HS.SAF.09.F12
CONTRACTOR WORK METHOD STATEMENT STATEMENT (EHS) 1.
Contractor Name : DANWA DANWA (!M"1009)
2. Wor# $ocat%on : &T 'N$ET A'R F'$TER ACCESS STA'R CASE FOR &T"11 12 21 22 1 AND 2
3.
Tra,e+ D%+c%*/%ne+ 'no/e, 'n Wor# : Supervisor, Electricians and Helpers.
!ro*o+e, Start%n- Date :
4.
r%e r%e De+cr%*t De+cr%*t%on %on O Wor# Wor# To e 3n,erta 3n,erta#en #en : 'NSTA$$AT 'NSTA$$AT'ON 'ON OF CA$E TRACA$ TRACA$E E FROM E4'ST'N& $'&HT'N& D 'N !CM TO NEW D FOR $'&H $'&HT' T'N& N& OF ACCES CCESS S STA STA'RCAS 'RCASE E FOR FOR &T 'N$ET A'R F'$TERS (A$$ &T 3N'TS).&$AND'N& 5 TERM'NAT'ON.
5. Too/+ S67+tance Portable Tools Tools Hand
Electrical
Pneumatic
Ha8ar,o6+ S67+tance+ Toxic Harmful
Flammable Irritant
Environment Impact
Corrosive
HS.SAF.09.F12
7. A**roa/+ Contractor+ S%te Re*.
ame
EMA$ Re*re+entat%e Area O
P1*:EE;0*1
Si!nature
$ate
ame
Si!nature
$ate
ame
Si!nature
$ate
ame
Si!nature
$ate
MA$ EHS De*artment •
•
•
The completed 3or< ethod Statement must be submitted at least +een 6//
HS.S*F.7.F49
8. Saet Ana/+%+ Seer%t ; !ro7a7%/%t = R%+# 'n,%%,6a/ Act%%t%e+ To Com*/ete Wor#. $%+ t 'n Se@6ence o Act%%t
?.1 !RE!ARAT !RE!ARAT'ON. 'ON.
',ent%%e, Ha8ar,(+) A++oc%ate, W%t Act%%t
!er+on+ E;*o+e, To Ha8ar,
!reca6t%on+ an, !/an o act%on+ To e Ta#en To Remoe Contro/ Ha8ar,+
Re+%,6a/ R%+# (3+e R%+# E+t%mator Cart)
•
• •
Slips, trips and fall at the same level. Hot environment anual handlin! ha"ards
aintain house
•
Emal, En!r., Supv. Elec, and helpers
•
9x9A8
•
File 45
1evision 7'956a69744+ 7'956a69744+
Pa!e B of
HS.S*F.7.F49
A!!ROA$(!erm%t to
•
•
Client coordination fails, >ob stopped, #or< unapproved. -peratives should be a#are of emer!enc procedure of E*@
Emal , En!r., Supv. Elec, helpers
•
•
•
:erif isolations. Start #or< after !ettin! permit from Emal. En!ineer D supervisor must ensure that the #or< permit is valid for the date and tine
*ll #or< force force are inducted b E*@
•
*ll personnel involve involve in the activities activities must #ear the re?uired PPE=s at all times'e!.hard hat, appropriate safet !lass, safet shoe, hand !loves, dust mas<, disposable coverall+
•
9x9A8
*dvance plannin! b contractor considerin! the time consumption to recive the permit from E*@
•
•
•
File 45
1evision 7'956a69744+ 7'956a69744+
Emer!enc procedure must be displaed at prominent location and cascade to operatives on re!ular interval and recorded. Ensure the operatives must be !o throu!h E*@ and $*3*2 safet induction.
Pa!e 8 of
HS.S*F.7.F49
•
?.2 'NSTA$$AT'ON OF CA$E S3!!ORT CA$E TRA 5 CA$E $ADDER. $ADDER.
0sin! dama!ed hand tools. • Sharp ed!es of cable support D tra & ladder.
•
Incompetent #or
•
•
Slips, trips and fall at the same level.
•
•
•
•
File 45
0sin! of bad condition of hand po#er tools. $rillin! #ithout clear safet !lass, dust mas< & ear plu! $ust from electric drill ma cause of fire alarm activation. 0nauthori"ed
Electricians & Helpers
•
•
Electricians & Helpers Electricians , supervisor & Helpers
•
•
•
Electricians & Helpers
•
•
Electricians & Helpers
*ll hand tools to be used must be in !ood condition. Inspect before use, periodicall maintained. Extra care to be ta
9 x 4 A9
9 x 4 A9
9 x 4 A9
Bx4AB
Bx4AB •
1evision 7'956a69744+ 7'956a69744+
-nl competent and authori"ed #or
HS.S*F.7.F49
usin! of hand po#er tools.
Supervisor to ensure all po#er source to be connected #ith E@C/ and onl 447: industrial industrial soc
•
•
Electrocution D Fire.
Electricians , supervisor & Helpers
Bx4AB
•
•
•
•
•
0sin! of bad condition step ladder. Fall from hei!ht scaffold or from ladder
•
Electricians & Helpers
•
•
•
File 45
anual handlin! ha"ards.
Electricians & Helpers
•
1evision 7'956a69744+ 7'956a69744+
Inspect ladder before use, assi!n one man to hold the ladder on the !round #hile in used. *l#as climb up and do#n facin! the ladder. $ont carr tools or materials in our hand #hile climbin! up and do#n ladder. Ensure #or
Bx4AB
9 x 4 A9
Pa!e 5 of
HS.S*F.7.F49
•
•
?. 3N$OAD'N& OF SCAFFO$D'N& (6+%n- 7oom tr6c#) ERECT'ON 5 D'SMANT$'N& .
ot usin! proper P.PE.=s 0nauthori"ed #orure due to una#are of site rules.
Electricians & Helpers *ll #or
•
9x4A9
9x4A9 •
• •
•
• •
•
• •
•
File 45
3ear P.P.E.s at all times ' e.!. hard hat, appropriate safet !lass, safet shoes, hand !loves, dust mas<, lon! sleeve shirt & reflective vest.+
1evision 7'956a69744+ 7'956a69744+
Personnel entr to be maintained in entr re!istered. -nl limited personnel authori"ed. *ctivit shall shall be supervised b receivin! authorit. authorit. Supervisor to ensure all applicable PT3 to be obtained prior to commencement commencement of the tas<. Proper coordination #ith client. Toolbox Toolbox tal< to be held at site, this shall cover the method statement and >ob safet analsis. analsis. -nl competent and authori"ed personnel to be deploed, supervisor to ensure all #or
HS.S*F.7.F49
cables nearb.
•
•
•
•
•
•
/ad house
•
•
•
•
•
aintain house
Scaffoldin! !roup •
•
File 45
Incompetent scaffolders. Scaffolders ma slip,
Bx4AB
Bx4AB •
1evision 7'956a69744+ 7'956a69744+
Scaffoldin! to be erected b competent and authori"ed scaffolders, scaffolders, toolbox tal< to be !iven to all Pa!e ( of
HS.S*F.7.F49
•
trip & Fall at same level or from hei!ht. •
•
• •
Electrocution. Fall of materials & tools, dama!ed propert inside existin! Substation.
Scaffoldin! !roup
Bx4AB •
•
•
•
•
•
File 45
scaffolders, remind them re!ardin! safe erection of scaffoldin!. *ll #or
1evision 7'956a69744+ 7'956a69744+
Strict instruction to be !iven durin! the cre# meetin!ever meetin!ever touch an electrical e?uipments inside the Substation, supervisor to close monitor the activities. Ensure full time safet covera!e throu!hout the >ob. *s far as possible provide access access to all panels for Emal operation. /arricade the #or
HS.S*F.7.F49
displaed #hich read J ;EEP *3*2 SC*FF-@$I% E1ECTI- I P1-%1ESSJ. •
•
?.B CA$E $A'N& $A'N& !3$$'N& ETWEEN$'&HT'N& D TO NEW STA'RCASE D.
•
•
•
•
•
File 45
ot usin! proper P.PE.=s
Sharp ed!es from existin! cable support D tra & ladder.
$ama!ed existin! cable.
Slips, trips and fall at the same level. 0sin! of bad condition step ladder. Fall from hei!ht
*ll #or
Cable pullin! !roup
•
•
Cable pullin! !roup
Cable pullin! !roup
Cable pullin! !roup
3ear P.P.E.s at all times ' e.!. hard hat, clear safet !lass inside the buildin!, safet shoes, hand !loves, lon! sleeve shirt & reflective vest.+ Note : This will be applicable for other activities.
•
• •
1evision 7'956a69744+ 7'956a69744+
Extra care to be ta
Extra care to be ta
9x4A9
9x4A9
9x4A9
9x4A9
Bx4AB
Pa!e 47 of
HS.S*F.7.F49
$on=t leave cut cable inside the buildin! & top of panels. Inspect ladder before use, assi!n one man to hold the ladder on the !round #hile in used. *l#as climb up and do#n facin! the ladder. $ont carr tools or materials in our hand #hile climbin! up and do#n ladder. Ensure #or
•
•
•
scaffold or from ladder.
•
•
•
•
?.B.>.2 'SO$AT'ON
•
Communication barriers amon! #or
Cable pullin! !roup
•
Cable pullin! !roup
•
*ll #or
Supervisor to !ive toolbox tal< re!ardin! proper manual handlin!. *ttach E*@ E*@ isolation isolation permit. /arricade the area #ith proper #arnin! si!na!es. 0se onl standard dan!er ta!s li
• •
•
•
File 45
%ood communication measures D devices shall be used.
1evision 7'956a69 744+
9x4A9
9x4A9 Bx9A5
Pa!e 44 of
HS.S*F.7.F49
•
•
CA$E DRESS'N&
• •
•
CA$E &$AND'N& 5 TERM'NAT'ONS.
•
•
•
•
File 45
anual handlin! Hand in>ur
Incompetent electrician. 0se of sharp hand tools. 0se dama!ed hand tools ma slip and in>ure electrician or dama!e propert. 0nauthori"ed usin! of hand po#er tools. Electrocution D Fire.
ta! -nl the person #ho place the loc< and ta! shall remove it $o not use conductive articles of >e#elr and clothin!'e!. clothin!'e!. #atch, bracelets rin!s etc+
•
Elec., & helpers
• •
•
Electricians & Helpers
•
•
Electricians & Helpers Electricians & Helpers
•
0se appropriate PPE,s Close supervision #ill be implemented. Supervisor to !ive tool box tal< re!ardin! proper manual handlin!.
9x4A9
:erif isolations Competent #or
-nl competent and authori"ed #or
9x4A9
Bx4AB Bx4AB
•
1evision 7'956a69744+ 7'956a69744+
Supervisor to ensure all po#er source to be connected #ith E@C/ and onl Pa!e 49 of
HS.S*F.7.F49
447: industrial industrial soc
•
•
•
Slips, trips and fall at the same level.
Electricians & Helpers
•
•
•
TEST'N&
•
Slip D Trip D Fall 6 same level
Testin! !roup •
•
•
•
0nauthori"ed person Electricit D Fire
-nl Emal /i! ) trained personnel to do the >ob. If re?uired safet bulletin needs to be issued. aintain !ood house
Testin! !roup
9
x4AB
9x4A9
Bx4AB •
•
• •
File 45
aintain house
1evision 7'956a69744+ 7'956a69744+
*ccess to#ards to#ards to the testin! testin! area to be barricaded and #atchman to be posted. Testin! Testin! area to be barricaded and proper si!n boards to be placed #hich read JTESTI% I P1-%1ESS ;EEP *3*2J. *void cable >oint. Clear everbod from the area Pa!e 4B of
HS.S*F.7.F49
#here testin! is in pro!ress.
•
•
Testin! e?uipment
Testin! !roup •
•
'NS!ECT'ON
0nauthori"ed #or
•
•
•
Slip D Trip D Fall 6 same level
3or
Supv,Elect & helpers
Elect & helpers Emal, En!r., Supv. Elec, and helpers
Emal, En!r., Supv. Elec, and helpers
•
•
*ll testin! e?uipments e?uipments must be in !ood conditioned and #ith valid calibration test certificates. *ll testin! e?uipments e?uipments must be approved b client prior to utili"e at site. -nl competent and authori"ed person to do the inspection, ensure notified the client #ith all necessar documents.
aintain !ood house
3ear P.P. P.P.E.s E.s at all times 'hard hat, appropriate safet !lass, safet shoes, hand !loves, dust mas<, fire retardant lon! sleeve shirt D pants.
Bx4AB
9x4A9
9x4A9
9x4A9
This sheet must be properl completed detailin! all of the steps re?uired to complete the >ob alon! #ith the se?uence of events and each of the ha"ards arisin!. Failure to properl complete the form #ill result in non6approval. File 45
1evision 7'956a69744+ 7'956a69744+
Pa!e 48 of
HS.S*F.7.F49
(Additional sheets to be used as required
9. Cem%ca/ Ana/+%+
(!his "or# to be used as required
!ro,6ct Name MSDS +6**/%e,
e+ No
Dan-ero6+ &oo,+ C/a++
File 45
Ha8ar,o6+ Mater%a/
e+ No
Nat6re o Ha8ar,
'rr%tat%on Carc%no-en Corro+%e To;%c Oter
Form
So/%, $%@6%, &a+ D6+t a*o6r M%+t
E;*o+6re Ro6te
'na/at%on S#%n Ee 'n-e+t%on
N6m7er o !eo*/e E;*o+e,
3 $or%ers onl&
D6rat%on o E;*o+6re
' hours
1evision 7'956a69744+ 7'956a69744+
Pa!e 4) of
HS.S*F.7.F49
Fre@6enc o E;*o+6re Contro/+ to 7e %m*/emente, E+t%mate o E;*o+6re
Ver& rare As er )S*S Ne-/%-%7/e )ar+inal H%-
!his sheet #ust be roerl& ,o#leted detailin+ all the ne,essar& ne,essar& in"or#ation. -ailure to roerl& ,o#lete the "or# $ill result in nonaro/al. nonaro/al.
File 45
1evision 7'956a69744+ 7'956a69744+
Pa!e 45 of