ORDER NO.
CRT4727 DEH-14UB/XNUC
CD RDS RECEIVER
DEH-14UB
/XNUC
DEH-1450UB DEH-1450UB DEH-1450UBG DEH-1490UB
/XNES /XNES1 /XNES
/XNID
This service manual should be used together with the following manual(s): Model No. CX-3287
Order No. CRT4759
Mech. Module S11.6STD
Remarks CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2011
K-ZZZ JUNE 2011 Printed in Japan
1
2
3
4
SAFETY INFORMATION CAUTION
A
This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING
This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65
B
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used:
- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. C
Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.
CAUTION This product is a class 1 laser product classified under the Safety of laser products, IEC 60825-1:2007, and contains a class 1M laser module. To ensure continued safety, do not remove any covers or attempt to gain access to the inside of the product. Refer all servicing to qualified personnel.
D
CAUTION—CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN, DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.
E
WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. F
2
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
A
Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited)
Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.
B
CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions.
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
3
1
2
3
4
CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5 1.2 NOTES ON SOLDERING .......................................................................................................................... 6 2. SPECIFICATIONS ............................................................................................................................................ 7 2.1 SPECIFICATIONS ..................................................................................................................................... 7 2.2 DISC/CONTENT FORMAT ........................................................................................................................ 8 3. BASIC ITEMS FOR SERVICE.......................................................................................................................... 9 3.1 CHECK POINTS AFTER SERVICING....................................................................................................... 9 3.2 PCB LOCATIONS .................................................................................................................................... 10 3.3 JIGS LIST .................................................................................................................................................11 3.4 CLEANING................................................................................................................................................11 4. BLOCK DIAGRAM.......................................................................................................................................... 12 5. DIAGNOSIS.................................................................................................................................................... 14 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 14 5.2 ERROR CODE LIST ................................................................................................................................ 15 5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 17 6. SERVICE MODE ............................................................................................................................................ 18 6.1 DISPLAY TEST MODE ............................................................................................................................ 18 6.2 CD TEST MODE ...................................................................................................................................... 19 7. DISASSEMBLY .............................................................................................................................................. 20 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 26 8.1 CD ADJUSTMENT................................................................................................................................... 26 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 27 8.3 PCL OUTPUT CONFIRMATION.............................................................................................................. 29 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 30 9.1 PACKING ................................................................................................................................................. 30 9.2 EXTERIOR............................................................................................................................................... 32 9.3 CD MECHANISM MODULE..................................................................................................................... 34 10. SCHEMATIC DIAGRAM............................................................................................................................... 36 10.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 36 10.2 KEYBOARD UNIT.................................................................................................................................. 42 10.3 CD CORE UNIT (S11.6STD) ................................................................................................................. 44 10.4 WAVEFORMS ........................................................................................................................................ 46 11. PCB CONNECTION DIAGRAM.................................................................................................................... 48 11.1 TUNER AMP UNIT................................................................................................................................. 48 11.2 KEYBOARD UNIT .................................................................................................................................. 52 11.3 CD CORE UNIT (S11.6STD).................................................................................................................. 54 12. ELECTRICAL PARTS LIST .......................................................................................................................... 56
A
B
C
D
E
F
4
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS
A
1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. 5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 6. area and a heat sink becomes hot areas. Be careful not to burn yourself.
B
C
D
7. Software update The software of this product is stored in IC671. Please replace IC671 when making the version upgrade of software.
E
F
DEH-14UB/XNUC 5
6
7
8
5
1
2
3
4
A
8. Capacitor Bond Lock (UC) Acetate Tape (GYH1026) 1 Please stick acetate tape along white line. 2 Please confirm line hiding with acetate tape. * length of tape : 24 ± 4 mm 1 2
B
9. Capacitor Bond Lock (ID, ES, ES1) Silicon Glue (GEM1017) Place the capacitor in the center of the silk print, and confirm it does not touch to the connector. Then, apply silicon glue.
C
NG
OK
1.2 NOTES ON SOLDERING D
For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). E
The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.
F
6
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
2. SPECIFICATIONS 2.1 SPECIFICATIONS
A
DEH-14UB/XNUC General Power source .................. 14.4 V DC (10.8 V to 15.1 V allowable) Grounding system ........... Negative type Maximum current consumption ................................ 10.0 A Backup current .............. 4.0 mA or less Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm (7 in. × 2 in. × 6-1/2 in.) Nose .................. 188 mm × 58 mm × 16 mm (7-3/8 in.× 2-1/4 in.× 5/8 in.) D Chassis .............. 178 mm × 50 mm × 165 mm (7 in.× 2 in.× 6-1/2 in.) Nose .................. 170 mm × 46 mm × 16 mm (6-3/4 in.× 1-3/4 in.× 5/8 in.) Weight ............................. 1.1 kg (2.4 lbs)
Usable discs ...................Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IHF-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)
USB USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)
B
FM tuner
Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ...................... –18 dB/oct Gain ......................... +6 dB to –24 dB Phase ..................... Normal/Reverse
CD player
Frequency range ............. 87.9 MHz to 107.9 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IHF-A network)
C
AM tuner Frequency range .............. 530 kHz to 1 710 kHz Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IHF-A network)
CEA2006 Specifications
D
Power output ................... 14 W RMS × 4 Channels (4 Ω and < = 1 % THD+N) S/N ratio .......................... 91 dBA (reference: 1 W into 4 Ω)
Note Specifications and the design are subject to modifications without notice.
System .......................... Compact disc audio system
E
Securing the front panel The front panel can be secured with the supplied screw.
F
Screw (BPZ20P060FTC) (UC) (XXX7020) (ID, ES)
DEH-14UB/XNUC 5
6
7
8
7
1
A
2
3
4
DEH-1450UB/XNES, DEH-1450UBG/XNES, DEH-1490UB/XNID WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)
General Rated power source .........14.4 V DC (allowable voltage range: 12.0 V to 14.4 V DC) Grounding system ............Negative type Maximum current consumption ................................ 10.0 A Backup current .............. 4.0 mA or less
USB USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed)
Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 188 mm × 58 mm × 16 mm D Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 170 mm × 46 mm × 16 mm Weight ............................. 1.1 kg
B
FM tuner Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ...................... –18 dB/oct Gain ......................... +6 dB to –24 dB Phase ..................... Normal/Reverse
C
D
CD player System .......................... Compact disc audio system Usable discs .................. Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3
Frequency range ............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network)
MW tuner Frequency range .............. 531 kHz to 1 602 kHz (9 kHz) 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)
SW tuner Frequency range .............. 2 300 kHz to 7 735 kHz (2 300 kHz to 2 495 kHz, 2 940 kHz to 4 215 kHz, 4 540 kHz to 5 175 kHz, 5 820 kHz to 6 455 kHz, 7 100 kHz to 7 735 kHz) 9 500 kHz to 21 975 kHz (9 500 kHz to 10 135 kHz, 11 580 kHz to 12 215 kHz, 13 570 kHz to 13 870 kHz, 15 100 kHz to 15 735 kHz, 17 500 kHz to 17 985 kHz, 18 015 kHz to 18 135 kHz, 21 340 kHz to 21 975 kHz) Usable sensitivity ............. 28 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)
Note Specifications and the design are subject to modifications without notice.
E
2.2 DISC/CONTENT FORMAT
F
8
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING A
To keep the product quality after servicing, please confirm following check points. No. 1
4
Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. Play back a CD. (Track search) Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Check whether no disc is inside the product.
5
Appearance check
2 CD 3 FM/AM tuner
Item to be confirmed The customer complain must not be reappeared. Display, audio and operations must be normal. No malfunction on display, audio and operation. Display, audio and operations must be normal.
B
The media used for the operating check must be ejected. No scratches or dirt on its appearance after receiving it for service.
See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
9
1
2
3
4
3.2 PCB LOCATIONS A
B
C CD Core Unit (S11.6STD)
C
A Tuner Amp Unit B Keyboard Unit D
A:DEH-14UB/XNUC B:DEH-1450UB/XNES C:DEH-1450UB/XNES1 D:DEH-1450UBG/XNES E:DEH-1490UB/XNID E
Unit Number
: QWM3319(A) : QWM3320(B,C,D,E)
Unit Name
: Tuner Amp Unit
Unit Number
: (A,B,C,E) : (D)
Unit Name
: Keyboard Unit
Unit Number
: CWX4023
Unit Name
: CD Core Unit (S11.6STD)
F
10
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
3.3 JIGS LIST - Jigs List Name 16P FFC Test Disc L.P.F. Acetate Tape Silicon Glue
A
Jig No. GGD1310 TCD-782 GYH1026 GEM1017
Remarks Tuner Amp Unit - CD Core Unit Checking the grating Checking the grating (Two pieces) Capacitor Bond Lock Capacitor Bond Lock
Grease No. GEM1024 GEM1038 GEM1043 GEM1045
Remarks CD Mechanism Module CD Mechanism Module CD Mechanism Module CD Mechanism Module
- Grease List Name Grease Grease Grease Grease
B
C
3.4 CLEANING
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned CD pickup lenses
Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008
D
E
F
DEH-14UB/XNUC 5
6
7
8
11
1
2
3
4
4. BLOCK DIAGRAM A
A
TUNER AMP UNIT
JA401 5
1
ANTENNA
16
2,3
18
FMMIXIN1
57
DACOUTL
PINDIN LNAIN
RF FRONT END IC IC401 TDA7706
I2CSCL
I2CSDA RSTN
34
112
33
111
31
107
DAC IC231 PCM1753DBQ
TUNSCL TUNSDA TUNPCE1 DACCS DACSCK DACLRCK DACDATA
B
DACBDATA DACBSCK AUDIO_XOUT
124
15
91
1
89
3
88
2
87
13
85
14
84
16
ML BCK LRCK VOUTL
DATA
7
MD MC SCK
JA892 69
2 KEYAD
WIRED REMOTE
129
3 KEYD
RESET
KEYAD KEYD
RES
1 GND
38
IC651 S-80827CNMC-B8M
1
B C D E ILMPW Q871 B.UP
SYSTEM MICRO COMPUTER IC601 (1/2) R5S7266ZD144FP ILMPW
FLASH ROM IC671 A :PEB035A8 B C D E :PEB034A8
C
ILM+B Q872
132 Q873
DIMMER
4
REGULATOR IC IC912 BA49182-V12
A :DEH-14UB/XNUC B :DEH-1450UB/XNES C :DEH-1450UB/XNES1 D :DEH-1450UBG/XNES E :DEH-1490UB/XNID
6
SW5V
SW5V
9
SWVDD
7
VDD3.3V
VDD
8
VDD1.2V
BSENS SYSPW SW5VCNT
11
128
1
141
2
7
SWVDD BSENS SYSPW
3
VDD12
5
SYS+B
VDDCONT
SWVDD
+B
SYS+B
+BUP
4
B.UP
10
SY C
D
C
PICKUP UNIT (P10.6)(SERVICE)
USB5V REGULATOR
VCC LD
LD-
MD
12
12
15
15
MD 5
V+3A
8
RF AMP, CD DECODER DIGITAL SERVO/DATA • PROCESSOR CPU
VDD
GND
1
Q101
2
5 PD
IC510 BD2232G-G VIN
LD
8
8
93
REFO
FOM
E
FOP
4
3 2
3 2
FOM
54 USB5V
5
EN
VDD
TOM 4
4 TOM
TD,FD
14 LD+
SD,MD
14
8 7
9
VOUT
OC
18
4
20
VDD
9
SOP
VDD
USBFLG
VBUS
VDD3.3V 67
VD
VD
TKO-
2
2
1
1
VD
VDSENS
Q751 B.UP Q752
FCO+ FCO-
M
SOM
3 SPO+ 2 SPO-
LOADING/CARRIAGE MOTOR
M
LCOP LCOM
5 4
14 23
40
22
41
MUTE 21
39
CNT LDIN
SLLDO+ SLLDO-
38 35 S903 DSCSNS
9
USBCTL
MECHA VD
TKO+
SPINDLE MOTOR
LOEJ CONT
DSCSNS
RESET
RESET
29
8
CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT)
8
RESET
120
CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT)
HOME
S901 HOME
2
VDCONT
CLCONT
DEH-14UB/XNUC 1
INV
3
CN701
IC301 BD8223EFV
1 TOP
SYNC
FB
54
CN701
ACTUATOR/ MOTOR DRIVER
FOP
10
12
PUEN
19
SW
VDD
IC201 PE5791A
TOP 1
LD+
F
REFOUT
VIN
AC,BD,E,F
HOLOGRAM UNIT
FOCUS ACT.
2 3
V+3A
PVIN
EN/ 5 SYNC 1
Q102 PD
REFO VREF
TRACKING ACT.
1
B.UP
CN101
R5S
IC501 BD9008F
CD CORE UNIT(S11.6 STD)
3
4
CDRST
5
6
7
8
A
JA251 PL
3
RCA OUT
Q251 1
TUNL
2
CDL
1
AUXL
4
6
POUT_L
IN2_L
P251
ELECTRONIC VOLUME/ SOURCE SELECTOR IC201 PML022A
IN1_L
B
JA901 IN4+_L
7
FRONT_L
11
FL+ FLIn FL-
VST VDT VCK
26
15
27
13
30
14
18
B.UP
STB
8
REAR_L
12
RLIn
DATA CLK
MUTE Q351 (1/2)
22
RL+
AMP IC301 PA2030A
MUTE
RL-
B.REM
9
FL+
7
FL-
5
RL+
3
RL-
BREM
25
1 3 5 7
14
POWER CONNECTOR Q351 (2/2) MUTE
21
C
ASENS Q931
ASENS 128 141 7
143
ACC
13
SWVDD BSENS SYSPW
B
B.UP
SYSTEM MICRO COMPUTER IC601 (2/2) R5S7266ZD144FP
01 008F
KEYBOARD UNIT JA1921
CN801
SSENS
AUXL 19 SOURCE 18
142
FRONT_AUX
AUXGND 1 AUXR 3 AUXL 2
CN1821 AUXL 19 SOURCE 18
D
SOURCE 4 S1826
SRC
ROTARY COMMANDER EN/ SYNC
5
19
S1842
SYNC ROT0 ROT1
131
ROT0
130
ROT1
6
6
4
4
ROT0
2
ROT1
1
S1827 5
KDT2
4
KST1
3
18 20
54
KDT0
USBCTL
KDT1
USBFLG
KDT2 KDT3
VBUS KYDT
KYDT
29
8
8
KYDT
20
KST0 KYDT
IC801 TC7SET08FUS1 DPDT 67
28
2
4
DPDT
10
10
20
20
DPDT
18
VDSENS DSENS
140
DSENS
DPDT
KST1
LCD DRIVER/ KEY CONTROLLER IC1801 PD6581A
KST2 KST3 KST4
15 16 25 26 14
KEY MATRIX
13 12 11 28
E LCD V1801
DSENS
.UP
REMOTE CONTROL SENSOR REM 14
VDCONT
5
ILM+B
120
1
17
5
ILM+B
CDRST
SWVDD
3
3
11
11
IC1802 GP1UXC14RK
SWVDD
D1851,D1852,D1853,D1854, D1855,D1856,D1857,D1858, D1859,D1860,D1861,D1862, D1863,D1864,D1865
D1866
CN1911 USB5V DM DP
52
DM
53
DP
13 15
13 15
USB5V
USB5V DM
DM
DP
DP
DEH-14UB/XNUC 5
6
7
F
2 3
USB
4
8
13
1
2
3
4
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART A
Power ON
Vcc = 1.2 V Pin 5 PVcc = 3.3 V Pin 1
BSENS
B
Pin 141 BSENS = L
ASENS Pin 143 ASENS = L C
DSENS Pin 140 DSENS = L
Starts communication with Grille microcomputer.
D
300 ms
SWVDD <- H Pin 128
300 ms In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 300 msec, the oscillator may be defective.
Source keys operative E
Source ON
SYSPW <- H Pin 7
F
Completes power-on operation. (After that, proceed to each source operation)
14
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
5.2 ERROR CODE LIST ERROR CODES A
If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from customers and facilitate failure analysis and repair work in servicing.
(1) DISPLAY METHOD If “0xFD” error mode is displayed in CD MODE (CD MODE area for display), an error code will be displayed in the MIN (minute display) and SEC (second display) areas. The same code is displayed in the MIN and SEC areas. The TNO area is blank (#0FFH), as it conventionally was. • Display example of the head unit Depending on the display capability of LCDs, the display format varies, as shown below. XX denotes an error number. Note: In a case of an OEM product, the error display format is subject to the specifications used by the equipment manufacturer. 8-digit display
6-digit display
ERROR-xx
ERR-xx
B
4-digit display E-xx
(2) LIST OF CD ERROR CODES (Error Mode: 0xFD) Code Classification Error code to be displayed
Details and possible causes
07
Servo
TOC reading NG
TOC information cannot be read. --> The partial disk or TOC content is illegal.
10
Servo
Carriage Home NG
11
Servo
Focus NG
The pickup cannot move toward the inner track. The CRG cannot move from the inner track. --> Defective HOME SW; Failure in CRG movement. Focusing not available --> Disc placed upside-down; Stains on the disc; excessive vibration.
12
Servo
Spindle Lock NG Subcode NG RF-amp NG
Spindle not locked. Subcode not readable. Proper RF AMP gain not obtained. --> Defective spindle; Scratches or stains on the disc; excessive vibration. --> A CD-R/RW disc that does not contain data loaded, or in a rare case, disc placed upside-down. --> RF signal error.
15
Servo
RF NG
The digital signal from the disc cannot be detected. --> A CD-R/RW disc that does not contain data loaded.
17
Servo
Setup NG
The laser output cannot be adjusted. Focus can be easily lost. --> Scratches or stains on the disc; excessive vibration.
30
Servo
Search Time Out
Failed to reach a target address. And, the search became a timeout. --> Carriage/Tracking error; Scratches on the disc; Stains on the disc
50
Mechanism
Load NG Eject NG
Disc loading/ejection not completed --> A foreign object inserted in the mechanism; Disc jammed.
51
Mechanism
Failure in retried turning for ejection
Disc could not be ejected even after disc turning had been retried. --> A foreign object inserted in the mechanism; Disc jammed.
C
D
E
NOTES • Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is generated. • If the TOC cannot be read, It stops because of error 07. • If you design a new head unit, be sure to use one of the display formats indicated in “Display example of the head unit.” • The 2 high-order digits of an error code denote the main classification, shown below. code classification 0x 1x Servo-related errors 3x 5x Mechanism-related errors F
• How to restore from each error is shown below. Servo-related errors(0X, 1X, 3X) : Servo-related errors CD Off, Eject, ACC Off, Back-up Off, Communication reset, Reset Load NG/Eject NG(50) : Reload, Eject, ACC Off, Back-up Off, Communication reset, Reset Failure in retried turning for ejection : CD On, Eject, ACC Off, Back-up Off, Communication reset, Reset
DEH-14UB/XNUC 5
6
7
8
15
1
2
3
4
USB storage device A
B
Message
Cause
Action
Message
Cause
Action
NO DEVICE
When plug and play is off, no USB storage device is connected.
Turn the plug and play on. Connect a compatible USB storage device.
SKIPPED
The connected USB storage device contains files embedded with Windows Media™ DRM 9/ 10.
Play an audio file not embedded with Windows Media DRM 9/10.
PROTECT
All the files in the USB storage device are embedded with Windows Media DRM 9/10.
Transfer audio files not embedded with Windows Media DRM 9/10 to the USB storage device and connect.
N/A USB
The USB device connected to is not supported by this unit.
Connect a USB Mass Storage Class compliant device. Disconnect your device and replace it with a compatible USB storage device.
CHECK USB The USB connector or USB cable has shortcircuited.
Check that the USB connector or USB cable is not caught in something or damaged.
The connected USB storage device consumes more than 500 mA (maximum allowable current).
Disconnect the USB storage device and do not use it. Turn the ignition switch to OFF, then to ACC or ON and then connect only compliant USB storage devices.
Message
Cause
Action
ERROR-19
Communication Perform one of failed. the following operations. –Turn the ignition switch OFF and back ON. –Disconnect the USB storage device. –Change to a different source. Then, return to the USB source.
ERROR-23
USB storage de- USB storage device was not for- vice should be formatted with matted with FAT12, FAT16 or FAT12, FAT16 or FAT32. FAT32.
FRMT READ Sometimes there is a delay between the start of playback and when you start to hear any sound.
Wait until the message disappears and you hear sound.
NO AUDIO
Transfer the audio files to the USB storage device and connect.
There are no songs.
The connected USB storage device has security enabled.
Follow the USB storage device instructions to disable the security.
C
D
E
F
16
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
5.3 CONNECTOR FUNCTION DESCRIPTION A
B
REAR OUTPUT
ANTENNA 15 13 11 9 7 5 3 1 16 14 12 10 8 6 4 2
1 2 3 4 5 6 7 8
9 10 11 12 13 14 15 16
FL+ FR+ FLFRRL+ RR+ RLRR-
WIRED REMOTE CONTROL (Except DEH-14UB/XNUC)
NC NC NC NC ACC B.REM B.UP GND
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
17
1
2
3
4
6. SERVICE MODE
6.1 DISPLAY TEST MODE A
The information such as the system microcomputer version is checked.
[How to enter Test mode] Press “ 1 ” and “ 3 ” keys simultaneously to start resetting.
[Operation key] Operation key
Processing
1+3
Enter display test mode Switch to next test mode
Remarks
B
[Test items] Start display test mode. (Press “ 1 ” + “ 3 ” keys simultaneously to start resetting.)
Key Illumination
Icon
Off
All off
On (an initial value)
All off
* Initial condition
System Version information is displayed. C
S
$ $ $ $
# # #
14SEG
$ PD number
For PEA010A, "010A" is displayed
# System microcomputer version
For Ver.7.01, "701" is displayed
On (an initial value or setting value of default menu)
All off
D
Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously. Display is normally updated Product operation is performed as usual, in appearance. On (an initial value or setting value of default Switching to next display menu) by pressing “ 1 ” + “ 3 ” keys simultaneously.
E
On (lighting condition of normal times)
Display update is stopped The screen gets still when entering this item. Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously.
On (an initial value or setting value of default menu)
On (state when entering test mode)
F
18
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
6.2 CD TEST MODE A
- Flow Chart [4]+[6]->BUP+ACC ON Test Mode IN
[Key]
[CD] or [SOURCE] Source ON
TRK
Contents
MIN
Display
[BAND]
[2] RF AMP *1 Gain switching TRK MIN SEC
Power On (T.Offset is adjusted) TRK MIN SEC
00
[BAND]
MIN
SEC
[BAND]
91
91
SEC
TRK
MIN
*2 TRK
MIN
SEC
0X
0X
0X
TRK
MIN
SEC
[>]
00 00 00 or 99 99 99
[3]
??
??
??
[3]
F,T,RF AGC*5 F.Bias display switching TRK MIN SEC
??
??
??
[<] CRG -
*6 00 00 00 or 99 99 99
*6 00 00 00 or 99 99 99
Self-adjusting switching *3 TRK MIN SEC
??
[<] CRG -
8X 8X 8X or 9X 9X 9X
8X 8X 8X or 9X 9X 9X
[>]
[<] CRG/TR Jump -
*4
*4
?tr ?min ?sec
?tr ?min ?sec
MIN
SEC
TRK
??
T.Balance adjustment / T.BAL coefficient display TRK MIN SEC
??
??
??
[2]
CRG/TR Jump + TRK
??
[2]
CRG +
F,T AGC / F.Bias RF AGC TRK MIN SEC
B
[2]
CRG +
[>]
RF AGC / RF AGC coefficient display TRK MIN SEC
SEC
[1]
Power Off
GG
Tracking Servo Close
?tr ?min ?sec
[BAND]
GG
[1]
Focus Mode switching
[1] T.Close & AGC Applicable servomechanism
Power Off MIN
GG
[6]
Focus Close S curve check TRK MIN SEC
91
TRK
00
[3]
Power Off TRK
00
MIN
Tracking Open
SEC
?tr ?min ?sec
8X 8X 8X or 9X 9X 9X
C
*6 [BAND]
[2]
Power Off TRK
*1)
MIN
Tracking Open
t
TYP TRK
8X 8X 8X or 9X 9X 9X
SEC
MIN
SEC
*2) Focus Close t TRK 00MIN00SEC00 (TRK99MIN99SEC99)
+ 6 dB t TRK 06MIN06SEC06
S. Curve t 01MIN01SEC01
TRK
+ 12 dB TRK 12MIN12SEC12
F EQ measurement setting TRK 02MIN02SEC02
[Key] [BAND] [>] [<] [1]
*3) F.Offset Display t RF.Offset t T.Offset Display t Switch to the order of the original display
[2] [3] [6]
*4) 100TR Jump
Operation Test Mode Power On/Off CRG + / TR Jump + (Direction of the external surface) CRG - / TR Jump (Direction of the internal surface) T. CLS & AGC & Applicable servomechanism / AGC,AGC display setting RF Gain switching / Offset adjustment display / T.Balance adjustment / T. Open F. Close,S. Curve / Rough Servo and RF AGC / F,T,RF AGC F. Mode switching / Tracking Close
D
E
*5) TRK/MIN/SEC t F.AGC t T.AGC Gain t F.Bias t RF AGC
*6) CRG motor voltage = 2 [V]
After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete. When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks to Wall, causing the actuator to be damaged). In the case of 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released. When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)
DEH-14UB/XNUC 5
6
7
8
F
19
1
2
3
4
7. DISASSEMBLY A
While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. - Removing the Panel Assy (Fig.1)
1 1
Remove the two hooks.
2
Remove the two hooks and then remove the Panel Assy.
1
2
2
Fig.1 B
Panel Assy - Removing the CD Mechanism Module (Fig.2, 3, 4)
1
Remove the screw.
2
Remove the two screws.
1
2
2 Fig.2
C
Heat sink side
The CD Mechanism Module side is made a bottom.
3
3 Fig.3
3
Push the area and remove the two hooks.
4
Slide the Tuner Amp Assy in the direction of the arrow and then remove the hooks of upper and lower.
Tuner Amp Assy
D
CD Mechanism Module
Lift off the Tuner Amp Assy from the Heat sink side.
5
E
The Tuner Amp Assy is fixed into the ditch.
5
6
Disconnect the FFC and then remove the CD Mechanism Module.
6 5
CD Mechanism Module
Fig.4
F
20
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
A
- Removing the Tuner Amp Unit (Fig.5)
1
1
Remove the two screws.
2
Remove the two screws.
3
Straighten the tabs at two locations indicated and then remove the Tuner Amp Unit.
3
1
2
B
3
2 Fig.5
Tuner Amp Unit C
- Attention of removing (Fig.6)
Don't remove this screws excluding the dismantlement of the CD Mechanism Module.
D
Fig.6
E
F
DEH-14UB/XNUC 5
6
7
8
21
1
2
3
4
- Disassembling the Panel Part (Fig.7, 8) A
1. Remove the arm while bending the rib of the panel upward.
B
Fig.7
2. Press the upside hook and the bottom side hook of the button at the same time, and pull out the button.
C
Fig.8
- Assembling the Panel Part (Fig.9, 10, 11) 1. Attach the button from the front side of the panel. D
E
Fig.9 2. Attach the spring to the arm as shown in the figure.
The bended tip of the spring is set to this side.
F
Hitch the spring to the groove. 22
Fig.10
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
3. Fit the spring in the groove at the position shown in the figure. A
4. Fit the boss on the lower side of the arm in the lower hole of the panel, and then warp the rib on the panel in the direction shown in the figure and fit the boss of the arm in the panel.
B
Fig.11
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
23
1
2
3
4
How to carry the mecha unit A
1. Hold the designated points (shown with dashed lines) of the upper chassis and the front/rear bracket. 2. Be careful not to hold the solid line portions or the CRG mecha part or insert foreign substances, to prevent distortion. 3. When holding the sides of the upper chassis, do not apply excessive force to prevent distortion. (Approx. 8N or less) Handling OK
B
Handling NG
C
D
E
F
24
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
How to remove the PU unit A
1. Create an empty-clamp state according to “How to create empty clamp state (motor drive)”. 2. Hook the feeding screw biasing spring to a tentative hooking portion (Fig 2b). Be careful not to get injured by the spring edge. 3. Hold the PU at the position A as shown in Fig 1. Slide the PU as far as possible toward the holder in the feeding screw so that a joint on the outer end of the feeding screw is loosened. 4. As shown in Fig 3, move the rear end of the feeding screw laterally and then upward, to remove it from the outer holder. 5. Lift the PU unit to disengage it from Part B of the chassis (Fig 4), and remove the PU unit. (Cautions) When re-installing the PU, be sure to first nip the chassis and the PU unit (Fig 4) at the position B. Also, make sure to fully hook the feeding screw biasing spring (Fig 2a). Please follow the service manual for adjustment of the PU unit after the re-installation. Slide toward inner circumference
B
Fig 2a
Fig 2b
Fig 1
Fully-hooked state
B
Fig 3
Tentatively-hooked state
C
The spring is below a resin flange and is built inside the sheet metal bending.
A
Fig 4
D
Outer holder Rear end of feeding screw
[Incorrect built-in state] The chassis is not nipped between the PU case and the PU rack.
Normal built-in state
E
F
DEH-14UB/XNUC 5
6
7
8
25
1
2
3
4
8. EACH SETTING AND ADJUSTMENT 8.1 CD ADJUSTMENT A
1) Cautions on adjustments In this product the single voltage (3.3 V) is used for the regulator. The reference voltage is the REFO1 (1.65 V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo’s misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately.
B
Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on.
C
2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. [4] + [6] -> BUP + ACC ON To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the (→) key or (←) key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0 dB, and the auto-adjustment values are reset to the default settings.
In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFAGC and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it.
D
E
F
26
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT A
Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed. B
Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Disc Mode
Oscilloscope, Two L.P.F. E, F, REFO1 TCD-782 TEST MODE CD CORE UNIT C
L.P.F.
F E
E
Xch
Oscilloscope
390 pF
VREF
REFO1
Ych
100 kohm
F
100 kohm
VREF
390 pF
D
L.P.F.
Checking Procedure 1. In test mode, load the disc and switch the 3 V regulator on. 2. Using the right and left buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble".
DEH-14UB/XNUC 5
6
7
8
E
F
27
1
A
2
Grating waveform
3
4
Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC
0 degrees
30 degrees
45 degrees
60 degrees
75 degrees
90 degrees
B
C
D
E
F
28
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
8.3 PCL OUTPUT CONFIRMATION A
- PCL output With the TESTIN (22 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started. Check that square wave of 600.0 kHz is output from PCL (8 Pin) of IC601. If clock signal is out of this range, this resonator (X602) must be changed for a new one.
B
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
29
1
2
3
4
9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
A
"
9.1 PACKING
B
UC
C
UC
UC UC
D
E
F
30
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
PACKING SECTION PARTS LIST Mark No.
*
* *
Description
DEH-14UB/ XNUC
DEH-1450UB/ DEH-1450UB/ DEH-1450UBG/ DEH-1490UB/ XNES XNES1 XNES XNID
1 2 3 4 5
Polyethylene Bag Protector Protector Cord Assy Accessory Assy
CEG1173 CHP4103 CHP4104 QDP3013 QEA3008
QEG3001 QHP3016 QHP3016 QDP3013 QEA3009
QEG3001 QHP3016 QHP3016 QDP3013 QEA3009
QEG3001 QHP3016 QHP3016 QDP3013 QEA3009
QEG3001 QHP3016 QHP3016 QDP3013 QEA3009
6 7 8 9 10
Screw Polyethylene Bag Screw Handle Screw
BPZ20P060FTC CEG1160 CRZ50P090FTC QNC3021 TRZ50P080FTC
Not used CEG1160 Not used QNC3021 TRZ50P080FTC
Not used CEG1160 Not used QNC3021 TRZ50P080FTC
Not used CEG1160 Not used QNC3021 TRZ50P080FTC
Not used CEG1160 Not used QNC3021 TRZ50P080FTC
11 12 13-1 13-2 13-3
Unit Box Contain Box Owner's Manual Warranty Card Service Network
QHG3165 QHL3165 QRD3102 QRY3001 Not used
QHG3160 QHL3160 QRD3103 Not used Not used
QHG3164 QHL3164 QRD3103 CRY1250 CRY1251
QHG3162 QHL3162 QRD3103 Not used Not used
QHG3166 QHL3166 QRB3198 CRY1304 CRY1305
14 15
Card Type RC Unit QXE1047 Case Assy Not used
QXE1047 QXA3129
QXE1047 QXA3129
QXE1047 QXA3129
QXE1047 QXA3129
A
B
Owner's Manual,Installation Manual Part No.
Language C
QRD3102
English, French, Spanish(Espanol)
QRD3103
English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic, Persian
QRB3198
English
D
E
F
DEH-14UB/XNUC 5
6
7
8
31
1
2
3
4
9.2 EXTERIOR A
B
B
A
C
D
A
E
A DEH-1450UB/XNES DEH-1450UB/XNES1 DEH-1450UBG/XNES DEH-1490UB/XNID
F
32
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
(1) EXTERIOR SECTION PARTS LIST Mark No.
*
>
Description
Mark No.
Part No.
Description
Part No.
25
Screw
BPZ20P100FTC
BSZ26P080FTC
26
Spring
CBH2210
1
Screw
ASZ26P050FTC
2
Screw
BSZ26P060FTC
3
Screw
4
Screw
BSZ26P120FTC
27
Knob Unit
CXE3692
5
Seal
See Contrast table (2)
28
Spring
YBL5010
29
Button(EJECT)
QAC3066
6
Spring
QBH3001
30
Button(LEFT)
QAC3068
7
Cover
QNM3029
8
Panel
QNS3126
31
Button(RIGHT)
QAC3069
9
Arm
QNV3025
32
Button(1-6, -)
QAC3070
10
Button
QNV3026
33
Button(DETACH)
QAC3071
34
Button(LIST, SRC, EQ, RETURN, BAND) QAC3072
35
Cover
A
QNS3226
11
CD Mechanism Module(S11.6) CXK5804
12
Cable
13
Cord Assy
QDP3013
36
Lighting Conductor
QNV3038
14
Case
QNB3002
37
Contact Rubber
QNV3041
15
Holder
QNC3020
38
Segment LCD(V1801)
CAW2018
39
Holder
QNC3031
40
Lighting Conductor
QNV3040
B
QDE3021
16
Panel
QNS3127
17
Tuner Amp Unit
See Contrast table (2)
18
Screw
BPZ26P080FTC
41
Rubber Connector
QNV3045
19
Screw
BSZ26P060FTC
42
Grille Unit
See Contrast table (2)
20
Screw
BSZ26P120FTC
43
Door
QAT3004
44
Card type RC Unit
QXE1047
45
Cover
CNS7068
46
Label
See Contrast table (2)
21
Holder
See Contrast table (2)
22
Heat Sink
QNR3002
23
Fuse(10 A)
YEK5001
24
Detach Grille Assy
See Contrast table (2)
C
(2) CONTRAST TABLE DEH-14UB/XNUC, DEH-1450UB/XNES, DEH-1450UB/XNES1, DEH-1450UBG/XNES and DEH-1490UB/XNID are constructed the same except for the following: Mark No. *
Description
DEH-14UB/ XNUC
DEH-1450UB/ DEH-1450UB/ DEH-1450UBG/ DEH-1490UB/ XNES XNES1 XNES XNID
5 17 21 24 42
Seal Tuner Amp Unit Holder Detach Grille Assy Grille Unit
CAN3984 QWM3319 QNC3034 QXA3489 QXA3439
Not used QWM3320 QNC3032 QXA3490 QXA3440
Not used QWM3320 QNC3032 QXA3490 QXA3440
Not used QWM3320 QNC3032 QXA3492 QXA3442
Not used QWM3320 QNC3032 QXA3493 QXA3443
46
Label
Not used
Not used
Not used
Not used
CNN3533
D
E
F
DEH-14UB/XNUC 5
6
7
8
33
1
2
3
4
9.3 CD MECHANISM MODULE A
A
B
(A) (B)
B
(A)
(B)
C
(A) (A)
B
C
C
(A)
D (A) (A)
D
(A) (B)
(A) (B)
E
A
C
(A)
(A) : GEM1024
F
(A)
34
(B) : GEM1043
DEH-14UB/XNUC 1
2
3
4
5
6
7
8
CD MECHANISM MODULE SECTION PARTS LIST Mark No.
Description
Mark No.
Part No.
Description
Part No.
50
Damper
CNW1198
CBA1835
51
Arm
CNW1726
Washer
CBF1038
52
Motor Unit(M2)(LOAD/CRG)
CXC4026
Spring
CBH3010
53
Screw Unit
CXC8894
54
Arm Assy
CXE5027
55
Washer
CBF1037 CBF1038
1
.....
2
Screw
BSZ20P040FTC
3
Screw(M2 x 4)
4 5 6
Spring
CBH2855
7
Spring
CBH2856
8
Spring
CBH2860
56
Washer
9
Screw
BSZ26P060FTC
57
Arm
CND6242
10
Spring
CBH3011
58
Collar
CNW2444
59
Roller
CNW1196
11
Coil Spring
CBH3095
60
Gear Unit
CXC8893
12
Spring
CBH3014
13
Spring
CBH3015
61
Washer
YE15FTC
14
Spring
CBH3016
62
Chassis Unit
CXE4528
15
Spring
CBH3017
63
Motor Unit(M1)(SPDL)
CXE2273
64
Screw
JFZ20P025FTC
65
Screw
JGZ17P022FTC
16
Spring
CBH3086 CBH3019
17
Spring
18
.....
66
Screw
EBA1028
19
Leaf Spring
CBL1824
67
CD Core Unit (S11.6STD)
CWX4023
20
Pickup Unit(P10.6)(Service)
CXX3556
68
Chassis
CNA3181
A
B
C
21
Bracket
CND4553
22
Arm
CND4555
23
Bracket
CND6127
24
Bracket
CND5710
25
Lever
CND5398
26
Sheet
CNN3678
27
Rack
CNV8342
28
Guide
CNW2240
29
Roller
CNW1172
30
Holder
CNW1195
31
Arm
CNW2241
32
Roller
CNW1175
33
.....
34
Arm
CNW1177
35
Arm
CNW1178
36
Gear
CNW1180
37
Gear
CNW1181
38
.....
39
Gear
CNW1183
40
Rack
CNW1184
41
Gear
CNW1185
42
Gear
CNW1186
43
Gear
CNW1187
44
Gear
CNW2287
45
Clamper
CNW1190
46
Arm
CNW1192
47
Holder
CNW1193
48
Holder
CNW1194
49
Damper
CNW1197
D
E
F
DEH-14UB/XNUC 5
6
7
8
35
1
2
3
4
10. SCHEMATIC DIAGRAM
10.1 TUNER AMP UNIT (GUIDE PAGE) A
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".
ILM+B ROT1
DGND
NM : No Mount
36
GRILLE
16 WAIT
15 PGND
GND
13 LRCK 14 GND
11 DATA 12 BCLK
10
SDA
VDD 9
SKIP
RESET 8
7
PGND WAIT R716
220
LRCK
BCLK
DATA
DGND1
SDA
VDD4
RESET
PCM1753DBQ
14
15
16
13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5
MC
SCK
ML
LRCK
4
IC231
DATA
BCK 1
2
C233
C232 0.01u/16
1000p/50
C239 LRCK
DATA
SCK
SCK
ML
BCK MC
MD
MC
MD
DATA
BCK
LRCK
CDDATAIN
CDLRCKIN
10p/50
8 80
1
79 AUDIO_X2
TDI
78 TCK TMS 77 TDI 76 TDO
TCK
TMS
R618
0.1u/10
AUDIO_X1
VSS7
PVCC6
81
C620
0.1u/10 82
VCC4
83
AUDIO_XOUT
DACBSCK
84
R617
C619
220
NM 85
86 CDSKIP
DACBDATA
87
R616
R614
100
100
R613
R611
90
89
88 DACDATA
DACLRCK
PVCC7
NM
NM
R619
C613
C615
C617
NM
NM
NM C611 100
0.1u/10
0.1u/10
R609
C612
91
93
92 VSS8
VCC5
DACSCK
CADATAIN
C609 94
R634
NM
95 CDLRCKIN
96
TUNPCK 99 RDS_INT 98 TUNPDI 97 NC
TUNPDO
CDSCKIN
PVCC4 CKIO 33 0.1u/10
BTTX
VCK
KYDT/TESTDI
VCK
32
29 KYDT
31
30
DPDT
0.1u/10 C618
C621
28
DPDT/TESTDO
VDT 27
VST
VCC3
26
25
24 0.1u/10
VSS3
PVCC3 23 C616
TESIN
R615 100k
TESTIN
22
MUTE
/USBFLG 20
SYNC 19
21
2.2k NM
VCC2
BTTX
VST
FLG
SYNC
USBCTL
VDCONT
BTRST
TELIN
SYSPW
MUTE
2.2k
R808 2.2k
ROT1
R810 2.2k
SWVD
DGND
ILMG C802
NM USGND
C803 NM
G D GND USBGND ILM GND
DEH-14UB/XNUC 2
CDSKIP
CDWAIT
CDLRCKIN
CDSCKIN
CE C607
0.1u/10 101
102
100 MISO
MOSI
PVCC8
103
VSS9 /SSL ANTPW
R803
ROT0 ILM
GND
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
1
3
150
150
R715
R714 NM
NM
NM R718
R720
R719
NM
CDDATAIN
CD_SDA C605
0.1u/10 104
NM
KYDT
0
4
1
2.2k
R814
5
SWVDD 3 2
ILMGND
NM
R804
C851
ROT0
6
8.2
R811
4.7k
7
DPDT2
R805
NM
R851
8
US5V
3 3
8.2k
9
KYDT
R812
R809
USBGND
RGBDT/USBGND
R806 8.2
ICLR1
C810 220p/50 C811 220p/50
10
CTF1713-A 2 2
44
D810 DZ2S068C
CN1821
11
L801 11
ICLR2 DM
DM 13 12 RGBCK/ILMCLR1
DPDT
100 100
DP
14
USB5V
R817
R801 22k R815
D811 DZ2S068C
B
AUXG
100
22k
0.1u/16
15
AUXR
R802 R816
D807 NM
16
DP
2.2k
SRC
C808
AUXGND
GND
D806 NM
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
A
R807 AUXL
2.2k
D801 DZ2S068C
AUXR
17
R818
C812 1u/16 D802 DZ2S068C
SOURCE
18
D804 DZ2S068C
19
D803 DZ2S068C
20
AUXL
D805 NM
NM
DSENS
RGBST/ILMCLR2
F
105 DIM
1u/16
GND GND GND
DSENS C818
CKS6288
0.1u/16 C961
10k
R813 RGBDT
CN801
10k
C969
R970
220p/50
10k
C809 0.1u/16
1
1k
R968
5
D809 DZ2S068C
GND
R964
6
NM
2
BTR
C967 470p/50
D808
U1OUT
GND
IN+2
7
C801 NM
3
10u C962
U1IN
1k
IN-2
GND
SYS+B L962 NM
8
R972 A GND
NM
OUT2
IN+1
10k
L961
R966
VCC
IN-1
R973
GND
4
OUT1
CCG1192-A
0
5
2
220p/50
NM
4
10k
C970
6
3
10k
C966
7
VCC
R969
47k
MIC1P
R965
R961
MIC1N
8
VDT
VA891
VA892
VA893
C963 R962 8.2k 1u/10
9
BTL
1
47k
10
VSS
LPF
C968 470p/50
R967
SPKR
1u/10
NM
11
DSENS1
BTRST BTRX BTTX
IC961 NJM4558MD
R971
VSS
KEYD KEYAD
except A
R963 8.2k
C964
NM D961
12
C965
SPKL
KEYD2
BT MOD
GND
GND 13
VSS
1k
VR105C5R0AAA
CN961 VKN1189
NRST_CPU
1k
R891
KEYAD2
W.REM&MIC
E
R892
NM
MIC1N
VA894
(W/R)
R691
MIC1PF
6 5 4 3 2 1
(RMIC)
R607
GND
JA891 YKS5035
0.1u/10
C604
USBCTL
GND
C614
1
TELIN1
USBCTL
R508
FLG 10k
BD2232G-G
SKIP
NC
VBUS
4 NM
/OC
1
5 FLG
EN
2
SSENS ASENS
144
3
143
8
BSENS
142
4
141
SSENS
7
BSENS
6
VOUT
GND
DSENS
ASENS R604 47k
VIN
RGBDT
BTTESTMD
VSS2
BTTESTMD 140
VSS12 BTTESTIN
/RDSLK
138 NM BTTESTIN 139
USBCTL
137 R641
18
RGBDT
RGBDT
17
SYNC
ILMCLR1 PVCC11 ILMCLR2
16
SYNC
GND
C513
1u/10
C511
3
0.1u/16
0.1u/16 C891
C892
KEYAD
except A
NM C510
2
CDRST
CDSCKIN 136
R610
R507
135
C610
R506
0.1u/10
R612 47k
5
BD9008F
ILMCLR2
0.1u/10
NM
VDCONT
51k
15
6
ROT0 ILMPW
14
RT
INV EN/SYNC
GND
7
134
KEYD ROT1
0.1u/10
133 C603
IC601 R5S7266ZD144FP
VSS11
PVCC2
ILMCLR1
NC PVCC10
SWVDD
13
CRG03
DACCS
47k C608
GND
1u/10
1
150 132
CDWAIT
R608
SW
C512
GND KEYD
R713 131
ILMPW
IC510
1 3 2
100k
130
ROT0
SYSTEM MICRO
CDSTBY
47k
220p/16
129
ROT1
5
C506
0.015u/16
VIN
FB
KEYD
8
PVIN
127 128
47k
18k
R505
4
0.1u/10
D502
R602
3
D501 RB160L-40
47k C503 6.8k
2
GND
C602
CRG03 D503
10k
R504
1
1u/16
GND
C507
IC501
C509
R601
SWVDD5
USB&USB5V
124
126 10k R603
ipod CP
NM
125
except A NM
NM R503 R502
R605
CDRST CDSRQ
ANTPW
123
CPPWR VSS10
SYSPW 8 PCL 9 TELIN 10 BT RST ROM 11 ROM 12 RAM_MON RAM_MON
122
CDWAIT
PVCC9
PCL 7
CDSTBY
NM
CPRST
USB5V
470 C502
R561
16
L501 CTH1475-A
R501
121
NM C505
R557 4.7k
CDSRQ
NC CPRST
VCC1
119
ML
GND
W.REM
118
120
22p/50
0.1u/10 GND
JA892 CKS4124
117
TUNSDA TUNSCL CP_SDA
6
116 C601 0.1u/10
2 2
CP_SCL
0.1u/10
114
CDRST
CP_SCL
IC551 341S2162
C508
2
R556 2.7k
220
113
CP_SCL
115
CP_SDA
1
4
3
5
D
C552
106
112
RF GND
CP_SDA
VSS1
*
NM
17 NC9 NC10 18 NC11 NC12 19 NC13 20
NC7 8 NC6 NC5 7 NC4 NC3 6
100
110 111
0
VCC6
109
CD_SCL
RSPCK
CD_SDA
CD_SCL
*
TUNPCE1
108
NM
107
NM
NM
R430
NM R414
NM
CD_SDA GND
DIMMER
*
R415
R418
1000p/50
C447
C439
1k
TUNPCE2
L415
NM
R417
CPPW
220u/6.3
9
R672
GND R416
D601 RB551V-30
11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15
10
47k
0.1u/10
2 PVCC1 NC
100
X601 CSS1603-A 1 3 1 3
4
R560
16.934MHz
1
C671 10k
10k R420
R419
R671
SO
2
3
R553 10k
SO
5
100
CDSKIP
CE#
3
47k
7 HOLD# 8 VDD
R562
47k
R551
C551
0.1u/10
R559
CD_SCL
WP#
C606
NM
C430
VSS
DGND
CPPW
R552 10k
4
SI SCK
GND C440 0.1u/10
L671 CTF1786-A
IC671 5 6
M2R6TP_GND
8.2
R428
*
SI SCK
KN601
CPRST
4.7k
CDSTBY
CDSRQ
VDD3.3V
FLASH ROM
L411 NM
GND
B.UP
VDD3.3V
R558
C703
SW5V
NM
C438 NM
C436
C433
*
Q551 LSA1576UB(QRS)
NM
D GND
NM
NM
DGND
L551
NM
C702 L701
NM
NM C706
NM
CTF1786-A
VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT
31
30
L410
L419
CCG1205 C442
46 GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33
R427
RF GND
C452 C434
100k C701
GND
VDCONT
NM C437
C435
0.1u/10
C429
9p/50 C431
C432
49
50
51
52
VCC-REF VDDIO1V2 VDDPLL1V2
VDD_CORE
*
RFGND
R721
NM C705
R421 0
C455
R408
C427
L409
29
28
VDIG
AMMIXIN2
AMMIXIN1
LNADEC2
GNDSLINK
27
25
24
26
R433
LNAIN2
LNAOUT2
23
22
C422 0.1u/10
R406
R431
*
NM NM
L416 NM C441
47 2.2u
1/4W 1/4W DGND R410 R412
RF GND
1
R703
NM
C704
2
L414 NM
8.2
*
DGND R429 NM
48
TEST
NM
*
6
VD 3
8
0.01u/16
L412 L413
32
1u/10
2
*
C454 NM DGND
C423 0.01u/16
1M
R405
C444 L417
NM
C451
C458 1M
*
LNAOUT
LNAIN
0.01u/16
L420
R434 C457
33
L418
LNADEC
GNDLNA
C415
21
L406
0.1u/10
R403
L405
R407
C408
C421
C443
18
GND RFGND
*
3
GND1 X1 CSS1805-A
SCL
4
5
1k
100k VDCONT
AGND
NM
L407 750 KP2311E
0.1u/10
16
20
15
C412 10u CCG1192-A RFGND C445 0.022u/16
17
0.1u/10
C404 C405
NM
C456
A GND
RFGND
L403
X2
C409 0.01u/16
C406
RFGND
CTF1786-A
0.1u/10 C419
C417
R402
4 FMMIXDEC 5 FMMIXIN2 C413 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND C450 9 orRFGND CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN 14 TCAM2 C411 0.01u/16
L402 CTF1786-A
3
C446 RFGND NM
0.01u/16
6p/50
C402
L401 0.15u
C403 0.01u/16
33p/50
D402
220
C401
*L404
1 2
C449 NM
R401 D401
KP2311E
NM
X401
64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 VCC-PLL 59 VCC-ADC_DAC 58 DACOUTR 57 DACOUTL 56 GND-ADC_DAC VREFDEC 55 C426 GND-REF 54 0.1u/10 OSCOUT OSCIN 53 R409 NM
C448
10u 19
RFGND
36.48MHz 4 GND2 1
C420
P401
3
KN401
NM
IMSA-6802-01Y900 R432
1
M2R6TP_GND
R413
CTF1786-A L408
AGND
JA401 YKS5041
TUNGND 2
C
TUNL
C428 9p/50
ANTENNA
TUNR
C418 CCG1192-A
B
5 SCL
VD
100k
R704 4.7k
C424 4700p/25
C234 CCG1192-A 10u C235
R717
47k R702
R712
6
RN4983
CD/USB:+5.22 dBs DGND
R701
R711
NM
R710
1
820
100
5
NM PGND
DAC
R709
2
GND VDSENS
C425 4700p/25
CTF1786-A
Detailed page
NM C708 NM C709
GND
220
4
R754
220
RKZ8.2KG(B2)
3
R753
R708
Q752
7
A-b
C707
R707
NM
VD1
6
A-a
3 /CDSRQ
CDSRQ
Q751 2SD2396(K)
FM(30%) -15dB±2.5: -15.0 dBs AM(30%) -15dB±2.5: -15.0 dBs
CN701
NM C710
7.4V
VD2
CDSTBY
MECHA VD
2
CD
CN701 VKN1192
1
B~E CCG1205 0.1u NM NM 330 360 390 NM NM 0 NM NM 0.1u PEB034A8
4 /CDSTBY
C
A NM NM 1u 3p 1.5k 470 680 0 0 NM 0.47u 0.1u NM PEB035A8
10u
C432 C433 C457 C458 R403 R406 R408 R431 R433 R434 C430 C431 C439 IC671
C753
15p 22p 2p 0.01u 8p NM NM 0.39uH NM 1.5uH 2.2uH 0.39uH 0.27uH NM
C754 0.1u/10 D751
B~E
47k
Guide page
A NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM 68n
C751 CCG1192-A
C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L417 L418 L420
R751
A-b
A-a
*
10k
A-a
Large size SCH diagram
A-b
R752
A-a
3
4
5
6
7
8
A
A-b ROR
13
PML022A
18
19
20
23
21
ROL
4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 9 NC1 NC2 10 VCC STB 11 VREF CLK 12 GND DATA
5
6
8
7
4
3
2
1
1k
R201 NM
C213
CCG1201-A 4.7u
10p/50 C203
10p/50 C215
C202
C201 CCG1192-A 10u
FM(30%): -5.9 dBs AM(30%): -5.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs
A GND
NM
GND
TUNL
Set back chart
0.47u/10
C308
0.47u/10
C302
0.47u/10
C306
0.47u/10
GND
R353
10k
220
2
12MHz
YSS5005-A 1 1
4
4
X602
IC REGULATOR SYSPW
+B VDD3.3V
SW5V
NM
ASEN1
100p/50
NM C259
NM
C261
C260
100p/50
1000p/50 FR+ P-GND3
19
FR-
20
VCC
21
RR+ MUTE
C321
C320
C319
23
RR-
24
P-GND4
25
B.REM
NM
NM
NM
D
CKM1586
FUSE
18 BUP1 BUP3
YEK5001 (10A) 16 GND 17
>
15 B.UP 14 BREM 13 ACC 12 A.ANT
22k
11 ILM 10
RL2 RR1 RL1 FR2
1SR154-400
FL2
NM
C927
1000p/50 C923
1000p/50
1000u/16 C926
1 C921
JA901
14.4V
RR2
FR1 FL1
9 8 7
TEL RRRL-
6
RR+
5
RL+
4
FR-
3
FL-
2
FR+
1
FL+
FM(30%):+20.1 dBs AM(30%):+20.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs
R934
D931
E
C931
R933
DIM
47k
0.1u/16
1k
HZU7L(A1)
4.7k
22k
GND
TELIN
R942
A.ANT
22k Q941 LSA1576UB(QRS)
L941 D941
NM
47k
E2 4 Q873 LTC143EUB
ILM GND
9 3 C2
8
B2 5
2 B1
7
C1 6
1 E1 NM ANTPW
ANTPW
6
DIAG
OUT
GND6 GND1 GND5 GND2 GND4 GND3 IN
VDD NM
D951 CRG03 1 2 3
GND
4 5
1k
2.2u 15k
1SS301 GND
R952 1/16W 4.7k
Q951
R951 1/10W
NM IC951 10
NM
D952
R875
CRG03
6
0
150 5 (1/4W)
RN4983
R876
C951
4
3 2
Q952 2SB1731-TLB
10k
Q953 LTC114EUB
R873
NM
Q872
1
R941
TELIN
C952
8.2k
DPDT
ROT0
R810 2.2k
D871 R879
DPDT KYDT
R880 180 D872
NM R878
2.2k 2.2k
NM
NM 0.1u/16 C871
2.2k C873
1u/16 R871
C872
ILMCLR1
NM
17
R943
8.2 DM 8.2 ILMCLR2
AC-GND
RFGND
Q871 2SD1767(QR)
NM
R805
3 3 NM
R931
R932
Q931 LSC4081UB(QRS)
SWVDD
B.UP ILMPW
R881
D874 D873 NM NM
NM
R877
DP
D875
NM
R806
R872 NM
CTF1713-A 2 2
NM
NM
NM D876
RKZ7.5KG(B2) R885 R874
AUXR AUXG
R884 1
AUXL
100 100
RRIn FRIn
16
TELIN
ASENS ASEN2
Dim off 13.96 V Dim on 9.72 V
R882
NM
2.2k 100
AGND
15
Q874 NM
R883 SSENS
RLIn
GND
BTRX
ILMPW R807
FLIn
12
AANT
D912 0.1u/16 C922
220u/6.3 C919 1000p/50 C920 R912
CCG1201-A C924
4.7u CCG1201-A
C651
1u/10
NM
C652
4.7u
S-80827CNMC-B8M
NM C918
NC1
C925
VSS
4
11
ACC
D911 1SR154-400
NM C917 4.7u CCG1201-A C911
NM
VDD
1000p/50 R911 C914 4.7u CCG1201-A 1 C929 C915 220u/6.3 NM C916 4.7u CCG1201-A C912
NC2
220u/6.3 C913
NM R651
OUT
5
FL+ SVR
GND
10 +BUP 11 VDDCONT
VDDCNT
C928
IC651
9 10
BREM
1SR154-400
12 GND
2
BTTX
VCK
KYDT
DPDT
100p/50
22k
D902
8 VDD12 9 SWVDD
BUP2
1
P-GND1
1SR154-400
6 SW5V 7 VDD
VDD1 1.2V SWVDD
RST
FL-
8
D954
600uH
4 +B 5 SYS+B
SYSB
1k
RESET
VCC
7
PW CONNECT
L901 CTH1432-A 2 1 GND1 GND2 D901
2 SYSPW 3 SW5VCNT
12p/50
R629
RL+
6
NM
IC912 BA49182-V12 1 BSENS
BSENS
BSENS SYSPW
USB GND
STBY
5
GND GND
C633
C
GND NM
MUTE
2
33
GND
ASENS
VDT
C256
22k
R257
C318
C312 0.1u/16
RN4983
D301
6
CRG03
1
CCG1192-A
10k
5
D302 CRG03
C632 12p/50
4
22
4
10u C351
2
CCH1732-A GND 3300u/16
MU1
3
P-GND2 RL-
18
C901
R352
MUTE
AC-GND
CCG1205-A 2.2u
TAB
2
14
A GND
CCG1205-A 2.2u GND C309 0.1u/16
1
13
C311
C310
R351
Q351
3
NM
C314
NM
GND
C317
0.47u/10
C307
GND
NM
C305
0.47u/10
0.47u/10
C315
0.47u/10
C304
C334 NM
C331 NM
C333 NM
C332 NM
DP DM
C313
NM
NM
C303
VBUS
100
GND
R809
C257
22k
6 NM
1 E1
470
1u/10
C638
10k
R632
R633
10k
R303 R302
2 B1
C1 6
47k
470
470
R333 470
R334
R331 SYS+B
SW5V
VDD3.3V
B.UP
VDD1.2V
3 C2
B2 5
GND
47k
47k R620
R642
STBY
E2 4
R304
NM
NM C637
C635
USBA GND
C631
36
C629
C301
100k
VST
GND
DDCONGND
IC301 PA2030A
10u/16 C316
VDSENS
AGND
GND
MUTE
C258
3 RN1910
2
Q252
4
1 68
47k
0.1u/10
69
GND
R332
C630
except A
47k
R630
10k
R628
0.1u/10
NM
3
R808 2.2k
4
Q301
R301
NM
D651
R803
5
NM
NM
VDD1.2V
NM R640
AVSS
35
33
L602
R631
KEYAD
D602
RB751S-40
TRST
TDO
TDI
ASEBRK
73
71 70
0.1u/10
C621
0.1u/10 C618
0.1u/10
5
RL
FR
RR
FL NM
NM C636
47k R621
C634
5 4
1
47k
6 3
8
7
NC
PVCC4 CKIO VSS4 BTRX NMI
VCK
KYDT/TESTDI
DPDT/TESTDO
BTTX
32
31
30
29
VDT
28
27
26
VST
VCC3 25
VSS3 24
C622
72 AVCC
67 VDSENS 66 NC 65 GND NC MODEL 64 MODELAD 63 USBUVSS C623 62 USBUVCC 0.1u/10 61 USBAVSS 60 C624 0.1u/10 USBAVCC 59 C625 0.1u/10 USBAPVCC 58 USBAPVSS R626 57 REFRIN 5.6k F% 56 USBDVSS C626 55 USBDVCC 0.1u/10 54 VBUS 53 DP 52 DM 51 USBDPVSS C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL NM R637 42 1.5k EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37
34
79 AUDIO_X2
AUDIO_X1
78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74
TCK
TMS
R618
0.1u/10 PVCC6
80
C620 81
82 VSS7
AUDIO_XOUT
VCC4
83
84
R617
C619
220
NM R616 85
DACBSCK
0.1u/10
NM
R619 2
10p/50
C617
NM NM
100 R613
R614 86
87
88 DACDATA
DACBDATA
CDSKIP PVCC3
MUTE
TESIN
23
22
21
TESTIN C616
R615 100k
820
AMP
SWVDD5
R804
2
KEYAD
0.1u/10
R811
1 3
FR
R254
CCG1201-A
except A
AVREF
P
44 R812
CKB1056
FL
6
C254 4.7u
FRch
JA251
GND
CRO
L801 11
PL
PR
820
VDD3.3V
NM
FM(30%): -5.9 dBs AM(30%): -5.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs
NM
R253
C253 4.7u
FLch
CCG1201-A
2 2
RCAG 2
820
16.934MHz
NM R639
GND
R252
4.7u
>
P251 CEK1286 R259
R256
C252 CCG1201-A
3A 1
B.UP PRch
C255
R255
3 4
6
VDD3.3V
5
Q251
2
1
MUTE
100p/50
820
CCG1201-A 4.7u
REAR OUTPUT
SYS+B
R251
C251
PLch
VST
RN1910
BTL
TUNR
AUXL
BTR
AUXR
AUXG
RR
SW5V
L601
B
RCA
VCK
X601 CSS1603-A 1 3 1 3
GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990
RL
GND
R258
24
22
IN2_R
IN1_R
IC201
1 IN1_L
TUL 1u/10
C211
C212
E-VOL output
C214
NM
C231
C233
C232 0.01u/16
CCG1192-A 10u
1000p/50
C239
NM
LRCK
DATA
SCK
Selector output FM(30%): -10.9 dBs AM(30%): -10.9 dBs AUX:+5.3 dBs CD/USB:+5.3 dBs
SCK
ML
BCK
NM
C204 10p/50
TUNER AMP UNIT
REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800
L201 NM
NM R206
FM(30%): -15.0 dBs AM(30%): -15.0 dBs AUX:+2.2 dBs CD/USB:+5.2 dBs
VDT
MC
MD
DATA
1u/10
R205 L231
CDSKIP
1u/10
C217 NM
820
D GND
1u/10
C209 C207 A GND R207
C237 R231
C205
NM
C238
1800p/50
E-VOL
1800p/50
PCM1753DBQ
14 MC
15 ML
13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5
SCK
LRCK
4
IC231
DATA
3
2
1
BCK
16
820
2 IN2_L
LPF
R232
IN3_R
C235
3 IN3_L
DAC NM
A
Selector input 17
NM
C234 CCG1192-A 10u
14
1u/10
C216
15
1u/10
C206
16
C208
TUR
1u/10
1u/10
SB:+5.22 dBs
C210
NM
GND
ROT1
C810 220p/50 C811 220p/50
IC801
B DEH-1450UB/XNES
3 GND GND
SWVDD
Vcc
C DEH-1450UB/XNES1
INA GND
OUTY
TC7SET08FUS1
F
5
4 C817
2
INB
0.1u/10
1
NM
C852
NM
C851
4.7k
NM R851
D811 DZ2S068C
A DEH-14UB/XNUC L851
D DEH-1450UBG/XNES E DEH-1490UB/XNID
A
GND
DEH-14UB/XNUC 5
6
7
8
37
VOUTL
A 3 3
VOUTR
AGND 9
TCK
820
R231
C238
A GND
B.UP
VDD3.3V
SW5V
NM
L231
C237
VCOM 10
NM
R618
8
C232 0.01u/16
TMS
820
C630
0.1u/10
C625
0.1u/10
C626
5.6k F%
R626
0.1u/10
0.1u/10
C623
GND
C624
MODEL
0.1u/10
70
69
0.1u/10
C622
except A
71
KEYAD 68 AVSS 67 VDSENS 66 NC 65 NC 64 MODELAD 63 USBUVSS 62 USBUVCC 61 USBAVSS 60 USBAVCC 59 USBAPVCC 58 USBAPVSS 57 REFRIN 56 USBDVSS 55 USBDVCC 54 VBUS 53 DP 52 DM 51
AVREF
NC
AVCC
72
47k
VCC
7
Hz
R619
NM
1800p/50
1800p/50
C231
47k R621
PCM1753DBQ
C233
8
CCG1192-A 10u
7
2
ASEBRK
1
TDI
_ 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST
TDO
6
3
74
5
4
TRST
73
LPF
D602
R232
R628
NM
USBA GND
NM
NM R206
R205
1u/10 1u/10
C209 C207
AGND
C217 NM
1u/10
E-VOL
1u/10
GND
GND
ROR 17
1u/10
C205
AUXL
NM
RB751S-40
R207
AUXG
10k
C212 TUNR
IC201 NM
20
21
18
19
TUR
NM
NM R640
L602
NM
NM R639
L601 VDD3.3V
VDD1.2V
100
R633
GND
SYS+B
NM
C214
NM
L201
15 STB
16
C204 10p/50
14 CLK
22 1u/10
C235
R630
R631
BTR
except A
13
GND
5 6
4
1
Q351
10k
R351
GND
C306
0.47u/10
C302
220
R353
C308
C307
0.47u/10
0.47u/10
C303
C304
C305
0.47u/10
NM
R301
C301
FM(30%): -5.9 dBs AM(30%): -5.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs
E-VOL output
FM(30%): -10.9 dBs AM(30%): -10.9 dBs AUX:+5.3 dBs CD/USB:+5.3 dBs
Selector output
FM(30%): -15.0 dBs AM(30%): -15.0 dBs AUX:+2.2 dBs CD/USB:+5.2 dBs
Selector input
2
1k
DM
470
3 MUTE
VST
VCK
VDT
C331 NM
DP
VBUS
VDSENS
KEYAD
A GND
C213
DATA 12 GND
CCG1201-A 4.7u
C234 CCG1192-A 10u
AUXR
47k
47k
BTL C634 C635
PML022A NM
23 TUL C211 TUNL
8 1
24 C638
7 2
NC2
9 NC1
10p/50 C215
ROL C202 B.UP
6 3
R201
10 VCC
VDD3.3V
5 4 SYS+B
11 VREF
10p/50 C203 SW5V
C201 CCG1192-A 10u VDD1.2V
1u/10 NM 10k
FL R331
1 IN1_L IN1_R 2 IN2_L IN2_R 3 IN3_L IN3_R 4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 1u/10
NM C636 NM C637 R632
FR 470 R332
RL R333 470
RR 470 R334
NM
NM C332
C206
NM C333
C216
NM C334
1u/10
10k
C208
R352
R252
C252 CCG1201-A
2 B1 1 E1
C1 6
MU1
0.47u/10
0.47u/10
0.47u/10
0.47u/10
3 C2 B2 5 NM
Q301
CCG1201-A
C310
CCH1732-A GND 3300u/16
C901
CCG1205-A 2.2u GND C309 0.1u/16
GND
NM
R302
820
R254
820
R253
AMP
C254 4.7u
CCG1201-A
C253 4.7u
MUTE
820
820
4.7u
R251
C251 CCG1201-A 4.7u
E2 4
FRch
FLch
PRch
PLch
RCA
1 Q251 Q252 R303 R304
C210
CCG1192-A
2 6 1 6
10k 47k
A
D302 CRG03
CCG1205-A 2.2u
C311
GND
NM
10u/16 C316
C313
GND
GND
NM
1
>
NM
R259
P251 CEK1286
3A
A GND
STBY
FR
FL
PR
PL
RCAG
AC-GND
GND
DDCONGND
2
MUTE RRP-GND4
22 23 24 25
RR+ 21
B.REM
FR-
P-GND3
VCC 20
FR+ 18 19
17
RRIn FRIn AC-GND 16
15
AGND 14
13
RLIn
11 12
FL+ SVR FLIn
9 10
FLP-GND1 8
RL+ VCC 7
6
STBY 5
4
3
TAB P-GND2 RL-
2
IC301 PA2030A 1
GND
NM
CKB1056
JA251
FM(30%): -5.9 dBs AM(30%): -5.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs
Set back chart
RR
RL
GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990
TUNER AMP UNIT
REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800
RN1910 RN1910
3 5 2 5
4 3 4
A-a A-b
10u C351
R258 C314 C317 C315
A-b
01
4
G03
22k NM NM NM
3
12 u/16
22k R256 R257
R255
22k 22k
C255 C256 C257
100p/50 100p/50 100p/50 C258
DEH-14UB/XNUC
100p/50
2
C318
1 C319
38 NM
F C261
E NM C259
D C260
C 4
5
6
2
1 3
3
C321
B 2
C320
A
1000p/50
1 4
REAR OUTPUT
3
2
2.2k
VCK
REFRIN
51
52
53
54
55
56
57
58
0.1u/10
C626
DP
AUXR AUXG
AUXL
SSENS
DPDT
DPDT
8
A-b
SWVDD
D875
NM
D876
NM
NM
R883
GND
GND
INA
C633
USB GND
12p/50
OUTY
Vcc
TC7SET08FUS1
3
2
NM
R881
IC801
INB
ILM GND
1
2
D874 D873 NM NM
NM
R882
ILMPW
1k
R629
12p/50
C632
USBA GND
100k
NM R651
D651
Q871 2SD1767(QR)
Q874 NM
4
5
Q873 LTC143EUB
GND
RST
RESET
1u/10
VSS
VDD
OUT
NC1
NC2 4
5
VDD1.2
3
1
2 RN4983
Q872 R873
ILMPW
6
150 5 (1/4W)
4
Dim off 13.96 V Dim on 9.72 V
S-80827CNMC-B8M
3
2
1
IC651
100
R633
B.UP
B.UP
NM
R875
DM
DP
VBUS
ANTPW
C1 6
B2 5
E2 4
TELIN
ASENS
SWVDD5
SYSPW
BSENS
MUTE
2 B1
3 C2 1 E1 NM ANTPW
Q951
220u/6.3 C913
ASEN2
6
7
8
9
10
ASEN1
OUT
IN NM
VDD
GND4 GND3
GND5 GND2
GND6 GND1
DIAG
NM IC951
C951
D931 HZU7L(A1)
GND
A-a A-b
5
4
3
2
1
6
5
4
MUTE
RN4983
Q351
IC REGULATOR
R931 22k
C331
GND
1
2
3
10k
R351
GND
D951 CRG03
GND
GND
GND
GND
10k
R952 1/16W
Q952 2SB1731-TLB
A.ANT
220
R353
MU1
1k
GND
1SS301
D941
2.2u C315
D302 CRG03
GND
D301
GND
NM
15k
R943
NM
2.2u
L941
TELIN
1SR154-400
D902
1SR154-400
E DEH-1490UB/XNID
D DEH-1450UBG/XNES
C DEH-1450UB/XNES1
B DEH-1450UB/XNES
GND
L901 CTH1432-A 2 1 GND1 GND2 D901
600uH
CRG03
A DEH-14UB/XNUC
1k
R941
22k Q941 LSA1576UB(QRS)
R942
RFGND
1SR154-400
D912
ASENS R934
12 GND
10 +BUP 11 VDDCONT
8 VDD12 9 SWVDD
6 SW5V 7 VDD
4 +B 5 SYS+B
2 SYSPW 3 SW5VCNT
D911 1SR154-400
VDDCNT
BUP2
SWVDD
1.2V
VDD1
SW5V
SYSB
+B
SYSPW
BSENS
IC912 BA49182-V12 1 BSENS
CCH1732-A GND 3300u/16
C901
2.2u GND C309 0.1u/16
SW5V SWVDD
23 24
FL1
FR1
FL2
FR2
RL1
RR1
RL2
RR2
TELIN
AANT
ACC
BREM
BUP1 BUP3
D954
FLFR+ FL+
4 3 2 1
RR+ 5
FR-
RL-
RL+
6
RR7
TEL
9 8
10
11 ILM
12 A.ANT
13 ACC
14 BREM
15 B.UP
>
FUSE
CKM1586
JA901 YEK5001 17 (10A) 16 GND
18
PW CONNECT NM
FM(30%):+20.1 dBs AM(30%):+20.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs
14.4V
RR-
22
B.REM
MUTE
P-GND4
21
25
FRVCC RR+
P-GND3
20
FR+
18 19
17
7
GND
NM
L851
ROT1
ROT0
KYDT
ILMCLR1
C629
0.1u/10
GND
5.6k F%
R626
0.1u/10
0.1u/10
C624
C625
VDD3.3V
59
SYS+B C928
60
C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL R637 NM 1.5k 42 EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37
USBDPVSS
DM
DP
VBUS
USBDVCC
USBDVSS
36
R642
DM 8.2 ILMCLR2
R805
8.2
R806
R807
32
C621
4.7k
30
VCK
R851
35
BTRX
33
4
4
YSS5005-A
USBAPVSS
47k R620
BTTX
31
BTTX
33
0.1u/10
C851
10u C351 1000u/16 C926
USBAVCC
R872 NM
PVCC4 CKIO VSS4 BTRX NMI
34
NM
1
C312 0.1u/16
USBAVSS
C872
R632 C651
C318 NM
USBAPVCC
NM
47k
C852
1u/16 R871
10k 1u/10
X602
C631
2.2k C873
1000p/50 R911 C914 4.7u CCG1201-A 1 C929 C915 220u/6.3
2
1
NM
R878
NM
NM C925
Q931 LSC4081UB(QRS)
12MHz
R884 1
NM
D871 R879
NM
NM C916 R932
1 4.7u CCG1201-A
C638 R877
4.7u
CCG1201-A C912 47k
10k
C921 C931
C319 NM
C333 NM C918
R352 0.1u/16 C922 0.1u/16
CCG1192-A 1000p/50 C923
C320 NM
C332
NM C917 4.7u CCG1201-A C911 C952
1000p/50
C321 NM
C334 4.7u
CCG1201-A C924 R933
NM
VDD3.3 DIM R876
NM
NM 0.1u/16
C871
C652 RKZ7.5KG(B2) R885 R874 0.1u/10
R880 180 D872
47k C817
NM NM
7
D952
DEH-14UB/XNUC NM
220u/6.3 C919 1000p/50 C920 R912 4.7k CRG03
6 4.7k
C927
5 R951 1/10W
6
Q953 LTC114EUB
5 8
A
B
C
D
E
39
F
0
C551
RFGND
M2R6TP_GND
KN401
TUNGND 2
0.1u/10
33p/50
C401
R401
D401
3
RFGND
DEH-14UB/XNUC
4
NC7 8 NC6 NC5 7 NC4 NC3 6
9
10
R553 10k
R552 10k
NM
L551
L420
C443
*
RFGND
GND
CTF1786-A
L403
*L404
RFGND
6p/50
CTF1786-A
L402
1
L406
*
R403
AGND
3
2
1
NM
C448
100
R560
17 NC9 NC10 18 NC11 NC12 19 NC13 20
16
15
NM NM 1u 3p 1.5k 470 680 0 0 NM 0.47u 0.1u NM PEB035A8
CCG1205 0.1u NM NM 330 360 390 NM NM 0 NM NM 0.1u PEB034A8
C424 4700p/25
C425 4700p/25
1
ipod CP
*
NM
R561
NM
*
TEST
*
DGND
*
8.2
46
NM
L410
0
D502
VDD3.3V
R428
L411 NM
8.2
AGND
NM NM
C440
NM
CCG1205 C442
L416 NM C441
R421 0
L414 NM
L412 L413
DGND R429 NM
*
DGND
0.1u/10
47 2.2u
48
GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33
VDD_CORE
2
3
C429
1/4W 1/4W DGND R410 R412
RF GND
*
USB&USB5V
*
RF GND
*
C454 NM
R434 C457
R562
DGND
X2
GND1 X1 CSS1805-A
4 GND2
X401
36.48MHz
R751
VD2
RF GND
*
Q751 2SD2396(K)
7.4V
CPRST
CP_SDA
CP_SCL
CPPW
NM
L419
TUNL
TUNR
GND VDSENS
10u
MECHA VD
NM C753
C751 CCG1192-A
Q752
SW5V
NM
R430
except A ROT1
KEYD
SWVDD5
ML
CDWAIT
CDSTBY
CDSRQ
CDRST
CPPW
CPRST
CP_SCL
CP_SDA
CD_SCL
CD_SDA GND
1k
R427
B.UP
NM
R754
KN601
NM
R417
NM
R416
C602
R605
2
7
SI
IC671
0.1u/10
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
47k
CE#
SO
WP#
0.1u/10
109
NM
C
VSS
C671
R671
SCK 7 HOLD# 8 VDD
6
5
CD_SCL
*
NM
R721
1
3
6
8
4
5
R704 4.7k
VD1
CD_SDA
0.1u/10
C601
SCK
SI
0.01u/16
100k C701
R703
100k
47k R702
R701
GND
M2R6TP_GND
GND
CD
CN701 VKN1192
FLASH ROM
820
R753
VDCONT
VDD3.3V
6
5
2 1
4
3
RN4983
A-a A-b
C754 0.1u/10 D751
B~E
FM(30%) -15dB±2.5: -15.0 dBs AM(30%) -15dB±2.5: -15.0 dBs
C432 C433 C457 C458 R403 R406 R408 R431 R433 R434 C430 C431 C439 IC671
RFGND
0.01u/16
C415
IC551 341S2162
100
R559
16
4.7k
R558
Q551 LSA1576UB(QRS)
L418
L405
C412
C413
10u CCG1192-A RFGND C445 0.022u/16
C408
A GND
0.01u/16
4 FMMIXDEC 5 FMMIXIN2 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND 9 orRFGND C450 CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN 14 TCAM2 C411 0.01u/16
C446 RFGND NM
15p 22p 2p 0.01u 8p NM NM 0.39uH NM 1.5uH 2.2uH 0.39uH 0.27uH NM
C428 9p/50 56
JA401 YKS5041
220
KP2311E
C402
NM
750
9p/50 C431
ANTENNA
C405
L401 0.15u
NM
1M
C458
47k
P401
C403 0.01u/16
C404
IMSA-6802-01Y900 R432
C451
C409 0.01u/16
R402
NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM 68n
1M
C432
47k 10k
0.1u/10
C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L417 L418 L420
R405
GNDLNA 17
D402
C417 LNAIN 18
LNADEC 10u 19
C418 CCG1192-A
KP2311E
1u/10
20
0.1u/10
0.1u/10
L407 0.1u/10 C419
64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 R406
C449 NM
NM
VCC-PLL
LNAIN2
C420
LNAOUT2
21
LNAOUT 22 33
0.1u/10 R407 C421
LNADEC2 23
C456
R413
R551
C427
C422 0.1u/10
51
CTF1786-A L408 59 VCC-ADC_DAC
C426 55
CTF1786-A 58 DACOUTR
57 DACOUTL 24 L409
54 0.1u/10
GNDSLINK
26
AMMIXIN1 R408
53 R409 NM 28
C406
C444
L417
R431
RKZ8.2KG(B2)
A
1
2
3
4
NC
CP_SCL
ROT1
KEYD
SWVDD
VSS11
PVCC10
NC
DACCS
CDWAIT
CDSTBY
CDSRQ
CDRST
VSS10
CPPWR
PVCC9
CPRST
CN701
L671 CTF1786-A
GND
SO
NM
C703
NM
C702
CP_SDA
TUNSDA TUNSCL
NM
C704
100k
R717
NM C706
GND
NM C705
DGND
NM
GND
PGND
NM C710
NM C709
NM C708
C707
DAC
CD/USB:+5.22 dBs
SYSTEM MICRO
R5S7266ZD144FP
IC601
NM
C235
C234 CCG1192-A 10u
D GND
2 2
X601 CSS1603-A 1 3 1 3
16.934MHz
820
R231
820
R232
A-b
B.UP
VDD3.3
SW5V
NM
L231
LP
68
69
70
71
72
67 VDSENS 66 NC 65 NC 64 MODELAD 63 USBUVSS 62 USBUVCC 61 USBAVSS 60 USBAVCC 59 USBAPVCC 58 USBAPVSS 57 REFRIN 56 USBDVSS 55 USBDVCC 54 VBUS 53 DP 52 DM 51
AVSS
KEYAD
AVREF
NC
AVCC
3
11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15
L415
52 29 C433
VDCONT R419
R752 C447
50 31
VDIG 27
R433 C452 C434
R418
49 32 NM
C436
AMMIXIN2 25
C423 0.01u/16
1000p/50
GND-ADC_DAC VREFDEC GND-REF OSCOUT OSCIN VCC-REF VDDIO1V2 VDDPLL1V2 NM
NM
C435 NM C437
C438 NM
VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT 30 C430
10k R420 R415
VD 1
B~E
NM R601
CTF1786-A C439 C455
10k NM R414
D601 RB551V-30
VD 2 CDSRQ
SCL
A
100k
3 /CDSRQ 220
C238
*
10k R603
4 /CDSTBY 220
SCL 100 108
CDSRQ
R707 CDSTBY
R708 CD_SCL
R709
CDSTBY
SDA
SKIP
5 TUNPCE2
L701
6 SDA
220 R710
SKIP 100 R711 CD_SDA C605 106
CDSKIP 107
VDD
RESET 8 VDD4
9
RESET 1k R712 CDRST
NM
7
TUNPCE1
CDDATAIN
C607
47k 104
DATA 150 R713
10 GND 11 DATA BCLK 150 R714 NM
12 BCLK 13 LRCK LRCK 150 R715 NM
102
R672 0.1u/10 VCC6
105 RSPCK
220
R719 CDLRCKIN
R718
16 WAIT CDWAIT
DGND1 NM 103
VSS9 /SSL
MC LRCK R611
R720
PVCC8
MD NM
R613 89
14 GND 15 PGND
MISO 100 TUNPCK 99 RDS_INT
SCK MD NM
CDSCKIN
CE 0.1u/10 101 MOSI
C609
CDDATAIN 0.1u/10
DATA SCK R614
NM 92
NM
IC231 CDSKIP 88
C611
ML C615
BCK MC C617 NM
PGND WAIT R716 R634 98 TUNPDI
NM 97 NC TUNPDO
CDSCKIN 96 CDSCKIN
CDLRCKIN 95 CDLRCKIN
94 VCC5
93 CADATAIN
10p/50 220
ASEBRK
BCK 100 VSS8
0.1u/10 R617 PVCC7
R609 91
C613 100
C239 C620
LRCK C619
1000p/50 0.1u/10 R616 DACLRCK
0.1u/10 DACSCK
NM R618
DATA 100
7
1 16 SCK BCK 2 15 DATA ML 3 14 LRCK MC 4 13 DGND MD 5 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC VCOM 10 VOUTL AGND 9 VOUTR TCK
DACBDATA 87 86 CDSKIP 85 DACBSCK 84 AUDIO_XOUT 83 VCC4 82 VSS7 81 PVCC6 80 AUDIO_X1 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST DACDATA
C612 90
R619 TDI
8
C232 0.01u/16 TMS
PCM1753DBQ C233 8
CCG1192-A 10u 7 2 1
TDO
6
3
3
2
TRST
1
74
A-a 73
40 1800p/50
F C237
E 1800p/50
D C231
C 5
B 47k R621
A 2
4
1 4
JA892 CKS4124
C
6
7
8
9
10
11
12
GND
U1OUT
U1IN
VSS
1
2
3
4
NRST_CPU 5
VCC
MIC1P
MIC1N
VSS
SPKR
VSS
SPKL
R
6 5 4 3 2 1
1 3 2
GND 13
CN961 VKN1189
W.REM&MIC
(W/R)
(RMIC)
JA891 YKS5035
except A
W.REM
0.1
GND
4
GND
R965
1k
1k
R966
NM
L961
1u/10
R964
GND
R963 8.2k
GND
C963 R962 8.2k
1u/10
C964
GND
KEYAD
GND
L501 CTH1475-A
GND
NM
ipod CP
GND
1k
1k
R891
GND
3
2
1
R892
GND
1u/16
C509
KEYD2
RT
GND
VIN
/OC
VOUT 4
5
BD9008F
INV EN/SYNC
FB
SW
10k
R969
C968 470p/50
BT MOD
except A
KEYAD2
IC501 PVIN
BD2232G-G
EN
GND
VIN
IC510
4
3
2
1
A GND
4
3
2
1
5
6
7
8
USB&USB5V
GND
IN+1
IN-1
OUT1
GND
10k
R972
IN+2
IN-2
OUT2
VCC
IC961 NJM4558MD
USBCTL
FLG
R507
R506
5
6
7
8
NM
10k
R968
C967 470p/50
SYS+B L962 NM
SYNC
LPF
GND
NM
51k
CRG03
CRG03 D503
D502
ASENS
SSENS
BSENS
RGBDT
A-a A-b
CN1821
DP
AUXGND
AUXR
SOURCE
AUXL
DSENS
CKS6288
CN801
14
15
16
17
18
19
20
4
5
6
7
8
9
10
11
GRILLE
DGND
1
ROT1 SWVDD 3 2 ILMGND
ILM+B
ROT0
RGBDT/USBGND
KYDT
USBGND
DPDT
USB5V
RGBCK/ILMCLR1
DM 13 12
RGBST/ILMCLR2
ILMCLR2
ILMCLR1
ILMPW
ROT0
ROT1
KEYD
DSENS1
except A SWVDD5
ML
CDWAIT
CDSTBY
CDSRQ
CDRST
B
BTR
BTL
BTRST BTRX BTTX
KEYAD
KEYD
USBCTL
FLG
VBUS
SYNC
CPRST
CP_SDA
R818
0
R814
2.2k
0.1u/16
DSENS C818
GND
RGBDT
NM
0.1u/10
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
C802
CDRST CDSRQ
SSENS ASENS
BSENS
DSENS
BTTESTMD
BTTESTIN
RGBDT
VSS12
ILMCLR2
PVCC11
ILMCLR1
ILMPW
ROT0
ROT1
KEYD
SWVDD
VSS11
PVCC10
NC
DACCS
CDWAIT
CDSTBY
NM
C803
ILMG
NC
D GND USBGND ILM GND
NM USGND
DGND
SWVD
ROT1
ILM
ROT0
KYDT
DPDT2
US5V
ICLR1
DM
ICLR2
DP
AUXG
AUXR
SRC
AUXL
144
143
142
141
BTTESTMD 140
138 NM BTTESTIN 139
R641
0.1u/10
C603
C602
R605
0 121
R817
R816
R5S7266ZD144FP
IC601
SYSTEM MICRO
22k R801 22k R815
R802
100 100
100
2.2k
R804
R810 2.2k
R808 2.2k
2.2k
NM
R803
NM R811
GND
3 3
CTF1713-A 2 2
44 R812
L801 11
2.2k
DP
AUXR AUXG
AUXL
SSENS
DPD
8
A-b
SWVD
NM
L851
ROT1
ROT0
KYDT
ILMCLR1
GND
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
38 RES PLLVCC 37
PLLVSS
MD_CLK0
MD_BOOT0
EXTAL
XTAL
VSS5
PVCC5
VSS6
USB_X1
USB_X2
ASEMD
USBDPVCC
USBDPVSS
DM
DP
VBUS
USBDVCC
USBDVSS
REFRIN
USBAPVSS
DM 8.2 ILMCLR2
R805
8.2
R806
R807
USBAVCC
USBAVSS
USBAPVCC
7
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
NM : No Mount
220p/16
GND
NM C505
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
GND
KEYD
MIC1N
MIC1PF
GND
NM
R557 4.7k
USB5V
0
NC9 NC10 18 NC11 NC12 19 NC13 20
R556 2.7k
VR105C5R0AAA
VA894
C970
0.1u/10
C892
220u/6.3
C552
VA893
0.1u/16
18k
5 11 VSS I2C_SCL/SPI_SIMO 12 4 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 3 VCC NC8 nRESET 2 NC2 14 MODE1/SPI_nSS 15 1 NC1
R501
0.1u/16 C891
VA892
47k C503
6.8k
10k
NM R503 R502
R504
470 C502
VA891
C508
NC7 8 NC6 NC5 7 NC4 NC3 6
C511
D501 RB160L-40 NM C510
R505 C506 1u/10
C965
22p/50 NM
0.015u/16 NM D961
17
R967 R961
16
10k 47k 47k
R971
9
C512 C966
10
220p/50
C507 C513 CCG1192-A
IC551 341S2162
10k
NM
C961
CP_SCL
R691
R561
220p/50
NM R973
R508 10k
4 5
R601 3 6
100k
10k R603 2 7
47k 1 8
NM
1u/10 10u C962
C969 1u/16
10k R970
D601 RB551V-30 R604 47k
NM
PVCC2
100
C604
/RDSLK
100
NM NM
1 2 PVCC1 NC 0.1u/10
VCC2 17
R560
3 D809 DZ2S068C
VCC1 0.1u/10
VSS1 4 DIM
ANTPW 6 ANTPW
DIMMER 5 C606 C809 0.1u/16
SYSPW 8 PCL
PCL 7 SYSPW D804 DZ2S068C
9
R607 D803 DZ2S068C
MUTE
R559
25
R602
R813 RGBDT D808
34
R553 10k
NM
C801
47k
R552 10k
R608
TELIN 47k BTRST D805 NM
RAM_MON C812 1u/16 D802 DZ2S068C
TELIN1 TELIN
10 BT RST ROM 11 ROM 12 RAM_MON 13 47k C608
VDCONT 14 0.1u/10 VDCONT
VSS2 15 D801 DZ2S068C
USBCTL 18 0.1u/10 USBCTL
16 R612 47k 0.1u/16 C808
C610 D806 NM
SYNC 19 R610 D807 NM
TESTIN
/USBFLG 20 2.2k FLG
PVCC3 22 R615 100k
VSS3 23 C616
VCC3 0.1u/10
TESIN
24 0.1u/10
VDT 26 VST
VST
27 VDT
C618
21 NM MUTE D811 DZ2S068C
C614 SYNC D810 DZ2S068C
29 KYDT
DPDT/TESTDO 28 DPDT 8.2k
7
R809
32 C621
VCK 30 VCK
BTTX
33 0.1u/10 4.7k
36 R642
PVCC4 CKIO VSS4 BTRX NMI
35 BTRX
KYDT/TESTDI
31 BTTX R851
6
C810 220p/50 C811 220p/50
47k R620
5
C851
DEH-14UB/XNUC
NM
6
C852
5 8
A-a
41
A
B
C
D
E
F
42
1
B
2
F COLOR2 GREEN
3
1
2
1
L1801
NM
GRILLE uCON&LCD
1801-1820
KEY MATRIX & CONNECTOR
1821-1850
LED
1851-1910
USB
1911-1920
AUX
1921-1930
S1835
3
D1851-D1865 : SML-D12P8W(KL)
DEH-14UB/XNUC
4
2
1
S1826 S1832
DGND
EJECT R1801 2.2k
R1802 2.2k
DGND
NM
1
4
6
1
CLK
2
R1867
R1826 NM
1 2 S1829
D1864
S1828
D1865
SEG36
680
S1831
R1858
2
1
NM
1
C1864
2
KDT1
KDT2
S1833
NM
1
1 2 S1834
C1865
2
NM
6
4
S1825
2
D1862
S1830
5
2
D1863
LEFT
680
S1822
R1866
CLOCK
NM
1
NM
2
R1857
S1824
NM
EQ
C1862
2
KDT0
3
C1863
D1860
3
SRC
D1861
2
680
S1823
R1865
2
NM
1
NM
S1827
R1856
1
C1860
1
C1861
1
R1824 0
2
NM
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
SEG20
S1821
DISP/BACK
D1858
R1823 0 SOURCE
D1859
5 MHz
NM
1
R1855
1
EQ
20
R1864
KST3
D1857
X1801 CSS1547
0
22
R1889
KST2
NM
KST1
C1858
R1825 NM
25
560
NM
NM
IC1802 GP1UXC14RK
NM
NM
KST4
R1854
17
C1857
REM
R1888
NM
D1855 RIGHT
KST0
NM
SIZE
1
DGND
D1856
GND
19
VCC
MODA
3
VSS
CCG1192-A 10u R1806
KDT2
680 R1863
26
NM
KDT3
NM
R1804
REM
27
2
1
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
GRILLE uCON
R1894
RS1/10SR***J-T C1801
KST4
R1853
28
C1855
29
C1856
SEG39
NM
30
LEFT
SEG38
D1853
SEG37
31
D1854
SEG35
SEG34
SEG33
SEG32
SEG31
SEG30
SEG29
32
EJECT
18
680
DPDT
R1862
21
NM
NC1
NM
KYDT
NM
SEG8
R1852
SEG9
C1853
23
C1854
R1805
X0
NM
X1
SEG10
LIST
SEG11
SOURCE
24
R1861
KST2
680
R1851
IC1801 PD6581A
NM D1851
SEG13 KDT3
C1851
NC2
NM D1852
KST4
C1852
SEG39
220 1/4W
55
16
SEG14 1
BAND
RS1/4SA***J-T 15
KDT0 KDT1
SEG15
KDT1
KST0
SEG37
220 1/4W
D KDT0
14
KST1
KST2
SEG4 SEG3
KST0
13
KST3
SEG16
KST1
12
VLCD
SEG28
SEG27
SEG26
SEG25
SEG24
SEG23
SEG22
SEG21
2
C1859
SYMBOL KST2
64 SEG36
SMLXA4WBETW1(Z1)
SEGMENT LCD SEG19 SEG18 SEG38
R1859
DGND SEG5
COM0
SEG6
KST3
63
11
SEG5
10
62
COM0
SEG6
COM1
SEG7
9
61
8
SEG12
COM1
60
SEG7
COM2
SEG8
COM3
59
7
58
SEG9
6
VDD
COM2
SEG10
COM3
SEG11 57
SEG0
SEG12 56
5
54
SEG0
SEG13
SEG1
53
4
52
SEG14 SEG17
SEG1
SEG15
SEG2
51
3
SEG16
SEG20
50
2
1
SEG17
SEG2
C
SEG4
49
SEG3
1u/10
C1802
B SEG18
R1860
SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 COM0 COM1 COM2 COM3
SEG19
D1866
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44
1 4
10.2 KEYBOARD UNIT
A
KEY MATRIX
RIGHT
2
BAND/ESC S1837 S1838 2
2
LIST 1
S1839
5 2
S1836
1 2
2 1
S1840
S1841
2
DISP/B
1 2
REMOTE
R1803 100
LED
CAW2018 V1801
E ILMGND
only D
REFERENCE AREA MAP
only
5
6
7
8
CN1821 CKS6287
1 3
DGND
2 4
AUX:+2.2 dBs
HT BAND/ESC S1837 1
2
S1842
S1838 1
5
2
27k
NM R1822
R1821
S1841 2
6
ROT0
7
USBGND
DPDT
11
USB5V
12
ILMCLR1
13
DM
14
ILMCLR2
15
DP
16
AUXGND
17
AUXR
18
SOURCE
19
AUXL
20
DSENS
B
A CN801
2
NM
CN1911 CKS6267
DGND
C
L1911
3
USB
NM
D1801
ILM+B
10
5V
DISP/BACK
ROT1
5
3
2
1
SWVDD
4
USBGND
S1840 1
ILMGND
3
KYDT
ROTARY COMMANDER DGND
5
2
9
CSD1168
2
DGND
8
S1839 1
1
2
1
4
A
KEYBOARD UNIT
NM
NM
C1922
NM
C1921
NM C1923
NM
VA1923
NM
ILMGND
CKN1090
SOURCE
KDT3
KDT2
JA1921
VA1922
VA1924
AUX
NM VA1921
B
2
1
4
NM
D1802
1
3
NM
NM
D1911
C1911
0.1u/16
6
C1912
5 ILM+B Dimmer off 12.96V Dimmer on 8.52V
D1912
4 DGND
0.1u/16
LED
DGND
NM
R1886
1k
NM
R1876
R1885
1k
NM R1875
820
R1884
R1874
NM
560
R1883
R1873
NM
820
R1882
NM
R1872
R1881
680
R1871
NM
R1867
680
R1858
USBGND
6
D1884
C DEH-1450UB/XNES1 D DEH-1450UBG/XNES CLK
D1885
D1882
4 5
D1883
1 2
D1879 D1880 D1881
B DEH-1450UB/XNES
E DEH-1490UB/XNID
3
EQ DISP/BACK BAND
D1876 D1877 D1878
D1873
LEFT
RIGTH
D1874
EJECT
NM
D1875
LIST SOURCE R1887
D1872
CLK
D1871
6
D1864 D1865
NM NM
E COLOR1
only D
RED
D1871-D1885 : SML-D12V8W(PQ)
except D
1
R1895
NM
ILMGND
0
NM
NM
2
6
0
R1892
NM
3
5
only D
R1893
4
R1890
Q1851
NM
R1891
ILMCLR
R1894
4
C1864
5
C1865
D
A DEH-14UB/XNUC
except D
F
B DEH-14UB/XNUC 5
6
7
8
43
1
2
3
4
10.3 CD CORE UNIT (S11.6STD) PICKUP UNIT(P10.6) (SERVICE) A
CXX3556 V3R3
2.4
4.7u/6.3 (2125)
C104
2.4 2.7 (1/10W)
(1/10SR,1608) R101 R102 R103 LD1
Q102 LTA123JUB
VCC TOP
TRK ACT
4
4
3
3
2
2
1
1
D101 NM TOM
C220
FOM
0.1u/10
C
RFI
TOP
82
R229
83
470
84
C217
R216
85
56p/50
1.2k
86
EQ1 RF2RFA.GND2 88 A.VDD2 89 A
BD
90
F
91
E
92
B F E 93
REFO
d
C229
0.1u/10
c
TE C225 TEC
C223
94
68p/50
95 FEO 96
ADCIN
C236
REFOUT FE-
FE
0.1u/10
R101 R102 R103 R246
ADCIN
C224
97
47p/50
98
TETEO 99
0.01u/16
100
C239
C104
CXE2273
TE2 TEC
2125:PARTS
M1 SPDL MOTOR
EQ2
C222 0.1u/10
NM
AC
RFO
87
C204
CKS4808-A
27p/50
E
F
BD
AC
TOP
FOP
FOM
TOM
81
RFO C228
NM
CN101
1608:PARTS C205 C209 C238 C240 C307 C308 C708
Land for manual soldering
C3T
C219 0.1u/10
AGCI
FOP
REFO2
*
AGCO 80
REFO1
NO MOUNT PARTS (NM)
A.GND1
79
1800p/50
RFAGC
C205
F.ACT: Applying positive voltage to FOP, the lens approaches DISC. T.ACT: Applying positive voltage to TOP, the lens moves outer circumference of DISC.
74
75 ATEST
f PD
LD
FOP
5
78
2
FOM
6
5
A.VDD1 77 C216
1
TOM
6
PD
NM
MD
AC
0.1u/10
5.6k
A+C
76 C221
4.7k
7
4p/50
7
F REFO
C218
8
VR
R218 R217
9
8
VREF
NM
9
P1+P6
E
C201
10
NM
11
10
EFM ATEST
NM
11
V+3A
BD V+3A
1M
12
R108
13
12
C101
GND
14
13
39 ASY
NM
P5+P10
14
R2
C110
VCC
15
C111
B+D
15
NM
C102 LD+
FOCUS ACT
LD
2SA1577(QR) 2.2k
LD-
HOLOGRAM UNIT
R109
C214
Q101
LD
B
R R R R
PUEN
0.047u/16
E:P5+P10 F:P1+P6
LD PD BLK SOM
Parts with Polarity IC201 IC301 D101 Q101 Q102 Q201
RED SOP
VDD
C202
D
C301 GND BL LCOM
YW
C312
5
LCOP NM
CSN1080-A 8SNS
S905 NM
FOP
7
FOM
8
TOM
9
2
8SNS
1
DSCSNS
2
S903
6
DSCSNS
10
TOP
CSN1081-A
DSCSNS SWITCHES: CD CORE UNIT (S11.6STD) S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH.....ON-OFF
C308
11
1u/10 (1608)
12 13
CLCONT LOEJ
4
CONT
MOTOR DRIVER LOGIC TABLE CLCONT LOEJ CONT
EJ
PLAY
OFF
H H L
H L L
L
L
H
L
VD
CLCONT
LOEJ
CONT
DEH-14UB/XNUC 1
LOAD
PGND
C 44
5
TD
The underlined indicates the switch position.
F
VDD 1
FD
C301
C306
14
SD
a9
NM
LCOM
4
NM
3
C313
2
SOP
MD
NM
SOM
NM
8
SIN SPIN 28 POWVCC CIN SLIN 27 SPOC315 BIAS 26 SPO+ FIN NM 25 TKIN SLLDOTIN FCIN 24 SLLDO+ CNT 23 POWGND LDIN 22 TKO- 29 GND 21 MUTE TKO+ PRTOUT 20 FCOPREGND 19 FCO+ 47k PRTLIM 18 R309 TKRNF PRTF 17 FCRNF 16 PRTT TKCDET PREVCC 15 FCCDET
C314
HOME
2
431
431 43 1
HOME
1
0.1u/10
HOME 3 S901
7
IC301 BD8223EFV
C307 1u/10 (1608)
E
CN702
ACTUATOR/ MOTOR DRIVER
CXC4026
2
3
2
LCOP
M2 LOAD/CRG MOTOR
4
PUEN
12k
12k R303
R304
SKIP
/CDSRQ
10k
Mask
51
LRCK0
/CDSRQ
/TESTIN
52
SKIP
53
55
54 /PUEN
/ADENA
VDCONT
56
57 VDSENS
58 TEMP
59 MONITOR_0
MONITOR_1
60
62
61 MONITOR_2
63 SD2
MONITOR_3
50
PC3
A.GND1
SDA
RFI
SCL
78 AGCO
8 0 7 0
81 82
R229
83
470
84
R216
85
TX/EMPH
SCKO
RF AMP, CD DECODER DIGITAL SERVO/DATA PROCESSOR CPU
DOUT PA7 LOEJ
RF2-
1.2k
86
CLCONT
RF87 A.GND2
IC201
A.VDD2
PE5791A
88
CONT DSCSNS
89
NC
A 90
EJSW
E 93
/CDSTBY
REFOUT
C223
94
ICECK
FE95
68p/50
FEO
IO.VDD1
ADCIN
IO.GND1
96 C224
97
47p/50
TE-
RESET
TEO
C.GND
98 99
C.VDD
TE2
NM
NM
C235
SCL C283 NM
R283
44 R281
0
56
43 R282
56
LRCK
56 R292
BCLK
C281
C282
0
NM
NM
R293
DATA
42
C284
0
41
NM
R202
0
LOEJ
40
R201
0
CLCONT
39
R264
1k
CONT
38
DSCSNS
37
8SNS
35
HOME EJSW
34 33
R245 R253
100k
NM
C
100k R240 47k
/CDSTBY ICECK
32
ICECK R297
31 C211
30
NM
0.1u/10
29
R237 C233
28 27
C210
26
0.1u/10
RESET
220
0.01u/16 R232
XTAL
VPP
X.GND
VPP CVDD CVDD
VDD2
C299 0.1u/10
VDD
VD2
RESET
VD1
SCL
SDA
SKIP
CDSRQ
CN701 CKS6146-A
I/O
VPP 9
SCK 7
ICECK 5
6
VD
/CDSRQ
VDD 1
CDSTBY
GND
NM CVDD 3
D
VDD1
3
(1608) NM C240
2
ICEMD
0.1u/10 0.1u/16 (1608)
0.1u/16 (1608)
CVDD
ICECK
VPP
X201 CSS1603-A
16.934 MHz
C209
10 GND
SCK
C238
SCK
NM 8 SI
6 SO
4
CN702
2
RESET
C202
C203
A0
STB
RST
INTQ
1
25
/XTAL
24 470
ICEMD
X.VDD
23 R294
22
DA.VDD
SDA R291
0
21
20
LOUT 19
REGC
DA.GND1
ROUT
DA.VDD1
DA.GND 18
17
16
15
14
REG16
REGS 13
D.GND
12
D.VDD
SI 9
SI
11
10
SO
SO 8 SCK
/SCK
A0
6
7
/STB
VPP
INTQ(INT1)
/RST
4
3
PD
LD
2
1
NM
C239
TEC
5
100
/WAIT
R254
HOME
F 92
0
36
12SNS
B 91
22
ADENA
BSCK0
45
LRCK
RFO
EQ1
56 470
B
ADENA
46
AGCI
EQ2
22
47
/WAIT
C3T
C219
56
48
80
0.1u/10
Flash 10k 22
49
79
1800p/50
0 56
0
C216
IO.GND2
IO.VDD2
A.VDD1 77
64
65
66
67 TD
FD
SD
68
70
71
69 MD
TEST
AD.GND
72
73 EFM
AD.VDD
75
74 ASY
ATEST 76
R232 R281 R282 R291 R294
GND
TESTIN
TEMP
TH201 NM
Q201 NM
ATEST
TEMP
R296
R260 C16M
MONI0
MONI2
b
MONI1
MDX
0.1u/10
(1608) R246
VDD
e
MDY
10k C215
R214
39k
EFM
ADENA
TEMP C212
C213
0.1u/10
GND
R215
ASY
A
CD CORE UNIT (S11.6STD)
4.7k
R306
4.7k 4.7k 4.7k 4.7k
3300p/50
C214
R308 4.7k
0.1u/10
8
PUEN
C305 0.022u/16
R310 R311 R312 R313
7
C
1000p/50 1000p/50
C304
0.047u/16
0
R307 1k
R305 SD 1k R302 TD
C302 C303
0 R301 FD
6
MD
5
/CDSTBY
R709 0
R706
SCL
R702
220
SKIP
100 R701
R708
SDA
0
100
RESET
1
VD
7.5V
2
VD
7.5V
3
/CDSRQ
4
/CDSTBY
5
SCL
6
SKIP
7
SDA
8
RESET
9
VDD
10 GND DATA
NM (1608)
C708
NM
C707
NM
C705
C710 1000p/50
GND
15 PGND
GND
16 WAIT
IIC-BUS Digital GND3
GND2
GND1
LRCK
WAIT
DATA BCLK
NM
NM C701
NM
NM C702
PGND
C703
L
NM
L
H
R710
L
R711
H L L
14 GND
i h g F PGND2
OFF
13 LRCK
/WAIT
PGND1
PLAY
CN701
GND
12 BCLK
LRCK
J
3.3V
E
11 DATA
BCLK
LOGIC TABLE
A
C DEH-14UB/XNUC 5
6
7
8
45
1
2
3
4
10.4 WAVEFORMS - CD CORE UNIT(S11.6STD)
A
1DSCSNS 3HOME 4LOEJ
5 V/div 5 V/div 5 V/div
Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V)
500 ms/div
1DSCSNS 5CLCONT 4LOEJ 6VD1
5 V/div 5 V/div 5 V/div 10 V/div
12 cm CD Loading operation
12 cm CD Loading operation
Ref.: GND
Ref.: GND
Mode: Normal
Mode: Normal
500 ms/div
B
7SIN 8CIN 9TIN
aFIN 200 mV/div 500 ms/div bRFOK(MONI_2) 2 V/div 7SIN 2 V/div
cTE dFE
12 cm CD-DA setup operation after loading
12 cm CD-DA Source On setup operation
Source On setup operation
Ref.: REFO
Ref.: REFO
Ref.: REFO
Mode: Normal
Mode: Normal
Mode: Normal
1 V/div 500 mV/div 500 mV/div
1 s/div
500 mV/div 200 ms/div 500 mV/div
C
dFE aFIN cTE 9TIN
D
E
500 mV/div 500 mV/div 500 mV/div 500 mV/div
46
eMDX 7SIN
2 V/div 50 ms/div 500 mV/div
eMDX 7SIN
5 μs/div
2 V/div 500 mV/div
CD-DA Play operation
Spindle waveform during play operation
Spindle waveform during play operation (Wider)
Ref.: REFO
Ref.: REFO
Ref.: REFO
Mode: Normal
Mode: Normal
Mode: Normal
aFIN dFE
F
20 ms/div
500 mV/div 200 ms/div 500 mV/div
cTE fRFAGC
500 mV/div 500 mV/div
2 ms/div
fRFAGC cTE 9TIN
1 V/div 500 μs/div 500 mV/div 500 mV/div
Focus Search waveform
Track Open waveform
100 Track Jump waveform (32 Track Jump x 3)
Ref.: REFO
Ref.: REFO
Ref.: REFO
Mode: TEST
Mode: TEST
Mode: TEST
DEH-14UB/XNUC 1
2
3
4
5
fRFAGC cTE 9TIN
6
1 V/div 500 mV/div 500 mV/div
2 ms/div
fRFAGC cTE 8CIN 7SIN
7
1 V/div 200 ms/div 1 V/div 500 mV/div 2 V/div
8
gLRCK 2 V/div hBCLK 2 V/div iDOUT(DATA) 2 V/div
32 Tracks Jump waveform (Zoom of 100 Track Jump waveform)
Search operation(Outter to Inner)
Digital Out waveform
Ref.: REFO
Ref.: REFO
Ref.: GND
Mode: TEST
Mode: Normal
Mode: Normal
1DSCSNS 5CLCONT 4LOEJ
5 V/div 5 V/div 5 V/div
1DSCSNS 3HOME 4LOEJ
500 ms/div
B
5 V/div 5 V/div 5 V/div
12 cm CD Eject operation
12 cm CD Eject operation
Ref.: GND
Ref.: GND
Mode: Normal
Mode: Normal
fRFAGC 9TIN cTE aFIN
1 V/div 1 V/div 1 V/div 1 V/div
A
10 us/div
500 ms/div
C
500 μs/div
Black Dot (800 μm) during play
D
Ref.: REFO
Mode: Normal
E
F
DEH-14UB/XNUC 5
6
7
8
47
1
2
3
4
11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP UNIT
> P 251 (A,7,128) Fuse 3 A
W. REM JA892
6
C313 C254
1
C253
D503
C510
C505
C503 R501 C502 R502
R504 R503 R506
C507
C334 R334 R332
D502
C261
120
15
C316
C251
1
IC301 5
VA893
C252
R252
1
R891
10 1
C308
Q251
R892
C306
4
VA891
C302
1
C307
Q252
R258 C258 R254 R251 C255 R255
P251
R259
SIDE B
R253 C257 R257
C260
Chip Part
5
C259 VA894
130 P.C.Board
2
JA891
C304
SIDE A
3
C892
3
2
C305
5
C891 1
C301
6
JA251
C303
REAR OUTPUT 4
B
CEK1286
150
140
Capacitor
Connector
TUNER AMP UNIT
C331 R331 R333 C333
A
C314 C317
1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams
VA892
NOTE FOR PCB DIAGRAMS
R256 C256
A
5
C508 IC501
R507
C506 R505 D501
C514
1
110
C509
L501
1
100
C
90
80
70 D
60
50
40
C
E
CN701
30
20
10 F
B
Y
48
FRON 0
A
X 10
20
30
40
50
60
DEH-14UB/XNUC 1
2
CN1821
3
4
70
80
5
6
7
8
A
SIDE A CEK1286
POWER SUPPLY 10
14
D302
9
13
16
D301
C312
C351
1 Q752 R753
D954
C318
C901
ANTENNA
R301 D902
Q301
R952 R951
D951
C513
C512
IC510 1
D875
R419
C615
C458
C417
60 55 50 L414
L413
R429
L416 C437 R421
D873
C238
C613
D871
D911
D
D912
C636
R231 R232
L231
C233
R639
C634
C239 C922
C231
C928 L601 C924
C929
C912
C911 C920 C916 C918
C914 C917
C921 R721
R912
C913
R911
C926
C923
C919 C915 IC912
5
E
1
D874 R882
R883
C511
D872
R410 R415 C612
C611
C622 R621
C630
C635
C637
C638
R632
R703 C701
IC231 1 5
10
R716
C872 R871
L602 R640
R718 R719 R720
C705 C706
10
15
C925
C632
E Q873
C235
C232
R628 D602
R630
C624
C871
C237 C620
R619 1
70
R631 C623
C438 C439
R562
R605 C601
R641
R627
C626 R626 C625
R620
C621
C651
D651
R637 R623 C628
C627
X602 1
C633
65
E
X601 1
R618
R873
C873
E
C234
C429 L419
Q872 1
R885
R874
Q871
R614 R616
C428 1 X401
R881
R601
R603 R962
R968 R651
60
R876 R875
C704
R412
C552 R557
R558
20
R559 R552 R553 R560 R561
C967 R970
C964
C963
10 5 1 15 10 5
55
R633
R717
1
75
C707 C708
80
50
R752
R751 R707 R701 R708 R709 R710 R711 R712 R702
R617 C619
R880
Q874 R420
R611
C617
C426
C435 C431 C432 L412
C442 C441
L415
R613
L408 C425 C424
45
R417
R634 C609 R609
85
CN701
R713 R714 R715
45
R625 R636 R622 R624
R704 1
40
C440
C436
C607
90
L701
40 R629 C631 C629
35
C447
C
L407
R409
R877 C605
95
1 IC651
35
R966 1 C652
IC401
R427
R430 R418 R416
110
30
C702
115
25
C618
R964 R642
120
IC601
20
R508 C616
R201
C703
125
15
C610
C614 R615
130
100
R608 C608
R610
135
10
L961
C965
140
105
R607
D961
L671
C602 R414
C604
R433 C454 C434 L411 R428
C433
5
C970
D601
C603
1
C606
C422
L410
R602
R604
C671
R402
C419
R408 C452 C427 C457 C455
5
R612
C969
CN961
1 R671
1
R965
15
R972 C961 L962
C710 C709
5
C966
5
IC961
R963
1
1
R969
R672
L401 C406 C409
D402 C448
30
C962
C421 L409
E R556
IC671
R691 C968 R967
C423
C449
C410
R434
C420 R407
25
R971
R961
10
R973
Q551
C413 C446
20
KN601
R406
C430
R551 C551
C418
IC551
R413
C415 C445 R405
C412
R401 C403
C402
C416
R403
L404
C414
L405
R431
C456 C450 C404 L402
C214
L406
L551
C443 L403
C444
C213
R432 P401 C401 D401
L420
L418
C411 C405 C407
C951
C408
R934
D952
Q931
C451
L417
5 C952
E
C931 R933
R941
C209
C217 C207
C205
C211
R205
L201
IC951 1
R932
Q941 C202
10
D931
E
1
1
R931
10 C204
KN401
C927 Q951
Q953
Q952
R942
5
R943
1
C215 C203
IC201
R206
1
L941
15
C201
20
E
E
D941
R207
JA401
C210
C206
D901
R879
1
18 17
R878
R352
R304 R302 R303
1
B C319
R351
R353 Q351 1
C212 C216 C208
C311
6
5
C315
C308
C306 C302
C307
2
1
15
C310
C334 R334 R332 C332
C304
C305 C301
C303
C331 R331 R333 C333
E
C320
15
3
Q751 C309 D751 C754 R754
10
6
L901
JA901
C753 C751
C321 25
15
FUSE
20 IC301
5
10 5
1
A
R884 D876
R872
C851
CN1821
80
D804
D806
D803
D802
D805 C812
R817 R816
1
D807 D801
D810 R804
D808
L801
R811
R814 1
C809
5
C818
15 10
20
F
CN801
FRONT 70
R813
C810
D811
C817
R851 D809
C811
C803
C801
R818
R802
R815
C808
R807
R801
R806
IC801 15
R812
R805
R809
R803
L851
R808
C802
R810
C852
90
100
110
120
130
140
DEH-14UB/XNUC 5
6
A
160
150 7
8
49
1
2
3
4
A
A
TUNER AMP UNIT
1
B
1
C
PCL
D
TESTIN 1
E
1
1
F
A 50
160
150
140
130
120
110
100
90
DEH-14UB/XNUC 1
2
3
4
80
5
6
7
8
A
SIDE B
150
1
140 1
1
130
B
120
110
100
C
90
80
70 D
60
50
40 E
30
20
10 F
Y 90
80
70
60
50
40
30
20
10
DEH-14UB/XNUC 5
6
X 7
0
A 8
51
B
52
1
2
0
D1876
20
30
40
D1859 D1878
50
C1859
D1858 D1877
C1853 D1879 D1856 C1856
3
60
70
2
80
S1825
D1881 D1861
90
3 S1831
D1883 D1863 C1863
110
5
120
S1839
10
130
S1830
6
5
1
S1824
CLOCK
140
D1885 D1865 C1865
D1882 D1862
100
C1862
4 S1835
15
4
3
AUX
JA1921
150
1
USB
CN1911
2
160
A
10
1
S1836
D
BAND /ESC
20
B
D1857
X
S1837
S1838
V1801
SEGMENT LCD
25
2
Y
D1873
D1866
30
6
S1841
C1855 S1834
D1855
35
5
DISP /BACK
S1833
RIGHT
40
4
S1822
S1842
5
S1827
3
C1857 S1840
D1851 D1871
LEFT
1
SRC
D1872
2
D1874
C1851
D1853
S1821
ROTARY COMMANDER
C1852 D1852 S1826
1
10
EQ
S1829
C
S1823
LIST
IC1802 1
20
30
C1854
D1875
E
S1828
S1832
D1854
B
40
F
EJECT
1 3 4
11.2 KEYBOARD UNIT KEYBOARD UNIT SIDE A
D1884 D1864 C1864
C1861
C1860 D1860 D1880
C1858
DEH-14UB/XNUC
4
C1912
19
15
CN1821
5
1
C1802
L1801
2
55 1
60
10
50
20
5
45
R1805 R1806 R1803
1
L1911 R1823
C1922
90
IC1801
10
15
80
X1801
R1824
D1802 1 R1801 R1892 R1802
70
1
D1801 1
R1874
60
R1825 R1821 R1822
R1863 R1856
R1853
50
40
30
R1887
R1861
R1889 R1888
R1871
R1881
R1862
R1864
R1854
R1883
R1873
R1852
R1851
20
10
F
X
0
10
20
30
40
B
Y
8
53
DEH-14UB/XNUC
C
100
R1855
CN801
A 110
R1872
R1804
D1911 D1912 C1911
VA1921 VA1922
VA1923 C1923 VA1924
120
R1885
D R1893 Q1851 R1894
B
130
R1891 R1895
30 25 20
C1801
1
R1867
140
R1882 R1875
R1826 R1859 R1884 R1866
R1876
40
1
150
C1921
35
A
160
R1860 R1857
1 R1890
R1858
7
6
5
SIDE B
KEYBOARD UNIT
B
8 7 6 5
R1886
R1865
E
1
2
3
4
11.3 CD CORE UNIT (S11.6STD)
C
CD CORE UNIT (S11.6STD)
SIDE A
A
PICKUP UNIT(P10.6)(SERVICE)
60 B
CN101 15
10
5
1
R246
R232
M2 LOADING/CARRIAGE MOTOR
R254
TH201 C235
1
HOME
C102
S901
C201
50
D101
CN702
R253 R245
1 5
10
F E
C238
C
R706
C240 C205
C710 R297
C299
40 C707 R701
C220
C705 R702
M1 SPINDLE MOTOR 30 D
CN701 15
10
5
A
1
CN701 C702
20
C307 R710 C701
C308
C312
E
R306 R303 R304
R201 R308
REFO1 10
5
1
IC301
10 R307 R305 R301 R302
R264 R202
15
20
25
C306 R309
Y
0 F
X
10
20
30
40
50
C 54
DEH-14UB/XNUC 1
2
3
4
5
7
8
CD CORE UNIT (S11.6STD)
SIDE B A
60
R101
R103
R102
C104
B
Q102 R108
Q101 E
C202 E X201 1
50
R109
R294 C203
C239
C209 15
20
25
R240
90 85
R291
C218 R218
R216 R229
C219 45
C283
R292
C204 C222
IC201
40
C281 C282
C301
40
R293 R282 R283 R281
35
C284
95
E
C
C223
80
Q201
30
C211
C101 C111 C236 C229
R296
C110
C224 100
10
C210
5
C233 R237
C225 1
C
6
C217 C228 R217
C216 C221
50 55
60
65
70
75
30 R215 R214
C215
C212
R709 R708
R260
D S905
C708
1
C214 C213
20
E
R711 C703
1 C305 C304 C302 C303
C313 C314 C315
R313 R312 R311 R310
DSCSNS 10
S903
Y
0 50
40
30
20
10
F
X
C DEH-14UB/XNUC 5
6
7
8
55
1
2
3
4
12. ELECTRICAL PARTS LIST A
B
NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No.
C
D
Circuit Symbol and No.
Part No.
A:DEH-14UB/XNUC B:DEH-1450UB/XNES C:DEH-1450UB/XNES1 D:DEH-1450UBG/XNES E:DEH-1490UB/XNID Unit Number : QWM3319(A) : QWM3320(B,C,D,E) Unit Name : Tuner Amp Unit Unit Number : (A,B,C,E) : (D) Unit Name : Keyboard Unit Unit Number : CWX4023 Unit Name : CD Core Unit (S11.6STD)
A Unit Number : QWM3319(A) Unit Name
: QWM3320(B,C,D,E) : Tuner Amp Unit
E
MISCELLANEOUS
F
IC 201 IC 231 IC 301 IC 401 IC 501
(A,98,112) (A,144,57) (A,78,141) (A,150,90) (A,20,113)
IC 510 IC 601 IC 651 IC 671 IC 801
(A,107,30) IC BD2232G-G (A,118,65) IC R5S7266ZD144FP (A,98,53) IC S-80827CNMC-B8M (A,126,85) Flash ROM Unit(A) PEB035A8 (A,126,85) Flash ROM Unit(B,C,D,E) PEB034A8 (A,108,19) L-MOS And Gate TC7SET08FUS1
IC 912
(A,145,28) IC
56
IC D/A Converter IC IC IC
PML022A PCM1753DBQ PA2030A TDA7706 BD9008F
BA49182-V12
Part No.
Q Q Q Q
251 351 751 752
(A,23,130) Chip Transistor RN1910 (A,88,127) Chip Transistor RN4983 (A,142,138) Transistor 2SD2396 (A,140,133) Chip Transistor RN4983
Q Q Q Q D
871 872 873 931 301
(A,146,69) Transistor (A,161,76) Chip Transistor (A,159,73) Transistor (A,118,104) Transistor (A,100,126) Diode
2SD1767 RN4983 LTC143EUB LSC4081UB CRG03
D D D D D
302 401 402 501 502
(A,96,126) Diode (A,158,106) Diode (A,158,99) Diode (A,29,109) Diode (A,20,124) Diode
CRG03 KP2311E KP2311E RB160L-40 CRG03
D D D D D D D
503 601 602 751 801 802 803
(A,20,122) Diode (A,117,81) Diode(B,C,D,E) (A,127,50) Diode(B,C,D,E) (A,138,134) Diode (A,114,13) Diode (A,117,12) Diode (A,121,12) Diode
CRG03 RB551V-30 RB751S-40 RKZ8.2KG(B2) DZ2S068C DZ2S068C DZ2S068C
D D D D D
804 809 810 811 872
(A,126,12) Diode (A,96,14) Diode (A,108,14) Diode (A,102,14) Diode (A,154,76) Diode
DZ2S068C DZ2S068C DZ2S068C DZ2S068C RKZ7.5KG(B2)
D D D D D
901 902 911 912 931
(A,139,125) Diode (A,136,125) Diode (A,158,65) Diode (A,162,65) Diode (A,116,107) Diode
1SR154-400 1SR154-400 1SR154-400 1SR154-400 HZU7L(A1)
L L L L
401 402 403 404
(A,159,102) Chip Coil LCTAWR15J2520 (A,151,101) Inductor CTF1786 (A,146,102) Inductor CTF1786 (A,155,103) Chip Coil(A) LCTAWR27J2520 (A,155,103) Chip Coil(B,C,D,E) LCTAWR39J2520 (A,142,103) Inductor(A) CTF1389
L 405 L 406
(A,139,101) Inductor(A) LCTAW220J2520 (A,139,101) Chip Coil(B,C,D,E) LCTAW1R5J2520 (A,162,95) Inductor CTF1786 (A,162,94) Inductor CTF1786 (A,137,93) Chip Coil(A) LCTAW470J2520
L 407 L 408 L 409
DEH-14UB/XNUC 1
2
3
4
5
6
Circuit Symbol and No.
7
Part No.
(A,137,93) Inductor(B,C,D,E)
Circuit Symbol and No.
LCTAW2R2J2520
L L L L
415 417 418 420
(A,146,81) Inductor CTF1786 (A,138,107) Chip Coil(B,C,D,E,) LCTAWR39J2520 (A,142,105) Chip Coil(B,C,D,E) LCTAWR27J2520 (A,145,106) Inductor(A) LCYB68NJ1608
L L L L
501 671 801 901
(A,34,109) Coil CTH1475 (A,131,81) Inductor CTF1786 (A,116,15) Inductor CTF1713 (A,112,140) Choke Coil 600 uH CTH1432
X 401 X 601 X 602 > P251 P 401
(A,161,87) Oscillator 36.48 MHz CSS1805 (A,134,59) Ceramic Resonator 16.934 MHz CSS1603 (A,114,49) Oscillator 12 MHz YSS5005 (A,7,128) Fuse 3 A CEK1286 (A,155,108) Surge Protector IMSA-6802-01Y900
CN701 CN801 JA251 JA401 JA892
(A,92,38) Connector VKN1192 (A,109,3) Connector CKS6288 (A,19,137) Pin Jack CKB1056 (A,158,128) Antenna Jack YKS5041 (A,42,138) Connector(B,C,D,E) CKS4124
JA901
(A,113,140) Plug Fuse(10 A)
>
CKM1586 YEK5001
RESISTORS
8
Part No.
R R R R
433 434 501 502
(A,141,90) (A) (A,144,97) (B,C,D,E) (A,22,119) (A,24,117)
RS1/16SS0R0J RS1/16SS0R0J RS1/10SR471J RS1/16SS4702F
R R R R R
503 504 505 506 508
(A,22,117) (A,20,119) (A,27,113) (A,15,114) (A,104,64)
RS1/16SS682J RS1/16SS1002F RS1/16SS183J RS1/16SS513J RS1/16SS103J
R R R R R
601 602 603 604 607
(A,116,83) (A,114,80) (A,115,83) (A,104,76) (A,104,70)
RS1/16SS103J RS1/16SS473J RS1/16SS104J RAB4CQ473J RS1/16SS473J
R R R R R
608 609 610 611 612
(A,104,69) (A,132,66) (A,103,65) (A,139,64) (A,106,76)
RS1/16SS473J RS1/16SS101J RS1/16SS222J RS1/16SS101J RS1/16SS473J
R R R R R
613 615 617 619 620
(A,142,64) (A,103,63) (A,132,62) (A,135,55) (A,105,57)
RS1/16SS101J RS1/16SS104J RS1/16SS221J RAB4CQ473J RS1/16SS473J
R R R R R
621 622 623 624 626
(A,131,52) (A,106,50) (A,113,51) (A,108,50) (A,121,51)
RS1/16SS473J RS1/16SS473J RS1/16SS152J RS1/16SS473J RS1/16SS5601F
R R R R R
201 231 232 251 252
(A,100,59) (A,147,56) (A,148,56) (A,19,130) (A,29,131)
RAB4CQ102J RS1/16SS821J RS1/16SS821J RS1/16SS821J RS1/16SS821J
R R R R R
255 256 303 304 331
(A,21,130) (A,26,130) (A,86,122) (A,86,125) (A,74,125)
RS1/16SS223J RS1/16SS223J RS1/16SS103J RS1/16SS473J RS1/16SS471J
R R R R R R
628 629 630 631 632 633
(A,127,51) (A,106,54) (A,125,50) (B,C,D,E) (A,125,52) (A,121,43) (A,117,43)
RS1/16SS103J RS1/16SS102J RS1/16SS473J RS1/16SS473J RS1/16SS103J RS1/16SS101J
R R R R R
332 333 334 351 352
(A,81,125) (A,75,125) (A,80,125) (A,91,127) (A,90,127)
RS1/16SS471J RS1/16SS471J RS1/16SS471J RS1/16SS103J RS1/16SS103J
R R R R R
636 642 651 671 672
(A,109,51) (A,92,53) (A,101,53) (A,131,86) (A,126,91)
RS1/16SS473J RS1/16SS473J RS1/16SS104J RS1/10SR473J RS1/10SR473J
R R R R
353 401 402 403
(A,91,128) (A,161,106) (A,161,99) (A,139,103) (A) (A,139,103) (B,C,D,E) (A,142,99)
RS1/16SS221J RS1/16SS221J RS1/16SS751J RS1/16SS152J RS1/16SS331J RS1/16SS105J
R R R R R
701 702 703 704 707
(A,97,43) (A,97,37) (A,99,41) (A,97,47) (A,97,44)
RS1/16SS473J RS1/16SS104J RS1/16SS104J RAB4CQ472J RS1/16SS221J
RS1/16SS471J RS1/16SS361J RS1/16SS330J RS1/16SS681J RS1/16SS391J RS1/4SA8R2J RS1/4SA8R2J
R R R R R
708 709 710 711 712
(A,97,42) (A,97,41) (A,97,40) (A,97,39) (A,97,38)
RS1/16SS221J RS1/16SS101J RS1/16SS221J RS1/16SS101J RS1/16SS102J
R 410 R 412
(A,137,96) (A,137,96) (A,139,95) (A,138,91) (A,138,91) (A,136,79) (A,137,84)
R R R R R
(A,145,107) (A,139,70) (A,141,70) (A,153,79) (A,142,84)
RS1/16SS105J RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS102J
R R R R R
713 714 715 716 717
(A,97,35) (A,97,34) (A,97,33) (A,96,31) (A,97,32)
RS1/16SS151J RS1/16SS151J RS1/16SS151J RS1/16SS221J RS1/16SS104J
(A,139,86) (A,137,104) (A)
RS1/16SS0R0J RS1/16SS0R0J
R R R R R
751 752 753 801 802
(A,97,45) (A,99,45) (A,143,133) (A,121,18) (A,124,18)
RS1/16SS473J RS1/16SS103J RS1/10SR821J RS1/10SR101J RS1/10SR101J
R 405 R 406 R 407 R 408
413 419 420 421 427
R 428 R 431
(A) (B,C,D,E) (A) (B,C,D,E)
DEH-14UB/XNUC 5
6
7
8
A
B
C
D
E
F
57
1
Circuit Symbol and No.
A
B
C
2
3
Part No.
R R R R R
803 804 805 806 807
(A,102,18) (A,109,14) (A,117,18) (A,118,18) (A,125,18)
RS1/10SR222J RS1/10SR222J RS1/10SR8R2J RS1/10SR8R2J RS1/10SR222J
R R R R R
808 809 810 814 815
(A,100,18) (A,104,18) (A,99,19) (A,105,11) (A,123,18)
RS1/10SR222J RS1/16SS822J RS1/10SR222J RS1/10SR0R0J RS1/10SR101J
R R R R R
816 817 818 851 871
(A,124,16) (A,121,16) (A,127,18) (A,96,16) (A,151,65)
RS1/16SS223J RS1/16SS223J RS1/10SR222J RS1/16SS472J RS1/10SR222J
R R R R R R R
873 876 879 880 884 891 892
(A,163,72) (A,124,40) (A,155,73) (A,154,72) (A,122,28) (A,54,133) (B,C,D,E) (A,58,136) (B,C,D,E)
RS1/4SA151J RS1/16SS0R0J RS1/10SR473J RS1/10SR181J RS1/16SS1R0J RS1/10SR102J RS1/10SR102J
R R R R R
911 912 931 932 933
(A,140,40) (A,144,41) (A,121,105) (A,118,106) (A,115,106)
R 934
(A,115,113)
E
F
307 308 309 310 311
(A,76,131) (A,79,131) (A,135,134) (A,83,128) 2.2 uF (A,82,131) 2.2 uF
CKSRYB474K10 CKSRYB474K10 CKSRYB104K16 CCG1205 CCG1205
C C C C C
312 313 351 401 402
(A,98,127) (A,67,128) (A,93,127) 10 uF (A,155,106) (A,158,104)
CKSRYB104K16 CEVW100M16 CCG1192 CCSSCH330J50 CCSSCH6R0D50
C C C C C C
403 404 405 406 407 408
(A,161,104) (A,150,100) (A,147,99) (A,160,101) (A,148,100) (A,141,107) (B,C,D,E)
CKSSYB103K16 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CCSSCH150J50
C C C C C
409 410 411 412 413
(A,162,101) (A,148,98) (A,145,100) (A,144,100) 10 uF (A,155,101)
CKSSYB103K16 CKSSYB103K16 CKSSYB103K16 CCG1192 CKSSYB103K16
RS1/10SR1R0J RS1/10SR1R0J RS1/16SS223J RS1/16SS473J RS1/16SS472J
C C C C C
414 415 416 417 418
(A,152,102) (A,141,99) (A,159,96) (A,160,95) (A,139,98) 10 uF
CKSRYB105K10 CKSSYB103K16 CKSRYB224K16 CKSSYB104K10 CCG1192
RS1/4SA102J
C 419 C 420 C 421 C 422 C 423
(A,158,93) (A,139,96) (A,137,95) (A) (A,137,95) (B,C,D,E) (A,140,92) (A,136,95)
CKSRYB105K10 CKSSYB104K10 CCSSCH101J50 CCSSCH220J50 CKSSYB104K10 CKSSYB103K16
C 428
(A,162,91) (A,162,92) (A,158,90) (A,138,90) (A) (A,138,90) (B,C,D,E) (A,161,89)
CKSSYB472K25 CKSSYB472K25 CKSSYB104K10 CCSSCH820J50 CCSSCK2R0C50 CCSSCH9R0D50
C C C C
429 430 431 432
(A,161,84) CCSSCH9R0D50 (A,139,85) (A) CKSRYB474K10 (A,158,84) (A) CKSSYB104K10 (A,157,82) 2.2 uF(B,C,D,E) CCG1205
C C C C
433 437 439 440
(A,140,83) (B,C,D,E) (A,156,81) (A,145,79) (B,C,D,E) (A,147,82)
CKSSYB104K10 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10
C C C C C C C
441 443 444 445 447 452 455
(A,152,81) 2.2 uF (A,145,104) (B,C,D,E) (A,139,104) (B,C,D,E) (A,142,101) (A,142,85) (A,134,90) (A) (A,137,88) (A)
CCG1205 CKSSYB103K16 CCSSCH8R0D50 CKSSYB223K16 CKSSYB102K50 CKSSYB105K6R3 CCSSCH100D50
C C C C C
457 458 503 505 506
(A,139,89) (A) (A,148,107) (A) (A,32,119) (A,11,119) Capacitor (A,27,114)
CKSSYB105K6R3 CCSSCJ3R0C50 CEVQW221M6R3 CEVW221M16 CKSSYB153K16
(A,26,114) (A,24,109)
CCSSCH220J50 CKSRYB105K16
C C C C C
201 202 203 204 205
(A,106,108) 10 uF (A,100,105) (A,103,108) 4.7 uF (A,100,106) (A,93,105)
CCG1192 CCSSCH100D50 CCG1201 CCSSCH100D50 CKSRYB105K10
C C C C C
206 207 208 209 210
(A,93,118) (A,97,106) (A,97,118) (A,99,106) (A,99,118)
CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10
C C C C C
211 212 215 232 233
(A,94,104) (A,95,118) (A,102,107) (A,144,52) (A,149,54) 10 uF
CKSRYB105K10 CKSRYB105K10 CCSSCH100D50 CKSSYB103K16 CCG1192
C C C C C
234 237 238 239 251
(A,146,63) 10 uF (A,148,60) (A,150,61) (A,147,58) (A,31,129) 4.7 uF
CCG1192 CCSRCH182J50 CCSRCH182J50 CKSSYB102K50 CCG1201
C C C C C
252 255 256 259 301
(A,35,130) 4.7 uF (A,20,130) (A,28,130) (A,33,135) (A,74,128)
CCG1201 CCSSCH101J50 CCSSCH101J50 CKSSYB102K50 CKSRYB474K10
C C C C C
302 303 304 305 306
(A,81,128) (A,76,128) (A,79,128) (A,74,131) (A,81,131)
CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10
58
Part No.
C C C C C
CAPACITORS
D
4
Circuit Symbol and No.
C C C C
424 425 426 427
C 508 C 509
DEH-14UB/XNUC 1
2
3
4
5
6
Circuit Symbol and No. C 510 C 512 C 601
(A,40,121) (A,113,29) (A,121,78)
CKSRYB105K10 CKSRYB105K10 CKSSYB104K10
C C C C C
602 603 604 605 606
(A,118,78) (A,114,78) (A,106,73) (A,131,72) (A,104,72)
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
607 608 609 610 612
(A,132,71) (A,106,67) (A,132,67) (A,105,66) (A,136,66)
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
616 617 618 619 620
(A,105,62) (A,133,63) (A,104,60) (A,132,61) (A,138,58)
CKSSYB104K10 CCSSCH100D50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
621 622 623 624 625
(A,106,57) (A,130,52) (A,124,51) (A,123,50) (A,122,51)
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
626 627 628 629 630
(A,120,51) (A,118,51) (A,114,51) (A,108,52) (A,128,52)
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
632 633 638 651 671
(A,115,47) (A,113,47) (A,122,43) (A,105,53) (A,131,83)
CCSSCH120J50 CCSSCH120J50 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10
C C C C C
701 751 754 808 809
(A,100,41) (A,147,131) 10 uF (A,141,135) (A,113,18) (A,125,9)
CKSSYB103K16 CCG1192 CKSSYB104K10 CKSRYB104K16 CKSRYB104K16
C C C C C
810 811 812 817 818
(A,100,15) (A,98,13) (A,123,12) (A,108,17) (A,124,6)
CCSRCH221J50 CCSRCH221J50 CKSRYB105K16 CKSSYB104K10 CKSRYB104K16
C C C C C C C
871 872 891 892 901 913 914
(A,158,75) (A,153,66) (A,34,139) (B,C,D,E) (A,50,138) (B,C,D,E) (A,133,124) 3 300 uF/16 V (A,141,40) (A,141,42) 4.7 uF
CKSSYB104K16 CKSRYB105K16 CKSRYB104K16 CKSRYB104K16 CCH1732 CKSSYB102K50 CCG1201
C C C C C
916 917 918 919 920
(A,150,41) (A,138,40) (A,153,42) (A,144,39) (A,147,42)
CCG1201 CCG1201 CCG1201 CKSSYB102K50 CCG1201
C 921 C 922 C 923 C 926 C 931
4.7 uF 4.7 uF 4.7 uF 4.7 uF
7
Part No.
(A,133,39) CKSRYB104K16 (A,157,54) (A) CEAT102M16 (A,157,54) 1 000 uF/16 V(B,C,D,E)CCH2024 (A,154,40) CKSSYB102K50 (A,133,41) CKSRYB102K50 (A,114,105) CKSRYB104K16 6
Part No.
B Unit Number : (A,B,C,E) Unit Name
A
: (D) : Keyboard Unit
MISCELLANEOUS IC 1801 IC 1802 D 1851 D 1852 D 1853
(B,85,23) IC (A,B,C,D,E) (A,159,36) Remote IC (A,16,30) LED(D) (A,53,30) LED(D) (A,16,20) LED(D)
PD6581A GP1UXC14RK SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)
D D D D D
1854 1855 1856 1857 1858
(A,6,41) LED(D) (A,55,20) LED(D) (A,62,5) LED(D) (A,7,19) LED(D) (A,16,10) LED(D)
SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)
D D D D D
1859 1860 1861 1862 1863
(A,52,10) LED(D) (A,74,5) LED(D) (A,87,5) LED(D) (A,100,5) LED(D) (A,113,5) LED(D)
SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)
D D D D D
1864 1865 1866 1871 1872
(A,125,5) (A,138,5) (A,63,21) (A,14,30) (A,54,31)
D D D D D
1873 1874 1875 1876 1877
(A,52,20) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,19,20) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,9,41) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,8,19) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,14,10) LED(Red) (A,B,C,E) SML-D12V8W(PQ)
D D D D D
1878 1879 1880 1881 1882
(A,51,10) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,63,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,76,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,89,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,101,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ)
D D D X S
1883 1884 1885 1801 1842
(A,114,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,126,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,139,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (B,74,22) Ceramic Resonator 5.00 MHz CSS1547 (A,36,20)Encoder(ROTARY COMMANDER) CSD1168
CN1821 CN1911 JA1921 V 1801
B
C
LED(D) SML-D12P8W(KL) LED(D) SML-D12P8W(KL) White LED SMLXA4WBETW1(Z1) LED(Red) (A,B,C,E) SML-D12V8W(PQ) LED(Red) (A,B,C,E) SML-D12V8W(PQ)
(B,108,9) Connector (A,154,22) Connector (A,153,7) Jack (A,138,32) Segment LCD
CKS6287 CKS6267 CKN1090 CAW2018
D
E
RESISTORS R R R R R
1801 1802 1803 1822 1823
(B,73,19) (B,73,17) (B,144,29) (B,54,24) (B,131,19)
RS1/10SR222J RS1/10SR222J RS1/10SR101J RS1/10SR273J RS1/10SR0R0J
R R R R
1824 1851 1852 1853
(B,69,26) (B,18,27) (D) (B,18,22) (D) (B,48,16) (D)
RS1/10SR0R0J RS1/4SA681J RS1/4SA681J RS1/4SA681J
DEH-14UB/XNUC 5
8
Circuit Symbol and No.
7
8
F
59
1
2
Circuit Symbol and No.
A
B
3
Part No.
(B,17,16) (D)
RS1/4SA561J
R 264
(A,22,9)
RS1/16SS102J
R R R R R
1856 1857 1858 1859 1860
(B,48,12) (D) (B,56,10) (D) (B,140,18) (D) (B,57,16) (B,55,16)
RS1/4SA681J RS1/4SA681J RS1/4SA681J RS1/4SA221J RS1/4SA221J
R R R R R
281 282 283 291 292
(B,33,38) (B,33,39) (B,35,38) (B,33,34) (B,33,36)
RS1/16SS560J RS1/16SS560J RS1/16SS0R0J RS1/16SS560J RS1/16SS0R0J
R R R R R
1871 1872 1873 1874 1875
(B,14,26) (B,51,16) (B,17,20) (B,61,10) (B,52,10)
RS1/4SA681J RS1/4SA821J RS1/4SA561J RS1/4SA821J RS1/4SA102J
R R R R R
293 294 296 301 302
(B,35,39) (B,27,48) (B,34,43) (A,27,9) (A,28,9)
RS1/16SS0R0J RS1/16SS471J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J
R R R R
1876 1889 1894 1895
(B,142,18) (A,B,C,E) (B,23,9) (D) (B,65,16) (D) (B,69,17) (A,B,C,E)
RS1/4SA102J RS1/10SR0R0J RS1/10SR0R0J RS1/10SR0R0J
R R R R R
303 304 305 306 307
(A,27,11) (A,28,11) (A,26,9) (A,26,11) (A,25,9)
RS1/16SS123J RS1/16SS123J RS1/16SS102J RS1/16SS472J RS1/16SS102J
R R R R R
308 309 310 311 312
(A,25,11) (A,35,6) (B,30,9) (B,30,10) (B,30,11)
RS1/16SS472J RS1/16SS473J RS1/16SS472J RS1/16SS472J RS1/16SS472J
R R R R R
313 701 702 706 708
(B,30,12) (A,21,38) (A,23,38) (A,32,42) (B,28,26)
RS1/16SS472J RS1/16SS101J RS1/16SS101J RS1/16SS221J RS1/16SS0R0J
R 709
(B,29,28)
RS1/16SS0R0J
C C C C
1801 1802 1911 1912
(A,B,C,E) (A,B,C,E) (A,B,C,E) (A,B,C,E) (A,B,C,E)
(B,147,32) 10 uF (B,95,23) (B,147,20) (B,130,27)
CCG1192 CKSRYB105K10 CKSRYB104K16 CKSRYB104K16
C Unit Number : CWX4023 Unit Name
: CD Core Unit (S11.6STD)
MISCELLANEOUS
D
CAPACITORS
IC 201 IC 301 Q 101 Q 102 X 201
(B,23,37) (A,37,11) (B,11,53) (B,15,54) (B,25,49)
IC PE5791A IC BD8223EFV Transistor 2SA1577 Chip Digital Transistor LTA123JUB Ceramic Resonator 16.934 MHzCSS1603
C C C C C
104 203 209 210 211
(B,12,57) (B,22,47) (B,28,47) (B,33,43) (B,33,41)
CKSQYB475K6R3 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10 CKSSYB104K10
S 901 S 903 CN101 CN701
(A,42,53) (B,21,12) (A,16,58) (A,25,29)
Spring Switch(HOME) CSN1080 Spring Switch(DSCSNS) CSN1081 Connector CKS4808 Connector CKS6146
C C C C C
212 213 214 215 216
(B,22,28) (B,18,26) (B,17,26) (B,19,28) (B,12,33)
CKSSYB104K10 CKSSYB332K50 CKSSYB473K16 CKSSYB104K10 CKSSYB182K50
C C C C C
217 218 219 220 221
(B,10,34) (B,10,36) (B,14,34) (A,18,38) (B,14,32)
CCSSCH560J50 CCSSCH4R0C50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
C C C C C
222 223 224 225 228
(B,13,37) (B,12,42) (B,13,45) (B,13,46) (B,10,33)
CKSSYB104K10 CCSSCH680J50 CCSSCH470J50 CKSSYB103K16 CCSSCH270J50
C C C C C
229 233 236 238 299
(B,9,40) (B,32,46) (B,8,40) (A,25,44) (A,26,41)
CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10
C C C C C
302 303 304 305 306
(B,28,12) (B,29,12) (B,27,12) (B,26,12) (A,31,7)
CKSSYB102K50 CKSSYB102K50 CKSSYB223K16 CKSSYB104K10 CKSSYB104K10
RESISTORS
E
F
Part No.
R 1854
CAPACITORS
C
4
Circuit Symbol and No.
R R R R R
101 102 103 108 109
(B,6,57) (B,8,57) (B,9,57) (B,18,55) (B,12,50)
RS1/10SR2R4J RS1/10SR2R4J RS1/10SR2R7J RS1/16SS105J RS1/16SS222J
R R R R R
201 202 214 215 216
(A,24,11) (A,23,9) (B,18,28) (B,17,28) (B,12,35)
RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J RS1/16SS393J RS1/16SS122J
R R R R R
217 218 229 232 237
(B,10,32) (B,10,35) (B,12,34) (A,31,54) (B,33,45)
RS1/16SS562J RS1/16SS472J RS1/16SS471J RS1/16SS0R0J RS1/16SS221J
R R R R
240 245 254 260
(B,34,40) (A,34,46) (A,37,56) (B,30,27)
RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS103J
60
DEH-14UB/XNUC 1
2
3
4
5
Circuit Symbol and No. C 307 C 308 C 710
(A,41,19) (A,31,15) (A,34,42)
6
7
8
Part No. CKSRYB105K10 CKSRYB105K10 CKSSYB102K50
A
Miscellaneous Parts List M 1 M 2
Pickup Unit(P10.6)(Service) CXX3556 Motor Unit(SPINDLE) CXE2273 Motor Unit(LOADING/CARRIAGE) CXC4026
B
C
D
E
F
DEH-14UB/XNUC 5
6
7
8
61