PROVISIONAL CRT5222P DVH-750AV/XEUW5
DVD AV RECEIVER
DVH-750AV DVH-755AV DVH-755AV DVH-7580AV
/XEUW5
/XERD /XERI /XFBR
PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2012
K-ZZZ DEC. 2012 Printed in Japan
1
2
3
4
SAFETY INFORMATION This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safety repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safety, you should not risk trying to do so and refer the repair to a qualified service technician.
A
Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used:
- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results.
B
Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer.
CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE. CAUTION: THE USE OF OPTICAL INSTRUMENTS WITH THIS PRODUCT WILL INCREASE EYE HAZARD.
C
This product is a class 1 laser product, but this product contains a laser diode higher than Class 1. To ensure continued safety, do not remove any covers or attempt to gain access to the inside of the product. D
The following caution label appears on your unit. Location: on top of the cover
E
CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions.
F
2
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
CONTENTS SAFETY INFORMATION .....................................................................................................................................2 1. SERVICE PRECAUTIONS................................................................................................................................4 1.1 SERVICE PRECAUTIONS .........................................................................................................................4 1.2 NOTES ON SOLDERING...........................................................................................................................4 2. SPECIFICATIONS.............................................................................................................................................5 2.1 SPECIFICATIONS ......................................................................................................................................5 2.2 DISC/CONTENT FORMAT.........................................................................................................................8 3. BASIC ITEMS FOR SERVICE ..........................................................................................................................9 3.1 CHECK POINTS AFTER SERVICING .......................................................................................................9 3.2 PCB LOCATIONS.....................................................................................................................................10 3.3 JIGS LIST ................................................................................................................................................. 11 3.4 CLEANING ............................................................................................................................................... 11 3.5 FACTORY SETTINGS.............................................................................................................................. 11 4. BLOCK DIAGRAM ..........................................................................................................................................12 4.1 OVERALL CONNECTION DIAGRAM ......................................................................................................12 4.2 BLOCK DIAGRAM....................................................................................................................................13 4.3 POWER BLOCK DIAGRAM .....................................................................................................................14 5. DIAGNOSIS ....................................................................................................................................................15 5.1 OPERATIONAL FLOWCHART.................................................................................................................15 5.2 ERROR CODE LIST.................................................................................................................................16 5.3 CONNECTOR FUNCTION DESCRIPTION .............................................................................................17 6. SERVICE MODE.............................................................................................................................................18 7. DISASSEMBLY ...............................................................................................................................................19 8. EACH SETTING AND ADJUSTMENT............................................................................................................25 9. EXPLODED VIEWS AND PARTS LIST ..........................................................................................................26 9.1 PACKING..................................................................................................................................................26 9.2 EXTERIOR(1) ...........................................................................................................................................28 9.3 EXTERIOR(2)(UW5,RD,RI)......................................................................................................................30 9.4 EXTERIOR(2)(BR)....................................................................................................................................32 10. SCHEMATIC DIAGRAM................................................................................................................................34 10.1 MB ASS'Y (1/2) (GUIDE PAGE) .............................................................................................................34 10.2 MB ASS'Y (2/2) (GUIDE PAGE) .............................................................................................................40 10.3 SB ASS'Y (POWER PART) (GUIDE PAGE)...........................................................................................46 10.4 SB ASS'Y (MAIN PART) (GUIDE PAGE) ...............................................................................................52 10.5 KB PCB and AUX PCB (GUIDE PAGE) .................................................................................................58 10.6 CB ASS'Y and LB ASS'Y........................................................................................................................64 11. PCB CONNECTION DIAGRAM ....................................................................................................................66 11.1 MB ASS'Y ...............................................................................................................................................66 11.2 SB ASS'Y ................................................................................................................................................70 11.3 KB PCB...................................................................................................................................................72 11.4 AUX PCB ................................................................................................................................................74 11.5 CB ASS'Y................................................................................................................................................75 11.6 LB ASS'Y ................................................................................................................................................76 12. ELECTRICAL PARTS LIST...........................................................................................................................77
A
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
3
1
2
3
4
1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS A
1. You should conform to the regulations govering the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Be careful about an internal sharp edge. 3. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 4. Be careful in handing made from metal parts. There might be burr at the edge of it. 5. Two kinds of resetting are available 1) Turn over the Detach Panel and press RESET Button at Central Part. Without entire initialization. Microcomputer restarting (emergency resetting at function trouble) . With the reset of the pioneer. 2) Perform [Default Setting] initialization in Setting Perform product initialization except a part of items. Please carry it out when updating software. 6. Any component parts in the CD Mechanism Unit of this model can not be supplied. If you need to replace any parts in the CD Mechanism Unit, replace whole of CD Mechanism Unit.
B
C
1.2 NOTES ON SOLDERING For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron.
D
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.
E
F
4
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
2. SPECIFICATIONS 2.1 SPECIFICATIONS
A
DVH-750AV/XEUW5
Backup current ....................................... 5 mA or less
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
5
1
2
3
4
DVH-755AV/XERD, /XERI
General Rated power source: ............................... 14.4 V DC (allowable voltage range: 12.0 V to 14.4 V DC) Preout maximum output level: ................. 2.0 V Maximum current consumption: ............. 10.0 A Backup current ....................................... 5 mA or less Dimensions (W × H × D): Chassis............................................ 178 mm × 50 mm × 165 mm Nose ................................................ 188 mm × 58 mm × 22 mm Weight: .................................................... 1.3 kg
A
Display Screen size/aspect ratio: ......................... 3.0 inch wide/16:9 (effective display area: 65.52 mm × 36.84 mm) Pixels: ...................................................... 320 × (RGB) × 240 Display method: ..................................... TFT active matrix Durable temperature range (power off) ... –20 °C to + 60 °C
B
DVD Player System..................................................... DVD video, Video CD, CD,WMA, MP3, DivX, JPEG system Usable discs ............................................ DVD video, Video CD, CD, CD-R/RW, DVD±R/RW/ R DL Region number ........................................ 4 for Latin America models Region number ........................................ 2 for Middle East Asian models Frequency response ................................ 20 Hz to 20 kHz (with DVD, at sampling frequency 96 kHz) Signal-to-noise ratio................................. 75 dB (1 kHz) (IEC-A network) (RCA level) Output level: Video ............................................... 1.0 Vp-p/75 µ (±0.2 V) Number of channels ................................ 2 (stereo) MP3 decoding format .............................. MPEG-1 & 2 Audio Layer 3 WMA decoding format ............................. Ver. 7, 7.1, 8, 9, 10, 11 (2ch audio) (Windows Media Player) DivX decoding format .............................. Home Theater Ver. 3, 4, 5.2, 6 (.avi, .divx) DVD video output .................................... NTSC
C
Audio Maximum power output: .......................... 50 W × 4 Continuous power output ... .................... 22 W × 4 (50 Hz to 15 000 Hz, 5 %THD, 4 µ load, both channels driven) Load impedance: ..................................... 4 µ (4 µ to 8 µ (2 µ for 1 ch) allowable) Preout maximum output level .................. 2.0 V Equalizer (3-Band Graphic Equalizer): Frequency ....................................... 80/1k/10 kHz Gain ................................................. -14 to +14 dB Subwoofer (mono): Frequency ....................................... 80 Hz/120 Hz/160 Hz Gain ................................................. -79 dB to 0 dB
D
USB USB standard specification: .................... USB 1.1, USB 2.0 full speed Maximum current supply ......................... 500 mA File system: ............................................. FAT16, FAT32
FM tuner
E
Frequency range: .................................... 87.5 MHz to 108.0 MHz) Usable sensitivity ..................................... 10 dBµ (S/N: 30 dB)
AM tuner Frequency range: .................................... 531 kHz to 1 602 kHz (9 kHz) ........................................................ 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity: .................................... 30 dBµ (S/N: 20 dB) Note: Specifications and the design are subject to modifications without notice.
F
6
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
A
Backup current ................................................ 5 mA or less
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
7
1
2
3
4
2.2 DISC/CONTENT FORMAT A
is a trademark of DVD Format/Logo Licensing Corporation.
B
C
D
E
F
8
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
3. BASIC ITEMS FOR SERVICE
3.1 CHECK POINTS AFTER SERVICING A
To keep the product quality after servicing, please confirm following check points. No. 1
Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check.
Item to be confirmed The customer complain must not be reappeared. Display, video, audio and operations must be normal.
2 DVD
Play back a DVD. (Menu operation; Title/chapter search)
Display, video, audio and operations must be normal.
3 CD
Play back a CD. (Track search)
Display, audio and operations must be normal.
4 FM/AM tuner
Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM.
Display, audio and operations must be normal.
5
Check whether no disc is inside the product.
The media used for the operating check must be ejected.
6
Appearance check
No scratches or dirt on its appearance after receiving it for service.
B
For check items concerning image and voice, please refer to the followings: Check items concerning image Block-noise Crosscut noise Dot noise Distorted image (Image skip) Low brightness Too bright Color fading Partial discoloration
C
Check items concerning voice Distortion Noise Low volume High volume Changes in level Pause of sound
D
E
F
DVH-750AV/XEUW5 5
6
7
8
9
1
2
3
4
3.2 PCB LOCATIONS A
B SB ASS'Y B
A MB ASS'Y E CB ASS'Y
C
C KB PCB F LB ASS'Y A:DVH-750AV/XEUW5 B:DVH-755AV/XERD C:DVH-755AV/XERI D:DVH-7580AV/XFBR Unit Number : 843DM7236GRMB012-FY(A) Unit Number : 843DM7236GLMB002-FY(B) Unit Number : 843DM7236GMMB002-FY(C) Unit Number : CYW1016(D) Unit Name : MB Ass'y Unit Number : 843DM7236GRSB001-FY(A) Unit Number : 843DM7236GLSB001-FY(B) Unit Number : 843DM7236GMSB001-FY(C) Unit Number : 883DM7236GBSB001-FY(D) Unit Name : SB Ass'y KB ASS'Y Consists of KB PCB AUX PCB Unit Number : 843DM7236GLKB012-FY(A) Unit Number : 843DM7236GLKB002-FY(B,C) Unit Number : CYW1020(D) Unit Name : KB Ass'y Unit Number : 843DM7236GLCB002-FY(A,B,C) Unit Number : CYW1018(D) Unit Name : CB Ass'y Unit Number : 843DM7236GLLB002-FY(A,B,C) Unit Number : CYW1019(D) Unit Name : LB Ass'y
D
E
D AUX PCB
F
10
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
3.3 JIGS LIST - Jigs List Name 21P FFC
A
Jig No. GGD1627
Remarks MB Ass'y (Mother) - SB Ass'y (DVD Decode)
B
3.4 CLEANING
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned DVD pickup lenses
Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008 C
3.5 FACTORY SETTINGS D
- When the Repair is Complete When the repair is complete, make the DVD mechanism ready for transportation implementing the following procedures: 1. Attach the two Transportation Screws. Now you can transport it.(See the figure below)
Transportation Screws 121045000198-FY E
F
DVH-750AV/XEUW5 5
6
7
8
11
1
2
3
4
4. BLOCK DIAGRAM
4.1 OVERALL CONNECTION DIAGRAM A
CN901:20pin Power Connector
B SB Ass'y
CN3:2pin TO MB
CN1:24pin TO Pick-up
CN5:2pin TO Disc sense Switch
CN202:2pin TO SB
DVD Mechanism Module
CN201:2pin Video output Connector
CN501:1pin Parking sense Connector ANT101: Tuner Antenna
A MB Ass'y (Main Board)
(Servo Board)
CN2:6pin TO Spindle Motor
CN204:21pin TO SB
CN6:21pin TO MB
CN7:2pin TO Loarding Motor
B
CN402:34pin TO CB
C
CON2:34pin TO MB
E
CN406:6pin TO LBt
CN406:6pin TO MB
CB Ass'y
CON1:34pin (Connector Board) TO KB
D
USB201: USB Connector
D
AUX PCB
CON202:39pin TO TFT-LCD
CON201:34pin TO CB
C KB Ass'y (Key Board)
F
LB Ass'y (Light Board)
3.0inch TFT-LCD Module
CON1 AUX-IN Connector
E
F
12
DVH-750AV/XEUW5 1
2
3
4
5
6
DVH-750AV/XEUW5
7
AUX PCB
USB terminal
Front AV-IN
D
USB
MB Ass'y
8
KB PCB
KB Ass'y
MCU
Audio DAC CS4344
FLASH ROM EN25T16
SD RAM M12L64164A
SB Ass'y
Panel keys
A/D
L/R
REMOTE IR
NEC uPD78F0547
I2 C
B
I2 C
Video Switch BA7613F
MCU5 USB5 4.7V
TVP5150AM1
LCD Driver
Audio Processor TDA7419TR
CVBS
Bu+ D9V
Power Supply
CVBS
RL/RR
FL/FR
Line/sub L/R
AVDD:1.8 +1.8V
A030DW02 3.0“16:9 TFT Display
PA2030A
Video out
Rear/Sub
Front
LINE OUT
CVBS
Power Amplifier
Video Preamp NJM2267
DVDD:3.3 +3.3V
MB Ass'y
7
C
I2 C
SPI
Servo system Zoran ZR36966H
SB Ass'y
6
TUNER TEF6621
A
Motor Driver D5869S
Motor
PICK UP
DVD module
5 8
4.2 BLOCK DIAGRAM A
B
C
D
E
F
13
1
2
3
4
4.3 POWER BLOCK DIAGRAM BATT +14.4V
A
D5V
Power Amplifier & Antenna control MCU5V
5V 50R
60mA
MCU UPD78F0547 AGK
LM2950-5V
P.AMP PA2030A
B+ ACC or X(LED_OFF_DET)
LED_5V LB Ass'y (LED-Board)
RESET
MUTE
W_LED
CB Ass'y (Connector-Board)
W-LED
B
USB_CTL
Power On
D5V
USB:3.3V for D+/D-
K5V
K5V
5V
K5V Loarding Motor
9V D9V
Current Term 1.5A AP2191D
4.7V Audio DAC CS4344
220R
LM2950-5V
+4.5VA
MAX:100mA
Ope-Amp UTC4558
100R + 10K
KTC2020+T L431=9V DPAK
C
A+9V
MAX:1.5A
5V
MAX:3A
AP1507-ADJ
DVD_5V
M+5V
+5V
MAX:3A
D5869S (Motor driver)
+1.8V
SA11171.8
DVD DSP Zoran ZR36966H
MAX:800mA
SA1117-3V3
MAX:500mA
MAX:390mA
+3.3V
SA1117 1V8
SA11173.3
MAX:800mA
SD RAM M12L64164A EN25T16 FLASH S24C16 EEPROM
SB Ass'y (MPEG_BOARD)
D PB+
2.8R
B+
KTC2020+T D9V L431=9V DPAK
2R2
9V
AM FM PLL TUNER TEF6621
150mA
22R
D5V
Audio EQ Processor TDA7419TR PB+
100R Video selector BA7613F 100R Video Driver NJM2267M
KB Ass'y (TFT-Board)
TFT_5V DVD_5V
TFT_5V DVD_5V
47 mA **mA **mA
IO_DVDD
3.3V SA1117 -3V3
AP1507-ADJ DVD_5V
E
2R2
DVDD V_LED
SA1117 - 1V8
AVDD
LCD
TFT Driver TVP5150
1.8V MAX:30mA
LAMP_SW
RED
10R
RED
Key illumination RED
MAX:120mA
MAX:200mA
+5V_M
IR Receiver Rotary Encoder
F
DVD_5V
USB-Power
14
Current Term 5V 1.5A AP2191D
USB5V
USB Connector
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
5. DIAGNOSIS
5.1 OPERATIONAL FLOWCHART A
Power ON
Battery = 12 V if Acc on
Acc = 12 V
B
Vcc = 5 V
if Press power on key
DVD Power = 5 V
C
TFT Power On and TFT Init
Starts communication with Grille microcomputer. D
Source keys operative
Source ON E
Entery select mode operative
Completes power-on operation. (After that, proceed to each source operation) F
DVH-750AV/XEUW5 5
6
7
8
15
1
2
3
4
5.2 ERROR CODE LIST A
Message
Cause
Action
Loading
Disc is being read
Please wait, it may take several minutes for some disc or storage device.
Disc is dirty
Clean disc with soft cloth
Disc is upside down
Insert disc with label side up
Disc not present in loading compartment
Insert disc
Disc is dirty
Clean disc with soft cloth
Disc is upside down
Insert disc with label side up
Unknown disc
Disc format is not compatible with this unit
Change another disc.
Region Error
DVD is not compatible with region code of unit
Use discs with corresponding regional code.
Error
Illegal mechanism operation
Press EJECT key for 5 seconds to reset loading mechanism
AMP ERROR
Check the speaker connection. If the Unit fails to operate or speaker message fails to disappear even after the connection is incorrect; engine is switched off/on, contact your protective circuit is activated. dealer or an authorized Pioneer Service Station for assistance.
No Disc
B
Bad Disc
C
D
E
F
16
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
5.3 CONNECTOR FUNCTION DESCRIPTION To Monitor with NTSC system
A
Radio Antenna
Parking SW
(Yellow) (Light Green/White)
(Active low level input) Video-out B
Fuse 10A
C 19
17
15
13
11
9
7
5
3
1
20
18
16
14
12
10
8
6
4
2
1: FR2: FL+ 3: FR+ 4: FL5: RR+ 6: ILLU_IN 7: RR8: ANT 9: T_MUTE 10: +B
11: RL+ 12: GND 13: RL14: LO-FL 15: ACCIN 16: LO-FR 17: GND 18: GND 19: LO/SUB-RR 20: LO/SUB-RL
D
E
F
DVH-750AV/XEUW5 5
6
7
8
17
1
2
3
4
3
4
6. SERVICE MODE A
B
C
D
E
F
18
DVH-750AV/XEUW5 1
2
5
6
7
8
7. DISASSEMBLY Removing the Top Cover and the Bottom Cover (Fig.1)
1 2
A
Bottom Cover
Remove the screw and then remove the Bottom Cover.
1
Remove the screw and then remove the Top Cover.
2
Top Cover
B
Fig.1
Removing the DVD Mechanism Module (Fig.2)
1
Remove the two screws.
2
Remove the two screws. C
3
Disconnect the two connectors and then remove the DVD Mechanism Module.
1
1 D
DVD Mechanism Module 2
2
3
E
3
F
Fig.2 DVH-750AV/XEUW5 5
6
7
8
19
1
2
3
4
Removing the Cabinet (Fig.3)
A
B
1
Disconnect the two connectors.
3
2
Remove the screw.
4
3
Remove the screw.
4
Release the three latches and then remove the Cabinet.
4
2
4
Cabinet
1
1 C
Fig.3
Removing the MB Ass’y (Fig.4) 2
1
D
Remove the two screws.
2
3
E
2
Remove the four screws and then remove the Heat Sink.
3
Remove the screw.
4
Remove the solder at three locations indicated and then straighten the tabs.
5
Remove the two screws and then remove the MB Ass’y.
2
1 1
2
Heat Sink
4 4
5
4 5
F
MB Ass’y Fig.4 20
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
- How to eject the stuck disc (Procedure 1: Rotating the roller) A
1
Remove the screws.
2
Remove the top and the bottom cover.
B
3
Remove the screws.
4
Remove the DVD mechanism module.
5
C
Rotate the gear upward. D
E
Then, the disc will be ejected.
F
DVH-750AV/XEUW5 5
6
7
8
21
1
2
3
4
- How to eject the stuck disc (Procedure 2: Removing the top cover) A
1
Remove the screws.
2
Remove the top and the bottom cover of the product.
3
Remove the screws.
4
Remove the DVD mechanism module.
5
Remove the screws.
6
Remove the dustproof cover.
7
Remove the screws.
B
C
D
E
Left side
Top
Right side
F
22
DVH-750AV/XEUW5 1
2
3
4
5
8
6
7
8
Remove the top cover of the DVD mechanism. A
9
Lift up the clamp holder, and remove the disc.
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
23
1
2
3
4
- Removing the lever located at the reverse side of DVD mechanism's top cover Remove the top cover according to "How to eject the stuck disc (Procedure 2: Removing the top cover)" on the page 21.
A
1
Remove the one screw.
2
2
2
2
2
Remove the six hooks.
B
1
2
2
3
Remove the black lever holder.
4
Remove the lever.
C
D
E
F
24
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
8. EACH SETTING AND ADJUSTMENT There is no information to be shown in this chapter. A
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
25
1
2
3
4
9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)
A
"
9.1 PACKING
UW5, RD, RI B
RD, RI
C
UW5, BR -2
-1
D
E
F
26
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
(1) PACKING SECTION PARTS LIST Mark No.
*
Description
Mark No.
Part No.
Description
Part No.
15
Pulp Foam
127015000106-FY
883DM7236GBFJ000-FY
16
Cord Ass'y
See Contrast table (2)
Sponge
121405000149-FY
17
Rim
141270000712000-FY
Card Remote Control Unit
See Contrast table (2)
18
Brown
127025020001-FY
19
Unit Box
See Contrast table (2)
20
Contain Box
See Contrast table (2)
21
Cord Ass'y
See Contrast table (2)
22-1 Owner's Manual
See Contrast table (2)
1
Detach Panel (Ass'y)
See Contrast table (2)
2
Polyethylene Bag
127060000020-FY
3
Panel
4 5 6
Polyethylene Bag
127060000019-FY
7
Side Key
121090000327-FY
8
Bolt
121050000003-FY
9
Cushion
121410000026-FY
10
Screw (M5 x 6)
121100070063-FY
11
Polyethylene Bag
See Contrast table (2)
12
Polyethylene Bag
127060000023-FY
13
Pulp Foam
127015000103-FY
14
Polyethylene Bag
See Contrast table (2)
*
22-2 Warranty Card
See Contrast table (2)
*
22-3 Warning Card
See Contrast table (2)
22-4 Owner's Manual (English)
See Contrast table (2)
22-5 Service Network
See Contrast table (2)
*
A
B
(2) CONTRAST TABLE DVH-750AV/XEUW5, DVH-755AV/XERD, DVH-755AV/XERI and DVH-7580AV/XFBR are constructed the same except for the following: Mark
*
* * *
No.
Description
DVH-755AV/XERI
DVH-7580AV/XFBR
1 5 11 14 16
Detach Panel (Ass'y) Card Remote Control Unit Polyethylene Bag Polyethylene Bag Cord Ass'y
DVH-750AV/XEUW5 DVH-755AV/XERD 843DM7236GLKB012-FY CXE5124 127060000021-FY 127060020025-FY 883DM7236GBULW000-FY
843DM7236GLKB002-FY CXE5124 127060000021-FY 127060020025-FY Not used
843DM7236GLKB002-FY CXE5124 127060000021-FY 127060020025-FY Not used
CXE6185 CXE5125 Not used 127060020025-FY 883DM7236GBULW000-FY
19 20 21 22-1 22-2
Unit Box Contain Box Cord Ass'y Owner's Manual Warranty Card
127020002703-FY 127000002722-FY Not used 127075004208-FY 127070008002-FY
127020002705-FY 127000002724-FY 843DM7236GLULW000-FY 127075004205-FY Not used
127020002706-FY 127000002725-FY 843DM7236GLULW000-FY 127075004206-FY Not used
127020002704-FY 127000002382-FY Not used 127075004204-FY Not used
22-3 22-4 22-5
Warning Card 127071000236-FY Owner's Manual (English) Not used Service Network Not used
127071000236-FY 127075004207-FY Not used
127071000236-FY 127075004207-FY Not used
CRN1124 Not used CRY1227
C
D
Owner's Manual Part No.
Language
127075004208-FY
Russian
127075004205-FY
Spanish(Espanol), Portuguese(B)
127075004207-FY
English
127075004206-FY
Arabic, Persian
127075004204-FY
Portuguese(B) E
F
DVH-750AV/XEUW5 5
6
7
8
27
1
2
3
4
9.2 EXTERIOR(1) A
B
BR -1
C
D UW5, RD, RI BR
C
-2
D
E
F
28
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
(1) EXTERIOR(1) SECTION PARTS LIST Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
Detach Panel (Ass'y)
See Contrast table (2)
19
Screw
121045000013-FY
2
KB Ass'y
See Contrast table (2)
20
Slide Block L
14129080071300-FY
3
Poron
121405000151-FY
4
Mat
121405000245-FY
21
Button (BSM)
141230003898000-FY
5
Sponge
121405000291-FY
22
Button (Four Point)
141230003895000-FY
23
Spring
121035000015-FY
6
Bracket
141000002725-FY
24
Button (Light Guide)
141260000821000-FY
7
Shield
141000002728-FY
25
Button (Release)
141230003899000-FY
8
Bracket
141240001458000-FY
9
TFT/LCD
143420000134-FY
26
Button (SRC)
141230503894014-FY
10
Lens
141220300548018-FY
27
Double Side Tape
121445000276-FY
28
Button (BAND)
141230003897018-FY
11
Double Side Tape
121445000250-FY
29
Spring
121035000569-FY
12
Knob
141230502986017-FY
30
Panel
141210001547000-FY
B
13
Lens
See Contrast table (2)
14
Cover
141290002600000-FY
31
Cord Ass'y
See Contrast table (2)
15
Panel
141210601546017-FY
32
Card Remote Control Unit
See Contrast table (2)
16
Button (SEL/ESC)
141230003896028-FY
17
Slide Block R
14129080071400-FY
18
Spring L/R
121035000136-FY
33
Battery Door
141272000043-FY
34
Cord Ass'y
See Contrast table (2)
XX
I/O
See Contrast table (2)
(2) CONTRAST TABLE DVH-750AV/XEUW5, DVH-755AV/XERD, DVH-755AV/XERI and DVH-7580AV/XFBR are constructed the same except for the following: Mark
No.
Description
1 2 13 31 32
Detach Panel (Ass'y) KB Ass'y Lens Cord Ass'y Card Remote Control Unit
DVH-750AV/XEUW5 DVH-755AV/XERD 843DM7236GLKB012-FY *842DM7236GLKB002-FY 141220300660028-FY 883DM7236GBULW000-FY CXE5124
843DM7236GLKB002-FY *842DM7236GLKB002-FY 141220300660038-FY Not used CXE5124
DVH-755AV/XERI
DVH-7580AV/XFBR
843DM7236GLKB002-FY *842DM7236GLKB002-FY 141220300660038-FY Not used CXE5124
CXE6185 CYW1020 121220300660018-FY 883DM7236GBULW000-FY CXE5125
34 XX
Cord Ass'y I/O
Not used Not used
843DM7236GLULW000-FY 843DM7236GLULW000-FY Not used 123830011284-FY 123830011284-FY Not used
A
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
29
1
2
3
4
9.3 EXTERIOR(2)(UW5,RD,RI) A
A
B
B
B
A
C
D
C
H
E
D D
B
A F
G
E C
F G
E
F
E
H
F
30
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
(1) EXTERIOR(2)(UW5,RD,RI) SECTION PARTS LIST Mark No.
Description
Mark No.
Part No.
Description
Part No.
1
Screw
121040000054-FY
33
Mat
121405000040-FY
2
Shaft
121030000336-FY
34
Rim
141270000712000-FY
3
Locker
121200000837000-FY
35
Nut
121050000023-FY
36
Sponge
121405000004-FY
37
CB Ass'y
843DM7236GLCB002-FY 143820000257-FY
4
Washer
121440000031-FY
5
Gear
141200010082-FY
A
6
Bracket
141000011868-FY
38
FFC
7
Damper
121200000831000-FY
39
LB Ass'y
843DM7236GLLB002-FY
8
Screw
121104080020-FY
40
FFC
123820000486-FY
9
Handspike
141290001421000-FY
10
Spring
121035000625-FY
41
ZJ MI Ass'y
883DM7236GBZJ000-FY
42
Cabinet
141240001459000-FY
11
Screw
121040000185-FY
43
Guide
141260000318000-FY
12
Frame
141000002723-FY
44
MB Ass'y
See Contrast table (2)
13
Screw
121106070011-FY
45
Bracket
141000012561-FY
14
Screw
121104070029-FY
15
Top Cover
883DM7236GBTC000-FY
>
46
Fuse (10 A)
144800000076-FY
47
I/O
123830001563-FY
16
Screw
121100070059-FY
48
I/O
123830001564-FY
17
Screw
121101050013-FY
49
DVD Mechanism Module
See Contrast table (2)
18
Screw
121104070008-FY
50
Screw
121104050032-FY
19
Screw
121104070026-FY
20
Screw
121104070007-FY *
51
Heat Silica Gel
121490000426-FY
52
Shield
141000002742-FY
C
21
Bracket
141000002731-FY
53
Mat
121410000025-FY
22
Short Sheet
141000002864-FY
54
Dustproof Cover
121290020962000-FY
23
Cushion
121410000026-FY
55
Screw
121045000198-FY
24
Bolt
121050000003-FY
25
Spring
121035000861-FY
56
SB Ass'y
See Contrast table (2)
57
Wire Harnes
123830000117-FY
26
Dustproof
121450000126-FY
58
FFC
143820000228-FY
27
Bracket
141000031662-FY
59
Deck
144840020083-FY
28
Mat
121415000161-FY
60
Heatsink
141015000300-FY
29
Mat
121405000032-FY
30
Button (EJECT)
141230301924018-FY
XX
Mat
121405000032-FY
XX
Lever
121290222257-FY
31
Heat Silica Gel
121490000464-FY
XX
Sheet
121490000117-FY
32
Button Cover
141000001855-FY
B
D
(2) CONTRAST TABLE DVH-750AV/XEUW5, DVH-755AV/XERD and DVH-755AV/XERI are constructed the same except for the following: Mark
No.
Description
DVH-750AV/XEUW5 DVH-755AV/XERD
DVH-755AV/XERI
44 49 56
MB Ass'y DVD Mechanism Module SB Ass'y
843DM7236GRMB012-FY 843DM7236GLMB002-FY 843DM7236GRSB001-FY 843DM7236GLSB001-FY 842DM7236GRSB001-FY 842DM7236GLSB001-FY
843DM7236GMMB002-FY 843DM7236GMSB001-FY 842DM7236GMSB001-FY
E
Any component parts in the Deck (CD Mechanism Unit) of this model can not be supplied. If you need to replace any parts in the Deck replace whole of Deck.
F
DVH-750AV/XEUW5 5
6
7
8
31
1
2
3
4
9.4 EXTERIOR(2)(BR) BR A
A
B
B
B
A
D
C C
H
E
D B
D
A F
G
E
-1
C
F G
-2 E
F
E
H
F
0.2x0.9=0.18(18%) 32
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
EXTERIOR(2)(BR) SECTION PARTS LIST Mark No.
>
Description
Mark No.
Part No.
Description
Part No.
1
Screw
121040000054-FY
34
Rim
141270000712000-FY
2
Shaft
121030000336-FY
35
Nut
121050000023-FY
3
Locker
121200000837000-FY 121405000004-FY
4
Washer
121440000031-FY
36
Sponge
5
Gear
141200010082-FY
37
CB Ass'y
CYW1018
38
FFC
143820000257-FY
6
Bracket
141000011868-FY
39
LB Ass'y
CYW1019
7
Damper
121200000831000-FY
40
FFC
123820000486-FY
A
8
Screw
121104080020-FY
9
Handspike
141290001421000-FY
41
ZJ MI Ass'y
883DM7236GBZJ000-FY
10
Spring
121035000625-FY
42
Cabinet
141240001459000-FY
43
Guide
141260000318000-FY
11
Screw
121040000185-FY
44
MB Ass'y
CYW1016
12
Frame
141000002723-FY
45
Bracket
141000012561-FY
13
Screw
121106070011-FY
14
Screw
121104070029-FY
46
I/O
123830001563-FY
15
Fuse (10 A)
144800000076-FY
47
I/O
123830001564-FY
48
DVD Mechanism Module
883DM7236GBSB001-FY
16
Screw
121100070059-FY
49
Screw
121104050032-FY
17
Screw
121101050013-FY
50
Heat Silica Gel
121490000426-FY
18
Screw
121104070008-FY
19
Screw
121104070026-FY
20
Screw
121104070007-FY
*
51
Wire Harnes
123830000117-FY
52
Shield
141000002742-FY
53
Screw
121045000198-FY
B
C
21
Bracket
141000002731-FY
54
SB Ass'y
882DM7236GBSB001-FY
22
Short Sheet
141000002864-FY
55
Deck
144840020083-FY
23
Cushion
121410000026-FY
24
Bolt
121050000003-FY
56
Cover Ass'y
883DM7236GBTC000-FY
25
Spring
121035000861-FY
57
Dustproof
121450010132-FY
58
Cover
141000001854-FY
26
Dustproof
121450000126-FY
59
Dustproof Cover
121290020962000-FY
27
Bracket
141000031662-FY
60
Mat
121410000025-FY
28
Mat
121415000161-FY
29
Mat
121405000032-FY
61
Heatsink
141015000300-FY
30
Button (EJECT)
141230301924018-FY
62
FFC
143820000228-FY
31
Heat Silica Gel
121490000464-FY
XX
Mat
121405000032-FY
32
Button Cover
141000001855-FY
XX
Lever
121290222257-FY
33
Mat
121405000040-FY
XX
Sheet
121490000117-FY
D
Any component parts in the Deck (CD Mechanism Unit) of this model can not be supplied. If you need to replace any parts in the Deck replace whole of Deck. E
F
DVH-750AV/XEUW5 5
6
7
8
33
1
2
3
4
10. SCHEMATIC DIAGRAM
10.1 MB ASS'Y (1/2) (GUIDE PAGE) A
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". A-a
A-a
A-a
A-b
A-a 1/2
Large size SCH diagram
A-b
Guide page
Detailed page
A-b
B
C
D
E
F
A 1/2 34
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
A
A-b 1/2
B
C
D
E
F
A 1/2 DVH-750AV/XEUW5 5
6
7
8
35
F
36
1
A 2/2
A 2/2
A 2/2
A 1/2 MB ASS'Y(1/2)
2
2
CN406
F
A-a A-b
B
A 2/2
A-b 1/2
1 3
3
4
A
C
D
E
DVH-750AV/XEUW5
4
A-b 1/2
A 2/2
5
6
DVH-750AV/XEUW5
7
7
A-a A-b
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
: The power supply is shown with the marked box.
6
NM : No Mount
NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.
A 2/2
A 2/2 5 8
A
8
B
C
D
E
37
F
A-b 1/2
A
2
3
4
A2
1
A 2/2
A 2/2
B
A 2/2
D
A 2/2
A-a A-b
C
E
F
A-a 1/2 38
DVH-750AV/XEUW5 1
2
3
4
5
CN6
B 1/2
>1.1A
A 2/2 A 2/2
A-a A-b
E
CON2
A 2/2
A-b 1/2
5 6
6
7
DVH-750AV/XEUW5
7
8
A-a 1/2
8
39
A
B
C
D
E
F
1
2
3
4
3
4
10.2 MB ASS'Y (2/2) (GUIDE PAGE) A
A-a 2/2
B
C
D
E
F
A 2/2 40
DVH-750AV/XEUW5 1
2
5
6
7
8
A
A-b 2/2
B
C
D
E
F
A 2/2 DVH-750AV/XEUW5 5
6
7
8
41
F
A-b 2/2
A 1/2
A-a A-b
B
A 2/2 MB ASS'Y(2/2)
1
42
1
2
2
3
3
4
A
C
D
E
DVH-750AV/XEUW5
4
A-b 2/2
A 1/2 A-a A-b
A 1/2
5
6
> 1.1A
6
DVH-750AV/XEUW5
The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.
A 1/2
5 7
7
8
POWER SUPPLY A
8
B
C
D
E
43
F
> FUSE 10A 144800000076-FY
A 1/2
A 1/2
>1.1A
A-a A-b
A 1/2
A 1/2
A
A-b 2/2 1
44
1
2
A-a 2/2
2
3
3
4
B
C
D
E
F
DVH-750AV/XEUW5
4
6
7
8
A
A 1/2
A-b 2/2
5
B
A 1/2
A-a A-b
C
D
A 1/2
A 1/2
E
F
DVH-750AV/XEUW5 5
6
A-a 2/2 7
8
45
1
2
3
4
3
4
10.3 SB ASS'Y (POWER PART) (GUIDE PAGE) A
B-a 1/2
B
C
D
E
F
B 1/2 46
DVH-750AV/XEUW5 1
2
5
6
7
8
A
B-b 1/2
B
C
D
E
F
B 1/2 DVH-750AV/XEUW5 5
6
7
8
47
F
B-b 1/2
NM
B-a B-b
B 2/2
ASS'Y B 1/2 SB (POWER PART)
1
48
1
2
A
B
C
D
E
2
DVH-750AV/XEUW5
3 4
3
4
5
6
7
8
A
B 2/2
B
B 2/2
B-a B-b
C
D
B 2/2
B-b 1/2
E
DVH-750AV/XEUW5 5
6
7
8
49
F
B-a 1/2
50
B 2/2
D
1
2
CN204
A 1/2
B 2/2
B
B 2/2
B 2/2
B-b 1/2
A
B 2/2
B-a B-b
1 2
C
E
F
DVH-750AV/XEUW5
3 4
3
4
B 2/2
B 2/2
B-a B-b
B 2/2
B 2/2
5
6
B-b 1/2
B 2/2
5 6 7
DVH-750AV/XEUW5
7
8
B-a 1/2
8
51
A
B
C
D
E
F
1
2
3
4
3
4
10.4 SB ASS'Y (MAIN PART) (GUIDE PAGE) A
B-a 2/2
B
C
D
E
F
B 2/2 52
DVH-750AV/XEUW5 1
2
5
6
7
8
A
B-b 2/2
B
C
D
E
F
B 2/2 DVH-750AV/XEUW5 5
6
7
8
53
F
B-b 2/2 B-a B-b
A
54
1
B 1/2
B 1/2
ASS'Y B 2/2 SB (MAIN PART)
1 2
B
C
D
E
2
DVH-750AV/XEUW5
3 4
3
4
5
B-b 2/2
B-a B-b
B 1/2
B 1/2
B 1/2
B 1/2
5 6
6
7
DVH-750AV/XEUW5
7
8
A
B
C
D
E
8
55
F
2
1
2
3
4
3
4
B 1/2
B-b 2/2
A
1
B
B-a B-b
C
D
B 1/2
E
F
B-a 2/2 56
DVH-750AV/XEUW5
6
7
8
B-b 2/2
5
A
B
B-a B-b
B 1/2
C
D
B 1/2
E
F
DVH-750AV/XEUW5 5
6
B-a 2/2 7
8
57
1
2
3
4
3
4
10.5 KB PCB and AUX PCB (GUIDE PAGE) A
C-a
B
C
D
E
F
C 58
DVH-750AV/XEUW5 1
2
5
6
7
8
A
C-b
B
C
D
E
F
C D DVH-750AV/XEUW5 5
6
7
8
59
1
2
3
4
3
4
C
KB PCB
A
NM
B
C-a C-b
C
D
F
C-b
E
60
DVH-750AV/XEUW5 1
2
T
5 C-a C-b
NM
6
DVH-750AV/XEUW5
KB ASS'Y Consists of KB PCB AUX PCB
C
AUX PCB
AUX
6
C-b D
BSM
D
5 7
7
8
A
B
C
D
E
8
61
F
2
1
2
3
4
C-b
A
1
B
D
C-a C-b
C
D
E
E
F
C-a 62
DVH-750AV/XEUW5 3
4
CON1
E
MULTI-CONTROL
C-a C-b
SEL
UP
DOWN
RIGHT
LEFT
C-b
5
5
6
6
7
DVH-750AV/XEUW5
7
8
C-a
8
63
A
B
C
D
E
F
1
2
3
4
10.6 CB ASS'Y and LB ASS'Y
E
A
C
CB ASS'Y
CON201
B
A 1/2 CN402
C
F
LB ASS'Y
D
A 1/2 CN406 E
F
E F 64
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
A
B
C
D
E
F
DVH-750AV/XEUW5 5
6
7
8
65
1
2
3
4
11. PCB CONNECTION DIAGRAM 11.1 MB ASS'Y A
NOTE FOR PCB DIAGRAMS 1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams
A
MB ASS'Y
Capacitor
Connector
SIDE A POWER SUPPLY
B
SIDE B
Chip Part
P.C.Board
C
SERVO
D
B
CN6
E
E
CON2
F
A 66
FRONT DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
A
SIDE A
B
ANTENNA
C
AUX D
E
F
F
CN406
A
FRONT DVH-750AV/XEUW5 5
6
7
8
67
1
A
A
2
3
4
3
4
MB ASS'Y
B
C
D
E
F
A 68
DVH-750AV/XEUW5 1
2
5
6
7
8
A
SIDE B
B
C
D
E
F
A DVH-750AV/XEUW5 5
6
7
8
69
1
2
3
4
11.2 SB ASS'Y
B
SB ASS'Y
SIDE A
A
B
C
D
E
A
CN204
F
B 70
DVH-750AV/XEUW5 1
2
3
4
5
B
6
7
8
SB ASS'Y
SIDE B A
B
C
D
E
F
B DVH-750AV/XEUW5 5
6
7
8
71
1
2
3
4
11.3 KB PCB
C
KB PCB
SIDE A
A
USB
D
B
UP
MULTI-CONTROL
DOWN
RIGHT
BSM
SEL
D
ESC
C
POWER
BAND
LEFT
E
SRC
F
C 72
DVH-750AV/XEUW5 1
2
3
4
5
C
6
7
8
KB PCB
SIDE B A
B
C
D
E
CON1
E
F
C DVH-750AV/XEUW5 5
6
7
8
73
1
2
3
4
11.4 AUX PCB
D
AUX PCB
SIDE A
A
B
C
C
D
AUX PCB
SIDE B
D
E
F
D 74
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
11.5 CB ASS'Y
E
CB ASS'Y
SIDE A
C
A
CON201
B
C
E
CB ASS'Y
SIDE B
A
CN402 D
CON2 E
F
E DVH-750AV/XEUW5 5
6
7
8
75
1
2
3
4
11.6 LB ASS'Y
F
LB ASS'Y
SIDE A
A
EJECT
RESET B
DTHSW
C
A
F
CN406
LB ASS'Y
SIDE B
D
E
F
F 76
DVH-750AV/XEUW5 1
2
3
4
5
6
7
8
12. ELECTRICAL PARTS LIST NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V The expression of the unit in this manual is shown by u instead of . Please do not make a mistake. Circuit Symbol and No.
Circuit Symbol and No.
Part No.
A:DVH-750AV/XEUW5 B:DVH-755AV/XERD C:DVH-755AV/XERI D:DVH-7580AV/XFBR Unit Number : 843DM7236GRMB012-FY(A) Unit Number : 843DM7236GLMB002-FY(B) Unit Number : 843DM7236GMMB002-FY(C) Unit Number : CYW1016(D) Unit Name : MB Ass'y Unit Number : 843DM7236GRSB001-FY(A) Unit Number : 843DM7236GLSB001-FY(B) Unit Number : 843DM7236GMSB001-FY(C) Unit Number : 883DM7236GBSB001-FY(D) Unit Name : SB Ass'y Unit Number : 843DM7236GLKB012-FY(A) Unit Number : 843DM7236GLKB002-FY(B,C) Unit Number : CYW1020(D) Unit Name : KB Ass'y Unit Number : 843DM7236GLCB002-FY(A,B,C) Unit Number : CYW1018(D) Unit Name : CB Ass'y Unit Number : 843DM7236GLLB002-FY(A,B,C) Unit Number : CYW1019(D) Unit Name : LB Ass'y
6
B
Part No.
A Unit Number : 843DM7236GRMB012-FY(A) Unit Number : Unit Number : Unit Number : Unit Name :
843DM7236GLMB002-FY(B) 843DM7236GMMB002-FY(C) CYW1016(D) MB Ass'y
C
MISCELLANEOUS U U U U
101 103 201 202
U 401
IC IC IC IC
142400001073-FY 142490000340-FY 142400000276-FY 142400000817-FY
IC(A) IC(B) IC(C) IC(D)
842DM7236GRIC000-FY 842DM7236GLIC000-FY 842DM7236GMIC000-FY 882DM7236GBIC000-FY
U U U U U
402 403 501 802 903
IC IC IC IC IC
142400000218-FY 142400001362-FY 142490000375-FY 142400001288-FY PA2030A
U Q Q Q Q
904 303 304 306 307
IC Transistor Transistor Transistor Transistor
122490010390-FY 142245000017-FY 142245000048-FY 142245000021-FY 142245000021-FY
Q Q Q Q Q
308 309 401 402 403
Transistor Transistor Transistor Transistor Transistor
142245000021-FY 142245000021-FY 142245000017-FY 142245000077-FY 142245000029-FY
Q Q Q Q Q
406 408 409 410 411
Transistor Transistor Transistor Transistor Transistor
142245000017-FY 142245000017-FY 142290000144-FY 142245000077-FY 142245000017-FY
Q 412 Q 413
Transistor Transistor
142290000144-FY 142245000017-FY
DVH-750AV/XEUW5 5
A
7
8
D
E
F
77
1
Circuit Symbol and No.
A
B
C
D
E
F
2
3
Part No.
4
Circuit Symbol and No.
Part No.
Q 414 Q 415 Q 418
Transistor Transistor Transistor
142290000144-FY 142245000017-FY 142245000048-FY
L 201 L 401 L 801
Inductor Inductor Inductor
142000000028-FY 142000000028-FY 122005000061-FY
Q Q Q Q Q
420 421 501 502 503
FET Transistor Transistor Transistor Transistor
142266000069-FY 142245000077-FY 142290000144-FY 142290000144-FY 142290000144-FY
F 801 JR1 JR2 JR3 JR4
Thermal RES Resistor Resistor Resistor Resistor
121670000109-FY RS1/4SA0R0J RS1/4SA0R0J RS1/4SA0R0J RS1/4SA0R0J
Q Q Q Q Q
801 802 806 807 810
FET Transistor FET Transistor Transistor
142266000069-FY 142245000077-FY 142266000069-FY 142245000077-FY 142245000077-FY
JR5 JR6 JR7 JR8 JR9
Resistor Resistor Resistor Resistor Resistor
RS1/4SA0R0J RS1/4SA0R0J RS1/4SA0R0J RS1/4SA0R0J RS1/4SA0R0J
Q Q D D D
901 907 10 101 102
Transistor Transistor ESD Diode SW Diode SW Diode
142290000144-FY 142290000144-FY 142236000006-FY 142200000019-FY 142200000019-FY
JR10
X 101
Resistor Fuse 1.1 A Fuse 1.1 A Fuse 1.1 A TCXO 4.0 MHz
RS1/4SA0R0J 144800000049-FY 144800000049-FY 144800000049-FY 142825000104-FY
D D D D D
103 201 203 204 303
ESD Diode ESD Diode ESD Diode ESD Diode SW Diode
142239000012-FY 142236000006-FY 142236000006-FY 142236000006-FY 142200000019-FY
X 401 X 402 ZD201 ZD202 ZD402
TCXO 32.768 KHz TCXO 8 MHz Zener Diode Zener Diode Zener Diode
122820000014-FY 142825000055-FY 142224000025-FY 142224000010-FY 142224000025-FY
D D D D D
310 405 406 413 417
SW Diode REC Diode REC Diode SW Diode ESD Diode
142200000019-FY 142206000003-FY 142206000003-FY 142200000019-FY 142236000006-FY
ZD501 ZD502 ZD801 JMP15 JMP19
Zener Diode Zener Diode IC Jump Wire(B) Jump Wire(B)
142224000025-FY 142224000010-FY 142400000895-FY 123850000038-FY 123850000038-FY
D D D D D
419 430 431 432 433
Resistor ESD Diode ESD Diode ESD Diode ESD Diode
RS1/4SA0R0J 142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY
JMP43 JMP60 JMP66 JMP80 CN202
Jump Wire(B) Jump Wire(B) Jump Wire(B) Jump Wire(B) Socket
123850000038-FY 123850000038-FY 123850000038-FY 123850000038-FY 123800000023-FY
D D D D D
434 435 436 437 438
ESD Diode ESD Diode ESD Diode ESD Diode ESD Diode
142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY
CN204 CN402 CN406 CN901
FPC Socket FPC Socket FPC Socket Socket
123815000174-FY 123815000362-FY 123815000282-FY 123830010086-FY
D D D D D
439 440 501 502 503
ESD Diode ESD Diode SW Diode SW Diode SW Diode
142236000006-FY 142236000006-FY 142200000019-FY 142200000019-FY 142200000019-FY
D D D D D
504 505 506 507 508
SW Diode SW Diode ESD Diode ESD Diode ESD Diode
142200000019-FY 142200000019-FY 142239000012-FY 142239000012-FY 142236000006-FY
D D D D D
510 800 801 806 901
ESD Diode REC Diode(A,B,C) REC Diode Schottky Diode REC Diode
142236000006-FY 122206000006-FY 142206000003-FY 142233000074-FY 122206000006-FY
L L L L L
2 102 103 104 105
Axis Inductor Inductor Inductor Axis Inductor Axis Inductor
142005000002-FY 122000000300-FY 142000000296-FY 142010000014-FY 142010000014-FY
Inductor Inductor
142000000298-FY 142000000028-FY
L 106 L 108
78
> FU1 > FU3 > FU201
RESISTORS R R R R R
1 3 4 5 8
RS1/10SR103J RS1/10SR102J RS1/10SR104J RS1/10SR0R0J RS1/10SR104J
R R R R R
15 101 102 103 104
RS1/10SR103J RS1/10SR102J RS1/10SR102J RS1/10SR101J 141608000330-FY
R R R R R
105 106 107 108 117
RS1/10SR472J RS1/10SR472J RS1/10SR223J RS1/10SR223J RS1/8SQ2R2J
R R R R R
127 128 129 130 131
RS1/10SR474J RS1/10SR474J RS1/10SR472J RS1/10SR102J RS1/10SR102J
DVH-750AV/XEUW5 1
2
3
4
5
Circuit Symbol and No. R R R R R
201 203 204 205 206
R R R R R
210 211 212 213 215
R R R R R
6
7
Part No.
Circuit Symbol and No.
8
Part No.
RS1/10SR750J RS1/4SA0R0J RS1/4SA0R0J RS1/10SR750J 141640000101-FY
R R R R R
437 438 439 440 442
141640000470-FY RS1/10SR330J 141640000101-FY RS1/10SR750J RS1/10SR750J
R R R R R
443 450 451 452 457
216 217 219 220 241A
RS1/10SR750J RS1/10SR750J RS1/8SQ0R0J RS1/8SQ0R0J RS1/10SR0R0J
R R R R R
458 459 460 460A 460B
R R R R R
320 321 322 323 324
RS1/10SR101J RS1/10SR560J RS1/10SR104J RS1/10SR103J RS1/4SA471J
R R R R R
461 462 463 464 465
R R R R R
325 326 327 328 329
141640000101-FY RS1/10SR223J RS1/10SR223J RS1/4SA471J RS1/10SR101J
R R R R R
466 467 468 473 474
RS1/10SR223J RS1/10SR561J RS1/10SR0R0J RS1/10SR103J RS1/10SR473J
R R R R R
330 331 340 341 342
RS1/10SR471J RS1/10SR223J RS1/10SR101J RS1/10SR223J RS1/10SR471J
R R R R R
475 476 477 480 482
RS1/10SR102J RS1/10SR103J RS1/10SR684J 141640000102-FY RS1/10SR102J
R R R R R
343 402 403 407 408
RS1/10SR101J 141640000473-FY 141618000101-FY RS1/10SR101J RS1/10SR102J
R R R R R
483 485 486 487 489
R R R R R
409 410 411 412 413
RS1/10SR101J RS1/10SR472J RS1/8SQ102J RS1/10SR561J RS1/10SR473J
R R R R R
490 494 495 496 497
R R R R R
414 415 417 418 419
RS1/10SR103J RS1/10SR103J 142040000189-FY RS1/10SR103J RS1/10SR562J
R R R R R
497A 498 498A 499 499A
R R R R R
420 422 423 424 425
RS1/10SR562J 141640000102-FY RS1/10SR102J RS1/10SR473J RS1/10SR473J
R R R R R
501 502 503 504 508
R R R R R
426 427 428 429 430
RS1/10SR473J 141640000101-FY RS1/10SR473J RS1/10SR103J RS1/10SR102J
R R R R R
509 510 511 512 513
R R R R R
431 432 433 434 435
RS1/10SR102J RS1/10SR102J RS1/10SR101J RS1/10SR101J RS1/10SR101J
R R R R R
514 515 516 517 518
RCF RCF RCF
RCF
RCF RCF
NET RES
RS1/10SR102J 141640000102-FY 141640000102-FY RS1/10SR473J RS1/10SR103J
A
RS1/10SR103J RS1/10SR473J RS1/8SQ102J 141618000473-FY RS1/10SR103J RS1/10SR101J RS1/10SR433J RS1/8SQ100J 141614000101-FY 141614000101-FY
RCF
B
141640000102-FY RS1/10SR0R0J RS1/10SR103J RS1/10SR104J RS1/10SR562J
C
RCF NET RES
Chip Bead
RCF
RCF
DVH-750AV/XEUW5 5
6
RCF
RCF
RCF
RCF
RS1/10SR102J RS1/8SQ102J RS1/4SA103J 141640000100-FY RS1/8SQ102J RS1/10SR102J RS1/4SA101J RS1/10SR103J 141640000103-FY RS1/10SR103J
D
RS1/10SR562J 141640000103-FY RS1/10SR103J RS1/10SR222J RS1/10SR103J RS1/10SR103J RS1/10SR103J RS1/10SR101J RS1/10SR222J RS1/10SR103J
RCF
RCF
7
E
141640000102-FY RS1/10SR473J RS1/10SR224J RS1/10SR223J RS1/10SR103J RS1/10SR123J 141640000223-FY RS1/10SR473J RS1/10SR105J RS1/10SR473J
8
F
79
1
Circuit Symbol and No.
A
B
RCF
2
3
Part No.
R R R R R
519 520 521 522 523
R R R R R
524 530 801 802 803A
RS1/10SR103J RS1/10SR223J RS1/8SQ473J RS1/10SR104J 141614019056-FY
R R R R R
803B 804 805 806 812
141614019056-FY RS1/8SQ561J RS1/10SR393J RS1/10SR153J RS1/10SR473J
R R R R R
813 814 819 820 821
R R R R R
830 831 840 841 842
RS1/10SR822J RS1/8SQ0R0J RS1/10SR0R0J RS1/10SR201J RS1/10SR272J
R R R R R
936 937 938 939 940
RS1/10SR473J RS1/10SR103J RS1/10SR822J RS1/10SR822J RS1/10SR822J
R R R R R
941 942 943 945 946
RS1/10SR822J RS1/10SR474J RS1/10SR474J RS1/10SR474J RS1/10SR474J
R R R R R
947 948 949 950 952
RS1/10SR273J RS1/10SR273J RS1/10SR273J RS1/10SR273J RS1/10SR103J
R R R R R
954 956 957 958 959
RS1/10SR101J RS1/10SR103J RS1/10SR153J RS1/10SR153J RS1/10SR752J
R R R R R
960 961 962 963 964
RS1/10SR752J RS1/10SR103J RS1/10SR103J RS1/8SQ223J RS1/8SQ223J
R R R R R
965 966 967 968 969
RS1/10SR472J RS1/10SR472J 141640000102-FY 141640000102-FY RS1/4SA472J
RCF RCF
141640000103-FY RS1/10SR103J RS1/10SR562J RS1/10SR752J RS1/10SR104J
RS1/10SR472J 141648000022-FY 141640000473-FY RS1/8SQ101J RS1/4SA0R0J
C
D
E
F
RCF RCF
R 971 R 986 R 987
RS1/4SA101J RS1/10SR102J RS1/10SR473J
CAPACITORS 80
4
Circuit Symbol and No.
Part No.
C C C C C
2 3 103 104 109
C C C C C
110 113 114 115 116
CKSRYB104K50 CCSRCH220J50 CCSRCH220J50 141803100105-FY 141803100105-FY
C C C C C
117 118 119 120 121
CKSRYB104K50 CKSRYB104K50 CKSRYB103K50 CKSRYB104K50 CKSRYB103K50
C C C C C
122 123 124 125 126
CKSRYB104K50 141803000474-FY 141803100105-FY 141803000474-FY 141803000474-FY
C C C C C
127 128 129 130 140
CCSRCH330J50 CCSRCH330J50 CKSRYB104K50 CKSRYB153K50 CKSRYB153K50
C C C C C
141 142 143 144 145
CKSRYB103K50 CKSRYB104K16 CKSRYB103K50 CCSRCH100D50 CKSRYB103K50
C C C C C
146 201 202 203 204
CKSRYB103K50 141809010106-FY 141809010106-FY CKSRYB104K16 141830090107-FY
C C C C C
205 206 207 208 209
E.CAP
141830110476-FY CKSRYB104K16 141809010106-FY 141809010106-FY 141809010106-FY
C C C C C
210 211 212 213 214
E.CAP E.CAP
E.CAP
141830090226-FY 141830090107-FY CKSRYB104K16 CKSRYB104K16 141830090107-FY
C C C C C
215 313 314 315 316
E.CAP E.CAP E.CAP E.CAP E.CAP
141830090226-FY 141830090107-FY 141830050225-FY 141830050225-FY 141830090226-FY
C C C C C
317 401 402 403 404
E.CAP
141830090226-FY CCSRCH120J50 CCSRCH120J50 CCSRCH220J50 CCSRCH220J50
C C C C C
405 406 407 408 409
E.CAP
E.CAP
E.CAP
CKSRYB102K50 CKSRYB102K50 CKSRYB102K50 CKSRYB102K50 141830090107-FY
CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 CKSRYB102K50 141830090107-FY
DVH-750AV/XEUW5 1
2
3
4
5
Circuit Symbol and No. E.CAP
6
C C C C C
410 411 412 413 414
C C C C C
415 419 420 451 473
C C C C C
474 475 501 502 502A
CKSRYB104K16 CKSRYB104K16 CKSRYB104K16 141803000225-FY 141803000225-FY
C C C C C
503 520 529 530 801
CKSRYB104K16 CKSRYB104K16 CCSRCH101J50 CCSRCH101J50 141830090107-FY
C C C C C
802 803 804 805 806
C C C C C
807 811 812 814 815
C C C C C
816 817 817A 818 819
C C C C C
819A 820 822 917 918
C C C C C
919 920 921 922 923
C C C C C
924 925 926 927 928
CKSQYB105K25 CKSQYB105K25 CKSQYB105K25 CKSRYB821K50 CKSRYB821K50
C C C C C
929 930 931 932 935
CKSRYB821K50 CKSRYB821K50 141830050225-FY 141830050225-FY 141830050225-FY
C C C C C
936 937 938 939 940
E.CAP
E.CAP E.CAP
E.CAP
E.CAP E.CAP
E.CAP
E.CAP
E.CAP
E.CAP
E.CAP
E.CAP E.CAP E.CAP E.CAP E.CAP E.CAP
7
Part No. 141830090107-FY CKSRYB104K16 141830090107-FY CKSRYB104K16 CKSQYB225K16
C C C C C
941 942 943 944 945
CKSRYB104K16 CKSQYB225K16 141890002209-FY 141830090226-FY 141830090226-FY
C C C C C
946 947 948 949 950
141830050225-FY 141830050225-FY 141830090226-FY CKSQYB225K16 CKSQYB225K16 6
CKSQYB225K16 CKSQYB225K16 141803000474-FY CKSRYB102K50 CKSRYB102K50
843DM7236GLSB001-FY(B) 843DM7236GMSB001-FY(C) 883DM7236GBSB001-FY(D) SB Ass'y
U 5
IC IC IC(A) IC(B) IC(C) IC(D) IC
142410000759-FY 142400001042-FY 842DM7236GRIC010-FY 842DM7236GLIC010-FY 842DM7236GMIC010-FY 882DM7236GBIC010-FY 142410000636-FY
U U U U U Q
6 8 9 10 11 1
IC IC IC IC IC Transistor
142400000819-FY 142410000806-FY 142400000416-FY 142400001047-FY 142400001048-FY 142251000005-FY
Q Q Q Q Q
2 3 4 5 6
Transistor FET FET FET Transistor
142251000005-FY 142266000069-FY 142266000002-FY 142266000002-FY 142290000012-FY
Q Q D D D
7 8 1 2 3
Transistor Transistor SW Diode SW Diode SW Diode
142290000005-FY 142290000144-FY 142200000019-FY 142200000019-FY 142200000019-FY
D D D D L
4 5 6 7 1
SW Diode SW Diode REC Diode Zener Diode Chip Bead
142200000019-FY 142200000019-FY 142206000013-FY 142224000016-FY 142040000012-FY
L L L L L
3 4 5 6 7
Chip Bead Chip Bead Inductor Inductor Inductor
142040000012-FY 142040000012-FY 142000000333-FY 142000000333-FY 142000000333-FY
L L L L L
8 11 12 13 14
Inductor Power Inductor Chip Bead Chip Bead Chip Bead
142000000333-FY 142000000116-FY 142040000189-FY 142040000189-FY 142040000189-FY
Chip Bead Chip Bead
142040000189-FY 142040000189-FY
L 15 L 16
DVH-750AV/XEUW5 5
A
B
MISCELLANEOUS
CKSRYB104K16 CKSRYB104K16 141830090107-FY 141809010106-FY CKSRYB104K16
141803010475-FY CKSRYB104K16 141842080338-FY CKSRYB104K16 CKSQYB105K25
141830090226-FY CKSRYB104K16 141830090107-FY CKSQYB225K16 CKSQYB225K16
E.CAP
Unit Number : Unit Number : Unit Number : Unit Name :
U 2 U 3 U 4
CKSRYB103K50 CKSRYB103K50 CKSRYB103K50 CKSRYB105K16 141830110476-FY
E.CAP
Part No.
B Unit Number : 843DM7236GRSB001-FY(A)
CKSRYB104K16 141830050225-FY 141830090107-FY CKSRYB104K16 CKSRYB103K50
141830090107-FY CKSRYB104K16 CKSRYB103K50 141842030108-FY CKSRYB104K16
8
Circuit Symbol and No.
7
8
C
D
E
F
81
1
Circuit Symbol and No.
A
B
C
D
E
2
3
Part No.
Circuit Symbol and No.
L 17 L 18 L 19
Chip Bead Chip Bead Chip Bead
142040000189-FY 142040000189-FY 142040000189-FY
L L L L L
20 21 22 23 24
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY
L 25 L 26 FB1 FB2 FB3
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000189-FY 142040000189-FY 142040000039-FY 142040000012-FY 142040000039-FY
FB4 FB5 FB6 FB8 FB15
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000054-FY 142040000006-FY 142040000006-FY 142040000039-FY 142040000012-FY
FB16 FB17 FB18 FB19 FB20
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000039-FY 142040000012-FY 142040000012-FY 142040000012-FY 142040000054-FY
FB21 FB22 FB23 TX1 TX2
Chip Bead Resistor Resistor TCXO 27 MHz TCXO 12 MHz
142040000054-FY RS1/16SS0R0J RS1/16SS0R0J 142825000059-FY 142825000105-FY
TC1 TC2 TC3 TC4 TC5
TAN.CAP TAN.CAP TAN.CAP Capacitor TAN.CAP
141845040107-FY 141845040107-FY 141845040107-FY 141806020106-FY 141845040107-FY
TC6 TC7 TC8 TC9 TC10
SMD E-CAP SMD E-CAP TAN.CAP TAN.CAP SMD E-CAP
141827000107-FY 141827000107-FY 141845010476-FY 141845040107-FY 141827000107-FY
TC11 SC1 SR1 SR2 SR3
SMD E-CAP Capacitor Resistor Resistor Resistor
141827000107-FY 141803000225-FY RS1/16SS472J RS1/16SS473J RS1/10SR222J
SR4 RP1 K 1 CN1 CN3
Resistor Resistor END-SENSE SW FFC Socket Wire Harnes
RS1/10SR102J RAB4CQ101J 123210000165-FY 143815000047-FY 123830000117-FY
CN6
FPC Socket
143800000109-FY
RESISTORS R R R R R F
1 2 3 4 5
RS1/8SQ100J RS1/8SQ100J RS1/10SR221J RS1/10SR221J RS1/16SS222J
R 6 R 7 R 8
RS1/16SS222J RS1/16SS103J RS1/16SS103J
82
4
Part No.
R 9 R 10
RS1/16SS103J RS1/16SS103J
R R R R R
11 12 13 14 15
RS1/16SS153J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS153J RS1/10SR103J
R R R R R
16 17 18 19 20
RS1/10SR103J RS1/10SR101J RS1/16SS103J RS1/16SS103J RS1/16SS103J
R R R R R
21 23 24 25 26
RS1/16SS103J RS1/16SS473J RS1/16SS103J RS1/16SS103J RS1/16SS103J
R R R R R
27 29 30 31 32
RS1/16SS103J RS1/16SS223J RS1/16SS223J RS1/8SQ0R0J RS1/10SR102J
R R R R R
33 34 35 36 37
RS1/10SR333J RS1/10SR102J RS1/16SS103J RS1/16SS103J RS1/10SR2001F
R R R R R
38 39 40 41 42
RS1/10SR2001F RS1/16SS103J RS1/16SS103J RS1/8SQ1R0J RS1/16SS0R0J
R R R R R
43 44 45 46 47
RS1/16SS103J RS1/16SS103J RS1/16SS103J RS1/16SS750J RS1/16SS750J
R R R R R
48 49 50 51 52
RS1/16SS750J RS1/16SS5102F RS1/16SS223J RS1/16SS5102F RS1/16SS5102F
R R R R R
53 54 55 56 57
RS1/16SS1502F RS1/10SR330J RS1/10SR0R0J RS1/10SR0R0J RS1/16SS101J
R R R R R
58 59 60 61 62
RS1/16SS101J RS1/10SR391J RS1/8SQ0R0J RS1/16SS102J RS1/8SQ2R2J
R R R R R
63 64 65 66 67
RS1/16SS103J RS1/16SS102J RS1/16SS102J RS1/10SR750J RS1/16SS102J
R 68 R 69 R 70
RS1/16SS221J RS1/16SS103J RS1/10SR750J
DVH-750AV/XEUW5 1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
Circuit Symbol and No.
8
Part No.
R 71 R 72
RS1/16SS103J RS1/10SR102J
C 14 C 15
R R R R R
73 74 75 76 77
RS1/10SR151J RS1/10SR750J RS1/16SS102J RS1/16SS750J RS1/16SS103J
C C C C C
16 17 18 20 21
SMD E-CAP SMD E-CAP
R R R R R
78 79 81 82 83
RS1/10SR750J RS1/16SS153J RS1/16SS750J RS1/16SS103J RS1/10SR472J
C C C C C
22 23 24 25 26
SMD E-CAP
R R R R R
84 85 86 87 88
RS1/16SS473J RS1/16SS472J 141604006191-FY RS1/8SQ750J RS1/16SS221J
C C C C C
27 28 29 31 32
SMD E-CAP
R R R R R
89 90 91 92 93
RAB4CQ102J RS1/16SS103J RS1/16SS470J RS1/10SR4R7J RS1/10SR472J
C C C C C
33 34 35 36 37
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB102K50
R R R R R
94 95 96 97 98
RS1/10SR472J RS1/10SR562J RS1/10SR562J RS1/10SR153J RS1/10SR153J
C C C C C
38 39 40 42 43
CKSRYB102K50 CKSSYB104K10 CKSSYB104K10 141845010476-FY CKSSYB104K10
R R R R R
99 100 101 102 103
RS1/10SR332J RS1/10SR332J RS1/8SQ151J RS1/10SR473J RS1/10SR473J
C C C C C
44 45 46 47 48
141803000151-FY CKSSYB104K10 CCSSCH330J50 CCSRCH100D50 CKSSYB104K10
R R R R R
104 105 106 107 108
RS1/10SR102J RS1/10SR102J RS1/16SS102J RS1/16SS102J RS1/16SS472J
C C C C C
49 50 51 52 53
CCSSCH330J50 CCSRCH100D50 141803000151-FY CKSSYB104K10 141809010106-FY
R R R R R
109 115 116 117 118
RS1/16SS103J RS1/16SS101J RS1/16SS103J RS1/10SR223J RS1/10SR223J
C C C C C
54 55 56 57 58
CKSSYB104K10 CKSSYB104K10 CCSRCH100D50 141803000151-FY CCSRCH100D50
R 119 R 120
RS1/10SR472J RS1/10SR473J
C C C C C
59 60 61 62 63
141803000151-FY CKSSYB104K10 CCSRCH101J50 CCSSCH220J50 CKSSYB104K10
C C C C C
64 65 66 67 68
CCSSCH220J50 CKSSYB104K10 CKSSYB104K10 141845040106-FY CKSSYB104K10
C C C C C
69 70 71 72 73
CAPACITORS C C C C C
1 2 3 4 5
141806020106-FY CKSSYB104K10 CKSRYB273K25 CKSSYB104K10 CKSSYB104K10
C C C C C
6 7 8 9 10
CKSSYB104K10 CKSRYB273K25 CKSSYB104K10 CKSSYB103K25 CKSSYB104K10
C 11 C 12 C 13
CKSRYB104K16 CKSSYB104K10 141806020106-FY
6
SMD E-CAP
SMD E-CAP SMD E-CAP
TAN.CAP
TAN.CAP
TAN.CAP
C 74 C 75 C 76
DVH-750AV/XEUW5 5
CKSSYB104K10 CKSRYB104K16 141827000107-FY 141827020476-FY CKSSYB104K10 CKSSYB104K10 141827020476-FY
A
141827000107-FY CKSSYB104K10 141827000107-FY CKSSYB104K10 141827010106-FY 141827000107-FY CKSSYB104K10 CKSSYB104K10 CKSSYB102K50 CKSSYB102K50
B
C
D
E
CKSSYB104K10 CKSSYB104K10 141845040106-FY CKSSYB104K10 CKSSYB104K10
F
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 7
8
83
1
Circuit Symbol and No.
A
B
C
D
E
F
2
3
Part No.
4
Circuit Symbol and No.
Unit Number : Unit Number : Unit Number : Unit Name :
Part No.
843DM7236GLKB012-FY(A) 843DM7236GLKB002-FY(B,C) CYW1020(D) KB Ass'y
C 77 C 78
CKSSYB104K10 CKSSYB104K10
C C C C C
79 80 82 83 84
CKSSYB104K10 CKSQYB225K16 141806000226-FY 141806000226-FY CKSSYB104K10
C C C C C
85 86 87 88 89
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
U U U Q Q
201 202 203 205 206
IC IC IC Transistor FET
142410000139-FY 142400001048-FY 142400001047-FY 142245000018-FY 142266000002-FY
C C C C C
90 91 92 93 94
CKSSYB104K10 CKSRYB152K50 CKSRYB152K50 CKSRYB272K50 CKSRYB272K50
Q D D D D
207 201 202 203 204
Transistor ESD Diode ESD Diode Schottky Diode ESD Diode
142251000020-FY 142239000012-FY 142239000012-FY 142233000120-FY 142236000006-FY
C C C C C
95 96 97 98 99
CKSRYB221K50 CKSRYB221K50 141806020106-FY 141806020106-FY CKSSYB104K10
D D D D D
205 206 207 208 209
ESD Diode ESD Diode ESD Diode ESD Diode ESD Diode
142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY
C C C C C
100 101 102 103 104
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10
D D D D D
210 211 212 213 214
ESD Diode ESD Diode ESD Diode ESD Diode ESD Diode
142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY 142236000006-FY
C C C C C
105 106 107 110 111
CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSRYB823K50 CKSRYB823K50
D L L L L
215 201 202 203 204
ESD Diode Inductor Inductor Power Inductor Chip Bead
142236000006-FY 142000000050-FY 142000000055-FY 142000000152-FY 142040000189-FY
C C C C C
112 113 114 115 116
141806020106-FY 141806020106-FY CCSSCH101J50 CCSSCH101J50 CCSSCH101J50
L L L L L
205 206 207 208 209
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY
C C C C C
117 118 119 120 121
CCSSCH101J50 CCSSCH101J50 CCSSCH101J50 CCSSCH101J50 CCSSCH101J50
L L L L L
210 211 212 213 214
Chip Bead Chip Bead Chip Bead Chip Bead Chip Bead
142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY
C C C C C
122 123 124 125 126
CCSSCH101J50 CCSSCH101J50 CCSSCH101J50 CCSSCH101J50 CCSSCH101J50
L 215 L 216 L 217 L 218 BD201
Chip Bead Chip Bead Chip Bead Chip Bead Resistor
142040000189-FY 142040000189-FY 142040000189-FY 142040000189-FY RS1/8SQ0R0J
C C C C
127 128 129 130
CCSSCH101J50 CCSSCH101J50 CCSSCH101J50 CCSSCH101J50
BD202 BD203 BD204 BD205 BD206
Chip Bead Resistor Chip Bead Chip Bead Chip Bead
142040000041-FY RS1/8SQ0R0J 142040000041-FY 142040000041-FY 142040000041-FY
KB Ass'y Consists of KB PCB AUX PCB
BD207 BD208 BD209 LED201A LED202A
Chip Bead Chip Bead Chip Bead LED LED
142040000041-FY 142040000041-FY 142040000041-FY 143405010069-FY 143405010069-FY
CD
LED203A LED204A LED205A
LED LED LED
143405010069-FY 143405010069-FY 143405010069-FY
84
MISCELLANEOUS
DVH-750AV/XEUW5 1
2
3
4
5
Circuit Symbol and No.
6
7
Part No.
LED208A LED209A
LED LED
143405010069-FY 143405010069-FY
LED210A LED211A LED212A XT201 ENC201
LED LED LED TCXO 14.318 18 MHz Encoder
143405010069-FY 143405010069-FY 143405010069-FY 142825000191-FY 121658000160-FY
SW208 SW209 SW210 SW211 SW212
Tact SW Tact SW Tact SW Tact SW Tact SW
123210000072-FY 123210000072-FY 123210000072-FY 123210000072-FY 123210000072-FY
SW213 SW214 SW215 SW217 SW221
Tact SW Tact SW Tact SW Tact SW Tact SW
123210000072-FY 123210000072-FY 123210000072-FY 123210000072-FY 123210000072-FY
REM201 USB201 CON1 CON201 CON202
Infrared Receiver Socket Socket Connector FPC Socket
143445000037-FY 123805000787-FY 123805000879-FY 123800000317-FY 143815000363-FY
RESISTORS
Circuit Symbol and No.
8
Part No.
R R R R R
244 245 246 247 250
RS1/8SQ471J RS1/8SQ471J RS1/8SQ471J RS1/8SQ471J RS1/10SR103J
R R R R R
251 252 253 254 255
RS1/10SR473J RS1/10SR103J RS1/8SQ2R2J RS1/10SR272J RS1/10SR103J
R R R R R
256 257 258 260 267
NET RES NET RES NET RES
R 268 R 269
141616000330-FY 141616000330-FY 141616000330-FY RS1/8SQ100J RS1/10SR0R0J
CAPACITORS C C C C C
47 49 201 202 203
CKSRYB102K50 CKSRYB102K50 CKSRYB103K50 CKSRYB103K50 CKSRYB104K16
67 68 201 202 207A
RS1/10SR223J RS1/10SR223J RS1/10SR102J RS1/10SR122J 141604010752-FY
C C C C C
204 207 208 209 210
CCSRCH101J50 CKSRYB331K50 CKSRYB681K50 CKSRYB331K50 CKSRYB104K16
R R R R R
208 209 210 211 212
RS1/10SR332J RS1/10SR392J RS1/10SR562J RS1/10SR102J RS1/10SR122J
C C C C C
212 213 214 215 216
CCSRCH330J50 CCSRCH330J50 CKSRYB104K16 121803000201-FY CKSRYB104K16
R R R R R
213 214 215 216 217
RS1/10SR102J RS1/10SR102J RS1/10SR152J RS1/10SR182J RS1/10SR222J
C C C C C
217 218 219 220 221
CKSRYB104K16 141809000106-FY 141842070107-FY 141809000106-FY CKSRYB104K16
R R R R R
218 219 220 225 227
RS1/10SR332J RS1/10SR203J RS1/10SR101J RS1/10SR103J RS1/10SR103J
C C C C C
222 223 224 225 226
R R R R R
228 229 230 231 232
RS1/10SR103J RS1/10SR102J RS1/10SR102J RS1/10SR332J RS1/10SR332J
C C C C C
227 228 229 230 231
R R R R R
233 234 235 236 237
RS1/10SR223J RS1/10SR223J RS1/10SR223J RS1/10SR180J RS1/10SR560J
C C C C C
232 233 234 235 236
CKSRYB105K16 CKSRYB104K16 141809000475-FY 141809000475-FY 141809000475-FY
R R R R R
238 239 240 242 243
RS1/10SR103J RS1/10SR105J RS1/10SR103J RS1/10SR103J RS1/8SQ471J
C C C C C
237 238 239 240 241
141809000475-FY 141809000475-FY CKSQYB225K16 141809000475-FY 141809000475-FY
DVH-750AV/XEUW5 6
B
RS1/8SQ470J RS1/8SQ470J
R R R R R
5
A
E.CAP
E.CAP E.CAP
E.CAP
7
C
D
141842070107-FY CKSRYB104K16 141842070107-FY CKSRYB104K16 141812010226-FY CKSRYB104K16 141842070107-FY CKSRYB104K16 CKSRYB105K16 CKSRYB105K16
8
E
F
85
1
2
Circuit Symbol and No.
A
3
4
3
4
Part No.
C C C C C
242 243 244 245 246
CKSQYB225K16 141809000475-FY CKSQYB225K16 CKSQYB225K16 141809000475-FY
C C C C C
247 248 250 270 271
141809000475-FY CKSRYB104K16 141812010226-FY 141809000106-FY 121803000201-FY
E Unit Number : 843DM7236GLCB002-FY(A,B,C) B
Unit Number : CYW1018(D) Unit Name : CB Ass'y MISCELLANEOUS CON1
Connector
123800020170-FY
F Unit Number : 843DM7236GLLB002-FY(A,B,C) C
Unit Number : CYW1019(D) Unit Name : LB Ass'y MISCELLANEOUS LED1 LED2 SW1 SW2 SW3
LED LED Tact SW Tact SW Tact SW
143405010069-FY 143405010069-FY 123210010125-FY 143210010096-FY 143210000097-FY
CN406
FPC Socket
123800010040-FY
D
E
F
86
DVH-750AV/XEUW5 1
2
