1AGAPAJAP043A
ABBR
AT ON
Abbreviations
Definitions
4WD
ASAE ASTM DIN
Deutsches lnst lnstit it
DT
Dual Dual Trac Tractio tio
fu
[4WD]
tP rM
HST
mls
Hydr Hydros osta tatic tic Tran Transm smis issi sion on et rs
er
on
PTa RH/LH
RaPS rpm
ll
te iv in
rls SAE SMV
WARNING
ABBR
AT ON
Abbreviations
Definitions
4WD
ASAE ASTM DIN
Deutsches lnst lnstit it
DT
Dual Dual Trac Tractio tio
fu
[4WD]
tP rM
HST
mls
Hydr Hydros osta tatic tic Tran Transm smis issi sion on et rs
er
on
PTa RH/LH
RaPS rpm
ll
te iv in
rls SAE SMV
WARNING
UN
MBOL
Sy
l§hl
Remote Remote Cylind Cylinderer-Ret Retrac rac
Dies Diesel el Fuel Fuel
o-e:JI
Stee Steeri ring ng Whee Wheell-Ti Tilt lt
Fuel-Level Enqi Enqine ne-H -Hot otat atio iona na
/mir\
Oper Operat atin in
Hour Hour
:OC:
Engine Engine Coolan Coolant-T t-Temp emperat erature ure ow
lu
ur
Star Star Aid) Aid) Park Parkin in
~--~
Engi Engine ne Inta Intake ke/C /Com ombu bust stio io
<>c:>
Brak Brak
;::0
ow
:::-
Beam Beam
AirAir-Fi Filt lter er
Char Chargi ging ng Cond Condit itio io
IV
ftI
Four Four-W -Whe heel el Driv Drivee-Of Of Fast
Turn Turn Sign Signal al Engine-Stop
IlJ
Engine-Run Star Starte te
Creep Read Read Oper Operat ator or's 's
Cont Contro ro
:-,-/.
nt
( S T O~, P)
Machine
D...
.......
Posi Positi tion on Lamp Lamp
Headli ligh ghtt-Hi High gh ~O Head
(®)
Cont Contro ro
Li
Spee Spee
Hour Hourme mete ter/ r/El Elap apse se
Batt Batter er
Remote Remote Cylind Cylinderer-Ext Extend end
Powe Powe Take Take-O -Off ff Clut Clutch ch Cont Contro roll-On On Posi Positi tion on
Posi Positi tion on Cont Contro roll-Ra Rais ised ed Posi Positi tion on Posi Positi tion on Cont Contro roll-Lo Lowe were re Draf Draf Cont Contro roll-Sh Shal allo lo Draf Draf Cont Contro roll-De Deep ep
Posi Positi tion on
Posi Positi tion on Posi Positi tion on
of Mach Machin in
Manu Manual al
It
unit.
DANGER:
WARNING:
CAUTION:
if not
CONTENTS
T P
nt JUMP
on
ea
Ligh
r S
ur
t L
igna
r &
e G
r S
t L
CONTENTS
g o
PTa PT
27
27
OPERATIO
DRAWBAR. 3-POIN
29
30
HI g t
g h
33 Position Contro
33
equipped)
35
l U
Inflatio
Pressure
38
CONTENTS
g T
r a d E
g A
y E
58
g G
CONTENTS
he
Injection
EVERY Anti-Freeze ep ac
66 67 ad ator
pi
s)
68 ;.68
di
ue
em
68
M S
AF
OPERAT ON
accident. operat ng
he tractor.
operation.
BEFORE OP RATI
TH
TRACTO 1AGAPAJAP045A
(1 ROPS (2 Seat belt
the tractor.
2. cautio
4.
labels on th tractor.
RaPS.
3.
rotect ve Struct re RO an ea belt lmos ll applic tions. hi combinatio will reduce th is seri injury eath should he tr ctor pset
necessar fo area with height constraints. (There is no operator protection provided by th RaPS
nd th seat el fast
correctl
ed fo
ll othe
perati ns.)
before operatin th tractor.
ending dril in ri di structure. da aged CA or RO no repaired or revised.
or cutt ng tr
tu
epla
fr ye
am ged.
controlled substances or whil fatigued
during operation
manual before operation, ay weaken th us
eplaced,
eading to th risk
acci ent. Us
ddit onal safety
required. KUBOTA Dealer tracto seat during operation. 0.Chec rakes, cl tch, ot er
"MAINTENANCE
echa ic
arts fo
section.
12 Us only implements meetin th specifications listed
ri
of up ets. When usin th
fron load r,
1. Pull only fr th drawbar. Ne er hitc to axle hous ng an othe poin except drawbar; uc arrangements wi increa th risk of seriou personal injury or deat
manual. we Fo wi re "TIRES WHEELS AN
Se BALLAST" ection))
(1 Drawbar
Re
2.
re missin
1AGAGAAAP1030
(1 Rear wheels
or da aged
when turning, on uneven ground an before stopping 4. Th tr ctor cannot turn with th differential locked an
(A Trea Widt
15. Do may affect in er onal njury.
5.
gras
or oper ting ever or ontrols.
7.
2.
an hide ob tacles walk th areafirs to be ure.
other obstructions do it.
off
S.
moving tractor.
children di engage
or "OFF". Ch
re
position. sa rt circuitr
is bypassed
them
watchf wo
deadly.
ey of anothe re ponsib
adult. children ente
EO
we
on slopes
Slopes
re
over ccid
aj
fact
ts whic
rela ed an re
lt
oss-of-c ntro an severe injury
ip
eath
Al slopes requir extr caution. 1. do
operation.
becaus thei increase traction ca give th operator fals confidence in th tractor' abilit to clim slopes 3.
ot ak sudden ch nges in sp ed ir ctio Avoi disengagin th clutch or changing gear spee 4. slope coul
ause loss
control.
Follow recommendation
fo proper ballasting
(1) SMVemble (2) Bracke
5. Observ
al loca traffi an safety regulations.
6.
anothe vehicle. times. 8. Do no appl th
ifferentia lock wh le travelin
9.
speeds. coul
ause th tr
(2 ra (RH) (3 Brak Peda Lock
carefully.
to to
oad. oc th 3-poin .Wh
(1 Safety chai
wh itch in th
ai ed
osit on
oa
SAFE OPERATIO
nt it 3-poin hitc usage. it re ov th
in
to
nd
ui
ed
2. ur to in tall th proper counterbalan fron of th tractor.
ey
2. stop before dismounting
eigh on th
lo erin spee no in th LO K" po itio to hold th implemen in th raised position
3. attachment on th ground
di PT
ic
ny
driven equipment
2.
(1 3·poin hitc lowering spee
(A "FAST" (8 "SLOW" (C "LOCK"
knob
Before servicin th tractor, park it urface et th parkin brake, lowe al implements to th
in ,engin an re ov (1 PT
Sh ft cove
ns
(A "NORMA POSITION (B "RAISE POSITION
in
th
near th engine
ey uffler
adiator, et
2.
ng
ls
and overfilling. 3.
labels attached to th equipment. lo it oxygen especially when recharging 4. Before ju ta ting dead batter parts.
5.
"OPERATING TH
read an follow
ENGINE section)
times.
oolant re over tank ad coolan or ater to th tank
SAFE
Discon ec th batt ry's roun able ef re workin on or near electric components To avoi he possibilit of attery xplosi n, do no se
lu
le el re
la ly
nd dd isti le wate as re
15.Escapin
an
unde pressure ha sufficient
injury Before disconnectin
hydrauli
lines, be sure to
ir hose
LOWE
hydrauli flui
re fr
da age.
levels
econnect it ast.
1AGAEAAAP114A
(1) Cardboard (2 Hydrauli line (3) Magnifying glass
luid escapi
(1) Batter
fr
inhole
be nvisib e, Do no us
.Do .D
scapin fluid, se edic octo on e. produc gangrene or severe allergic reaction
suitable blocking beforehand
.A infl te tire abov th reco in th operator's manual
ende
pressure sh wn
lAGAKADAP2D2A
,Se wheels or dj stin th wh read wi th 4.M ke sure th whee bolt have ee ight ne
th
is luid will
CAUTIO
MAAAP400A
"G
(2)Part No.TA
1AGAPAJAP061
240-9848-1 [Foldabl
ROPS type
WARNING
LABELS
(1)Part No TA040-4965-2
1AGAMAAAP2450
(2)Par
No TA040-4959-3
1AGAMAAAP2470
1AGAMAAAP2500 1AGAPAJAP062E
1AGAPAJAP0518
(1)Par No.35260-3491-4
VO RS Rea an d e s ta n Be
U RY : o p e a to r' s m a n a l b e o r o pe r o n mak ve om PT is O F F . th Do pa ac or at ny me. Be ow ot pe pl ve op man ss of nd ol gu ary. 5 . C he c Keep al s h d s p la c an stay away from movi pa s. 7. oc he wo ke pe og vi on oa Sl ow or ppl vi ke 9. On pu SMV mb za equ ed by ocal af an 0. Pu on Be 12 Securel
mou we mov ke supporttractorand
mpl men
ou
pa ki
ke
1AGAMAAAP2620 1AGAMAAAP2390
(4)Par No TD030-4958-1
I> ®~G '''0
0· MF
.&
• Q U E T O H Y O O OE N
H'
R E S eR V E C A PA C Y iM iN )
55 13
R O" ~A T E !Y .
O N L Y F O R S T AR T I N G < N G ~' E .O O N O
B A IT ER Y
O N L Y AT
V EN T I .A 1 E O P ' A CE S
S T N EC iW lH AC IO .
F LU S
O B E CT S
M MU JA 1E LY W
R'
sor
UE H AR O
Wl RA DL
U) 00
N O O iS AS SE M8 L
E X P LO S IV E G AS E S
Ci ar s, mes p a k s c ou l c au s ater p lo de . A lw a hi ey an ce ater Do po c on ne ct io n w i h ou t p r op e r n st ru ct io n a n t ra in in g
1 AG AP A A P0 5
1AGAPAJAP063E
H AN DL 'N G
AN
C AU S E
'PPeYfH'S
Pr;QDLCTFOAOT~ER
AN
5 I< CI Tl S
A VO I
surfac et
, ~A ~ " J l Rl .1 .
W > T I< OU T C AR E
W AE R
F AC I
F lA EA ~
E >P 1. 0S K. l~ .
VSES.
O A S PA AK S
~ ~ : ~~T og D r ; ! ~· A R T O : L E S
S f - !G $W AL LO WE D
W A T E A P R O M P T lY . I N C A S S : 0 1= A C C I D O O A l C O H r A C T . C O N S t JL 1 A D C < : '! l ) DO
A GA MA AA P4 0
S U! .f 1. .m I, ; Aa C
like muffler.
~ ~ ~ ~ ~ ~ ~ D E : ~ r~ ~ ; ~ ; ~ ~ ~ ~ ~ 'i :v ~ ~ ~ = ~ ~ s B E E ~ ~ i •OO
DANGER
fO
f I - CH O~ C L tI R£ H
G AS GE N R AT E
aATrERYIS
C H AR G E T H '
H Ri 1 O H R )
op
imp lements beforeworkingunderneath.
(2)Part No.TD060-3012-2
NX
(3)Par No 32751-4958-1 Stay clea o f e ng in e belt.
FLAw..tAelE_
TH
B AT IE R
DR~K
£NYO
~ E D ! A T El Y
00 NO
CH RG
NE
F IR E O R S P
( SE AL WT Y E /
POISON
C AU S E S
V ER E B U R N
C o nt a n s s u u r a c d . A v o c on ta c w i s k in , e ye s o r c lo th in g I n e v en t o f a cc id en t f lu s w it h w a te r a n c a p h ys ic ia n m m e d a te l . .
UT OF RE
OF
HI DR
1AGAMAAAP2400
(1)Par No.TA040-4932-
[Rigid ROPS type
(2}par NO.6C140-4746-1 [Rigid ROPS type
1AGAPAJAP064E
rn
4.
ri
la (are atta
r, th ed in th r,
am
location(s as th repl
(s ff ed co pone t. in
la re
CI sire to el yo
th
this an th ro ghly of th regula maintenanc
rvic onta yo pu ch ed yo
C TO R lu
ro
it
ft
wi fi ha yourself
th UBOT trac or yo
ot th tr ctor an en in
rial
re
in
do so
De le sh fr lo UBOT
whic De ler.
ers.
space provided. Type
Serial No (1 Tracto serial number
Tractor Engine Date of Purchase Na (T
Dealer il ed
pu ch
er
1AGAPAJA P027
(1 Engine serial number
1AGAPAJAP044A
(1 Tracto identification plat
SPECIFICATIONS S P E C IF IC A T O N
ABL L4400
Model
2WD
4WD
Model
V2203-M-E2A
Type
Indirect injection, Vertical Water-Cooled
cycl diesel
Numberof cylinders Bore an stroke Engine
Ne power*
! r
PT power' (factory observed)
kW (HP) rpm
28.0 (37.5) 12600
m ( Batter
139.5 (102.9
capacity lo
Fuel
(1
ie
Fuel tank Capacities
e c
6 (
Engine coolan
6.
(U.S.qts.
(6.9
n c m( Overal widt l h !i
Dimensions
300 (118.3
(min.tread t (
0 ( 184 (72.6)
Min. ground clearance
38
mm (in.
,I
(15.2)
1280 (50.4).138 (54.3) 1480 (58.3) 1580 (62.2)
Ii
Tread
0(
115 (45.5)
~1
5(
1375(303 tire size Traveling system I!
I'
Rear ry yp si gl
Clutch
Hydrostati
Steering Ge
Transmission Brakin
'1
Max. lift force
revers
2. (8.5 (U.S.gals.)
min
29.4 (7.8
At lift points
kg (Ibs.)
1300 (2870)
24in behind Jift points
kg (lbs.
1053 (2310)
MP (kgf em' )[psi]
Engine spee
NO E~"Manufacturer'
17.7 (180 [2560] SAE 1-3/8. 6-splines
RearPTO PTO
forw rd an
poin hitc
System pressure PTO
powe steering
hb
Pum capacity Thre
shift,
st ge
Mechanical We disk type
system
.t
Hydraulic unit
1430(3153)
stimat
rpm
he om an
rese ve th
540/2475
ight to change th specifications withou
otic
R AV E N G S P EE D S te en in Model
L4400
Tire size (Rear)
14.9-24
eg shif leve
km/h
shif leve
.... Low
Forward
mph
1.
7.1
High
10.0
6.2
16.3
10.1
24.0
14.9
1.5
Reverse Reverse
5.6 5.1
re
rv
th
ig
to
ge th
cifi
ti ns with
ti
rp
IMPLEMEN
LIMITATION
IMPLEMENT LIMITATIONS Th
UB TA Trac or
as been th roughl re so
este
fo prop
perfor ance wi
ch da ag othe prop rt an in ur he operator or others An wi mpro er implemen ar no co ered th warranty
mp ements so
al unct on
read (max wi th with ar
or failures of th trac or result ng from us
tire
Front .2WD
or approved by UBOTA. ci
fiftin capacity
Rear
4WD
0 mm (
13
kg (2 70 fbs.
Actual figure Implemen weight WI and/or size
Max. Drawba Load
L4400
Traile loadin weight Max capacity
0 kg (
g(
Implemen weight .... ........ .. Th impl me t' weig wh ch ca be pu on th ower li k: Max. drawba load ................W~ Traile load ng we gh .... ......The ax oading we gh or railer (wit ou railer we gh
8<_zt LAGAIAZAP1218 NOTE:
;1
'I
,1
x.-.
~~31 W2 W1
IMPLEMENT LlMITATIONS'
No.
Implement
Remarks
L4400
Max load capacity
Trailer
Max. drawba load Mid-mount Rotary-Cutter
Mower Flai Mowe ickl Sprayer
ar
Pull type
Max cuttin
widt
Max weight
mm (in.
--
kg (Ibs.)
Max Guttingwidth Max weight Max. cuttin widt
mm (in.
1524 (60)
Max weight Max. cuttin widt
mm (in.
Max. weight Max. tank capacity
Rotary Tiller
Max. tillin widt
Bottom Plow
Max. size
(gals.
40
(gals.
1200 (317
mm (in.
1520 (60)
(106
1981 (78)
Chisel Plow Broa
Caster
Max weight
kg (Ibs.)
40
Max. widt
mm (in.
1829 (72)
Max weight
kg (lbs.)
35
Cultivator
(770
Max weight
Manure Spreader 10
(880
0 ( Nu be of ro Max weight Max. cuttin widt Max. oi pressure Max. cuttin
widt
rnr (in.)
1829 (72) 2 (
x l 13
Front-en
Loader
g c
0 (
Max. oi pressure Su fram
14
Bo Blad
Max. cuttin widt
ac Ho
16
Snow Blad
mm (in.
1651 (65)
mm (in.
22
kg (Ibs.)
45
Max weight Max. diggin
15
Necessary
Max. weight
dept
(90) (990
1830 (72) Max weight
kg (Ibs.)
35 (770 1676 (66)
Max weight
kg (Ibs.)
28
(620
NS RU
NT
UME
PA
CON
OL
:l
1AGAPAAAP01
ILLUSTRATE
CONTENTS
(1
oofant te perature gauge.................
24
(2
ue
23
(3
auge............ il
......
23
(4)
Glow pfug indicator.............................
12
(5
Tu
18
(6
Head figh switch....................
(8
signal switch....................
ourm te
achometer.....................
18
24
(9
Electrical charge iamp..........................
23
(10)
Hazard ligh switch..............................
18
)
K
1AGA PAJAP053
ILLUSTRATED CONTENTS
ILLUSTRATED CONTENTS 1) (2
ai gear shif lever............. ............ ............ ...... Clutch pedal................................... ck in
21
(11)
Parking brak lever ..........................................
25
21
(12)
Brake pedal .....................................................
20,22
25
(13)
Foot throttle .....................................................
22
(14)
Position controlleve
33
22
(15)
Draft contro lever (If equipped) ........................
21
(16)
Cup holder .......................................................
sp
leve
33
(6)
Rang
(7)
Seat belt.................................................................
18
(17)
Remote contro valv leve (if equipped) ..........
35
(8)
Operator's seat.......................................................
17
(18)
PTO clutch controllever .................................
27
(19)
Remote contro valv couple (i equipped ......
36
(10)
gear shif leve (Shuttle shif lever)............
.......................................
Hand throttle /ever.................................................
22
PR DAI
PE
ON CHECK
C H EC K
re he cond tion of th
ri el
ractor
heck it before star ing.
CAUTION
To
void
ersona injury
engine the ground. heck item
Walk around inspec io ve Chec transmission oi leve ra
re
Chec
ndicators, gauges an
Chec
ight re
eter
Refuel (See "D IL
HE K" in Periodic Servic
sect on
r, (See "D NG R, WARN NG AN in Safe Operatio section)
PE
AUTION LA ELS"
HE
GI HE
CAUTION
To avoi
personal injury
manual. locate
on th
tractor.
closed building withou
proper ventilation.
lever.
GI
PE
HE
GI HE
CAUTION
To avoi
GI
personal injury
manual. locate
on th
tractor.
closed building withou tart engine
ly ro
proper ventilation. op rator'
at
lever.
pedals again.
all "NEUTRAL position
an to plac
PTO leve in
"OFF" position before starting th engine IMPORTANT:
r.
To
art seconds.
(1 Parkin
brak
(A Interloc th brak pedals (8 "DEPRESS (C "PULL"
leve
IMPORTANT:
pull ng th
ar in
ra
leve up
PT
"OFF" position
position.
l c
) " (8) ;'OPEN"
r., "OFF"
"LOWEST" position
position.
(1 in ar shit leve (2 Rang gear shif leve (Shuttle shif lever)
clutch contro leve in
(H "HIGH" (N "NEUTRAL POSITION (L "LOW (R) "REVERSE"
(1 Position contro leve (2 Draf contro leve (i equipped
(AJ "DOWN"
(1 Hand Throttle leve (2) Foot Throttle
"INCREASE"
1AGAPAAAP055B
"OFF"
e"START" 00 "PREHEA
if) ·ON"
n. Iftr uble
ould cc
ny lo
tion
il th en in
location come on
1AGAPAAAPD5SE
(1) Engine oil pressure (2 Electrical charge
(3) Glow plug indicator
IMPORTANT: fficient er fail to on ct ysic aily ec ar full referrin to il he ction. (See "D ll HE K" in erio ic rvic ecti n)
GTH
OL
WEA HE
st ps (1 thro gh (8
re as
he
he
ng
bove
tarts.
IMPORTANT:
"NEUTRAL
an
position
lectri al charge amps ar "OFF".
@]@]
~[gJ determin
th cause.
~o~o
lAGAPAAAP056G
(1 Glow plug indicato
ff the
seconds.)
tr
(-
OF).
OP
HE
GI
U M P S T A R T IN G CAUTION
To av id
erso al injury
ks
fl
fr
tt
engine.
NOTE:
le to
ti
te
of negative tr to
jumper tt ry
WA CAUTION
To avoi
pers na injury
up. es
to
"NEUTRAL"
to
"OFF"
equipped)
position during warm-up.
(+) If
Temperatur
of
Rang possible,
10.
Ambien
temperatur
rm-u
5t (-4 to
IMPORTANT:
time
eq reme
IMPORTANT:
system.
electrica system. starting
I;
lo
or dead batter
ondition
PE OP Ho
HE
tr ct is life th tr to ra to ju ff
nd ed
C TO R
in ai ed
ac or
ro
ti
CT te
li
in
OP equipped)
ee
to is
dl
du in
im
forman
th "bre
in -i
an th lo ge
ea ly to tain he life of th tr ct r,
OP
CAUTION
th
tr
O LD A
ea of tractor.
the
ri
as possible. in
an li
tr
to
fo lowi
re
ti
ho ld
be observed.
and attachments.
your Dealer.
1. Re
th
olts
engine. necessary. fast speed.
in tr
tor.
ri ario
in rt
il re
rs "b ok
-in"
nd
1AGAMAAAP292A
1) Se bolt
2. Fold th ROPS woul
ordinarlly be required rthe tail ha in rv (See "MAINTENANCE section)
rs To avoi th
personal injury St
ROPSslowl
an
carefully.
KU80TA
Rais
(1 ROPS
th
ROPS to
ri
siti
1AGAPAAAP057A
(2 Hair pi
cotter
cotters.
CAUTION
To avoi
CAUTION
personal injury
installe
an secure
To avoi with th
hair pi
cotters.
personal injury Ss
cotters.
CAUTION
To avoi
personal injury
os tion an
(1) Set bolt (2 Hair pi cotter
lAGAMAAAP292B
bolt (2 Hair pi cotter
ur
with th
hair pi
tt rs
STARTING 1.
pin.
CAUTION
void personal in ur tracto
is stopped.
afte each adjustment id
on he ra or
1AGAMAAAP295A
(1 Cotter pi (2 Nu
(1 Travel adjust leve
(8 To incr
se te si
ul up he tr ve
'1
djus ever an
or forwar requir d. Th th leve is released
~-
ea
li
seat ac oc
ar
Selectin
osit on he
li ht switch
Turn Signal
light Switch optimu
r' se ha he ea is pr perl ocked. osit on th suspen io adjust andl atth hori onta position.
I:
Turn th ligh switch clockwise, an th followin activate on th switch position (A
FF.... '0 ) ~
(C) i
Hazard Light
suspension setting.
IMPORTANT:
i_]"
ositio s.
~D
lights ar
Head lights OFF. Head lights di med, lo
beam
Head lights ON, high beam.
J,,'I
L:;
it
WARNING
To avoi
personal ir~!Jry:
AB ar
installed.
rd
rn Hazard Light
This seat belt is auto-locking retractabl
type
1.
flashing (hazar
on), turn th knob clockwise.
2.
flashing turn th
knob counterclockwise
3.
light off) turn th knob clockwise. knob counterclockwise. 1AGAPAJAP0458
1) Seat belt
.Tract
ig
(1 ea ligh (2 Side turn igna (3) Taillight p r r ; -
gnal
Hazard ligh Hazard I· Ig ht
.Tract
ig
(1 ea ligh (2 Side turn igna (3) Taillight p r r ; -
GA
gnal
Hazard ligh Hazard I· Ig ht
D4
((~HT.ead (AJ" (BrO (GrO
(LOIir (H GH)"
"HYDRAULIC UNIT section)
"HYDRAULIC UNIT section)
WARNING
To avoi
personal injury
roll-over.
ne ua ra da dj stme tracto to swerve or roll-over.
ca caus th
CAUTION
To avoi
-(1) Position contro leve
personal injury
oa sh ftin
forw rd
ss
contro
perate at re uced speed, perate heel driv engage (i equipped).
th difference an
righ at lo
nd le pedals speeds (F el
usin locked together
1AGAPAJAP003B
th fron
us carefully.
il us rate
be ow
pera io
y)
isen ag
he
(AJ ·UP
6.
Lever
CAUTION
av id pers na
nj ry
stages "HIGH" "LOW an "REVERSE".
tracto to lung in an unex ecte Th
clutch is d d
revers
el
preven
speeds ar obtained
(1 ai ge shif leve (2 Ra ge ea shif leve (Shuttle shif lever)
(1 Clutch peda IMPORTANT:
manner
re atur
clutch
ear:
(L "LOW (N) "NEUTRAL" (H "HIGH" (R) "REVERSE"
IMPORTANT:
clutch pedal.
procee
wi
sp ed change
not. ra Presence Contro system (OPC),
ra
Fron
heel Driv
Leve
CAUTION
To avoi
personal injury
travelin
an pushin
at road speed.
ur
it forwar
decrease
engine speed.
e ct l
wheel drive
load shifting forwar
or os
of ontrol
betwee tw an four whee dr ve Beaware of th difference an us carefully.
stopped. Shif he leve to "O
to en ag th fron wh el
drive.
(1 Hand throttle leve (2 Foot throttle
releas
To
ldr (B) "OFF
IMPORTANT:
whee driv lever. to th tr ctor turn th st erin lever. pave
he
nd
ve th
oads.
jobs:
1. When greate with
front-en
ulli
fo ce is ne de
such
workin
loader (1)Brake pedals
push th tracto forward, or increa ed br king ed ce spee
th
"INCREASE" -EC EASE
lutc
STOPPING
.E
.Stopping 2.
caus
3.
as show
elow
is on se th pa king br ke
C H EC K D U R
Engine oi pressure
DR
pr sc ib
leve th in icator in th n.
Easy
than 1000 hile drivin ak he follow ng chec part ar functionin normally
to se that llth Periodic Servic
section)
lectrica charge
If th
ho ld happ du in op ration ch ck th el ctrica ha ging yste or on ul your lo al KUBOTA Dealer NOTE: your loca KUBOTA Dealer fo instructions
(1)Easy checker(TM) (2)Fue gauge (3)Coolant temperatur
gaug
fuel level. ente th fuel system Bl ed ng Fuel
ys em in as required in Pe iodi Se vice
section)
~~
~(
[B]JO
an
Hourmeter/Tachometer
pera re
peed an th hour th tracto
CAUTION
To av id pers na
injury:
as ee
ti tracto an hour
ee
th
used th Jast digi indicate
1.
"hot".
by referrin
to "Troubleshooting
section.
1AGAPNAP056D
(1) Engine revolutio
(2 Hour
(1 Coolan temperatur
gaug
used
perated.
(A PT
40rp
1/10 of
PARKING
O P ER A N G
.Parking
ECHN QUES
Differential Lock
CAUTION
To avoi
WARNING
personal injury
BEFORE DISMOUNTIN
TRACTO
control:
IM
differential lock engaged. engaged.
in
making
In
turn in fiel
conditions
ra differential lock pedal. Both wheels will then turn together reducing Slippage.
lever.
depressed.
(1 Parkin
brak
(A Interloc th brak (8 "DEPRESS
leve
(C
pedals
P UL L
(1)
ia lo
IMPORTANT:
ss (B Releas
IMPORTANT:
pullin th
ar in
br ke le er
engine down
ff
le er in thei neutra position in re
machine.
th
rkin
br ke
othe is completely stopped. on th brak pedals alternately.
to "DISENGAGE
.O CAUTION
To avoi
To avoi
stra
wh
together Uneven brakin caus th ou te
tracto
maintain steerin
Ro
Terr in
persona injury:
vi
at road speeds coul
to roll-over.
im lement
lo
CAUTION
personal injury ss
rati
tt ched be sure to
stee fo safe operation. av
descending
ability
slope.
vers caus loss of control. itches or anks whic ro
tr
co
ma collapse unde th
wet.
stability. (See Whee Adjustment section)
in Tire
Wheels an Ballas
equipment. to contro
peed withou usin
running. Slow engine peed
brakes.
make th
teerin
little
(1) SMVemble (2 Bracket
powe steering.
er ng op ed
speeds.
P T O O P E RA T O N
NOTE:
ee
is po it on ay
ar ou
lo oo er
io
im
P T O O P E RA T O N
NOTE:
tachometer board.
CAUTION
To avoi
le
personal injury
equipment.
followin 1.
OC 1.
is in th erig ge
"ON" position
steps. ti s. ta
th engine 3. Tilt th operator's seat forward. 4. lu
2.
(1
2) PT (1 PT
clutch contro feve
Ta speed. NOTE:
peed wh engaging th TO th to th re mm nded peed
pe th throttle stop automaticall
lever half way.
Engine Spee rpm
clutch cont ol leve
5.
f!
IMPORTANT:
weather. no onti uously
~"ON"
ea
hift th PT
Shaft
utch contro le er
rpm
afte standing up.
28
ct th
(1 PT
shaf
PT
shaf co er
over
(AJ"NORMAL POSITION" (BJ"RAfSE POSfTlON"
DRAWBAR
H R E E P O IN IN T H I C H
DRAWBAR
(2 Li ting ting ro Le t) (3 Tele Telesc scop opic ic stab stabil iliz izer er (4 Lowe Lower, r, link link (5) Lift Liftin in ro (Rig (Right ht (6) Drawba Drawba (7 Fi ed draw drawba ba ra (8 wi draw drawba ba ra
1AGAPAJAP0568
if quip quippe ped) d)
29
3 ·P · P O IN IN T H I C H Attach chin in 2. Atta Make Make pr ar ti ns fo implement.
nd
et chin chin
impl implem emen ents ts
tt chin chin
CAUTION
Hydr Hydrau auli li Cont Cont ol Unit Unit Us Re eren erence ce Char Chart" t" in Hydr Hydrau auli li Unit Unit sect sectio ion. n.
oi
rs
al inju injury ry
le
arki arki
ra
is
ppli ppli
surface.
full full rang rang
er ti
PT
fo inte interf rf re
ar ti
in fter fter adju adjust stme ment nt ight ighten en he lock lock nu secu secure rely ly
em
lo
ou ed
le
it
in in
nd
be
attached.
le
.Top Link
posi posi io by shor shor enin enin or leng length then enin in he to link link Afte Afte adju adjust stme ment nt tigh tighte te th lock lock nu secu secure rely ly ei
THREE~POI THREE~POINT NT HITCH
THREE~POI THREE~POINT NT HITCH
DRAWBAR .Tel .Teles esco copi pi
Stab Stabil iliz izer er
WARNING
Adju Adjust st th tele telesc scop opic ic stab stabil iliz izer er to cont contro ro hori horizo zont ntal al sway sway of th impl implem emen ent. t. Afte Afte alig aligni ning ng sati satisf sfac acto tori rily ly inse insert rt th setset-pi pi
thro throug ug
id
rs
in ry
an the
tractor
to
pers person onal al inju injury ry or death.
locked.
permitted.
drawbar. "IMPLEMENT LIMITATIONS" section.
1AGA 1AGAPA PAJA JA
(1 (2 (3) (4 (5
05SA 05SA
Oute Oute tube tube Set-p Set-pin in Hole Hole Slot Slot
prev preven en he
ro
hitt hittin in th trac tracto to re
wh
ls
1AGAPAJAP059A
(1 PT shaf shaf (2) Drawba Drawba (3 Draw Drawba ba pi
Hole Holes: s: (A), (A),(B (B
DRAWBAR
Dr
by
in th
igure.
1AGAMAAAP310D
Hole:
H YD R AU L
UN
IMPORTANT:
op rati hydrauli
ydraulic
is ttem te wh he en in system ma be damaged.
echa is
is
adjusted
till old, th
roperly. Unless
he im le en
lightl to
intain
onstan
ull.
KUBOTA Dealer fo adjustment se he im le en pull with th
PO NT HI CH CON
OL
raft
nt
le er
H YD R AU L
UN
IMPORTANT:
op rati hydrauli
ydraulic
is ttem te wh he en in system ma be damaged.
echa is
is
adjusted
till old, th
roperly. Unless
he im le en
lightl to
intain
onstan
ull.
KUBOTA Dealer fo adjustment se he im le en pull with th
PO NT HI CH CON
egardles
th
ou
raft
nt
le er
OL
ll requir
lever.
(1 Draf contro leve (2 Position contro leve
(1 Position contro leve (2 Draf contro leve
(A "UP" (B "DOWN" (C "FLOAT
(A) "SENSITIVE" (B) "INSENSITIVE" (C) "FLOAT"
ro
we
Sp
CAUTION
To avoi
personal injury
injury
implement. Lowe th draf contro leve to th poin wher
au in
loss of trac io
owerin
ju te
adjustin
an ground sp ed
ee
to tw
th
pl re
-p in lo erin
en
ho ld be
co ds
spee kn b.
lAGAIAZAP079A
(1 Ground surfac (2 Implemen penetrat (3 Ligh soil
[wit
(1 3-Poin lowering spee
knob
limi
(A "FAST" (B "SLOW" (e) "LOCK"
Draf control]
lever
freely alon with th ground conditions [wit
Position control]
conditions.
A U X IL IA R Y H Y D R A U L C S .Hydra li
MO H YD R U L equipped)
Type Outlet
lo
.D
le
ti
C ON T O L
Valv
loader fron blade, etc. Wh
implem
is
ttac ed
Leve will return to neutra when released
IMPORTANT:
YS
A U X IL IA R Y H Y D R A U L C S .Hydra li
MO H YD R U L equipped)
Type Outlet
lo
.D
le
ti
C ON T O L
YS
Valv
loader fron blade, etc. Wh
implem
is
ttac ed
Leve will return to neutra when released
IMPORTANT: show
in th Illustration
re ie
lv
te
io
will
rh
l.
simultaneously.
(1 Remote contro valv leve (1 (2) Remote contro valv leve (2) (3 Remote contro valv leve (3
(A "FORWARD" (B "REARWARD"
--t>
Pressure Returning Leve (1 (1
Bloc cove
(A Fr nt ea pump implement ax fiow 31.7 Umin (8.4 gals./min) Ma pressure .7 /c (C From implemen (Outlet) (D From impl ment (Tan port
Port
Port
In Out
Out --{>
In
Out
In Out
--t>
--t>
In Rearward
Port
Out
In
--t>
In
--t>
em ntro ve up er onnecting and Disconnecting This va ve ma
lace
th floa
de
th th contro
CAUTION
To av id personal injury
or retract, lettin implemen follow th ground
connecti
or disconnectin
lines. s.
ea
both coup ers.
3. In
4.
coupler. couplers ar firmly connecte ti
1.
(1 Remote contro valv leve without float position (2 Remote contro valv leve with floa position
(AJ "FORWARD" (B) "REARWARD
hydrauli
pressure in th
hydrauli
couple to releas
2. Clea th couplers 3.
hoses.
dust plugs. Pressure
--{>
Returning
couplers to hydrauli
Leve (1 Port
Out IB
Out.
In Full Rearward
Leve (2 Port
In [O
Out
Out
t>
t>
In
Float Float
Couple size or [A [B
[DJ
PT 1/
NOTE:
position th transmission flui
Co su
NOTE:
yo
ocal KU OT
ma overheat
le fo fu th
detail
hoses.
it.
or er to andl th hydr ul cs applicable to al ty es
ro er y, th
impl ment
pera or must be fami ia wi
th followin
an soil on itions it is se ul fo ge er
this info mati
j4.i
ot
~ .
Remarks
lAGAMAAAP3H8
iAGAPAJAP006F
Soil condition
ma
ondition
J .
Implement
houg
Gauge wheel
To link
op in
lever
1AGAMAAAP316A
1AGAPAJAP046D
Telescopic stabilizers
lever (2
Draft control lever Light soil
or 2or3
Heavy soil or
2or3 i
Harrow (spike, springtooth, disc type or
Sub-soiler ..
Weeder, ridger ... Earthmover, digger, scraper, manure fork, rear
Position control
Insert th set-pin throug th
Draf an Mixed control
oute tube that alig wi on of
Plac th draft control ot
Loose
suitable position an se th implement pull with the position control lever Position control Hold th draft control leve at th most fron position
YES
YES/NO
Tighten
th inne bar. For implements with gaug wheels, lowe th position contro leve al way.
Telescopic stabllizer should be tigh enough to prevent excessive implement movement when
HE WHEE
TIRES WARNING
To void
A D JU S M EN T CAUTION
erso al injury
To void
erso al injury
tr il r,
th
fo maximu
proper equipment
removing ressur
show
in th
oper tor'
id
ti
stability. wheel.
anual. vices. ca ttle or ccid nt ll lowered, If necess ry to work
IMPORTANT:
servicin
KUBOTA
it
.I fl ti
ress re
vel, it at ra ro lo chec it everyday an inflat
he ours as necessary.
ri of ime. Thus
kgf/cm',
20 psi)
kgf/cm',
20 psi)
kgf/cm',
32 psi)
Rear
st nd
ro
Wh
suitable
lockin
before and.
wi
tw
wh
rive
standard equipped tires. change
17.5L-24, 6PR
8.
or djustment, securely su port them
or axle
0k
27
re
re
id
mounting bolts. position an tighte th bolts.
15
Front 0k
kgf/cm',
20 psi)
kgf/cm',
20 ps
(See "Adjusting Toe-in in Maintenanc
section)
NOTE: ro weights
Tires Dual tire ar no approved
1AGAPAJAP049A
1) ront axle ountin bo 147 N-m (12.6 to 15.0 kgf- (91. to 108A ft /b (2 Tie-ro mounting bolt 71 N-m (6.2 to 7.2 kgf-m)(44. to 52.1 ft-/bs) 3) Ti od clam
1AGAPAJAP036A
1 A A PA JA P0 3
1AGAPAJAP038A
1AGAPAJAP039A
Models
Farm ~ - - - - - - - - + - - - - - - - - - - - - - - - ~ - - - - - - - - - - - - - - - - r - - - - - - - - - - - - - - - - r - - - - - - - - - - - - - - ~ (50A
IMPORTANT:
(50.
in.)
NOTE:
1AGAMAAAP318A
Fron tr ad ca
ot
ad usted.
Tire
8.3-16 Farm
read
1155mm (45. in.)
~i
27
8.50-15 Turf
27
1200 mm (47. in.)
10-16.5 IN
i0.50ll15 Turf
1180 mm (46.5 in.)
1195mm (47. in.)
NOTE: D.. fo nd stri IMPORTANT: NOTE:
1AGAMAAA.P318A
tr
widt is
in
ts
2.
standard equipped tires.
Models
le t) to
ir
itio
ig
ts
tr
widt is
in
ts
2.
le t) to
standard equipped tires.
ir
itio
ig
ts
Models
14.9-24 1i
8i 1500 1i
Models
44x18-20 Turf
(56.
in.)
th
re
IMPORTANT;
be damaged. to th
ll wi
to
service interval. (See "MAINTENANCE
1AGAPAJAP050A
section)
ft
ri in
he
BALLAST
Ballast Ad weig rear heel eede improv trac on fo stability. Th amount of rear ballas should be matche
CAUTION
To avoi
personal injury
needed. liquid ballast, rear whee weight or
combinatio
of both
used. arW ee
Th rear wh el
maintain steering control.
eavy rear
ounted mple
revent ip over
emov
nt
en
eigh
he
li fron
ig
eigh
n)
an be ttache
he rear heel
heels.
onge need d.
he fron en eigh ca be at ac ed he bu per. Se yo implemen pera or's anua fo required nu be of eigh cons lt yo loca KUBO De le use.
1AGAMAA.AP320B
(1 Rear whee weight
IMPORTANT: Do no overload tires.
aximum weight pe whee 1AGAMAA.AP320A
(1 Fron en weight (2) Bumper
IMPORTANT:
25 kg
pieces (386Ibs.)
aximum weight NOTE;
(optio on 4W
models).
Pieces (185Ibs.)
.!
economical ballast. Used properly it will no da ag tires, co this th
re weig ti
th ir
iq id
th wa er from fr he ee th
es ei
tire
tire rc
in ul
le fo hi
Us ro rv ce
fill
Tire size
x.
.)
of water] .,
Slus free at -2 "C (- 1°F) [Approx. 1. kg (3.51bs. of water
[A
x.
.2
I bs .
of water
IMPORTANT: .f position).
1AGAMAAAP321A
(2 Wate
(8 Incorrect-10
compressed
cushion Full Wate ca no be
MAINTENANCE S E R V C E N T ER V A L Indication on hour mete
Items
No. Engine oi
Engine oi filter
Hydraulic oi filter
Transmission flui
r on t a xl e c as e o i (4WD) Fron axle pivo
400 Change
Replace
Replace
Change
Change
Adjust
Engine star system Whee bolt torque
condition
Ai cleaner elemen [Doubl elemen type] Primar
500
55
600
650
elemen
Check
Check
every
every
every
every
every
every
every
every
55
61
61
64
65 66
53
54
55
Check
every 10 Hr
59
Clean
every 10 Hr
56
'1
Replace
every year
66
'2
Replace
every year
66
11 Ai cleaner elemen [Doubl elemen type] Secondary
Ref
00
every
Greasing
Batter
rQ
450
Since
element Fuel filter elemen
lean
12
Replace
13
Fa
belt
Clutch
Brake
16
Radiator hose an clamp
Adjust
17
every
every
57
65
57
Adjust
every 10 Hr
58
Adjust
every 10 Hr
58
Check
eplace Powe steering oi line
every 10 Hr
Check
eplace
every
every y ea r every
every y ea r
62
68
63
68
MAINTENANCE
Indication on hour mete
Items
No. Fuel line
200
50
250
Check
every 00 Hr
59
Replace
every ye
68
18
19
Toe-in
every
Adjust
Intake ai line
45
63
every
Check
20
63
every year
Replace
"3
68
'3
21
Greasing (2WD fron whee hub)
22
Engine valv clearance
Adjust
every Hr
66
'4
23
Fue injectio nozzle Injection
Check
every 50 Hr
66
'4
66
*4
every
every
24
25 26 27
29
65
Coolin
system
Coolant
Flush
every year
66
Change
every year
66
Fue system
Bleed
Clutc water
Drain
Service
Replace
required
housing
Fuse
68
Replace
69 69
70
IMPORTANT:
*1 Air Replac
it only if necess ry
(@
en in Pl as
arke
ar
egiste ed as emissi
acco ding to he abov instru tion se Warran Stat ment in detail
elated critical le
ar
KUBOTA inthe U.S.EP
no road
LUBRICANTS Locations
No.
Capacities
Lubricants
42 (11.1 U.S.gals.
Fuel
(6. U.S.qts.)
No
-D dies
fu
-10 t(14°F) Fres clea wate with anti-freez :AP
rv SAE30,SAE10W-30 or 10W40
Above 25"'(;(77'F)
Engine crankcase (with filter
(8. U.S.qts.)
SAE20,SAE10W-30 or 10W-40
to 25"(;' (32 to 77'F)
SAE10W,SAE10W-30 or 10W4
Belowo'c (32'F) Transmission case
40.0
Fron axle case [4WO]
(10.
U.S.gals.)
9 U
D - S
0 g
Greasing
r o e o
[2WO] [2WOJ
Fr nt xl supp rt [4WO]
[wit Draft Contro (i equipped)]
ck
Batter
Unti grease overflows.
terminal
mo
NOTE:
CG-4
Fuel Low-sulfur CF CF-4
CG-4
High-sulfur
Remark T8N~10
rate
mo
Multipurpose typ grease
sy te (C Do
co ul
ur lo ix iffere
et
lu ri UB ra
ti
tr ssio it orta ha lti-gr ra is io luid us KUBOTA SUPE UOT fluid fo optimu protection an performance. Deal or rthe tail.) ra s.
in
is
PER OD
RV .Hood
CAUTION
To avoi
personal injury
ic s.
ey
or beaccidentall
an se tl
ud
ly
ea
lowered. If necessar
own, to work
servicin or adjust ent, securely suppor them with stands or suitable blocking beforehand
CAUTION
To vo
er on
jury ro
ntac
th
ovin
parts; running. th
re ho
suppor
link
re ur
ul
es lt
(1 Mascot (2 Hood
(AJ "OPEN"
NOTE:
suppor link.
1AGAPAJAP007A
) S
) " (B "PUSH"
DA
CH CK
cover.
ng
2.
CAUTION
To avoid persona injury
to check and parking brak
ok
"ON"
un
as lo
parts
ec
fu li
1!\GAPAJAP008A
CAUTION
(1 Side cove 2) Wing ol
es
fron cover.
injury: th
ngin
ef re refu li
by fuel gauge. he
/4
tank. ov se grad o.1- ie el fuel at te pe atures belo -10t (14°F).
(1 Fron cove 2) in bo (3 Groove (4 Pi
Fuel tank capacity
42
(11.
.S.gal .)
PERIODIC SERVIC
50
IMPORTANT:
therwi ai will te he ue syst bleeding before next engine start.
CAUTION
fire.
at
fu
ecessitati
tank fill he ta
befo
pa ki
ve ni
oil level.
t.
1. Pa
NOTE:
th
chin
in te
in industrial an heav (SAE J313 JUN87)
fla surface.
re afte he ngin
stop ed
3.
mobile service.
clean, replac
it,
0975
Flas
Point,
cC (F
Temperatures,
"C
(oF)
90%
28
33
(See "LUBRICANTS" in Maintenanc
Ash weigh volume
section)
10 percent Residuum,
Min 52 (125
the prescribed
Max
0.05
Kinematic cS or mm'/s 40 "C
0.01
0.35
Viscosity Saybolt, SUS at
Capweight
Min
Max
Max
32.6
40.1
0.50
Strip Cerrosian
NO.3
Cetane Nurnber
40
1AGAPAJAP027C
1)
il inlet
(A
(1) Dipstick
il leve is acceptable within this range.
IMPORTANT: ve
ix wo iffe en type
i!
im le en
nd hu
ff en in
CAUTION
To avoi
t. (See "LUBRICANTS" in Maintenanc
personal injury
Section) completely.
"FULL" an "LO,""J"mark of recovery tank
ra to (S "Flu olin st an ever year maintenance)
an in
Co la t" in
(5 q)" AGAPAJAP024A
(1) Gauge
(2
A)
il leve is acceptable
it in this range.
il inle
IMPORTANT:
1AGAPAJAP022C
(1 Recovery tank
(A "FULL" (B "LOW
IMPORTANT:
ca ti
ab ve
recovery tank Dealer.
curely retighte
th
p.
CS
Checker(TM)
CAUTION
To avoi
mete (s an Easy Ch cker(TM) lamps. 2. Replac if broken
personal injury
Be screen.
1. left.
remove al th foreig
material
attachin
(1 Radiator screen (2 Knob bolt
IMPORTANT:
fo th ai cleane
and Clutch Pedal
WARNING
To avoi
personal injury
eq
ra
ra
tm er
ro l-
smooth operation ju hours maintenance)
HO
Br
r.
hardware before operatin
tractor.
HO .L foll wing points very conditions lubricat
ours
grease fittings more often.
(1 Grease fittin (Frant axle support)
(1 Grease fiftin
(Knuckle shaft)[RH, LH
re ov th br th pl an pply reas ov rflows from reat er lu port Afte greasing reinstal th breather plug
ntil re
(1 Grease fittin (2 Grease tittin (3 Grease fiftin
(Top link (Lifting rod) [RH] (Top link bracket)(wit
1AGAPAJAP011A
(1 Grease fittin (Front axle support) (2 Breather plug
(1 Batter
terminal
draf contra/)(i equipped
CAUTION
To avoi avoi
pers person onal al inju injury ry
testing. oper operat at re
rati rati
th
tract tractor or
befo before re test testin in
th "N
TR
ON th th
ft
(1 Clut Clutch ch peda peda (2 Rang Rang gear gear shif shif leve leve (S uttl uttl (3 PT clut clutch ch cont contro ro leve leve
shif shif leve lever) r)
th
"S
service.
ft th
to OF
position. tc
service. th th ta
second. fo this this serv servic ice. e.
PERI PERIOD ODIC IC SERV SERVIC IC
PERI PERIOD ODIC IC SERV SERVIC IC
oa
CAUTIO~. dp r a
EVERY
ol Torq Torque ue
Checkmg
r o
Changing wheel,
WI
s a
HOURS.
y. the engm
To avoi
d r
o c an
them them tigh tight. t.
espe especi cial ally ly when when
tr
n p ea dd
he
01
engi engine ne is still wa.rm 2.
nanc nanc sect sectio ion) n)
eo
AGAPAJAP050A
N-m (14 2) 21 N-m (22
ft-fbs ft-fbs 60 ft-fbs ~ g ~ ~100 ~ :ft-fbs
U.S.qts.)
56
PERI PERIOD ODIC IC SERV SERVIC IC
Cleaner Prim Primar ar Re Cl
th he ri
le ne ry le en
Elem Elemen en ri
ry
le en
th elem elemen en in dete deterg rgen en fo 15 minu minute te then then wash wash
1AGAPAJAP013A
(1 Drai Drai plug plug
3. Re la
ir le
er ri
ry elem elem nt
comes comes first. first. NOTE:
dust.
(1 (2 (3 (4
Seco Second ndar ar (saf (safet ety) y) elem elemen en Prim Primar ar elem elemen en Cove Cove Evac Evacua uato to valv valv
IMPORTANT:
to th elem elemen ent. t. wher wher repl replac acin in Ever Ever
is requ requir ired ed
Year Year main mainte tena nanc nce) e)
place.
CAUTION
To avoi
rins th inside with kerosene
personal injury
tension.
rinse. Proper fa belt tension
dust an dirt (See "Bleedin
Fuel System in servic as required.)
pulleys. bolt and, u~in
leve placed betwee
th alternator
deflection of th belt fall within acceptable limits
1AGAIAZAP080A
1) Fuel cock (2 Fuel fifter bowl
(A "CLOSE
(1 Bolt
AGAIAZAP
(1
(2 (3 (4 (5)
77A
ring Filter elemen Spring Filter bowl Scre ring
IMPORTANT:
je io nt is
le
je re to le
re filt
ar wl
(A Chec th be tensio (B To tighte
.A just ng Proper clutch peda free travel
20 to 30 mm (13/16 to 1-3/16 ln.) th pe al
rakePe al
CAUTION
personal injury
To avoi
checking brak
tr ve at to of pe al stroke
acceptabl
pedal.
(5/8 to 1 3 / 1 6 in.)
Proper brak peda fre travel
limits
Keep th fr tr ve inth rjg~ an left br ke pe al equal.
Releas th pa king rake travel
th
acceptabl
(1 Clutch ro (2 Nu (3 Cotter pi
op of ed
stroke
limits
(A Free travel
(1 oc nu (2) Turnbuckl
(A Free trav
.Checkin an no damaged.
Batter
ondition
DANGER
void th
ssibilit
tt ry
lo io
instructions below.
level) mark rt
therwise th re
turely
batter teri rate
componen wh ch
re leve is betwee th
UPPE
an
LOWE
levels
CAUTION
To avoi (1) Fuel line (2 Clam band
NOTE:
fuel system
personal injury
running.
ge me ical attentio workin
around th
battery.
maintenance) Th factory-installe
attery is of non-refill bl
Mishan ling he ba tery horten th servic if an ad to maintenanc costs. he or gi al ba er is ai tena ce ree, ut need so servicing.
batter periodically
Chec th batter conditio Stat Green
White
by readin th indicator.
batter of equa specificatio
show
in tabl
Table
of indicato displa
Specif gravit of el ctroly nd qual ty electrolyt ar both in good condition.
Need changing battery.
Reserve
CCA
Normal
13
582
6.5
CCA: Cold Cranking Ampere
1. When storin
th tracto fo 1011period remove th batter from tractor, adjust th electrolyt to th proper
CAUTION
he batt ry self di ch rg Recharge nd ce ever ix mo th hargin
he
at ery. (if equipped)
(1) Batter
1.
positi
1.
ermina to he harger po itiv
terminal an
standard fashion.
Wh usin oost charge tt ry it is ecessary recharge th batter as earl as possible
whil
it is tored.
in cold seasons.
CAUTION
CAUTION
To avoi
To avoi
personal injury
oi filter cartridge.
oi filter cartridge.
th ne
r.
transmission case an drai th oi completely intoth
filter.
fter dr inin reinst ll th dr in
th surface. Tighte filter by hand an additional rm ll de re
personal injury
little
th il le on th di ti Th il up to th pr cribed le l.
lug.
turn only
ke sure th
th
ngin
re le is th
ngin
(1 Drai plug
th
r.
1AGAPAJAP027B
(1 Engine oi filter IMPORTANT:
KUBOTA genuin filter.
1AGAPAAAP004A
(1) Hydraulic oi filter
th ne filt r. te fi rf e. then ti ht it
ha
ta an ad itio al
ti /2 turn
Chec to se if ra iato ho es ar hour of oper tion si mo th
roperl fixe ev ry 20 hi he er co es fi st
securely. 2.
radiator hose ar swollen, hardened or cracked. Repl ce os an os cl mp ev ry year or ea lier cracked.
(1 Oi (2 Gauge
7.
Oil leve! is acceptable within this range.
fter ru ning th engi
fo
leveL 8.
throug
th seal
IMPORTANT:
1AGAPAJAP020A
(1 Radiator hose (2 Clam band
temperatur is nearly is called "Overheating unloaded idling 2.
minute
of unloaded idling
3. 10
th caus
of overheat ng
cc rdin
th ma ua
th engine
.Adjusting not damaged.
oe-i th
ra
.Adjusting
oe-i
not damaged. re lace
th
re ai th
ce
ahead position. th engine.
ra
th
hub height. hub height. less than rear ista
If ot
dj
ti ro length
iAGAPAJAP022A
se
iAGAIAl.A,P072A
an no damaged. re lace
repair th
(8)
ce
(C "FRONT
[4WO]
proper toe-in measuremen is obtained th t. in th -r
o we r
er
p re s
hoses
!?/i--",_____..,,~
Il\~~ 1AGAPAJAP023A
HO proper toe-in measuremen
is obtained
CAUTION
avoi
ft
personal injury to co
letely to th il pa inin ei st ll th
fficie ly
ra
ug
er line th ga (See "LUBRICANTS" in Maintenanc ec th
il le
Oil capacity (1 Snap ring (2 Tie-ro nu (167 to 19 N-m, (3 Tie-ro join
7t
20 kgf-m)
(2 Oi fillin plug
(1 Drai plug
in
Section) ..
dd il to re ri ed le .6 U.
al .)
l.
IMPORTANT:
is
maintenance)
at 2. 3. 4. Fill
port.
5.
1AGAPAJAP025A
( 1 ) C h e ck p lu g (2 Fillin plug
Detach th cover, an appl bearin
grease
EVERY
HOURS Coolant
whee vibratio
ca occu causin vibratio
in th steering
wheel.
CAUTION
To avoi
/6 turn
et ghte
personal injury
th
time
lock nut. completely.
re
ve
ll
to co
irecti
letely
rain th co la t.
th cl
instructio re ra
Instal th radiator ca securely tank.
1 A A PA JA P0 1
(1 Adjustin 2) oc
scre
if necessary. 11 Properly dispos
H OU R onsu
ou loca KUBO
of used coolant.
le fo this ervice
H OU R In
ti
Pressure onsu
ou loca KUBO
le fo this ervice
H OU R onsu
EVERY
ou loca KUBO
le fo this ervice
YEAR 1AGAPAJAP026A
an
Secondar
(See Cl in ir Cl hours maintenance)
Elemen Prim ry
1) rain
le ent" in very
oc
types. Us ethylene glycol EG ty
fo th
radiator with fres wate an empt
again.
2.
engine fill the
inside. (%) for
then fill into th radiator
034 standard, more specifically also to SA
1AGAPAJAP022B
(1 Radiator ca (2) Recovery tank
(A
"FULL"
(8
LOW"
J814c.
IMPORTANT: antifreeze mixing rati must be less than 50%.
IMPORTANT: no star engine withou coolant.
Vol Anti-freeze
radiator.
OF
°C
°C
40 50
At 1.01
O'Pa (760mmHg pressure (atmospheric).
could overheat. pressure
Anti-Freez
ithi th co ling system
5. Adding th LL (1)
CAUTION
by evaporation.
percentage.
poison.). ta
of
medi al attention.
different
differen additive components an th engine ma fail to perfor as specified.
of immediately.
cleaning agent. Th ausing harmfu substances
LL
contains anticorrosiv
agent.
adversel affectin th engine parts. years. NOTE: concentrated antifreeze. ater on
antifreeze.
"C
radiator.
to keep th antifree
mixing rati le
than
68
PERIODIC SERVIC
RV CE lace th oses clamps (See Ch ckin di to se an hours maintenance)
la
in
very 20
Ai
st
R E Q U IR E re
he ta
2.
ve is ompl tely
ty
3.
lace th
se
cl
time.
ps in
maintenance)
lace th
se
clamps
maintenance)
sult your loca
UBOT
eale fo hi servic
lAGAPAJAP027A
(1 Fuel oc 2) en
th
st
(A "CLOSE" (B "OPEN"
en in
IMPORTANT:
lines. Otherwise, engine runs irregularl
housing. wate ma ge into th clut
damage by fuses. housing. Chec it by pushin
somewher
in th electrical system
th same capacity
or stalls frequently
housing. wate ma ge into th clut
damage by fuses. housing. Chec it by pushin
somewher
in th electrical system
th same capacity an drai th water, them instal th plug again. IMPORTANT:
electrica problems.
1AGAPAJAP0138
(1 Spli pi plug
1AGAPAAAP063A
1AGAPAJAP028A
Protecte
CAPACITY(A) (1
15
(2
10
(3
10
(7)
circui
Hazard
Panel
St rt
rela
(8)
125W Taillight
8W
Turn signal Turn signal
1.7W
STORAGE
STORAGE
STORAGE Re he er he er followin th batter storag procedures (See "Battery condition" in ever hour in periodic servic section)
CAUTION
To avoi
personal injury
running.
closed building withou proper ventilation.
operatin
A C TO R
th tracto an gettin
injured.
O RA G E
sheltere from th elements Cove th tractor. St th tr ar from sunlight an excessiv heat If th tracto must be stored outdoors cove it with waterproof tarpaulin.
ee
ti
ec
he
IMPORTANT:
of time follow th procedures outlined below. washing. coole down
from storage.
MO STORAGE
necessary.
HE
C TO R
OM
ar low. fr un ax 3. Instal th battery. Before installing th battery, be sure itis full charged.
part fo abou five minutes. ng e, rust making clutch disengagemen nex operation.
at impossible at th implements). e.
er
es.If
ac engine off inspection lookin fo evidence of oi or wate leaks. brak an test th brakes fo proper adjustment as yo move forward. Adjust th brakes as necessary.
(1 Wooden bloc
TROUBLESHOOTING E N G IN E T R O U B L E S H O O T IN G
rr
Trouble
Countermeasure
Cause fuel ow Replac
filter if necessary.
nu ar tight. le th ue system maintenance) ng ne is ifficu won't start.
st rt or
se oi
of di eren vi cosities de ending on
Us engine bloc heater (Optional) the
Clea
batter cables
terminals.
enough. In
Insufficient engine power. Engine stop suddenly
Insufficient or dirt fuel le
or replac
Refuel. le th
Insufficient fuel.
th elemen
ue system
ha ge he ue an
nece sary ue
lter
Black Exhaus fume ar colored.
..
is white
the
d w Injectio nozzle trouble. Fuel qualit is oor.
..
Engine overloade Lo
co la
leve
il coolin system connection
Engine overheats ir
radi to core or gr ll screen
Coolan flow rout
corroded
or leaks.
Remove al trash. Flus
coolin
system
he correc evel hoses
OPTIONS Cons lt ou loca
Fo extremel
UBOT
Dealer fo furthe detail
cold weathe starting
High visibility fo nigh work
Fo fron ballas Fo rear ballas
1890,
over 1,000 small.
ti
Necessitie
construction
ts
re
ts
Giant.
an
transportation
know-how,
too
can