
~
-
-
. . -
x
QTY
RX-900 ASSEMBLY - FUEL TANK (216444-01) ITEM #
PART #
DESCRIPTION
QTY
-
. . ~ ~
-
~ .
-
-
FUEL TANK HYDRAULIC FITTINGS ASSY. ( 208415-03 )
RX-900 ( 4-TRACK ) MAINFRAME ASSEMBLY ( 221438-01 )
NEXT PAGE
PREVIOUS PAGE
RX-900 ( 4-TRACK ) MAINFRAME ASSEMBLY ( 221438-01 )
NEXT PAGE
PREVIOUS PAGE
RX-900 ( 4-TRACK ) MAINFRAME ASSEMBLY ( 221438-01 )
RX-900 ( 4-TRACK ) MAINFRAME ASSEMBLY ( 221438-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
PART NO.
221311-01 83416 83742-04 83700 211314-04 142982-04 140858 90227-04 84444 220016-03 89772 83065 83376-04 205039-04 84426-04 211318-04 205817-04 136039-04 211530-04 80349-04
DESCRIPTION
RX-900 C27 MAINFRAME WLDMT. GREASE NIPPLE - 1/8 NPT FIT - 1/8” NPT - 4 JIC ST FIT - 1/4” NPT -4 JIC ST GREASE LINE - 1/4” X 44” LG 4X4 ST GREASE LINE - 1/4” X 23” LG 4X4 ST 3/8 LOAD BINDER CHAIN - 3/8 X 26” FLAT WASHER - 1/4 MOD. - DRUM DRIVE LUBE BOTTLE HEX NUT - 1/4” - 20 GR8 LOCK WASHER - 1/4” SPRING STEEL FLAT WASHER - 1” ID NOM. REAR MOLDBOARD CYLINDER FIT - 6 JIC - 8 SAE 90 DEG. GREASE LINE - 1/4” X 89” LG 4X4 ST’S GREASE LINE - 1/4” X 80” LG 4X4 ST’S GREASE LINE - 1/4” X 72” LG 4X4 ST’S GREASE LINE - 1/4” X 64” LG 4X4 ST’S HOSE BARB - 1/4” NPT X 3/8” BARB
NO. REQ’D 1 38 54 22 6 2 2 4 4 1 4 4 8 2 4 8 10 8 4 1
NEXT PAGE
NEXT PAGE PREVIOUS PAGE
PREVIOUS PAGE
ASSY-PANEL- RX-900-4 CAT (220546-01) ITEM #
PART # -
DESCRIPTION -
-
-
QTY
-
-
-
-
-
-
-
ASSY-PANEL- RX-900-4 CAT (220546-01) ITEM #
PART #
DESCRIPTION
QTY
-
-
14
-
4 1
. -
~ ~ -
2 x
~ . . -
RX-900 HOOD SUPPORT ASSEMBLY ( 209273-01 )
RX-900 HOOD SUPPORT ASSEMBLY ( 209273-01 ) REF NO. 1 2 3 4 5 6 7 8 9
PART NO.
209236-03 209237-03 209238-04 86645-04 86556-04 95929 84674 83781-04 139741-04
DESCRIPTION ( 145386-01 ) HOOD SUPPORT LOWER TUBE WELDMENT HOOD SUPPORT UPPER TUBE WELDMENT QUICK RELEASE PIN - 1/2 DIA. X 2” GRIP AREA ALUMINUM SLEEVE 1/16 CABLE - AIRCRAFT 7/7 X 1/16 X 10 LG HEX BOLT - 1/2-13 X 3” LG HEX BOLT - 1/2-13 X 2” LG FLAT WASHER - 1/2” LOCK NUT - 1/2”
NO. REQ’D 2 2 2 4 2 2 2 4 4
RX-900 DECAL ASSEMBLY ( 219197-01 )
In
N G I N R A W
Pur suit o f Ex ce ll e nce
NEXT PAGE
PREVIOUS PAGE
RX-900 DECA DECA L ASSEM A SSEMB B LY ( 219197-01 )
NEXT PAGE
RX-900 DECAL ASSEM A SSEMB B LY PREVIOUS PAGE
NEXT PAGE
( 219197-01 )
S t t and and cl cl e e c o c o nv nv eyo ar of a r rea . eyo r d i i sch ea . sch arg e
D o o n n ot ad c on ve ju st yo r yo r wh ile en gi ne is ne is ru nn in in g.
RX-900 DECA DECA L ASSEM A SSEMB B LY PREVIOUS PAGE
( 219197-01 )
RX-900 DECA DECA L S ASSEMBLY ( 219197-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO.
139461- 02 139461-02 122129-04 12212904 139458-04 13945804 139462-02 13946202 204523-02 20452302 218382-04 21838204 92820-04 92820-0 4 92870-04 92870-0 4 131690-04 13169004 95906-03 208048-04 139630-04 139457-04 13945704 202475-04 20247504 131841-04 89716-04 89716-0 4 141100-04 120827-04 12082704 92787-04 92787-0 4 146360-04 14636004 92803-04 92803-0 4 96088-04 96088-0 4
DESCRIPTION ( 145386-01 ) DECAL - WARNING DECAL - FIRE EXTINGUISHER DECAL - FIRE & CUTTER DRUM DECAL - WARNING DATA DAT A PLATE - GAUGE FILTER MINDER & PRESSURE GAUGE DAT DATA A PLATE DECAL - STAND CLEAR MACHINE SERIAL NUMBER PLATE UNIVERSAL PA PATENT TENT PLATE DECAL - AMERICAN FLAG 8 1/4” X 15” DECAL - RX-900 - 6” DECAL - TRACK (SMALL) DECAL - DANGER MOTION DECAL - IMPOTABLE WA WATER TER DECAL - CIRCLED BLUE “R” (3/4” HIGH) DECAL - SLOW MOVING SAFETY DECAL - “R” 36” TALL RED DECAL - COMPRESSED AIR DECAL - BELT GUARD DECAL - BATTER BATTERY Y (INT (INT.. SYM.) DECAL - PINCH POINT AREA DECAL GREASE HERE 1” X 2”
NO. REQ’D 2 1 2 2 1 1 2 REF 1 2 2 4 2 3 3 1 1 2 2 1 4 16
RX-900 DECALS DECAL S ASSEMBLY ( 219197-01 ) REF NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64
PART NO. 143063 216882-04 216882 -04 139455-04 139455 -04 208905-03 208905 -03 210860-02 210860 -02 134598-04 134598 -04 207966-04 207966 -04 207432-04 207432 -04 139459-04 139459 -04 211937-04 217829-03 217829 -03 219193-03 219193 -03 219195-03 219195 -03 219194-04 219194 -04
DESCRIPTION ( 145386-01 ) DECAL - 1” YELLOW STRIPING DECAL - ANTI-SPIN VALVE DECAL - INSTALL HANDRAIL SAFETY BARS DECAL - DEUTSCH PLUG DECAL - VALVE DECAL - MAX OPERATION TIME DECAL - LOCKOUT / TAGOUT DECAL - COLD OIL LEVEL DECAL - TRACK (LARGE) DECAL KIT - 60 AMP BREAKER DECAL - DO NOT FILL DECAL - LH REAR GREASE POINT FUNCTION DECAL - RH REAR GREASE POINT FUNCTION DECAL - RH FRONT GREASE POINT FUNCTION
NO. REQ’D REF 2 2 1 2 1 2 1 4 1 1 1 1 1
SECTION 3 : TRACK DRIVE
ASSEMBLY
PART NO.
RIGHT FRONT LEG TUBE RT. FRT. INNER LEG TUBE / TRACK ASSY. LEFT FRONT LEG TUBE LT. FRT. INNER LEG TUBE / TRACK ASSY. RIGHT REAR LEG TUBE RT. REAR INNER LEG TUBE / TRACK ASSY. LEFT REAR LEG TUBE LT. REAR INNER LEG TUBE / TRACK ASSY. RIGHT TRACK ASSY. LEFT TRACK ASSY. TRACK GEAR UNIT ASSY. STEERING
212252-01 212253-01 212249-01 212250-01 212527-01 212248-01 221269-01 212246-01 208900-01 208899-01 206030-01-C7 206014-01
S/N
PAGE NO.
127 & UP
3.1
127 & UP
3.5 3.9
128 & UP
3.13 3.17
175 & UP
3.21 3.25 3.29 3.33 3.35 3.37 3.39
NEXT PAGE
PREVIOUS PAGE
ASSEMBLY - RIGHT FRONT LEG TUBE (212252-01) 4
16
17 4
15 8
14
ASSEMBL Y - RIGHT FRONT LEG TUBE (212252-01) ITEM #
PART # -
DESCRIPTION
QTY .
-
-
. -
-
. -
-
. -
.
.
-
14
~ . -
.
NEXT PAGE
PREVIOUS PAGE
ASSY - R FRONT INNER LEG TUBE / TRACK (212253-01) ITEM #
PART #
DESCRIPTION
-
-
QTY
.
-
-
-
. ~ ~
-
-
x
-
-
.
~ -
-
x
. ~
NEXT PAGE
PREVIOUS PAGE
ASSEMBLY - LEFT FRONT LEG TUBE (202249-01) 4 16
4
17
7
15
ASSEMBLY - LEFT FRONT LEG TUBE (202249-01) ITEM #
PART # -
DESCRIPTION
QTY .
-
-
-
. -
-
. -
-
. -
.
.
-
1
~ .
NEXT PAGE
PREVIOUS PAGE
ASSY - L FRONT INNER LEG TUBE / TRACK (212250-01) ITEM #
PART #
DESCRIPTION
-
-
.
. -
QTY
-
-
-
~ ~
-
-
x
-
-
.
~ -
-
x
. ~
RIGHT REAR LEG TUBE ASSY. ( 212527-01 )
NEXT PAGE
PREVIOUS PAGE
RIGHT REAR LEG TUBE ASSY. ( 212527-01 )
RIGHT REAR LEG L EG TUBE ASSEMBLY ( 212527-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO.
205885- 01R 205885-01R 212248-01 21224801 212512-01 21251201 83317 138111-02 13811 1-02 91222-04 205918-03 20591803 134271-01 13427101 210338-03 21033803 83752-04 89034-04 205934-04 20593404 205946-04 20594604 95930 11Y44 96476 93144 212528-01 21252801 83056 83757 207754-03 20775403 83781-04 83781-0 4
DESCRIPTION ( 145386-01 ) RIGHT REAR OUTER LEG TUBE WLDMT WLDMT.. & MACH. RIGHT REAR INNER LEG TUBE / TRACK ASSY ASSY.. REAR LEG TUBE CYLINDER LOCK WASHER - 1/2” BOTTOM LEG TUBE BUSHING LOCK WASH WASHER ER - 7/8” REAR LEG TUBE LOWER RETAINING RING SWIVEL PIN LOCKING PLATE REAR ROTA ROTATING TING BEARING LOCK WASH WASHER ER - 3/4” HITCH PIN HEX BOLT - 7/8-9 UNC X 7” LG GR8 HEX BOLT - 7/8-9 UNC X 3 1/2” LG GR8 HEX BOLT - 3/4-10 X 2 3/4” LG HEX BOLT - 3/4-10 X 4 1/2” LG HEX BOLT - 3/8-16 X 1 1/4” LG HEX BOLT - 1/2-13 X 1 1/2” LG RIGHT REAR LEG TUBE TOP CAP / CYLINDER MOUNT LOCK WASHER - 3/8” FLAT WASHER - 3/8” REAR SAFETY BAR FLAT WASHER 1/2”
NO. REQ’D 1 1 1 16 1 24 1 2 1 28 1 9 15 8 20 8 16 1 8 8 1 1
RT. REAR INNER LEG TUBE / TRACK ASSY. ( 212248-01 )
NEXT PAGE
PREVIOUS PAGE
RT.REAR INNER LEG TUBE / TRACK ASSY. ( 212248-01 )
RT.REAR INNER LEG TUBE / TRACK ASSY. ( 212248-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
208900-04 205964-01 205916-03 138079-03 205966-02 205967-04 121914-04 204868-01 26F62 83754 83781-04 209474-03 209534-03 83317 84674 86164 O1202 O1702 209686-04 120550 83890-04
DESCRIPTION ( 145386-01 ) RIGHT TRACK ASSY. RIGHT REAR TRACK YOKE/ INNER LEG TUBE WLDMT. REAR LEG TUBE UPPER RETAINING RING TOP LEG TUBE BUSHING TRACK FRAME BOLT TRACK YOKE WASHER PLATE HEX NUT - 2 1/2-8 UNF TRACK BASKET WLDMT. CSK BOLT - 3/8-16 X 1 1/4” LG HEX BOLT - 1/2-13 UNC X 1” LG FLAT WASHER - 1/2” FRONT TRACK REAR PUSH BAR REAR TRACK PUSH BAR LOCKWASHER - 1/2” HEX BOLT - 1/2-13 X 2” LG HEX BOLT - 1/2-13 X 1 1/4” LG HEX BOLT - M16-2 X 45MM LOCKWASHER - 16MM TRACK DRIVE MOTOR FIT - 1/4 BSP X 6 JIC ST FIT - 12 JIC - 12 FLG. 90 DEG. CODE 62
NO. REQ’D 1 1 1 1 1 1 1 1 8 2 7 1 1 7 2 2 2 2 1 1 2
LEFT REAR LEG TUBE ASSY. ( 221269-01 )
NEXT PAGE
LEFT REAR LEG TUBE ASSY. PREVIOUS PAGE
( 221269-01 )
LEFT REAR LEG TUBE ASSEMBLY ( 221269-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
205885-01L 212246-01 212512-01 83317 138111-02 91222-04 205918-03 134271-01 210338-03 83752-04 210832-03 205934-04 205946-04 95930 11Y44 96476 93144 221268-03 83056 83757 84322
DESCRIPTION ( 145386-01 )
NO. REQ’D
LEFT REAR OUTER LEG TUBE WLDMT. & MACH. LEFT REAR INNER LEG TUBE / TRACK ASSY. REAR LEG TUBE CYLINDER LOCK WASHER - 1/2” BOTTOM LEG TUBE BUSHING LOCK WASHER - 7/8” REAR LEG TUBE LOWER RETAINING RING SWIVEL PIN LOCKING PLATE REAR ROTATING BEARING LOCK WASHER - 3/4” STEERING INDICATOR HEX BOLT - 7/8-9 UNC X 7” LG GR8 HEX BOLT - 7/8-9 UNC X 3 1/2” LG GR8 HEX BOLT - 3/4-10 X 2 3/4” LG HEX BOLT - 3/4-10 X 4 1/2” LG HEX BOLT - 3/8-16 X 1 1/4” LG HEX BOLT - 1/2-13 X 1 1/2” LG DEPTH INDICATOR ROD WLDMT. LOCK WASHER - 3/8” FLAT WASHER - 3/8” HEX BOLT - 3/8-16 X 1” LG
1 1 1 16 1 24 1 2 1 28 1 9 13 8 20 8 16 1 10 10 2
LT. REAR INNER LEG TUBE / TRACK ASSY. ( 212246-01 )
NEXT PAGE
PREVIOUS PAGE
LT.REAR INNER LEG TUBE / TRACK ASSY. ( 212246-01 )
LT.REAR INNER LEG TUBE / TRACK ASSY. ( 212246-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
208899-04 205962-01 205916-03 138079-03 205966-02 205967-04 121914-04 204868-01 89142 83754 83781-04 209474-03 209534-03 83317 84674 86164 O1202 O1702 209686-04 120550 83890-04
DESCRIPTION ( 145386-01 ) LEFT TRACK ASSY. LEFT REAR TRACK YOKE/ INNER LEG TUBE WLDMT. REAR LEG TUBE UPPER RETAINING RING TOP LEG TUBE BUSHING TRACK FRAME BOLT TRACK YOKE WASHER PLATE HEX NUT - 2 1/2-8 UNF TRACK BASKET WLDMT. HEX BOLT - 1/2-13 UNC X 1 3/4” LG HEX BOLT - 1/2-13 UNC X 1” LG FLAT WASHER - 1/2” FRONT TRACK REAR PUSH BAR REAR TRACK PUSH BAR LOCKWASHER - 1/2” HEX BOLT - 1/2-13 X 2” LG HEX BOLT - 1/2-13 X 1 1/4” LG HEX BOLT - M16-2 X 45MM LOCKWASHER - 16MM TRACK DRIVE MOTOR FIT - 1/4 BSP X 6 JIC ST FIT - 12 JIC - 12 FLG. 90 DEG. CODE 62
NO. REQ’D 1 1 1 1 1 1 1 1 2 2 7 1 1 7 2 2 2 2 1 1 2
RX-900(4) RIGHT TRACK ASSEMBLY ( 208900-01 )
RX-900(4) RIGHT TRACK ASSEMBLY ( 208900-01 ) REF NO. 1 2 3 4 5 6 7 8
9 10 11 12 13 14 15
DESCRIPTION ( 145386-01 )
PART NO.
NO. REQ’D
206030-01-C4 206030-01-C5 206030-01-C6 206030-01-C7 206030-01-C8
RIGHT TRACK FRAME SPROCKET SCREW WASHER GEAR BOX SCREW
1 1 21 89 1 18
208896-01 208889-04 208888-04 208892-04 93187 127254-04 206030-01-C13 206030-01-C14
TRACK ASSY. W/O SHOES 14” REPLACEABLE TRACK GROUSER 14” REPLACEABLE TRACK PAD REPLACEABLE PAD NUT TRACK BOLTS 5/8 X 2 1/8” TRACK NUT 5/8” WEAR SIDE PLATE SCREW
208896-01-C1 206030-01-C15
TRACK ROLLER SCREW
4 16
206030-01-C16
IDLER UNIT
1
1 26 26 104 104 104 1 4
RX-900(4) LEFT TRACK ASSEMBLY ( 208899-01 )
RX-900(4) LEFT TRACK ASSEMBLY ( 208899-01 ) REF NO. 1 2 3 4 5 6 7 8
9 10 11 12 13 14 15
PART NO.
DESCRIPTION ( 145386-01 )
NO. REQ’D
206030-01-C4 206030-01-C5 206030-01-C6 206030-01-C7 206030-01-C8
LEFT TRACK FRAME SPROCKET SCREW WASHER GEAR BOX SCREW
1 1 21 89 1 18
208895-01 28889-04 208888-04 208892-04 93187 127254-04 206030-01-C13 206030-01-C14
TRACK ASSY. W/O SHOES 14” REPLACEABLE TRACK GROUSER 14” REPLACEABLE TRACK PAD REPLACEABLE PAD NUT TRACK BOLTS 5/8 X 2 1/8” TRACK NUT 5/8” WEAR SIDE PLATE SCREW
208895-01-C1 206030-01-C15
TRACK ROLLER SCREW
4 16
206030-01-C16
IDLER UNIT
1
1 26 26 104 104 104 1 4
RX-900 FRONT GEAR UNIT ASSY. ( 206030-01-C7 )
RX-900 FRONT GEAR UNIT ASSY. ( 206030-01-C7 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
208897-01-C2-1 208897-01-C2-2 208897-01-C2-3 208897-01-C2-4 208897-01-C2-5 208897-01-C2-6 208897-01-C2-7 208897-01-C2-8 208897-01-C2-9 208897-01-C2-10 208897-01-C2-11 208897-01-C2-12 208897-01-C2-13 208897-01-C2-14 208897-01-C2-15 208897-01-C2-16 208897-01-C2-17 208897-01-C2-18 208897-01-C2-19 208897-01-C2-20
DESCRIPTION ( 145386-01 ) SCREW OIL BREATHER PLUG WASHER COVER ASSY. O-RING PAD SUN GEAR REDUCTION ASSY. CIRCLIP PLANETARY SPACER NUT CENTERING RING GASKET, LIFETIME O-RING REDUCTION ASSY. CIRCLIP SPACER SUN GEAR SINTERED DISC
NO. REQ’D 10 2 2 1 1 1 1 1 5 5 5 1 1 1 1 1 1 1 1 4
STEERING ASSEMBLY ( 206014-01 )
STEERING ASSEMBLY ( 206014-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
PART NO. 205348-01 205229-03 83734-04 205393-03 205983-04 205984-04 83317 93144 205392-03 143041 207314-03 83049-04 83099 207324-03 136479 207297-03 207300-03 83459-04 84638-04 136422-04
DESCRIPTION ( 145386-01 ) CYLINDER - 5” X 16.13” STROKE SEALED BEARING 1.75 DIA. FIT - 6 JIC - 6 SAE 90 DEG. FRONT TIE ROD CYLINDER PIN FORGED ROD END LOCKWASHER - 1/2 HEX BOLT - 1/2-13 UNC X 1 1/2” LG REAR TIE ROD ASSY. SCREW - 1/4-20 X 3/8” LG CUP PT. SET. REAR CONTROL ARM 3/8” STUDDED ROD END NUT - 3/8-24 UNF REAR CONTROL ROD LOCKNUT - 3/8-24 UNF - NYLON LOCK REAR LEG TUBE LINKAGE BRACKET FRONT LEG TUBE LINKAGE BRACKET FIT - 8 SAE X 8 JIC ST FIT - 8 SAE X 8 JIC SW RUN TEE LH 3/8” STUDDED ROD END
NO. REQ’D 4 12 2 1 4 4 4 4 1 2 2 2 4 2 4 1 1 6 2 2
SECTION 4 : CONVEYORS ASSEMBLY
PART NO.
PRIMARY CONVEYOR SECONDARY CONVEYOR SECONDARY CONVEYOR SECONDARY CONVEYOR CRADLE 13 DEG. TROUGHING IDLER ( PRIMARY ) 20 DEG. TROUGHING IDLER ( PRIMARY ) 28 DEG. TROUGHING IDLER ( PRIMARY ) 28 DEG. TROUGHING IDLER ( SECONDARY ) HEAD SHAFT BEARING
216895-01 220998-01 219893-01
S/N 158 & UP 171 & UP
209616-01
PAGE NO. 4.1 4.5 4.11 4.17
216707-01
158 & UP
4.19
216709-01
158 & UP
4.20
216710-01
158 & UP
4.21
219892-01 207006-03
167 & UP
4.22 4.23
NEXT PAGE
PREVIOUS PAGE
PRIMARY CONVEYOR ASSEMBLY (216895-01) ITEM #
PART # -
DESCRIPTION
QTY
. . . .
. . -
-
-
-
~
X A
-
2 DE
HEAD P LLEY TR
HIN
Y -
-
-
IDLER
PRIMARY CONVEYOR ASSEMBLY (216895-01) ITEM #
PART #
DESCRIPTION
-
.
~ ~
~ ~ -
-
-
x
QTY
SECONDARY CONVEYOR ASSEMBLY ( 220998-01 )
48
NEXT PAGE
58
67 26
56 25 24
27
28 29
47 68
55
47
48
21 55
12
13 11
14
15
16
SECONDARY CONVEYOR ASSEMBLY ( 220998-01 )
PREVIOUS PAGE
NEXT PAGE
56 24
47 55
47,48
35
46
32
34 43
41 42 64
69 47 48 55
70
1
47,48,55,57
31 65 46
63
23
53
66
30
SECONDARY CONVEYOR ASSEMBLY ( 220998-01 )
PREVIOUS PAGE
56 47 55 1 48
48
47
43
47 45
44 35
36
65
45 33 50
1
47,48,55,57
RX-900 SEC. CONVEYOR ASS'Y (220998-01) ITEM #
PART # -
DESCRIPTION -
E ND E . . . .
NDARY
NV. IDE
QTY KIRTIN
.
-
.
.
.
. .
. . . . . . . .
.
. .
.
WLDT
.
. .
.
.
.
RX-900 SEC. CONVEYOR ASS'Y (220998-01) ITEM #
PART #
DESCRIPTION
QTY
. -
-
-
-
-
~ ~ -
11
-
4 -
-
SECONDARY CONVEYOR ASSEMBLY ( 219893-01 )
SECONDARY CONVEYOR ASSEMBLY ( 219893-01 )
SECONDARY CONVEYOR ASSEMBLY ( 219893-01 )
SECONDARY CONVEYOR ASSEMBLY ( 219893-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO.
215537-01 210022-04A 207039-04 207017-03 219892-01 207183-03 207006-03 206879-04 207096-03 214796-03 203247-03 146284 85874-04 207102-03 207100-03 203945-03 97047-04 98453 207044-01L 207044-01R 207088-01L 207088-01R
DESCRIPTION ( 145386-01 ) SECONDARY CONVEYOR APCHE BELT - SEC. CONV. 42” LG X 639” LG PULLEY - HEAD LAGGED WING 12” OD X 42” LG IDLER - RETURN 5 1/2” DIA. ASSEMBLY-28 TROUGHING IDLER RX-900 RETURN ROLLER BRACKET HEAD SHAFT BEARING SUB-ASSY. TYPE E END CLOSURE KIT SEC. CONV. HEAD PULLEY SHAFT B-LOCK TAPER LOCK COUPLING 1 15/16” X 1 1/2” TORQUE ARM SAUER DANFOSS MOTOR CONNECTOR - 12 JIC - 16 SAE M TAIL SHAFT BEARING SUB-ASSY TAIL PULLEY SHAFT TAIL PULLEY BRACE BUSHING - GARMAX 2” ID X 1 1/2” LG HEX NUT - 1-8 UNC GR8 L.H. HEAD PULLEY TOP ADJ. PLATE R.H. HEAD PULLEY TOP ADJ. PLATE L.H. FRONT SIDE SKIRTING R.H. FRONT SIDE SKIRTING
NO. REQ’D 1 1 2 3 9 6 2 3 1 1 1 1 2 2 1 2 4 10 1 1 1 1
SECONDARY CONVEYOR ASSEMBLY ( 219893-01 ) REF NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71
PART NO. 213632-03 213633-03 130862 130864 211976-01 139741-04 83781-04 83317 86164 83288 83754 133787-04 83757 215875-03 96476 215873-03 217636-03 217632-03 217926-03 217927-03 218049-04
DESCRIPTION ( 145386-01 ) LEFT REAR SIDE BELT GUARD RIGHT REAR SIDE BELT GUARD CLAMP - 1/2” ASSY. CLAMP - 1” HOSE 1 1/2” ASSY. TAIL PULLEY ADJUSTMENT PLATE WLDMT. RETAINER CLIP FLAT WASHER - 1/2 STEEL LOCK WASHER - 1/2 SPRING STEEL HEX BOLT - 1/2-13 X 1 1/4” LG GR8 HEX NUT - 1/2-13 HEX BOLT - 1/2-13 X 1 LG GR8 CLAMP WASHER FLAT WASHER - 3/8 SCREED PIN WLDMT. HEX BOLT - 3/8-16 UNC X 1 1/4” LG REAR COVER CLAMP BAR RECEIVING HOUSING UPPER SIDE CLAMP BAR RECEIVING HOUSING BOTTOM CLAMP BAR RECEIVING HOUSING REAR BT. CLAMP BAR RECEIVING HOUSING REAR TOP CLAMP BAR ROLLER RETAINER CLIP
NO. REQ’D 1 1 4 8 2 5 218 258 172 54 126 97 34 8 8 1 2 2 1 1 6
SECONDARY CONVEYOR CRADLE ASSEMBLY ( 209616-01 )
SECONDARY CONVEYOR CRADLE ASSEMBLY ( 209616-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
PART NO.
209504-01 206785-03 205231-03 OO891 83752-04 206187-01 207299-04 207298-04 206925-03 90087-04 96475 83055 83056 207316-03 205229-03 130862 130455
DESCRIPTION ( 145386-01 ) CRADLE WLDMT. CRADLE PIN WLDMT. SEALED ROLLER BEARING - 2 1/2” DIA. HEX BOLT - 3/4-10 X 1 3/4 LG LOCKWASHER - 3/4 CYL. - 4” BORE X 25 STROKE SAFETY CABLE LIFT CABLE SPREADER BAR CHAIN - LOOP/ 1.75 OPENING DEPTH HEX BOLT - 3/8-16 X 2” HEX NUT - 3/8-16 LOCKWASHER - 3/8 SEC. CONV. PIVOT PIN SEALED BEARING - 1.750 CLAMP - 1/2” ASSY. CLAMP - 1” HOSE 1 1/2” ID
NO. REQ’D 1 1 2 1 1 3 2 2 1 2 4 4 4 2 4 4 8
28 DEG. TROUGHING IDLER ( SECONDARY CONVEYOR ) ( 219892-01 )
HEAD SHAFT BEARING ASSEMBLY ( 207006-03 )
SECTION 5 : HYDRAULICS ASSEMBLY
PART NO.
HYDRAULIC TANK AUXILIARY CIRCUIT BRAKE CIRCUIT BELT TENSION CIRCUIT CYLINDER - BELT TENSION ELEVATION CYLINDER - LEG TUBE ENDGATE CYLINDER - ENDGATE FAN FRT. MOLDB OARD CYL. - FRT. MOLDB OARD RR. MOLDBOARD CYL. - RR. MOLDBOARD HOOD CIRCUIT CYLINDER - HOOD LIFT PRIMARY CONVEYOR SECONDARY CONVEYOR
206009-01 214715-01 208019-03 208029-03 206915-04 210810-01 205338-01 210851-03 205037-04 214716-01 210847-03 205038-04 210836-03 205039-04 208030-03 204944-04 208027-03 210831-01
S/N 101 & UP
PAGE NO. 5.1 5.5 5.6 5.7 5.8 5.9 5.11 5.12 5.13 5.14 5.15 5.16 5.17 5.18 5.19 5.20 5.22 5.23
RX-900 HYDRAULIC TANK ASSEMBLY ( 206009-01 )
NEXT PAGE
RX-900 HYDRAULIC TANK ASSEMBLY PREVIOUS PAGE
( 206009-01 )
RX-900 HYDRAULIC TANK ASSEMBLY ( 206009-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
206624-01 206643-01 206648-03 127453 87237-04 203404-03 203403-03 203405-03 12K35 84071-04 83752-04 86127-04 96476 83056 89013-04 80250 92037-04 137269-04 29G37 23J52 29E61
DESCRIPTION ( 145386-01 ) HYDRAULIC TANK HYDRAULIC TANK LID HYDRAULIC TANK LID GASKET SIGHT GLASS GAUGE FILLER CAP RUBBER MOUNT - HEADWASHER J-2049-54 RUBBER MOUNT - 3/4” BOLT HLE CBA28-800 RUBBER MOUNT - TAILWASHER J-2949-69 HEX BOLT - 3/4-10 UNC X 4” LG NUT - 3/4-10 ASTM 563 AGID.8 LOCKWASHER - 3/4” SPRING STEEL HEX BOLT - 3/8-16 X 3/4” LG HEX BOLT - 3/8-16 X 1 1/4” LOCKWASHER - 3/8” SPRING STEEL FILTER TANK STRAINER NIPPLE - CLOSE 3/4” NPT BALL VALVE - 3/4” NPT FILTER - ELEMENTS MILRON FILTER HOUSING - 2 ELEMENT W/ BYPASS ELBOW - 1/8” NPT M X 1/8” NPT FEM. GAUGE - PRESSURE USE W/ 15 PST FILTER
NO. REQ’D 1 1 1 1 1 4 4 4 2 4 4 16 8 24 4 1 1 4 2 2 2
AUXILIARY CIRCUIT ASSEMBLY ( 214715-01 )
BRAKE CIRCUIT ASSEMBLY ( 208019-03 )
BELT TENSION CIRCUIT ASSEMBLY ( 208029-03 )
CYLINDER ASSY.- BELT TENSIONER ( 206915-04 )
ELEVATION CIRCUIT ASSEMBLY ( 4-TRACK ) ( 210810-01 )
ELEVATION CIRCUIT ASSEMBLY ( 4-TRACK ) ( 210810-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12
134503S 128235S 127121S 127121S 127121S 127121S 208468S 208468S 208468S 208468S 83475-04 89598
DESCRIPTION ( 145386-01 ) HOSE ASSY. - 3/8 X 156” LG 6X6 ST - 6X6 LN 90 DEG. HOSE ASSY. - 3/8 X 156” LG 6X6 ST - 6X6 90 DEG. HOSE ASSY. - 3/8 X 86” LG 6X6 ST - 6X6 ST HOSE ASSY. - 3/8 X 86” LG 6X6 ST - 6X6 ST HOSE ASSY. - 3/8 X 86” LG 6X6 ST - 6X6 ST HOSE ASSY. - 3/8 X 86” LG 6X6 ST - 6X6 ST HOSE ASSY. - 3/8 X 114” LG 6X6 ST - 6X6 LN 90 DEG. HOSE ASSY. - 3/8 X 114” LG 6X6 ST - 6X6 LN 90 DEG. HOSE ASSY. - 3/8 X 114” LG 6X6 ST - 6X6 LN 90 DEG. HOSE ASSY. - 3/8 X 114” LG 6X6 ST - 6X6 LN 90 DEG. FIT - 6 JIC BULKHEAD UNION FIT - 6 JIC SW BRANCH TEE
*REFERENCE TO HOSE KIT
NO. REQ’D REF REF REF REF REF REF REF REF REF REF 2 2
CYLINDER ASSY.- LEG TUBE ( 205338-01 )
ENDGATE CIRCUIT ASSEMBLY ( 210851-03 )
CYLINDER ASSY.- ENDGATE ( 205037-04 )
FAN CIRCUIT ASSEMBLY ( 214716-03 )
FRONT MOLDBOARD CIRCUIT ASSEMBLY ( 210847-03 )
CYLINDER ASSY.- FRT. MOLDBOARD ( 205038-04 )
REAR MOLDBOARD CIRCUIT ASSEMBLY ( 210836-03 )
CYLINDER ASSY.- RR. MOLDBOARD ( 205039-04 )
HOOD CIRCUIT ASSEMBLY ( 208030-03 )
CYLINDER ASSY.- HOOD LIFT ( 204944-04 )
PRIMARY CONVEYOR CIRCUIT ASSEMBLY ( 208027-03 )
SECONDARY CONVEYOR CIRCUIT ASSEMBLY ASSEMB LY ( 210831-01 )
SECONDARY CONVEYOR CIRCUIT ASSEMBLY ASSEMB LY ( 210831-01 ) REF NO.
PART NO.
DESCRIPTION ( 145386-01 )
NO. REQ’D
*REFERENCE TO HOSE KIT 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
134283 134283 93366-04 9336604 99650S 98813S 208378S 208378 S 147637S 147637 S 208587S 208587 S 147338S 147338 S 208377S 208377 S 208377S 208377 S 208381 208381 208382 125136S 125136 S 125136S 125136 S 132293S 132293 S 132293S 132293 S 130186S 130186 S 130186S 130186 S
HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 1/2” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 1/2” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 1/2” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 3/4” HOSE ASSY ASSY.. - 1/2” HOSE ASSY ASSY.. - 1/4” HOSE ASSY ASSY.. - 1/4” HOSE ASSY ASSY.. - 1/4” HOSE ASSY ASSY.. - 1/4” HOSE ASSY ASSY.. - 1/4” HOSE ASSY 1/4”
HP X 39” LG 12X12 ST - 12X12 ST HP X 39” LG 12X12 ST - 12X12 ST STD X 40” LG 8X8 ST - 8X8 ST HP X 48” LG 12X12 ST - 12X12 ST HP X 50” LG 12X12 ST - 12X12 ST STD X 50” LG 8X8 ST - 8X8 ST HP X 254” LG 12X12 ST - 12X12 90 DEG. HP X 251” LG 12X12 ST - 12X12 90 DEG. STD X 240” LG 8X8 ST - 8X8 ST HP X 190” LG 12X12 ST - 12X12 ST HP X 190” LG 12X12 ST - 12X12 ST HP X 188” LG 12X12 ST - 12X12 ST HP X 188” LG 12X12 ST - 12X12 ST STD X 186” LG 8X8 ST - 8X8 ST X 196” LG 6X4 ST - 6X4 90 DEG. X 196” LG 6X4 ST - 6X4 90 DEG. X 43” LG 6X4 ST - 6X4 90 DEG. X 43” LG 6X4 ST - 6X4 90 DEG. X 132” LG 6X4 ST - 6X4 90 DEG. X 132” LG 6X4 ST 6X4 90 DEG.
REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF
CYLINDER CYL INDER ASSY A SSY..- CONVEYOR SWING ( 206187-01 )
STEERING CIRCUIT ASSEMBLY ASSEMB LY ( 210809-03 )
CYL INDER ASSY CYLINDER A SSY.. ( 205348-01 )
TRAVEL CIRCUIT ASSEMBLY ( 208018-01 )
TRAVEL CIRCUIT ASSEMBLY ( 208018-01 ) REF NO.
PART NO.
DESCRIPTION ( 145386-01 ) *REFERENCE TO HOSE KIT
NO. REQ’D
WATER PUMP CIRCUIT ASSEMBLY ( 208023-01 )
VALVE STACK / MANIFOLD CIRCUIT ASSEMBLY ( 208028-01 )
VALVE MANIFOLD / RETURN CIRCUIT ASSEMBLY ( 214743-01 )
VALVE MANIFOLD / RETURN CIRCUIT ASSEMBLY ( 214743-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8
120284A 130411A 130010S 126753A 211585A 127163S 130189A 135614S
DESCRIPTION
HOSE ASSY. - 1/4-84” 6X4 ST - 4X4 90 DEG. HOSE ASSY. - 3/4 STD X 70” LG 12X12 ST - 12X12 ST HOSE ASSY. - 1 STD X 30” LG 16X16 ST - 16X16 90 DEG. HOSE ASSY. - 3/4-33” 12X12 ST - 12X12 90 DEG. HOSE ASSY. - 1” X 17” 16X16 ST - 16X16 90 DEG. HOSE ASSY. - 1” X 96” 16X16 ST - 16X16 90 DEG. HOSE ASSY. - 1/4-135” 6X4 ST - 6X4 90 DEG. HOSE ASSY. - 1” X 130” 16X16 ST - 16X16 90 DEG.
NO. REQ’D
REF REF REF REF REF REF REF REF
HYD. GENERATOR ( 120-4 kw ) ( 211178-01 )
HYDRAULIC COMPONENTS : WATER MANIFOLD FRONT MANIFOLD REAR MANIFOLD FRONT RETURN MANIFOLD REAR RETURN MANIFOLD 3-WAY CONTROL VALVE MULTI-FUNCTION VALVE FRONT DRIVE ANTI-SPIN VALVE REAR DRIVE ANTI-SLIP VALVE HI-PRESSURE IN-LINE FILTER HOOD HOLDING BLOCK POWER PACK GAUGE- SECONDARY CONV. GAUGE- PRIMARY CONV. GAUGE- TRAVEL GAUGE- CLUTCH GAUGE- AUXILIARY
210718-04 210164-03 218379-03 210691-03 210651-03 214695-04 218369-03 205349-04 205350-04 208645-03 211421-04 211427-04 211430-04 211433-04 211429-04 211434-04 211428-04
5.37 5.38 5.39 5.40 5.41 5.42 5.43 5.44 5.45 5.46 5.47 5.48 5.49 5.50 5.51 5.52 5.53
WATER MANIFOLD ASSEMBLY ( 210718-04 )
FRONT MANIFOLD ASSEMBLY ( 210164-03 )
REAR MANIFOLD ASSEMBLY ( 218379-03 )
FRONT RETURN MANIFOLD ASSEMBLY ( 210691-03 )
REAR RETURN MANIFOLD ASSEMBLY ( 210651-03 )
3-WAY CONTROL VALVE ASSEMBLY ( 214695-04 )
MULTI-FUNCTION VALVE ASSEMBLY ( 218369-03 )
HI-PRESSURE IN LINE FILTER ASSEMBLY ( 208645-03 )
HOOD HOLDING BLOCK VALVE ASSEMBLY ( 211421-04 )
SECONDARY CONVEYOR GAUGE ( 211430-04 )
PRIMARY CONVEYOR GAUGE ( 211433-04 )
TRAVEL GAUGE ( 211429-04 )
CLUTCH GAUGE ( 211434-04 )
AUXILIARY GAUGE ( 211428-04 )
SECTION 6 : ELECTRICAL ASSEMBLY ELECTRICAL ASSY. (CAT. 950) ELECTRICAL ASSY. (CAT. 950) OPERATORS CONSOLE ( CAT. 950 ) CENTER OPERATORS CONSOLE ( CAT. 950 ) RT. OPERATORS CONSOLE LT. OPERATORS CONSOLE BELT TENSIONER BOX MOLDBOARD BOX LEFT FRONT GROUND BOX RIGHT FRONT GROUND BOX RT. & LT. FRONT GROUND BOX HARNESS RIGHT REAR GROUND BOX LEFT REAR GROUND BOX RT. & LT. REAR GROUND BOX HARNESS LT, FRT. & RR. LIGHTS HARNESS RT, FRT. & RR. LIGHTS HARNESS
PART NO.
S/N
PAGE NO.
221842-01 220680-01
183 & UP 175-182
6.1 6.7
220970-01
175 & UP
6.13
220969-01 216125-01 210952-01 210769-04 210733-03 210985-02 210984-02
175 & UP
6.19 6.23 6.27 6.31 6.32 6.33 6.37
210695-02 210986-02 210987-02
6.41 6.42 6.35
210696-02
6.48
210770-03
6.49
210771-03
6.50
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 )
NEXT PAGE
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 )
NEXT PAGE
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 )
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 ) REF.# 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART #
221112-01 89077-04 142961-03 130644 202719-04 87953-04 87328-04 141038 89801-04S 206119-04 90103 89297 90871 83757 83056 83055 84332 208721-04 208723-04 208725-04 208719-04
DESCRIPTION
ELECTRICAL SCHEMATIC - CAT ENGINE BACK-UP ALARM AUX. SWITCH BRACKET BATTERY ISOLATION SWITCH 8D BATTERY 1400CCA HEX NUT 5/16 - 18 LOCK WASHER- 5/16 SPRING STEEL 3/4 ELECTRICAL TAPE 24 VOLT HELLA LAMP FUEL LEVEL SENDER LOCK WASHER - #10 HEX BOLT- 5/16” - 18 X 1” FLAT WASHER- 5/16 STEEL FLAT WASHER- 3/8” STEEL LOCK WASHER- 3/8” SPRING STEEL HEX NUT- 3/8- 16 GR8 HEX BOLT - 3/8-16 UNC X 1” BATTERY CABLE - BATTERY NEG TO ISO SWITCH BATTERY CABLE - ISO SWITCH TO STARTER GROUND BATTERY CABLE - ISO SWITCH TO STARTER POS BATTERY CABLE - JUMPER
QTY.
1 1 1 2 2 2 2 10 10 1 6 2 4 8 6 6 6 REF REF REF REF
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 ) REF. # 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66
PART #
210708-02 210714-01 210709-02 210734-01 210727-02 210733-03 210769-03 210783-03 210861-03 210719-02 208624-03 211163-03 210792-02 210774-03 202046-04 209165-04 209184-03 90101 139471 97779-04S 206829 04
DESCRIPTION
WIRE HARNESS - FRONT VALVES WIRE HARNESS - FRONT VALVES DIN PLUG WIRE HARNESS - REAR VALVES WIRE HARNESS - REAR VALVES DIN PLUG WIRE HARNESS - ANTI-SPIN VALVES MOLDBOARD ELECTRICAL BOX ASSY. BELT TENSIONER ELECTRICAL BOX ASSY. WIRE HARNESS - FUEL GAUGE WIRE HARNESS - WATER VALVE AND SENSOR WIRE HARNESS - HOOD POWER WIRE HARNESS WIRE HARNESS - 40 PIN PLUG (ENGINE) WIRE HARNESS - PROXIMITY SWITCH WIRE HARNESS - LIGHT CONVEYOR EXTENSION HOLDER - MEGA FUSE MEGA FUSE - 150 AMP DECAL - ALTERNATOR, POWER PACK, & HEATER FUSE SLOT HD. SCREW - 10-32 TOGGLE SWITCH SINGLE POLE (MOMENT L & R) ALARM - SINGLE HORN 24 VOLTS RUBBER GROMMET
QTY.
REF REF REF REF REF REF REF REF REF REF REF REF REF REF 1 1 1 4 2 2 1
RX-900 CAT. ELECTRICAL ASSEMBLY ( 221842-01 ) REF. # 91 92 93 94 95 96 97 98 99 100 101 102 103 104 105 106 107 108 109
PART #
DESCRIPTION
QTY.
83905-04 126976 83114 140001-04 122101-C2 204965-04 06996 205051-04
1/4 X 14 WIRE TIE 1/8 X 5 1/2 WIRE TIE HEX BOLT - 1/4-20 UNC X 1/2” RECEPTACLE - ELEMENT SEALED CONDUIT FITTING 3/8” CLOSURE CAP - A SIZE RECEPTACLE SCREW - M3-0.5 DECAL - WORK LIGHT
12 112 6 2 2 2 2 1
83924 210678-04 220947-02 211284-04 92917 211300-04 20Z54 221836-01 221837-01 213349-04
HEX BOLT - 3/8-16 UNC X 1 1/4” RESISTOR - 10 WATTS 50 OHMS ASSY. - START ASSIST TO STARTER WIRE HARNESS- ISO SWITCH TO 60 AMP BREAKER SCREW, SLOTTED HD. 10-32 X 3/4” WIRE HARNESS- ISO SWITCH GRD TO POWER PACK 60 AMP BREAKER KIT - WIRE HARNESS & BOXES RX-900-3 CAT KIT - WIRE HARNESS & BOXES RX-900-4 CAT WIRE HARNESS - STARTER GROUND TO ECM GROUND
6 1 1 REF 4 1 2 1 1 REF
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 )
NEXT PAGE
PREVIOUS PAGE
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 )
NEXT PAGE
PREVIOUS PAGE
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 )
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO.
89077-04 142961-03 130644 202719-04 87953-04 87328-04 141038 89801-04S 206119-04 90103 89297 90871 83757 83056 83055 84332 208721-04 208723-04 208725-04 208719-04 208720 04
DESCRIPTION ( 145386-01 ) ELECTRICAL SCHEMATIC - CAT ENGINE BACK-UP ALARM AUX. SWITCH BRACKET BATTERY ISOLATION SWITCH 8D BATTERY 1400CCA HEX NUT 5/16 - 18 LOCK WASHER- 5/16 SPRING STEEL 3/4 ELECTRICAL TAPE 24 VOLT HELLA LAMP FUEL LEVEL SENDER LOCK WASHER - #10 HEX BOLT- 5/16” - 18 X 1” FLAT WASHER- 5/16 STEEL FLAT WASHER- 3/8” STEEL LOCK WASHER- 3/8” SPRING STEEL HEX NUT- 3/8- 16 GR8 HEX BOLT - 3/8-16 UNC X 1” BATTERY CABLE - BATTERY NEG TO ISO SWITCH BATTERY CABLE - ISO SWITCH TO STARTER GROUND BATTERY CABLE - ISO SWITCH TO STARTER POS BATTERY CABLE - JUMPER BATTERY CABLE BATTERY POS TO ISO SWITCH
NO. REQ’D 1 1 1 2 2 2 2 10 10 1 6 2 4 22 22 20 16 REF REF REF REF REF
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 ) REF NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71
PART NO.
210733-03 210769-03 210783-03 210861-03 210719-02 208624-03 211163-03 210792-02 210774-03 202046-04 209165-04 209184-03 90101 139471 97779-04S 206829-04 143227 131551 92554 204123-04 214105-04
DESCRIPTION ( 145386-01 ) MOLDBOARD ELECTRICAL BOX ASSY. BELT TENSIONER ELECTRICAL BOX ASSY. WIRE HARNESS - FUEL GAUGE WIRE HARNESS - WATER VALVE AND SENSOR WIRE HARNESS - HOOD POWER WIRE HARNESS WIRE HARNESS - 40 PIN PLUG (ENGINE) WIRE HARNESS - PROXIMITY SWITCH WIRE HARNESS - LIGHT CONVEYOR EXTENSION HOLDER - MEGA FUSE MEGA FUSE - 150 AMP DECAL - ALTERNATOR, POWER PACK, & HEATER FUSE SLOT HD. SCREW - 10-32 TOGGLE SWITCH SINGLE POLE (MOMENT L & R) ALARM - SINGLE HORN 24 VOLTS RUBBER GROMMET LEVEL SWITCH LOCK WASHER - #6 FLAT WASHER - #6 STROBE LIGHT POWER RELAY
NO. REQ’D REF REF REF REF REF REF REF REF REF 1 1 1 4 2 2 1 1 2 2 1 1
RX-900 CAT. ELECTRICAL ASSEMBLY ( 220680-01 ) REF NO. 101 102 103 104 105 106 107 108 109 110 111 112 113 114
PART NO.
210678-04 220947-02 211284-04 92917 211300-04 20Z54 220974-02 220973-02 213349-04 129349 97490-C1 211055-03 139704-04 220313-03
DESCRIPTION ( 145386-01 ) RESISTOR - 10 WATTS 50 OHMS ASSY. - START ASSIST TO STARTER WIRE HARNESS- ISO SWITCH TO 60 AMP BREAKER SCREW, SLOTTED HD. 10-32 X 3/4” WIRE HARNESS- ISO SWITCH GRD TO POWER PACK 60 AMP BREAKER KIT - WIRE HARNESS & BOXES RX-900-3 CAT KIT - WIRE HARNESS & BOXES RX-900-4 CAT WIRE HARNESS - STARTER GROUND TO ECM GROUND RESISTOR - 10 WATT, 250 OHMS SWITCH COVER CUTTER HOUSING PROXIMITY SENSOR ASSY. STAR WASHER - 5/8” INTERNAL - EXTERNAL KIT - MILLS ENGINE GROUND
NO. REQ’D 1 1 REF 4 1 2 1 1 REF 2 2 1 6 1
CAT. OPERATORS CONSOLE ELECTRICAL ASSY. NEXT PAGE ( 220970-01 )
CAT. OPERATORS CONSOLE ELECTRICAL ASSY. ( 220970-01 ) PREVIOUS P AGE NEXT PAGE
FRONT&REAR STEERINGCALIBRATIO N TOCALIBRATESETFRONT&REARTRACK STRAIGHT AHEAD. THENDEPRESS&HOLD DOWNCALIBRATIONSWITCH FOR5SECOND THENRELEASE. STEERINGINNOWCALIBRATED
CAT. OPERATORS CONSOLE ELECTRICAL ASSY. ( 220970-01 ) PREVIOUS PAGE
CAT. OPERATORS CONSOLE ELECTRICAL ASSY. ( 220970-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO.
206016-01 210952-01 220969-01 216125-01 132173-04 84444 83065 89772 83114 207768-03 204582-03 210488-01 13C69 135807-04 211559-04 83757 83056 128862 124296 90101 92552 129349
DESCRIPTION ( 145386-01 ) OPERATOR CONSOLE ASSEMBLY ASSY. - LEFT SIDE OPERATOR CONSOLE ASSY. - CENTER OPERATOR CONSOLE ASSY. - RIGHT SIDE OPERATOR CONSOLE BB HEAD SS SCREW - 1/4-20 UNC X 5/8” FLAT WASHER - 1/4” LOCK WASHER - 1/4” HEX NUT - 1/4-20 UNC HEX BOLT - 1/4-20 UNC X 1/2” CROSS BAR - TRAVEL CONTROL LINKAGE LINK - TRAVEL CONTROL LINKING OPERATOR CONSOLE BACKING PLATE ELECTRICAL - TERMINAL BLOCK SLOTTED SCREW - 10-32 X 1” LOCK NUT - 3/8-16 CENTER GR8 FLAT WASHER - 3/8” LOCK WASHER - 3/8” RELAY - 24 VOLTS 40 AMP DIODE - 6 AMP AXIAL SLOTTED SCREW - 10-32 X 3/4” FLAT WASHER - #10 RESISTOR 250 OHM 25 WATTS
NO. REQ’D 1 1 1 1 26 38 38 36 6 1 2 1 204 40 8 8 8 7 9 37 9 2
CAT. OPERATORS CONSOLE ELECTRICAL ASSY. ( 220970-01 ) REF NO. 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71 72
PART NO. 210846-02 210808-02 210842-02 210849-02 210853-02 210862-03 210826-03 210829-02 220971-01 220968-02 216121-02 210798-02 210939-02 210800-02 210840-02 210852-02 210844-02 O6996 O4762 92554 131551 208299 04
DESCRIPTION ( 145386-01 ) PIG TAIL - LEFT FRONT GROUND BOX PIG TAIL - LEFT CONSOLE #2 PIG TAIL - LEFT REAR GROUND BOX PIG TAIL - PUMP CAT ENGINE PIG TAIL - FRONT VALVE PIG TAIL - WATER VALVE & SENSOR PIG TAIL - RIGHT LIGHT FRONT & REAR PIG TAIL - PROXIMITY SWITCH PIG TAIL - CAT ENGINE PIG TAIL - CENTER CONSOLE HARNESS #2 PIG TAIL - RIGHT CONSOLE #1 PIG TAIL - RIGHT CONSOLE #2 PIG TAIL - CENTER CONSOLE #1 PIG TAIL - RIGHT CONSOLE #3 PIG TAIL - RIGHT REAR GROUND BOX PIG TAIL - REAR VALVE PIG TAIL - RIGHT FRONT GROUND BOX SLOTTED SCREW - M3-0.5 X 20 5.8 84 HEX NUT - M3-0.5 GR8 934 FLAT WASHER - #6 LOCK WASHER - #6 PLASTIC NUT DEUTSCH
NO. REQ’D REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF REF 36 36 72 36 1
CAT.. OPERATORS CONSOLE EL CAT ELECTRICA ECTRICAL L ASSY A SSY.. ( 220970-01 ) REF NO. 101 102 103 104 105 106 107 108 109 110 111 11 1 112 113 114 115 116 117 118 119 120 121 122
PART NO.
DESCRIPTION ( 145386-01 )
NO. REQ’D
136165 83657-04 126976 130627 208746-03 208747-03 208748-03 208749-03 220966-03 208752-03 208753-03 210416-01 210678-04
WIRE TIE - 3/32 X 7 WIRE TIE - 1/8 X 7 WIRE TIE - 1/8 X 5 1/2 RUBBER GROMMET - 3 OD X 2 3/8 ID WIRE HARNESS - LEFT FRONT TRACK MOTOR WIRE HARNESS - RIGHT FRONT TRACK MOTOR WIRE HARNESS - LEFT REAR TRACK MOTOR WIRE HARNESS - RIGHT REAR TRACK MOTOR DECAL KIT - DEUTSCH PLUG WIRE HARNESS - STEERING SENSOR LEFT REAR WIRE HARNESS - STEERING SENSOR RIGHT FRONT DATA PLATE KIT - TERMINAL ID STRIPS RESISTOR - 50 OHM 10 WATTS
75 375 140 2 REF REF REF 1 1 REF REF 1 1
210432-04 210433-04 210434-04 211631-04 149509 209077-04 208890-03 210939 02
ELECTRICAL CONNECTOR 16-14 AWG ELECTRICAL CONNECTOR 22-18 AWG ELECTRICAL CONNECTOR 12-14 AWG ELECTRICAL CONNECTOR 10-12 AWG FUSE HOLDER FUSE 5 AMP WIRE HARNESS - CENTER TRACK MOTOR WIRE HARNESS CENTER CONSOLE #1
50 30 100 40 1 1 REF REF
CAT.. CENTER OPERATORS CONSOL CAT CONSOLE E A SSY SSY.. ( 220969-01 )
NEXT PAGE
CAT.. CENTER OPERATORS CONSOL CAT CONSOLE E A SSY SSY.. PREVIOUS P AGE
( 220969-01 )
CAT.. CENTER OPERATORS CONSOL CAT CONSOLE E A SSY SSY.. ( 220969-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
220964-01 220965-01 13E68 139471 129916 97542 97678 97490-C1 97490 20Z53 219633-04 130406 130406-C1 142946-C1 207662-03 207719-03 207716-03 207717-03 207664-03 207668-04 130934
DESCRIPTION ( 145386-01 )
NO. REQ’D
DATA PLATE - CENTER OPERATOR CONSOLE COMPONENT PLATE - CENTER CONSOLE SWITCH - TOGGLE SP ST ON/OFF SWITCH - TOGGLE MOMENTARY SPRING TOGGLE SWITCH SWITCH - ON/OFF TOGGLE SP-ST-SR SWITCH TOGGLE DPST SWITCH - COVER SWITCH - TWO POLE ON-OFF-ON SWITCH - TOGGLE DPST FPM/ MPM GAUGE ROTARY POT - 25 WATTS 100 OHMS HANDLE - 5150 CONTROL KNOB 24 VOLT BULB GAUGE - DIAGNOSTIC & DISPLAY WIRE HARNESS - CAM & POWER WIRE HARNESS - JUMPER 9” WIRE HARNESS - POWER VIEW GAUGE - TACHOMETER POWER VIEW JUMPER TERM RESISTOR GAUGE - FUEL 24 VOLTS
1 1 3 7 1 1 1 1 1 1 1 1 1 2 1 1 1 1 1 1 1
RIGHT OPERATORS CONSOLE ELECTRICAL ASSY. ( 216125-01 ) NEXT PAGE
RIGHT OPERATORS CONSOLE ELECTRICAL ASSY. ( 216125-01 ) PREVIOUS PAGE
RIGHT OPERATORS CONSOLE ELECTRICAL ASSY. ( 216125-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
210396-02 210399-02 205652-03 205653-03 135893 13E68 97543 139471 207020-04 20Z53 149903 120276-C1 206037-04 133678 133682 144757-04 210797-02 216123-02 210799-02 136712-04 97542
DESCRIPTION ( 145386-01 ) DATA PLATE - RIGHT OPERATOR CONSOLE OPERATOR CONSOLE - RIGHT ALUM BACKING PLATE CONTROL - STEERING JOYSTICK CONTROL - CONVEYOR JOYSTICK CONTROL - JOYSTICK (FORWARD & REVERSE) SWITCH - TOGGLE SP ST ON/OFF SWITCH - SR/ OFF/ ST TOGGLE SWITCH SWITCH - TOGGLE MOMENTARY SPRING LED ILLUMINATED E-STOP SWITCH - FOUR POLE ON-NONE-ON ELECTRIC POTENTIOMETER KNOB - POTENTIOMETER LIGHT - SERIES 177 GREEN LENS LIGHT - SERIES BASE LIGHT - 28 VOLTS CONSOLE LIGHT WIRE HARNESS - RIGHT HAND CONSOLE HARNESS #2 WIRE HARNESS - RIGHT HAND CONSOLE HARNESS #1 WIRE HARNESS - RIGHT HAND CONSOLE HARNESS #3 SWITCH - FOUR POLE ON-ON-ON SWITCH - SINGLE POLE ON-NONE-ON
NO. REQ’D 1 1 1 1 1 2 1 3 1 1 1 1 1 1 1 1 REF REF REF 1 1
LEFT OPERATORS CONSOLE ELECTRICAL ASSY. ( 210952-01 )
NEXT PAGE
LEFT OPERATORS CONSOLE ELECTRICAL ASSY. ( 210952-01 ) PREVIOUS PAGE
NEXT PAGE
LEFT OPERATORS CONSOLE ELECTRICAL ASSY. ( 210952-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO. 210395-02 210398-02 205652-03 205653-03 205752-03 13E68 97543 139471 207020-04 206037-04 133678 133682 97944-04 144757-04 210805-02 210807-02 97542 208307-04 208009-04 137176-04 142946-C1 136481
DESCRIPTION ( 145386-01 ) DATA PLATE - LEFT OPERATOR CONSOLE OPERATOR CONSOLE - LEFT ALUM BACKING PLATE CONTROL - STEERING JOYSTICK CONTROL - CONVEYOR JOYSTICK CONTROL - JOYSTICK (FORWARD & REVERSE) SWITCH - TOGGLE SP ST ON/OFF SWITCH - SR/ OFF/ ST TOGGLE SWITCH SWITCH - TOGGLE MOMENTARY SPRING LED ILLUMINATED E-STOP LIGHT - SERIES 177 GREEN LENS LIGHT - SERIES BASE LIGHT - 28 VOLTS PLUG - HOLE 1/2” CONSOLE LIGHT WIRE HARNESS - LEFT HAND CONSOLE HARNESS #1 WIRE HARNESS - LEFT HAND CONSOLE HARNESS #2 SWITCH - SINGLE POLE MOM-NONE-OFF DEUTSCH 4 PIN RECEPTACLE DEUTSCH LOCKING WEDGE ELECTRICAL PIN 24 VOLT BULB SPACER CONTROL
NO. REQ’D 1 1 1 1 1 1 1 3 1 2 2 2 2 1 REF REF 1 1 1 4 1 2
BELT TENSIONER CONTROL BOX ( 210769-04 )
MOLDBOARD CONTROL BOX ( 210733-03 )
LEFT FRONT GROUND ELECTRICAL B OX ( 210985-02 )
NEXT PAGE
LEFT FRONT GROUND ELECTRICAL BOX PREVIOUS PAGE
( 210985-02 )
LEFT FRONT GROUND BOX ASSEMBLY ( 210985-02 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
210570-02 210574-03 210845-02 207998-04 208803-04 207020-04 139471 97542 97944-04 140001-04 122101-C3 204965-04 205051-04 O6996 O4762 131551 92554
DESCRIPTION ( 145386-01 ) LEFT FRONT ELECTRICAL GROUND BOX DATA PLATE - LEFT FRONT GROUND BOX PIG TAIL - LEFT FRONT GROUND BOX NUT DEUTSCH SIZE 24 LOCKWASHER DEUTSCH LED ILLUMINATED E-STOP SWITCH - TOGGLE MOMENTARY SPRING SWITCH ON-OFF HOLE PLUG - 1/2” RECEPTACLE - ELEMENT SEALED CONDUIT NUT CLOSURE CAP - A-SIZE RECEPTACLE DECAL - WORK LIGHT SCREW - M3-0.5 NUT - M3-0.5 LOCKWASHER - #6 FLAT WASHER - #6
NO. REQ’D 1 1 1 1 1 1 2 1 2 1 1 1 1 1 1 1 2
RIGHT FRONT GROUND ELECTRICAL BOX ( 210984-02 )
NEXT PAGE
RIGHT FRONT GROUND ELECTRICAL BOX PREVIOUS PAGE
( 210984-02 )
RIGHT FRONT GROUND BOX ASSEMBLY ( 210984-02 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17
PART NO.
210571-02 210575-03 210843-02 207998-04 208803-04 207020-04 139471 97542 97944-04 140001-04 122101-C3 204965-04 205051-04 O6996 O4762 131551 92554
DESCRIPTION ( 145386-01 ) RIGHT FRONT ELECTRICAL GROUND BOX DATA PLATE - RIGHT FRONT GROUND BOX PIG TAIL - RIGHT FRONT GROUND BOX NUT DEUTSCH SIZE 24 LOCKWASHER DEUTSCH LED ILLUMINATED E-STOP SWITCH - TOGGLE MOMENTARY SPRING SWITCH ON-OFF HOLE PLUG - 1/2” RECEPTACLE - ELEMENT SEALED CONDUIT NUT CLOSURE CAP - A-SIZE RECEPTACLE DECAL - WORK LIGHT SCREW - M3-0.5 NUT - M3-0.5 LOCKWASHER - #6 FLAT WASHER - #6
NO. REQ’D 1 1 1 1 1 1 2 1 2 1 1 1 1 1 1 1 2
HARNESS-RT. & LT. FRONT GROUND BOX ( 210695-02 )
RIGHT REAR GROUND BOX ASSEMBLY ( 210986-02 )
NEXT PAGE
RIGHT REAR GROUND BOX ASSEMBLY PREVIOUS PAGE
( 210986-02 )
RIGHT REAR GROUND BOX ASSEMBLY ( 210986-02 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
210573-02 210577-03 210839-02 207998-04 208803-04 80411-04 80419-04 207020-04 139471 97542 97944-04 140001-04 122101-C3 204965-04 205051-04 O6996 O4762 131551 92554 O6996 O4762
DESCRIPTION ( 145386-01 ) RIGHT REAR ELECTRICAL GROUND BOX DATA PLATE - RIGHT REAR GROUND BOX PIG TAIL - RIGHT REAR GROUND BOX NUT DEUTSCH SIZE 24 LOCKWASHER DEUTSCH AMPHENOL 10 PIN PLUG AMPHENOL 10 PIN PLUG CAP LED ILLUMINATED E-STOP SWITCH - TOGGLE MOMENTARY SPRING SWITCH ON-OFF HOLE PLUG - 1/2” RECEPTACLE - ELEMENT SEALED CONDUIT NUT CLOSURE CAP - A-SIZE RECEPTACLE DECAL - WORK LIGHT SCREW - M3-0.5 NUT - M3-0.5 LOCKWASHER - #6 FLAT WASHER - #6 SCREW - M3-0.5 NUT - M3-0.5
NO. REQ’D 1 1 1 1 1 1 1 1 6 1 4 1 1 1 1 1 1 1 2 4 4
LEFT REAR GROUND BOX ASSEMBLY ( 210987-02 )
NEXT PAGE
LEFT REAR GROUND BOX ASSEMBLY PREVIOUS PAGE
( 210987-02 )
LEFT REAR GROUND BOX ASSEMBLY ( 210987-02 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
PART NO.
210572-02 210576-03 210841-02 207998-04 208803-04 80411-04 80419-04 207020-04 139471 97542 97944-04 140001-04 122101-C3 204965-04 205051-04 O6996 O4762 131551 92554 O6996 O4762
DESCRIPTION ( 145386-01 ) LEFT REAR ELECTRICAL GROUND BOX DATA PLATE - LEFT REAR GROUND BOX PIG TAIL - LEFT REAR GROUND BOX NUT DEUTSCH SIZE 24 LOCKWASHER DEUTSCH AMPHENOL 10 PIN PLUG AMPHENOL 10 PIN PLUG CAP LED ILLUMINATED E-STOP SWITCH - TOGGLE MOMENTARY SPRING SWITCH ON-OFF HOLE PLUG - 1/2” RECEPTACLE - ELEMENT SEALED CONDUIT NUT CLOSURE CAP - A-SIZE RECEPTACLE DECAL - WORK LIGHT SCREW - M3-0.5 NUT - M3-0.5 LOCKWASHER - #6 FLAT WASHER - #6 SCREW - M3-0.5 NUT - M3-0.5
NO. REQ’D 1 1 1 1 1 1 1 1 6 1 4 1 1 1 1 1 1 1 2 4 4
HARNESS-RT. & LT. REAR GROUND BOX ( 210696-02 )
LEFT FRONT & REAR LIGHTS HARNESS ( 210770-03 )
RIGHT FRONT & REAR LIGHTS HARNESS ( 210771-03 )
HARNESS- PUMP ON CAT. ENGINE ( 208809-03 )
HARNESS- FRONT VALVES ( 210708-02 )
HARNESS- FRONT VALVES DIN PLUG ( 210714-01 )
NEXT PAGE
PREVIOUS PAGE
HARNESS- FRONT VALVES DIN PLUG ( 210714-01 )
HARNESS- REAR VALVES ( 210709-02 )
HARNESS- REAR VALVES DIN PLUG ( 210734-01 )
NEXT PAGE
PREVIOUS PAGE
HARNESS- REAR VALVES DIN PLUG ( 210734-01 )
CLUTCH & TWO-SPEED HARNESS ( 210745-02 )
NEXT PAGE
PREVIOUS PAGE
CLUTCH & TWO-SPEED HARNESS ( 210745-02 )
ANTI-SPIN VALVES HARNESS ( 210727-02 )
WATER VALVE & SENSOR HARNESS ( 210861-03 )
HOOD HARNESS ( 210719-02 )
POWER WIRE HARNESS ( 208624-03 )
HARNESS- 40 PIN PLUG ( ENGINE ) ( 210766-03 )
FLOAT & PROXIMITY SWITCH HARNESS ( 210792-02 )
CONVEYOR LIGHTS EXT’N. HARNESS ( 210774-03 )
SECTION 7 : WATER SYSTEM ASSEMBLY
PART NO.
SPRAYBAR REAR WATER FILL
220683-01 220688-01
S/N 175 & UP
PAGE NO. 7.1 7.7
RX-900 SPRAYBAR ASSEMBLY ( 220683-01 )
NEXT PAGE
RX-900 SPRAYBAR ASSEMBLY PREVIOUS PAGE
( 220683-01 )
NEXT PAGE
PREVIOUS PAGE
RX-900 SPRAYBAR ASSEMBLY ( 220683-01 )
RX-900 SPRAYBAR ASSEMBLY ( 220683-01 ) REF NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
PART NO. 207123-03 207239-03 96476 83757 83056 220688-01 89652 89654 89924-04 90201 45228 136028-04 208274-04 80164 87588-04 91321-04 80249 80105 213363-02 80591 123421-04 92144
DESCRIPTION ( 145386-01 ) PRIMARY CONV. SPRAY BAR SEC. CONV. SPRAY BAR WLDMT. HEX BOLT - 3/8-16 X 1 1/4” FLAT WASHER - 3/8” LOCK WASHER 3/8” REAR WATER FILL ASSY. (NOT SHOWN) FULL-FLOW BALL VALVE - 2” NPT COUPLING - QD 2” MALE CLOSE NIPPLE -2” NPT ELBOW - 2” NPT 90 STREET CLAMP - 3/8” HOSE 1/2” WORM FIT - 1/2” NPT X 1/2 HOSE BARB REDUCER - BELL 3/4” NPT X 1/2” NPT NIPPLE - CLOSE 1/2” NPT VALVE - BALL 1/2” NPT HOSE - WATER 3/4” (BLACK) HOSE REEL ELBOW - 3/4” NPT 90 STREET HOSE CLAMP - 3/4” WATER MANIFOLD CLOSE NIPPLE - 1 1/4” NPT IN-LINE CHECK VALVE 1 1/4” NPT PLUMB 1 1/4” NPT 90 ST
NO. REQ’D 1 1 2 9 9 1 1 1 1 1 6 6 3 3 3 552” 4 5 1 2 1 2
RX-900 SPRAYBAR ASSEMBLY ( 220683-01 ) REF NO.
PART NO.
51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70 71
16P29 131104-04 95966 207184-03 127777 207134-04 207182-04 207158-04 136019-04 121200 209123-04 207133-04 86645-04 93107 128851 86556-04 94047 142236-04 87626 80229 88266
DESCRIPTION ( 145386-01 ) CLAMP - BOLT SIZE 1/2” HOSE HOSE REEL CLAMP - 7/8” CUSHION - TUBE (3/8” BOLT) FRONT SPRAY BAR SOC. HD. SCREW - 1/4”-20 X 3/4” LG ATOM CLAMP 1/4 SZ10 ZIP-TIP ASSY. FIT - QUICK DISC. 3/4” NPT M HOSE - WATER 1/2” (BLACK) MANIFOLD TO PRIMARY FLASHING HEX BOLT - 3/8-16 X 3” LG PLUMB - 1/2” SS. CLOSE NIPPLE PLUMB - 3/4” SS CAP ALUMINUM SLEEVE SPRAYER - NOZZLE BRASS COUPLING - QUICK DISCONNECT. ALUM. DUST PLUG CABLE - AIRCRAFT 7/7 X 1/16 X 12” LG UNION - 1 1/4” NPT NIPPLE - 1 1/2” NPT X 5” LG PLUMB - TEE 3/4” NPT FEMALE STL. PLUMB - 1/2” PIPE PLUG PLUMB - 3/4 X 1/2” NPT BUSHING RED.
NO. REQ’D 6 1 6 1 2 2 3 2 78” 1 1 3 1 1 1 1 1 1 1 1 1
RX-900 REAR WATER FILL ASSEMBLY ( 220688-01 )
SECTION 8 : OPTIONAL EQUIPMENT ASSEMBLY FIXED WORK LIGHTS RETRO KIT- AIR COMPRESSOR BRKT. MOBA DUAL-SONIC CONTROL
PART NO.
S/N
PAGE NO.
211184-01
8.1
217262-01
8.3
216094-01
8.7
FIXED WORK LIGHT ASSEMBLY ( 211184-01 )
RETRO KIT - AIR COMPRESSOR BRKT. ( 217262-01 )
NEXT PAGE
PREVIOUS PAGE
RETRO KIT - AIR COMPRESSOR BRKT. ( 217262-01 )
RETRO KIT - AIR COMPRESSOR BRKT. ( 217262-01 ) REF NO.
PART NO.
DESCRIPTION ( 145386-01 )
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
217164-03 83317 88445 217161-02 88164 216867-01 217168-03 217169-02 86164 89151 217163-03 84444 83065 89772 204662-04
AIR COMPRESSOR TENSION CLEVIS R.H. LOCKWASHER 1/2” SPRING STEEL NUT,JAM 1”-8 UNC COMPRESSOR TENSION MOUNTING BRACKET NUT, LOCK 3/4-10 BELTGUARD, COMPRESSOR COVER COMPRESSOR TENSION COUPLING COMPRESSOR TENSION MOUNTING BRACKET BOLT, HEX 1/2-13 X 1 1/4” BOLT, HEX 3/4-10 X 3” AIR COMPRESSOR TENSION CLEVIS L.H. WASHER, FLAT 1/4” STEEL LOCKWASHER 1/4” SPRING STEEL NUT, HEX 1/4-20 RUBBER M/M FLEX-BOLT SAND. MT 1/4 UNC
NO. REQ’D 1 3 1 1 2 1 1 1 3 2 1 2 2 2 1
MOBA DUAL-SONIC CONTROL ( 216094-01 )
NEXT PAGE
PREVIOUS P AGE
MOBA DUAL-SONIC CONTROL ( 216094-01 )
MOBA DUAL-SONIC CONTROL ( 216094-01 ) REF NO.
PART NO.
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21
216095-04 205115-03 95966 207001-03 147017-03 208484-03 122352-04 132173-04 83065 89772 86164 83754 83317 133393 210255-04 99965 122081-04 O1157 86143-04 124296 84444
DESCRIPTION ( 145386-01 ) COLD PLANER SONIC GRADE CONTROL SYSTEM RIGHT SIDE HAND SET BRACKET CLAMP - 7/8” CUSHION - TUBE (3/8” BOLT) MOBA SYSTEM CABLE ASSY. RH OUTRIGGER ARM WLDMT. GRADE CONTROL OUTRIGGER ARM GRADE CONTROL OUTRIGGER BRACKET BHEAD SS SCREW - 1/4-20 X 5/8” LOCK WASHER - 1/4” HEX NUT - 1/4-20 HEX BOLT - 1/2-13 X 1 1/4” HEX BOLT - 1/2-13 X 1” LOCK WASHER - 1/2” CLAMPING HANDLE HITCH PIN - 1 3/16” SPRING TYPE CLAMP - 2” RUBBERIZED TUBE CLAMPING HANDLE HEX BOLT - M6-1 X 16MM LG HEX BOLT - 1/4-20 X 5/8” DIODE 6 AMP AXIAL FLAT WASHER - 1/4”
NO. REQ’D 1 1 3 2 2 2 2 16 28 16 6 4 10 2 1 3 4 4 8 4 28
RX-900-4 CAT HOSE KIT
ROADTEC PART NUMBER 218315-04
EFFECTIVE SN 164
TIER Hose No. Roadtec P/N Hose dia
B
Hose End 2
B
O.A.L
Circuit
2
36
129838S
1/4
F471TC0639060604XS
PARKER ASSY #
Hose type Parker # Cut hose Hose End 1 STD
471TC-4
84
6 X 4 ST
1.30
6 X 4 90
1.38
87
REAR DRIVE
2
37
131018S
1/4
F471TC0639060604XS
STD
471TC-4
71
6 X 4 ST
1.30
6 X 4 90
1.38
74
REAR DRIVE
2
38
134003S
3/8
F471TC0639080606XS
STD
471TC-6
27
8 X 6 ST
1.46
6 X 6 90
1.28
30
REAR DRIVE
RX-900-4 CAT HOSE KIT
ROADTEC PART NUMBER 218315-04
EFFECTIVE SN 164
TIER Hose No. Roadtec P/N Hose dia
B
Hose End 2
B
O.A.L
Circuit
6 X 6 ST
1.26
6 X 6 ST
1.26
89
REAR ELEVATION
86
6 X 6 ST
1.26
6 X 6 ST
1.26
89
REAR ELEVATION
114
6 X 6 ST
1.26
6 X 6 LN 90
1.27
117
ELEVATION
114
6 X 6 ST
1.26
6 X 6 LN 90
1.27
117
ELEVATION
471TC-6
114
6 X 6 ST
1.26
6 X 6 LN 90
1.27
117
ELEVATION
STD
471TC-6
114
6 X 6 ST
1.26
6 X 6 LN 90
1.27
117
ELEVATION
F782TC0639121212XS
HP
782TC-12
167
12 X 12 ST
1.90
12 X 12 90
2.36
171
PRIMARY CONV
F782TC0606121212XS
HP
782TC-12
167
12 X 12 ST
1.90
12 X 12 90
2.36
171
PRIMARY CONV
1/2
F471TC0606080808XS
STD
471TC-8
137
8 X 8 ST
1.37
8 X 8 ST
1.37
140
PRIMARY CONV
208585S
3/4
F782TC0637121212XS
HP
782TC-12
150
12 X 12 ST
1.90
12 X 12 45
2.88
155
PRIMARY CONV
208586S
3/4
F782TC0637121212XS
HP
782TC-12
155
12 X 12 ST
1.90
12 X 12 45
2.88
160
PRIMARY CONV
8
74
127121S
8
75
127121S
3/8
8
76
208468S
3/8
8
77
208468S
3/8
8
78
208468S
8
79
9 9
PARKER ASSY #
Hose type Parker # Cut hose Hose End 1 STD
471TC-6
F471TC0606060606XS
STD
471TC-6
F471TC0641060606XS
STD
471TC-6
F471TC0641060606XS
STD
471TC-6
3/8
F471TC0641060606XS
STD
208468S
3/8
F471TC0641060606XS
80
127158S
3/4
81
127158S
3/4
9
82
208584S
9
83
9
84
3/8
F471TC0606060606XS
86
RX-900-4 CAT HOSE KIT
ROADTEC PART NUMBER 218315-04
EFFECTIVE SN 164
TIER Hose No. Roadtec P/N Hose dia
B
Hose End 2
B
O.A.L
Circuit
13
124
130946A
1/4
F471TC0639060604JX
PARKER ASSY #
Hose type Parker # Cut hose Hose End 1 STD
471TC-4
20
6 X 4 ST
1.30
6 X 4 90
1.38
23
HOOD
14
125
131030S
3/4
F451TC0641121212XS
STD
451TC-12
90
12 X 12 ST
1.73
12 X 12 LN 90
1.95
94
AUXILIARY
14
126
96540S
3/4
F451TC0606121212XS
STD
451TC-12
98
12 X 12 ST
1.73
12 X 12 ST
1.73
101
AUXILIARY
14
127
93323-04S
3/4
F471TC0639121212XS
STD
451TC-12
40
12 X 12 ST
1.73
12 X 12 ST
1.73
43
AUXILIARY
14
128
129851S
3/4
F451TC0606121212XS
STD
451TC-12
135
12 X 12 ST
1.73
12 X 12 ST
1.73
138
AUXILIARY
14
129
127058A
3/4
F451TC0606121212JX
STD
451TC-12
55
12 X 12 ST
1.73
12 X 12 ST
1.73
58
AUXILIARY
14
130
97812A
3/8
F471TC0639060806JX
STD
471TC-6
45
6 X 6 ST
1.26
8 X 6 90
1.50
48
AUXILIARY
RX-900-4 CAT HOSE KIT
ROADTEC PART NUMBER 218315-04
EFFECTIVE SN 164
TIER Hose No. Roadtec P/N Hose dia
B
Hose End 2
B
O.A.L
Circuit
23
163
134771A
1/4
F471TC0606060604JX
PARKER ASSY #
Hose type Parker # Cut hose Hose End 1 STD
471TC-4
52
6 X 4 ST
1.30
6 X 4 ST
1.30
55
ENGINE
23
164
134771A
1/4
F471TC0606060604JX
STD
471TC-4
52
6 X 4 ST
1.30
6 X 4 ST
1.30
55
ENGINE
23
165
121675A
1/4
F471TC0639060604JX
STD
471TC-4
32
6 X 4 ST
1.30
6 X 4 90
1.38
35
ENGINE
23
166
121675A
1/4
F471TC0639060604JX
STD
471TC-4
32
6 X 4 ST
1.30
6 X 4 90
1.38
35
ENGINE
23
167
99703A
3/4
F451TC0606121212JX
STD
451TC-12
20
12 X 12 ST
1.73
12 X 12 ST
1.73
23
ENGINE
23
168
129871A
1/4
F471TC0606060604JX
STD
471TC-4
36
6 X 4 ST
1.30
6 X 4 90
1.38
39
ENGINE
23
169
129871A
1/4
F471TC0606060604JX
STD
471TC-4
36
6 X 4 ST
1.30
6 X 4 90
1.38
39
ENGINE
24
170
93621-04
1/2
F471TC0639080808JX
STD
471TC-8
43
8 X 8 ST
1.37
8 X 8 90
1.40
46
AIR COMPRESSOR ASS'Y
24
171
209207
3/8
F471TC0639080606JX
STD
471TC-6
84
6 X 8 ST
1.25
8 X 6 90
1.50
87
AIR COMPRESSOR ASS'Y
24
172
130211
1/2
F471TC0606080808JX
STD
471TC-6
139
8 X 8 ST
1.37
8 X 8 ST
1.37
142
AIR COMPRESSOR ASS'Y
24
173
132115
3/8
F471TC0639060806JX
STD
471TC-6
141
6 X 6 ST
1.26
8 X 6 90
1.50
144
AIR COMPRESSOR ASS'Y
24
174
93402-04
3/8
F471TC0639080806JX
STD
471TC-6
11
8 X 6 ST
1.46
8 X 6 90
1.50
14
AIR COMPRESSOR ASS'Y
24
175
96950
3/8
F471TC0606080806JX
STD
471TC-6
8
8 X 6 ST
1.46
8 X 6 ST
1.46
11
AIR COMPRESSOR ASS'Y
24
176
209212
1/2
F471TC0639080808JX
STD
471TC-8
141
8 X 8 ST
1.37
8 X 8 90
1.40
144
AIR COMPRESSOR ASS'Y
24
177
209214
1/4
F471TC0639040404JX
STD
471TC-4
141
4 X 4 ST
1.19
4 X 4 90
1.19
143
AIR COMPRESSOR ASS'Y
25
178
97280-04S
3/8
F471TC0639060606JX
STD
471TC-6
117
6 X 6 ST
1.26
6 X 6 ST
1.26
120
EAR MOLDBOARD PRESSU
25
179
96865S
3/8
F471TC0639060606JX
STD
471TC-6
16
6 X 6 ST
1.26
6 X 6 ST
1.26
19
BELT TENSION PRESSURE
