sony_playstation_3_bdpt1001_bpx2001_sm-bdd-0013e-01_[ET]

SM-BDD-0013E-01 BDPT-1001 BPX-2001 BD DRIVE SERVICE MANUAL 1st edition

CS Department

Reproduction Prohibited

SAFETY CHECK-OUT

SPECIAL COMPONENT NOTICE CAUTION

After correcting the original service problem, perform the following safety checks before releasing the set to the customer: 1. Check the area of your repair for unsoldered or poorly soldered connections. Check the entire board surface for solder splashes and bridges. 2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors. 3. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. 4. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement. 5. Check the power cable for cracks and abrasion. Recommend the replacement of any such power cable to the customer. 6.ChecktheB+voltagetoseeitisatthevalues 6.ChecktheB+voltagetoseei tisatthevaluesspecifed. specifed. 7. Check the metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.

Ensure that this product is disconnected from the power plug before the laser protective housing is removed.

LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers.). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)

CLASS 1M LASER RADIATION WHEN OPEN DO NOT VIEW DIRECTLY WITH OPTICAL INSTRUMENTS.

This label is located on the BD/DVD/CD Drive laser protective housing inside the enclosure. BD/DVD/CD drive rear-side view

CAUTION:

To Exposed Metal Parts on Set

The use of optical instruments with this product will increase eye hazard.

here

CAUTION Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.

0.15 F

1.5 k 

AC voltmeter (0.75 V)

WARNING!! WHEN SERVICING, DO NOT APPROACH THE LASER EXIT WITH THE EYE TOO CLOSELY. IN CASE IT IS NECESSARY TO CONFIRM LASER BEAM EMISSION, BE SURE TO OBSERVE FROM A DISTANCE OF MORE THAN 25 cm FROM THE SURFACE OF THE OBJECTIVE LENS ON THE OPTICAL PICK-UP BLOCK.

Earth Ground

Fig. A. Using an AC voltmeter to check AC leakage.

SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY. 0

CAUTION Risk of Explosion if Battery is replaced by an Incorrect Type. Dispose of Used Batteries According to the Instructions.

Lithium Batteries If an equipment is provided with a replaceable lithium battery, the following applies: – if the battery is placed in an OPERATOR ACCESS AREA, there shall be a warning close to the battery or in both the operating and the service instructions: – if the battery is placed elsewhere in the equipment, there shall be a warning close to the battery or in the service instructions.

The components identified by mark contain confidential information. Strictly follow the instructions whenever the components are repaired and/or replaced.


TABLE OF CONTENTS 1. CIRCUIT DIAGRAM

3. EXPLODED VIEWS

1-1. 1-2. 1-3. 1-4. 1-5. 1-6. 1-7. 1-8. 1-9.

3-1. 3-2. 3-3. 3-4. 3-5. 3-6.

BL1-001 Board .............................................1-2 BL2-001 Board .............................................1-2 BMD-001 Board (1/4) ..................................1-3 BMD-001 Board (2/4) ..................................1-4 BMD-001 Board (3/4) ..................................1-5 BMD-001 Board (4/4) ..................................1-6 BMD-002 Board (1/3) ..................................1-7 BMD-002 Board (2/3) ..................................1-8 BMD-002 Board (3/3) ..................................1-9

2. PRINTED WIRING BOARDS 2-1. 2-2. 2-3. 2-4. 2-5. 2-6.

BL1-001 Board .............................................2-1 BL2-001 Board .............................................2-1 BMD-001 Board (Side A) ............................2-2 BMD-001 Board (Side B) ............................2-3 BMD-002 Board (Side A) ............................2-4 BMD-002 Board (Side B) ............................2-5

Loading Complete Assy Section ..................3-1 Loading Block Assy Section ........................3-2 Base Frame Complete Assy Section............. 3-3 Top Frame Complete Assy Section .............. 3-4 Front Arm Assy Section................................3-5 Optical Pick-up Section ................................ 3-6

4. ELECTRICAL PARTS LIST BL1-001 Board .............................................4-1 BL2-001 Board .............................................4-1 BMD-001 Board ...........................................4-1 BMD-002 Board ...........................................4-4


SECTION 1 CIRCUIT DIAGRAM

Note on Schematic Diagram: • All capacitors are in m F unless otherwise noted. pF: mm F 50 WV or less are not indicated except for electrolytics and tantalums. • All resistors are in W and 1 / 4 W or less unless otherwise specied. • % : indicates tolerance. Note: The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specied.

Note: Les composants identiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécié.

Reproduction Prohibited 1-1. BL1-001 BOARD

1-2. BL2-001 BOARD

BL1-001 BOARD CN100

R101

JL100

R104

BL2-001 BOARD

R110

R108 C103

C100 R100

R102

C105 R105

1 0 1 C

R103

SE101

2 0 1 C

R106 C106

SE100 R112

R200

R113 CN200

JL200

IC100 C107

JL201

D200

R114

S100

S101

CN101

S102

Q101

Q100

R109

JL101 C104 R107

R111

Reproduction Prohibited 1-3. BMD-001 BOARD (1/4)

BMD-001 BOARD (1/4) 0 1 2 6 6 6 1 1 1 L L L C C C

R212

R206

R215

C266

5 7 9 5 5 5 1 1 1 L L L C C C

5 6 7 2 2 2 6 6 6 R R R

5 6 6 6 1 1 L L C J

3 6 1 L C

8 9 0 5 6 6 6 7 7 7 1 1 1 1 1 L L L L L 9 8 7 6 5 C C C J J 0 0 0 0 0 1 1 1 1 1 R R R R R

7 8 9 7 7 7 1 1 1 L L L 8 1 C C J 2 C

C203

R213

R202

R203

C207

C265 C264

C197

7 6 1 L C

C222

C263

C262 C261 C260

C187

C259 C186

C270

C185

R114

CL183

C184

CL182

CL112 R239

CL111

R238 R113

CL110

R237

C183

R236

CL109 C101

R235

L100

R129

C182

C233

R226 C189

R234

C107

C109

Q507

C223 C181 C226

C111

R229

IC110

R228

IC110

C225

R111

C224

C178

C102 R103

Q508

CL151

C108

C231

FL104

R227

C110

C232

R240 R230

8 8 1 C

R127 R133

C180

R112

R288 R124

R119

L103

CL150 CL149

R118 R126

R289

C238 CL148

R139

C228 R290

C179

R110

C193

C114

R291

C192 C191 R278

C227 R292

C190

R277

R293

CL100 R104 CN103

Q104

6 9 1 C

FL103

9 9 1 C

C200

6 5 1 L C

4 5 1 L C

C209

C206

5 7 6 6 2 2 R R

5 1 2 C

9 8 9 9 2 2 R R

7 6 9 9 2 2 R R

4 9 2 R

5 9 2 R

5 6 3 3 1 1 R R

C213

C217

R243

R244

C106

C105

R245

C104

R246

C103 D101

R214 C255

R204 C257

C256 CN101

1 2 2 C

9 1 2 C

8 2 4 5 6 6 1 1 1 L L J L J J

C269

CN102

8 9 0 6 6 7 2 2 2 R R R

7 1 2 R

C258

R260

C254

D100

C126 C243

JL110 CL106

R258

R272

CL105

C245

R271

R273

CL104

R218

CL103

Q103

R219

CL102

R199 C120

C251 R201 CL101

R134

C118

R711

Q102

Q109

JL109

R259

CL128 R125

JL108

R141

R128

R147

JL133

R132

R138

R131

C116 R140

R130 C122 C127

IC103

CN104 Q107

C121 IC103

X101

IC101

R150

R193 R137

R600 C237

R231

C124

IC108

CL140 R601

R162

C117

L101

CL138 CL137 C274

C136

CL135

C156

IC108

CL136

C175 R232

R224

R211

CN100

4 5 6 3 4 3 3 7 2 2 2 2 C C C C

R102

Q105

Q106

C159

C135

4 2 3 3 5 5 2 2 2 C C C

C194 R210

R242

C134 C154 R163

R249

R187

C133

R209

R101

CL144

R251

R223

C157 R606

C115

CL143

C158

C195

C119

R607

C176 C155

CL142

C198

CL117 CL146

C141 CL116

R602

CL145

CL184

R222

CL152 CL186

C161

R281

C139 R181

R121

R605

R100 CL113

R180

C162

R233

C113

R241 R603

CL187

CL185 2 8 2 R

C239 R122

C250

CL153

R250

C140 CL115

3 8 2 R

4 8 2 R

C241 C240

5 8 2 R

C242

R171

CL114 C144

The components identied by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specied.

Les composants identiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécié.


R441

9 0 1 2 3 4 5 6 7 3 4 4 4 4 4 4 5 5 3 3 3 3 3 3 3 3 3 L L L L L L L L L C C C C C C C C C

3 4 0 0 3 3 L L C C

9 0 1 0 1 1 3 3 3 R R R

BMD-001 BOARD (2/4)

C383 R453 R454

R331

IC310

9 4 7 6 3 3 R C

C324

C306

IC310 R451

8 0 1 3 5 6 6 6 3 3 3 3 L L L L C C C C

C379 R450 C343

R333

IC304

R449

IC308

R335 R443

R346 C342

C346 C397

R341 R308

IC314

C345 R344

C337

R396 C400 R307

R304 R303

C395

IC300

CL319

R398

R811

C396

IC300

CL318 CL317

R302 CL316 5 0 4 L C

6 8 3 C

CL314 CL313

3 6 7 5 3 3 R R

CL312

7 8 3 C

CL315 CL310

R410

C341

CL321

R306 CL320 R305

X301

0 9 3 R

3 9 3 R

0 0 4 R

2 3 4 0 0 0 4 4 4 R R R

R445

CL327

R446

CL328

R447

CL329

R448

CL330

R803

C403 C404

R320

C405 C406

6 7 8 9 0 1 2 0 0 0 0 1 1 1 4 4 4 4 4 4 4 L L L L L L L C C C C C C C

CL441

CL311 C457

R301 C301

C458

CL429

CN300

CL428 R414

CL427

C300

CN301

R416

CL426 CL425 R463

CL424 CL423

2 2 3 L C

3 4 5 2 2 2 3 3 3 L L L C C C

4 6 3 2 4 3 L L C C

5 3 4 L C

4 0 3 C

5 3 3 L C 2 3 0 0 3 3 L C C

2 1 3 R

0 1 3 C

9 0 3 C

8 0 3 C

6 2 3 R 1 1 3 C

5 1 3 R

3 2 1 1 3 3 C C

CL422

6 2 3 C

CL421 CL420

9 9 3 C

CL419 4 1 3 C

2 1 2 2 3 3 C C

3 2 3 C

CL418 CL417 CL416 CL415

R388

CL414

R387 R300

CL413

R386

IC300 IC300

R452 4 8 3 R

4 3 3 C

5 0 4 R

7 6 3 L C 2 6 3 L C

4 5 6 6 3 3 L L C C

5 0 3 L C

6 3 3 C

1 0 2 3 4 4 7 7 7 C 3 3 3 L L L C C C

8 9 6 6 3 3 L L C C

7 3 3 R

9 3 3 R

0 9 3 L C

1 7 3 L C

R424 CL437 CL438

1 2 0 0 3 3 L L C C

2 3 4 R

R423

2 0 4 C

6 5 7 7 3 3 L L C C

4 4 4 R 8 3 0 3 4 4 R R

0 3 4 7 0 9 8 8 8 7 3 7 3 3 3 3 4 3 L L L L L L C C C C C C 0 6

6 8 3 L C

R425

CL439 CL440

R366

R426

RB307 C376

2 8 3 L C

3 R

R427 1 2 7 8 0 2 2 2 2 3 3 3 3 3 3 R R R R R

C375

RB306 R430 R419

C374

R431 R470

C373 R323

R420

RB305

R325 R421

C372 D300

D301

R378

R324 CL354

R422 R415

C370

R376

CL353

R471

R418

CL436

CL443

R374 CL442

CL431 CL432

IC300

CL346

R372 R371

IC300

R370

R439

R369

R440

R368

R412 CL392

1 0 4 R

CL402

R417 RB304

CL450 CL400 CL399 CL398

R367

R458

CL300

C450

IC309

R434

R459

FB301

R406 C369 CL397 C368 CL396 C367 CL395 C366

C319 C318 C317

R460

C451 C452

IC309

S300

C320

C316

CL445 CL444

R375

CL352 R397 CL351 R411 CL350 R336 CL349 R399 CL348 R409 CL347

Q300

C371

R377

R461

C453 RB301

RB303

C454

R462

C456 C460 C392

RB312

C455

C315 C382

C391

RB300

RB302

R464 R465

7 2 3 C

R352

8 0 1 2 3 5 2 3 3 3 3 3 3 3 3 3 3 3 C C C C C C

0 4 4 4 3 3 C C

C307

RB308

RB309

R351 CL306

IC301

C305

2 4 3 R

8 9 0 1 4 4 5 5 3 3 3 3 C C C C

5 3 4 R

6 7 8 3 3 3 4 4 4 R R R

8 0 1 2 3 5 5 6 6 6 6 6 3 3 3 3 3 3 C C C C C C

C352

5 7 4 4 3 3 R R 2 9 3 R

9 8 3 R

1 9 3 R

R442

R429

R413

7 9 0 1 2 3 5 5 8 8 8 8 3 3 3 3 3 3 R R R R R R

C381

C390 C389

3 5 7 8 3 3 8 8 8 9 4 3 3 3 3 L L L L L C C C C C

3 4 6 7 5 5 5 5 3 3 3 3 C C C C

R472 C377 C461

9 8 3 L C

CL370 C339

R343

R355

R313

R364

R362

R349 R348

R350

8 3 3 R

0 4 3 R

R365 R363 R358

R332

R329

C359

C329

C325

3 0 3 C I

C380 R361

R354 C355

CL359 CL378

IC303




BMD-001 BOARD (3/4)

R524

0 1 4 4 5 5 L L J J

L507

JL500 JL501

FB527

C650 CN502

C610

JL502

FB528

JL503 JL504

C651

L506

JL505 JL506 L511

JL507

JL542

JL538

JL543

JL539

JL508 JL509

C613

L510

JL510 C612

C611 R907

IC509

C507

IC503

R503

L509

L508

Q500

IC503 L514

R502

IC509

R555 R508 R500

L500

C506

1 0 5 D

C505

R511

R514

R509

C503

C504

C516

FB499

C514

R529

R515

R554

ET501

Q506

ET502 R518

R509

IC506

Q502 L503

L505

R510 IC508

IC507

ET503

IC508

Q501

R906

IC506

ET504 R523

R556

C523

R522 C605

C606

C607

C608

C609

C616

IC507

C652

C501

C500

R521

ET506 C649

C614

C615

D502

R552

R

C508

CL521

IC500

R516

R512

R546 CL519

IC500

C510

CL518

S500 0 0 5 D

C512

R498

R547

FL500

IC501

FL501 CL520

IC501

R513 FL502

FL503 C509

7 9 1 3 5 7 3 3 4 4 4 4 5 5 5 5 5 5 C C C C C C

1 3 5 7 9 1 3 5 7 9 1 3 5 7 9 1 5 5 5 5 5 6 6 6 6 6 7 7 7 7 7 8 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 C C C C C C C C C C C C C C C C

R504

R505 IC502

C513 C535 R507

C603

C534

C602

C533 R548

C601

C532

C600

C531

C599

C530

C598

C529

C597

C528

C596

C527

C595 C594

C515

IC300

C593

IC505

IC300

C592 IC300

C591

IC300

C590 C589 C604 C588 C587 C586 C585 C584 C583

4 8 1 4 7 9 1 3 5 7 1 1 2 2 2 2 3 3 3 3 5 5 5 5 5 5 5 5 5 5 L L L L L L L L L L J J J J J J J J J J 0 2 4 6 8 0 7 7 7 7 7 8 5 5 5 5 5 5 C C C C C C

6 8 0 2 4 6 8 9 0 2 4 6 8 0 2 4 6 8 3 3 4 4 4 4 4 4 5 5 5 5 5 6 6 6 6 6 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 C C C C C C C C C C C C C C C C C C

3 7 0 3 6 8 0 2 4 6 1 1 2 2 2 2 3 3 3 3 5 5 5 5 5 5 5 5 5 5 L L L L L L L L L L J J J J J J J J J J

2 6 9 2 5 1 1 1 2 2 5 5 5 5 5 L L L L L J J J J J

1 5 1 1 5 5 L L J J

C648 ET507

R520 C619

3 5 5

ET505

L504 FB557

C618


BMD-001 BOARD (4/4)

7 4 6 C

R517

7 1 6 C

R519

0 9 1 2 3 2 6 6 6 C C C

0 1 4 4 6 6 C C

2 2 6 C

3 2 6 C

4 2 6 C

5 2 6 C

C626 C638 C627

R540

C645

R539 R538

R544

R537 R536 C646

R535 R534 R533

C642

IC504

R532

R545

IC504 C637

C636

C628 CL536

CL532 C629

R531

R541

R530

R542

C635

CL538 CL533

R543

CL534

CL537

CL535

1 0 9 5 5 4 5 5 5 R R R

2 2 5 L C

3 4 5 2 2 2 5 5 5 L L L C C C 4 3 3 3 6 6 C C

6 7 8 2 2 2 5 5 5 L L L C C C 4 4 6

C

3 4 6 C

9 0 1 2 3 3 5 5 5 L L L 2 1 C C C 3 3 6 6 C C

0 3 6 C


BMD-002 BOARD (1/3)

0 1 2 6 6 6 1 1 1 L L L C C C

R212

R206

5 7 9 5 5 5 1 1 1 L L L C C C

7 8 9 4 4 4 1 1 1 R R R

5 6 6 6 1 1 L L C C

3 6 1 L C

8 9 6 6 1 1 L L C C

0 5 6 7 7 7 9 8 7 6 5 1 1 1 0 0 0 0 0 L L L 1 1 1 1 1 J J R R R R R C 7 8 9 7 7 7 1 1 1 L L L C C J

C266

R 21 5

C203

R 21 3

R202

R203

C207

C265 C264

C197

8 1 2 C

7 6 1 L C

C222

C263

C262 C261 C260

C187

C259 C270

C186

R114

C185 CL183

C184

CL182

CL112 R239

CL111

R238 R 1 3

CL110

R 1 5 1

C183

R237 R236

CL109 L100

C101

C182

R235

C233

R129 R226 C107

R234

C189

C109

Q110

C223 C181 C226

C111

IC110

R229

C225

IC110

R228

C224

R111

C178

C102 R103 C108

Q111

C231

FL104

R227

C110

C232

R240 R230

8 8 1 C

R127 R133

R152

CL151

R112

C180 R288

R124

R119

L103

CL150

R118

R289

CL149 C238 R126

CL148

R139

C228 R290

C179

R110

C193 R291

C192 R125

R153

C191

R278

C227 R292

C190

R277 CL100

R293 R104

CN103 R120

R154 Q104

R156

R155

6 9 1 C

FL103

9 9 1 C

C200

Q112

4 6 5 5 1 1 L L C C

C209

C206

IC111 8 5 1 L J

5 7 6 6 2 2 R R

5 1 2 C

9 8 9 9 2 2 R R

7 6 9 9 2 2 R R

5 9 2 R

C217

2 4 6 6 1 1 L L J J

4 9 2 R

6 5 3 3 1 1 R R

C213

9 1 2 C

1 2 2 C

C269

CN102 R243

C106

R244

C105

R245

C104

R246

C103 R260 R214 R204

C255

C257

C256

8 9 0 6 6 7 2 2 2 R R R

C258

D101

CN101

D100

C126

R217

CL191

C243

CL192 CL106

R258

R272

CL105

C245

R271

R273

CL104

R218

CL103

R201

Q103

R219

CL102 C251

R199

CL101 JL109

Q109

R150

Q102 R259

JL108

IC103 CN104

IC103

Q107

R140 C237

R231

IC108 CL140

R141 C117 R162

L101

CL138

R158

CL137

R157 C136

C244

C274

C156

IC108

CL136

C175 R232

CL135

R224

R211

CN100

5 6 3 3 3 7 2 2 2 C C C

R102

Q106

Q105

C135

4 2 3 3 5 5 2 2 2 C C C

CL188

C159

C194 R210

C134 C154

R242

R249

R187

R163

R209

C133

R101

CL189

R223

CL144

R251

C157 C115

CL143 R145 C195

C119

CL142

C176

R146

C198

CL117 CL146

C141 C158 C155

CL116

R142

R250

CL145

CL115

C161

R281

R181 R180 R144

CL113 C113

R171

R222

CL152

R241 R143

CL187

CL185 2 8 2 R

C239 R122

C250 CL114

CL184

C162 R233

C139 R121

R100

CL190

CL153

CL186

C140

3 8 2 R

4 8 2 R

C241 C240

5 8 2 R

C242


C144



BMD-002 BOARD (2/3)

R441 R474

3 4 0 1 2 0 0 6 6 6 3 3 4 4 4 L L L L L C C C C C

9 0 1 0 1 1 3 3 3 R R R

1 2 3 4 4 4 3 3 3 L L L C C C

R331

R453

C383

IC310

R485

IC310

9 7 4 3 6 R 3 C

R449

RB317

R451

8 0 1 3 5 6 6 6 3 3 3 3 L L L L C C C C

6 7 6 5 5 1 6 6 0 1 3 4 4 3 3 C C C C C

C343

R333

R335

IC304

R346 IC304

C342 C346 C464

C337

R308

R344 X301

C463

C395

C341

R396

R398 CL321

R302

C400

R307

CL320

R306

CL319

IC300

R305

CL318

IC300

R304

CL317

R303

CL316

C396

3 6 7 5 3 3 R R

6 8 3 C

R443

5 0 4 L

C

CL314 CL313

C462

CL312 3 9 3 R

CL315

CL311 C457

0 2 3 4 0 0 0 0 4 4 4 4 R R R R

8 9 5 5 4 4 L L C C

6 7 8 9 0 1 2 0 0 0 0 1 1 1 4 4 4 4 4 4 4 L L L L L L L C C C C C C C

CL441

CL310 R301 CL322 CL323 C458 CN300

CL324

CL429

CL325

CL428 CL427 CL426

CN301

R416

CL425 R463

CL424 CL423 CL422 4 6 5 3 2 3 4 3 4 L L L C C C

5 3 3 L C 2 3 0 0 3 3 C C

0 1 3 C

4 0 3 C

2 2 7 1 4 3 R R

6 0 3 C

8 9 0 0 3 3 C C

6 2 3 R

3 5 7 1 4 3 R R

1 1 3 C

3 2 1 1 3 3 C C

CL421

2 2 1 3 2 C 3 C

4 1 3 C

3 2 3 C

6 2 3 C

5 9 6 9 4 3 C C

CL420 CL419 CL418 CL417 CL416 CL415

R388

CL414

R387

CL413

R386

R300

IC300 IC300 R452 4 8 3 R

4 3 3 C

7 6 3 L C 2 4 5 6 6 6 3 3 3 L L L C C C

5 0 3 L C

6 3 3 C

1 0 2 3 4 4 7 7 7 C 3 3 3 L L L C C C

8 9 6 6 3 3 L L C C

7 3 3 R

9 3 3 R

0 1 9 7 3 3 L L C C

2 3 4 R

R423

R424

2 0 4 C

CL437

R487

CL438

R425

R486

CL439

1 2 0 0 3 3 L L C C

4 7 4 7 4 3 R 8 L 0 0 C 3 5 6 3 4 4 7 7 R L 3 3 3 4 C L L R C C

0 3 4 8 8 8 3 3 3 9 L L L 7 C C C 3 L C 0 6 3 R

6 8 3 L C

R366

CL440

2 8 3 L C

R426

RB307

R488

R427

1 2 7 8 0 8 9 2 2 2 2 3 7 8 3 3 3 3 3 4 4 R R R R R R R

C375

RB306 R430

C374

R419 R431

R323

RB305

R325

R420 R470 R421

C372 D300

D301

R476

C371

CL354

R378

C370

CL353

R377

R324

R411 R336 R439 R440

R399 R409

R422

R415 CL445 CL444

R418

R376

CL352 R397

Q300

R471

CL443

R375 CL351

CL436

R374

CL442 R412

CL350 CL431

CL349 CL348 CL347

IC300

CL346

R417

CL432 CL392 R372

IC300

R371

CL402

RB313

RB314

RB1 35

1 9 0 7 4 4 R R

RB1 36

RB304 0 1 2 3 4 8 8 8 8 8 4 4 4 4 4 R R R R R

CL450

R370

CL300

R369

CL453

R368

CL454

R367

CL400 CL399

R458

CL398 C450 R459 R406

IC309

R434

CL455 CL456

R460

C451 C452

FB301

R461

C453

C369 CL397 C368 CL396 C367 CL395 C366

IC309

C454

RB301

RB303

C456

R462

C460

RB312

C455 S300

C392

C382

R465

R442

R464 C391

RB302

RB300 7 2 3 C

8 0 1 2 3 5 2 3 3 3 3 3 3 3 3 3 3 3 C C C C C C

0 4 7 4 4 3 4 3 3 C C C

8 9 0 1 4 4 5 5 5 5 6 7 8 7 9 0 1 2 3 3 3 3 3 7 3 3 3 3 5 5 8 8 8 8 C C C C 4 4 4 4 4 3 3 3 3 3 3 R R R R R R R R R R R 8 0 1 2 3 5 5 6 6 6 6 6 3 3 3 3 3 3 C C C C C C

C352

R352

C307 RB308

R351

RB309

2 4 3 R

C381

2 9 3 R

9 8 3 R

1 9 3 R

3 3 5 7 8 3 6 3 8 8 8 9 4 4 3 3 3 3 L L L L L L C C C C C C

3 4 6 7 5 5 5 5 3 3 3 3 C C C C

0 7 C339 3 L C

R343

IC303

R349

R348

R350

8 3 3 R

0 4 3 R

R332

R329

C325

R358

3 0 3 C I

R363

R354 C359

C329

CL359

C390 C389

7 4 3 R

R361

C380


CL378 C355

Les composants identiés par une marque ! sont critiques pour la sécurité. Ne les remplacer que par une piéce


BMD-002 BOARD (3/3)

R524

L507

JL500

0 1 4 4 5 5 L L J J

C650 CN502

FB527

JL501 C610

JL502

FB528

JL503 JL504

C651

L506

JL505 JL506

JL542

JL538

JL543

JL539

JL507 L511

JL508 JL509

C613

JL510

L510 C612 L509

C611 R532

L508

Q500

IC509 C507

IC503

R503

IC503 IC509

R502

L514

C511

R508

C506

R539

R511

R500

L500

1 0 5 D

C505

R506

R514

C503

C504

C502

C516

FB500

C514

R529

R515

R554

IC508 R518

R509

JL546 Q503

Q502

IC508

R510

R523 IC506

IC507

R531

L505

L503

R 53 6

C 60 5

C606

C607

R522

JL548 R521

FB557

C652

C501

C500

L504

C609

C608

IC507

R530

JL547

R556 C616

C523

JL549 C69 4

R504 C614

C615

R520 C619

3 5 5

D502

R552

R

C508

CL521

IC500

IC500

R516

R512

R546 CL519

CL518 C510 S500 D500 C512

R505

FL500 R513 FL501

R537 R547

CL520

IC501

FL502

FL503 C509

IC501

R535

IC510 R534

IC510 R538

C535 C534

R533

C533 C532 C653

C531 C530 C529

R557

R558

C528

IC511

C527 C537 C539 C655

C541

IC300

C543

IC300

IC300 IC300

C545 C547 C551 C553 C555 C557 C559

C584 C583


6 8 0 2 4 6 8 9 0 2 4 6 8 0 2 4 6 8 0 2 4 6 8 0 3 3 4 4 4 4 4 4 5 5 5 5 5 6 6 6 6 6 7 7 7 7 7 8 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 C C C C C C C C C C C C C C C C C C C C C C C C


2 6 9 2 5 1 1 1 2 2 5 5 5 5 5 L J L L L L J J J J

1 5 1 1 5 5 L L J J

C618

C68 4


SECTION 2 PRINTED WIRING BOARDS

2-1. BL1-001 BOARD

2-2. BL2-001 BOARD

1

2

3

4

5

6

7

A

1

A

2

3

BL2-001 BOARD (SIDE A)

2 0 1 S

4

5

BL2-001 BOARD (SIDE B)

CN200

R200

B

B

D200

23 1-871-577-

C

1 0 1 Q

1 4 9 1 0 0 1 1 1 R C R

Q100

7 0 1 R

2 1 1 R

7 0 1 C

5 0 1 C

D

R103 0 1 S 1

0 0 1 C I

C106

S 1 0 0

1 0 1 R102 C 4 3 1 1 1 1 R R

BL1-001 BOARD (SIDE A)

13

0 0 1 E S

SE101

R110 C103 4 0 1 R

R108

R101 0 0 1 R

5 0 1 R

R106 C102

0 0 1 C

23 1-871-576-

13

BL1-001 BOARD (SIDE B) E

Note on Printed Wiring Boards: • :Patternfromthesidewhichenablesseeing. (Theotherlayer’spatternsarenotindicated.) 0 0 1 N C

Caution: Patternfaceside:Partsonthepatternfacesideseen ( Si de B ) f ro m th e pa tt er n fa ce a re i nd ic at ed . Partsfaceside: Partsonthepartsfacesideseen ( Si de A ) f ro m th e pa rt s fa ce a re i nd ic at ed .

F CN101

G

H

1-871-576-

23 13

1-871-577-

23 13

Reproduction Prohibited 2-3. BMD-001 BOARD (SIDE A)

13

12

11

10

9

8

7

6

5

4

3

2

1

BMD-001 BOARD (SIDE A) A CN301

5 0 5 T E

CN100

CN103 1 3 4 R

0 3 4 4 5 6 7 R 2 2 2 2 9 4 4 4 4 R R R R 1 4 R

3 2 4 R

ET507

CN102

C455

2 1 4 R

2 2 4 R 1 2 4 R

0 2 4 R

8 5 4 R 7 1 4 R

2 4 4 R

1 6 4 R

2 6 4 R

0 6 4 R

9 5 4 R

C250

R364 9 5 3 C

R365 R362

0 9 3 C 1 0 3 B F

D301

R325 R323 1 0 4 C

D300

0 0 3 Q

9 0 3 C I

1 9 3 C

2 0 4 C

R375

3 3 4 R

0 6 3 R

1 6 3 C

4 7 3 R

R376

8 0 4 2 R 3 4 R 4 4 4 R

1 2 3 R

2 2 3 R

8 7 6 6 3 3 R R

9 3 3 4 3 3 C R

7 5 7 5 3 3 C R

2 1 3 R 4 R389 0 3 C 4 2 6 7 6 5 5 4 3 3 3 3 C C C C

C303

2 3 3 R

9 2 3 R

R

9 2 3 C

8 3 4 R

9 0 4 5 3 3 C C

5 2 6 R

R348

C

4 0 1 R

C

R605

C186

6 2 2

R

7 9 1 C

2 5 1 9 5 3 3 1 0 1 3 3 3 3 3 C C C C R

C313 5

1 2 C

R299

IC103

7 0 2 C

9 0 2 C

R206

R213

7 8 1 R

C157

R212

3 1 2 C

IC110

C158

C161 R109 R106

1 5 4 R

R454

1 3 3 R

C162

R211 3 3 2 R

R136

2 2 2 C

1 0 6 R

R602

R250

2 5 5

R450

R310 R544

R311

R545

1 4 5 R

2 3 4 4 5 5 R R

9 0 1 Q 8 5 2 R

1 0 2 R

R512

R404

C379

0 0 4 R

3 0 4 R

C397

R402 1 1 8 R

R307 R398

1 0 5 T E

R406 0 0 3 S

C395R396

IC314

8 0 3 R

C396

4 4 6 C

IC504

1 4 6 C

R434 0 1 4 R

1 0 5 C

2 3 6 C

3 2 6 C

6 0 5 C I

C500

9 4 6

C

7 4 5 R

IC501

C235

8 0 5 C

C

7 0 5 C I

FB557

R217

R269

R271

1 2 5 R

E R518

1 0 5 Q

3 2 5 C 0 2 5 R

R509

IC508

3 2 5 R

C615 C614

L503

R556 3 3 6 C

X301

8 4 6 C

C620

4 5 2 C

R510

C616

2 0 5 Q

8 1 6 C

1 0 1 N C

R272

C234

3 5 5 R 2 2 5 R

L505

C

R218

Q106

6 4 5 R

9 0 5 C

R906

C621

0 0 3 R

9 1 6

C

1 5 2

R273 C510

L504

R306

9 1 2 R

R513

4 0 2 R 0 3 6 C

R302 R303

R449

C236

R268

IC500

R603

IC308

C383

5 0 1 Q 3 7 2

C512

C126

D100

R214

C627

C244

4 8 2 R

R259

D

C253

1 1 7 R

0 0 5 D

C198 Q102 C195

9 9 1 R

2 5 2 C

R270

R498

R

R209

3 0 1 Q

0 6 2 R

4 0 5 T E

3 2 2 R

R249

0 0 5 S

D502

R222 R251

R309

B R

IC310

C

4 1 5 L

0 0 6 R

R210 1 0 1 D

R135 4 4 3 R

IC300

7 0 3

R505

3 8 2 R

C155

R180

R107 R105

R295

6 0 3 B R

R507

C240

R181 R108

4 5 1 C

C241

R453

C513

4 4 1 C

R294

R401

2 0 5 C I

8 5 4 1 5 5 R C

R215

R296

1 4 3 C

5 R

IC505

1 7 1 R

R297

7 3 3 C

4

C461 0

3 3 1 C

R626

R298

2 8 3 C

R313

C305 4 3 1 C

L101

C322

R439

R162

R

3 0 2 C

R627

C321 C314

1 0 3 C I

C187

C196

C

R409

RB300 RB301

C136

7 0 9

0 0 2

1 8 3 C

RB302

B

C274 C141

5 6 7 8 9 7 8 9 0 3 3 3 3 3 2 2 2 3 2 2 2 2 2 2 2 2 2 R R R R R R R R R

C

R391

C312

RB303

C139 C140

R112 3 0 1 2 9 9 9 9 1 1 1 1 C C C C

R361 5 5 3

0 8 3 C

2 9 3 C

R101

R281 3 1 1

C199 1 3 3 C

R102

R100

0 8 7 1 7 7 1 2 2 R R R

R392

C310

6 2 3 R

9 8 3

8 1 1 R

R363 4 5 3 R

C325

R347

9 1 1 R

R358

RB309

0 1 7 8 8 3 3 3 4 R R R

R327

R345

1 1 1 R

9 4 3 R

0 5 3

3 0 3 C I

1 2 2 2 1 1 R R

C102 C108 C110

4 1 1 R

2 5 6

9 0 6 C

8 0 6 C

7 0 6 C

6 0 6 C

5 0 6 C

6 0 5 T E

F

C

IC304 C617

3 0 8 R

R320

6 4 4 R

C404

0 9 3 R

7 8 3 C

C405

6 0 4 C

C403

R447 C638

R448

C636

R393 R445 3 0 5 T E

7 8 5 5 4 4 C C

0 8 6 4 2 4 3 3 3 3 5 5 5 5 5 R R R R R

1 3 5 R

0 3 5 R 2 0 5 T E

1-871-575-

34 24 14

G

Reproduction Prohibited 2-4. BMD-001 BOARD (SIDE B)

1

2

3

4

5

6

7

8

9

10

11

12

13

BMD-001 BOARD (SIDE B) A 0 7 2 C

0 9 1 2 3 4 5 6 6 5 6 6 6 6 6 6 2 2 2 2 2 2 2 2 C C C C C C C C

0 6 2 0 1 6 5 5 5 5 4 4 4 4 4 C C C C C

C269

1 1 1 C

5 6 7 8 5 5 5 5 2 2 2 2 C C C C

C101

4 5 4 C

0 7 4 R 8 1 4 R

3 5 4 C

1 3 2 R

7 1 1 C

C135

5 1 1 C

C 9 2 5

C185

R

C610

6 0 6 R

C156

C 0 5 6 C

2 0 5

FB527

7 0 5 L

7 0 6 R 5 6 4 4 2 2 R R

5 6 0 0 1 1 C C

4 0 1 C

R282

3 1 6 C

C176

C183

C506 5 5 5 R

4 0 1 Q

6 0 5 Q

8 2 3 C

6 0 2 C

R113

C238

0 0 4 C

1 4 3 R

Q507 C107

5 7 3 C

0 0 1 L

9 1 2 C

4 0 1 L F

C231

C

IC108

4 2 2 C

6 2 2

5 2 2 C C

C223

L509

1 2 2 C

C228

C227

9 1 6 7 3 3 R R

R377

C351

R330

1 7 3 7 5 8 3 4 4 2 4 2 5 5 5 5 5 5

6 4 3

8 0 3 C

0 7 3 C

C346

4 2 3 C

C306

C342

2 4 2 C

E Q107 4 0 1 N C

7 3 2 C

R241

C561

C539

C575

C577

C590

C578

C565

3 4 2 C

3 0 5

0 0 5 Q

2 0 5 R

3 0 5 C I

3 0 5 C

4 1 5 R

C628

5 4 2 C

C642

C629

6 1 5 C 0 0 5 R

6 0 5 R

4 1 5

C 9 9 4 B F

1 0 5 D

0 5 1 R

C626

C548

7 2 1 C

R147

C122 C124

C118

R141

4 3 1

R

R132 5 2 1 R

0 2 1 C

C567

C534

C588

C533

C589

0 0 6 C

C560 C373

R137 R138

3 4 6 C

6 1 1 C

R140

0 3 1 R

X101

9 8 7 6 7 6 5 9 9 9 9 8 8 8 5 5 5 5 5 5 5 C C C C C C C

7 8 3 R

9 3 6 C

C 63 5

5 7 3 3 5 5 R R

3 6 5 C

C549

C572 8 9 1 7 3 5 C C

C319

9 3 5 R

0 2 3 C

C544

C538 R443 C554 R386

R379 4 6 3 C

7 1 5 R 9 1 5 R

C 63 7 3 3 5 R

4 3 1 0 8 8 8 8 5 5 5 5 C C C C

C386

0 4 6 C

4 3 6 C

3 0 5 L F

C556

R388

8 5 5 C

2 2 6 C

R128

4 0 3 B R

C571

C601

C568

4 2 6 C

R193

5 0 3 B R

6 6 5 C

C569

C602

6 4 5 C

0 4 5 C

C

C121 IC101

4 6 5 C

C570

R305 5 2 6

1 3 6 C

0 4 4 R

6 7 3 C

2 6 5 C

C541

C374

R131 0 0 5 L

4 0 3 R

C

C645 4 0 5 C

R397

4 8 3 R

C591

2 5 5 C

R301

R515 7 0 5 C

R

FL500

9 4 5 R 6 4 6

1 1 4

C576

C532

C603

6 1 5 R

R399

C399 C372

C535 1 0 3 C

7 3 8 9 0 1 2 3 8 8 9 9 1 1 2 2 2 2 R R R R R R

0 5 5 R

C315

FL502

R293

2 4 2 R 1 5 5 R

8 0 5 L

R

F

4 9 1 C

R285

6 1 3 C550 C

C573

C537

2 1 6 C

R405

R324 R336

3 2 4 9 9 7 5 5 5 C C C

C551 2 5 3 C

R335

R

R

7 3 3 R

R366

R

5 4 9 9 9 2 5 5 5 1 C C C 0 0 3 5 5 L C F

C557

6 3 3 C

9 3 3

R328

2 7 3

C300

9 7 3 2 5 5 8 8 3 3 3 3 R R R R

C553

R292

L510

4 3 3 C

R378 0 7 3 R

C559 C C C C C C

7 1 2 C

C 2 32

C348

C371

C555

R333

C 2 33

1 1 6

RB312

R452

6 2 3 C

3 5 1 6 4 4 R R

8 6 3 C

8 3 3 R

5 3 4 R

R342 C302

C307

4 0 6 C

FL103

3 0 1 L

L511

C340 R352

0 4 3 R

0 8 5 3 6 5 6 6 3 3 3 3 C C C C

C536

C542

8 1 2 C

R351

C343

R267 IC509

3 5 3 C

6 3 4

R 5 4 3 C

C323

4 5 3 C

3 0 2 R

3 7 0 3 2 3 3 3 3 C C C

C317

R265

R103

C

C109

D

R202

Q508

R126

3 0 1

5 4 7 2 1 2 C R

9 1 1 C

C179

9 2 1 R

8 8 1 C

R240

R234

C114

C239

1 5 6 C 8 2 5 B F

C505

R232

N C

C 18 0

C181

2 8 1 C

R508

4 3 4 4 2 2 R R

C 17 8

RB308

1 1 5 R

C159

L506

C189

C184

R554

6 1 4 R

7 6 6 6 3 3 C C

9 6 3

R524

R414 R463

R

4 6 4 R

R163

2 7 4 R

5 1 4 R

9 2 4

R139 R124

B

1 7 4 R

C647 R441

3 7 3 R 6 5 3 R

CN300

1-871-575-

G

34 24 14

Reproduction Prohibited 2-5. BMD-002 BOARD (SIDE A)

13

12

11

10

9

8

7

6

5

4

3

2

1

BMD-002 BOARD (SIDE A) A CN301

7 4 5 L J

CN100

CN103 CN102

3 4 5 6 7 2 2 2 2 2 4 4 4 4 4 R R R R R

1 3 4 R

0 3 4 R

2 2 4 R

9 1 4

R

JL549

8 5 4 R

R

1 6 4 R

7 1 4 R

2 4 4 R

1 2 4 R

0 2 4 R

C455

2 1 4

R102

5 0 9 5 6 5 1 4 4 R R R

9 3 3 4 3 3 C R 9 4 3 R

Q112

R156 0 9 3 C

C250

2 6 4 R

4 5 1 0 R 2 1 R

2 3 3

IC111 1 0 3 B F

R323

2 3 4 R

0 0 3 Q

4 0 3 C

2 1 3

R325

D300

1 0 4 C

R 1 2 6 6 6 5 3 3 3 C C C

2 0 4 C 8 0 4 R 3 3 4 R 4 4 4

4 7 3 R 1 2 3 R

R376 R375

0 6 3 R

2 2 3

R

C303

9 5 3 C

7 4 1 R

C344

7 5 3 C 8 3 4 R

0 3 C

C351

5 3 3 C

R475

0 1 2 3 9 9 9 9 1 1 1 1 C C C C

R361 4 5 5 5 3 3 R C

1 9 3 R

2 9 3 R

RB309 9

R

8 1 1 R

0 1 1

R

7 7 2 R

C186

6 2 2

C199

R144

C139 C140 C141

C274

R157

C136

R158

B

2 3 5 R

R162

C187 4 3 1 C

IC103

R148

3 3 1 C

L101

0 0 2 C

4 R

7 9 1 C

3 0 2 C

C196

C310 3 7

R101

R281 3 1 1 C

5 6 7 8 9 7 8 9 0 3 3 3 3 3 2 2 2 3 2 2 2 2 2 2 2 2 2 R R R R R R R R R

R

5 1 1 1 1 2 3 3 3 R C C

R100

4 0 1 R

R112

R358

C325

9 1 1

R278

R348 R363

R389 R347

1 1 1 R

R350

3 0 3 C I

9 2 3 C

R472

8 7 0 1 7 6 6 8 8 3 3 3 3 3 4 R R R R R

R327

R

9 2 3 R

R

D301

1 2 2 2 1 1 R R

C102 C108 C110

4 1 1 R

R149 1 7 1 R

C312 9 0 3 C I

1 9 3 C

C313

9 8 3

C322

C323

C

R326 5 1 2 C

C314 0 8 3 C

9 0 2 C

RB300

C158

C342

C161

R109 R106

R296 R105

6 4 3 R

R474

R295

3 3 2 R

R309 6 0 3 B R

1 1 5 3 4 3 R R

R310

R303

7 8 4 R

R404 9 4 4 R

R306

R259

R

R143

2 5 5

4 8 2 R

C236

7 4 5 R

9 1 2

C273

1 0 5 C

6 0 5 C I

C500

9 1 6

9 4 6 C

C

R218 R273

Q106

IC501 9 0 5 C

R537

8 0 5 C

7 0 5 C I

R 3 5 4 5 0 R 5 R

L504

1 2 5 R

C616

2 0 5 Q

R531

R271

E

C234

C523

2 2 5 R

R396 R398

1 0 1 N C

R217

R269

C235 R530

1 5 2 C

R272

6 4 5

R510

8 0 3 R

R

R513 C510

4 0 2 R

D

C244 5 0 1 Q

R268

IC500

R

C126

R307

2 0 4 R

3 0 5 Q

6 3 5 R 0 2 5 R

R518 R509

IC508

3 2 5 R

C615 C614

L503

R434

C396

C395

0 0 3 R

8 5 2

C241

D100

R214

R443 R406 0 0 3 S

9 0 1 Q

C195

R

C512

R512

C253

0 5 1

0 0 5 D

FB557

R403 0 0 4 R

C383

8 8 4 R

6 8 4 R

2 5 2 C

R270

R505

C198 Q102

9 1 9 0 1 2 R R

R302 IC310

D502

R250

R209

D101

R311

7 0 3 B R

R485

3 2 2 R

3 0 1 Q

R

0 0 5 S

R210

R249

6 4 5 L J

R453

R142 R222

R251

0 6 2

IC300

R401

4 1 5 L

0 4 1 R

3 8 2 R

R211

2 2 2 C

R135

1 4 1 R

C155

R136 7 1 3 B R

4 5 1 C

C240

R181 R180

C162

R107

R294

C346

RB301

7 8 1 R

R108

R297

R483

RB302

C157

R212

C I

R298

3 3 3 R

R335

2 8 3 C

RB303

R206

R213

R299

6 1 3 B R

1 8 3 C

C

4 4 1 C

R215 0 1 1

3 1 2 C

R409 R439

2 9 3 C

7 0 2 C

R556 8 4 6 C

X301

8 1 6

C

L505 2 5 6

9 0 6

C

8 0 6 C

7 0 6 C

6 0 6 C

5 0 6 C

8 4 5 L J

F

C 3 9 3 R

IC304

7 8 5 5 4 4 C C

1-874-277-

33 23 13

G

Reproduction Prohibited 2-6. BMD-002 BOARD (SIDE B)

1

2

3

4

5

6

7

8

9

10

11

12

13

BMD-002 BOARD (SIDE B) A 0 7 2 C

0 9 1 2 3 4 5 6 6 5 6 6 6 6 6 6 2 2 2 2 2 2 2 2 C C C C C C C C

0 6 2 0 1 6 5 5 5 5 4 4 4 4 4 C C C C C

C269

1 1 1 C

5 6 7 8 5 5 5 5 2 2 2 2 C C C C

C101

4 5 4 C

0 7 4 R 8 1 4 R

3 5 4 C

R139 R124

B

R

1 3 2 R

7 1 1 C

C135

5 1 1 C

C185 R554

C610

3 4 2 R

C

C159 0 5 6 C

FB527

R232

L506

L507

3 0 1 C

4 0 1 C

6 0 1 C

3 5 1 R

R508 C505

5 0 1 C

C179

C180

2 3 3 C

6 4 2 R

C183 R240

R234 4 0 1 Q

C506

1 3 3 C

5 2 1 R 6 2 1 R

8 2 3 C

9 2 1 R

8 8 1 C

Q110

C239 R282 3 1 6 C

C176

9 1 1 C

L511

4 3 5 R

1 1 6

C

3 5 6 3 3 5

L509

R

2 4 2 C

R285

L510 2 1 6 C

CN104

4 9 1 C

R241

3 0 5 C I

2 0 5 0 0 5 Q

4 1 5 R

4 0 5 C

2 0 5 C

R558

C231

1 1 5 C I

6 5 2 2 2 2 C C

4 2 2

C

C228

C227

C467 C305 C466

R293

1 0 3 R

C372

0 3 5 C

C574

C534

C531

C549 C557

FL502

4 6 5 C

4 7 3 C

5 4 2 C

1 5 5 C

2 3 5 C 6 5 5

C

1 4 5 4 C 8 5 C

9 3 5 C

3 8 5 C

7 3 5 C

C580

5 8 3 5 6 5 C C

2 7 5 C

5 1 3 B R

5 0 3 B R 6 6 5 C

C553

R484

4 1 3 B R

R480

R479

C555

R482

C

2 6 5 C

C370

C548

5 7 3

3 1 3 B R

0 7 5 C

C559

R397 R481

4 8 3 R

FL500 C547

0 6 5 C

9 9 3 R

C527

C533

3 0 5 L F

0 4 4 R

C550

C543 C576

2 4 5 C

C546

R292

1 0 5 L F

C578 1 7 3 C

C348 7 3 8 9 0 1 2 3 8 8 9 9 1 1 2 2 2 2 R R R R R R

C

4 0 3

B R

C544

6 8 3 C

4 1 5

C538

R387

C

C554

R388

0 0 5 B F

R 1 0 5 D

R411 R366

C343

C315

1 2 2 C

C223

0 4 5

C306

6 1 5 C 0 0 5 R

C503 6 0 5

R

C232

7 5 5 R

C

R324

8 2 5 C

5 4 5 C

6 3 5 C 9 2 5 C

C352 C302

C341

R305

R515 7 0 5 C

5 5 6 C

9 1 2 C

C109

C558

C350

C326 C337 4 4 3 R

2 4 2 R

6 1 5 R

L508

3 0 5 R

IC510

C349 C465

7 1 2 C

6 3 3

R

R336 C552

C400

FL103

R304

3 4 2 C

Q107 7 3 2 C

C

9 3 3 R

7 3 3

R378 R489

2 7 3 R

9 7 5 5 3 3 3 2 R R 8 8 3 3 R R

C463

C462

1 0 5 0 1 1 R L

C233 R535

R538

IC108

4 3 3 C

R330 R478 R328

R452

C464

9 9 3 C

R265

R476 R377

9 1 6 7 3 3 R R

RB312

0 7 3 R

5 0 3 6 4 3 R C 2 4 3 R

6 1 4 R

R

R351 R

R352 C307

C308

2 3 5 0 1 1 R L

FL104

D

3 7 0 3 2 3 3 3 3 C C C

R463

8 7 6 6 6 6 3 3 3 C C C

8 3 3

8 5 3 5 6 6 3 3 3 C C C

6 3 4

C340 C316

6 0 2 C

C107

8 1 2 C

IC509

R

R103 R267

8 2 5 B F

R202 R203

C347

Q111

R113

5 4 7 2 1 2 C R

RB308

0 4 3

4 3 5 5 3 3 C C

C181

2 8 1 C

C238

1 5 6 C

E

R539 C511

5 4 2 R

4 4 2 R

C178

C189

C184

R511

6 4 1 R

5 4 1 R

C156

2 0 5 N C

9 6 3 C

9 2 5 R

R524

5 1 4 R

5 6 4 R

4 6 4

R163

1 7 4 R

R386

R379

F

0 0 5 L

4 6 3 C

R441

3 7 3

R

6 5 3 R

CN300

1-874-277-

G

33 23 13


SECTION 3 EXPLODED VIEWS • LOADING COMPLETE ASSY

NOTE:

• Themechanicalparts withnoreference numberintheexplodedviewsarenotsupplied. • Accessoriesaregiveni nthelastofthi s partslist.

NOTE:

Thecomponentsidentiedby mark ! ordottedlinewithmark ! arecriticalforsafety. Replaceonlywithpartnumber specied.

•SCClassication: S:SuppliedpartsU:Unsuppliedparts CAUTION

Useofcontrolsoradjustmentsorperformance ofproceduresotherthanthosespeciedherein mayresultinhazardousrediationexposure.

Lescomposantsidentiésparune marque ! sontcritiquespour lasécurité. Nelesremplacerqueparunepiéce portantlenumérospécié.

SPECIAL COMPONENT NOTICE

Thecomponentsidentiedbymark contain condentialinformation. Strictlyfollowtheinstructionswheneverthe componentsarerepairedand/orreplaced.

SC

Ref. No.

Part No.

Description

S U S S U

1 2 3 4 5

9-910-001-47 A-1203-908-A 2-894-364-02 3-948-339-12 3-074-552-02

LOADING COMPLETE ASSY LOADING BLOCK ASSY SPRING (MD), LEAF SCREW, TAPPING 0 PLATE 2 MAIN 2X5 S TITE

6 7 8 9

1-834-594-11 2-698-708-02 A-1267-249-A X-2177-119-1

CABLE, FLEXIBLE FLAT (FFC-60) CUSHION (PWB) BMD-001 COMPL (SERVICE) SHIELD ASSY (MD)

!

S S S S

Remark

• LOADING COMPLETE ASSY (1.5G)

3-1. LOADING COMPLETE ASSY SECTION

2

1

SC

Ref. No.

Part No.

Description

S U S S U

1 2 3 4 5

A-1433-712-A A-1203-908-A 2-894-364-02 3-948-339-12 3-074-552-02

LOADING COMPLETE ASSY (1.5G) LOADING BLOCK ASSY SPRING (MD), LEAF SCREW, TAPPING 0 PLATE 2 MAIN 2X5 S TITE

6 7 8 9

1-834-594-11 2-698-708-02 A-1433-743-A X-2177-119-1

CABLE, FLEXIBLE FLAT (FFC-60) CUSHION (PWB) BMD-002 COMPL (SERVICE) SHIELD ASSY (MD)

S S S S

5

3

5

7

4 6

8

9

4

!

Remark


3-2. LOADING BLOCK ASSY SECTION

52 51 53

62

54 55 55

55

56 58

57

59

61

60

SC

Ref. No.

Part No.

Description

S U U U S

51 52 53 54 55

9-910-001-52 2-698-683-01 1-471-407-11 2-698-682-02 3-948-339-12

COVER ASSY, TOP YOKE (CHUCK PULLEY) MAGNET PULLEY, CHUCK SCREW, TAPPING

S S S U S

56 57 58 59 60

A-1204-033-A 2-647-360-61 A-1204-035-C A-1203-909-A 2-888-817-01

FRAME COMPLETE ASSY, TOP SCREW (B2), TAPPING ARM ASSY, FRONT FRAME COMPLETE ASSY, BASE LABEL, LASER CAUTION

S S

61 62

3-069-212-01 A-1204-038-B

TAPE, HARNESS STOPPER PULLEY ASSY, CHUCK

Remark


3-3. BASE FRAME COMPLETE ASSY SECTION 108 112 104 113 109

107

#1

135

SC

Ref. No.

Part No.

Description

U U U S U

101 102 103 104 105

X-2149-112-1 2-698-620-01 2-698-633-01 2-059-635-11 2-698-466-01

ARM SUB ASSY, SWING GEAR (SWING ARM) WASHER (GEAR) SCREW GEAR (A)

U U S S S

106 107 108 109 110

2-698-467-01 2-698-652-01 2-698-624-02 2-698-629-01 X-2149-103-1

GEAR (CAM DRIVING) SPRING (SLIDE CAM), COMPRESSION CAM (L), SLIDE BRACKET, MOTOR MOTOR ASSY, LOADING

U U U S S

111 112 113 114 115

2-698-465-01 2-647-360-61 2-698-630-01 A-1267-250-A 1-833-249-11

WHEEL, WORM SCREW (B2), TAPPING SPRING (BU HOLDER), LEAF BL1-001 COMPL (SERVICE) CABLE, FLEXIBLE FLAT (FFC-014)

U S S U U

116 117 118 119 120

2-698-653-01 2-890-570-01 2-698-625-02 2-698-626-02 2-698-664-01

SPRING (BU HOLDER), EXTENSION LABEL, SERIAL NUMBER CAM (R), SLIDE FRAME, BASE SPRING (SHUTTER ARM), TORSION

U S S S U

121 122 123 124 125

2-698-623-01 2-698-628-01 A-1203-919-D 3-069-212-01 2-698-631-02

ARM, SHUTTER ARM, LINK BASE FRAME ASSY TAPE, HARNESS STOPPER SHEET (BASE FRAME)

U U U U U

126 127 128 129 130

2-698-617-01 2-698-621-01 2-698-622-01 2-698-654-02 2-698-618-01

GEAR (SHAFT R) SLIDER (SHUTTER), LOCK LEVER (SHUTTER), LOCK SPRING (LOCK SLIDER), EXTENSION GEAR (BELT)

S S U S S

131 132 133 134 135

2-698-651-01 2-698-650-01 2-698-619-01 2-698-666-01 A-1203-920-A

BELT (FRONT ARM) GEAR (SHAFT L) GEAR (IDLER) COVER, BOTTOM ARM ASSY, SWING

U S

136 #1

A-1204-032-B 7-627-554-38

FRAME SUB ASSY, BASE SCREW, PRECISION +P 2X1.8 TYPE1

110

104 103

105

112 111

102

114 106

101

OPTICAL PICK-UP SECTION

115 104

117

116

118

133

104

132

107

131 130 128 119

129

123

127

126

120 125 121 136

122 124

104

124

134

Remark


3-4. TOP FRAME COMPLETE ASSY SECTION

151 154

151 158 155 156 157

153

159

152

151

160

169

171 161 151

168

162 166 167

163

164 165

170 151

SC

Ref. No.

Part No.

Description

S U U U S

151 152 153 154 155

2-059-635-11 2-698-660-02 2-698-686-01 2-698-656-02 1-964-978-11

SCREW ARM (REAR GUIDE), LOCK SPRING (LOCK ARM), TORSION ARM (L), CHUCK HARNESS, 2PIN CONNECTOR (LED)

U U U U U

156 157 158 159 160

A-1205-601-A 2-698-655-03 2-699-485-01 2-698-661-02 2-889-123-03

BL2-001 COMPL FRAME, TOP SPRING (REAR GUIDE ARM), TORSION ARM, REAR GUIDE ARM (A), DETECTION

U U U U U

161 162 163 164 165

2-698-687-01 2-698-657-04 2-698-685-01 2-698-658-01 2-698-663-01

SPRING (CHUCK ARM), EXTENSION ARM (R), CHUCK SPRING (SUPPORT ARM), TORSION ARM, SUPPORT SHUTTER

U U U S U

166 167 168 169 170

2-889-118-01 2-698-665-01 2-889-128-02 3-069-212-01 A-1204-034-H

HOOK (SHUTTER) SPRING (SHUTTER), TORSION SHEET, FRAME TOP TAPE, HARNESS STOPPER FRAMEASSY, TOP

U

171

2-698-662-01

ROLLER (REAR GUIDE)

Remark


3-5. FRONT ARM ASSY SECTION

204

201

202

202

203

205 206 207

209

208 206

212

209

209

213 213

210

210 209 211

SC

Ref. No.

Part No.

Description

U U U U U

201 202 203 204 205

2-698-697-02 2-698-699-03 2-698-688-04 2-698-698-02 2-698-694-01

LOCK (FRONT ARM L) SPRING (LOCK FA), TORSION BRACKET (FRONT ARM) LOCK (FRONT ARM R) ARM (FB), LINK

U U U U U

206 207 208 209 210

2-698-633-01 2-698-710-01 2-698-693-01 2-698-691-02 2-698-692-02

WASHER (GEAR) SPRING (FRONT ARM), TORSION ARM (FA), LINK GEAR (FRONT ARM) GEAR (ROLLER)

U U U

211 212 213

2-698-690-02 2-698-689-02 2-698-695-02

ARM (R), FRONT ARM (L), FRONT ROLLER, RUBBER

Remark


3-6. OPTICAL PICK-UP SECTION

SC

Ref. No.

Part No.

Description

S S S S S

251 252 253 254 255

8-820-372-03 2-698-669-01 2-698-668-01 2-698-627-01 1-833-247-11

DEVICE, OPTICAL KEM400AAA/J1NP1 SCREW, STEP INSULATOR HOLDER, BU CABLE, FLEXIBLE FLAT (FFC-019)

256

1-833-248-13

CABLE, FLEXIBLE FLAT (FFC-045)

S

252

!

Remark

253

251

256

252

253

255

254

Thecomponentsidentiedby mark 0ordottedlinewithmark 0arecriticalforsafety. Replaceonlywithpartnumber specied.

Lescomposantsidentiésparune marque 0sontcritiquespour lasécurité. Nelesremplacerqueparunepiéce portantlenumérospécié.


SECTION 4 ELECTRICAL PARTS LIST

NOTE:

• Duetostandardization, replacementsin thepartslistmaybedefferentfromthe partsspeciedinthediagramsorthe componentsusedontheset. • RESISTORS METAL:Metal-lmresistor. F:nonammable • SEMICONDUCTORS Ineachcase,u: m,forexample: uA..:mA..uPA..: mPA.. uPB.. :mPB..uPC..: mPC..uPD..: mPD.. • CAPACITORS uF: mF •COILS uH: mH SC

Ref. No.

S

Thecomponentsidentiedby mark ! ordottedlinewithmark ! arecriticalforsafety. Replaceonlywithpartnumber specied. Lescomposantsidentiésparune marque ! sontcritiquespour lasécurité. Nelesremplacerqueparunepiéce portantlenumérospécié. Whenindicatingpartsbyreference number,pleaseincludetheboard.

Part No.

Description

A-1267-250-A

BL1-001 COMPL (SERVICE) *************

Remark

< CONNECTOR > U U

CN100 CN101

CONNECTOR, FFC/FPC (ZIF) 14P CONNECTOR 2P < TRANSISTOR >

U U

Q100 Q101

TRANSISTOR 2SC4081T106Q PHOTO SENSOR CPT-184S-C-TU-BCD < RESISTOR >

U U U

R107 R109 R111

METAL CHIP METAL CHIP METAL CHIP

100K 1K 10K

0.5% 0.5% 0.5%

1/16W 1/16W 1/16W

< SWITCH > U S100 SWITCH, PUSH (1 KEY) U S101 SWITCH, PUSH (1 KEY) U S102 SWITCH, PUSH (1 KEY) ***************************************************************** U

BL2-001 COMPL *************

SPECIAL COMPONENT NOTICE

Thecomponentsidentiedbymark contain condentialinformation. Strictlyfollowtheinstructionswheneverthe componentsarerepairedand/orreplaced. NOTE:

•SCClassication: S:Suppliedparts U:Unsuppliedparts

Part No.

Description

Remark

SC

Ref. No.

Remark

SC

Ref. No.

U U U U U

C196 C197 C198 C199 C200

Part No.

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

Description 100PF 0.1uF 10uF 100PF 0.1uF

5% 10% 10% 5% 10%

50V 10V 16V 50V 10V

U U U U U

C321 C322 C323 C324 C325

Part No.


Description 1uF 0.22uF 0.1uF 0.1uF 10uF

20% 10% 10% 10% 20%

Remark 6.3V 6.3V 10V 10V 16V

U U U U U

C203 C206 C207 C209 C213


0.1uF 0.1uF 0.001uF 0.022uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 50V 16V 10V

U U U U U

C326 C327 C328 C329 C330


0.1uF 22PF 22PF 0.1uF 22PF

10% 5% 5% 10% 5%

10V 50V 50V 10V 50V

U U U U U

C215 C217 C218 C219 C221


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C331 C332 C333 C334 C335


220PF 220PF 0.022uF 0.1uF 0.0047uF

10% 10% 10% 10% 10%

50V 50V 16V 10V 50V

SC

Ref. No.

U U U U U

C106 C107 C108 C109 C110


0.001uF 47uF 0.1uF 0.1uF 0.1uF

10% 20% 10% 10% 20%

50V 6.3V 10V 10V 16V

U U U U U

C222 C223 C224 C225 C226


0.1uF 0.22uF 0.1uF 100PF 0.1uF

10% 10% 10% 5% 10%

10V 6.3V 10V 50V 10V

U U U U U

C336 C340 C341 C342 C343


0.1uF 220PF 0.0015uF 0.0033uF 0.1uF

10% 10% 10% 10% 10%

10V 50V 50V 16V 10V

U U U U U

C113 C114 C115 C117 C119

CERAMIC CHIP SHORT CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0 0.1uF 0.1uF 0.1uF

10%

10V

20% 20% 20%

16V 16V 16V

U U U U U

C227 C228 C232 C233 C234


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C345 C348 C349 C350 C351


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C126 C133 C135 C136 C139


2.2uF 22uF 0.1uF 470PF 0.01uF

20% 20% 20% 10% 10%

16V 16V 16V 50V 25V

U U U U U

C235 C236 C237 C238 C239


0.1uF 0.1uF 100PF 22uF 0.1uF

10% 10% 5% 20% 10%

10V 10V 50V 16V 10V

U U U U U

C352 C353 C354 C356 C357


0.1uF 0.001uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

10V 50V 50V 50V 50V

U U U U U

C140 C141 C144 C154 C155


0.01uF 0.01uF 0.1uF 0.01uF 0.1uF

10% 10% 10% 10% 20%

25V 25V 10V 25V 16V

U U U U U

C240 C241 C242 C243 C244

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP

0.1uF 0.1uF 0.1uF 220uF 0.001uF

10% 10% 10% 20% 10%

10V 10V 10V 16V 50V

U U U U U

C358 C359 C360 C361 C362


0.068uF 0.1uF 0.001uF 0.0068uF 0.0068uF

10% 10% 10% 10% 10%

10V 10V 50V 16V 16V

U U U U U

C156 C157 C158 C161 C162


0.1uF 0.1uF 0.1uF 0.1uF 10uF

20% 10% 20% 20% 10%

16V 10V 16V 16V 16V

U U U U U

C250 C251 C254 C273 C300


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C363 C364 C365 C366 C367


0.0068uF 0.1uF 0.0068uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

16V 10V 16V 10V 10V

U U U U U

C175 C176 C178 C179 C180


0.01uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

25V 10V 10V 10V 10V

U U U U U

C301 C302 C303 C304 C306


0.1uF 0.1uF 0.1uF 0.33uF 0.1uF

10% 10% 10% 20% 10%

10V 10V 10V 10V 10V

U U U U U

C368 C369 C370 C371 C372


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C181 C182 C183 C184 C185


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C307 C308 C310 C311 C312


470PF 0.1uF 0.0068uF 0.1uF 0.001uF

10% 10% 10% 10% 10%

50V 10V 16V 10V 50V

U U U U U

C373 C374 C375 C376 C380


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C186 C187 C188 C189 C190


0.1uF 0.1uF 0.001uF 0.1uF 47PF

10% 10% 10% 10% 5%

10V 10V 50V 10V 50V

U U U U U

C313 C314 C315 C316 C317


0.001uF 0.01uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

50V 25V 10V 10V 10V

U U U U U

C381 C382 C383 C386 C389


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C191 C192 C193 C194 C195


47PF 100PF 100PF 0.01uF 0.1uF

5% 5% 5% 10% 10%

50V 50V 50V 25V 10V

U U U

C318 C319 C320

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0.1uF

10% 10% 10%

10V 10V 10V

U U U

C390 C391 C392


0.1uF 0.1uF 0.1uF

10% 10% 10%

10V 10V 10V

< CONNECTOR > U

CN200

U

D200

PIN, CONNECTOR 2P < DIODE > LED CL-200IR-X-TU < RESISTOR >

U R200 METAL CHIP 220 0.5% 1/16W ***************************************************************** S

A-1267-249-A

BMD-001 COMPL (SERVICE) ************** < CAPACITOR >

U U U U U

C101 C102 C103 C104 C105


0.1uF 0.1uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

10V 10V 50V 50V 50V


SC

Ref. No.

Remark

SC

Ref. No.

Remark

SC

Ref. No.

U U U U U

C395 C396 C399 C400 C401

Part No.


Descriptio n 15PF 15PF 0.1uF 0.1uF 0.0068uF

5% 5% 10% 10% 10%

50V 50V 10V 10V 16V

U U U U U

C557 C558 C559 C560 C561

Part No.


Description 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C616 C617 C620 C621 C622

Part No.


Descriptio n 100PF 0.1uF 0.1uF 0.1uF 0.1uF

5% 10% 10% 10% 10%

Remark 50V 10V 10V 10V 10V

U U U U U

C402 C450 C451 C452 C453


0.0068uF 100PF 100PF 100PF 100PF

10% 5% 5% 5% 5%

16V 50V 50V 50V 50V

U U U U U

C562 C563 C564 C565 C566


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C623 C624 C625 C626 C627


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C454 C455 C456 C457 C458


100PF 0.1uF 100PF 0.1uF 0.1uF

5% 10% 5% 10% 10%

50V 10V 50V 10V 10V

U U U U U

C567 C568 C569 C570 C571


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C628 C629 C630 C631 C632


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

IC103 IC108 IC110 IC300 IC303

IC IC IC IC IC

BD7956FS-E2 BA5888FP-E2 CXA2720R-TL CXD5063GG-1 NJM13403V(TE2)

U U U U U

C460 C500 C501 C503 C504


100PF 1uF 0.47uF 100PF 100uF

5% 10% 10% 5% 20%

50V 6.3V 6.3V 50V 6.3V

U U U U U

C572 C573 C574 C575 C576


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C633 C634 C635 C636 C637


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

IC304 IC309 IC310 IC500 IC501

IC IC IC IC

K4S641632K-UC75T MX25L1005MC-12G PST3629UL PST3814UL

U U U U U

C505 C506 C507 C508 C509


1uF 10uF 22uF 0.1uF 0.1uF

10% 20% 20% 10% 10%

16V 16V 16V 10V 10V

U U U U U

C577 C578 C579 C580 C581


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C638 C639 C640 C641 C642


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

IC503 IC504 IC506 IC507 IC508

IC IC IC IC IC

TPS64201DBVRG4 CXD5064R-T6 MM3292FNRE TC7WH74FK(TE85R) TPS64203DBVRG4

U U U U U

C510 C512 C523 C527 C528


0.1uF 0.22uF 1uF 0.1uF 0.1uF

10% 10% 20% 10% 10%

10V 6.3V 6.3V 10V 10V

U U U U U

C583 C584 C585 C586 C587


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C643 C644 C645 C646 C647


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U

IC509

U U U U U

C529 C530 C531 C532 C533


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C588 C589 C590 C591 C592


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C648 C649 C650 C651 C652


1uF 1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

6.3V 6.3V 16V 16V 10V

U U U U U

C534 C535 C536 C537 C538


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C593 C594 C595 C596 C597


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C539 C540 C541 C542 C543


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C598 C599 C600 C601 C602


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

< CONNECTOR > U U U U U

!

U U

!

! ! !

CN100 CN101 CN102 CN103 CN104

CONNECTOR, FFC/FPC (ZIF) 19P CONNECTOR, FFC/FPC (ZIF) 14P CONNECTOR, FFC/FPC (ZIF) 8P CONNECTOR, FFC/FPC (ZIF) 45P PIN, CONNECTOR 2P

CN301 CN502

CONNECTOR, FFC/FPC (ZIF) 60P PIN, CONNECTOR (PC BOARD) 4P

C544 C545 C546 C547 C548


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C603 C604 C605 C606 C607


0.1uF 0.1uF 0.1uF 1uF 22uF

10% 10% 10% 10% 20%

10V 10V 10V 10V 10V

U U U U U

C549 C550 C551 C552 C553


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C608 C609 C610 C611 C612

CERAMIC CHIP TANTAL. CHIP ELECT CHIP ELECT CHIP ELECT CHIP

22uF 47uF 100uF 100uF 100uF

20% 20% 20% 20% 20%

10V 6.3V 16V 6.3V 6.3V

U U U

C554 C555 C556


0.1uF 0.1uF 0.1uF

10% 10% 10%

10V 10V 10V

U U U

C613 C614 C615

ELECT CHIP CERAMIC CHIP CERAMIC CHIP

100uF 1uF 0.1uF

20% 10% 10%

6.3V 10V 10V

Ref. No.

Part No.

Description

Remark

< FILTER > U U U U U

FL103 FL104 FL500 FL501 FL502

U

FL503

FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) < IC >

IC BD7800FP-E2 < COIL >

U U U U U

L100 L101 L103 L500 L503

COIL, CHOKE COIL, CHOKE COIL, CHOKE COIL, CHOKE COIL, CHOKE

150uH 10uH 4.7uH 10uH 10uH

U U U U U

L506 L507 L508 L509 L510

COIL, CHOKE 1uH COIL, CHOKE 4.7uH COIL, CHOKE 4.7uH COIL, CHOKE 4.7uH INDUCTOR (EMI FERRITE) (2012)

U U

L511 L514

INDUCTOR (EMI FERRITE) (2012) INDUCTOR (EMI FERRITE) (2012)

U U U U U

Q102 Q103 Q104 Q105 Q106

FET RTR025N03TL FET RTR025N03TL TRANSISTOR UMH4NTN TRANSISTOR DTC144EE-TL TRANSISTOR UMH11NTN

U U U U U

Q107 Q109 Q500 Q501 Q502

TRANSISTOR DTA143EE-TL TRANSISTOR UMH11NTN FET RSQ035P03TR TRANSISTOR DTC144EE-TL FET IRF7422D2TRPBF

U U U

Q506 Q507 Q508

TRANSISTOR DTC115EETL FET RTQ035P02TR FET RTQ035P02TR

< TRANSISTOR >

< DIODE > U U U U U

SC

U U U U U

D100 D101 D500 D501 D502

U U U U U

FB301 FB499 FB527 FB528 FB557

DIODE DIODE DIODE DIODE DIODE

RR264M-400 RR264M-400 DAP202K-T-146 RB051LA-40TR DAP202K-T-146

< FERRITE BEAD > FERRITE, EMI (SMD) (1608) FERRITE, EMI (SMD) (2012) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) (2012)


SC

R ef . N o.

P ar t N o.

D es cr ip ti on

R em ar k

< RESISTOR > U U U U U

R101 R102 R104 R105 R106

RES-CHIP RES-CHIP SHORT CHIP RES-CHIP RES-CHIP

68 180 0 10K 10K

U U U U U

R107 R108 R109 R110 R111

RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT CHIP

47K 47K 47K 10K 0

5% 5%

1/16W 1/16W

5% 5%

1/16W 1/16W

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

U U U U U

R112 R114 R118 R119 R121

SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP RES-CHIP

0 0 0 0 10K

U U U U U

R122 R124 R126 R127 R129

RES-CHIP METAL CHIP RES-CHIP SHORT CHIP SHORT CHIP

100 12K 1K 0 0

U U U U U

R133 R135 R136 R139 R163

SHORT CHIP SHORT CHIP SHORT CHIP METAL CHIP METAL CHIP

0 0 0 3.3K 0.33

U U U U U

R171 R180 R181 R187 R199

SHORT CHIP METAL CHIP METAL CHIP METAL CHIP SHORT CHIP

0 0.56 0.56 10K 0

U U U U U

R201 R202 R203 R204 R206

SHORT CHIP METAL CHIP METAL CHIP RES-CHIP SHORT CHIP

0 12K 24K 10K 0

0.5% 0.5% 5%

1/16W 1/16W 1/16W

U U U U U

R212 R214 R217 R218 R219

METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

1.8K 15K 10K 100 100

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R222 R224 R226 R227 R228

METAL CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP

1 0 0 0 0

5%

1/3W

U U U U U

R229 R230 R231 R232 R233

SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP

0 0 0 0 0

U U U U U

R234 R235 R236 R237 R238


0 0 0 0 0

U

R240

SHORT CHIP

0

5%

1/16W

5% 0.5% 5%

1/16W 1/16W 1/16W

0.5% 1%

5% 5% 0.5%

1/16W 1/2W

1/3W 1/3W 1/16W

SC

R ef . N o.

R em ar k

SC

R ef . N o.

R em ar k

SC

R ef . N o.

U U U U U

R241 R242 R243 R244 R245

P ar t N o.

METAL CHIP SHORT CHIP METAL CHIP METAL CHIP METAL CHIP

D es cr ip ti on 1 0 22 22 22

5%

1/3W

5% 5% 5%

1/10W 1/10W 1/10W

U U U U U

R342 R343 R344 R346 R348

P ar t N o.

METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP

D es cr ip ti on 4.7K 4.7K 470 1.5K 4.7K

0.5% 0.5% 5% 5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R418 R419 R420 R421 R422

P ar t N o.

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

D es cr ip ti on 1K 82 82 82 22

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

R em ar k

U U U U U

R246 R258 R259 R260 R265

METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP

22 680K 5.6 100 22K

5% 5% 5% 5% 0.5%

1/10W 1/16W 1/3W 1W 1/16W

U U U U U

R349 R350 R351 R352 R354

METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

22K 22K 4.7K 10K 4.7K

0.5% 0.5% 0.5% 0.5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R423 R424 R425 R426 R427

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP RES-CHIP

82 0 82 82 22

5%

1/16W

5% 5% 5%

1/16W 1/16W 1/16W

U U U U U

R267 R268 R269 R270 R271


22K 10K 10K 2.2K 100

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R355 R357 R358 R359 R360

SHORT CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP

0 4.7K 4.7K 1K 100

5% 0.5% 5% 5%

1/16W 1/16W 1/16W 1/16W

U U U U U

R430 R431 R432 R433 R434

RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP

82 82 4.7K 4.7K 47K

5% 5% 0.5% 0.5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R272 R273 R277 R278 R282


100 100 47K 47K 10

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R361 R363 R365 R366 R367

METAL CHIP METAL CHIP SHORT CHIP METAL CHIP RES-CHIP

22K 22K 0 47K 100

0.5% 0.5%

1/16W 1/16W

0.5% 5%

1/16W 1/16W

U U U U U

R435 R436 R437 R438 R442


1K 1K 1K 1K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R283 R284 R285 R288 R289

RES-CHIP RES-CHIP RES-CHIP SHORT CHIP SHORT CHIP

10 10 10 0 0

5% 5% 5%

1/16W 1/16W 1/16W

U U U U U

R368 R369 R370 R371 R372


100 100 100 100 100

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R443 R444 R449 R452 R453

RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP

10K 47K 47K 47K 47K

5% 0.5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R290 R291 R292 R293 R294


0 0 0 0 0

U U U U U

R374 R375 R376 R377 R378


47K 47K 47K 47K 47K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R454 R458 R459 R460 R461

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP RES-CHIP

47K 0 10K 10K 100

5%

1/16W

5% 5% 5%

1/16W 1/16W 1/16W

U U U U U

R295 R296 R297 R298 R299


0 0 0 0 0

U U U U U

R379 R380 R381 R382 R383

SHORT CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

0 4.7K 4.7K 4.7K 4.7K

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

U U U U U

R462 R463 R464 R465 R470

RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT CHIP

100 100K 10K 10K 0

5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W

U U U U U

R300 R301 R302 R303 R304


2.2K 47K 47K 47K 47K

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R384 R386 R387 R388 R389

RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP

47K 47K 47K 47K 10K

5% 5% 5% 5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R471 R498 R502 R503 R504

SHORT CHIP SHORT CHIP RES-CHIP METAL CHIP RES-CHIP

0 0 10 0.047 47K

5% 1% 5%

1/16W 1/4W 1/16W

U U U U U

R305 R307 R309 R310 R311


47K 47K 33 33 33

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R391 R392 R393 R396 R397

METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP

10K 10K 33 1K 47K

0.5% 0.5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R506 R508 R509 R510 R511

METAL CHIP METAL CHIP RES-CHIP SHORT CHIP METAL CHIP

560K 330K 10K 0 27K

0.5% 0.5% 5%

1/16W 1/16W 1/16W

0.5%

1/16W

U U U U U

R312 R315 R320 R324 R326

METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP

3.3K 12K 10K 10K 100K

0.5% 0.5% 5% 5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R398 R399 R400 R401 R402


1M 47K 33 33 33

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R512 R514 R515 R516 R517

SHORT CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP

0 180K 560K 10K 22K

0.5% 0.5% 5% 5%

1/16W 1/16W 1/16W 1/16W

U U U U U

R329 R331 R332 R333 R336

METAL CHIP SHORT CHIP METAL CHIP SHORT CHIP RES-CHIP

47K 0 47K 0 47K

0.5%

1/16W

0.5%

1/16W

5%

1/16W

U U U U U

R403 R404 R405 R408 R409

RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP

33 33 47K 47K 47K

5% 5% 5% 0.5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R518 R519 R520 R521 R522

RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP

10K 22K 2K 3.3K 150

5% 5% 0.5% 0.5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U

R337 R339 R341

RES-CHIP RES-CHIP SHORT CHIP

10K 4.7K 0

5% 5%

1/16W 1/16W

U U U

R411 R415 R416

RES-CHIP RES-CHIP RES-CHIP

47K 10K 82

5% 5% 5%

1/16W 1/16W 1/16W

U U U

R523 R524 R529

METAL CHIP SHORT CHIP SHORT CHIP

0.047 0 0

1%

1/4W


SC

Ref. No.

Remark

SC

Ref. No.

Remark

SC

Ref. No.

Remark

SC

Ref. No.

U U U U U

R530 R531 R532 R533 R534

Part No.


Descriptio n 10K 10K 10K 10K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

C115 C117 C119 C126 C133


0.1uF 0.1uF 0.1uF 2.2uF 22uF

20% 20% 20% 20% 20%

16V 16V 16V 16V 16V

U U U U U

C227 C228 C232 C233 C235


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C360 C361 C362 C363 C364


0.001uF 0.0068uF 0.0068uF 0.0068uF 0.1uF

10% 10% 10% 10% 10%

50V 16V 16V 16V 10V

U U U U U

R535 R536 R537 R538 R539


10K 10K 10K 10K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

C135 C136 C139 C140 C141


0.1uF 470PF 0.01uF 0.01uF 0.01uF

20% 10% 10% 10% 10%

16V 50V 25V 25V 25V

U U U U U

C236 C237 C238 C239 C240


0.1uF 100PF 22uF 0.1uF 0.1uF

10% 5% 20% 10% 10%

10V 50V 10V 10V 10V

U U U U U

C365 C366 C367 C368 C369


0.0068uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

16V 10V 10V 10V 10V

U U U U U

R540 R541 R542 R543 R544

RES-CHIP SHORT CHIP SHORT CHIP SHORT CHIP RES-CHIP

10K 0 0 0 100

5%

1/16W

5%

1/16W

U U U U U

C144 C154 C155 C156 C157


0.1uF 0.01uF 0.1uF 0.1uF 0.1uF

10% 10% 20% 20% 10%

10V 25V 16V 16V 10V

U U U U U

C241 C242 C243 C244 C251

CERAMIC CHIP CERAMIC CHIP ELECT CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 220uF 0.001uF 0.1uF

10% 10% 20% 10% 10%

10V 10V 16V 50V 10V

U U U U U

C370 C371 C372 C374 C375


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

R545 R546 R547 R549 R550

RES-CHIP SHORT CHIP SHORT CHIP RES-CHIP RES-CHIP

100 0 0 47K 47K

5%

1/16W

5% 5%

1/16W 1/16W

U U U U U

C158 C161 C162 C175 C176


0.1uF 0.1uF 10uF 0.01uF 0.1uF

20% 20% 20% 10% 10%

16V 16V 16V 25V 10V

U U U U U

C273 C302 C303 C305 C306


0.1uF 0.1uF 0.33uF 0.1uF 0.1uF

10% 10% 20% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C380 C381 C382 C383 C386


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

R551 R552 R553 R555 R556

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP SHORT CHIP

47K 0 10K 10K 0

5%

1/16W

5% 5%

1/16W 1/16W

U U U U U

C178 C179 C180 C181 C182


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C307 C308 C310 C311 C312


470PF 0.1uF 0.0068uF 0.1uF 0.001uF

10% 10% 10% 10% 10%

50V 10V 16V 10V 50V

U U U U U

C389 C390 C391 C392 C399


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

RB300 RB301 RB302 RB303 RB304

RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) CONDUCTOR, NETWORK 0X4 (1005)

U U U U U

C183 C184 C185 C186 C187


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C313 C314 C315 C316 C321


0.001uF 0.47uF 100PF 0.1uF 0.1uF

10% 10% 10% 10% 10%

50V 6.3V 50V 10V 10V

U U U U U

C400 C401 C402 C455 C457


0.1uF 0.0068uF 0.0068uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 16V 16V 10V 10V

U U U U U

RB305 RB306 RB307 RB308 RB309

CONDUCTOR, NETWORK 0X4 (1005) CONDUCTOR, NETWORK 0X4 (1005) CONDUCTOR, NETWORK 0X4 (1005) RES, NETWORK 4.7KX4 (1005) RES, NETWORK 4.7KX4 (1005)

U U U U U

C188 C189 C190 C191 C192


0.001uF 0.1uF 47PF 47PF 100PF

10% 10% 5% 5% 5%

50V 10V 50V 50V 50V

U U U U U

C322 C323 C325 C326 C327


1uF 0.1uF 10uF 0.1uF 22PF

10% 10% 20% 10% 5%

6.3V 10V 16V 10V 50V

U U U U U

C458 C462 C463 C464 C465


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U

RB312

RES, NETWORK 4.7KX4 (1005)

U U U U U

C193 C194 C195 C196 C197


100PF 0.01uF 0.1uF 100PF 0.1uF

5% 10% 10% 5% 10%

50V 25V 10V 50V 10V

U U U U U

C328 C329 C330 C331 C332


22PF 0.1uF 22PF 220PF 220PF

5% 10% 5% 10% 10%

50V 10V 50V 50V 50V

U U U U U

C466 C467 C502 C504 C505


0.1uF 0.1uF 47uF 47uF 1uF

10% 10% 20% 20% 10%

10V 10V 6.3V 6.3V 16V

U U U U U

C198 C199 C200 C203 C206


10uF 100PF 0.1uF 0.1uF 0.1uF

20% 5% 10% 10% 10%

16V 50V 10V 10V 10V

U U U U U

C333 C335 C340 C341 C342


0.022uF 0.0047uF 220PF 0.0015uF 0.0033uF

10% 10% 10% 10% 10%

16V 50V 50V 50V 16V

U U U U U

C506 C507 C508 C509 C510


10uF 22uF 0.1uF 0.1uF 0.1uF

20% 20% 10% 10% 10%

16V 10V 10V 10V 10V

U U U U U

C207 C209 C213 C215 C217


0.001uF 0.022uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

50V 16V 10V 10V 10V

U U U U U

C343 C347 C348 C349 C350


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C511 C512 C523 C527 C528


0.022uF 0.22uF 1uF 0.1uF 0.1uF

10% 10% 20% 10% 10%

16V 6.3V 6.3V 10V 10V

U U U U U

C218 C219 C221 C222 C223


0.1uF 0.1uF 0.1uF 0.1uF 0.22uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 6.3V

U U U U U

C351 C352 C353 C354 C356


0.1uF 0.1uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

10V 10V 50V 50V 50V

U U U U U

C529 C530 C531 C532 C533


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U

C224 C225 C226


0.1uF 100PF 0.1uF

10% 5% 10%

10V 50V 10V

U U U

C357 C358 C359


0.001uF 0.001uF 0.1uF

10% 10% 10%

50V 50V 10V

U U U

C534 C535 C536


0.1uF 0.1uF 0.1uF

10% 10% 10%

10V 10V 10V

< NETWORK RESISTOR >

< VIBRATOR > U X301 VIBRATOR, CRYSTAL (33.8688MHz) ***************************************************************** S

A-1433-743-A

BMD-002 COMPL (SERVICE) ************* < CAPACITOR >

U U U U U

C101 C102 C103 C104 C105


0.1uF 0.1uF 0.001uF 0.001uF 0.001uF

10% 10% 10% 10% 10%

10V 10V 50V 50V 50V

U U U U U

C106 C107 C108 C109 C110


0.001uF 47uF 0.1uF 0.1uF 0.1uF

10% 20% 10% 10% 20%

50V 6.3V 10V 10V 16V

U

C113

CERAMIC CHIP

0.1uF

10%

10V

Part No.

Description

Part No.

Descriptio n

Part No.

Description

Remark


SC

R ef . N o.

R em ar k

SC

R ef . N o.

U U U U U

C537 C538 C539 C540 C541

P ar t N o.


D es cr ip ti on 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

CN102 CN103 CN104 CN301 CN502

U U U U U

C542 C543 C544 C545 C546


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C547 C548 C549 C550 C551


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C552 C553 C554 C555 C556


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C557 C558 C559 C560 C562


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C564 C566 C568 C570 C572


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C574 C576 C578 C580 C583


0.1uF 0.1uF 0.1uF 0.1uF 0.1uF

10% 10% 10% 10% 10%

10V 10V 10V 10V 10V

U U U U U

C584 C605 C606 C607 C608


0.1uF 0.1uF 1uF 22uF 22uF

10% 10% 10% 20% 20%

10V 10V 10V 10V 10V

U U U U U

C609 C610 C611 C612 C613

TANTAL. CHIP ELECT CHIP ELECT CHIP ELECT CHIP ELECT CHIP

47uF 100uF 100uF 100uF 100uF

20% 20% 20% 20% 20%

6.3V 16V 6.3V 6.3V 6.3V

U U U U U

C614 C615 C616 C648 C649


1uF 0.1uF 100PF 1uF 1uF

10% 10% 5% 10% 10%

10V 10V 50V 6.3V 6.3V

U U U U

C650 C651 C652 C653

CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP

0.1uF 0.1uF 0.1uF 1uF

10% 10% 10% 10%

16V 16V 10V 10V

U U U U

! !

!

D100 D101 D501 D502

P ar t N o.

SC

R ef . N o.

SC

R ef . N o.

CONNECTOR, FFC/FPC (ZIF) 8P CONNECTOR, FFC/FPC (ZIF) 45P PIN, CONNECTOR 2P CONNECTOR, FFC/FPC (ZIF) 60P PIN, CONNECTOR (PC BOARD) 4P

D es cr ip ti on

U U U U U

Q105 Q106 Q107 Q109 Q111

TRANSISTOR DTC144EE-TL TRANSISTOR UMH2NTN TRANSISTOR DTA143EE-TL TRANSISTOR DTC144EE-TL FET RTQ035P02TR

U U U U U

R278 R282 R283 R284 R285


470K 10 10 10 10

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

< DIODE >

U U U U

Q112 Q500 Q502 Q503

TRANSISTOR UMH2NTN FET RSQ035P03TR FET IRF7422D2TRPBF TRANSISTOR 2SC5658T2L

U U U U U

R301 R302 R303 R304 R305


47K 47K 47K 47K 47K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R101 R102 R105 R106 R107


68 180 10K 10K 47K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R307 R309 R310 R311 R315

RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP

47K 33 33 33 12K

5% 5% 5% 5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R108 R109 R110 R121 R122


47K 47K 10K 10K 100

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R324 R326 R329 R332 R335

RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

10K 10K 47K 47K 3K

5% 0.5% 0.5% 0.5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R124 R126 R139 R153 R154

METAL CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP

12K 1K 3.3K 10K 10K

0.5% 5% 0.5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R336 R342 R343 R344 R346

RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP

47K 4.7K 4.7K 470 1.5K

5% 0.5% 0.5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R155 R157 R158 R163 R180

RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP

10K 47K 47K 0.33 0.56

5% 0.5% 0.5% 1% 5%

1/16W 1/16W 1/16W 1/2W 1/3W

U U U U U

R348 R349 R350 R351 R354


4.7K 22K 22K 4.7K 4.7K

0.5% 0.5% 0.5% 0.5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R181 R187 R202 R203 R204

METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP

0.56 10K 12K 24K 10K

5% 0.5% 0.5% 0.5% 5%

1/3W 1/16W 1/16W 1/16W 1/16W

U U U U U

R357 R358 R359 R360 R361

RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP

1K 4.7K 1K 100 22K

5% 0.5% 5% 5% 0.5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R212 R214 R217 R218 R219


1.8K 15K 10K 100 100

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R363 R366 R367 R368 R369

METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP

22K 47K 100 100 100

0.5% 0.5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R222 R241 R243 R244 R245


1 1 22 22 22

5% 5% 5% 5% 5%

1/3W 1/3W 1/10W 1/10W 1/10W

U U U U U

R370 R374 R375 R376 R377


100 47K 47K 47K 47K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R378 R379 R380 R381 R382

RES-CHIP SHORT CHIP RES-CHIP RES-CHIP METAL CHIP

47K 0 4.7K 4.7K 4.7K

5%

1/16W

5% 5% 0.5%

1/16W 1/16W 1/16W

U U U U U

R383 R384 R386 R387 R388


4.7K 47K 47K 47K 47K

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U

R389 R391 R392

METAL CHIP METAL CHIP METAL CHIP

10K 10K 10K

0.5% 0.5% 0.5%

1/16W 1/16W 1/16W

DIODE DIODE DIODE DIODE

R em ar k

RR264M-400 RR264M-400 RB051LA-40TR DAP202K-T-146

< FERRITE BEAD > U U U U

FB301 FB527 FB528 FB557

FERRITE, EMI (SMD) (1608) FERRITE, EMI (SMD) FERRITE, EMI (SMD) FERRITE, EMI (SMD) (2012) < FILTER >

U U U U

FL103 FL104 FL500 FL503

FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD) FILTER, EMI REMOVAL (SMD)

U U U U U

IC103 IC108 IC110 IC300 IC303

IC IC IC IC IC

BD7956FS-E2 BA5888FP-E2 CXA2720R-TL CXD5065GB-1 NJM13403V(TE2)

U U U U U

IC304 IC309 IC310 IC500 IC501

IC IC IC IC

K4S641632K-UC75T MX25L1005MC-12G PST3629UL PST3810UL

U U U U U

IC503 IC507 IC508 IC509 IC510

IC IC IC IC IC

TPS64201DBVRG4 TC7WH74FK(TE85R) TPS64203DBVRG4 BD7800FP-E2 PST3443UL

< IC >

< COIL > 150uH 10uH 4.7uH 10uH 10uH

!

CN100 CN101

CONNECTOR, FFC/FPC (ZIF) 19P CONNECTOR, FFC/FPC (ZIF) 14P

R em ar k

COIL, CHOKE COIL, CHOKE COIL, CHOKE COIL, CHOKE COIL, CHOKE

U U U U U

L506 L507 L508 L509 L510

COIL, CHOKE 1uH COIL, CHOKE 4.7uH COIL, CHOKE 4.7uH COIL, CHOKE 4.7uH INDUCTOR (EMI FERRITE) (2012)

U U U U U

R246 R258 R259 R260 R265

METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP

22 680K 5.6 100 22K

5% 5% 5% 5% 0.5%

1/10W 1/16W 1/3W 1W 1/16W

U U

L511 L514

INDUCTOR (EMI FERRITE) (2012) INDUCTOR (EMI FERRITE) (2012)

U U U U U

R267 R268 R269 R270 R272


22K 10K 10K 2.2K 100

0.5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U

Q102 Q103 Q104

U U

R273 R277

RES-CHIP RES-CHIP

100 47K

5% 5%

1/16W 1/16W

FET RTR025N03TL FET RTR025N03TL TRANSISTOR UMH2NTN

P ar t N o.

D es cr ip ti on

R em ar k

< RESISTOR >

L100 L101 L103 L500 L503

< TRANSISTOR >

!

D es cr ip ti on

U U U U U

< CONNECTOR > U U

P ar t N o.


SC

Ref. No.

Remark

SC

Ref. No.

U U U U U

R397 R399 R400 R401 R402

Part No.


Descriptio n 47K 47K 33 33 33

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R521 R522 R523 R533 R534

Part No.

METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP

Description 3.3K 150 0.047 20K 36K

0.5% 0.5% 1% 5% 5%

1/16W 1/16W 1/4W 1/16W 1/16W

Remark

U U U U U

R403 R404 R408 R409 R411

RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP

33 33 47K 47K 47K

5% 5% 0.5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R536 R537 R538 R539 R553

RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP

100K 4.7K 6.8K 1K 10K

5% 5% 5% 0.5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R416 R419 R420 R421 R422


82 82 82 82 22

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R423 R424 R425 R426 R427


82 22 82 82 22

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R430 R431 R432 R433 R434

RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP

82 82 4.7K 4.7K 47K

5% 5% 0.5% 0.5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R435 R436 R437 R438 R442


1K 1K 1K 1K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R443 R444 R449 R452 R453

RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP

47K 47K 47K 47K 47K

5% 0.5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R459 R460 R463 R464 R465


10K 10K 100K 10K 10K

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R472 R473 R474 R475 R476

METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP

3K 3K 75 18K 47K

0.5% 0.5% 0.5% 0.5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R485 R486 R487 R488 R502


47K 47K 47K 47K 10

5% 5% 5% 5% 5%

1/16W 1/16W 1/16W 1/16W 1/16W

U U U U U

R503 R504 R506 R508 R509

METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP

0.047 10K 560K 270K 10K

1% 5% 0.5% 0.5% 5%

1/4W 1/16W 1/16W 1/16W 1/16W

U U U

R511 R516 R520

METAL CHIP RES-CHIP METAL CHIP

27K 10K 2K

0.5% 5% 0.5%

1/16W 1/16W 1/16W

< NETWORK RESISTOR > U U U U U

RB300 RB301 RB302 RB303 RB304

RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005)

U U U U U

RB305 RB306 RB307 RB308 RB309

RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 33X4 (1005) RES, NETWORK 4.7KX4 (1005) RES, NETWORK 4.7KX4 (1005)

U

RB312

RES, NETWORK 4.7KX4 (1005)

U

X301

< VIBRATOR > VIBRATOR, CERAMIC (33.868MHz)

sony_playstation_3_bdpt1001_bpx2001_sm-bdd-0013e-01_[ET]

Recommend Documents