ROOMAIR IRCONDIT ITIO IONER AW0690A AW0790A AW07FASAA AW07FASBA AW07FASEA AW0890A AW09FASBA AW09FASEA AW09FBSEA
SERVICE AIRCONDITIONER
AW1090A AW10FAJ AA AW10FAJ BA AW12FAJ AA AW12FAJ BA AW12FAJ DA AW12FAJ EA AW12FBJ EA
AW1290A AW14FAMBA AW18FAMBA AW18FAMCA AW18FAMBB AWT18FAMDA AW18FAMEA AW18FBMEA AW24FAMBB AW24FAMBA AW24FAMCA AWT24FAMEA
M anu anual CONTENTS
1. Precau caution ions 2. Product Specificat ecifications 3. Installat allationandOperating Instructions 4. DisassemblyandReassembly 5. Troubleshooting 6. ExplodedViews andParts List 7. Block lock Diag iagram 8. PCB Diagram 9. WiringDiagram 10. Schematic Diag Diagrams
1. Precau Precaution tions
1. Warning: arning: Prior to repair repair, disconnect disconnect the power cord from the circuit breaker. 2. Use proper proper parts: parts: Use onl only y exact exact replacement parts. (Also, we recommend replacing parts rather than repairing them.) 3. Use the proper proper tools: tools: Use the proper proper tools tools and test equipment, and know how to use equipment may cause problems laterintermittent contact, for example.
Fig. 1-1 1-1 A void D anger ang erou ouss C ont on tact
4. Power Power Cord Cord:: Prior Prior to to repa repair ir,, check check the power cord and replace it if necessary. 5. Avoid void using using an exten extension sion cord cord,, and avoid avoid tapping into a power cord. This practice may result in malfunction or fire. 6. After completing completing repairs repairs and and reassembly reassembly,, check the insulation resistance. Procedure: Prior to applying power, measure the resistance between the power cord and the ground terminal. The resistance must be greater than 30 megohms.
Fig. 1-2 1-2 N o Tapp ing and N o E xtensi xtension C ords ords
7. Make Make sure sure that that the grou grounds nds are are adequa adequate. te. 8. Make Make sure that that the instal installat lation ion condi conditio tions ns are satisfactory. satisfactory. Relocate the unit if necessary. 9. Keep chil childre dren n away from from the the unit unit while while it is being repaired. 10. Be sure to clean the unit unit and its surrounding surrounding area.
Fig. 1-3 1-3 N o K ids N earby!
Fig .1 -4 C le an the U n it
Sa m s u n g El e c t r o n i c s
1 -1
1. Precau Precaution tions
1. Warning: arning: Prior to repair repair, disconnect disconnect the power cord from the circuit breaker. 2. Use proper proper parts: parts: Use onl only y exact exact replacement parts. (Also, we recommend replacing parts rather than repairing them.) 3. Use the proper proper tools: tools: Use the proper proper tools tools and test equipment, and know how to use equipment may cause problems laterintermittent contact, for example.
Fig. 1-1 1-1 A void D anger ang erou ouss C ont on tact
4. Power Power Cord Cord:: Prior Prior to to repa repair ir,, check check the power cord and replace it if necessary. 5. Avoid void using using an exten extension sion cord cord,, and avoid avoid tapping into a power cord. This practice may result in malfunction or fire. 6. After completing completing repairs repairs and and reassembly reassembly,, check the insulation resistance. Procedure: Prior to applying power, measure the resistance between the power cord and the ground terminal. The resistance must be greater than 30 megohms.
Fig. 1-2 1-2 N o Tapp ing and N o E xtensi xtension C ords ords
7. Make Make sure sure that that the grou grounds nds are are adequa adequate. te. 8. Make Make sure that that the instal installat lation ion condi conditio tions ns are satisfactory. satisfactory. Relocate the unit if necessary. 9. Keep chil childre dren n away from from the the unit unit while while it is being repaired. 10. Be sure to clean the unit unit and its surrounding surrounding area.
Fig. 1-3 1-3 N o K ids N earby!
Fig .1 -4 C le an the U n it
Sa m s u n g El e c t r o n i c s
1 -1
Notice : The The sym symbol bol of model odel nam name
Type
A
B
C
1 -2
Model Name AW0690A
AW07FASBA
AW09FASBA
AW0790A
AW07FASEA
AW09FASEA
AW07FASAA
AW0890A
AW09FBSEA
AW1090A
AW12FAJ AW12FAJ AA AA
AW12FAJ EA
AW10FAJ AW10FAJ AA AA
AW12FAJ AW12FAJ BA BA
AW12FBJ AW12FBJ EA
AW10FAJ AW10FAJ BA BA
AW12FAJ DA
AW1290A
AW18FAMCA
AW18FAMEA
AW24FAMBA
AW14FAMBA
AW18FAMBB
AW18FBMEA
AW24FAMCA
AW18FAMBA
AWT18FAMDA
AW24FAMBB
AWT24FAMEA
Sa m su n g El e c t r o n i c s
2. Product Specifi ecific cations 2-1Table able Item Type
Unitof Measure
AW0690A
AW0790A AW0890A AW07FASAA
-
AW1090A AW10FAJAA AJ AA
AW12FAJAA AJ AA
AW1290A
520 x 345 x 485
mm
600 x 394 x 595
660 x 425 x 730
Voltage
Volt
115 11 5
Phase
-
SINGLE
Frequency
Hz
60
Operating Current
A
5.6
6.8
7.4
9.2
12
11.7
Power Consumption
W
600 60 0
715
815
1020
1300
1250
Refrigerant Type
FREON
R-22
g
380 38 0
350
380
485
610
580 58 0
BTU/h
6000
7000
8000
10000
12300
12500
BTU/h.W
10
9.8
9.8
10
9.4
10
Net W eight eight
kg
29
28
29
45
45
50
Condenser
Row
2 x 17
3 x 17
2 x 19
Condenser Fan
Type
Evaporator
Row
Evaporator Fan
Type
Fan M otor
Model
IC-9630SWD6F IC-9630SWD6C IC-9630SWD6E
AFS095ZREA
AFS100ZREB
OSME-708SWC
Compressor(Rotary)
Model
44A062HS1EB
44A072HW1EB
44B102HU1EF
44B124HU1EL
44B124HU1EL
-
M RA12040-12008
M RA98706-12008 M RA12083-12008
M RA12109-12007 M RA98693-12008
M RA98693-12007
Compressor Capacitor
µF / VAC
30/370
25/370
35/370
40/370
45/370
45/370
Fan Motor Capacitor
µF / VAC
4.5/440
6/450
6/450
8/440
15/450
8/440
RPM RPM
810/750/690
800/750/700
910/810/750
920/820/770
920/850/780
800/750/700
Refrigerant Charge Capacity EER EER
Overload Protect
Fan Speed
2 x 15 Propeller Fan 2 x 14
2 x 14
2 x 15
Blower
44A080HU1EB
Thermo Control
-
Thermistor
Off Timer
hr
24
Sa m s u n g El e c t r o n i c s
Remarks
WINDOW
Dimensions: (Width X Height X Depth)
2 -1
Table(cont.) Item Type
AW18FAMBA AMBA AW24FAMBA Unitof AW07FASBA AW09FASBA AW10FAJBA AJ BA AW12FAJBA AJ BA AW14FAMBA Remarks Measure AW18FAMBB AW24FAMBB -
WINDOW
Dimensions: (Width X Height X Depth)
520 x 345 x 485
mm
600 x 394 x 595
Voltage
Volt
220 (230-208)
Phase
-
SINGLE
Frequency
Hz
60
Operating Current
A
3.5
4.7
5.2
6
660 x 425 x 730
6.5
12.5
9.5
11.5 Power Consumption
W
750
1000
1100
1290
1400
2667
2000
2500 Refrigerant Type Refrigerant Charge
FREON g
R-22 410
420
500
510
570
1320
1090
1280 Capacity
BTU/h
7000
9000
10000
12000
14000
24000
18000
24000 EER EER
BTU/h.W
9.3
9
9
9.3
10
8.8
9
8.2 Net W eight eight
kg
Condenser
Row
Condenser Fan
Type
Evaporator
Row
29 2 x 15
2 x 15
43
45
53
61
71
2 x 17
2 x 17
2 x 19
3 x 16
3 x 16
2 x 15
3 x 15
Propeller Fan 2 x 14
4 x 15 3 x 15
Evaporator Fan
Type
Fan M otor
Model
IC-9630SWF6G IC-9630SWF6G
AFS095ZTEA
AFS105ZUEA
OSM E-906SWC
Compressor(Rotary)
Model
44A072IW1EB
44B102IU1EL
44B124HU1EL
44B135IU1EL
Overload Protect
Blower
44B092IW1EF
-
M RA12043-12008 M RA12032-12008
RAC12049-9622
M RA12008-12008
RAC12074-9622
µF / VAC
Fan Motor Capacitor
µF / VAC
3/450
3/450
2.5/450
3.5/450
6/450
RPM RPM
910/780/690
910/780/690
800/720/650
900/840/780
950/850/750
25/370
20/370
20/450
30/450
Thermo Control
-
Thermistor
Off Timer
hr
24
2-2
AFS145ZUEA
48B175IV1EH
48B220IV1EH
48B197IV1EH
Compressor Capacitor
Fan Speed Control
AFS145ZUEA
30/450
M RA12107-12007
INTERNAL
RAC12016-9622
M RA12068-12007
35/450
30/450
40/450
40/450
6/450
6/450
1060/1010/970 1060/1010/970
Sa m s u n g El e ct r o n i c s
Table(cont.) Item Type
Unitof Measure
AW18FAMCA
AW24FAMCA
-
WINDOW
mm
660 x 425 x 730
Voltage
Volt
208-240
Phase
-
SINGLE
Frequency
Hz
60
Operating Current
A
8.5
12.5
Power Consumption
W
1800
2695
Dimensions: (Width X Height X Depth)
Refrigerant Type
FREON
R-22
g
1090
1320
BTU/h
18000
23700
BTU/h.W
10
8.8
Net W eight
kg
61
71
Condenser
Row
3 x 16
3 x 16
Condenser Fan
Type
Evaporator
Row
Evaporator Fan
Type
Fan M otor
Model
AFS145ZUEA
AFS145ZUEA
Compressor(Rotary)
Model
48B175IV1EH
EDB260211A
-
MRA12107-12007
INTERNAL
Compressor Capacitor
µF / VAC
35/450
30/450
Fan Motor Capacitor
µF / VAC
6/450
6/450
RPM
1060/1010/970
1060/1010/970
Refrigerant Charge Capacity EER
Overload Protect
Fan Speed
Propeller Fan 3 x 15
4 x 15 Blower
Thermo Control
-
Thermistor
Off Timer
hr
24
Samsung Electronics
Remarks
2-3
Table(cont.) Item Type
Unitof Measure -
Dimensions: (Width X Height X Depth)
AW12FAJ DA
mm
AWT18FAMDA WINDOW
600 x 394 x 595
660 x 425 x 730
Voltage
Volt
200-220
Phase
-
SINGLE
Frequency
Hz
50
Operating Current
A
6.8
10.5
Power Consumption
W
1330
2050
Refrigerant Type
FREON
R-22
g
660
1480
BTU/h
12000
18000
BTU/h.W
9.0
8.8
Net W eight
kg
45
71
Condenser
Row
2 x 14
4 x 16
Condenser Fan
Type
Evaporator
Row
Evaporator Fan
Type
Fan M otor
Model
AFS105AUEA
OSME-1206SWC
Compressor(Rotary)
Model
48A124MV1EL
48B180MT1EH
-
MRA98706-12008
MRA12108-12007
Compressor Capacitor
µF / VAC
30/450
40/450
Fan Motor Capacitor
µF / VAC
4/450
6/450
RPM
890/840/780
930/880/830
Refrigerant Charge Capacity EER
Overload Protect
Fan Speed
Propeller Fan 2 x 14
3 x 15 Blower
Thermo Control
-
Thermistor
Off Timer
hr
24
2-4
Remarks
Samsung Electronics
Table(cont.) Item Type
Unitof Measure
AW09FASEA AW09FBSEA
-
AW12FAJEA AW12FBJEA
AW18FAMEA AWT24FAMEA AW18FBMEA
520 x 345 x 485
mm
600 x 394 x 595
660 x 425 x 730
Voltage
Volt
220-240
Phase
-
SINGLE
Frequency
Hz
50
Operating Current
A
3.5
4.5
5.8
9
14
Power Consumption
W
750
1000
1330
2000
3000
Refrigerant Type
FREON
R-22
g
410
390
660
1160
980
BTU/h
7000
9000
12000
18000
24000
BTU/h.W
9.3
9.0
9.0
9.0
8.0
Net W eight
kg
28
29
45
60
71
Condenser
Row
2 x 14
3 x 16
3 x 16
Condenser Fan
Type
Evaporator
Row
Evaporator Fan
Type
Fan M otor
Model
Compressor(Rotary)
Model
44A070JW1EB
-
Compressor Capacitor Fan M otor Capacitor
Refrigerant Charge Capacity EER
Overload Protect
Fan Speed
2 x 15
Propeller Fan 2 x 14
2 x 14
3 x 15
Blower IC-9430SWJ5A
AFS105AUEA
OSME-1404SAC
OSME-1256SWC
44B092JW1EF
48A124JV1EL
48B180JV1EH
AWG5532EXC
MST24AMN-12008
MRA12056-12007
MRA12030-12008
MRA12016-12007
INTERNAL
µF / VAC
25/450
30/450
30/450
40/450
45/450
µF / VAC
2.5/450
3/450
3.5/450
6/450
6/450
RPM
850/810/750
910/860/810
890/840/780
1060/1010/960
930/880/830
Thermo Control
-
Thermistor
Off Timer
hr
24
Samsung Electronics
Remarks
WINDOW
Dimensions: (Width X Height X Depth)
AW07FASEA
2-5
2-2Dimensions 2-2-1Main Unit (Type “A”) (U nit : m m )
5 8 4
Frontview
Side view
5 4 3
5 4 3
520
2-6
Samsung Electronics
2-2-2Main Unit (Type “B”) (U nit : m m )
5 9 5
4 9 3
4 9 3
600
Samsung Electronics
2-7
2-2-3 Main Unit (Type “C”) (U nit : m m )
5 9 6
Frontview
Sideview
5 2 4
5 2 4
660
2-2-3 Remote Control
Timer setting button Sleeptimersettingbutton Operatingmode selectionbuttons
Temperature adjustment buttons
Fan speed adjustmentbuttons
Energy Saver button Air flow blade swing button
2-8
ON/OFFbutton
Samsung Electronics
3. Installationand Operating Instructions 3-1Installation
* When selecting the area for installing the unit, be sure to obtain approval of the customer. 1. Make sure that you install the unit in an area that provides good ventilation. The air conditioner must not be blocked by any obstacle affecting the air flow near the air inlet and air outlet. 2. Make sure that you install the unit in an area which can endure the weight and vibration of the unit. 3. Make sure that you install the unit away from heat or vapor.
6. Make sure that you install the unit in an area which provides easy drainage for condensed water. 7. Make sure that you install the unit in an area not exposed to rain or direct sunlight. (Install a separate sunblind if exposed to direct sunlight.) 8. Do not install the unit in an area subjected to noise or vibration amplification which may affect your neighbor. (Fix the unit firmly if mounted in a high place.)
4. Make sure that you install the unit in an area where the cooled air can be evenly spread in a room. 5. Make sure that you install the unit in an area away from TVs, audio units, cordless phones, fluorescent lighting fixtures and other electrical appliances. (obtain a clearance of at least one meter)
Caution:
Do not use the air conditioner in such areas as a greasy area(including machine oil), saline area(sea side), or sulphuric area(hot spring). When using the air conditioner in these areas, special maintenance is required. Contact your local dealer or our service center for advice.
Samsung Electronics
3-1
3-2FunctionDescription
Fan speed indicator (LOW, MED, HIGH) Temperature/Timer settings
Air flow blade swing indicator Energy saver indicator ON/ OFF Timer adjustment button
Temperature adjustment buttons
Sleep mode adjustment button
Operating mode indicators (COOL, FAN) Remote control sensor Air flow blade swing ON/OFF button
Timer indicator Energy saver ON/OFF button
Fan Speed adjustment button (LOW, MED, HIGH)
Operating mode selection button (COOLING, FAN)
Operating on/off
3-2-1Coolingoperation mode The compressor is turned on and off according to the ambient temperature and set temperature. 1) Compressor on and off control • Compressor on and off control according to the ambient temperature * The compressor is turned off when "ambient temperature = set temperature * The compressor is turned on when "ambient temperature = set temperature +1 C" 2) Default value after power reset ➔ set temperature = 24 C (75 F) Fan speed = High 3) Set temperature indicating (setting) range : 1 C(1 F) interval from 18 C to 30 C. (64 F to 86 F) ˚
˚
˚
˚
˚
˚
˚
˚
˚
3-2-2Fanoperationmode 1) If "Fan operation mode" signal is received from remocon or panel. ➔ the compressor is immediately turned off and only fan motor is operated at set blowing speed. ➔ it changes such as "High ➔ Med ➔ Low ➔ High"(if Fan speed is selected). 2) The initial Fan motor speed is set to "High". 3) The set temperature can not be indicated and set.
3-2-3 Energy saver operation mode * If the compressor turn off at the cooling operation, the fan motor turn off after operation during the fixation time only, and operation that energy saver by turn off the fixation time only, and operation that energy saver by turn off the motor continuously before the condition of the compressor on. * The fan motor is not operated at flow wind operation. * Energy saver operation specification at the cooling operation. 1) Fan motor control in compressor on : operate with setting wind speed 2) Fan motor control in compressor off : After compressor off, the fan motor is operated breeze for 2 minutes and then it turn off. 3) After the fan motor off, the compressor and fan motor is operated normally when the compressor on.
3-2
Samsung Electronics
3-2-4Auto Restart (AW✳✳FB✳EA) : OPTION 1) The operation mode, wind volume of fan motor and the set temperature right before the blackout are memorized in EEPROM and so the operation can continue with the previous operation mode, wind volume of fan motor and the set temperature after the recover of blackout.
3-2-5Sleep operation mode 1) Enable to sleep operation only when cooling operation. 2) First, 7-SEG LED DISPLAY "SLEEP" while 15 second, Second, 7-SEG LED DISPLAY "8Hr" And, automatically SET OFF after operated while 8 Hour 3) If sleep operation, setting Temperature rise 1 C after 1 Hour 4) ON TIMER operation, not operation, ENERGY SAVER operation, not sleep operation. ˚
3-2-6Air flow blade swingmotor operation 1) The Air flow blade swing motor is turned on and off according to Air flow blade swing operation in remocon or panel, if SET is cooling or Fan operation mode. 2) If the operation mode is "ENERGY SAVER", in case of fan motor being turned off Air flow blade swing motor is immediately turned off.
3-2-7LEDdisplay indication in case of error detection ERRO R O PERATIO N
7-SEG LED D ISPLAY
R O O M TH E R M IS TO R (O PEN or SH O RT)
E1 d isplayed
1) Set operation in case of error occurrence. • Malfunction of each temperature sensor (open, short) - Error mode display, warning sound. - The operation status is off.
Samsung Electronics
3-3
3-2-8Panel key operation Key discription Key name POWER
Mode
Fan speed
Temperature (, )
3-4
Key operational function O peration start and stop * First O N = operation start, second O N = operation stop - Selected as "O FF –> C O O L or FA N ".(D EFA U LT=O FF) C * ontinuou s ope ration is not available. O peration m ode change * at every O N - Selected as "C O O L –> FA N ". (D efault= C O O L) * If operation is O FF,it is considered as an invalid key. * C ontinuou s ope ration is not available. Fan m otor speed setting * at every O N - Selected as “H IG H – > M ED – > LO W – > H IG H ”. (D EFA U LT=H IG H ) C urrently displayed set tem pe rature increase/decrease * A t every pressing, the set tem perature is change d b y 1˚C ,(1˚F) (increase() : 18˚C – > 19˚C – > ... – > 29˚C – > 30˚C ), (64˚F -> 65˚F -> ... -> 85˚F -> 86˚F) (decrease() : 24˚C – > 23˚C – > ... – > 17˚C – > 18˚C ), (86˚F -> 84˚F -> ... -> 65˚F -> 64˚F) I n case of t he set t em perature of 30˚ C ( 86˚ F), w he n the “increase ”key is pressed * tem perature do es no t increase any m ore. * In case of the set tem perature of 18˚C (64˚F), w he n the “decrease”key is pressed tem perature does not decrease any m ore. * In case of above situation,w hen “increase/decrease“key is pressed by rem ocon, w arning sound is generated. * If operation is O FF,it is considered as an invalid key. * In case of “FA N ”m od e o peration , it is considered as an invalid key. * C ontinu ous operation is available.
Air Swing
C irculaire m otor operation and stop * O nce O N = C irculaire m otor ope ration.A nother O N -C irculaire m otor stop. * C ontinu ous operation is not available. * In case of operation stop,w he n the fan m otor is turned off it is considered as an invalid key.
Timer (ON/OFF)
Setting the on/off tim er O FF TIM ER H O U R “if set is ope ration * C an set “ * C an set “O N TIM ER H O U R “if set is not ope ration “displayed * O nce O N = standb y setting TIM ER : “–– * In case of key p ressing in status of standby se tting O N /O FF TIM ER (– – H r– > 1H r – > 2H r – > ...– > 23H r – > 24H r) * If press TIM ER key countinuosly operate such the low er part (– – H r– > 1H r – > 2H r – > ... – > 24H r – > --H r) * C ontinu ous operation is available.
Sleep
SLEEP m ode on and off * O nce O N =SLEEP m ode on, Another O N =SLEEP m ode off •C ontinuous operation is not abailable •O peration o ff, on tim er O pe ration,save op eration , not key ope ration N * ot SL EE P operation is FAN m ode
Energy Saver
Pow er save m ode on and off * O nce O N =P ow er save m ode on,Another O N =P ow er save m ode off * C ontinuou s ope ration is not available. * If operation is O FF,it is considered as an invalid key.
Samsung Electronics
3-2-9LEDlamp operationspecifications LAMP name COOLING (
Operations specifications The m ode is set to "C O O L" – > ON O thers – > O FF
)
FAN (
)
The m ode is set to "FA N " – > ON O thers – > O FF
HIGH (
)
The m ode is set to "H IG H " – > ON O thers – > O FF
MED (
)
The m ode is set to "M ED " – > ON O thers – O FF >
LOW (
)
The fan spe ed is set to "LO W " – > ON O thers – > O FF
TIMER (
The m ode is set to "TIM ER " – > ON O thers – > O FF
)
ENERGY SAVER (
AIR SWING (
(1)
(3)
)
)
The m ode is set to "E N E R G Y S AV ER " – > ON O thers – > O FF The m ode is set to "A ir Sw ing " – > ON O thers – > O FF In case of set tem pe rature d isplay -> N O .(1) 7–SEG LE D D ISPLA Y indicates tem perature of the tens digit -> N O .(2) 7-SEG LE D D ISPLA Y indicates tem perature of the units digit In case of tim e display -> N O .(1) 7–SEG LE D D ISPLA Y indicates tim e of the tens digit -> N O .(2) 7–SEG LE D D ISPLA Y indicates tim e o f the units digit
(2)
In case of set tem pe rature d isplay -> N O .(3) 7–SEG LE D D ISPLA Y indicates tem perature un it(˚) -> N O .(4) 7-SEG LE D D ISPLA Y indicates tem perature unit(C ), (F) In case of tim e display -> N O .(3) 7–SEG LE D D ISPLA Y indicates tim e unit(H ) of the tens digit -> N O .(4) 7–SEG LE D D ISPLA Y indicates tim e u nit(r)of the un its digit
(4)
First,7–SEG LE D D ISPLA Y "SLEEP " w hile 15 second, Second,7-SE G LED D ISP LAY "8H r"
(1)
(2)
(3)
(4)
Samsung Electronics
3-5
3-3Remocon Control
Timer settingbutton Temperature adjustment buttons
Sleeptimersettingbutton Operatingmode selectionbuttons
Fan speed adjustmentbuttons
Energy Saver button Air flow blade swing button
ON/OFFbutton
3-3-1Remocon key operation 11) In case of pressing ”POWER”key, operation start and stop. 12) In case of pressing ”COOL”key, cool mode operation start. 13) In case of pressing ”FAN”key, fan mode operation start. 14) In case of pressing ”HIGH”key, fan motor operates high speed. 15) In case of pressing ”MED”key, fan motor operates mid speed. 16) In case of pressing ”LOW”key, fan motor operates low speed. 17) In case of pressing ”ENERGY SAVER”on/off key, set operates as power saving mode. 18) In case of pressing ””key, set temperature increase by 1 C(18 C ~ 30 C), 1 F(64 F ~ 86 F). 19) In case of pressing ””key, set temperature decrease by 1 C(30 C ~ 18 C), 1 F(86 F ~ 64 F). 10) In case of pressing ”TIMER”key, the convenient reserve TIMER time increase by 1 Hr (1Hr ~ 24Hr). 11) In case of pressing ”SLEEP”key, SLEEP operates. 12) In case of power off, all keys except POWER key are considered as an invalid key. ˚
˚
3-6
˚
˚
˚
˚
˚
˚
˚
˚
˚
˚
Samsung Electronics
3-3-2 Resistor values table of “ROOM THERMISTOR” for each temperature Tem perature
THER M ISTO R RESISTO R
Tem perature
THER M ISTO R RESISTO R
[˚C ]
[Koh m ] ± 1%
[˚C ]
[Koh m ] ± 1%
70 69 68
2.229
29 28 27
8.622
2.296 2.365
67 66 65
2.437 2.512 2.589
26 25 24
9.632 10.000 10.380
64 63
2.669 2.752
23 22
10.780 11.200
62 61 60
2.838 2.928 3.021
21 20
11.630 12.090 12.560 13.060 13.570 14.120 14.680
8.944 9.281
59 58 57 56
3.116 3.216 3.319 3.426
19 18 17 16 15
55 54
3.537 3.652
14 13
15.280 15.900
53 52
12 11
51
3.772 3.897 4.026
10
16.550 17.240 17.960
50
4.161 18.700 19.480
49
4.300
9 8
48 47
4.444 4.594
7 6
20.290 21.150
46 45
4.749 4.912
5 4
22.050 22.990
44
5.080
3
23.900
43 42
5.256 5.439
2 1
25.030 26.130
41 40
5.630 5.828
0
27.280
-1
28.470
39 38 37 36
6.033 6.246 6.468
-2 -3 -4 -5
29.720 31.040 32.430
35
6.699 6.941
34 33 32 31 30
Samsung Electronics
-6
33.890 35.430
7.192 7.455
-7 -8
37.050 38.760
7.729 8.015 8.313
-9
40.560
3-7
4. DisassemblyandReassembly 4-1Compressor Replacement Flow Chart Locate cause of defect
R elease refrige rant
D isconnect electricalw iring from com pressor C ut refrigerant lines from com pressor Plug disconnected line s
R eplace com pressor
Inspect electrical w iring for defects, and term inals for correct and secure connections
Solder discharge line
Solder suction line
Use nitrogen gas
Perform soldering function
Y
Problem ? Fillsystem w ith nitrogen gas
N
C heck for leakag e
Y Leakage?
C orrective action C heck refrigerant oillevel
N R elease nitrogen gas?
Y
Low oillevel?
N Evacuate system
A dd oilas necessary R echarge system
Pinch and braze filling tube
4-1
Samsung Electronics
4-2 Disassembly and Reassembly Procedure 4-2-1 Type “A” Stop operating the air conditioner, and pull out the power cord before repair. No. !
Part name A ss'y G rill
Procedures
Remarks
1. Pullthe pane lfront and rem ove the screw on the grille.
*The type of front-panel depends on models.
2.H old the low er part of grillw ith tw o hands w hile pressing dow n on both sides of the low er part of the cabinet, pullit forw ard by about 30 ,and the then lift it up for rem oval.
@
A ss'y Cabinet
1. R em ove the tw o screw s both side cabinet. 2. Pullthe fron t bo th side ,and rem ove the unit from the cabinet.
#
A ss'y C ontrol
1. R em ove the blade V and arm blade. 2. R em ove 2 screw s,and 2 earth w ire screw s. 3. R em ove tw o lead w ire assem blies. 4. Take out the control bo x forw ard.
Samsung Electronics
4-2
Disassembly and Reassembly
No.
Part name
Procedures
$
Fram e U p
1. R em ove 6 screw s on the Fram e up and rem ove the F ram e up and the reinf from case cond.
%
Case Cond & Propeller Fan
1. R em ove tw o screw s on the bo ttom side, and 4 screw s on the case cond.
Remarks
2. Pullup the case cond and separate the cond case from the con d. 3. R em ove the nut flange, and rem ove the propeller fan
4-3
Samsung Electronics
Disassembly and Reassembly
No.
Part name
Procedures
^
C ond C asing
1. R em ove the con d casing
&
B low er & M otor
1. M ove the m otor & blow er tow ard the evap,and lift up the m otor & blow er from the fram e low .
Samsung Electronics
Remarks
4-4
Disassembly and Reassembly
4-2-2 Type “B” Stop operating the air conditioner, and pull out the power cord before repair. No. !
Part name A ss'y G rill
Procedures
Remarks
1. Pullthe pane lfront and rem ove the screw on the grille.
*The type of front-panel depends on models.
2.H old the low er part of grillw ith tw o hands w hile pressing dow n on both sides of the low er part of the cabinet, pullit forw ard by about 30, and the then lift it up for rem oval.
@
A ss'y Cabinet
1. R em ove the screw s on both sides of the cabinet to disconn ect the cabinet and fram e. 2. Pullthe handle on the front side of the bottom , and rem ove the unit from the cabinet.
#
A ss'y C ontrol
1. R em ove 6 screw s,and e arth w ire screw . 2. R em ove three lead w ire assem blies. 3. R em ove the blade V and arm blade. 4. Take out the control box forw ard.
4-5
Samsung Electronics
Disassembly and Reassembly
No.
Part name
Procedures
$
Fram e U p
1. R em ove 10 screw s on the Fram e U p.
%
Case Cond & Prope ller Fan
1. R em ove tw o screw s on the bo ttom side, and 5 screw s on the case cond.
Remarks
2. R em ove the nut flange, and rem ove the propellr fan
Samsung Electronics
4-6
Disassembly and Reassembly
No.
➅
Part name B low er & M otor
Procedures
Remarks
1. R em ove tw o screw s on the clip m otor, and rem ove the clip m otor. 2. M ove the m otor & blow er tow ard the evap,and lift up the m otor & blow er from the fram e low .
➆
4-7
C ond C asing
1. R em ove the cond casing
Samsung Electronics
Disassembly and Reassembly
4-2-3 Type “C” Stop operating the air conditioner, and pull out the power cord before repair. No. !
Part name A ss'y G rille
Procedures
Remarks
1. Pullthe pane lfront and rem ove the screw on the grille.
*The type of front-panel depends on models.
2.H old the low er partof grillw ith tw o hands w hile pressing dow n on both sides of the low er part of the cabinet, pullit forw ard by about 30 ,and the then lift it up for rem oval.
@
A ss'y Cabinet
1. R em ove the screw s on both sides of the cabine t to disconnect the cabinet and fram e. 2. Pullthe handle on the front side of the bottom ,and rem ove the unit from the cab inet.
#
A ss'y C ontrol
Samsung Electronics
1. R em ove 10 screw s,on the evap cover and earth w ire screw .
4-8
Disassembly and Reassembly
No.
Part name
Procedures
Remarks
2. R em ove 3 screw on the controlbox and tw o lead w ire assem blies. 3. Take out the control box forw ard.
$
A ss’ y - Evaporator
1. R em ove for screw s on the left and right side of the evaporator.
%
Plate - Evap C asing
1. Lift up the evaporator,and rem ove the tray drain. 2. R em ove tw o screw s on the left side of the plate evap casing .
4-9
Samsung Electronics
Disassembly and Reassembly
No.
Part name
Procedures
^
B low er
1. Loo sen the hexagon nut, and rem ove the blow er.
&
Prope ller Fan
1. R em ove tw o screw s on the bottom side,and 5 screw s on the case cond.
Remarks
2. Loo sen the hexagon nut, and rem ove the fan
*
M otor Su pporte & M otor
1. R em ove four hexagon nuts on the b ase pan. 2. M ove the m otor - assem bly tow ard the cond enser, and lift up the m otor assem bly from the fram e. 3. R em ove the clips on both sides carefully using the (-) driver.
Samsung Electronics
4-10
MEMO
4-11
Samsung Electronics
5. Troubleshooting Check the basic checkpoints first to determine whether it is machine trouble or a problem in the operation method. When it is not related to the basic checkpoints, perform checking in accordance with the procedures of troubleshooting by symptom.
5-1Basic Checkpoints for Troubleshooting 1) Is the voltage of the power source appropriate ? (1) It should be within the rating voltage ±10% range. (2) The air conditioner may not operate properly when the voltage is out of this range. 2) Is the connection with the fan motor, compressor wire, and starting condenser appropriately made ? 3) The symptoms listed in the table below are not indicative of machine trouble. Sym ptom
C ause and check
N o operation
•Check w hetherthere is pow er failure orthe pow er plug is pulled out. •C he ck w hethe r the un it is stop pe d as a resu lt of com pletion of the sleep tim e. •Pullout the po w er plug for ten second s, and the n insert it again.
A ir flow s,but no cooling
•C heck w hether the Air filter is clogged w ith dust or is dirty. •Check w hether the desired tem perature is too high. Set the desired tem perature to a low er leve lthan the curren t tem perature. •C heck w hether it is in "FA N " m ode.
The rem ocon does n ot o pe rate
•Check w hetherbattery is com pletely depleted. •C h eck w h eth er th e b atte ry is p ro pe rly in se rte d. •C heck w hether the receiving w indow of the rem ocon for the asse m bly m ain P C B is blinded. •C heck w hether the rem ocon is affected by jam m ing due to a neo n sign.
N o te m p erature settin g
•C h eck w hethe rthe u nit is in "FA N " m o de . (In "FA N " m o de, on ly the cu rre nt te m p erature is d isplayed, and the desired tem perature is not set.)
❈ Checking and Display of Fault Area E R R O R O P E R ATIO N
E R R O R O P E R ATIO N
R O O M TH E R M IS TO R (O P EN O R S H O R T )
E1 displayed
Samsung Electronics
5-1
5-2TroubleshootingbySymptom 5-2-1 No power 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range.) (2) Is the electric wire in good contact ?(CN 71, RY 71) (3) Is the output voltage of the IC01(KA 7812) normal ?(DC 11.5V ~ DC 12.5V) (4) Is the output voltage of the IC02(KA7805) normal ?(DC 4.5V ~ DC 5.5V)
Turn off t he power, and then turn it on again five seconds later.
Dose the buzzer sound, when the power on?
Y
Normal operation.
N
Check whet her the "COOLING ICON" LED lamp is on, and the operation starts w hen pressing the ON/ OFF button of t he remocon.
Y
Normal operation.
N
Is the F701(3.15A) fuse blown?
Y
Replace the fuse.
N
Is the primary voltage of the transformer normal? (the rating voltage ±10% range.)
N
Check the pow er cord and electric wire.
Y
Is the secondary voltage of the transformer normal? (AC 13V ~ AC 17V)
N
Check and replace the trans.
Y
Is the rectifier diode(D101~D104) normal?
N
• Check the D101 ~ D104 for cold soldering. • Replace the rectifier diode
Y
- Is the voltage of DC 17V ~ DC 23V applied at both ends of the C101 electrolytic condenser? - Is the voltage of DC 12V applied at both ends of the C102 electrolytic condenser? - Is the voltage of DC 5V applied at both ends of the C103 electrolytic condenser?
Y Are the IC01(KA7812) and IC02(KA7805) normal ?
Y
N
N
• Check both ends of the C101 for short and cold soldering. • Check the +12V for a short. • Check the +5V for a short. • Check and replace the C101~104. • Check the IC01, and IC02 for cold soldering and a short. • Replace the IC01, and IC02.
Replace the assembl y main PCB.
5-2
Samsung Electronics
5-2-2 When the MEMBRANE KEY PAD AND LED DISPLAY 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range.) (2) Is the electric wire in good contact ?(CN71, RY71) (3) Is the connection of the assembly main PCB, and MEMBRANE KEY PAD in good contact? (CN91)
Turn off the pow er, and then turn it on again five seconds later.
Normal operation
N
W hen the LED DISPLAY is not operated. Y
Check the micom (IC04) for a short, and replace it.
N
Is the voltage of the m icom (IC04) No.1, 2, 38~43 port a square wave? Y
Check the micom (IC04) for a short, and replace it.
N
Is the voltage of the m icom (IC04) No.3, 4, 10, 11, 44 port a square wave? Y
Check the Q901~ Q905 for a short, and replace it.
N
Is the voltage of the Q901 ~ Q905 square wave?
W hen the M EMBRANE KEY is not operated.
N
Normal operation
Y
Is the voltage of the micom (IC04) No.13, 14 port a square wave?
N
Check the micom (IC04) for a short , and replace it.
N
Check the micom (IC04) for a short , and replace it.
Y
Is the voltage of the m icom (IC04) No.3, 4, 10, 11, 44 port a square wave? Y
Replace the M EMBRANE KEY PAD.
Y
Check the IC07 for a short, and replace it.
N
Is the voltage of the IC07 No. 10~16 a square value? Y
Replace the M EMBRANE KEY PAD
Samsung Electronics
5-3
5-2-3 When the remocon is not operated 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range. ) (2) Is the electric wire in good contact ? (CN71, RY71) (3) Is the assembly main PCB in good contact with the MEMBRANE KEY PAD(CN91) (4) Is the battery voltage of the remocon above DC 2.7V?
Turn off t he power, and then turn it on again five seconds later.
Dose the Buzzer sound, when the power on?
N
Go to the clause "No pow er".
Y
Check whet her the "COOLING ICON" LED lamp is on and th operation starts w hen pressing the on/off button of the remocon.
Y
The remocon is normally operated.
N
Is the battery voltage of the remocon above DC 2.7V?
N
Replace the battery.
Y
Does the X-TAL(RJ 455JB) oscillate normally?
N
• Check the X-TAL for cold soldering and a short. • Replace relevant components.
N
• Check the micom(ICT1) QT1, and QT2 for cold soldering and a short. • Replace relevant components.
Y
Is the collector voltage of the remocon QT1, QT2 a square wave? Y
Is the input voltage of the micom(IC04) No. 15 pin of the assembly main PCB a aquare wave?
N
• Check the R415 components. • Check the assemb ly main PCB micom(IC04).
Y
Replace the assembl y main PCB.
5-4
Samsung Electronics
5-2-4 When the compressor is not operated 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range. ) (2) Is the desired temperature lower than the indoor temperature in the “COOL” mode? (Compressor stopped) (3) Is the starting condenser in good contact? (4) Is the electric wire in good contact ? (CN71, RY71) (5) Is the output voltage of the IC01(KA7812) and IC02(KA7805) normal ?
Turn off t he power, and then turn it on again five seconds later.
Dose the Buzzer sound, when the power on?
N
Go to the clause "No power".
Y
Check whet her the "COOLING ICON" LED lamp is on and the operation starts when pressing the on/of f button of t he remocon.
N
• Go to the clause "when he remocon does not operate".
Y
Check whether the compressor is activated in three minutes after t urning on the power w ith the "COOLING ICON" LED lamp being switched on when selecting the cool mode of t he remocon.
Y
Normal operation.
N
Is the IC03 output normal? - When the compressor is ON, IC03 No. 15 pin –> Low.
N
• Check the IC03 for short and cold soldering. • Replace the IC03.
N
• Check the relay coil resistance. (resistance : About 150Ω±20 Ω) • Replace the relay.
Y
Does the relay(RY71) operate normally? - When the compressor is ON, the RY71 should operate. Y
Is the compressor normal? Y
N
• Check the operation of the O.L.P, and replace it if necessary. • Check the compressor resistance.(0Ω : short, ∞Ω : open)
Replace the compressor.
Samsung Electronics
5-5
5-2-5 Whenthe air swingmotor is not operated 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range. ) (2) Is the electric wire in good contact ?(CN71, RY71) (3) Is the swing motor connector in good contact?(CN71) (4) Is the terminal connected to the swing motor in good contact? (5) Is the output voltage of the IC01(KA7812) and IC02(KA7805) normal?
Turn off t he power, and then turn it on again five seconds later. N
Go to the clause "No pow er".
Dose the buzzer sound, when the power on? Y
Check whether the “COOLING ICON” LED lamp is on, and the operation starts when pressing the ON/OFF button of t he remocon?
N
Go to the clause of “ w hen the remocon dose not operated”
Y
Does the air-swing m otor operate w hen pressing the air-swing button of the remote control?
Y
Normal operation.
N
Is the IC03 output normal? - W hen the air-swing motor is on, IC03 No. 11 pin ➝ Low
N
• Check the IC03 for a short and cold soldering. • Replace the IC03.
N
• Check the relay coil resistance. (Normal: About 400Ω) • Replace the relay.
N
• Check the air-swing motor resistance. (0Ω : short, ∞Ω : open)
Y
Does the relay(RY 75) operate normally? - W hen the air-swing motor is operated, the RY75 should be operated. Y
Is the air-sw ing motor normal? Y
Replace the air-swing motor.
5-6
Samsung Electronics
5-2-6Whenthe fan motor does not operated 1) Check points (1) Is the voltage of the power source normal ? (the rating voltage ±10% range. ) (2) Is the electric wire in good contact ?(CN71, RY71) (3) Is the starting condenser(FAN MOTOR) in good contact? (4) Is the fan motor connector in good contact?(CN73) (5) Is the output voltage of the IC01(KA7812) and IC02(KA7805) normal ?
Turn off the pow er, and then turn it on again five seconds later. N
Go to the clause "No power".
Dose the buzzer sound, when the power on? Y
Check whether the "COOLING ICON" LED lamp is on and the operation starts when pressing the on/off butt on of the remocon.
N
• Go to the clause of "when the remocon does not operated".
N
• Check the IC03 for a short and cold soldering. • Replace the IC03.
N
• Check the relay coil resistance. (Normal: About 400Ω) • Replace the relay.
Y
Is the IC03 output normal? - When t he fan motor is High, IC03 No. 13 pin –> LOW . - W hen the fan mot or is M ed, IC03 NO. 14 pin –> LOW. - W hen the fan motor i s Low, IC03 No. 16 pin –> LOW. Y
Does the relay(RY 72, 73) operate normally? - W hen the f an motor is High, RY72 should operate. - W hen the fan mot or is M ed, RY73 should operate. - W hen the f an motor is Low, RY76 should operate. Y
N
Is the fan motor normal? Y
• Check the fan motor resistance. (0Ω : short, ∞Ω : open) • Check the fan motor thermal fuse? (130˚C)
Replace the fan motor.
Samsung Electronics
5-7
6. Exploded View andParts List 6-1Main unit (Type “A”) 8 2
5 2 9 2
6 2
3 3
3 1
8 1
5 1
7 2
2 2 4 2
0 2 1 2
3 2
0 1
9 1
4 1
7 1
9
2 1
5 3
0 3
6 1
3 0 3 5 0 3
4 0 3
5 8
2 0 3
6 0 3 8 0 3
7 1 0 0 3 3
1 1
6
7
9 0 3 0 1 0 3
1 1 0 3
4 3 4
3 2
3
2 1 0 3
1 3
1 2 2 2
2
6-1
1
Samsung Electronics
Part
List (Type “A”)
No
C ode N o.
D escripition
Q’ ty
Specification AW 0690A
1
2
AW 0790A AW 07FASAA AW 07FASBA AW 07FASEA
AW 0890A AW 09FASBA AW 09FASEA AW 09FBSEA
D B 64-10158A
G R ILLE-A IR IN LET
H IPS,2m m
1
1
-
-
-
1
-
-
-
D B 64-00104A
G R ILLE-A IR IN LET
H IPS,2m m
-
-
1
-
1
-
1
1
1 -
D B 64-00104B
G R ILLE-A IR IN LET
H IPS,2m m
-
-
-
1
-
-
-
-
D B 92-70096D
A SS'Y PA N EL-FR O N T
A SSY
1
1
-
-
-
1
-
-
-
D B 92-00052A
A SS'Y PA N EL-FR O N T
A SSY
-
-
1
-
1
-
1
1
1
D B 92-00052B
A SS'Y PA N EL-FR O N T
A SSY
-
-
-
1
-
-
-
-
-
2-1
D B 63-30158A
FILTER -G U A R D
H IPS,2m m
1
1
-
-
-
1
-
-
-
D B 74-00005C
FILTER -G U A R D
ZEN O B LU E
-
-
1
1
1
-
1
1
1
2-2
D B 64-70093A
PA N EL-FR O N T
H IPS,2m m
1
1
-
-
-
1
-
-
-
D B 64-00167A
P A N EL-FR O N T
H IPS,2m m
-
-
1
-
1
-
1
1
1 -
2-3
3
D B 64-00167B
P A N EL-FR O N T
H IPS,2m m
-
-
-
1
-
-
-
-
D B 66-30191A
B LA D E-H
H IPS
1
1
-
-
-
1
-
-
-
D B 66-00053A
B LA D E-H
H IPS
-
-
1
-
1
-
1
1
1
D B 66-00053B
B LA D E-H
H IPS
-
-
-
1
-
-
-
-
-
D B 96-00045C
A SSY-EVA P
2R *14S
1
1
1
-
-
1
-
-
-
D B 75-00001B
ASSY-EVA P
2R *14S
-
-
-
1
1
-
-
-
-
D B 96-00045B
ASSY-EVA P
3R *14S
-
-
-
-
-
-
1
-
-
D B 96-00045A
ASSY-EVA P
2R *14S
-
-
-
-
-
-
-
1
1 1
4
D B 90-00002D
A SSY FR A M E-LO W ER
AW 07A 1SB ,-
1
1
1
1
1
1
1
1
5
D B 66-30211B
B LA D E-V
PP,SC -97525R
1
1
1
1
1
1
1
1
1
6
D B 66-70030A
LEVER -D A M PER
H IPS,SC -94445R
1
1
1
-
1
1
1
1
1
D B 66-70030C
LEVER -D A M PER
H IPS,W 9391
-
-
-
1
-
-
-
-
-
7
D B 67-50078A
B LO W ER
ABS
1
1
1
1
1
1
1
1
1
8
D B 31-00073A
M O TO R FA N
IC -9630SW D 6F
1
-
-
-
-
-
-
-
-
D B 31-00073E
M O TO R FA N
IC -9630SW D 6C
-
1
-
-
-
-
-
-
-
D B 31-00004P
M O TO R FA N
IC -9630SW D 6E
-
-
1
-
-
-
-
-
-
D B 31-00073C
M O TO R FA N
IC -9430SW J5A
-
-
-
-
1
-
-
1
1 -
D B 31-00073B
M O TO R FA N
IC -9630SW D 6E
-
-
-
-
-
1
-
-
D B 31-00073D
M O TO R FA N
IC -9630SW D 6G
-
-
-
1
-
-
1
-
-
D B 67-50077A
FA N -PR O PELLER
ABS
1
1
1
1
1
1
1
1
1
10
D B 90-00013B
A SSY-C A SE-C O N D
A SSY
1
1
1
1
1
1
1
1
1
11
D B 90-00014G
A SSY FR A M E-U PPER
A SSY
1
1
-
1
1
1
1
1
1
9
D B 90-00014H
A SSY FR A M E-U PPER
A SSY
-
-
1
-
-
-
-
-
-
12
D B 61-00027B
F R A M E-R EIN F
PP,G R AY
1
1
1
1
1
1
1
1
1
13
D B 75-00002A
C O N D EN SER
2R ,15S,G R O O VE
1
1
-
1
-
-
-
1
1
D B 75-00002B
C O N D EN SER
2R ,15S,G R O O VE
-
-
1
-
1
-
1
-
-
D B 75-00011B
C O N D EN SER
2R ,15SG R O O VED
-
-
-
-
-
1
-
-
-
D B 63-10388A
CAP
EPD M ,B LK
-
-
1
1
1
-
1
1
1
14 15 16
17
18
19
D B 90-20212F
A SSY-B A SE
SG C C -M ,SC 94445T
1
1
-
-
-
1
-
-
-
D B 90-20212B
A SSY-B A SE
SG C C -M ,SC 94445T
-
-
1
1
1
-
1
1
1
D B 96-00260A
A SSY-TU B E C A PILLA R Y
1.3*1100
1
-
-
-
-
-
-
-
-
D B 62-00372A
A SSY-TU B E C A PILLA R Y
C 1220T-H
-
1
1
-
-
-
-
-
-
D B 96-00077A
A SSY-TU B E C A PILLA R Y
AW 0719
-
-
-
1
1
-
-
-
-
D B 96-00552A
A SSY-TU B E C A PILLA R Y
1.42xL1200
-
-
-
-
-
1
-
-
-
D B 96-00046A
A SSY-TU B E C A PILLA R Y
AW 09A 2SB
-
-
-
-
-
-
1
-
-
D B 96-00077B
A SSY-TU B E C A PILLA R Y
AW 09G 2SE
-
-
-
-
-
-
-
1
1
D B 96-00008B
A SSY TU B E SU C TIO N
AW 07A 2SB
1
1
-
1
1
1
-
-
-
D B 62-00370A
A SSY TU B E SU C TIO N
C 1220T-0,M EI-C O M P
-
-
1
-
-
-
-
-
-
D B 96-10736A
A SSY TU B E SU C TIO N
AW 09B 0SB
-
-
-
-
-
-
1
-
-
D B 96-10736B
A SSY TU B E SU C TIO N
AW 09G 2SE
-
-
-
-
-
-
-
1
1
D B 62-00150C
TU B E D ISC H A R G E
C 1220T-0,D 7.94,T0.7
1
1
-
1
1
-
-
-
-
D B 62-00391A
TU B E D ISC H A R G E
C 1220T-O ,O D 7.93,T0.7
-
-
1
-
-
-
-
-
-
D B 62-00483A
TU B E D ISC H A R G E
C 1220T-O ,O D 7.93,T0.7
-
-
-
-
-
1
-
-
-
D B 62-00152A
TU B E D ISC H A R G E
C 1220T-0,D 7.94,T0.7
-
-
-
-
-
-
1
1
-
D B 62-00440A
TU B E D ISC H A R G E
C 1220T-0,D 7.94,T0.7
-
-
-
-
-
-
-
-
1 -
44A 062H S1EB
C O M PR ESSO R
115V,60H z,R 22,1Ph
1
-
-
-
-
-
-
-
44A 072H W 1EB
C O M PR ESSO R
1Ph,115V,R 22,60H z
-
1
-
-
-
-
-
-
-
D B 95-00113E
C O M PR ESSO R
2R 11S3R 126-6,M ATSU SH TA
-
-
1
-
-
-
-
-
-
44A 072IW 1EB
C O M PR ESSO R
208-230V,60H z,1Ph,R -22
-
-
44A 070JW 1EB
C O M PR ESSO R
220-240V,50H z,1Ph,R -22
-
-
44A 080H U 1EB
C O M PR ESSO R
115V,60H Z,1PH ,8.0K
-
-
-
44B 092IW 1EF
C O M PR ESSO R
208-239V,60H z,1Ph,R -22
-
-
-
-
1
-
-
-
-
-
-
1
-
-
-
-
-
-
1
-
-
-
-
-
-
1
-
-
44B 092JW 1EF
C O M PR ESSO R
1Ph,50H z,R 22,220-240V
-
-
-
-
-
-
-
1
1
20
D B 60-30028A
N U T-W A SH ER
H EX,2C ,M 8,ZPC
1
1
1
1
1
1
1
1
1
21
D B73-00070A
G RO M M ET-ISO LATO R
N R 35°∆
1
1
1
1
1
1
1
1
1
22
D B 63-10026A
C O VER -TER M IN A L
N O R YL,SEI-701
1
1
-
1
1
1
1
1
1
Samsung Electronics
6-2
Part List (Type “A”) (cont.)
No
C ode N o.
D escripition
Q’ ty
Specification AW 0690A
AW 0790A AW 07FASAA AW 07FASBA AW 07FASEA
AW 0890A AW 09FASBA AW 09FASEA AW 09FBSEA
22
D B 63-00023A
C O VER -TER M IN A L
M E1
-
-
1
-
-
-
-
-
-
23
D B 60-30018A
N U T-FLA N G E
PI0.8,M 5,SM 20C
1
1
1
1
1
1
1
1
1
24
25
D B 47-20002F
O LP
M R A 12040-12008
1
-
-
-
-
-
-
-
-
D B 47-20001V
O LP
M R A 98706-12008
-
1
-
-
-
-
-
-
-
D B 35-00012B
O LP
M R A 98705
-
-
1
-
-
-
-
-
-
D B 47-20002J
O LP
M R A 12043-12008
-
-
1
-
-
-
-
-
D B 47-20001Y
O LP
M ST24A M N -12008
-
-
-
-
1
-
-
-
D B 47-20066B
O LP
150/69,31.0
-
-
-
-
-
1
-
-
-
D B 47-20002A
O LP
M R A 12032-12008
-
-
-
-
-
-
1
-
1
D B 47-20002U
O LP
M R A 12056-12007
-
-
-
-
-
-
-
1
D B 64-00135H
C A B IN ET
SG C C -M
1
1
-
-
-
1
-
-
-
D B 64-00135A
C A B IN ET
SEC C -P,SC -94445T
-
-
1
1
1
-
1
1
1
26
D B 64-00048B
SH U TTER -A N G LE U P
H IPS,T3.0,520
1
1
-
-
-
1
-
-
-
27
D B 92-00113A
A SSY SH U TTER -LF
A SSY
1
1
-
-
-
1
-
-
-
28
D B 92-00112A
A SSY SH U TTER -R H
A SSY
1
1
-
-
-
1
-
-
-
29
D B 61-30219F
B R A C KET-IN STA LL
SG C C -A ,T1.6
1
1
-
-
-
1
-
-
-
30
D B 93-00465K
A SSY C O N TR O L-E
A SSY
1
-
-
-
-
-
-
-
-
D B 93-00465Q
A SSY C O N TR O L-E
A SSY
-
1
-
-
-
-
-
-
-
D B 93-00705A
A SSY C O N TR O L-E
A SSY
-
-
1
-
-
-
-
-
-
D B 9 3 -0 04 65 L
A S S Y C O N T R O L -E (TAIW AN )
A SSY
-
-
1
-
-
-
-
-
-
D B 9 3-0 046 5M
A S SY C O N T R O L -E (TA IW A N ) A SSY
-
-
1
-
-
-
-
-
D B 93-00465D
A SSY C O N TR O L-E
A SSY
-
-
-
-
1
-
-
-
-
D B 93-00465H
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
1
-
-
-
D B 93-00465G
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
1
-
-
D B 93-00465C
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
-
1
-
D B 93-00465P
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
-
-
1 1
31
D B 93-00284K
ASSY R EM O C O N
A SSY
1
1
1
1
1
1
1
1
33
D B 97-30156C
A SSY A C C ESSO R Y
A SSY
1
1
-
-
-
1
-
-
-
34
D B 60-30002A
N U T-FLA N G E
M6
1
1
1
1
1
1
1
1
1
35
D B 60-30004A
N U T FLA N G E
M 6,SM 20C
1
1
1
1
1
1
1
1
1
6-3
Samsung Electronics
6-2Main unit (Type “B”) 8 1
0 2
6 1
7 1
9 1 4 1
1 2
1 1
5 1 3 1
0 1
8 2
3
4
9
8
2 1
7 5 2
7
6 5 2
4 5 2
6 7 2
3 2
8 5 2
4 2
5
5 2
0 1 5 2
5 5 2 2 1 5 3 2 5 2 3 1 5 2
9 5 2
1 1 5 2 2 5 2 1 5 2
2 2
3 2
6 2
1 2
2 2 2
1
Samsung Electronics
6-4
Part
No 1 2 2-1 2-2 2-3 3
4
5
6 7 9
10 11
12 13
14
15 16 17 18 19 20
21
22 23 24 25
26
6-5
List (Type “B”) D escripition
G R ILLE-A IR IN LET G R ILLE-A IR IN LET A SSY PA N EL-FR O N T A SSY PA N EL-FR O N T PA N EL-FR O N T PA N EL-FR O N T G U A R D A IR -FILTER G U A R D A IR -FILTER B LA D E-H B LA D E-H A SSY-B A SE A SSY-B A SE A SSY-B A SE A SSY-C O N D A SSY-C O N D A SSY-C O N D A SSY-C O N D A SSY-EVA P A SSY-EVA P A SSY-EVA P A SSY-FR A M E LO W A SSY-FR A M E LO W B LO W ER B LO W ER M O TO R FA N M O TO R FA N M O TO R FA N M O TO R FA N M O TO R FA N FA N -PR O PELLER A SSY-C A SE-C O N D A SSY-C A SE-C O N D A SSY-C A SE-C O N D A SSY FR A M E-U P A SSY FR A M E-U P TU B E-C A PILLA R Y TU B E-C A PILLA R Y TU B E-C A PILLA R Y TU B E-C A PILLA R Y TU B E-C A PILLA R Y TU B E SU C TIO N TU B E SU C TIO N TU B E SU C TIO N TU B E-D ISC H A R G E TU B E-D ISC H A R G E N U T-W A SH ER G R O M M ET-ISO LATO R G R O M M ET-ISO LATO R SPR IN G -O LP C O VER -TER M IN A L O LP-PO LYESTER O LP-PO LYESTER O LP-PO LYESTER O LP-PO LYESTER O LP-PO LYESTER O LP-PO LYESTER R O TA R Y C O M PR ESSO R :22 R O TA R Y C O M PR ESSO R :22 R O TA R Y C O M PR ESSO R :22 R O TA R Y C O M PR ESSO R :22 R O TA R Y C O M PR ESSO R :22 R O TA R Y C O M PR ESSO R :22 A SSY C A B I A SSY C A B I B LA D E-V LEVER -D A M PER ASSY C O N TR O L A SSY C O N TR O L A SSY C O N TR O L A SSY C O N TR O L A SSY C O N TR O L A SSY C O N TR O L A SSY C O N TR O L(VIETN A M ) A SSY C O N TR O L A SSY C O N TR O L ASSY R EM O C O N A SSY R EM O C O N
Code N o. D B 64-10145A D B 64-00101A D B 92-00133A D B 92-00072A D B 64-70080A D B 64-00168A D B 63-30142A D B 63-00073B D B 66-30169A D B 66-00049A D B 90-20184L D B 90-20184B D B 90-20184A D B 96-00587A D B 96-00587B D B 96-00250B D B 96-30279A D B 96-40203C D B 96-40173A D B 96-40173B D B 90-50133J D B 90-50133A D B 67-50078A D B 67-50073A D B 31-00074A D B 31-00074E D B 31-00074B D B 31-00074D D B 31-00074C D B 67-50072A D B 61-10152A D B 90-00142A D B 90-00142B D B 90-50142E D B 90-50142F D B 96-00387A D B 62-00649A D B 62-00510A D B 62-00550A D B 62-31741A D B 96-00348B D B 96-00931A D B 62-31742A D B 62-00327B D B 62-31740A D B 60-30028A D B 73-00070A D B 73-00067A D B 67-60020A D B 63-10026A D B 35-00004Y D B 35-00015M D B 47-20001U D B 47-20001M D B 47-20001V D B 47-20001Z 44B 102H U 1EF 44B 102IU 1EL 44B 124H U 1EL 44B 124IU 1EL 48A 124M V1EL 48A 124JV1EL D B 90-00364B D B 90-00364A D B 66-30170A D B 66-70024A D B 93-00558A D B 93-00559A D B 93-00674H D B 93-00571A D B 93-00587A D B 93-00674F D B 93-00674M D B 93-00577A D B 93-00674L D B 93-00284K D B 93-00284M
Q’ ty
Specification H IPS,T2.5 H IPS,T2.5 A SS'Y SC -94445R A SS'Y SC -94445R H IPS H IPS,T2.5 H IPS,T2 A B S,ZEN O B LU E PP,T2.5 PP,T3 SEC C -P,T1 SEC C -P,T1 SEC C -P,T1 A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y AB S AB S A FS-095ZR EA A FS-095ZTEA A FS-100ZR EB A FS-105ZU EA A FS-105A U EA A S,350 A SS'Y A SS'Y A SS'Y A SS'Y A SS'Y H EX,2C ,M 8,ZPC NR NR STS304-W PA N O RYL,-,SEI-701 M R A 12109-12007 R A C 12049-9622 M R A 98693-12007 M R A 12008-12008 M R A 12030-12008 M R A 98706-12008 115V,60H z,1Ph,R -22 208-230V,60H z,1Ph,R -22 115V,60H z,1Ph,R -22 208-230V,60H z,1Ph,R -22 200-220V,50H z,1Ph,R -22 220-240V,50H z,1Ph,R -22 A SS'Y A SS'Y PP,T3 H IPS,T2.5 A SSY A SSY A SSY A SSY A SSY A SSY A SSY A SSY A SSY A SSY A SSY
AW 1090A
AW 10FAJAA
AW 10FAJBA
AW 12FAJAA
AW 12FAJBA
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
AW 12FAJDA
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
AW 12FAJEA
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
AW 12FBJEA
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 -
Samsung Electronics
6-3Main unit (Type “C”)
5 2
6 1
0 1 9 2 2 1
2 1 1
4 2
7 1
5 4 1 1
1
8 2 3 1 2 2
3 1
1 4 1
2
0 1 9
1 9
6
5
3 3
8
8 1 3
3
5 1 3
2 3
3 1
4
7 1 3
9 1 3
1 1 1 3
2 1 1 3
6 - 3 1 1 3 1 3
4 1
1 3
4 1 4 3 1 1 3
0 1 1 3
2 1 3
1 1 3
2 1 1 1
4 3
1
Samsung Electronics
6-6
Part List (Type “C”)
Q’ ty N o C ode N o.
D escripition
Specification A W 1 29 0A
1
1-1
1-2
1-3
A W 1 4F A M B A
A W 1 8F AM B A
A W 1 8F A M B B
A W 1 8F A M C A
A W 1 8F A M E A
A W 1 8F B M E A
A W T 18 FA M D A
A W 2 4F A M B A
A W 2 4F AM B B
A W 2 4F A M C A
W T2 4F AM E A
D B 92-70101F
A SSY PA N EL-FR O N T
A SSY
1
-
-
-
-
-
-
-
-
-
-
-
D B 92-00067A
A SSY PA N EL-FR O N T
A SSY
-
1
1
1
1
1
1
1
1
1
1
1
D B 92-00067B
A SSY PA N EL-FR O N T(TA IW A N ) A SSY
-
-
1
-
-
-
-
-
-
-
-
-
D B 64-10163A
G R ILLE-A IR IN LET
H IPS,T2.5
1
-
-
-
-
-
-
-
-
-
-
-
D B 64-00178A
G R ILLE-A IR IN LET
H IPS,M -P/J
-
1
1
1
1
1
1
1
1
1
1
1
D B 64-00178B
G R ILLE-A IR IN LET(TA IW A N )
H IPS,W 9391
-
-
1
-
-
-
-
-
-
-
-
-
D B 63-30167C
G U A R D A IR -FILTER
A B S,T2,SC -94445R ,-
1
-
-
-
-
-
-
-
-
-
-
-
D B 63-00100C
G U A R D A IR -FILTER
ZEN O B LU E,G R EEN
-
1
1
1
1
1
1
1
1
1
1
1
D B 66-30205A
B LA D E-H
PP
1
-
-
-
-
-
-
-
-
-
-
-
D B 66-00120A
B LA D E-H
C -PP,M -P/J
-
1
1
1
1
1
1
1
1
1
1
1
D B 66-00120B
B LA D E-H (TA IW A N )
PP,W 9391(W H T)
-
-
1
-
-
-
-
-
-
-
-
-
D B 64-70102A
PA N EL-FR O N T
H IPS,T2.5
1
-
-
-
-
-
-
-
-
-
-
-
D B 64-00177A
PA N EL-FR O N T
H IPS,M -P/J
-
1
1
1
1
1
1
1
1
1
1
1
D B 64-00177B
PA N EL-FR O N T(TA IW A N )
H IPS,W 9391(W H T)
-
-
1
-
-
-
-
-
-
-
-
-
D B 90-00304A
A SSY B A SE
M -P/J,44B FR A M E
1
-
-
-
-
-
-
-
-
-
-
-
D B 90-00304G
A SSY B A SE
M -P/J,44B D R A IN
-
1
-
-
-
-
-
-
-
-
-
-
D B 90-00304E
A SSY B A SE
M -P/J,48B D R A IN
-
-
1
1
1
1
1
1
-
1
-
-
D B 90-00304F
A SSY B A SE
M -P/J,48/55D W D R A IN
-
-
-
-
-
-
-
-
1
-
1
D B 90-20215A
A SSY B A SE
-
-
-
-
-
-
-
-
-
-
-
1
3
D B 63-40019A
TR AY-D R A IN
30FO A M -PS
1
1
1
1
1
1
1
1
1
1
1
1
4
D B 96-00654A
A SSY EVA P
M -P/J,2R *15S
1
1
-
-
-
-
-
-
-
-
-
-
D B 96-00254A
A SSY EVA P
M -P/J,3R *15S
-
-
1
1
1
1
1
-
-
-
-
-
D B 96-40207B
A SSY EVA P
M -P/J,3R *15S
-
-
-
-
-
-
-
1
-
1
-
-
D B 96-00253A
A SSY EVA P
M -P/J,4R *15S
-
-
-
-
-
-
-
-
1
-
1
-
D B 96-40207A
A SSY EVA P
1.7W AVE
-
-
-
-
-
-
-
-
-
-
-
1
5
D B 61-00440A
M O U N T M O TO R
SG C C -M ,T1.2
1
1
1
1
1
1
1
1
1
1
1
1
6
D B 31-00075A
M O TO R FA N
O SM E-708SW C ,M -P/J
1
-
-
-
-
-
-
-
-
-
-
-
D B 31-00075J
M O TO R FA N
O SM E-906SW C ,M -P/J
-
1
-
-
-
-
-
-
-
-
-
-
1-4
2
8
9
-
D B 31-00075E
M O TO R FA N
A FS145ZU EA ,M -P/J
-
-
1
1
1
-
-
-
1
1
1
-
D B 31-00075H
M O TO R FA N
O SM E-1404SA C ,M -P/J
-
-
-
-
-
1
1
-
-
-
-
-
D B 31-00075F
M O TO R FA N
O SM E-1206SW C ,M -P/J
-
-
-
-
-
-
-
1
-
-
-
-
D B 31-00085A
M O TO R FA N
O SM E-1256SW C ,M -P/J
-
-
-
-
-
-
-
-
-
-
-
1 1
D B 96-00026A
EVA P-PLATE C A SIN G
A SSY
1
1
1
1
1
1
1
1
-
-
-
D B 96-00026B
EVA P-PLATE C A SIN G
A SSY
-
-
-
-
-
-
-
-
1
1
1
-
D B 67-00096A
B LO W ER
A B S+ G /F20% ,M -P/J
1
1
1
1
1
1
1
1
1
1
1
1 1
9-1
D B 60-30002A
N U T-W A SH ER
M6
1
1
1
1
1
1
1
1
1
1
1
10
D B 61-00609A
C A SE EVA P
30FO A M -PS,W H T
1
1
-
-
-
1
1
1
-
-
-
-
D B 61-10182A
C A SE EVA P
30FO A M -PS
-
-
1
1
1
-
-
-
1
1
1
1
11
D B 63-10487A
C O VER -EVA P
PP,T2.5
1
1
1
1
1
1
1
1
1
1
1
1
12
D B 70-10679A
PLATE-PA R TITIO N
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
1
1
1
1
13
D B 61-00448A
C A SE C O N D
PP(TA LC ),T2.5,B LK
1
1
1
1
1
1
1
1
1
1
1
-
D B 61-10183A
C A SE C O N D
PP,T2
-
-
-
-
-
-
-
-
-
-
-
1
14
D B 67-00047A
FA N -PR O PELLER
A B S,M -P/J
1
1
1
1
1
1
1
1
1
1
1
-
D B 67-50028A
FA N -PR O PELLER
A B S+ G LA SS-FIB ER
-
-
-
-
-
-
-
-
-
-
-
1 1
14-1
D B 60-30004A
N U T-W A SH ER
M 6,SM 20C
1
1
1
1
1
1
1
1
1
1
1
15
D B 96-00664A
A SSY C O N D
M -P/J,2R *19S*560
1
1
-
-
-
-
-
-
-
-
-
-
D B 96-00328B
A SSY C O N D
1.7 D ,H EX,SF
-
-
1
1
1
-
-
-
1
1
1
-
D B 96-00328A
A SSY C O N D
A SSY
-
-
-
-
-
1
1
-
-
-
-
-
D B 96-00092A
A SSY C O N D
4X16,W AVE2.0
-
-
-
-
-
-
-
1
-
-
-
-
D B 96-00328B
A SSY C O N D
1.7,D ,H EX,SF
-
-
-
-
-
-
-
-
1
1
1
-
D B 96-30358A
A SSY C O N D
1.7W AVE
-
-
-
-
-
-
-
-
-
-
-
1
D B 62-00566A
TU B E C A PILLA R Y
2.75
1
-
-
-
-
-
-
-
-
-
-
-
D B 62-00596A
TU B E C A PILLA R Y
AW 14FA M B A ,-,-,-
-
1
-
-
-
-
-
-
-
-
-
-
D B 62-00519A
TU B E C A PILLA R Y
2.75
-
-
1
-
1
1
1
-
-
1
-
-
D B 62-00588A
TU B E C A PILLA R Y
2.75,22K
-
-
-
1
-
-
-
-
-
-
-
-
D B 96-00283A
TU B E C A PILLA R Y
1.2X1000X3
-
-
-
-
-
-
-
1
-
-
-
-
D B 62-00516A
TU B E C A PILLA R Y
2.75,24K
-
-
-
-
-
-
-
-
1
-
1
-
D B 62-31988A
TU B E C A PILLA R Y
C 1220T-H ,1.3
-
-
-
-
-
-
-
-
-
-
-
1
D B 62-00563A
TU B E SU C TIO N
12K
1
1
-
-
-
-
-
-
-
-
-
-
D B 62-00518A
TU B E SU C TIO N
18K
-
-
1
1
1
1
1
-
-
-
-
-
D B 62-00518C
TU B E SU C TIO N
O D 12.7,24K
-
-
-
-
-
-
-
1
-
1
-
-
D B 62-00515A
TU B E SU C TIO N
24K
-
-
-
-
-
-
-
-
1
-
1
-
D B 62-31987B
TU B E SU C TIO N
C 1220T-O ,T0.8
-
-
-
-
-
-
-
-
-
-
-
1
D B 62-00534B
TU B E D ISC H A R G E
O D 9.52
1
1
-
-
-
-
-
-
-
-
-
-
D B 62-00457B
TU B E D ISC H A R G E
O D 9.52
-
-
1
1
1
-
-
1
-
1
-
-
D B 62-00067C
TU B E D ISC H A R G E
C 1220T-0,O D 9.52,T0.7
-
-
-
-
-
1
1
-
-
-
-
-
16
17
18
6-7
Samsung Electronics
Part List (Type “C”)
Q’ ty N o C ode N o.
D escripition
Specification A W 1 29 0A
A W 1 4F A M B A
A W 1 8F A M B A
A W 1 8F AM B B
A W 1 8F A M C A
A W 1 8F A M E A
A W 1 8F B M E A
A W T 18 FA M D A
A W 2 4F A M B A
A W 2 4F A M B B
A W 2 4F AM C A
W T2 4F A M E A
D B 62-00514A
TU B E D ISC H A R G E
9.52,24K
-
-
-
-
-
-
-
-
1
-
1
-
D B 62-00025A
TU B E D ISC H A R G E
24K
-
-
-
-
-
-
-
-
-
-
-
1
19
D B 60-30018A
N U T-FLA N G E
PI0.8,M 5,SM 20C
1
1
1
1
1
1
1
1
1
1
1
-
20
D B 63-10026A
C O VER -TER M IN A L
N O R YL
1
1
1
1
1
1
1
1
-
1
-
-
D B 63-00038A
C O VER -TER M IN A L
N O R YL,T2,B LK
-
-
-
-
-
-
-
-
1
-
1
-
D B 47-20001U
O LP
M R A 98693-12007
1
-
-
-
-
-
-
-
-
-
-
-
21
D B 35-00015H
O LP
R A C 12074-9622
-
1
-
-
-
-
-
-
-
-
-
-
D B 35-00004W
O LP
M R A 12107-12007
-
-
1
-
1
-
-
-
-
-
-
-
D B 35-00015E
O LP
R A C 12016-9622
-
-
-
1
-
-
-
-
-
-
-
-
D B 47-20001P
O LP
M R A 12016-12007
-
-
-
-
-
1
1
-
-
-
-
-
D B 35-00004X
O LP
M R A 12108-12007
-
-
-
-
-
-
-
1
-
-
-
-
D B 47-20002Z
O LP
M R A 12
-
-
-
-
-
-
-
-
-
1
-
-
22
D B 60-30028A
N U T-W A SH ER
H EX,2C ,M 8,ZPC ,-,-
23
D B 7 3-0 00 70 A
G R O M M E T IS O L AT O R
N R 3 5° ∆
D B 73-00067A
G R O M M ET ISO LATO R
NR
-
-
1
1
1
1
1
1
-
1
-
D B 73-00041A
G R O M M ET ISO LATO R
EPD M ,D A EW O O
-
-
-
-
-
-
-
-
1
-
1
-
44B 124H U 1EL
C O M PR ESSO R
115V,60H z
1
-
-
-
-
-
-
-
-
-
-
-
24
25
31
32
33 34
1 1
1 1
1 -
1 -
1 -
1 -
1 -
1 -
1 -
1 -
1 -
1 -
44B 135IU 1EL
C O M PR ESSO R
208-230V,60H Z
-
1
-
-
-
-
-
-
-
-
-
-
48B 175IV1EH
C O M PR ESSO R
208-230V,60H z
-
-
1
-
1
-
-
-
-
-
-
-
48B 190IV1EH
C O M PR ESSO R
208-230V,60H z
-
-
-
1
-
-
-
-
-
-
-
-
48B 180JV1EH
C O M PR ESSO R
50H z,220-240V
-
-
-
-
-
1
1
-
-
-
-
-
48B 180M T1EH
C O M PR ESSO R
200-220V,50H Z
-
-
-
-
-
-
-
1
-
-
-
-
D B 95-00113C
C O M PR ESSO R
ED B 260211A ,230V,60H z
-
-
-
-
-
-
-
-
1
-
1
-
48B 220IV1EH
C O M PR ESSO R
60H z,208-230V
-
-
-
-
-
-
-
-
-
1
-
-
D B 95-10351B
C O M PR ESSO R
AW G 5532EXC
-
-
-
-
-
-
-
-
-
-
-
1
D B 64-00138J
C A B IN ET
SG C C -M ,SC -94445T
1
-
-
-
-
-
-
-
-
-
-
-
D B 64-00138A
C A B IN ET
SEC C -P,SC -94445T
-
1
1
1
1
1
1
1
1
1
1
1
D B 93-00484P
A SSY C O N TR O L-E
A SSY
1
-
-
-
-
-
-
-
-
-
-
-
D B 93-00484W
A SSY C O N TR O L-E
A SSY
-
1
-
-
-
-
-
-
-
-
-
-
D B 93-00484H
A SSY C O N TR O L-E
A SSY
-
-
1
-
1
-
-
-
-
-
-
-
D B 93-00484X
A SSY C O N TR O L-E(TA IW A N )
A SSY
-
-
1
-
-
-
-
-
-
-
-
-
D B 93-00484L
A SSY C O N TR O L-E
A SSY
-
-
-
1
-
-
-
-
-
1
-
-
D B 93-00484N
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
1
-
-
-
-
-
-
D B 93-00774B
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
1
-
-
-
-
-
D B 93-00484M
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
-
1
-
-
-
-
D B 93-00774G
A SSY C O N TR O L-E(VIETN A M )
A SSY
-
-
-
-
-
-
-
1
-
-
-
-
D B 93-00484K
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
-
-
1
-
1
-
D B 93-00717A
A SSY C O N TR O L-E
A SSY
-
-
-
-
-
-
-
-
-
-
-
1
D B 66-70024A
LEVER -D A M PER
H IPS,T2.5
1
1
1
1
1
1
1
1
1
1
1
1
D B 66-70024C
LEVER -D A M PER (TA IW A N )
H IPS,T2.5,W 9391
-
-
1
-
-
-
-
-
-
-
-
-
D B 61-60125A
FR A M E-B LA D E
H IPS,T2.5
1
1
1
1
1
1
1
1
1
1
1
1
D B 93-00284K
A SSY R EM O C O N
W -R A C ,A R C -709
1
-
1
1
1
1
1
1
1
1
1
1
D B 93-00284M
A SSY R EM O C O N
W -R A C ,A R C -710
-
1
-
-
-
-
-
-
-
-
-
-
Samsung Electronics
6-8
6-3Ass’y Control 13
2
7
1
11
4
8 3
5 6
12 9 14 10
Part
List (Type “A”)
N o C ode N o.
D escripition
Q’ ty
Specification AW 0690A AW 0790A
AW 07FASAA
AW 07FASAA
AW 07FASBA
(TAIW AN )
(TAIW AN )
AW 07FASEA
AW 0890A
A W 0 9F A SB A
A W 0 9F A SE A
A W 0 9F B S EA
1
D B 61-00417A
C A SE C O N TR O L-LO W
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
1
2
D B 61-00419A
C A SE C O N TR O L-U P SM (E)
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
1
1
3
2501-001227
C -O IL
30uF,400V
1
-
-
-
-
-
-
-
-
-
2501-001226
C -O IL
25uF,400V
-
1
-
1
1
1
-
-
-
-
2501-001216
C -O IL
35/5uF,370V
-
-
1
-
-
-
-
-
-
-
2501-001228
C -O IL
35uF,400V
-
-
-
-
-
-
1
-
-
-
2501-001225
C -O IL
20uF,400V
-
-
-
-
-
-
-
1
-
-
2501-001236
C -O IL
30uF,450V
-
-
-
-
-
-
-
-
1
1
4
D B 65-10008B
C LIP-C A PA C ITO R
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
1
1
5
2301-001450
C -FILM ,M PE-PPF
4500nF,440V
1
-
-
-
-
-
-
-
-
-
2301-001449
C -FILM ,M PE-PPF
6000nF,440V
-
1
-
-
-
-
1
-
-
-
2301-001367
C -FILM ,M PE-PPF
6000nF,450V
-
-
-
1
-
-
-
-
-
-
2301-001370
C -FILM ,M PE-PPF
2500nF,450V
-
-
-
-
-
1
-
-
-
-
2301-001369
C -FILM ,M PE-PPF
3000nF,450V
-
-
-
-
1
-
-
1
1
1
6 7 8
1
D B 26-00006B
TR A N S-PO W ER
A C 115V,50H z/60H z,D C 17V
1
1
1
1
-
-
1
-
-
-
D B 26-00006A
TR A N S-PO W ER
A C 230V,50H z/60H z,D C 17V
-
-
-
-
1
1
-
1
1
1
D B 31-00084A
M O TO R -SYN C H R O N O U S
M 2C K59ZT79-H
1
1
1
1
-
-
1
-
-
-
D B 31-00084B
M O TO R -SYN C H R O N O U S
M 2LJ49ZV32
-
-
-
-
1
1
-
1
1
1
D B 93-00407A
A SSY PC B M A IN
A SSY
1
1
-
-
-
-
1
-
-
-
D B 93-00407B
A SSY PC B M A IN
A SSY
-
-
1
1
1
1
-
1
1
-
D B 93-00407D
A SSY PC B M A IN
A SSY
-
-
-
-
-
-
-
-
-
1
9
D B 64-00259A
PA N EL C O N TR O L-S(E)
H IPS,T2.0
1
1
1
1
1
1
1
1
1
1
10
D B 34-00013B
SW ITC H M EM B R A N E
99*134.5,PC
1
1
1
-
-
1
1
1
1
1
DB 34-00015B
SW ITCH M EM BR AN E(TAIW AN )
99.1*134.5,PET
-
-
-
1
1
-
-
-
-
-
11
D B 32-10051A
TH ER M ISTO R
10K/25,3425K
1
1
1
1
1
1
1
1
1
1
12
D B 39-00343A
PO W ER C O R D -A SS'Y
125V,13A ,TA N D EM
1
1
1
1
-
-
1
-
-
DB 39-00342A
PO W ER CO RD -ASS'Y(TAIW A N )
-
-
-
-
D B 39-00348A
PO W ER C O R D -A SS'Y
H O N G KO N G ,250V,15A
-
-
-
-
-
1
-
D B 39-00344A
PO W ER C O R D -A SS'Y
250V,13A ,TA N D EM
-
-
-
-
-
-
-
13
D B 66-70031A
A R M -B LA D E
14
D B 64-00321A
W IN D O W R EM O C O N
6-9
250V,16A ,TA N D EM
PS
1
-
-
-
-
-
-
-
1
1
1
-
-
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
Samsung Electronics
Exploded View and Parts List
8
4
5
12 13
7
3 6
10 11 9 2 14 1
Part List (Type “ B”)
N o C ode N o.
D escripition
Q’ ty
Specification AW 1090A
1 2 3
AW 10FAJAA
AW 10FAJBA
AW 12FAJAA AW 12FAJBA
AW 12FAJDA
AW 12FAJEA
AW 12FBJEA
D B 34-00013B
SW ITC H M EM B R A N E
99x134,PC
1
1
-
1
1
1
1
D B 34-00015B
SW ITC H M EM B R A N E
99.1x134.5,PET
-
-
1
-
-
-
-
1 -
D B 64-00259A
PA N EL C O N TR O L-S(E)
H IPS,T2.0
1
1
1
1
1
1
1
1
D B 93-00407A
A SSY PC B M A IN
A SSY
1
-
-
-
-
-
-
-
D B 93-00407B
A SSY PC B M A IN
A SSY
-
1
1
1
1
1
1
-
D B 93-00407D
A SSY PC B M A IN
A SSY
-
-
-
-
-
-
-
1
4
D B 61-00421A
C A SE C O N TR O L-U P J(E)
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
5
D B 31-00084A
M O TO R -SYN C H R O N O U S
M 2LJ49ZV32
1
1
-
1
-
-
-
-
D B 31-00084B
M O TO R -SYN C H R O N O U S
M 2LJ49ZV32
-
-
1
-
1
1
1
1
6
2501-001229
C -O IL
40uF,400V
1
1
-
-
-
-
-
-
2501-001234
C -O IL
20uF,450V
-
-
1
-
-
-
-
-
2501-001230
C -O IL
45uF,400V
-
-
-
1
-
-
-
-
2501-001236
C -O IL
30uF,450V
-
-
-
-
1
1
1
1
7
D B 65-10008B
C LIP-C A PA C ITO R
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
8
D B 66-70022D
A R M -B LA D E
PS,SC -96527R
1
1
1
1
1
1
1
1
9
10
D B 39-00343B
PO W ER C O R D -A SS'Y
125V,15A ,PA R A LLEL
1
1
-
1
-
-
-
-
D B 39-00342A
PO W ER C O R D -A SS'Y
250V,16A ,TA N D EM
-
-
1
-
-
-
-
-
D B 39-00344A
PO W ER C O R D -A SS'Y
250V,13A ,TA N D EM
-
-
-
-
1
-
-
-
D B 39-10089Q
PO W ER C O R D -A SS'Y
250V,15A
-
-
-
-
-
1
-
-
D B 39-00348A
PO W ER C O R D -A SS'Y
250V,15A
-
-
-
-
-
1(VIETN A M )
1
1
2301-001448
C -FILM ,M PE-PPF
8000nF,440V
1
-
-
-
-
-
-
-
2301-001381
C -FILM ,M PE-PPF
8000nF,450V
-
1
-
-
-
-
-
-
2301-001370
C -FILM ,M PE-PPF
2500nF,450V
-
-
1
-
-
-
-
-
2301-001452
C -FILM ,M PE-PPF
15000nF,250V
-
-
-
1
-
-
-
-
2301-001378
C -FILM ,M PE-PPF
3500nF,450V
-
-
-
-
1
-
1
1 -
2301-001379
C -FILM ,M PE-PPF
4000nF,450V
-
-
-
-
-
1
-
D B 26-00006B
TR A N S-PO W ER
A C 115V,50H z/60H z
1
1
-
1
-
-
-
-
D B 26-00006A
TR A N S-PO W ER
A C 230V,50H z/60H z
-
-
1
-
1
1
1
1
12
D B 61-00417A
C A SE C O N TR O L-LO W
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
13
D B 32-10051A
TH ER M ISTO R
10K/25,-,3425K
1
1
1
1
1
1
1
1
14
D B 64-00321A
W IN D O W R EM O C O N
1
1
1
1
1
1
1
1
11
Samsung Electronics
6-10
Exploded View and Parts List
9
5
6
13
14
8
4 11
7 12
2
10
15 1
Part List (Type “ C”)
N o C ode N o.
D escripition
Q’ ty
Specification A W 12 90 A
1 2 4
99*144.2,PC
A W 14 FA M B A A W 18 FA M B A A W 18 FA M B B A W 18 FA M C A A W 18 FA M E A A W 18 F B M E A AW T18FAM DA
A W 2 4F A M B A
A W 2 4F A M B B
A W 2 4F A M C A
AW T24FAM EA
D B 34-00013A
SW ITC H M EM B R A N E
1
1
1
1
1
1
1
1
1
1
1
D B 34-00015A
SW ITC H M EM B R A N E(TA IW A N ) 99.1*144.2,PET
-
-
1
-
-
-
-
-
-
-
-
1 -
D B 64-00261A
PA N EL C O N TR O L-M (E)
H IPS,T2
1
1
1
1
1
1
1
1
1
1
1
1
D B 93-00407A
A SSY PC B M A IN
A SSY
1
-
-
-
-
-
-
-
-
-
-
-
D B 93-00407B
A SSY PC B M A IN
A SSY
-
1
1
1
1
1
-
1
1
1
1
1
D B 93-00407D
A SSY PC B M A IN
A SSY
-
-
-
-
-
-
1
-
-
-
-
-
5
D B 61-00419A
C A SE C O N TR O L-U P SM (E)
S G C C -M ,T0.7
1
1
1
1
1
1
1
1
1
1
1
1
6
D B 31-10152A
A SSY-M O TO R SW IN G
M 2C K59ZT19-H
1
-
-
-
-
-
-
-
-
-
-
-
D B 95-20065F
A SSY-M O TO R SW IN G
M 2LJ49ZU 3
-
1
1
1
1
1
1
1
1
1
1
1
7
2301-001448
C -FILM ,M PE-PPF
8000nF,440V
1
-
-
-
-
-
-
-
-
-
-
-
2301-001367
C -FILM ,M PE-PPF
6000nF,450V
-
1
1
1
1
1
1
1
1
1
1
1
8
D B 65-10008B
C LIP-C A PA C ITO R
SG C C -M ,T0.8
1
1
1
1
1
1
1
1
1
1
1
1
9
D B 66-00186A
A R M -B LA D E
PO M ,B LK
1
1
1
1
1
1
1
1
1
1
1
1
10
11
D B 39-00343B
PO W ER C O R D -A SS'Y
125V,15A ,PA R A LLEL
1
-
-
-
-
-
-
-
-
-
-
D B 39-00342A
PO W ER C O R D -A SS'Y
250V,16A ,TA N D EM
-
1
1(TA IW A N )
-
-
-
-
-
-
-
-
-
D B 39-00344A
PO W ER C O R D -A SS'Y
250V,13A ,TA N D EM
-
-
1
-
1
-
-
-
-
-
-
-
D B 39-00345A
PO W ER C O R D -A SS'Y
250V,15A ,TA N D EM
-
-
-
1
-
-
-
D B 39-00348B
PO W ER C O R D -A SS'Y
H O N G KO N G ,250V,15A
-
-
-
-
-
1
1
D B 39-10089R
PO W ER C O R D -A SS'Y
250V,15A
-
-
-
-
-
-
-
1
-
-
-
D B 39-00200B
PO W ER C O R D -A SS'Y
SPT,250V,20A
-
-
-
-
-
-
-
-
1
-
1
-
D B 39-10001K
PO W ER C O R D -A SS'Y
240V,60H Z,20A
-
-
-
-
-
-
-
-
-
-
-
1
1 (VIETN AM )
-
1 -
-
-
-
2501-001230
C -O IL
45uF,400V,B K
1
-
-
-
-
-
-
-
-
-
-
1
2501-001236
C -O IL
30uF,450V
-
1
-
-
-
-
-
-
1
-
1
-
2501-001237
C -O IL
35uF,450V
-
-
1
-
1
-
-
-
-
-
-
-
2501-001238
C -O IL
40uF,450V
-
-
-
1
-
1
1
-
-
1
-
-
2501-001239
C -O IL
45uF,450V
-
-
-
-
-
-
-
1
-
-
-
-
D B 26-00006B
TR A N S-PO W ER
A C 115V,50H z/60H z
1
-
-
-
-
-
-
-
-
-
-
-
D B 26-00006A
TR A N S-PO W ER
A C 230V,50H z/60H z
-
1
1
1
1
1
1
1
1
1
1
1
13
D B 61-00417A
C A SE C O N TR O L-LO W
SG C C -M
1
1
1
1
1
1
1
1
1
1
1
1
14
D B 32-10051A
TH ER M ISTO R
10K/25,3425K
1
1
1
1
1
1
1
1
1
1
1
1
15
D B 64-00321A
W IN D O W R EM O C O N
1
1
1
1
1
1
1
1
1
1
1
1
12
6-11
Samsung Electronics
7. Block Diagram 7-1Refrigerating Cycle Block Diagram PIN CH PIPE (SER VICE VA LVE)
SU CTIO N LIN E
D IS C H A R G E L IN E
A C C U M U L A TO R /C O M P R ES SO R
EVAPORATOR
CONDENSER
C A P IL L A R Y T U B E
PIN CH PIPE (SER VICE VA LVE)
7-2Basic Structure 7-2-1MicomControl Diagram MAIN MICOM Room Temperature sensor
MembranePadcontrol A/Dconverter
Receiving Unit of Remocon
• • • • •
EEPROM
(RemoteControl) Operation Swing Timer
(Key operation) Energe saver Temp.set(!, ") Operation, M ode Swing, Sleep Fan select, Timer
Led display control (Remocon control) Remocon Single Receiving
• Remocon single control
Sleep
• Swing motor control
Compressor
Fan speed (high)
• Compressor control
Fan motor
Fan speed (med)
• Buzzer control
Fan speed (low)
• Temperature control
Fan
Powercircuit (DC 12V)
Energy saver
Temp.setting(")
Samsung Electronics
Power circuit (DC 5V)
• Fan motor control
Cool
Temp.setting(!)
Swing motor
Reset Circuit Oscillation Circuit
Down Trans (AC15V) Power input (AC230V), (AC115V)
7-1
7-2-2 MicomPin Assignment
KS88C4716
7-2
SEG-DATA(c)
1
P0.1
P4.4
44
GRID5
SEG-DATA(b)
2
P0.0
P0.2
43
SEG-DATA(d)
GRID4
3
P4.3
P0.3
42
SEG-DATA(e)
GRID3
4
P4.2
P0.4
41
SEG-DATA(f)
Vcc
5
VDD
P0.5
40
SEG-DATA(g)
Vss
6
VSS
P0.6
39
SEG-DATA(h)
10M Hz RESONATOR
7
Xout
P0.7
38
SEG-DATA(a)
10M Hz RESONATOR
8
Xin
P1.0
37
EEPROM CLK
TEST
9
TEST
P1.1
36
EEPROM IN
GRID2
10
P4.1
P1.2
35
EEPROM OUT
GRDI1
11
P4.0
P1.3
34
BUZZER
RESET
12
RESET
P1.4
33
AUTO RESTART OPTION
KEY-IN1
13
P2.0
P1.5
32
JIG OUTPUT
KEY-IN2
14
P2.1
P3.7
31
OPTION
REMOCON SINGLE RECEIVE
15
P2.2
P3.6
30
SENSOR THERMISTOR(103AT)
EEPROM CS
16
P2.3
P3.5
29
OPTION (HEAT PUM P)
LOW FAN
17
P2.4
P3.4
28
OPTION (HEAT PUM P)
COM PERSSOR
18
P2.5
P3.3
27
OPTION (HEAT PUM P)
M ED FAN
19
P2.6
P3.2
26
OPTION (HEAT PUM P)
HIGH FAN
20
P2.7
P3.1
25
ENERGY SAVER OPTION
OPTION (HEAT PUM P)
21
P4.5
P3.0
24
SWINGMOTOR
Vcc
22
AVref
AVss
23
GND
Samsung Electronics
8. PCB Diagram 8-1ASS’Y Main PCB (Code No ; DB93-00407A, B, D) • DB93-00407A( I ) •DB93-00407B(II) •DB93-00407D(III)
Samsung Electronics
8-1
Part List
NO.
CODE-NO
1
-
2
DESCRIPTION
SPECIFICATION
1
2
3
REMAKRS
DIODE-RECTIFIER
1T4
4
4
4
D101~D104
1405-000147
VARISTOR
470V 4500A
1
1
1
VA71
3
DE13-20017A
IC-DRIVE
KID65003AP
2
2
2
IC03, IC07
4
DE13-20009A
IC
KA7533Z
1
1
1
IC05
5
DE13-20016A
IC-VOLT REGU
KA7805A
1
1
1
IC02
6
DE13-20008A
IC-VOLT REGU
KA7812A
1
1
1
IC01
7
DE60-10100A
SCREW TAPPIN G
PH-3 L6
1
1
1
8
DE62-30031A
HEAT SINK
A6063 L23.5 W 30
1
1
1
9
-
C-AL
2200µF 25V
1
1
1
C102
10
-
C-AL
1000µF 35V
1
1
1
C101
11
-
C-AL
100µF 10V
1
1
1
C103
12
-
C-AL
22µF 16V
1
1
1
C104
13
-
CONNECTOR WA FER
YW396-03AV YEL
1
1
1
CN11
14
-
CONNECTOR WA FER
YW396-03AV WHT
1
1
1
CN71
15
3711-003407
CONNECTOR WA FER
YW396-05AV WHT
1
1
1
CN73
16
-
CONNECTOR WA FER
JSW250-02 RED
1
1
1
CN41
17
-
CONNECTOR WA FER
JSW250-03 RED
1
1
1
CN12
18
DE32-10037A
FUSE
250V 3.15A
1
1
1
F701
19
-
FUSE HOLDER
FB 58 20M M
1
1
1
F701
20
DE30-20016A
BUZZER
CSB2220BA
1
1
1
BZ61
21
2001-001172
R-CARBON
620 OHM 1/ 2W
1
1
1
R601
22
-
REM OCON M ODU LE
KSM 713TE5
1
1
1
RM 41
23
-
CONNECTOR WA FER
FCZ254-08S
1
1
1
CN91
24
-
JUM PER WIRE
PI0.6 52M M
24
24
24
J1~J13, J15~J24, J32
25
-
JUM PER WIRE
PI0.6 52M M
1
1
0
OP01
26
-
JUM PER WIRE
3216 TYPE
7
7
7
J25~J31
27
-
PCB-M AIN
FR-1 81.5* 134.5
1
1
1
28
-
R-CARBON
RD 1/4W 180-J
8
8
8
R903~R910
29
-
R-CARBON(2012)
M CR10 330-J
5
5
5
R404~R406, R415, R902
31
-
R-CARBON(2012)
M CR10 1 0K-J
9
10
10
R301, R407, R408, R410~R414, R501, R901(R411)
32
2004-001137
R-CARBON
RD 1/8W 6.8K-F
1
1
1
R403
33
2004-000218
R-CARBON
RD 1/8W 10K-F
2
2
2
R401, R402
34
-
R-CARBON(2012)
M CR10 1 K-J
1
2
1
R201, R202
35
-
R-CARBON(2012)
M CR 100K-J
1
1
1
R409
36
-
C-CERAM IC(2012)
M CR21 2 F 104Z
9
9
9
C105, C106, C401~C406, C410
37
-
C-CERAM IC(2012)
M CR21 2 F 223Z
4
4
4
C501, C502, C601, C901
38
-
C-CERAM IC(2012)
M CR21 2 F 101Z
1
1
1
C407
39
-
C-CERAM IC(2012)
M CR21 2 F 102Z
3
3
3
C408, C409, C902
40
-
TRANSISTOR
KRA226S
5
5
5
Q901~Q905
41
-
TRANSISTOR
KRC246S
1
1
1
Q906
42
-
DIODE-SWITCHIN G(SM ALL)
1N4148
5
5
5
D901~D905
43
DB09-00091A
IC-M CU
KS88C4716
1
1
1
IC04
44
3501-001058
RELAY-POW ER
ID 1U
1
1
1
RY71
45
2802-000103
CERAM I C RESONATOR
10M Hz
1
1
1
X501
46
DB07-00010A
LED DISPLAY
ELF-316GWB
1
1
1
47
3501-000399
RELAY
JQ1A 12V
4
4
4
RY72, 73, 75, 76
48
-
R-CARBON
M CR10 4 .7K-J
1
0
0
R411
49
-
IC-M ASK ROM
P93LC56B
0
0
1
IC06
8-2
Samsung Electronics
9. Wiring Diagram 9-1 AW0690A/AW0790A/AW07FAS✳A/AW0890A/AW09F✳S✳A/AW1090A/AW10FAJ ✳A 9-1 AW12F✳ J ✳A/AW1290/AW14FAMBA/AW18FAM✳A/AWT18FAMDA/AW24FAMBB
CN73
DIAGRAM - ELECTRIC
Samsung Electronics
DB68-02015A
9-1
9-2 AW24FAMBA/AW24FAMCA/AWT24FAMEA
CN73
DIAGRAM - ELECTRIC
9-2
DB68-02053A
Samsung Electronics
10. Schematic Diagrams 10-1 Main PCB (AW0690A/AW0790A/AW07FAS✳A/AW0890A/AW09FAS✳A/AW1090A/AW10FAJ ✳A/AW12FAJ ✳A/AW1290A/AW14FAMBA✳/AW(T)18FAM✳A/AW(T)24FAM✳A)
OPTION No.
RESISTOR VALUE 10K- J
UNIT OF TEMP. OPTION C
˚
R411 4. 7K- J
F
˚
Samsung Electronics
10-1
10-2MainPCB (AW09FBSEA/AW12FBJEA/AW18FBMEA)
OPTION No.
RESISTOR VALUE 10K- J
UNIT OF TEMP. OPTION C
˚
R411 4. 7K- J
F
˚
10-2MainPCB (AW09FBSEA/AW12FBJEA/AW18FBMEA)
OPTION No.
RESISTOR VALUE 10K- J
UNIT OF TEMP. OPTION C
˚
R411 4. 7K- J
F
˚
10-2
Samsung Electronics
10-3Remote Control
