Diagrama Electrico 330 - 336d Excavadora Caterpillar

a

b

c

d

e

f

g

h

i

j

k

l

m

n

o

p

q

r

s

t

u

v

w

x

y

z

aa

bb

cc

dd

ee

Harness And Wire Electrical Schematic Symbols

ff

Symbols

24

24

RENR9587-05 October 2011

23

23

Circuit Breaker Symbol

Flow Symbol

Symbols And Definitions Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it. Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

22

22

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

21

21

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

20

20

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

T

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

19

19

330D and 336D Excavator Electrical System

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

18

18

17

17

MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness And Wire Symbols Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

1 2

16

C-C4 130-6795

AG-C3 130-6795

Part Number for Connector Plug

Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...) Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....) Part Number For Connector Recepticle

Socket

Pin

L-C12 3E-5179

AG-C4 111-7898 1

325-AG135 PK-14

15

15

2

Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes

16

Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

1

Receptacle Pin or Socket Number

9X-1123

Fuse (5 Amps) Component Part Number

Plug

14

14

13

13

336D: JTF1-197 M4T1-206

5A

Single Wire Connector Harness identification code: This example indicates wire 135 in harness "AG".

330D: NBD1-840 MAG1-UP B6H1-652 EAH1-724 FFK1-325 JLP1-737 EDX1-UP MEY1-310

200-L32 BK-14

2 Ground Connection

Circuit Identification Wire Color Number

Wire Gauge

Volume 1 of 2: Engine and Chassis © 2011 Caterpillar, All Rights Reserved

Machine Harness Connector And Component Locations

12

12 11

11

10

10

9

9

8

8

7

7

6

6

5

5

4

4

3

3

2

2

1

1

a

b

c

d

e

f

g

h

i

j

k

l

m

n

o

p

q

r

s

t

u

v

w

x

y

z

aa

bb

cc

dd

ee

Related Electrical Service Manuals Vol 1 Component Location Component Alarm - Travel (ATCH)

Vol 1 Connector Location Connector Number CONN 1

Serial Service Port

Schematic Location

Machine Location

I-18

J-22, J-6

Schematic Location B-15

Machine Location H-16, H-5

Alternator

H-16

E-20, E-8

Assembly - Block

H-3

I-22, I-6

Title

Sensor - Pump #1 Pressure

Schematic Location C-14

Machine Location C-16, C-7

Sensor - Pump #2 Pressure

B-14

D-16, D-7

Sensor - Squeeze Pressure (ATCH)

C-8

J-20, J-8

Component

Consist:

Battery - Rear

H-6

H-22, H-6

Solenoid - 1p/2p Change #1 (ATCH)

A-14

E-15, E-6

Engine Control:

RENR5089

Machine Control:

RENR9848

Solenoid - 1p/2p Change #2 (ATCH)

A-14

E-15, E-6

I-22, I-6

Solenoid - A/c Compressor Clutch

F-18

E-20, E-20

Breaker - Heater

H-2

I-22, I-6

Solenoid - Boom Check 1 (ATCH)

C-6

K-18, K-5

Breaker - Main

H-2

I-22, I-6

Solenoid - Boom Check 2 (ATCH)

C-6

K-18, K-5

Control - Engine

H-18

C-18, C-7

Solenoid - Boom Down Line Cutoff (ATCH)

D-6

F-19, F-7

Control - Gateway

L-16

I-22, I-7

Solenoid - Double Action (ATCH)

A-14

E-15, E-6

Control - Machine

G-2

I-22, I-7

Solenoid - Ether (ATCH)

K-11

G-22, G-7

CONN 7

L-16

I-21, I-7

Diode - Power Relay (ATCH)

B-4

L-15, L-6

Solenoid - Fine Swing

C-6

I-19, I-7

CONN 8

A-11

I-17, I-7

Diode - Start Relay

I-3

I-22, I-6

Solenoid - Flow Limit (ATCH)

B-14

C-16, C-5

Ground - Ecm Mount

I-16

I-22, I-7

Solenoid - Heavy Lift (ATCH)

F-6

G-18, G-6

Ground - Frame 1

G-11

D-20, D-6

Solenoid - Hydraulic Lock

G-6

G-19, G-6

I-21, I-6

CONN 10

J-9

I-21, I-6

Ground - Frame 2

F-15

E-18, E-6

Solenoid - Iapcv

B-16

C-19, C-7

CONN 11

J-9

I-21, I-6

Ground - Frame 3

G-17

C-18, C-5

Solenoid - Injector Cylinder #1

E-15

D-20, D-8

CONN 12

E-8/E-9

E-18, E-6

Ground - Frame 4

A-8

J-17, J-6


E-15

D-20, D-8

Ground - Frame 5 1

H-3

I-22, I-5


D-15

D-19, D-8

K-18

I-22, I-5


D-15

D-19, D-8

CONN 13

E-8/E-9

E-18, E-6

Ground - Frame 5 2

CONN 14

F-8

E-18, E-6

Ground - Frame 6

H-6

G-22, G-5


D-15

D-18, D-8

Heater - Air (glow Plug)

H-17

C-19, C-8


D-15

D-18, D-8

CONN 15

F-8

E-18, E-6

Horn - Forward Warning LH (high)

B-6

K-18, K-6

Solenoid - Power Shift Pressure

B-14

C-15, C-7

CONN 16

C-7

K-19, K-6

Horn - Forward Warning LH (low)

B-6

K-19, K-6

Solenoid - Quick Coupler (ATCH)

C-14

C-16, C-7

CONN 17

B-7/C-7

L-19, L-8

Indicator - Air Cleaner

K-11

F-19, F-7

Solenoid - Quick Coupler High

E-6

C-16, C-7

Indicator - Hydraulic Oil Filter

A-12

F-15, F-6

Solenoid - Quick Coupler Low

E-6

C-16, C-7

Lamp - Boom LH (ATCH)

B-6

T-20, T-9

Solenoid - Radiator Fan Speed Cont.

C-14

C-15, C-7

CONN 18

B-7

K-18, K-6

CONN 19

A-6

K-16, K-6

Lamp - Boom RH (ATCH)

B-6

T-17, T-9

Solenoid - Relief 1

C-8

J-20, J-7

CONN 20

A-6

K-16, K-6

Lamp - Chassis

A-6

M-16, M-5

Solenoid - Relief 1 Check

C-8

J-20, J-7

CONN 21

A-4

M-15, M-6

CONN 22

A-4

M-15, M-6

Motor - Starter

H-17

C-17, C-6

Solenoid - Reversing Fan Change

G-8

F-18, F-6

CONN 23

L-1

I-22, I-5

Motor - Washer

G-3

I-22, I-6

Solenoid - Single Action 1 (ATCH)

B-8

J-20, J-8

Motor - Washer Lower (ATCH)

G-3

I-22, I-6

Solenoid - Single Action 2 (ATCH)

B-8

J-17, J-8

Receptacle - Jump Start

H-6

G-22, G-6

Solenoid - Stem 1 Extend

A-14, B-12

E-15, E-6

H-17

C-19, C-7

Solenoid - Stem 1 Retract

A-14, B-12

E-15, E-6

Motor - A/c Condenser Fan

J-11

I-21, I-6

Motor - Priming Fuel Pump

L-12

D-22, D-6

Solenoid - Relief 2

C-8

J-17, J-7

Solenoid - Relief 2 Check

C-8

J-17, J-7

CONN 24

J-1

I-22, I-5

CONN 25

J-1

I-22, I-5

Relay - Air Heater

CONN 26

J-1

I-22, I-5

Relay - Refueling Start (ATCH)

A-4

L-15, L-6


B-12

E-15, E-6

CONN 27

I-1

I-22, I-5

Relay - Refueling Stop (ATCH)

B-4

L-15, L-6


B-12

E-15, E-6

Relay - Refueling Power (ATCH)

A-4

L-15, L-6


B-14

E-15, E-6

CONN 28

I-1

I-22, I-5

Relay - Start

H-3

I-22, I-6


B-14

E-15, E-6

CONN 29

I-1

I-22, I-5

CONN 30

H-1

I-22, I-5

CONN 58

E-7

G-19, G-6

SENR3581

D-22, D-5

H-21, H-6

J-9

2071557 (DELCO 42 MT)

C-20, C-6

K-12

H-6

CONN 9

SENR4975

C-16

I-2

C-18, C-8

6V5582 (DENSO F8.0)

Sensor - Top Engine Speed Timing (run)

Breaker - Alternator

C-18, C-7

Consist:

Sensor - Water Separator Level (ATCH)

Battery - Rear (ATCH)

E-16

2071556

H-22, H-6

I-22, I-7

A-16

SENR3860

H-21, H-6

I-22, I-7

CONN 6

2371962 (DELCO 50 MT)

H-6

J-17

CONN 5

SENR4130

H-6

K-17

I-22, I-7

1855294 (DENSO HDB)

Battery - Front

CONN 3

J-17

Electric Starting Motor:

Form Number

Battery - Front (ATCH)

CONN 2

CONN 4

Alternator:

Resistor - Can #1

C-3

I-22, I-6

Solenoid - Swing Brake

G-6

G-19, G-6

Resistor - Can #2

C-3

I-22, I-6

Solenoid - Travel Speed

G-6

G-19, G-6

Sender - Hydraulic Temperature

A-12

F-16, F-6

Solenoid - Travel Straight

G-6

G-19, G-7

Sensor - Ambient Temperature

K-12

E-22, E-5

Solenoid -1 Way / 2 Way Change (ATCH)

C-8

J-17, J-7

Sensor - Atmospheric Pressure

A-16

C-18, C-7

Switch - Boom Down Pressure (ATCH)

D-6

G-19, G-7

Sensor - Bottom Engine Speed Timing (

C-16

C-20, C-6

Switch - Boom Up/ Down Pressure (ATCH

D-6

G-18, G-6

Sensor - Engine Coolant Temperature

B-16

D-20, D-7

Switch - Coolant Level

K-12

C-22, C-5

Sensor - Engine Oil Pressure

B-16

C-18, C-6

Switch - Disconnect

H-3

I-23, I-6

Sensor - Engine Speed Pickup

G-17

C-17, C-7

Switch - Engine Oil Level

G-17

C-18, C-6

Sensor - Fuel Level

A-12

I-17, I-7

Sensor - Fuel Pressure

L-12

D-22, D-6

Switch - Fuel Pressure

L - 12

E-22, E-7

Switch - Hammer Return Filter (ATCH)

E-12

H-17, H-7

Sensor - Fuel Temperature

L-12

D-22, D-6

Switch - Hydraulic Oil Level

B-12

G-17, G-6

Sensor - Injection Actuation Pressure

A-16

C-19, C-7

Switch - Priming Pump

L-12

D-23, D-7

Sensor - Intake Manifold Air Temperatu

B-16

C-18, C-7

Switch - Refueling (ATCH)

A-11

H-15, H-8

Sensor - Intake Manifold Pressure

B-16

C-19, C-7

Switch - Refueling Start (no) (ATCH)

A-4

M-15, M-6

Sensor - Pressure Olwd

C-11

K-19, K-5

Switch - Refueling Stop (nc) (ATCH)

A-4

M-15, M-6

Machine locations are repeated for components located close together.

Product Link Radio:

RENR7911

Off Machine Switch Specification Part No.

Function

Actuate

167-3466

ATCH Boom Down Pressure Switch

202-9002

ATCH Boom Up Down Pressure Switch

212-2768

Fuel Pressure Switch

490 ± 49 Kpa (71 ± 7.1 psi) 13780 Kpa max (1999 psi max) 103.4 ± 13.8 Kpa (15 ± 2 psi)

Deactuate

Contact Position

290 Kpa min (42 psi min) 10335 ± 889 Kpa (1499 ± 129 psi) 69 Kpa min (10 psi min)

Part No. 4I-5394

121-1491

163-6700

Sender:

Solenoid:

Sender:

171-0188

Solenoid:

174-3016

Resistor:

239-1134

Solenoid:

Component Description Hyd temp ATCH - Reversing Fan Change ATCH - Quick Coupler High ATCH - Quick Coupler Low Travel Start Travel Speed Swing Brake Hyd Lock Fuel Level ATCH - Flow Limit Can 1 Data Link Can 2 Data Link ATCH - Ether

¹ At room temperature unless otherwise noted.

ff

Wire Description Wire Number

Wire Color

101 103 105 108 109 112 113 114 115 117 118 120 123 124 125 127 129 130 135 139 141 142 143 147 149 152 154 160 165 168 169 172 175 177 179 180 184 188 189 199

RD RD RD RD RD PU OR RD RD RD GY YL WH GY RD OR BU RD BU OR RD RD BR PU RD BU RD PU YL RD PK RD RD RD BU GN RD WH RD OR

200 210 229 235 A209 A234 C212 C214

BK BK BK BK BK BK BK BK

304 306 307 308 310 317 320 321 322 323 325 326 329 331 365 391

WH GN OR YL PU YL RD BR GY WH PK RD YL OR YL PK

251 252 261 262 403 405 410 412 430 450 451 487 491 495 496 C468 E472 E473 E474 E480 F400 F401 F421 F424 F425 F426 F427 F429 F473 G428 H446 H473 H474 H475 H476 H479 L460 L463 L464 X416

YL YL GN GN GN GY WH BU BU YL BR OR PK GN WH BU GN GY OR PK GY GY YL YL PU BU PK BU YL BU PK BR GN BU WH OR YL GY BR OR

501 506 508 509 511 512 514 530 535 575 576 578 590 592 A513 A537 A579 A580 A581 A582 A584 A586 A588 C506 C560 C566 C569 E554 E562 E564 E565

GN PU PU WH BR GN PU OR BU YL PK BU GY BU RD PK OR BR GN PU BU OR GN WH OR PK YL PK PU PK BU

603 607 615 616 638 645 646 684 A623

PK PK YL BU WH RD RD RD BU

763 779 780 788 789 A701 A702 A703 A704

BU WH PU YL RD GY PU BR GN

Normally Open Normally Closed Normally Closed

Resistor, Sender and Solenoid Specifications

Event Codes Engine Control

Resistance (Ohms)¹ 6134 - 7496 Event Code

32.0 ± 3.2

Empty: 83.5 ± 1.5 Half: 33.8 ± 2.0 Full: 8.0 ± 1 - (-0.5) 11.7 ± 1.2 120 ± 10% 20

Condition

E096

High Fuel Pressure

E162

High Boost Pressure

E198

Printed in U.S.A.

Low Fuel Pressure

E265

User Defined Shutdown

E360

Low Engine Oil Pressure

E361

High Engine Coolant Temperature

E362

Engine Overspeed

E390

Fuel Filter Restriction

E539

High Intake Manifold Air Temperature

Description

Wire Number

Power Circuits Bat + A705 Radio Backup A706 Key Sw A745 Air Heater Relay A751 Alt Output (+) Term. A751 Main Power Rly Output A755 Opr Mon Panel Vmis B+ Swed A756 Warning Horn (forward) A757 Cab Lamp Relay A758 Power Converter + 24v BAtchery In A760 Acc Wiper Con A762 Atch 12v 7a Converter 1 + 24v Swed In A768 Atch Seat Heater Sw A769 A/c A770 A/c F716 Atch Air Suspension F773 Cigar Lighter F774 Eng Con BAtchery + G723 Atch 12v 7a Socket + 12v Sw In H704 Radio Converter + 24v Sw In H746 Aux Ckt 2 H747 Aux Ckt 3 H792 Atch Boom Float Disable Relay M736 Coupler Disengage Sol M737 Headlamp Relay M739 Atch Under Window Limit Sw M740 Neutral Start Limit Sw A M743 Right Cab Flood Lamp M744 Crane Caution Lamp M745 Excavator Fuel Pump Sw M746 Back Up Epr Valve Sw M747 Product Link Radio 2nd Genration M748 A/c M749 Main Brkr N707 Atch 12v 7a Converter 1 + 24v Sw In N749 Aux Ckt 1 N789 Machine Con + BAtchery N793 Atch Radio Mute Sw N794 Neutral Start Limit Sw C N795 Atch Rotary Beacon Stwitch R725 Ground Circuits R746 Main Chassis R747 Converter Output (24/12 Volt) T725 Bat (-) T725 Electronic Pump Ctrl Gnd T776 Hex Machine Ctrl Gnd T788 J1939 Shield Gnd X738 Multi-station Control Return 892 Smms Return 893 Basic Machine Circuits A893 Starter Relay No. 1 Output F889 Starter Relay Coil To Neut Start Sw G826 Key Sw To Neutral Start Sw G827 Main Power Relay Coil G828 Start Aid Sw To Start Aid Sol G828 Start Aid Relay To Start Aid Sol G829 Horn Relay Coil To Sw G829 Backup Alarm Lamp Travel Alarm G833 Warning Horn (forward) G833 Fuel Pump Power G849 Fuel Pump Relay Cut-out G850 Key Sw 'c' Term. G854 Fuel Pump To Sw G855 Backup Alarm Relay Coil G856 Fuel Pump Relay To Sw G857 Remote Start/stop J842 Monitoring Circuits K843 Payload Mon - System Gnd K844 Main Module Harness Code 0 K847 Tehc Ident Code 1 K848 Tehc Ident Code 2 K849 Alternator (r) Term. K850 Opr Mon Oil Press. (low Setting) K851 Action Alarm K852 Opr Mon Cool Flow K856 Opr Mon Air Filter K857 Tach Sender + K858 Tach Sender K859 Hyd Oil Flow Sw K860 Hyd Oil Temp Snr K861 Fuel Level Signal K862 Opr Mon Panel Hyd Oil Level K863 Eng Oil Level K864 Atch 12v Snr Supply K865 Stem 1 Modulation K866 Stem 2 Modulation K868 Spare Analog Input #1 K869 Low Oil Pressure K871 High Coolant Temp K872 Fuel Temp K876 Maintenance Incicator K877 Trolling Mode K879 Maintenance Clear K883 Hour Meter + L885 Diagnostic Lamp Driver Cust L886 Transmission Warning R800 Transmission Oil Press R818 Boom Lower Check Press Snr R819 Travel Straight Press Sw T858 Travel Right Press Sw T859 Travel Left Press Sw T860 Joystick Press Sw 944 Fuel Level 945 Trip Clear Switch 994 Low Coolant Level Lamp 995 Hour Meter 998 General Alarm Driver C967 Accessory Circuits C987 Wiper - Front (low) C991 Washer - Front C991 Radio Speaker - Left E963 Radio Speaker - Left (commom) E964 Radio Speaker - Right E965 Radio Speaker - Right (com) E966 A/c Condensor Motor E997 Washer Right G966 Sw To Wiper Sw G973 Wiper - Aux (park) G976 Wiper - Aux (low) J906 Washer - Aux K900 Wiper Sw To Intermittent Module K904 Dc/dc Converter Power Output K906 Dc/dc Converter Memory Output K907 Seat Heater (resistive Element In Cushion) K990 Wiper Motor + L968 Wiper Motor L969 Wiper Motor Raise L972 Wiper Motor Stop L973 Front Window Limit Sw To Wiper Cont L976 Wiper Sw To Wiper Cont L983 Safety Sol Relay To Sol L984 Hi Relay L985 Left Rear Speaker M906 Left Rear Speaker (com) M967 Second Dc/dc Converter Power Output M971 A/c Conler To A/c Compressor Clutch M972 Spare Relay No M973 Spare Relay Nc #2 M974 Spare Relay No #2 N940 Lighting Circuits N941 Rotary Beacon N957 Flood Lamp - Front N959 Cab Flood Lamp/rops N960 Bucket Flood Lamp/boom Flood Lamp N963 Rotary Beacon N970 Headlamp Relay N973 Light Sw To Front Flood Relay N979 Cab Flood Lamp N981 Right Cab Flood Lamp Sw To Relay T901 Control Circuits T902 Torque Converter Sw T957 Coupler Engage Sol T958 Coupler Disengage Sol T959 Eng Speed (+) T960 Cont Lever Lock T961 Injector #1 T962 Injector #2 T967 Injector #3 X994 Injector #4

Wire Color BU GY WH YL YL PK BU GY BR GY PU BU GY PK WH OR WH YL PK YL BR BR BU WH YL PK GN WH BU YL BU OR PK PU BK BU GN GY WH WH PK GY WH WH RD GN PK BR GN OR WH BR BU WH WH GN GN PK PK BR BU PK PU WH YL BK GN GY PU WH YL BR BU GN PU WH YL BR BU GN GY OR PK PU WH BR BU WH OR BR BU GN BR BU BR OR YL GY GY WH OR OR BR GY BU BR BU RD PK PK BK WH BU YL RD PU OR BU BR YL GN GN BU GN OR WH BU GN GN WH OR YL BU OR BR PK BR YL BU YL PK PK OR OR YL BR GN GN YL PK PU YL BR BU GN WH YL BR

Component Identifiers (CID¹) Module Identifier (MID²) Engine Control System (MID No. 036)

Description

Control Circuits (continued) Injector #5 Injector #6 Fuel Pressure After Cooler Temp (pin 15) After Cooler Temp Pin 15 Throttle Sw #1 Throttle Sw #2 Throttle Sw #3 Throttle Sw #4 Electronic Pump Cont Throttle +5v Electronic Pump Cont Eng Speed Ground Pump Con Valve #1 (+) Pump Con Valve #2 (-) Electronic Pump Con Bypass Sw To Resistor Shutdown (nc)(app Specific) (pin 8) Governor Accel Governor Decel Heavy Lift Sol Valve Impl Cont Reversing Fan Sol Fan Con Sol Positive Fan Con Sol Return Sw To Relay 2 Governor Command Front Flow Con Valve Sol Sol Return 2 Travel Straight Sol Atch Boom Float Disable Relay Atch Smart Boom Select Sw Atch Boom Check Sol1 Atch Smart Boom Up/down Relay Atch Smart Boom Down Relay Atch Boom Down Press Sw Atch Boom Check Sol 2 Fuel Press Sw Left Exhaust Temperature Ambient Temp Snr Foot Pedal Sw Aux (ele) Pedal-lh Aux (ele) Pedal-rh Fuel Filter Sw Turbo Outlet Press Sensor Atmospheric Press Sensor Fuel Filter Sw Fuel Filter Sw Fuel Pump Relay Fuel Priming Pump Return Filter Sw. To Conler Start Mod Right (-) Port/cat Data Link (-) Start Mod Right (+) Port/cat Data Link (+) Fuel Sw To Fuel Pump Throttle Position Feedback Filter Sensor +5v Filter Sensor Common Press Snr +5v Pressure Sensor +5v Press Snr Com Pressure Sensor Common Eng Temp Snr Com Engine Temperature Sens Engine Inj Actuation Pressure Inlet Air Heater Return Inj Actuation Press Cont Valve Iap Cont Valve Common Tdc Probe + Tdc Probe Digital Return Stem 3 Extend Sw Stem 4 Extend Sw Stem 3 Retract Sw Stem 4 Retract Sw Atch Stem 1 Atch Stem 2 Atch Stem 3 Atch Stem 4 Stem 1 Con Valve A Stem 2 Con Valve A Stem 3 Con Valve A Stem 4 Con Valve A Stem 1 Con Valve B Stem 2 Con Valve B Stem 3 Con Valve B Stem 4 Con Valve B Atch Relief Valve 1 Atch Relief Valve 2 Atch 1-way / 2-way Con Valve Atch Sol Return 2 Atch Sol Return 3 Pump Exchange Sol Single/double Action Exchange Sol Atch Relief Sol Atch Change Check Sol Double Action Sol Troll Enable Pcp Sw Panel Option Sw Sw Panel Option Sw +8v Digital Sensor Power Transmission Oil Temp Sensor Slow Vessel Mode Injector High Side Injector High Side Injector High Side Data Link + Data Link Oil Pressure Filtered Coolant Temperature Digital Snr Return (pin 29) Inlet Air Temperature Inlet Air Heater + Fuel Filter Monitor Fuel Filter Monitor Engine Speed/timing AEngine Speed/timing A+ Engine Speed/timing BEngine Speed/timing B+ Hydraulic Lock Remote Shutdown Boom Raise Press Sw To Crush Press Sw Water Separator Snr Keyswitch J1939 Data Link + Pump Discharge - Signal Swing Brake Sol - Signal Swing Brake Sol - +b J1939 Data Link Electronic Pump Con Ps Valve (-) Electronic Pump Con Ps Valve (+) Low Idle Sw Fine Swing Cont Relay To Sol Valve Excavator Fuel Pump Sw Injector Common 1 & 2 Injector Common 3 & 4 Injector Common 5 & 6 Aux Ckt 1 (pwm In) Vmis Jacket Coolant Level Primary Throttle Position Secondary Throttle Position Synchronize Ip 1 Synchronize Ip 2 Engine Analog Sensor Power +5v Engine Analog Sensor Return Rxd - Comm #1 Rxd - Comm #3 Txd - Comm #1 Txd - Comm #3 Dtr - Comm #1 Dcd - Comm #1 Signal Gnd - Comm #1 Signal Gnd - Comm #3 Mss Exciter Coil In Mss Exciter Coil Out Inj 1 Return Inj 2 Return Inj 3 Return Inj 4 Return Inj 5 Return Inj 6 Return Pump Discharge Mean Press Starter Interlock

CID

Component

0001

Injector Cylinder #1

0002


0003


0004


0005


0006


0041

Sensor Supply Voltage

0042

Injector Actuation Valve

0091

Throttle Position Sensor

0094

Fuel Pressure Sensor

0100

Engine Oil Pressure Sensor

0110

Engine Coolant Temperature Sensor

0164

Injector Actuation Pressure Sensor

0168

Electrical System Voltage

0172

Intake Manifold Air Temp Sensor

0174

Engine Temperature Sensor

0190

Engine Speed/timing Sensor.

0253

Personality Module Mismatch

0261

Engine Timing Calibration

0262

5 Volt Dc Sensor Power Supply

0268

Check Programmable Parameters

0274

Atmospheric Pressure Sensor

0286

Low Oil Pressure Lamp

0342

Secondary Engine Speed/timing Sensor

0617

Inlet Air Heater Relay

1639

Machine Security System

1785

Intake Manifold Pressure Sensor

2417

Ether Injection Control Solenoid

Machine Control System (MID No. 039) CID

Component

0041


0096

Fuel Level Sensor

0110


0167

Alternator Charging Voltage Sensor

0168


0171

Ambient Air Temperature Sensor

0190

Engine Speed/timing Sensor

0246

Can Data Link

0247

J1939 Data Link.

0248

Cat Data Link

0254

Electronic Control Module

0262


0271

Action Alarm

0362

Radiator Fan Speed Solenoid

0374

Swing Brake Solenoid

0544

Engine Cooling Fan Speed Sensor.

0581

Power Shift Pressure Solenoid

0586

Engine Speed Dial Switch

0588

Monitoring System Display

0598

Travel Speed Solenoid Valve

0600

Hydraulic Oil Temperature Sender

0735

Heavy Lift Solenoid Valve

1130

Left Side Attachment Pedal Sensor

1160

Hydraulic Lock Solenoid

1178

Boom Overload Pressure Sensor

1522

Relief Check Valve-2 Solenoid

1523


1525

Travel Straight Solenoid

1590

Main Pump Flow Limitation Pressure Solenoid

1593

Attachment Valve #1 Extend Pressure Solenoid

1594


1595


1596

Attachment Valve #1 Retract Pressure Solenoid

1597


1598


1609

Squeeze Pressure Sensor

1657

Left Joystick Thumbwheel

1658

Right Joystick Thumbwheel

1665

Variable Relief Valve #1 Pressure Solenoid

1666


1931

Auxiliary Circuit Flow Combining Solenoids

2265

Hydraulic Pump 1 Outlet Pressure Sensor

2266


2280

The Travel Alarm Relay

2300

Switch Panel

Product Link Radio (MID No. 122 ) CID

Component

0168


0254


0269

Sensor Power Supply

1251

Alternator R-terminal Signal

¹ The CID is a diagnostic code that indicates which circuit is faulty. ² The MID is a diagnostic code that indicates which electronic control module diagnosed the fault.

Failure Mode Identifiers (FMI)¹ FMI No.

Failure Description

0

Data valid but above normal operational range.

1

Data valid but below normal operational range.

2

Data erratic, intermittent, or incorrect.

3

Voltage above normal or shorted high.

4

Voltage below normal or shorted low.

5

Current below normal or open circuit.

6

Current above normal or grounded circuit.

7

Mechanical system not responding properly.

8

Abnormal frequency, pulse width, or period.

9

Abnormal update.

10

Abnormal rate of change.

11

Failure mode not identifiable.

12

Bad device or component.

13

Out of calibration.

14

Parameter failures.

15

Parameter failures.

16

Parameter not available.

17

Module not responding.

18

Sensor supply fault.

19

Condition not met.

20

Parameter failures.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

36 Page,

Level Symbol

RENR9587-05 VOL 1 of 2

Temperature Symbol

(Dimensions: 48 inches x 35 inches)

T Pressure Symbol

L67

OR-18 PK-18 GN-18 YL-18 BR-18

CONN 3

GN-C4 GK-C2 2434508 84RE01 2305010 84RE01 MATE GL-C1 (PL121SR)(NOTE AA)

J

172-GN7 RD-18 403-GN11 GN-18

MATE GK-C2 (PL121SR)(NOTE AA) N963-GN18 OR-18 N959-GN16 PK-18 N981-GN22 GN-18 235-GN13 BK-18

308-GN9 YL-16

SWG1 SWG2 SWG3

1 2 3 4

RD-18 BK-18 GN-18 YL/BK-18

ATCH-WATER SEPARATOR LEVEL SNSR 1782345 8-32 VDC CHASSIS GND OUTPUT 1 OUTPUT 2

1 2

BU-18 BU-18

PROBE SUPPLY PROBE SUPPLY

AMBIENT TEMP SENSOR 1078618

C-C16 1552267 A A760-C108 GY-18 B 235-C154 BK-18 C N789-C107 BU-18

L12

+B GND SIGNAL

514-C12 PU-16 C506-C13 WH-16 200-C161 BK-16

L16

780-AL1 PU-16

L9

OR-18

PK-18

1 2

1 2

C-C23 2434505 84RE01

L9

1 2

CONN 9 C-C21 2434505 84RE01

C-C22 2304011 84RE01 780-C8 PU-16

C-C20 2304011 84RE01 1 X738-C39 PK-18 2

CONN 10 C-C70 2434505 84RE01

1 2

CONN 11

L13

C-C69 2304011 84RE01 H704-C202

PK-18

C-C72 C-C71 2434506 84RE01 2304013 84RE01 1 K863-C204 OR-18 2 K859-C205 BR-18 3 L968-C206 OR-18

L6

L9

L4

L4

L2

C-C1 1636637 84RE01 130-C1 RD-14 172-C2 RD-18 L973-C80 GN-16 A588-C3 GN-18

130-C1 RD-14 147-C10 PU-16 168-C51 RD-10 172-C2 RD-18 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 310-C44 PU-16 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 403-C14 GN-18 405-C16 GY-18 412-C17 BU-18 430-C18 BU-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 506-C45 PU-18 514-C12 PU-16 578-C46 BU-16 607-C7 PK-16 616-C9 BU-16 780-C8 PU-16 892-C48 BR-18 893-C47 GN-18 998-C71 BR-18 A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 C506-C13 WH-16 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C123 RD-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C68 WH-18 G976-C32 BU-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K906-C62 GN-18 K907-C63 BU-18 L968-C207 OR-18 L969-C66 WH-18 L972-C33 BU-18 L973-C80 GN-16 N793-C86 GN-18 N794-C58 GY-18 N795-C59 WH-18 X738-C39 PK-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18

308-C4 184-C5 322-C6 607-C7 780-C8 616-C9 147-C10 E554-C11 514-C12 C506-C13 403-C14

L20

L20

L69

L69

L69

L50

L50

L50

L1

C-C3 2434510 84RE01 E474-C52 OR-18 K844-C53 GY-18 K848-C54 WH-18 E473-C55 GY-18 K843-C56 GN-18 K847-C57 PU-18 N793-C86 GN-18 N794-C58 GY-18 N795-C59 WH-18 252-C60 YL-18 262-C61 GN-18 NOTE E

C-C4 2304009 84RE01 K906-C62 GN-18 K907-C63 BU-18 A768-C64 BU-18 A769-C65 GY-18 L969-C66 WH-18 L968-C207 OR-18 F889-C68 WH-18 F773-C69 OR-18 F774-C70 WH-18 998-C71 BR-18

L20

101-CR1 RD-00

101-CF1 RD-00

L20 YL-16 PU-16 BU-18 YL-18 PU-18 WH-18 YL-18 OR-18 PK-18 YL-18 BR-18 BR-18 PU-18 WH-18 YL-18 BU-18 GN-18 GY-18 PK-18 PU-18 WH-18 BR-18 BU-18 WH-18 BR-18 BU-18 GN-18 WH-18 YL-18 YL-18 PK-18 BU-18 YL-18 BK-14 BK-18 BK-18 BK-18

CYL HEAD SOL 6

YL-16

INTAKE MAINIFOLD AIR TEMP SNSR 1978391 SIGNAL GROUND

995-A12 BU-18 G833-A44 PK-18

A-C6 1552269 1 2

COOLANT TEMP SNSR 1978392 SIGNAL GROUND

G854-A100 PK-18 G855-A91 PU-18

A-C3 1552269 1 2

IAP CONTROL VALVE 2188654 BK-18 BK-18

G826-A38 BR-18 G827-A43 BU-18 994-A10 GY-18

A-C15 ENGINE OIL PRESS SENSOR 1552267 1978394 A ANALOG +5V B GROUND C SIGNAL

G828-A39 WH-18 G829-A41 GN-18 R746-A20 PK-18

G828-A95 WH-18 G829-A94 GN-18 G849-A96 BR-18

A751-A13 G833-A46 T725-A32 N707-A31 G826-A35 G827-A36 C991-A33

YL-18 PK-18 WH-18 PU-18 BR-18 BU-18 PK-18

A G828-A40 WH-18 G829-A42 GN-18 R747-A6 GY-18

A-C13 INJECTOR ACTION PRESS SENSOR 2366220 3E3370 A OR-18 ANALOG +5V B YL-18 GROUND C GN-18 SIGNAL

1 2 3 4 5 6 7 8

1 2

ATCH-FLOW LIMIT SOL 1710188 (NOTE G,H,J,K,L,M)

C-C60 3E3364

ATCH-STEM 3 RETRACT SOL 0000000 (NOTE N)

1 2

ATCH-STEM 3 EXTEND SOL 0000000 (NOTE N)

1 2

GG-C3 1552269 GG-C2 1552269

ATCH-STEM 1 RETRACT SOL 0000000 (NOTE L,M,AD)

1 2

BU-18 GY-18

1 2

1 2 1 2

GF-C2 1552269 GF-C1 1552269

L155

K857-GF3 WH-18 K868-GF14 BR-18

K860-GF2 BU-18 K868-GF15 BR-18

GC-C3 1552269

GC-C2 1552269

K871-GC8 235-GC17

WH-18 BK-18

C-C55 1552269 1 496-C23 WH-18 2 235-C176 BK-18

235-C175 491-C20

K856-GF1 PU-18 K868-GF16 BR-18

K871-GC9 235-GC16

1 2

ATCH-STEM1 EXTEND SOL 0000000 (NOTE K) 14

1 2

GC-C1 1552269

L52

WH-18 BK-18

ATCH-TRAVEL ALARM 2139100

GE-C3 1552269 K857-GE2 WH-18 K868-GE5 BR-18

HYD OIL LEVEL SW 2130677

1 2

321-C40 487-C19 491-C20 496-C23 235-C172 235-C173

BR-18 OR-18 PK-18 WH-18 BK-18 BK-18

235-C175 235-C178 T HYD TEMP SENDER 4I5394

A B C

+B GROUND SIGNAL

L73

L60

L54

235-C173 235-C172 235-C175 235-C176 235-C177

BK-18 BK-18 BK-18 BK-18 BK-18

BK-18 BK-18

ATCH-QUICK COUPLER SOL HIGH 1211491 (NOTE AC)

779-GU2 200-GU6

GU-C3 1552269 1 WH-16 2 BK-18

ATCH-QUICK COUPLER SOL LOW 1211491 (NOTE AC)

HYD OIL FILTER INDICATOR 1733518

1 2

OR-18 OR-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

L58

L74

L76

ATCH-SQUEEZE PRESS SENSOR 2218859 (NOTE L)

109-WA1 RD-8 109-CL1 RD-4 101-CJ1 RD-4

177-A71

RD-6

177-WE1 RD-6

A209-K15 308-K14 H446-K16 M745-K5 M749-K10 200-K9 200-K9 200-K11 200-K12 200-K13 200-K4 200-K4 200-K13

BK-18 YL-18 PK-18 GY-18 PK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

L77

1 2

GF-C7 GF-C14 1552269 3E3364 1 K877-GF8 BU-18 2 235-GF17 BK-18

ATCH-RELIEF 2 SOL 0000000 (NOTE L)

1 2

ATCH-RELIEF 2 CHECK SOL 0000000 (NOTE L)

C-C36 2434505 84RE01 L973-C80 GN-16 200-C169 BK-16

L37

L37

1 2

C-C37 2304011 84RE01

CONN 8

325-WJ1

1 2

168-C51 322-C6 325-C174 607-C7 616-C9 L973-C80

L36

325-WJ1

L5 L10

L20

NOTE E

K-C6 1552269 1 GY-18 2 BK-18

ATCH-BOOM CHECK SOL 1 2154919

CONN 16

AM-C1 AM-C2 1552269 2304011 84RE01 1 L973-AM1 GN-16 1 2 200-AM2 BK-16 2

MATE C-C38

L40

CONN 17 C-C38 2304011 84RE01 616-C9 BU-16 200-C193 BK-16

L694

PK-18

PK-18

200-C169 200-C193 200-C194 200-C195 200-C196

RD-10 GY-16 PK-18 PK-16 BU-16 GN-16 BK-16 BK-16 BK-16 BK-16 BK-10

GY-16 BK-16

L49

M740-C74 PK-18 K863-C204 OR-18 763-C75 BU-18 L969-C66 WH-18 K859-C205 BR-18 H746-C76 H704-C202 M737-C77 K871-C78 K866-C79

L18

NOTE E NOTE E

NOTE E

YL-18 PK-18 WH-18 WH-18 WH-18

788-C81

YL-18

K864-C82 K868-C83 L968-C67 K869-C84 H747-C85 K907-C63

PK-18 BR-18 OR-18 BU-18 BR-18 BU-18

A762-C87

PU-18

A588-C88 K865-C89 K876-C90 K877-C91 G723-C92 K860-C93

GN-18 PU-18 BR-18 BU-18 YL-18 BU-18

M739-C94

YL-18

K856-C95 K861-C96 K857-C97 K862-C98 K858-C99

PU-18 GN-18 WH-18 GY-18 YL-18

F889-C100

WH-18

252-C101 262-C102

YL-18 GN-18

251-C103 261-C104

YL-18 GN-18

E997-C123

RD-18

184-C105 235-C106

RD-14 BK-14

N789-C107

BU-18

K852-C38 A760-C108 H476-C30 A755-C24 A758-C27 L972-C33 184-C109 235-C110

GN-18 GY-18 WH-18 PK-18 BR-18 BU-18 RD-14 BK-14

M906-C111

BU-18

A209-C112 A756-C25 A757-C26 K848-C54 K844-C53 308-C113

BK-18 BU-18 GY-18 WH-18 GY-18 YL-16

E472-C29 F889-C115 K847-C57 K843-C56 H475-C35 K849-C36 893-C116 K904-C117 T967-C118

GN-18 WH-18 PU-18 GN-18 BU-18 YL-18 GN-18 GN-18 YL-18

H446-C119 E474-C52 H473-C31 H474-C34 K850-C120 K851-C37 892-C121 E473-C55

PK-18 OR-18 BR-18 GN-18 BR-18 BU-18 BR-18 GY-18

N793-C86 GN-18 G973-C201 OR-18

L19

N794-C58 N795-C59

GY-18 WH-18

L39

168-C51 RD-10 325-C174 PK-18 607-C7 PK-16 200-C195 BK-16 200-C196 BK-10

C-C39 E-C1 2434505 84RE01 2304011 84RE01 1 322-E1 GY-16 322-C6 GY-16 2 200-C194 BK-16 200-E3 BK-16

L40

L41

168-X16 329-X17

X-C8 1552269 1 RD-18 2 YL-18

ATCH-BOOM LAMP LH 1532521

329-X17 168-X16

YL-18 RD-18

ATCH-BOOM LAMP RH 1532521

168-X15 RD-18 168-X14 RD-18 168-X14 RD-18 168-X13 RD-18 168-X1 RD-10 323-X12 WH-10 329-X18 YL-18

L48

MATE C-C40

CONN 19 MATE C-C42

GY-16 GY-16 BK-16 BK-16

X-C2 1211038 RE01 1 168-X1 RD-10 2 200-X2 BK-10 1 2

L42

X-C1 2304011 84RE01 325-X3 PK-18

C-C40 C-C41 1160126 84RE01 1211038 RE01 168-C51 RD-10 1 200-C196 BK-10 2 CONN 20

ATCH-REFUELING SW 5C6108 (NOTE W)

FORWARD WARNING HORN LH (LOW) 7Y3919

FORWARD WARNING HORN RH (HIGH) 7Y3920

RD-10 PK-18 YL-18 YL-18 YL-18 GN-18 GN-18 GN-18 BK-10 BK-10 BK-18 BK-10

L43

CONN 28

GU-C1 2434507 84RE01 780-GU1 PU-16 779-GU2 WH-16 A588-GU3 GN-18 200-GU4 BK-18

1 2 3 4

WASHER MOTOR 7T8890

1 2 MOTOR

ATCH-LOWER WASHER MOTOR 7T8890

DESCRIPTION FRAME LEFT SIDE REAR FRAME ENGINE ROOM FRONT FRAME ENGINE ROOM REAR FRAME RIGHT SIDE FRONT FRAME BREAKER BOX LOWER FRAME BAT. ROOM JUMP START FRAME PLATFORM LOWER PLATFORM REAR CAB RIGHT SIDE FRONT CAB RIGHT SIDE REAR CAB TOP PL ECM MOUNT

IDENT PART NO. SH

MACHINE ECM 2218874

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54

TRAVEL STRAIGHT SOL ATT STEM-4 RETRACT PRV TRAVEL SPEED SOL PS PRESS. PRV ATT STEM-4 EXTEND PRV SPARE (STB) VALIABLE FAN MOTOR PRV REVERSE FAN SOL FLOW LIMIT PRESS. PRV 2 PUMP FLOW COMBINE SOL 1WAY/2WAY CHANGE SOL BOOM UP LIMIT PRV (FOR CRANE) SPARE (PRV) SPARE (OC) CAN-3 SHEILD SPEED SENSOR - (ENG) (OFFSET ANGLE SENSOR) VARIABLE RELIEF-1 PRV PRV RETURN PRV RETURN PRV RETURN PRV RETURN SWING BRAKE SOL FAN SPEED SPEED SENSOR + (ENG) CAN-4 SHEILD HYD LOCK CANCEL SW VARIABLE RELIEF-2 PRV VARIABLE RELIEF-1 CHECK SOL VARIABLE RELIEF-2 CHECK SOL HEAVY LIFT SOL ATT STEM-1 RETRACT PRV STK OUT LIMIT SOL (FOR CRANE) BKT LOCK SOL (FOR CRANE) PRV RETURN CAN-4 + CAN-4 ATT STEM-1 EXTEND PRV ATT STEM-2 RETRACT PRV ATT STEM-2 EXTEND PRV ATT STEM-3 RETRACT PRV ATT STEM-3 EXTEND PRV SPARE (PRV) ENG SPEED COMMAND CAN-3 + CAN-3 CAN-2 + (J1939)(MSS) CAN-2 - (J1939)(MSS) CAN-2 SHEILD(MSS) CAN-1 + (MONITOR AND SW PANEL) CAN-1 - (MONITOR AND SW PANEL) CAN-1 SHEILD (MONITOR AND SW PANEL) HYD LOCK SOL SPARE (FREQ IN)

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54

+B GND RS422 RX+ (REMOTE CONTROL EQUIPMENT) AMBIENT TEMP (SLIDE ARM POSITION SENSOR) (BOOM ANGLE SENSOR) (STICK ANGLE SENSOR) ATT STEM-4 STATUS 5V SUPPLY (POWER SUPPLY FOR POTENTIO) IMPLEMENT PRESS. SW THROTTLE-1 THROTTLE-4 ONE TOUCH LOW IDLE SW +B GND RS422 RX- (REMOTE CONTROL EQUIPMENT) SQUEEZE PRESS. SENSOR SPARE (PWM IN) ANALOG RETURN THROTTLE-2 THROTTLE-3 LH HANDLE FORE SW LH HANDLE UPPER SW KEY SW RS422 TX+ (REMOTE CONTROL EQUIPMENT) RS422 TX- (REMOTE CONTROL EQUIPMENT) SPARE (PWM IN) 8V SUPPLY (POWER SUPPLY FOR SENSOR) BACKUP SW RH HANDLE FORE SW (FOR SMART BOOM) RH HANDLE UPPER SW TRAVEL LEFT PRESS. SW ATT STEM-1 STATUS CDL + (ET) PUMP PRESS. SENSOR-1 PUMP PRESS. SENSOR-2 BOOM CYL ROD PRESS. (FOR CRANE) BOOM CYL HEAD PRESS. (FOR OL & CRANE) THUMB WHEEL-LH TRAVEL STRAIGHT PRESS. SW TRAVEL RIGHT PRESS. SW ATT STEM-2 STATUS ATT STEM-3 STATUS CDL - (ET) THUMB WHEEL-RH CANCEL SW (FOR CRANE) BUCKET EXTEND PRESS. SW (FOR CRANE) FOOT SW BOOM UP PRESS. SW SPARE (PWM IN/STG) SPARE (PWM IN/STG) SPARE (PWM IN) SPARE (PWM IN) AUX PEDAL LH AUX PEDAL RH

C-C34 3E3370 YL-18 A GN-18 B C

CAN 2 RESISTOR 1743016 84RE01

CAN 1 RESISTOR 1743016 84RE01

A C E F G H J K L M N P R T U V W X Y AA AC AE AF AG AH AJ AK AL AM AN AP AR AT AU AV AW AX AY GA GC GE GF GG GH GJ GK GL GM GN GP GR GT GU GV

267-7592 283-2933 267-8073 267-7591 259-4877 251-0580 251-0614 267-7915 --251-0543 238-1585 238-1587 167-3456 167-3456 170-9295 170-9295 --238-1579 238-1595 238-1597 ------251-0299 --234-1124 259-5121 238-1588 275-6865 ----238-1601 ------238-2479 ----251-0598 275-6935 275-6937 275-6936 259-5125 259-5254 --267-7813 259-4940 --259-4887 275-6938 259-5119 267-7644 267-7830 267-7672

2 1 1 3 2 2 3 1 2 1 1 2 2 2 2 1 1 1 2 3 1 1 1 1 3 3 1 1 1 1 3 1 1 1 1 3 3 1 3

I

MATE GA-C1 SH3 E-12

CONN 29

MATE J-C1 SH3 E-12

CONN 30 MATE GT-C6 SH3 D-12

CA CC CE CF CG CH CJ CK CL CM CN CP CR CT CU CV CW CX CY FA FC

251-0625 170-6929 231-1827 259-5126 170-6929 193-3515 251-0303 --251-0304 234-1035 --259-5127 259-5128 ------------238-2390 238-2391

1 1 1 1 1 1 2 1 1 1 1 3 3

WA WC WE WF WG WK WJ WK WL WM

234-1037 234-1038 238-2280 ----163-6758 238-1593 ----267-7807

1 1 1 3 1 1

PA PC PE

7G-1060 132-1806 128-8886

2 1 1

ABBREVIATION FOR SCHEMATIC GND-FR 1 GND-FR 2 GND-FR 3 GND-FR 4 GND-FR 5 X GND-FR 6 GND-FR 7 GND-PLATFORM GND-CAB 1 GND-CAB 2 GND-CAB 3 GND-ECM MOUNT

LOC DESCRIPTION NOTE HARNESS AS. E-12 PLATFORM L-1 CHASSIS B-7 HORN F-8 CAB C-6 CONSOLE RH F-5 CONSOLE LH E-12 BOOM FLOAT (CAB) I-1 BOOM FLOAT (CHASSIS) ----B-4 KEY SW (CONSOLE RH) B-7 LIGHTING (02) BOOM (LONG) C C-7 LIGHTING (02) BOOM (SHORT) D F-2 LIGHTING (02) CAB LH F-2 LIGHTING (02) CAB RH F-2 LIGHTING (02) CAB LH (GUARD) P E-2 LIGHTING (02) CAB RH (GUARD) P ----A-6 REFUELING PUMP W A-4 REFUELING START SW (N/O) W A-4 REFUELING STOP SW (N/C) W ------------A-11 SECONDARY SHUTDOWN ----A-7 MOUNTING RADIO R J-9 HAMMER RETURN FILTER X J-9 QUICK COUPLER (CHASSIS) C-6 FINE SWING --------J-9 REVERSING FAN ------------A-2 QUICK COUPLER (TOGGLE SW) --------E-12 CONFIG. 2,11 (CAB) G,H I-1 CONFIG. 2,11 (CHASSIS) G,H E-9 SYSTEM 16 K E-8 SYSTEM 3,5,14,17 J,L,M,AD F-8 MEDIUM CIRCUIT N A-7 12V POWER SUPPLY AB ----K-18 PRODUCT LINK (RADIO) Y,Z J-15 PRODUCT LINK (SERVICE CONN) Y,Z ----K-16 PRODUCT LINK (GATEWAY) Y I-1 ELEC PRIMING PUMP (CHASSIS) D-12 ELEC PRIMING PUMP (CAB) D-12 UNIVERSAL QUICK COUPLER (CAB) AC H-1 UNIVERSAL QUICK COUPLER (CHASSIS) AC B-2 UNIVERSAL QUICK COUPLER (TOGGLE SW) AC CABLE AS. H-7 BAT. - STARTER (STD) H-6 BAT. - BAT. (STD) H-6 BAT. - DISCONNECT SW (STD) H-7 BAT. - STARTER (COLD) A H-6 BAT. - BAT. (COLD) A H-6 BAT. - DISCONNECT SW (COLD) A H-3 TERM. BLK - MAIN BKR ----H-3 ALT BKR - TERM. BLK H-3 HEATER BKR - TERM. BLK ----H-7 JUMP START TERM. BLK - STARTER B H-7 BAT - JUMP START TERM. BLK B ------------------------A-10 MAIN RELAY - FUSE BASE A-10 MAIN RELAY - FUSE BASE WIRE AS. H-3 TERM. BLK - START RELAY H-3 START RELAY - TERM. BLK H-3 TERM. BLK - MAIN BKR --------B-10 LAMP TIMER JUMPER A-12 REFUELING LEVEL SW W --------I-17 PRODUCT LINK ANTENNA (GND) Y,Z STRAP AS. F-10 PLATFORM - CHASSIS H-3 DISCONNECT SW - CHASSIS F-17 ENGINE - CHASSIS

DESCRIPTION BLADE, SPADE, RING, OR SCREW TERMINAL

SYMBOL

12

11

10

9

8

7

COMPONENTS ARE SHOWN INSTALLED ON A FULLY OPERABLE MACHINE WITH THE KEY OFF AND ENGINE OFF. NOTE A: USE WITH COLD WEATHER, -32 DEGREES C. NOTE B: USE WITH JUMP START.

ATCH-POWER RELAY DIODE 1974385

E

D

C

ATCH WIRE, CABLE, COMPONENT

NOTE C: USE WITH LONG BOOM.

CIRCUIT GROUPING DESIGNATION

NOTE E: THE FOLLOWING WIRES MUST BE TWISTED PAIRS. AT LEAST 1 TURN PER 25 mm. 251-YL AND 261-GN 252-YL AND 262-GN 892-BR AND 893-GN T901-YL AND T902-PK

ABBREV BK BR BU GN GY OR PK PU RD WH YL

NOTE F: USE WITH TIME DELAY CAB LIGHTS. NOTE G: USE WITH TOOL CONTROL SYSTEM CONFIG. 2.

L47

168-X1 365-X6 L976-X9 200-X4 200-X5 168-X13 168-X15 168-X15 365-X7 L976-X10 325-X3 365-X8 168-X13 L976-X11

RD-10 YL-18 GN-18 BK-18 BK-10 RD-18 RD-18 RD-18 YL-18 GN-18 PK-18 YL-18 RD-18 GN-18

X-C4 1495051 84RE02 L976-X9 GN-18 365-X6 YL-18 200-X4 BK-18 329-X18

YL-18

NOTE J: USE WITH TOOL CONTROL SYSTEM SYSTEM 3. 1 2 3 4 5

NOTE K: USE WITH TOOL CONTROL SYSTEM SYSTEM 16. NOTE L: USE WITH TOOL CONTROL SYSTEM SYSTEM 14. NOTE M: USE WITH TOOL CONTROL SYSTEM SYSTEM 17. NOTE N: USE WITH TOOL CONTROL SYSTEM MEDDIUM CIRCUIT. NOTE P: USE WITH FRONT GUARD CAB LIGHTS.

ATCH-REFUELING STOP RELAY 1495050 X-C5 1495051 84RE02 L976-X19 GN-18 365-X7 YL-18 168-X15 RD-18 L976-X19 L976-X10

GN-18 GN-18

NOTE S: USE WITH LOWER WINDSHIELD WIPER WITH WASHER.

1 2 3 4 5

NOTE T: USE WITH 12V-7A POWER SUPPLY WITH CIGAR LIGHTER TYPE SOCKET. NOTE U: USE WITH 12V-2X7A POWER SUPPLY WITH TWO CIGAR LIGHTER TYPE SOCKET. NOTE V: USE WITH CAT MSS (ANTI THEFT DEVICE).

ATCH-REFUELING START RELAY 1495050

CONN 22

X-C7 2304011 84RE01 168-X13 RD-18 L976-X11 GN-18

1 2

CONN 21 L46

X-C6 2434505 84RE01 365-X8 YL-18 325-X3 PK-18

Y-C1 2434505 84RE01 168-Y1 RD-18 L976-Y2 GN-18

NOTE W: USE WITH ELECTRIC REFUELING PUMP WITH AUTO SHUT OFF.

SWITCH AS. 2381594

NOTE X: USE WITH HYD. RETURN FILTER FOR HAMMER. (CAN BE INSTALLED ON ONLY TOOL CONTROL SYSTEM CONFIG. 1, 2, 3, 3' AND 11)

1 2

AA-C1 2304011 84RE01 365-AA1 YL-18 325-AA2 PK-18

COLOR BLACK BROWN BLUE GREEN GRAY ORANGE PINK PURPLE RED WHITE YELLOW

SXL MM2 63.4 50.1 18.93 12.10 7.50 4.73 2.96 1.88 1.18 0.78

B

AV MM2 60 50 20 15 8 5 3 2 1.25 0.85

NOTE Y: USE WITH PRODUCT LINK PL321SR SYSTEM.

A

NOTE Z: USE WITH PRODUCT LINK PL121SR SYSTEM.

ATCH-REFUELING START SW NO 6T9442

L45

AWG 00 0 4 6 8 10 12 14 16 18

NOTE R: FIELD INSTALLATION 12V RADIO READY FOR REAR LOCATION.

SWITCH AS. 2381596

ATCH-REFUELING STOP SW NC 9X4184

6

F

ELECTRICAL CONNECTION TO MACHINE STRUCTURE INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT CONNECTOR GOLD TERMINAL

-

SCHEMATIC FOR MODEL : 330D

NOTE AA: THE SCHEMATIC SHOWS THE BASIC SYSTEM LAYOUT FOR A COMPLETE PL321SR SYSTEM IMPLEMENTATION (RADIO & GATEWAY ECM). IN A RADIO ONLY OPTION (PL121SR) THE RADIO HARNESS CONN (GK-C1) CONNECTS DIRECTLY TO THE MACHINE HARNESS CONN (C-C18) AND THE RADIO HARNESS CONN (GK-C2) CONNECTS TO THE SERIAL SERVICE CONNECTOR HARNESS CONN (GL-C1).

PART No.

NOTE AB: FIELD INSTALLATION 12V POWER SUPPLY READY FOR REAR LOCATION.

SHEET

CHG-LEVEL

251-0617 04 1 OF 2

NOTE AC: USE WITH UNIVERSAL QUICK COUPLER. NOTE AD: USE WITH TOOL CONTROL SYSTEM SYSTEM 5.

13

G

CIRCUIT NOT CONNECTED +

NOTE H: USE WITH TOOL CONTROL SYSTEM CONFIG. 11.

C-C42 C-C43 2434505 84RE01 2304011 84RE01 1 325-C174 PK-18 CONN 19 2

GND-FR 4

1 2 MOTOR

C-C35 3E3370 YL-18 A GN-18 B C

252-C131 262-C130

ATCH-REFUELING POWER RELAY 2130772

168-X1 325-X3 365-X6 365-X7 365-X8 L976-X9 L976-X10 L976-X11 200-X2 200-X2 200-X4 200-X5

1 2 3 4 5 6

MATE GR-C1 SH3 E-12

NOTE D: USE WITH SHORT BOOM.

BU-16 BK-16

CHASSIS LAMP 1532523

607-C7 PK-16 200-C195 BK-16

CONN 20

322-E2 322-E1 200-E3 200-E4

BREAKER BOX

C-C27 1532620 84RE01 (J1)(54 BLACK)

ATCH-REFUELING PUMP 2291859

CONN 18

322-C6 GY-16 616-C9 BU-16 L973-C80 GN-16 200-C169 BK-16 200-C193 BK-16 200-C194 BK-16

CONN 27

SPLICE X-C3 1160126 84RE01 1 323-X12 WH-10 2 200-X5 BK-10

BU-16 BK-16

ATCH-SINGLE ACTION SOL 2 2154890 (NOTE G,H)

1 2 3 4

(NOTE W)

616-N2 BU-16 200-N5 BK-16

322-E2 200-E4

IDENT 1 2 3 4 5 6 7 8 9 10 11 12

C-C25 7T5957 84RE01

NOTE E

616-P2 BU-16 200-P5 BK-16

N-C1 2434505 84RE01 616-N1 BU-16 1 200-N4 BK-16 2

CONN 26

H

C-C24 7T5957 84RE01 200-C165 BK-18 506-C45 PU-18

L19

ATCH-FINE SWING SOL 1163526

(NOTE C)

L76

L37

WH-18 YL-18 OR-18 PK-18 YL-18 BR-18 BR-18 PU-18 WH-18 YL-18 BU-18 GN-18 GY-18 PK-18 PU-18 WH-18 BR-18 BU-18 WH-18 BR-18 BU-18 GN-18 WH-18 PK-18 BU-18 YL-18 BK-14 BK-18 BK-18 BK-18 YL-18 YL-18 YL-18 YL-18

+B GROUND SIGNAL

ATCH-BOOM CHECK SOL 2 2154890

P-C1 2434505 84RE01 616-P1 BU-16 1 200-P4 BK-16 2

CONN 17

ATCH-SINGLE ACTION SOL 1 2154890 (NOTE G,H)

L76

C-C50 1552269 495-C22 GN-18 235-C173 BK-18

L17

ATCH-OLWD PRESS. SENSOR 2218859

(NOTE D)

GC-C4 1552269 1 K872-GC12 OR-18 2 200-GC19 BK-18

K872-GC11 OR-18 200-GC14 BK-18

F889-C129 G723-C92 G973-C201 H446-C119 H746-C76 H747-C85 K850-C120 K856-C95 K857-C97 K858-C99 K860-C93 K861-C96 K862-C98 K864-C82 K865-C89 K866-C79 K868-C83 K869-C84 K871-C78 K876-C90 K877-C91 K904-C117 M737-C77 M740-C74 M906-C111 T967-C118 235-C166 A209-C122 A209-C124 A209-C125 M739-C94 M739-C94 M739-C134 M739-C135

J

DEFINED GROUND POINTS AT THE MASCHINE

251-C133 261-C132

ATCH-1WAY 2WAY CHANGE SOL 0000000 (NOTE L,M)

120A HEATER BREAKER 2164970

PC STRAP DISC-FRAME GND 1321806

PU-18 BU-16 BK-18 BK-18 BK-18 BK-18

K859-C205 BR-18 K863-C204 OR-18 184-C5 RD-14 184-C5 RD-14 184-C105 RD-14 184-C109 RD-14 308-C113 YL-16 763-C75 BU-18 788-C81 YL-18 892-C121 BR-18 893-C116 GN-18 A588-C88 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A760-C108 GY-18 A762-C87 PU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E997-C123 RD-18 F889-C129 WH-18 F889-C129 WH-18 F889-C115 WH-18 F889-C100 WH-18 F889-C68 WH-18 F889-C68 WH-18 G723-C92 YL-18 G973-C201 OR-18 H446-C119 PK-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 H746-C76 YL-18 H747-C85 BR-18 H704-C202 PK-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K850-C120 BR-18 K851-C37 BU-18 K852-C38 GN-18 K856-C95 PU-18 K857-C97 WH-18 K858-C99 YL-18 K860-C93 BU-18 K861-C96 GN-18 K862-C98 GY-18 K864-C82 PK-18 K865-C89 PU-18 K866-C79 WH-18 K868-C83 BR-18 K869-C84 BU-18 K871-C78 WH-18 K876-C90 BR-18 K877-C91 BU-18 K904-C117 GN-18 K907-C63 BU-18 L968-C67 OR-18 L969-C66 WH-18 L972-C33 BU-18 N793-C86 GN-18 M737-C77 WH-18 M739-C94 YL-18 M740-C74 PK-18 M906-C111 BU-18 N789-C107 BU-18 N794-C58 GY-18 N795-C59 WH-18 T967-C118 YL-18 A209-C112 BK-18 A209-C112 BK-18 A209-C122 BK-18 A209-C124 BK-18 A209-C125 BK-18 235-C166 BK-14 235-C166 BK-14 235-C106 BK-14 235-C110 BK-14 251-C49 YL-18 251-C49 YL-18 251-C103 YL-18 251-C133 YL-18 251-C133 YL-18 261-C50 GN-18 261-C50 GN-18 261-C104 GN-18 261-C132 GN-18 261-C132 GN-18 252-C60 YL-18 252-C60 YL-18 252-C101 YL-18 252-C131 YL-18 252-C131 YL-18 262-C61 GN-18 262-C61 GN-18 262-C102 GN-18 262-C130 GN-18 252-C131 YL-18 261-C132 GN-18 251-C133 YL-18

NOTE E

K-C5 1552269 1 M749-K10 PK-18 2 200-K11 BK-18

M745-K5 200-K12

108-CM1 RD-4

DISCONNECT SW 7N0719

NOTE E

1 2

GC-C5 1552269

L75

BR-18 GY-18

L57

GROUND SIGNAL

L59

200-CE1 BK-00

ATCH-BOOM DOWN LINE CUTOFF SOL 1850472 K-C2 1552269 1 M748-K8 BR-18 2 200-K9 BK-18

616-N3 200-N6

C-C52 C-C51 2304011 84RE01 2434505 84RE01 1 325-C174 PK-18 2 WJ-C1 2304011 84RE01

BK-18

K872-GC11 K872-GC12 200-GC14 200-GC19 200-GC13 200-GC15 200-GC2 200-GC2 200-GC15 200-GC13

L10

780-GU1 200-GU5

616-P3 200-P6

L54

K859-C205 BR-18 K863-C204 OR-18 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 892-C121 BR-18 893-C116 GN-18 A588-C88 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A760-C108 GY-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E997-C123 RD-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 H704-C202 PK-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K907-C63 BU-18 L968-C67 OR-18 L969-C66 WH-18 L972-C33 BU-18 N789-C107 BU-18 N793-C86 GN-18 N794-C58 GY-18 N795-C59 WH-18 147-C73 PU-16 147-C73 PU-16 308-C113 YL-16 763-C75 BU-18 788-C81 YL-18 A762-C87 PU-18

L20

GU-C2 1552269 1 PU-16 2 BK-18

K-C8 1552267 A 308-K14 YL-18 B A209-K15 BK-18 C H446-K16 PK-18

GF-C8 GF-C13 1552269 3E3364 1 PU-18 2 YL-18

K865-GF11 M739-GF21

L156

L35

FUEL LEVEL SENSOR 1636700

C-C56 1552269 1 235-C178 BK-18 2 487-C19 OR-18

K879-GC5 GN-18 200-GC15 BK-18

GE-C2 1552269 1 K856-GE1 PU-18 2 K868-GE4 BR-18 K868-GE3 BR-18 K868-GE3 BR-18

1 2

BK-18 PK-18

RD-4

506-C45 578-C46 200-C165 200-C164 200-C163 200-C163

L6

L75

ATCH-RELIEF 1 CHECK SOL 0000000 (NOTE L,M)

L62

L62

L65

K858-GG5 YL-18 K869-GG18 BU-18 K869-GG27 BU-18 K869-GG27 BU-18

1 2

ATCH-DOUBLE ACTION SOL 1211491 (NOTE G,H)

ENGINE

L62

L38 C-C53 C-C54 1552269 3E3364 1 321-C40 BR-18 2 235-C177 BK-18

GN-18 WH-16 PU-16 BK-18 BK-18 BK-18 BK-18

L10

MATE HYD LOCK SOL (NOTE AC)

L75

1 2

K876-GF7 235-GF20

L63

L57

235-C178

15

GF-C21 3E3364

ATCH-STEM 1 EXTEND SOL 0000000 (NOTE J,L,M,AD)

K862-GG6 GY-18 K869-GG17 BU-18

1 2

ATCH-1P 2P CHANGE SOL 1 1211491 (NOTE G,H)

A-C11 ATMOSPHERIC PRESSURE SENSOR 1978393 1552267 A ANALOG +5V B GROUND C SIGNAL

16

1 2

GF-C3 1552269

K861-GF4 GN-18 K868-GF13 BR-18

L38

ATCH-STEM1 RETRACT SOL 0000000 (NOTE K)

17

ATCH-STEM 2 EXTEND SOL 0000000 (NOTE J,L,M)

GF-C15 3E3364

1 2

C-C59 1552269 1 M737-C77 WH-18 2 M739-C135 YL-18

ATCH-1P 2P CHANGE SOL 2 1211491 (NOTE G,H)

C-C57 CONN 5 3E3388 A751-C144 YL-18 G833-C145 PK-18 T725-C146 WH-18 N707-C147 PU-18 G828-C148 WH-18 G829-C149 GN-18 C991-C150 PK-18

L34

1 2

GF-C4 1552269

GN-18

A588-GU3 779-GU2 780-GU1 200-GU10 200-GU10 200-GU5 200-GU6

GU-C5 1552269 1 A588-GU8 GN-18 2 200-GU9 BK-18

ATCH-BOOM UP DOWN PRESS SW 2029002 K-C4 1552269 1 H792-K1 BR-18 2 M749-K10 PK-18

GF-C11 GF-C19 1552269 3E3364 1 BR-18 2 BK-18

GF-C9 GF-C18 1552269 3E3364 1 K866-GF9 WH-18 2 235-GF18 BK-18

L59

L59

ATCH-STEM 2 RETRACT SOL 0000000 (NOTE L,M)

C-C63 1552267 308-C187 YL-18 A209-C189 BK-18 T967-C118 YL-18

C-C61 1552269 A768-C64 1 2 A769-C65

POWER SHIFT PRESS. SOL 0000000

A-C12 INTAKE MANIFOLD PRESSURE SENSOR 2101747 1552267 A ANALOG +5V B GROUND C SIGNAL

A-C16 1552264

A B C

+B GROUND SIGNAL

L62

C967-A15 BU-18 G833-A45 PK-18

A-C7 1552269 1 2

PUMP 2 PRESS. SENSOR 2218859

L158

A588-GU3

L74

ATCH-RELIEF 1 SOL 0000000 (NOTE L,M)

L64

L57

308-C127

E963-A27 BK-18 E964-A26 WH-18

L52

L52

GF-C16 3E3364

GU-C4 3E3364 A588-GU7 GN-18 200-GU9 BK-18

ATCH-BOOM DOWN PRESS SW 1673466 K-C3 1552269 1 M748-K7 2 M745-K6

1 2

YL-18 BR-18

C-C62 1552267 A 308-C186 YL-18 B A209-C188 BK-18 C K904-C117 GN-18

+B GROUND SIGNAL

YL-18 BK-18 PK-18 BK-18 GY-18 GY-18 GY-18 GY-18 GY-18 BK-18 PK-18 PK-18 BK-18 BR-18 BR-18 BR-18 BR-18 GY-18 BR-18

GF-C5 GF-C17 1552267 3E3370 A 308-GF24 YL-18 B A209-GF19 BK-18 C M906-GF12 BU-18

200-GC2 BK-18 200-GC15 BK-18 200-GC13 BK-18

BK-14

229-C185 BK-14 F889-C129 WH-18

(RUN) TOP SPD/TMG SNSR A 1097194 SIG SIG +

+ INLET AIR HEATER -

1 2 3 4 5 6 7 8 9 10 11 12

L29

C-C30 2304009 84RE01 147-C73 PU-16 K871-C78 WH-18 K866-C79 WH-18 K864-C82 PK-18 M739-C134 YL-18 K876-C90 BR-18 K865-C89 PU-18 K877-C91 BU-18 G973-C201 OR-18

GF-C12 GF-C20 1552269 3E3364 1 K864-GF10 PK-18 2 M739-GF22 YL-18

L64

PK-18 RD-10 GY-16 PK-16 BU-16 GN-16

229-C184

A-C4 1003320 A B

C-C17 1552269 H746-C76 H747-C85

L52

L59

PUMP 1 PRESS. SENSOR 2218859

308-K14 A209-K15 H446-K16 200-K4 M745-K2 M745-K2 M745-K5 M745-K6 M745-K6 200-K9 M749-K10 M749-K10 200-K9 M748-K3 M748-K3 M748-K7 M748-K8 M745-K6 H792-K1

L72

L79

325-C174 168-C51 322-C6 607-C7 616-C9 L973-C80

BK-14

E965-A48 BU-18 E966-A49 YL-18

A-C5 (CRANK) BOTTOM SPD/TMG SNSR B 1097195 1112416 SIG A B SIG +

1 2

RADIATOR FAN SPEED CONT SOL 0000000

1 2 3 4 CONN 13 5 6 MATE C-C30 7 8 9 10 11 12

1 2

MATE C-C49 (NOTE AC)

L56

L37

229-C183

C987-A99 RD-18 G850-A98 BU-18

A-C2 1552269 1 2

ATCH-QUICK COUPLER SOL 2603876

L65

235-C173 BK-18 495-C22 GN-18 325-C174 PK-18

RD-14 RD-14

G856-A22 WH-18 G857-A30 YL-18

A-C10 A-C14 1552269 3E3364 1 + TIMING PROBE 2 - CONNECTOR

L65

AL-C2 2304011 84RE01 780-AL1 PU-16 1 200-AL2 BK-18 2

C-C31 2434510 84RE01

ATCH-BOOM RAISE PRESS SW 1673466 (NOTE G,H)

L45

A751-A13 YL-18 T725-A32 WH-18 N707-A31 PU-18

1 2 3 4 5 6 7 8

1 2 CONN 12 3 4 MATE C-C32 5 6 7 8

GC-C6 1552269 1 OR-18 2 BK-18

329-X18 YL-18 365-X6 YL-18 L976-X9 GN-18 200-X4 BK-18

F-C7 1539693

A751-C144 YL-18 G833-C145 PK-18 T725-C146 WH-18 N707-C147 PU-18 G828-C148 WH-18 G829-C149 GN-18 C991-C150 PK-18

G973-GC7 235-GC10

L44

CYL HEAD SOL 5

C-C32 2312295 84RE01 K856-C95 PU-18 K860-C93 BU-18 K857-C97 WH-18 K861-C96 GN-18 K868-C83 BR-18 308-C126 YL-18 A209-C124 BK-18 M906-C111 BU-18

L56 L73

L27

C-C33 2434509 84RE01

L74

F-C6 1539693

L34

ATCH-HEAVY LIFT SOL 1216303

L48

CYL HEAD SOL 4

BU-18 GY-18 BK-18 BK-18 BK-18 BK-18 YL-18 YL-18 YL-18 YL-18 YL-18 BR-18 GN-18 WH-18 YL-18 YL-18

1 2

L156

L60

235-GF23 BK-18 A768-C64 A769-C65 A209-C122 A209-C122 A209-C188 A209-C189 308-C128 308-C128 308-C186 308-C187 H746-C76 H747-C85 K904-C117 M737-C77 M739-C135 T967-C118

C-C44 C-C45 1552269 3E3364 1 YL-18 2 BK-18

CONN 58

BK-10

F-C5 1539693

L33

C-C67 2305010 84RE01 K858-C99 YL-18 K862-C98 GY-18 K869-C84 BU-18 K850-C120 BR-18

1 2 3 4 5 6

200-C196

G849-A96 BR-18 G850-A98 BU-18 G854-A100 PK-18 G855-A91 PU-18 R747-A6 GY-18

CYL HEAD SOL 3

WH-18 PK-18 YL-18 BR-18 PU-18 BU-18

L76

BR-18 BR-18 BU-18 BU-18 WH-18 WH-18 WH-18 GN-18 GN-18 GN-18 PK-18 PK-18 PK-18

101-C139

C-C26 1532630 84RE02 (J2)(54 BROWN)

HYD LOCK SOL 1211491

L61

G833-A47 PK-18

G826-A35 G826-A38 G827-A36 G827-A43 G828-A40 G828-A95 G828-A39 G829-A94 G829-A42 G829-A41 G833-A45 G833-A46 G833-A44

130-C1 RD-14 308-C127 YL-16 317-C15 YL-18 405-C16 GY-18 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C129 WH-18 229-C182 BK-14 229-C182 BK-14 229-C183 BK-14 229-C184 BK-14 229-C185 BK-14

K866-GF9 K864-GF10 M739-GF6 K876-GF7 K865-GF11 K877-GF8

PU-18 WH-18 BU-18 YL-18 BK-18 BK-18 BK-18 BK-18 BK-18 YL-18 YL-18 YL-18 YL-18 YL-18 PK-18 BR-18 BU-18 BK-18

NOTE E

F-C4 1539693

GF-C6 2434510 84RE01

K865-GF11 K866-GF9 K877-GF8 M739-GF21 235-GF18 235-GF17 235-GF20 235-GF23 235-GF23 M739-GF22 M739-GF22 M739-GF21 M739-GF6 308-GF24 K864-GF10 K876-GF7 M906-GF12 A209-GF19

G826-A1 BR-18 G827-A2 BU-18

CYL HEAD SOL 2

147-GC3 PU-16 K866-GC1 WH-18 K871-GC6 WH-18 G973-GC7 OR-18 G973-GC7 OR-18 235-GC10 BK-18

L53

BR-18 BR-18 BR-18 BR-18 BR-18 BR-18 BR-18 BR-18 PU-18 WH-18 BU-18 GN-18

PK-18 BU-18 BU-18 BK-18 WH-18 WH-18 YL-18 RD-18

A B

R746-A20 C967-A15 E965-A48 E963-A27 E964-A26 G856-A22 G857-A30 C987-A99

130-C179 RD-14 130-C180 RD-14 130-C181 RD-14 130-C1 RD-14

235-GF23 BK-18

F-C3 1539693

GG-C1 C-C68 2434508 84RE01 2434508 84RE01 1 K858-GG5 YL-18 2 CONN 14 K862-GG6 GY-18 K869-GG27 BU-18 3 MATE C-C67 4 5 6

GC-C8 2434510 84RE01 1 147-GC3 PU-16 2 K871-GC6 WH-18 3 K866-GC1 WH-18 4 5 CONN 13 6 MATE C-C30 7 8 9 G973-GC7 OR-18 10 11 12

L72

L54

L53

C991-A33 PK-18 994-A10 GY-18 995-A12 BU-18

RD-4

L155

WASHER TANK 1761931 1761932 (NOTE S)

L156

C-C29 C-C28 K-C7 2434506 84RE01 2304013 84RE01 2434506 84RE01 1 1 308-K14 YL-18 308-C114 YL-18 2 2 MATE C-C28 A209-C125 BK-18 A209-K15 BK-18 3 3 CONN 15 H446-C119 PK-18 H446-K16 PK-18

L60

BK-18 BK-18 BK-18 BK-18 GN-18 BK-18 WH-18 WH-18 WH-18 BK-18 PU-16 WH-18 BK-18 BK-18 OR-18 OR-18 OR-18 OR-18 235-GC10 235-GC18 235-GC17 235-GC16 K879-GC5 200-GC15 K871-GC9 K871-GC8 K871-GC6 235-GC10 147-GC3 K866-GC1 200-GC15 200-GC2 K872-GC4 K872-GC4 K872-GC12 K872-GC11 L51

L28

L63

CYL HEAD SOL 1

L28

L78

L55

F-C2 1539693

L26

L59

L59

BR-18 BR-18 PU-18 PU-18 BK-18 YL-18 PK-18 GN-18 WH-18 WH-18 BU-18 BU-18 YL-18 BU-18

L32

AK-C2 2304011 84RE01 X738-AK1 PK-18 1 235-AK2 BK-18 2

BK-18

T858-A23 GY-18-XLPE

130-C1 RD-14 308-C127 YL-16 317-C15 YL-18 405-C16 GY-18 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 A751-C144 YL-18 C991-C150 PK-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C129 WH-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 N707-C147 PU-18 T725-C146 WH-18 229-C182 BK-14

L156

GF-C10 2434509 84RE01 K856-GF1 PU-18 K860-GF2 BU-18 K857-GF3 WH-18 K861-GF4 GN-18 K868-GF5 BR-18 308-GF24 YL-18 A209-GF19 BK-18 M906-GF12 BU-18

K876-GF7 K868-GF5 K865-GF11 K856-GF1 A209-GF19 308-GF24 K864-GF10 K861-GF4 K857-GF3 K866-GF9 K860-GF2 K877-GF8 M739-GF6 M906-GF12

T859-A37 WH-18-XLPE

T860-A90 OR-18-XLPE T860-A89 OR-18-XLPE T859-A88 WH-18-XLPE T859-A87 WH-18-XLPE T858-A86 GY-18-XLPE T858-A85 GY-18-XLPE

T957-A16 T958-A17 T959-A18 T960-A19 T961-A28 T962-A29 T860-A90 T860-A89 T859-A88 T859-A87 T858-A86 T858-A85

ATCH-HAMMER RETURN FILTER SW 2344515

304-WC1 WH-8

109-C138

SWING BRAKE SOL 1211491

C-C49 1552269 1 A588-C167 GN-18 2 200-C171 BK-18

G723-C92 235-C199

GE-C1 2434509 84RE01 K856-GE1 PU-18 1 2 CONN 12 3 K857-GE2 WH-18 4 MATE C-C32 K868-GE3 BR-18 5 6 7 8

235-GF23

T860-A34 OR-18-XLPE

PU-18-XLPE YL-18-XLPE BR-18-XLPE BU-18-XLPE GN-18-XLPE WH-18-XLPE

RD-4 RD-4 WH-8 YL-18 PU-18 BU-18 BK-18

L65

L65

L79

T957-A16 T958-A17 T959-A18 T960-A19 T961-A28 T962-A29

A-C9 F-C1 CONN 6 3E5179 1552252 1 A701-F1 GY-16-NW PU-18-XLPE 2 A702-F3 PU-16-NW YL-18-XLPE 3 A703-F5 BR-16-NW BR-18-XLPE 4 A704-F7 GN-16-NW BU-18-XLPE 5 A705-F9 BU-16-NW GN-18-XLPE 6 A706-F11 GY-16-NW WH-18-XLPE 7 OR-18-XLPE L985-F12 YL-16-NW 8 L985-F10 YL-16-NW OR-18-XLPE 9 WH-18-XLPE L984-F8 OR-16-NW 10 WH-18-XLPE L984-F6 OR-16-NW 11 GY-18-XLPE L983-F4 WH-16-NW 12 GY-18-XLPE L983-F2 WH-16-NW

101-C139 108-C136 304-C137 788-C81 A762-C87 C468-C28 235-C192

235-GF23 BK-18

L31

108-CM1 RD-4

TRAVEL SPEED SOL 1211491

C-C48 1552269 1 GN-18 2 BK-18

K906-C62 235-C197

L56

L151

L79

L30

177-WE1 RD-6

80A MAIN BREAKER 1712210

TRAVEL STRAIGHT SOL 1211491

C-C47 1552269 1 763-C75 BU-18 2 235-C198 BK-18

L29

L50

L151

BU-18 GN-18 YL-18 GN-18 PK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

CONN 25

BUS-BAR 2382279

GND-FR 5 1

PILOT MANIFOLD 2155037

L29 L25

L52

L151

START RELAY 1251302

200-C164 BK-18 578-C46 BU-16

323-X12 WH-10 168-X1 RD-10 168-X13 RD-18 168-X15 RD-18 329-X18 YL-18

L28

L29

L151

763-C75 A588-C167 G723-C92 K906-C62 M740-C74 200-C171 235-C170 235-C170 235-C197 235-C198 235-C203 235-C203 235-C199 235-C200

C-C46 1552269 1 PK-18 BK-18 2

L49

PU-16 YL-18 YL-18 OR-18 PK-18 BR-18 PU-18 WH-18 YL-18 BU-18 GN-18 GY-18 PK-18 PU-18 WH-18 BR-18 BU-18 WH-18 BR-18 BU-18 YL-18 BU-18 BK-18 BK-18 147-C73 308-C126 308-C114 G973-C201 H446-C119 K850-C120 K856-C95 K857-C97 K858-C99 K860-C93 K861-C96 K862-C98 K864-C82 K865-C89 K866-C79 K868-C83 K869-C84 K871-C78 K876-C90 K877-C91 M739-C134 M906-C111 A209-C124 A209-C125

200-GU4 BK-18 200-GU10 BK-18

RD-10 BR-18 GY-16 OR-18 PK-18 GN-18 WH-18 PK-16 BU-16 GN-16 BK-18 168-C51 321-C40 322-C6 487-C19 491-C20 495-C22 496-C23 607-C7 616-C9 L973-C80 235-C172

L27

L26

L25

L151

L79

L151

200-GU10 BK-18 779-GU2 WH-16 780-GU1 PU-16 A588-GU3 GN-18

L25 YL-18 BU-18 GY-18 YL-18 BR-18 GN-18 WH-18 YL-18 YL-18 BK-18 308-C128 A768-C64 A769-C65 H746-C76 H747-C85 K904-C117 M737-C77 M739-C135 T967-C118 A209-C122

200-C171 BK-18 763-C75 BU-18 A588-C167 GN-18 K906-C62 GN-18 M740-C74 PK-18 235-C170 BK-18 G723-C92 YL-18 101-C139 RD-4 108-C136 RD-4 130-C1 RD-14 304-C137 WH-8 308-C127 YL-16 317-C15 YL-18 405-C16 GY-18 788-C81 YL-18 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 A751-C144 YL-18 A762-C87 PU-18 C468-C28 BU-18 C991-C150 PK-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C129 WH-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 N707-C147 PU-18 T725-C146 WH-18 235-C192 BK-18 229-C182 BK-14

BK-4 BK-18 BK-16 BK-18 BK-18 BK-18 200-C190 200-C191 200-C161 200-C162 200-C163 200-C171

L71 BK-18

BK-18 BK-16

200-AL2

200-GP3 200-GP5

200-GU4 BK-18 200-GU10 BK-18

780-AL1 PU-16 200-AL2 BK-18

ENGINE

L151

L73

RD-14

WH-18

L25

L71

L25

BK-18 BK-18 GN-16 GN-16 GN-16 BK-16 RD-6

200-CE1 BK-00 200-CH1 BK-00

L6 L25

GND-FR 2

ATCH-BATTERY FRONT 3T5760 (NOTE A)

80A ALT BREAKER 1712210

WH-8

200-CE1 BK-00 200-CH1 BK-00

L20

200-C190 BK-4

L151

GY-18

F716-C21

L155

L72

L50 BK-18 BK-18 235-GC18 235-GC10

BK-18 BK-16

235-C166 BK-14 235-C170 BK-18 235-C172 BK-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18 235-C192 BK-18 229-C182 BK-14

235-C154 235-C160

X738-AK1 PK-18 235-AK2 BK-18

200-C191 BK-18

ENG OIL LEVEL SW 2130677

ATCH-BATTERY REAR 3T5760 (NOTE A)

MATE A-C41 SH2 C-12

1 2 3 4

109-CL1 RD-4

BLOCK AS 1211023

200-X5 BK-10 323-X12 WH-10

C468-C28 BU-18 235-C192 BK-18

M740-C74 235-C200

ATCH-REVERSING FAN CHANGE SOL 1211491

L28

130-C180 130-C181

H704-AR1 PK-18 235-AR2 BK-18

235-AR2 BK-18

E966-A49 YL-18

130-C179

AR-C2 1552269 1 H704-AR1 PK-18 2 235-AR2 BK-18

L23

C-C65 1552269

POS NEG

CONN 24

MATE A-C29 SH2 D-12

1 2 3 4 5 6 7 8 9 10 11 12

K-C1 2434507 84RE01 H792-K1 BR-18 M745-K2 GY-18 M748-K3 BR-18 200-K4 BK-18

L72

1 2

GND-FR 1

ENG SPEED PICKUP 4P5820 1 2

POS NEG

START RELAY DIODE 1974385 RE01

304-C137

L76

L31

BK-16 BK-16 BK-16 BK-16

788-C81 YL-18 A762-C87 PU-18

A-C21 1552269

1 2

177-A71 RD-6 108-C136 RD-4 L5

200-CH1 BK-00

101-CG1 RD-00

101-CF1 RD-00

200-C169 200-C193 200-C194 200-C195

C-C66 1552269

200-K4 BK-18 200-K13 BK-18

1 2

L24

101-CF1 RD-00 101-CP1 RD-00 101-CA1 RD-00

L78

PE STRAP ENG-FRAME GND 1400860

235-C192 BK-18 235-C172 BK-18 235-C170 BK-18 229-C182 BK-14 235-C43 BK-18 235-C160 BK-16 235-C166 BK-14 235-C41 BK-18 235-C154 BK-18 235-C42 BK-18

MOTOR

L22

MTRBAT

200-A30 200-A18 306-A2 306-A3 306-A20 200-A85 177-A71

A-C9 1552269

GND-FR 6

L22

L21 WH-8

101-C139 RD-4 101-CA1 RD-00 101-CP1 RD-00 101-CF1 RD-00

101-C139 RD-4 108-C136 RD-4 130-C1 RD-14 147-C73 PU-16 168-C51 RD-10 304-C137 WH-8 308-C127 YL-16 308-C128 YL-18 308-C128 YL-18 308-C127 YL-16 308-C168 YL-16 308-C126 YL-18 308-C114 YL-18 308-C114 YL-18 308-C126 YL-18 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 405-C16 GY-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 763-C75 BU-18 788-C81 YL-18 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 A588-C167 GN-18 A751-C144 YL-18 A762-C87 PU-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 C991-C150 PK-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C129 WH-18 G723-C92 YL-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 G973-C201 OR-18 H746-C76 YL-18 H446-C119 PK-18 H747-C85 BR-18 K850-C120 BR-18 K856-C95 PU-18 K857-C97 WH-18 K858-C99 YL-18 K860-C93 BU-18 K861-C96 GN-18 K862-C98 GY-18 K864-C82 PK-18 K865-C89 PU-18 K866-C79 WH-18 K868-C83 BR-18 K869-C84 BU-18 K871-C78 WH-18 K876-C90 BR-18 K877-C91 BU-18 K904-C117 GN-18 K906-C62 GN-18 L973-C80 GN-16 M737-C77 WH-18 M739-C134 YL-18 M739-C135 YL-18 M740-C74 PK-18 M906-C111 BU-18 N707-C147 PU-18 T725-C146 WH-18 T967-C118 YL-18 200-C161 BK-16 200-C162 BK-18 200-C163 BK-18 A209-C122 BK-18 A209-C124 BK-18 A209-C125 BK-18 229-C182 BK-14 235-C170 BK-18 235-C172 BK-18 235-C192 BK-18

304-C137

S

109-C138 RD-4 403-C151 GN-18 E554-C11 PK-18

G

L97

ATCH-JUMP START RECEPTACLE 2G1830 P N (NOTE B)

L51

L22

235-GF23 BK-18 235-GF23 BK-18 235-AR2 BK-18

BK-4

BK-18

200-C190

L52

405-C16

RD-4

BATTERY FRONT 3T5760

BLOCK GP 9W0742 (NOTE B)

K868-GF13 K868-GF14 K868-GF25 K868-GF25 K868-GF15 K868-GF16 K868-GF5 K868-GF5 K856-GF1 K857-GF3 K860-GF2 K861-GF4

OR-18 WH-18

109-C138

L24

POS NEG

101-CP1 RD-00

L59

F773-C69 F774-C70

GN-18

STARTER MOTOR 2071556 2371962 (NOTE A)

G829-A93 GN-18 YL-18

B+ B-

403-C151

306-A2 GN-16 200-A30 BK-18

101-CR1 RD-00

235-AR2

(65A)

R

780-AL1 PU-16

101-CA1 RD-00 101-CP1 RD-00 101-CF1 RD-00

AIR HEATER RELAY 2234453

ALTERNATOR 1855294

BREAKER BOX

306-A3 GN-16 200-A18 BK-18

200-CE1 BK-00

NEG

BATTERY REAR 3T5760

308-C113 147-C73 763-C75 788-C81 A762-C87 F889-C129 G723-C92 G973-C201 H446-C119 H746-C76 H747-C85 K850-C120 K856-C95 K857-C97 K858-C99 K860-C93 K861-C96 K862-C98 K864-C82 K865-C89 K866-C79 K868-C83 K869-C84 K871-C78 K876-C90 K877-C91 K904-C117 M737-C77 M739-C134 M739-C135 M740-C74 M906-C111 T967-C118 235-C166 A209-C122 A209-C124 A209-C125

1 1

108-C136 RD-4

G828-A92 WH-18

317-C15

101-C139 RD-4 108-C136 RD-4 109-C138 RD-4 130-C1 RD-14 168-C51 RD-10 304-C137 WH-8 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 403-C151 GN-18 405-C16 GY-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 A588-C167 GN-18 A751-C144 YL-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 C991-C150 PK-18 E554-C11 PK-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 K906-C62 GN-18 L973-C80 GN-16 N707-C147 PU-18 T725-C146 WH-18 200-C161 BK-16 200-C162 BK-18 200-C163 BK-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18 235-C154 BK-18 235-C160 BK-16 308-C168 YL-16 308-C168 YL-16 308-C4 YL-16 308-C140 YL-16

A C COMPRESSOR CLUTCH SOL 2597243

AIR HEATER 1593537

POS

K

MATE A-C1 SH2 C-12

GC-C7 2305010 84RE01 K866-GC1 WH-18 200-GC2 BK-18 147-GC3 PU-16 K872-GC4 OR-18 K879-GC5 GN-18

101-CJ1 RD-4

101-CP1 RD-00

101-CF1 RD-00

L65

GN-18 BR-18

L97 101-CP1 RD-00

101-CF1 RD-00

101-CC1 RD-00

CONN 23

MATE A-C16 SH2 E-12

L72 L155

L157

101-CP1 RD-00

101-CF1 RD-00

L54

893-C153 892-C152

H704-AR1 PK-18

X738-AK1 PK-18

101-CP1 RD-00

C-C64 2304011 84RE01 1 E554-C11 PK-18 2 200-C191 BK-18

L50

BREAK POINT 1 SH2 B-12

101-CA1 RD-00

L

1 2 3 4 5 6 7 8 9 10 11 12

GP-C1 2434507 84RE01 326-GP1 RD-16 A893-GP2 OR-16 T788-GP4 GN-16 200-GP3 BK-18

L69

L50

101-CA1 RD-00

L34

BR-18

L72 L155

101-CA1 RD-00

A B

998-C71

L72 L155

101-CA1 RD-00

ENGINE

GND-FR 3

L155

YL-16 RD-14 GY-16 PK-16 PU-16 BU-16 PU-16 PK-18 PU-16 WH-16 GN-18

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54

317-C15 YL-18 405-C16 GY-18 412-C17 BU-18 430-C18 BU-18 487-C19 OR-18 491-C20 PK-18 F716-C21 WH-18 495-C22 GN-18 496-C23 WH-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 C468-C28 BU-18 E472-C29 GN-18 H476-C30 WH-18 H473-C31 BR-18 G976-C32 BU-18 L972-C33 BU-18 H474-C34 GN-18 H475-C35 BU-18 K849-C36 YL-18 E997-C123 RD-18 K851-C37 BU-18 K852-C38 GN-18 X738-C39 PK-18 321-C40 BR-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18 310-C44 PU-16 506-C45 PU-18 578-C46 BU-16 893-C47 GN-18 892-C48 BR-18 251-C49 YL-18 261-C50 GN-18 NOTE E NOTE E C-C2 1343295 84RE01 168-C51 RD-10 1

L10

101-CA1 RD-00

B

18

X738-AK1 PK-18

L36

(+) BATTERY KEYSWITCH

X738-AK1 PK-18

BR-18 OR-18 PK-18 WH-18 BK-18 BK-18

(-) BATTERY PRIMARY THROTTLE POSITION

780-AL1 PU-16

321-C40 487-C19 491-C20 496-C23 235-C172 235-C173

(-) BATTERY

AK-C1 2434505 84RE01 X738-AK1 PK-18

780-AL1 PU-16

L35

(-) BATTERY

L6

L62

SLOW VESSEL MODE SWITCH

L5

L72

L38

(+) BATTERY UNSWITCHED (+) BATTERY UNSWITCHED

A C CONDENSER FAN MOTOR 2457910

1 2

GND-ECM MOUNT

L59

(+) BATTERY UNSWITCHED

L8

L156

GL-C2 8T8732 GL-C3 8T8731

L65

C

+B SIGNAL GND

A B C

L69

L9 LOW OIL PRESS. OUTPUT

AL-C1 2434505 84RE01 780-AL1 PU-16

L20

L71 THROTTLE BACKUP (ACCEL) THROTTLE BACKUP (DECEL)

172-C2 RD-18 310-C44 PU-16 403-C14 GN-18 412-C17 BU-18 430-C18 BU-18 514-C12 PU-16 780-C8 PU-16 892-C48 BR-18 893-C47 GN-18 C506-C13 WH-16 G976-C32 BU-18 X738-C39 PK-18 147-C10 PU-16 147-C10 PU-16 147-C72 PU-16 147-C73 PU-16 130-C1 RD-14 168-C51 RD-10 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 405-C16 GY-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 506-C45 PU-18 578-C46 BU-16 607-C7 PK-16 616-C9 BU-16 998-C71 BR-18 A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C123 RD-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K906-C62 GN-18 K907-C63 BU-18 L968-C207 OR-18 L969-C66 WH-18 L972-C33 BU-18 L973-C80 GN-16 N793-C86 GN-18 N794-C58 GY-18 N795-C59 WH-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18

AIR CLEANER INDICATOR 2552966

L12

A B

D

L968-C206

H704-AR1

A B

CAT DATA LINK (+) CAT DATA LINK (-)

1

235-GN23 BK-18

ENGINE CONTROL MODULE A-C1 2555282 2645732 J2 1 2 3 4 INTAKE AIR HEATER 5 C987-A99 RD-18 MAINTENANCE LAMP 6 7 8 9 IAP CONTROL VALVE RETURN 10 G855-A91 PU-18 11 12 COOLANT TEMPERATURE SENSOR 13 995-A12 BU-18 14 INTAKE MANIFOLD AIR PRESSURE SENSOR 15 R746-A20 PK-18 TRANSMISSION OIL PRESSURE SENSOR 16 ANALOG RETURN (BOOST,IAP) 17 G829-A93 GN-18 18 STARTER INTERLOCK 19 IAP CONTROL VALVE 20 G854-A100 PK-18 21 22 23 24 PASSIVE SPD -1: (RUN) TOP SPD/TMG SNSR A 25 E963-A27 BK-18 TDC SERVICE PROBE + 26 G856-A22 WH-18 TRANSMISSION OIL TEMPERATURE SENSOR 27 ENGINE OIL PRESSURE SENSOR 28 994-A10 GY-18 +8V DIGITAL POWER (COOLANT LVL,EXHAUST TEMP) 29 TEMPERATURE SENSOR COMMON 30 G833-A47 PK-18 31 SMART WASTEGATE ACTUATOR (-) (POTENTIAL) 32 33 34 PASSIVE SPD +1: (RUN) TOP SPD/TMG SNSR A 35 E964-A26 WH-18 TDC SERVICE PROBE - 36 G857-A30 YL-18 37 FUEL LEVEL SENSOR 38 EXHAUST TEMPERATURE SENSOR 39 FUEL PRESSURE SENSOR 40 C991-A33 PK-18 41 42 43 SMART WASTEGATE ACTUATOR (+) (POTENTIAL) 44 45 PASSIVE SPD +2: (CRANK) BOTTOM SPD/TMG SNSR B 46 E966-A49 YL-18 PASSIVE SPD -2: (CRANK) BOTTOM SPD/TMG SNSR B 47 E965-A48 BU-18 48 COOLANT LEVEL SENSOR 49 50 51 52 53 ANALOG RETURN (FUEL,LUBE) 54 G827-A2 BU-18 55 INTAKE MANIFOLD AIR TEMPERATURE SENSOR 56 C967-A15 BU-18 ATMOSPHERIC PRESSURE SENSOR 57 R747-A6 GY-18 58 59 60 61 FUEL TEMPERATURE SENSOR 62 A751-A13 YL-18 LOAD FEED BACK (+) (FUTURE) 63 64 FUEL PRESSURE SWITCH 65 T725-A32 WH-18 66 67 68 69 70 LOAD FEEDBACK (-) (FUTURE) 71 PRESSURE SENSOR +5V (BOOST,IAP) 72 G828-A92 WH-18 73 74 75 76 77 78 INTAKE AIR HEATER RETURN 79 G850-A98 BU-18 PRESSURE SENSOR +5V (FUEL,LUBE) 80 G826-A1 BR-18 +5V ANALOG POWER (TRANS TEMP, TRANS PRESS.) 81 82 FUEL PRESSURE SWITCH RETURN 83 N707-A31 PU-18 84 INJECTOR ACTION PRESS SENSOR 85 G849-A96 BR-18 86 87 88 89 90 91 DIGITAL RETURN (COOLANT LEVEL, EXHAUST TEMP) 92 ANALOG RETURN (TRANS TEMP & PRESS,FUEL LEVEL) 93 94 95 96 97 98 INJECTOR 5 & 6 HS 99 T860-A34 OR-18-XLPE 100 101 102 103 INJECTOR 1 & 2 HS 104 T858-A23 GY-18-XLPE INJECTOR 6 LS 105 T962-A29 WH-18-XLPE INJECTOR 3 LS 106 T959-A18 BR-18-XLPE INJECTOR 5 LS 107 T961-A28 GN-18-XLPE INJECTOR 4 LS 108 T960-A19 BU-18-XLPE 109 110 111 112 113 114 INJECTOR 3 & 4 HS 115 T859-A37 WH-18-XLPE INJECTOR 1 LS 116 T957-A16 PU-18-XLPE 117 INJECTOR 2 LS 118 T958-A17 YL-18-XLPE 119 120 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

ATCH-ETHER SOL 2391134

L12

SERIAL SERVICE CONNECTOR

5V ANALOG POWER ANALOG RETURN 8V DIGITAL POWER HOUR METER (-)

PU-18 WH-18

L11

780-C8 PU-16 H704-C202 PK-18 X738-C39 PK-18 K859-C205 BR-18 K863-C204 OR-18 L968-C67 OR-18 L968-C207 OR-18

L13 1 2

ALTERNATOR R-TERM SWG4

A B

E

C-C10 3E3364

UNSWITCHED POWER

A B

ENGINE F

1 2

NOTE E

YL-16 GN-18 BR-18 BR-18 GN-18 GN-18 YL-18 GY-18 PK-18 WH-18 GN-18 PK-18 PK-18 PU-18 BU-18 WH-18 BK-16 BK-18 BK-18 BK-16 OR-18 OR-18 BR-18 OR-18

L51

G

C-C9 1552269

C-C14 7Y3967 84RE01 430-C18 BU-18 1 C-C15 7Y3966 84RE01 235-C158 BK-18 1

PRODUCT LINK (NOTE AA)

H

310-C44 PU-16 200-C162 BK-18

308-C140 403-C151 892-C121 892-C152 893-C116 893-C153 A751-C144 A760-C108 C991-C150 G828-C148 G829-C149 G833-C145 H704-C202 N707-C147 N789-C107 T725-C146 200-C161 200-C162 235-C154 235-C160 L968-C207 K863-C204 K859-C205 L968-C67

NOTE E

578-C46 BU-16 506-C45 PU-18 200-C163 BK-18

COOLANT LEVEL SW 2459206

1 2

AR-C1 2434505 84RE01

SENSOR SUPPLY +8V SENSOR SUPPLY RETURN KEY SWITCH ON BODY GND

2

L4

L4

L5

FUEL PRESS. SENSOR 2392396

CAN HIGH

RS-232 PORT #3-TXD RS-232 PORT #3-RXD RS-232 PORT #3-GND GROUND

3

L3

101-C139 RD-4 109-C138 108-C136 RD-4 304-C137 WH-8

+5V GND SIGNAL

L16

L71

4

L3

L3

WH-18 BU-18 GN-16 GN-18 GY-18 WH-18 BK-18 BK-18 BK-18 PU-18 BU-16

OR-18 YL-18 GN-18

NOTE E

PU-16 RD-18 PU-16 GN-18 BU-18 BU-18 PU-16 PU-16 BR-18 GN-18 WH-16 BU-18 PK-18

L4

A B C

NOTE E

C-C8 1552267

CAN SHIELD

L12

147-C72 172-C2 310-C44 403-C14 412-C17 430-C18 514-C12 780-C8 892-C48 893-C47 C506-C13 G976-C32 X738-C39

L969-C66 L972-C33 L973-C80 N793-C86 N794-C58 N795-C59 235-C41 235-C42 235-C43 506-C45 578-C46

235-C158 BK-18 310-C44 PU-16 430-C18 BU-18 514-C12 PU-16 C506-C13 WH-16 200-C161 BK-16 200-C162 BK-18

BK-18 BK-18 235-C155 235-C156

L12

FUEL PRESS. SW 2122768

C-C12 C-C13 1552272 3E3376 1 147-C72 PU-16 2 235-C155 BK-18 3 G976-C32 BU-18 4

L16

L15 BK-18 BK-16 BK-18

BK-18 235-C157

147-C72 412-C17 A751-C144 A760-C108 C991-C150 G828-C148 G829-C149 G833-C145 G976-C32 N707-C147 N789-C107 T725-C146 235-C154

235-C159 235-C160 235-C158

PU-16 BU-18 YL-18 GY-18 PK-18 WH-18 GN-18 PK-18 BU-18 PU-18 BU-18 WH-18 BK-18

L14

FUEL TEMP SENSOR 1978391

BK-18

CONN 1

I

SIGNAL GND

235-AK2

B C A

N960-GL2 N957-GL1 N979-GL3

OR-18 PK-18 GN-18

GL-C1 GN-C5 2434508 84RE01 2305010 84RE01 1 N960-GL2 OR-18 N963-GN18 OR-18 2 N959-GN16 PK-18 N957-GL1 PK-18 3 N979-GL3 GN-18 N981-GN22 GN-18 4 5 CONN 4 6

CAN LOW

5

L10

N960-GN17 N957-GN15 N979-GN21 N970-GN19 N973-GN20

L70

RS-232 PORT #1-CDC RS-232 PORT #1-GND

6

147-C73 PU-16 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 892-C121 BR-18 893-C116 GN-18 A588-C88 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A760-C108 GY-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E997-C123 RD-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 H704-C202 PK-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K907-C63 BU-18 L969-C66 WH-18 L972-C33 BU-18 N789-C107 BU-18 N793-C86 GN-18 N794-C58 GY-18 N795-C59 WH-18 K859-C205 BR-18 K863-C204 OR-18 L968-C67 OR-18

1 2 3 4 5 6

WH-18 GN-18 PK-18

C-C7 3E3370

147-C72 PU-16 172-C2 RD-18 308-C140 YL-16 310-C44 PU-16 403-C151 GN-18 403-C14 GN-18 403-C141 GN-18 403-C141 GN-18 412-C17 BU-18 430-C18 BU-18 514-C12 PU-16 892-C143 BR-18 892-C143 BR-18 892-C48 BR-18 892-C121 BR-18 892-C152 BR-18 893-C142 GN-18 893-C142 GN-18 893-C47 GN-18 893-C116 GN-18 893-C153 GN-18 A751-C144 YL-18 A760-C108 GY-18 C506-C13 WH-16 C991-C150 PK-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 G976-C32 BU-18 N707-C147 PU-18 N789-C107 BU-18 T725-C146 WH-18 200-C161 BK-16 200-C162 BK-18 235-C154 BK-18 235-C160 BK-16

ATCH-PRIMING PUMP 0000000

L12

OR-18 PK-18 GN-18 YL-18 BR-18

RS-232 PORT #1-TXD

RS-232 PORT #1-RXD RS-232 PORT #1-DTR

7

BK-18 WH-18 RD-18

C-C6 1552269 WH-18 1 PU-18 2

C-C11 1552269 412-C17 BU-18 235-C156 BK-18

172-C2 RD-18 308-C140 YL-16 403-C141 GN-18 892-C143 BR-18 893-C142 GN-18 235-C159 BK-18

N973-GN20 BR-18 N979-GN21 GN-18

CONN 2

GN-C3 GK-C1 2305010 84RE01 2434508 84RE01 1 172-GN8 RD-18 172-GK1 RD-18 2 308-GN10 YL-16 308-GK3 YL-16 3 403-GN12 GN-18 403-GK4 GN-18 4 5 6 235-GN14 BK-18 235-GK2 BK-18 N960-GK6 N957-GK5 N979-GK9 N970-GK7 N973-GK8

N960-GN17 OR-18 N970-GN19 YL-18

T725-C146 N707-C147

CAT DATA LINK + CAT DATA LINK -

L70

L68

MATE C-C18 (PL121SR)(NOTE AA)

L68

N957-GN15 PK-18

L67

L68 GND-FR 5 2

893-GN6 GN-18 892-GN5 BR-18

200-GP3 BK-18 326-GP1 RD-16 A893-GP2 OR-16 T788-GP4 GN-16

1

NOTE E

L15

G828-C148 G829-C149 C991-C150

L69

GPS ANTENNA

C-C5 1552269 A751-C144 YL-18 1 G833-C145 PK-18 2

BK-16 BK-18

1

CONN 7

GATEWAY ECM 2399954 (NOTE Y) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64 65 66 67 68 69 70

8

ATCH-PRIMING PUMP SW 1655970

GP-C3 1552269 1 MOTOR T788-GP4 GN-16 2 200-GP5 BK-16

L15 GN-C2 1607690 84RE01

9

L70

NOTE E

200-GP5 200-GP3

SATELLITE ANTENNA

L70

L14

L14

L71

L66 K

L67

200-WM1 BK-16

(Dimensions: 48 inches x 35 inches)

PROD LINK 2ND GENERATION RADIO 2639088 (NOTE Y,Z) GK-C3 1552252 PROD LINK ANTENNA 2662861 1 BATT+ 172-GK1 RD-18 (NOTE Y,Z) 2 GND 235-GK2 BK-18 308-GK3 YL-16 KEY SWITCH ON 3 4 403-GK4 GN-18 ALT R-TERM 5 N957-GK5 PK-18 RS-232-TXD 6 SAT GPS 7 RS-232-RXD N960-GK6 OR-18 8 RS-232-GND N979-GK9 GN-18 9 RS-232-DTR N970-GK7 YL-18 RS-232-DCD 10 N973-GK8 BR-18 11 12

BR-18 GN-18 RD-18 RD-18 RD-18 RD-18 YL-16 YL-16 YL-16 YL-16 GN-18 GN-18 GN-18 GN-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 GN-18 YL-16 RD-18 PK-18 PK-18 OR-18 OR-18 YL-18 BR-18 GN-18 GN-18

MATE GK-C1 (PL121SR) (NOTE AA)

C-C18 2305010 84RE01 172-C2 RD-18 308-C140 YL-16 403-C141 GN-18 892-C143 BR-18 893-C142 GN-18 235-C159 BK-18

10

L7

NOTE E

1 2 3 4 5 6

MATE GN-C1 (PL321SR) (NOTE AA)

GP-C2 1552267 A A893-GP2 OR-16 C B 326-GP1 RD-16

11

130-C1 RD-14 147-C73 PU-16 168-C51 RD-10 184-C5 RD-14 251-C49 YL-18 252-C60 YL-18 261-C50 GN-18 262-C61 GN-18 308-C4 YL-16 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 405-C16 GY-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 998-C71 BR-18 A588-C167 GN-18 A588-C88 GN-18 A588-C3 GN-18 A588-C3 GN-18 A755-C24 PK-18 A756-C25 BU-18 A757-C26 GY-18 A758-C27 BR-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 E472-C29 GN-18 E473-C55 GY-18 E474-C52 OR-18 E554-C11 PK-18 E997-C123 RD-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 F889-C68 WH-18 H473-C31 BR-18 H474-C34 GN-18 H475-C35 BU-18 H476-C30 WH-18 K843-C56 GN-18 K844-C53 GY-18 K847-C57 PU-18 K848-C54 WH-18 K849-C36 YL-18 K851-C37 BU-18 K852-C38 GN-18 K906-C62 GN-18 K907-C63 BU-18

1 2 3 4 5 6 GN-C1 2434508 84RE01

L66

892-GN5 893-GN6 172-GN1 172-GN1 172-GN7 172-GN8 308-GN3 308-GN3 308-GN9 308-GN10 403-GN4 403-GN4 403-GN11 403-GN12 235-GN2 235-GN2 235-GN13 235-GN23 235-GN14 235-GN14 403-GN12 308-GN10 172-GN8 N957-GN15 N959-GN16 N960-GN17 N963-GN18 N970-GN19 N973-GN20 N979-GN21 N981-GN22

CONN 7

RD-18 YL-16 GN-18 BR-18 GN-18 BK-18

12

L9

172-GN1 308-GN3 403-GN4 892-GN5 893-GN6 235-GN2

C-C19 2434508 84RE01

13

L8

L66

L

36 Page,

RENR9587-05 VOL 1 of 2

PRODUCT LINK (NOTE AA)

14

BR-18 OR-18 OR-18 YL-16 GN-18 BR-18 BR-18 GN-18 GN-18 YL-18 GY-18 PK-18 WH-18 GN-18 PK-18 PK-18 PU-18 BU-18 WH-18 BK-16 BK-18 BK-18 BK-16 OR-18

15

K859-C205 K863-C204 L968-C67 308-C140 403-C151 892-C121 892-C152 893-C116 893-C153 A751-C144 A760-C108 C991-C150 G828-C148 G829-C149 G833-C145 H704-C202 N707-C147 N789-C107 T725-C146 200-C161 200-C162 235-C154 235-C160 L968-C207

16

101-C139 RD-4 108-C136 RD-4 109-C138 RD-4 130-C1 RD-14 168-C51 RD-10 304-C137 WH-8 308-C4 YL-16 308-C140 YL-16 317-C15 YL-18 321-C40 BR-18 322-C6 GY-16 403-C151 GN-18 405-C16 GY-18 487-C19 OR-18 491-C20 PK-18 495-C22 GN-18 496-C23 WH-18 607-C7 PK-16 616-C9 BU-16 892-C152 BR-18 893-C153 GN-18 998-C71 BR-18 A588-C167 GN-18 A751-C144 YL-18 A768-C64 BU-18 A769-C65 GY-18 C468-C28 BU-18 C991-C150 PK-18 E554-C11 PK-18 F716-C21 WH-18 F773-C69 OR-18 F774-C70 WH-18 G828-C148 WH-18 G829-C149 GN-18 G833-C145 PK-18 K906-C62 GN-18 L973-C80 GN-16 N707-C147 PU-18 T725-C146 WH-18 200-C161 BK-16 200-C162 BK-18 200-C163 BK-18 235-C41 BK-18 235-C42 BK-18 235-C43 BK-18 235-C154 BK-18 235-C160 BK-16

17

780-AL1 PU-16

18

5

4

3

2

1

WIRE GROUP COLOR DESCRIPTIONS WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON. VOLTAGE CONVERTER OUTPUT CIRCUIT. STARTING CIRCUIT. GROUND CIRCUIT. STARTING AID CIRCUIT. MONITOR CIRCUIT. ENGINE CONTROL CIRCUIT MACHINE CONTROL CIRCUIT. MACHINE SECURITY CONTROL CIRCUIT. HEATER AND AIR CONDITIONER CIRCUIT. TURN SIGNAL/WIPER/WASHER CIRCUIT. CAT DATA LINK. CAN 1 CAN 2 RS-232 DATA LINK / RS-485 DATA LINK

Wire Number

Description

Color

Wire Color

Power Circuits 101 103 105 108 109 112 113 114 115 117 118 120 123 124 125 127 129 130 135 139 141 142 143 147 149 152 154 160 165 168 169 172 175 177 179 180 184 188 189 199

RD RD RD RD RD PU OR RD RD RD GY YL WH GY RD OR BU RD BU OR RD RD BR PU RD BU RD PU YL RD PK RD RD RD BU GN RD WH RD OR

200 210 229 235 A209 A234 C212 C214

BK BK BK BK BK BK BK BK

304 306 307 308 310 317 320 321 322 323 325 326 329 331 365 391

WH GN OR YL PU YL RD BR GY WH PK RD YL OR YL PK

251 252 261 262 403 405 410 412 430 450 451 487 491 495 496 C468 E472 E473 E474 E480 F400 F401 F421 F424 F425 F426 F427 F429 F473 G428 H446 H473 H474 H475 H476 H479 L460 L463 L464 X416

YL YL GN GN GN GY WH BU BU YL BR OR PK GN WH BU GN GY OR PK GY GY YL YL PU BU PK BU YL BU PK BR GN BU WH OR YL GY BR OR

501 506 508 509 511 512 514 530 535 575 576 578 590 592 A513 A537 A579 A580 A581 A582 A584 A586 A588 C506 C560 C566 C569 E554 E562 E564 E565

GN PU PU WH BR GN PU OR BU YL PK BU GY BU RD PK OR BR GN PU BU OR GN WH OR PK YL PK PU PK BU

603 607 615 616 638 645 646 684 A623

PK PK YL BU WH RD RD RD BU

763 779 780 788 789 A701 A702 A703 A704

BU WH PU YL RD GY PU BR GN

Control Circuits (continued)

Bat + Radio Backup Key Sw Air Heater Relay Alt Output (+) Term. Main Power Rly Output Opr Mon Panel Vmis B+ Swed Warning Horn (forward) Cab Lamp Relay Power Converter + 24v BAtchery In Acc Wiper Con Atch 12v 7a Converter 1 + 24v Swed In Atch Seat Heater Sw A/c A/c Atch Air Suspension Cigar Lighter Eng Con BAtchery + Atch 12v 7a Socket + 12v Sw In Radio Converter + 24v Sw In Aux Ckt 2 Aux Ckt 3 Atch Boom Float Disable Relay Coupler Disengage Sol Headlamp Relay Atch Under Window Limit Sw Neutral Start Limit Sw A Right Cab Flood Lamp Crane Caution Lamp Excavator Fuel Pump Sw Back Up Epr Valve Sw Product Link Radio 2nd Genration A/c Main Brkr Atch 12v 7a Converter 1 + 24v Sw In Aux Ckt 1 Machine Con + BAtchery Atch Radio Mute Sw Neutral Start Limit Sw C Atch Rotary Beacon Stwitch Ground Circuits Main Chassis Converter Output (24/12 Volt) Bat (-) Electronic Pump Ctrl Gnd Hex Machine Ctrl Gnd J1939 Shield Gnd Multi-station Control Return Smms Return Basic Machine Circuits Starter Relay No. 1 Output Starter Relay Coil To Neut Start Sw Key Sw To Neutral Start Sw Or Snr Module Main Power Relay Coil Start Aid Sw To Start Aid Sol Start Aid Relay To Start Aid Sol Horn Relay Coil To Sw Backup Alarm Lamp Travel Alarm Warning Horn (forward) Fuel Pump Power Fuel Pump Relay Cut-out Key Sw 'c' Term. Fuel Pump To Sw Backup Alarm Relay Coil Fuel Pump Relay To Sw Remote Start/stop Monitoring Circuits Payload Mon - System Gnd Vmis Main Module Harness Code 0 Tehc Ident Code 1 Tehc Ident Code 2 Alternator (r) Term. Opr Mon Oil Press. (low Setting) Action Alarm Opr Mon Cool Flow/ds2 App Spec)(pin 26) Opr Mon Air Filter Tach Sender + Tach Sender Hyd Oil Flow Sw Hyd Oil Temp Snr Fuel Level Signal Opr Mon Panel Hyd Oil Level Eng Oil Level Atch 12v Snr Supply Stem 1 Modulation Stem 2 Modulation Spare Analog Input #1 Low Oil Pressure High Coolant Temp Fuel Temp Maintenance Incicator Trolling Mode Maintenance Clear Hour Meter + Diagnostic Lamp Driver Cust Transmission Warning Transmission Oil Press Boom Lower Check Press Snr Travel Straight Press Sw Travel Right Press Sw Travel Left Press Sw Joystick Press Sw Fuel Level Trip Clear Switch Low Coolant Level Lamp Hour Meter General Alarm Driver Accessory Circuits Wiper - Front (low) Washer - Front Radio Speaker - Left Radio Speaker - Left (commom) Radio Speaker - Right Radio Speaker - Right (com) A/c Condensor Motor Washer Right Sw To Wiper Sw Wiper - Aux (park) Wiper - Aux (low) Washer - Aux Wiper Sw To Intermittent Module Dc/dc Converter Power Output Dc/dc Converter Memory Output Seat Heater (resistive Element In Cushion) Wiper Motor + Wiper Motor Wiper Motor Raise Wiper Motor Stop Front Window Limit Sw To Wiper Cont Wiper Sw To Wiper Cont Safety Sol Relay To Sol Hi Relay Left Rear Speaker Left Rear Speaker (com) Second Dc/dc Converter Power Output A/c Conler To A/c Compressor Clutch Spare Relay No Spare Relay Nc #2 Spare Relay No #2 Lighting Circuits Rotary Beacon Flood Lamp - Front Cab Flood Lamp/rops Bucket Flood Lamp/boom Flood Lamp Rotary Beacon Headlamp Relay Light Sw To Front Flood Relay Cab Flood Lamp Right Cab Flood Lamp Sw To Relay Control Circuits Torque Converter Sw Coupler Engage Sol Coupler Disengage Sol Eng Speed (+) Cont Lever Lock Injector #1 Injector #2 Injector #3 Injector #4

A705 A706 A745 A751 A751 A755 A756 A757 A758 A760 A762 A768 A769 A770 F716 F773 F774 G723 H704 H746 H747 H792 M736 M737 M739 M740 M743 M744 M745 M746 M747 M748 M749 N707 N749 N789 N793 N794 N795 R725 R746 R747 T725 T725 T776 T788 X738 892 893 A893 F889 G826 G827 G828 G828 G829 G829 G833 G833 G849 G850 G854 G855 G856 G857 J842 K843 K844 K847 K848 K849 K850 K851 K852 K856 K857 K858 K859 K860 K861 K862 K863 K864 K865 K866 K868 K869 K871 K872 K876 K877 K879 K883 L885 L886 R800 R818 R819 T858 T859 T860 944 945 994 995 998 C967 C987 C991 C991 E963 E964 E965 E966 E997 G966 G973 G976 J906 K900 K904 K906 K907 K990 L968 L969 L972 L973 L976 L983 L984 L985 M906 M967 M971 M972 M973 M974 N940 N941 N957 N959 N960 N963 N970 N973 N979 N981 T901 T902 T957 T958 T959 T960 T961 T962 T967 X994

BU GY WH YL YL PK BU GY BR GY PU BU GY PK WH OR WH YL PK YL BR BR BU WH YL PK GN WH BU YL BU OR PK PU BK BU GN GY WH WH PK GY WH WH RD GN PK BR GN OR WH BR BU WH WH GN GN PK PK BR BU PK PU WH YL BK GN GY PU WH YL BR BU GN PU WH YL BR BU GN GY OR PK PU WH BR BU WH OR BR BU GN BR BU BR OR YL GY GY WH OR OR BR GY BU BR BU RD PK PK BK WH BU YL RD PU OR BU BR YL GN GN BU GN OR WH BU GN GN WH OR YL BU OR BR PK BR YL BU YL PK PK OR OR YL BR GN GN YL PK PU YL BR BU GN WH YL BR

Failure Mode Identifiers (FMI)¹ FMI No.

Component Identifiers (CID¹) Module Identifier (MID²) Engine Control System (MID No. 036)

Description

Failure Description

Injector #5 Injector #6 Fuel Pressure After Cooler Temp (pin 15) After Cooler Temp Pin 15 Throttle Sw #1 Throttle Sw #2 Throttle Sw #3 Throttle Sw #4 Electronic Pump Cont Throttle +5v Electronic Pump Cont Eng Speed Ground Pump Con Valve #1 (+) Pump Con Valve #2 (-) Electronic Pump Con Bypass Sw To Resistor Shutdown (nc)(app Specific) (pin 8) Governor Accel Governor Decel Heavy Lift Sol Valve Impl Cont Reversing Fan Sol Fan Con Sol Positive Fan Con Sol Return Sw To Relay 2 Governor Command Front Flow Con Valve Sol Sol Return 2 Travel Straight Sol Atch Boom Float Disable Relay Atch Smart Boom Select Sw Atch Boom Check Sol1 Atch Smart Boom Up/down Relay Atch Smart Boom Down Relay Atch Boom Down Press Sw Atch Boom Check Sol 2 Fuel Press Sw Left Exhaust Temperature Ambient Temp Snr Foot Pedal Sw Aux (ele) Pedal-lh Aux (ele) Pedal-rh Fuel Filter Sw Turbo Outlet Press Sensor Atmospheric Press Sensor Fuel Filter Sw Fuel Filter Sw Fuel Pump Relay Fuel Priming Pump Return Filter Sw. To Conler Start Mod Right (-) Port/cat Data Link (-) Start Mod Right (+) Port/cat Data Link (+) Fuel Sw To Fuel Pump Throttle Position Feedback Filter Sensor +5v Filter Sensor Common Press Snr +5v Pressure Sensor +5v Press Snr Com Pressure Sensor Common Eng Temp Snr Com Engine Temperature Sens Engine Inj Actuation Pressure Inlet Air Heater Return Inj Actuation Press Cont Valve Iap Cont Valve Common Tdc Probe + Tdc Probe Digital Return Stem 3 Extend Sw Stem 4 Extend Sw Stem 3 Retract Sw Stem 4 Retract Sw Atch Stem 1 Atch Stem 2 Atch Stem 3 Atch Stem 4 Stem 1 Con Valve A Stem 2 Con Valve A Stem 3 Con Valve A Stem 4 Con Valve A Stem 1 Con Valve B Stem 2 Con Valve B Stem 3 Con Valve B Stem 4 Con Valve B Atch Relief Valve 1 Atch Relief Valve 2 Atch 1-way / 2-way Con Valve Atch Sol Return 2 Atch Sol Return 3 Pump Exchange Sol Single/double Action Exchange Sol Atch Relief Sol Atch Change Check Sol Double Action Sol Troll Enable Pcp Sw Panel Option Sw Sw Panel Option Sw +8v Digital Sensor Power Transmission Oil Temp Sensor Slow Vessel Mode Injector High Side Injector High Side Injector High Side Data Link + Data Link Oil Pressure Filtered Coolant Temperature Digital Snr Return (pin 29) Inlet Air Temperature Inlet Air Heater + Fuel Filter Monitor Fuel Filter Monitor Engine Speed/timing AEngine Speed/timing A+ Engine Speed/timing BEngine Speed/timing B+ Hydraulic Lock Remote Shutdown Boom Raise Press Sw To Crush Press Sw Water Separator Snr Keyswitch J1939 Data Link + Pump Discharge - Signal Swing Brake Sol - Signal Swing Brake Sol - +b J1939 Data Link Electronic Pump Con Ps Valve (-) Electronic Pump Con Ps Valve (+) Low Idle Sw Fine Swing Cont Relay To Sol Valve Excavator Fuel Pump Sw Injector Common 1 & 2 Injector Common 3 & 4 Injector Common 5 & 6 Aux Ckt 1 (pwm In) Vmis Jacket Coolant Level Primary Throttle Position Secondary Throttle Position Synchronize Ip 1 Synchronize Ip 2 Engine Analog Sensor Power +5v Engine Analog Sensor Return Rxd - Comm #1 Rxd - Comm #3 Txd - Comm #1 Txd - Comm #3 Dtr - Comm #1 Dcd - Comm #1 Signal Gnd - Comm #1 Signal Gnd - Comm #3 Mss Exciter Coil In Mss Exciter Coil Out Inj 1 Return Inj 2 Return Inj 3 Return Inj 4 Return Inj 5 Return Inj 6 Return Pump Discharge Mean Press Starter Interlock

CID

Harness And Wire Electrical Schematic Symbols

RENR9587-05 April 2011

Symbols

Component

0001


0002


0003


0004


0005


0006


0041


0042

Injector Actuation Valve

0091

Throttle Position Sensor

0094

Fuel Pressure Sensor

0100

Engine Oil Pressure Sensor

0110


0164

Injector Actuation Pressure Sensor

0168


0172

Intake Manifold Air Temp Sensor

0174

Engine Temperature Sensor

0190

Engine Speed/timing Sensor.

0253

Personality Module Mismatch

0261

Engine Timing Calibration

0262


0268

Check Programmable Parameters

0274

Atmospheric Pressure Sensor

0286

Low Oil Pressure Lamp

0342

Secondary Engine Speed/timing Sensor

0617

Inlet Air Heater Relay

1639

Machine Security System

1785

Intake Manifold Pressure Sensor

2417

Ether Injection Control Solenoid

T

Pressure Symbol

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it. Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be disconnected from the component. Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine. Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine. Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

330D and 336D Excavator Electrical System 330D: NBD1-840 MAG1-UP B6H1-652 EAH1-724 FFK1-325 JLP1-737 EDX1-UP MEY1-310

Component Sensor Supply Voltage

0096

Fuel Level Sensor

0110


0167

Alternator Charging Voltage Sensor

0168


0171

Ambient Air Temperature Sensor

0190

Engine Speed/timing Sensor

0246

Can Data Link

0247

J1939 Data Link.

0248

Cat Data Link

0254


0262


0271

Action Alarm

0362

Radiator Fan Speed Solenoid

0374

Swing Brake Solenoid

0544

Engine Cooling Fan Speed Sensor.

0581

Power Shift Pressure Solenoid

0586

Engine Speed Dial Switch

0588

Monitoring System Display

0598

Travel Speed Solenoid Valve

0600

Hydraulic Oil Temperature Sender

0735

Heavy Lift Solenoid Valve

1130

Left Side Attachment Pedal Sensor

1160

Hydraulic Lock Solenoid

1178

Boom Overload Pressure Sensor

1522


1523


1525

Travel Straight Solenoid

1590

Main Pump Flow Limitation Pressure Solenoid

1593


1594


1595


1596


1597


1598


1609

Squeeze Pressure Sensor

1657

Left Joystick Thumbwheel

1658

Right Joystick Thumbwheel

1665


1666


1931

Auxiliary Circuit Flow Combining Solenoids

2265


2266


2280

The Travel Alarm Relay

2300

Switch Panel

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

T

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

336D: JTF1-197 M4T1-206

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work. MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch) that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness And Wire Symbols 1 2

Pin or Socket Number

a

Product Link Radio (MID No. 122 )

b

c

d

e

f

g

h

i

j

k

l

m

n

o

p

q

r

s

t

u


0254


0269

Sensor Power Supply

1251

Alternator R-terminal Signal

19

18

18

17

17

16

16

15

15

14

14

13

13

¹ The CID is a diagnostic code that indicates which circuit is faulty. ² The MID is a diagnostic code that indicates which electronic control module diagnosed the fault.

Component Locations Schematic Location

Machine Location

Air Suspension (atch)

J-5

K-22, K-6

Alarm-Action

E-1

M-20, M-6

Component

Schematic Location

Machine Location

Relay- Qc Hyd Lock 1 (atch)

C-12

J-23, J-7

Relay- Qc Hyd Lock 2 (atch)

B-12

J-23, J-7 J-23, J-7

Component

Aux Pedal Lh

I-1

N-22, N-5

Relay- Qc Hyd Lock On (atch)

C-12

Control- Monitor

F-1

N-20, N-6

Relay- Qc Hyd Lock Priority (atch)

C-12

J-23, J-7

Control- Switch Panel

C-1

L-20, L-6

Relay- Single (atch)

D-11

J-21, J-7

Control- Wiper

D-1

J-20, J-6

Relay- Smart Boom Down (atch)

E-10

J-21, J-7

Converter- 12v-7a 1 (atch)

I-4

K-22, K-5

Relay- Smart Boom Up/Down (atch)

E-11

J-21, J-7

Converter- 12v-7a 2 (atch)

H-4

K-22, K-5

Relay- Travel Alarm

C-9

J-23, J-7

Converter- 12v-7a Power

A-7

J-20, J-6

Resistor- Backup

E-7

J-22, J-7

Converter- Radio

A-9

J-20, J-6

Resistor- Can 1

B-2

L-20, L-6

Diode- Accessory

H-7

M-23, M-5

Resistor- Can 2

B-6

M-20, M-6

Diode- Hyd Lock

H-7

L-23, L-5

Switch- 2nd Filter

B-3

L-20, L-6

Diode- Lamp

E-9

J-23, J-7

Switch- Backup Epr Valve

F-5

K-21, K-6

Diode- Main Relay

A-10

J-23, J-7

Switch- Backup Governor

F-5

K-21, K-6

Fuse Block

B-10/D-8

J-23, J-7

Switch- Exciter Coil (atch)

G-3

L-21, L-7

Ground- Cab 1

B-4

J-20, J-6

Switch- Fine Swing Cont (atch)

A-3

L-20, L-6

Ground- Cab 2

D-7

K-20, K-6

Switch- Fuel Filter

H-6

L-20, K-6

Ground- Cab 3

D-3

J-20, J-10

Switch- Idle- One Touch Low

H-3

L-21, L-7

Ground- Platform

I-9

J-23, J-5

Switch- Key

G-3

L-21, L-7

Heater - Seat (atch)

H-4

K-21, K-6

Switch- Lower Washer (atch)

A-4

L-20, L-6

Indicator- Unit

G-3

L-21, L-7

Switch- Lower Wiper (atch)

A-3

L-20, L-6

Joystick- Left Hand (atch)

J-3

L-22, L-7

Switch- Neutral Start Limit

J-4

L-23, L-6

Joystick- Left Hand 3 (atch)

J-3

L-22, L-7

Switch- Over Load Warning (atch)

A-5

L-20, L-6

Joystick- Right Hand (atch)

H-3

L-21, L-7

Switch- Pressure- Aux Pedal (atch)

I-1

N-21, N-5

Joystick- Right Hand 3 (atch)

H-3

L-21, L-7

Switch- Pressure- Aux Pump Stem 4 (atch)

I-1

N-22, N-5

Key Reader- Mss (atch)

G-3

L-21, L-6

Switch- Pressure- High Stem 1 (atch)

H-1

N-21, N-5

Lamp- Cab Lh (atch)

H-1

N-23, N-10

Switch- Pressure- Medium Stem 3 (atch)

I-1

N-22, N-5

Lamp- Cab Rh (atch)

G-1

N-20, N-10

Switch- Pressure- Travel Left

H-1

N-22, N-5

Lamp- Caution (for Crane)(atch)

B-3

I-20, I-10

Switch- Pressure- Travel Right

H-1

N-21, N-5

Meter- Service

E-1

M-20, M-6

Switch- Pressure- Travel Straight (atch)

H-1

N-21, N-5

Motor- Lower Wiper (atch)

I-1

N-22, N-5

Switch- Quick Coupler (atch)

A-2

L-20, L-6

Motor- Wiper

D-1

N-20, N-6

Switch- Radio Mute (atch)

A-4

L-20, L-6

Outlet- 12v-7a A (atch)

C-6

J-20, J-7

Switch- Rocker (option)

B-3

L-20, L-6

Outlet- 12v-7a B (atch)

C-7

J-20, J-7

Switch- Seat Heater (atch)

A-6

L-20, L-6

Relay- Beacon (atch)

D-9

J-23, J-7

Switch- Secondary Shutdown

G-11

L-23, L-6

Relay- Boom Float Disable (atch)

E-11

J-21, J-7

Switch- Smart Boom Select (atch)

A-5

K-20, K-6

Machine Harness Connector And Component Locations

12

11

10

10

9

9

8

8

7

7

6

6

5

5

4

4

3

3

2

2

1

1

a

b

c

d

e

f

g

h

i

j

k

l

m

n

o

p

q

r

s

t

u

Connector Number

Machine Location

Connector Number

Schematic Location

Machine Location

J-6

K-22, K-5

1028016

Resistor:

2

Data erratic, intermittent, or incorrect.

Relay- Chasis Lamp

E-9

J-23, J-7

Switch- Under Window Limit (atch)

E-1

N-20, N-6

CONN 25

H-12

I-22, I-5

CONN 42

J-6

K-22, K-5

1743016

Resistor:

3

Voltage above normal or shorted high.

Relay- Ether (atch)

C-9

J-23, J-7

Switch- Universal Qc (atch)

A-1

L-20, L-6

4

Voltage below normal or shorted low.

CONN 26

H-12

I-22, I-5

CONN 44

H-6

K-21, K-5

Relay- Horn

E-10

J-23, J-7

Switch- Upper Window Limit

E-1

M-20, M-10

5

Current below normal or open circuit.

CONN 27

F-12

I-22, I-5

CONN 45

G-6

K-21, K-5

Relay- Main

A-10

J-23, J-7

Switch-Horn

I-4

L-22, L-7

6

Current above normal or grounded circuit.

CONN 28

F-12

I-22, I-5

CONN 46

G-6

K-21, K-5

7

Mechanical system not responding properly.

Relay- Nuetral Start

D-9

J-23, J-7

Timer- Lamp Delay (atch)

B-10

J-23, J-7

CONN 29

D-12

I-22, I-5

CONN 47

F-6

K-21, K-5

8

Abnormal frequency, pulse width, or period.

J-21, J-7

Unit- A/c

H-9

Part No.

J-21,-J-6

Off Machine Switch Specification Part No.

1673466

Function ATCH Aux Punp Pressure Switch (Stem 4) ATCH Midium Pressure Switch (Stem 3) ATCH High Pressure Switch (Stem 1) ATCH Travel Straight Pressure Switch Travel Lert Pressure Switch Travel Right Pressure Switch

Actuate

490 ± 49 Kpa (71± 7.1 psi)

Deactuate

290 Kpa min (42 psi min)

y

z

aa

bb

cc

ET CONN

Component Description

dd

ee

ff

Resistance (Ohms)¹

Backup Can 1 Data Link Can 2 Data Link

Event Codes Engine Control

CONN 30

F-12

I-22, I-5

CONN 48

B-8

J-20, J-6

CONN 31

G-11

K-22, K-5

CONN 49

A-6/A-7/B-6

J-20, J-6

CONN 32

F-10

J-21, J-6

CONN 50

G-4

L-21, L-6

Event Code

CONN 33

B-10

J-23, J-6

CONN 51

A-2/A-3

L-20, L-6

E096

High Fuel Pressure

47 ± 5% 120 ± 10%

High Boost Pressure

Condition

Related Electrical Service Manuals Title Alternator: Electric Starting Motor:

Form Number 1855294 (DENSO HDB)

SENR4130

2371962 (DELCO 50 MT)

SENR3860

CONN 34

F-10

J-21, J-6

CONN 52

G-2/H-2

M-23, M-10

E162

CONN 35

F-9

J-21, J-6

CONN 53

G-2

M-23, M-10

E198

Low Fuel Pressure

Consist:

6V5582 (DENSO F8.0)

SENR4975

E265

User Defined Shutdown

Consist:

2071557 (DELCO 42 MT)

SENR3581

E360

Low Engine Oil Pressure

E361

High Engine Coolant Temperature

E362

Engine Overspeed

E390

Fuel Filter Restriction

E539

High Intake Manifold Air Temperature

Contact Position

Normally Open

x

¹ At room temperature unless otherwise noted.

Machine locations are repeated for components located close together.

Bad device or component.

w

Resistor Specifications

CONN 41

D-10

v

Connector Locations Schematic Location

I-22, I-5

Relay- Priming Pump (atch)

12

11

H-12

Parameter failures.

ff

19

CONN 24

20

ee

20

L-21, L-7

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

dd

20

G-3

Condition not met.

cc

Component

0168

Switch- Throttle Position

19

bb

21

J-23, J-7

Sensor supply fault.

aa

21

D-9

18

z

22

Relay- Cab Lamp

Module not responding.

y

22

Data valid but below normal operational range.

17

x

23

1

Parameter not available.

w

23

K-21, K-5

16

v

24

G-7/H-6

Parameter failures.

Wire Gauge

Wire Color

24

CONN 40

15

Circuit Identification Number

Printed in U.S.A.

I-22, I-5

Parameter failures.

200-L32 BK-14

© 2011 Caterpillar All Rights Reserved

J-12

Out of calibration.

Ground Connection

Volume 2 of 2: Cab Area

CONN 23

14

Component Part Number

2

Harness identification code: This example indicates wire 135 in harness "AG".

L-20, L-6

13

9X-1123

Plug

B-3

12

Fuse (5 Amps)

Receptacle

Switch- Stg (option)

Failure mode not identifiable.

5A

Single Wire Connector

J-23, J-7

11

Part Number For Connector Recepticle

1

325-AG135 PK-14

E-9

Abnormal rate of change.

L-C12 3E-5179

AG-C4 111-7898

Socket

Pin

Relay- Boom Lamp

10

Harness Connector Serialization Code: The "C" stands for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)

Part Number for Connector Plug

C-C4 AG-C3 130-6795 130-6795

Sure-Seal connector: Typical representation of a Sure-Seal connector. The plug and receptacle contain both pins and sockets. Harness Identification Letter(s): (A, B, C, ..., AA, AB, AC, ...)

Wire, Cable, or Harness Assembly Identification: Includes Harness Identification Letters and Harness Connector Serialization Codes

Data valid but above normal operational range.

Abnormal update.

1 2

Deutsch connector: Typical representation of a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

0

9

Circuit Breaker Symbol

Flow Symbol

Fuse - A component in an electrical circuit that will open the circuit if too much current flows through it.

0041

CID

Level Symbol

Symbols And Definitions

Machine Control System (MID No. 039) CID

Temperature Symbol

CONN 36

F-8

J-21, J-6

CONN 54

G-2

M-20, M-10

CONN 37

I-8

K-21, K-5

CONN 55

G-2

M-20, M-10

CONN 38 CONN 39

F-7 F-7

J-21, J-6 J-21, J-6

CONN 56 CONN 57

A-2 E-7

L-20, L-6 K-22, K-8

The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component.

2071556

Engine Control:

RENR5089

Machine Control:

RENR9848

Product Link Radio:

RENR7911

24 Page

Wire

RENR9587-05 VOL 2

Wire Description Wire Number

8

7

1 2

84RE01 +12V MEMORY OUT +12V SWITCHED OUT GND (12V) GND (24V) +24V BATTERY IN +24V SWITCHED IN

ATCH-12V-7A CONVERTER 2 2341004 (NOTE U)

2304009 84RE01 A-C24 K906-A73 GN-18 A768-A77 BU-18 A769-A78 GY-18 105-A37 RD-16 A537-A41 PK-18 K907-A74 BU-18

HYD LOCK DIODE 1974385 RE01 1 2

1 2 3 4

A-C34 2434508 84RE01 308-A139 YL-16 326-A159 RD-16 307-A24 OR-16 252-A126 YL-18 262-A127 GN-18 NOTE E A-C42 2434510 84RE01 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 L972-A96 BU-18 F774-A107 WH-18 F773-A106 OR-18 607-A95 PK-16

L98

G-C6 G-C7 2304011 84RE01 2434505 84RE01 1 A537-G9 PK-18 2 200-G35 BK-18 200-G33 BK-18 ATCH-SEAT HEATER 200-G34 BK-18 2299093 200-G32 BK-16 2359027(UN TILT) 200-G32 BK-16 2 1 103-G49 RD-16 105-G8 RD-16 113-G44 OR-18 252-G21 YL-18 262-G22 GN-18 307-G20 OR-16 308-G17 YL-16 308-G17 YL-16 L100 308-G18 YL-16 308-G19 YL-16 NOTE E 326-G54 RD-16 508-G50 PU-18 509-G46 WH-18 511-G51 BR-18 512-G47 GN-18 607-G30 PK-16 607-G48 PK-16 A755-G23 PK-18 A756-G24 BU-18 A757-G25 GY-18 A758-G26 BR-18 NOTE E E472-G1 GN-18 E473-G2 GY-18 K843-G3 GN-18 K847-G4 PU-18 L972-G27 BU-18 L100 200-G45 BK-18

CONN 44

2434510 84RE01 G-C2 K906-G5 GN-18 A768-G6 BU-18 A769-G7 GY-18 105-G8 RD-16 A537-G9 PK-18 K907-G10 BU-18 M736-G11 BU-18 L969-G12 WH-18 L968-G13 OR-18 998-G14 BR-18 A770-G15 PK-18 F889-G16 WH-18

1 2 3 4 5 6 7 8 9 10 11 12

CONN 45

G-C3 2305010 84RE01 308-G17 YL-16 326-G54 RD-16 307-G20 OR-16 252-G21 YL-18 262-G22 GN-18

1 2 3 4 5 6

NOTE E

CONN 46

169-A140 PK-18 200-A94 BK-16 235-A88 BK-18

1 2 3 4 5 6 7 8 9 10 11 12

A-C26 2434509 84RE01 113-A155 OR-18 200-A102 BK-18 509-A69 WH-18 512-A67 GN-18 607-A103 PK-16 103-A63 RD-16 508-A68 PU-18 511-A66 BR-18

1 2 3 4 5 6 7 8

G-C8 G-C9 2397352 84RE01 2472693 84RE01 1 E472-G1 GN-18 1 2 235-G42 BK-18 2 3 E473-G2 GY-18 3 4 235-G41 BK-18 4 5 K843-G3 GN-18 5 6 K847-G4 PU-18 6

G-C4 2304009 84RE01 A755-G23 PK-18 A756-G24 BU-18 A757-G25 GY-18 A758-G26 BR-18 L972-G27 BU-18 F774-G28 WH-18 F773-G29 OR-18 607-G30 PK-16

L99

169-G31 PK-18 200-G32 BK-16 235-G36 BK-18

G-C10 7Y3967 84RE01 1 235-G43 BK-18 G-C11 7Y3967 84RE01 1 L972-G27 BU-18

G-C12 1552264 308-G19 YL-16 200-G34 BK-18 252-G21 YL-18 262-G22 GN-18 T901-G52 YL-18 T902-G53 PK-18

235-G41 235-G42 235-G43 235-G40

BK-18 BK-18 BK-18 BK-18

235-G36 235-G36 235-G40 235-G39 235-G37 235-G37

BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

G-C5 2312295 84RE01 113-G44 OR-18 200-G45 BK-18 509-G46 WH-18 512-G47 GN-18 607-G48 PK-16 103-G49 RD-16 508-G50 PU-18 511-G51 BR-18

AJ-C1 2312295 84RE01 113-AJ1 OR-18 200-AJ3 BK-18 509-AJ4 WH-18 512-AJ5 GN-18

1 2 3 4 5 6 7 8

12 11 1 2 3 4 5 6 7 8 21 9 10 13 14 15 16 17 18 19 20

103-AJ6 RD-16 508-AJ7 PU-18 511-AJ8 BR-18 MATE A-C26 (NOTE R)

K906-G5 GN-18

2

A768-G6 BU-18

5

235-G38 BK-18

8

A769-G7 GY-18

11

L154

177-FA1 RD-4

RADIO CONVERTER 2341004 (NOTE R)

L154

10

9

L137

200-F160 BK-16 103-F96 RD-16 615-F129 YL-16 A584-F169 BU-18 L117

BK-14 BK-16 BK-16 BK-18 BK-16 200-F116 200-F149 200-F160 200-F157 200-F162

L134

L135

200-F8 BK-18 200-F166 BK-18 200-F168 BK-16 200-F180 BK-18

L121

261-F152 GN-18 251-F23 YL-18 103-F7 RD-18 251-F189 YL-18 261-F52 GN-18 308-F144 YL-16 892-F12 BR-18 893-F11 GN-18

103-F70 RD-16 113-F101 OR-18 135-F95 BU-14 147-F22 PU-16 252-F190 YL-18 262-F191 GN-18 430-F33 BU-18 487-F34 OR-18 506-F103 PU-18 535-F117 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 780-F21 PU-16 892-F98 BR-18 893-F111 GN-18 A537-F108 PK-18 C569-F97 YL-14 G976-F36 BU-18 L973-F197 GN-16 X738-F35 PK-18 200-F113 BK-14 210-F47 BK-14 229-F45 BK-14 235-F114 BK-18 251-F23 YL-18 261-F152 GN-18

103-F6 RD-16 103-F96 RD-16 103-F7 RD-18 103-F70 RD-16

615-F129 YL-16 103-F96 RD-16 A584-F169 BU-18 200-F160 BK-16

OPERATOR STATION 1

DOME LAMP 1761986

L114

L114

ENG OIL PRESS. ENG OIL LEVEL COOLANT LEVEL HYD OIL LEVEL AIH CONT STATUS + BATTERY GND ACC CAN1 + CAN1 CDL + CDL ACTION ALARM

F-C33 1552269 1 199-F165 OR-18 410-F89 WH-18 2

ACTION ALARM 1321829

E SERVICE METER 1978832

ATCH-UNDER WINDOW LIMIT SW 1296466 L111

152-F59 BU-16

535-F148 BU-16

535-F117 BU-16 535-F124 BU-16 535-F151 BU-16

535-F148 BU-16 L110

WIPER MOTOR 1893424

L111

MOTOR

118-F90 GY-16 501-F28 GN-18 506-F103 PU-18 530-F29 OR-18 590-F67 GY-18 A584-F169 BU-18 A586-F26 OR-18 200-F168 BK-16 200-F180 BK-18

F

VIDEO (NTSC/PAL) GND

L112

410-F89 WH-18 103-F27 RD-18 199-F165 OR-18 152-F59 BU-16 403-F76 GN-18 535-F117 BU-16 535-F124 BU-16 535-F151 BU-16 200-F166 BK-18

NOTE E

FUEL LEVEL COOLANT TEMP HYD OIL TEMP ALT R-TERM.

F-C30 2677629 84RE01 1 +B 103-F27 RD-18 F-C31 2677629 84RE01 1 GROUND 200-F166 BK-18 F-C32 2677629 84RE01 1 SIGNAL 403-F76 GN-18

103-F24 RD-18 251-F147 YL-18 261-F51 GN-18 308-F144 YL-16 403-F4 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18 495-F1 GN-18 496-F5 WH-18 892-F12 BR-18 893-F11 GN-18 C468-F9 BU-18 200-F8 BK-18 410-F89 WH-18

L113

MONITOR 2602193

1 2

RCA JACK (VIDEO)

1 3 6 4 5 2

BU/BK BU/RD GN BU BK

L110

F-C25 7Y3958 84RE01 A579-F176 OR-16 A580-F177 BR-16 A581-F178 GN-16 A582-F179 PU-16 200-F168 BK-16

L109

D

200-F168 BK-16 F-C26 1114816 84RE01 1 A579-F176 OR-16 2 A580-F177 BR-16 13 A581-F178 GN-16 12 A582-F179 PU-16 4 A586-F26 OR-18 9 590-F67 GY-18 8 501-F28 GN-18 7 530-F29 OR-18 10 200-F180 BK-18 11 5 506-F103 PU-18 6 118-F90 GY-16 3 A584-F169 BU-18

W. CCW W. CW REV STOP INT-6 INT-3 LOW WASH GND RAISE-S WA+ ACC WIPER CUT

200-F168 BK-16

L117

L134 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 200-F138 BK-16 200-F139 BK-16 200-F140 BK-16 103-F6 RD-16 615-F129 YL-16

152-F59 BU-16 199-F69 OR-18 308-F104 YL-16 331-F187 OR-18 603-F133 PK-18 607-F49 PK-18 645-F88 RD-18 684-F130 RD-18

L115

L111

PU-18 WH-18 BR-18 GN-18 508-F120 509-F121 511-F118 512-F119

200-F116 BK-14

403-F115 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18 495-F1 GN-18 496-F5 WH-18 C468-F9 BU-18

200-F68 BK-14 103-F70 RD-16 113-F101 OR-18 135-F95 BU-14 147-F22 PU-16 251-F23 YL-18 252-F190 YL-18 261-F152 GN-18 262-F191 GN-18 430-F33 BU-18 487-F34 OR-18 506-F103 PU-18 535-F117 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 780-F21 PU-16 892-F98 BR-18 893-F111 GN-18 A537-F108 PK-18 C569-F97 YL-14 G976-F36 BU-18 L973-F197 GN-16 X738-F35 PK-18 200-F113 BK-14 210-F47 BK-14 229-F45 BK-14 235-F114 BK-18 L139 105-F137 RD-16 105-F137 RD-16 105-F77 RD-16 105-F102 RD-16 105-F40 RD-16 105-F40 RD-16 113-F61 OR-18 118-F90 GY-16 123-F64 WH-18 129-F57 BU-16 147-F63 PU-16 147-F83 PU-16

L109

L110

L154

113-F81 OR-18 129-F57 BU-16 251-F189 YL-18 251-F189 YL-18 251-F109 YL-18 251-F100 YL-18 261-F52 GN-18 261-F52 GN-18 261-F50 GN-18 261-F48 GN-18 331-F187 OR-18 430-F33 BU-18 487-F34 OR-18 501-F28 GN-18 530-F29 OR-18 590-F67 GY-18 645-F88 RD-18 646-F32 RD-18 780-F30 PU-18 A586-F26 OR-18 G976-F36 BU-18

NOTE E

430-F33 BU-18 487-F34 OR-18 X738-F35 PK-18 G976-F36 BU-18 T725-F37 WH-18 L122

1

F-C19 7Y3967 84RE01 L885-F39 BU-18

2ND FILTER SW

1

F-C14 7Y3967 84RE01 R725-F38 WH-18

1

GND-CAB 1

F-C11 7Y3967 84RE01 T725-F37 WH-18 CAN 1 RESISTOR 2 1743016 84RE01

F-C17 1636803 84RE01

ATCH BEACON SW

147-F17 PU-16 780-F31 PU-16

CONN 51

L154

F-C50 7Y3952 84RE01 AW-C1 7Y3953 84RE01 780-AW2 PU-16

F-C48 3E3370

ATCH-SEAT HEATER SW ATCH-OVER LOAD WARNING SW ATCH-LOWER WASHER SW 2382211 2382215 ATCH-SMART BOOM SELECT SW 2382210 2382214 (NOTE S)

ATCH-RADIO MUTE SW ATCH-LOWER WIPER SW 2382216 2382209 (NOTE R) (NOTE S)

CAUTION LAMP (FOR CRANE)

DIGITAL GND DIGITAL GND

B

251-F100 YL-18 261-F48 GN-18

CONN 56 5 4 3 2 1

GV-C1 1673542 84RE01

ABBREV BK BR BU GN GY OR PK PU RD WH YL

SYMBOL

COLOR BLACK BROWN BLUE GREEN GRAY ORANGE PINK PURPLE RED WHITE YELLOW

SPLICE CIRCUIT NOT CONNECTED ELECTRICAL CONNECTION TO MACHINE STRUCTURE INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT CONNECTOR GOLD TERMINAL ATCH WIRE, CABLE, COMPONENT CIRCUIT GROUPING DESIGNATION

E565-GV4 BU-16 E562-GV3 PU-16 147-GV1 PU-16 147-GV2 PU-16

2

147-GV2 PU-16

5

1 3 4 6

CAB, PLATFORM AND CONSOLE AREA OF OPERATOR STATION SCHEMATIC FOR MODEL : 330D

ATCH-UNIVERSAL QC SW 1055175 (NOTE AC)

51

SWITCH GP 2677671

GT-C1 7Y3953 84RE01 E562-GT22 PU-16 147-GT17 PU-16

DESCRIPTION BLADE, SPADE, RING, OR SCREW TERMINAL

PART No.

251-0617

CHG-LEVEL SHEET

04 2 OF 2

ATCH-QUICK COUPLER SW 7N2353

OPERATOR STATION 4

2ND FILTER SW OLWD CANCEL SW OPTION STG SW FINE SWING SW SM BM UP/DOWN SM BM DOWN QUICK COUPLER SW OPTION ROCKER SW WASHER WIPER INT-3 WIPER INT-6 WIPER LOW CHAS LAMP RELAY BOOM LAMP RELAY TRAVEL ALARM

ATCH-FINE SWING CONT SW 2382212

CAB 5

AIR CLEANER SW CAPSULE FILTER SW SP FILTER SW WTR SPR LEVEL SW FUEL FILTER SW DIGITAL GND DIGITAL GND

NOTE E

147-GT17 PU-16 E562-GT22 PU-16 E562-GT22 PU-16 E562-GT21 PU-16 E562-GT16 PU-16 E562-GT18 PU-16 MATE F-C50 CONN (NOTE AC)

147-AW1 PU-16 SWITCH GP 2382478

6

A B C

E565-GT20 BU-16 E562-GT21 PU-16 147-GT17 PU-16

1 2

F-C20 1636803 84RE01

147-F188 PU-16 200-F156 BK-18 200-F181 BK-18

PK-18 PK-18 BU-16 YL-18 PK-18 BK-18 BK-18 607-F159 607-F154 535-F151 575-F106 576-F107 200-F158 200-F156

F-C40 1636803 84RE01

607-F154 PK-18 L973-F198 GN-16

OR-16 OR-16 BK-18 BK-18 139-F186 113-F185 200-F170 200-F158

607-F193 PK-18 607-F159 PK-18

607-F171 PK-18 607-F193 PK-18 578-F105 BU-16

535-F124 BU-16 200-F194 BK-18 200-F170 BK-18

F-C21 1636803 84RE01

C

261-F48 GN-18 251-F100 YL-18

GT-C7 1636803 84RE01

1 2

F-C15 1636803 84RE01

4 3 1 2 5

F-C16 1636803 84RE01

4 1 3 2 5

F-C18 1636803 84RE01

4 3 1 2 5

F-C13 1636803 84RE01

ACC GND CAN1 + CAN1 -

F-C2 1636699 84RE02

L154

L154

607-F172 PK-18 607-F171 PK-18 M747-F42 BU-18 M746-F192 YL-18 M744-F195 WH-18 200-F167 BK-18 200-F194 BK-18

L154

4 3 1 2 5

L129

L130

E480-F43 PK-18 200-F183 BK-18 200-F167 BK-18

F-C49 2304011 84RE01 113-F185 OR-16 139-F186 OR-16

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18

780-F30 PU-18 L885-F39 BU-18 530-F29 OR-18 590-F67 GY-18 A586-F26 OR-18 501-F28 GN-18 646-F32 RD-18 645-F88 RD-18 331-F187 OR-18 165-F110 YL-18

F-C63 7Y3967 1 165-F110 YL-18

CAUTION LAMP (FOR CRANE)

SWITCH PANEL 2277575 A1 A2 A3 A4 A5 A6 A7 A8 A9 A10 A11 A12

R725-F38 WH-18 E480-F43 PK-18 L886-F13 BR-18 L973-F196 GN-18

NOTE E

L154

7

F-C1 1636659 84RE01 113-F81 OR-18 200-F25 BK-18 251-F109 YL-18 261-F50 GN-18

NOTE E

3

CAB 2

1

CAB

L123 OPTION ROCKER SW

FUEL FILTER SW

L123

L128

OPTION STG SW

CIGAR LIGHTER 9W0335 F-C4 1532602 RE01

200-F122 BK-16

123-F64 WH-18 147-F17 PU-16 147-F188 PU-16 199-F69 OR-18 199-F165 OR-18 535-F124 BU-16 535-F151 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 603-F133 PK-18 607-F49 PK-18 780-F31 PU-16 A537-F108 PK-18 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 200-F181 BK-18 235-F46 BK-18 L973-F197 GN-16 L973-F196 GN-18 L973-F198 GN-16 L973-F198 GN-16 E480-F43 PK-18

113-F185 OR-16 139-F186 OR-16

NOTE E

E480-F43 PK-18 L973-F196 GN-18 F-C36 7Y3967 84RE01 1 L886-F13 BR-18

1

OPERATOR STATION

200-F122 BK-16 200-F182 BK-18 200-F139 BK-16 200-F113 BK-14 200-F160 BK-16 200-F168 BK-16 200-F8 BK-18 200-F166 BK-18 200-F180 BK-18

501-F28 GN-18 530-F29 OR-18 590-F67 GY-18 A586-F26 OR-18 200-F122 BK-16

X738-F35 PK-18

147-F83 PU-16 147-F63 PU-16 147-F22 PU-16 147-F17 PU-16 147-F188 PU-16 199-F69 OR-18 199-F165 OR-18 535-F124 BU-16 535-F151 BU-16 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 603-F133 PK-18 607-F49 PK-18 780-F31 PU-16 A537-F108 PK-18 L973-F197 GN-16 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 235-F46 BK-18 200-F181 BK-18 200-F25 BK-18 200-F182 BK-18 200-F182 BK-18 780-F30 PU-18 113-F81 OR-18 129-F57 BU-16 251-F189 YL-18 261-F52 GN-18 331-F187 OR-18 430-F33 BU-18 487-F34 OR-18 645-F88 RD-18 646-F32 RD-18 G976-F36 BU-18

129-F57 BU-16

X738-F35 PK-18 200-F25 BK-18 200-F122 BK-16

L123

L121

L126

L125

L121

L130

L131

F-C3 9G1906 84RE02 1

200-F113 BK-14 200-F139 BK-16 200-F160 BK-16

535-F151 BU-16 535-F124 BU-16 199-F165 OR-18 118-F90 GY-16 152-F59 BU-16 506-F103 PU-18 535-F117 BU-16 A584-F169 BU-18

L973-F197 GN-16 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 X738-F35 PK-18 210-F47 BK-14 229-F45 BK-14 235-F114 BK-18 235-F114 BK-18 235-F112 BK-18 235-F46 BK-18 199-F165 OR-18 535-F124 BU-16 535-F151 BU-16

L127 12V POWER CONVERTER 2341004 (NOTE AB)

252-F20 YL-18 262-F19 GN-18

4 3 2 1 5

CAN 2

8

NOTE E

L132

L119

L124

607-F184 PK-18 607-F172 PK-18 235-F46 BK-18

GH-C1 2305010 84RE01

NOTE E

123-F64 WH-18 200-F173 BK-18 200-F183 BK-18

1 2

NOTE E L130

607-F174 PK-18 607-F184 PK-18 A537-F108 PK-18

TURN SIGNAL/WIPER/WASHER CIRCUIT. CAT DATA LINK. CAN 1

GH-C3 2304013 GH-C4 2434506 (NOTE AB)

262-F150 GN-18 252-F153 YL-18

CONN 49

CONN 49

HEATER AND AIR CONDITIONER CIRCUIT.

CONN 49

MACHINE SECURITY CONTROL CIRCUIT.

NOTE E 235-F112 BK-18 893-F142 GN-18 892-F143 BR-18 105-F40 RD-16

NOTE E

4 3 2 1 5

F-C54 3E3370

MACHINE CONTROL CIRCUIT.

1 2 3 4 5 6

A513-AJ10 RD-18 592-AJ11 BU-18 200-AJ2 BK-18 200-AJ3 BK-18 103-AJ6 RD-16 139-AJ9 OR-18 1 2 3 4 5 6

F-C51 2434505 84RE01

A B C

L154

GROUND CIRCUIT.

OPERATOR STATION 11

188-GH5 WH-16

STARTING CIRCUIT.

A513-GH1 RD-18 592-GH2 BU-18 200-GH3 BK-18 200-GH7 BK-18 117-GH4 RD-18 139-GH6 OR-16

VOLTAGE CONVERTER OUTPUT CIRCUIT.

ENGINE CONTROL CIRCUIT

F-C22 2397356 84RE01 1 495-F1 GN-18 2 3 491-F3 PK-18 4 403-F4 GN-18 5 6 7 405-F62 GY-18 8 9 C468-F9 BU-18 10 412-F2 BU-18 11 496-F5 WH-18 12 F-C23 2304009 84RE01 1 103-F24 RD-18 2 200-F8 BK-18 3 308-F144 YL-16 4 5 251-F147 YL-18 6 261-F51 GN-18 7 893-F11 GN-18 8 892-F12 BR-18 9 10 11 12 410-F89 WH-18

NOTE E

199-F165 OR-18 118-F90 GY-16 152-F59 BU-16 506-F103 PU-18 535-F117 BU-16 535-F124 BU-16 535-F151 BU-16 A584-F169 BU-18

1

177-FA1 RD-4

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.

AJ-C3 2434505 84RE01 139-AJ9 OR-18 2 MATE F-C49 113-AJ1 OR-18 (NOTE R) 1

L98

(NOTE R)

112-FC1 PU-4 MAIN RELAY 2130772

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.

+12 V MEMORY OUT +12 V SWITCHED OUT GND (12V) GND (24V) +24 V BATTERY IN +24 V SWITCHED IN AJ-C2 2305010

177-A71 RD-6 177-FA1 RD-4

AJ-C4 2312295 84RE01 AJ-C5 2434509 84RE01

1 2 3 4 5 6 7 8

200-F140 BK-16

308-F144 YL-16 308-F104 YL-16 308-F141 YL-16

WIRE GROUP COLOR DESCRIPTIONS

MONITOR CIRCUIT. (VIMS) / (CMS) / (EMS) / (OTHER)

A513-AJ10 RD-18 592-AJ11 BU-18 512-AJ5 GN-18 511-AJ8 BR-18

L133 L133

MAIN RELAY DIODE F-C5 1211022 84RE01 7Y3952 84RE01 1 200-F146 BK-18 2 308-F145 YL-18

F-C27 9W1951 B D E A C F G H J

RESISTOR 2 1743016

L120

STARTING AID CIRCUIT.

177-FA1 RD-4

308-F141 YL-16 308-F104 YL-16 308-F144 YL-16

L98

+12 V MEMORY OUT +12 V SWITCHED OUT GND (12V) GND (24V) +24 V BATTERY IN +24 V SWITCHED IN

L108

105-F137 RD-16 200-F138 BK-16 308-F141 YL-16

RD-16 PU-18 WH-18 BR-18 GN-18 BK-18 OR-18 OR-18 OR-18

V-C4 7Y3966 84RE01

200-V2 BK-16

200-F157 BK-18

ANTENNA 2594883

L121

L124

607-F49 PK-18 607-F174 PK-18 199-F69 OR-18 199-F165 OR-18 603-F133 PK-18 200-F173 BK-18

188-GH5 WH-16

103-AJ6 508-AJ7 509-AJ4 511-AJ8 512-AJ5 200-AJ3 113-AJ1 113-AJ1 139-AJ9

G

1

V-C3 7Y3967 84RE01 1

A584-F169 BU-18

501-F28 GN-18 530-F29 OR-18 590-F67 GY-18 A586-F26 OR-18

L123

L126

NOTE E NOTE E

NOTE E

4 3 1 2 5

188-GH5 WH-16 L98

U-C4 7Y3966 84RE01

WINDOW LIMIT SW 1176306

L107

L126

NOTE E

L119

WH-18 PU-16 PU-16 PU-16

1 188-GH5 WH-16

WK-C1 F-C29 3E3364 1552269 1 684-F130 RD-18 684-WK1 RD-18 2 646-F32 RD-18

A B C

229-F45 BK-14

C569-F97 YL-14 117-GH4 RD-18

112-FC1 PU-4

F-C28 1552267

F-C46 1532602 RE01

ET CONN

L133 T776-GR5 RD-16

L98

18 19 20

DESCRIPTION A/C BLOWER PRODUCT LINK BOOM LAMP A/C CONDENSER FAN CAB LAMP DOME LAMP/MEMORY KEY SW HORN MACHINE ECM ENGINE ECM AUX CKT 2 AUX CKT 3 REFUELING PUMP SPARE SPARE SPARE SPARE 12V POWER SUPPLY PRIMING PUMP SPARE SPARE

F-C47 1532602 RE01

L120

17

AMP 15A 5A 10A 10A 10A 10A 10A 10A 25A 15A 10A 10A 30A 5A 25A 25A 10A 5A 10A 15A 30A

ATCH-12V-7A SOCKET A 1210987 (NOTE T,U)

NOTE E

T776-GR5 RD-16

L120

NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

ATCH-LAMP DELAY TIMER 1636704 (NOTE F) MATE F-C29 RELAY 1 LAMP SW 2 (NOTE F) F-C24 3E3370 +B A GND B KEY OFF C

WH-16

WIPER CONT 1557042

L133

CONN 48

509-AJ4 WH-18 508-AJ7 PU-18 200-AJ2 BK-18

112-FC1 PU-4 RIGHT SIDE

1

U-C3 7Y3967 84RE01 1

L114

103-F7 RD-18 103-F7 RD-18 103-F24 RD-18 103-F27 RD-18 251-F23 YL-18 251-F189 YL-18 251-F147 YL-18 251-F147 YL-18 261-F52 GN-18 261-F152 GN-18 261-F51 GN-18 261-F51 GN-18 308-F144 YL-16 892-F12 BR-18 893-F11 GN-18

NOTE E

L118

WH-16 ATCH-CAB LAMP RH 1673441 RD-16

F-C37 1673630 84RE01 1 103-F96 RD-16 3 200-F162 BK-16 2 4

405-F62 GY-18 412-F2 BU-18 491-F3 PK-18 495-F1 GN-18 496-F5 WH-18 C468-F9 BU-18 403-F115 GN-18 403-F115 GN-18 403-F4 GN-18 403-F76 GN-18

L119

M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 200-F138 BK-16 200-F139 BK-16 200-F140 BK-16

177-FA1 RD-4

112-FC1 PU-4

FUSE INSTRUCTION

L118

L133

AUX CKT 1

L133

LEFT SIDE

L136

152-F59 BU-16 199-F69 OR-18 331-F187 OR-18 603-F133 PK-18 607-F49 PK-18 615-F129 YL-16 645-F88 RD-18 684-F130 RD-18

ATCH-12V-7A SOCKET B 1210987 (NOTE U)

143-J13 BR-18

J-C6 CONN 33 7Y3966 84RE01 1 143-J13 BR-18 F-C55 7Y3967 84RE01

C OFF S ON B ST KEY SWITCH 9G7641

L116

L135

T-C4 7Y3966 84RE01

616-V1 YL-16

V-C2 CONN 55 7Y3967 84RE01

1

T-C3 7Y3967 84RE01 1

200-U2 BK-16

V-C1 CONN 54 7Y3966 84RE01

1

RD-16

(NOTE P)

615-F129 YL-16 615-F129 YL-16 615-F163 YL-16 615-F164 YL-16 200-F161 BK-16 200-F155 BK-16 200-F149 BK-16 200-F149 BK-16 103-F96 RD-16 A584-F169 BU-18 200-F157 BK-18 200-F162 BK-16

NOTE E

L133

L142

188-GH5 WH-16

1

R-C4 7Y3966 84RE01

616-U1 YL-16

U-C2 CONN 53 7Y3967 84RE01

M-C7 7Y3966 84RE01 C566-M22 PK-18

+ -

L135

L138

AUX CKT 3 1 F-C38 7Y3967 84RE01

RELAY SPARE SPACE 2

1 F-C39 7Y3967 84RE01

U-C1 CONN 52 7Y3966 84RE01

1

M-C8 7Y3967 84RE01 C560-M21 OR-18

SPEAKER R 7Y5505

GND-CAB 3

L117

L117

200-F136 BK-18 200-F134 BK-18 200-F123 BK-18 200-F68 BK-14 200-F138 BK-16 200-F139 BK-16 200-F140 BK-16

GH-C2 2434505 84RE01

124-F65 GN-14 169-F175 PK-18 160-F53 PU-16 129-F57 BU-16 179-F56 BU-16 113-F61 OR-18 147-F63 PU-16 123-F64 WH-18 152-F59 BU-16 118-F90 GY-16 127-F60 OR-16 120-F55 YL-16 199-F135 OR-16 180-F54 GN-16 143-F41 BR-18

L145

AUX CKT 2 1 F-C45 7Y3967 84RE01

200-GH3 BK-18 592-GH2 BU-18 A513-GH1 RD-18

177-A71 RD-6

T776-GR5 RD-16

15A 5A 10A 10A 10A 5A 10A 5A 10A 10A 10A 10A 10A 10A 5A 5A 5A 10A 10A 15A

200-T2 BK-16

ATCH-CAB LAMP LH 1673441

R-C3 7Y3967 84RE01 1

200-F168 BK-16

317-F82 YL-18 200-F123 BK-18 147-F14 PU-16 147-F83 PU-16 310-F99 PU-16

RELAY SPARE SPACE 1

T-C2 F-C44 7Y3966 84RE01 7Y3967 84RE01 1 200-F155 BK-16

THROTTLE POS SW 1060107 1 BK COM 2 PK S1 3 BU S2 4 GN S3 5 BR S4 6

L137

L135

105-F102 RD-16 308-F104 YL-16 103-F6 RD-16 105-F77 RD-16 113-F61 OR-18 118-F90 GY-16 123-F64 WH-18 129-F57 BU-16 147-F63 PU-16 147-F83 PU-16

200-F123 BK-18 200-F134 BK-18 200-F136 BK-18

3 2 1

L98

L154

FUSE BASE 2382319 (TAN) (RED) (LIGHT BLUE) (NATURAL) (GREEN)

615-T1 YL-16

CONN 55

IND UNIT 1709324 GND +B

M-C6 1532541 84RE01 113-M13 OR-18 200-M14 BK-18 509-M15 WH-18 C566-M22 PK-18 512-M16 GN-18 607-M17 PK-16 103-M18 RD-16 508-M19 PU-18 C560-M21 OR-18 511-M20 BR-18

+ -

SPEAKER L 7Y5505

L134

123-F64 147-F22 147-F63 147-F83

177-A71 RD-6

326-M23 RD-16 307-M9 OR-16 105-M10 RD-16

200-F116 BK-14

210-F47 BK-14 135-F95 BU-14 229-F45 BK-14 C569-F97 YL-14 105-F40 RD-16 252-F20 YL-18 252-F20 YL-18 252-F190 YL-18 252-F153 YL-18 252-F153 YL-18 262-F19 GN-18 262-F19 GN-18 262-F191 GN-18 262-F150 GN-18 262-F150 GN-18 892-F12 BR-18 892-F98 BR-18 892-F143 BR-18 892-F143 BR-18 893-F11 GN-18 893-F111 GN-18 893-F142 GN-18 893-F142 GN-18 235-F112 BK-18

ATCH-ETHER RELAY 1613128

L106

200-R2 BK-16

T-C1 F-C43 7Y3967 84RE01 7Y3966 84RE01 1 615-F164 YL-16

R

308-M8 YL-16

ACC 1 GND 2 SPKR LH(-) 3 AUX-SPKR(-) 4 SPKR RH(-) 5 ILLUM 6 BACKUP 7 SPKR LH(+) 8 AUX-SPKR(+) 9 SPKR RH(+) 10

F-C34 7Y3955 84RE01 508-F120 PU-18 1 509-F121 WH-18 2 3

H

ATCH-TRAVEL STRAIGHT PRESS. SW 1673466

CONN 54

1

1

199-F69 OR-18 251-F189 YL-18 252-F190 YL-18 261-F52 GN-18 262-F191 GN-18 331-F187 OR-18 430-F33 BU-18 487-F34 OR-18 575-F106 YL-18 576-F107 PK-18 578-F105 BU-16 603-F133 PK-18 607-F49 PK-18 645-F88 RD-18 780-F21 PU-16 780-F21 PU-16 780-F30 PU-18 780-F31 PU-16 892-F12 BR-18 892-F98 BR-18 893-F11 GN-18 893-F111 GN-18 A537-F108 PK-18 C569-F97 YL-14 G976-F36 BU-18

(NOTE AB) REMOVE ESTABLISHED 10A FUSE 1 2 3 4 5

R-C2 F-C42 7Y3966 84RE01 7Y3967 84RE01 1 200-F161 BK-16

ATCH-ANTENNA CABLE 2382260

646-F32 RD-18 105-F40 RD-16 113-F81 OR-18 113-F81 OR-18 113-F101 OR-18 113-F61 OR-18 123-F64 WH-18 129-F57 BU-16 135-F95 BU-14 147-F22 PU-16 147-F63 PU-16 147-F83 PU-16

5A

T776-GR5 RD-16

ATCH-QC HYD LOCK RELAY 1 1495050 (NOTE AC) GT-C4 1495051 84RE02 1 E564-GT13 PK-18 2 200-GT11 BK-18 3 E562-GT16 PU-16 4 5 779-GT5 WH-16

117-GH4 RD-18 T776-GR5 RD-16

L143

139-GH6 OR-16 188-GH5 WH-16

177-A71 RD-6

TRAVEL ALARM RELAY 1613128

147-F58 PU-18 331-F187 OR-18 147-F58 PU-18 147-F14 PU-16 321-F44 BR-18

L144

2 1

177-A71 RD-6

143-J13 BR-18 143-J13 BR-18

1 2 3 4 5

L106

AUX SPKR

308-F104 YL-16 105-F102 RD-16

154-F93 RD-18 199-F69 OR-18 306-F92 GN-16 307-F94 OR-16 310-F99 PU-16 317-F82 YL-18 320-F85 RD-18 321-F44 BR-18 322-F86 GY-16 331-F187 OR-18 603-F133 PK-18 607-F49 PK-18 607-F87 PK-16 615-F129 YL-16 616-F84 BU-16 638-F91 WH-16 645-F88 RD-18 684-F130 RD-18

MATE F-C49 (NOTE AB)

L149 L147

603-F133 PK-18 200-F134 BK-18 199-F69 OR-18 199-F135 OR-16 638-F91 WH-16

L105

1

1

1 2 3 4 5

ATCH-BEACON RELAY 1613128

175-F72 RD-14 172-F10 RD-18 149-F80 RD-16 125-F71 RD-16 115-F78 RD-16 103-F6 RD-16 105-F77 RD-16 114-F79 RD-16 184-F74 RD-14 130-F75 RD-14 141-F16 RD-16 142-F15 RD-16 168-F73 RD-10

15A 5A 10A 10A 10A 10A 10A 10A 25A 15A 10A 10A 30A 5A 25A 25A 10A 10A 15A 30A

306-F92 GN-16

L140

149-F80 RD-16 115-F78 RD-16 114-F79 RD-16 199-F135 OR-16 160-F53 PU-16 147-F83 PU-16

GND-CAB 2

L144

154-F93 RD-18 200-F136 BK-18 307-F94 OR-16

200-F68 BK-14 120-F55 YL-16 124-F65 GN-14 125-F71 RD-16 127-F60 OR-16 130-F75 RD-14 154-F93 RD-18 168-F73 RD-10 169-F18 PK-18 172-F10 RD-18 175-F72 RD-14 179-F56 BU-16 184-F74 RD-14 306-F92 GN-16 307-F94 OR-16 310-F99 PU-16 317-F82 YL-18 320-F85 RD-18 321-F44 BR-18 322-F86 GY-16 607-F87 PK-16 616-F84 BU-16 638-F91 WH-16 A770-F66 PK-18

200-GH7 BK-18

1 2 3 4 5

NEUTRAL START RELAY 1613128

L146

GR-C3 1495051 84RE02 1 A893-GR2 OR-16 2 200-GR4 BK-18 3 T776-GR5 RD-16 4 5 T788-GR3 GN-16

141-2759 113-8490 113-8491 113-8493 124-3548

L143

L145

114-F126 RD-18 320-F85 RD-18 114-F126 RD-18 114-F79 RD-16 322-F86 GY-16

103-F6 RD-16 105-F77 RD-16 125-F71 RD-16 130-F75 RD-14 168-F73 RD-10 172-F10 RD-18 175-F72 RD-14 184-F74 RD-14 114-F79 RD-16 115-F78 RD-16 149-F80 RD-16

FUSE BASE

ATCH-SINGLE RELAY 1495050 RE01 (NOTE G,H) GA-C2 1495051 84RE02 1 K866-GA1 WH-18 2 200-GA2 BK-18 3 147-GA3 PU-16 4 K879-GA4 GN-18 5 K872-GA5 OR-18

5A 10A 15A 25A 30A

169-F175 PK-18 113-F61 OR-18 118-F90 GY-16 120-F55 YL-16 123-F64 WH-18 124-F65 GN-14 127-F60 OR-16 129-F57 BU-16 147-F63 PU-16 152-F59 BU-16 179-F56 BU-16 160-F53 PU-16 199-F135 OR-16

L143

115-F127 RD-18 684-F128 RD-18 115-F127 RD-18 115-F78 RD-16 615-F129 YL-16

1 2 3 4 5

HORN RELAY 1613128

L146

L153

160-F132 PU-18 A623-F131 BU-18 160-F132 PU-18 160-F53 PU-16 607-F49 PK-18 607-F87 PK-16

1 2 3 4 5

CAB LAMP RELAY 1613128

L142

M-C3 1552273 235-M3 BK-18 A755-M4 PK-18 A756-M5 BU-18 A757-M6 GY-18 A758-M7 BR-18

ATCH-AM FM RADIO FOR JPN 2510537 ATCH AM FM RADIO FOR OSJ 2510539 ATCH AM RADIO FOR JPN 2510541

L137

ATCH-HIGH PRESS. SW STEM1 1673466

615-R1 YL-16

CONSOLE(RH)

169-F18 PK-18 A770-F66 PK-18 M744-F195 WH-18 M746-F192 YL-18 M747-F42 BU-18 169-F175 PK-18

+1

TRAVEL R PRESS. SW 1673466

L107

BACKUP EPR VALVE SW 3 1636710 K907-G10 BU-18 1 169-G31 PK-18 6 L969-G12 WH-18 4 A770-G15 PK-18 9 M736-G11 BU-18 7 F889-G16 WH-18 12 L968-G13 OR-18 10 235-G37 BK-18 235-G38 BK-18

235-G38 BK-18 235-G37 BK-18 L968-G13 OR-18 F889-G16 WH-18 M736-G11 BU-18 A770-G15 PK-18 L969-G12 WH-18 169-G31 PK-18 K907-G10 BU-18

M-C2 7Y3952 84RE01 1 607-M1 PK-16 2 200-M2 BK-18

L104

ANTENNA

ATCH-LOWER WIPER MOTOR 1677079 (NOTE S)

A-C35 1552269 1 H474-A147 GN-18 2 235-A149 BK-18

L103

CONN 50

-

A-C13 A-C14 1552269 3E3364 1 1 H473-A38 BR-18 2 2 235-A118 BK-18

ATCH EXCITER COIL 2065208 M-C5 M-C4 (NOTE V) 1552269 3E3364 2 T902-M12 PK-18 2 1 T901-M11 YL-18 1

L104

L107

S

+

TRAVEL L PRESS. SW 1673466

CONN 53

L103

M-C1 1211168 84RE01 T902-M12 PK-18 T901-M11 YL-18 607-M1 PK-16 200-M2 BK-18 235-M3 BK-18 A755-M4 PK-18 A756-M5 BU-18 A757-M6 GY-18 A758-M7 BR-18 308-M8 YL-16 326-M23 RD-16 307-M9 OR-16 105-M10 RD-16 113-M13 OR-18 200-M14 BK-18 509-M15 WH-18 512-M16 GN-18 607-M17 PK-16 103-M18 RD-16 508-M19 PU-18 511-M20 BR-18

3 1 4 2

CONN 52 F-C41 R-C1 7Y3967 84RE01 7Y3966 84RE01 1 615-F163 YL-16

NOTE E

F-C35 7Y3955 84RE01 511-F118 BR-18 1 2 512-F119 GN-18 3

135-F95 BU-14

1 2 3 4 5

CHAS LAMP RELAY 1613128

ATCH-BOOM FLOAT DISABLE RELAY 1495050 RE01 J-C4 1495051 84RE02 1 143-J11 BR-18 2 M743-J12 GN-18 3 143-J11 BR-18 4 143-J13 BR-18 5 M744-J14 WH-18

149-F125 RD-18 645-F88 RD-18 149-F125 RD-18 149-F80 RD-16 616-F84 BU-16

KEY ON GND CAN + CAN COIL SIG COIL RET

A-C8 3E3376

ATCH-JOYSTICK RH 2277616

ATCH-MSS KEYREADER 2180404 (NOTE V) 1 2 3 4 5 6 7 8

3 1 4 2

A-C40 1552269 1 H475-A146 BU-18 2 235-A148 BK-18

SW-COM SW-1 SW-2

ONE TOUCH LOW IDLE SW 2220225

F774-G28 WH-18 F773-G29 OR-18

CONN 47

210-F47 BK-14

1 2 3 4 5

BOOM LAMP RELAY 1613128

A-C7 1552272 576-A40 PK-18 535-A65 BU-16 575-A39 YL-18 200-A110 BK-18

ATCH-MIDIUM PRESS. SW STEM3 1673466

SW-3

1

ATCH-JOYSTICK RH 3 SW 2475185

G-C14 3E3388

G-C13 1027964 84RE01 T902-G53 PK-18 T901-G52 YL-18 607-G30 PK-16 200-G33 BK-18 235-G39 BK-18 A755-G23 PK-18 A756-G24 BU-18 A757-G25 GY-18 A758-G26 BR-18 308-G18 YL-16 326-G54 RD-16 307-G20 OR-16 105-G8 RD-16 113-G44 OR-18 200-G45 BK-18 509-G46 WH-18 512-G47 GN-18 607-G48 PK-16 103-G49 RD-16 508-G50 PU-18 511-G51 BR-18

BACKUP GOV SW 1 1636711 F773-G29 OR-18 3 F774-G28 WH-18

2

998-G14 BR-18

1 2 3 4 5 6 7 8

1

SW-3

1

+B GND PWM OUT

1 2 3 4 5 6

SW-4 SW-COM SW-1 SW-2

1

CONN 47

105-F137 RD-16 308-F104 YL-16 308-F144 YL-16 684-F130 RD-18 200-F138 BK-16 200-F140 BK-16 646-F32 RD-18

FUSE BASE

BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18 BK-18

A-C12 A-C44 1552269 3E3364 1 1 K849-A150 YL-18 2 235-A151 BK-18 2

NOTE E

200-GH7 BK-18

L150

I

A-C25 A-C45 1552269 3E3364 1 K851-A142 BU-18 1 2 235-A144 BK-18 2

OPERATOR STATION

1 2

G-C1 2305008 84RE01 E472-G1 GN-18 E473-G2 GY-18 K843-G3 GN-18 K847-G4 PU-18

L98

252-F190 YL-18 262-F191 GN-18

508-F120 PU-18 509-F121 WH-18 511-F118 BR-18 512-F119 GN-18 200-F116 BK-14 251-F23 YL-18 261-F152 GN-18

495-F1 GN-18 496-F5 WH-18 C468-F9 BU-18

ATCH-12V-7A CONVERTER 1 2341004 (NOTE T,U)

ATCH-AUX PUMP PRESS. SW STEM4 1673466

CAB

ACC DIODE 1974385 RE01

CONN 40

A-C2 2304011 84RE01 F-C53 2434505 84RE01

F-C58 F-C56 2304013 84RE01 2434506 84RE01 M744-F195 WH-18 1 M744-J14 WH-18 M746-F192 YL-18 2 M746-J7 YL-18 M747-F42 BU-18 3 M747-J10 PU-18 J-C5 2304013 84RE01 F-C57 1532602 RE01 1 BACKUP RESISTOR A770-F66 PK-18 1028016 1 169-F18 PK-18 169-F175 PK-18 F-C52 1532602 RE01

L150

200-A110 235-A143 235-A143 235-A144 235-A148 235-A163 235-A163 235-A104 235-A149 235-A132 235-A137 235-A137 235-A132 235-A136 235-A151 235-A162 235-A162 235-A118 235-A152

A-C31 A-C32 1552269 3E3364 1 K852-A105 GN-18 1 2 235-A104 BK-18 2

L80

ATCH-AUX PEDAL LH 2277597

OPERATOR STATION

A-C33 2434507 84RE01 E472-A84 GN-18 E473-A50 GY-18 K843-A57 GN-18 K847-A22 PU-18

252-A49 YL-18 262-A128 GN-18

262-A127 GN-18 262-A121 GN-18 262-A128 GN-18 252-A126 YL-18 252-A120 YL-18 252-A49 YL-18

508-A68 509-A69 511-A66 512-A67 200-A51 251-A47 261-A48

PU-18 WH-18 BR-18 GN-18 BK-14 YL-18 GN-18

495-A54 GN-18 496-A61 WH-18 C468-A62 BU-18

147-A58 PU-16 L973-A161 GN-16 235-A33 BK-18 200-A29 BK-14 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 491-A56 PK-18 147-F22 PU-16 L973-F197 GN-16 235-F114 BK-18 200-F113 BK-14 403-F115 GN-18 405-F62 GY-18 412-F2 BU-18 491-F3 PK-18

1 2 3 4 5 6

A-C5 2434508 1 2 3 4 5 6

84RE01 +12V MEMORY OUT +12V SWITCHED OUT GND (12V) GND (24V) +24V BATTERY IN +24V SWITCHED IN

L98

200-GH7 BK-18

143-J13 BR-18

T776-GR5 RD-16

12

A-C46 1552269

CONN 57

F-C12 7Y3952 84RE01 1 A623-F131 BU-18 2 684-F130 RD-18 684-F128 RD-18

H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 N793-A160 GN-18 N794-A129 GY-18

L119

638-A19 WH-16 200-A53 BK-16

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 200-F68 BK-14 892-F98 BR-18 893-F111 GN-18 103-F70 RD-16 113-F101 OR-18 430-F33 BU-18 487-F34 OR-18 506-F103 PU-18 780-F21 PU-16 A537-F108 PK-18 578-F105 BU-16 535-F117 BU-16 575-F106 YL-18 576-F107 PK-18 G976-F36 BU-18 X738-F35 PK-18 135-F95 BU-14 210-F47 BK-14 C569-F97 YL-14 229-F45 BK-14

A770-F66 PK-18

321-F44 BR-18

317-F82 YL-18

308-F104 YL-16 310-F99 PU-16

PK-16 RD-18 OR-16 GN-16 GN-14 OR-16 RD-14 RD-18 RD-14

616-F84 BU-16 125-F71 RD-16 322-F86 GY-16 120-F55 YL-16 172-F10 RD-18 179-F56 BU-16 638-F91 WH-16 105-F102 RD-16 169-F18 PK-18

L150 LAMP DIODE 1211022 84RE01

ATCH-SMART BOOM DOWN RELAY 1495050 RE01 J-C3 1495051 84RE02 1 M746-J9 YL-18 2 200-J6 BK-18 3 M748-J3 OR-18 4 M747-J10 PU-18 5 M746-J9 YL-18 M746-J8 YL-18

CAB

OPERATOR STATION

L146 L98

L150

ATCH-SMART BOOM UP DOWN RELAY 1495050 RE01 J-C2 1495051 84RE02 1 M745-J2 BU-18 2 200-J5 BK-18 3 M746-J7 YL-18 4 M746-J8 YL-18 5 H792-J1 BR-18

L148

ATCH-QC HYD LOCK ON RELAY 1495050 (NOTE AC) GT-C3 1495051 84RE02 1 E564-GT14 PK-18 2 200-GT10 BK-18 3 A588-GT8 GN-18 4 5 E564-GT14 PK-18 E564-GT15 PK-18 CAB

NOTE E

200-F123 BK-18 200-F136 BK-18 200-F134 BK-18 200-F68 BK-14 200-F138 BK-16 200-F139 BK-16 200-F140 BK-16

L148

L154

ATCH-QC HYD LOCK RELAY 2 1495050 (NOTE AC) GT-C5 1495051 84RE02 1 779-GT6 WH-16 2 200-GT12 BK-18 3 E565-GT20 BU-16 4 5 780-GT1 PU-16

A

A-C11 2434508 1 2 3 4 5 6

ATCH-FOOT SW 2051339

A-C36 A-C37 2397352 84RE01 2472693 84RE01 1 E472-A133 GN-18 1 +8V 2 235-A136 BK-18 2 GND 3 N794-A129 GY-18 3 PWM OUT 4 4 5 5 CALIBRATION 6 6 CALIBRATION

CAB

L142

L148 L147

L149

J-C1 2305008 84RE01 H792-J1 BR-18 M745-J2 BU-18 M748-J3 OR-18 200-J4 BK-18

AMP DESCRIPTION 15A A/C 5A BACKUP 10A CHASSIS LAMP 10A CIGAR LIGHTER 10A 12V-7A CONVERTER 2 5A SW PANEL/RADIO 10A TRAVEL ALARM/ATCH SOL 5A SEAT HEATER 10A LOWER WIPER/WASHER 10A WIPER/WASHER 10A AIR SUSPENSION 10A 12V-7A CONVERTER 1 10A BEACON 10A AUX CKT 1 5A SMART BOOM 5A SPARE 5A SPARE 10A SPARE 10A 12V POWER SUPPLY SW 15A SPARE

C569-A27 YL-16 229-A28 BK-16 200-A112 BK-16 179-A17 BU-16 179-A16 BU-16 179-A64 BU-16 179-A64 BU-16

IMPLEMENT PRESS. SW 1673466

L139

200-J4 BK-18 200-J4 BK-18 200-J5 BK-18 200-J6 BK-18 H792-J1 BR-18 M743-J12 GN-18 M745-J2 BU-18 M748-J3 OR-18 143-J13 BR-18 M744-J14 WH-18 M746-J7 YL-18 M747-J10 PU-18

ATCH-QC HYD LOCK PRIORITY RELAY 1495050 (NOTE AC) GT-C2 1495051 84RE02 1 E562-GT18 PU-16 2 200-GT9 BK-18 3 E564-GT13 PK-18 4 E564-GT15 PK-18 5 A588-GT7 GN-18

NO 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

5

A-C28 A-C48 3E3364 1552269 1 N793-A160 GN-18 1 2 235-A152 BK-18 2

ATCH-JOYSTICK LH 2277617

HORN SW 2220225

L148

ATCH-PRIMING PUMP RELAY 1495050 RE01

OPERATOR STATION

200-A7 BK-14 892-A31 BR-18 893-A32 GN-18 103-A63 RD-16 113-A117 OR-18 430-A42 BU-18 487-A43 OR-18 506-A35 PU-18 780-A83 PU-16 A537-A41 PK-18 578-A34 BU-16 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 G976-A45 BU-18 X738-A44 PK-18 135-A25 BU-16 210-A26 BK-16 C569-A27 YL-16 229-A28 BK-16

A770-A141 PK-18

321-A122 BR-18

317-A59 YL-18

308-A108 YL-16 310-A55 PU-16

616-A13 BU-16 125-A92 RD-16 322-A15 GY-16 120-A1 YL-16 172-A9 RD-18 179-A64 BU-16 638-A19 WH-16 105-A37 RD-16 169-A140 PK-18

607-A21 PK-16 154-A23 RD-18 127-A124 OR-16 306-A20 GN-16 124-A86 GY-14 307-A24 OR-16 175-A87 RD-14 320-A14 RD-18 184-A11 RD-14

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

NOTE E

L147

B

F-C9 1211168 84RE01

L98

L152

D

C

A-C47 1552269

NOTE E

CONN 39

SW-COM SW-1 SW-2 SW-3

1

CAB

M743-J12 GN-18 1 MATE K-C1 2 SH1 I-1 3 4

1

L98

CONN 38

1

1 2 3 4 5 6

L98

L139

L152

CONN 36

+B GND PWM OUT

1 2 3 4 5 6

CONSOLE(RH)

J-C7 J-C8 2434507 84RE01 2305008 84RE01 E472-J15 GN-18 1 E473-J16 GY-18 2 MATE G-C1 K843-J17 GN-18 3 M743-J12 GN-18 4

A-C23 1027964 84RE01

F-C8 1027964 84RE01

F-C7 1288950 84RE01

607-F87 154-F93 127-F60 306-F92 124-F65 307-F94 175-F72 320-F85 184-F74

780-GT1 PU-16 779-GT2 WH-16 A588-GT3 GN-18 200-GT4 BK-18

M743-J12 GN-18 M743-J12 GN-18

CONN 29

130-A10 RD-14

168-A70 RD-10

177-A71 RD-6 177-A71 RD-6

E562-GT16 PU-16 E562-GT18 PU-16 E565-GT20 BU-16

24 Page, Color 2

M743-J12 GN-18

L147

200-GT12 BK-18 200-GT19 BK-18 200-GT11 BK-18 200-GT10 BK-18 200-GT9 BK-18 200-GT12 BK-18

E

CONN 35

F-C6 1027964 84RE01

779-GT2 WH-16 779-GT2 WH-16 779-GT5 WH-16 779-GT6 WH-16 780-GT1 PU-16 A588-GT3 GN-18 A588-GT3 GN-18 A588-GT7 GN-18 A588-GT8 GN-18 200-GT4 BK-18 L153

CONN 34

A-C27 1211168 84RE01

A-C22 1254766 84RE01

130-F75 RD-14

1 MATE GU-C1 2 SH1 H-1 3 4

A-C20 1211168 84RE01

F-C10 1343296 84RE01

GT-C6 2305008 84RE01

CONN 30

RENR9587-05 VOL 2

CONN 32

L148

1 MATE GP-C1 2 SH1 I-1 3 4

L146

GR-C1 2305008 84RE01 326-GR1 RD-16 A893-GR2 OR-16 T788-GR3 GN-16 200-GR4 BK-18

A-C43 1552269 1 H476-A145 WH-18 2 235-A137 BK-18

NOTE E

A-C3 1343295 84RE01

135-A25 BU-16 210-A26 BK-16 200-A111 BK-16 120-A119 YL-16 120-A109 YL-16 120-A1 YL-16 120-A1 YL-16 A-C4 2305010 84RE01

CONN 40

NOTE E

1 2 3 4 5 6

L81

L83

M743-J12 GN-18 NOTE E

SW-3 ATCH-JOYSTICK LH 3 SW 2475185

H-C7 2472693 84RE01

H-C4 7Y3967 84RE01 1 320-H8 RD-18 H-C5 7Y3967 84RE01 1 200-H9 BK-18

L83

NOTE E

168-F73 RD-10

CONN 27

GA-C1 2434508 84RE01 K866-GA1 WH-18 200-GA2 BK-18 147-GA3 PU-16 K872-GA5 OR-18 K879-GA4 GN-18

L84

M743-J12 GN-18

M743-J12 GN-18 L98

L102

A-C10 2305010 84RE01

L88 1 2

L92

M743-J12 GN-18

OPERATOR STATION

1 2 MATE GC-C7 3 SH1 I-1 4 5 6

1 2 3 4

H-C3 2397352 84RE01 E472-H1 GN-18 235-H6 BK-18 E474-H2 OR-18 235-H7 BK-18 K844-H3 GY-18 K848-H4 WH-18

J

L81

789-A158 RD-18 E997-A154 RD-18

MATE A-C33

1

535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 E472-A133 GN-18

F716-AG2 WH-18

L92

CONN 28

200-A53 BK-16

326-GR1 RD-16

OPERATOR STATION

3

L973-A161 GN-16 X738-A44 PK-18 200-A7 BK-14 200-A29 BK-14 200-A51 BK-14 210-A26 BK-16 229-A28 BK-16 235-A33 BK-18

A-C15 2304011 84RE01 AG-C1 2434505 84RE01 SECONDARY SHUTDOWN SW 4D1836 2 1 235-AG1 BK-18

A-C18 2434505 84RE01 A-C17 2304011 84RE01

1

SW-4 SW-COM SW-1 SW-2

CONSOLE(LH)

789-A157 RD-18 789-A123 RD-18 789-A158 RD-18

ATCH-BEACON LAMP

NEUTRAL START LIMIT SW 1114799

1

200-H14 BK-16 A588-H11 GN-18 154-H10 RD-18 189-H12 RD-18 320-H8 RD-18 E472-H1 GN-18 E474-H2 OR-18 K844-H3 GY-18 K848-H4 WH-18 235-H5 BK-18 235-H5 BK-18 235-H6 BK-18 235-H7 BK-18 200-H13 BK-16 200-H13 BK-16 200-H14 BK-16 200-H9 BK-18

CONN 42

OR-18 OR-18 OR-18 OR-18 OR-18

CONN 40

L101

H-C1 2434508 84RE01 320-H8 RD-18 200-H13 BK-16 154-H10 RD-18 189-H12 RD-18 A588-H11 GN-18 127-H15 OR-16

1 2 3 4 5 6

L126

L87 L89

L93

1 + B 2 GND ATCH-AIR SUSPENSION 2405063

L83

789-A157 RD-18 113-A156 OR-18

CONN 31

BREAK POINT 1 SH1 I-4

F

200-A82 BK-16 200-A94 BK-16 200-A102 BK-18 200-A110 BK-18 200-A111 BK-16 200-A112 BK-16

200-A8 BK-14 200-A93 BK-14 200-A53 BK-16 200-A85 BK-16 200-A7 BK-14 200-A29 BK-14 200-A51 BK-14 L93

235-A115 BK-18 F716-A114 WH-18

2 1

G

1 2 3 4 5 6

L969-A89 WH-18 L968-A90 OR-18 998-A138 BR-18 A770-A141 PK-18 F889-A101 WH-18

235-A115 BK-18 F716-A114 WH-18

L97

L97

1 2 3 4 5 6

H-C6 1552267 A 154-H10 RD-18 B A588-H11 GN-18 C 189-H12 RD-18

H-C9 H-C8 2304011 84RE01 2434505 84RE01 1 127-H15 OR-16 2 200-H14 BK-16

H-C2 2305010 84RE01 E472-H1 GN-18 E474-H2 OR-18 K844-H3 GY-18 K848-H4 WH-18 235-H5 BK-18

L115

177-A71 RD-6 306-A20 GN-16 200-A85 BK-16

113-A117 113-A117 113-A155 113-A156 113-A156

L90

L973-A161 GN-16 X738-A44 PK-18 200-A7 BK-14 200-A8 BK-14 200-A29 BK-14 200-A51 BK-14 200-A53 BK-16 200-A93 BK-14 235-A33 BK-18

X738-A44 PK-18 235-A143 BK-18 235-A33 BK-18 235-A115 BK-18 235-A125 BK-18 235-A125 BK-18 235-A76 BK-18 235-A88 BK-18 235-A132 BK-18 235-A113 BK-18 235-A113 BK-18

L89

103-A63 RD-16 105-A37 RD-16 113-A117 OR-18 120-A1 YL-16 127-A124 OR-16 135-A25 BU-16 154-A23 RD-18 169-A140 PK-18 179-A64 BU-16 252-A126 YL-18 262-A127 GN-18 307-A24 OR-16 308-A139 YL-16 320-A14 RD-18 508-A68 PU-18 509-A69 WH-18 511-A66 BR-18 512-A67 GN-18 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 607-A95 PK-16 607-A103 PK-16 A537-A41 PK-18 A770-A141 PK-18 C569-A27 YL-16 210-A26 BK-16 229-A28 BK-16

K843-A57 GN-18 K844-A46 GY-18 K847-A22 PU-18 K848-A36 WH-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 K906-A73 GN-18 K907-A74 BU-18 L968-A90 OR-18 L969-A89 WH-18 L972-A96 BU-18 L973-A161 GN-16 N793-A160 GN-18 N794-A129 GY-18

NOTE E

A-C6 2304009 84RE01 124-A86 GY-14 200-A8 BK-14 175-A87 RD-14 E554-A4 PK-18 607-A91 PK-16 200-A93 BK-14 514-A5 PU-16 C506-A6 WH-16 125-A92 RD-16

1 2 3 4 5 6 7 8 9 10 11 12

B/R B/W R R/G P B R/W O/G R/L

200-A93 BK-14 200-A8 BK-14 E554-A4 PK-18 C506-A6 WH-16 514-A5 PU-16 124-A86 GY-14 125-A92 RD-16 175-A87 RD-14 607-A91 PK-16

A-C41 CONN 26 2434510 84RE01 MATE C-C4 SH1 J-1 1 K906-A73 GN-18 2 K907-A74 BU-18 3 A768-A77 BU-18 4 A769-A78 GY-18 5 L969-A89 WH-18 6 L968-A90 OR-18 7 F889-A101 WH-18 8 F773-A106 OR-18 9 F774-A107 WH-18 10 998-A138 BR-18 11 12

130-A10 RD-14 147-A58 PU-16 168-A70 RD-10 172-A9 RD-18 177-A71 RD-6 184-A11 RD-14 251-A47 YL-18 252-A120 YL-18 261-A48 GN-18 262-A121 GN-18 306-A20 GN-16 308-A80 YL-16 310-A55 PU-16 317-A59 YL-18 321-A122 BR-18 322-A15 GY-16 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 495-A54 GN-18 496-A61 WH-18 506-A35 PU-18 514-A5 PU-16 578-A34 BU-16 607-A81 PK-16 616-A13 BU-16 780-A83 PU-16 892-A31 BR-18 893-A32 GN-18 C468-A62 BU-18 C506-A6 WH-16 E554-A4 PK-18 G976-A45 BU-18

514-A5 PU-16 C506-A6 WH-16 E554-A4 PK-18 200-A8 BK-14 200-A93 BK-14

252-A120 YL-18 262-A121 GN-18

A C UNIT 2299080

L973-A161 GN-16 X738-A44 PK-18 200-A7 BK-14 200-A29 BK-14 200-A51 BK-14 200-A53 BK-16 235-A33 BK-18

CONN 25 A-C1 2304009 84RE01 E474-A79 OR-18 K844-A46 GY-18 K848-A36 WH-18 E473-A50 GY-18 K843-A57 GN-18 K847-A22 PU-18 N793-A160 GN-18 N794-A129 GY-18

L88

A-C19 2305010 84RE01 320-A14 RD-18 200-A82 BK-16 154-A23 RD-18 789-A123 RD-18 A588-A12 GN-18 127-A124 OR-16

L81

200-A110 BK-18 235-A132 BK-18 235-A143 BK-18 235-A137 BK-18 120-A1 YL-16 135-A25 BU-16 179-A64 BU-16 C569-A27 YL-16 200-A111 BK-16 200-A112 BK-16 210-A26 BK-16 229-A28 BK-16 235-A137 BK-18 103-A63 RD-16 105-A37 RD-16 169-A140 PK-18 307-A24 OR-16 308-A139 YL-16 326-A159 RD-16 508-A68 PU-18 509-A69 WH-18 511-A66 BR-18 512-A67 GN-18 607-A95 PK-16 607-A103 PK-16 998-A138 BR-18 A537-A41 PK-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 A768-A77 BU-18 A769-A78 GY-18 A770-A141 PK-18 E472-A84 GN-18 E473-A50 GY-18 F773-A106 OR-18 F774-A107 WH-18 F889-A101 WH-18 H476-A145 WH-18 K843-A57 GN-18 K847-A22 PU-18 K906-A73 GN-18 K907-A74 BU-18 L968-A90 OR-18 L969-A89 WH-18 L972-A96 BU-18 200-A94 BK-16 200-A102 BK-18 235-A88 BK-18 252-A126 YL-18 262-A127 GN-18

L85

A-C30 2434508 84RE01 E472-A72 GN-18 E474-A79 OR-18 K844-A46 GY-18 K848-A36 WH-18 235-A76 BK-18

L82

L82

E472-A133 GN-18 H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 N793-A160 GN-18 N794-A129 GY-18

235-A76 BK-18 235-A88 BK-18 235-A132 BK-18 235-A143 BK-18 326-A159 RD-16 103-A63 RD-16 105-A37 RD-16 113-A117 OR-18 120-A1 YL-16 127-A124 OR-16 135-A25 BU-16 154-A23 RD-18 169-A140 PK-18 179-A64 BU-16 252-A126 YL-18 262-A127 GN-18 307-A24 OR-16 308-A139 YL-16 320-A14 RD-18 508-A68 PU-18 509-A69 WH-18 511-A66 BR-18 512-A67 GN-18 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 607-A95 PK-16 607-A103 PK-16 A537-A41 PK-18 A770-A141 PK-18 C569-A27 YL-16 210-A26 BK-16 229-A28 BK-16

CONN 37

GR-C2 A-C50 A-C49 2434505 84RE01 2434505 84RE01 2304011 84RE01 1 326-A159 RD-16 1 326-GR1 RD-16 2 2

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17

H

1 MATE C-C3 2 SH1 J-1 3 4 5 6 7 8 9 10 11 12

L87

235-A76 BK-18 235-A88 BK-18 235-A132 BK-18 235-A143 BK-18

E472-A72 GN-18 E472-A84 GN-18 E472-A116 GN-18 E472-A116 GN-18 E473-A50 GY-18 E474-A79 OR-18 E554-A4 PK-18 E997-A154 RD-18 F716-A114 WH-18 F773-A106 OR-18 F774-A107 WH-18 F889-A101 WH-18 G976-A45 BU-18 H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 H476-A145 WH-18

NOTE E

L87

2

CONSOLE(LH)

CONN 41

L91

A-C29 1343296 84RE01 MATE C-C2 SH1 J-1 1 168-A70 RD-10

NOTE E

GND-PLATFORM

L91

CONN 24

L96

E472-A133 GN-18 E473-A50 GY-18 E474-A79 OR-18 E997-A154 RD-18 F773-A106 OR-18 F774-A107 WH-18 F889-A101 WH-18 H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 H476-A145 WH-18 K843-A57 GN-18 K844-A46 GY-18 K847-A22 PU-18 K848-A36 WH-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 K906-A73 GN-18 K907-A74 BU-18 L968-A90 OR-18 L969-A89 WH-18 L972-A96 BU-18 N793-A160 GN-18 N794-A129 GY-18

L94

L90

317-A59 YL-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 F716-A114 WH-18 495-A54 GN-18 496-A61 WH-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 C468-A62 BU-18 E472-A116 GN-18 H476-A145 WH-18 H473-A38 BR-18 G976-A45 BU-18 L972-A96 BU-18 H474-A147 GN-18 H475-A146 BU-18 K849-A150 YL-18 E997-A154 RD-18 K851-A142 BU-18 K852-A105 GN-18 X738-A44 PK-18 321-A122 BR-18 235-A125 BK-18 235-A113 BK-18 235-A143 BK-18 310-A55 PU-16 506-A35 PU-18 578-A34 BU-16 893-A32 GN-18 892-A31 BR-18 251-A47 YL-18 261-A48 GN-18

200-A85 BK-16 130-A10 RD-14 147-A58 PU-16 168-A70 RD-10 172-A9 RD-18 177-A71 RD-6 184-A11 RD-14 251-A47 YL-18 252-A120 YL-18 261-A48 GN-18 262-A121 GN-18 306-A20 GN-16 308-A80 YL-16 310-A55 PU-16 317-A59 YL-18 321-A122 BR-18 322-A15 GY-16 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 495-A54 GN-18 496-A61 WH-18 506-A35 PU-18 514-A5 PU-16 578-A34 BU-16 607-A81 PK-16 616-A13 BU-16 780-A83 PU-16 892-A31 BR-18 893-A32 GN-18 998-A138 BR-18 A588-A12 GN-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 A768-A77 BU-18 A769-A78 GY-18 C468-A62 BU-18 C506-A6 WH-16 E472-A133 GN-18

127-A124 OR-16 154-A23 RD-18 320-A14 RD-18 A588-A12 GN-18 E472-A72 GN-18 E474-A79 OR-18 K844-A46 GY-18 K848-A36 WH-18 200-A82 BK-16 235-A76 BK-18 789-A123 RD-18 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18

E473-A50 GY-18 E474-A79 OR-18 E997-A154 RD-18 F773-A106 OR-18 F774-A107 WH-18 F889-A101 WH-18 H473-A38 BR-18 H474-A147 GN-18 H475-A146 BU-18 H476-A145 WH-18 K843-A57 GN-18 K844-A46 GY-18 K847-A22 PU-18 K848-A36 WH-18 K849-A150 YL-18 K851-A142 BU-18 K852-A105 GN-18 K906-A73 GN-18 K907-A74 BU-18 L968-A90 OR-18 L969-A89 WH-18 L972-A96 BU-18 N793-A160 GN-18 N794-A129 GY-18

L87

130-A10 RD-14 147-A58 PU-16 168-A70 RD-10 172-A9 RD-18 177-A71 RD-6 184-A11 RD-14 251-A47 YL-18 252-A120 YL-18 261-A48 GN-18 262-A121 GN-18 306-A20 GN-16 308-A80 YL-16 310-A55 PU-16 317-A59 YL-18 321-A122 BR-18 322-A15 GY-16 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 495-A54 GN-18 496-A61 WH-18 506-A35 PU-18 578-A34 BU-16 607-A81 PK-16 616-A13 BU-16 780-A83 PU-16 892-A31 BR-18 893-A32 GN-18 C468-A62 BU-18 G976-A45 BU-18

308-A80 YL-16 184-A11 RD-14 322-A15 GY-16 607-A81 PK-16 780-A83 PU-16 616-A13 BU-16 147-A58 PU-16 E554-A4 PK-18 514-A5 PU-16 C506-A6 WH-16 403-A52 GN-18

103-A63 RD-16 105-A37 RD-16 113-A117 OR-18 120-A1 YL-16 124-A86 GY-14 125-A92 RD-16 127-A124 OR-16 130-A10 RD-14 135-A25 BU-16 147-A58 PU-16 154-A23 RD-18 168-A70 RD-10 169-A140 PK-18 172-A9 RD-18 175-A87 RD-14 177-A71 RD-6 179-A64 BU-16 184-A11 RD-14 251-A47 YL-18 252-A120 YL-18 252-A126 YL-18 261-A48 GN-18 262-A121 GN-18 262-A127 GN-18 306-A20 GN-16 307-A24 OR-16 308-A80 YL-16 308-A139 YL-16 308-A108 YL-16 308-A108 YL-16 310-A55 PU-16 317-A59 YL-18 320-A14 RD-18 321-A122 BR-18 322-A15 GY-16 403-A52 GN-18 405-A75 GY-18 412-A60 BU-18 430-A42 BU-18 487-A43 OR-18 491-A56 PK-18 495-A54 GN-18 496-A61 WH-18 506-A35 PU-18 508-A68 PU-18 509-A69 WH-18 511-A66 BR-18 512-A67 GN-18 535-A65 BU-16 575-A39 YL-18 576-A40 PK-18 578-A34 BU-16 607-A81 PK-16 607-A95 PK-16 607-A103 PK-16 607-A91 PK-16 607-A21 PK-16 607-A21 PK-16 616-A13 BU-16 780-A83 PU-16 892-A31 BR-18 893-A32 GN-18 A537-A41 PK-18 A770-A141 PK-18 C468-A62 BU-18 C569-A27 YL-16 G976-A45 BU-18

I

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 MATE C-C124 SH1 L-1 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54

998-A138 BR-18 A588-A12 GN-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 A768-A77 BU-18 A769-A78 GY-18 E472-A72 GN-18 E472-A84 GN-18

200-A7 BK-14 200-A8 BK-14 200-A29 BK-14 200-A51 BK-14 200-A53 BK-16 200-A93 BK-14 200-A85 BK-16

326-GR1 RD-16

CONN 23

A-C16 1532620 84RE01 130-A10 RD-14 172-A9 RD-18 L973-A161 GN-16 A588-A12 GN-18

OPERATOR STATION L95

GND-FR 7

200-A82 BK-16 200-A94 BK-16 200-A102 BK-18 200-A110 BK-18 200-A111 BK-16 200-A112 BK-16 998-A138 BR-18 A588-A12 GN-18 A755-A100 PK-18 A756-A99 BU-18 A757-A98 GY-18 A758-A97 BR-18 A768-A77 BU-18 A769-A78 GY-18 E472-A72 GN-18 E472-A84 GN-18 E472-A133 GN-18

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21

J

L95

L95

L95

3

L126

PA STRAP PLATF-FRAME GND 7G1060

4

OPERATOR STATION

4 3 1 2 5

PA STRAP PLATF-FRAME GND 7G1060

L86

5

L100

L86

6

L98

9

OPERATOR STATION

L81

10

L84

11

L84

12

A

Diagrama Electrico 330 - 336d Excavadora Caterpillar

Recommend Documents