CELCOM KV MODERNIZATION
FLEXI GSM/UMTS SITE SURVEY CHECKLIST B00715 / G17401 KM410LBRIGN_HOT & (KPG BSC1) (N6)
SITE CATEGORY Check Applicable Boxes: A: NEW SITE
B: INDOOR SITE
C: OUTDOOR SITE
D: SWAP SITE
E: IN-BUILDING Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 1 of 33
CELCOM KV MODERNIZATION
TABLE OF CONTENTS 1
SITE IDENTIFICATION INFORMATION -1.1 Access Route To Site -1.2 Access To The Site And Delivery Procedure -1.3 Site Access -1.4 POC (Point Of Contact) Information
2
SITE TYPE -2 Site Type
3
SITE DESIGN SURVEY -3.1 Proposed Type Of BTS Equipment -3.2 Swap Site Specification -3.3 General Specification -3.4 Site Environment Photos -3.5 Proposed Equipment Location -3.6 RF Cable & Jumper -3.7 Existing 2G and 3G Equipment List
4
ANTENNA DETAILS -4.1 Existing Antenna Photos
5
POWER -5.1 AC & DC And Grounding
6
TRANSMISSION AND ALARM
7
CIVIL AND STRUCTURE WORK
8
VANDALISM
9
MODE OF DISMANTLING (DECOMM) EXISTING 2G EQUIPMENT
10
SITE MATERIAL LIST
11
SUMMARY SCOPE OF WORK (CELCOM)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 2 of 33
CELCOM KV MODERNIZATION
1. SITE IDENTIFICATION INFORMATION Customer Name:
CELCOM
Complete Site Address:
Location ID:
B00715
KM410 BERINGIN HOT
2G Site ID/Name:
G17401 KM410LBRIGN_HOT
LEMBAH BERINGIN,
3G Site ID/Name:
1.1
NORTH SOUTH HIGHWAY,
BSC ID:
KPG BSC 1
Site Survey Date:
18 / 05 / 2012
SELANGOR.
Access Route To Site Building:
Shop-lot:
Latitude/Longitude:
Greenfield: N 3.5752
Monopole:
Tower:
Ramo
E 101.5250
REMARKS (please indicate exact equipment location (i.e. inside MDF room etc.), exact door/entrance/stairs/lift etc. to take):
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 3 of 33
CELCOM KV MODERNIZATION
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 4 of 33
CELCOM KV MODERNIZATION
1.2
ACCESS TO THE SITE AND DELIVERY PROCEDURE Check one of the following, adding explanations where needed on the selection line and in the notes section: Freight Elevator:
Passenger Elevator:
Stairs:
Manpower requirement: 4 Persons Boom Truck Required:
45 Ton Crane Required:
Other Delivery Requirements:
1.3
Sky-lift Required:
Lorry & Hand Carry
SITE ACCESS See Customer guidelines and Customer site access data for use of keys, combination, access, special access instructions, and site entry notification requirements. Is the site always staffed with security personnel?
Yes
No
Is the site fenced?
Yes
No
Keys Required?
Yes
No
Access Letter Required?
Yes
No
Other:
Record advance notification requirements to gain access to the site (if any) and list any permit requirements or local codes that will impact the installation project. Also, indicate who the actual owner is and any special instruction to enter and if work permit is needed. Then, please get all the necessary forms and ask for detailed procedures and check if other requirements are necessary such as CDIB, NIOSH and IRATEC.
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 5 of 33
CELCOM KV MODERNIZATION
1.4
POC (POINT OF CONTACT) INFORMATION For shelter/site access if not at location (Collect business card if available and verify, through contact, that the contact name is correct): Contact Name:
FOD JAMALI
Contact Title and Company:
CELCOM (M) BHD CMX7
Contact Address:
Lot 4465/51 Office JL.2/62, Bandar Manjalara, 52100 Kepong Kuala Lumpur.
Contact Phone Number:
019-2710341
Does this POC represent the site owner?
Yes
No
Notes on site identification information:
2. SITE TYPE Check the following site type descriptions that apply, adding explanations where needed on the selection line and in the notes section: Ground Shelter Ground (Outdoor) Micro Cell Caged Type Pole Mount Rooftop (Outdoor) Rooftop Shelter Tower Site Wall Mount Other: Room Reno
Is the site co-located?
Yes
No
If the site is co-located, with whom (other operator – please take photos and include all information such as Maxis LRD no. etc.)? MAXIS
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 6 of 33
CELCOM KV MODERNIZATION
3.
SITE DESIGN SURVEY SWAP TYPE: NORMAL HOT SWAP COLD SWAP Mark up a Customer provided site design or develop a site sketch illustrating the following details. Check off each detail that has been sketched.
3.1
PROPOSED TYPE OF BTS EQUIPMENT Check all that apply, adding explanations where needed on the selection line and in the notes section: Flexi GSM/WCDMA BTS - Pole/Tower Flexi GSM/WCDMA BTS – Wall Flexi GSM/WCDMA BTS – Indoor stacked on Floor Flexi GSM/WCDMA BTS – Outdoor stacked on floor /I-Beam
3.2
3.3
SWAP SITE SPECIFICATIONS What type of mounting platform will be used (concrete, raised floor, plinth etc.)?
CABIN FLOOR
Any possible location of temporary installation before swap?
YES
NO
GENERAL SPECIFICATIONS Check one of the following, adding explanations where needed on the selection line and in the notes section: BTS Inside Equipment Room BTS Inside Equipment Room w/Tower BTS Inside Mfg. Shelter (Ground) BTS Inside Mfg. Shelter (Rooftop) BTS Inside (Water Tower) BTS Outdoor Pad BTS Outdoor Platform BTS Outdoor Rooftop BTS Outdoor (Water Tower) Roof-Mounted Antenna Utility Pole (outdoor platform or pad) Utility Pole (with shelter) Other:
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 7 of 33
CELCOM KV MODERNIZATION
3.4 SITE ENVIRONMENT PHOTOS (take as many photos as you can from every possible angles for all elements to avoid re-visit for survey)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 8 of 33
CELCOM KV MODERNIZATION
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 9 of 33
CELCOM KV MODERNIZATION
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 10 of 33
CELCOM KV MODERNIZATION
3.5
PROPOSED EQUIPMENT LOCATION (please indicate in photos the following)
Propose new caging Proposed New Rectifier
Proposed 2G Node-B
1. Proposed 2G Node-B & New Rectifier
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 11 of 33
CELCOM KV MODERNIZATION
3.6 RF CABLE & JUMPER Check the Existing RF Jumper cable is connected to the right sector and mark the RF Jumper cable as per Sector for Site preparation purposes. Any other risk on installing new Jumper cables to the new Flexi WCDMA BTS?
Yes
Length of the jumper cable (Existing) Node-B
2mtrs
Length of the jumper cable (Proposed) Node-B
3mtrs
Length of the jumper cable (Existing) Antenna
5mtrs
Length of the jumper cable (Proposed) Antenna
10mtrs
No
1. Existing 2G BTS jumper Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 12 of 33
CELCOM KV MODERNIZATION
2. Existing 2G Feeder route
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 13 of 33
CELCOM KV MODERNIZATION
3.7 EXISTING 2G AND 3G EQUIPMENT LIST Existing Equipment:
Frequency:
MetroSite50 Outdoor
GSM900
Supreme Outdoor
GSM1800
Optima Compact Outdoor
W900
Indoor Supreme
W2100
Flexi Rel 1.0/2.0
GSM900 (E//))
Ericsson (E//)
GSM1800 (E//)
Indoor: Outdoor:
2202 2102
2206+BOC 2106
2216+BOC
2106i
2308
2308
3. EXISTING 2G AND 3G
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 14 of 33
CELCOM KV MODERNIZATION
Existing Configuration G900 ERICSSON INDOOR G900 ERICSSON OUTDOOR G1800 ERICSSON INDOOR G1800 ERICSSON OUTDOOR G900 ERICSSON MICRO G188 ERICSSON MICRO G900 DBS NSN Node‐B G900 MACRO NSN Node‐B W900 DBS NSN Node‐B W900 MACRO NSN Node‐B W2100 DBS NSN Node‐B W2100 MACRO NSN Node‐B
Proposed Configuration G1800 Micro RRH G1800 DBS RFM G1800 DBS RFM ‐ 2 RFM FXEA G1800 Macro RFM G1800 W900 Macro RFM G1800 W900 Micro RRH G900 W900 DBS RFM G900 G1800 W900 DBS RFM G900 G1800 W900 DBS RFM ‐ 2 RFM FXDA G900 G1800 W900 DBS RFM ‐ Change RFM FXEA to RRH FHEA G900 G1800 W900 Macro RFM G900 W900 DBS RFM W2100 G900 W900 DBS RFM ‐ 2 RFM FXDA G900 W900 DBS RRH G900 W900 Macro RFM G900 W900 Micro RRH Special configuration A Special configuration B
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Tick if applicable 9 Tick if applicable 9
Date: 18/5/2012
Page: Page 15 of 33
CELCOM KV MODERNIZATION
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 16 of 33
CELCOM KV MODERNIZATION
4
ANTENNA DETAILS Tick if using Remote Electrical Tilting (RET) GSM900
Height (m)
Azimuth
MHA/TMA (Y/N)
EMP (Y/N)
Brand
Type (VPole or X-Pole)
Ant Band (Single/Dual/ Tri-Band)
Freq (900/180 0/2100)
ETilt
MTilt
Feeder Type
Feeder Length (m)
Sector 1
55m
80
N/A
N/A
Abcom
V-POLE
SINGLEBAND
900
7/8”
75m
Sector 2
55m
200
N/A
N/A
Abcom
V-POLE
SINGLEBAND
900
7/8”
75m
340
N/A
N/A
Abcom
V-POLE
SINGLEBAND
900
7/8”
75m
Brand
Type (VPole or X-Pole)
Ant Band (Single/Dual/ Tri-Band)
Freq (900/180 0/2100)
ETilt
MTilt
Feeder Type
Feeder Length (m)
Brand
Type (VPole or X-Pole)
Freq (900/1800/ 2100)
ETilt
MTilt
Feeder Type
Feeder Length (m)
Brand
Type (VPole or X-Pole)
Freq (900/180 0/ 2100)
ETilt
MTilt
Feeder Type
Feeder Length (m)
Sector 3
55m
Tick if using Remote Electrical Tilting (RET) GSM1800
Height (m)
Azimuth
MHA/TMA (Y/N)
EMP (Y/N)
Sector 1 Sector 2 Sector 3
Tick if using Remote Electrical Tilting (RET) WCDMA 900
Height (m)
Azimuth
MHA/TMA (Y/N)
EMP (Y/N)
Ant Band (Single/Dual/ Tri-Band)
Sector 1 Sector 2 Sector 3
Tick if using Remote Electrical Tilting (RET) WCDMA 2100
Height (m)
Azimuth
MHA/TMA (Y/N)
EMP (Y/N)
Ant Band (Single/Dual/ Tri-Band)
Sector 1 Sector 2 Sector 3
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 17 of 33
CELCOM KV MODERNIZATION
4.1 Existing Antenna Photos
1. 2G 900 Sector 1 at 80°
2. 2G 900 Sector 2 at 200°
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 18 of 33
CELCOM KV MODERNIZATION
3. 2G 900 Sector 3 at 340°
4. 2G 900 Antenna Type
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 19 of 33
CELCOM KV MODERNIZATION
1. PROPOSED NEW MGB AT LOCATION
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 20 of 33
CELCOM KV MODERNIZATION
2 G 900 Antennas
2. Proposed RFM Location (FEEDERLES TYPE)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 21 of 33
CELCOM KV MODERNIZATION
2 G 900 Antennas
3. Swap V-Pole To X-Pole Antenna
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 22 of 33
CELCOM KV MODERNIZATION
5.
POWER
5.1 AC AND DC POWER & GROUNDING Capture all available MCB breakers Capture the existing DC MCB of 2G and 3G equipment Capture photos of all AC breakers Capture the existing ACPDB photos Capture existing Rectifier photos Capture Earth/Bus Bar location
AC
Breaker (Amps)
AC Cable Length
GNDG Cable Length
Existing
20A X 3
7m
7m
Proposed
32A X 3
15m
15m
DC Cable Length
GNDG Cable Length
DC (2G)
Breaker (Amps)
Existing
Proposed
63A X 1
15m
15m
DC (3G)
Breaker (Amps)
DC Cable Length
GNDG Cable Length
Existing
Proposed
Rectifier Type
No. Of Modules
No. Of Battery Banks
DELTA
2
2
Rectifier Type
No. Of Modules
No. Of Battery Banks
Additional Remarks:
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 23 of 33
CELCOM KV MODERNIZATION
Proposed New 32A x 3pcs AC Breaker
1. Existing ACPDB
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 24 of 33
CELCOM KV MODERNIZATION
6.
TRANSMISSION AND ALARM Take detailed photos of location and how many inside E// or TOC and trace link from where to where. As for external alarm, please take all photos of the DDF/Yellow Box so we can see clearly the color-coding. Transmission (please attach photos) Location (inside rectifier, TOC, 19" Rack or 2G BTS) Interface (75 ohm or 120 ohm) Existing Quantity Length from 2G BTS to DDF Length from 3G NB to DDF
E1 2G BTS 120 ohm 1 15m 2pcs Siemen Balun
Proposed No. Of Balun Required (Specify exact type)
FE
N/A N/A
N/A
Existing N/A
Proposed
Red Phase
N/A
Yellow Phase
N/A
Blue Phase
N/A
CPS/AC Failure
N/A
Rectifier Failure
N/A
Intruder/Door
N/A
CO2
N/A
Caging Vibration
N/A
Compressor 1 Failure
N/A
Compressor 2 Failure
N/A
External Alarm (Please tick & attach photos) Termination Location (Please specify)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 25 of 33
CELCOM KV MODERNIZATION
1. Existing transmission for 2G
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 26 of 33
CELCOM KV MODERNIZATION
7.
CIVIL WORK AND STRUCTURAL WORK CME Required (Please tick) None MGB/Bus‐bar Modify I‐Beam New AC Breaker New Boom & Bracket New Horizontal Cable Ladder New Plinth New Vertical Cable Ladder Open Cover of Trunk (for feeder line) Open Lock Bar Open Roof Open Shelter Remove I‐Beam Add cable ladder for RRH Inlet for DC & Fiber Cable
Please tick 9 9 9 9
1. Proposed New MGB at Tower Site Name: KM410LBRIGN_HOT
Site ID: G17401
2. Proposed New MGB at Plinth Date: 18/5/2012
Page: Page 27 of 33
CELCOM KV MODERNIZATION
3. Open Cover of Trunk (for feeder line) Steel Cage
Remarks
1. Existing Flexi cage already at site? (Y/N)
NA
1a. If yes, please indicate which version 1b. If no, is there space for additional Flexi cage (850mmx850mmx2100mm inclusive of allowance to open the roof)?
NA
2. Stacking more than 6 modules is not recommended, is a 2nd Flexi cage required? (Y/N) 2a. If 2nd stacking required, is there space for additional Flexi cage (850mmx850mmx2100mm inclusive of allowance to open the roof)? 2b. If no please explain:
NA NA NA NA
3. Existing rectifier cage or lock bar already at site (if existing is damaged then choose N)? (Y/N) 3a. If no, is the space enough for rectifier cage (1100mmx1100mmx2200mm including 1m allowance to open the back/front doors)?
NA
3b. If yes, should we replace with new or maintain the existing? 3bi. If we replace, is the space enough for rectifier cage (1100mmx1100mmx2200mm including 1m allowance to open the back/front doors)? 4. If your response for 1. and 3. are no (no space), can we propose one big cage for both rectifier and Flexi (1100mx2100mmx2200mm)? (Y/N) 4a. If yes, is the space enough for rectifier cage (1100mmx1100mmx2200mm including 1m allowance to open the back/front doors)?
NA
4b. If no, is a special design required? (Y/N)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
NA
NA NA NA NA
Date: 18/5/2012
Page: Page 28 of 33
CELCOM KV MODERNIZATION
8.
VANDALISM Vandalism (please attach photos) None Air‐Cond./Compressor stolen Battery missing BTS/NB stolen Caging vandalized Door vandalized Earth/Bus‐bar missing Feeder/Jumper/Cable vandalized Fence cut GNDG missing Lock‐bar vandalized Padlock vandalized Rectifier stolen Sub‐DB vandalized Others:________________________
1. MGB at Tower Missing
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Please tick 9
2. MGB at Plinth Missing
Date: 18/5/2012
Page: Page 29 of 33
CELCOM KV MODERNIZATION
9.
MODE OF DISMANTLING (DECOMM) OF EXISTING 2G EQUIPMENT Freight Elevator:
Passenger Elevator:
Stairs:
Manpower requirement (please specify): Lorry Crane Required:
5 Persons
45 Ton Crane Required:
Sky-lift Required:
LORRY CRANE
9.1
TRAFFIC MANAGEMENT Traffic Management Requirement Specify if Traffic Management Requirements? Also Record Persons or Company in Charge
1
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Please tick
Proposed Lorry Crane
Date: 18/5/2012
Page: Page 30 of 33
CELCOM KV MODERNIZATION
11.
SITE MATERIAL LIST
No
Item code
Description
Qty
Remarks
1
CS80016.09
M10 Bolt Set (SS)
2
CS80016.09
M10 Anchor Bolt Set (GI)
3
CS80604.97
Cable Lug ‐ 25mm2 single hole with M8x30mm bolt‐1pc & nut‐1pc & M8 flat washer ‐ 1pcs
4
CS80016.15
Cable Lug ‐ 16mm2 single hole with M6x 30mm bolt & M6 nut‐1pc & M6 washer‐1pc
5
CS80016.21
Cable lug cap 25 mm2 Green
6
CS81016.21
Cable lug cap 16 mm2 blue
7
CS82016.21
Cable lug cap 16 mm2 Red
8
CS80016.23
PVC Cable Ties ‐ Black with UV Protection 12" x 4.8mm (W)
300
9
CS80009.60
Cable lable (set) plastic (NodeB Site) ‐ Indoor
1 set
10
CS80016.07
RJ45 Connector Shielded
2 pcs
11
CS80016.08
Rubber Boot for RJ45 Plug (Black)
2 pcs
12
CS80025.13
25mm2 Grounding Cable Green (IV)
15 m
13
CS80011.97
16mm2 Power Cable Blue
15 m
14
CS80011.68
16mm2 Power Cable Black
15 m
15
CS72311.52
Jumper 3,0m 1/2"s 7/16ma‐7/16m
5 m
16
CS80016.25
PVC Cable Ties ‐ Black with UV Protection 15" x 7.6mm (W)
100
17
CS80016.28
Electrical Tape (Black) ‐ 3M Scotch Super 33+ (19mm x 20,1m x 0,177)
6
18
CS80016.29
3M Scotch 23, Rubber Splicing Tape
6
19
CS80014.19
Marker Tie PLM 1M‐M
20
CS73339.11
Insulation Tape 15 x 10m Y/G
6
21
CS73339.02
Self Amalgamating Tape 25 x 10m
6
22
CS80010.45
Bracket
23
CS73339.20
Insulation Tape 19 x 18m Black
6
24
CS73320.08
Cable Tie 7.68 x 390 Black UV
25
CS82016.20
Cable lug cap 6 mm2 Red
26
CS83016.20
Cable lug cap 6 mm2 Yellow
27
CS81016.20
Cable lug cap 6 mm2 Blue
28
CS80016.20
Cable lug cap 6 mm2 Green
29
CS84016.20
Cable lug cap 6 mm2 Black
30
CS80016.06
8 pair 120ohm cable (Southern Cable)
31
CS80051.58
6mm2 x 5 Core AC Power Cable (Red, Yellow, Blue, Green, Black) (Non Armoured Cable)
32
CS80031.63
Double Clamp for 1 x 18mm Dia 2 Core DC Cable + 7 mm Dia Optical Cable, rubber cushion for optical cable
33
DC cable 2x1 16mmsq
34
NSN: CONNECTOR 7‐16 DIN (F) STRAIGHT FOR 1/2" CABLE Hiflex/SuperFlex
35
NSN: Connector N (M) for ½” Feeder Cable Superflex
36
NSN" Feeder ½” Cable Hiflex/Superflex
37
CONNECTOR 7‐16 DIN (M) STRAIGHT FOR 1/2"
38
7‐16 DIN Connector male, right angle for RF 1/2" superflex.
39
HYBRID Coulper (4port) N –type 3dB
40
Dummy load 100 watt,N‐type male, 50ohms ‐ 50 watt T‐50‐NM‐S
41
1.6/5.6 Male to 3 Pole IDC Balun (Brand:AC&E)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 32 of 33
CELCOM KV MODERNIZATION
42
NSN: BNC (M) to 3‐pole IDC Balun
43
1.6/5.6 R/A female clamp for 2.5C2V cable (Brand: Vael)
44
BNC ST/FEMALE Crimp 2.5c2v
12.
SUMMARY SCOPE OF WORK (CELCOM)
Site Name: KM410LBRIGN_HOT
Site ID: G17401
Date: 18/5/2012
Page: Page 33 of 33