IVECO TRUCKS Heavy Truck Iveco Stralis (Iveco Stralis) - Trunk tractors and chassis or trucks international and re!ional truckin!" Stralis truck includes #ei!ht #ei!ht ro$ %& to '' tons euied #ith en!ines Iveco Cursor (*%+-,+ h")" .ierent /0els ('012 012 0')2 three variants o $ulti-ca3s (/ctive Ti$e2 /ctive .ay2 .ay2 /ctive /ctive Sace)2 the ossi3ility tyes o trailers2 se$itrailers and 3odies - no $atter #hat the ro3le$ truckin! 3eore you #ere not - the $odel nu$3er o trucks Stralis vehicles you #ill #ill ind cost-eective car"
IVECO 4/U5 4/U5T T CO.ES +%%% +%% % 6alunction o the vehicle seed sensor circuit +%%1 Sensor Circuit 6alunction % edal acceleration +%%* 6is$atch si!nal s#itches the 3rake edal and acceleration sensors +%% Circuit 6alunction clutch s#itch +%%7 Incorrect si!nal s#itches the 3rake edal +%%& 5oss o volta!e on3oard net#ork controller ro$ the ter$inal 8%,8 +%11 Control Circuit 6alunction la$ 6I5 (Check En!ine) +%1 Syste$ volta!e is outside the oeratin! ran!e o the controller +%*% Circuit 6alunction coolant te$erature sensor +%*1 Incorrect si!nal circuit coolant te$erature sensor +%** Te$erature Te$erature Sensor Circuit 6alunction o the intake air +%*' Sensor Circuit 6alunction char!e air ressure +%*, Te$erature Te$erature Sensor Circuit 6alunction o uel +%* Sensor Circuit 6alunction o uel ressure in the rail +%*/ Te$erature Te$erature Sensor Circuit 6alunction oil +%*E lo# level si!nal in the sensor ressure coolant +%*4 Incorrect si!nal circuit ressure coolant +%'% The ault or oen circuit sensor (reuency) o the crankshat osition +%'* Sensor Circuit 6alunction (hase) o the ca$shat +%'' 6is$atch ro3es synchroni9ation si!nals (reuency and hase) +%', 4ault relay control circuit an % +%'& 4uel Heater Circuit 6alunction +%'. 6a0i$u$ er$issi3le seed o the en!ine crankshat +%,% Hi!h level si!nal circuit ressure sensor rail +%,1 Hi!h ressure uel rail +%,* 5o# ressure uel rail +%,' uel ressure in the rail a3ove the $a0i$u$ +%,, uel ressure in the rail 3elo# the $ini$u$ +%,& Circuit 6alunction o the uel u$ (hi!h ressure u$) +%,C Incorrect uel in:ection ti$e or In:ector cylinder % +%,. Incorrect ti$e uel in:ection in:ector * +%,E Incorrect ti$e uel in:ection in:ector , +%,4 6alunction o the uel syste$2 aect the to0icity o the e$issions +%% The ault in:ector control circuit % +%1 The ault in:ector control circuit 1 +%* The ault in:ector control circuit * +%' Circuit 4ault in:ector ' +%, The ault in:ector control circuit , +% The ault in:ector control circuit +%7 Oen or short on the 8#ei!ht8 o the control circuit in:ector ' +%; The ault in:ector control circuit % +%& The ault in:ector control circuit % +%/ in:ector control circuit ailure % +%< in:ector control circuit ailure % +%C li$it torue dro in cylinder % +%E $ini$u$ reuired nu$3er o in:ections is not satisied +%7% =ro3le$ % in:ector control channel +%7* 4ault In:ector control channel 1 +%7C Controller> 6alunction channel (driver) % in:ector control +%7. ?eneral alar$ syste$ co$3ustion air-uel $i0ture +%74 controller> incorrect recordin! or no recordin! I6/-in:ector codes +%;1 Te$erature Te$erature Sensor Circuit 6alunction o the intake air (.4I.) +%;* 5o# si!nal circuit air lo# sensor +%;, Hi!h level si!nal circuit air lo# sensor
+%;7 Increased air lo# throu!h the E?R valve +%;; Reduced air lo# throu!h the E?R valve +%;& Short-circuit on the circuit 3oard net#ork recirculation valve control +%;<-ault circuit-3oard net#ork throttle E?R valve +%;C uel syste$ too 8oor8 at its $a0i$u$ enrich$ent +%;. to0ic e$issions o o0ides o nitro!en (@O0) a3ove the irst threshold +%&1 Short-circuit to the control circuit 3oard net#ork tur3o +%&' Increased eror$ance (o#er) o the tur3ochar!er +%&, Reduced eror$ance (o#er) o the tur3ochar!er +%&E 5i$itin! the torue caused 3y the ailure o syste$s o ICE +%/; 6a0i$u$ allo#a3le te$erature o the $eterin! valve urea +%<% Oen Inor$ation C/@-line 8H8 +%<* Oen Inor$ation C/@-line A5B +%<7 Inor$ation C/@-3us is 3usy +% there is no resonse ro$ the dash o the car +%C* C/@-3us> there is no resonse ro$ the tacho!rah +%.% Controller> 4ault S=I-channel +%.1 Controller> 4ault EE=RO6-$e$ory +%.* Controller> locked or en!ine start +%.' Controller> 4ault ir$#are re3oot +%., Controller> Error initiali9in! ro!ra$ +%. Controller> internal synchroni9ation error +%.7 controller> incorrect en!ine $ana!e$ent cali3ration otion +%.; Controller> 4ault ir$#are re3oot +%.& Controller> 4ault /.C si!nals +%./ Controller> 4ault lash RO6 (checksu$ error) +*.* Controller> Error initiali9in! ro!ra$ +%E1 I$$o3iliser> ault 3lock or chains ( uel suly is 3locked) +%E* Error $onitorin! ro!ra$ o en!ine syste$s +%E' Increased reuency o rotation o the en!ine crankshat +%E Controller> Tye % Volta!e suly or sensor out o ran!e +%E7 controller> volta!e tye 1 or sensor o#er suly out o ran!e +%E; controller> volta!e tye * to the sensor suly is out o ran!e +%E& controller> suly volta!e hi!her than the er$issi3le +%E/ Controller> suly volta!e 3elo# the allo#a3le +%E< Sensor Circuit 6alunction at$osheric (a3solute) air ressure +%4% Sensor Circuit 6alunction de3ris articulate ilter +%41 Incorrect si!nal in the sensor circuit de3ris articulate ilter +%4* Sensor Circuit 6alunction de3ris ilter articulate ilter +%4' 5o# si!nal in the sensor circuit de3ris articulate ilter +%4, Hi!h si!nal sensor circuit de3ris articulate ilter +%4 te$erature sensor ailed to e0haust converter +%47 Sensor Circuit 6alunction The e0haust !as te$erature +%4; Incorrect si!nal circuit e0haust te$erature sensor +%4& The hi!h level o re!eneration articulate ilter +%4/ lo# level o re!eneration articulate ilter +%4< Eiciency converter 3elo# acceta3le standards +%4C Slo# resonse to chan!es in te$erature sensor to the converter +1%1 Sensor Circuit 6alunction 1 edal acceleration +1%, 4atal auto$atic control 3oard +11, Circuit 4ault $ana!e$ent $ain relay +11< =o#er circuit ault !lo# +11E 4ault relay control circuit 3ooster elektro3en9onasosa +1*1 Si!nal coolant te$erature sensor is out o ran!e +1* Incorrect si!nal in the sensor circuit ressure uel rail #hen stoin! en!ine +1*/ Hi!h Volta!e circuit oil te$erature sensor +1,% Hi!h ressure uel rail +1,& Short-circuit on-3oard net#ork control circuit u$ +1,C Invalid ti$e or uel in:ection in:ector 1 +1,. Incorrect uel in:ection ti$e or In:ector cylinder ' +1,E Incorrect ti$e uel in:ection in:ector
+1,4 4ault in:ection syste$ aectin! e$issions o @O0 +17, =oor co$3ustion air-uel $i0ture in the cylinder % +17 =oor co$3ustion air-uel $i0ture in the cylinder 1 +177 =oor co$3ustion air-uel $i0ture in the cylinder * +17; =oor co$3ustion air-uel $i0ture in the cylinder ' +17& =oor co$3ustion air-uel $i0ture in the cylinder , +17/ =oor co$3ustion air-uel $i0ture in the cylinder +17C Controller> 6alunction channel (driver) 1 in:ector driver +1;% @ot /ctual air lo# throu!h the E?R valve +1;* 6a0i$u$ er$issi3le deviation o the air lo# on the oeratin! $ode +1;, 6a0i$u$ er$issi3le deviation o the air lo# at idle +1; Si!nal lo# sensor out o ran!e +1;7 Increased air lo# throu!h the E?R valve +1;; Reduced air lo# throu!h the E?R valve +1;& Short on 8#ei!ht8 o the control circuit o the E?R valve +1;<-ault 8#ei!ht8 o the control circuit o the E?R valve throttle +1&1 Oen or short circuit on the 8#ei!ht8 o the control circuit tur3ochar!er +1<' C/@-3us> there is no resonse ro$ the tri co$uter or test eui$ent +1C& C/@-3us> invalid data ro$ the instru$ent cluster or tacho!rah +14; Incorrect si!nal circuit e0haust te$erature sensor +144 Critical ti$e o in:ection to dissolve the oil in the en!ine cylinder +*%, .isosa3le #aiver o the auto$atic on-3oard control +*1< 4ault relay control circuit !lo# lu!s +*,& Short on 8#ei!ht8 o the control circuit u$ +*,4 air o#er ailure aectin! the to0ic e$issions +*;, 6a0i$u$ er$issi3le deviation o the air lo# in the load $ode +*; Si!nal lo# sensor out o ran!e +*;& Oen state recirculation valve or ever O? +*;< Oen Throttle RRC state or increased e0haust !as te$erature +*&1 4ault-3oard net#ork control circuit tur3ochar!er and hi!h te$erature +*&. ro3a3ility o e0ceedin! the nor$s o to0ic e$issions (O<.) - a rich $i0ture Restriction +*&E en!ine torue in order to rotect the tur3ochar!er +*C& C/@-3us> hi!h channel loadin! +*4* Incorrect si!nal in the sensor circuit de3ris articulate ilter +*4; Sensor Circuit 6alunction The e0haust !as te$erature ater the ilter +*4/ 5o# level 1 re!eneration articulate ilter +',4 =ro3le$ la$3da re!ulator aectin! the to0ic e$issions +'; I$lausi3le si!nal circuit I/T sensor +'4/ 5o# level * re!eneration articulate ilter +,,4 6alunction E?R aectin! to0ic e$issions ++% The ault si!nal circuit or loss o activity o the o0y!en sensor % ++1 4aulty o0y!en sensor heater circuit % ++* o0y!en sensor % si!nal is out o ran!e ++' 4aulty o0y!en sensor heater circuit % ++, o0y!en sensor % si!nal is out o ran!e ++ The ault si!nal circuit or loss o activity o the o0y!en sensor % ++7 o0y!en sensor % si!nal is out o ran!e ++& Controller> invalid si!nal o the o0y!en sensor % ++/ Controller> oen or short circuit on the 8#ei!ht8 o the o0y!en sensor heater circuit % ++C Oen or short circuit on the 8#ei!ht8 o the o0y!en sensor heater circuit % ++. si!nal o the o0y!en sensor % is out o ran!e (ull load) ++E o0y!en sensor si!nal is out o ran!e % (artial load) ++4 si!nal o the o0y!en sensor % is out o ran!e (en!ine sto) +&E 5i$itin! torue due to the in:ection ault
