GA 55.pdf

Atlas Copco Stationary Air Compressors GA 55+, GA 75+, GA 90 Aircooled GA 55+, GA 75+, GA 90 Watercooled Watercooled

Parts list

From following serial No. onwards: AII 380 000

•

•

Copyright 2006, Atlas Copco Airpower n.v., Antwerp, Belgium. Any unauthorized use or copying of the contents or any part thereof is prohibited. This applies in particular to trademarks, model denominations, part numbers and drawings. Use only authorized parts. Any damage or malfunction caused by the use of unauthorized parts is not covered by Warranty or Product Liabili ty.

No. 2930 1430 01 Registration code : APC G 55-90 / 39

2006-06

www.atlascopco.com

Parts list

Contents Inhoud Innehåll Inhaltsverzeichnis Table des matières Indice

Compressor element(s) and drive gear  Compressorelement(en) en aandrijving Kompressorelement och drivning Kompressorelement(e) und Antrieb Elément(s) compresseur(s) et entraînement Elemento(s) compresor(es) y accionamiento Elemento(i) compressore e ingranaggi di azionamento Kompressorelement og drivhjul Elemento(s) compressor(es) e accionamento Kompressorelement(er) og drivgir  Kompressorielementit ja voimansiirto ............................... Air inlet Luchtinlaat Luftintag Lufteinlaß Admission d’air  Entrada de aire Presa d’aria Luftindsug Admissão de ar  Luftinnløp Tuloilma.............................................................................. Unloader  Ontlader  Avlastningsenhet Entlastungsvorrichtung Déchargeur  Descargador  Gruppo di messa a vuoto Aflaster  Sistema de descarga Avlaster  Kevennin............................................................................. Air receiver  Luchtketel Luftbehållare Luftbehälter  Réservoir d’air  Depósito de aire Serbatoio dell’aria Oliebeholder  Reservatório de ar  Luftbeholder  Ilmasäiliö ............................................................................

2

Indice Innholdsfortegnelse Índice Indholdsfortegnelse Sisällysluettelo

1

Air flow and cooling system Luchtstroming en koelsysteem Luftflöde och kylsystem Luftstrom und Kühlsystem Flux d’air et circuit de refroidissement Flujo de aire y sistema de refrigeración Flusso d’aria e sistema di raffreddamento Luftflow og kølesystem Fluxo de ar e sistema de arrefecimento Luftstrøm og kjølesystem Ilman virtaus ja jäähdytysjärjestelmä -

2

3

Oil system Oliesysteem Oljesystem Ölsystem Système d’huile Sistema de aceite Sistema dell’olio Oliesystem Sistema de óleo Oljesystem Voitelujärjestelmä ...............................................................

7

Air outlet Luchtuitlaat Luftutlopp Luftauslaß Sortie d’air  Salida de aire Mandata dell’aria Luftafgang Saida de ar  Luftutløp Paineilmaputki -

4

5 GA (W) ...... ............ ............ ............ ............ ............ ............ ........... ........... ............ ............ ............ .......... 6 GA (A) ...... ............ ............ ........... ........... ............ ............ ........... ........... ............ ............ ........... .......... .....

-

8 Pack - GA (W) ...... ........... ........... ............ ............ ........... ........... ............ ............ ............ .......... .... 9 Full Feature Feature - GA (A) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ....... 10 Full Featur Featuree - GA (W) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ..... 11 Pack - GA (A) ...... ............ ............ ............ ............ ............ ........... ........... ............ ........... .......... .....

2930 1430 01

Parts list

Contents Inhoud Innehåll Inhaltsverzeichnis Table des matières Indice

Compressor element(s) and drive gear  Compressorelement(en) en aandrijving Kompressorelement och drivning Kompressorelement(e) und Antrieb Elément(s) compresseur(s) et entraînement Elemento(s) compresor(es) y accionamiento Elemento(i) compressore e ingranaggi di azionamento Kompressorelement og drivhjul Elemento(s) compressor(es) e accionamento Kompressorelement(er) og drivgir  Kompressorielementit ja voimansiirto ............................... Air inlet Luchtinlaat Luftintag Lufteinlaß Admission d’air  Entrada de aire Presa d’aria Luftindsug Admissão de ar  Luftinnløp Tuloilma.............................................................................. Unloader  Ontlader  Avlastningsenhet Entlastungsvorrichtung Déchargeur  Descargador  Gruppo di messa a vuoto Aflaster  Sistema de descarga Avlaster  Kevennin............................................................................. Air receiver  Luchtketel Luftbehållare Luftbehälter  Réservoir d’air  Depósito de aire Serbatoio dell’aria Oliebeholder  Reservatório de ar  Luftbeholder  Ilmasäiliö ............................................................................

2

Indice Innholdsfortegnelse Índice Indholdsfortegnelse Sisällysluettelo

1

Air flow and cooling system Luchtstroming en koelsysteem Luftflöde och kylsystem Luftstrom und Kühlsystem Flux d’air et circuit de refroidissement Flujo de aire y sistema de refrigeración Flusso d’aria e sistema di raffreddamento Luftflow og kølesystem Fluxo de ar e sistema de arrefecimento Luftstrøm og kjølesystem Ilman virtaus ja jäähdytysjärjestelmä -

2

3

Oil system Oliesysteem Oljesystem Ölsystem Système d’huile Sistema de aceite Sistema dell’olio Oliesystem Sistema de óleo Oljesystem Voitelujärjestelmä ...............................................................

7

Air outlet Luchtuitlaat Luftutlopp Luftauslaß Sortie d’air  Salida de aire Mandata dell’aria Luftafgang Saida de ar  Luftutløp Paineilmaputki -

4

5 GA (W) ...... ............ ............ ............ ............ ............ ............ ........... ........... ............ ............ ............ .......... 6 GA (A) ...... ............ ............ ........... ........... ............ ............ ........... ........... ............ ............ ........... .......... .....

-

8 Pack - GA (W) ...... ........... ........... ............ ............ ........... ........... ............ ............ ............ .......... .... 9 Full Feature Feature - GA (A) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ....... 10 Full Featur Featuree - GA (W) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ..... 11 Pack - GA (A) ...... ............ ............ ............ ............ ............ ........... ........... ............ ........... .......... .....

2930 1430 01

Parts list

Contents Inhoud Innehåll Inhaltsverzeichnis Table des matières Indice

Indice Innholdsfortegnelse Índice Indholdsfortegnelse Sisällysluettelo

Air dryer  Luchtdroger  Lufttorkare Lufttrockner  Sécheur d’air  Secador de aire Essiccatore d’aria Lufttørrer  Secador de ar  Lufttørker  Kuivain -

Full Feature ...... ............ ............ ........... ........... ............ ........... ........... ............ ............ ........... .....

Start cubicle Startkast Startskåp Anlaßschrank  Armoire de démarrage Cubículo de arranque Armadio apparecch. di avviamento Starterskab Cubículo-arranque Startskap Käynnistinkotelo

12

Drain system Aftapsysteem Avtappningssystem Ablaßsystem Système de vidange Sistema de drenaje Sistema di scarico Drænsystem Sistema de drenagem de condensados Avtappingssystem Lauhteenpoistojärjestelmä -

13 Pack - GA (W) ...... ............ ........... ........... ............ ........... ........... ............ ........... ........... ........ 14 Full Feature Feature - GA (A) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ....... 15 Full Feature Feature - GA (W) ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ..... 16 Pack - GA (A) ...... ............ ........... ........... ............ ............ ........... ........... ............ ........... .........

2930 1430 01

-

17 IEC ...... ............ ........... ........... ............ ............ ........... ........... ............ ............ ........... ........... ............ ........ 18 CSA/UL CSA/ UL ..... ........... ............ ............ ........... ........... ............ ............ ........... ........... ............ ........... .....

Bodywork  Carrosserie Karosseri Karosserie Capotage Carrocería Cappottatura Karosseri Carroceria Kabinett Kotelo GA (A/W) (A/W) - Common Common parts parts ... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... ...... .......

19

Service kits Service kits Service Kits Service kits Service kits Kit per la manutenzione Service kits Conjuntos de reparação Servicesett Huoltotarvikesarjat .........................................................

20

-

3

Parts list

1

63328_01

Ref.

Part number

Qty Name

1 010 1 015 1 030 1 040 1 050 1 060 1 100 1 110 1 120 1 130 2 010

1616 7146 90 0101 1951 40 0147 1365 03 0663 2111 46 0663 2109 78 1619 6032 00 1622 4633 00 0337 2293 23 1622 3668 00 0211 1963 16

1 2 10 1 1 4 1 1 1 1 1

4

1080 4241 01 1080 4241 11 1080 4241 02 1080 4241 18 1080 4241 13 1080 4241 04 1080 4241 17 1080 4241 06 1080 4241 14 1080 4242 11 1080 4242 02 1080 4242 18 1080 4242 13 1080 4242 04

Remarks

Service stage Pi n Hexagon bolt O-ring O-ring Nipple Spacer   Parallel key Washer   Hex socket screw Motor   GA 55+ (A) 200V/50Hz GA 55+ (A/W) 200V/60Hz GA 55+ (A/W) 230V/50Hz GA 55+ (A/W) 230V/60Hz GA 55+ (A/W) 380V/60Hz GA 55+ (A/W) 400V/50Hz GA 55+ (A/W) 460V/60Hz GA 55+ (A/W) 500V/50Hz GA 55+ (A/W) 575V/60Hz GA 75+ (A/W) 200V/60Hz GA 75+ (A/W) 230V/50Hz GA 75+ (A/W) 230V/60Hz GA 75+ (A/W) 380V/60Hz GA 75+ (A/W) 400V/50Hz

Ref.

Part number

2 020 2 030 2 040 2 050 2 060 2 100 2 110 2 120 2 130 2 510 3 001 3 002 3 003 3 005

1080 4242 17 1080 4242 06 1080 4242 14 1080 4243 11 1080 4243 02 1080 4243 18 1080 4243 13 1080 4243 04 1080 4243 17 1080 4243 06 1080 4243 14 1622 3666 00 1616 5517 00 1622 3665 00 0335 2178 00 0147 1477 03 1619 6032 00 0508 1100 98 1622 3645 00 1622 3740 00 1088 1001 04 1622 3667 00 1622 3668 00 0211 1963 16 1622 3793 00

Qty Name

1 1 1 1 4 1 1 1 1 1 1 1 1 1

Remarks

GA 75+ (A/W) 460V/60Hz GA 75+ (A) 500V/50Hz GA 75+ (A/W) 575V/60Hz GA 90 (A/W) 200V/60Hz GA 90 (A/W) 230V/50Hz GA 90 (A/W) 230V/60Hz GA 90 (A/W) 380V/60Hz GA 90 (A/W) 400V/50Hz GA 90 (A/W) 460V/60Hz GA 90 (A/W) 500V/50Hz GA 90 (A/W) 575V/60Hz Gearbox housing Lip seal Bushing Circlip Bolt Nipple Bearing Key Drain nipple Warning mark   Spacer   Washer   Hexagon screw Oil nozzle

2930 1430 01

Parts list

1

Compressor element and drive gear

Ref.

Part number

Qty Name

3 010 3 020 3 030 3 040 3 050 3 060 3 070 3 080 3 090 3 100 3 101 3 102 3 103 3 104 3 110 3 120

1613 6752 19 1613 9598 01 0147 1493 03 0211 1400 03 0301 2358 00 0333 3237 00 1622 3622 00 0147 1400 03 0301 2358 00 0333 3237 00 1613 6752 18 0211 1400 03 0333 3237 00 0301 2358 00 0147 1479 03 0301 2378 00

1 1 1 2 2 2 1 5 5 5 2 4 4 4 2 2

Antivibration pad Spacer   Hex.bolt Cap screw Washer   Lock washer   Support Hexagon bolt Washer   Lock washer   Antivibration pad Cap screw Lock washer   Washer   Hexagon bolt Washer  

1

Plug assembly

3 170 1622 3698 80

4 010

1622 3698 00 1622 3699 00 0663 2101 80

1622 3692 07 1622 3692 07 1622 3692 13 1622 3692 17 1622 3692 19 1622 3692 17 1622 3692 15 1622 3692 15 1622 3692 09 1622 3692 11 1622 3692 13 1622 3692 11 1622 3692 11 1622 3692 09 1622 3692 05 1622 3692 41 1622 3692 41 1622 3692 43 1622 3692 37 1622 3692 37 1622 3692 33 1622 3692 31 1622 3692 31 1622 3692 21 1622 3692 25 1622 3692 07 1622 3692 07 1622 3692 15 1622 3692 17 1622 3692 29 1622 3692 07 1622 3692 07 1622 3692 17 1622 3692 17 1622 3692 15 1622 3692 15 1622 3692 13 1622 3692 03 1622 3692 41 1622 3692 03 1622 3692 39 1622 3692 39 1622 3692 35

2930 1430 01

• • •

1 1 1 1

Remarks

Plug Magnet O-Ring Gear drive GA 55+ 7. 7.5 bar(e) GA 55+ 7. 7 .5 bar(e) JPN 50Hz GA 55+ 7. 7 .5 bar(e) JPN 60Hz GA 55+ 7. 7 .5 bar(e) HAV GA 55+ 8 bar(e) GA 55+ 8 bar(e) HAV GA 55+ 10 10 bar(e) GA 55+ 10 bar(e) JPN 50Hz GA 55+ 10 bar(e) JPN 60Hz GA 55+ 10 1 0 bar(e) HAV GA 55+ 10 100 psig GA 55+ 10 100 psig HAV GA 55+ 12 125 psig GA 55+ 12 125 psig HAV GA 55+ 15 150 psig GA 75+ 7. 7.5 bar(e) GA 75+ 7. 7 .5 bar(e) JPN 50Hz GA 75+ 7. 7 .5 bar(e) JPN 60Hz GA 75+ 7. 7 .5 bar(e) HAV GA 75+ 8 bar(e) GA 75+ 8 bar(e) HAV GA 75+ 10 10 bar(e) GA 75+ 10 bar(e) JPN 50Hz GA 75+ 10 bar(e) JPN 60Hz GA 75+ 10 1 0 bar(e) HAV GA 75+ 13 13 bar(e) GA 75+ 13 bar(e) JPN 50Hz GA 75+ 13 bar(e) JPN 60Hz GA 75+ 13 1 3 bar(e) HAV GA 75+ 10 100 psig GA 75+ 10 100 psig HAV GA 75+ 12 125 psig GA 75+ 12 125 psig HAV GA 75+ 15 150 psig GA 75+ 15 150 psig HAV GA 75+ 17 175 psig GA 75+ 17 175 psig HAV GA 90 7.5 bar(e) GA 90 7.5 bar(e) HAV GA 90 8 bar(e) GA 90 8 bar(e) HAV GA 90 10 bar(e) GA 90 10 bar(e) HAV

Ref.

4 020

Part number

1622 3692 01 1622 3692 27 1622 3692 37 1622 3692 01 1622 3692 01 1622 3692 27 1622 3692 27 1622 3692 23 1622 3692 21 1622 3692 17 1622 3692 08 1622 3692 08 1622 3692 14 1622 3692 18 1622 3692 20 1622 3692 18 1621 3692 16 1621 3692 16 1622 3692 10 1622 3692 12 1622 3692 14 1622 3692 12 1622 3692 12 1622 3692 10 1622 3692 06 1622 3692 42 1622 3692 42 1622 3692 44 1622 3692 38 1622 3692 38 1622 3692 34 1622 3692 32 1622 3692 32 1622 3692 22 1622 3692 26 1622 3692 08 1622 3692 08 1621 3692 16 1622 3692 18 1622 3692 30 1622 3692 08 1622 3692 08 1622 3692 18 1622 3692 18 1621 3692 16 1621 3692 16 1622 3692 14 1622 3692 04 1622 3692 42 1622 3692 04 1622 3692 40 1622 3692 40 1622 3692 36 1622 3692 02 1622 3692 28 1622 3692 38 1622 3692 02 1622 3692 02 1622 3692 28 1622 3692 28 1622 3692 24 1622 3692 22 1622 3692 18

Qty Name

1

Remarks

GA 90 13 bar(e) GA 90 13 bar(e) HAV GA 90 100 psig GA 90 100 psig HAV GA 90 125 psig GA 90 125 psig HAV GA 90 150 psig GA 90 150 psig HAV GA 90 175 psig GA 90 175 psig HAV Gear driven GA 55+ 7. 7.5 bar(e) GA 55+ 7. 7 .5 bar(e) JPN 50Hz GA 55+ 7. 7 .5 bar(e) JPN 60Hz GA 55+ 7. 7 .5 bar(e) HAV GA 55+ 8 bar(e) GA 55+ 8 bar(e) HAV GA 55+ 10 10 bar(e) GA 55+ 10 1 0 bar(e) JPN 50Hz GA 55+ 10 1 0 bar(e) JPN 60Hz GA 55+ 10 1 0 bar(e) HAV GA 55+ 10 100 psig GA 55+ 10 100 psig HAV GA 55+ 12 125 psig GA 55+ 12 125 psig HAV GA 55+ 15 150 psig GA 75+ 7. 7.5 bar(e) GA 75+ 7. 7 .5 bar(e) JPN 50Hz GA 75+ 7. 7 .5 bar(e) JPN 60Hz GA 75+ 7. 7 .5 bar(e) HAV GA 75+ 8 bar(e) GA 75+ 8 bar(e) HAV GA 75+ 10 10 bar(e) GA 75+ 10 1 0 bar(e) JPN 50Hz GA 75+ 10 1 0 bar(e) JPN 60Hz GA 75+ 10 1 0 bar(e) HAV GA 75+ 13 13 bar(e) GA 75+ 13 1 3 bar(e) JPN 50Hz GA 75+ 13 1 3 bar(e) JPN 60Hz GA 75+ 13 1 3 bar(e) HAV GA 75+ 10 100 psig GA 75+ 10 100 psig HAV GA 75+ 12 125 psig GA 75+ 12 125 psig HAV GA 75+ 15 150 psig GA 75+ 15 150 psig HAV GA 75+ 17 175 psig GA 75+ 17 175 psig HAV GA 90 7.5 bar(e) GA 90 7.5 bar(e) HAV GA 90 8 bar(e) GA 90 8 bar(e) HAV GA 90 10 bar(e) GA 90 10 bar(e) HAV GA 90 13 bar(e) GA 90 13 bar(e) HAV GA 90 100 psig GA 90 100 psig HAV GA 90 125 psig GA 90 125 psig HAV GA 90 150 psig GA 90 150 psig HAV GA 90 175 psig GA 90 175 psig HAV

5

Parts list

2

63330_02

6

2930 1430 01

Parts list

2

Air inlet

Ref.

Part number

Qty Name

1020 1025 1030 1040 1045 1050 1070 1075 1080

1622 0795 00 1622 0796 00 1622 9639 00 0211 1964 75 0686 3716 01 0661 1000 38 1613 8907 00 1613 2357 00

1 1 1 4 1 1 1 1 1

1085 1090 1095 1100 1105 1110 1115 1120

1622 0958 00 1622 0958 00 1622 0958 01 1622 0958 00 1622 0958 00 1622 0958 01 0661 1000 44 1622 1041 00 0686 3716 07 0661 1000 44 1079 5840 19 0661 1000 39 1622 0977 00 1089 0574 55

2010 <<< >>>

2020 0663 2107 37

2930 1430 01

1 1 1 1 1 1 1 1 1

1

Remarks

Valve housing Spring Check valve Cap screw Hexagon plug Seal washer   Valve body Compr.spring Nipple 7.5 bar(e) 10 bar(e) 13 bar(e) 100 psig 150 psig 175 psig Seal washer   Piston Hexagon plug Seal washer   Nipple Seal washer   Gasket Temp.sensor   Unloader assemby

O-ring

Ref.

Part number

Qty Name

2021 2030 2050 2060 2070

0301 2344 00 0147 1360 03 0347 6120 00 1622 3631 00 0147 1963 08

4 4 2 1 2

Washer   Hexagon bolt Hose clip Filter plate Hexagon bolt

1

Air filter

2090 1613 9502 00

2100 2110 2120 2130 2140 2200 2210 3010 3020 4010 4020 4030 4040 4050 4060 4070

1613 9503 00 0301 2344 00 0147 1363 03 0575 1216 62 1079 5840 03 0661 1000 40 1089 0574 12 0989 4220 15

•

1622 0894 80

1622 0894 00 1613 7912 01 1622 3619 00 0663 7138 00 0147 1363 03 0301 2344 00 0663 7138 00 0147 1363 03 0301 2344 00

• •

1 2 2 1 1 1 1 1

Filter element Washer   Hexagon bolt Hose Nipple Seal washer   Temp.sensor   Grommet

1

Hose assembly

1 1 1 1 2 2 1 2 2

Remarks

Hose Indicator   Pipe O-ring Hexagon bolt Washer   O-ring Hexagon bolt Washer  

7

Parts list

3

63331_20

8

2930 1430 01

Parts list

3

Unloader valve

Ref.

1005 1010 1015 1020 1030 1035 1040 1045 1050 1055 1060 1065 1070 1080 1100

Part number

Qty Name

1622 3648 80

1622 3648 00 1622 3794 00 0335 2182 00 1622 3686 00 1622 3688 00 0261 1099 32 1622 3687 00 1622 3689 00 1622 3690 00 1622 3691 00 0663 7151 00 0160 0996 86 0301 2318 00 0663 2111 55 1622 3182 00

2930 1430 01

1 • • • • • • • • • • • • • • •

1 1 1 1 1 1 1 1 1 1 1 2 2 1 1

Remarks

Unloader assembly

Housing Cover   Int.circlip Valve Rod Hexagon nut Piston Guidance tape Bushing Quadring O-ring Cross rec screw Washer   O-ring Guide

Ref.

Part number

1105 1622 3183 00 1110 1622 3184 00 1115 1622 3185 00 2005 2010 2015 2020 2025 2030 2035 2040 2045 2050 2055

1622 3694 80

1622 3694 00 1622 3694 01 1622 3694 02 1513 0477 00 1622 3694 03 1622 3694 04 1622 3694 05 1622 3694 06 1622 3694 07 0226 3300 18 0663 2112 69

Qty Name

•

1 1 1

Seal Bushing Spring

•

1

Blow off valve

• •

•• •• •• •• •• •• •• •• •• •• ••

1 1 1 1 1 1 1 2 1 4 1

Remarks

Housing Cover   Piston Piston ring Seal Seal Rivet Insert Seal Bolt O-ring

9

Parts list

4

63332_03

10

2930 1430 01

Parts list

4

Air receiver

Ref.

1010

Part number

Qty Name

1

1202 5749 00 1202 5749 00 1202 5401 00 1613 5452 00 1613 5452 00 1613 7810 00

1

2020 2030 2040 2050 2060 2070 2080 2090 2100 2110 2120 2130 2140 2150 2160 2170 2180 2190 2200 2210 2220 2230 2240 2250 2260 2270 2280 2290 2300

1622 1622 1622 1622 1622

3695 3695 3695 3695 5562

1622 1622 1622 1622 1622

2930 1430 01

3658 3658 3658 3658 3658

99 82 85 95 86

Safety valve 7.5 bar(e) 10 bar(e) 13 bar(e) 100 psig 150 psig 175 psig Vessel ass’y

•

1 1 1 1 4 1 1 1 1 1 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 4 1 4 1

CE/ASME LL/DIR  MOL MOM SQL Shield Bushing Oil separator   Oil level gauge Hex. Bolt O-ring O-ring Scavenge line Nipple Seal washer   Cover   Parallel pin Seal washer   O-ring Nipple Retaining ring Non return valve O-ring Spring Piston Spring Piston valve Washer   Washer   Hexagon bolt Hexagon bolt Hexagon nipple Washer   O-ring

•

1

Vessel

99 82 85 95 86

1622 3657 00 1613 8103 00 1622 3656 00 1622 3659 00 0147 1365 03 0663 7139 00 0663 3120 00 1622 3654 80 1079 5840 18 0661 1000 38 1622 3661 00 0101 2465 00 0661 1000 40 0663 2101 01 1622 3693 00 0335 3111 00 1613 9005 01 0663 2108 11 1622 3664 00 1622 3663 00 1622 3662 00 1613 3221 00 1613 3223 01 1613 3222 00 0147 1244 03 0147 1249 03 0571 0035 85 0301 2321 00 0663 2113 24

Remarks

• • • • • • • • • • • • • • • • • • • • • • • • • • • •

CE/ASME LL/DIR  MOL MOM SQL

Ref.

Part number

3010 1622 3658 00 3020 1622 3655 00 1622 3655 00 1622 3655 00 1622 3655 00 1622 5087 00 3030 0147 1961 17 3040 0663 2107 49 3050 1622 0003 00 1622 0003 01 1622 0003 01 1622 0003 01 1613 9349 00 3060 0244 4184 00 3070 1202 8992 00 3080 0663 2102 15 3090 1622 3660 00 3100 0663 2111 17 3110 0686 4206 00 4030 4040 4050 4070 4110 4120 4140 4150 4160 4170 5010 5020 5030 5040 5060 5090 5100 5110 5120 5130 5140 5150

1622 3650 80

0335 2131 00 1622 3650 00 0661 1000 44 1622 3653 00 1622 4614 00 0686 6448 00 0663 2106 16 0147 1325 03 0301 2335 00 0603 4100 42 0392 1100 28 0301 2335 00 0291 1110 00 1613 8967 12 0147 1963 08 1089 0575 43 0147 1322 03 0301 2344 00 0575 1205 11 0603 4100 42 0852 0010 22 0687 3103 00

Qty Name

••

4 1 1 1 1 1

Vessel Valve housing CE/ASME LL/DIR   MOL MOM SQL Hexagon bolt O-ring Dataplate vessel CE/ASME LL/DIR   MOL MOM SQL Drive screw Plug O-ring Plug O-ring Hex.plug

•

1

Oil filter pipe

•• ••

•• •• ••

•• •• •• •• ••

•• •• •• •• •• •• •• •• •• ••

1 1

Remarks

8 2 1

1 1 1 1 1 1 1 3 3 1 4 4 4 1 1 1 2 2 1 1 1 1

Circlip Filter pipe housing Seal washer   Bypass valve Cover   Hexagon plug O-ring 94,5 x 3 Hex.bolt Washer   Nipple Vibration damper   Washer   Lock nut Cable Hexagon bolt Press.transducer   Hexagon bolt Washer   Hose assembly Nipple Ball valve Pipe cap

11

Parts list

5

63336_04

12

2930 1430 01

Parts list

5

Air flow and cooling system - GA (A)

Ref.

1010

Part number

1622 3646 15 1622 3646 01 1622 3646 11 1622 3646 11 1622 3646 11 1622 3646 01 1622 3646 11 1622 3646 11 1622 3646 03 1622 3646 12 1622 3646 15 1622 3646 01 1622 3646 11 1622 3646 11 1622 3646 11 1622 3646 01 1622 3646 11 1622 3646 11 1622 3646 03 1622 3646 12 1622 3646 33 1622 3646 22 1622 3646 31 1622 3646 31 1622 3646 31 1622 3646 22 1622 3646 31 1622 3646 31 1622 3646 24 1622 3646 32

2930 1430 01

Qty Name

1

Remarks

Fan ass’y GA 55+ (A) 200V/60Hz CSA/UL GA 55+ (A) 230V/50Hz IEC GA 55+ (A) 230V/60Hz IEC GA 55+ (A) 230V/60Hz CSA/UL GA 55+ (A) 380V/60Hz IEC GA 55+ (A) 400V/50Hz IEC GA 55+ (A) 460V/60Hz IEC GA 55+ (A) 460V/60Hz CSA/UL GA 55+ (A) 500V/50Hz IEC GA 55+ (A) 575V/60Hz CSA/UL GA 75+ (A) 200V/60Hz CSA/UL GA 75+ (A) 230V/50Hz IEC GA 75+ (A) 230V/60Hz IEC GA 75+ (A) 230V/60Hz CSA/UL GA 75+ (A) 380V/60Hz IEC GA 75+ (A) 400V/50Hz IEC GA 75+ (A) 460V/60Hz IEC GA 75+ (A) 460V/60Hz CSA/UL GA 75+ (A) 500V/50Hz IEC GA 75+ (A) 575V/60Hz CSA/UL GA 90 (A) 200V/60Hz CSA/ UL GA 90 (A) 230V/50Hz IEC GA 90 (A) 230V/60Hz IEC GA 90 (A) 230V/60Hz CSA/ UL GA 90 (A) 380V/60Hz IEC GA 90 (A) 400V/50Hz IEC GA 90 (A) 460V/60Hz IEC GA 90 (A) 460V/60Hz CSA/ UL GA 90 (A) 500V/50Hz IEC GA 90 (A) 575V/60Hz CSA/ UL

Ref.

Part number

Qty Name

1020 2010 2020 2030 2040 3010

0147 1963 08 1622 3625 00 0147 1963 08 1622 3628 80 0147 1963 08

4 1 4 2 4 1

3020 3025 3030 3040 3050

1622 3779 00 1622 3780 00 1622 3781 00 0147 1963 08 0348 0102 11 0574 9918 14 0147 1323 03 0300 0274 34

3060 1622 3767 00 1622 3769 00 1622 3771 00

3070 3080 3090 3100 3110 3120 3130 3140 3150

1622 3797 00 0147 1323 03 0300 0274 34 1622 3787 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1363 03

4030

•

•

1622 3766 00 1622 3768 00 1622 3770 00

4040 2250 4983 00 4050 0661 1000 44 4500 1622 3797 00

•• •• ••

Remarks

4 3 2 4 4

Hexagon bolt Fan support Hexagon bolt Plate 1) Hexagon bolt Cooler plate GA 55+ (A) GA 75+ (A) GA 90 (A) Hexagon bolt Cable tie Hose assembly Hexagon bolt Washer  

1

Aftercooler

1 4 4 1 1 2 2 1 2 2

GA 55+ (A) GA 75+ (A) GA 90 (A) Decal Hexagon bolt Washer   Pipe O-ring Washer   Hexagon bolt O-ring Washer   Hexagon bolt

1

Oilcooler

2 2 1

GA 55+ (A) GA 75+ (A) GA 90 (A) Nipple Seal washer   Decal

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650

13

Parts list

6

63337_04

14

2930 1430 01

Parts list

6

Air flow and cooling system - GA (W)

Ref.

Part number

Qty Name

1010 1020 1030 1040 1050 1060 1070 1080 1085 1090 1100 1110 1130 1140 1150 1151 1152 1153 1154 1155 1156 1158 1160 1170 1171 1172 1173 1180 1190 1200 1201 1202 1203 1204

1622 4640 81 0147 1962 72 0301 2335 00 1622 4652 80 1622 4642 00 0147 1962 72 0301 2335 00 1622 4653 80 0574 9918 15 1622 4642 02 0147 1962 72 0301 2335 00 0147 1326 03 0301 2335 00 1089 9556 28 0160 6039 00 0661 1000 46 0301 2315 00 0605 8700 24 0261 2106 00 0661 1000 44 2250 4983 00 1622 4646 80 1622 4645 81 0291 1110 00 0661 1000 38 0686 3716 01 0147 1962 72 0301 2335 00 0663 3143 00 0686 3716 01 0661 1000 38 0686 3716 02 0661 1000 39

1 4 4 1 1 2 2 1 2 1 2 2 4 4 1 4 1 4 1 8 1 1 1 1 1 1 1 2 2 1 2 2 1 1

Cooler plate Hexagon bolt Washer   Aftercooler   Support Hexagon bolt Washer   Oilcooler   Hose assembly Support Hexagon bolt Washer   Hexagon bolt Washer   Fan Screw Seal washer   Washer   Bushing Nut Seal washer   Nipple Pipe Pipe Lock nut Seal washer   Hex. plug Hexagon bolt Washer   O-ring Hex. plug Seal washer   Hex. plug Seal washer  

1210 1613 9370 80

1

WSD 250

0663 6147 00 0663 6136 00 0663 2133 00 0663 2111 27

2930 1430 01

• • • •

1 1 1 1

Remarks

O-ring 114,5 x 3 O-ring 59,5 x 3 O-ring 39,2 x 3 O-ring 31,5 x 3

Ref.

Part number

Qty Name

1220 1230 1240 1250 1255 1260 1270 1280 1300 1330 1340 1360 1370 1372 1374 1376 1378 1380 1460 1470 1480 1490 1500 1510 1520 1530

0663 3143 00 0147 1475 00 0301 2378 00 1622 4641 80 0147 1364 03 0301 2344 00 0663 7138 00 0147 1476 03 0301 2344 00 1622 4643 80 0663 7138 00 1622 4644 00 0663 7138 00 0661 1000 46 0605 8700 24 0661 1000 44 2250 4983 00 0574 9874 02 1622 4650 80 0147 1962 72 0301 2335 00 1900 0710 41 1089 0574 49 1622 0661 01 1088 0031 04 1622 0663 03

1 4 4 1 2 2 1 2 2 1 2 1 1 1 1 1 1 1 1 4 4 1 2 1 1 1

2120 1622 4649 80

1622 4649 10 1622 4649 13 1622 4649 14 1622 4649 11 0129 3110 00 1622 4649 15

1 • • • • • •

1 1 1 6 26 2

Remarks

O-ring Hexagon bolt Washer   Pipe Hexagon bolt Washer   O-ring Hexagon bolt Washer   Pipe O-ring Pipe O-ring Seal washer   Bushing Seal washer   Nipple Hose assembly Plate Hexagon bolt Washer   AIE exp. module Temp. sensor   Cable Connector   Cable temp.sensor   Air duct assy 1) Plate Plate Plate Plate Rivet Support

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650

15

Parts list

7

Oil system

63338_05

Ref.

Part number

Qty Name

1080 0575 1244 50 1140 0574 9919 01

2030

1622 3652 80 1622 4601 80

1622 3652 00 1622 4601 00 2040 0663 2113 23 2500 1079 9909 57 1079 9920 76

16

•

•

Remarks

1 1

Hose assembly Hose assembly

1

Oil filter element assy

1 1 1

4000 Hrs 8000 Hrs Oil filter element 4000 Hrs 8000 Hrs O-ring Label 4000 Hrs 8000 Hrs

Ref.

Part number

Qty Name 1

3010

1622 1622 1622 1622 1622 1622

3759 3759 3759 3759 3759 3759

80 80 81 80 80 81

1622 3759 00 1622 3759 00 1622 3759 01 1622 3759 00 1622 3759 00 1622 3759 01

•

1

Remarks

Thermostat assembly

7.5 bar(e) 10 bar(e) 13 bar(e) 100 psig 150 psig 175 psig Plug 7.5 bar(e) 10 bar(e) 13 bar(e) 100 psig 150 psig 175 psig

2930 1430 01

Parts list

8

Air outlet - Pack GA (A)

63341_06

Ref.

Part number

Qty Name

1010 1020 1030 1040 1050 1060 2010 2030 2050 2055

1622 3786 00 0663 7138 00 0301 2344 00 0147 1363 03 0147 1963 08 1089 0575 54 0852 0010 20 0070 6002 05 0581 0000 35

1 1 2 2 2 1 1 AR 2 1

1614 5941 00 2060 0661 1000 38 2065 0653 1331 00

2930 1430 01

2 1

Remarks

Pipe O-ring Washer   Hexagon bolt Hexagon bolt Pressure transducer   Ball valve Tube Coupling Adaptor   NPT Seal washer   Flat gasket NPT

Ref.

Part number

Qty Name

Remarks

0147 1963 08 1622 3796 00 1622 3795 00 0160 6040 00

1

6 1 1 4

Plate ass’y

1)

3080 1622 3626 81

1

Plate

1)

3010 1622 3629 80

3021 3050 3060 3070

3090 0147 1963 08

4

Hexagon bolt Cover   Seal Screw Hexagon bolt

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650

17

Parts list

9

Air outlet - Pack GA (W)

63342_06

Ref.

Part number

Qty Name

1010 1020 1030 1040 1050 1060 2010 2030 2050 2055

1622 3786 00 0663 7138 00 0301 2344 00 0147 1363 03 0147 1963 08 1089 0575 54 0852 0010 20 0070 6002 05 0581 0000 35

1 1 2 2 2 1 1 AR 2 1

1614 5941 00 2060 0661 1000 38 2065 0653 1331 00 18

2 1

Remarks

Pipe O-ring Washer   Hexagon bolt Hexagon bolt Pressure transducer   Ball valve Tube Coupling Adaptor   NPT Seal washer   Flat gasket NPT

Ref.

Part number

Qty Name

Remarks

1

0147 1963 08 1622 3796 00 1622 3795 00 0160 6040 00

6 1 1 4

Hexagon bolt Cover   Seal Screw

Plate ass’y

1)

3080 1622 3626 81

1

Plate

1)

3010 1622 3629 80

3021 3050 3060 3070

3090 0147 1963 08

4

Hexagon bolt

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650

2930 1430 01

Parts list

10

Air outlet - Full Feature - GA (A)

63343_06

Ref.

Part number

Qty Name

1010 1020 1030 1040 1050 1060 1070 2010 2030 2050 2055

1622 3785 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1364 03 0852 0010 20 0070 6002 05 0581 0000 35

1 1 2 2 1 2 2 1 AR 2 1

1614 5941 00 2060 0661 1000 38 2065 0653 1331 00 3010 1622 4627 01 1622 4627 01 1622 4626 01 1622 4626 01 3020 0605 8300 72 0605 8300 72 3040 0663 2104 75 0663 2104 75 0663 2104 98 0663 2104 98

2930 1430 01

2 1 1

1 1

Pipe O-ring Washer   Hexagon bolt O-ring Washer   Hexagon bolt Ball valve Tube Coupling Adaptor   NPT Seal washer   Flat gasket NPT Outlet pipe ID 120 ID 170 ID 245 ID 285 Bushing ID 120 ID 170 O-ring ID 120 ID 170 ID 245 ID 285

Remarks

Ref.

3050

3060

4010 4020 4030 4040 4050 4060 4090

Part number

0147 1326 03 0147 1326 03 0147 1364 03 0147 1364 03 0301 2335 00 0301 2335 00 0301 2344 00 0301 2344 00 0211 1325 03 0211 1325 03 1622 3643 00 1622 3643 00 0147 1963 08 0160 6040 00 1622 3626 80 0147 1963 08 1622 4636 00 1622 4636 00

Qty Name

2

2

6 1 6 4 1 4 1

Hexagon bolt ID 120 ID 170 ID 245 ID 285 Washer   ID 120 ID 170 ID 245 ID 285 Cap screw ID 120 ID 170 Dryer frame ID 120 ID 170 Hexagon bolt Screw Plate Hexagon bolt Plate ID 120 ID 170

Remarks

1)

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit /Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650 19

Parts list

11

63344_06

20

2930 1430 01

Parts list

11

Air outlet - Full Feature - GA (W)

Ref.

Part number

Qty Name

1010 1020 1030 1040 1050 1060 1070 2010 2030 2050 2055

1622 3785 00 0663 7138 00 0301 2344 00 0147 1363 03 0663 7138 00 0301 2344 00 0147 1364 03 0852 0010 20 0070 6002 05 0581 0000 35

1 1 2 2 1 2 2 1 AR 2 1

1614 5941 00 2060 0661 1000 38 2065 0653 1331 00 3010 1622 4627 01 1622 4627 01 1622 4626 01 1622 4626 01 3020 0605 8300 72 0605 8300 72 3040 0663 2104 75 0663 2104 75 0663 2104 98 0663 2104 98

2930 1430 01

2 1 1

1 1

Pipe O-ring Washer   Hexagon bolt O-ring Washer   Hexagon bolt Ball valve Tube Coupling Adaptor   NPT Seal washer   Flat gasket NPT Outlet pipe ID 120 ID 170 ID 245 ID 285 Bushing ID 120 ID 170 O-ring ID 120 ID 170 ID 245 ID 285

Remarks

Ref.

3050

3060

4010 4020 4030 4040 4050 4060 4090

Part number

0147 1326 03 0147 1326 03 0147 1364 03 0147 1364 03 0301 2335 00 0301 2335 00 0301 2344 00 0301 2344 00 0211 1325 03 0211 1325 03 1622 3643 00 1622 3643 00 0147 1963 08 0160 6040 00 1622 3626 80 0147 1963 08 1622 4636 00 1622 4636 00

Qty Name

2

2

6 1 6 4 1 4 1

Hexagon bolt ID 120 ID 170 ID 245 ID 285 Washer   ID 120 ID 170 ID 245 ID 285 Cap screw ID 120 ID 170 Dryer frame ID 120 ID 170 Hexagon bolt Screw Plate Hexagon bolt Plate ID 120 ID 170

Remarks

1)

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 67(AR) 30 x 2040 x 1650 21

Parts list

12

63345_17

22

2930 1430 01

Parts list

12

Air dryer - Full Feature Ref.

Part number

Qty Name 1

8092 2650 68 8092 2650 76 8092 2651 00 8092 8092 8092 8092 8092 8092 8092 8092

2651 2650 2651 2650 2651 2651 2651 2651

34 84 18 92 26 42 59 91

8092 8092 8092 8092 8092 8092

2652 2651 2652 2650 2650 2650

25 83 17 50 68 76

8092 2651 00 8092 8092 8092 8092 8092 8092 8092 8092

2651 2650 2651 2650 2651 2651 2651 2651

34 84 18 92 26 42 59 67

8092 2651 91 8092 8092 8092 8092

2652 2651 2652 2650

25 83 17 76

8092 2651 00 8092 8092 8092 8092 8092 8092 8092 8092

2651 2650 2651 2650 2651 2651 2651 2651

34 84 18 92 26 42 59 67

8092 2651 91 8092 8092 8092 8092 8092

2652 2651 2652 2651 2652

25 75 09 83 17

1624 1624 1624 1624

2368 2368 2306 2306

80 80 80 80

1010

• •

1088 0803 08 0348 0111 06

2930 1430 01

•• ••

1

1 1

Air dryer

Remarks

GA 55+ ID 120 460V/60Hz GA 55+ ID 170 200-230V/ 50Hz GA 55+ ID 170 200-230V/ 60Hz GA 55+ ID 170 380V/60Hz GA 55+ ID 170 400V/50Hz GA 55+ ID 170 460V/60Hz GA 55+ ID 170 500V/50Hz GA 55+ ID 170 575V/60Hz GA 55+ ID 245 400V/50Hz GA 55+ ID 245 460V/60Hz GA 55+ ID 285 200230V60Hz GA 55+ ID 285 380V/60Hz GA 55+ ID 285 500V/50Hz GA 55+ ID 285 575V/60Hz GA 75+ ID 120 400V/50Hz GA 75+ ID 120 460V/60Hz GA 75+ ID 170 200-230V/ 50Hz GA 75+ ID 170 200-230V/ 60Hz GA 75+ ID 170 380V/60Hz GA 75+ ID 170 400V/50Hz GA 75+ ID 170 460V/60Hz GA 75+ ID 170 500V/50Hz GA 75+ ID 170 575V/60Hz GA 75+ ID 245 400V/50Hz GA 75+ ID 245 460V/60Hz GA 75+ ID 285 200-230V/ 50Hz GA 75+ ID 285 200230V60Hz GA 75+ ID 285 380V/60Hz GA 75+ ID 285 500V/50Hz GA 75+ ID 285 575V/60Hz GA 90 ID 170 200-230V/ 50Hz GA 90 ID 170 200-230V/ 60Hz GA 90 ID 170 380V/60Hz GA 90 ID 170 400V/50Hz GA 90 ID 170 460V/60Hz GA 90 ID 170 500V/50Hz GA 90 ID 170 575V/60Hz GA 90 ID 245 400V/50Hz GA 90 ID 245 460V/60Hz GA 90 ID 285 200-230V/ 50Hz GA 90 ID 285 200230V60Hz GA 90 ID 285 380V/60Hz GA 90 ID 285 400V/50Hz GA 90 ID 285 460V/60Hz GA 90 ID 285 500V/50Hz GA 90 ID 285 575V/60Hz

Frame assy

ID 120 ID 170 ID 245 ID 285 Grommet Connector  

Ref.

1020

1030

Part number

1624 2370 00 1624 2370 00 1624 2307 00 1624 2307 00 1624 2371 00 1624 2371 00 1624 2308 00 1624 2308 00

1060 1624 1624 1624 1624

1080 1090 1100 1110 1120 1130 1140 1160 1170 1500

2372 2372 2310 2310

1624 2374 00 1624 2374 00 1624 2314 00 1624 2314 00 2010 1624 2451 00 2020 1617 0315 00 2030 1617 0092 03 3010 2289 2274 2275 2276

•

1

•

1

•

1

••

1

1624 2412 00 1624 2411 00 1624 2414 00 1624 2415 00 3020 0581 0000 71 3030 0661 1000 39 3050 1624 2390 04 1624 2390 03 1624 2390 02 1624 2390 01 3060 1089 0575 54 4010 1624 2675 00 1624 2675 00 1624 2668 00 1624 2669 00

Support ID 120 ID 170 ID 245 ID 285 Support ID 120 ID 170 ID 245 ID 285 Plate assy

•

2 1 1

•

1

Heat exchanger

••

1

••

1

•• • • • • • • • • • •

• •

80 80 80 80

1624 2289 00 1624 2274 00 1624 2275 00 1624 2276 00

Remarks

ID 120 ID 170 ID 245 ID 285 Bracket ID 120 ID 170 ID 245 ID 285 Bolt Support assy Rivet Hex.bolt Ser.washer   Washer   Hex.bolt Washer   Plug Tap screw Plate ID 120 ID 170 ID 245 ID 285 Insulation Ring (all) Ring

80 80 80 80

1624 2375 00 1624 2375 00 1624 2312 00 1624 2312 00 0147 1325 03 1624 2309 80 0129 3270 40 0147 1247 03 0333 3220 00 0300 0274 64 0147 1323 03 0300 0276 47 0111 1686 12 1079 2263 02

1624 1624 1624 1624

Qty Name

• • •

• •

2 1 5 4 4 4 4 4 8 2 2

1 1 1

1 1

ID 120 ID 170 ID 245 ID 285 Heat exchanger   ID 120 ID 170 ID 245 ID 285 Label ID 120 ID 170 ID 245 ID 285 Pipe coupling Seal washer   Label ID 120 ID 170 ID 245 ID 285 Press.transducer   Insulation ID 120 ID 170 ID 245 ID 285 23

Parts list

12

63345_17

24

2930 1430 01

Parts list

12

Air dryer - Full Feature

Ref.

Part number

4020

1624 2677 00 1624 2677 00 1624 2670 00 1624 2670 00 4030 1624 2671 00 4040 1624 2679 00 1624 2676 00 1624 2673 00 1624 2671 00 4050 1624 2680 00 1624 2678 00 1624 2674 00 1624 2672 00 5010 1617 1269 00 5012 1079 9903 48 5030 0346 1000 41 5050 1079 2263 01 5090 0147 1247 03 5100 0301 2327 00 5120 0333 3220 00 5121 0346 1000 37 5130 1624 2278 00 1624 2290 00 1624 2291 00 1624 2292 00 5140 0147 1247 03 5150 0333 3220 00 5170 0300 0274 64 5190 1624 2293 00 5250 0348 0110 03 5260 0226 3343 07 5270 0291 1110 00 5300 0348 0101 13 5320 1617 1625 00 1617 1625 00 1617 2428 00 1617 2428 00 5330 0697 9809 10 5360 0301 2335 00 5370 0333 3227 00 5401 0395 6005 96 6100 1619 5563 02 1617 2750 00 1617 0314 00 1617 0107 00 1617 1524 04 6110 1624 2297 07 1624 2297 08 1624 2297 09 1624 2297 09 6120 1624 2383 00 6140 1617 0314 00 1617 0476 00

Qty Name •

• •

•

• • • • • • • • •

• • • • • • • • •

• • • • • •• •• •• •• •• • ••

• • ••

••

2930 1430 01

1

Remarks

Insulation ID 120 ID 170 ID 245 ID 285 1 Insulation 1 Insulation ID 120 ID 170 ID 245 ID 285 1 Insulation ID 120 ID 170 ID 245 ID 285 AR Freon gas 1 Warning label 2 Pipe clamp 2 Screw 1 Hex.bolt 1 Washer   1 Ser.washer   1 Pipe clamp 1 Condenser   ID 120 ID 170 ID 245 ID 285 6 Hex.bolt 6 Ser.washer   6 Washer   1 Filter dryer   1 Anchor   1 Tapping screw 1 Locknut 2 Cable tie 1 Liquid separator   ID 120 ID 170 ID 245 ID 285 1 Locknut 1 Washer   1 Ser.washer   1 Foam 1 Pipe assy 3 Schräder valve 1 Non return valve 1 Nut 1 Sleeve 1 HGB Valve 1 Pipe assy 1 Temperature Expantion Valve ID 120 ID 170 ID 245 ID 285 1 Pipe 1 Pipe assy 1 Nut ID 170 575V CSA/UL ID 285 500V IEC 1 Sleeve

Ref.

Part number

1617 0386 00 1617 0477 00 7010 1624 2386 00 7020 1617 2361 00 7030 1617 2499 14 1617 2499 07 1617 2499 11 1617 2499 12 1617 2499 09 1617 2499 10 1617 2499 10 7040 1617 1617 1617 1617

1641 1641 2501 2501

7165 8010

•

1 1 1

•

1

••

1

••

1

•

1

•

1

•

1

• •

80 80 80 80

1617 1641 01 1617 1641 01 1617 2501 00 1617 2501 00

7160

Qty Name

1617 1642 00 1617 1642 00 1617 1808 03 1617 1808 03 1624 2452 00 1624 2452 00 1624 2453 00 1624 2453 00 1624 2455 00 1624 2455 00 1624 2295 04 1624 2295 05 1624 2295 03 1624 2295 04 1624 2295 06 1624 2295 04 1619 7767 33 1619 7767 30 1624 2296 02 1624 2295 08 1624 2296 03 1624 2296 02 1614 7168 20 1614 7168 19 1624 2295 02 1624 2295 04 1624 2295 05 1624 2295 03 1624 2295 04 1624 2295 06 1624 2295 04 1619 7767 33 1619 7767 30

Remarks

ID 170 575V CSA/UL ID 285 500V IEC Insulation Insulation Insulation ID 120 ID 170 ID 245 IEC ID 245 CSA/UL ID 285 ID 285 500V IEC ID 285 575V CSA/UL Insulation assy

ID 120 ID 170 ID 245 ID 285 Insulation plate ID 120 ID 170 ID 245 ID 285 Insulation ID 120 ID 170 ID 245 ID 285 Insulation ID 120 ID 170 ID 245 ID 285 Insulation ID 120 ID 170 Refr. compressor   GA 55+ ID 120 460V/60Hz GA 55+ ID 170 200-230V/ 50Hz GA 55+ ID 170 200-230V/ 60Hz GA 55+ ID 170 380V/60Hz GA 55+ ID 170 400V/50Hz GA 55+ ID 170 460V/60Hz GA 55+ ID 170 500V/50Hz GA 55+ ID 170 575V/60Hz GA 55+ ID 245 400V/50Hz GA 55+ ID 245 460V/60Hz GA 55+ ID 285 200230V60Hz GA 55+ ID 285 380V/60Hz GA 55+ ID 285 500V/50Hz GA 55+ ID 285 575V/60Hz GA 75+ ID 120 400V/50Hz GA 75+ ID 120 460V/60Hz GA 75+ ID 170 200-230V/ 50Hz GA 75+ ID 170 200-230V/ 60Hz GA 75+ ID 170 380V/60Hz GA 75+ ID 170 400V/50Hz GA 75+ ID 170 460V/60Hz GA 75+ ID 170 500V/50Hz GA 75+ ID 170 575V/60Hz

25

Parts list

12

63345_17

26

2930 1430 01

Parts list

12

Air dryer - Full Feature Ref.

Part number

Qty Name

1624 2296 02 1624 2295 08 1624 2296 03 1624 2296 03 1624 2296 02 1614 7168 20 1614 7168 19 1624 2295 05 1624 2295 03 1624 2295 04 1624 2295 06 1624 2295 04 1619 7767 33 1619 7767 30 1624 2296 02 1624 2295 08 1624 2296 03 1624 2296 03

8020

1624 2296 02 1624 2296 04 1624 2296 02 1614 7168 20 1614 7168 19 0147 1331 03 0147 1331 03

•

4 4

0147 1331 03

4

0147 1331 03 0147 1331 03 0147 1331 03 0147 1331 03 1619 5337 03 0147 1331 03 0147 1331 03 0147 1331 03

4 4 4 4 3 4 4 4

0147 1331 03 1619 5337 03 1619 5337 03 0147 1331 03 0147 1331 03 0147 1331 03

4 3 3 4 4 4

0147 1331 03

4

0147 1331 03 0147 1331 03 0147 1331 03 0147 1331 03 1619 5337 03 0147 1331 03 0147 1331 03 0147 1331 03

4 4 4 4 3 4 4 4

0147 1331 03

4

0147 1331 03 1619 5337 03 2930 1430 01

4 3

Remarks

GA 75+ ID 245 400V/50Hz GA 75+ ID 245 460V/60Hz GA 75+ ID 285 200-230V/ 50Hz GA 75+ ID 285 200230V60Hz GA 75+ ID 285 380V/60Hz GA 75+ ID 285 500V/50Hz GA 75+ ID 285 575V/60Hz GA 90 ID 170 200-230V/ 50Hz GA 90 ID 170 200-230V/ 60Hz GA 90 ID 170 380V/60Hz GA 90 ID 170 400V/50Hz GA 90 ID 170 460V/60Hz GA 90 ID 170 500V/50Hz GA 90 ID 170 575V/60Hz GA 90 ID 245 400V/50Hz GA 90 ID 245 460V/60Hz GA 90 ID 285 200-230V/ 50Hz GA 90 ID 285 200230V60Hz GA 90 ID 285 380V/60Hz GA 90 ID 285 400V/50Hz GA 90 ID 285 460V/60Hz GA 90 ID 285 500V/50Hz GA 90 ID 285 575V/60Hz Hexagon bolt GA 55+ I D 120 460V/60Hz GA 55+ I D 170 200-230V/ 50Hz GA 55+ I D 170 200-230V/ 60Hz GA 55+ I D 170 380V/60Hz GA 55+ I D 170 400V/50Hz GA 55+ I D 170 460V/60Hz GA 55+ I D 170 500V/50Hz GA 55+ I D 170 575V/60Hz GA 55+ I D 245 400V/50Hz GA 55+ I D 245 460V/60Hz GA 55+ ID 285 200230V60Hz GA 55+ I D 285 380V/60Hz GA 55+ I D 285 500V/50Hz GA 55+ I D 285 575V/60Hz GA 75+ I D 120 400V/50Hz GA 75+ I D 120 460V/60Hz GA 75+ I D 170 200-230V/ 50Hz GA 75+ I D 170 200-230V/ 60Hz GA 75+ I D 170 380V/60Hz GA 75+ I D 170 400V/50Hz GA 75+ I D 170 460V/60Hz GA 75+ I D 170 500V/50Hz GA 75+ I D 170 575V/60Hz GA 75+ I D 245 400V/50Hz GA 75+ I D 245 460V/60Hz GA 75+ I D 285 200-230V/ 50Hz GA 75+ ID 285 200230V60Hz GA 75+ I D 285 380V/60Hz GA 75+ I D 285 500V/50Hz

Ref.

8030 8040 8050 8060

Part number

Qty Name

1619 5337 03 0147 1331 03

3 4

0147 1331 03

4

0147 1331 03 0147 1331 03 0147 1331 03 0147 1331 03 1619 5337 03 0147 1331 03 0147 1331 03 0147 1331 03

4 4 4 4 3 4 4 4

0147 1331 03

4

0147 1331 03 0147 1331 03 0147 1331 03 1619 5337 03 1619 5337 03 0300 8019 00 0333 3214 00 0301 2315 00 1088 1001 01

•

4 4 4 3 3 4 1 1 3

GA 75+ I D 285 575V/60Hz GA 90 ID 170 200-230V/ 50Hz GA 90 ID 170 200-230V/ 60Hz GA 90 ID 170 380V/60Hz GA 90 ID 170 400V/50Hz GA 90 ID 170 460V/60Hz GA 90 ID 170 500V/50Hz GA 90 ID 170 575V/60Hz GA 90 ID 245 400V/50Hz GA 90 ID 245 460V/60Hz GA 90 ID 285 200-230V/ 50Hz GA 90 ID 285 200230V60Hz GA 90 ID 285 380V/60Hz GA 90 ID 285 400V/50Hz GA 90 ID 285 460V/60Hz GA 90 ID 285 500V/50Hz GA 90 ID 285 575V/60Hz Washer   Ser.washer   Washer   Warning mark  

•

1

Fan assy

••

1

8070 1624 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617 1617

2390 2581 2057 2581 2057 2057 2581 2582 2582 2057 2581 2057 2057 2057 2057 2057 2582 2582

• • •

80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80 80

1617 2581 00 1617 2057 00 1617 2581 00 1617 2057 00 1617 2057 00 1617 2581 00 1617 2582 00 1617 2582 00 1617 2057 00 1617 2581 00 1617 2057 00 1617 2057 00 1617 2057 00 1617 2057 00 1617 2057 00 1617 2582 00 1617 2582 00 1617 2059 00 8080 1503 0786 00 8090 0147 1326 03 8100 0333 3227 00

•• • • •

1 1 4 4

Remarks

ID 120 400V/50Hz ID 120 460V/60Hz ID 170 200-230V/50Hz ID 170 200-230V/60Hz ID 170 380V/60Hz ID 170 400V/50Hz ID 170 460V/60Hz ID 170 500V/50Hz ID 170 575V/60Hz ID 245 400V/50Hz ID 245 460V/60Hz ID 285 200-230V/50Hz ID 285 200-230V60Hz ID 285 380V/60Hz ID 285 400V/50Hz ID 285 460V/60Hz ID 285 500V/50Hz ID 285 575V/60Hz Fan ID 120 460V/60Hz ID 170 200-230V/50Hz ID 170 200-230V/60Hz ID 170 380V/60Hz ID 170 400V/50Hz ID 170 460V/60Hz ID 170 500V/50Hz ID 170 575V/60Hz ID 245 400V/50Hz ID 245 460V/60Hz ID 285 200-230V/50Hz ID 285 200-230V60Hz ID 285 380V/60Hz ID 285 400V/50Hz ID 285 460V/60Hz ID 285 500V/50Hz ID 285 575V/60Hz Fan grating Rotation arrow Hex.bolt Ser.washer   27

Parts list

12

63345_17

28

2930 1430 01

Parts list

12

Air dryer - Full Feature Ref.

Part number

8110 8123 8165 8180 8200 8230 8231 8260 8270 8280

0300 8019 00 0348 0101 13 0226 3256 00 1617 3077 85 1089 9139 04 0226 3343 07 0348 0111 06 1619 5703 00 0333 3214 00 0301 2315 00

9030 1624 1624 1624 1624 1624 1624 1624

2313 2313 2313 2313 2313 2365 2365

1624 2389 00 1624 2389 00 1624 2389 00 1624 2389 00 1624 2389 00 1624 2313 00 1624 2313 00 1624 2313 00 1624 2313 00 1624 2313 00 1624 2365 00 1624 2365 00 1088 0015 14 9200 1624 2362 80 1624 2360 80 1624 2362 80 1624 1624 1624 1624 1624 1624 1624 1624

2362 2360 2362 2360 2362 2360 2362 2388

80 80 80 80 80 80 80 80

1624 1624 1624 1624 1624 1624

2362 2362 2362 2360 2362 2360

80 80 80 80 80 80

1624 2362 80

2930 1430 01

2362 2360 2362 2360 2362 2360 2362

80 80 80 80 80 80 80

Remarks

•

4 10 2 1 1 2 1 1 2 2

Washer   Cable tie Screw Temp.sensor   Fan switch Tapping screw Connector   High pressure switch Ser.washer   Washer  

• •

1

Crankcase heater

• • • • • • • • •

••

2

200-230V/50Hz 200-230V/60Hz 380V/60Hz 400V/50Hz 460V/60Hz 500V/50Hz 575V/60Hz Connector plug Clamp 200-230V/50Hz 200-230V/60Hz 380V/60Hz 400V/50Hz 460V/60Hz Crankcase heater   200-230V/50Hz 200-230V/60Hz 380V/60Hz 400V/50Hz 460V/60Hz 500V/50Hz 575V/60Hz Pin contact

• •

1

Wiring

80 80 80 80 80 80 80

1088 0015 02

1624 1624 1624 1624 1624 1624 1624

Qty Name

•• ••

••

1 1

1

Ref.

Part number

Qty Name

1624 2388 80 1624 2388 80 1624 1624 1624 1624

2362 2362 2362 2360

80 80 80 80

1624 2362 80 1624 1624 1624 1624 1624 1624 1624 1624

2362 2360 2362 2360 2362 2360 2362 2388

80 80 80 80 80 80 80 80

1624 2388 80 1624 1624 1624 1624 1624

2362 2360 2362 2362 2362

80 80 80 80 80

1624 2361 00 1624 2361 00 1624 2361 00 1624 2361 00 1624 2361 00 1624 2361 00

••

1

Remarks

GA 75+ ID 285 200-230V/ 50Hz GA 75+ ID 285 200230V60Hz GA 75+ ID 285 380V/60Hz GA 75+ ID 285 500V/50Hz GA 75+ ID 285 575V/60Hz GA 90 ID 170 200-230V/ 50Hz GA 90 ID 170 200-230V/ 60Hz GA 90 ID 170 380V/60Hz GA 90 ID 170 400V/50Hz GA 90 ID 170 460V/60Hz GA 90 ID 170 500V/50Hz GA 90 ID 170 575V/60Hz GA 90 ID 245 400V/50Hz GA 90 ID 245 460V/60Hz GA 90 ID 285 200-230V/ 50Hz GA 90 ID 285 200230V60Hz GA 90 ID 285 380V/60Hz GA 90 ID 285 400V/50Hz GA 90 ID 285 460V/60Hz GA 90 ID 285 500V/50Hz GA 90 ID 285 575V/60Hz Plate 200-230V/50Hz 200-230V/60Hz 380V/60Hz 460V/60Hz 500V/50Hz 575V/60Hz

GA 55+ ID 120 460V/60Hz GA 55+ ID 170 200-230V/ 50Hz GA 55+ ID 170 200-230V/ 60Hz GA 55+ ID 170 380V/60Hz GA 55+ ID 170 400V/50Hz GA 55+ ID 170 460V/60Hz GA 55+ ID 170 500V/50Hz GA 55+ ID 170 575V/60Hz GA 55+ ID 245 400V/50Hz GA 55+ ID 245 460V/60Hz GA 55+ ID 285 200230V60Hz GA 55+ ID 285 380V/60Hz GA 55+ ID 285 500V/50Hz GA 55+ ID 285 575V/60Hz GA 75+ ID 120 400V/50Hz GA 75+ ID 120 460V/60Hz GA 75+ ID 170 200-230V/ 50Hz GA 75+ ID 170 200-230V/ 60Hz GA 75+ ID 170 380V/60Hz GA 75+ ID 170 400V/50Hz GA 75+ ID 170 460V/60Hz GA 75+ ID 170 500V/50Hz GA 75+ ID 170 575V/60Hz GA 75+ ID 245 400V/50Hz GA 75+ ID 245 460V/60Hz 29

Parts list

13

Drain System - Pack - GA (A)

63350_06

Ref.

Part number

Qty Name

1010 1060 1100 1110 1120

1622 3798 81 0581 0000 87 0581 0000 35 0661 1000 38 0070 6002 03

1 1 3 3 AR

30

Drain assembly Pipe coupling Coupling Seal washer   Plastic tube

Remarks

Ref.

Part number

Qty Name

1130 1140 1150 1160 1170

0070 6002 13 0581 0000 73 0661 1000 39 0581 0000 71 0147 1963 08

AR 1 3 2 2

Remarks

Plastic tube Straight coupling Seal washer   Straight coupling Hexagon bolt

2930 1430 01

Parts list

14

Drain System - Pack - GA (W)

63351_06

Ref.

Part number

Qty Name

1010 1030 1040 1050 1060 1100

1622 3798 81 1613 8084 00 0581 0001 45 0581 0000 53 0581 0000 87 0581 0000 35

1 1 1 1 1 2

2930 1430 01

Drain assembly Coupling Coupling Coupling Pipe coupling Coupling

Remarks

Ref.

Part number

Qty Name

1110 1 120 1 130 1150 1160 1170

0661 1000 38 0070 6002 03 0070 6002 13 0661 1000 39 0581 0000 73 0147 1963 08

4 AR AR 2 1 2

Remarks

Seal washer   Plastic tube Plastic tube Seal washer   Straight coupling Hexagon bolt 31

Parts list

15

Drain System - Full Feature - GA (A)

63352_06

Ref.

Part number

Qty Name

1010 1060 1100 1110 1120

1622 3798 81 0581 0000 87 0581 0000 35 0661 1000 38 0070 6002 03

2 2 6 6 AR

32

Drain assembly Pipe coupling Coupling Seal washer   Plastic tube

Remarks

Ref.

Part number

Qty Name

1130 1140 1150 1160 1170

0070 6002 13 0581 0000 73 0661 1000 39 0581 0000 71 0147 1963 08

AR 2 6 4 4

Remarks

Plastic tube Straight coupling Seal washer   Straight coupling Hexagon bolt

2930 1430 01

Parts list

16

Drain System - Full Feature - GA (W)

63353_06

Ref.

Part number

Qty Name

1010 1030 1040 1050 1060 1070

1622 3798 81 1613 8084 00 0581 0001 45 0581 0000 53 0581 0000 87 0581 0000 71

2 1 1 1 2 2

2930 1430 01

Drain assembly Coupling Coupling Coupling Pipe coupling Pipe coupling

Remarks

Ref.

Part number

Qty Name

1100 1110 1 120 1 130 1150 1160 1170

0581 0000 35 0661 1000 38 0070 6002 03 0070 6002 13 0661 1000 39 0581 0000 73 0147 1963 08

5 7 AR AR 5 2 4

Remarks

Coupling Seal washer   Plastic tube Plastic tube Seal washer   Straight coupling Hexagon bolt 33

Parts list

17

63357_12

34

2930 1430 01

Parts list

17

Cubicle - CSA/UL Ref.

Part number

Qty Name 1

1002 1004 1005 1010 1015 1020

1025 1030 1035 1040 1045 1050 1055 1060 1065 1070 1075 1080 1085 1090 1095 1100 1105 1110

1111

1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900

2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514

55 55 52 51 56 55 53 52 56 56 54 53

0697 9809 06 0697 9810 22 1079 9901 68 1079 9906 09 1079 9911 01

1079 9925 28 1079 9925 28 1079 9924 26 1079 9924 26 1079 9925 28 1079 9925 28 1079 9924 26 1079 9924 26 1079 9925 28 1079 9925 28 1079 9924 26 1079 9924 26 1088 0015 02 1088 0015 36 1088 0031 02 1088 0031 03 1088 0031 05 1088 0031 13 1088 0031 18 1088 0031 22 1088 0031 29 1088 0031 49 1088 0031 82 1088 0031 84 1088 0031 86 1088 0037 04 1088 0037 06 1089 0362 50 1089 0362 51 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 04 1089 0506 04 1089 0506 04

2930 1430 01

• • • • • •

• • • • • • • • • • • • • • • • • •

•

1 1 1 1 1 2 2 1 1 2 2 1 1 2 2 1 1 1 2 2 1 1 1 4 2 1 1 2 1 1 1 1 2 1 4 4 6 4 4 4 6 6 4 4 6 6 1

Remarks

Ref.

Cubicle

GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Lock nut Plug Warning label Label Label Label GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Connector plug Connector socket Connector   Connector   Connector   Connector   Adaptor for connector  Connector   Connector   Connector   Connector   Connector   Connector   Connector   Connector   Contact block   Push button End bracket GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Terminal GA 55+ 460V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz

1115 1120 1125 1130 1135 1140 1145

Part number

1089 0506 04 1089 0506 04 1089 0506 75 1089 0612 01 1089 0700 01 1089 0700 02 1089 0700 03 1089 0700 04

1089 9168 34 1089 9168 34 1089 9168 26 1089 9168 26 1089 9168 34 1089 9168 34 1089 9168 26 1089 9168 26 1089 9168 34 1089 9168 34 1089 9168 26 1089 9168 26 1150 1089 9511 51 1151 1089 9511 15 1152 1089 9511 16 1155 1089 9416 93 1160 1089 9415 81 1089 9415 81 1089 9415 45 1089 9415 36 1089 9415 83 1089 9415 81 1089 9415 46 1089 9415 45 1089 9415 83 1089 9415 83 1089 9415 61 1089 9415 46 1161 1089 9415 61 1089 9415 61 1089 9415 35 1089 9415 34 1089 9415 62 1089 9415 61 1089 9415 44 1089 9415 35 1089 9415 62 1089 9415 62 1089 9415 44 1089 9415 44 1165 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1170 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55

Qty Name

• • • • • • •

1 2 1 1 8 8 2

•

1 1 1 1

•

2

•

1

•

1

•

1

• • •

Remarks

GA 90 460V/60Hz GA 90 575V/60Hz Terminal Fuse holder   Connector   Connector   Connector pin Connector socket Fuse link   GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Relay Socket Clip Supply terminal GA 55+ 575V/60Hz Contactor   GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Contactor   GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Contact block   GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Contact block   GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 575V/60Hz 35

Parts list

17

63357_12

36

2930 1430 01

Parts list

17

Cubicle - CSA/UL Ref.

Part number

1175

1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1180 1089 9416 01 1185 1089 9446 22 1089 9446 22 1089 9424 47 1089 9424 41 1089 9446 22 1089 9446 22 1089 9424 48 1089 9424 47 1089 9446 22 1089 9446 22 1089 9446 21 1089 9424 48 1186 1089 9416 70 1089 9416 70 1089 9416 66 1089 9416 66 1089 9416 71 1089 9416 70 1089 9416 67 1089 9416 66 1089 9416 71 1089 9416 71 1089 9416 68 1089 9416 67 1190 1089 9416 75 1191 1089 9556 05 1195 1613 3431 00 1200 1614 8949 00 1205 1089 9436 47 1089 9436 47 1089 9436 45 1089 9436 44 1089 9436 47 1089 9436 47 1089 9436 45 1089 9436 45 1089 9436 47 1089 9436 47 1089 9436 45 1089 9436 45 1206 1622 3042 10 1622 3042 10 1622 3042 10 1622 3042 10 1622 3042 10 1622 3042 10 1210 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01

2930 1430 01

Qty Name •

• •

•

• • • • •

•

•

1

1 1

1

1 1 1 1 1

3

1

Remarks

Contact block   GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 575V/60Hz Aux.contact block   Overload relay GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Circuit breaker   GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Connection block   Air inlet Label Data plate Transformer   GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 55+ 460V/60Hz GA 55+ 575V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz Connection GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz Plate GA 55+ 200V/60Hz GA 55+ 230V/60Hz GA 75+ 200V/60Hz GA 75+ 230V/60Hz GA 90 200V/60Hz GA 90 230V/60Hz GA 90 460V/60Hz

Ref.

Part number

1220 1622 3697 00 1231 1622 1692 00 1622 1692 00 1622 1692 00 1622 3042 00 1622 1692 00 1235 0090 1400 02 1500 9820 3138 02 2010 2020 2030 2040 2050 2060 3010 3020 3030

1622 3602 80

Qty Name

Remarks

•

Wire harness Connection element GA 55+ 460V/60Hz GA 75+ 460V/60Hz GA 75+ 575V/60Hz GA 90 460V/60Hz GA 90 575V/60Hz AR Rail 1 Service diagram

•

1

• •

•

1 3

Cubicle

1 1 AR AR AR 1 1 4 4

Cubicle Foam Seal Seal Seal Decal Regulator   Hexagon bolt Washer  

1

Dryer rail

1089 9168 62 1089 9168 61 4085 1089 9415 14 4090 1089 9415 25 1089 9415 34 4095 0090 1400 02 4500 9820 3549 02

Low amperage range High amperage range 1 Label below 15 A above 15 A 1 Housing for connector   6 Crimp contact 8 Crimp contact 1 Crimp terminal 3 Crimp contact 2 Crimp terminal 1 Connector   1 Connector   1 Connector   1 Frame for connector   2 End bracket 6 Fuse holder   3 Fuse link   below 15 A above 15 A 3 Fuse link   below 15 A above 15 A 1 Contactor   1 Contactor   below 15 A above 15 A AR Rail 1 Service diagram

5090

1

Solenoid valve

4010 4 015 4020 4025 4030 4035 4040 4045 4050 4055 4060 4065 4070 4075 4080

1622 3602 10 1202 6584 01 1202 6584 01 1202 6584 01 1622 3783 00 1900 0710 12 0147 1169 03 0301 2315 00

•• •• •• •• •• ••

1900 2600 62 1900 2600 66

1079 9924 96 1079 9925 34 1088 0029 17 1088 0029 58 1088 0029 63 1088 0029 82 1088 0029 86 1088 0029 88 1088 0037 62 1088 0037 63 1088 0037 65 1088 0036 12 1089 0506 30 1089 0612 01 1089 9168 02 1089 9168 30

1089 0702 09 1089 0702 10

0663 2104 83 5091 1088 1001 01

•

1 1

1)

50 Hz 60 Hz O-ring Warning mark  

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 64(AR) 20 x 2040 x 1650

37

Parts list

18

63358_12

38

2930 1430 01

Parts list

18

Cubicle - IEC

Ref.

Part number

Qty Name 1

1002 1004 1005 1010 1015 1020 1025 1030 1035 1040 1045 1050 1055 1060 1065 1070 1075 1080 1085 1090 1095 1100

1101

1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900 1900

2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514 2514

09 09 04 01 04 04 08 08 05 02 05 04 07 07 06 03 06 05

0697 9809 24 0697 9810 29 1079 9901 68 1079 9906 09 1088 0015 02 1088 0015 36 1088 0031 02 1088 0031 03 1088 0031 05 1088 0031 13 1088 0031 18 1088 0031 22 1088 0031 29 1088 0031 49 1088 0031 82 1088 0031 84 1088 0031 86 1088 0037 04 1088 0037 06 1089 0362 50 1089 0362 51

1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 04 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30

2930 1430 01

• • • • • • • • • • • • • • • • • • • • • •

•

1 1 1 1 1 2 2 1 1 1 4 2 1 1 2 1 1 1 1 2 1 1

6 6 6 4 6 6 4 4 6 4 6 6 4

Cubicle

Remarks

GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Lock nut Plug Warning label Label Connector plug Connector socket Connector   Connector   Connector   Connector   Adaptor for connector  Connector   Connector   Connector   Connector   Connector   Connector   Connector   Connector   Contact block   Push button Terminal GA 55+ 380V/60Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 380V/60Hz GA 90 460V/60Hz GA 90 500V/50Hz End bracket GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz

Ref.

Part number

1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1089 0506 30 1105 1089 0506 75 1110 1089 0612 01 1115 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 25 1089 0612 25 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 25 1089 0612 25 1089 0612 24 1089 0612 24 1089 0612 24 1089 0612 24 1120 1089 0700 01 1125 1089 0700 02 1130 1089 0700 03 1135 1089 0700 04 1140 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1089 9362 04 1145 1089 9511 51 1146 1089 9511 15 1147 1089 9511 16 1150 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09 1089 9415 09

Qty Name

• • •

• • • • •

• • • •

4 6 4 6 6 1 2 2

1 1 8 8 1

1 1 1 1

Remarks

GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Terminal Fuse holder   Fuse GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Connector   Connector   Connector pin Connector socket Cover for terminal GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 500V/50Hz Relay Socket for relay Clip for relay Contact block   GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz

39

Parts list

18

63358_12

40

2930 1430 01

Parts list

18

Cubicle - IEC

Ref.

1155

1160

1165

1166 1170

Part number

1089 9415 45 1089 9415 45 1089 9415 35 1089 9415 34 1089 9415 35 1089 9415 35 1089 9415 61 1089 9415 61 1089 9415 44 1089 9415 44 1089 9415 44 1089 9415 35 1089 9415 61 1089 9415 61 1089 9415 61 1089 9415 44 1089 9415 61 1089 9415 44 1089 9415 61 1089 9415 61 1089 9415 44 1089 9415 44 1089 9415 44 1089 9415 44 1089 9415 81 1089 9415 81 1089 9415 45 1089 9415 45 1089 9415 45 1089 9415 44 1089 9415 81 1089 9415 81 1089 9415 81 1089 9415 61 1089 9415 81 1089 9415 45 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9415 55 1089 9416 75 1089 9416 75

1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1089 9415 56 1175 1089 9416 01

2930 1430 01

Qty Name •

1

•

2

•

1

•

1

•

1

•

1

Remarks

Contactor   GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Contactor   GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Contact block   GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 500V/50Hz Connection block   GA 90 230V/50Hz GA 90 230V/60Hz Contact block   GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 500V/50Hz Aux.contact block  

Ref.

1180

1185

1186

1190

Part number

1089 9416 30 1089 9416 30 1089 9416 26 1089 9416 26 1089 9416 26 1089 9416 26 1089 9416 30 1089 9416 30 1089 9416 27 1089 9416 26 1089 9416 27 1089 9416 26 1089 9416 71 1089 9416 71 1089 9416 28 1089 9416 28 1089 9416 28 1089 9416 27 1089 9446 21 1089 9446 21 1089 9424 47 1089 9424 47 1089 9424 47 1089 9424 47 1089 9446 22 1089 9446 22 1089 9424 49 1089 9424 49 1089 9424 49 1089 9424 47 1089 9446 22 1089 9446 22 1089 9446 22 1089 9446 21 1089 9446 22 1089 9424 49 1622 3042 10 1622 3042 10 1622 3042 10 1622 3042 10 1089 9436 45 1089 9436 45 1089 9436 44 1089 9436 39 1089 9436 44 1089 9436 44 1089 9436 47 1089 9436 47 1089 9436 45 1089 9436 40 1089 9436 45 1089 9436 44 1089 9436 47 1089 9436 47 1089 9436 45 1089 9436 40 1089 9436 45 1089 9436 45

Qty Name •

1

•

1

•

3

•

1

Remarks

Circuit breaker   GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Overload relay GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz Connection GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 90 230V/50Hz GA 90 230V/60Hz Transformer   GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz GA 90 500V/50Hz

41

Parts list

18

63358_12

42

2930 1430 01

Parts list

18

Cubicle - IEC

Ref.

1191

1195

Part number

1622 3042 00 1622 3042 00 1622 3042 00 1622 3042 00 1622 3042 00

1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1622 3399 01 1196 1089 9556 05 1200 1613 6639 00 1205 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1622 1692 00 1215 1622 3697 00 1220 0090 1400 02 1500 9820 3138 02 2010 2020 2030 2040 2050 2060 3010 3020 3030

4005 4010 4015 4020 4025 4030 4035 4040 4045 4050 4060 4065 4070 4075

1622 3602 80

1622 3602 10 1202 6584 01 1202 6584 01 1202 6584 01 1622 3783 00 1900 0710 12 0147 1169 03 0301 2315 00

Qty Name

•

Connection element GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz Plate GA 55+ 230V/50Hz GA 55+ 230V/60Hz GA 75+ 230V/50Hz GA 75+ 230V/60Hz GA 90 230V/50Hz GA 90 230V/60Hz GA 90 380V/60Hz GA 90 400V/50Hz GA 90 460V/60Hz 1 Air inlet 1 Data plate 3 Connection element GA 55+ 380V/60Hz GA 55+ 400V/50Hz GA 55+ 460V/60Hz GA 55+ 500V/50Hz GA 75+ 380V/60Hz GA 75+ 400V/50Hz GA 75+ 460V/60Hz GA 75+ 500V/50Hz GA 90 500V/50Hz 1 Wire harness AR Rail 1 Service diagram

• •

1

•

•

• • •

• •

•• •• •• •• •• ••

1900 2600 61 1900 2600 65

1088 0029 17 1088 0029 58 1088 0029 63 1088 0029 82 1088 0029 86 1088 0029 88 1088 0037 62 1088 0037 63 1088 0037 65 1088 0036 12 1089 0506 30 1089 0612 01

1089 0612 24 1089 0612 25 1089 0612 28 1089 0612 30

2930 1430 01

Remarks

6 6 6 3 6 1

Cubicle Foam Seal Seal Seal Decal Regulator   Hexagon bolt Washer  

1

Dryer rail

• •

1 6 8 1 3 2 1 1 1 1 2 6 3

• •

3

• • • • • • • • • • • • • • • • • • • • • • • •

Cubicle

1 1 AR AR AR 1 1 4 4

Ref.

Part number

4080 1089 9415 14 4085 1089 9415 24 1089 9415 25 4090 0090 1400 02 4500 9820 3549 02

Qty Name • •

• •

5090

1 1

Contactor   Contactor   Below 16 A Above 16 A AR Rail 1 Service diagram 1

1089 0702 09 1089 0702 10

0663 2104 83 5091 1088 1001 01

•

Remarks

1 1

Solenoid valve

50 Hz 60 Hz O-ring Warning mark  

1) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : Foam: 0395 6001 64(AR) 20 x 2040 x 1650

1)

Low amperage range High amperage range Housing for connector  Crimp contact Crimp contact Crimp terminal Crimp contact Crimp terminal Connector   Connector   Connector   Frame for connector  End bracket Fuse holder   Fuse Below 16 A Above 16 A Fuse link   Below 16 A Above 16 A 43

Parts list

19

63359_10

44

2930 1430 01

Parts list

19

Bodywork

Ref.

Part number

Qty Name

1010 1020 1030 1040 1045 1046

1622 5577 80 0147 1963 08 1622 5578 80 0147 1963 08 1622 5676 00 0147 1963 08

2 4 1 2 1 2

1050 1622 3637 80

1

Remarks

1 1 1 4 2 1

Beam assembly 1) Hexagon bolt Beam assembly 2) Hexagon bolt Beam Hexagon bolt Door assembly 2) Lock   Decal Door assembly 2) Lock   Door assembly 2) Lock   Door assembly 2) Lock   Decal Panel inlet Hexagon bolt Tap screw Drain plate

1

Panel assembly

1380 1622 3615 80

1

2 4 2 1 4

Roof assembly 2)

Hexagon bolt Hexagon bolt Hexagon bolt Z-plate Hexagon bolt

1460 1622 0533 81

1

Baffle

1622 3633 80 0690 1132 01

• •

1060 1622 3636 80

1622 3633 80

1 •

1065 1622 3636 81

1622 3633 80

1100 1110 1115 1120

•

1131 1132 1133 1134 1390 1391 1392 1400 1410

1

1 • •

1130 1622 3617 80

1613 9846 01 0301 2335 00 0291 1110 00 0147 1247 03 0333 3220 00

1

1

1070 1622 3638 80

1622 3633 80 0690 1132 01 1622 3616 00 0147 1963 08 0226 3343 59 1622 6605 00

1 1

•

0147 1963 08 0147 1963 08 0147 1963 08 1622 3782 00 0147 1963 08

1 1 1 1 1

Decal Washer   Lock nut Hexagon bolt Lock washer  

3)

1470 0211 1249 03

4

Cap screw

1480 1622 5531 80

1

Cubicle door assy

1

Frame assembly

1622 3633 81

•

1622 3600 80

2020 2060 1079 9922 39

2930 1430 01

• •

2 1 2

Lock  

Frame Warning label

Ref.

Part number

2070 3010 3020 3030 3040 3045 3050 3060 3070 3090 3100 3110 3120

1079 9903 48 1622 3644 00 0301 2335 00 0291 1110 00 1621 0606 00 1621 0607 00 0211 1249 03 0333 3220 00 0261 2108 00 0147 1963 08 1622 4616 00 0211 1249 03 0333 3220 00

Qty Name •

1622 3642 80

4010 4020 1503 1056 00 5010 1622 4631 05 1622 4631 06 1622 4631 03 1622 4631 04 1622 4631 01 1622 4631 02 6005 0211 1325 03 6010 1622 3643 00 6020 0147 1963 08 6030 0160 6040 00 6040 1622 3626 80 6050 0111 1686 12 6060 0147 1963 08 6070 1622 4636 00

• •

4 1 1 1 4 4 8 8 2 4 1 2 2

Warning label Panel Washer   Lock nut Hinge Hinge Cap screw Lock washer   Nut Hexagon bolt Bracket Cap screw Lock washer  

1

Plate

1 Plate AR Seal 1 Decal GA55+ GA55+ FF GA75+ GA75+ FF GA90 GA90 FF 6 Cap screw 1 Dryer frame 6 Hexagon bolt 4 Screw 1 Plate 4 Plug 4 Hex.bolt 1 Plate

Remarks

1)

1)

1-3) Lined with / Bekleed met / Beklädd med / Ausgekleidet mit / Garnir de / Rivestido de / Allineato con / Foret med / Revestido com / Kledd med / Vuorattu : 1) Foam: 0395 6001 66(AR) 25 x 2040 x 1650 2) Foam: 0395 6001 67(AR) 30 x 2040 x 1650 3) Foam: 0395 6001 69(AR) 50 x 2040 x 1650

45

Parts list

21 Ref.

Service kits

Part number

Qty Name

2901 0245 01

1

2901 0522 00

1

2901 0045 01

1

2901 1453 00

0663 7139 00 1613 3223 01 1622 3662 00 0663 2101 01 1622 3664 00 0335 3111 00 0633 3120 00

1

• • • • • • •

2901 1460 00

0663 2109 78 0337 2293 23 0663 2111 46 1622 0977 00 0663 2107 37

1

• • • • •

2901 1084 00

1622 0977 00 0661 1000 44 0661 1000 44 0661 1000 38 0661 1000 39 1622 0796 00 1622 9639 00 0663 7138 00 1613 2357 00 1613 8907 00

• • • • • • • • •

46

1 1 1 1 1 1 1 1 1 1

1

• • • • • • •

2901 1463 00

1622 3686 00 1622 3694 80 1622 3690 00 1622 3689 00 1622 3691 00 0663 7154 00 1622 3182 00 1622 3183 00 1622 3184 00 1622 3185 00 0301 2318 00 0160 0996 86 0663 2111 55 0663 2107 37 0211 1957 79 0661 1000 40

1 1 1 1 1

1

•

2901 1462 00

0335 2178 00 0508 1100 98 1616 5517 00 1622 3665 00 1622 3740 00 0663 2107 89 0502 1092 55

1 1 1 1 1 1 1

1 1 1 1 1 1 1 1

• • • • • • • • • • • • • • • •

1 1 1 1 1 1 1 1 1 1 2 2 1 1 2 1

Remarks

Oil can

ROTO-INJECTFLUID 5 l

Ref.

Part number 2901 1452 00

ROTO-INJECTFLUID 20 l

1622 3654 80 0663 2108 11 1613 9005 01 0661 1000 38

Oil barrel

2901 1454 00

Oil can

ROTO-INJECTFLUID 5 l

Qty Name

1622 3759 80 0663 7137 00

1 • • • •

1 1 1 1

1 • •

1 1

Remarks

Scavenge line kit

Scavenge line O-ring Non return valve Seal washer  

Thermostat kit 40°C

Thermostat ass’y O-ring

Minimum Pressure Valve kit

O-ring washer   spring O-ring spring circlip O-ring

2901 1464 00

Element mounting kit

2901 0566 12

O-ring Parallel key O-ring gasket O-ring

Check and Oil stop valve kit

Gasket Seal washer   Seal washer   Seal washer   Seal washer   Spring Check valve O-ring Spring Valve body

1622 3759 81 0663 7137 00

1 • •

2901 1455 00

1622 3759 82 0663 7137 00 1613 9503 00 1622 3652 80 0663 2106 16

1 • •

• •

• • •

2901 0566 22

1622 3656 00 0663 2111 16

•

•

Tropical thermostat kit (75°C)

Thermostat ass’y O-ring

Air/ Oil filter kit (4000 Hrs)

Air filter element Oil filter element O-ring

1

Air/ Oil long life filter kit (8000 Hrs)

1 1 2 1 2

1 •

Thermostat kit 60°C

Thermostat ass’y O-ring

1 1 1

1 •

2901 1465 00

1622 3798 81 9820 9583 00

1 1

1 •

2901 1096 00

1622 4601 80 0663 2106 16 1613 9503 00

1 1

Oil filter element O-ring Air filter element

Oil separator kit

Oil separator   O-ring

Electronic drain kit

1 1

Drain assembly Maintenance & operating manual CDi16

1

Preventative maintenance kit GA55+-90

Motor overhaul kit

Circlip Bearing Lipseal kit Bushing Drain nipple O-ring Bearing

2901 1453 80

2901 1453 00 2901 1084 00 2901 1463 00 2901 0566 12 2901 0566 22

• • • • •

1 1 1 1 1

MPV kit Check & Oil stop valve kit Unloader kit Air/Oil filter kit Oil separator kit

Unloader

Valve Blow off valve Bushing Guidance tape Quadring O-ring Guide Seal Bushing Spring Washer   Screw O-ring O-ring Screw Seal washer  

2930 1430 01

Parts list Notes:

.......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... ..........................................................................................................................................................................................................

2930 1430 01

47

Parts list Notes:

.......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... .......................................................................................................................................................................................................... ..........................................................................................................................................................................................................

48

2930 1430 01

Atlas Copco Stationary Air Compressors GA 55+, GA 75+, GA 90 Aircooled GA 55+, GA 75+, GA 90 Watercooled

Parts list