Pioneer Deh 1450ub

ORDER NO.

CRT4727 DEH-14UB/XNUC

CD RDS RECEIVER

DEH-14UB

/XNUC

DEH-1450UB DEH-1450UB DEH-1450UBG DEH-1490UB

/XNES /XNES1 /XNES

/XNID

This service manual should be used together with the following manual(s): Model No. CX-3287

Order No. CRT4759

Mech. Module S11.6STD

Remarks CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly

PIONEER CORPORATION 1-1, Shin-ogura, Saiwai-ku, Kawasaki-shi, Kanagawa 212-0031, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2011

K-ZZZ JUNE 2011 Printed in Japan

1

2

3

4

SAFETY INFORMATION CAUTION

A

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician. WARNING

This product may contain a chemical known to the State of California to cause cancer, or birth defects or other reproductive harm. Health & Safety Code Section 25249.6 - Proposition 65

B

Where in a manufacturer’s service documentation, for example in circuit diagrams or lists of components, a symbol is used to indicate that a specific component shall be replaced only by the component specified in that documentation for safety reasons, the following symbol shall be used:

- Safety Precautions for those who Service this Unit. When checking or adjusting the emitting power of the laser diode exercise caution in order to get safe, reliable results. C

Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer.

CAUTION: USE OF CONTROLS OR ADJUSTMENTS OR PERFORMANCE OF PROCEDURES OTHER THAN THOSE SPECIFIED HEREIN MAY RESULT IN HAZARDOUS RADIATION EXPOSURE.

CAUTION This product is a class 1 laser product classified under the Safety of laser products, IEC 60825-1:2007, and contains a class 1M laser module. To ensure continued safety, do not remove any covers or attempt to gain access to the inside of the product. Refer all servicing to qualified personnel.

D

CAUTION—CLASS 1M INVISIBLE LASER RADIATION WHEN OPEN, DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

E

WARNING! The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. F

2

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

A

Laser diode characteristics Wave length : 785 nm to 814 nm Maximum output : 1 190 µW(Emitting period : unlimited)

Additional Laser Caution Transistors Q101 in PCB drive the laser diodes. When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam.

B

CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions.

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

3

1

2

3

4

CONTENTS SAFETY INFORMATION..................................................................................................................................... 2 1. SERVICE PRECAUTIONS ............................................................................................................................... 5 1.1 SERVICE PRECAUTIONS ........................................................................................................................ 5 1.2 NOTES ON SOLDERING .......................................................................................................................... 6 2. SPECIFICATIONS ............................................................................................................................................ 7 2.1 SPECIFICATIONS ..................................................................................................................................... 7 2.2 DISC/CONTENT FORMAT ........................................................................................................................ 8 3. BASIC ITEMS FOR SERVICE.......................................................................................................................... 9 3.1 CHECK POINTS AFTER SERVICING....................................................................................................... 9 3.2 PCB LOCATIONS .................................................................................................................................... 10 3.3 JIGS LIST .................................................................................................................................................11 3.4 CLEANING................................................................................................................................................11 4. BLOCK DIAGRAM.......................................................................................................................................... 12 5. DIAGNOSIS.................................................................................................................................................... 14 5.1 OPERATIONAL FLOWCHART ................................................................................................................ 14 5.2 ERROR CODE LIST ................................................................................................................................ 15 5.3 CONNECTOR FUNCTION DESCRIPTION ............................................................................................. 17 6. SERVICE MODE ............................................................................................................................................ 18 6.1 DISPLAY TEST MODE ............................................................................................................................ 18 6.2 CD TEST MODE ...................................................................................................................................... 19 7. DISASSEMBLY .............................................................................................................................................. 20 8. EACH SETTING AND ADJUSTMENT ........................................................................................................... 26 8.1 CD ADJUSTMENT................................................................................................................................... 26 8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT.................................................... 27 8.3 PCL OUTPUT CONFIRMATION.............................................................................................................. 29 9. EXPLODED VIEWS AND PARTS LIST.......................................................................................................... 30 9.1 PACKING ................................................................................................................................................. 30 9.2 EXTERIOR............................................................................................................................................... 32 9.3 CD MECHANISM MODULE..................................................................................................................... 34 10. SCHEMATIC DIAGRAM............................................................................................................................... 36 10.1 TUNER AMP UNIT (GUIDE PAGE) ....................................................................................................... 36 10.2 KEYBOARD UNIT.................................................................................................................................. 42 10.3 CD CORE UNIT (S11.6STD) ................................................................................................................. 44 10.4 WAVEFORMS ........................................................................................................................................ 46 11. PCB CONNECTION DIAGRAM.................................................................................................................... 48 11.1 TUNER AMP UNIT................................................................................................................................. 48 11.2 KEYBOARD UNIT .................................................................................................................................. 52 11.3 CD CORE UNIT (S11.6STD).................................................................................................................. 54 12. ELECTRICAL PARTS LIST .......................................................................................................................... 56

A

B

C

D

E

F

4

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

1. SERVICE PRECAUTIONS 1.1 SERVICE PRECAUTIONS

A

1. You should conform to the regulations governing the product (safety, radio and noise, and other regulations), and should keep the safety during servicing by following the safety instructions described in this manual. 2. Before disassembling the unit, be sure to turn off the power. Unplugging and plugging the connectors during power-on mode may damage the ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. 5. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. 6. area and a heat sink becomes hot areas. Be careful not to burn yourself.

B

C

D

7. Software update The software of this product is stored in IC671. Please replace IC671 when making the version upgrade of software.

E

F

DEH-14UB/XNUC 5

6

7

8

5

1

2

3

4

A

8. Capacitor Bond Lock (UC) Acetate Tape (GYH1026) 1 Please stick acetate tape along white line. 2 Please confirm line hiding with acetate tape. * length of tape : 24 ± 4 mm 1 2

B

9. Capacitor Bond Lock (ID, ES, ES1) Silicon Glue (GEM1017) Place the capacitor in the center of the silk print, and confirm it does not touch to the connector. Then, apply silicon glue.

C

NG

OK

1.2 NOTES ON SOLDERING D

For environmental protection, lead-free solder is used on the printed circuit boards mounted in this unit. Be sure to use lead-free solder and a soldering iron that can meet specifications for use with lead-free solders for repairs accompanied by reworking of soldering. Compared with conventional eutectic solders, lead-free solders have higher melting points, by approximately 40 C. Therefore, for lead-free soldering, the tip temperature of a soldering iron must be set to around 373 C in general, although the temperature depends on the heat capacity of the PC board on which reworking is required and the weight of the tip of the soldering iron. Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). E

The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia.

F

6

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

2. SPECIFICATIONS 2.1 SPECIFICATIONS

A

DEH-14UB/XNUC General Power source .................. 14.4 V DC (10.8 V to 15.1 V allowable) Grounding system ........... Negative type Maximum current consumption ................................ 10.0 A Backup current .............. 4.0 mA or less Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm (7 in. × 2 in. × 6-1/2 in.) Nose .................. 188 mm × 58 mm × 16 mm (7-3/8 in.× 2-1/4 in.× 5/8 in.) D Chassis .............. 178 mm × 50 mm × 165 mm (7 in.× 2 in.× 6-1/2 in.) Nose .................. 170 mm × 46 mm × 16 mm (6-3/4 in.× 1-3/4 in.× 5/8 in.) Weight ............................. 1.1 kg (2.4 lbs)

Usable discs ...................Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IHF-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)

USB USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)

B

FM tuner

Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ...................... –18 dB/oct Gain ......................... +6 dB to –24 dB Phase ..................... Normal/Reverse

CD player

Frequency range ............. 87.9 MHz to 107.9 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IHF-A network)

C

AM tuner Frequency range .............. 530 kHz to 1 710 kHz Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IHF-A network)

CEA2006 Specifications

D

Power output ................... 14 W RMS × 4 Channels (4 Ω and < = 1 % THD+N) S/N ratio .......................... 91 dBA (reference: 1 W into 4 Ω)

Note Specifications and the design are subject to modifications without notice.

System .......................... Compact disc audio system

E

Securing the front panel The front panel can be secured with the supplied screw.

F

Screw (BPZ20P060FTC) (UC) (XXX7020) (ID, ES)

DEH-14UB/XNUC 5

6

7

8

7

1

A

2

3

4

DEH-1450UB/XNES, DEH-1450UBG/XNES, DEH-1490UB/XNID WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format .......... Linear PCM & MS ADPCM (Non-compressed)

General Rated power source .........14.4 V DC (allowable voltage range: 12.0 V to 14.4 V DC) Grounding system ............Negative type Maximum current consumption ................................ 10.0 A Backup current .............. 4.0 mA or less

USB USB standard specification ................................... USB 2.0 full speed Maximum current supply ................................... 1 A USB Class ....................... MSC (Mass Storage Class) File system....................... FAT12, FAT16, FAT32 MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3 WMA decoding format ..... Ver. 7, 7.1, 8, 9, 10, 11, 12 (2 ch audio) (Windows Media Player) WAV signal format ...........Linear PCM & MS ADPCM (Non-compressed)

Dimensions (W × H × D): DIN Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 188 mm × 58 mm × 16 mm D Chassis .............. 178 mm × 50 mm × 165 mm Nose .................. 170 mm × 46 mm × 16 mm Weight ............................. 1.1 kg

B

FM tuner Audio Maximum power output ... 50 W × 4 Continuous power output ................................... 22 W × 4 (50 Hz to 15 000 Hz, 5 % THD, 4 Ω load, both channels driven) Load impedance .............. 4 Ω (4 Ω to 8 Ω allowable) Preout maximum output level ................................... 2.0 V Tone controls: Bass Frequency .......... 100 Hz Gain .................. ±12 dB Mid Frequency .......... 1 kHz Gain .................. ±12 dB Treble Frequency .......... 10 kHz Gain .................. ±12 dB Subwoofer (mono): Frequency ................. 50 Hz/63 Hz/80 Hz/100 Hz/ 125 Hz Slope ...................... –18 dB/oct Gain ......................... +6 dB to –24 dB Phase ..................... Normal/Reverse

C

D

CD player System .......................... Compact disc audio system Usable discs .................. Compact disc Signal-to-noise ratio ......... 94 dB (1 kHz) (IEC-A network) Number of channels ........ 2 (stereo) MP3 decoding format ...... MPEG-1 & 2 Audio Layer 3

Frequency range ............. 87.5 MHz to 108.0 MHz Usable sensitivity ............. 9 dBf (0.8 µV/75 Ω, mono, S/N: 30 dB) Signal-to-noise ratio ......... 72 dB (IEC-A network)

MW tuner Frequency range .............. 531 kHz to 1 602 kHz (9 kHz) 530 kHz to 1 640 kHz (10 kHz) Usable sensitivity ............. 25 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)

SW tuner Frequency range .............. 2 300 kHz to 7 735 kHz (2 300 kHz to 2 495 kHz, 2 940 kHz to 4 215 kHz, 4 540 kHz to 5 175 kHz, 5 820 kHz to 6 455 kHz, 7 100 kHz to 7 735 kHz) 9 500 kHz to 21 975 kHz (9 500 kHz to 10 135 kHz, 11 580 kHz to 12 215 kHz, 13 570 kHz to 13 870 kHz, 15 100 kHz to 15 735 kHz, 17 500 kHz to 17 985 kHz, 18 015 kHz to 18 135 kHz, 21 340 kHz to 21 975 kHz) Usable sensitivity ............. 28 µV (S/N: 20 dB) Signal-to-noise ratio ......... 62 dB (IEC-A network)

Note Specifications and the design are subject to modifications without notice.

E

2.2 DISC/CONTENT FORMAT

F

8

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

3. BASIC ITEMS FOR SERVICE

3.1 CHECK POINTS AFTER SERVICING A

To keep the product quality after servicing, please confirm following check points. No. 1

4

Procedures Confirm whether the customer complain has been solved. If the customer complain occurs with the specific media, use it for the operation check. Play back a CD. (Track search) Check FM/AM tuner action. (Seek, Preset) Switch band to check both FM and AM. Check whether no disc is inside the product.

5

Appearance check

2 CD 3 FM/AM tuner

Item to be confirmed The customer complain must not be reappeared. Display, audio and operations must be normal. No malfunction on display, audio and operation. Display, audio and operations must be normal.

B

The media used for the operating check must be ejected. No scratches or dirt on its appearance after receiving it for service.

See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

9

1

2

3

4

3.2 PCB LOCATIONS A

B

C CD Core Unit (S11.6STD)

C

A Tuner Amp Unit B Keyboard Unit D

A:DEH-14UB/XNUC B:DEH-1450UB/XNES C:DEH-1450UB/XNES1 D:DEH-1450UBG/XNES E:DEH-1490UB/XNID E

Unit Number

: QWM3319(A) : QWM3320(B,C,D,E)

Unit Name

: Tuner Amp Unit

Unit Number

: (A,B,C,E) : (D)

Unit Name

: Keyboard Unit

Unit Number

: CWX4023

Unit Name

: CD Core Unit (S11.6STD)

F

10

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

3.3 JIGS LIST - Jigs List Name 16P FFC Test Disc L.P.F. Acetate Tape Silicon Glue

A

Jig No. GGD1310 TCD-782 GYH1026 GEM1017

Remarks Tuner Amp Unit - CD Core Unit Checking the grating Checking the grating (Two pieces) Capacitor Bond Lock Capacitor Bond Lock

Grease No. GEM1024 GEM1038 GEM1043 GEM1045

Remarks CD Mechanism Module CD Mechanism Module CD Mechanism Module CD Mechanism Module

- Grease List Name Grease Grease Grease Grease

B

C

3.4 CLEANING

Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned CD pickup lenses

Cleaning tools Cleaning liquid : GEM1004 Cleaning paper : GED-008

D

E

F

DEH-14UB/XNUC 5

6

7

8

11

1

2

3

4

4. BLOCK DIAGRAM A

A

TUNER AMP UNIT

JA401 5

1

ANTENNA

16

2,3

18

FMMIXIN1

57

DACOUTL

PINDIN LNAIN

RF FRONT END IC IC401 TDA7706

I2CSCL

I2CSDA RSTN

34

112

33

111

31

107

DAC IC231 PCM1753DBQ

TUNSCL TUNSDA TUNPCE1 DACCS DACSCK DACLRCK DACDATA

B

DACBDATA DACBSCK AUDIO_XOUT

124

15

91

1

89

3

88

2

87

13

85

14

84

16

ML BCK LRCK VOUTL

DATA

7

MD MC SCK

JA892 69

2 KEYAD

WIRED REMOTE

129

3 KEYD

RESET

KEYAD KEYD

RES

1 GND

38

IC651 S-80827CNMC-B8M

1

B C D E ILMPW Q871 B.UP

SYSTEM MICRO COMPUTER IC601 (1/2) R5S7266ZD144FP ILMPW

FLASH ROM IC671 A :PEB035A8 B C D E :PEB034A8

C

ILM+B Q872

132 Q873

DIMMER

4

REGULATOR IC IC912 BA49182-V12

A :DEH-14UB/XNUC B :DEH-1450UB/XNES C :DEH-1450UB/XNES1 D :DEH-1450UBG/XNES E :DEH-1490UB/XNID

6

SW5V

SW5V

9

SWVDD

7

VDD3.3V

VDD

8

VDD1.2V

BSENS SYSPW SW5VCNT

11

128

1

141

2

7

SWVDD BSENS SYSPW

3

VDD12

5

SYS+B

VDDCONT

SWVDD

+B

SYS+B

+BUP

4

B.UP

10

SY C

D

C

PICKUP UNIT (P10.6)(SERVICE)

USB5V REGULATOR

VCC LD

LD-

MD

12

12

15

15

MD 5

V+3A

8

RF AMP, CD DECODER DIGITAL SERVO/DATA • PROCESSOR CPU

VDD

GND

1

Q101

2

5 PD

IC510 BD2232G-G VIN

LD

8

8

93

REFO

FOM

E

FOP

4

3 2

3 2

FOM

54 USB5V

5

EN

VDD

TOM 4

4 TOM

TD,FD

14 LD+

SD,MD

14

8 7

9

VOUT

OC

18

4

20

VDD

9

SOP

VDD

USBFLG

VBUS

VDD3.3V 67

VD

VD

TKO-

2

2

1

1

VD

VDSENS

Q751 B.UP Q752

FCO+ FCO-

M

SOM

3 SPO+ 2 SPO-

LOADING/CARRIAGE MOTOR

M

LCOP LCOM

5 4

14 23

40

22

41

MUTE 21

39

CNT LDIN

SLLDO+ SLLDO-

38 35 S903 DSCSNS

9

USBCTL

MECHA VD

TKO+

SPINDLE MOTOR

LOEJ CONT

DSCSNS

RESET

RESET

29

8

CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT)

8

RESET

120

CD DATA (CDSRQ,CDSTBY,SKIP, SCL,SDA,DATA,BCLK,LRCK,WAIT)

HOME

S901 HOME

2

VDCONT

CLCONT

DEH-14UB/XNUC 1

INV

3

CN701

IC301 BD8223EFV

1 TOP

SYNC

FB

54

CN701

ACTUATOR/ MOTOR DRIVER

FOP

10

12

PUEN

19

SW

VDD

IC201 PE5791A

TOP 1

LD+

F

REFOUT

VIN

AC,BD,E,F

HOLOGRAM UNIT

FOCUS ACT.

2 3

V+3A

PVIN

EN/ 5 SYNC 1

Q102 PD

REFO VREF

TRACKING ACT.

1

B.UP

CN101

R5S

IC501 BD9008F

CD CORE UNIT(S11.6 STD)

3

4

CDRST

5

6

7

8

A

JA251 PL

3

RCA OUT

Q251 1

TUNL

2

CDL

1

AUXL

4

6

POUT_L

IN2_L

P251

ELECTRONIC VOLUME/ SOURCE SELECTOR IC201 PML022A

IN1_L

B

JA901 IN4+_L

7

FRONT_L

11

FL+ FLIn FL-

VST VDT VCK

26

15

27

13

30

14

18

B.UP

STB

8

REAR_L

12

RLIn

DATA CLK

MUTE Q351 (1/2)

22

RL+

AMP IC301 PA2030A

MUTE

RL-

B.REM

9

FL+

7

FL-

5

RL+

3

RL-

BREM

25

1 3 5 7

14

POWER CONNECTOR Q351 (2/2) MUTE

21

C

ASENS Q931

ASENS 128 141 7

143

ACC

13

SWVDD BSENS SYSPW

B

B.UP

SYSTEM MICRO COMPUTER IC601 (2/2) R5S7266ZD144FP

01 008F

KEYBOARD UNIT JA1921

CN801

SSENS

AUXL 19 SOURCE 18

142

FRONT_AUX

AUXGND 1 AUXR 3 AUXL 2

CN1821 AUXL 19 SOURCE 18

D

SOURCE 4 S1826

SRC

ROTARY COMMANDER EN/ SYNC

5

19

S1842

SYNC ROT0 ROT1

131

ROT0

130

ROT1

6

6

4

4

ROT0

2

ROT1

1

S1827 5

KDT2

4

KST1

3

18 20

54

KDT0

USBCTL

KDT1

USBFLG

KDT2 KDT3

VBUS KYDT

KYDT

29

8

8

KYDT

20

KST0 KYDT

IC801 TC7SET08FUS1 DPDT 67

28

2

4

DPDT

10

10

20

20

DPDT

18

VDSENS DSENS

140

DSENS

DPDT

KST1

LCD DRIVER/ KEY CONTROLLER IC1801 PD6581A

KST2 KST3 KST4

15 16 25 26 14

KEY MATRIX

13 12 11 28

E LCD V1801

DSENS

.UP

REMOTE CONTROL SENSOR REM 14

VDCONT

5

ILM+B

120

1

17

5

ILM+B

CDRST

SWVDD

3

3

11

11

IC1802 GP1UXC14RK

SWVDD

D1851,D1852,D1853,D1854, D1855,D1856,D1857,D1858, D1859,D1860,D1861,D1862, D1863,D1864,D1865

D1866

CN1911 USB5V DM DP

52

DM

53

DP

13 15

13 15

USB5V

USB5V DM

DM

DP

DP

DEH-14UB/XNUC 5

6

7

F

2 3

USB

4

8

13

1

2

3

4

5. DIAGNOSIS

5.1 OPERATIONAL FLOWCHART A

Power ON

Vcc = 1.2 V Pin 5 PVcc = 3.3 V Pin 1

BSENS

B

Pin 141 BSENS = L

ASENS Pin 143 ASENS = L C

DSENS Pin 140 DSENS = L

Starts communication with Grille microcomputer.

D

300 ms

SWVDD <- H Pin 128

300 ms In case of the above signal, the communication with Grille microcomputer may fail. If the time interval is not 300 msec, the oscillator may be defective.

Source keys operative E

Source ON

SYSPW <- H Pin 7

F

Completes power-on operation. (After that, proceed to each source operation)

14

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

5.2 ERROR CODE LIST ERROR CODES A

If a CD memory device is inoperable, or operation of such media is stopped by an error, the error mode is established and a cause of the error is displayed by an error code. Indication of error codes is intended to reduce the number of calls from customers and facilitate failure analysis and repair work in servicing.

(1) DISPLAY METHOD If “0xFD” error mode is displayed in CD MODE (CD MODE area for display), an error code will be displayed in the MIN (minute display) and SEC (second display) areas. The same code is displayed in the MIN and SEC areas. The TNO area is blank (#0FFH), as it conventionally was. • Display example of the head unit Depending on the display capability of LCDs, the display format varies, as shown below. XX denotes an error number. Note: In a case of an OEM product, the error display format is subject to the specifications used by the equipment manufacturer. 8-digit display

6-digit display

ERROR-xx

ERR-xx

B

4-digit display E-xx

(2) LIST OF CD ERROR CODES (Error Mode: 0xFD) Code Classification Error code to be displayed

Details and possible causes

07

Servo

TOC reading NG

TOC information cannot be read. --> The partial disk or TOC content is illegal.

10

Servo

Carriage Home NG

11

Servo

Focus NG

The pickup cannot move toward the inner track. The CRG cannot move from the inner track. --> Defective HOME SW; Failure in CRG movement. Focusing not available --> Disc placed upside-down; Stains on the disc; excessive vibration.

12

Servo

Spindle Lock NG Subcode NG RF-amp NG

Spindle not locked. Subcode not readable. Proper RF AMP gain not obtained. --> Defective spindle; Scratches or stains on the disc; excessive vibration. --> A CD-R/RW disc that does not contain data loaded, or in a rare case, disc placed upside-down. --> RF signal error.

15

Servo

RF NG

The digital signal from the disc cannot be detected. --> A CD-R/RW disc that does not contain data loaded.

17

Servo

Setup NG

The laser output cannot be adjusted. Focus can be easily lost. --> Scratches or stains on the disc; excessive vibration.

30

Servo

Search Time Out

Failed to reach a target address. And, the search became a timeout. --> Carriage/Tracking error; Scratches on the disc; Stains on the disc

50

Mechanism

Load NG Eject NG

Disc loading/ejection not completed --> A foreign object inserted in the mechanism; Disc jammed.

51

Mechanism

Failure in retried turning for ejection

Disc could not be ejected even after disc turning had been retried. --> A foreign object inserted in the mechanism; Disc jammed.

C

D

E

NOTES • Indications of error codes are available only during disc operations, because CD operations are unavailable if a mechanical error is generated. • If the TOC cannot be read, It stops because of error 07. • If you design a new head unit, be sure to use one of the display formats indicated in “Display example of the head unit.” • The 2 high-order digits of an error code denote the main classification, shown below. code classification 0x 1x Servo-related errors 3x 5x Mechanism-related errors F

• How to restore from each error is shown below. Servo-related errors(0X, 1X, 3X) : Servo-related errors CD Off, Eject, ACC Off, Back-up Off, Communication reset, Reset Load NG/Eject NG(50) : Reload, Eject, ACC Off, Back-up Off, Communication reset, Reset Failure in retried turning for ejection : CD On, Eject, ACC Off, Back-up Off, Communication reset, Reset

DEH-14UB/XNUC 5

6

7

8

15

1

2

3

4

USB storage device A

B

Message

Cause

Action

Message

Cause

Action

NO DEVICE

When plug and play is off, no USB storage device is connected.

 Turn the plug and play on.  Connect a compatible USB storage device.

SKIPPED

The connected USB storage device contains files embedded with Windows Media™ DRM 9/ 10.

Play an audio file not embedded with Windows Media DRM 9/10.

PROTECT

All the files in the USB storage device are embedded with Windows Media DRM 9/10.

Transfer audio files not embedded with Windows Media DRM 9/10 to the USB storage device and connect.

N/A USB

The USB device connected to is not supported by this unit.

 Connect a USB Mass Storage Class compliant device.  Disconnect your device and replace it with a compatible USB storage device.

CHECK USB The USB connector or USB cable has shortcircuited.

Check that the USB connector or USB cable is not caught in something or damaged.

The connected USB storage device consumes more than 500 mA (maximum allowable current).

Disconnect the USB storage device and do not use it. Turn the ignition switch to OFF, then to ACC or ON and then connect only compliant USB storage devices.

Message

Cause

Action

ERROR-19

Communication Perform one of failed. the following operations. –Turn the ignition switch OFF and back ON. –Disconnect the USB storage device. –Change to a different source. Then, return to the USB source.

ERROR-23

USB storage de- USB storage device was not for- vice should be formatted with matted with FAT12, FAT16 or FAT12, FAT16 or FAT32. FAT32.

FRMT READ Sometimes there is a delay between the start of playback and when you start to hear any sound.

Wait until the message disappears and you hear sound.

NO AUDIO

Transfer the audio files to the USB storage device and connect.

There are no songs.

The connected USB storage device has security enabled.

Follow the USB storage device instructions to disable the security.

C

D

E

F

16

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

5.3 CONNECTOR FUNCTION DESCRIPTION A

B

REAR OUTPUT

ANTENNA 15 13 11 9 7 5 3 1 16 14 12 10 8 6 4 2

1 2 3 4 5 6 7 8

9 10 11 12 13 14 15 16

FL+ FR+ FLFRRL+ RR+ RLRR-

WIRED REMOTE CONTROL (Except DEH-14UB/XNUC)

NC NC NC NC ACC B.REM B.UP GND

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

17

1

2

3

4

6. SERVICE MODE

6.1 DISPLAY TEST MODE A

The information such as the system microcomputer version is checked.

[How to enter Test mode] Press “ 1 ” and “ 3 ” keys simultaneously to start resetting.

[Operation key] Operation key

Processing

1+3

Enter display test mode Switch to next test mode

Remarks

B

[Test items] Start display test mode. (Press “ 1 ” + “ 3 ” keys simultaneously to start resetting.)

Key Illumination

Icon

Off

All off

On (an initial value)

All off

* Initial condition

System Version information is displayed. C

S

$ $ $ $

# # #

14SEG

$ PD number

For PEA010A, "010A" is displayed

# System microcomputer version

For Ver.7.01, "701" is displayed

On (an initial value or setting value of default menu)

All off

D

Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously. Display is normally updated Product operation is performed as usual, in appearance. On (an initial value or setting value of default Switching to next display menu) by pressing “ 1 ” + “ 3 ” keys simultaneously.

E

On (lighting condition of normal times)

Display update is stopped The screen gets still when entering this item. Switching to next display by pressing “ 1 ” + “ 3 ” keys simultaneously.

On (an initial value or setting value of default menu)

On (state when entering test mode)

F

18

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

6.2 CD TEST MODE A

- Flow Chart [4]+[6]->BUP+ACC ON Test Mode IN

[Key]

[CD] or [SOURCE] Source ON

TRK

Contents

MIN

Display

[BAND]

[2] RF AMP *1 Gain switching TRK MIN SEC

Power On (T.Offset is adjusted) TRK MIN SEC

00

[BAND]

MIN

SEC

[BAND]

91

91

SEC

TRK

MIN

*2 TRK

MIN

SEC

0X

0X

0X

TRK

MIN

SEC

[>]

00 00 00 or 99 99 99

[3]

??

??

??

[3]

F,T,RF AGC*5 F.Bias display switching TRK MIN SEC

??

??

??

[<] CRG -

*6 00 00 00 or 99 99 99

*6 00 00 00 or 99 99 99

Self-adjusting switching *3 TRK MIN SEC

??

[<] CRG -

8X 8X 8X or 9X 9X 9X


[>]

[<] CRG/TR Jump -

*4

*4

?tr ?min ?sec

?tr ?min ?sec

MIN

SEC

TRK

??

T.Balance adjustment / T.BAL coefficient display TRK MIN SEC

??

??

??

[2]

CRG/TR Jump + TRK

??

[2]

CRG +

F,T AGC / F.Bias RF AGC TRK MIN SEC

B

[2]

CRG +

[>]

RF AGC / RF AGC coefficient display TRK MIN SEC

SEC

[1]

Power Off

GG

Tracking Servo Close

?tr ?min ?sec

[BAND]

GG

[1]

Focus Mode switching

[1] T.Close & AGC Applicable servomechanism

Power Off MIN

GG

[6]

Focus Close S curve check TRK MIN SEC

91

TRK

00

[3]

Power Off TRK

00

MIN

Tracking Open

SEC

?tr ?min ?sec


C

*6 [BAND]

[2]

Power Off TRK

*1)

MIN

Tracking Open

t

TYP TRK


SEC

MIN

SEC

*2) Focus Close t TRK 00MIN00SEC00 (TRK99MIN99SEC99)

+ 6 dB t TRK 06MIN06SEC06

S. Curve t 01MIN01SEC01

TRK

+ 12 dB TRK 12MIN12SEC12

F EQ measurement setting TRK 02MIN02SEC02

[Key] [BAND] [>] [<] [1]

*3) F.Offset Display t RF.Offset t T.Offset Display t Switch to the order of the original display

[2] [3] [6]

*4) 100TR Jump

Operation Test Mode Power On/Off CRG + / TR Jump + (Direction of the external surface) CRG - / TR Jump (Direction of the internal surface) T. CLS & AGC & Applicable servomechanism / AGC,AGC display setting RF Gain switching / Offset adjustment display / T.Balance adjustment / T. Open F. Close,S. Curve / Rough Servo and RF AGC / F,T,RF AGC F. Mode switching / Tracking Close

D

E

*5) TRK/MIN/SEC t F.AGC t T.AGC Gain t F.Bias t RF AGC

*6) CRG motor voltage = 2 [V]

After the [EJECT] key is pressed keys other than the [EJECT] key should not be pressed, until disc ejection is complete. When the key [2] or [3] is pressed during the Focus Search, the power supply should be immediately turned off (otherwise the lens sticks to Wall, causing the actuator to be damaged). In the case of 100TR Jump, the mechanism shall be set to the Tracking Close mode when the key is released. When the power is turned on/off the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. Do not do Tracking Servo Close before doing Focus Servo Close. (Because the overcurrent flows)

DEH-14UB/XNUC 5

6

7

8

F

19

1

2

3

4

7. DISASSEMBLY A

While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. - Removing the Panel Assy (Fig.1)

1 1

Remove the two hooks.

2

Remove the two hooks and then remove the Panel Assy.

1

2

2

Fig.1 B

Panel Assy - Removing the CD Mechanism Module (Fig.2, 3, 4)

1

Remove the screw.

2

Remove the two screws.

1

2

2 Fig.2

C

Heat sink side

The CD Mechanism Module side is made a bottom.

3

3 Fig.3

3

Push the area and remove the two hooks.

4

Slide the Tuner Amp Assy in the direction of the arrow and then remove the hooks of upper and lower.

Tuner Amp Assy

D

CD Mechanism Module

Lift off the Tuner Amp Assy from the Heat sink side.

5

E

The Tuner Amp Assy is fixed into the ditch.

5

6

Disconnect the FFC and then remove the CD Mechanism Module.

6 5

CD Mechanism Module

Fig.4

F

20

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

A

- Removing the Tuner Amp Unit (Fig.5)

1

1


2


3

Straighten the tabs at two locations indicated and then remove the Tuner Amp Unit.

3

1

2

B

3

2 Fig.5

Tuner Amp Unit C

- Attention of removing (Fig.6)

Don't remove this screws excluding the dismantlement of the CD Mechanism Module.

D

Fig.6

E

F

DEH-14UB/XNUC 5

6

7

8

21

1

2

3

4

- Disassembling the Panel Part (Fig.7, 8) A

1. Remove the arm while bending the rib of the panel upward.

B

Fig.7

2. Press the upside hook and the bottom side hook of the button at the same time, and pull out the button.

C

Fig.8

- Assembling the Panel Part (Fig.9, 10, 11) 1. Attach the button from the front side of the panel. D

E

Fig.9 2. Attach the spring to the arm as shown in the figure.

The bended tip of the spring is set to this side.

F

Hitch the spring to the groove. 22

Fig.10

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

3. Fit the spring in the groove at the position shown in the figure. A

4. Fit the boss on the lower side of the arm in the lower hole of the panel, and then warp the rib on the panel in the direction shown in the figure and fit the boss of the arm in the panel.

B

Fig.11

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

23

1

2

3

4

How to carry the mecha unit A

1. Hold the designated points (shown with dashed lines) of the upper chassis and the front/rear bracket. 2. Be careful not to hold the solid line portions or the CRG mecha part or insert foreign substances, to prevent distortion. 3. When holding the sides of the upper chassis, do not apply excessive force to prevent distortion. (Approx. 8N or less) Handling OK

B

Handling NG

C

D

E

F

24

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

How to remove the PU unit A

1. Create an empty-clamp state according to “How to create empty clamp state (motor drive)”. 2. Hook the feeding screw biasing spring to a tentative hooking portion (Fig 2b). Be careful not to get injured by the spring edge. 3. Hold the PU at the position A as shown in Fig 1. Slide the PU as far as possible toward the holder in the feeding screw so that a joint on the outer end of the feeding screw is loosened. 4. As shown in Fig 3, move the rear end of the feeding screw laterally and then upward, to remove it from the outer holder. 5. Lift the PU unit to disengage it from Part B of the chassis (Fig 4), and remove the PU unit. (Cautions) When re-installing the PU, be sure to first nip the chassis and the PU unit (Fig 4) at the position B. Also, make sure to fully hook the feeding screw biasing spring (Fig 2a). Please follow the service manual for adjustment of the PU unit after the re-installation. Slide toward inner circumference

B

Fig 2a

Fig 2b

Fig 1

Fully-hooked state

B

Fig 3

Tentatively-hooked state

C

The spring is below a resin flange and is built inside the sheet metal bending.

A

Fig 4

D

Outer holder Rear end of feeding screw

[Incorrect built-in state] The chassis is not nipped between the PU case and the PU rack.

Normal built-in state

E

F

DEH-14UB/XNUC 5

6

7

8

25

1

2

3

4

8. EACH SETTING AND ADJUSTMENT 8.1 CD ADJUSTMENT A

1) Cautions on adjustments In this product the single voltage (3.3 V) is used for the regulator. The reference voltage is the REFO1 (1.65 V) instead of the GND. If you should mistakenly short the REFO1 with the GND during adjustment, accurate voltage will not be obtained, and the servo’s misoperation will apply excessive shock to the pickup. To avoid such problems: a. Do not mix up the REFO1 with the GND when connecting the (-) probe of measuring instruments. Especially on an oscilloscope, avoid connecting the (-) probe for CH1 to the GND. b. In many cases, measuring instruments have the same potential as that for the (-) probe. Be sure to set the measuring instruments to the floating state. c. If you have mistakenly connected the REFO1 to the GND, turn off the regulator or the power immediately.

B

Before mounting and removing filters or leads for adjustment, be sure to turn off the regulator. For stable circuit operation, keep the mechanism operating for about one minute or more after the regulator is turned on.

C

2) Test mode This mode is used to adjust the CD mechanism module. To enter the test mode. [4] + [6] -> BUP + ACC ON To exit from the test mode. Turn off the ACC and back up. Notes: a. During ejection, do not press any other keys than the EJECT key until the loaded disc is ejected. b. If you have pressed the (→) key or (←) key during focus search, turn off the power immediately to protect the actuator from damage caused by the lens stuck. c. For the TR jump modes except 100TR, the track jump operation will continue even if the key is released. d. For the CRG move and 100TR jump modes, the tracking loop will be closed at the same time when the key is released. e. When the power is turned off and on, the jump mode is reset to the single TR (91), the RF amp gain is set to 0 dB, and the auto-adjustment values are reset to the default settings.

In the test mode, any software protections will not work. Avoid applying any mechanical or electrical shock to the mechanism during adjustment. The RFAGC and RFO signals with a wide frequency range are easy to oscillate. When observing the signals, insert a resistor of 1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it.

D

E

F

26

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

8.2 CHECKING THE GRATING AFTER CHANGING THE PICKUP UNIT A

Note : The grating angle of the PU unit cannot be adjusted after the PU unit is changed. The PU unit in the CD mechanism module is adjusted on the production line to match the CD mechanism module and is thus the best adjusted PU unit for the CD mechanism module. Changing the PU unit is thus best considered as a last resort. However, if the PU unit must be changed, the grating should be checked using the procedure below. Purpose : To check that the grating is within an acceptable range when the PU unit is changed. B

Symptoms of Mal-adjustment : If the grating is off by a large amount symptoms such as being unable to close tracking, being unable to perform track search operations, or taking a long time for track searching. Method : Measuring Equipment Measuring Points Disc Mode

Oscilloscope, Two L.P.F. E, F, REFO1 TCD-782 TEST MODE CD CORE UNIT C

L.P.F.

F E

E

Xch

Oscilloscope

390 pF

VREF

REFO1

Ych

100 kohm

F

100 kohm

VREF

390 pF

D

L.P.F.

Checking Procedure 1. In test mode, load the disc and switch the 3 V regulator on. 2. Using the right and left buttons, move the PU unit to the innermost track. 3. Press key 3 to close focus, the display should read "91". Press key 2 to implement the tracking balance adjustment the display should now read "81". Press key 3. The display will change, returning to "81" on the fourth press. 4. As shown in the diagram above, monitor the LPF outputs using the oscilloscope and check that the phase difference is within 75 . Refer to the photographs supplied to determine the phase angle. 5. If the phase difference is determined to be greater than 75 try changing the PU unit to see if there is any improvement. If, after trying this a number of times, the grating angle does not become less than 75 then the mechanism should be judged to be at fault. Note Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint Reloading the disc changes the clamp position and may decrease the "wobble".

DEH-14UB/XNUC 5

6

7

8

E

F

27

1

A

2

Grating waveform

3

4

Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC

0 degrees

30 degrees

45 degrees

60 degrees

75 degrees

90 degrees

B

C

D

E

F

28

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

8.3 PCL OUTPUT CONFIRMATION A

- PCL output With the TESTIN (22 pin) status of IC601 to be “H”, it is shifted to PCL Output Test mode after reset started. Check that square wave of 600.0 kHz is output from PCL (8 Pin) of IC601. If clock signal is out of this range, this resonator (X602) must be changed for a new one.

B

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

29

1

2

3

4

9. EXPLODED VIEWS AND PARTS LIST NOTES : Parts marked by " * " are generally unavailable because they are not in our Master Spare Parts List.

The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.)

A

"

9.1 PACKING

B

UC

C

UC

UC UC

D

E

F

30

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

PACKING SECTION PARTS LIST Mark No.

*

* *

Description

DEH-14UB/ XNUC

DEH-1450UB/ DEH-1450UB/ DEH-1450UBG/ DEH-1490UB/ XNES XNES1 XNES XNID

1 2 3 4 5

Polyethylene Bag Protector Protector Cord Assy Accessory Assy

CEG1173 CHP4103 CHP4104 QDP3013 QEA3008

QEG3001 QHP3016 QHP3016 QDP3013 QEA3009




6 7 8 9 10

Screw Polyethylene Bag Screw Handle Screw

BPZ20P060FTC CEG1160 CRZ50P090FTC QNC3021 TRZ50P080FTC

Not used CEG1160 Not used QNC3021 TRZ50P080FTC




11 12 13-1 13-2 13-3

Unit Box Contain Box Owner's Manual Warranty Card Service Network

QHG3165 QHL3165 QRD3102 QRY3001 Not used

QHG3160 QHL3160 QRD3103 Not used Not used

QHG3164 QHL3164 QRD3103 CRY1250 CRY1251

QHG3162 QHL3162 QRD3103 Not used Not used

QHG3166 QHL3166 QRB3198 CRY1304 CRY1305

14 15

Card Type RC Unit QXE1047 Case Assy Not used

QXE1047 QXA3129

QXE1047 QXA3129

QXE1047 QXA3129

QXE1047 QXA3129

A

B

Owner's Manual,Installation Manual Part No.

Language C

QRD3102

English, French, Spanish(Espanol)

QRD3103

English, Spanish(Espanol), Portuguese(B), Traditional Chinese, Arabic, Persian

QRB3198

English

D

E

F

DEH-14UB/XNUC 5

6

7

8

31

1

2

3

4

9.2 EXTERIOR A

B

B

A

C

D

A

E

A DEH-1450UB/XNES DEH-1450UB/XNES1 DEH-1450UBG/XNES DEH-1490UB/XNID

F

32

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

(1) EXTERIOR SECTION PARTS LIST Mark No.

*

>

Description

Mark No.

Part No.

Description

Part No.

25

Screw

BPZ20P100FTC

BSZ26P080FTC

26

Spring

CBH2210

1

Screw

ASZ26P050FTC

2

Screw

BSZ26P060FTC

3

Screw

4

Screw

BSZ26P120FTC

27

Knob Unit

CXE3692

5

Seal

See Contrast table (2)

28

Spring

YBL5010

29

Button(EJECT)

QAC3066

6

Spring

QBH3001

30

Button(LEFT)

QAC3068

7

Cover

QNM3029

8

Panel

QNS3126

31

Button(RIGHT)

QAC3069

9

Arm

QNV3025

32

Button(1-6, -)

QAC3070

10

Button

QNV3026

33

Button(DETACH)

QAC3071

34

Button(LIST, SRC, EQ, RETURN, BAND) QAC3072

35

Cover

A

QNS3226

11

CD Mechanism Module(S11.6) CXK5804

12

Cable

13

Cord Assy

QDP3013

36

Lighting Conductor

QNV3038

14

Case

QNB3002

37

Contact Rubber

QNV3041

15

Holder

QNC3020

38

Segment LCD(V1801)

CAW2018

39

Holder

QNC3031

40

Lighting Conductor

QNV3040

B

QDE3021

16

Panel

QNS3127

17

Tuner Amp Unit


18

Screw

BPZ26P080FTC

41

Rubber Connector

QNV3045

19

Screw

BSZ26P060FTC

42

Grille Unit


20

Screw

BSZ26P120FTC

43

Door

QAT3004

44

Card type RC Unit

QXE1047

45

Cover

CNS7068

46

Label


21

Holder


22

Heat Sink

QNR3002

23

Fuse(10 A)

YEK5001

24

Detach Grille Assy


C

(2) CONTRAST TABLE DEH-14UB/XNUC, DEH-1450UB/XNES, DEH-1450UB/XNES1, DEH-1450UBG/XNES and DEH-1490UB/XNID are constructed the same except for the following: Mark No. *

Description

DEH-14UB/ XNUC

DEH-1450UB/ DEH-1450UB/ DEH-1450UBG/ DEH-1490UB/ XNES XNES1 XNES XNID

5 17 21 24 42

Seal Tuner Amp Unit Holder Detach Grille Assy Grille Unit

CAN3984 QWM3319 QNC3034 QXA3489 QXA3439

Not used QWM3320 QNC3032 QXA3490 QXA3440




46

Label

Not used

Not used

Not used

Not used

CNN3533

D

E

F

DEH-14UB/XNUC 5

6

7

8

33

1

2

3

4

9.3 CD MECHANISM MODULE A

A

B

(A) (B)

B

(A)

(B)

C

(A) (A)

B

C

C

(A)

D (A) (A)

D

(A) (B)

(A) (B)

E

A

C

(A)

(A) : GEM1024

F

(A)

34

(B) : GEM1043

DEH-14UB/XNUC 1

2

3

4

5

6

7

8

CD MECHANISM MODULE SECTION PARTS LIST Mark No.

Description

Mark No.

Part No.

Description

Part No.

50

Damper

CNW1198

CBA1835

51

Arm

CNW1726

Washer

CBF1038

52

Motor Unit(M2)(LOAD/CRG)

CXC4026

Spring

CBH3010

53

Screw Unit

CXC8894

54

Arm Assy

CXE5027

55

Washer

CBF1037 CBF1038

1

.....

2

Screw

BSZ20P040FTC

3

Screw(M2 x 4)

4 5 6

Spring

CBH2855

7

Spring

CBH2856

8

Spring

CBH2860

56

Washer

9

Screw

BSZ26P060FTC

57

Arm

CND6242

10

Spring

CBH3011

58

Collar

CNW2444

59

Roller

CNW1196

11

Coil Spring

CBH3095

60

Gear Unit

CXC8893

12

Spring

CBH3014

13

Spring

CBH3015

61

Washer

YE15FTC

14

Spring

CBH3016

62

Chassis Unit

CXE4528

15

Spring

CBH3017

63

Motor Unit(M1)(SPDL)

CXE2273

64

Screw

JFZ20P025FTC

65

Screw

JGZ17P022FTC

16

Spring

CBH3086 CBH3019

17

Spring

18

.....

66

Screw

EBA1028

19

Leaf Spring

CBL1824

67

CD Core Unit (S11.6STD)

CWX4023

20

Pickup Unit(P10.6)(Service)

CXX3556

68

Chassis

CNA3181

A

B

C

21

Bracket

CND4553

22

Arm

CND4555

23

Bracket

CND6127

24

Bracket

CND5710

25

Lever

CND5398

26

Sheet

CNN3678

27

Rack

CNV8342

28

Guide

CNW2240

29

Roller

CNW1172

30

Holder

CNW1195

31

Arm

CNW2241

32

Roller

CNW1175

33

.....

34

Arm

CNW1177

35

Arm

CNW1178

36

Gear

CNW1180

37

Gear

CNW1181

38

.....

39

Gear

CNW1183

40

Rack

CNW1184

41

Gear

CNW1185

42

Gear

CNW1186

43

Gear

CNW1187

44

Gear

CNW2287

45

Clamper

CNW1190

46

Arm

CNW1192

47

Holder

CNW1193

48

Holder

CNW1194

49

Damper

CNW1197

D

E

F

DEH-14UB/XNUC 5

6

7

8

35

1

2

3

4

10. SCHEMATIC DIAGRAM

10.1 TUNER AMP UNIT (GUIDE PAGE) A

Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST".

ILM+B ROT1

DGND

NM : No Mount

36

GRILLE

16 WAIT

15 PGND

GND

13 LRCK 14 GND

11 DATA 12 BCLK

10

SDA

VDD 9

SKIP

RESET 8

7

PGND WAIT R716

220

LRCK

BCLK

DATA

DGND1

SDA

VDD4

RESET

PCM1753DBQ

14

15

16

13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5

MC

SCK

ML

LRCK

4

IC231

DATA

BCK 1

2

C233

C232 0.01u/16

1000p/50

C239 LRCK

DATA

SCK

SCK

ML

BCK MC

MD

MC

MD

DATA

BCK

LRCK

CDDATAIN

CDLRCKIN

10p/50

8 80

1

79 AUDIO_X2

TDI

78 TCK TMS 77 TDI 76 TDO

TCK

TMS

R618

0.1u/10

AUDIO_X1

VSS7

PVCC6

81

C620

0.1u/10 82

VCC4

83

AUDIO_XOUT

DACBSCK

84

R617

C619

220

NM 85

86 CDSKIP

DACBDATA

87

R616

R614

100

100

R613

R611

90

89

88 DACDATA

DACLRCK

PVCC7

NM

NM

R619

C613

C615

C617

NM

NM

NM C611 100

0.1u/10

0.1u/10

R609

C612

91

93

92 VSS8

VCC5

DACSCK

CADATAIN

C609 94

R634

NM

95 CDLRCKIN

96

TUNPCK 99 RDS_INT 98 TUNPDI 97 NC

TUNPDO

CDSCKIN

PVCC4 CKIO 33 0.1u/10

BTTX

VCK

KYDT/TESTDI

VCK

32

29 KYDT

31

30

DPDT

0.1u/10 C618

C621

28

DPDT/TESTDO

VDT 27

VST

VCC3

26

25

24 0.1u/10

VSS3

PVCC3 23 C616

TESIN

R615 100k

TESTIN

22

MUTE

/USBFLG 20

SYNC 19

21

2.2k NM

VCC2

BTTX

VST

FLG

SYNC

USBCTL

VDCONT

BTRST

TELIN

SYSPW

MUTE

2.2k

R808 2.2k

ROT1

R810 2.2k

SWVD

DGND

ILMG C802

NM USGND

C803 NM

G D GND USBGND ILM GND

DEH-14UB/XNUC 2

CDSKIP

CDWAIT

CDLRCKIN

CDSCKIN

CE C607

0.1u/10 101

102

100 MISO

MOSI

PVCC8

103

VSS9 /SSL ANTPW

R803

ROT0 ILM

GND

The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.

1

3

150

150

R715

R714 NM

NM

NM R718

R720

R719

NM

CDDATAIN

CD_SDA C605

0.1u/10 104

NM

KYDT

0

4

1

2.2k

R814

5

SWVDD 3 2

ILMGND

NM

R804

C851

ROT0

6

8.2

R811

4.7k

7

DPDT2

R805

NM

R851

8

US5V

3 3

8.2k

9

KYDT

R812

R809

USBGND

RGBDT/USBGND

R806 8.2

ICLR1

C810 220p/50 C811 220p/50

10

CTF1713-A 2 2

44

D810 DZ2S068C

CN1821

11

L801 11

ICLR2 DM

DM 13 12 RGBCK/ILMCLR1

DPDT

100 100

DP

14

USB5V

R817

R801 22k R815

D811 DZ2S068C

B

AUXG

100

22k

0.1u/16

15

AUXR

R802 R816

D807 NM

16

DP

2.2k

SRC

C808

AUXGND

GND

D806 NM

NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.

A

R807 AUXL

2.2k

D801 DZ2S068C

AUXR

17

R818

C812 1u/16 D802 DZ2S068C

SOURCE

18

D804 DZ2S068C

19

D803 DZ2S068C

20

AUXL

D805 NM

NM

DSENS

RGBST/ILMCLR2

F

105 DIM

1u/16

GND GND GND

DSENS C818

CKS6288

0.1u/16 C961

10k

R813 RGBDT

CN801

10k

C969

R970

220p/50

10k

C809 0.1u/16

1

1k

R968

5

D809 DZ2S068C

GND

R964

6

NM

2

BTR

C967 470p/50

D808

U1OUT

GND

IN+2

7

C801 NM

3

10u C962

U1IN

1k

IN-2

GND

SYS+B L962 NM

8

R972 A GND

NM

OUT2

IN+1

10k

L961

R966

VCC

IN-1

R973

GND

4

OUT1

CCG1192-A

0

5

2

220p/50

NM

4

10k

C970

6

3

10k

C966

7

VCC

R969

47k

MIC1P

R965

R961

MIC1N

8

VDT

VA891

VA892

VA893

C963 R962 8.2k 1u/10

9

BTL

1

47k

10

VSS

LPF

C968 470p/50

R967

SPKR

1u/10

NM

11

DSENS1

BTRST BTRX BTTX

IC961 NJM4558MD

R971

VSS

KEYD KEYAD

except A

R963 8.2k

C964

NM D961

12

C965

SPKL

KEYD2

BT MOD

GND

GND 13

VSS

1k

VR105C5R0AAA

CN961 VKN1189

NRST_CPU

1k

R891

KEYAD2

W.REM&MIC

E

R892

NM

MIC1N

VA894

(W/R)

R691

MIC1PF

6 5 4 3 2 1

(RMIC)

R607

GND

JA891 YKS5035

0.1u/10

C604

USBCTL

GND

C614

1

TELIN1

USBCTL

R508

FLG 10k

BD2232G-G

SKIP

NC

VBUS

4 NM

/OC

1

5 FLG

EN

2

SSENS ASENS

144

3

143

8

BSENS

142

4

141

SSENS

7

BSENS

6

VOUT

GND

DSENS

ASENS R604 47k

VIN

RGBDT

BTTESTMD

VSS2

BTTESTMD 140

VSS12 BTTESTIN

/RDSLK

138 NM BTTESTIN 139

USBCTL

137 R641

18

RGBDT

RGBDT

17

SYNC

ILMCLR1 PVCC11 ILMCLR2

16

SYNC

GND

C513

1u/10

C511

3

0.1u/16

0.1u/16 C891

C892

KEYAD

except A

NM C510

2

CDRST

CDSCKIN 136

R610

R507

135

C610

R506

0.1u/10

R612 47k

5

BD9008F

ILMCLR2

0.1u/10

NM

VDCONT

51k

15

6

ROT0 ILMPW

14

RT

INV EN/SYNC

GND

7

134

KEYD ROT1

0.1u/10

133 C603

IC601 R5S7266ZD144FP

VSS11

PVCC2

ILMCLR1

NC PVCC10

SWVDD

13

CRG03

DACCS

47k C608

GND

1u/10

1

150 132

CDWAIT

R608

SW

C512

GND KEYD

R713 131

ILMPW

IC510

1 3 2

100k

130

ROT0

SYSTEM MICRO

CDSTBY

47k

220p/16

129

ROT1

5

C506

0.015u/16

VIN

FB

KEYD

8

PVIN

127 128

47k

18k

R505

4

0.1u/10

D502

R602

3

D501 RB160L-40

47k C503 6.8k

2

GND

C602

CRG03 D503

10k

R504

1

1u/16

GND

C507

IC501

C509

R601

SWVDD5

USB&USB5V

124

126 10k R603

ipod CP

NM

125

except A NM

NM R503 R502

R605

CDRST CDSRQ

ANTPW

123

CPPWR VSS10

SYSPW 8 PCL 9 TELIN 10 BT RST ROM 11 ROM 12 RAM_MON RAM_MON

122

CDWAIT

PVCC9

PCL 7

CDSTBY

NM

CPRST

USB5V

470 C502

R561

16

L501 CTH1475-A

R501

121

NM C505

R557 4.7k

CDSRQ

NC CPRST

VCC1

119

ML

GND

W.REM

118

120

22p/50

0.1u/10 GND

JA892 CKS4124

117

TUNSDA TUNSCL CP_SDA

6

116 C601 0.1u/10

2 2

CP_SCL

0.1u/10

114

CDRST

CP_SCL

IC551 341S2162

C508

2

R556 2.7k

220

113

CP_SCL

115

CP_SDA

1

4

3

5

D

C552

106

112

RF GND

CP_SDA

VSS1

*

NM

17 NC9 NC10 18 NC11 NC12 19 NC13 20

NC7 8 NC6 NC5 7 NC4 NC3 6

100

110 111

0

VCC6

109

CD_SCL

RSPCK

CD_SDA

CD_SCL

*

TUNPCE1

108

NM

107

NM

NM

R430

NM R414

NM

CD_SDA GND

DIMMER

*

R415

R418

1000p/50

C447

C439

1k

TUNPCE2

L415

NM

R417

CPPW

220u/6.3

9

R672

GND R416

D601 RB551V-30

11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15

10

47k

0.1u/10

2 PVCC1 NC

100

X601 CSS1603-A 1 3 1 3

4

R560

16.934MHz

1

C671 10k

10k R420

R419

R671

SO

2

3

R553 10k

SO

5

100

CDSKIP

CE#

3

47k

7 HOLD# 8 VDD

R562

47k

R551

C551

0.1u/10

R559

CD_SCL

WP#

C606

NM

C430

VSS

DGND

CPPW

R552 10k

4

SI SCK

GND C440 0.1u/10

L671 CTF1786-A

IC671 5 6

M2R6TP_GND

8.2

R428

*

SI SCK

KN601

CPRST

4.7k

CDSTBY

CDSRQ

VDD3.3V

FLASH ROM

L411 NM

GND

B.UP

VDD3.3V

R558

C703

SW5V

NM

C438 NM

C436

C433

*

Q551 LSA1576UB(QRS)

NM

D GND

NM

NM

DGND

L551

NM

C702 L701

NM

NM C706

NM

CTF1786-A

VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT

31

30

L410

L419

CCG1205 C442

46 GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33

R427

RF GND

C452 C434

100k C701

GND

VDCONT

NM C437

C435

0.1u/10

C429

9p/50 C431

C432

49

50

51

52

VCC-REF VDDIO1V2 VDDPLL1V2

VDD_CORE

*

RFGND

R721

NM C705

R421 0

C455

R408

C427

L409

29

28

VDIG

AMMIXIN2

AMMIXIN1

LNADEC2

GNDSLINK

27

25

24

26

R433

LNAIN2

LNAOUT2

23

22

C422 0.1u/10

R406

R431

*

NM NM

L416 NM C441

47 2.2u

1/4W 1/4W DGND R410 R412

RF GND

1

R703

NM

C704

2

L414 NM

8.2

*

DGND R429 NM

48

TEST

NM

*

6

VD 3

8

0.01u/16

L412 L413

32

1u/10

2

*

C454 NM DGND

C423 0.01u/16

1M

R405

C444 L417

NM

C451

C458 1M

*

LNAOUT

LNAIN

0.01u/16

L420

R434 C457

33

L418

LNADEC

GNDLNA

C415

21

L406

0.1u/10

R403

L405

R407

C408

C421

C443

18

GND RFGND

*

3

GND1 X1 CSS1805-A

SCL

4

5

1k

100k VDCONT

AGND

NM

L407 750 KP2311E

0.1u/10

16

20

15

C412 10u CCG1192-A RFGND C445 0.022u/16

17

0.1u/10

C404 C405

NM

C456

A GND

RFGND

L403

X2

C409 0.01u/16

C406

RFGND

CTF1786-A

0.1u/10 C419

C417

R402

4 FMMIXDEC 5 FMMIXIN2 C413 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND C450 9 orRFGND CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN 14 TCAM2 C411 0.01u/16

L402 CTF1786-A

3

C446 RFGND NM

0.01u/16

6p/50

C402

L401 0.15u

C403 0.01u/16

33p/50

D402

220

C401

*L404

1 2

C449 NM

R401 D401

KP2311E

NM

X401

64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 VCC-PLL 59 VCC-ADC_DAC 58 DACOUTR 57 DACOUTL 56 GND-ADC_DAC VREFDEC 55 C426 GND-REF 54 0.1u/10 OSCOUT OSCIN 53 R409 NM

C448

10u 19

RFGND

36.48MHz 4 GND2 1

C420

P401

3

KN401

NM

IMSA-6802-01Y900 R432

1

M2R6TP_GND

R413

CTF1786-A L408

AGND

JA401 YKS5041

TUNGND 2

C

TUNL

C428 9p/50

ANTENNA

TUNR

C418 CCG1192-A

B

5 SCL

VD

100k

R704 4.7k

C424 4700p/25

C234 CCG1192-A 10u C235

R717

47k R702

R712

6

RN4983

CD/USB:+5.22 dBs DGND

R701

R711

NM

R710

1

820

100

5

NM PGND

DAC

R709

2

GND VDSENS

C425 4700p/25

CTF1786-A

Detailed page

NM C708 NM C709

GND

220

4

R754

220

RKZ8.2KG(B2)

3

R753

R708

Q752

7

A-b

C707

R707

NM

VD1

6

A-a

3 /CDSRQ

CDSRQ

Q751 2SD2396(K)

FM(30%) -15dB±2.5: -15.0 dBs AM(30%) -15dB±2.5: -15.0 dBs

CN701

NM C710

7.4V

VD2

CDSTBY

MECHA VD

2

CD

CN701 VKN1192

1

B~E CCG1205 0.1u NM NM 330 360 390 NM NM 0 NM NM 0.1u PEB034A8

4 /CDSTBY

C

A NM NM 1u 3p 1.5k 470 680 0 0 NM 0.47u 0.1u NM PEB035A8

10u

C432 C433 C457 C458 R403 R406 R408 R431 R433 R434 C430 C431 C439 IC671

C753

15p 22p 2p 0.01u 8p NM NM 0.39uH NM 1.5uH 2.2uH 0.39uH 0.27uH NM

C754 0.1u/10 D751

B~E

47k

Guide page

A NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM 68n

C751 CCG1192-A

C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L417 L418 L420

R751

A-b

A-a

*

10k

A-a

Large size SCH diagram

A-b

R752

A-a

3

4

5

6

7

8

A

A-b ROR

13

PML022A

18

19

20

23

21

ROL

4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 9 NC1 NC2 10 VCC STB 11 VREF CLK 12 GND DATA

5

6

8

7

4

3

2

1

1k

R201 NM

C213

CCG1201-A 4.7u

10p/50 C203

10p/50 C215

C202

C201 CCG1192-A 10u

FM(30%): -5.9 dBs AM(30%): -5.9 dBs AUX:+10.3 dBs CD/USB:+10.3 dBs

A GND

NM

GND

TUNL

Set back chart

0.47u/10

C308

0.47u/10

C302

0.47u/10

C306

0.47u/10

GND

R353

10k

220

2

12MHz

YSS5005-A 1 1

4

4

X602

IC REGULATOR SYSPW

+B VDD3.3V

SW5V

NM

ASEN1

100p/50

NM C259

NM

C261

C260

100p/50

1000p/50 FR+ P-GND3

19

FR-

20

VCC

21

RR+ MUTE

C321

C320

C319

23

RR-

24

P-GND4

25

B.REM

NM

NM

NM

D

CKM1586

FUSE

18 BUP1 BUP3

YEK5001 (10A) 16 GND 17

>

15 B.UP 14 BREM 13 ACC 12 A.ANT

22k

11 ILM 10

RL2 RR1 RL1 FR2

1SR154-400

FL2

NM

C927

1000p/50 C923

1000p/50

1000u/16 C926

1 C921

JA901

14.4V

RR2

FR1 FL1

9 8 7

TEL RRRL-

6

RR+

5

RL+

4

FR-

3

FL-

2

FR+

1

FL+

FM(30%):+20.1 dBs AM(30%):+20.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs

R934

D931

E

C931

R933

DIM

47k

0.1u/16

1k

HZU7L(A1)

4.7k

22k

GND

TELIN

R942

A.ANT

22k Q941 LSA1576UB(QRS)

L941 D941

NM

47k

E2 4 Q873 LTC143EUB

ILM GND

9 3 C2

8

B2 5

2 B1

7

C1 6

1 E1 NM ANTPW

ANTPW

6

DIAG

OUT

GND6 GND1 GND5 GND2 GND4 GND3 IN

VDD NM

D951 CRG03 1 2 3

GND

4 5

1k

2.2u 15k

1SS301 GND

R952 1/16W 4.7k

Q951

R951 1/10W

NM IC951 10

NM

D952

R875

CRG03

6

0

150 5 (1/4W)

RN4983

R876

C951

4

3 2

Q952 2SB1731-TLB

10k

Q953 LTC114EUB

R873

NM

Q872

1

R941

TELIN

C952

8.2k

DPDT

ROT0

R810 2.2k

D871 R879

DPDT KYDT

R880 180 D872

NM R878

2.2k 2.2k

NM

NM 0.1u/16 C871

2.2k C873

1u/16 R871

C872

ILMCLR1

NM

17

R943

8.2 DM 8.2 ILMCLR2

AC-GND

RFGND

Q871 2SD1767(QR)

NM

R805

3 3 NM

R931

R932

Q931 LSC4081UB(QRS)

SWVDD

B.UP ILMPW

R881

D874 D873 NM NM

NM

R877

DP

D875

NM

R806

R872 NM

CTF1713-A 2 2

NM

NM

NM D876

RKZ7.5KG(B2) R885 R874

AUXR AUXG

R884 1

AUXL

100 100

RRIn FRIn

16

TELIN

ASENS ASEN2

Dim off 13.96 V Dim on 9.72 V

R882

NM

2.2k 100

AGND

15

Q874 NM

R883 SSENS

RLIn

GND

BTRX

ILMPW R807

FLIn

12

AANT

D912 0.1u/16 C922

220u/6.3 C919 1000p/50 C920 R912

CCG1201-A C924

4.7u CCG1201-A

C651

1u/10

NM

C652

4.7u

S-80827CNMC-B8M

NM C918

NC1

C925

VSS

4

11

ACC

D911 1SR154-400

NM C917 4.7u CCG1201-A C911

NM

VDD

1000p/50 R911 C914 4.7u CCG1201-A 1 C929 C915 220u/6.3 NM C916 4.7u CCG1201-A C912

NC2

220u/6.3 C913

NM R651

OUT

5

FL+ SVR

GND

10 +BUP 11 VDDCONT

VDDCNT

C928

IC651

9 10

BREM

1SR154-400

12 GND

2

BTTX

VCK

KYDT

DPDT

100p/50

22k

D902

8 VDD12 9 SWVDD

BUP2

1

P-GND1

1SR154-400

6 SW5V 7 VDD

VDD1 1.2V SWVDD

RST

FL-

8

D954

600uH

4 +B 5 SYS+B

SYSB

1k

RESET

VCC

7

PW CONNECT

L901 CTH1432-A 2 1 GND1 GND2 D901

2 SYSPW 3 SW5VCNT

12p/50

R629

RL+

6

NM

IC912 BA49182-V12 1 BSENS

BSENS

BSENS SYSPW

USB GND

STBY

5

GND GND

C633

C

GND NM

MUTE

2

33

GND

ASENS

VDT

C256

22k

R257

C318

C312 0.1u/16

RN4983

D301

6

CRG03

1

CCG1192-A

10k

5

D302 CRG03

C632 12p/50

4

22

4

10u C351

2

CCH1732-A GND 3300u/16

MU1

3

P-GND2 RL-

18

C901

R352

MUTE

AC-GND

CCG1205-A 2.2u

TAB

2

14

A GND

CCG1205-A 2.2u GND C309 0.1u/16

1

13

C311

C310

R351

Q351

3

NM

C314

NM

GND

C317

0.47u/10

C307

GND

NM

C305

0.47u/10

0.47u/10

C315

0.47u/10

C304

C334 NM

C331 NM

C333 NM

C332 NM

DP DM

C313

NM

NM

C303

VBUS

100

GND

R809

C257

22k

6 NM

1 E1

470

1u/10

C638

10k

R632

R633

10k

R303 R302

2 B1

C1 6

47k

470

470

R333 470

R334

R331 SYS+B

SW5V

VDD3.3V

B.UP

VDD1.2V

3 C2

B2 5

GND

47k

47k R620

R642

STBY

E2 4

R304

NM

NM C637

C635

USBA GND

C631

36

C629

C301

100k

VST

GND

DDCONGND

IC301 PA2030A

10u/16 C316

VDSENS

AGND

GND

MUTE

C258

3 RN1910

2

Q252

4

1 68

47k

0.1u/10

69

GND

R332

C630

except A

47k

R630

10k

R628

0.1u/10

NM

3

R808 2.2k

4

Q301

R301

NM

D651

R803

5

NM

NM

VDD1.2V

NM R640

AVSS

35

33

L602

R631

KEYAD

D602

RB751S-40

TRST

TDO

TDI

ASEBRK

73

71 70

0.1u/10

C621

0.1u/10 C618

0.1u/10

5

RL

FR

RR

FL NM

NM C636

47k R621

C634

5 4

1

47k

6 3

8

7

NC

PVCC4 CKIO VSS4 BTRX NMI

VCK

KYDT/TESTDI

DPDT/TESTDO

BTTX

32

31

30

29

VDT

28

27

26

VST

VCC3 25

VSS3 24

C622

72 AVCC

67 VDSENS 66 NC 65 GND NC MODEL 64 MODELAD 63 USBUVSS C623 62 USBUVCC 0.1u/10 61 USBAVSS 60 C624 0.1u/10 USBAVCC 59 C625 0.1u/10 USBAPVCC 58 USBAPVSS R626 57 REFRIN 5.6k F% 56 USBDVSS C626 55 USBDVCC 0.1u/10 54 VBUS 53 DP 52 DM 51 USBDPVSS C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL NM R637 42 1.5k EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37

34

79 AUDIO_X2

AUDIO_X1

78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST 74

TCK

TMS

R618

0.1u/10 PVCC6

80

C620 81

82 VSS7

AUDIO_XOUT

VCC4

83

84

R617

C619

220

NM R616 85

DACBSCK

0.1u/10

NM

R619 2

10p/50

C617

NM NM

100 R613

R614 86

87

88 DACDATA

DACBDATA

CDSKIP PVCC3

MUTE

TESIN

23

22

21

TESTIN C616

R615 100k

820

AMP

SWVDD5

R804

2

KEYAD

0.1u/10

R811

1 3

FR

R254

CCG1201-A

except A

AVREF

P

44 R812

CKB1056

FL

6

C254 4.7u

FRch

JA251

GND

CRO

L801 11

PL

PR

820

VDD3.3V

NM


NM

R253

C253 4.7u

FLch

CCG1201-A

2 2

RCAG 2

820

16.934MHz

NM R639

GND

R252

4.7u

>

P251 CEK1286 R259

R256

C252 CCG1201-A

3A 1

B.UP PRch

C255

R255

3 4

6

VDD3.3V

5

Q251

2

1

MUTE

100p/50

820

CCG1201-A 4.7u

REAR OUTPUT

SYS+B

R251

C251

PLch

VST

RN1910

BTL

TUNR

AUXL

BTR

AUXR

AUXG

RR

SW5V

L601

B

RCA

VCK

X601 CSS1603-A 1 3 1 3

GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990

RL

GND

R258

24

22

IN2_R

IN1_R

IC201

1 IN1_L

TUL 1u/10

C211

C212

E-VOL output

C214

NM

C231

C233

C232 0.01u/16

CCG1192-A 10u

1000p/50

C239

NM

LRCK

DATA

SCK

Selector output FM(30%): -10.9 dBs AM(30%): -10.9 dBs AUX:+5.3 dBs CD/USB:+5.3 dBs

SCK

ML

BCK

NM

C204 10p/50

TUNER AMP UNIT

REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800

L201 NM

NM R206


VDT

MC

MD

DATA

1u/10

R205 L231

CDSKIP

1u/10

C217 NM

820

D GND

1u/10

C209 C207 A GND R207

C237 R231

C205

NM

C238

1800p/50

E-VOL

1800p/50

PCM1753DBQ

14 MC

15 ML

13 MD DGND 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC 7 VCOM 10 VOUTL 8 AGND 9 VOUTR 5

SCK

LRCK

4

IC231

DATA

3

2

1

BCK

16

820

2 IN2_L

LPF

R232

IN3_R

C235

3 IN3_L

DAC NM

A

Selector input 17

NM

C234 CCG1192-A 10u

14

1u/10

C216

15

1u/10

C206

16

C208

TUR

1u/10

1u/10

SB:+5.22 dBs

C210

NM

GND

ROT1

C810 220p/50 C811 220p/50

IC801

B DEH-1450UB/XNES

3 GND GND

SWVDD

Vcc

C DEH-1450UB/XNES1

INA GND

OUTY

TC7SET08FUS1

F

5

4 C817

2

INB

0.1u/10

1

NM

C852

NM

C851

4.7k

NM R851

D811 DZ2S068C

A DEH-14UB/XNUC L851

D DEH-1450UBG/XNES E DEH-1490UB/XNID

A

GND

DEH-14UB/XNUC 5

6

7

8

37

VOUTL

A 3 3

VOUTR

AGND 9

TCK

820

R231

C238

A GND

B.UP

VDD3.3V

SW5V

NM

L231

C237

VCOM 10

NM

R618

8

C232 0.01u/16

TMS

820

C630

0.1u/10

C625

0.1u/10

C626

5.6k F%

R626

0.1u/10

0.1u/10

C623

GND

C624

MODEL

0.1u/10

70

69

0.1u/10

C622

except A

71

KEYAD 68 AVSS 67 VDSENS 66 NC 65 NC 64 MODELAD 63 USBUVSS 62 USBUVCC 61 USBAVSS 60 USBAVCC 59 USBAPVCC 58 USBAPVSS 57 REFRIN 56 USBDVSS 55 USBDVCC 54 VBUS 53 DP 52 DM 51

AVREF

NC

AVCC

72

47k

VCC

7

Hz

R619

NM

1800p/50

1800p/50

C231

47k R621

PCM1753DBQ

C233

8

CCG1192-A 10u

7

2

ASEBRK

1

TDI

_ 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST

TDO

6

3

74

5

4

TRST

73

LPF

D602

R232

R628

NM

USBA GND

NM

NM R206

R205

1u/10 1u/10

C209 C207

AGND

C217 NM

1u/10

E-VOL

1u/10

GND

GND

ROR 17

1u/10

C205

AUXL

NM

RB751S-40

R207

AUXG

10k

C212 TUNR

IC201 NM

20

21

18

19

TUR

NM

NM R640

L602

NM

NM R639

L601 VDD3.3V

VDD1.2V

100

R633

GND

SYS+B

NM

C214

NM

L201

15 STB

16

C204 10p/50

14 CLK

22 1u/10

C235

R630

R631

BTR

except A

13

GND

5 6

4

1

Q351

10k

R351

GND

C306

0.47u/10

C302

220

R353

C308

C307

0.47u/10

0.47u/10

C303

C304

C305

0.47u/10

NM

R301

C301


E-VOL output


Selector output


Selector input

2

1k

DM

470

3 MUTE

VST

VCK

VDT

C331 NM

DP

VBUS

VDSENS

KEYAD

A GND

C213

DATA 12 GND

CCG1201-A 4.7u

C234 CCG1192-A 10u

AUXR

47k

47k

BTL C634 C635

PML022A NM

23 TUL C211 TUNL

8 1

24 C638

7 2

NC2

9 NC1

10p/50 C215

ROL C202 B.UP

6 3

R201

10 VCC

VDD3.3V

5 4 SYS+B

11 VREF

10p/50 C203 SW5V

C201 CCG1192-A 10u VDD1.2V

1u/10 NM 10k

FL R331

1 IN1_L IN1_R 2 IN2_L IN2_R 3 IN3_L IN3_R 4 IN4+_L IN4+_R 5 IN4-_L IN4-_R 6 POUT_L POUT_R 7 FRONT_L FRONT_R 8 REAR_L REAR_R 1u/10

NM C636 NM C637 R632

FR 470 R332

RL R333 470

RR 470 R334

NM

NM C332

C206

NM C333

C216

NM C334

1u/10

10k

C208

R352

R252

C252 CCG1201-A

2 B1 1 E1

C1 6

MU1

0.47u/10

0.47u/10

0.47u/10

0.47u/10

3 C2 B2 5 NM

Q301

CCG1201-A

C310

CCH1732-A GND 3300u/16

C901

CCG1205-A 2.2u GND C309 0.1u/16

GND

NM

R302

820

R254

820

R253

AMP

C254 4.7u

CCG1201-A

C253 4.7u

MUTE

820

820

4.7u

R251

C251 CCG1201-A 4.7u

E2 4

FRch

FLch

PRch

PLch

RCA

1 Q251 Q252 R303 R304

C210

CCG1192-A

2 6 1 6

10k 47k

A

D302 CRG03

CCG1205-A 2.2u

C311

GND

NM

10u/16 C316

C313

GND

GND

NM

1

>

NM

R259

P251 CEK1286

3A

A GND

STBY

FR

FL

PR

PL

RCAG

AC-GND

GND

DDCONGND

2

MUTE RRP-GND4

22 23 24 25

RR+ 21

B.REM

FR-

P-GND3

VCC 20

FR+ 18 19

17

RRIn FRIn AC-GND 16

15

AGND 14

13

RLIn

11 12

FL+ SVR FLIn

9 10

FLP-GND1 8

RL+ VCC 7

6

STBY 5

4

3

TAB P-GND2 RL-

2

IC301 PA2030A 1

GND

NM

CKB1056

JA251


Set back chart

RR

RL

GRILL 801 - 850 SWVDD5 851 - 870 ILMPW 871 - 890 W.REM&MIC 891 - 900 PW CONNECT 901 - 910 IC REG 911 - 930 ASENS 931 - 940 TELIN 941 - 950 A.ANT 951 - 960 BT MOD 961 - 990

TUNER AMP UNIT

REFERENCE AREA MAP EVOL 201 - 230 DAC 231 - 250 RCA 251 - 300 AMP 301 - 400 TUNER 401 - 500 USB&USB5V 501 - 550 I-POD 551 - 600 UCOM 601 - 650 RESET 651 - 670 FLASH ROM 671 - 690 DSENS 691 - 700 CD MECHA 701 - 750 MECHA VD 751 - 800

RN1910 RN1910

3 5 2 5

4 3 4

A-a A-b

10u C351

R258 C314 C317 C315

A-b

01

4

G03

22k NM NM NM

3

12 u/16

22k R256 R257

R255

22k 22k

C255 C256 C257

100p/50 100p/50 100p/50 C258

DEH-14UB/XNUC

100p/50

2

C318

1 C319

38 NM

F C261

E NM C259

D C260

C 4

5

6

2

1 3

3

C321

B 2

C320

A

1000p/50

1 4

REAR OUTPUT

3

2

2.2k

VCK

REFRIN

51

52

53

54

55

56

57

58

0.1u/10

C626

DP

AUXR AUXG

AUXL

SSENS

DPDT

DPDT

8

A-b

SWVDD

D875

NM

D876

NM

NM

R883

GND

GND

INA

C633

USB GND

12p/50

OUTY

Vcc

TC7SET08FUS1

3

2

NM

R881

IC801

INB

ILM GND

1

2

D874 D873 NM NM

NM

R882

ILMPW

1k

R629

12p/50

C632

USBA GND

100k

NM R651

D651

Q871 2SD1767(QR)

Q874 NM

4

5

Q873 LTC143EUB

GND

RST

RESET

1u/10

VSS

VDD

OUT

NC1

NC2 4

5

VDD1.2

3

1

2 RN4983

Q872 R873

ILMPW

6

150 5 (1/4W)

4

Dim off 13.96 V Dim on 9.72 V

S-80827CNMC-B8M

3

2

1

IC651

100

R633

B.UP

B.UP

NM

R875

DM

DP

VBUS

ANTPW

C1 6

B2 5

E2 4

TELIN

ASENS

SWVDD5

SYSPW

BSENS

MUTE

2 B1

3 C2 1 E1 NM ANTPW

Q951

220u/6.3 C913

ASEN2

6

7

8

9

10

ASEN1

OUT

IN NM

VDD

GND4 GND3

GND5 GND2

GND6 GND1

DIAG

NM IC951

C951

D931 HZU7L(A1)

GND

A-a A-b

5

4

3

2

1

6

5

4

MUTE

RN4983

Q351

IC REGULATOR

R931 22k

C331

GND

1

2

3

10k

R351

GND

D951 CRG03

GND

GND

GND

GND

10k

R952 1/16W

Q952 2SB1731-TLB

A.ANT

220

R353

MU1

1k

GND

1SS301

D941

2.2u C315

D302 CRG03

GND

D301

GND

NM

15k

R943

NM

2.2u

L941

TELIN

1SR154-400

D902

1SR154-400

E DEH-1490UB/XNID

D DEH-1450UBG/XNES

C DEH-1450UB/XNES1

B DEH-1450UB/XNES

GND

L901 CTH1432-A 2 1 GND1 GND2 D901

600uH

CRG03

A DEH-14UB/XNUC

1k

R941

22k Q941 LSA1576UB(QRS)

R942

RFGND

1SR154-400

D912

ASENS R934

12 GND

10 +BUP 11 VDDCONT

8 VDD12 9 SWVDD

6 SW5V 7 VDD

4 +B 5 SYS+B

2 SYSPW 3 SW5VCNT

D911 1SR154-400

VDDCNT

BUP2

SWVDD

1.2V

VDD1

SW5V

SYSB

+B

SYSPW

BSENS

IC912 BA49182-V12 1 BSENS

CCH1732-A GND 3300u/16

C901

2.2u GND C309 0.1u/16

SW5V SWVDD

23 24

FL1

FR1

FL2

FR2

RL1

RR1

RL2

RR2

TELIN

AANT

ACC

BREM

BUP1 BUP3

D954

FLFR+ FL+

4 3 2 1

RR+ 5

FR-

RL-

RL+

6

RR7

TEL

9 8

10

11 ILM

12 A.ANT

13 ACC

14 BREM

15 B.UP

>

FUSE

CKM1586

JA901 YEK5001 17 (10A) 16 GND

18

PW CONNECT NM

FM(30%):+20.1 dBs AM(30%):+20.1 dBs AUX:+36.3 dBs CD/USB:+36.3 dBs

14.4V

RR-

22

B.REM

MUTE

P-GND4

21

25

FRVCC RR+

P-GND3

20

FR+

18 19

17

7

GND

NM

L851

ROT1

ROT0

KYDT

ILMCLR1

C629

0.1u/10

GND

5.6k F%

R626

0.1u/10

0.1u/10

C624

C625

VDD3.3V

59

SYS+B C928

60

C627 50 ASEMD USBDPVCC 49 R622 0.1u/10 ASEMD 47k 48 USB_X2 47 R627 USB_X1 46 NM VSS6 C628 45 PVCC5 0.1u/10 44 VSS5 R623 43 XTAL R637 NM 1.5k 42 EXTAL 41 MD_BOOT0 R624 47k 40 MD_CLK0 R625 NM 39 PLLVSS R636 38 RES 47k PLLVCC 37

USBDPVSS

DM

DP

VBUS

USBDVCC

USBDVSS

36

R642

DM 8.2 ILMCLR2

R805

8.2

R806

R807

32

C621

4.7k

30

VCK

R851

35

BTRX

33

4

4

YSS5005-A

USBAPVSS

47k R620

BTTX

31

BTTX

33

0.1u/10

C851

10u C351 1000u/16 C926

USBAVCC

R872 NM


34

NM

1

C312 0.1u/16

USBAVSS

C872

R632 C651

C318 NM

USBAPVCC

NM

47k

C852

1u/16 R871

10k 1u/10

X602

C631

2.2k C873

1000p/50 R911 C914 4.7u CCG1201-A 1 C929 C915 220u/6.3

2

1

NM

R878

NM

NM C925

Q931 LSC4081UB(QRS)

12MHz

R884 1

NM

D871 R879

NM

NM C916 R932

1 4.7u CCG1201-A

C638 R877

4.7u

CCG1201-A C912 47k

10k

C921 C931

C319 NM

C333 NM C918

R352 0.1u/16 C922 0.1u/16

CCG1192-A 1000p/50 C923

C320 NM

C332

NM C917 4.7u CCG1201-A C911 C952

1000p/50

C321 NM

C334 4.7u

CCG1201-A C924 R933

NM

VDD3.3 DIM R876

NM

NM 0.1u/16

C871

C652 RKZ7.5KG(B2) R885 R874 0.1u/10

R880 180 D872

47k C817

NM NM

7

D952

DEH-14UB/XNUC NM

220u/6.3 C919 1000p/50 C920 R912 4.7k CRG03

6 4.7k

C927

5 R951 1/10W

6

Q953 LTC114EUB

5 8

A

B

C

D

E

39

F

0

C551

RFGND

M2R6TP_GND

KN401

TUNGND 2

0.1u/10

33p/50

C401

R401

D401

3

RFGND

DEH-14UB/XNUC

4


9

10

R553 10k

R552 10k

NM

L551

L420

C443

*

RFGND

GND

CTF1786-A

L403

*L404

RFGND

6p/50

CTF1786-A

L402

1

L406

*

R403

AGND

3

2

1

NM

C448

100

R560

17 NC9 NC10 18 NC11 NC12 19 NC13 20

16

15

NM NM 1u 3p 1.5k 470 680 0 0 NM 0.47u 0.1u NM PEB035A8

CCG1205 0.1u NM NM 330 360 390 NM NM 0 NM NM 0.1u PEB034A8

C424 4700p/25

C425 4700p/25

1

ipod CP

*

NM

R561

NM

*

TEST

*

DGND

*

8.2

46

NM

L410

0

D502

VDD3.3V

R428

L411 NM

8.2

AGND

NM NM

C440

NM

CCG1205 C442

L416 NM C441

R421 0

L414 NM

L412 L413

DGND R429 NM

*

DGND

0.1u/10

47 2.2u

48

GND1V2 45 GPIO0 44 GPIO1 43 GPIO2 42 GPIO3 41 GPIO4 40 GPIO5 39 GPIO6 38 GPIO7 37 GPIO8 36 GND3V3 35 VDD3V3 34 I2CSCL I2CSDA 33

VDD_CORE

2

3

C429

1/4W 1/4W DGND R410 R412

RF GND

*

USB&USB5V

*

RF GND

*

C454 NM

R434 C457

R562

DGND

X2

GND1 X1 CSS1805-A

4 GND2

X401

36.48MHz

R751

VD2

RF GND

*

Q751 2SD2396(K)

7.4V

CPRST

CP_SDA

CP_SCL

CPPW

NM

L419

TUNL

TUNR

GND VDSENS

10u

MECHA VD

NM C753

C751 CCG1192-A

Q752

SW5V

NM

R430

except A ROT1

KEYD

SWVDD5

ML

CDWAIT

CDSTBY

CDSRQ

CDRST

CPPW

CPRST

CP_SCL

CP_SDA

CD_SCL

CD_SDA GND

1k

R427

B.UP

NM

R754

KN601

NM

R417

NM

R416

C602

R605

2

7

SI

IC671

0.1u/10

130

129

128

127

126

125

124

123

122

121

120

119

118

117

116

115

114

113

112

111

110

47k

CE#

SO

WP#

0.1u/10

109

NM

C

VSS

C671

R671

SCK 7 HOLD# 8 VDD

6

5

CD_SCL

*

NM

R721

1

3

6

8

4

5

R704 4.7k

VD1

CD_SDA

0.1u/10

C601

SCK

SI

0.01u/16

100k C701

R703

100k

47k R702

R701

GND

M2R6TP_GND

GND

CD

CN701 VKN1192

FLASH ROM

820

R753

VDCONT

VDD3.3V

6

5

2 1

4

3

RN4983

A-a A-b

C754 0.1u/10 D751

B~E

FM(30%) -15dB±2.5: -15.0 dBs AM(30%) -15dB±2.5: -15.0 dBs

C432 C433 C457 C458 R403 R406 R408 R431 R433 R434 C430 C431 C439 IC671

RFGND

0.01u/16

C415

IC551 341S2162

100

R559

16

4.7k

R558

Q551 LSA1576UB(QRS)

L418

L405

C412

C413

10u CCG1192-A RFGND C445 0.022u/16

C408

A GND

0.01u/16

4 FMMIXDEC 5 FMMIXIN2 FMPINDRV FMMIXIN1 FMPINDDEC 0.01u/16 6 GNDRF C414 7 TCAM 1u/10 8 VCCRF IC401 AGND 9 orRFGND C450 CK_SEL TDA7706 NM 10 GNDVCO LFREF 11 LFREF C407 C410 LF1 12 LF1 13 VCCVCO PINDDEC 0.1u/10 0.01u/16 PINDIN 14 TCAM2 C411 0.01u/16

C446 RFGND NM

15p 22p 2p 0.01u 8p NM NM 0.39uH NM 1.5uH 2.2uH 0.39uH 0.27uH NM

C428 9p/50 56

JA401 YKS5041

220

KP2311E

C402

NM

750

9p/50 C431

ANTENNA

C405

L401 0.15u

NM

1M

C458

47k

P401

C403 0.01u/16

C404

IMSA-6802-01Y900 R432

C451

C409 0.01u/16

R402

NM 100p 82p NM NM 1u 10p 0.27uH CTF1389 22uH 47uH NM NM 68n

1M

C432

47k 10k

0.1u/10

C408 C421 C427 C443 C444 C452 C455 L404 L405 L406 L409 L417 L418 L420

R405

GNDLNA 17

D402

C417 LNAIN 18

LNADEC 10u 19

C418 CCG1192-A

KP2311E

1u/10

20

0.1u/10

0.1u/10

L407 0.1u/10 C419

64 TVDAC 63 C416 TCFM 62 0.22u/16 PLLTEST 61 GND-PLL 60 R406

C449 NM

NM

VCC-PLL

LNAIN2

C420

LNAOUT2

21

LNAOUT 22 33

0.1u/10 R407 C421

LNADEC2 23

C456

R413

R551

C427

C422 0.1u/10

51

CTF1786-A L408 59 VCC-ADC_DAC

C426 55

CTF1786-A 58 DACOUTR

57 DACOUTL 24 L409

54 0.1u/10

GNDSLINK

26

AMMIXIN1 R408

53 R409 NM 28

C406

C444

L417

R431

RKZ8.2KG(B2)

A

1

2

3

4

NC

CP_SCL

ROT1

KEYD

SWVDD

VSS11

PVCC10

NC

DACCS

CDWAIT

CDSTBY

CDSRQ

CDRST

VSS10

CPPWR

PVCC9

CPRST

CN701

L671 CTF1786-A

GND

SO

NM

C703

NM

C702

CP_SDA

TUNSDA TUNSCL

NM

C704

100k

R717

NM C706

GND

NM C705

DGND

NM

GND

PGND

NM C710

NM C709

NM C708

C707

DAC

CD/USB:+5.22 dBs

SYSTEM MICRO

R5S7266ZD144FP

IC601

NM

C235

C234 CCG1192-A 10u

D GND

2 2

X601 CSS1603-A 1 3 1 3

16.934MHz

820

R231

820

R232

A-b

B.UP

VDD3.3

SW5V

NM

L231

LP

68

69

70

71

72

67 VDSENS 66 NC 65 NC 64 MODELAD 63 USBUVSS 62 USBUVCC 61 USBAVSS 60 USBAVCC 59 USBAPVCC 58 USBAPVSS 57 REFRIN 56 USBDVSS 55 USBDVCC 54 VBUS 53 DP 52 DM 51

AVSS

KEYAD

AVREF

NC

AVCC

3

11 VSS I2C_SCL/SPI_SIMO 12 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 VCC NC8 nRESET 14 NC2 MODE1/SPI_nSS NC1 15

L415

52 29 C433

VDCONT R419

R752 C447

50 31

VDIG 27

R433 C452 C434

R418

49 32 NM

C436

AMMIXIN2 25

C423 0.01u/16

1000p/50

GND-ADC_DAC VREFDEC GND-REF OSCOUT OSCIN VCC-REF VDDIO1V2 VDDPLL1V2 NM

NM

C435 NM C437

C438 NM

VCCREG1V2 REG1V2 VREG3V3 RSTN RDSINT 30 C430

10k R420 R415

VD 1

B~E

NM R601

CTF1786-A C439 C455

10k NM R414

D601 RB551V-30

VD 2 CDSRQ

SCL

A

100k

3 /CDSRQ 220

C238

*

10k R603

4 /CDSTBY 220

SCL 100 108

CDSRQ

R707 CDSTBY

R708 CD_SCL

R709

CDSTBY

SDA

SKIP

5 TUNPCE2

L701

6 SDA

220 R710

SKIP 100 R711 CD_SDA C605 106

CDSKIP 107

VDD

RESET 8 VDD4

9

RESET 1k R712 CDRST

NM

7

TUNPCE1

CDDATAIN

C607

47k 104

DATA 150 R713

10 GND 11 DATA BCLK 150 R714 NM

12 BCLK 13 LRCK LRCK 150 R715 NM

102

R672 0.1u/10 VCC6

105 RSPCK

220

R719 CDLRCKIN

R718

16 WAIT CDWAIT

DGND1 NM 103

VSS9 /SSL

MC LRCK R611

R720

PVCC8

MD NM

R613 89

14 GND 15 PGND

MISO 100 TUNPCK 99 RDS_INT

SCK MD NM

CDSCKIN

CE 0.1u/10 101 MOSI

C609

CDDATAIN 0.1u/10

DATA SCK R614

NM 92

NM

IC231 CDSKIP 88

C611

ML C615

BCK MC C617 NM

PGND WAIT R716 R634 98 TUNPDI

NM 97 NC TUNPDO

CDSCKIN 96 CDSCKIN

CDLRCKIN 95 CDLRCKIN

94 VCC5

93 CADATAIN

10p/50 220

ASEBRK

BCK 100 VSS8

0.1u/10 R617 PVCC7

R609 91

C613 100

C239 C620

LRCK C619

1000p/50 0.1u/10 R616 DACLRCK

0.1u/10 DACSCK

NM R618

DATA 100

7

1 16 SCK BCK 2 15 DATA ML 3 14 LRCK MC 4 13 DGND MD 5 12 NC ZEROL/NA 6 ZEROR/ZEROA 11 VCC VCOM 10 VOUTL AGND 9 VOUTR TCK

DACBDATA 87 86 CDSKIP 85 DACBSCK 84 AUDIO_XOUT 83 VCC4 82 VSS7 81 PVCC6 80 AUDIO_X1 79 AUDIO_X2 78 TCK TMS 77 TDI 76 TDO ASEBRKAK/ASEBRK 75 TRST DACDATA

C612 90

R619 TDI

8

C232 0.01u/16 TMS

PCM1753DBQ C233 8

CCG1192-A 10u 7 2 1

TDO

6

3

3

2

TRST

1

74

A-a 73

40 1800p/50

F C237

E 1800p/50

D C231

C 5

B 47k R621

A 2

4

1 4

JA892 CKS4124

C

6

7

8

9

10

11

12

GND

U1OUT

U1IN

VSS

1

2

3

4

NRST_CPU 5

VCC

MIC1P

MIC1N

VSS

SPKR

VSS

SPKL

R

6 5 4 3 2 1

1 3 2

GND 13

CN961 VKN1189

W.REM&MIC

(W/R)

(RMIC)

JA891 YKS5035

except A

W.REM

0.1

GND

4

GND

R965

1k

1k

R966

NM

L961

1u/10

R964

GND

R963 8.2k

GND

C963 R962 8.2k

1u/10

C964

GND

KEYAD

GND

L501 CTH1475-A

GND

NM

ipod CP

GND

1k

1k

R891

GND

3

2

1

R892

GND

1u/16

C509

KEYD2

RT

GND

VIN

/OC

VOUT 4

5

BD9008F

INV EN/SYNC

FB

SW

10k

R969

C968 470p/50

BT MOD

except A

KEYAD2

IC501 PVIN

BD2232G-G

EN

GND

VIN

IC510

4

3

2

1

A GND

4

3

2

1

5

6

7

8

USB&USB5V

GND

IN+1

IN-1

OUT1

GND

10k

R972

IN+2

IN-2

OUT2

VCC

IC961 NJM4558MD

USBCTL

FLG

R507

R506

5

6

7

8

NM

10k

R968

C967 470p/50

SYS+B L962 NM

SYNC

LPF

GND

NM

51k

CRG03

CRG03 D503

D502

ASENS

SSENS

BSENS

RGBDT

A-a A-b

CN1821

DP

AUXGND

AUXR

SOURCE

AUXL

DSENS

CKS6288

CN801

14

15

16

17

18

19

20

4

5

6

7

8

9

10

11

GRILLE

DGND

1

ROT1 SWVDD 3 2 ILMGND

ILM+B

ROT0

RGBDT/USBGND

KYDT

USBGND

DPDT

USB5V

RGBCK/ILMCLR1

DM 13 12

RGBST/ILMCLR2

ILMCLR2

ILMCLR1

ILMPW

ROT0

ROT1

KEYD

DSENS1

except A SWVDD5

ML

CDWAIT

CDSTBY

CDSRQ

CDRST

B

BTR

BTL

BTRST BTRX BTTX

KEYAD

KEYD

USBCTL

FLG

VBUS

SYNC

CPRST

CP_SDA

R818

0

R814

2.2k

0.1u/16

DSENS C818

GND

RGBDT

NM

0.1u/10

137

136

135

134

133

132

131

130

129

128

127

126

125

124

123

122

C802

CDRST CDSRQ

SSENS ASENS

BSENS

DSENS

BTTESTMD

BTTESTIN

RGBDT

VSS12

ILMCLR2

PVCC11

ILMCLR1

ILMPW

ROT0

ROT1

KEYD

SWVDD

VSS11

PVCC10

NC

DACCS

CDWAIT

CDSTBY

NM

C803

ILMG

NC

D GND USBGND ILM GND

NM USGND

DGND

SWVD

ROT1

ILM

ROT0

KYDT

DPDT2

US5V

ICLR1

DM

ICLR2

DP

AUXG

AUXR

SRC

AUXL

144

143

142

141

BTTESTMD 140

138 NM BTTESTIN 139

R641

0.1u/10

C603

C602

R605

0 121

R817

R816

R5S7266ZD144FP

IC601

SYSTEM MICRO

22k R801 22k R815

R802

100 100

100

2.2k

R804

R810 2.2k

R808 2.2k

2.2k

NM

R803

NM R811

GND

3 3

CTF1713-A 2 2

44 R812

L801 11

2.2k

DP

AUXR AUXG

AUXL

SSENS

DPD

8

A-b

SWVD

NM

L851

ROT1

ROT0

KYDT

ILMCLR1

GND

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

38 RES PLLVCC 37

PLLVSS

MD_CLK0

MD_BOOT0

EXTAL

XTAL

VSS5

PVCC5

VSS6

USB_X1

USB_X2

ASEMD

USBDPVCC

USBDPVSS

DM

DP

VBUS

USBDVCC

USBDVSS

REFRIN

USBAPVSS

DM 8.2 ILMCLR2

R805

8.2

R806

R807

USBAVCC

USBAVSS

USBAPVCC

7

The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation.

NM : No Mount

220p/16

GND

NM C505

NOTE : Symbol indicates a resistor. No differentiation is made between chip resistors and discrete resistors. Symbol indicates a capacitor. No differentiation is made between chip capacitors and discrete capacitors.

GND

KEYD

MIC1N

MIC1PF

GND

NM

R557 4.7k

USB5V

0

NC9 NC10 18 NC11 NC12 19 NC13 20

R556 2.7k

VR105C5R0AAA

VA894

C970

0.1u/10

C892

220u/6.3

C552

VA893

0.1u/16

18k

5 11 VSS I2C_SCL/SPI_SIMO 12 4 I2C_SDA/SPI_SOMI MODE0/SPI_CLK 13 3 VCC NC8 nRESET 2 NC2 14 MODE1/SPI_nSS 15 1 NC1

R501

0.1u/16 C891

VA892

47k C503

6.8k

10k

NM R503 R502

R504

470 C502

VA891

C508


C511

D501 RB160L-40 NM C510

R505 C506 1u/10

C965

22p/50 NM

0.015u/16 NM D961

17

R967 R961

16

10k 47k 47k

R971

9

C512 C966

10

220p/50

C507 C513 CCG1192-A

IC551 341S2162

10k

NM

C961

CP_SCL

R691

R561

220p/50

NM R973

R508 10k

4 5

R601 3 6

100k

10k R603 2 7

47k 1 8

NM

1u/10 10u C962

C969 1u/16

10k R970

D601 RB551V-30 R604 47k

NM

PVCC2

100

C604

/RDSLK

100

NM NM

1 2 PVCC1 NC 0.1u/10

VCC2 17

R560

3 D809 DZ2S068C

VCC1 0.1u/10

VSS1 4 DIM

ANTPW 6 ANTPW

DIMMER 5 C606 C809 0.1u/16

SYSPW 8 PCL

PCL 7 SYSPW D804 DZ2S068C

9

R607 D803 DZ2S068C

MUTE

R559

25

R602

R813 RGBDT D808

34

R553 10k

NM

C801

47k

R552 10k

R608

TELIN 47k BTRST D805 NM

RAM_MON C812 1u/16 D802 DZ2S068C

TELIN1 TELIN

10 BT RST ROM 11 ROM 12 RAM_MON 13 47k C608

VDCONT 14 0.1u/10 VDCONT

VSS2 15 D801 DZ2S068C

USBCTL 18 0.1u/10 USBCTL

16 R612 47k 0.1u/16 C808

C610 D806 NM

SYNC 19 R610 D807 NM

TESTIN

/USBFLG 20 2.2k FLG

PVCC3 22 R615 100k

VSS3 23 C616

VCC3 0.1u/10

TESIN

24 0.1u/10

VDT 26 VST

VST

27 VDT

C618

21 NM MUTE D811 DZ2S068C

C614 SYNC D810 DZ2S068C

29 KYDT

DPDT/TESTDO 28 DPDT 8.2k

7

R809

32 C621

VCK 30 VCK

BTTX

33 0.1u/10 4.7k

36 R642


35 BTRX

KYDT/TESTDI

31 BTTX R851

6

C810 220p/50 C811 220p/50

47k R620

5

C851

DEH-14UB/XNUC

NM

6

C852

5 8

A-a

41

A

B

C

D

E

F

42

1

B

2

F COLOR2 GREEN

3

1

2

1

L1801

NM

GRILLE uCON&LCD

1801-1820

KEY MATRIX & CONNECTOR

1821-1850

LED

1851-1910

USB

1911-1920

AUX

1921-1930

S1835

3

D1851-D1865 : SML-D12P8W(KL)

DEH-14UB/XNUC

4

2

1

S1826 S1832

DGND

EJECT R1801 2.2k

R1802 2.2k

DGND

NM

1

4

6

1

CLK

2

R1867

R1826 NM

1 2 S1829

D1864

S1828

D1865

SEG36

680

S1831

R1858

2

1

NM

1

C1864

2

KDT1

KDT2

S1833

NM

1

1 2 S1834

C1865

2

NM

6

4

S1825

2

D1862

S1830

5

2

D1863

LEFT

680

S1822

R1866

CLOCK

NM

1

NM

2

R1857

S1824

NM

EQ

C1862

2

KDT0

3

C1863

D1860

3

SRC

D1861

2

680

S1823

R1865

2

NM

1

NM

S1827

R1856

1

C1860

1

C1861

1

R1824 0

2

NM

SEG35

SEG34

SEG33

SEG32

SEG31

SEG30

SEG29

SEG28

SEG27

SEG26

SEG25

SEG24

SEG23

SEG22

SEG21

SEG20

S1821

DISP/BACK

D1858

R1823 0 SOURCE

D1859

5 MHz

NM

1

R1855

1

EQ

20

R1864

KST3

D1857

X1801 CSS1547

0

22

R1889

KST2

NM

KST1

C1858

R1825 NM

25

560

NM

NM

IC1802 GP1UXC14RK

NM

NM

KST4

R1854

17

C1857

REM

R1888

NM

D1855 RIGHT

KST0

NM

SIZE

1

DGND

D1856

GND

19

VCC

MODA

3

VSS

CCG1192-A 10u R1806

KDT2

680 R1863

26

NM

KDT3

NM

R1804

REM

27

2

1

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

GRILLE uCON

R1894

RS1/10SR***J-T C1801

KST4

R1853

28

C1855

29

C1856

SEG39

NM

30

LEFT

SEG38

D1853

SEG37

31

D1854

SEG35

SEG34

SEG33

SEG32

SEG31

SEG30

SEG29

32

EJECT

18

680

DPDT

R1862

21

NM

NC1

NM

KYDT

NM

SEG8

R1852

SEG9

C1853

23

C1854

R1805

X0

NM

X1

SEG10

LIST

SEG11

SOURCE

24

R1861

KST2

680

R1851

IC1801 PD6581A

NM D1851

SEG13 KDT3

C1851

NC2

NM D1852

KST4

C1852

SEG39

220 1/4W

55

16

SEG14 1

BAND

RS1/4SA***J-T 15

KDT0 KDT1

SEG15

KDT1

KST0

SEG37

220 1/4W

D KDT0

14

KST1

KST2

SEG4 SEG3

KST0

13

KST3

SEG16

KST1

12

VLCD

SEG28

SEG27

SEG26

SEG25

SEG24

SEG23

SEG22

SEG21

2

C1859

SYMBOL KST2

64 SEG36

SMLXA4WBETW1(Z1)

SEGMENT LCD SEG19 SEG18 SEG38

R1859

DGND SEG5

COM0

SEG6

KST3

63

11

SEG5

10

62

COM0

SEG6

COM1

SEG7

9

61

8

SEG12

COM1

60

SEG7

COM2

SEG8

COM3

59

7

58

SEG9

6

VDD

COM2

SEG10

COM3

SEG11 57

SEG0

SEG12 56

5

54

SEG0

SEG13

SEG1

53

4

52

SEG14 SEG17

SEG1

SEG15

SEG2

51

3

SEG16

SEG20

50

2

1

SEG17

SEG2

C

SEG4

49

SEG3

1u/10

C1802

B SEG18

R1860

SEG0 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32 SEG33 SEG34 SEG35 SEG36 SEG37 SEG38 SEG39 COM0 COM1 COM2 COM3

SEG19

D1866

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44

1 4

10.2 KEYBOARD UNIT

A

KEY MATRIX

RIGHT

2

BAND/ESC S1837 S1838 2

2

LIST 1

S1839

5 2

S1836

1 2

2 1

S1840

S1841

2

DISP/B

1 2

REMOTE

R1803 100

LED

CAW2018 V1801

E ILMGND

only D

REFERENCE AREA MAP

only

5

6

7

8

CN1821 CKS6287

1 3

DGND

2 4

AUX:+2.2 dBs

HT BAND/ESC S1837 1

2

S1842

S1838 1

5

2

27k

NM R1822

R1821

S1841 2

6

ROT0

7

USBGND

DPDT

11

USB5V

12

ILMCLR1

13

DM

14

ILMCLR2

15

DP

16

AUXGND

17

AUXR

18

SOURCE

19

AUXL

20

DSENS

B

A CN801

2

NM

CN1911 CKS6267

DGND

C

L1911

3

USB

NM

D1801

ILM+B

10

5V

DISP/BACK

ROT1

5

3

2

1

SWVDD

4

USBGND

S1840 1

ILMGND

3

KYDT

ROTARY COMMANDER DGND

5

2

9

CSD1168

2

DGND

8

S1839 1

1

2

1

4

A

KEYBOARD UNIT

NM

NM

C1922

NM

C1921

NM C1923

NM

VA1923

NM

ILMGND

CKN1090

SOURCE

KDT3

KDT2

JA1921

VA1922

VA1924

AUX

NM VA1921

B

2

1

4

NM

D1802

1

3

NM

NM

D1911

C1911

0.1u/16

6

C1912

5 ILM+B Dimmer off 12.96V Dimmer on 8.52V

D1912

4 DGND

0.1u/16

LED

DGND

NM

R1886

1k

NM

R1876

R1885

1k

NM R1875

820

R1884

R1874

NM

560

R1883

R1873

NM

820

R1882

NM

R1872

R1881

680

R1871

NM

R1867

680

R1858

USBGND

6

D1884

C DEH-1450UB/XNES1 D DEH-1450UBG/XNES CLK

D1885

D1882

4 5

D1883

1 2

D1879 D1880 D1881

B DEH-1450UB/XNES

E DEH-1490UB/XNID

3

EQ DISP/BACK BAND

D1876 D1877 D1878

D1873

LEFT

RIGTH

D1874

EJECT

NM

D1875

LIST SOURCE R1887

D1872

CLK

D1871

6

D1864 D1865

NM NM

E COLOR1

only D

RED

D1871-D1885 : SML-D12V8W(PQ)

except D

1

R1895

NM

ILMGND

0

NM

NM

2

6

0

R1892

NM

3

5

only D

R1893

4

R1890

Q1851

NM

R1891

ILMCLR

R1894

4

C1864

5

C1865

D

A DEH-14UB/XNUC

except D

F

B DEH-14UB/XNUC 5

6

7

8

43

1

2

3

4

10.3 CD CORE UNIT (S11.6STD) PICKUP UNIT(P10.6) (SERVICE) A

CXX3556 V3R3

2.4

4.7u/6.3 (2125)

C104

2.4 2.7 (1/10W)

(1/10SR,1608) R101 R102 R103 LD1

Q102 LTA123JUB

VCC TOP

TRK ACT

4

4

3

3

2

2

1

1

D101 NM TOM

C220

FOM

0.1u/10

C

RFI

TOP

82

R229

83

470

84

C217

R216

85

56p/50

1.2k

86

EQ1 RF2RFA.GND2 88 A.VDD2 89 A

BD

90

F

91

E

92

B F E 93

REFO

d

C229

0.1u/10

c

TE C225 TEC

C223

94

68p/50

95 FEO 96

ADCIN

C236

REFOUT FE-

FE

0.1u/10

R101 R102 R103 R246

ADCIN

C224

97

47p/50

98

TETEO 99

0.01u/16

100

C239

C104

CXE2273

TE2 TEC

2125:PARTS

M1 SPDL MOTOR

EQ2

C222 0.1u/10

NM

AC

RFO

87

C204

CKS4808-A

27p/50

E

F

BD

AC

TOP

FOP

FOM

TOM

81

RFO C228

NM

CN101

1608:PARTS C205 C209 C238 C240 C307 C308 C708

Land for manual soldering

C3T

C219 0.1u/10

AGCI

FOP

REFO2

*

AGCO 80

REFO1

NO MOUNT PARTS (NM)

A.GND1

79

1800p/50

RFAGC

C205

F.ACT: Applying positive voltage to FOP, the lens approaches DISC. T.ACT: Applying positive voltage to TOP, the lens moves outer circumference of DISC.

74

75 ATEST

f PD

LD

FOP

5

78

2

FOM

6

5

A.VDD1 77 C216

1

TOM

6

PD

NM

MD

AC

0.1u/10

5.6k

A+C

76 C221

4.7k

7

4p/50

7

F REFO

C218

8

VR

R218 R217

9

8

VREF

NM

9

P1+P6

E

C201

10

NM

11

10

EFM ATEST

NM

11

V+3A

BD V+3A

1M

12

R108

13

12

C101

GND

14

13

39 ASY

NM

P5+P10

14

R2

C110

VCC

15

C111

B+D

15

NM

C102 LD+

FOCUS ACT

LD

2SA1577(QR) 2.2k

LD-

HOLOGRAM UNIT

R109

C214

Q101

LD

B

R R R R

PUEN

0.047u/16

E:P5+P10 F:P1+P6

LD PD BLK SOM

Parts with Polarity IC201 IC301 D101 Q101 Q102 Q201

RED SOP

VDD

C202

D

C301 GND BL LCOM

YW

C312

5

LCOP NM

CSN1080-A 8SNS

S905 NM

FOP

7

FOM

8

TOM

9

2

8SNS

1

DSCSNS

2

S903

6

DSCSNS

10

TOP

CSN1081-A

DSCSNS SWITCHES: CD CORE UNIT (S11.6STD) S901:HOME SWITCH.........ON-OFF S903:DSCSNS SWITCH.....ON-OFF

C308

11

1u/10 (1608)

12 13

CLCONT LOEJ

4

CONT

MOTOR DRIVER LOGIC TABLE CLCONT LOEJ CONT

EJ

PLAY

OFF

H H L

H L L

L

L

H

L

VD

CLCONT

LOEJ

CONT

DEH-14UB/XNUC 1

LOAD

PGND

C 44

5

TD

The underlined indicates the switch position.

F

VDD 1

FD

C301

C306

14

SD

a9

NM

LCOM

4

NM

3

C313

2

SOP

MD

NM

SOM

NM

8

SIN SPIN 28 POWVCC CIN SLIN 27 SPOC315 BIAS 26 SPO+ FIN NM 25 TKIN SLLDOTIN FCIN 24 SLLDO+ CNT 23 POWGND LDIN 22 TKO- 29 GND 21 MUTE TKO+ PRTOUT 20 FCOPREGND 19 FCO+ 47k PRTLIM 18 R309 TKRNF PRTF 17 FCRNF 16 PRTT TKCDET PREVCC 15 FCCDET

C314

HOME

2

431

431 43 1

HOME

1

0.1u/10

HOME 3 S901

7

IC301 BD8223EFV

C307 1u/10 (1608)

E

CN702

ACTUATOR/ MOTOR DRIVER

CXC4026

2

3

2

LCOP

M2 LOAD/CRG MOTOR

4

PUEN

12k

12k R303

R304

SKIP

/CDSRQ

10k

Mask

51

LRCK0

/CDSRQ

/TESTIN

52

SKIP

53

55

54 /PUEN

/ADENA

VDCONT

56

57 VDSENS

58 TEMP

59 MONITOR_0

MONITOR_1

60

62

61 MONITOR_2

63 SD2

MONITOR_3

50

PC3

A.GND1

SDA

RFI

SCL

78 AGCO

8 0 7 0

81 82

R229

83

470

84

R216

85

TX/EMPH

SCKO

RF AMP, CD DECODER DIGITAL SERVO/DATA PROCESSOR CPU

DOUT PA7 LOEJ

RF2-

1.2k

86

CLCONT

RF87 A.GND2

IC201

A.VDD2

PE5791A

88

CONT DSCSNS

89

NC

A 90

EJSW

E 93

/CDSTBY

REFOUT

C223

94

ICECK

FE95

68p/50

FEO

IO.VDD1

ADCIN

IO.GND1

96 C224

97

47p/50

TE-

RESET

TEO

C.GND

98 99

C.VDD

TE2

NM

NM

C235

SCL C283 NM

R283

44 R281

0

56

43 R282

56

LRCK

56 R292

BCLK

C281

C282

0

NM

NM

R293

DATA

42

C284

0

41

NM

R202

0

LOEJ

40

R201

0

CLCONT

39

R264

1k

CONT

38

DSCSNS

37

8SNS

35

HOME EJSW

34 33

R245 R253

100k

NM

C

100k R240 47k

/CDSTBY ICECK

32

ICECK R297

31 C211

30

NM

0.1u/10

29

R237 C233

28 27

C210

26

0.1u/10

RESET

220

0.01u/16 R232

XTAL

VPP

X.GND

VPP CVDD CVDD

VDD2

C299 0.1u/10

VDD

VD2

RESET

VD1

SCL

SDA

SKIP

CDSRQ

CN701 CKS6146-A

I/O

VPP 9

SCK 7

ICECK 5

6

VD

/CDSRQ

VDD 1

CDSTBY

GND

NM CVDD 3

D

VDD1

3

(1608) NM C240

2

ICEMD

0.1u/10 0.1u/16 (1608)

0.1u/16 (1608)

CVDD

ICECK

VPP

X201 CSS1603-A

16.934 MHz

C209

10 GND

SCK

C238

SCK

NM 8 SI

6 SO

4

CN702

2

RESET

C202

C203

A0

STB

RST

INTQ

1

25

/XTAL

24 470

ICEMD

X.VDD

23 R294

22

DA.VDD

SDA R291

0

21

20

LOUT 19

REGC

DA.GND1

ROUT

DA.VDD1

DA.GND 18

17

16

15

14

REG16

REGS 13

D.GND

12

D.VDD

SI 9

SI

11

10

SO

SO 8 SCK

/SCK

A0

6

7

/STB

VPP

INTQ(INT1)

/RST

4

3

PD

LD

2

1

NM

C239

TEC

5

100

/WAIT

R254

HOME

F 92

0

36

12SNS

B 91

22

ADENA

BSCK0

45

LRCK

RFO

EQ1

56 470

B

ADENA

46

AGCI

EQ2

22

47

/WAIT

C3T

C219

56

48

80

0.1u/10

Flash 10k 22

49

79

1800p/50

0 56

0

C216

IO.GND2

IO.VDD2

A.VDD1 77

64

65

66

67 TD

FD

SD

68

70

71

69 MD

TEST

AD.GND

72

73 EFM

AD.VDD

75

74 ASY

ATEST 76

R232 R281 R282 R291 R294

GND

TESTIN

TEMP

TH201 NM

Q201 NM

ATEST

TEMP

R296

R260 C16M

MONI0

MONI2

b

MONI1

MDX

0.1u/10

(1608) R246

VDD

e

MDY

10k C215

R214

39k

EFM

ADENA

TEMP C212

C213

0.1u/10

GND

R215

ASY

A

CD CORE UNIT (S11.6STD)

4.7k

R306

4.7k 4.7k 4.7k 4.7k

3300p/50

C214

R308 4.7k

0.1u/10

8

PUEN

C305 0.022u/16

R310 R311 R312 R313

7

C

1000p/50 1000p/50

C304

0.047u/16

0

R307 1k

R305 SD 1k R302 TD

C302 C303

0 R301 FD

6

MD

5

/CDSTBY

R709 0

R706

SCL

R702

220

SKIP

100 R701

R708

SDA

0

100

RESET

1

VD

7.5V

2

VD

7.5V

3

/CDSRQ

4

/CDSTBY

5

SCL

6

SKIP

7

SDA

8

RESET

9

VDD

10 GND DATA

NM (1608)

C708

NM

C707

NM

C705

C710 1000p/50

GND

15 PGND

GND

16 WAIT

IIC-BUS Digital GND3

GND2

GND1

LRCK

WAIT

DATA BCLK

NM

NM C701

NM

NM C702

PGND

C703

L

NM

L

H

R710

L

R711

H L L

14 GND

i h g F PGND2

OFF

13 LRCK

/WAIT

PGND1

PLAY

CN701

GND

12 BCLK

LRCK

J

3.3V

E

11 DATA

BCLK

LOGIC TABLE

A

C DEH-14UB/XNUC 5

6

7

8

45

1

2

3

4

10.4 WAVEFORMS - CD CORE UNIT(S11.6STD)

A

1DSCSNS 3HOME 4LOEJ

5 V/div 5 V/div 5 V/div

Note : 1. The encircled numbers denote measuring points in the circuit diagram. 2. Reference voltage REFO1(1.65 V)

500 ms/div

1DSCSNS 5CLCONT 4LOEJ 6VD1

5 V/div 5 V/div 5 V/div 10 V/div

12 cm CD Loading operation

12 cm CD Loading operation

Ref.: GND

Ref.: GND

Mode: Normal

Mode: Normal

500 ms/div

B

7SIN 8CIN 9TIN

aFIN 200 mV/div 500 ms/div bRFOK(MONI_2) 2 V/div 7SIN 2 V/div

cTE dFE

12 cm CD-DA setup operation after loading

12 cm CD-DA Source On setup operation

Source On setup operation

Ref.: REFO

Ref.: REFO

Ref.: REFO

Mode: Normal

Mode: Normal

Mode: Normal

1 V/div 500 mV/div 500 mV/div

1 s/div

500 mV/div 200 ms/div 500 mV/div

C

dFE aFIN cTE 9TIN

D

E

500 mV/div 500 mV/div 500 mV/div 500 mV/div

46

eMDX 7SIN

2 V/div 50 ms/div 500 mV/div

eMDX 7SIN

5 μs/div

2 V/div 500 mV/div

CD-DA Play operation

Spindle waveform during play operation

Spindle waveform during play operation (Wider)

Ref.: REFO

Ref.: REFO

Ref.: REFO

Mode: Normal

Mode: Normal

Mode: Normal

aFIN dFE

F

20 ms/div

500 mV/div 200 ms/div 500 mV/div

cTE fRFAGC

500 mV/div 500 mV/div

2 ms/div

fRFAGC cTE 9TIN

1 V/div 500 μs/div 500 mV/div 500 mV/div

Focus Search waveform

Track Open waveform

100 Track Jump waveform (32 Track Jump x 3)

Ref.: REFO

Ref.: REFO

Ref.: REFO

Mode: TEST

Mode: TEST

Mode: TEST

DEH-14UB/XNUC 1

2

3

4

5

fRFAGC cTE 9TIN

6

1 V/div 500 mV/div 500 mV/div

2 ms/div

fRFAGC cTE 8CIN 7SIN

7

1 V/div 200 ms/div 1 V/div 500 mV/div 2 V/div

8

gLRCK 2 V/div hBCLK 2 V/div iDOUT(DATA) 2 V/div

32 Tracks Jump waveform (Zoom of 100 Track Jump waveform)

Search operation(Outter to Inner)

Digital Out waveform

Ref.: REFO

Ref.: REFO

Ref.: GND

Mode: TEST

Mode: Normal

Mode: Normal

1DSCSNS 5CLCONT 4LOEJ


1DSCSNS 3HOME 4LOEJ

500 ms/div

B


12 cm CD Eject operation

12 cm CD Eject operation

Ref.: GND

Ref.: GND

Mode: Normal

Mode: Normal

fRFAGC 9TIN cTE aFIN

1 V/div 1 V/div 1 V/div 1 V/div

A

10 us/div

500 ms/div

C

500 μs/div

Black Dot (800 μm) during play

D

Ref.: REFO

Mode: Normal

E

F

DEH-14UB/XNUC 5

6

7

8

47

1

2

3

4

11. PCB CONNECTION DIAGRAM 11.1 TUNER AMP UNIT

> P 251 (A,7,128) Fuse 3 A

W. REM JA892

6

C313 C254

1

C253

D503

C510

C505

C503 R501 C502 R502

R504 R503 R506

C507

C334 R334 R332

D502

C261

120

15

C316

C251

1

IC301 5

VA893

C252

R252

1

R891

10 1

C308

Q251

R892

C306

4

VA891

C302

1

C307

Q252

R258 C258 R254 R251 C255 R255

P251

R259

SIDE B

R253 C257 R257

C260

Chip Part

5

C259 VA894

130 P.C.Board

2

JA891

C304

SIDE A

3

C892

3

2

C305

5

C891 1

C301

6

JA251

C303

REAR OUTPUT 4

B

CEK1286

150

140

Capacitor

Connector

TUNER AMP UNIT

C331 R331 R333 C333

A

C314 C317

1.The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram. 2.Viewpoint of PCB diagrams

VA892

NOTE FOR PCB DIAGRAMS

R256 C256

A

5

C508 IC501

R507

C506 R505 D501

C514

1

110

C509

L501

1

100

C

90

80

70 D

60

50

40

C

E

CN701

30

20

10 F

B

Y

48

FRON 0

A

X 10

20

30

40

50

60

DEH-14UB/XNUC 1

2

CN1821

3

4

70

80

5

6

7

8

A

SIDE A CEK1286

POWER SUPPLY 10

14

D302

9

13

16

D301

C312

C351

1 Q752 R753

D954

C318

C901

ANTENNA

R301 D902

Q301

R952 R951

D951

C513

C512

IC510 1

D875

R419

C615

C458

C417

60 55 50 L414

L413

R429

L416 C437 R421

D873

C238

C613

D871

D911

D

D912

C636

R231 R232

L231

C233

R639

C634

C239 C922

C231

C928 L601 C924

C929

C912

C911 C920 C916 C918

C914 C917

C921 R721

R912

C913

R911

C926

C923

C919 C915 IC912

5

E

1

D874 R882

R883

C511

D872

R410 R415 C612

C611

C622 R621

C630

C635

C637

C638

R632

R703 C701

IC231 1 5

10

R716

C872 R871

L602 R640

R718 R719 R720

C705 C706

10

15

C925

C632

E Q873

C235

C232

R628 D602

R630

C624

C871

C237 C620

R619 1

70

R631 C623

C438 C439

R562

R605 C601

R641

R627

C626 R626 C625

R620

C621

C651

D651

R637 R623 C628

C627

X602 1

C633

65

E

X601 1

R618

R873

C873

E

C234

C429 L419

Q872 1

R885

R874

Q871

R614 R616

C428 1 X401

R881

R601

R603 R962

R968 R651

60

R876 R875

C704

R412

C552 R557

R558

20

R559 R552 R553 R560 R561

C967 R970

C964

C963

10 5 1 15 10 5

55

R633

R717

1

75

C707 C708

80

50

R752

R751 R707 R701 R708 R709 R710 R711 R712 R702

R617 C619

R880

Q874 R420

R611

C617

C426

C435 C431 C432 L412

C442 C441

L415

R613

L408 C425 C424

45

R417

R634 C609 R609

85

CN701

R713 R714 R715

45

R625 R636 R622 R624

R704 1

40

C440

C436

C607

90

L701

40 R629 C631 C629

35

C447

C

L407

R409

R877 C605

95

1 IC651

35

R966 1 C652

IC401

R427

R430 R418 R416

110

30

C702

115

25

C618

R964 R642

120

IC601

20

R508 C616

R201

C703

125

15

C610

C614 R615

130

100

R608 C608

R610

135

10

L961

C965

140

105

R607

D961

L671

C602 R414

C604

R433 C454 C434 L411 R428

C433

5

C970

D601

C603

1

C606

C422

L410

R602

R604

C671

R402

C419

R408 C452 C427 C457 C455

5

R612

C969

CN961

1 R671

1

R965

15

R972 C961 L962

C710 C709

5

C966

5

IC961

R963

1

1

R969

R672

L401 C406 C409

D402 C448

30

C962

C421 L409

E R556

IC671

R691 C968 R967

C423

C449

C410

R434

C420 R407

25

R971

R961

10

R973

Q551

C413 C446

20

KN601

R406

C430

R551 C551

C418

IC551

R413

C415 C445 R405

C412

R401 C403

C402

C416

R403

L404

C414

L405

R431

C456 C450 C404 L402

C214

L406

L551

C443 L403

C444

C213

R432 P401 C401 D401

L420

L418

C411 C405 C407

C951

C408

R934

D952

Q931

C451

L417

5 C952

E

C931 R933

R941

C209

C217 C207

C205

C211

R205

L201

IC951 1

R932

Q941 C202

10

D931

E

1

1

R931

10 C204

KN401

C927 Q951

Q953

Q952

R942

5

R943

1

C215 C203

IC201

R206

1

L941

15

C201

20

E

E

D941

R207

JA401

C210

C206

D901

R879

1

18 17

R878

R352

R304 R302 R303

1

B C319

R351

R353 Q351 1

C212 C216 C208

C311

6

5

C315

C308

C306 C302

C307

2

1

15

C310

C334 R334 R332 C332

C304

C305 C301

C303

C331 R331 R333 C333

E

C320

15

3

Q751 C309 D751 C754 R754

10

6

L901

JA901

C753 C751

C321 25

15

FUSE

20 IC301

5

10 5

1

A

R884 D876

R872

C851

CN1821

80

D804

D806

D803

D802

D805 C812

R817 R816

1

D807 D801

D810 R804

D808

L801

R811

R814 1

C809

5

C818

15 10

20

F

CN801

FRONT 70

R813

C810

D811

C817

R851 D809

C811

C803

C801

R818

R802

R815

C808

R807

R801

R806

IC801 15

R812

R805

R809

R803

L851

R808

C802

R810

C852

90

100

110

120

130

140

DEH-14UB/XNUC 5

6

A

160

150 7

8

49

1

2

3

4

A

A

TUNER AMP UNIT

1

B

1

C

PCL

D

TESTIN 1

E

1

1

F

A 50

160

150

140

130

120

110

100

90

DEH-14UB/XNUC 1

2

3

4

80

5

6

7

8

A

SIDE B

150

1

140 1

1

130

B

120

110

100

C

90

80

70 D

60

50

40 E

30

20

10 F

Y 90

80

70

60

50

40

30

20

10

DEH-14UB/XNUC 5

6

X 7

0

A 8

51

B

52

1

2

0

D1876

20

30

40

D1859 D1878

50

C1859

D1858 D1877

C1853 D1879 D1856 C1856

3

60

70

2

80

S1825

D1881 D1861

90

3 S1831

D1883 D1863 C1863

110

5

120

S1839

10

130

S1830

6

5

1

S1824

CLOCK

140

D1885 D1865 C1865

D1882 D1862

100

C1862

4 S1835

15

4

3

AUX

JA1921

150

1

USB

CN1911

2

160

A

10

1

S1836

D

BAND /ESC

20

B

D1857

X

S1837

S1838

V1801

SEGMENT LCD

25

2

Y

D1873

D1866

30

6

S1841

C1855 S1834

D1855

35

5

DISP /BACK

S1833

RIGHT

40

4

S1822

S1842

5

S1827

3

C1857 S1840

D1851 D1871

LEFT

1

SRC

D1872

2

D1874

C1851

D1853

S1821

ROTARY COMMANDER

C1852 D1852 S1826

1

10

EQ

S1829

C

S1823

LIST

IC1802 1

20

30

C1854

D1875

E

S1828

S1832

D1854

B

40

F

EJECT

1 3 4

11.2 KEYBOARD UNIT KEYBOARD UNIT SIDE A

D1884 D1864 C1864

C1861

C1860 D1860 D1880

C1858

DEH-14UB/XNUC

4

C1912

19

15

CN1821

5

1

C1802

L1801

2

55 1

60

10

50

20

5

45

R1805 R1806 R1803

1

L1911 R1823

C1922

90

IC1801

10

15

80

X1801

R1824

D1802 1 R1801 R1892 R1802

70

1

D1801 1

R1874

60

R1825 R1821 R1822

R1863 R1856

R1853

50

40

30

R1887

R1861

R1889 R1888

R1871

R1881

R1862

R1864

R1854

R1883

R1873

R1852

R1851

20

10

F

X

0

10

20

30

40

B

Y

8

53

DEH-14UB/XNUC

C

100

R1855

CN801

A 110

R1872

R1804

D1911 D1912 C1911

VA1921 VA1922

VA1923 C1923 VA1924

120

R1885

D R1893 Q1851 R1894

B

130

R1891 R1895

30 25 20

C1801

1

R1867

140

R1882 R1875

R1826 R1859 R1884 R1866

R1876

40

1

150

C1921

35

A

160

R1860 R1857

1 R1890

R1858

7

6

5

SIDE B

KEYBOARD UNIT

B

8 7 6 5

R1886

R1865

E

1

2

3

4

11.3 CD CORE UNIT (S11.6STD)

C


SIDE A

A

PICKUP UNIT(P10.6)(SERVICE)

60 B

CN101 15

10

5

1

R246

R232

M2 LOADING/CARRIAGE MOTOR

R254

TH201 C235

1

HOME

C102

S901

C201

50

D101

CN702

R253 R245

1 5

10

F E

C238

C

R706

C240 C205

C710 R297

C299

40 C707 R701

C220

C705 R702

M1 SPINDLE MOTOR 30 D

CN701 15

10

5

A

1

CN701 C702

20

C307 R710 C701

C308

C312

E

R306 R303 R304

R201 R308

REFO1 10

5

1

IC301

10 R307 R305 R301 R302

R264 R202

15

20

25

C306 R309

Y

0 F

X

10

20

30

40

50

C 54

DEH-14UB/XNUC 1

2

3

4

5

7

8


SIDE B A

60

R101

R103

R102

C104

B

Q102 R108

Q101 E

C202 E X201 1

50

R109

R294 C203

C239

C209 15

20

25

R240

90 85

R291

C218 R218

R216 R229

C219 45

C283

R292

C204 C222

IC201

40

C281 C282

C301

40

R293 R282 R283 R281

35

C284

95

E

C

C223

80

Q201

30

C211

C101 C111 C236 C229

R296

C110

C224 100

10

C210

5

C233 R237

C225 1

C

6

C217 C228 R217

C216 C221

50 55

60

65

70

75

30 R215 R214

C215

C212

R709 R708

R260

D S905

C708

1

C214 C213

20

E

R711 C703

1 C305 C304 C302 C303

C313 C314 C315

R313 R312 R311 R310

DSCSNS 10

S903

Y

0 50

40

30

20

10

F

X

C DEH-14UB/XNUC 5

6

7

8

55

1

2

3

4

12. ELECTRICAL PARTS LIST A

B

NOTE: Parts whose parts numbers are omitted are subject to being not supplied. The part numbers shown below indicate chip components. Chip Resistor RS1/_S___J,RS1/__S___J Chip Capacitor (except for CQS.....) CKS....., CCS....., CSZS..... The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Meaning of the figures and others in the parentheses in the parts list. Example) IC 301 is on the point (face A, 91 of x-axis, and 111 of y-axis) of the corresponding PC board. IC 301 (A, 91, 111) IC NJM2068V Circuit Symbol and No.

C

D

Circuit Symbol and No.

Part No.

A:DEH-14UB/XNUC B:DEH-1450UB/XNES C:DEH-1450UB/XNES1 D:DEH-1450UBG/XNES E:DEH-1490UB/XNID Unit Number : QWM3319(A) : QWM3320(B,C,D,E) Unit Name : Tuner Amp Unit Unit Number : (A,B,C,E) : (D) Unit Name : Keyboard Unit Unit Number : CWX4023 Unit Name : CD Core Unit (S11.6STD)

A Unit Number : QWM3319(A) Unit Name

: QWM3320(B,C,D,E) : Tuner Amp Unit

E

MISCELLANEOUS

F

IC 201 IC 231 IC 301 IC 401 IC 501

(A,98,112) (A,144,57) (A,78,141) (A,150,90) (A,20,113)

IC 510 IC 601 IC 651 IC 671 IC 801

(A,107,30) IC BD2232G-G (A,118,65) IC R5S7266ZD144FP (A,98,53) IC S-80827CNMC-B8M (A,126,85) Flash ROM Unit(A) PEB035A8 (A,126,85) Flash ROM Unit(B,C,D,E) PEB034A8 (A,108,19) L-MOS And Gate TC7SET08FUS1

IC 912

(A,145,28) IC

56

IC D/A Converter IC IC IC

PML022A PCM1753DBQ PA2030A TDA7706 BD9008F

BA49182-V12

Part No.

Q Q Q Q

251 351 751 752

(A,23,130) Chip Transistor RN1910 (A,88,127) Chip Transistor RN4983 (A,142,138) Transistor 2SD2396 (A,140,133) Chip Transistor RN4983

Q Q Q Q D

871 872 873 931 301

(A,146,69) Transistor (A,161,76) Chip Transistor (A,159,73) Transistor (A,118,104) Transistor (A,100,126) Diode

2SD1767 RN4983 LTC143EUB LSC4081UB CRG03

D D D D D

302 401 402 501 502

(A,96,126) Diode (A,158,106) Diode (A,158,99) Diode (A,29,109) Diode (A,20,124) Diode

CRG03 KP2311E KP2311E RB160L-40 CRG03

D D D D D D D

503 601 602 751 801 802 803

(A,20,122) Diode (A,117,81) Diode(B,C,D,E) (A,127,50) Diode(B,C,D,E) (A,138,134) Diode (A,114,13) Diode (A,117,12) Diode (A,121,12) Diode

CRG03 RB551V-30 RB751S-40 RKZ8.2KG(B2) DZ2S068C DZ2S068C DZ2S068C

D D D D D

804 809 810 811 872


DZ2S068C DZ2S068C DZ2S068C DZ2S068C RKZ7.5KG(B2)

D D D D D

901 902 911 912 931


1SR154-400 1SR154-400 1SR154-400 1SR154-400 HZU7L(A1)

L L L L

401 402 403 404

(A,159,102) Chip Coil LCTAWR15J2520 (A,151,101) Inductor CTF1786 (A,146,102) Inductor CTF1786 (A,155,103) Chip Coil(A) LCTAWR27J2520 (A,155,103) Chip Coil(B,C,D,E) LCTAWR39J2520 (A,142,103) Inductor(A) CTF1389

L 405 L 406

(A,139,101) Inductor(A) LCTAW220J2520 (A,139,101) Chip Coil(B,C,D,E) LCTAW1R5J2520 (A,162,95) Inductor CTF1786 (A,162,94) Inductor CTF1786 (A,137,93) Chip Coil(A) LCTAW470J2520

L 407 L 408 L 409

DEH-14UB/XNUC 1

2

3

4

5

6


7

Part No.

(A,137,93) Inductor(B,C,D,E)


LCTAW2R2J2520

L L L L

415 417 418 420

(A,146,81) Inductor CTF1786 (A,138,107) Chip Coil(B,C,D,E,) LCTAWR39J2520 (A,142,105) Chip Coil(B,C,D,E) LCTAWR27J2520 (A,145,106) Inductor(A) LCYB68NJ1608

L L L L

501 671 801 901

(A,34,109) Coil CTH1475 (A,131,81) Inductor CTF1786 (A,116,15) Inductor CTF1713 (A,112,140) Choke Coil 600 uH CTH1432

X 401 X 601 X 602 > P251 P 401

(A,161,87) Oscillator 36.48 MHz CSS1805 (A,134,59) Ceramic Resonator 16.934 MHz CSS1603 (A,114,49) Oscillator 12 MHz YSS5005 (A,7,128) Fuse 3 A CEK1286 (A,155,108) Surge Protector IMSA-6802-01Y900

CN701 CN801 JA251 JA401 JA892

(A,92,38) Connector VKN1192 (A,109,3) Connector CKS6288 (A,19,137) Pin Jack CKB1056 (A,158,128) Antenna Jack YKS5041 (A,42,138) Connector(B,C,D,E) CKS4124

JA901

(A,113,140) Plug Fuse(10 A)

>

CKM1586 YEK5001

RESISTORS

8

Part No.

R R R R

433 434 501 502

(A,141,90) (A) (A,144,97) (B,C,D,E) (A,22,119) (A,24,117)

RS1/16SS0R0J RS1/16SS0R0J RS1/10SR471J RS1/16SS4702F

R R R R R

503 504 505 506 508

(A,22,117) (A,20,119) (A,27,113) (A,15,114) (A,104,64)

RS1/16SS682J RS1/16SS1002F RS1/16SS183J RS1/16SS513J RS1/16SS103J

R R R R R

601 602 603 604 607

(A,116,83) (A,114,80) (A,115,83) (A,104,76) (A,104,70)

RS1/16SS103J RS1/16SS473J RS1/16SS104J RAB4CQ473J RS1/16SS473J

R R R R R

608 609 610 611 612

(A,104,69) (A,132,66) (A,103,65) (A,139,64) (A,106,76)

RS1/16SS473J RS1/16SS101J RS1/16SS222J RS1/16SS101J RS1/16SS473J

R R R R R

613 615 617 619 620

(A,142,64) (A,103,63) (A,132,62) (A,135,55) (A,105,57)


R R R R R

621 622 623 624 626

(A,131,52) (A,106,50) (A,113,51) (A,108,50) (A,121,51)

RS1/16SS473J RS1/16SS473J RS1/16SS152J RS1/16SS473J RS1/16SS5601F

R R R R R

201 231 232 251 252

(A,100,59) (A,147,56) (A,148,56) (A,19,130) (A,29,131)

RAB4CQ102J RS1/16SS821J RS1/16SS821J RS1/16SS821J RS1/16SS821J

R R R R R

255 256 303 304 331

(A,21,130) (A,26,130) (A,86,122) (A,86,125) (A,74,125)


R R R R R R

628 629 630 631 632 633

(A,127,51) (A,106,54) (A,125,50) (B,C,D,E) (A,125,52) (A,121,43) (A,117,43)

RS1/16SS103J RS1/16SS102J RS1/16SS473J RS1/16SS473J RS1/16SS103J RS1/16SS101J

R R R R R

332 333 334 351 352

(A,81,125) (A,75,125) (A,80,125) (A,91,127) (A,90,127)


R R R R R

636 642 651 671 672

(A,109,51) (A,92,53) (A,101,53) (A,131,86) (A,126,91)

RS1/16SS473J RS1/16SS473J RS1/16SS104J RS1/10SR473J RS1/10SR473J

R R R R

353 401 402 403

(A,91,128) (A,161,106) (A,161,99) (A,139,103) (A) (A,139,103) (B,C,D,E) (A,142,99)

RS1/16SS221J RS1/16SS221J RS1/16SS751J RS1/16SS152J RS1/16SS331J RS1/16SS105J

R R R R R

701 702 703 704 707

(A,97,43) (A,97,37) (A,99,41) (A,97,47) (A,97,44)


RS1/16SS471J RS1/16SS361J RS1/16SS330J RS1/16SS681J RS1/16SS391J RS1/4SA8R2J RS1/4SA8R2J

R R R R R

708 709 710 711 712

(A,97,42) (A,97,41) (A,97,40) (A,97,39) (A,97,38)


R 410 R 412

(A,137,96) (A,137,96) (A,139,95) (A,138,91) (A,138,91) (A,136,79) (A,137,84)

R R R R R

(A,145,107) (A,139,70) (A,141,70) (A,153,79) (A,142,84)

RS1/16SS105J RS1/16SS103J RS1/16SS103J RS1/16SS0R0J RS1/16SS102J

R R R R R

713 714 715 716 717

(A,97,35) (A,97,34) (A,97,33) (A,96,31) (A,97,32)


(A,139,86) (A,137,104) (A)

RS1/16SS0R0J RS1/16SS0R0J

R R R R R

751 752 753 801 802

(A,97,45) (A,99,45) (A,143,133) (A,121,18) (A,124,18)

RS1/16SS473J RS1/16SS103J RS1/10SR821J RS1/10SR101J RS1/10SR101J

R 405 R 406 R 407 R 408

413 419 420 421 427

R 428 R 431

(A) (B,C,D,E) (A) (B,C,D,E)

DEH-14UB/XNUC 5

6

7

8

A

B

C

D

E

F

57

1


A

B

C

2

3

Part No.

R R R R R

803 804 805 806 807

(A,102,18) (A,109,14) (A,117,18) (A,118,18) (A,125,18)

RS1/10SR222J RS1/10SR222J RS1/10SR8R2J RS1/10SR8R2J RS1/10SR222J

R R R R R

808 809 810 814 815

(A,100,18) (A,104,18) (A,99,19) (A,105,11) (A,123,18)

RS1/10SR222J RS1/16SS822J RS1/10SR222J RS1/10SR0R0J RS1/10SR101J

R R R R R

816 817 818 851 871

(A,124,16) (A,121,16) (A,127,18) (A,96,16) (A,151,65)

RS1/16SS223J RS1/16SS223J RS1/10SR222J RS1/16SS472J RS1/10SR222J

R R R R R R R

873 876 879 880 884 891 892

(A,163,72) (A,124,40) (A,155,73) (A,154,72) (A,122,28) (A,54,133) (B,C,D,E) (A,58,136) (B,C,D,E)

RS1/4SA151J RS1/16SS0R0J RS1/10SR473J RS1/10SR181J RS1/16SS1R0J RS1/10SR102J RS1/10SR102J

R R R R R

911 912 931 932 933

(A,140,40) (A,144,41) (A,121,105) (A,118,106) (A,115,106)

R 934

(A,115,113)

E

F

307 308 309 310 311

(A,76,131) (A,79,131) (A,135,134) (A,83,128) 2.2 uF (A,82,131) 2.2 uF

CKSRYB474K10 CKSRYB474K10 CKSRYB104K16 CCG1205 CCG1205

C C C C C

312 313 351 401 402

(A,98,127) (A,67,128) (A,93,127) 10 uF (A,155,106) (A,158,104)

CKSRYB104K16 CEVW100M16 CCG1192 CCSSCH330J50 CCSSCH6R0D50

C C C C C C

403 404 405 406 407 408

(A,161,104) (A,150,100) (A,147,99) (A,160,101) (A,148,100) (A,141,107) (B,C,D,E)

CKSSYB103K16 CKSSYB104K10 CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CCSSCH150J50

C C C C C

409 410 411 412 413

(A,162,101) (A,148,98) (A,145,100) (A,144,100) 10 uF (A,155,101)

CKSSYB103K16 CKSSYB103K16 CKSSYB103K16 CCG1192 CKSSYB103K16

RS1/10SR1R0J RS1/10SR1R0J RS1/16SS223J RS1/16SS473J RS1/16SS472J

C C C C C

414 415 416 417 418

(A,152,102) (A,141,99) (A,159,96) (A,160,95) (A,139,98) 10 uF

CKSRYB105K10 CKSSYB103K16 CKSRYB224K16 CKSSYB104K10 CCG1192

RS1/4SA102J

C 419 C 420 C 421 C 422 C 423

(A,158,93) (A,139,96) (A,137,95) (A) (A,137,95) (B,C,D,E) (A,140,92) (A,136,95)

CKSRYB105K10 CKSSYB104K10 CCSSCH101J50 CCSSCH220J50 CKSSYB104K10 CKSSYB103K16

C 428

(A,162,91) (A,162,92) (A,158,90) (A,138,90) (A) (A,138,90) (B,C,D,E) (A,161,89)

CKSSYB472K25 CKSSYB472K25 CKSSYB104K10 CCSSCH820J50 CCSSCK2R0C50 CCSSCH9R0D50

C C C C

429 430 431 432

(A,161,84) CCSSCH9R0D50 (A,139,85) (A) CKSRYB474K10 (A,158,84) (A) CKSSYB104K10 (A,157,82) 2.2 uF(B,C,D,E) CCG1205

C C C C

433 437 439 440

(A,140,83) (B,C,D,E) (A,156,81) (A,145,79) (B,C,D,E) (A,147,82)

CKSSYB104K10 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10

C C C C C C C

441 443 444 445 447 452 455

(A,152,81) 2.2 uF (A,145,104) (B,C,D,E) (A,139,104) (B,C,D,E) (A,142,101) (A,142,85) (A,134,90) (A) (A,137,88) (A)

CCG1205 CKSSYB103K16 CCSSCH8R0D50 CKSSYB223K16 CKSSYB102K50 CKSSYB105K6R3 CCSSCH100D50

C C C C C

457 458 503 505 506

(A,139,89) (A) (A,148,107) (A) (A,32,119) (A,11,119) Capacitor (A,27,114)

CKSSYB105K6R3 CCSSCJ3R0C50 CEVQW221M6R3 CEVW221M16 CKSSYB153K16

(A,26,114) (A,24,109)

CCSSCH220J50 CKSRYB105K16

C C C C C

201 202 203 204 205

(A,106,108) 10 uF (A,100,105) (A,103,108) 4.7 uF (A,100,106) (A,93,105)

CCG1192 CCSSCH100D50 CCG1201 CCSSCH100D50 CKSRYB105K10

C C C C C

206 207 208 209 210

(A,93,118) (A,97,106) (A,97,118) (A,99,106) (A,99,118)

CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10 CKSRYB105K10

C C C C C

211 212 215 232 233

(A,94,104) (A,95,118) (A,102,107) (A,144,52) (A,149,54) 10 uF

CKSRYB105K10 CKSRYB105K10 CCSSCH100D50 CKSSYB103K16 CCG1192

C C C C C

234 237 238 239 251

(A,146,63) 10 uF (A,148,60) (A,150,61) (A,147,58) (A,31,129) 4.7 uF

CCG1192 CCSRCH182J50 CCSRCH182J50 CKSSYB102K50 CCG1201

C C C C C

252 255 256 259 301

(A,35,130) 4.7 uF (A,20,130) (A,28,130) (A,33,135) (A,74,128)

CCG1201 CCSSCH101J50 CCSSCH101J50 CKSSYB102K50 CKSRYB474K10

C C C C C

302 303 304 305 306

(A,81,128) (A,76,128) (A,79,128) (A,74,131) (A,81,131)

CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10 CKSRYB474K10

58

Part No.

C C C C C

CAPACITORS

D

4


C C C C

424 425 426 427

C 508 C 509

DEH-14UB/XNUC 1

2

3

4

5

6

Circuit Symbol and No. C 510 C 512 C 601

(A,40,121) (A,113,29) (A,121,78)

CKSRYB105K10 CKSRYB105K10 CKSSYB104K10

C C C C C

602 603 604 605 606

(A,118,78) (A,114,78) (A,106,73) (A,131,72) (A,104,72)

CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

607 608 609 610 612

(A,132,71) (A,106,67) (A,132,67) (A,105,66) (A,136,66)


C C C C C

616 617 618 619 620

(A,105,62) (A,133,63) (A,104,60) (A,132,61) (A,138,58)

CKSSYB104K10 CCSSCH100D50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

621 622 623 624 625

(A,106,57) (A,130,52) (A,124,51) (A,123,50) (A,122,51)


C C C C C

626 627 628 629 630

(A,120,51) (A,118,51) (A,114,51) (A,108,52) (A,128,52)


C C C C C

632 633 638 651 671

(A,115,47) (A,113,47) (A,122,43) (A,105,53) (A,131,83)

CCSSCH120J50 CCSSCH120J50 CKSRYB105K10 CKSRYB105K10 CKSSYB104K10

C C C C C

701 751 754 808 809

(A,100,41) (A,147,131) 10 uF (A,141,135) (A,113,18) (A,125,9)

CKSSYB103K16 CCG1192 CKSSYB104K10 CKSRYB104K16 CKSRYB104K16

C C C C C

810 811 812 817 818

(A,100,15) (A,98,13) (A,123,12) (A,108,17) (A,124,6)

CCSRCH221J50 CCSRCH221J50 CKSRYB105K16 CKSSYB104K10 CKSRYB104K16

C C C C C C C

871 872 891 892 901 913 914

(A,158,75) (A,153,66) (A,34,139) (B,C,D,E) (A,50,138) (B,C,D,E) (A,133,124) 3 300 uF/16 V (A,141,40) (A,141,42) 4.7 uF

CKSSYB104K16 CKSRYB105K16 CKSRYB104K16 CKSRYB104K16 CCH1732 CKSSYB102K50 CCG1201

C C C C C

916 917 918 919 920

(A,150,41) (A,138,40) (A,153,42) (A,144,39) (A,147,42)

CCG1201 CCG1201 CCG1201 CKSSYB102K50 CCG1201

C 921 C 922 C 923 C 926 C 931

4.7 uF 4.7 uF 4.7 uF 4.7 uF

7

Part No.

(A,133,39) CKSRYB104K16 (A,157,54) (A) CEAT102M16 (A,157,54) 1 000 uF/16 V(B,C,D,E)CCH2024 (A,154,40) CKSSYB102K50 (A,133,41) CKSRYB102K50 (A,114,105) CKSRYB104K16 6

Part No.

B Unit Number : (A,B,C,E) Unit Name

A

: (D) : Keyboard Unit

MISCELLANEOUS IC 1801 IC 1802 D 1851 D 1852 D 1853

(B,85,23) IC (A,B,C,D,E) (A,159,36) Remote IC (A,16,30) LED(D) (A,53,30) LED(D) (A,16,20) LED(D)

PD6581A GP1UXC14RK SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)

D D D D D

1854 1855 1856 1857 1858

(A,6,41) LED(D) (A,55,20) LED(D) (A,62,5) LED(D) (A,7,19) LED(D) (A,16,10) LED(D)

SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)

D D D D D

1859 1860 1861 1862 1863

(A,52,10) LED(D) (A,74,5) LED(D) (A,87,5) LED(D) (A,100,5) LED(D) (A,113,5) LED(D)

SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL) SML-D12P8W(KL)

D D D D D

1864 1865 1866 1871 1872

(A,125,5) (A,138,5) (A,63,21) (A,14,30) (A,54,31)

D D D D D

1873 1874 1875 1876 1877

(A,52,20) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,19,20) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,9,41) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,8,19) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,14,10) LED(Red) (A,B,C,E) SML-D12V8W(PQ)

D D D D D

1878 1879 1880 1881 1882

(A,51,10) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,63,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,76,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,89,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,101,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ)

D D D X S

1883 1884 1885 1801 1842

(A,114,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,126,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (A,139,5) LED(Red) (A,B,C,E) SML-D12V8W(PQ) (B,74,22) Ceramic Resonator 5.00 MHz CSS1547 (A,36,20)Encoder(ROTARY COMMANDER) CSD1168

CN1821 CN1911 JA1921 V 1801

B

C

LED(D) SML-D12P8W(KL) LED(D) SML-D12P8W(KL) White LED SMLXA4WBETW1(Z1) LED(Red) (A,B,C,E) SML-D12V8W(PQ) LED(Red) (A,B,C,E) SML-D12V8W(PQ)

(B,108,9) Connector (A,154,22) Connector (A,153,7) Jack (A,138,32) Segment LCD

CKS6287 CKS6267 CKN1090 CAW2018

D

E

RESISTORS R R R R R

1801 1802 1803 1822 1823

(B,73,19) (B,73,17) (B,144,29) (B,54,24) (B,131,19)

RS1/10SR222J RS1/10SR222J RS1/10SR101J RS1/10SR273J RS1/10SR0R0J

R R R R

1824 1851 1852 1853

(B,69,26) (B,18,27) (D) (B,18,22) (D) (B,48,16) (D)

RS1/10SR0R0J RS1/4SA681J RS1/4SA681J RS1/4SA681J

DEH-14UB/XNUC 5

8


7

8

F

59

1

2


A

B

3

Part No.

(B,17,16) (D)

RS1/4SA561J

R 264

(A,22,9)

RS1/16SS102J

R R R R R

1856 1857 1858 1859 1860

(B,48,12) (D) (B,56,10) (D) (B,140,18) (D) (B,57,16) (B,55,16)

RS1/4SA681J RS1/4SA681J RS1/4SA681J RS1/4SA221J RS1/4SA221J

R R R R R

281 282 283 291 292

(B,33,38) (B,33,39) (B,35,38) (B,33,34) (B,33,36)

RS1/16SS560J RS1/16SS560J RS1/16SS0R0J RS1/16SS560J RS1/16SS0R0J

R R R R R

1871 1872 1873 1874 1875

(B,14,26) (B,51,16) (B,17,20) (B,61,10) (B,52,10)

RS1/4SA681J RS1/4SA821J RS1/4SA561J RS1/4SA821J RS1/4SA102J

R R R R R

293 294 296 301 302

(B,35,39) (B,27,48) (B,34,43) (A,27,9) (A,28,9)

RS1/16SS0R0J RS1/16SS471J RS1/16SS0R0J RS1/16SS0R0J RS1/16SS0R0J

R R R R

1876 1889 1894 1895

(B,142,18) (A,B,C,E) (B,23,9) (D) (B,65,16) (D) (B,69,17) (A,B,C,E)

RS1/4SA102J RS1/10SR0R0J RS1/10SR0R0J RS1/10SR0R0J

R R R R R

303 304 305 306 307

(A,27,11) (A,28,11) (A,26,9) (A,26,11) (A,25,9)


R R R R R

308 309 310 311 312

(A,25,11) (A,35,6) (B,30,9) (B,30,10) (B,30,11)


R R R R R

313 701 702 706 708

(B,30,12) (A,21,38) (A,23,38) (A,32,42) (B,28,26)

RS1/16SS472J RS1/16SS101J RS1/16SS101J RS1/16SS221J RS1/16SS0R0J

R 709

(B,29,28)

RS1/16SS0R0J

C C C C

1801 1802 1911 1912

(A,B,C,E) (A,B,C,E) (A,B,C,E) (A,B,C,E) (A,B,C,E)

(B,147,32) 10 uF (B,95,23) (B,147,20) (B,130,27)

CCG1192 CKSRYB105K10 CKSRYB104K16 CKSRYB104K16

C Unit Number : CWX4023 Unit Name

: CD Core Unit (S11.6STD)

MISCELLANEOUS

D

CAPACITORS

IC 201 IC 301 Q 101 Q 102 X 201

(B,23,37) (A,37,11) (B,11,53) (B,15,54) (B,25,49)

IC PE5791A IC BD8223EFV Transistor 2SA1577 Chip Digital Transistor LTA123JUB Ceramic Resonator 16.934 MHzCSS1603

C C C C C

104 203 209 210 211

(B,12,57) (B,22,47) (B,28,47) (B,33,43) (B,33,41)

CKSQYB475K6R3 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10 CKSSYB104K10

S 901 S 903 CN101 CN701

(A,42,53) (B,21,12) (A,16,58) (A,25,29)

Spring Switch(HOME) CSN1080 Spring Switch(DSCSNS) CSN1081 Connector CKS4808 Connector CKS6146

C C C C C

212 213 214 215 216

(B,22,28) (B,18,26) (B,17,26) (B,19,28) (B,12,33)


C C C C C

217 218 219 220 221

(B,10,34) (B,10,36) (B,14,34) (A,18,38) (B,14,32)

CCSSCH560J50 CCSSCH4R0C50 CKSSYB104K10 CKSSYB104K10 CKSSYB104K10

C C C C C

222 223 224 225 228

(B,13,37) (B,12,42) (B,13,45) (B,13,46) (B,10,33)

CKSSYB104K10 CCSSCH680J50 CCSSCH470J50 CKSSYB103K16 CCSSCH270J50

C C C C C

229 233 236 238 299

(B,9,40) (B,32,46) (B,8,40) (A,25,44) (A,26,41)

CKSSYB104K10 CKSSYB103K16 CKSSYB104K10 CKSRYB104K16 CKSSYB104K10

C C C C C

302 303 304 305 306

(B,28,12) (B,29,12) (B,27,12) (B,26,12) (A,31,7)


RESISTORS

E

F

Part No.

R 1854

CAPACITORS

C

4


R R R R R

101 102 103 108 109

(B,6,57) (B,8,57) (B,9,57) (B,18,55) (B,12,50)

RS1/10SR2R4J RS1/10SR2R4J RS1/10SR2R7J RS1/16SS105J RS1/16SS222J

R R R R R

201 202 214 215 216

(A,24,11) (A,23,9) (B,18,28) (B,17,28) (B,12,35)

RS1/16SS0R0J RS1/16SS0R0J RS1/16SS103J RS1/16SS393J RS1/16SS122J

R R R R R

217 218 229 232 237

(B,10,32) (B,10,35) (B,12,34) (A,31,54) (B,33,45)

RS1/16SS562J RS1/16SS472J RS1/16SS471J RS1/16SS0R0J RS1/16SS221J

R R R R

240 245 254 260

(B,34,40) (A,34,46) (A,37,56) (B,30,27)

RS1/16SS473J RS1/16SS104J RS1/16SS104J RS1/16SS103J

60

DEH-14UB/XNUC 1

2

3

4

5

Circuit Symbol and No. C 307 C 308 C 710

(A,41,19) (A,31,15) (A,34,42)

6

7

8

Part No. CKSRYB105K10 CKSRYB105K10 CKSSYB102K50

A

Miscellaneous Parts List M 1 M 2

Pickup Unit(P10.6)(Service) CXX3556 Motor Unit(SPINDLE) CXE2273 Motor Unit(LOADING/CARRIAGE) CXC4026

B

C

D

E

F

DEH-14UB/XNUC 5

6

7

8

61

Pioneer Deh 1450ub

Recommend Documents