Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Sign up to vote on this title
Useful
Not useful
Translation of the original operating
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Contents
CONTENTS 1
Foreword........................................................ Foreword ........................................................ 4
5.2
Compressed air connection...... connection............ ......
5.3
Cooling water connection................... connection...................
5.4
Electrical connection........................... connection...........................
1.1
About these operating operating instructions instructions............4
1.2
Notes.........................................................5 Notes.........................................................5
1.3
Intended use............................................. use............................................. 5
6.1
Initial commissioning commissioning........................... ...........................
1.4
Intentional Intentional misuse..................................... misuse..................................... 6
6.1.1
1.5
Service...................................................... Service...................................................... 6
Cooling water control in a water-coole compressor system............................. system.............................
1.6
Nameplate.................................................7 Nameplate .................................................7
6.2
Normal operation................................ operation................................
6.3
Routine commissioning....................... commissioning.......................
6.4
Commissioning after a long shutdown............................................ shutdown ............................................
6.5
Commissioning after a fault...... fault ............ ......
2
Safety conditions.......................................... conditions .......................................... 8
2.1
General safety instructions...... instructions............ ............ ........... ..... 8
2.2
Instructions about particular types of danger ....................................................... ....................................................... 8
2.3
Protection and safety equipment...... equipment ............ ........ .. 9
2.4
Residual hazards.................................... hazards.................................... 10
2.5
Identification of safety instructions...... instructions.......... .... 10
2.6
Safety sign.............................................. sign.............................................. 10
2.7
Transport and positioning..... positioning ........... ............ ............ ...... 14
2.8
Normal operation.................................... operation.................................... 14
2.9 2.10
3
6
Commissioning and operating...... operating ............ ......
7
Troubleshooting ......................................
8
Maintenance and Service....................... Service .......................
8.1
General information...... information............ ............ ............ ......
8.2
Service................................................ Service................................................
8.3
Inspection of protection and safety equipment........................................... equipment ...........................................
Special tasks...........................................14 tasks...........................................14
8.4
Routine maintenance.......................... maintenance..........................
Conversions and changes to the machine...................................................15 machine ...................................................15
8.5
Maintenance plan............................... plan ...............................
8.6
Maintenance work............................... work...............................
Design and function................................... function ................................... 16
8.6.1 Accesses............................................ Accesses............................................ 8.6.2
Filter mat cooling air inlet................... inlet ....................
8.6.3
Inlet filter cooling air switch cabinet (R compressors )..................................... ).....................................
System scheme air-cooled compressor ..............................................21 ..............................................21
8.6.4
Condensate drain............................... drain...............................
3.4
System scheme water-cooled compressor ..............................................23 ..............................................23
8.6.5
Lubricating oil..................................... oil.....................................
8.6.6
3.5
Air circuit................................................. circuit................................................. 25
8.6.7
3.6
External water circuit...... circuit............ ............ ............ ............ ...... 27
8.6.8 8.6.8
........... Ejector vent system..... system........... ............ ............ ..... Sign up to vote on this title Cooling system................................... system................................... Useful Not useful ............ ................. ........... ............ ............ ............ ............ ............ ............ ......
3.7
Internal water circuit................................28 circuit................................28
8.6.9 Air Filter .............................................. ..............................................
3.1
General description.................................16 description.................................16
3.2
Compressor design.................................17 design.................................17
3.3
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Contents
CONTENTS 1
Foreword........................................................ Foreword ........................................................ 4
5.2
Compressed air connection...... connection............ ......
5.3
Cooling water connection................... connection...................
5.4
Electrical connection........................... connection...........................
1.1
About these operating operating instructions instructions............4
1.2
Notes.........................................................5 Notes.........................................................5
1.3
Intended use............................................. use............................................. 5
6.1
Initial commissioning commissioning........................... ...........................
1.4
Intentional Intentional misuse..................................... misuse..................................... 6
6.1.1
1.5
Service...................................................... Service...................................................... 6
Cooling water control in a water-coole compressor system............................. system.............................
1.6
Nameplate.................................................7 Nameplate .................................................7
6.2
Normal operation................................ operation................................
6.3
Routine commissioning....................... commissioning.......................
6.4
Commissioning after a long shutdown............................................ shutdown ............................................
6.5
Commissioning after a fault...... fault ............ ......
2
Safety conditions.......................................... conditions .......................................... 8
2.1
General safety instructions...... instructions............ ............ ........... ..... 8
2.2
Instructions about particular types of danger ....................................................... ....................................................... 8
2.3
Protection and safety equipment...... equipment ............ ........ .. 9
2.4
Residual hazards.................................... hazards.................................... 10
2.5
Identification of safety instructions...... instructions.......... .... 10
2.6
Safety sign.............................................. sign.............................................. 10
2.7
Transport and positioning..... positioning ........... ............ ............ ...... 14
2.8
Normal operation.................................... operation.................................... 14
2.9 2.10
3
6
Commissioning and operating...... operating ............ ......
7
Troubleshooting ......................................
8
Maintenance and Service....................... Service .......................
8.1
General information...... information............ ............ ............ ......
8.2
Service................................................ Service................................................
8.3
Inspection of protection and safety equipment........................................... equipment ...........................................
Special tasks...........................................14 tasks...........................................14
8.4
Routine maintenance.......................... maintenance..........................
Conversions and changes to the machine...................................................15 machine ...................................................15
8.5
Maintenance plan............................... plan ...............................
8.6
Maintenance work............................... work...............................
Design and function................................... function ................................... 16
8.6.1 Accesses............................................ Accesses............................................ 8.6.2
Filter mat cooling air inlet................... inlet ....................
8.6.3
Inlet filter cooling air switch cabinet (R compressors )..................................... ).....................................
System scheme air-cooled compressor ..............................................21 ..............................................21
8.6.4
Condensate drain............................... drain...............................
3.4
System scheme water-cooled compressor ..............................................23 ..............................................23
8.6.5
Lubricating oil..................................... oil.....................................
8.6.6
3.5
Air circuit................................................. circuit................................................. 25
8.6.7
3.6
External water circuit...... circuit............ ............ ............ ............ ...... 27
8.6.8 8.6.8
........... Ejector vent system..... system........... ............ ............ ..... Sign up to vote on this title Cooling system................................... system................................... Useful Not useful ............ ................. ........... ............ ............ ............ ............ ............ ............ ......
3.7
Internal water circuit................................28 circuit................................28
8.6.9 Air Filter .............................................. ..............................................
3.1
General description.................................16 description.................................16
3.2
Compressor design.................................17 design.................................17
3.3
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Conten 9.6.1
D75 + D90, 50Hz, air-cooled "A" and water-cooled "W" (European version)... version) ..... .. 70
9.6.2
D110 + D132, 50Hz, air-cooled "A" and water-cooled "W" (European version)... version) ..... .. 71
9.6.3
D160, 50Hz, air-cooled "A" and watercooled "W" (European version)...............72 version) ...............72
9.6.4
D110 RS, 50Hz, air-cooled "A" and watercooled "W" (European version)...............73 version) ...............73
9.6.5
D132 RS, 50Hz, air-cooled "A" and watercooled "W" (European version)...............75 version) ...............75
9.6.6
D160 RS, 50Hz, air-cooled "A" and watercooled "W" (European version)...............76 version) ...............76
9.6.7
D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (European version)... version) ..... .. 78
9.6.8
D110 + D132, 60Hz, air-cooled "A" and water-cooled "W" (European version)... version) ..... .. 79
9.6.9
D160, 60Hz, air-cooled "A" and watercooled "W" (European version)...............80 version) ...............80
9.6.10 D110 RS, 60Hz, air-cooled "A" and watercooled "W" (European version)...............81 version) ...............81 9.6.11 D132 RS, 60Hz, air-cooled "A" and watercooled "W" (European version)...............83 version) ...............83 9.6.12 D160 RS, 60Hz, air-cooled "A" and watercooled "W" (European version)...............84 version) ...............84 9.6.13 D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (USA version)..... version)........... ........ .. 86 9.6.14 D110 + D132, 60Hz, air-cooled "A" and water-cooled "W" (USA version)..... version)........... ........ .. 87 9.6.15 D160, 60Hz, air-cooled "A" and watercooled "W" (USA version)....................... version)....................... 88 9.6.16 D110 RS, 60Hz, air-cooled "A" and watercooled "W" (USA version)....................... version)....................... 89 9.6.17 D132 RS, 60Hz, air-cooled "A" and watercooled "W" (USA version)....................... version)....................... 91 9.6.18 D160 RS, 60Hz, air-cooled "A" and watercooled "W" (USA version)....................... version)....................... 92 9.7
Installation plan....................................... plan....................................... 94
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
1
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Foreword
1
FOREWORD
Gardner Denver screw compressors are the product of years of research and development. This experience in conjunction with high quality requirements ensures that the manufactured screw compressors are long-lasting, providing guaranteed reliability and economic operation. Equally, the stringent requirements for environmental protection are also met.
1.1
These operating instructions apply for the following compressors from Gardner Denver Deutschland GmbH: D75-10A V2 D90-8A V2 D90-10A V2 D110-8A V2 D110RS-8A V2 D110-10A V2 D110RS-10A V2 D132-8A V2 D132RS-8A V2 D132-10A V2 D132RS-10A V2 D160-10A V2 D160RS-10A V2 D75-8W V2 D75-10W V2 D90-8W V2 D90-10W V2
The basis of these operating instructions are t master operating instructions ZS1101886 /02, which are relevant for translations of the opera instructions.
These operating instructions are an inherent p of the compressor. They must be available an cessible near the compressor at all times.
These operating instructions provide you with the information you need for safe operation an maintenance of the compressor. This includes
About these operating instructions
D75-8A V2
These operating instructions are written for ing- and maintenance personnel.
Installation and connection of the compres
Commissioning and operation of the comp sor
Replacement of wear parts and consumab such as filters or oil
Identification of faults and rectification of m functions
Carrying out of visual inspections for dama on a rotational basis
Cleaning, maintenance and repair of the co pressor
You're Reading a Preview
The dealer's or manufacturer's workshop, with
Unlock full accessqualified with a freeand trial.experienced personnel, is respo
sible for all maintenance work that goes beyon customary service work and requires specialis Download With Free Trial technical knowledge.
All pressures given in these operating instruct are, where not otherwise specified, positive pr sures (gauge pressures). Target groups
The target groups for these operating instruct Sign up to vote on this title are operators, maintenance personnel and ele cians. Useful Not useful
After training, the operator is permitted to sta and shut down the compressor and activate th
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Fore
1.2
Notes
General information The operating instructions must be read and used by every person who is assigned to work with and on the compressor. Irrespective of these operating instructions, the laws, regulations, directives and standards applicable in the place of use must be observed. Training The provision of local operator training is undertaken by authorised service technicians. The training documentation comprises these operating instructions and the repair manual, which is only issued as part of service training. These measures ensure that the assigned work can be reliably carried out. Warranty Gardner Denver Deutschland GmbH will not be held liable for the safe functioning of the compressor if it used other than for its normal use or for purposes not listed in the operating instructions.
Copyright
These operating instructions are subject to right and may only be used for the agreed pose, i.e. as a reference for in-plant purpos
Forwarding or reproduction of this docume ploitation and sharing of its content are forb den, insofar as this is not expressly author Infringements will incur payment of compe tion. All rights reserved for the case of gran a patent, petty-patent or design registration Reselling
If the compressor is resold, these operatin structions must be handed over to the new ator together with the compressor. If neces the operating instructions must be reordere Gardner Denver by specification of the ord firmation number. The compressor must no any circumstances be resold without these ing instructions.
1.3
Intended use
The compressor conforms to the state of th and the applicable safety conditions at the its bringing to market provided it is used fo Gardner Denver Deutschland GmbH excludes all Preview purpose. warranty and liability in the event of: You're Reading atended From a design point of view, neither intenti Operating errors. Unlock full access with a free trial. misuse nor all of the residual dangers can Use of the compressor for other than the inavoided, without limiting the intended funct tended purpose. Download With Free Trial The compressor is designed for the compr Damage resulting from deliberate misuse or of atmospheric oil-free air (compressed air non-observance of the operating instructions. ving pressure equipment) the compressor suitable for the compression of other gases Damage or injuries caused by non-OEM components. The compressor is only classed as being u Use of spare or wear parts or operating fluids its intended purpose if the following points that do not originate from or are not currently observed: recommended by or have not been previously Sign up to vote on this title The compressor is used according to th recommended by Gardner Denver Deutschland Useful Not useful erating instructions. GmbH. The working steps and standard operat Inadequate maintenance. cedures of the operator are followed.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
1
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Foreword Is not operated by trained personnel.
Manipulation of sensor signals.
Is changed or modified.
Signal modification of sensors.
The safety instructions are not observed.
Operation without protection and safety eq ment.
Alongside these operating instructions, the following apply: Relevant accident prevention regulation Generally recognised safety rules Country-specific conditions
Operation with defective, deactivated or m nipulated protection and safety equipment safety valves, or operation with other such safety relevant defects.
Use by private users or users without tech training.
Installation location / installation altitude
Operation outside industrial environmen
The compressor is intended for installation in a suitable compressor room. The compressor is not suitable for open-air installation!
Non-adherence to maintenance intervals.
The permissible installation altitude of the compressor is limited dependent on the operating pressure, ambient humidity and ambient temperature at which it is operated. The permissible installation altitude is specified for each individual case by consultation between the customer and Gardner Denver. Working environment
Omission of maintenance and repair work.
Incorrect execution of maintenance and re work. Limitations on use Operation of the compressor is not permitted
outside the permissible ambient temperatu
above the permitted altitude of the installat location.
The illumination in the region of the compressor on an insufficiently load-bearing substrate. You're Reading a Preview must be ≥ 200 lx during normal operation. in areas with an explosive atmosphere. The illumination for inspection and repairUnlock work full access with a free trial. must be ≥ 500 lx. 1.5 Service
Ambient temperature for operation: see "Technical Download With Free Trial If you have any questions about or problems w data". the compressor please contact your responsib Gardner Denver agency. Pressure equipment The trained specialised personnel will ensure For pressure equipment/systems a pressure rereceive quick and proper assistance. lief device (safety valve or similar) dimensioned to match the weakest pressure carrying component In case of queries and conforming to the relevant regulations must spare p If you have a up query or wish totitle make a be installed in the compressed air system. Sign to vote on this order, please specify the identification numb Not useful Useful year of manufacture on the name plate. Speci 1.4 Intentional misuse cation of this data will ensure that you receive Incorrect use and misuse correct information and/or spare parts.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Fore Name: Gardner Denver , Inc Quincy, Illinois
Contact: Address:
Model 1
Phone
Serial Number 2
Type
3 Machine
Fax
4
Version
COMPRESSOR
5
Weight
Email: Chart 1-1: Local Gardner Denver agency
1.6
kg
6
Nameplate
Made in Germany
Airend
7
8
Order Mumber
9
Compression Medium
10
/
V
Voltage / Phase / Frequency Flow
11 12
Stage Pressure
13
Suction Pressure
14
Full Load Current
15
Speed
16
Installed Motor Capacity
17
You're Reading a Preview Fig. 1-2:trial. Nameplate Unlock full access with a free
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
1
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
2
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety conditions
2
SAFETY CONDITIONS
Any person who is involved with the operation, maintenance or repair of the compressor, must read and follow the safety conditions.
The operating instructions must be supplemented with instructions for the observatio operating peculiarities including monitoring reporting obligations, e.g. in respect of wor organisation, working processes, responsi ties, etc.
Gardner Denver Deutschland GmbH accepts no responsibility for material damage or injuries that arise from non-observation of safety conditions or the failure to observe normal levels of care and attention, even where this is not expressly stated in these operating instructions.
Personnel selection and qualification; fund mental responsibilities
2.1
The authorised personnel must:
General safety instructions
Organisational measures
Only reliable and authorised personnel may w on the compressor.
be trained by Gardner Denver.
The following organisational measures contribute to the safe use of the compressor:
be trained according to its responsibilities, ties and activities and instructed about the compressor.
Only appointed personnel may work on the compressor. The personnel have been trained and briefed about the compressor.
have the physical and mental capabilities t fulfil its responsibilities and carry out its and activities on the compressor.
Before starting work, the personnel must have have understood the operating instructions read the operating instructions, in particular the respect of its responsibilities, duties and ac "Safety Conditions" chapter. Don’t leave this ities on the compressor and be able to pra until you start work – it’s too late. This applies cally implement this. in particular to personnel who only work on the machine occasionally, e.g. to carry out mainte2.2a Preview Instructions about particu You're Reading nance.
types of danger
Unlock full access with a free trial. The responsibilities of the personnel for operElectrical energy ation, maintenance and repair must be clearly defined. Download With Free Trial
The safe and hazard-aware working of the personnel must be checked regularly.
Personnel who are to be trained in, taught about or instructed as part of a general training course, must only work on the compressor under the constant supervision of an authorised person. If safety-relevant changes are made to compressor or arise in its operating behaviour, the compressor must be immediately shutdown and the fault reported to the responsible post/
DANGER
Electric shock Life-threatening electric shock
When carrying out any work on electrical equipment, exercise extreme care. Sign up to vote on this title starting the maintenance ➯ Before work, switch compressor to a useful Useful Notthe voltage-free state and secure to p vent switching back on. ➯
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety cond Only for RS compressors: Due to the residual voltage on the capacitors, a waiting time of at least 10 minutes must elapse after switching to a zero volts state (main switch OFF) before the switch cabinet can be opened. Observe the danger sign on the switch cabinet! See table "Safety signs".
All protective and safety equipment must b tached and checked for trouble-free operat fore every commissioning, in particular afte tenance and repair work.
In addition, the legally prescribed testing fr cies of the country of use must be adhered
NOTE Noise The sound pressure level without the sound-proofing enclosure is 110 dB(A). Remaining for long periods alongside the compressor without its soundproofing enclosure can result in irreversible hearing impairment. Only operate the compressor without the soundproofing enclosure during test runs. Wear ear defenders!
Operation of the compressor is only perm with complete and operational protective a safety equipment. Emergency-stop
The compressor can be rendered safe in d ous situations using the emergency-stop p ton.
The sound pressure level with the sound-proofing enclosure is approximately: see "Technical data". During normal operation the compressor may only be operated with a closed acoustic hood.
Emergency-stop pushbuttons are attached
Oils, fats and other chemical substances
Using emergency-stop
When handling oils, fats and other chemical substances, observe the applicable safety conditions!
1 Press the
pushbutto The compressor is placed in a safe con
on the compressor control panel
optionally in a control room (control cen
Rectify the fault that was the cause of th Exercise caution when using hot operating fluids You're Reading a2Preview Emergency-stop. and additives, there is a risk of burns or scalds! Unlock full access with a free Seetrial. the "Troubleshooting" chapter. Explosive areas 3 Unlock the pushbut Turn the pushbutton anticlockwise. Download With Free Trial
DANGER
Risk of explosion The compressor is not designed for operation in explosive atmospheres. ➯
Operation of the compressor in explosive atmospheres is forbidden!
Legionella formation with water-cooled compressors and an open cooling circuit
WARNING
4 Set the compressor in operation. See section "Commissioning after a fau chapter "Commissioning and operation" Safety valves / non-return valve
The compressor is protected against excee using of the permissible operating pressure Sign up to vote on this title valves. Open the safety valves at 3.5 bar ( Useful Not useful or (2nd airend) 11.4 bar airend).
The compressor is secured by a non-retur on the pressure side against reverse flow f
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
2
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety conditions
2.4
Residual hazards
DANGER WORD
Hot surfaces
Danger (danger sequence)
Some parts of the compressor become very hot in operation (up to 235 °C). A danger warning sign on the compressor enclosure warns of the danger.
Description of the danger (dan source)
Safety sign
Protective measure (danger p vention)
Before starting any maintenance and repair work, the compressor must be sufficiently cooled.
Parts of safety instructions
Personal protective equipment We recommend the wearing of the following personal protective equipment: Safety shoes Safety glasses for all work with compressed air and open enclosure Ear defenders during test runs with an open acoustic hood
2.5
Danger (danger sequence): The danger sequence names the type of hazard.
Description of the danger (danger source) danger source names the cause of the hazard Protective measure (danger prevention) ger prevention describes the measures for batting the hazard.
Danger word: The danger word subdivides th severity of the danger into four steps, graphic highlighted by different colours. The danger w is used in the safety instructions as described low.
Identification of safety instructions
Within the operating instructions, safety instructions are used as special warnings with the following described names and symbols.
DANGER indicates a directly dangerous situa tion which, if not protected against, could resu death or serious (irreversible) injuries.
You're Reading a Preview These special warnings are intended to prevent WARNING indicates a potentially dangerous s danger and are located close to the possible dantion which, if not protected against, could resu Unlock full access with a free trial. ger both in terms of space and time: death or serious (irreversible) injuries. on the system close to the danger source
CAUTION indicates a potentially dangerous s
of actions / activity is described
minor or less serious (reversible) injuries.
Download With Trial tionFree which, if not protected against, could resu in the operating instructions, before a sequence Structure of safety instructions The special warnings in the operating instructions are structured as follows:
2.6
ATTENTION indicates information or recomm dations that directly or indirectly concern the s of persons or system protection.
Safety sign
Sign up to vote on this title The following safety signs (danger signs) may be used in the surroundings of the compressor and in t Useful Not useful operating instructions. Safety sign
Meaning
Use / Behaviour
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety cond Safety sign
Meaning
Use / Behaviour
Pressurised part or system
Identification of devices or rooms in which there is manently or occasionally a significantly higher air sure than in the normal atmosphere.
Do not open the devices or rooms before pressur equalisation has taken place. Never operate the compressor with open doors or loose enclosure panels.
Running the compressor with open doors or loose sure panels is forbidden except during test runs. H sound pressure level, risk of injury! Normal operation only with closed enclosure.
Do not breath in any Use of the compressed air produced by this comp compressed air from this as breathing air is forbidden. Drawn in substance system be harmful to health. Do not use compressed air as breathing air. Electrical voltage
Warning of dangerous, electrical voltage.
Only a qualified electrician following electrotechni ulations may carry out work on the electrical equi of the compressor. System runs on
After pressing of the stop button , the com runs on for 30 seconds.
You're Reading a Preview
Do not open the compressor enclosure before the pressor stationary. Unlock full access with is a free trial.
Observe the instruction Identification of operating instructions where addi Downloadinformation With Free is Trial manual to be found in the operating instruc the manufacturer).
Before the device is operated, the operator (user) must have read and understood the instruction m (manufacturer's usage instructions). Wear ear defenders
Identification of areas with a heightened sound level. Sign up to vote onsuitable this title ear defender Only enter the area wearing
Warning against indus-
Useful
Not useful
Warning of in-plant industrial trucks (e.g. forklifts)
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
2
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety co conditions Safety sign
Meaning
Use / Behaviour
Warning against moving machine parts
During maintenance maintenance work it is necessary to check so functions with an opened enclosure. There is a risk o injury due to rotating or translational movements.
Maintenance work must only be carried out by specia trained personnel.
Warning Warning of hand hand injuries injuries Danger Danger that the hand hands s could be crushe crushed, d, drawn drawn in or otherwise injured. Maintain a safe distance. Warning of automatic start-up
In normal operating mode, the compressor may start automatically automatically at any time. The r eadiness for operatio of the compressor is indicated by the green LED on t control panel. Do not carry out any work on the compressor, if the green LED illuminates.
Warning Warning of of hot surface surfaces s
Parts of the comp compresso ressorr become become very very hot during during ope tion (up to 235 °C). Risk of injury due to hot surfaces Before starting any maintenance and repair work, compressor must be sufficiently cooled.
Warni Warning ng of suffo suffocat cation ion
Risk Risk of suffoc suffocati ation on due due to inade inadequ quate ate vent ventila ilatio tion n and extraction in the compressor room.
The operator must provide adequate ventilation of th compressor room.
Warning of crushing haz- Warning of crushing hazards due to working materia ards (e.g. a machine) or a structural element (e.g. covers, enclosure panels, protection devices, boundary fence
When working on the identified workstations, increas awareness is necessary. Remaining under the load is forbidden
It is not permitted to remain under a suspended load The driver is notSign permitted to drive up to vote on thisthe titleindustrial truc there is a person beneath the load. Moreover, the dri Useful Not useful ver is obliged to check that persons do not stand or w under the load.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety co cond Safety sign
Meaning
Use / Behaviour
Safety valve
Opening pressure of the safety valves (values sticker on the control panel).
Check the connecting terminals and tighten if necessary. For additional additional information see the operating instructions.
Warning against loosened connecting terminals. T clamping pressure can be released after some tim
Electrical voltage
Warning of dangerous, electrical voltage.
Residual voltage of the capacitors
Warning of electrical energy stores in the form tors. These can conduct a life-threatening electric age.
XX bar
Regularly check the terminals according to the sa guidelines and retighten as necessary.
Only open the switch cabinet (RS compressor) 10 utes after switching the compressor off (zero volts
Check the DC bus voltage of the frequency conve the mains connection strip of the frequency conve The precise position of the terminals "DC+" and "D can be taken from the supplied frequency convert operating instructions.
10 min
Only a qualified electrician following electrotechni ulations may carry out work on the electrical equi of the compressor. Spring tension
Warning of te tensioned spring inside the suction
Before opening the suction regulator read the rep manual.
Risk of microbe contami- Warning against legionella contamination of the c nation water if an open cooling circuit is used.
Constant monitoring of the cooling water by the m nance personnel. Sign up to vote on this title Attention: hot hot liquid
Useful Not useful Warning against against hot oil or or hot coolant.
Before opening coolant circuits, allow the compre
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
2
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety co conditions
2.7
Transport an and po positioning
Transport A suitable forklift forklift with forks of adequate adequate length length must be used to transport the compressor. Dependent on type, the compressor weighs up to 3,800 kg. Only insert the forks at the intended load support points. The compressor must not be transported using a crane, even when still in its packaging. packaging. No person may remain in the danger area during transport. In particular, do not encroach into the area under the raised compressor or place your feet beneath it. Positioning / installation location The entire surface of the compressor must be placed on an even suitable substrate. The installation location (compressor room) must be dimensioned so that there is sufficient access to the compressor and the necessary cooling is ensured. No inflammable or explosive materials may be stored in the vicinity of the compressor.
2.8
Normal operation
The compressor may only be operated in a technically fault-free condition for its intended use, with an awareness of safety and hazards while observing the operating instructions. Only operate the compressor if all protective and safety equipment, sound insulation, ventilation and extraction equipment and the cooling water supply (water-cooled compressors compressors only) are present and serviceable. Check regularly that: All hoses and pipelines are are serviceable and firmly attached.
When using compressed air to clean equip ment, proceed with great care and always eye protection. Safety measures
Only operate the compressor with the enclosu closed.
At least once per per shift check the compressor externally visible damage and defects. Immed ately report changes that have occurred (inclu ing in the operating behaviour) to the respons ble post/person. If necessary stop the compre immediately immediately and secure. Immediately Immediately rectify faults.
Do not switch off or remove extraction and ve tion equipment when the compressor is runnin Remote control
If a remote control is available, a sign with the lowing lettering must be clearly visible on the c pressor: "Attention! The compressor is remote controlled and could start without warning!"
In addition safety precautions must be implemented so that nobody works on the compres when it is under remote control.
2.9
Special tasks
Organisational
Adhere to the the prescribed maintenance maintenance work a intervals including details about the replaceme of parts/part assemblies contained in the oper instructions.
Maintenance and repair work must only be ca out under the supervision of or by a person qu fied to carry out this work.
If necessary, cordon off a wide area around th Sign up to vote on this title workplace. Useful appropriate Not useful for the task equipment Workshop
essential for carrying out maintenance and rep work.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Safety cond Maintenance/Troubleshooting Only carry out maintenance and repair work with the compressor switched off and mains power off. Secure the compressor to prevent inadvertent switching on. Before opening the compressor enclosure: Drain the compressor. Wait for automatic pressure discharge to complete. Wait until the residual electrical energy has drained from the capacitors. Allow the compressor to cool to room temperature. Cleanliness During maintenance and repair work always check for cleanliness. Keep dirt away by covering parts and uncovered openings with a clean cloth, paper or adhesive strips.
Tighten up all threaded connectors loosene ing maintenance and repair work. Likewise all other threaded connectors.
Before release of the compressor for opera ter maintenance and repair work, ensure th operating pressures, temperatures and tim tings are correct and that the control and s off equipment is fully serviceable.
If safety and protective equipment must be moved, then it must be immediately replac ter completion of the work and checked for ble-free operation.
2.10
Conversions and chang the machine
Do not make any changes or additions to o build the compressor without prior consulta with Gardner Denver. Unauthorised changes to the machine are thorised for safety reasons.
Oil leaks lead to a slippery floor. Thoroughly clean the work area after completion of maintenance and repair work.
Genuine parts are designed especially for chine. We expressly point out that we also authorise parts and special equipment that supplied by us. The fitting and/or use of Cleaning agents may therefore impair active and/or pa You're Reading aucts Preview safety. When cleaning parts, never use solvents or cleaning agents that could chemically attack the materiUnlock full access with a free trial. on the part of the manufacture Any liability als. damage arising from the use of non-origina
or special Take precautions to prevent harmful vapours fromWith Free Download Trial equipment is excluded. The sam plies for the fitting and adjustment of safety solvents or cleaning agents. ment and valves as well as to the welding o Weight / lifting gear bearing or pressure carrying parts. When replacing heavy individual parts and assemblies carefully attach and secure to the lifting gear so that no danger can arise. Use only suitable and technically flawless lifting gear and load handling equipment with adequate load capacity. Never work or remain under suspended loads. Spare parts
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
3
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
3
DESIGN AND FUNCTION
3.1
General description
The compressor is an oil-free compressing, twostage screw compressor with one sound-proofed enclosure. The main components are the drive motor, the airend unit, the cooling and lubrication system and the electronic control. The airend unit comprises the drive gear and the first and second airends. The parts of the airends through which the air flows are provided with a special wear-reducing and corrosion-resistant coating. Rolling contact bearings and gearbox are oil-lubricated. The air and oil system are designed so that no oil can get into the air circuit. The ejector ventilation system produces a defined vacuum pressure in the oil-lubricated area of the airend unit thus preventing any oil from escaping into the surroundings.
Compression principle
The airends comprise a main rotor and an aux iary rotor with intermeshing spiral toothing. A s chronized gearbox in each airend ensures the contact-free running of the rotors. Compressio chambers are delimited by the flanks of the to ing and the compressor casing. The rotation o the rotors continuously reduces the volume in chambers until the compressed air is pushed through the outlet window of the stage casing. Screw compressors count amongst rotation-d placement compressors without oscillating but with a pulsing output.
To minimise the power consumption of the air unit and to limit the airend temperatures to tec nically permissible values, the compression ta place in two stages with interstage cooling (in tercooler). In addition the casing of the stages cooled by the internal cooling circuit Electronic control unit
The main components of the electronic contro unit are a microprocessor, a touchscreen, film tected keys and LEDs.
Detailed description of the operating instructio forathe electronic control unit. You're Reading Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun
3.2
Compressor design
Air-cooled
14 16
13
15 12
17
11
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial 10 1
9 2
3
4
5
6
7
Fig. 3-1: Overview part 1
8
Sign up to vote on this title
Silencing withuseful filter mesh Useful baffle Not
[1]
Condensation trap (intercooler)
[10]
[2]
Oil / water cooler
[11] Aftercooler
[3]
Oil Filter
[12]
Intercooler
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
3
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
18
18
17
16 15
1 2 3 4 5
6
You're Reading a Preview
14
Unlock full access with a free trial.
13
Download With Free Trial 7
8
9
10
11
12
Fig. 3-2: Overview part 2
[1]
Suction regulator
[10]
Drive motor Sign up to vote on this title Oil pump Useful Not useful Water pump
[2]
Motor lubrication system
[11]
[3]
Non-return valve
[12]
[4]
Safety valve (line pressure max.)
[13] Air Filter
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun Water-cooled
14
13 12
15
11
16 17 18
You're Reading a Preview Unlock full access with a free trial.
10
Download With Free Trial
1
2
3
4
5
8
9
6 7
[1]
Condensation trap (interstage cooler)
[10]
Sign up to vote on this title Silencing withuseful filter mesh Useful baffle Not
[2]
Oil / water cooler
[11]
Cooling water manifold
[3]
Oil Filter
[12] Aftercooler
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
3
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
16 1
15
17
18
2 3
4 5
You're Reading a Preview Unlock full access with a free trial.
6
Download With Free Trial 7 14
13 Sign up to vote on this title
8
9
10
11
Useful
12
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun
3.3
System scheme air-cooled compressor
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
3
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
Components No
Name
No
Name
No
Name
1
Intake air filter
11
Aftercooler
22
Temperature contro (oil circuit)
2
Suction regulator
12
Pressure relief valve
23
Heat exchanger
3
First airend
13
Water separator (aftercooler)
24
Oil Filter
4
Snubber
14
Safety valve (final pressure)
25
Cooler internal coo water circuit
5
Intercooler
15
Filter water separator
26
Temperature contro (internal cooling wate cuit)
6
Water separator (intercooler)
16
Shuttle valve
27
Compensating tank
7
Safety valve (intermediate pressure)
17
Blow-off silencer
28
Cooling water pum
8
Second airend
18
Maintenance unit
29
Drive motor
9
Combined silencer and snubber
19
Vacuum generator
30
Speed control (inve
10
Non-return valve
20
Ultra-fine filter
31
Radial fan
32
Radial fan
21
You're Reading a Preview Oil pump
Unlock full access with a free trial.
Chart 3-2: Components
Instrumentation & control technology Download With Free Trial No
Name
No
Name
No
Name
B0
Ambient pressure absolute
R0
Ambient temperature
S5
Oil filter differential sure
B1
Inlet pressure first airend R1
Inlet temperature first airend
S12
Oil level
B2
Outlet pressure first airend
R2
Outlet temperature first Water level Sign upS18 to vote on this title airend Useful Not useful
B3
Inlet pressure second airend
R3
Inlet temperature second M1airend PTC
Drive motor positor
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun
3.4
System scheme water-cooled compressor
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
3
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
Components No
Designation
No
Designation
No
Designation
1
Intake air filter
12
Pressure relief valve
23
Heat exchanger
2
Suction regulator
13
Water separator (aftercooler)
24
Oil Filter
3
First airend
14
Safety valve (final pressure)
25
Cooler internal coo water circuit
4
Snubber
15
Filter water separator
26
Temperature contro (internal cooling wate cuit)
5
Interstage cooler
16
Shuttle valve
27
Compensating tank
6
Water separator (interstage cooler)
17
Blow-off silencer
28
Cooling water pum
7
Safety valve (intermediate pressure)
18
Maintenance unit
29
Drive motor
8
Second airend
19
Vacuum generator
30
Speed control (inve
9
Combined silencer and snubber
20
Ultra-fine filter
31
Radial fan
10
Non-return valve
21
Oil pump
32
Throttle valves exte cooling water circuit
11
Aftercooler
22
34
Safety valve (external water circuit)
You're Reading a Preview
Temperature control 33 valve (oil circuit) Unlock full access with a free trial.
Strainer sieve
Download With Free Trial
Chart 3-5: Components
Instrumentation & control technology No
Designation
No
Designation
B0
Ambient pressure absolute
R2
B1
Inlet pressure first airend R3
Outlet temperature first S5 Oil filter differential p airend sure Sign up to vote on this title Inlet temperature second S12 Oil useful level Useful Not airend
B2
Outlet pressure first
R4
Outlet temperature sec-
No
S18
Designation
Water level
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun No
Designation
No
Designation
No
Designation
B8
Vacuum in gearbox cas- E1 ing
Condensate drain control L
Balance piston f
R0
Ambient temperature
E2
Condensate drain control H
Balance piston s airend
R1
Inlet temperature first airend
E4
Motor lubrication system G
Gearbox casing
E5
Motor lubrication system
Chart 3-6: Instrumentation & control technology
3.5
Air circuit 3
2 2
1
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
3
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
4 5 6
3 7
8
2
You're Reading a Preview 1 Unlock full access with a free trial.
Fig. 3-6: Air cooling circuit (water-cooled)
Download With Trialsilencer [5] Free Blow-off
[1]
Combined silencer and snubber
[2]
Safety valve
[6]
Suction regulator
[3]
Aftercooler
[7]
Blow-off valve
[4]
Interstage cooler
[8]
Snubber
The air is sucked in via a suction filter and reaches the first airend via the suction regulator. Here the is compressed to the intermediate pressure and then cooled in the intercooler. Compression to the fin Sign up to vote on this title compression pressure desired by the customer then takes place in the second stage. The compresse Not useful Useful air is output to the compressed air network via the aftercooler. Condensate formed during cooling is s rated by an automatic condensate separator.
If the compressor is operating off-load, the compressed air output from the second stage is discharge
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun
3.6
External water circuit
You're Reading a Preview Unlock full access with a free trial.
2 1
Download With Free Trial
3
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
3
3.7
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
Internal wa water ci circuit
A I 4
5
W I O
3 2
1
6
7
Fig. 3-8: Internal water circuit
[A]
Air-cooled system system
[4]
Expansion line
[W]
Water-cooled system
[5]
Expansion tank with level sensor
[1]
Water pump
[6]
Cooling water drain
[2]
Temperature Temperature control valve
[7]
Oil / water cooler
[3]
Water/air (A) - coolerWater/water (W) cooler
The two airend stages are cooled by the internal cooling water circuit (casing cooling) while the lubric oil is cooled in the oil/water cooler. Sign up to vote on this title The water pump pumps the water to the second airend, to the first airend, to the oil/water cooler and Useful Not useful back to the water/air cooler.
Temperature Temperature control is implemented implemented via the cooling water temperature control valve. Water volume fl ations are compensated by the expansion tank.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun
3.8
Oil circuit
4
3 2 1
Sign up to vote on this title
Useful
Not useful
Fig. 3-9: Oil circuit
[1]
Oil / water cooler
[5]
Oil filler neck
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
3
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and function
3.9
The compressed air connection is correctly connected to the compressed air network.
Ejector vent system
The oil and cooling water levels are OK.
6 7
5 4
8
Ventilation of the compressor chamber is anteed.
The cooling water supply is guaranteed (w ter-cooled compressors only). The direction of rotation of the drive motor been checked.
All protective and and safety equipment equipment is fitted serviceable.
3
The electronic control unit indicates [Read Start].
2
Pressure demand from the compressed air work.
1
Operating sequence
Fig. 3-10: Ejector vent system
[1]
Second stage condensate separator (aftercooler water separator)
[2]
Compressed air connection ejector vent system
[3]
Solenoid valve Y3
[4]
Maintenance Maintenance unit (water separator, pressure regulator, pressure gauge)
[5]
Ejector (vacuum generator)
[6]
Extract air
[7]
Ultra-fine filter
[8]
Oil return
The ejector ventilation system produces a defined vacuum pressure in the oil-lubricated area of the airend unit thus preventing any oil from escaping into the surroundings. The ejector vent system uses compressed air from the compressed air network. The air passes via
Switch on the cooling water supply (water-cooled compressor only). Press the start button < I > on the control panel. The compressor is switched on.
Checking of the start parameters (tempera tures, pressures, sensors, cooling water by the electronic control unit.
Once the start parameters have been fulfill the cooling water pump and the oil pump a switched on sequentially; the water and oil cuit are running.
Simultaneously, solenoid valve Y3 is actua so that the ejector vent system starts opera
If the water and oil pressure are correct, th drive motor is started.
After running up up of the drive motor, motor, soleno valvesSign Y1 up and to Y2 voteare on switched this title in a time-d layed manner, regulator opens Not useful Useful the suction two fans are switched on. The compressor now in load operation. operation .
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Design and fun – If the line pressure drops below the minimum line pressure [Line Pressure min.]: Fan 2 is switched on, solenoid valves Y1 and Y2 are switched on, the blow-off valve is closed and the suction regulator is opened. The compressor operates under load until the maximum line pressure [Line Pressure max.] is reached. Automatic operation. – Once the off-load period has elapsed: the drive motor is switched off, fan 1 runs for 30 seconds longer, solenoid valve Y3 closes after 30 seconds and the ejector vent system is shutdown. As soon as the drive motor stops, the oil and water pumps are switched off. Press the stop button < O > on the control panel. The compressor is switched off. The compressor enters "Ready to start" (standby) mode. If the compressor is switched off, then the cooling water supply can likewise be switched off (water-cooled compressors only).
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
4
Transport and positioning
4
TRANSPORT AND POSITIONING
4.1
Transport
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Transporting the compressor
Delivery The compressor is screwed onto a transport pallet and packaged with a film cover. The centre of gravity and lifting points are marked on the packaging. Receipt of goods Upon receipt of goods check for transport damage. 1 Check the delivery for visible damage.
Fig. 4-1: Lifting points
2 Check the completeness of the delivery using the delivery note.
1 Remove the screws from the transport pall
3 Immediately inform the shipper, Gardner Denver and insurance of any missing parts or damage.
3 Transport the compressor to the destinatio point.
2 Lift the compressor from the transport palle
4 Align the compressor and set down. Weight Dependent on type, the compressor weighs up to 3,800kg (gross). The weight is stated on the nameplate which is visible from the outside.
4.2
Storage
Transport
where possible, heated room. This applies pa
Storage of compressors
The compressor should be stored in a dry and You're Reading a Preview
Unlock full accesslarly with aduring free trial. the winter months.
DANGER Risk of fatal injury
Download WithNOTICE Free Trial
Risk of fatal injury due to toppling or falling parts ➯
A suitable forklift with forks of adequate length must be used to transport the compressor.
➯
Only insert the forks at the intended lifting points.
➯
The compressor must not be transported using a crane, even when still in its packaging.
Material damage
Material damage through exceeding of the pe missible temperature range
Where there is a risk that the permissible temperature limits of +2 ...+65 °C could b over or undershot, contact Gardner Denv Sign up to vote on this title Corrosion protection Useful Not useful Before they leave the factory all compressors protected against corrosion during transport a ➯
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Transport and positio The installation location (compressor room) must be dimensioned such that the compressor has a clearance on all sides of 1m ("A" and "B") and above the compressor of 1.50 m. Moreover, adequate access must be provided for maintenance.
In the event of unfavourable local condition stall air ducts in which the flow velocity of t ing air must not exceed 5 m/s. We recomm a minimum channel cross section of 1.2 m cooled compressor) and 0.45 m 2 (water-co compressor).
NOTE
To ensure effective heat removal, the inst auxiliary fans must be dimensioned such their air flow is 15 to 20% greater that the ing air flow required by the compressor.
If installing several compressors in one co pressor room, then this applies to the tota cooling air flows required by all the compr present in the compressor room.
The following figure shows the recommend tilation requirements. Fig. 4-2: Positioning / clearances
Position the compressor so that it is sufficiently accessible and the required cooling is ensured. Do not block the air inlet. Avoid moisture. Ventilation
You're Reading a Preview Unlock full access with a free trial.
DANGER Risk of suffocation
Download With Free Trial
Risk of suffocation due to inadequate ventilation ➯
The operator must provide adequate ventilation of the compressor room.
To be able to dissipate the heat generated during operation, the compressor room must be of sufficient size and have adequate ventilation. The recommended minimum size of the compressor room is 60 m 3.
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
4
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Transport and positioning
Positioning the compressor
DANGER Risk of injury Danger due to incorrect positioning ➯
Consider the permissible bearing force of the substrate.
➯
Ensure there is a hard and even substrate.
➯
The entire surface of the compressor must be placed on an even suitable substrate.
➯
The compressor must not be operated on the transport pallet.
➯
No inflammable or explosive materials may be stored in the vicinity of the compressor.
1 Set down the compressor at the destination point. 2 Ensure that the bearing surface is even to within 3mm. (The compressor does not have any levelling means fitted on it)
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Preparations for commission
5
PREPARATIONS FOR COMMISSIONING
5.1
Pipelines
5.2 1
Remove all blank flanges, plugs, caps and desiccant containing pouches before fitting the pipelines.
A
Manifolds and pipe connections must be of the correct size and be suitable for the respective operating pressure. Label compressed air and water pipes according to the local regulations.
1 2
Support all pipelines with correctly dimensioned supports; pipes must not support any loads. If compressed air hose is used, it must be correctly dimensioned and be suitable for the operating pressure and temperature. Do not use any abraded, damaged or inferior quality hose. A shut-off valve must be fitted in the supply line so that the compressor can be isolated for maintenance purposes. No additional non-return valve may be installed. The additional non-return valve would impede the air supply to the vacuum generator.
Compressed air connec
3 4 5
Fig. 5-1: Compressed air and condensate conn
[1]
Compressed air connection
[A1] Automatic condensate drain, afterco
[A2] Condensate drain pipe aftercooler v valve (use if there is a malfunction o automatic condensate drain)
[A3] Automatic condensate drain, interco
Preview If a high level of condensate formationYou're is ex- Reading a[A4] Condensate drain pipe intercooler vi pected, the compressed air connection for the valve (use if there is a malfunction o Unlock full access with a free trial. ejector vacuum generator must be connected to a automatic condensate drain) condensate-free compressed air supply. In case of doubt, contact Gardner Denver. Download With Free Trial The two automatic condensate drains must be provided with separate lines that are routed to a drain or a collecting tank. The drains lines leading away from the condensate connections must not be designed to rise more than 5 m! An air tank with sufficient volume (as a buffer) must be installed between the compressor and the compressed air network. As a guide, the tank capacity should equal 10 % of the delivery quantity, e.g. a compressor with a delivery quantity of 10
DANGER
Risk of bursting
The compressed air outlet temper can be up to 95°C.
The burst strength of the follow components of the supply line Sign uptomer to votenetwork) on this title must be suitab these Not useful Useful temperatures. ➯
WARNING
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
5
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Preparations for commissioning
WARNING
5.3
Cooling water connection
Risk of injury If an incorrect connection is made, the connector could come loose and the free connection result in severe personal in jury. ➯
➯
When connecting the compressor to the compressed air network, the connecting flange must be checked in addition to the operating temperatures and pressures. When connecting hoses, suitable measures must be taken to prevent the dangerous "whipping" of a loose hose end.
1 2
Fig. 5-2: Cooling water connection (1)
Checking the connection flange
[1]
Inlet for external cooling water
The pressure connection comprises a DIN flange.
[2]
Outlet for external cooling water
The connection label is stamped outside on the flange plate: DN80, PN16 1 Read off the connection label.
WARNING Legionella contamination
Health risk with open cooling system 2 Ensure that connector and flange match. You're Reading a Preview ➯ Constant testing of the water qua in the cooling circuit for the numb Connecting the compressor to the comUnlock full access with a free trial. of microbes. pressed air mains
The compressor is completely assembledDownload in the With Free Trialthe compressor to the cooling Connecting factory. The connection to the compressed air netwater mains work must be made with a flexible line, e.g. a comThe compressor is completely assembled in th pressed air hose or expansion joint. factory. The connection to the cooling water m Only use hose couplings and connections of the must be made with a flexible line, e.g. a comcorrect type and size. pressed air hose or expansion joint. 1 Ensure that the supply line can be connected Only use correctly sized connectors. free from tension. Sign upthe to vote thisbe title that linesoncan connected fre 1 Ensure 2 Connect the connection line to the compressed from tension. Useful Not useful air connection of the compressor. 2 Connect the connecting line with the comp 3 Secure the hose lines. sor cooling water inlet and outlet.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Preparations for commission •
Cooling water inlet temperature min.: 5 °C / 41 °F
•
Cooling water inlet temperature max.: 42 °C / 107 °F
•
Cooling water outlet temperature max.: 57 °C / 134 °F
Cooling water requirement at maximum power and (ΔT = 15 K , Δp = 0.7 bar / 13 psi) •
75KW = 89 l/min / 23 gal/min
•
90KW = 111 l/min / 29 gal/min
•
110KW = 132 l/min / 35 gal/min
•
132KW = 155 l/min / 41 gal/min
•
160KW = 170 l/min / 45 gal/min
ΔT: Cooling water outlet temperature = Cooling water inlet temperature + ΔT Δp:
The compressor system is executed comp the factory according to EN 60204 (industr chinery).
The compressor power supply must be for industrial equipment and must fulfil a requirements of EN60204-1/IEC60204tact Gardner Denver if the positioning c tions differ from the conditions as they scribed in EN 60204.
Implement the electrical connection and protective measures in accordance with BS or the appropriate local regulations. eral, the supplementary regulations of t spective power supply utility must be co ered.
A main switch must be fitted on-site ups of the compressor (DIN EN 1012 - 1) in that such a switch has not already been in the factory as a special accessory. T switch must fulfil the requirements of th standard EN 60 204-1 (Electrical equipm machines), as well as EN 60947-2 (low switchgear).
The compressor must be fused using s backup fuses in accordance with EN 60 Cooling water inlet pressure - Δp (low voltage directives). You're Reading a Preview The values relate to fresh water quality without adIf third party circuits are retrospectively access with a free trial. ditives (e.g. antifreeze). If the cooling Unlock water full quality trolled via the electronic control, e.g. lig deviates from this, please contact Gardner Denheating or similar, that cannot be switch ver. Download With Free Trial from the main switch, these excluded c Set the cooling water volume in accordance with must be labelled according to EN 60204 the description "Cooling water control in a warouted separately. Moreover, warning s ter-cooled compressor system". must be attached close to the main swi close to the relevant circuits. Cooling water outlet pressure =
NOTE The cooling water outlet temperature should where possible be greater than 57 °C to prevent heightened limescale formation.
5.4
Electrical connection
Should an electrical connection to an un earthed AC electrical circuit (IT network made, observe the instructionsin the su Sign up to voteofonthe thisfrequency title documentation conver Useful Not useful RS compressors).
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
5
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Preparations for commissioning
Electrically connecting the compressor
2 Set the safety switch according to the supp network voltage and frequency.
Check the setting of the control transforme 1
DANGER
2
Electric shock Life-threatening electric shock
3
➯
Work on the electrical equipment must only be carried out by autho rised electricians or electrical tech cians.
➯
With types D110RS - D160RS the is a risk of electric shocks due to charged capacitors! Switch the compressor to a zero volts state and wait 10 minutes be fore touching any electrical parts.
➯
Checking the DC bus voltage.
4
Fig. 5-3: Supply line openings
[1]
Compressed air connection
[2]
Filter mat cooling air inlet
[3]
Condensate drain
[4]
Supply line cover panel
The control transformer is set to the rated age ex works.
Experience has shown that the actual supp voltage may differ from the rated voltage.
DANGER Electric shock
You're Reading aTo Preview match the local circumstances, the cor-
rect setting of the control transformer must a free trial. Life-threatening electric shock Unlock full access withchecked when the compressor is under loa ➯
by measuring the control voltages and if ne Work on the electrical equipment sary the transformer then reset. Download With Free Trial must only be carried out by authorised electricians or electrical techni A number of taps are provided for this purp cians. (see wiring diagram).
1 Remove the factory-provided cover panel. 2 Insert the customer-provided supply line panel. 3 Feed the power supply cable through the openings in the switch cabinet. 4 Connect the power supply cable, see the wiring diagram. 5 Tighten the cable glands.
NOTICE
Material damage
Incorrect setting of the control transformer en Sign up to vote on this title dangers trouble-free operation. Useful Not useful ➯ Checking of the setting of the control tr former forms part of commissioning and p riodic inspection/maintenance, as the ma
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Commissioning and opera
6
COMMISSIONING AND OPERATING
6.1
Initial commissioning
9 Check the factory setting of the pressur points (minimum line pressure [Line Pre min.] and maximum [Line Pressure max readjust if necessary.
NOTICE
10 Ensure the external cooling water supp equate (water-cooled compressor only)
Material damage
11 Press the start button < I >.
Although every compressor has already undergone a test run in the factory and has undergone a careful final inspection in dispatch, the possibility of transport damage cannot be excluded.
12 Check the direction of rotation of the tor (not RS compressors) or the fans (R pressors ). See the following descriptio
➯
➯
Before commissioning check the compressor once more for damage and monitor it during its initial operating hours. If the compressor is being connected to a power supply network and started for the first time, then dependent on the version, the direction of rotation of the drive motor and/or fans must be checked.
13 Check the output voltages of the contro former in load operation.
Check the direction of rotation of the dr motor (not RS compressors )
DANGER Risk of injury
The drive motor rotational directio only be checked if the clutch cove mounted.
– Drive motor for non-RS compressors – Fans for RS compressors
➯
Preparations
Before switching on, check tha there is nobody in the danger
Check all electrical and electronic compoMaintain an adequate distance You're Reading a Preview➯ nents/devices for water ingress or condensate rotating machine parts! formation, in case of complaints, contact GardUnlock full access with a free trial. ➯ Wear ear defenders! ner Denver. ➯ Except for test runs, only oper If the compressor has been in storage for a Download substantial period of time (up to 2 years), the With Free Trial the compressor with the enclo closed. main switch must be switched on at least one hour prior to starting. This ensures the operability of the capacitors and prevents any damage from occurring. If the compressor has been stored for longer than 2 years, consult Gardner Denver. Carry out the initial commissioning as follows 1 Check the cooling water level (internal water circuit).
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
6
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Commissioning and operating
3 Remove the protective cover from the clutch. 4 Switch the main switch ON. 5 Press the start button < I >. 6 Check the rotational direction. 7 If the rotational direction is incorrect: Immediately switch the compressor off with the ; not the Stop button < O >, as otherwise damage to the compressor may occur, even if it only operates very briefly. 8 Switch the main switch OFF. 9 Correct the rotational direction. Change the compressor rotating field. 10 Replace the protective cover on the clutch. 11 Close the enclosure. Checking the direction of rotation of the fans (for RS compressors )
CAUTION
Fig. 6-3: Check direction of rotation of fan motor (w ter-cooled system)
Risk of falling
The rotational direction of the fan motors can checked with the enclosure still closed.
The rotational direction of the fan motors can only be checked "from above".
1 Place a suitable ladder alongside the comp sor and use it to climb up.
➯
Ensure safe climbing means are 2 aCheck the rotational direction. You're Reading Preview provided. The rotational direction arrow can be deter Unlock full access with a free trial. mined through the protective cover.
1
3 If the rotational direction is incorrect: switch the compressor. Download With Free Trial 4 Switch the main switch OFF. 1
5 Correct the rotational direction. Change the compressor rotating field. Temperature start-up protection The compressor does not start up at ambient peraturesSign lessupthan + 2on °C. to vote this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes ASC 100-D CompAir 5437 Air
Save
Embed
Share
Print
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Commissioning and opera 6.1.1
Cooling water control in a watercooled compressor system
Cooler, water-cooled compressor system
NOTE
The cooling water volumes of the individu ers are preset in the factory and secured tamper-evident seal. Adjustment of the hand valves
2
1
-
+
+
+
-
-
You're Reading a Preview
3
Fig. 6-4: Cooler layout
Unlock full access with a free trial. Fig. 6-5: Display schematics Delcos XL
[A]
Jacket / oil cooling
The hand Download With Free Trial valves A, B and C are preset. Fu
[B]
Interstage cooler
[C]
Aftercooler
adjustment is not normally necessary. In th that the values given below are not achieve readjustment can be undertaken.
The following specified values only app at least 45 minutes operation under full up to vote "1" on this title • OilSign temperature approximately 25°C
useful above the cooling water inlet temperatu Useful Not
•
Second stage air inlet temperature 2 imately 9°C / 16.2°F to 10°C / 18°F abo
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
6
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Commissioning and operating
NOTICE
6.2
Normal operation
Electronic control unit Material damage Operating conditions to be adhered to before the adjustment work ➯
Hand valves A - C completely open before system starting.
➯
Ensure the cooling water supply is adequate.
➯
Operate the system for at least 45 minutes at full load. °
Maximum pressure and maximum speed for speed-controlled systems.
Fig. 6-6: Control panel
[1]
Touchscreen display
[2]
Start button < I >
[3]
Stop button< O >
This adjustment work must only be carried out by trained maintenance personnel .
[4]
Slowly close hand valve A (jacket / oil cooler) until the oil temperature "1" has risen by about 1°C / 1.8°F.
Red LED Slow flashing: Warning Fast flashing: Fault
[5]
Yellow LED Slow flashing: Maintenance necessary
°
•
Maximum pressure for systems without speed control.
•
Slowly close hand valve B (interstage cooler) [6] Green LED until the second stage air inlet temperature "2" Lit up permanently: System in operation is approximately 9°C / 16.2°F to 10°C You're / 18°F Reading a Preview Flashing: System on standby above the water inlet temperature. Pushbutton Unlock full access[7] with a free trial. For water inlet temperatures that are well below the ambient temperature, a second stage air inlet temperature 2" of approximately 5°C / 9°F to With Free TrialDANGER Download 10°C / 18°F above ambient temperature must Risk of injury be aimed for (avoidance of condensation).
•
Slowly close hand valve C (aftercooler) until the temperature difference cooling water outlet "3" to cooling water inlet "4" is approximately 15°C / 27°F.
The compressor can start automatica at any time when it is in standby mod with the green LED flashing. Do not carry out any work on the compressor, if the green LED is Sign up to vote on this title flashing. Useful Not useful Switching on ➯
1 Press the start button < I > on the control
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Commissioning and opera Partial load operation (on-load operation at reduced speed only RS compressors ) [On-Load] Off-load [Off-Load] Observations during operation During operation the compressor must be regularly checked to ensure leak-tightness of the cooling water circuit and oil circuit.
6.4
Commissioning after a shutdown
If commissioning after a long shutdown, co Gardner Denver.
6.5
Commissioning after a
NOTICE
Condensate drain
Material damage
The condensate drains from the intercooler and aftercooler are activated under sensor control.
Avoid switching the compressor on multip times without rectification of the fault as lead to considerable mechanical damage.
Switching off 1 Press the stop button < O > on the control panel.
➯
Only switch the compressor back on a the fault is rectified.
– The compressor runs on for 30 seconds (soft stop). After this time, drive motor and fan 1 are switched off.
Re-commissioning after a fault (automa switching off)
– Once the drive motor is stationary, oil pump, water pump and fan 2 are switched off.
1 Switch main switch off and secure to switching back on.
Emergency-stop
Faults are displayed in the display menu "F log".
2 Rectify the fault. See the "Troubleshooting" chapter.
The compressor can be rendered safe in dangerYou're Reading a3Preview Switch on the main switch. ous situations using the emergency-stop pushbutton. fault in the fault log. 4 a Acknowledge Unlock full access with free trial.
5 After acknowledgement, the message [ to Start] appears on the display, provide • on the compressor control panel Download With Free Trial other fault exists. • optionally in a control room (control centre) 6 Press the start button < I > on the contr panel. Using emergency-stop – The compressor is switched on. 1 Press the pushbutton. – The compressor runs in automatic m The compressor is placed in a safe condition. See the operating sequence descrip 2 Rectify the fault that was the cause of the oper the section "Control (automatic Emergency-stop. Sign up to vote on this title in the chapter "Design and function" See the "Troubleshooting" chapter. Useful Not useful 3 Unlock the pushbutton. Turn the pushbutton anticlockwise. Emergency-stop pushbuttons are attached:
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
7
7
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Troubleshooting
TROUBLESHOOTING
NOTICE
Troubleshooting instructions The following tables list possible fault causes and remedies. The troubleshooting measures listed in these operating instructions may only be carried out by specially trained personnel. All work going beyond this must be carried out by the manufacturer's service personnel! Work on the electrical equipment must only be carried out by authorised electricians or electrical technicians. Remedies are described in detail in the repair manual, which is provided as part of operator training.
Material damage
Material damage due to improper/incorrect tr bleshooting measures. ➯
If the remedies listed here are insufficient for rectification of the fault, consult Gardn Denver.
➯
For fault and warning messages that are output to the display of the electronic con unit, observe the information in the "Trou bleshooting" chapter in the operating instructions of the electronic control unit.
Fault: The system will not start Possible Cause
Remedy
Missing operating or control voltage
Check fuses, main switch and power cable.
Fault is not acknowledged
Acknowledge fault in the electronic control un
Drive motor defective
Check connections, winding, etc.
Compressor defective
Rotate the compressor by hand, if necessary replace.
Ambient temperature < +2 °C
You're Reading a Preview
Ensure that the ambient temperature is at least
°C,with if necessary Unlock full access a free trial. provide stationary heating. Chart 7-1: Troubleshooting upon: The system will not start
Download With Free Trial
Fault: The system remains stationary during the start-up phase Possible Cause
Remedy
Short circuit in the compressor
Determine the cause of the short circuit and Replace defective fuses.
Terminals loose
Check the terminals and tighten if necessary Sign up to vote on this title Too frequent manual switching on and off results in Avoid frequent manual switching on and off. Useful Not useful exceeding of the maximum motor switching cycles Allow the electric motor to cool. Suction regulator does not close completely
Provide access to the suction regulator, replac
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Troublesho Possible Cause
Remedy
Heavy leaks
Check compressor. For example: Check for leaks.
Safety valve defective or open after chec Condensate drain set to test function. Suction regulator does not open completely
Provide access to the suction regulator, re necessary. Check solenoid valves (Y1 and Y2).
Chart 7-3: Troubleshooting upon: System does not reach the set line pressure
Fault: System switches off Possible Cause
Remedy
Water inlet temperature too high
Check the cooling water supply.
(only water-cooled compressors) Ambient temperature too high
Ventilate the compressor room.
Electric motor defective
Check electric motor and positor.
Fan defective
Check fan, replace if necessary.
Sensors, connections or leads defective
Check sensors, connections and leads.
Wire cross section of the electrical leads too small
Measure current consumption, if necessary
You're Readingleads. a Preview
Compressor defective
Unlock full access with a free trial. Replace compressor
Chart 7-4: Troubleshooting upon: System switches off
Download With Free Trial
Fault: Off-load pressure too high Possible Cause
Remedy
Compressor does not discharge
Check suction regulator, blow-off silencer return valve and replace if necessary.
Suction regulator does not close completely
Provide access to the suction regulator, re necessary. Sign up to vote on this title Check solenoid (Y1 and Y2). Useful valves useful Not
Chart 7-5: Troubleshooting upon: Off-load pressure too high
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
7
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Troubleshooting
Troubleshooting: Lubricator
If faults occur when operating the lubricator, please check the possible causes of error using the follo table. Fault Lubrication system not working
Possible Cause
Remedy
Cable incorrectly connected
Connect up cable correctly
No voltage
Check voltage at plug.
Cable failure
Connect new cable.
Lubrication system signals “System running” (green LED) although the grease cartridges are empty.
Setting "VOL" switch
Lubrication system signalling “Fault" (red LED)
Line and/or connection parts blocked
Lubrication system signals “End of dispensing” (red and green LED) although the grease cartridges are not empty.
Fit full grease cartridges.
Partially filled grease cartridges fitted
Back pressure too high
Clean line and connection par then switch lubrication system and on again.
Setting "VOL" switch
Fit full grease cartridges.
Almost empty grease cartridges replaced with partially filled grease cartridges
Chart 7-7: Troubleshooting and fault rectification for lubricator
NOTE
You're Reading a Preview
Observe the fault messages on the operating panel display. Unlock full access with a free trial. The corresponding measures for fault clearance are described in the operating instructions of the tronic control unit.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se
8
MAINTENANCE AND SERVICE
Maintenance and service are decisive for ensuring that the compressor can fulfil the requirements made of it for fault-free operation and running time. Therefore the adherence to the prescribed maintenance schedule and the careful execution of all maintenance and service work are indispensable. Support is available from your responsible Gardner Denver agency. They will create an individual maintenance plan for you.
8.1
General information
Target groups The maintenance work listed in these operating instructions may only be carried out by specially trained personnel.
Fig. 8-1: Position bleeder valve air-cooled comp system
[1]
Bleeder valve
All work going beyond this must be carried out by the manufacturer's service personnel! Safety Observe the safety instructions in the chapter Safety conditions.
DANGER
You're Reading a Preview
Electric shock
Unlock full access with a free trial.
Life-threatening electric shock ➯
➯
Download When carrying out any work on the With Free Trial electrical equipment, exercise extreme care. Before starting the maintenance work, switch the compressor to a voltage-free state and secure to prevent switching back on.
Fig. 8-2: Position bleeder valve water-cooled co sor system
WARNING
Sign up to vote on this title Protection measures for safe maintenan Useful Not useful routine) (safety
Risk of injury due to hot bleeder valve The compressed air outlet temperature
[1]
Bleeder valve
For all maintenance work, if not expressly elsewhere:
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
8 Observe the information about hazardous substances. Manual pressure relief
WARNING Pressure components Even when the compressor is depressurised, the aftercooler remains under pressure. ➯
Carry out manual pressure discharge before maintenance work is carried out in the vicinity of the aftercooler.
1 Connect the (site provided) shut-off valve in the supply line. 2 Switch the main switch OFF. 3 Open the enclosure, create access. 4 Undo the lock screw on the closed air vent valve (ball valve at the aftercooler). 5 Depressurise the aftercooler by careful opening of the air vent valve.
Check the DC bust voltage of the frequenc converter
The DC bus voltage is measured at the mains minal strip of the frequency converter. The pre position of the terminals "DC+" and "DC-" can taken from the supplied frequency converter o ating instructions.
1 Measure the voltage between the DC+ and DC- terminals.
2 Measure the voltage between the DC+ term and the chassis.
3 Measure the voltage between the DC- term and the chassis.
The voltage must read zero in all three measu ments.
8.2
Service
The global spare parts and customer service n work of Gardner Denver is available worldwid The local Gardner Denver subsidiary or the re sponsible dealer is available for any spare par requirements.
It is important that the model name and the se 6 Close the air vent valve and screw in the air number of the compressor are stated in all me You're Reading a Preview vent valve. sages. 7 Upon completion of maintenance work, open Unlock full accessSpare with a free trial.orders parts the shut-off valve in the supply line. Spare parts orders to: Test run Download With Free Trial Gardner Denver Deutschland GmbH A test run should be carried out after all main Aftersales tenance work; this should amongst other things Im Boorstück 9 make possible the detection of any leaks. During D-55469 Simmern every test run, the low-noise running of the comTel.: +49 (0)6761/832-136 pressor must also be ensured. Fax.: +49 (0)6761/832-411 Fax.: +49 (0)6761/12746 Electrical components e-mail: [email protected] Sign up to vote on this title
DANGER Electric shock
Useful NOTE
Not useful
The spare parts order is placed based on the
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se Compressor enclosure; here in particular the openings (doors) Safety valves and the suction regulator-blow-off valve must be operating flawlessly, for example they must not be blocked by dirt or paint.
2 1
Emergency stop pushbutton /Emergency stop function The switching function of the contacts can be checked by an electrician.
NOTE The Emergency-stop function must only be activated in dangerous situations. Otherwise the result could be increased wear or even damage to the compressor.
Fig. 8-3: Safety valves
An electrician can check the switch function of the contacts.
[1]
Safety valve
[2]
Valve cap
Functional checking of the safety valves
4 Turn the valve cap anticlockwise until a ble blowing off can be heard.
The functional checking of the safety valves must be carried out by a safety specialist. The result of the functional check must be documented. 1 Switch the main switch OFF.
5 Turn the valve cap clockwise as far as i The valve must completely close again.
8.4
Routine maintenance
2 Open the enclosure, create access.You're Reading a Preview All maintenance work and checks listed in 3 Press the start button < I >. maintenance plan must be carried out and Unlock full access with a free trial. Allow the compressor to run under load. mented at the specified intervals. maintenance, overhauls and repairs to Download With All Free Trial
NOTICE
compressor must be documented.
Hearing damage Increased sound pressure level when operating without the sound-proofing enclosure. ➯
Wear ear defenders.
WARNING Risk of burns/scalding Risk of burns/scalding due to escaping hot condensate / hot compressed air.
Service and maintenance work must be ca out by the local Gardner Denver agency. Cleanliness
The compressor room and the compressor roundings must always be kept clean. Sign up to vote on this title The compressor must be checked regularl useful Useful Not damage and excess wear.
Spilt oil must be immediately wiped up. Oil must be removed immediately.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service Immediately replace worn-through or damaged wires.
Lubricating oil Renolin AC68 (harmless if h dled normally)
Leak points
WARNING Risk injury due to high pressure ➯
➯
Corrosion inhibiting antifreeze coolant Hav XLC (harmful to health)
Do not manually investigate leak points in the system. Always use paper or board for this purpose.
In the event of accidents or prolonged contact operating fluids, observe the information in the hazardous substance data sheets!
Prevent leakage of operating fluids. Carefully clear up any operating fluids that esc Observe the information in the hazardous sub stance data sheets!
If leaks are suspected, check the corresponding area for leaks.
Oil carbon deposits in the oil lubrication sy tem
Immediately repair or replace damaged or leaking pipe or hose connections.
High oil temperatures reduce the service life o oil and this can lead to oil carbon deposits in t oil lubrication system. Oil carbon deposits can sult in damage to the bearings and gearboxes
Emission or leakage of operating fluids The following operating fluids are used in the compressor:
8.5
Maintenance plan
Maintenance work should be carried out regularly as recommended in the following maintenance plan In the majority of cases the maintenance plan is appropriate, however under certain circumstances it possible that changes to the details may be necessary. The maintenance plan should always be used You're Reading Preview then this should be discussed w a guideline. However, if based on experience a change is a necessary, Gardner Denver. Unlock full access with a free trial.
Maintenance plan: Weekly checks Component
Action Download With Free Trial Necessary qualification Carried
Filter mat cooling air inlet
Check, clean and replace as necessary.
Maintenance personnel
Inlet filter cooling air switch cabinet (only RS compressors)
Check and replace as necessary.
Maintenance personnel
Condensate drain
Intercooler, function check.
Maintenance Sign up to vote personnel on this title
Aftercooler, function check.
Useful personnel Not useful Maintenance
Check level and top up as
Maintenance personnel
Lubricating oil
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se Component
Action
Necessary qualification Exe
Electronic control unit
Check fault statistics.
Operator
Air Filter
Check air filter and filter cartridge, replace if necessary.
Maintenance personnel
Hoses and pipelines
Check for leaks or as the case Maintenance personnel may be, damage.
Electrical wiring
Check connections and condi- Electrician tion.
Compressor
Maintain the compressor room Operator and surroundings clean.
Dirt trap (only water-cooled compressors)
Remove sieve and clean
Maintenance personnel
Chart 8-2: Maintenance plan: Service A
Maintenance plan: Service B - every 8,000 hours or 12 months, weekly checks plus service plus the following work: Component
Action
Necessary qualification Carr
Air Filter
Replace filter cartridge.
Maintenance personnel
Oil Filter
Replace oil filter.
Maintenance personnel
Ultra-fine filter
Replace filter element.
Maintenance personnel
Balance piston
Replace diaphragm (1st Trained service personairend). nel Unlock full access with a free trial.
You're Reading a Preview
Replace diaphragm (2nd Trained service personairend). Download With Free Trialnel Control air filter
Replace control air filter.
Maintenance personnel
Maintenance unit
Replace filter element.
Maintenance personnel
Solenoid valve Y3 (vacuum generator)
Replace valve.
Maintenance personnel
Lubricating oil
Change the oil.
Electronic control unit
Test the emergency-stop function.
Chart 8-3: Maintenance plan: Service B
Maintenance personnel Sign up to vote on this title Operator Useful Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
8
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
Component
Action
Necessary qualification Carried
Non-return valve
Replace complete valve.
Trained service personnel
Drive clutch
Check for play and replace inserts if necessary.
Trained service personnel
Snubber (1st airend)
Replace seals.
Trained service personnel
Combined silencer and snubber (2nd airend)
Replace seals.
Trained service personnel
Intercooler
Replace inlet seal.
Trained service personnel
Aftercooler
Replace inlet seal.
Trained service personnel
Blow-off silencer
Replace silencer.
Trained service personnel
Condensate trap
Replace complete condensate Trained service persondrain. nel
Chart 8-4: Maintenance plan: Service C
Notes
Operating parameters:The current settings, e.g. maximum line pressure [Line Pressure max.] and m You'rebe Reading a Preview mum line pressure [Line Pressure min.] should documented in the customer operations log. Implem tation and results of maintenance work and inspections should likewise be logged in this operations lo Unlock full access with a free trial. In this way Gardner Denver can identify the specific service for your compressor.
Maintenance work:The individual maintenance tasks that the service personnel can carry out, are de Download With tailed in the following chapter. All other maintenance work Free must Trial be carried out by trained service pers nel using the repair manual.
Service cycles: The earliest date always applies; i.e. if the operating hours are reached before the ca dar date, then the service in question must be carried out.
Oil change periods: The oil change periods can be extended to 16,000 operating hours or 24 month provided the oil analyses permit this. Oil analyses are carried out during the warranty period in a labo tory appointed by Gardner Denver. Signcircuit up to vote onbe thischanged title Coolant change: The coolant (cooling liquid) of the internal cooling must every 32
operating hours or after 48 months. The mixing ratio is 33 % glycol (Havoline ethylene glycol (ba Not useful Useful XLC and 67 % water.
Servicing kits: To identify the correct servicing kit, see the following table "Part numbers for servicin
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se
NOTE The compressor is supplied with Renolin AC68. The following oil types can be used instead: •
Shell Turbo T68
•
Mobil Rarus 426
•
Esso Teresso 68
•
Castrol Perfecto T68
Pressure accumulator (snubber)
Checking of the pressure accumulator (snubber) must be carried out according to national regulat We recommend the following checking intervals for the snubber: External inspection: 2 years Internal inspection: 5 years Strength test: 10 years Electronic control unit
Information concerning the maintenance points for the electronic control unit can be found in the e tronic control unit operating instructions.
8.6
Maintenance work
8.6.1
Accesses
Blow-off silencer Suction regulator
You're Reading a Preview
Ultra-fine filter Access to the components inside the compressor Unlock full access with a free trial. system is via the accesses in the enclosure listed Oil Filter below. Balance piston
Download With Free Trial
Maintenance unit Control air filter Shuttle valve
1 2
3
Solenoid valves (Y1 and Y2) Access 2 provides access to: Drive Signclutch up to vote on this title
Useful Snubber
Not useful
Access 3 provides access to:
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
The condition of the filter mat must be checke regular visual inspections. 1 Undo the fastening screws. 2 Remove the filter mat.
4
3 Check the filter mat condition. 5
– If damaged, replace the filter mat. 4 Clean the filter mat. – Brush off the filter mat.
– Wash off the filter mat with a mild clean solution. – Thoroughly rinse the filter mat and allo dry. 5 Insert the filter mat. Fig. 8-5: Accesses 4 - 5
[4]
Access 4
[5]
Access 5
6 Attach the fastening screws.
8.6.3
Inlet filter cooling air switch cabinet (RS compressors )
Access 4 provides access to: Air Filter Aftercooler Non-return valve Access 5 provides access to: Switch cabinet
8.6.2
Filter mat cooling air inlet
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
1
2
Fig. 8-7: Inlet filter (only RS compressors )
Sign up to vote on this title
3
4
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se
Check the function of the condensate d valve
Fig. 8-9: Inlet filter, opened
The switch cabinet is equipped with four inlet filters. The filter pad of the inlet filter cannot be cleaned, rather must be replaced if it becomes clogged with dust. 1 Pivot open the louvred grille of the inlet filter. 2 Remove the filter pad.
You're Reading aFig. Preview 8-10: Condensate drain
3 Check the condition of the filter pad.
[1] separator Unlock full access with a free Condensate trial.
– If necessary, replace the filter pad.
[2] Condensate trap 4 Insert the filter pad into the louvred grille. Download With Free [3] Trial Button The soft side ("A") of the filter pad must point [4] Connecting screw outwards (towards the louvred grille). 5 Place the louvred grille onto the filter housing.
[5]
8.6.4
Check the condensate drain.
Condensate drain
Electrical connections
Automatic condensate drain
1 Switch the main switch OFF.
Moisture contained in the compressed air network condenses in the air coolers (intercooler and aftercooler) and is separated by the cyclone separator. The condensate is automatically drained off by the condensate drain that is attached to the cyclone
2 Open the enclosure, create access. Sign up to vote on this title 3 Switch the main switch ON. Useful Not useful 4 Press button . Condensate flows away.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
8.6.5
Topping up the oil
Lubricating oil
Checking the fill level
4 3 2 1
Fig. 8-12: Lubricating oil system
Fig. 8-11: Level indicator
[1]
Oil / water cooler
[2]
Oil temperature control valve
[3]
Oil Filter
[4]
Oil pump
[5]
Oil filler neck
[6]
Oil level indicator
You're Reading a Preview
The fill level should be checked approximately Unlock 30 full access[7] with a free Oil trial. sump minutes after switching the compressor off, then [8] Oil drain the oil will have settled in the system. 1 Switch the main switch OFF.
Download With Free Trial
2 Open the enclosure, create access. 3 Check the level at the level indicator. The fill level must be between the "min." and "max." markings. The oil volume between the "min" and "max" markings is approximately 3 l. – Top up with oil if the oil level is too low. 4 Close the enclosure.
NOTE
Do not mix different oil types together. Always only top up with the currently used oi 1 Switch the main switch OFF. 2 Open the enclosure, create access. Signthe up cap to vote on the this oil titlefiller neck. 3 Remove from
Useful Notquantities useful the 4 Top up oil in small and wait u the oil has settled in the system. This prevents over filling.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se Changing the oil
NOTE
Catch the used oil, do not allow it to seep the ground. Dispose of according to the regulations! 5
Do not spill oil! Ensure leak tightness!
4 6 7 8
3 2 1
1 Switch the main switch OFF. 2 Open the enclosure, create access.
3 Position a suitable container beneath th drain.
4 Remove the cap from the oil filler neck.
5 Open the drain valve and allow the oil to out completely. Dispose of the lubricatin – Change the oil filter. Fig. 8-13: Lubricating oil system
[1]
Oil / water cooler
[2]
Oil temperature control valve
[3]
Oil Filter
[4]
Oil pump
[5]
Oil filler neck
[6]
Oil level indicator
[7]
Oil sump
[8]
Oil drain
6 Close the drain valve.
7 Top up the oil in small quantities and wa the oil has settled in the system. This prevents over filling. Oil capacity: s "Technical data". 8 Close the oil filler neck.
You're Reading a9Preview Close the enclosure. Unlock full access with a free trial. the oil filter Changing
Download With Free Trial
Oil can be drained via the oil drain. Fresh oil is topped up via the oil filler neck.
Where possible drain the oil while still warm so that it can flow out more easily.
WARNING Risk of scalding Risk of scalding by hot oil. ➯
Only change the oil when the compressor is stationary and depres-
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
1 Switch the main switch OFF.
1
2 Open the enclosure, create access.
2
3 Unscrew the old oil filter and dispose of. 4 Apply a thin film of oil to the seal of the new oil filter. 5 Screw the oil filter on by hand and tighten. Observe the instructions on the oil filter!
3
6 Tighten the oil filter by a further quarter turn.
5
4
7 Close the enclosure.
8.6.6
Ejector vent system
Function check / adjust vacuum pressure
6 7
5 4
8
Fig. 8-16: Ejector vent system
3
[1]
Suction regulator
[2]
Blow-off valve
You're Reading a Preview 2
Unlock full access[3] with a free trial. Maintenance unit
1
[4]
Control air filter
[6]
Solenoid valve Y1
[7]
Solenoid valve Y2
Download With Trial pressure sensor [5] Free Vacuum
Fig. 8-15: Ejector vent system, schematic diagram
[8]
Shuttle valve
[1]
Second stage condensate separator (aftercooler water separator)
[9]
Ultra-fine filter
[2]
Compressed air connection ejector vent system
[3]
Solenoid valve Y3
1 Switch the main switch OFF. Sign up to vote on this title 2 Open the enclosure,Not create access. Useful useful
[4]
Maintenance unit (water separator,
3 Switch the main switch ON. 4 Press the start button < I >.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se 7 Adjust the pressure regulator so that -5 mbar is displayed on the vacuum pressure sensor.
4 Unscrew the filter holder with the filter e
8 Close the enclosure.
6 Take off the filter element.
5 Take off the guide plate and housing se
7 Undo the knurled screw and demount th deflector in the casing bottom.
NOTE The vacuum created in the oil system depends on the flow velocity in the vacuum generator. Hence the vacuum cannot be exactly preset via the pressure regulator. The described adjustment is adequate for fault-free operation.
8 Clean the casing bottom and float defle ing mild cleaning agent and then blow-o compressed air.
WARNING
Changing the filter element of the maintenance unit
Risk of injury Risk of injury to the eyes. ➯
1 2 6 7 8 9
3
Wear safety glasses.
9 Insert the float detector in the casing bo and tighten using the knurled screw. 10 Insert a new filter element.
11 Position the guide plate and casing sea
4
12 Screw in filter holder with the filter elem
5
13 Screw the casing bottom on hand-tight. 14 Close the enclosure.
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Fig. 8-17: Ejector vent system
[1]
Suction regulator
[2]
Blow-off valve
[3]
Maintenance unit
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
8
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
Replacing the ultra-fine filter element
Replacing solenoid valve Y3
1 2 6 7 8 9
3 4 5
1
Fig. 8-18: Ejector vent system
Fig. 8-19: Solenoid valve Y3
You're Reading a Preview
[1]
Suction regulator
[1]
Second stage condensate separator (aftercooler water separator) Unlock full access with a free trial.
[2]
Blow-off valve
[3]
Maintenance unit
[4]
Control air filter
[5]
Vacuum pressure sensor
[6]
Solenoid valve Y1
The solenoid valve Y3 in the ejector vent syste must be changed regularly.
[7]
Solenoid valve Y2
1 Switch the main switch OFF.
[8]
Shuttle valve
2 Open the enclosure, create access.
[9]
Ultra-fine filter
3 Undo the electrical connections from the noid valve. Sign up to vote on this title 4 Demount the solenoid from the valve b useful Useful Notcoil
[2]
Download With Trial valve Y3 [3] Free Solenoid
The ultra-fine filter element in the ejector vent system must be changed regularly. 1 Switch the main switch OFF.
Compressed air connection
5 Demount the valve body.
6 Fit new valve bodies. When doing so use t
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes ASC 100-D CompAir 5437 Air
Save
Embed
Share
Print
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se 8.6.7
Refill cooling water
Cooling system
Checking the fill level 3 3
A
I I
5
W
5
W
I
3 2
I 2
4
O
4
O
3
A
O
O 1 1
6 7
Fig. 8-21: Internal cooling water system Fig. 8-20: Internal cooling water system
[A]
To the water/air cooler
[A]
To the water/air cooler
[B]
From the water/air cooler
[B]
From the water/air cooler
[1]
Water pump
[1]
Water pump
[2]
Temperature control valve
[2]
Temperature control valve
[3]
Water/air cooler
[3]
Water/air cooler
[4]
Expansion line
[5]
Expansion line You're Reading a[4] Preview [5]
Expansion tank with level sensor
Expansion tank with level sensor
[6]
Cooling water drain
[6]
Cooling water drain
[7]
Oil / water cooler
[7]
Oil / water cooler
Unlock full access with a free trial.
Download With Free Trial
The fill level should be checked approximately 10 minutes after switching the compressor off, then the cooling water will have settled in the system. 1 Switch the main switch OFF. 2 Open the enclosure, create access. 3 Check the cooling water level at the level indicator on the expansion tank. The fill level must be between the "min." and "max." markings.
NOTE
The mixing ratio of the cooling water is 33 col (Havoline XLC ethylene glycol (basis) 67% water.
WARNING
Sign up to vote on this title Risk of scalding Not useful Useful
Risk of scalding due to escaping h cooling water.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
8
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
4 Top up with cooling water until the required filling level is reached. Top up cooling water in small quantities and wait until the cooling water has settled in the system. This prevents over filling. 5 Fit the cap on the expansion tank. 6 Close the enclosure.
Filling with cooling water 1 Remove the cap from the expansion tank.
2 Top up with cooling water until the required ing level is reached. Top up cooling water in small quantities an wait until the cooling water has settled in system. This prevents over filling. 3 Fit the cap on the expansion tank.
Changing the cooling water
4 Switch the main switch ON. 3
5 Press the start button < I >. Let the compressor run for approximately 5 minutes under load until the cooling water been distributed around the system.
A I
4
O
6 Press stop button< O >.
5
7 Check the fill level.
W
8 Top up with cooling water, if necessary.
I
3 2
9 Close panel
O
Cleaning the dirt trap 6
1 7
1
2 3
Fig. 8-22: Internal cooling water system
You're Reading a Preview
[A]
To the water/air cooler
Unlock full access with a free trial.
[B]
From the water/air cooler
[1]
Water pump
[2]
Temperature control valve
[3]
Water/air cooler
[4]
Expansion line
[5]
Expansion tank with level sensor
[6]
Cooling water drain
[7]
Oil / water cooler
Download With Free Trial
The cooling water can be drained via the cooling water drain. Fresh cooling water is topped up via the expansion tank.
Sign up to vote on this title
[1]
Useful
Safety valve
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se Cleaning the dirt trap
8.6.9
Air Filter
WARNING Risk of scalding Risk of scalding due to escaping hot cooling water. ➯
Only open the cap of the expansion tank once the internal cooling water system has cooled sufficiently.
➯
Carefully open the cap and let any pressure leak out.
➯
Only then should the cap be completely opened.
WARNING Legionella contamination Health risk with open cooling systems. ➯
Constant testing of the water quality in the cooling circuit for the number of microbes.
1 Switch main switch OFF and secure to prevent restarting.
Fig. 8-23: Air Filter
[1]
Air Filter
[2] Air filter cap 2 Isolate the cooling water supply and outlet.Reading a Preview You're [3] Filter element (fitted) 3 Open the enclosure, create access. Unlock full access with a free trial.
The compressor is equipped with an air filt air filter is used to filter the inlet air. The co 5 Carefully release the cover of the dirt trap (2). With Free Trial Download of the air filter must be checked by regular 6 Catch the escaping coolant. inspections. 7 Clean the dirt trap sieve. Moreover the air filter must be changed, if 4 Preposition a capture container.
9 Close the enclosure.
message [Service due] or [Air Filter] is dis on the electronic control unit.
10 Re-open the cooling water supply and outlet.
Checking the air filter
11 Check for leaks.
1 Switch thetomain switch OFF. Sign up vote on this title 2 Open the enclosure, create access. Useful Not useful
8 Fit the dirt trap sieve.
3 Demount the air filter cover. 4 Check the filter element.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
Replace the air filter element
Replacing the filter element of the control a filter
NOTICE 1
Material damage
2
Operation of the compressor without air filters, even briefly, can result in considerable damage to the compressor. ➯
Never operate the compressor without an air filter.
3
➯
No dirt must get into the clean air side of the air filter!
5
4
1 Switch the main switch OFF. 2 Open the enclosure, create access. 3 Demount the air filter cover. 4 Change the filter element. 5 Fit the air filter cover. 6 Close the enclosure.
8.6.10
Control air filter
The control air filter removes moisture and solid bodies from the control air system.
You're Reading [1]a Preview Suction regulator Blow-off Unlock full access[2] with a free trial. valve [3]
Maintenance unit
[4] Free Control Download With Trial air filter [5]
Vacuum pressure sensor
[6]
Solenoid valve Y1
[7]
Solenoid valve Y2
[8]
Shuttle valve
[9]
Ultra-fine filter
Sign up to vote on this title 1 Switch the main switch OFF. Useful Not useful 2 Open the enclosure, create access. 3 Unscrew the casing bottom.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Se 10 Screw the casing bottom on hand-tight. 11 Close the enclosure.
8.6.11
11 Insert the plug in the drive. Function check of the lubricator
Drive motor / Lubricator
The drive motor is fitted with an automatic motor lubrication system. Maintenance of the motor lubrication system is limited to replacement of the grease cartridges. Empty grease cartridges or a fault on the lubricator is indicated on the compressor electronic control unit by means of a message [Warning: Mot.lubr. sys] (also refer to the operating instructions of the electronic control unit).
1 2
Replacing a grease cartridge 1 2 3 4
Fig. 8-25: Lubricator display elements
[1]
Function display (2 LEDs)
[2]
"TIME" switch
[3]
Plug connection
You're Reading a[4] Preview "VOL" switch Unlock full access with trial.the function using the LEDs. 1 a free Check
LED
Signal
Green
Continuous signal OK. “Sy ning”.
Red
Continuous signal Dispensing < 30 seconds process
Download With Free Trial Fig. 8-24: Lubricator
[1]
Cable with plug
[2]
Lubricator drive
[3]
Grease cartridge
[4]
Drive motor
1 Switch the main switch OFF. 2 Open the enclosure, create access.
Red
Explana
Continuous signal Error/Fault > 30 seconds Sign up to vote on this title Green Continuous signal Grease ca Useful Not useful empty, cha and red Chart 8-7: LEDs
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
8
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Maintenance and Service
8.6.12
Control system
Testing the Emergency-stop pushbutton
[1]
Touchscreen display
[2]
Start button < I >
[3]
Stop button< O >
[4]
Red LED Slow flashing: Warning Fast flashing: Fault
[5]
Yellow LED Slow flashing: Maintenance necessary
[6]
Green LED Lit up permanently: System in operation Flashing: System on standby
[7]
Pushbutton
NOTE
You're Reading a Preview
Unlock full access with a free trial.
With Free Trial The Emergency-stop function must only Download be activated in dangerous situations. Otherwise the result could be increased wear or even damage to the compressor. Only test the Emergency-stop pushbutton when the compressor is at a standstill. 1 Press stop button< O >. – The electronic control unit status message is [Ready to Start]. 1 Press the pushbutton.
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen
9
APPENDIX
9.1
Shutdown
9.3
Removal WARNING
Routine shutdown
Harmful to health
Routine shutdowns are for example shutdowns for maintenance work.
Risk of damage to health due to o ing fluids and additives
1 Switch main switch OFF and secure to prevent switching back on.
Lubricants and additives may cau reparable damage to the health, tr allergies or irritate the mucous me brane.
2 Close the shut-off valves between the compressor and compressed air network. 3 Depressurise the aftercooler by careful opening of the air vent valve.
➯
When handling lubricants and ditives, always observe the valid operating instructions/ha ardous substance data sheets
➯
Avoid direct contact with lubric and additives. Wear personal tective equipment!
➯
Where injuries occur in which cants and additives are involve consult a doctor and name the stances involved. Have the hazardous substanc sheet readily available.
Shutdown for a longer period For shutdowns longer than six months, contact Gardner Denver. Final shutdown To prevent restarting of the compressor or misuse by unknown parties, the compressor must be rendered unusable. The compressor is rendered unusable by removal of the electronic control unit. Contact Gardner Denver for advice.
9.2
You're Reading a Preview CAUTION
Lubricants and additives
Unlock full access with a free trial. Risk of slipping The compressor contains approximately 20 litres Risk of slipping due to escaped op of oil for lubricating the gearbox and the bearings Download With Free Trialing fluid of the airend unit. ➯ Immediately clear up any oper The drive motor lubricator contains two grease fluid that has escaped. cartridges. ➯
The internal water circuit contains a water-glycol mixture (approximately 70% water and 30% glycol). Safety data sheets When handling operating fluids and additives, the corresponding safety data sheets must be observed.
Avoid direct contact with ope ing fluids. Wear personal prote equipment!
Preconditions Sign up to vote on this title The compressor is out of service. Useful Not useful
– The compressor is switched to a state.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
Demounting the power supply
3 Unscrew lubricator (grease cartridge with d and cover) from the lubricating point.
DANGER
4 Close the lubricating point. 5 Close the enclosure.
Electric shock Life-threatening electric shock ➯
Demounting the air filter
Work on the electrical equipment must only be carried out by authorised electricians or electrical technicians.
1 Disconnect the power supply cable, see the wiring diagram. 2 Remove the power supply cable. 3 Attach plugs to the power supply cable openings.
1 Demount all filter elements and filter mats. pose of filter elements and filter mats. – Air filter cartridge – Filter mat
– Inlet filter cooling air switch cabinet (on compressors) – Control air filter
9.4
Disposal
Demounting the pipelines
General
1 Disconnect the compressed air connection.
The compressor must be dismantled and strip down by specialised personnel. The applicabl cal safety and environmental protection regula tions must be adhered to when doing this.
2 Disconnect the condensate drain pipes. 3 Allow the condensate to drain away completely. 4 Immediately clear up any condensate that has escaped. Draining the cooling water 1 Open the enclosure, create access.
When disposing of substances harmful to hea the instructions of the corresponding safety da sheets must be observed.
You're Reading a Preview Packaging material, cleaning agents and used
residual lubricants must be delivered to a recy full access with a free trial. 2 Position a suitable container beneath Unlock the coolcentre in accordance with the regulations valid ing water drain. the place of use. 3 Open the drain valve and allow the cooling wa- With Free Trial Download WEEE-Directive ter to flow out completely. Dispose of the cooling water. In accordance with the WEEE directive (2002 4 Close the drain valve. 5 Close the enclosure. Draining the lubricating oil 1 Open the enclosure, create access. 2 Position a suitable container beneath the oil drain. 3 Open the drain valve and allow the oil to flow
EC), Gardner Denver undertakes to support th recovery and reuse of electrical and electronic vices. Contact Gardner Denver for advice.
Disposal Sign up to vote on this title The compressor should be stripped down into useful "according Useful Not disposal component parts to permit material composition", for example into base m als, plastics, textile products.
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Upload
Sign In
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes ASC 100-D CompAir 5437 Air
Save
Embed
Share
Print
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen Material / substance
Disposal type Recycling
Metals
x
Cable
x
Seals
Landfill
Hazardous waste
x
Plastics
x1
x
Filters
x
Operating fluids
x2
Chart 9-1: Substances and materials used and their dis posal
1 2
Where possible Disposal according to the safety data sheet or manufacturer's information
9.5
Limit values of dissolved matter NOTE
The following data are guidelines, which may deviate under certain operating conditions. The ove You'reare Reading Preview No guarantee claims can be mad composition and the operating temperature alwaysa decisive. based on the data. Unlock full access with a free trial.
Dissolved matter / specific values pH value (at 25 °C / 77 °F) Carbonate hardness
Circulating water
Download With Free Trial CaCO3
Total hardness
Through-flow
6-9
6-9
< 100 mg/l (5.6 °dH)
< 50 mg/l (2.8
< 2 mmol/l < 200 ppm < 11.5 °dH < 20 °fH
Chloride
Cl-
Sulfate
SO42-
< 0,5 mmol/l < 50 ppm < 2.8 °dH < 5 °fH Sign up to vote on this
Nitrate
NO3-
< 100 mg/l
< 100 mg/l
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
Dissolved matter / specific values Ammonia
NH3
Conductivity
Circulating water
Through-flow wa
0
0
> 50 < 800 µS/cm
> 50 < 200 µS/cm
Chart 9-2: Limit values of dissolved matter
9.6
Technical Specification
9.6.1
D75 + D90, 50Hz, air-cooled "A" and water-cooled "W" (European version)
D75 + D90,
D75
D90
50Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
Minimum operating pressure
[bar]
Ambient temperature
[°C]
2 / 45
2 / 40
2 / 45
Volume flow
[m3/min]
12.91
10.63
15.65
After cooler outlet temperature above ambient temperature
"A" [°C]
7
8
Aftercooler outlet temperature above ambient temperature
"W" [°C]
7
8
Sound pressure level (ISO 2151)
"A" [dB(A)]
75
74
76
"W" [dB(A)]
72
70
73
Sound pressure level (ISO 2151) Rated output drive motor
8,0
10,0 4,0
You're Reading a Preview
Unlock full access with a free trial.
[kW]
Total current consumption during load operation Download[A] With Free Trial (400V) Electric motor
8,0
75
90
175
199
IP55 (IE3) - IEC 60034-2-1 ECA Qualifying
Rated speed drive motor
[rpm]
Rated output fan motor
[kW]
Rated output oil pump
[kW]
Rated output cooling water pump
[kW]
2970 {"A" = 2 x 1.25 (IP54)} ; {"W" = 1 x 1.1 (IP54)} Sign up to vote on this title 0.55 (IP54) useful Useful Not 0.75 (IP54)
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D75 + D90,
D75
D
50Hz, air-cooled "A" and water-cooled "W" (European version) Cooling water outlet temperature, external
[°C]
57
Max. cooling water pressure, external
[bar]
8
Cooling water connections
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
[l]
24
Compressed air connection
Flange EN 1092-1 / 13 B1 / DN80x8 / PN16
Condensate drain
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
"A"= 3023 ; "W"=3223
"A"=322 "W"=34
2597 x 1744 x 2001
Chart 9-3: Technical data; D75 + D90 , 50Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.2
D110 + D132, 50Hz, air-cooled "A" and water-cooled "W" (European vers
D110 + D132,
D110
D1
50Hz, air-cooled "A" and water-cooled "W" (European version)
You're Reading a Preview
Maximum operating pressure Minimum operating pressure Ambient temperature
[bar]
Unlock full access with a free trial.
8,0
10,0
[bar]
8,0 4,0
[°C]Free Trial 2 / 45 Download With
2 / 40
2 / 45
19.51
17.39
22.39
Volume flow
[m3/min]
After cooler outlet temperature above ambient temperature
"A" = [°C]
9
7
11
Aftercooler outlet temperature above ambient temperature
"W" = [°C]
8
8
7
Sound pressure level (ISO 2151) Sound pressure level (ISO 2151)
Sign up 77 to vote on this "A" [dB(A)] 77 title useful Useful75 Not74 "W" [dB(A)]
Rated output drive motor
[kW]
110
78 77 1
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 + D132,
D110
D132
50Hz, air-cooled "A" and water-cooled "W" (European version) Recommended fuse rating (time-delayed)
[A]
6 x 160
Cooling air volume flow
[m3/min]
Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
Cooling water volume, external (@ΔT=15K)
[l/min]
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
Cooling water pressure
[bar]
8
("A" = 338) ; ("W" = 85) "A" = 22 120 / 40 [35 °C / 45 °C]
Weight
120 / 85 [35 °C / 40 °C]
110 / 25 [35 °C / 45 °C]
132 @Δp=1.0 bar
[l]
155 @Δp=1
24
You're Reading a Preview
Flange EN 1092-1 / 13 / B1 / DN80x8 / PN16
Unlock full access with a free trial.
5 x G1/2"
[kg]
"A"=3265 ; Download With Free Trial "W"=3465
Dimensions L x B x H
[mm]
"A"=3432 ; "W"=3632
2597 x 1744 x 2001
Chart 9-4: Technical data; D110 + D132 , 50Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.3
D160, 50Hz, air-cooled "A" and water-cooled "W" (European version)
D160 ,
D160
Sign up to vote on this title
50Hz, air-cooled "A" and water-cooled "W" (European version)
M
i
ti
110 [35 40
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
Condensate drain
"A" = 2
"A" = 30 ; "W" = 20
Cooling water connections
Compressed air connection
6 x 20
[b ]
Useful
Not useful 10 0
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160 ,
D160
50Hz, air-cooled "A" and water-cooled "W" (European version)
Rated output drive motor
[kW]
160
Total current consumption during load operation (400V)
[A]
340
Electric motor
IP55 (IE3) - IEC 60034-2-1 ECA Qualifying
Rated speed drive motor
[rpm]
2970
Rated output fan motor
[kW]
{"A" = 2 x 3.2 (IP54)} {"W" = 1 x 1.1 (IP54)}
Rated output oil pump
[kW]
0.55 (IP54)
Rated output cooling water pump
[kW]
0.75 (IP54)
Recommended cable cross-section (400V)
[mm2]
Recommended fuse rating (time-delayed)
[A]
Cooling air volume flow
[m3/min]
Cooling air outlet temperature above ambient temperature
[°C]
2 x 3 x 95 PE95 6 x 250 ("A" = 338) ; ("W" = 8 "A" = 27
You're Reading a Preview "A" [Pa]
90 / 50 [35 °C / 40 °C
Unlock full access[l]with a free trial.
"A" = 30 ; "W" = 20
Residual pressure at ambient temperature Coolant volume, internal
Cooling water volume, external (@ΔT=15K)
[l/min]
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
Cooling water pressure
[bar]
8
Download With Free Trial
Cooling water connections Total oil quantity Compressed air connection
[l]
170 @Δp=1.3 bar
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4) Sign up to vote on this title 24 Not useful Useful Flange EN 1092-1 / 13 B1 / DN80x8 / PN16
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
9
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 RS,
D110 RS
D110 R
50Hz, air-cooled "A" and water-cooled "W" (European version) Ambient temperature
[°C]
2 / 45 min speed
2 / 40
max. speed
min speed
spe
Volume flow rate / final pressure [bar]
[m3/min]
9,06 / 6
19.42 / 6 10.77 / 6 17
Volume flow rate / final pressure [bar]
[m3/min]
8,97 / 7
19.37 / 7 10.764 / 8
Volume flow rate / final pressure [bar]
[m3/min]
8.89 / 8
19.32 / 8
After cooler outlet temperature above ambient temperature
"A" [°C]
8
7
Aftercooler outlet temperature above ambient temperature
"W" [°C]
7
8
Sound pressure level (ISO 2151)
"A" [dB(A)]
76 / 78
76 / 78
Sound pressure level (ISO 2151)
"W" [dB(A)]
72 / 75
71 / 74
Rated output drive motor
[kW]
Total power consumption during load operation (380V / 400V)
[A]
17.4
10.51 / 10
17.
110 262 / 249
You're Reading a Preview
Electric motor Rated speed drive motor Rated output fan motor
Unlock full access with a free trial.
[rpm]
Download With Free Trial
IP55 (IE3) - IEC 60034-2-1 ECA Qualifying
1909 / 3600
2417 / 36
[kW]
{"A" = 2 x 3.2 (IP54)} ; {"W" = 1 x 1.1 (IP54)}
Rated output oil pump
[kW]
0.55 (IP54)
Rated output cooling water pump
[kW]
0.75 (IP54)
Recommended cable cross-section (380V + 400V)
[mm2]
3 x 95 PE50
Recommended fuse rating (time-delayed) (380V + 400V)
[A]
Cooling air volume flow
[m3/min]
Sign up to vote on this title x 300 Useful Not3useful
("A" = 338) ; ("W" = 85)
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D110 RS,
D110 RS
D11
50Hz, air-cooled "A" and water-cooled "W" (European version) Cooling water connections
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
[l]
24
Compressed air connection
Flange EN 1092-1 / 13 B1 / DN80x8 / PN16
Condensate drain
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
"A"=3278 ; "W"=3478 2597 x 1744 x 2001
Chart 9-6: Technical data; D110 RS, 50Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.5
D132 RS, 50Hz, air-cooled "A" and water-cooled "W" (European version)
D132 RS,
D132 RS
D13
50Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
8,0
10
Minimum operating pressure
[bar]
4,0
4
Ambient temperature
[°C]a Preview You're Reading
2 / 45
Unlock full access with a free trial. min
max. speed
speed
2 / 40 min speed
Volume flow rate / final pressure [bar]Download With [m3/min] Free Trial 9.13 / 6
22.82 / 6 10.81 / 6
Volume flow rate / final pressure [bar]
[m3/min]
9.03 / 7
22.75 / 7 10.66 / 8
Volume flow rate / final pressure [bar]
[m3/min]
8.95 / 8
22.68 / 8
After cooler outlet temperature above ambient temperature
"A" = [°C]
Aftercooler outlet temperature above ambient temperature
"W" = [°C]Sign up to vote8on this title Useful Not useful
Sound pressure level (ISO 2151)
"A" [dB(A)]
10.51 / 10
12
77 / 79
1
77
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D132 RS,
D132 RS
D132 R
50Hz, air-cooled "A" and water-cooled "W" (European version) Recommended cable cross-section (380V + 400V)
[mm2]
3 x 120 PE70
Recommended fuse rating (time-delayed) (380V + 400V)
[A]
Cooling air volume flow
[m3/min]
Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
"A" = 30 ; "W" = 20
Cooling water volume, external (@ΔT=15K)
[l/min]
155 @Δp=1.2 bar
Cooling water inlet temperature
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature
[°C]
57
Cooling water pressure
[bar]
8
3 x 300 ("A" = 338) ; ("W" = 85) "A" = 26 110 / 25 [35 °C / 45 °C]
Cooling water connections
110 / 80 [35 °C / 40 °C]
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
You're Reading a Preview [l]
24
Compressed air connection
Unlock full access with a free trial.
Flange EN 1092-1 / 13 / B1 / DN80x8 / PN16
Condensate drain
Download With Free Trial
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
"A"=3476 ; "W"=3676 2597 x 1744 x 2001
Chart 9-7: Technical data; D132 RS, 50Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.6
D160 RS, 50Hz, air-cooled "A" and water-cooled "W" (European version)
D160 RS, 50Hz, air-cooled "A" and water-cooled "W" (European version)
Sign up to vote onD160 this title RS
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160 RS,
D160 RS
50Hz, air-cooled "A" and water-cooled "W" (European version) Aftercooler outlet temperature above ambient temperature
"W" = [°C]
9
Sound pressure level (ISO 2151)
"A" [dB(A)]
77 / 79
Sound pressure level (ISO 2151)
"W" [dB(A)]
73 / 78
Rated output drive motor
[kW]
Total power consumption during load operation (380V / 400V)
[A]
160 304 / 289
Electric motor
IP55 (IE3) - IEC 60034-2-1 ECA Qualifying
Rated speed drive motor
[rpm]
1687 / 3320
Rated output fan motor
[kW]
{"A" = 2 x 3.2 (IP54)} {"W" = 1 x 1.1 (IP54)}
Rated output oil pump
[kW]
0.55 (IP54)
Rated output cooling water pump
[kW]
0.75 (IP54)
Recommended cable cross-section (380V + 400V)
[mm2]
3 x 150 PE95
You're Reading Recommended fuse rating (time-delayed) (380V [A] a Preview + 400V) Cooling air volume flow
Unlock full access with a free trial.
[m3/min]
Cooling air outlet temperature above ambient [°C]Free Trial Download With temperature
6 x 355 ("A" = 338) ; ("W" = 8 "A" = 26
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
"A" = 30 ; "W" = 20
Cooling water volume, external (@ΔT=15K)
[l/min]
170 @Δp=1.3 bar
Cooling water inlet temperature, external
[°C]
Cooling water outlet temperature, external
[°C]
Cooling water pressure
[bar]
Cooling water connections
90 / 50 [35 °C / 40 °C
min. = 5 ; max. = 42 Sign up to vote on this title 57 Useful Not useful 8 EN 10226 1 1/4 Rp 1
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
9.6.7
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (European version)
D75 + D90,
D75
D90
60Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
8,0
10,0
8,0
Minimum operating pressure
[bar]
Ambient temperature
[°C]
2 / 45
2 / 40
2 / 45
Volume flow
[m³/min]
12.39
10.85
15.92
After cooler outlet temperature above ambient temperature
"A" [°C]
Aftercooler outlet temperature above ambient temperature
"W" [°C]
Sound pressure level (according to ISO 2151)
4,0
7
8
6
7
7
"A" [dB(A)]
76
75
77
Sound pressure level (according to ISO 2151)
"W" [dB(A)]
73
71
74
Rated output electric motor
[kW]
Total power consumption during load operation (380V / 460V)
[A]
75
90
198 / 152
Electric motor
225 / 17
IP55 , EISA 2007 (IE3)
Rated speed
You're Reading [rpm] a Preview
3560
Rated output fan motor
[kW]with a free trial. Unlock full access
{"A" = 2 x 1.4 (IP54)} ; {"W" = 1 x 1.8 (IP54)}
Rated output oil pump
Download[kW] With Free Trial
0.66 (IP-54)
Rated output cooling water pump
[kW]
Recommended cable cross-section (380V / 460V)
[mm²]
Recommended fuse rating (time-delayed) (380V + 460V)
[A]
Cooling air volume flow
[m³/min]
Cooling air outlet temperature above ambient temperature
[°C]
1.1 (IP-54) 3 x 95 PE50 / 3 x 50 PE25 3 x 250 / 3 x 160
3 x 95 PE50 3 x 70 PE35 3 x 250 / 3
Sign up to ("A" vote = on225) this title ; ("W" = 95)
Useful Not useful "A"=19
"A"=23
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D75 + D90,
D75
D
60Hz, air-cooled "A" and water-cooled "W" (European version) Total oil quantity
[l]
24
Compressed air connection
Flange EN 1092-1 / 13 B1 / DN80x8 / PN16
Condensate drain
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
"A"=3023 ; "W"=3223
"A"=322 "W"=34
2597 x 1744 x 2001
Chart 9-9: Technical data; D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.8
D110 + D132, 60Hz, air-cooled "A" and water-cooled "W" (European vers
D110 + D132,
D110
D1
60Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
Minimum operating pressure
[bar]
Ambient temperature
[°C]
Volume flow
8,0
10,0
8,0 4,0
2 / 45
2 / 40
2 / 45
[m³/min] You're Reading a Preview 18.99
16.89
22.59
After cooler outlet temperature aboveUnlock ambient full access"A" with[°C] a free trial. temperature
9
7
11
Aftercooler outlet temperature above Download ambient "W"Free [°C] Trial With temperature
7
8
8
Sound pressure level (according to ISO 2151)
"A" [dB(A)]
78
78
78
Sound pressure level (according to ISO 2151)
"W" [dB(A)]
76
75
78
Rated output electric motor
[kW]
Total power consumption during load operation (380V / 460V)
[A]
[rpm]
1
291 / 227 Sign up to vote on this title
Electric motor Rated speed
110
Useful
331
Not ,useful IP55 EISA 2007 (IE3 3560
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 + D132,
D110
D132
"A"=22
"W"=2
60Hz, air-cooled "A" and water-cooled "W" (European version) Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
Cooling water volume, external (@ΔT=15K)
[l/min]
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
Cooling water pressure
[bar]
8
120 / 40 [35 °C / 45 °C]
120 / 85 [35°C / 40°C]
110 / 25 [35°C / 45°C]
"A" = 30 ; "W" = 20 132 @Δp=1.0 bar
Cooling water connections
155 @Δp=1
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
[l]
24
Compressed air connection
Flange EN 1092-1 / 13 / B1 / DN80x8 / PN16
Condensate drain
5 x G1/2"
You're Reading [kg] a Preview "A"=3265 ;
Weight Dimensions L x B x H
Unlock full access with a free trial.
[mm]
"A"=3432 ; "W"=3632
"W"=3465
2597 x 1744 x 2001
Chart 9-10: Technical data; D110 + D132, 60Hz, air-cooledWith "A" and water-cooled "W" (European version) Download Free Trial
9.6.9
110 [35°
D160, 60Hz, air-cooled "A" and water-cooled "W" (European version)
D160,
D160
60Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
Minimum operating pressure
[bar]
Ambient temperature
[°C]
10,0 Sign up to vote on this title 4,0 Useful Not useful 2 / 40
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160,
D160
60Hz, air-cooled "A" and water-cooled "W" (European version) Rated speed
[rpm]
3560
Rated output fan motor
[kW]
{"A" = 2 x 3.9 (IP54)} {"W" = 1 x 1.8 (IP54)}
Rated output oil pump
[kW]
0.66 (IP-54)
Rated output coolant pump
[kW]
1.1 (IP-54)
Recommended cable cross-section (380V / 460V)
[mm²]
Recommended fuse rating (time-delayed)
[A]
Cooling air volume flow
[m³/min]
Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
"A" = 30 ; "W" = 20
Cooling water volume, external (@ΔT=15K @Δp=0.7 bar)
[l/min]
170 @Δp=1.3 bar
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
2 x 3 x 95 PE95 / 2 x 3 x 70 6 x 250 / 6 x 200 ("A" = 349) ; ("W" = 95 "A"=27 90 / 50 [35 °C / 40°C
You're Reading a Preview
Cooling water pressure Cooling water connections Total oil quantity
Unlock full access with a free trial.
[bar]
Download With Free Trial [l]
8 EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4) 24
Compressed air connection
Flange EN 1092-1 / 13 B1 / DN80x8 / PN16
Condensate drain
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
Sign up to vote"A"=3644 on this title, "W"=3844
Useful
Not useful x 1744 x 2001 2597
Chart 9-11: Technical data; D160, 60Hz, air-cooled "A" and water-cooled "W" (European version)
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
9
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 RS,
D110 RS
D110 R
60Hz, air-cooled "A" and water-cooled "W" (European version) Volume flow rate / final pressure [bar]
[m³/min]
8,97 / 7
19.37 / 7 10.64 / 8 17
Volume flow rate / final pressure [bar]
[m³/min]
8.89 / 8
19.32 / 8
After cooler outlet temperature above ambient temperature
"A" [°C]
8
7
Aftercooler outlet temperature above ambient temperature
"W" [°C]
7
8
Sound pressure level (according to ISO 2151) at 70% load / 100% load
"A" [dB(A)]
76 / 78
76 / 78
Sound pressure level (according to ISO 2151) at 70% load / 100% load
"W" [dB(A)]
73 / 76
72 / 75
Rated output electric motor
[kW]
Total power consumption during load operation (380V / 460V)
[A]
10.51 / 10
17.
110 264 / 200
Electric motor
264 / 19
IP55 , EISA 2007 (IE3)
Rated speed min. / max.
[rpm]
1909 / 3600
Rated output fan motor
You're Reading a Preview
{"A" = 2 x 3.9 (IP54)} ; {"W" = 1 x 1.8 (IP54)}
Rated output oil pump
Unlock full access [kW]with a free trial.
0.66 (IP-54)
Rated output coolant pump
[kW]
2417 / 36
[kW]
Download With Free Trial
Recommended cable cross-section (380V + 400V)
[mm²]
Recommended fuse rating (time-delayed) (380V + 400V)
[A]
Cooling air volume flow
[m³/min]
Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
1.1 (IP-54) 3 x 150 PE95 / 3 x 95 PE95 3 x 315 / 3 x 250 ("A" = 349) ; ("W" = 95)
"A"=22 Sign up to vote on this title
Useful Not useful 120 / 40 [35 120 / 85 [35 °C / 45 °C] °C / 40 °C]
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D110 RS,
D110 RS
D11
60Hz, air-cooled "A" and water-cooled "W" (European version) Condensate drain
5 x G1/2"
Weight
[kg]
Dimensions L x B x H
[mm]
"A"=3278 ; "W"=3478 2597 x 1744 x 2001
Chart 9-12: Technical data; D110 RS, 60Hz, air-cooled "A" and water-cooled "W" (European version)
9.6.11
D132 RS, 60Hz, air-cooled "A" and water-cooled "W" (European version)
D132 RS,
D132 RS
D13
60Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
8,0
10
Minimum operating pressure
[bar]
4,0
4
Ambient temperature
[°C]
2 / 45 min speed
2 / 40
max. speed
min speed
Volume flow rate / final pressure [bar]
[m³/min]
9.13 / 6
22.82 / 6 10.81 / 6
Volume flow rate / final pressure [bar]
[m³/min]
9.03 / 7
22.75 / 7 10.66 / 8
Volume flow rate / final pressure [bar]
[m³/min]
8.95 / 8
22.68 / 8
You're Reading a Preview
Unlock full access with a free trial.
10.51 / 10
After cooler outlet temperature above ambient "A" [°C] temperature Download With Free Trial
12
Aftercooler outlet temperature above ambient temperature
"W" [°C]
8
Sound pressure level (according to ISO 2151) at 70% load / 100% load
"A" [dB(A)]
77 / 79
77
Sound pressure level (ISO 2151) at 70% load / 100% load
"W" [dB(A)]
74 / 79
72
Rated output electric motor
[kW]
Total power consumption during load operation (380V / 460V)
[A]
Sign up to vote on this title 132 Useful Not useful 302 / 226
1
302
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D132 RS,
D132 RS
D132 R
60Hz, air-cooled "A" and water-cooled "W" (European version) Cooling air volume flow
[m³/min]
("A" = 349) ; ("W" = 95)
Cooling air outlet temperature above ambient temperature
[°C]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[l]
"A" = 30 ; "W" = 20
Cooling water volume, external (@ΔT=15K)
[l/min]
155 @Δp=1.2 bar
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
Cooling water pressure
[bar]
8
"A"=26 110 / 25 [35 °C / 45 °C]
Cooling water connections
EN 10226-1 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4)
Total oil quantity
[l]
24
Compressed air connection Condensate drain Weight
Flange EN 1092-1 / 13 / B1 / DN80x8 / PN16
You're Reading a Preview [kg]
Dimensions L x B x H
110 / 80 [35 °C / 40 °C]
Unlock full access with a free trial.
[mm]
5 x G1/2" "A"=3476 ; "W"=3676 2597 x 1744 x 2001
Chart 9-13: Technical data; D132 RS, 60Hz, air-cooled "A" and water-cooled "W" (European version)
Download With Free Trial
9.6.12
D160 RS, 60Hz, air-cooled "A" and water-cooled "W" (European version)
D160 RS,
D160 RS
60Hz, air-cooled "A" and water-cooled "W" (European version) Maximum operating pressure
[bar]
Minimum operating pressure
[bar]
Ambient temperature
[°C]
10,0 Sign up to vote on this title 4,0 Useful Not useful 2 / 40 min speed
max spe
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160 RS,
D160 RS
60Hz, air-cooled "A" and water-cooled "W" (European version) Sound pressure level (ISO 2151) at 70% load / 100% load
"A" [dB(A)]
Rated output drive motor
[kW]
Total power consumption during load operation (380V / 460V)
[A]
74 / 79 160 385 / 258
Electric motor
IP55 , EISA 2007 (IE3
Rated speed drive motor
[rpm]
1687 / 3320
Rated output fan motor
[kW]
{"A" = 2 x 3.9 (IP54)} {"W" = 1 x 1.8 (IP54)}
Rated output oil pump
[kW]
0.66 (IP54)
Rated output cooling water pump
[kW]
1.1 (IP54)
Recommended cable cross-section (380V + 460V)
[mm2]
Recommended fuse rating (time-delayed) (380V + 460V)
[A]
Cooling air volume flow
[m3/min]
3 x 185 PE95 / 3 x 150 P 3 x 400 / 3 x 315 ("A" = 349) ; ("W" = 9
You're Reading Cooling air outlet temperature above ambient [°C]a Preview temperature
Unlock full access with a free trial.
Residual pressure at ambient temperature Coolant volume, internal
"A" [Pa]
[l] Free Trial Download With
"A" = 29 90 / 50 [35 °C / 40 °C "A" = 30 ; "W" = 20
Cooling water volume, external (@ΔT=15K)
[l/min]
Cooling water inlet temperature, external
[°C]
min. = 5 ; max. = 42
Cooling water outlet temperature, external
[°C]
57
Cooling water pressure
[bar]
8
Cooling water connections Total oil quantity Compressed air connection
[l]
170 @Δp=1.3 bar
10226-1 Sign up to voteEN on this title 1/4 Rp 1 1/4 (DIN 2999-R 1 1/4) Useful Not useful 24 Flange EN 1092 1 / 13
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
9.6.13
D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
D75 + D90,
D75
D90
60Hz, air-cooled "A" and water-cooled "W" (USA version) Maximum operating pressure
[psig]
116
145
116
Minimum operating pressure
[psig]
Ambient temperature
[°F]
Volume flow
[cfm]
After cooler outlet temperature above ambient temperature
"A" [°F]
Aftercooler outlet temperature above ambient temperature
"W" [°F]
11
13
13
Sound pressure level (according to ISO 2151)
"A" [dB(A)]
76
75
77
Sound pressure level (according to ISO 2151)
"W" [dB(A)]
73
71
74
Rated output electric motor
[hp]
100
125
Total power consumption during load operation (460V / 575V)
[A]
152 / 128
173 / 15
58 36 / 113
36 / 104
36 / 113
438
383
562
13
Electric motor
36 /
15
IP55 , EISA 2007 (IE3)
Rated speed
You're Reading [rpm] a Preview
3560
Rated output fan motor
[hp] with a free trial. Unlock full access
{"A" = 2 x 1.9 (IP54)} ; {"W" = 1 x 2.5 (IP54)}
Rated output oil pump
Download[hp] With Free Trial
0.9 (IP-54)
Rated output cooling water pump
[hp]
Recommended cable cross-section (460V / 575V) Recommended fuse rating (time-delayed) (460V + 575V)
[A]
Cooling air volume flow
[cfm]
Cooling air outlet temperature above ambient temperature
[°F]
1.5 (IP-54) AWG 3/0 / AWG 2/0 (single supply)
AWG 4/0 / AW 3/0 (single sup
175 / 150
225 / 17
Sign up to vote on this ;title ("A" = 7946) ("W" = 3354)
Useful Not useful "A"=34
"A"=42
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D75 + D90,
D75
D
60Hz, air-cooled "A" and water-cooled "W" (USA version) Compressed air connection
Flange 3" ANSI B16.
Condensate drain
5 x 1/2 NPT
Weight
[lbs]
Dimensions L x B x H
[inch]
"A"=6665 ; "W"=7105
"A"=712 "W"=75
102.2 x 68.7 x 78.8
Chart 9-15: Technical data; D75 + D90, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
9.6.14
D110 + D132, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
D110 + D132,
D110
D1
60Hz, air-cooled "A" and water-cooled "W" (USA version) Maximum operating pressure
[psig]
Minimum operating pressure
[psig]
Ambient temperature
[°F]
Volume flow
[cfm]
116
145
116 58
36 / 113
36 / 104
36 / 113
671
596
798
After cooler outlet temperature above ambient "A" [°F] temperature You're Reading a Preview
20
1
Aftercooler outlet temperature aboveUnlock ambient full access"W" with[°F] a free trial. temperature
13
14
14
Sound pressure level (according to ISO 2151) With "A" Free [dB(A)] Download Trial
78
78
79
Sound pressure level (according to ISO 2151)
"W" [dB(A)]
76
75
78
Rated output electric motor
[hp]
150
Total power consumption during load operation (460V / 575V)
[A]
227 / 189
Electric motor Rated speed
[rpm]
Rated output fan motor
[hp]
1 257
IP55 , EISA 2007 (IE3 Sign up to vote on this title 3580 Useful Not useful {"A" = 2 x 5.3 (IP54)} {"W" = 1 x 2.5 (IP54)}
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 + D132,
D110
D132
60Hz, air-cooled "A" and water-cooled "W" (USA version) Residual pressure at ambient temperature
"A" [Pa]
120 / 40 [95 °F / 113 °F]
Coolant volume, internal
[gal]
Cooling water volume, external (@ΔT=15K)
[gal/min]
Cooling water inlet temperature
[°F]
min. = 41 ; max. = 107
Cooling water outlet temperature
[°F]
134
Cooling water pressure
[psig]
115
110 / 25 [95 °F / 113 °F]
35 @Δp=15psi
41 @Δp=1
1 1/4 - 11 1/2 NPT [gal]
6.4
Compressed air connection
Flange 3" ANSI B16.5
Condensate drain
5 x 1/2 NPT
Weight
[lbs]
Dimensions L x B x H
[inch]
"A"=7198 ; "W"=7639
"A"=7566 ; "W"=8007
102.2 x 68.7 x 78.8
Chart 9-16: Technical data; D110 + D132, 60Hz, air-cooled "A" and water-cooled "W" (USA version) You're Reading a Preview
9.6.15
110 [95 104
"A" = 8 ; "W" = 5.3
Cooling water connections Total oil quantity
120 / 85 [95°F / 104°F]
D160, 60Hz, air-cooled "A"Unlock and water-cooled "W" full access with a free trial.(USA version)
D160,
60Hz, air-cooled "A" and water-cooledDownload With Free Trial "W" (USA version)
D160
Maximum operating pressure
[psig]
145
Minimum operating pressure
[psig]
58
Ambient temperature
[°F]
Volume flow
[cfm]
After cooler outlet temperature above ambient temperature
"A" [°F]
Aftercooler outlet temperature above ambient
"W" [°F]
36 / 104
Sign up to vote on this796 title 20 Useful Not useful 14
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160,
D160
60Hz, air-cooled "A" and water-cooled "W" (USA version) Rated output oil pump
[hp]
0.9 (IP-54)
Rated output coolant pump
[hp]
1.5 (IP-54)
Recommended cable cross-section (460V / 575V)
AWG 4/0 / AWG 3/0 (double
Recommended fuse rating (time-delayed)
[A]
200 / 175
Cooling air volume flow
[cfm]
Cooling air outlet temperature above ambient temperature
[°F]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[gal]
Cooling water volume, external (@ΔT=15K)
[gal/min]
Cooling water inlet temperature
[°F]
min. = 41 ; max. = 10
Cooling water outlet temperature
[°F]
134
Cooling water pressure
[psig]
115
("A" = 12325) ; ("W" = 33 "A"=49 90 / 50 [95 °F / 104 °F "A" = 8 ; "W" = 5.3 45 @Δp=19psi
Cooling water connections
1 1/4 - 11 1/2 NPT
Total oil quantity
You're Reading a Preview [gal]
Compressed air connection
Unlock full access with a free trial.
Condensate drain Weight
Download With Free Trial [lbs]
Dimensions L x B x H
[inch]
6.4 Flange 3" ANSI B16. 5 x 1/2 NPT "A"=8034 ; "W"=8475 102.2 x 68.7 x 78.8
Chart 9-17: Technical data; D160, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
9.6.16
D110 RS, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
D110 RS,
D110 RS Sign up to vote on this title
60Hz, air-cooled "A" and water-cooled "W" (USA version) Maximum operating pressure
[psig]
Useful
D11
Not useful 116
1
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
9
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D110 RS,
D110 RS
D110 R
60Hz, air-cooled "A" and water-cooled "W" (USA version) Aftercooler outlet temperature above ambient temperature
"W" [°F]
13
14
Sound pressure level (according to ISO 2151)
"A" [dB(A)]
76 / 78
76 / 78
Sound pressure level (according to ISO 2151)
"W" [dB(A)]
73 / 76
72 / 75
Rated output electric motor
[hp]
Total current consumption during load operation (460V)
[A]
150 200
Electric motor
199
IP55 , EISA 2007 (IE3)
Rated speed min. / max.
[rpm]
1909 / 3600
Rated output fan motor
[hp]
{"A" = 2 x 5.3 (IP54)} ; {"W" = 1 x 2.5 (IP54)}
Rated output oil pump
[hp]
0.9 (IP-54)
Rated output cooling water pump
[hp]
1.5 (IP-54)
Recommended cable cross-section (380V + 400V)
MCM 250 (single supply)
Recommended fuse rating (time-delayed) (460V) [A] Cooling air volume flow
You're Reading a Preview [cfm]
225 ("A" = 12325) ; ("W" = 3354
Unlock full access with a free trial.
Cooling air outlet temperature above ambient temperature
[°F]
Download With Free Trial
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[gal]
Cooling water volume, external (@ΔT=15K)
[gal/min]
Cooling water inlet temperature, external
[°F]
Cooling water outlet temperature, external
[°F]
Cooling water pressure
[psig]
Cooling water connections
2417 / 36
"A"=47
120 / 40 [95 °F / 113 °F]
120 / 85 [95 °F / 104 °F
"A" = 8 ; "W" = 5.3 35 @Δp=15psi min. = 41 ; max. = 107 134 Sign up to vote on this title
Useful
115 Not useful 1 1/4 - 11 1/2 NPT
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen
9.6.17
D132 RS, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
D132 RS,
D132 RS
D13
60Hz, air-cooled "A" and water-cooled "W" (USA version) Maximum operating pressure
[psig]
116
1
Minimum operating pressure
[psig]
58
5
Ambient temperature
[°F]
36 / 113
36 / 10
min speed
max. speed
min speed
806 / 87
382 / 87
Volume flow rate / final pressure [psig]
[cfm]
322 / 87
Volume flow rate / final pressure [psig]
[cfm]
319 / 102 803 / 102 376 / 116
Volume flow rate / final pressure [psig]
[cfm]
316 / 116 801 / 116 371 / 145
After cooler outlet temperature above ambient temperature
"A" [°F]
21.5
1
Aftercooler outlet temperature above ambient temperature
"W" [°F]
14
1
Sound pressure level (according to ISO 2151) at 70% load / 100% load
"A" [dB(A)]
77 / 79
Sound pressure level (according to ISO 2151) at "W" [dB(A)] You're Reading a Preview 70% load / 100% load Rated output electric motor
74 / 79
Unlock full access[hp] with a free trial.
180
Total current consumption during load operation [A] Download With Free Trial (460V)
226
Electric motor
2
IP55 , EISA 2007 (IE3
Rated speed min. / max.
[rpm]
Rated output fan motor
[hp]
Rated output oil pump
[hp]
Rated output coolant pump
[hp]
Recommended cable cross-section (380V + 400V)
73
1550 / 3380
1559
{"A" = 2 x 5.3 (IP54)} {"W" = 1 x 2.5 (IP54)}
0.9 (IP-54) Sign up to vote on this title
Useful
1.5 (IP-54) Not useful
MCM 300 (single supply)
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D132 RS,
D132 RS
D132 R
60Hz, air-cooled "A" and water-cooled "W" (USA version) Cooling water outlet temperature, external
[°F]
134
Cooling water pressure
[psig]
115
Cooling water connections
1 1/4 - 11 1/2 NPT
Total oil quantity
[gal]
6.4
Compressed air connection
Flange 3" ANSI B16.5
Condensate drain
5 x 1/2 NPT
Weight
[lbs]
Dimensions L x B x H
[inch]
"A"=7663 ; "W"=8104 102.2 x 68.7 x 78.8
Chart 9-19: Technical data; D132 RS, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
9.6.18
D160 RS, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
D160 RS,
D160 RS
60Hz, air-cooled "A" and water-cooled "W" (USA version) Maximum operating pressure
[psig]
145
Minimum operating pressure
You're Reading a Preview
[psig]
58
Ambient temperature
[°F]
36 / 40
Unlock full access with a free trial.
min speed
max. spe
Volume flow rate / final pressure [psig] Download[cfm] With Free Trial 378 / 87
827 / 8
Volume flow rate / final pressure [psig]
[cfm]
373 / 116
823 / 1
Volume flow rate / final pressure [psig]
[cfm]
367 / 145
819 / 14
After cooler outlet temperature above ambient temperature
"A" [°F]
Aftercooler outlet temperature above ambient temperature
"W" [°F]
Sound pressure level (according to ISO 2151) at 70% load / 100% load
"A" [dB(A)]
18 16 Sign up to vote on this title
Useful
useful Not77 / 79
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
Download
ASC 100-D CompAir 5437 Air
1
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen D160 RS,
D160 RS
60Hz, air-cooled "A" and water-cooled "W" (USA version) Recommended cable cross-section (380V + 400V)
MCM 400 (single supply)
Recommended fuse rating (time-delayed) (460V) [A]
300
Cooling air volume flow
[cfm]
("A" = 12325) ; ("W" = 33
Cooling air outlet temperature above ambient temperature
[°F]
Residual pressure at ambient temperature
"A" [Pa]
Coolant volume, internal
[gal]
Cooling water volume, external (@ΔT=15K)
[gal/min]
Cooling water inlet temperature, external
[°F]
min. = 41 ; max. = 10
Cooling water outlet temperature, external
[°F]
134
Cooling water pressure
[psig]
115
"A"=52 90 / 50 [95 °F / 104 °F "A" = 8 ; "W" = 5.3 45 @Δp=19psi
Cooling water connections Total oil quantity
1 1/4 - 11 1/2 NPT [gal]
6,4
Compressed air connection
Flange 3" ANSI B16.
Condensate drain
You're Reading a Preview
5 x 1/2 NPT
Weight
Unlock full access[lbs] with a free trial.
"A"=8131 ; "W"=8572
Dimensions L x B x H
[inch]
Download With Free Trial
102.2 x 68.7 x 78.8
Chart 9-20: Technical data; D160 RS, 60Hz, air-cooled "A" and water-cooled "W" (USA version)
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
9
9.7
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
Installation plan D75-D160(RS)-A
141(A)
C
) G C ( 5 8 6
B
7 4 7 1
45(A)
680
543(D) 320 320
910 220
220
1 0 0 0 2 2 3 0 2 3
) B ( 5 7 9
2 ) 9 D ( 1 2 6 5
) B ( 0 7 1
173(D)
) E ( 0 ) 9 A 3 ( 2 0 0 1
X 1210(B) 317(B) 105(E)
1265(CG)
D
) E ( 5 5 1
92(E)
X ) G C ( 0 5 7
) C ( 8 7 5 1 ) C ( 3 8
4 4 7 1
) F ( 9 4 9 5 2 0 3 3 4
146 197
You're Reading a243(F) Preview
Unlock full access with a free trial.
71(C) 1390(C)
C
2599
Download With Free Trial
A
Sign up to vote on this title
F B
E
Useful
Not useful
D
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen
D75-D160(RS)-W
141(A)
C
) G C ( 5 8 6
B
7 4 7 1
45(A)
680
543(D) 320 320
173(D) ) B ( 5 7 9
0 2 3 0 2 3
910 220
220
2 ) 9 D ( 1 2 6 5
X
) B ( 0 7 1
1210(B) 317(B) 105(E)
1265(CG) ) G C ( 0 5 7
Ø560 ) C ( 7 7 4
) E ( 5 5 1
92(E)
4 4 7 1
C You're Reading a Preview
455(C) 2599
Unlock full access with a free trial.
A
243(F)
Download With Free Trial
197 146
) G ( 0 1 2
X ) F ( 9 4 9 5 2 0 3 3 4
143(G)
) E ( 0 ) 9 A 3 ( 2 0 0 1
D F 100
G
B
Sign up to vote on this title
E
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
1
Download
9
ASC 100-D CompAir 5437 Air
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
min. 1000
2 7 6
0 0 0 1 . n i m
8 9 9
6 9 8
7 6 1
7 7 8 0 0 0 1 . n i m
6 9 8
min. 1000
2 7 6
9 9 8
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes ASC 100-D CompAir 5437 Air
Save
Embed
Share
Print
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen
D75-D160(RS)-A
5.6(A)
C
B
6 . 3 0
1.8(A)
21.4(D)
) G C ( 7 2
26.8
12.6 12.6
35.8 8.7
8.7
8 . 8 7 ) 6 B . ( 2 4 . 1 8 6 3 . 2 1
) E ( 4 . 5 ) 1 A ( 5 . 9 3
6.8(D)
) 6 . D ( 7 1 . 2 2
X
) B ( 7 . 6
43.6(B) 12.5(B) 4.1(E)
49.8(CG)
3.6(E)
X
) G C ( 5 . 9 2
) C ( 1 . 2 6 ) C ( 3 . 3
) E ( 1 . 6
7 . 8 6
) F ( 1 . 8 . 1 . 4 2 6 1 1 1
5.8 7.8 9.6(F)
You're Reading a Preview C
2.8(C) 54.7(C) 102.3
Unlock full access with a free trial.
Download With A Free Trial
F B
Sign up to vote on this title
Useful E
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
1
465 views
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
9
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appendix
D75-D160(RS)-W
5.6(A)
C
B
6 . 3 0
21.6(D)
) G C ( 7 2
26.8
12.6 12.6
35.8 8.7
8.7
8 . 8 7 ) 6 B . ( 2 4 . 1 8 6 3 . 2 1
) E ( 4 . 5 ) 1 A ( 5 . 9 3
6.8(D)
) 6 . D ( 7 1 . 2 2
X
) B ( 7 . 6
43.6(B) 12.5(B) 4.1(E)
1.8(A) 49.8(CG)
D
) E ( 1 . 6
3.6(E)
) G C ( 5 . 9 2
Ø22 ) C ( 8 . 8 1
7 . 8 6
C You're Reading a Preview
17.9(C) 102.3
Unlock full access with a free trial.
A
9.6(F)
Download With Free Trial
7.8 5.8
) G ( 3 . 8
X ) F ( 1 8 . 1 . 4 . 6 1 2 1 1
5.6(G)
D F 3.9
G
B E
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join
Search
Home
Saved
465 views
1
Sign In
Upload
Join
RELATED TITLES
0
CompAir D_DRS Series Operations Manual Rev.02 Nov.11, 2013
Uploaded by Chez LaRa
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Manual de partes
Save
Embed
Share
Print
ASC 100-D CompAir 5437 Air
1
Download
of 100
3.9 Kaeser Compressor -
Kaeser Compressor
Search document
Appen
min. 39.4
5 . 6 2
4 9 3 n i m
3 5 . 4
2 7 . 5
3 0
3 1 4 . 9 3 . n i m
2 7 . 5
min. 39.4
5 . 6 2
4 . 5 3
You're Reading a Preview Unlock full access with a free trial.
Download With Free Trial
Sign up to vote on this title
Useful
Not useful
Home
Saved
Books
Audiobooks
Magazines
News
Documents
Sheet Music
Upload
Sign In
Join