sony-cpd_e220.pdf

CPD-E220/E215E/E220E [CPD-E220]

SERVICE MANUAL

Equator Model S. Hemisphere Model N. Hemisphere Model Chassis No. SCC-L35B-A [CPD-E215E]

AEP Model Chassis No. SCC-L35D-A [CPD-E220E]

AEP Model Chassis No. SCC-L35C-A

H1 CHASSIS SPECIFICATIONS CRT

Viewable image size

Resolution Maximum

Recommended Standard image area Deflection frequency*

AC input voltage/current Power consumption Dimensions Mass Plug and Play

0.24 mm aperture grille pitch (center) 17 inches measured diagonally 90-degree deflection FD Trinitron Approx. 327 × 243 mm (w/h) (14 3/4 × 9 5/8 inches) 16.0" viewing image

* Recommended horizontal and vertical timing condition • Horizontal sync width should be more than 1.0 µsec. • Horizontal blanking width should be more than 3.0 µsec. • Vertical blanking width should be more than 500 µsec. Design and specifications are subject to change without notice.

Horizontal: 1600 dots (E220/E220E) 1280 dots (E215E) Vertical: 1200 lines (E220/E220E) 1024 lines (E215E) Horizontal: 1024 dots Vertical: 768 lines Approx. 312 × 234 mm (w/h) (12 3/8 × 9 1/4 inches) Horizontal: 30 to 85 kHz (E220/E220E) 30 to 70 kHz (E215E) Vertical: 48 to 120 Hz 220 to 240 V, 50/60 Hz, 0.9 A 120 W Approx. 404 × 413.5 × 419.5 mm (w/h/ d) (16 × 16 3/8 × 16 5/8 inches) Approx. 20 kg (44 lb 1 oz) DDC1/DDC2B/DDC2Bi

TRINITRON COLOR COMPUTER DISPLAY ®

CPD-E220/E215E/E220E

SAFETY CHECK-OUT

After correcting the original service problem, perform the following safety checks before releasing the set to the customer: 1. Check the area of your repair for unsoldered or poorly-soldered connections. Check the entire board surface for solder splashes and bridges. 2. Check the interboard wiring to ensure that no wires are “pinched” or contact high-wattage resistors. 3. Check that all control knobs, shields, covers, ground straps, and mounting hardware have been replaced. Be absolutely certain that you have replaced all the insulators. 4. Look for unauthorized replacement parts, particularly transistors, that were installed during a previous repair. Point them out to the customer and recommend their replacement. 5. Look for parts which, though functioning, show obvious signs of deterioration. Point them out to the customer and recommend their replacement. 6. Check the line cords for cracks and abrasion. Recommend the replacement of any such line cord to the customer. 7. Check the B+ and HV to see if they are specified values. Make sure your instruments are accurate; be suspicious of your HV meter if sets always have low HV. 8. Check the antenna terminals, metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC Leakage. Check leakage as described below. To Exposed Metal Parts on Set

0.15 µF

1.5 kΩ

AC Voltmeter (0.75 V)

Earth Ground

Fig. A. Using an AC voltmeter to check AC leakage.

LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers’ instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The “limit” indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOMs that are suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A) WARNING!! NEVER TURN ON THE POWER IN A CONDITION IN WHICH THE DEGAUSS COIL HAS BEEN REMOVED. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY SHADING AND MARK 0 ON THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. CIRCUIT ADJUSTMENTS THAT ARE CRITICAL FOR SAFE OPERATION ARE IDENTIFIED IN THIS MANUAL. FOLLOW THESE PROCEDURES WHENEVER CRITICAL COMPONENTS ARE REPLACED OR IMPROPER OPERATION IS SUSPECTED. AVERTISSEMENT!! NE JAMAIS METTRE SOUS TENSION QUAND LA BOBINE DE DEMAGNETISATION EST ENLEVÉE. ATTENTION AUX COMPOSANTS RELATIFS À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE TRAME ET UNE MARQUE 0 SONT CRITIQUES POUR LA SÉCURITÉ. NE LES REMPLACER QUE PAR UNE PIÈCE PORTANT LE NUMÉRO SPECIFIÉ. LES RÉGLAGES DE CIRCUIT DONT L’IMPORTANCE EST CRITIQUE POUR LA SÉCURITÉ DU FONCTIONNEMENT SONT IDENTIFIÉS DANS LE PRÉSENT MANUEL. SUIVRE CES PROCÉDURES LORS DE CHAQUE REMPLACEMENT DE COMPOSANTS CRITIQUES, OU LORSQU’UN MAUVAIS FONCTIONNEMENT EST SUSPECTÉ.

–2–


POWER SAVING FUNCTION This monitor meets the power-saving guidelines set by VESA, ENERGY STAR, and NUTEK. If the monitor is connected to a computer or video graphics board that is DPMS (Display Power Management Signaling) compliant, the monitor will automatically reduce power consumption in three stages as shown below. Power mode

Power consumption

1 (power) indicator

normal operation

≤ 120 W

green

1 standby

≤ 15 W

green and orange alternate

2 suspend (sleep)*

≤ 15 W

green and orange alternate

3 active off** (deep sleep)*

≤3W

orange

power off

0W

off

* “Sleep” and “deep sleep” are power saving modes defined by the Environmental Protection Agency. ** When your computer is in a power saving mode, MONITOR IS IN POWER SAVE MODE appears on the screen if you press any button on the monitor. After a few seconds, the monitor enters the power saving mode again.

DIAGNOSIS This monitor is equipped with a self-diagnosis function. If there is a problem with your monitor or computer, the screen will go blank and the 1 (power) indicator will either light up green or flash orange. If the 1 (power) indicator is lit in orange, the computer is in power saving mode. Try pressing any key on the keyboard.

If all four color bars appear (white, red, green, blue), the monitor is working properly. Reconnect the video input cable and check the condition of your computer. If the color bars do not appear, there is a potential monitor failure. Inform your authorized Sony dealer of the monitor’s condition.

MENU

If the 1 (power) indicator is flashing orange

RESET

1 (power) indicator

If the 1 (power) indicator is green 1 Disconnect the video input cable or turn off the connected computer.

2 Press the 1 (power) button twice to turn the monitor off and then on.

Press the 1 (power) button twice to turn the monitor off and then on. If the 1 (power) indicator lights up green, the monitor is working properly. If the 1 (power) indicator is still flashing, there is a potential monitor failure. Count the number of seconds between orange flashes of the 1 (power) indicator and inform your authorized Sony dealer of the monitor’s condition. Be sure to note the model name and serial number of your monitor. Also note the make and model of your computer and video board.

3 Move the control button , for 2 seconds before the monitor enters power saving mode. MENU

–3–


TIMING SPECIFICATION PRIMARY MODE MODE AT PRODUCTION

MODE 1

MODE 2

MODE 3

MODE 4

MODE 5

MODE 6

MODE 7

MODE 8

640 X 480

800 X 600

832 X 624

1024 X 768

1024 X 768

720 X 400

640 X 480

1280 X 1024

25.175 MHz

56.250 MHz

57.283 MHz

78.750 MHz

94.500 MHz

28.322 MHz

36.000 MHz

135.000 MHz

31.469 kHz

53.674 kHz

49.725 kHz

60.024 kHz

68.677 kHz

31.469 kHz

43.269 kHz

79.976 kHz

usec

usec

usec

usec

usec

usec

usec

usec

H. TOTAL

31.778

18.631

20.111

16.660

14.561

31.777

23.111

12.504

H. BLK

6.356

4.409

5.586

3.657

3.725

6.355

5.333

3.022

H. FP

0.636

0.569

0.559

0.203

0.508

0.636

1.556

0.119

H. SYNC

3.813

1.138

1.117

1.219

1.016

3.813

1.556

1.067

RESOLUTION CLOCK — HORIZONTAL — H-FREQ

H. BP

1.907

2.702

3.910

2.235

2.201

1.907

2.222

1.837

H. ACTIV

25.422

14.222

14.524

13.003

10.836

25.422

17.778

9.481

59.940 Hz

85.061 Hz

74.550 Hz

75.030 Hz

84.997 Hz

70.087 Hz

85.008 Hz

75.025 Hz

lines

lines

lines

lines

lines

lines

lines

lines

V. TOTAL

525

631

667

800

808

449

509

1066

V. BLK

45

31

43

32

40

49

29

42

V. FP

10

1

1

1

1

12

1

1

V. SYNC

2

3

3

3

3

2

3

3

V. BP

33

27

39

28

36

35

25

38

V. ACTIV

480

600

624

768

768

400

480

1024

— VERTICAL — V. FREQ(HZ)

— SYNC — INT(G) EXT(H/V)/POLARITY EXT(CS)/POLARITY INT/NON INT

NO

NO

NO

NO

NO

NO

NO

NO

YES -/-

YES +/+

YES -/-

YES +/+

YES +/+

YES -/+

YES -/-

YES +/+

NO

NO

NO

NO

NO

NO

NO

NO

NON INT

NON INT

NON INT

NON INT

NON INT

NON INT

NON INT

NON INT

2000.8.28 VER.

–4–


TABLE OF CONTENTS Section

Title

Page

1. GENERAL .................................................................. 1-1 2. DISASSEMBLY 2-1. 2-2. 2-3. 2-4. 2-5. 2-6.

Cabinet Removal ................................................. A and D Boards Removal ................................... Service Position .................................................... Picture Tube Removal .......................................... H Board Removal ................................................. Harness Location ..................................................

2-1 2-1 2-2 2-2 2-3 2-4

3. SAFETY RELATED ADJUSTMENT ............. 3-1 4. ADJUSTMENTS ...................................................... 4-1 5. DIAGRAMS 5-1. 5-2. 5-3. 5-4. (1) (2) (3) 5-5.

Block Diagrams ................................................... 5-1 Frame Schematic Diagram .................................. 5-5 Circuit Boards Location ...................................... 5-6 Schematic Diagrams and Printed Wiring Boards .. 5-7 Schematic Diagram of H Board ......................... 5-8 Schematic Diagram of A Board ......................... 5-9 Schematic Diagrams of D (a, b, c, d) Board .................................. 5-13 Semiconductors .................................................. 5-23

6. EXPLODED VIEWS 6-1. 6-2. 6-3.

Chassis ................................................................. 6-1 Picture Tube ........................................................ 6-2 Packing Materials ................................................ 6-3

7. ELECTRICAL PARTS LIST ............................ 7-1

–5–


SECTION 2 DISASSEMBLY 2-1. CABINET REMOVAL Push in the tip of a screwdriver about 10mm to unlock the claw.

Cabinet Cabinet

2

Bezel assembly

Bezel assembly

3

1

Two claws

Cabinet

Two screws (+BVTP 4 x 16)

2-2. A AND D BOARDS REMOVAL 7

A board

CN309 CN307 CN304 GND CN303 GND

CN2

CN310

CN302 CN301

GND

9

CN903 CN602

Connector (2P)

Three screws (+BVTT 3 x 12) 2

Cable stopper 1

GND

10

Four screws (+BVTT 3 x 8)

8 12

6

Screw (+BVTT 3 x 8 )

I/O cable assembly

D board

3

Cable holder 5

Cable 4

2-1

Cable cover

Screw (+M 4 x 8)


2-3. SERVICE POSITION

A board

1 3

2

2-4. PICTURE TUBE REMOVAL 2

A board

GND

CN307 GND

9

Tention spring

3 8

Degauss coil

10 11

Two screws (+BVTP 4 x 16)

Neck assembly

Deflection yoke

CN602

5 6

Four screws (Hexagon)

CN2

Chassis assembly

CN903 Connector (2P)

1

Anode cap (See page 2-3.)

4

12 13

Two degauss coil holder

Two degauss coil holder

Bezel assembly Cussion 7

2-2

Picture tube

Two screws (+BVTT 4 x 8)


2-5. H BOARD REMOVAL

1

Screw (+BVTP 4 x 16) 2 3

H bracket

Claw

Picture tube

4

5

H board

Menu button

Bezel assembly

Cussion

• REMOVAL OF ANODE-CAP NOTE: Short circuit the anode of the picture tube and the anode cap to the metal chassis, CRT shield or carbon painted on the CRT, after removing the anode.

• REMOVING PROCEDURES c b a

Anode Button

1 Turn up one side of the rubber cap in the direction indicated by the arrow A.

2 Using a thumb pull up the rubber cap firmly in the direction indicated by the arrow B.

• HOW TO HANDLE AN ANODE-CAP 1 Don’t scratch the surface of anode-caps with sharp shaped material! 2 Don’t press the rubber hardly not to damage inside of anodecaps! A material fitting called as shatter-hook terminal is built in the rubber. 3 Don’t turn the foot of rubber over hardly! The shatter-hook terminal will stick out or damage the rubber.

2-3

3 When one side of the rubber cap is separated from the anode button, the anode-cap can be removed by turning up the rubber cap and pulling up it in the direction of the arrow C.


2-6. HARNESS LOCATION

Degauss coil H board

Picture tube

CN2

CN1

CN903

CN505

CN901

CN603

D board

CN504

CN501

CN502

CN902

CN602

CN302

AC inlet

CN301 CN304

CN303

CN309

CN310

CN307

A board

2-4


SECTION 3 SAFETY RELATED ADJUSTMENT 8)

When replacing parts shown in the table below, the following operational checks must be performed as a safety precaution against X-ray emissions from the unit. Part Replaced ( ] )

HV Regulator Circuit

D board

IC502, T501 (FBT)

HV HOLD DOWN Circuit

D board

D538, R521, T501 (FBT)

Beam Current Protector Circuit

D board

IC901, R949, T501 (FBT)

After adjusting the High Voltage within specification, put the VR cover on VR501 as shown below and apply sufficient amount of RTV around VR501.

b) HV Protector Circuit Check 1) Confirm that the voltage between cathode of D517 an GND is more than 27.5 VDC. 2) Using an external DC Power supply, apply the voltage shown below between cathode of D517 on "D" and GND, and confirm that the HV Hold-Down circuit works. (Raster disappears) Apply DC Voltage: Less than 35.8 VDC.

Allow the unit to warm up for one minute prior to checking the following conditions:

Check Condition • Input voltage • Input signal • Controls • B+ Voltage

a) HV Regulator Check 1) Input white cross hatch signal. (fH = 69 kHz) 2) CONT maximum and BRT center 3) Cut off Screen VR (G2). 4) Input voltage: 120 ± 2 VAC 5) Confirm that the voltage is within the voltage range shown below. Standard voltage: 26.9 KV ± 0.4 KV 6) When replacing components identified by ], make sure to recheck the High Voltage. 7) Verify the High Voltage as shown above (26.9 KV ± 0.4 KV) is within specification. If not, set H. SIZE data at minimum (-127) and then adjust VR501 on "D" Board.

: 120 ± 2 VAC : (fH = 69 kHz), White Cross Hatch : CONT (max) & BRT (center) : 179 ± 3.0 VDC

c) Beam Protector Check (Software logic) 1) Using an external current source, apply < 1.55mA between pin qa of FBT (T501) and GND, and confirm that the raster fades out. Check Condition • Input voltage • Input signal • Controls

: 120 ± 2 VAC : (fH = 69 kHz), White Cross Hatch : CONT (max) & BRT (center)

d) B+ Voltage Check 1) Input white cross hatch (fH = 69 kHz) signal. 2) CONT (max) & BRT (center) 3) Input voltage: 120 ± 2 VAC Note: Use NF power supply or make sure that distortion factor is 3% or less. 4) Confirm that the voltage is within the voltage range shown below. Standard voltage: 179 ± 3.0 VDC

VR501

3-1


#2 SECTION 4 ADJUSTMENTS

Connect the communication cable of the computer to the connector located on the monitor. Run the service software and then follow the instruction. I2C Interface Card

I2 C Interface Cable HD15 Connector Adapter Computer as a Jig

Video Cable

• Landing Fine Adjustment 1. 2. 3. 4.

Put the set inside the Helmholtz coil. Set TLH plate to zero position. Input the single green signal. Demagnetize the CRT surface with the hand degausser , and perform auto degaussing. 5. Attach the wobbling coil to the designated part of the CRT neck. 6. Attach the sensor of the landing adjustment unit on the CRT surface. Purity magnet position

L/D control specification ±5 ±5 ±5

a d

±5 ±5 ±5

(µm)

10. If the corner landing is out of specification, put a disk magnet for the landing correction. 11. Perform auto degauss in case disk magnets are used. 12. Remove the sensor and wobbling coil. 13. Fix purity magnet on DY with UL black tape.

7. Adjust the DY position and purity, and the DY tilt. 8. Fasten DY with screw. Note: Torque 20 +2 -1 kgcm 9. Adjust top and bottom pins by pitching DY up and down with two wedges. Also leave the yaw of DY to physical center position with Another two wedes.

c

±7 ±7 ±7

“a” and “b” must be equal, and “c” and “d” must be equal.

b

4-1


• Convergence Specification

• Convergence Rough Adjustment 1. Enter the crosshatch signal. 2. Recheck focus and readjust when focus was worse. 3. Adjust roughly H. STAT and V. STAT convergence by 4 pole magnet. 4. Adjust roughly HMC and VMC by 6 pole magnet.

B

• Convergence Adjustment 1. Open H and V Stat by 4 pole magnet. 2. Adjust 6 pole magnet perform HMC and VMC. 3. Adjust 4 pole magnet close both Stat of R.G.B just overlap each other Horizontal and Vertical. 4. Adjust TLH for side MC by TLH magnet when R or B is in the opposite direction. 5. Adjust XCV to correct Vertical cross MC. 6. Adjust XBV to correct Vertical bow MC. 7. Adjust TLV to corect Vertical tilt MC. 8. Adjust YCH to correct top and bottom Horizontal cross MC. 9. Adjust YBH to correct top and bottom Horizontal bow MC. 10. Using permalloys to correct MC of the cornters. 11. Check convergence for whole screen. If necessary, perform step from 3-9 and correct with permalloys. 12. Paint lock 4 pole magnet, 6 poles magnets, XBV reactor XCV corrector and TLH corrector handle.

A

0.30 mm

B

0.35 mm

• Vertical and Horizontal Position and Size Specification A

b

B Purity Mg.

All mode

• White Balance Adjustment Specification (1) 9300K (2) 6500K x = 0.283 ± 0.01 x = 0.313 ± 0.01 y = 0.298 ± 0.01 y = 0.329 ± 0.01 (2) 5000K x = 0.346 ± 0.01 y = 0.359 ± 0.01

a 6Pole Mg

MODE

A

TLH

MODE

All mode

A

312 mm

B

234 mm

XCV

a b

YV

YCH

CRT

DY

1.5 mm 1.5 mm

• Focus adjustment Adjust the focus volume 1 and 2 for the optimum focus.

4Pole Mg

XCV

XBV

YCH B

R

TLV

R

B YBH

TLH R B B R

Focus 1 (V) Focus 2 (H)

B

R

R

B

B

R

R

B

FBT

4-2

A

C

D

TO D BOARD CN903

TO D BOARD CN902

TO D BOARD CN603

11

12

13

14

15

B

6

7

8

9

10

TO D BOARD CN901

1

2

3

4

5

SIGNAL-IN HD15 PIG-TAIL

P701 MENU ORANGE/LED GREEN/LED

ABL +5V +6.3V +12V +81V

CN303

CN302 CLAMP SDA/I SCL/I H_RTN V_RTN G1

CN301 RED GREEN BLUE

5-1. BLOCK DIAGRAMS

1 2 3

5 6 4 3 1

H

7 8 9 3 4 5

2 4 6

LED701 POWER

5-1

SW701 MENU

CLAMP AMP Q001,002

SONG BUFF Q008

(VIDEO, RGB OUT)

(USER CONTROL)

+5V +6.3V +12V +81V

A

DIAGRAMS

SECTION 5

15 ABL IN

27 BLK

21 SDA 20 SCL

19 CLAMP

7 SOGI

2 R IN 6 G IN 11 B IN

6

17 P5/B

18 HOR

19 VERT

H SYNC BUFF Q003 V SYNC BUFF Q005

5 SCK

6 SIN

12 P0/BK0

15 P3/G

OSD BLKIN 1

P6 9 P7 10

P2 14 P4 16

D105

D205

D305

G2 CONT Q004

B VOUT1 1

G VOUT3 5

R VOUT2 3

IC003 OSD

OSDB 13

7

OSDG 9

– +

13 P1/R

5

IC004 AMP

R CUT-OFF Q101

G CUT-OFF Q201

OSDR 4

DA1 26

DA2 25

DA3 24

DA4 23

11 B VIN1

B OUT 29

B CUT-OFF Q301

8 G VIN3

9 R VIN2

IC002 RGB OUT

G OUT 32

R OUT 35

IC001 PRE AMP,OSD MIX

B-SS3562-BD1-EPS05

2 1 4 3

1

CN304 CS0 CS1 CS2 CS3

CN309 1.2kV

R.G.B

G1 G2

5-2

CRT

F

E

TO D BOARD FBT

TO D BOARD FBT

TO D BOARD FBT

TO D BOARD CN502

TO D BOARD CN504

FV1

FV2

HV

B

D

TO A BOARD CN302

TO H BOARD P701

DGC

A

TO VIDEO CABLE

2 3 1

CN903 ORANGE/LED GREEN/LED MENU

DGC NC DGC

CN602

1 2 3

6 2 1 7 5

V_RTN SDA/I SCL/I H_RTN G1

AC-SOCKET

3

CN901 CLAMP

CN601

1 3 4 5 6

CN902 H-IN V-IN PCDET SDA SCL

TH602

F601

S601 POWER

RELAY DRIVE Q615

RY601

LF601 LFT

SW901 RESET

#3 E220, E220E

#3 E215E

+5V

OUT 3

IC606

TH601

K

G

K

A

G

D601 AC RECT

IC604

A

TEST 7 SDA 5 SCL 6

IC902 EEP ROM

H_RETURN

ABL/O

H SYNC BUFF Q902

1 IN

IC903 RESET

PB0/SCLD

PD6/CLAMPOUT PB1/SDAD

VSYNCI

5-3

D610

L606

PC3/PWM3 4

PA2/TDO 38

PC7/PWM7 8

PS5/PWM5 6

D627

SW Q401

2

FB

COMP

V AEF

1

OSC

4

I SENSE

OUT

Vcc

IC601 PWM CONTROL

8

D623

T601

#3 E220 [NH], E220E, E215E

PA4 36

PA5 35

PB6/AIN2/PWM0 10

PB7/AIN3/PWM1 9

PC4/PWM4 5

PA7/BLANKOUT 31

D609

SW Q601

SW Q611

JW106

OSCIN 33

OSCOUT 32

3

6

7

FB603

SWITCHING Q602

JW105

#3 E220 [SH, EQ]

D626

BOP CONT Q532,535

19 SDA

18 SCL

D604 1

9

3

Q531

Q532,535

+12V

IC 501 DEFLECTION CONTROL

17 HUNLOCK

15 HSYNC

PD4/ITB 24

14 VSYNC

16 CLBL

PD0/V SYNCO 20

X901 24MHz

BUFF Q526

PD1/H SYNCO 21

PA6 34

PD3/ITA/VFBACK 23

#3 E220 [SH, EQ]

7 PS6/PWM6

37 PA3

12 PB4/AIN0

42 PA0/OCMP 39 PA1/RDI

29 PB2/SCU

1 PC0/HSYNCDIV 30 PB3/SDAI

25 PD5/HFBACK

11 PB5/AIN1

19 26 28 27

18 HSYNCI

40 Reset

IC901 CPU

8

H DRIVE Q520,521

18

17

16

13

12

10

D618

D622

D617

K

+5V

D615

D628

D616

D631

D613

7 +V IN

IC401 V OUT OUT 5

H DRIVE OUT Q502

R

D612

+ –

A

IC603 VOLTAGE FEED BACK

2

3

IC504 AMP

B DRIVE Q515,516

1

+16V SW Q609

+16V SW CONT Q610

1 -V IN FLYBACK 3

+12V

#3 E220, E220E

11

D517

IC602 VOLTAGE FEED BACK

T603 PIT

BOP CONT Q510, Q513

FOCUS 32

BOP 3

BDRV 6

BIN 5

EWDRV 11

HFLB 1

VOUT2 12

VOUT1 13

HDRV

#3 E215E

-16V SW Q617

-16V SW CONT Q616, Q618

TILT DRIVE Q541, Q542

SYNC BUFF Q538, 539

DF AMP Q504, Q530

SWITCHING Q501

H DRIVE Q523,527

T503

T502

6

8

10

9

6

OVP Q525, 534

+6.3V SW Q607

+6.3V SW CONT Q608

D512

D511

1 IN

2

1

8

4

COMP

V AEF

FB

5

T504

H CENT DRIVE Q517,518

3

6

11

7

+5V SW Q603

+5V SW CONT Q604

I SENSE

OUT

IC502 PWM CONT

OSC

H OUT Q503

OUT 3

IC605 +5V REG

#3 E220, E220E

H CENT Q519

BUFF Q546

DF AMP Q514, Q543, Q544

1

2

5

1

5

Q522

RY501

L505

RELAY DRIVE Q540

+5V

+6.3V

-16V

+16V

+81V

+200V

D521

3

6

7

8

10

9

1

T501 FBT

ABL CONT Q528, 529

5-4

OUT 3

IC607 +12V REG 1 IN

D509

SW Q511

VR501 HV ADJ

5 1 3 4 6

1 2

1

4 1 2 3

B-SS3562-BD2-EPS05

µ-COM, DEFLECTION CONTROL, DEFLECTION, HV, POWER SUPPLY

+12V

FV2 TO CRT

FV1 TO CRT

HV TO CRT ANODE CAP

#3 E220, E220E

S CAP CHANGE Q506, Q508

ABL CONT Q533

4

15

13

FV2

FV1

14

11

12

HV

D

S CAP CHANGE Q505,Q524, Q536, Q537

1 2 3 4 5 6

CN603 CN305 ABL +81V +12V +6.3V +5V

CN505 ROTATION+ ROTATION-

CN504 1.2kV

CN502 CS1 CS2 CS3 CS0

H DY(-) V DY(-) V DY(+)

CN501 H DY(+) H DY(+) H DY(-)

C

TILT(ROTATION) COIL

E

F

V.DY

H.DY

TO A BOARD CN303

TO A BOARD CN309

TO A BOARD CN304

H

USER CONTROL

DGC

N

L

1 2 3

G

CN601 AC-SOCKET

DGC NC DGC

CN602 3P

CN903 4P

1 2 3 4

MENU ORANGE/LED GREEN/LED GND

1 2 3 4

P701 7P

MENU ORG LED GRN LED GND

GND +5V ABL +6.3V +12V GND +81V

5-2. FRAME SCHEMATIC DIAGRAM

CN303 7P

CN603 7P

5-5

CN302 9P

CN901 10P

A

VIDEO, RGB OUT

SOG GND H_RTN V_RTN G1 GND CLAMP SDA/I SCL/I

1 2 3 4 5 6 7 8 9

D

CN301 6P

RGND RED GGND GREEN BGND BLUE

µ-COM,DEFLECTION CONTROL, DEFLECTION,HV,POWER

Auto-Size(NC) 10 9 SOG 8 GND 7 H_RTN 6 V_RTN 5 G1 4 GND 3 CLAMP 2 SDA/I 1 SCL/I

7 6 5 4 3 2 1

7 6 5 4 3 2 1

GND +5V ABL +6.3V +12V GND +81V

CN304 4P CN502 4P

CS1 CS0 CS3 CS2 1 2 3 4

4 3 2 1 CS1 CS0 CS3 CS2

CN309 1P CN504 1P

1.2kV 1 1

1.2kV

1 2 3 4 5 6

VIDEO CABLE

VIDEO CABLE 1 2 3 4 5 6 7

CN902 7P

DY+ DY+ DYDYDYDY+

ROTATIONROTATION+

CN505 2P

H H H H V V

CN501 6P

B-SS3562-KESSENZU-EPS05

H-IN GND V-IN PCDET SDA SCL PC+5V(NC)

2 1

1 2 3 4 5 6

H DY

TILT(ROTATION) COIL

HV

V DY

HG H

RGB G1 G2

PICTURE TUBE

5-6

H

D

5-3. CIRCUIT BOARDS LOCATION

A

D board IC502, T501 (FBT)

D board D538, R521, T501 (FBT)

D board IC901, R949, T501 (FBT)

HV Regulator Circuit Check

HV Hold-down Circuit Check

Beam Current Protector Circuit Check

Part Replaced (])

• All resistors are in ohms. • f : nonflammable resistor. • F : fusible resistor. f : internal component. • • p : panel designation, and adjustment for repair. • All variable and adjustable resistors have characteristic curve B, unless otherwise noted. e : earth-ground. • • E : earth-chassis. • All voltages are in V. • Readings are taken with a 10 M digital multimeter. • Readings are taken with a color-bar signal input. • Voltage variations may be noted due to normal production tolerances. • * : Can not be measured. • Circled numbers are waveform references. • s : B + bus. • S : B – bus. • When replacing components identified by ] , make the necessary adjustments indicated. (See page 3-1) • When replacing the part in below table, be sure to perform the related adjustment.

Pitch: 5 mm Rating electrical power 1/4 W (CHIP : 1/10 W)

• All capacitors are in µF unless otherwise noted. (pF: µµF) Capacitors without voltage indication are all 50 V. • Indication of resistance, which does not have one for rating electrical power, is as follows.

Note:

5-7

5-4. SCHEMATIC DIAGRAMS AND PRINTED WIRING BOARDS

1 Circuit diagram division code

Ref. No.

Note: The components identified by shading and mark 0 are critical for safety. Replace only with part number specified.

b

H

Board

l

Schematic diagram

Note: Les composants identifiés par un tramé et une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.

a

• Divided circuit diagram One sheet of D board circuit diagram is divided into four sheets, each having the code D-a to D-d . For example, the destination ab1 on the D-a sheet is connected to ab1 on the D-b sheet.


P701 4P 1 2 3 4

LED701 LT6463-23-D51 (POWER)

2

3

H (USER CONTROL)

USER CONTROL

TO D-a BOARD CN901

(h)

D

C

B

A

1

(1) Schematic Diagram of H Board

R701 2.15k 1%

5-8

R706 3.83k

4

6

5

4

SW701

1

MENU 3 2

5

R709 17.4k 1%

R702 10.2k 1%

B-SS3562-H..-EPS05

R705 6.19k

6

7

I

H

G

F

E

D

C

B

6

7

8

9

11

12

13

14

15

SIGNAL IN HD15 PIG-TAIL

1

2

3

4

10

TO D-d BOARD CN603

+81VS GND +12V +6.3V ABL +5V GND

CN303 7P

TO D-a BOARD CN901

SOG GND H_RTN V_RTN G1 GND CLAMP SDA/I SCL/I

CN302 9P

+5V DDSCL DDSDA PCDET

CN306 4P

TO D-a BOARD CN902

H-IN GND V-IN PCDET DDSDA DDSCL

CN305 6P

H-IN V-IN GND RGND RED GGND GREEN BGND BLUE

R015 240 1/4W

R055 22k

R021 10k

C017 0.1 100V

D003 MTZJ5.1B

C027 470p

0

C020 47 16V

R028 1k

C048 220 16V

/WP

NC

VCLK

VCC

FB001 0.45µH

C019 0.1 100V

FB004 150µH

FB005 150µH

FB002 2µH

C011 10 100V

/TEST

VSS

SCL

IC005 24C21 DDC

+5V

C012 0.1 100V

C021 470 10V

+81VF

+80VF

C108 0.1

R102 4.7k

D012 1N4148

SDA

Q005 2SC945P V SYNC BUFF

5.0

+5V

D009 1N4148

C109 220p

FB009

C041 FB010 220p

D008 1N4148

R022 2.4k

R056 22k

C046 33p

C047 33p

C105 0.1

FB008

D013 1N4148

D011 1N4148

C026 2700p 50V

C120 0.1

R120 47 R106 47

R105 47

D010 1N4148

FB301 JW

FB201 JW

FB101 JW

H

0.75 Vp-p (H)

1

5-9

R302

L002

FB210

R008 2.4k

C022 390p 50V

1.08 Vp-p (H)

2

• A BOARD WAVEFORMS

1 2 3 4 5 6 7

1 2 3 4 5 6 7 8 9

1 2 3 4

1 2 3 4 5 6

1 2 3 4 5 6 7 8 9

R026 470

R046 3k

C302 10 50V

R013 4.7k

R029 1.5k

C035 100 10V

+5V

D301 1SS119

D302 1SS119

+5V

C029 1000p 50V

C004 0.22 16V

C303 0.1 50V

5.0

VSS

P1/R

3.10 Vp-p (H)

P7

C023 100 10V

P0/BK0

P2

TCK

VDD1

P3/G

SIN

P5/B

CS

P4

HOR

SCK

VERT

VIR

AC

IC003 M35047 OSD VDD2

P6

R054 1M

+5V

CPOUT

C103 0.1 50V

5.0

5.0

5.0

1.3

4

C032 1 50V

C033 4700p 50V

R012 1k

R016 470

+5V +12V

C203 0.1 50V

+12V

C002 220 16V

+12V

D201 1SS119

EXTFB

GNDA

GOUT

VCCR

OSDR

GNDR

MBRI

BOUT

EXTFB

BLK

SOGI

VCCG

OSDG

GNDG

0

R002 100

R001 100

R036 100

R037 100

R030 10k

0.2

5.0

5.0

2.9

2.9

1.5

2.1

0.6

4.7

2.1

1.1

4.4

2.9

2.0

C043 4.7 35V N.P

R004 100

L001 100µH

3.24 Vp-p (H)

R113 33

0

R213 33

0

C030 470 10V

R313 33

5

JW035 150µH

+5VF

CLAMP

SOG OUT

ABLIN

SCL

DA4

GND5

GNDB

SDA

DA3

OSDB

VCC

DA2

VCCB

NC

DA1

BIN

3

EXTFB

GIN

2

ROUT

VCC2

RIN

1

OSD BLKIN

IC001 M52743BSP PRE AMP,OSD MIX

0

3.8

5.0

0.6

4.4

0.1

2.6

0.1

2.9

0.1

2.6

0.1

C054 0.1

R003 18k

R308 20k

R208 20k

R108 20k

L301 0.1µH

L201 0.1µH

C010 0.1 50V

FB006 3µH C009 47 16V

FB218

7

GND

+12V

C038 47 16V

D001 1SS119

R309 470

3

FB215 R215 150 1/2W

C207 0.1

R025 2.2k

D305 HSS82

R311 1M

D304 HSS82

C306 0.1 100V

R209 470

1

D103 HSS82

C107 0.1

C037 0.22 16V

R032 1K

C028 330p

C014 1000p 2kV

SG001

C106 0.1 100V

R033 220k

C015 0.47 16V

R023 470k

+12V

C016 1000p

D105 HSS82

R111 1M

D104 HSS82

D017 ER106 C045 10000P 1.5KV

R042 100 1/2W

C013 0.1 50V

+6.3V FB003 2.2 2W

44.5 Vp-p (H)

8

R024 150k

R031 22M

D205 HSS82

R211 1M

D204 HSS82

C206 0.1 100V

R109 470

Q101 BF420 R CUT-OFF

+81V

Q004 2SC4634 G2 CONT

FB315 R315 100 1/2W

L102 0.47µH

52.7

2

FB115

R107 4.7k

Q201 BF420 G CUT-OFF

D203 HSS82

L202 0.47µH

10

R115 100 1/2W

R VOUT2

41.9

4

GND2

C012 0.1 100V

+81V

R207 4.7k

Q301 BF420 B CUT-OFF

D303 HSS82

5

53.1

6

VCC C011 10 100V

C307 0.1

C019 0.1 100V

+80VF

L302 0.47µH

C310 100p

G VIN3 8

G VOUT3

43.5 Vp-p (H)

7

R307 4.7k

C210 100p

R310 3k

+81V

C110 100p

R110 3k

R210 3k

9

R VIN2

2.9 2.0

10

11 2.1

+12VF

IC002 LM2415 RGB OUT

3.02 Vp-p (H)

6

D005 1SS119

C050 3900p 100V

R303 1k

R304 12

R203 1k

R204 12

L101 0.1µH

C304 C204 C104 0.1 0.1 0.1 50V 50V 50V

C008 0.1 50V

R005 1k

R006 10k

+12V

R103 1k

R104 12

C005 C006 220 0.1 16V 50V

+12VF

9

B VIN1

8

VBB

+12V D101 1N4148

D202 1SS119

7

GND1

6

D102 1N4148

C034 R039 0.1 2.4k 50V

R020 18k

C025 0.1 50V

Q002 2N3904 CLAMP AMP D002 1N4148

H

C102 10 50V C202 10 50V

0.75 Vp-p (H)

3

+5V

+80VF +81VF +12V +12V +6.3V

0.2

0.8

R010 100

R011 470

R014 4.7k

Q003 2N3904 H SYNC BUFF

0

4.4

+5V

D004 1SS119

R018 100

R019 100

Q001 2N3904 CLAMP AMP

-0.2

R007 100

1.1

R009 1k

+5V

R301 R201 R101 75 75 75

5

B VOUT1

4

A(VIDEO,RGB OUT)

6

CN301 9P

5

7

8

3

4

3

5

2

17 18

2

1

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19

A

1

1 2

20 19 18 17

3 4 5 6 7 8 9 10

R112 300 1/2W

6

5

4

OUT.B -IN.A

Vcc

OUT,A

Vee

R034 10k 1/2W

5-10

R035 2.2M 1/2W

1 2 3 4

1

CN309 1P

1.2kV

13

43.5 Vp-p (H)

qa

TO D-b BOARD CN502

CS1 CS0 CS3 CS2

CN304 4P

TO D-b BOARD CN504

43.5 Vp-p (H)

0

B-SS3562-A..-EPS05

HV TO D BOARD FBT

-IN.B +IN.A

+IN.B

IC004 LM358 AMP

SG301

SG201

SG101

12

V901 PICTURE TUBE

43.5 Vp-p (H)

9

J001 CRT_SOKET

RGB G1 G2

C039 100 16V

+12V

R312 300 1/2W

R212 300 1/2W

HG H

11

6

(2) Schematic Diagram of A Board

7 8

16 15 14 13 12 11

5

4 3 2 1

44.5 Vp-p (H)

qs

14

I

H

G

F

E

D

C

B

1 2 3 4 5 6 7

1 2 3 4

TO A BOARD CN302

R919 *

C915 *

C926 100p

R952 47

R945 47

D902 MTZJ-5.1A

R958 100

MENU ORANGE/LED GREEN/LED

ac1

ad1

C927 100p

0.5

R920 *

R959 *

HSYNC/O

RESET

Q902 * H SYNC BUFF

C909 470p

R951 28k

SW901

C924 4.7

R915 30.1k

R948 1.4k

C905 2.2

R950 47k

R949 10k

+5V

R921 1k

VSYNC/O

MENU

ABL/O

H-DRIVER

C904 2.2

C903 2.2

C902 2.2

C906 2.2

D910 1N4148

D911 1N4148

R914 33.2

R911 1k

R909 1k

R908 10k

R943 100

FB901 2µH

C910 0.1

R912 10k 1/8W

C908 0.1

+5V

R906 1k

R905 1k

R904 100

R903 1k

R902 1k

TILT TEST

0.4

0

4.2

0.5

C907 10

4.9

C925 0.1

C928 0.1

3.1

R907 1k

2.5

1.2

4.9

a

b

1

D-b sheet.

Circuit diagram division code

Ref. No.

5-13

• Divided circuit diagram One sheet of D board circuit diagram is divided into four sheets, each having the code D-a to D-d . For example, the destination ab1 on the D-a sheet is connected to ab1 on the

1 SCL/I 2 SDA/I 3 CLAMP 4 GND 5 G1 6 V_RTN 7 H_RTN 8 GND 9 SOG Auto-Size(NC) 10

CN901 10P

TO VIDEO CABLE

H-IN GND V-IN PCDET SDA SCL PC+5V(NC)

CN902 7P

TO H BOARD P701


CN903 4P

D-a

3

(µ-COM,DEFLECTION CONTROL)

H-CENTER/O BRI ABL/PWM

A

2

0.5

PA3

PA4

PS5/PWM5

PS6/PWM6

PA6

OSCIN

PB7/AIN3/ PWM1

PB6/AIN2/ PWM0

PB0/SCLD

PD4/ITB PD3/ITA/ VFBACK PD2/ CSYNCI

VSYNCI

PD1/ HSYNCO

4

PD5/HFBACK

3

PD0/ VSYNCO

HSYNCI

PD6/CLAMPOUT

USBDP

VSS

PB2/SCU

PB1/SDAD

PB3/SDAI

VDD

USBDM

PA7/ BLANKOUT

PB4/AIN0

USBVCC

OSCOUT

PB5/AIN1

5

PA5

PC7/PWM7

2

PA2/TDO

PA1/RDI

1

PC3/PWM3

PC4/PWM4

Reset

TEST/Vpp

PC2/PWM2

PA0/OCMP

PC1/VA

IC901 ST72774 CPU

PC0/ HSYNCDIV

4

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26 25 24 23

1

GREEN/LED

0.7 ORANGE/LED

R925 10k

-0.6

D905 MTZJ-5.1A

R913 1k

R937 47

X901 24MHz

R954 10k

IC903 M51951B RESET

+5V

2

GND

D903 MTZJ-5.1A

R930 10k 1/8W

R931 10k 1/8W

+5V

D904 MTZJ-5.1A

R928 R929 10k 10k 1/8W

D907 1N4148

D908 1SS119

H_RETURN

R927 2.7k 1/8W

+5V

R953 10k

3 OUT IN 1

R935 10k

5.0

C921 22p 50V

C922 22p 50V

C923 2.2

R940 10k

+5V

6

C919 47p

TEST

BLK

C918 47p

1 3.2 Vp-p (H)

2 3.4 Vp-p (H)

4.9

5.0

4.9

C570 10 50V

R5122 60.4k

7

R5123 10k

A2

SCL

SDA

3

1

C920 0.1

4

8

C563 330 16V

8

C502 0.1

3.2

4.9

5.0

0.2

C503 0.1

R505 2.8k 1%

D542 1N4148

C507 0.0047 100V

5.4

4.5

R504 732 1.0 1% C506 0.01 2.6 100V

2.4

R503 4.7k

C504 0.01 100V

2.7

R502 22.1k 1% 3.1

D541 1N4148

C505 0.1

C516 33p 50V

7

IC504(2/2) LM358N

6 5

4.0 Vp-p (V)

4

-16V

C587 C580 0.1 0.1

-1.4

+12V

Q542 2SB647 TILT DRIVE

-2.0

R5124 100

-2.0

Q541 H2N6718L TILT DRIVE

5.0 Vp-p (H)

R933 22

R932 22

Vss

A1

TEST

A0

R5120 26.7k

C572 47 16V

Vcc

IC902 M24C16BN6 EEPROM

C571 0.1 50V

0.3

3

IC504(1/2) LM358N 0.3 AMP 2

R934 47

+5V

R5121 10K

• D - a BOARD WAVEFORMS

D906 MTZJ-5.1A

R926 100

R946 100 1/8W

R936 1M

R956 160

CS4

0.2

1.7

5.0

4.1

0.7-4.0

5.0

4.9

0.1

2.3

2.2

0.1

4.9

4.9

0

R941 220 1/8W

2.0

5.0

R942 220 1/8W

5

8 7 6 5

22

TILT

1 2

(3) Schematic Diagrams of D (a a , b , c , d ) Board

XSEL

HDRV

VCAP

GNDS

HREF

FOCUS

2.8

R501 27k

0.2

6.1

2.5

1.5

2.5

5.3

R507 10k

R592 47k

0.1

5

R506 C508 10k 100p 50V

C531 0.01 R596 100V 59k

R500 43

R513 100

R571 4.7k

6

D501 1SS119

C509 3300p 100V

R508 12k

R522 *

+12V

HSYNC/O

FOCUS

HFLB

BOP

BDRV

HDRV

ab4

ab3

ab2

ab1

ad3

ad2

11

1 2

7

4.7k 4.7k 10k -

2N3904

100p

E220 [NH]

8

13

9

4.7k 4.7k 10k -

2N3904

100p

E220 [SH, EQ]

3.0 Vp-p (V)

TILT(ROTATION) COIL

R522 R919 R920 R959 - :Not used

Q902

ROTATION+ ROTATION-

5-14

12 D-a BOARD * MARKS LIST

C915

Ref. No.

CN505 2P

#3

5.0 Vp-p (V)

B-SS3563-D..-P1-EPS05

HUNLOCK G1/VBLK

C512 C513 100p 100p 50V 50V

R510 R511 100 100

5.0 Vp-p (H)

R404 R406 0.75 1.5 1W

R407 330 1W

C404 1000 25V

C405 0.22 50V

+16V

10

R403 3.3 1/2W

L509 150µH

R411 R412 6.81k 6.81k 1% 1%

C402 470 25V

C403 0.022 100V

R401 1.82k

3

C510 C534 C535 1000 0.1 100 16V 50V 16V

-16V

4

6

-14.3

C408 470 35V

D402 1N4002

2.8 Vp-p (24MHz)

5

HFLB

HSMOD

6.3

BOP

XRAY

HPLL2

BSENS

BDRV

BIN

HBUF

HCAP

PGND HPLL1

10

VCC

2.9

2.9

0

5.7

EWDRV

VOUT2

VOUT1

VREF

9

8

7

VSYNC

HSYNC

VAGC

VSOMD

COR

SDA

6

0.4

0.8

SCL

2

15.2

IC401 LA78040 V OUT

R529 1k

HUNLOCK CLBL

IC501 TDA4841 DEFLECTION CONTROL

0.1

0.8

Q526 2SC3400 BUFF

C409 1000p 100V

7 + 0.7 1 -

0.7

9

R402 C406 1.82k 0.0033 1% 100V

31 32

3 4

17 18 19 20 21 22 23 24 25 26 27 28 29 30

16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

VSYNC/O

2.0 Vp-p (V)

4.7k 4.7k 10k -

2N3904

100p

E220E

12.0 Vp-p (H)

0

470 JW 0

-

-

E215E

14

Ò D

-a board

Schematic diagram

I

H

G

F

E

D

C

B

V DY-

V DY+

HUNLOCK

BOP

BDRV

HDRV

HFLB

FOCUS

G1/VBLK

D535 1SS119

D539 1SS119

R526 4.7k

R533 1.3k 2W

JW108 *

C515 0.022 250V

157.5

Q512 2SC3400 BOP CONT

6.1

R568 10k

2.9

D518 1SS119

R567 10k

C542 R580 0.022 100V *

D510 1SS119

5.3

+12V

Q520 * H DRIVE

16.4

3.1

D506 1SS119

Q513 2SA733 BOP CONT

a

b

1

Ref. No.


58.9

L503 10mH

Q511 H2N6718L SW

R517 10k

R560 150k

R527 10k

4.2

5-15

R587 JW

57.8

Q523 2SD669A H DRIVE

BRI

S

C541 4.7

D517 1SS119

C576 0.1

R5103 20k

-27.6

R583 1.8 3W

R530 1.8 3W

92.8

SG501 1.5KV

R532 47 1/2W

Q503 2SC5587 H OUT

D507 SB140 -0.4

R5102 13k

1.4

1.9

Q531 KSP92

5

D508 5TUZ47C

R5113 51k

5

7

2

11

FB508 2.3µH

C521 4300p 2kV

R576 150k 1/2W

0.4

L501 1.2mH

R597 33 1/2W

C565 2.2 250V

R565 1k

D512 PS104R

C550 0.01 250V

D511 PS104R

R5134 4.7 1W

58.0 Vp-p (V)

qa

qs

0.6

D

1.2

R575 3k

-b board

Q504 2SC945 DF AMP

R5130 10k

R5129 1k

95.7

102.9

D525 MTZJ-5.1A

Q505 2SC945 S-CAP CHANGE

R538 4.7k

0.6

0

R539 10k

+12V

Q518 2SB649A H CENT DRIVE

-77.3

96.2

Q517 2SD669A H CENT DRIVE

C592 4.7 35V

D592 1SS119

+12V

7

1k Vp-p (H)

C560 4700p

44.6

qd

R544 100k 1/2W

S

Q524 IRF640 S-CAP CHANGE

C524 *

Q519 2SC2688 H CENT

95.6

C549 R535 330 1k 25V

C548 R536 330 6.8k 25V

ABL/PWM R572 10

R573 36k

+12V

1.0

l

Schematic diagram

1.8 Vp-p (V)

R5108 18k

R5107 10k

C595 0.1 400V

C593 0.22 63V

R577 360

74.8

R5109 1M

Q529 2SC945P ABL CONT

Q530 2SC2688 DF AMP

C589 1

R5110 470

R5111 20k

R5131 C585 820k 330p 1/8W 500V

FB507 2.3µH

C583 22 160V

T504

R5112 6.8k

Q528 2SC945P ABL CONT

+12V

6

• D - b BOARD WAVEFORMS

6

7

4 5

8

C538 0.1

R528 120 1/2W C543 1000p 100V

9

3

10

2

1

6

7

2 1

8

3

10 9

T502

T503

C574 330

D523 1SS119

4

5

R585 10k

R523 10k

16.4 15.8

Q532

16.4 2SA733

C523 47 35V

Q510 2SA733 BOP CONT

16

Q502 * H DRIVE OUT

R518 510k

56.4

Q527 2SC945 H DRIVE

D504 1SS119

2.5

R582 2.7k

R512 1k 1/8W

4

D527 HZ12A1

Q535 2SC3400

R531 *

+16V

0.5

C555 0.1 50V

3.3

R563 47k

D540 1SS119

C575 0.01

R509 3.6k

C514 0.1

D503 D2L40

C518 1500p 1kV

C517 220p 3kV

Q516 2SA733 B DRIVE

5.4

FB501 3µH

Q515 2SC945 B DRIVE

D502 MTZJ-15A

S

C587 33 16V

R525 56

92.7

C401 0.1 250V

Q501 SFS9634 SWITCHING

Q521 * H DRIVE

15

6.0

+12V

R540 C556 1M 100 1/2W 250V

FB504 3µH R524 8.2k

+200V

D519 PS104R (SR1003)

+5V

Q401 2SC945 SW

R409 10k

R408 3.3k 1/2W

R516 4.3k


ab4

bc2

bc1

ab3

ab2

ab1

(DEFLECTION)

D-b

3

BLK

2

H-DRIVER

A

1

C547 0.1 50V

H-CENTER/O

C594 C584 * *

C557 4700p

43.9

R5119 4.7k

R534 10 1W

R578 1k 1/2W

S

C528 *

L506 10mH

R547 *

Q508 * S-CAP CHANGE

R549 *

+12V

5

4

3

L504 * RY501

R557 10 1W

2

1

R591 56k

C573 4.7 35V

C582 220 100V

+81V

R589 10k

12.0 Vp-p (H)

qg

R545 *

9

D532 Z10-160B

Q506 * S-CAP CHANGE

C526 *

D526 1SS119

Q537 2SC945 S-CAP CHANGE 0.6

0

R5118 10k

+12V

R595 4.7k

Q540 2SC945 RELAY DRIVE

R5117 JW(10)

D534 JW

R574 82k

+12V

L502 100µH

D524 1SS119

D530 1SS119

C591 0.1

R590 1M

D531 1SS119

R5126 1.18k

+12V

Q514 2SC945 DF AMP

Q544 TIP127 DF AMP

R5104 10k 1/2W

62.0 Vp-p (H)

qf

R5115 100k 1/2W

S

R5106 470

R5006 15k

D513 BYV26C

Q543 TIP122 DF AMP

Q536 IRF640 S-CAP CHANGE

C525 *

C568 *

R5128 30 1/2W

R5127 10 1/2W

D520 PG104R

R5004 0.12 1/2W

C590 0.1

Q533 2SA733

R586 80.7k

8

C566 1 250V

qh

C522 *

C577 22 250V

Q546 * BUFF

D514 PG104R

R543 270 1W

R5008 0.12 1/2W

R598 *

L505

120 Vp-p (H)

D522 PG104R

10

14 13

12

11

1 2 3 4

6 5 4 3 2 1

5-16

B-SS3563-D..-P2-EPS05

CS4

bc6

bc5

bc4

bd1

bc3

V DY+ V DY-

11

H.DY

R531 R545 R547 R549 R580 R598 - :Not used

Q502 Q506 Q508 Q520 Q521 Q546

L504

V.DY

1.8k 100k/ 1/2W 4.7k 10k 100 1k

IRFU110 IRF640 2SCS945P 2SCS945P 2SA733 RN1203

28➩H

-

C522 C524 C525 C526 C528 C568 C584 C594 JW108

E220 [NH] 0.24/ 250V 0.12/ 250V 0.1/ 250V 0.33/ 250V 4700p 1000p 470p 470p

Ref. No.

D-b BOARD * MARKS LIST

TO A BOARD CN304

CS2 CS3 CS0 CS1

CN502 4P

V DY+ V DYH DYH DYH DY+ H DY+

CN501 6P

#3

12

1.8k 100k/ 1/2W 4.7k 10k 100 1k


28➩H

-

0.24/ 250V 0.12/ 250V 0.1/ 250V 0.33/ 250V 4700p 1000p 470p 470p

E220 [SH, EQ]

13 E220E

1.8k 100k/ 1/2W 4.7k 10k 100 1k


28➩H

-

0.24/ 250V 0.12/ 250V 0.1/ 250V 0.33/ 250V 4700p 1000p 470p 470p

E215E

1k 470 -

2SC2655-Y -

25.5➩H

JW

0.33/ 250V 0.18/ 250V 0.24/ 250V 680p 680p

I

H

G

F

E

D

C

B

A

1

D529 1N4148

R584 47k

C558 0.033 100V

3

C554 470p

C561 680p

C559 0.0022 100V

OSC

GND

VCC

OUT

ISENSE

VAEF

FB

COMP

IC502 UC3843A PWM CONT

a

b

1

D-b sheet.

Ref. No.


5-17

C562 0.1

R569 680 1/2W

D533 1SS119

R5133 10k

Q539 2SC945 SYNC BUFF

R593 JW

+12V

4

• Divided circuit diagram One sheet of D board circuit diagram is divided into four sheets, each having the code D-a to D-d . For example, the destination ab1 on the D-a sheet is connected to ab1 on the

ac1

bc1

bc2

D-c (HV)

2

1

2

3

4

8

7

6

5

C546 100p

C598 0.1

Q538 2SC945 SYNC BUFF C553 470p

R579 2.7k

R570 2.2k

R561 47k

5

Q534 2SC945 OVP

R553 100k

R556 10k

R558 15k

R559 1k

C564 47 25V

R555 100

D516 1N4148

R5132 47k

C539 10 100V

+81V

C545 10

Q525 2SA733 OVP

D537 1N4148

R554 15 1/8W

6

C540 0.1

R5003 10k

R552 100k

D538 MTZJ-15A

R520 0.22 1W

S

Q522 2SK2843

R5001 100 2W

C537 3900p 1kV

R599 1.82k

R551 10k

R521 23.7k

D515 BYV26C

D521 BYV27-200

FB502 10.8µH R519 100 2W

7

D509 PS104R

C599 220

C536 1500p 1.2kV

8

3

6

7

8

10

9

1

9

T501 FBT

HV

4

15

16

13

FV2

FV1

14

12 11

R5009 0.12

R594 20k

C533 2.2

HV ADJ

VR501 100k

R515 68k

D528 RGP02-18

TO PICTURE TUBE

10

D543 RGP02-18

R5100 100k

bc6

bc3

bc4

bc5

1

12

5-18

B-SS3563-D..-P3-EPS05

C567 0.01 2kV

C532 0.047 100V

11

CN504 1P

1.2kV TO A BOARD CN309

13

14

Ò D

-c board

Schematic diagram

I

H

G

F

E

D

C

B

N

L

1 2 3

18.7

220 1/8W

K

A

0.1

G

1

D-d

R623 100

D608 RD27EB4

C614 0.1 50V

C603 470p 250V

R626 15k

0.1

SW

C615 100 16V

Q601 2SA733

10k

2.6

R625

C604 470p 250V

C648

D609 1SS119

2.1

R624 9.1k

4700p 400V

VA601 C601 0.68

R627 10k

+16V

R628 62 L609 1/4W 100µH

F601 4A 250V

Q615 2SC945P RELAY DRIVE

D611 1N4148

5

6

2

RY601

3

R621 220 1/8W

TH602

16.5

4

FB613 300µH

FB612 300µH

(POWER SUPPLY)

0.1

IC606 MCR100

R622

C619 0.1 50V

R629 160 1/4W

C640 0.1 250V

R673 47k

C649 4700p 400V

250V

a

b

1


Ref. No.

5-19


DGC

DGC NC DGC

CN602 3P

G

CN601 AC-SOCKET

ad1

4

C643 0.1 50V

0.7

R677 1M

D629 1SS119

R619 10k

D610 1SS119

2

1

R618 10k

R672 2M

Q611 2SC3400 SW

3

4

LF601

S601

1.1

0.4

2.5

3.4

G

D630 1SS119

5.7

51.9

IC601 UC3842A PWM CONTROL

K

A

OSC

C654 22 25V

Vcc

FB

ISENSE OUT

GND

VAEF

COMP

C613 270p 50V

R612 4.99k 1% C612 0.01 100V

7.1

5.0

R603 30k 2W

TH601 10

D601 D4SB60L-F AC RECT

IC604 MCR100-8

POWER R601 C602 1M 0.47 1/2W 250V

5

2

3

1 3 4

2

8 7 6 5

A

1

C605 4700p 250V

D621 *

R609 2.7k 1/4W

D606 1N4148

C650 *

L606 *

R678 1.2M

R605 150k 2W

C611 R616 680p 3.92k 50V

D

-d board

l

3

1

4

6

VA603

FB614 1.5µH

T601 *

0.1

R614 0.22 2W

R615 1.82k

R670 1M

7.0

C620 100p 1kV

S

Q602 2SK2607 SWITCHING

124.4

R653 220 2W

D605 FB621 UF4007G23 JW

D626 1N4148

FB611 *

C606 330 450V

C608 0.1 400V

D623 *

D607 RD27EB4

FB616 2µH

C607 220 35V

C609 *

JW105 *

D627 *

FB609 *

7

Schematic diagram

R611 18

R610 10

6

5.0 4 3 C616 R620 0.1 1k 50V

1.7

9

8

2

1

10

11

12

7 C647 100 35V

13

6

D604 PS104R

14

15

5

4

16

17

2 3

18

1

IC602 TLP621Y VOLTAGE FEED BACK

T603

FB620 3µH

JW105 *

FB610 *

8

5.3

+5V

FB608 2µH

FB622 3µH

FB607 JW(10)

FB606 3µH

D616 UF5402G

D617 PG104R

A

K

R640 1k

2.5

C623 100p

C630 470 25V

R641 470

C622 0.22

C655 10 160V

R644 2.8k 1%

R675 107k 1% R643 115k 1%

C652 0.22 250V

C626 100 250V

D612 1N4004

C625 220 100V

C628 1000 25V

R660 10k

L605 100µH

C632 470 25V

C651 C645 1000 470 25V 16V

L601 100µH

D622 UF5402G

IC603 TL431ACLP VOLTAGE FEED BACK

R

5.3

D628 ER206

10

D618 SR10031A

D631 D615 UF5404G UF5404G

C638 R648 1000p 1kV 150 1/2W

D613 ER206

R654 0.12 1/2W

R642 160 1/4W

9

L610 JW

R651 10k

D619 1SS119

Q616 2SC3400 -16V SW CONT

Q618 2SA733 -16V SW CONT

1

2

IN OUT GND

R659 470

1

3

2

IN OUT GND

3

4.9

+12V

R634 10k

Q604 2SC3400 +5V SW CONT

+5V

+6.3V

12

bd1

ad3

ad2

1 2 3 4 5 6 7

5-20

#3

TO A BOARD CN303

+81V GND +12V +6.3V ABL +5V GND

CN603 7P

13

BYV26C UF5406 UF5406 3➩H 3➩H 3➩H 1.5➩H 15➩H PFC TRANSFORMER

C609 C650 D621 D623 D627 FB609 FB610 FB611 FB614 JW105 JW106 L606 T601 - :Not used

E220 [NH] 0.33/ 630V 0.022/ 630V

Ref. No.

D-d BOARD * MARKS LIST

B-SS3563-D..-P4-EPS05

C635 1000 10V

R658 10k

C658

R633 1k

Q603 2SA966 +5V SW

C634 1000 16V

+5V

L607 100µH

IC607 MCT7812CT +12V REG

IC605 MCT7805CT +5V REG

C646 1000 25V

+81V

L604 +200V 100µH

L603 100µH

R656 10k

4.9

+16V

R666 1.5k 1/4W

0.1

D603 1N4148 Q610 2SC3400 +16V SW CONT

R665 10k

15.9

L602 100µH

L608 JW

Q608 2SC3400 +6.3V SW CONT

2.6

Q609 2SB1375 +16V SW

-16V

R669 1 1/2W

R652 300

5.9

Q607 2SA966 +6.3V SW

D625 1SS119

11

Q617 2SC2655Y -16V SW

R630 2.2 2W

C633 1000 25V

R661 1.5k

-

JW

JW JW

JW JW JW

-

-

E220 [SH, EQ]

PFC TRANSFORMER

15➩H

-

3➩H 3➩H 3➩H 1.5➩H

BYV26C UF5406 UF5406

0.33/ 630V 0.022/ 630V

E220E

14

E215E

PFC TRANSFORMER

15➩H

-

3➩H 3➩H 3➩H 1.5➩H

BYV26C UF5406 UF5406

0.22/ 630V 0.01/ 630V

5-5. SEMICONDUCTORS BH3863F BH3863F-E2

M52743BSP n

RN1203

2SC4632LS-CB7

MAA3371X

LETTER SIDE

n 1

TOP VIEW

36 pin DIP

ST72774

1

TOP VIEW 24 pin SOP

B n

C

1

LA78040

TOP VIEW

42 pin DIP

TDA4841

BYV26C UF05G

MCR100 MCR100-8RL

CATHODE n

1

TOP VIEW

1

CATHODE

CATHODE GATE

BF420 LM2415T

2N3904

DTC124ESA 2SC3400

E B C

2SA1221-L

n

E

E C B

C

B

TOP VIEW

8 pin DIP

MCT7812CT TA7805S

2SA733-Q 2SA733TP-QP 2SA966-Y 2SB647A-C 2SC2655 2SC2655-Y 2SC945-P

IRFU110 IRFU110A

ANODE

ANODE

E C B

1

D2L40-TA ER106 HSS82 HZ12 HZ18-2 HZ5C1 HZ5C2 MTZJ-T-73-15A PS104R RD27EB4 RGP02-18 SB140-6339 UF4007G23 UF5402G UF5404G UF5406 10E2 IN4002 IN4004 IN4148 CATHODE

IRF640

2SB649-C 2SB649A-B 2SC2688-LK 2SD669AVC

TOP VIEW

20 pin DIP

M51951BSL

G

D

LETTER SIDE

S

-

-

E C B

n

~

~-

-

M35047

~ ~

-

EGP10D CATHODE

E

C B

5-23

ANODE

CATHODE

TLP621D4-Y-LF2 4 3

1

2

2

D4SB60L D4SB60L-F

S

SEL4225R-D

4 3

ANODE

D

ANODE

1

G

1

MTZJ-15A MTZJ-5.1A MTZJ-5.1B RD15ES-B1 RD5.1ESB2 1SS119-25 1SS119-25TD

32 pin DIP

7

LM358N M24C16BN6 UC3842A C3843A 24LC21/P

CATHODE

ANODE

E

E C B

ANODE


SECTION 6 EXPLODED VIEWS NOTE: • Items with no part number and no description are not stocked because they are seldom required for routine service. • The construction parts of an assembled part are indicated with a collation number in the remark column.

• Items marked " * " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

Les composants identifiés par une marque ¡ sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié.

6-1. CHASSIS 7-685-648-79 7-685-872-09 7-685-663-71 7-685-881-09

+BVTP 3X12 +BVTT 3X8 +BVTP 4X16 +BVTT 4X8

The components identified by mark ¡ are critical for safety. Replace only with part number specified.

8418113010

8026114012

4 5

10

3 1

7 9 6

REF.NO. PART NO. 1 #1 1 3 4 #1 4

DESCRIPTION

REMARK

REF.NO. PART NO.

* A-1272-229-A A BOARD, COMPLETE [E220, E220E] S07C2U0242 * A-1272-279-A A BOARD, COMPLETE [E215E] SOE2150244 * 4-060-151-01 STOPPER, CABLE 4-072-384-01 CABINET [E220E, E215E] 4-072-384-11 CABINET [E220]

6 #1 6 #1 6 #1 6 7

5 #1 5 #1 5

* 4-079-241-01 LABEL, INFORMATION [E220E] 9011097C2V * 4-079-241-11 LABEL, INFORMATION [E220] 9011097C1N * 4-079-241-21 LABEL, INFORMATION [E215E]

6-1

9 10

DESCRIPTION

REMARK

* A-1348-021-A D BOARD, COMPLETE [E220E] C07C2U0144 * A-1348-026-A D BOARD, COMPLETE [E220 for NH] SM7C1J5144 * A-1348-036-A D BOARD, COMPLETE [E220 for EQ, SH] * A-1348-037-A D BOARD, COMPLETE [E215E] SOE2155144 0 1-453-358-11 TRANSFORMER, FLYBACK 7050307C2U 1-757-540-11 I/O CABLE ASSY 4-073-622-01 SPONGE

C7107C2U11


6-2. PICTURE TUBE 7-685-663-71 7-685-881-09

+BVTP 4X16 +BVTT 4X8

8026114012

68 64 62

61

66 65

60 64

69

59

58

70

63

57 71 72

61

55 51 56

67

54 52


53


REF.NO. PART NO. 51

DESCRIPTION

X-4038-291-1 BEZEL ASSY [E220E]

#1 51

X-4038-292-1 BEZEL ASSY [E220]

#1 51

X-4038-570-1 BEZEL ASSY [E215E]

52 53

REMARK

REF.NO. PART NO.

52-54 GP7C2V7001 52-54 1Q010T7C1N 52-54 IR011TE215

4-072-387-01 BUTTON, POWER 3-653-339-01 SPRING, COMPRESSION

54 55 56

4-042-353-11 EMBLEM (NO.7), SONY * A-1304-219-A H BOARD, COMPLETE S07C2U0342 4-384-096-01 SCREW (4X16), TAPPING, +P 8433144020 #1 57 0 8-738-549-05 PICTURE TUBE (17TKB) (FILM INTENSITY SOUTH) [E220 for EQ, SH] 57 0 8-738-558-05 PICTURE TUBE (17TKB) (FILM INTENSITY UP) [E220 for NH, E220E, E215E]

6-2

DESCRIPTION

REMARK

58 0 8-451-435-12 DEFLECTION YOKE (Y17TKJ-M) 59 0 1-452-923-41 NECK ASSY 60 4-060-166-01 SPACER, DEFRECTION YOKE 61 4-045-123-21 HOLDER, DEGAUS COIL 62 4-060-155-01 HOLDER, HV CABLE 63 4-060-603-01 SPRING, TENSION 64 4-072-413-01 BAND, DG COIL 65 0 1-419-255-11 DEGAUSS COIL 66 4-365-808-01 SCREW (5), TAPPING 67 X-4037-104-1 STAND ASSY 68 69 70 71 72

4-072-411-01 4-308-870-00 1-452-032-00 1-452-094-00 4-051-736-21

HOLDER, DGC CLIP, LEAD WIRE MAGNET, DISK; 10mmφ MAGNET, ROTATABLE DISK; 15mmφ PIECE A (90), CONV. CORRECT

56


6-3. PACKING MATERIALS

101 102

103

104

105



REF.NO. PART NO.

DESCRIPTION

REMARK

REF.NO. PART NO.

#1 101 0 1-776-027-11 CORD SET, POWER [E220E, E215E] 102 4-079-242-11 MANUAL, INSTRUCTION [E220E] 9012097C2V #1 102 4-079-242-21 MANUAL, INSTRUCTION [E220] 9012097C1N #1 102 4-080-479-11 MANUAL, INSTRUCTION [E215E] 901209E215 103 * 4-072-417-01 CUSHION (UPPER)

DESCRIPTION

REMARK

104 * 4-072-418-01 CUSION (LOWER) 105 * 4-079-271-01 INDIVIDUAL CARTON [E220E] 9001097C2V #1 105 * 4-079-570-01 INDIVIDUAL CARTON [E220] 9001097C1N #1 105 * 4-080-496-01 INDIVIDUAL CARTON [E215E] 900109E215

6-3


REF.NO. PART NO. NOTE:


SECTION 7


DESCRIPTION


(a)

ELECTRICAL PARTS LIST REMARK REF.NO. PARThave NO. RESISTORS DESCRIPTION • All variable and adjustable resistors characteristic curve B, unless otherwise • All resistors are in ohms noted. • F : nonflammable

REMARK

• Items marked " * " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items.

Les composants identifiés par une marque ¡ sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. When indicating parts by reference number, please include the board name. REF.NO. PART NO.

DESCRIPTION

REF.NO. PART NO.

REMARK

A BOARD, COMPLETE ***************************

DESCRIPTION

REMARK

#4 C103 #4 C104 C106

1-163-189-11 CERAMIC 0.1µF 1-163-189-11 CERAMIC 0.1µF 1-135-383-11 METALIZED FILM 0.1µF

50V 7146104456 50V 7146104456 100V 5075104501

#4 C107 #4 C201 C202 #4 C203 #4 C204

1-136-165-11 1-135-791-11 1-126-964-11 1-163-189-11 1-163-189-11

METALIZED FILM 0.1µF 33pF ELECT 10µF CERAMIC 0.1µF CERAMIC 0.1µF

50V 50V 50V 50V 50V

5134104452 7183330556 5156100T50 7146104456 7146104456

C206 #4 C207 #4 C301 C302 #4 C303

1-135-383-11 1-136-165-11 1-135-791-11 1-126-964-11 1-163-189-11

METALIZED FILM 0.1µF METALIZED FILM 0.1µF 33pF ELECT 10µF CERAMIC 0.1µF

100V 50V 50V 50V 50V

5075104501 5134104452 7183330556 5156100T50 7146104456

#4 C304 C306 #4 C307

1-163-189-11 CERAMIC 0.1µF 1-135-383-11 METALIZED FILM 0.1µF 1-136-165-11 METALIZED FILM 0.1µF

4-382-854-11 SCREW (M3X10), P, SW (+) (IC002) C001 C002 #4 C004 C005 #4 C006

1-126-964-11 1-126-934-11 1-115-340-11 1-135-397-11 1-163-189-11

ELECT ELECT CERAMIC ELECT CERAMIC

10µF 220µF 0.22µF 47µF 0.1µF

50V 16V 16V 16V 50V

5156100T50 5156221S16 7144224106 515X470T16 7146104456

#4 C008 #4 C009 #4 C010 C011 #4 C012

1-136-165-11 1-126-947-11 1-163-189-11 1-128-582-11 1-130-777-11

METALIZED FILM ELECT CERAMIC ELECT PETP FILM

0.1µF 47µF 0.1µF 10µF 0.1µF

50V 16V 50V 100V 100V

5134104452 5156470T16 7146104456 5156100T01 5116104111

#4 C013 #4 C014 C015 C016 #4 C017

1-163-189-11 1-137-877-11 1-107-823-11 1-163-009-11 1-130-777-11

CERAMIC CERAMIC CERAMIC CERAMIC PETP FILM

0.1µF 1000pF 0.47µF 0.001µF 0.1µF

50V 2KV 16V 50V 100V

7146104456 51011021C3 7144474106 7144102256 5116104111

#4 C019 C022 C023 #4 C025 #4 C026

1-130-777-11 1-163-131-00 1-135-393-11 1-163-189-11 1-164-161-91

PETP FILM CERAMIC ELECT CERAMIC CERAMIC

0.1µF 390pF 100µF 0.1µF 2200pF

100V 50V 10V 50V 50V

5116104111 7183391556 5156101T10 7146104456 7144222156

C028 C029 C030 C032 #4 C033

1-163-263-11 1-102-074-21 1-135-393-11 1-135-398-11 1-163-017-11

CERAMIC CERAMIC ELECT ELECT CERAMIC

330pF 0.001µF 100µF 1µF 4700pF

50V 50V 10V 50V 50V

7183331556 5101102152 5156101T10 5156109T50 7144472156

#4 C034 C035 #4 C037 #4 C038 #4 C039

1-163-189-11 1-135-393-11 1-115-340-11 1-126-947-11 1-104-665-91

CERAMIC ELECT CERAMIC ELECT ELECT

0.1µF 100µF 0.22µF 47µF 100µF

50V 10V 16V 16V 16V

7146104456 5156101T10 7144224106 5156470T16 5156101T16

D001 D002 D003 D004 D017

8-719-911-19 8-719-070-90 8-719-109-85 8-719-911-19 8-719-074-13

DIODE 1SS119-25 DIODE 1N4148 ZENER DIODE RD5.1ESB2 DIODE 1SS119-25 DIODE BYV26C

4120511900 412014148T 41205005C2 4120511900 413010426C

#4 C040 C042 C043 #4 C044 C045

1-137-150-11 Pending 1-135-404-11 1-130-777-11 Pending

PETP FILM CERAMIC ELECT PETP FILM CERAMIC

0.01µF 33pF 4.7µF 0.1µF 0.01µF

100V 5116103511 50V 5121330552 35V 5162479T35 100V 5116104111 1.5KV 5104103463

D101 D102 D103 D104 D105

8-719-070-90 8-719-070-90 8-719-970-82 8-719-970-82 8-719-970-82

DIODE 1N4148 DIODE 1N4148 DIODE HSS82 DIODE HSS82 DIODE HSS82

412014148T 412014148T 4130190820 4130190820 4130190820

#4 C101 C102

1-135-791-11 1-126-964-11 ELECT

33pF 10µF

50V 50V

D201 D202

8-719-911-19 DIODE 1SS119-25 8-719-911-19 DIODE 1SS119-25

50V 7146104456 100V 5075104501 50V 5134104452

CN301 1-564-510-81 CN302 1-564-510-81 CN303* 1-564-510-81 CN304* 1-564-507-11 CN307 1-695-915-11

PLUG, CONNECTOR 6P PLUG, CONNECTOR 9P PLUG, CONNECTOR 7P PLUG, CONNECTOR 4P TAB (CONTACT) 1P

CN309 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN) CN310 1-695-915-11 TAB (CONTACT) 1P CN311 Pending 1P CN312 Pending 1P

4490600330 4490900330 4490700330 4490400330

3340236016

7183330556 5156100T50

7-1

4120511900 4120511900


(a) REF.NO. PART NO.

DESCRIPTION


REMARK

D203 D204 D205

8-719-970-82 DIODE HSS82 8-719-970-82 DIODE HSS82 8-719-970-82 DIODE HSS82

4130190820 4130190820 4130190820

D301 D302 D303 D304 D305

8-719-911-19 8-719-911-19 8-719-970-82 8-719-970-82 8-719-970-82

4120511900 4120511900 4130190820 4130190820 4130190820

DIODE 1SS119-25 DIODE 1SS119-25 DIODE HSS82 DIODE HSS82 DIODE HSS82

REF.NO. PART NO.

1-414-793-21 1-469-611-11 1-535-303-31 1-535-303-31 1-535-303-31

BEAD, FERRITE 0.45µH INDUCTOR, FERRITE BEAD 2µH JUMP WIRE JUMP WIRE JUMP WIRE

FB006 1-469-402-11 BEAD, FERRITE 3µH #4 FB101 1-535-303-31 JUMP WIRE #4 FB201 1-535-303-31 JUMP WIRE #4 FB301 1-535-303-31 JUMP WIRE

DESCRIPTION

REMARK

#4 FB001 FB002 #4 FB003 #4 FB004 #4 FB005


7099458250 4322209005 5406100000 5406100000 5406100000 4322309006 5406100000 5406100000 5406100000

R001 R002 R004 #4 R005 R006

1-247-807-31 1-247-807-31 1-216-025-11 1-215-049-91 1-216-073-91

CARBON (SMALL) 100 CARBON (SMALL) 100 RES-CHIP 100 RES-CHIP 1K RES-CHIP 10K

1/4W 4050510155 1/4W 4050510155 1/10W 4010110152 1/10W 4010110252 1/10W 4010110352

R007 #4 R008 #4 R009 R010 #4 R011

1-216-025-11 1-216-660-11 1-215-049-91 1-216-025-11 1-216-041-11

RES-CHIP RES, CHIP RES-CHIP RES-CHIP RES-CHIP

100 2.4K 1K 100 470

1/10W 4010110152 1/10W 4010124252 1/10W 4010110252 1/10W 4010110152 1/10W 4010147152

#4 R012 R013 R014 R015 #4 R016

1-215-049-91 1-216-065-11 1-216-065-11 1-247-816-11 1-216-041-11

RES-CHIP 1K RES-CHIP 4.7K RES-CHIP 4.7K CARBON (SMALL) 240 RES-CHIP 470

1/10W 4010110252 1/10W 4010147252 1/10W 4010147252 1/4W 4050524155 1/10W 4010147152

R017 R018 R019 R020 #4 R021

1-247-807-31 1-216-025-11 1-216-025-11 Pending 1-244-297-11

CARBON (SMALL) 100 RES-CHIP 100 RES-CHIP 100 METAL FILM 4.42K RES-CHIP 32.4K

1/4W 4050510155 1/10W 4010110152 1/10W 4010110152 1/4W 4257044421 1/10W 419A132422

#4 #4 #4 #4 #4

R022 R023 R024 R025 R026

1-216-660-11 1-216-121-11 1-247-883-11 1-249-421-11 1-216-041-11

RES, CHIP 2.4K RES-CHIP 1M CARBON (SMALL) 150K CARBON (SMALL) 2.2K RES-CHIP 470

1/10W 4010124252 1/10W 4010110552 1/4W 4050515455 1/4W 4050522255 1/10W 4010147152

#4 R027 #4 R028 R029 R030 #4 R031

1-215-049-91 1-215-049-91 1-216-053-11 1-216-073-91 1-244-274-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL FILM

1K 1K 1.5K 10K 22M

1/10W 4010110252 1/10W 4010110252 1/10W 4010115252 1/10W 4010110352 1/4W 4160422655

#4 R032 #4 R033 R034 #4 R035 #4 R036

1-215-049-91 1-216-105-11 Pending 1-244-273-11 1-216-025-11

RES-CHIP RES-CHIP

1K 220K 10K 2.2M 100

1/10W 4010110252 1/10W 4010122452 1/2W 4050210355 1/2W 4160222555 1/10W 4010110152

#4 R037 #4 R039 R042 #4 R046 R049

1-216-025-11 1-216-660-11 Pending 1-216-662-11 1-216-073-91

RES-CHIP RES, CHIP RES-CHIP RES-CHIP

100 2.4K 100 3K 10K

1/10W 4010110152 1/10W 4010124252 1/2W 4050210155 1/10W 4010130252 1/10W 4010110352

R050 R051 #4 R054 R101 #4 R103

1-216-065-11 1-216-053-11 1-216-121-11 1-216-022-11 1-215-049-91

RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

4.7K 1.5K 1M 75 1K

1/10W 4010147252 1/10W 4010115252 1/10W 4010110552 1/10W 4010175002 1/10W 4010110252

#4 #4 #4 #4

1-249-393-11 1-249-425-11 1-247-862-11 1-216-041-11 1-247-903-81

CARBON (SMALL) 12 CARBON (SMALL) 4.7K CARBON (SMALL) 20K RES-CHIP 470 CARBON (SMALL) 1M

1/4W 4050512055 1/4W 4050547255 1/4W 4050520355 1/10W 4010147152 1/4W 4050510555

IC001 8-759-582-06 IC M52743BSP IC002 8-759-569-64 IC BH3863F IC003 Pending IC M35047-XXX IC004 8-759-991-16 IC LM358N

4159527432 4159350470 4159358000

J001 0 1-251-598-11 SOCKET, PICTURE TUBE

4570307Y11

L001 #4 L002 L101 #4 L102 L201

1-469-400-11 1-535-303-31 1-469-398-11 1-419-618-11 1-469-398-11

INDUCTOR, MICRO 100µH JUMP WIRE INDUCTOR, MICRO 0.1µH INDUCTOR, MICRO 0.47µH INDUCTOR, MICRO 0.1µH

432B101006 5406100000 432B108006 432B478006 432B108006

#4 L202 L301 #4 L302

1-419-618-11 INDUCTOR, MICRO 0.47µH 1-469-398-11 INDUCTOR, MICRO 0.1µH 1-419-618-11 INDUCTOR, MICRO 0.47µH

432B478006 432B108006 432B478006

Q001 Q002 Q003 Q004 #4 Q005

8-729-139-04 8-729-139-04 8-729-139-04 8-729-823-81 8-729-029-86

TRANSISTOR 2N3904 TRANSISTOR 2N3904 TRANSISTOR 2N3904 TRANSISTOR 2SC4632LS-CB7 TRANSISTOR DTC124ESA

4111139040 4111139040 4111139040 4100246340 4116612030

Q008 #4 Q101 #4 Q201 #4 Q301

8-729-139-04 8-729-048-20 8-729-048-20 8-729-048-20

TRANSISTOR 2N3904 TRANSISTOR BF420 TRANSISTOR BF420 TRANSISTOR BF420

4111139040 4114804200 4114804200 4114804200

R104 R107 R108 R109 R111

R112 R113 R115 R201 #4 R203

7-2

METAL FILM RES-CHIP

Pending 1-216-013-11 RES-CHIP Pending 1-216-022-11 RES-CHIP 1-215-049-91 RES-CHIP

300 33 62 75 1K

1/2W 4050230155 1/10W 4010133052 1/2W 4050262055 1/10W 4010175002 1/10W 4010110252


REF.NO. PART NO.

#4 #4 #4 #4

R204 R207 R208 R209 R211

1-249-393-11 1-249-425-11 1-247-862-11 1-249-413-11 1-247-903-81

DESCRIPTION

CARBON (SMALL) 12 CARBON (SMALL) 4.7K CARBON (SMALL) 20K CARBON (SMALL) 470 CARBON (SMALL) 1M

R212 R213 R215 R301 #4 R302

Pending 1-216-013-11 RES-CHIP Pending 1-216-022-11 RES-CHIP 1-535-303-31 JUMP WIRE

#4 #4 #4 #4 #4

R303 R304 R307 R308 R309

1-215-049-91 1-249-393-11 1-249-425-11 1-247-862-11 1-249-413-11

R311 R312 R313 R315

1-247-903-81 CARBON (SMALL) 1M Pending 300 1-216-013-11 RES-CHIP 33 Pending 62



300 33 100 75

RES-CHIP 1K CARBON (SMALL) 12 CARBON (SMALL) 4.7K CARBON (SMALL) 20K CARBON (SMALL) 470

REMARK

1/4W 1/4W 1/4W 1/4W 1/4W

(a)(d)

REF.NO. PART NO.

4050512055 4050547255 4050520355 4050547155 4050510555

1/2W 4050230155 1/10W 4010133052 1/2W 4050210155 1/10W 4010175002 5406100000 1/10W 4010110252 1/4W 4050512055 1/4W 4050547255 1/4W 4050520355 1/4W 4050547155

REMARK

#4 C507 C508

1-136-287-11 PETP FILM 1-163-251-11 CERAMIC

0.0047µF 100pF

100V 5116472511 50V 7183101556

C509 #4 C510 C512 C513 #4 C514

Pending 1-107-914-11 1-163-251-11 1-163-251-11 1-163-189-11

ELECT CERAMIC CERAMIC CERAMIC

0.0033µF 1000µF 100pF 100pF 0.1µF

50V 16V 50V 50V 50V

5144332550 5153102S25 7183101556 7183101556 7146104456

C515 C517 #4 C518 C521 #4 C522

1-136-195-11 1-128-981-11 1-137-876-11 Pending Pending

METALIZED FILM 0.022µF CERAMIC 220pF CERAMIC 1500pF 4300pF FILM 0.24µF

250V 3KV 1KV 2KV 250V

5074223102 510H221193 5101152132 51904323A3 5199244583 [E220/E220E]

#4 C522

Pending

FILM

250V 5199334583 [E215E] 50V 5156100T50 250V 5198124583 [E220/E220E] 250V 5198184583 [E215E] 250V 5198104583 [E220/E220E]

C523 #4 C524

1/4W 4050510555 1/2W 4050230155 1/10W 4010133052 1/2W 4050262055

DESCRIPTION

#4 C524 #4 C525

1-126-964-11 ELECT 1-117-660-21 PETP FILM Pending

PETP FILM

1-117-659-21 PETP FILM

0.33µF 10µF 0.12µF 0.18µF 0.1µF

#4 SG001 1-135-791-11 SPARK GAP SG101 Pending SPARK GAP SG201 Pending SPARK GAP SG301 Pending SPARK GAP

7183330556 4700000003 4700000003 4700000003

******************************************************************************************

D BOARD, COMPLETE *************************** 1-500-644-11 INDUCTOR (D521, D623, D627) 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN) (CN503, R530, R603, R614, R653) 1-533-223-11 HOLDER, FUSE (F601) 46905Y1101 1-785-907-11 PLUG, CONNECTOR 1P (R576, R583, R605, R653) 3340101525 4-382-854-01 SCREW (M3X8), P, SW (+) (C409, IC605, IC607, Q503, Q506, Q508, Q517, Q518, Q519, Q534, Q544, Q602)

#4 C525

Pending

PETP FILM

0,24µF

#4 C528

1-163-017-11 CERAMIC

#4 C529

1-136-165-11 METALIZED FILM 0.1µF

250V 5198244583 [E215E] 250V 5190334583 [E220/E220E] 50V 7144472156 [E220/E220E] 50V 5134104452

#4 C526

Pending

PETP FILM

0.33µF

#4 C531 #4 C532 C533 #4 C534 #4 C535

1-137-150-11 1-137-962-11 1-126-961-11 1-163-189-11 1-104-665-91

PETP FILM METALIZED FILM ELECT CERAMIC ELECT

0.01µF 0.047µF 2.2µF 0.1µF 100µF

100V 100V 50V 50V 16V

C536 #4 C537 C539 #4 C540 C541

Pending 1-137-878-11 1-128-563-11 1-163-189-11 1-135-395-11

CERAMIC ELECT CERAMIC ELECT

1500pF 3900pF 68µF 0.1µF 4.7µF

1.6KV 5192152573 1KV 5101392132 100V 5156680T01 50V 7146104456 50V 5156479T50

C542 #4 C543 C545 C546 C547

1-137-395-91 1-137-873-11 1-126-964-11 Pending Pending

PETP FILM CERAMIC ELECT CERAMIC METALIZED FILM

0.022µF 1000pF 10µF 100pF 0.1µF

100V 100V 50V 50V 50V

5116223111 5101102112 5156100T50 5101101152 5077104505

4700pF

5116103511 5074473101 5156229T50 7146104456 5156101T16

C401 C402 C403 #4 C404 #4 C405

1-137-395-91 1-128-528-51 1-137-395-91 1-107-914-11 1-130-499-11

METALIZED FILM ELECT PETP FILM ELECT PETP FILM

0.1µF 470µF 0.022µF 1000µF 0.22µF

250V 25V 100V 25V 50V

5074104102 5156471S25 5116223111 5153102S25 5110224550

C548 C549 C550 #4 C553 C554

Pending Pending 1-135-352-11 1-163-133-21 Pending

ELECT 330µF ELECT 330µF METALIZED FILM 0.01µF 470pF CERAMIC 470pF

25V 25V 250V 50V 50V

5156331T25 5156331T25 5074103102 7183471556 5128471552

#4 C406 C408 #4 C409 C502 C503

1-136-298-11 1-126-951-11 1-104-987-11 Pending Pending

PETP FILM ELECT PE TEREPHTHALATE METALIZED FILM METALIZED FILM

0.0033µF 470µF 0.001µF 0.1µF 0.1µF

100V 35V 100V 50V 50V

5116332111 5156471S35 5116102111 5077104505 5077104505

#4 C555 #4 C556 #4 C558 C559 #4 C560

1-136-165-11 1-163-189-11 1-137-352-11 1-136-684-51 1-163-189-11

METALIZED FILM CERAMIC PETP FILM PETP FILM CERAMIC

0.1µF 0.1µF 0.0033µF 0.0022µF 0.1µF

50V 50V 100V 100V 50V

5134104452 7146104456 5116333111 5116222111 7146104456

#4 C504 C505 #4 C506

1-137-150-11 PETP FILM 0.01µF Pending METALIZED FILM 0.1µF 1-137-150-11 PETP FILM 0.01µF

100V 5116472511 50V 5077104505 100V 5116103511

#4 C561 #4 C562 #4 C563

1-163-007-11 1-163-189-11 CERAMIC 1-104-661-91 ELECT

680pF 0.1µF 330µF

50V 50V 16V

7144681156 7146104456 5156331T16

7-3


(d) REF.NO. PART NO. #4 C564 #4 C565 C566 C567 #4 C568

DESCRIPTION

1-126-947-11 ELECT 1-107-651-11 ELECT

REMARK

REF.NO. PART NO.

47µF 4.7µF

25V 5156470T25 250V 5156479S03

C625 C626

1µF 0.01µF 1000pF

#4 C628 C630 #4 C631 C632 #4 C633

C570 #4 C571 #4 C572

1-126-964-11 ELECT 1-163-189-11 CERAMIC 1-126-947-11 ELECT

10µF 0.1µF 47µF

250V 5190105583 2KV 51041034C3 50V 7144102156 [E220/E220E] 50V 5156100T50 50V 7146104456 16V 5156470T16

#4 #4 #4 #4 #4

C573 C574 C575 C576 C577

1-135-404-11 1-126-970-11 1-163-031-91 1-163-189-11 1-107-662-11

ELECT ELECT CERAMIC ELECT

4.7µF 330µF 0.01µF 0.1µF 22µF

35V 50V 50V 50V 250V

5162479T35 5156331S50 7146103456 7146104456 5156220S03

#4 C580 #4 C581 #4 C582 C583 #4 C584

1-130-499-11 1-130-499-11 1-128-564-91 Pending Pending

PETP FILM PETP FILM ELECT ELECT CERAMIC

0.22µF 0.22µF 220µF 4.7µF 470pF

50V 50V 100V 100V 50V

5110224550 5110224550 5156221T01 515X479T01 7144471156 [E220/E220E]

#4 C584

Pending

CERAMIC

680pF

50V

C585 C589 #4 C590 #4 C591

Pending 1-135-398-11 1-163-189-11 1-163-189-11

CERAMIC ELECT CERAMIC CERAMIC

1000pF 1µF 0.1µF 0.1µF

7144681156 [E215E] 500V 5101102142 50V 5156109T50 50V 7146104456 50V 7146104456

#4 C592 C593 #4 C594

1-135-404-11 ELECT Pending PETP FILM Pending CERAMIC

4.7µF 0.22µF 470pF

35V 50V 50V

#4 C594 #4 C595

Pending Pending Pending

Pending

CERAMIC CERAMIC

CERAMIC

680pF

1-137-871-11 METALIZED FILM 0.1µF

5162479T35 5113224150 7144471156 [E220/E220E] 50V 7144681156 [E215E] 400V 5074104104

#4 C598 1-163-189-11 CERAMIC C599 1-126-969-11 ELECT #4 C601 0 1-113-511-11 #4 C602 0 1-113-511-11 C603 0 1-135-380-11 CERAMIC

0.1µF 220µF 0.47µF 0.47µF 470pF

50V 50V 250V 250V 250V

7146104456 5156221T50 5067474425 5067474425 5063471325

C604 0 1-135-380-11 C605 1-135-351-11 C606 1-135-396-11 #4 C607 1-126-949-11 #4 C608 1-137-871-11

470pF 4700pF 220µF 220µF 0.1µF

250V 250V 450V 35V 400V

5063471325 5063472425 515P331S45 5156221T35 5074104104

CERAMIC CERAMIC ELECT ELECT METALIZED FILM



#4 C609

Pending

METALIZED FILM 0.33µF

#4 C611 #4 C612

1-163-007-11 1-137-150-11 PETP FILM

680pF 0.01µF

630V 5074334106 [E220/E220E] 630V 5074224106 [E215E] 50V 7144681156 100V 5116103511

#4 C609

Pending


#4 C613 #4 C614 #4 C616 C618 #4 C619

1-163-002-11 1-163-189-11 1-163-189-11 1-126-964-11 1-163-189-11

CERAMIC CERAMIC ELECT CERAMIC

270pF 0.1µF 0.1µF 10µF 0.1µF

50V 50V 50V 50V 50V

#4 C620 C622 #4 C623

1-135-389-11 CERAMIC Pending 1-163-251-11 CERAMIC

100pF 0.22µF 100pF

1KV 510H101132 50V 5113224150 50V 7183101556

DESCRIPTION

REMARK

1-125-700-11 ELECT 1-107-955-51 ELECT

220µF 100µF

100V 5156221S01 250V 515X101S03

1-107-914-11 1-128-528-51 1-163-189-11 1-128-528-51 1-107-914-11

ELECT ELECT CERAMIC ELECT ELECT

1000µF 470µF 0.1µF 470µF 1000µF

25V 25V 50V 25V 25V

5153102S25 5156471S25 7146104456 5156471S25 5153102S25

C634 1-107-884-81 #4 C635 1-126-926-11 C638 1-164-143-11 #4 C640 0 1-115-165-11 #4 C643 1-163-189-11

ELECT ELECT CERAMIC CAP, FILM CERAMIC

1000µF 1000µF 1000pF 0.1µF 0.1µF

16V 10V 1KV 250V 50V

5156102S16 5156102S10 5101102132 5067104425 7146104456

C645 1-126-935-91 #4 C646 1-107-914-11 C647 1-135-401-11 #4 C648 0 1-137-930-11 #4 C649 0 1-137-930-11

ELECT ELECT ELECT CERAMIC CERAMIC

470µF 1000µF 100µF 4700pF 4700pF

16V 25V 35V 400V 400V

5156471T16 5153102S25 5156101T35 5061472440 5061472440

#4 C650

Pending


#4 C650

Pending


C651 C652 C654 C655

1-107-914-11 1-137-972-11 1-128-551-11 1-107-636-11

ELECT METALIZED FILM ELECT ELECT

1000µF 0.22µF 22µF 10µF

630V 5074223106 [E220 [NH]/E220E] 630V 5074103106 [E215E] 25V 5153102S25 250V 5077224102 25V 5156220T25 160V 5156100T02

C902 C903 C904 C905 C906

1-126-961-11 1-126-961-11 1-126-961-11 1-126-961-11 1-126-961-11

ELECT ELECT ELECT ELECT ELECT

2.2µF 2.2µF 2.2µF 2.2µF 2.2µF

50V 50V 50V 50V 50V

5156229T50 5156229T50 5156229T50 5156229T50 5156229T50

C907 C908 C909 C910 C914

1-126-964-11 1-163-189-11 1-163-133-21 1-163-189-11 1-163-251-11

ELECT CERAMIC CERAMIC CERAMIC

10µF 0.1µF 470pF 0.1µF 100pF

50V 50V 50V 50V 50V

5156100T50 7146104456 7183471556 7146104456 7183101556

#4 C915

1-102-973-21 CERAMIC

100pF

50V

#4 #4 #4 #4

1-163-243-11 1-163-243-11 1-163-189-11 CERAMIC 1-163-235-91

47pF 47pF 0.1µF 22pF

50V 50V 50V 50V

5128101552 [E220/E220E] 7183470556 7183470556 7146104456 7183220556

#4 C922 C923 #4 C924 #4 C925 #4 C926

1-163-235-91 1-126-961-11 1-135-395-11 1-163-189-11 1-163-251-11

ELECT ELECT CERAMIC CERAMIC

22pF 2.2µF 4.7µF 0.1µF 100pF

50V 50V 50V 50V 50V

7183220556 5156229T50 5156479T50 7146104456 7183101556

#4 C927

1-163-251-11 CERAMIC

100pF

50V

7183101556

#4 #4 #4 #4

#4 #4 #4 #4

C918 C919 C920 C921

7144271156 7146104456 7146104456 5156100T50 7146104456

CN501 Pending 6P CN502 Pending 4P #4 CN503 1-506-108-41 PIN, CONNECTOR (TERMINAL PIN) CN504 #4 CN505

7-4

Pending

1P 2P

3340236016 [E220E/E215E] C488020185


REF.NO. PART NO.



DESCRIPTION

REMARK

(d)

REF.NO. PART NO.

DESCRIPTION

#4 CN60101-251-227-11 AC SOCKET #4 CN602 1-815-267-11 PIN, CONNECTOR 3P CN603 Pending 7P CN901 Pending 9P #4 CN902 1-564-510-51 PLUG, CONNECTOR 7P

4570707C00 4490301100

D615 D616 D617

4490700330

CN903* 1-564-507-11 PLUG, CONNECTOR 4P

4490400330

#4 D618 D619 #4 D621

8-719-074-17 DIODE SR1003 8-719-911-19 DIODE 1SS119-25 8-719-074-13 DIODE BYV26C

D622 #4 D623

8-719-074-19 DIODE UF5402G 8-719-048-23 DIODE UF5406

#4 D625 D626 #4 D627

8-719-911-19 DIODE 1SS119-25 8-719-911-19 DIODE 1SS119-25 8-719-048-23 DIODE UF5406

#4 D628 D629

8-719-048-23 DIODE UF5406 8-719-911-19 DIODE 1SS119-25

D402 D501 D502 D503 D504

8-719-200-02 8-719-911-19 8-719-110-39 8-719-052-86 8-719-911-19

DIODE 10E2 DIODE 1SS119-25 ZENER DIODE RD15ES-B1 DIODE D2L40-TA DIODE 1SS119-25

4120104002 4120511900 4130152400 4120511900

D506 D507 D508 #4 D509 D510

8-719-911-19 8-719-987-31 Pending 8-719-083-88 8-719-911-19

DIODE 1SS119-25 DIODE SB140-6339 DIODE 5TUZ47CTO-220NIS DIODE PS104R DIODE 1SS119-25

4120511900 4130104140 413050Z470 4130101040 4120511900

#4 D511 #4 D512 D513 D514 D515

8-719-083-88 8-719-083-88 8-719-074-13 8-719-074-25 8-719-074-13

DIODE PS104R DIODE PS104R DIODE BYV26C DIODE PG104R DIODE BYV26C

4130101040 4130101040 413010426C 4130101041 413010426C

#4 D516 D517 D518 #4 D519 D520

8-719-911-19 8-719-911-19 8-719-911-19 8-719-083-88 8-719-074-25

DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25 DIODE PS104R DIODE PG104R

4120511900 4120511900 4120511900 4130101040 4130101041

D521 D522 D523 D524 D525

Pending 8-719-074-25 8-719-911-19 8-719-911-19 8-719-921-42

DIODE BYV26C-200 DIODE PG104R DIODE 1SS119-25 DIODE 1SS119-25 ZENER DIODE MTZJ-5.1A

4130204270 4130101041 4120511900 4120511900 41205005C1

D526 #4 D527 #4 D528 D530 D531

8-719-911-19 8-719-110-35 8-729-074-16 8-719-911-19 8-719-911-19

DIODE 1SS119-25 ZENER DIODE HZ12 DIODE RGP02-18 DIODE 1SS119-25 DIODE 1SS119-25

4120511900 4120501202 4130100218 4120511900 4120511900

#4 D532 D533 D535 D538 D592

8-729-077-81 8-719-911-19 8-719-921-42 8-719-110-39 8-719-911-19

ZENER DIODE Z10-160B DIODE 1SS119-25 DIODE MTZJ-5.1A ZENER DIODE RD15ES-B1 DIODE 1SS119-25

D601 0 8-719-510-53 D603 8-719-911-19 #4 D604 8-719-083-88 D605 8-719-053-19 D606 8-719-911-19

DIODE D4SB60L DIODE 1SS119-25 DIODE PS104R DIODE UF4007G23 DIODE 1SS119-25

4130400600 4120511900 4130101040 413010426D 4120511900

#4 D607 #4 D608 D609 D610 D611

8-719-154-15 8-719-154-15 8-719-911-19 8-719-911-19 8-719-911-19

ZENER DIODE RD27EB4 ZENER DIODE RD27EB4 DIODE 1SS119-25 DIODE 1SS119-25 DIODE 1SS119-25

4120502705 4120502705 4120511900 4120511900 4120511900

D612 #4 D613

8-719-911-55 DIODE U05G 8-719-048-23 DIODE UF5406

REMARK

8-719-077-80 DIODE UF5404G 8-719-074-19 DIODE UF5402G 8-719-074-25 DIODE PG104R

4130305404 4130305402 4130101041

4120511900 413010426C [E220 [NH]/E220E/E215E] 4130305402 4130305406 [E220 [NH]/E220E/ E215E] 4120511900 4120511900 4130305406 [E220 [NH]/E220E/E215E] 4130305406 4120511900

D630 D631 D901 D902 D903

8-719-911-19 8-719-077-80 8-719-921-42 8-719-921-42 8-719-921-42

DIODE 1SS119-25 DIODE UF5404G ZENER DIODE MTZJ-5.1A ZENER DIODE MTZJ-5.1A ZENER DIODE MTZJ-5.1A

4120511900 4130305404 41205005C1 41205005C1 41205005C1

D904 D905 D906 D908

8-719-921-42 8-719-921-42 8-719-921-42 8-719-911-19

ZENER DIODE MTZJ-5.1A ZENER DIODE MTZJ-5.1A ZENER DIODE MTZJ-5.1A DIODE 1SS119-25

41205005C1 41205005C1 41205005C1 4120511900

F601 0 1-576-231-11 FUSE (H.B.C.) (4A/250V)

5268400052

FB502 FB504 FB507 FB508 FB604

1-419-981-11 1-469-402-11 1-412-911-11 1-412-911-11 1-469-611-11

COIL, CHOKE 10.8µH BEAD, FERRITE 3µH BEAD, FERRITE 2.3µH BEAD, FERRITE 2.3µH BEAD, FERRITE 2µH

4120510160 4120511900

FB605 #4 FB606 FB607 FB608 #4 FB609

1-469-611-11 1-469-611-11 1-469-611-11 1-469-611-11 Pending

BEAD, FERRITE 2µH BEAD, FERRITE 2µH BEAD, FERRITE 2µH BEAD, FERRITE 2µH BEAD, FERRITE 3µH

41205015AU 4120511900

#4 FB610

Pending

BEAD, FERRITE 3µH

4323100103 4322309006 7099159250 7099159250 4322309504 4322309504 4322309504 4322309504 4322309504 4322309504 [E220 [NH]/E220E/E215E]

4322309504 [E220 [NH]/E220E/E215E] #4 FB611 Pending BEAD, FERRITE 3µH 4322309504 [E220 [NH]/E220E/E215E] FB612 1-419-445-11 COIL, CHOKE 300µH 7065R10301 FB613 1-419-445-11 COIL, CHOKE 300µH 7065R10301 #4 FB614 Pending BEAD, FERRITE 1.5µH 7099159250 [E220 [NH]/E220E/E215E] FB620 1-469-611-11 BEAD, FERRITE 2µH FB622 1-469-611-11 BEAD, FERRITE 2µH FB624 1-469-611-11 BEAD, FERRITE 2µH

4120104004 4130305406

7-5

4322309504 4322309504 4322309504


(d) REF.NO. PART NO.

DESCRIPTION


REMARK

REF.NO. PART NO.


DESCRIPTION

REMARK

IC401 8-759-593-28 IC LA78040 IC501 Pending IC TDA4841 IC502 Pending IC UC3843A IC504 8-759-991-16 IC LM358N IC601 8-759-582-09 IC UC3842A IC602 IC603 IC604 IC605 IC606

8-749-016-36 8-759-466-12 8-729-051-32 8-759-231-53 8-729-048-22

IC TLP621D4-Y-LF2 IC TL431ACLP TRANSISTOR MCR100-8RL IC TA7805S TRANSISTOR MCR100

#4 IC607 8-759-088-08 IC MCT7812CT IC901 Pending IC ST72774 IC902 8-759-650-44 IC M24C16BN6 IC903 8-759-605-05 IC M51951BSL

4159817200 4159484100 4159384300 4159358000 4159384200

415943100A 4114510080 4159780501 4114501006 4159781201 4159727750 415924C160 4159519510

#4 Q512 Q513 #4 Q514 #4 Q515 Q516

8-729-194-57 8-729-141-03 8-729-194-57 8-729-194-57 8-729-141-03

TRANSISTOR 2SC945-P TRANSISTOR 2SA733-QP TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR 2SA733-QP

411020945P 4110007330 411020945P 411020945P 4110007330

Q517 #4 Q518 Q519 #4 Q520

8-729-306-92 8-729-304-92 8-729-119-80 8-729-194-57

TRANSISTOR 2SD669AVC TRANSISTOR 2SB649-C TRANSISTOR 2SC2688-LK TRANSISTOR 2SC945-P

#4 Q521

8-729-141-03 TRANSISTOR 2SA733-QP

410030669A 410010649A 4100226880 411020945P [E220/E220E] 4110007330 [E220/E220E]

Q522 Q523 Q524 Q525 #4 Q526

8-729-048-61 8-729-306-92 8-729-906-93 8-729-141-03 8-729-029-86

TRANSISTOR 2SK2843LB2SONY TRANSISTOR 2SD669AVC TRANSISTOR IRF640 TRANSISTOR 2SA733-QP TRANSISTOR DTC124ESA

4101528430 410030669A 4105906400 4110007330 4116612030

#4 Q527 #4 Q528 #4 Q529 Q530 Q531

8-729-194-57 8-729-194-57 8-729-194-57 8-729-119-80 8-729-051-31

TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR 2SC2688-LK TRANSISTOR KSP92

411020945P 411020945P 411020945P 4100226880 4112409200

Q532 Q533 #4 Q534 Q535 Q536

8-729-141-03 8-729-141-03 8-729-194-57 8-729-029-86 8-729-906-93

TRANSISTOR 2SA733-QP TRANSISTOR 2SA733-QP TRANSISTOR 2SC945-P TRANSISTOR DTC124ESA TRANSISTOR IRF640

4110007330 4110007330 411020945P 4116612030 4105906400

#4 #4 #4 #4

Q537 Q538 Q539 Q540 Q541

8-729-194-57 8-729-194-57 8-729-194-57 8-729-194-57 Pending

TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR H2N6718L

411020945P 411020945P 411020945P 411020945P 4111167180

Q542 #4 Q543 #4 Q544 #4 Q546

8-729-122-12 8-729-055-78 8-729-055-77 8-729-029-86

TRANSISTOR 2SA1221-L TRANSISTOR TIP122 TRANSISTOR TIP127 TRANSISTOR DTC124ESA

8-729-141-03 TRANSISTOR 2SA733-QP

411010647A 4103200122 4103200127 4116612030 [E220/E220E] 4110007330

Q602 #4 Q603 #4 Q604 Q607 Q608

8-729-040-92 8-729-194-57 8-729-029-86 8-729-200-36 8-729-206-21

TRANSISTOR 2SK2607 TRANSISTOR 2SC945-P TRANSISTOR DTC124ESA TRANSISTOR 2SA966-Y TRANSISTOR RN1203

4102207800 411020945P 4116612030 4110009660 4116612030

Q609 #4 Q610 #4 Q611 #4 Q615 Q616

Pending 8-729-029-86 8-729-029-86 8-729-194-57 8-729-029-86

TRANSISTOR 2SB1065 TRANSISTOR DTC124ESA TRANSISTOR DTC124ESA TRANSISTOR 2SC945-P TRANSISTOR DTC124ESA

4100110650 4116612030 4116612030 411020945P 4116612030

Q617 Q618 Q901 #4 Q902

8-729-265-52 8-729-141-03 8-729-139-04 8-729-139-04

TRANSISTOR 2SC2655 TRANSISTOR 2SA733-QP TRANSISTOR 2N3904 TRANSISTOR 2N3904

4100226550 4110007330 4111139040 4111139040 [E220/E220E]

#4 #4 #4 #4

L501 L502 L503 L504

#4 L504

1-412-550-11 1-469-994-11 1-459-104-11 1-419-986-11 Pending

INDUCTOR, MICRO 1.2mH COIL, PEAKING 100µH COIL, CHOKE 10mH COIL, CHOKE 28µH COIL, CHOKE 25.5µH

#4 #4 #4 #4 #4

L505 L506 L509 L601 L602

1-419-568-11 1-459-104-11 1-469-995-11 1-412-537-31 1-412-537-31

COIL, LINEARITY COIL, CHOKE 10mH COIL, PEAKING 150µH COIL, CHOKE 100µH COIL, CHOKE 100µH

#4 #4 #4 #4

L603 L604 L605 L606

1-412-537-31 1-412-537-31 1-412-537-31 Pending

COIL, CHOKE 100µH COIL, CHOKE 100µH COIL, CHOKE 100µH COIL, CHOKE 15µH

#4 L607

4323122003 4321101006 4323103003 4323280003 [E220/E220E] 4323255903 [E215E] 708S205R50 4323103003 4321151006 4323101303 4323101303

4323101303 4323101303 4323101303 7067C2U150 [E220 [NH]/E220E/E215E] 1-410-645-31 INDUCTOR, MICRO 100µH 4326101005

Q601

LF6010 1-433-798-11 TRANSFORMER, LINE FILTER

7065Y11133

Q401 Q501 #4 Q502

8-729-194-57 TRANSISTOR 2SC945-P Pending TRANSISTOR SFS9634 8-729-042-34 TRANSISTOR IRFU110

#4 Q502

Pending

TRANSISTOR 2SC2655-Y

Q503 Q504 Q505 #4 Q506

8-729-052-42 8-729-194-57 8-729-194-57 8-729-906-93

TRANSISTOR 2SC5587 TRANSISTOR 2SC945-P TRANSISTOR 2SC945-P TRANSISTOR IRF640

#4 Q508

8-729-194-57 TRANSISTOR 2SC945-P

Q510 Q511

8-729-141-03 TRANSISTOR 2SA733-QP Pending TRANSISTOR H2N6718L

411020945P 4107496340 4103801100 [E220/E220E] 411022655Y [E215E] 4100255870 411020945P 411020945P 4105906400 [E220/E220E] 411020945P [E220/E220E] 4110007330 4111167180

7-6


REF.NO. PART NO.

DESCRIPTION

REMARK

#4 R401 #4 R402 #4 R403 R404 R406

1-227-370-11 1-227-370-11 1-260-298-51 Pending 1-243-478-11

RES-CHIP 1.82K RES-CHIP 1.82K CARBON (SMALL) 3.3 METAL OXIDE FILM 0.75 CARBON (SMALL) 1.5

1/10W 419A118212 1/10W 419A118212 1/2W 4050133955 1W 4171075856 1/4W 4050515955

#4 R407 R408 R409 R411 R412

1-260-322-51 Pending Pending 1-242-988-11 1-242-988-11

CARBON (SMALL) 330 CARBON (SMALL) 3.3K RES-CHIP 10K METAL FILM 6.81K METAL FILM 6.81K

1/2W 4050133155 1/2W 4050133254 1/10W 4010110202 1/4W 4257046811 1/4W 4257046811

#4 #4 #4 #4 #4

R500 R501 R502 R503 R504

1-247-798-11 1-216-083-11 1-227-372-11 1-216-065-11 1-227-379-11

CARBON (SMALL) 43 RES-CHIP 27K RES-CHIP 22.1K RES-CHIP 4.7K RES-CHIP 732

1/4W 4050543055 1/10W 4010127352 1/10W 419A122122 1/10W 4010147252 1/10W 419A173202

#4 #4 #4 #4

R505 R506 R507 R508 R509

Pending 1-216-073-91 1-216-073-91 1-249-430-11 1-247-844-11

RES-CHIP 2.8K RES-CHIP 10K RES-CHIP 10K CARBON (SMALL) 12K CARBON (SMALL) 3.6K

1/10W 4010128202 1/10W 4010110352 1/10W 4010110352 1/4W 4050512355 1/4W 4050536255

#4 #4 #4 #4

R510 R511 R512 R513 R515

1-216-025-11 1-216-025-11 1-216-198-11 1-216-025-11 Pending


1/10W 4010110152 1/10W 4010110152 1/8W 4010810252 1/10W 4010110152 1/10W 4010168302

#4 #4 #4 #4

R516 R517 R518 R519 R520

1-247-846-11 1-216-073-91 1-218-769-11 1-244-194-11 Pending

CARBON (SMALL) 4.3K RES-CHIP 10K RES-CHIP 510K METAL OXIDE 100 METAL OXIDE FILM 0.22

1/4W 4050543255 1/10W 4010110352 1/10W 4010151452 2W 4172010156 1W 4171022856

R521 #4 R522

Pending METAL FILM 1-216-065-11 RES-CHIP

22.6K 4.7K

#4 R522

1-216-041-11 RES-CHIP

470

#4 R523 #4 R524 #4 R525

1-216-073-91 RES-CHIP 10K 1-216-071-11 RES-CHIP 8.2K 1-243-482-11 CARBON (SMALL) 56

1/4W 4257042262 1/10W 4010147252 [E220/E220E] 1/10W 4010147152 [E215E] 1/10W 4010110352 1/10W 4010182252 1/4W 4050556055

#4 R526 #4 R527 R528 #4 R529 #4 R530

1-216-065-11 1-216-073-91 Pending 1-249-417-11 1-244-277-11

1/10W 4010147252 1/10W 4010110352 1/2W 4077B12155 1/4W 4050510255 3W 417731895A

#4 R531

1-216-055-11 RES-CHIP

1.8K

#4 R531

1-215-049-91 RES-CHIP

1K

#4 R532 R533 R534

1-260-312-51 CARBON (SMALL) 47 Pending METAL OXIDE 1.3K Pending METAL OXIDE 10

1/10W 4010118252 [E220/E220E] 1/10W 4010110252 [E215E] 1/2W 4050147055 1W 4177113253 1W 4171010053

#4 R535 #4 R536 R537 #4 R538 #4 R539

1-249-417-11 1-216-069-11 Pending 1-216-065-11 1-216-073-91

1/4W 4050510255 1/10W 4010168252 1/4W 4050115355 1/10W 4010147252 1/10W 4010110352

RES-CHIP 4.7K RES-CHIP 10K METAL FILM 120 CARBON (SMALL) 1K METAL OXIDE 1.8

CARBON (SMALL) 1K RES-CHIP 6.8K CARBON (SMALL) 15K RES-CHIP 4.7K RES-CHIP 10K

(d)

REF.NO. PART NO.

100 100 1K 100 68K



#4 #4 #4 #4

R540 R543 R544 R545

1-260-364-51 1-242-979-11 1-260-352-51 1-260-352-51

DESCRIPTION CARBON (SMALL) 1M METAL OXIDE 270 CARBON (SMALL) 100K CARBON (SMALL) 100K

REMARK 1/2W 1W 1/2W 1/2W

4050110555 4177127153 4050110455 4050110455 [E220/E220E] 1/4W 4050547255 [E220/E220E]

#4 R547

1-249-425-11 CARBON (SMALL) 4.7K

#4 R549

1-216-073-91 RES-CHIP

10K

R551 R552 R553 #4 R554

Pending Pending Pending 1-216-154-11

RES-CHIP RES-CHIP RES-CHIP RES-CHIP

10K 100K 100K 15

#4 R555 #4 R556 R557 #4 R558 #4 R559

1-247-807-31 1-216-073-91 Pending 1-249-431-11 1-249-417-11

CARBON (SMALL) 100 RES-CHIP 10K METAL OXIDE 10 CARBON (SMALL) 15K CARBON (SMALL) 1K

1/4W 4050510155 1/10W 4010110352 1W 4171010053 1/4W 4050515355 1/4W 4050510255

#4 #4 #4 #4 #4

R560 R561 R562 R563 R565

1-216-101-11 1-249-437-11 1-216-073-91 1-249-437-11 1-215-049-91

RES-CHIP 150K CARBON (SMALL) 47K RES-CHIP 10K CARBON (SMALL) 47K RES-CHIP 1K

1/10W 4010115452 1/4W 4050547355 1/10W 4010110352 1/4W 4050547355 1/10W 4010110252

#4 #4 #4 #4 #4

R566 R567 R568 R569 R570

1-249-429-11 1-216-073-91 1-249-429-11 1-260-326-51 1-216-057-91

CARBON (SMALL) 10K RES-CHIP 10K CARBON (SMALL) 10K CARBON (SMALL) 680 RES-CHIP 2.2K

1/4W 4050510355 1/10W 4010110352 1/4W 4050510355 1/2W 4050168155 1/10W 4010122252

#4 #4 #4 #4 #4

R571 R572 R573 R574 R575

1-249-425-11 1-249-393-11 1-247-868-91 1-216-095-11 1-216-662-11

CARBON (SMALL) 4.7K CARBON (SMALL) 10 CARBON (SMALL) 36K RES-CHIP 82K RES-CHIP 3K

1/4W 4050547255 1/4W 4050510055 1/4W 4050536355 1/10W 4010182352 1/10W 4010130252

R576 R577 #4 R578 #4 R579 #4 R580

1-242-973-11 Pending 1-249-417-11 1-216-059-11 1-216-025-11

METAL OXIDE 30K CARBON (SMALL) 68 CARBON (SMALL) 1K RES-CHIP 2.7K RES-CHIP 100

3W 4177330355 1/4W 4050568055 1/4W 4050510255 1/10W 4010127252 1/10W 4010110152 [E220/E220E]

#4 R580

1-216-041-11 RES-CHIP

R581 #4 R582 #4 R583 #4 R584

Pending 1-249-422-11 1-244-277-11 1-249-089-11

CARBON (SMALL) 33K CARBON (SMALL) 2.7K METAL OXIDE 1.8 RES-CHIP 47K

1/10W 4010147152 [E215E] 1/4W 4050533355 1/4W 4050527255 3W 417731895A 1/10W 4010147352

#4 R585 R586 R589 #4 R590 #4 R591

1-249-401-11 Pending Pending 1-247-903-81 1-216-091-11

CARBON (SMALL) 47 METAL FILM 110K METAL FILM 10K CARBON (SMALL) 1M RES-CHIP 56K

1/4W 4050547055 1/4W 4257041103 1/4W 4257041002 1/4W 4050510555 1/10W 4010156352

#4 R592 R594 #4 R595 R596 R597

1-216-089-11 Pending 1-216-065-11 Pending Pending

RES-CHIP RES-CHIP RES-CHIP

1/10W 4010147352 1/10W 4010112452 1/10W 4010147252 1/10W 4010182302 1/2W 4050182055

#4 R598

1-215-049-91 RES-CHIP

7-7

470

47K 120K 4.7K 82K CARBON (SMALL) 82 1K

1/10W 4010110352 [E220/E220E] 1/10W 4010110202 1/10W 4010110402 1/10W 4010110402 1/8W 4010815052

1/10W 4010110252 [E220/E220E]



(d) REF.NO. PART NO.

DESCRIPTION

REMARK

#4 R599 1-227-370-11 R601 0 1-260-132-11 R603 Pending R605 Pending

RES-CHIP 1.82K CARBON (SMALL) 560K METAL OXIDE 30K METAL OXIDE FILM 150K

1/10W 419A118212 1/2W 4050156455 2W 4172030353 1W 4171015456

#4 #4 #4 #4 #4

R609 R610 R611 R612 R614

1-249-422-11 1-216-001-11 1-249-396-11 1-227-377-11 1-216-361-11

CARBON (SMALL) 2.7K RES-CHIP 10 CARBON (SMALL) 18 RES-CHIP 4.99K METAL OXIDE 0.22

1/4W 4050527255 1/10W 4010110052 1/4W 4050518055 1/10W 419A149912 1/4W 4172022855

#4 #4 #4 #4 #4

R615 R616 R618 R619 R620

1-244-176-11 1-244-179-11 1-216-073-91 1-216-073-91 1-215-049-91

METAL FILM METAL FILM RES-CHIP RES-CHIP RES-CHIP

1.82K 3.92K 10K 10K 1K

1/4W 4257041821 1/4W 4257043921 1/10W 4010110352 1/10W 4010110352 1/10W 4010110252

#4 #4 #4 #4 #4

R621 R622 R623 R624 R625

1-216-182-11 1-216-182-11 1-216-025-11 1-216-072-11 1-216-073-91


220 220 100 1.9K 10K

1/8W 4010822152 1/8W 4010822152 1/10W 4010110152 1/10W 4010191252 1/10W 4010110352

#4 R626 R627 #4 R628 #4 R629 R630

1-216-077-11 Pending 1-247-802-11 1-249-417-11 Pending

RES-CHIP 15K RES-CHIP 4.12K CARBON (SMALL) 62 CARBON (SMALL) 1K RES-CHIP 3.9K

1/10W 4010115352 1/10W 419A141212 1/4W 4050562055 1/4W 4050510255 1/10W 4010139252

R631 R632 #4 R640 #4 R641 #4 R642

Pending Pending 1-249-429-11 1-249-413-11 1-249-409-11

RES-CHIP 10K RES-CHIP 10K CARBON (SMALL) 10K CARBON (SMALL) 470 CARBON (SMALL) 220

1/10W 4010110202 1/10W 4010110202 1/4W 4050510355 1/4W 4050547155 1/4W 4050522155

R643 R644 #4 R648 #4 R651 R652

Pending Pending 1-260-089-11 1-216-073-91 1-243-480-11

RES-CHIP 115K RES-CHIP 2.8K CARBON (SMALL) 150 RES-CHIP 10K CARBON (SMALL) 300

1/10W 419A111532 1/10W 4010128202 1/2W 4050115155 1/10W 4010110352 1/4W 4050530155

R653 R655 #4 R656 #4 R658 #4 R659

1-215-888-11 Pending 1-249-429-11 1-249-429-11 1-249-417-11

METAL OXIDE 220 RES-CHIP 1.6K CARBON (SMALL) 10K CARBON (SMALL) 10K CARBON (SMALL) 1K

2W 4172022155 1/10W 4010116252 1/4W 4050510355 1/4W 4050510355 1/4W 4050510255

#4 #4 #4 #4

R660 R661 R665 R666 R669

1-249-429-11 1-249-419-11 1-216-073-91 1-249-419-11 Pending

CARBON (SMALL) 10K CARBON (SMALL) 1.5K RES-CHIP 10K CARBON (SMALL) 1.5K CARBON (SMALL) 1

1/4W 4050510355 1/4W 4050515255 1/10W 4010110352 1/4W 4050515255 1/2W 4050110955

R670 #4 R672 #4 R673 #4 R675 R676

Pending 1-216-128-11 1-216-089-11 1-244-185-11 Pending

CARBON (SMALL) 1.5M RES-CHIP 2M RES-CHIP 47K METAL FILM 107K RES-CHIP 0

1/4W 4050515555 1/10W 4010120552 1/10W 4010147352 1/4W 4257041073 1/8W 4010800052

#4 R677 R678 #4 R902 #4 R903 R904

1-216-121-11 Pending 1-249-417-11 1-249-417-11 1-247-807-31

RES-CHIP 1M CARBON (SMALL) 2M CARBON (SMALL) 1K CARBON (SMALL) 1K CARBON (SMALL) 100

1/10W 4010110552 1/4W 4050520555 1/4W 4050510255 1/4W 4050510255 1/4W 4050510155

#4 R905 #4 R906

1-249-417-11 CARBON (SMALL) 1K 1-249-417-11 CARBON (SMALL) 1K

1/4W 4050510255 1/4W 4050510255

REF.NO. PART NO.


DESCRIPTION

REMARK

#4 R907 #4 R908 #4 R909

1-249-417-11 CARBON (SMALL) 1K 1-216-073-91 RES-CHIP 10K 1-249-417-11 CARBON (SMALL) 1K

1/4W 4050510255 1/10W 4010110352 1/4W 4050510255

#4 #4 #4 #4 #4

1-216-073-91 1-249-417-11 1-216-222-91 1-249-417-11 1-244-247-11

1/10W 4010110352 1/4W 4050510255 1/8W 4010810352 1/4W 4050510255 1/4W 4257043329

R910 R911 R912 R913 R914

RES-CHIP 10K CARBON (SMALL) 1K RES-CHIP 10K CARBON (SMALL) 1K METAL FILM 33.2

#4 R915 #4 R918 #4 R919

1-240-907-11 METAL FILM 30.1K 1-216-073-91 RES-CHIP 10K 1-249-425-11 CARBON (SMALL) 4.7K

#4 R920

1-216-073-91 RES-CHIP

10K

#4 R921

1-215-049-91 RES-CHIP

1K

#4 #4 #4 #4 #4

R922 R923 R924 R925 R926

1-216-073-91 1-216-073-91 1-215-049-91 1-249-429-11 1-216-025-11

RES-CHIP 10K RES-CHIP 10K RES-CHIP 1K CARBON (SMALL) 10K RES-CHIP 100

1/10W 4010110352 1/10W 4010110352 1/10W 4010110252 1/4W 4050510355 1/10W 4010110152

#4 #4 #4 #4 #4

R927 R928 R929 R930 R931

1-216-065-11 1-216-073-91 1-216-222-91 1-216-222-91 1-216-222-91


4.7K 10K 10K 10K 10K

1/10W 4010147252 1/10W 4010110352 1/8W 4010810352 1/8W 4010810352 1/8W 4010810352

#4 #4 #4 #4 #4

R932 R933 R934 R935 R936

1-249-397-11 1-249-397-11 1-249-401-11 1-216-222-91 1-216-121-11

CARBON (SMALL) 22 CARBON (SMALL) 22 CARBON (SMALL) 47 RES-CHIP 10K RES-CHIP 1M

1/4W 4050522055 1/4W 4050522055 1/4W 4050547055 1/8W 4010810352 1/10W 4010110552

#4 #4 #4 #4 #4

R937 R938 R939 R940 R941

1-216-017-11 1-216-222-91 1-216-222-91 1-216-073-91 1-216-174-11


47 10K 10K 10K 100

1/10W 4010147052 1/8W 4010810352 1/8W 4010810352 1/10W 4010110352 1/8W 4010810152

#4 R942 #4 R943 R944 #4 R945 #4 R946

1-216-174-11 1-247-807-31 Pending 1-216-017-11 1-216-174-11

RES-CHIP 100 CARBON (SMALL) 100 RES-CHIP 470 RES-CHIP 47 RES-CHIP 100

1/8W 4010810152 1/4W 4050510155 1/8W 4010847152 1/10W 4010147052 1/8W 4010810152

R948 R949 #4 R950 R951 #4 R952

Pending Pending 1-218-769-11 Pending 1-216-017-11


1/10W 4010114202 1/10W 4010151352 1/10W 4010151452 1/10W 4010128302 1/10W 4010147052

R954 #4 R955 #4 R959

Pending RES-CHIP 10K 1-249-429-11 CARBON (SMALL) 10K RES-CHIP 0

1.4 51K 510K 28K 47

1/4W 4257043012 1/10W 4010110352 1/4W 4050547255 [E220/E220E] 1/10W 4010110352 [E220/E220E] 1/10W 4010110252

#4 R5001 1-244-194-11 METAL OXIDE 100 #4 R5003 1-249-429-11 CARBON (SMALL) 10K

1/10W 4010110202 1/4W 4050510355 1/10W 4010100052 [E215E] 2W 4172010156 1/4W 4050510355

#4 #4 #4 #4 #4

1/10W 4010113352 1/10W 4010110352 1/2W 4050110355 1/4W 4050547155 1/4W 4050510355

7-8

R5102 R5103 R5104 R5106 R5107

1-216-075-11 1-216-073-91 1-260-340-51 1-249-413-11 1-249-429-11

RES-CHIP 120K RES-CHIP 10K CARBON (SMALL) 10K CARBON (SMALL) 470 CARBON (SMALL) 10K


REF.NO. PART NO. R5108 R5109 R5110 R5111 R5112

Pending 1-216-121-11 1-216-041-11 1-216-684-11 1-216-069-11

DESCRIPTION RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP

REMARK

(d)(h)

REF.NO. PART NO.

18K 1M 470 20K 6.8K

1/10W 4010118302 1/10W 4010110552 1/10W 4010147152 1/10W 4010120352 1/10W 4010168252

R5113 Pending RES-CHIP 51K R5114 Pending RES-CHIP 120K #4 R5115 1-216-352-51 CARBON (SMALL) 100K #4 R5116 1-216-352-51 CARBON (SMALL) 100K R5117 1-247-807-31 CARBON (SMALL) 100

1/10W 4010151352 1/10W 4010112452 1/2W 4050110455 1/2W 4050110455 1/4W 4050510155

#4 #4 #4 #4 #4

RES-CHIP 10K CARBON (SMALL) 4.7K RES-CHIP 26.7K CARBON (SMALL) 10K RES-CHIP 60.4K

1/10W 4010110352 1/4W 4050547255 1/10W 419A126722 1/4W 4050510355 1/10W 419A160422

R5123 Pending RES-CHIP 10K R5124 1-247-807-31 CARBON (SMALL) 100 CARBON (SMALL) 430 R5125 Pending R5126 Pending RES-CHIP 1.47K CARBON (SMALL) 20 R5127 Pending

1/10W 4010110202 1/4W 4050510155 1/4W 4050543155 1/10W 419A114712 1/2W 4050120055

CARBON (SMALL) 36 RES-CHIP 1K RES-CHIP 10K RES-CHIP 820K RES-CHIP 47K

1/2W 4050136055 1/10W 4010110252 1/10W 4010110352 1/8W 4010882452 1/10W 4010147352

METAL OXIDE FILM 4.7

1W

#4 #4 #4 #4



DESCRIPTION

REMARK

VR5010

Pending

RES, ADJ, CERMET 50K (HV ADJ)

5.22E+11

X901

1-781-719-11 VIBRATOR, CRYSTAL (24MHz)

7152400010

******************************************************************************************

#4 #4 #4 #4

R5118 R5119 R5120 R5121 R5122

1-216-073-91 1-249-425-11 1-244-295-11 1-249-429-11 1-244-299-11

R5128 R5129 R5130 R5131 R5132

Pending 1-215-049-91 1-216-073-91 1-216-268-11 1-216-089-11

R5134

Pending

H BOARD, COMPLETE ****************************

C701 C702

1-135-360-11 CERAMIC 1-135-360-11 CERAMIC

1000pF 1000pF

7181102552 7181102552

#4 LED7011-517-965-11 DIODE LT5J62-23-D63 (POWER)

412065J620

4171247956 #4 R701 R702 #4 R705 #4 R706 #4 R709

RY501 1-755-423-11 RELAY #4 RY60101-775-031-11 RELAY

4420412016 4420612014

1-244-177-11 Pending 1-244-180-11 1-244-178-11 1-244-181-11

METAL FILM METAL FILM METAL FILM METAL FILM METAL FILM

2.15K 10.2K 6.19K 3.83K 17.4K

4257042151 4257041022 4257046191 4257043831 4257041742

SW701 1-771-734-11 SWITCH, TACTILE (MENU) S602 1-771-757-11 SWITCH, POWER PUSH SW901 1-771-930-11 SWITCH, KEY BOARD (RESET)

4410606000

4410204018 4410604034 ******************************************************************************************

SG501 1-519-422-21 GAP, SPARK

5106152204

T501 0 1-453-358-11 #4 T502 1-435-846-11 #4 T503 1-435-845-11 T504 1-435-844-11 #4 T601 0 1-435-853-11

TRANSFORMER, FLYBACK TRANSFORMER, DRIVER

7050307C2U 7050207C2U 7050907C2U TRANSFORMER, FOCUS 7050507C2U PFC X’FORMER 7051309R00 [E220 [NH]/E220E/E215E]

#4 T603 0 1-435-843-11 TRANSFORMER, POWER

7050107C2U

TH60101-803-533-11 THERMISTOR TH60201-803-963-11 THERMISTOR

710501003B 7106070027

7-9

sony-cpd_e220.pdf

Recommend Documents