A380-LEVEL I - ATA 50 Cargo _ Accessory Compartments

A380 TECHNICAL TRAINING MANUAL MANUAL MAINTENANCE COURSE - T1 & T2 (RR / Metric) LEVEL I - ATA 50 Cargo & Accessory Compartments

This document must be used for training purposes only

Under no circumstances should this document be used as a reference

It will not be updated.

All rights reserved No part of this manual may be reproduced in any form, by photostat, microfilm, retrieval system, or any other means, without the prior written permission of AIRBUS S.A.S.

A380 TECHNICAL TRAINING MANUAL

LEVEL I - AT ATA 50 CARGO & ACCESSORY COMPARTMENTS COMPARTMENTS Cargo Cargo & Accessory Accessory Compartments Compartments Introduction . . . . . . . . . . . . . . . . 2 Cargo Cargo Compartments Compartments Presentation Presentation . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Cargo Cargo Loading System Presentation Presentation . . . . . . . . . . . . . . . . . . . . . . . . . 12

0 T 0 T D 0 L 2 8 0 6 0 Y 0 L

MAINTENANCE COURSE - T1 & T2 (RR / Metric) LEVEL I - ATA ATA 50 Cargo & Accessory Compartments

TABLE OF CONTENTS

Mar 21, 2006 Page 1


CARGO & ACCESSORY ACCESSORY COMP COM PARTMENTS INTRODUCTION General The cargo and accessory compartments deal with: - The cargo compartments, - The cargo loading system, - The accessory compartments.

1 0 0 0 0 0 0 0 0 1 Z 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L


CARGO CA RGO & AC ACCE CESS SSOR ORY Y COMP COMPAR ARTM TMEN ENTS TS INT INTR RODU ODUCT CTION ION

Marr 15 Ma 15,, 2006 2006 Page 2


1 0 0 0 0 0 0 0 0 1 Z 0 5 M L 0 T 0 T D 0 L 2 8 0 6

GENERAL 0 Y 0 L



Marr 15 Ma 15,, 2006 2006 Page 3


CARGO & ACCESSORY ACCESSORY COMP COM PARTMENTS INTRODUCTION Accessory Compartments The avionics equipment is installed in two compartments: - The main avionics compartment located in the forward section of the fuselage, below the cockpit and the flight crew rest area, - The upper avionics compartment located behind the crew rest area, at the level of the upper deck. The main avionics compartment contains the normal electrical power center and most of the systems computers; it is accessible: - From the cockpit, through a hatch. The upper avionics compartment contains the emergency emergency electrical power center, some ultimate emergency equipment and most of the In-Flight Entertainment (IFE) equipment; it is accessi ble through a door, from the upper deck cabin.

1 0 0 0 0 0 0 0 0 1 Z 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L



Marr 15 Ma 15,, 2006 2006 Page 4


1 0 0 0 0 0 0 0 0 1 Z 0 5 M L 0 T 0 T D 0 L 2 8 0 6

ACCESSORY COMPARTMENTS 0 Y 0 L



Marr 15 Ma 15,, 2006 2006 Page 5


CARGO COMPARTMENTS PRESENTATION General The aircraft has three lower deck cargo compartments in the lower part of the fuselage. They are: - The forward cargo compartment, - The aft cargo compartment, - The bulk cargo compartment. The forward and aft cargo compartments are equipped with an independent operated semi-automatic Cargo Loading System (CLS) and can accommodate cargo in containers or on pallets. The bulk cargo compartment is designed for transportation of bulk cargo, passenger luggage and live animals. Access to the forward, aft and bulk cargo compartments is gained through doors located on the right hand side of the fuselage. Two hydraulically operated outwards opening doors give access to the forward and aft cargo compartments. The bulk cargo has one manually operated door, which opens inwards. The three compartments have bilge drains.

1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L


CARGO COMPARTMENTS PRESENTATION

Mar 15, 2006 Page 6


1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6

GENERAL 0 Y 0 L



Mar 15, 2006 Page 7


CARGO COMPARTMENTS PRESENTATION Cargo Compartments Interior And Lining The inside of the cargo compartments has: - Floor panels, - Ceiling panels, - Side linings, - Partition walls. All the linings and panels are sealed to give a fully sealed compartment for fire containment and extinguishing. Rapid decompression panels are installed flush in the sidewall linings to prevent damage from differential pressure. In case of decompression in the cabin or in the cargo compartment, they equalize the pressure in both sections, to avoid damage to the structure. Access panels are installed for the maintenance of components located behind the linings. The bulk cargo compartment has nets to separate the bulk and the aft compartments.

1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L



Mar 15, 2006 Page 8


1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 6

0

8

CARGO COMPARTMENTS COMPARTMENTS INTERIOR AND LINING 0

Y

0 L



Mar 15, 2006 Page 9


CARGO COMPARTMENTS PRESENTATION Cargo Compartments Capacity The standard configuration embodies a "block" arrangement of Unit Load Devices (ULDs) providing for 20 x LD3 containers or a combination of 7 x 88" or 96" x 125" pallets in the FWD Cargo Compartment, and 16 x LD3 containers or a combination of 6 x LD3 containers and 3 x 88" or 96" x 125" pallets in the AFT Cargo Compartment. As an option, a Pallet Turning Turning Unit capability can be installed. 3 additional 88" or 96" x 125" pallets can then be arranged lengthwise in the tunnel area of the AFT cargo compartment, in lieu of the 6 LD3 containers. The bulk cargo compartment can only be loaded with bulk and loose baggage. The usable volume of the bulk cargo compartment is 14.3 m 3 (505 ft3) and the maximum load capacity is about 2541 kg (5602 lb). A divider net separates the bulk cargo compartment from the aft cargo compartment.

1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L



Mar 15, 2006 Page 10


1 0 0 0 0 0 0 0 0 1 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6

CARGO COMPARTMENTS CAPACITY 0 Y 0 L



Mar 15, 2006 Page 11


CARGO LOADING SYSTEM PRESENTA PRESENTATION TION General Both the forward and aft cargo compartments have an independent semi-automatic Cargo Loading System (CLS), electrically powered and controlled from an Outside Control Panel (OCP) and an Inside Control Panel (ICP) with joysticks.

1 0 0 0 0 0 0 0 0 2 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L


CARGO LOADING SYSTEM PRESENTATION

Mar 15, 20 2006 Page 12


1 0 0 0 0 0 0 0 0 2 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6

GENERAL 0 Y 0 L



Mar 15, 20 2006 Page 13


CARGO LOADING SYSTEM PRESENTA PRESENTATION TION Cargo Loading System

5

0

P

2

0

0

0

0

0

0

0

0

1

One person, through inside and outside control panels can operate the CLS. The semi-automatic cargo loading systems of the forward and the aft lower deck cargo compartments are similar in construction and work independently. The CLS has: - Inside and outside control panels, - A power switch, - A compartment Control Box (CCB), - Sector Control Boxes (SCB), - Power Drive Units (PDUs), - Proximity switches located on different latches, - Mechanical components as: latches, guides, rollers, ball units. The CLS works only if the power switch is set to ON, the aircraft power is available and the manual door sill latches are down. The control panels send electrical signals through the CCB and SCB to the applicable PDU. The PDUs move the Unit Load Devices (ULDs) in the necessary direction and to their loading position. When the ULD is in the correct loading position, you must lock the latch manually. manually. The locked latches electrically isolate the related PDU. The CLS is connected to the aircraft Onboard Maint enance System (OMS) to report system/component failures. If there is no electrical power available, it is possible to load or unload the cargo compartments manuall y. M L 0 T 0 T D 0 L 2 8 0 6 0 Y 0 L



Mar 15, 20 2006 Page 14


1 0 0 0 0 0 0 0 0 2 P 0 5 M L 0 T 0 T D 0 L 2 8 0 6

CARGO LOADING SYSTEM 0 Y 0 L



Mar 15, 20 2006 Page 15

AIRBUS S.A.S. 31707 BLAGNAC cedex, FRANCE STM REFERENCE L0Y06082 MARCH 2006 PRINTED IN FRANCE AIRBUS S.A.S. 2006 ALL RIGHTS RESERVED AN EADS JOINT COMPANY WITH BAE SYSTEMS

A380-LEVEL I - ATA 50 Cargo _ Accessory Compartments

Recommend Documents