Vigilon 4/6 loops & Compact (VA) panels & network nodes
Sounder function
Auxiliary Relays
A Mark II S-Cubed or S-Quad sounder can operate in turbo mode if configured during The two auxiliary relays in the control panel are defaulted to operate on: commissioning to provide further 3dB output. The sound outputs are based on the settings of the FABs and SABs at the panel that gives changing levels over 2 seconds duration in 8 time slots. The • a sectored fire event the Auxiliary relay 1 and s standard outputs are synchronised with the 34000 sounders and other S-Cubed or S-Quad devices • a fault event the Auxiliary relay 2. d installed in the same system. n The volume of the sound output can be individually set at the device, note that the sound level the auxiliary relays can be configured for normally-open or normally-closed a operation. not be set lower than 65dBA at 1m for standards compliance. The system prevents m should the relays may be configured to be operated with: adjustment of volume down to zero. Another feature that can be configured is the soft start that m ramps the sound volume gradually to the maximum level set at the device. • a Fault
o c Turbo and Non Turbo Modes m The S-Cubed or S-Quad sounders can output in turbo and/or in non turbo modes. The high and low e t mappings are used to change the tone output of the S-Cubed or S-Quad sounder. The turbo s FAB y mode outputs a waveform with a basic frequency that is the same as the resonant frequency of the s piezo inside each device. The non turbo mode outputs modulated turbo waveform. e n o o l Non-Turbo square wave m r a i z e Turbo square wave o f e d c y n f p o v a Non-Turbo high tone (Default) n e u y c Turbo high tone w q o a n e b t f r e u r u t s i c s q e r Turbo low tone - high output Non-Turbo low tone - high output f o r b a f t n o o h i t n a n i s f Non-Turbo low tone (Default) r Turbo low tone w o e s v s s m e r d e e f r o s a Turbo rich high tone t Non-Turbo rich high tone a l n e e u i v a m d l o M e W a s Turbo rich low tone Non-Turbo rich low tone d i u G C x i d n e p p A
• a Warning • any combination of Sectored Fire events • or any of the above combination It is possible to delay the operation of each relay by up to 10 minutes after the first FIRE event. The accuracy of the delay is 0 - 4 seconds. The relay will operate immediately for fault and warning events.
s d n a m m o c m e t s y s e n o l a d n a t s r o f s e n i l e d i u G C x i d n e p p A
Commissioning instructions
Appendix D - Guidelines for Networked system commands
s d These functions explained in this section apply to networked systems. See also guidelines for standalone system.For n information on Command build actions across a network, see Appendix C. a m commissioning a network of control panels, ensure the software version is the same across all the m panels. ThisWhen is also applicable when an existing network is to be installed with additional panels. o c m Master Sectors e t s NETWORK PANEL 2 y PANEL 1 s ASSIGN d MASTER MASTER e SECTOR SECTOR 2 SECTOR 1 k r ASSIGN ASSIGN o SECTOR 255 PER that has DELAY w just gone BLOCK NETWORK t into fire e ASSIGN N 64 PER MASTER ASSIGN ALARM r SECTOR PANEL that has o just ASSIGN gone f AUX s into fire RELAY e ASSIGN n i l COMMAND e BUILD d i u COMMAND ACTION BUILD SECTOR G ASSIGN D COMMAND BUILD TRIGGER x i d n e p p A
O N O F F
O N
F O F
O N
O F F
O N O F F
O N
F O F
O N O F F
SIGNAL 1
SIGNAL 2
SIGNAL 3
SIGNAL 1
SIGNAL 2
SIGNAL 3
ALL SIGNALS OFF
ALL SIGNALS OFF
There can be up to a maximum of 64 Master Sectors per
panel a total of 255 master sectors per network system they are therefore a collection of:
• Sectors • Delayblocks • Master Alarms • and Aux Relays from one or more Systems. they provide global alarm actions across a network of
control panels
Guidelines Fire input sectors must only be assigned to one Master
Sector. Output Sectors can be assigned to more than one Master
Sector. Master Sectors can be actioned by a Sectored Fire Event. a triggered Master Sector can action (one or any
combination of):
• Sector • another Master Sector • Command Build (not locally) • Delay Blocks • Master Alarms • or Auxiliary Relays. If a Sector assigned to a Master Sector has a Fire Event, the
Master Sector will not perform any local actions on the Panel in alarm. If a Command Build actions a Master Sector, the actions
will be performed on other panels, but Command Builds will not be triggered. A Master Sector must have something assigned to it before
any Master Sector action links can be made to it. Master Sector Fire Event actions on other Panels can be
stopped by global Silence Alarms.
Vigilon 4/6 loops & Compact (VA) panels & network nodes
Master Groups
MASTER GROUP 1
LINK
MASTER GROUP 2
MCC / MCB CARD 0
Once message passing has been setup for global repeat or mimic indication, the local panel will also have to route reset messages to other groups, besides group 0. Groups within different Control Panels can be assigned to the same
Master Group Global controls can be configured to output/input or both.
MASTER GROUP 3 RESET
OUTPUT
MASTER GROUP 4
Messages and controls within a standalone system do not require any
INPUT
setting up
RESET
the Group 0 contains all panel events and fire resets and therefore must
always be assigned to a Master Group.
MASTER GROUP 5 MASTER GROUP 6 SILENCE ALARMS
BOTH MASTER GROUP 7
BOTH SILENCE ALARMS
MASTER GROUP 8
There can be up to a maximum of 8 Master Groups per network. These are a collection of Groups used for:
• selective fire and non fire event message routing within a Control Panel or around a Network of Panels
• and for routing Global Controls ‘Silence Alarms, Sound Alarms and/or Reset’ to designated Control Panels on a Network. Messages can be displayed or printed on Control Panels or Repeat Panels. Messages are routed on
a Card by Card basis, ie: Card 0 = Panel LCD Card 15 on Vigilon (Card 0 on Vigilon Compact) = Panel Printer Cards 1-6 = Repeats and Mimics (Loops 1-6)
• Each Card can be configured to display/print All Events (default) or just Fire Events. Repeat Panels on the same loop will always give the same information.
The Verify control button that is applicable for EN panels only can operate globally, like the Sound alarms, Silence alarms and Reset buttons.
s d n a m m o c m e t s y s d e k r o w t e N r o f s e n i l e d i u G D x i d n e p p A
Commissioning instructions This page has been intentionally left blank.
s d n a m m o c m e t s y s d e k r o w t e N r o f s e n i l e d i u G D x i d n e p p A
Vigilon 4/6 loops & Compact (VA) panels & network nodes
Appendix E - Cards This section contains copies of instruction leaflets supplied with each card.
s d r a C E x i d n e p p A
Commissioning instructions This page has been intentionally left blank.
s d r a C E x i d n e p p A
4 1 8 8 9 0 6 _ i s s u e 2 _ 0 2 / 0 9 _ n e w M C C
r N d e i s O s u T k l i t b s i n e r e d p l m O a a m c o n v c a e e g d e e o d t h n f r t o a o e m b t m h a e e t h t t c t e e a r o l M y m s C u n p r C i s o f , u n a t l e c h a n e e t i t o s a s c n o t a r s n h d l i e t h s M e e m U v c a S e a y T o r r d .
b t h T a a h c t e k m M p l u C a n s C e t . b h e a r s e m a o b v a e t e d t r b y e i n f o s r u e l a t h t o e i n c s a l r e d e i v s e f i o t t r e d d i s i n k t h e
B a t t e r y c o n n e c t i o n
( n R o e l n a c t i v o e n d h e u n m s i i n d i t g y )
t e S m t o r p a e g r e a t u r e
t e O m p p e r e a r t i a n t u g r e
L i t h i u m B a t t e r y
W e i g h t
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
m a D t R C h e i e R a c s n c p s p 2 o l 0 u r o a a f d s m c 3 a i e e 2 n c g t o e t 3 u h o f t a r e V r o e r e b c l q ’ t h l s a e l e u t s u i . t l n i e v s d a e r t y r l b e u c a n o n t t y t t i o e y t l n r w p i s e i . s e . t h
9 6 g ( a p p r o x i m a t e )
P 8
P 7
P 6
P 5
P 4
P 3
P 2
P 1
C A R D 6
C A R D 5
C A R D 4
C A R D 3
C A R D 2
C A R D 1
C A R D 1 5
C A R D 0
B a c k p l a n e
# f o r V I G 1 -7 2 o n l y
1
L N o L N ( L ( L ( L O o O o O o o o e o e p o p o p o w p t w p t t t t i p o i p o i p o o o C r C r n P n P n P r ) r ) r o o a k a k ) o c c c r o d r o d e e e # r # r R R s s s s s s S S o o o 2 2 r r r 3 3 C C C 2 2 a a a o o r r r r r d d d o o o r r r R R R S S S 2 2 2 3 3 3 2 2 2
o o L r o R S p 2 P 3 r 2 o c e s s o r C a r d ( S U P P L I E D )
N e t w o r k o r I O C a r d ( O p t i o n a l )
L M o c a a i n l C C o o n n t t r r o o l l l l e e r r C C a a r r d d o ( S r U P P L I E D )
P t M 1 o a C b e s e A f t i r R t t C D e d o 0 t n o o t r n s o l l e b o r a c k C c e k t a p r l d a n M e ( C C )
t h t h U e e s e C M t o C h m C e m t U i o S s B s c i o p o o n n n r i n e t o g c t n t o t o o l .
2 0 w a y r i b b o n
O v e r a l l s i z e
T e c h n i c a l d a t a
1 5 7 m m h e i g h t x 1 0 0 m m w i d t h
B A T T 1 d R i e s k m b o v e e f o i r n e s i n u l s a t a t i o l l n i n s g l e t h e e v c e a o r r d
B a c k p l a n e
C a r d g u i d e s
S R w e i s t c e h t S W 1
V 2 C 4 2 h .x 1 i p x 1 -1 4 3
s M l C o L t C m i t h a c i r a u r k d m e f d i b s P t a t 1 i t n e ( t M o r y C t + C h e s / i L B d e C C a c u k p ) p l a n e
4 0 w a y r i b b o n
l c S o e c a a b l c u t e e r d s e ( o a t h n t e t t h h w e e t f o b o a d l r i c ) b k u b p n o l d n a n e e r t h e c l a m p
V s M 4 h i . o n 3 i 7 u l m d u b m e
d b i n p o e t o f o w n o e r t e h r i n e e e t h b d a e d r m a e c o A v k w l w e a p a r i l n y n a s s e s n b e e f e o s u . o n r r s d p P e e p o u w r r l r e e . y . e m T r o t h h d v e e o a p w l p o n o a n w t r e h f l e e i i t r s i u b t n c p a g o t t s e m h r o f p o y l u s c e l u a r t d e d p l b p s y e l y
t t o c o U S o o B l m a c m c p o i c e o n s p r n s i t t e o c n t i i n o n g
a n t i - s t a t i c w W o h e r k n p h r a o n c d e l d i n u g r e t s h . e c a r d a l w a y s u s e
c 4 P a 0 4 b -w s l o e a c f r y k o r i e m b t b t t h o o e n a D c c K e C p t a
c 2 P a 0 2 b -w s l o e a c f r y k o r i e m b t b t t h o o e n a D c c K e C p t a
C c o f o a D m b l K m e s C i n s s o a n i w d o n c C A i o o n n I g n m O n t o e m C o c i a l t s r s d c s i i o t o o s n n n P i n n o e 2 g c a t t n t r o e t o d o q l u t . h P 4 T r i e o h e U n e d S t D f B h K o r p e C t h o M r e r i t C b o C b c n a o o n M n n n e C d c C t t h i . e o n
V ( T h I V G I s i G 1 - l -2 M e 4 C a f l a C e n t d -2 c 4 o V ) v I w e G r h 1 i s -7 c t h h 2 i e V s M i d a g e i l s i n o i C n g n o p e a d n t n r e o f o l l r ( s l . i n e r s ) t a C l l a a r t i d o n i n l T o h c e a t i o M n C i n C c t h a e d r b m a c u k p s l t b a n e e i n . s t a l l e d i n t h e c o r r e c t
( V I G -M C C -2 4 )
M aD a t a i n an d C I n o s t n al l a t t r o oi l n C a r d
B a c k p l a n e
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 9 0 6 _ i s s u e 2 _ 0 2 / 0 9 _ n e w M C C
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
D D d p A W i o r t o o s t h E n n p d u e E o o o s c t t e t e E b d d a n u s i n d D o d r n p f o i r . o f e b s v i a t e a h c t e o a t t i i f s e r v r w u e i u e : i t i s s t e h a s u y b h f l o o e l u r u l i f r e d l e n c , o y b t h c r e e m l i n p a g l a h c c k o e a u n s t r g e e i n h . g o , l d w a s t e .
a v p A c a i o r t c o a d t h u r s d u c e a i t e n n t a d c a n e b d o l w e b f r a t i e h t h c t e t e i n y r r a c i u l e s t i i n s e o n g s f a c h u l o l o e n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i e n s a g i p c i o k s a l s a e g t i d i n o g o n f , .
T h i s p a g e h a s b e e n i n t e n t i o n a l l y l e f t b l a n k .
I n s t a l l a t i o n
M C C
4 1 8 8 8 6 1 . 0 2 _ 0 2 / 0 7 _ M C C E N
b h # a a A c v k i n R p g l A a 1 M n 6 C e h l i a a n r s e d i d n i s o s p o f l n l a l a s y y h a f i . n t t e d d w i h n e V r i e g i t l h o e n p a n e l
P 8
P 7
L O O P 4 P 6
L O O P 2 P 4
L O O P 1 P 3
I O C P 2
i n T h t h e e M b C a C c k p c l a a r n d e m . u s t b e f i t t e d i n t h e c o r r e c t l o c a t i o n
L C C P 1
N V i e g t w i l o o n r k C n o o n d t r e o l b p a a c n k p e l l a a n n d e
T o D K C P 4
R A M C a r d #
P S r p o c a e c s e f s o o r r 3 s L o o p
L o o p P r o c e s s o r c a r d
( n R o e l n a c t i v o e n d h e u n m s i i n d i g y t )
S t o r a g e t e m p e r a t u r e
t e O m p p e r e a r t i a n t u g r e
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
1
L O O P 3 P 5
I n p u t / O u t p u t c a r d
M a i n C o n t r o l c a r d
c 2 a 0 b w l e a y r i b b o n
a e R c q e c u p o i l v a r a d l c i e n e g n t t h t t e o y p t h e b e . a t e m D t r i y a s n p u o o n f s y l a c e w t u o f i r a t h e l r l t ’ u h s e i n s s s e d a t r b m u e c a t t i t e o o r n r i s e s
L i t h i u m B a t t e r y
C R 2 0 3 2 3 V c e l l .
P 1
c 4 a 0 b w l e a y r i b b o n
W e i g h t
9 6 g ( a p p r o x i m a t e )
O v e r a l l s i z e i n m m 1 5 7 h e i g h t x 1 0 0 w i d t h
T e c h n i c a l d a t a
B a c k p l a n e
c 2 2 o 0 0 0 n - n w 7 a i e y n c t r t i o d b V i r b i O e o g n c n 1 l y t l c - 2 f y i a 4 t t o b / t l 7 h e t h i 2 e e n p M M a a C n C C V e C g i l b . 1 / u n i - l 2 o d 4 d / 7 e P O . 2 p A S l T a s n o F e n e l / o b r n t u o e a d t r h y e e
r N s e O l e s u T e v l b e t i n e s i d p l r O a a e c m m n e a d o c g v e e o e t n d h t o a f e r b t h m o a e e m t t c t a t e r o l h y m s e i u n M p o r f C s n a C u l e c a n e , t i t a t h o s s e n o t c n h a d i i r s t h s d k e m M o c a U r a y S r d T .
r T e h m e o b v e a t d t e b y r e f o i n r s e u l t h a e t i o Mn C d i C s k i o s r f i s t t e e l d e v i n e t h m e u b s a t c b k e p l a n e .
n t h F o e i d t e M t h , C e s C c e e f o r r c o h r e c a t t h r e c t h o y i v t p e p 2 e r 2 l e 1 a o f 1 f p . a -x n x e x l i o n r
B a t t e r y c o n n e c t i o n
+ L i s t h i u i d e m u p b a t t e r y d R i e s k m b o v e e f o r i n e s i n u l s a t t a o i l l i n n g s l e t h e v e e c o a r r d
C h i p 2 2 1 1 -x x x
BM a C c C k p c l a a n r e d f i s t l s o i t n m t a o r t k h e e d P 1 ( M C C / L C C )
o b c c p w n c o M T p e h h a t o o p a h i a t n t f p r i i h d i o i i V V t o r n a n s e t r o r t I I m n e n C e l s o G G s o u l s o a n .E p v m u -M -M : c u f f e a s n o l a b m a n r t e r r t C C l e b d c e E o b e r t h C C r e c a i l o l N ( n f f s e -E U r M s l v s t i .T 2 o t v e 2 f C a N P r e a t e n ) e h r 1 C l -N G l d e 1 c d s r C s a h R t i a a t N o i O a s o i x i o p x p s e n d r r D n t a h p ,x s u t w 4 ( n . e r h p o U C o . M g s a x p P p e v l r e a c r G i k x C r a i e i C o n e d r a . d d f g ) t e 2 C 2 h 1 i 1 p -x x x f 2 P r 0 2 o m -w s a o t c h y k e r e i t D b K b t o C o n a c c a c e b p l t e a
B A T T 1
s M l C o t C m a c a r k r e d d f i s P t 1 i n ( t M o C t h C e / L B C a C c ) k p l a n e
2 C 2 h 1 i 1 p -x x x
S W 1
S R w e i s t e c h t
f 4 P r 0 4 o m -w s o a t h y c k e r e i t D b K b t o o C n a c c a c e b p l t e a
t U o c S o o l m B c m p o i o n s r n s i t e o o c n t t i i n a o n g c c e p t
M C C b u i l d P R E F e b r u a r y 2 0 0 7
M C C b u i l d P O S T F e b r u a r y 2 0 0 7
( f o r E N v e r s i o n 4 .x x p a n e l s & n o d e s )
M aD a t a i n an d C I n o s t n al l a t t r o oi l n C a r d s
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 8 6 1 . 0 2 _ 0 2 / 0 7 _ M C C E N
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
Main Control Card (EN) - Compatibility Information a v p A c a i o r t c o a d t h r s u e d c e a u i t n n t a d c a n e b d o l e w b f r a t i e h t h c t t e i n y e r r c a l e i u t i s i s n o g e n s f a c h u l o l o e n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i e n s a g i p c i o k s a l s a e g t i d i n o g o n f , .
Current products
Past Products
8 line display
Vigilon EN + Zn LEDs Post Feb 05
Vigilon EN Network Node
Control Panel 3 4 5 6 Zones 1 2 17 18 19 20 21 22
P a nleh e a hl ty Fault
SystemFaul t
Fire
GENT1998
15:45
Delay Ver ify Commission
Vigilon Fire System GENT2005
Delay
Next
CB253
Next
Disablement
Vigilon Fire System GENT1998
P a en h l e l at yh
VigilonFire System GENTLimited 2003 Designed to EN54 Pt 2 & 4
on 1 54 :Commissi 5 Sounder
System Fault
Prreevviuioso su P
Ne e xx tt N
Test Next
1 17
Sounder
2 18
3 19
4 20
5 6 21 22
7 23
8 24
9 1 0 1 1 25 26 27
12 1 3 14 1 5 28 29 30 30
Fault
Fire Panel Healthy
15:45
System Fault
Power
1 2 :00 Fire
Vigilon Fire System GENT1998
Disabl ement
N et x
Commission
Power
P r e v ui o s
SystemFault Delay
CB254
Test
Power
Disablement
16 32
2 3 4 5 6 7 Zones 1 17 18 19 20 21 22 23
8 9 1 0 11 12 13 14 15 24 25 26 27 28 29 30 30 Fire
Fault
16 32
Pan el hea tl hy
12:00
Fault
15:45
Power Fault
CB253
Verify
Vigilon Fire System GENT 2005 Designed to EN54 Pt 2 & 4
System Fault
P an el h ea tl hy
1 2: 00
Sounder
Sounder
SystemFault
Vigilon Fire System
CB253
Next
Vigilon Fire System GENT 1998
Pa nel he althy
Fire
Fault
Sounder
SystemFault
12:00
Fire Vigilon Fire System GENT 1998
Part number 2211-xxx
Sounder
GENT 1998 CB254 Disablement
Without Zone LED
Previo us
Next
With Zone LED
Vig EN-Zn Post Feb 05 2211-143 Vig EN 2211-152
Commissi on
Power
Prev ious
Next
Power
Disablement
Power
Disablement
Power
Power Previous
D D d p A W i o r t o o s t h E n n p d u e E o o o c e E t t s e t b d d a n u s i n d D o d r n p f o i r . o f e b s v i a t e a h c t e o a t t i i f s e r v r w u e i u e s : i t i s t h a s e f y b l h u o e l l u r o i f r e u l e n c d , o y b t h r e m c e l i n p a g l a h c c k o e a u n g s t r i e e n h . g o , l d w a s t e .
Vigilon Fire System GENT1998
Power
Previo u s
Zones
Delay
P a n ehl e at hl y Fault
Fire
Disablement Disablement
Power
Network Node
1 2 :00
Fault
CB254 Previous
Disablement
Fire Vigilon Fire System GENT 2005
Previous
System Fault System fault
Sounder
P a nleh e ahl ty
Fire
Vigilon EN
Power
Verify
Disablement
Verify
Vigilon Fire System GENT2005 Designed to EN54 Pt 2 & 4
CB254 Next
Fault Panel Healthy
Fault
Power Previous P r e v ui o s
Power Fa ult System Fault
4h e5ahl6ty 7 8 9 1 0 11 1 1 1 3 1 41 5 1 6 Zones 1 2 3 P a nle 2 :200 17 18 19 20 21 22 23 24 25 26 27 28 29 30 30 32 Fault Fire
15:45
Test
Sounder
Control Panel
Control Panel
CB253
Disabl ement
Test Disablement
Power Fault
Fire Panel Healthy Vigilon Fire System
SystemFault
Vigilon EN
Fire Panel Healthy
Main Control Card
Vigilon EN + Zn LEDs Pre Feb 05
7 8 9 1 0 1 1 1 2 31 1 4 1 5 6 1 23 24 25 26 27 28 29 30 30 32
Fault
1 2 :00
Fault Power Faul t System Fault
16 line display
D a t a a n d I n s t a l l a t i o n
Next
Previous
Next
With Zone LED
Vig EN-Zn Pre Feb 05 2211-147
Vig EN 2211-155
VIG-MCC-UPGR
Vig EN 2211-176
VIG-MCC-EN-NOD-UPG
M a i n C o n t r o l C a r d s ( M C C )
4 1 8 8 8 6 0 . 0 2 _ 0 2 / 0 7 _ M C C B S
R A M N C
3 4 0 8 C o n t r o l p a n e l b a c k p l a n e
L O O P P R O C E S S O R C A R D S I O C
3 4 0 4 & 3 3 0 0 M k 1 C o n t r o l p a n e l b a c k p l a n e
N V i e g t w i l o o n r k a n n d o d 3 e 4 b K a C c o k n p t r l o a n l e p a n e l C M a A A n R I d D N C O N T R O L
P 7
L O O P 3 P 5
L O O P 2 P 4
L O O P 1 P 3
N O R M A L
H A L T
3 5 0 5 T e r m i n a l n o d e b a c k p l a n e
N i n R e 1 A t w 6 M o l r i n C k e a r c d d a i r s ( d p o l n a l y y f p t i a t n e e d l )
P S r p o c a e c s e f s o o r r 3 s L o o p
L o o p P r o c e s s o r c a r d
P 4
( L S C l A O o O t R o D P r L P C o R a o O r p C d 2 2 E ) o S p S t i O o n R a
C M A A R I D N C O N T R O L
l
+ -
P 5
S S L P O A T R E C A R I D O
P 6 P 7 C C M A O A R N I D T N R O L
L o o p ( 3 3 0 0 )
I n p u t / O u t p u t c a r d
M a i n C o n t r o l c a r d
c 2 a 0 b w l e a y r i b b o n
C R 4 0 A I B B B W L O A E N Y
S
f ( o N C N E r a r T 3 o t d 3 u W 0 s O 0 e ) d R K
P 1
P 4
C 3 o 3 n 0 t r 0 o M l k p N a ,2 C n L e 3 O l 2 O b K P a a 3 P R c n 4 O k d 0 4 C p l S E a S S n e 3 O e n 3 R a 0 t 0 C o A r R 2 D
I O C
I O C P 2
L C C P 1
T o D K C
R A M
E A C A C
1
P 8
L O O P 4 P 6
b 3 a 2 c K k p a l n a n d e S e n a t o r 2 N e t w o r k I n t e r f a c e
E
A C
A C
+ -
P 4 P 5 P 6
( l L S o l o O o O t p o 1 P r C P R a O r d C E 1 ) S S O R C A R D
( S l o t o N r E C a C T W r d A O 1 R R 3 D K ) S S L P O A T R E
P 7
( C M S C l A O A o N I t R N o D T R r C O a L r d 0 )
c 4 a 0 b w l e a y r i b b o n
c d s M r i n a a u U e s m r r d m a f S o u l . a c T v a g e N e t e i o d a O t o s T f n O r d o t t h h b m s i n i e e s k c e c m p t h o t l o a r h m a c e s e p y e M e l r d C e b o e a n s o C v t t e u n , e e n l a t r h i y t t s i m e s n o e c n a t r a d t l h e
C R 2 0 A I B B B W L O A E N Y
( S M l A o I t N o C r C O a N r d T 0 R ) O L C ( I S N A l P o R t U D o T r O C a U r T d ( R P S A 1 U l o 5 T t M ) o ( C r M A C e R a m D r d o r 3 y ) ) C A R D
C ( I O a S l r o d t C 1 o A 5 r R ) D d e O I o n n a g b s l e l w e i t c h D o n g l e
+ L i s t h i u i d e m u b p a t t e r y d R i e s k m b o v e e f o r i n e s i u n l s a t t a o i l l i n n g s l e t h e v e e c o a r r d
BM a C c C k p c l a a n r e d f s t i l s o t i n m t a o r h k t e e d P 1 ( M C C / L C C )
B s M F i a e e C t t C t h c t e h of e a r c r y t r o h r r c ov t e o e e c t t n r y n el p c h e af e c . of pi 2 t i p o a 2 n en 1 1
f 2 P r 0 2 o m -w s o a t h y c k e r e i t D b K b t o C o n a c c a c e b p l t e a
2 C 2 h 1 i 1 p -x x x
S W 1
S R w e i s t c e h t
C h i p 2 2 1 1 -x x x
2 n t h c o 0 o e n 0 d 7 2 v e e i c 0 r n o - w t t o n a e n y d a O e r f r V n c i o l i y t b m g d b 1 i o E - f i r t e n N 2 4 t c c h t t e l a o / y 7 b 2 M B l t o e S p C i C t h n p a n e a a e b n l u M V e i l i l / C g n d C 1 / o P n . - 2 o d O 4 d e S / 7 e t h T 2 . a F p A t e l i a s n o s b r u e n l a / o r t y e
l -x o x r x n i o n d t h e e ,
2 C 2 h 1 i 1 p -x x x
B A T T 1
s M l C o t C m a c a r k r e d d f i t P s 1 i n ( t M o C t h C e / L B C a C c ) k p l a n e
f i m T t h t e u e d s t b i n b e a t t e h e r t r e m y b o i n a v s c e u k d l p l b a t a i n e o f n e o . r d e s i t h k e o r M s l C e C e v i e s
f 4 P r 0 4 o m -w s a o t h y c k e r e i t D b K b t o C o n a c c a c e b p l t e a
t U o c S o o l m B c m o i p n s o r n s i t e o o c n t t i i n a o c n g c e p t
M C C b u i l d P R E F e b r u a r y 2 0 0 7
M C C b u i l d P O S T F e b r u a r y 2 0 0 7
( n R o e l n a c t i v o e n d h e u n m s i i n d i g y t )
S t o r a g e t e m p e r a t u r e
t e O m p p e r e a r t i a n t u g r e
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
a e O c q n c u l o i v y r a r d e l p i n e n g l t a t t c o y e t h p t h e e . e m D b i a a s n p t e u o t r f s y a c e w o t u f t i r h e a l r t l ’ u h s e i n s s s e a d t r b m u e c a t t i t e o o r n r i s e . s
V V V M m 2 w p C T h I G I G I C u 2 i a G 1 t n a i h e r s d -M -M -M C s t 1 a l -x s l ( e b o C C C p e x n a M a u n C f x C C C t l f i t i , m d C e - -V -B o 3 n t s b t ) t e c 5 3 S s e e 0 + - : d e e r r o o v t 0 , N o c o m p t -N V O h i e f i r o t n h a I D n s O G r c h a e t s a l D -M U i n f r c o p E a v s o o P a e r n . C G r h d d r C , e B g a l S e b e - 3 v s 3 e a i n .A v o 4 4 f f . g e f 0 K o M r T p n s 0 -M e h a M r i a a C c e o r C n n n i a t d C a r p n C 3 C d u i / o p U i r m s 3 n o n P s s + t p b r G u c o t e p a r R i s r p o ( l l a l n l a , t e l e t i t r r e i o c d o ) l n h . p i
L i t h i u m B a t t e r y
W e i g h t
O v e r a l l s i z e i n m m
C R 2 0 3 2 3 V c e l l .
9 6 g ( a p p r o x i m a t e )
1 5 7 h e i g h t x 1 0 0 w i d t h
T e c h n i c a l d a t a
i n T h t h e e M a p C p C r c o p a r r d i a m t e u b s a t c b k p e f l t i a n t e e d , i s n e t e h e i l l c u s o t r r e r a t c i o t n l s o . c a t i o n
B a c k p l a n e
( f o r B S v e r s i o n 3 + p a n e l s & n o d e s )
M aD a t a i n an d C I n o s t n al l a t t r o oi l n C a r d s
b y H o n e y w e l l
C o p p e r N e t w o r k C a r d ( E N 5 4 ) 4 1 8 8 8 3 2 i s s u e 2 _ 1 2 / 0 5
p o r r p e n a v i F r o n o d u o m e e s l
o r N C e o t wn o t r o r k l N P o a n d e e l
N C e o t wn o t r o r k l N P o a n d e e l
S N C o e o c t n k w n e o e t r c k P t i 8 c o a n ( r s C d B a r i f A d n o r C 6 K ) P L A N E
S N C o e o c t n k w n e o e t r P k c t i 8 c o a n ( r s C d a i o f r n B d r A 6 C ) K P L A N E
0 1 V -v e 2 + 3 v e 0 4 V
c o n n e c t i N o n o
i T s h a e s 0 s V h o c w o n n n . e c t i o n
I 5 -v e 6 + 7 v e I 8
P 1 0
0 1 V -v e 2 + 3 v e 0 4 V I 5 -v e 6
C a b l e s c r e e n
c o n n e c t i N o n o
+ 7 v e I 8
P 1 0
o p T r a o n n N o e d l e x e t
1
C o n n e c t i n g t h e P a n e l s a n d N o d e s
L a o c c o a n l C t r o o l n p t a r W o n h l l e e l e r o r s r e o n a f e c t w t o w p a o r r p e e r i k s n n a o e t d t V e w e , e o r n k r s i s c o a n u r r 4 e d . t i 0 h s 0 e o p p l r a u l n g a g e t e / l e n d .r o i n d t e o
p n p U a a n e t n s i w e n e g l o l s s r t / k h n l a o n e o d d C o e N o s p ,w e p d t w p e e i t p h o r e r N u k n p n e d t e w t o n o d o t 1 e r o k . s n 2 c K c a c a m n d r a b b l c a e a e m t b l c y e o a p n x e i n . d i m s t e u c a m t n e c o e d f i n b u e a p t w s t o e e c 3 e n u 1 r e C o n t r o l
a T b m p n b T d l b a e e h a h u u d c c t t e i g s s w w k k r t g e d p p o e c b e s u l l r e o a a k n p s a n e d n e p n -l c i n e d c i e e u . o o t o n f o mn -l n r i f r n n i t t e b n t r e h h o e c s l e e e y t r e w t s e p s a s o w d o l p n t t a a r e i n k d t t n c m o e P . s h b l c a t 8 e l e a e o T r s u r h a m o d o n d n r n e d i s i r n n o t a c h u n s a t a t h e d e e l e r e e t . b w i l b n d c a o m o d a c c r t o u r k a k p d s k P a n a t l d e a l o l 1 b o r n d e 0 i e d w c e ,w e s a p s d t e l i a h t e u t h e n g d t t i e g s a c o t t h x s p l e o d a l o i t r e s o .W n r t i e d p g a n a t r l a s l h o n i s a s m o c t e a h o n e t n a b h i l t e t h e i s s e
( n R o e l n a t c i o v n e d h e n u m s c i i n d i t g y )
S t o r a g e t e m p e r a t u r e
t O W e m p e i p e r g e h r a t t i a n t u g r e
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
C a b l e
T e r m i n a t i o n s
O p e r a t i n g v o l t a g e
7 B b N T 2 a e e 5 g e l c d k t m V w r ( e p a i R l o n ( p n a r p 9 n k a l S r 7 4 e o 2 s c b 8 x 9 l a l 5 r o i o d m ( t c ) e i k a P s x 8 t P e i n 1 m ) a s 0 t p a a l l e l s s ) e d u m i n i n g
B a u d
N o d e a d d r e s s r a n g e
O v e r a l l s i z e
2 4 0 0 , 9 6 0 0 , 1 9 .2 K a n d 3 8 .4 K
1 t o 3 1
1 2 8 m m h e i g h t x 1 0 0 m m w i d t h
T e c h n i c a l d a t a
• V I G N O D E .
V i g i l o n N e t w o r k N o d e
• • • • • • • V I G 4 N E T
V I G 4
V I G 3 N E T
V I G 3
V I G 2 N E T
V I G 2
V I G 1 N E T
V I G 1
V i g i l o n F i r e P a n e l s
T h i s n e t w o r k c a r d c a n b e i n s t a l l e d i n :
( V I G -N C ) f o r E N 5 4 V i g i l o n N e t w o r k
C I n o s t p al l p a t e oi r ni N s n r e t u t t w c i o o s n r k C a r d ( E N ) b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
C o p p e r N e t w o r k C a r d ( E N 5 4 ) 4 1 8 8 8 3 2 i s s u e 2 _ 0 5 / 0 9
F a x ( U K ) : + 4 4 ( 0 ) 1 1 6 2 4 6 2 3 0 0
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
W e b s i t e : w w w . g e n t . c o . u k
o G b e l i n c a t b t i y o n H o t o n e n y o w t e i f l y l r a e n s y e p r v e e r s s o t h n e o r f g i s h u t c h t o r r e e v i v s i i s o n e s t h o s i f p c h u a b n l i g c e a t s i . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
6 3
f a c t o r y s e t t i n g s
D D d p A W i o r t o o s t h E n n p d u e E o o o c e E t t s e b d d t n D a d u s i n r p o d n f o i r . o v f e s i b t e a a h c t o a t t e e i v f s r r i w u e i u e : i t i s s t e h a s u y b h f l o o e l u r u l i f r e d l e n c , o y b t h r e e m c l i n p a g a l h c c k o e a u n s t r g e e i n h . g o , l d w a s t e .
2
1 6 4
o n
o o f f n
o o f f n
o n
o o f f n
o n
A d o d n r e s s o n
B a u d
4 3
o n
o 8 f f
o o 7 f f f f
o o o o 6 f f f f f f f f
o o o o o 5 f f f f f f f f f f
o n
o o o o o 4 f f f f f f f f f f
o n
o o o o o 3 f f f f f f f f f f o n
o o f f n
o n
o n
o f f
3 8 .4 K
1 9 .2 K
9 6 0 0
N o d e a d d r e s s s w i t c h n u m b e r s a n d s e t t i n g s
o 2 n B f u a f m u b d e r o 1 r a f s t f a e n s 2 d w 4 i s t 0 e c 0 h t t i n g s
T h e c o p p e r n e t w o r k c a r d i s f a c t o r y s e t f o r 3 8 .4 K b a u d w i t h n o d e a d d r e s s 4 .
O f f
C o p p e r N e t w o r k C a r d
8 7 6 5 4 3 2 1
S w i t c h s e t t n O i n g s
S W 1
L N I M L O C O C C O - C C C P N - - I L n n e p M w a o - t i c L o u a t o r O n l o k u C C p C t o o n n P a p r u t r d r t r t o o C l o c l l e C a e s r r d a s r C o d r a r C d a r d B a c k p l a n e
N C
I O C / N C
L O O P 4
L O O P 3
L O O P 2
L O O P 1
I O C / N C
P 8
P 7
P 6
P 5
P 4
P 3
P 2
C A R D 6
C A R D 5
C A R D 4
C A R D 3
C A R D 2
C A R D 1
C A R D 1 5
M C C / L C C P 1
b a c k p l a n e
C A R D 0
T o D K C P P
4
N e t w o r k C a r d
I n s t a l l a t i o n i n s t r u c t i o n s
c r 2 i 0 a b b b w l e o a n y
1
c r 4 i 0 a b b b w l e o a n y
C o p p e r N e t w o r k C a r d ( E N )
C o p p e r N e t w o r k C a r d ( B S ) 4 1 8 8 -7 8 9 i s s u e 2 _ 1 2 / 0 5
p o r r p e n a v i F r o n o d e u o e l s m
o r N C e o t wn o t r o r k l N P o a n d e e l
N C e o t wn o t r o r k l N P o a n d e e l
S N C o e o c t n k w n e o e t r c P k t i 8 c o a n ( r s C d B a r i f A d n o r C 6 K ) P L A N E
S N C o e o c t n k w n e o e t r c P k t i 8 c o a n ( r s C d a f r i n o B d r A 6 C ) K P L A N E
0 1 V -v e 2 + 3 v e 0 4 V
c o n n e c t i N o n o
i T s h a e s 0 s V h o c w o n n n . e c t i o n
I 5
-v e 6 + 7 v e I 8
P 1 0
0 1 V -v e 2 + 3 v e 0 4 V
C a b l e s c r e e n
c o n n e c t i N o n o
I 5 -v e 6 + 7 v e I 8
a T b d b a o d l b a e e ( n T h o h r d d c d e i c p s t k r i e k c l c e d p u c r a o s P l m o g a t n s u a 1 n e g i t p n r p d e a n -l i 0 u ,w e d l o l e t r mn -l ) d h s l i o n n i h e n a e b n t t o i e .W o e e t c a t d r s h x t w e h t a t w s h e s o o i e e n t r i r k p d i n n b n a c a c l a h s b i a a s a l t c e a o s c r i p k n b d s l a s u d o o b p l e e i c a t s n r l l w t a e u n o w u a t s g e t t h e e s e r k e e o . e d m g f e n d c o s u e e d c a n t d t o i a r n f o d t i c b r t h e o h e t n a a e l r o r t s o c h p e b y a l w o e a s s n p n c t m e s a n o k e l e t l e n e m e p t a s t l c o a . n l s P T s a e n t p d 8 d h a g r e n e o . t n e o g o d s n o c d r a t a n o t e e h m r e f r d e i m n m t w s t t h i a a u n o e t a r u s l t k s
p s U ( R S t O W C e p T O B N O a a n e t e n c n s i e m p e a p a n o u e e r l o b u o v g e r n a r p e l e s l i m e s l a r g r d d r e a t t e / e a a c i g h h i n a n v e a a t t l r n e o o n t e i i l d e a n n n d d t t d s t w N C u g d h t e e i i g o r z o r e m s o u e p e e r n v n m p e s d k o p t s s s w e e l e l c i t o p r r i r a o o a e n d r i a N g g k e t n n p t y e u ,w ( g d ) t r T e e w e e n i o t r t h m r o k u i u -1 0 7 B b N T ± 2 1 1 n p n c p 0 2 e a 4 t 2 a a e e 5 c C g 8 t l c r l a t o ) d d k t r m V 0 0 o o C b ( 3 m t n a p w e , ( l 1 a o o i e 9 o n R 9 1 m l .2 d m n p t a r 0 4 t K e n k a y % o h 5 p l S r 9 4 6 p 7 e m s a 5 0 e o x b 8 e 2 s c 5 a C 0 i c i x l . c m g 9 5 r l o a , i a o d h ) C m ( t c n u 1 b t m k e i 9 l b a P s e e x . x t P 2 8 i e a d n 1 c o f K m ) i o 1 s s 0 u t t 0 p n a a a a 0 n p l n n l t e s e l s m o d c ) e e c 3 d u m t 3 e m 1 b 8 i d C e n w . i 4 t n i w n o i K g d n e a t t e r h o n l
P 1 0
o p T r a o n n N o e d l e x e t 1
C o n n e c t i n g t h e P a n e l s a n d N o d e s
S p e c i f i c a t i o n
• V I G N O D E V 3 + o r 3 4 K N O D E V 3 +
V i g i l o n o r 3 4 K N e t w o r k ( o r T e r m i n a l ) N o d e
• • • • • • • V I G 4 N E T V 3 +
V I G 4 V 3 +
V I G 3 N E T V 3 +
V I G 3 V 3 +
V I G 2 N E T V 3 +
V I G 2 V 3 +
V I G 1 N E T V 3 +
V I G 1 V 3 +
o r 3 4 K 1 V 3 +
V i g i l o n o r 3 4 K F i r e P a n e l s
T h i s n e t w o r k c a r d c a n b e i n s t a l l e d i n :
( V I G / 3 4 K -N C -V 3 + ) f o r B S 5 8 3 9 V i g i l o n o r 3 4 K N e t w o r k
C I n o s t p al l p a t e oi r ni N s n r e t u t c w t i o o s n r k C a r d
( B S ) b y H o n e y w e l l
2
b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
C o p p e r N e t w o r k C a r d ( B S ) 4 1 8 8 -7 8 9 i s s u e 2 _ 0 5 / 0 9
F a x ( U K ) : + 4 4 ( 0 ) 1 1 6 2 4 6 2 3 0 0
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
W e b s i t e : w w w . g e n t . c o . u k
o G b e l n i c a t b t i y o n H o t o n e n y o w t e i f l y l r a e n s y e r v p e e s r s t o h n e o r i f g h s u t c t h o r r e v e v i s i s i e o n t s h i o s f p c u h b a l i n c g a e t i s o . n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
6 3
f a c t o r y s e t t i n g s
D D d p A W i o r t o o s t h E n n p d u e E o o o c e E t t s e b d d t n D a d u s i n r p o d n f o i r . o v f e s i b t e a a h c t o a t t e e i v f s r r i w u e i u e : i t i s s t e h a s u y b h f l o o e l u r u l i f r e d l e n c , o y b t h r e e m c l i n p a g l a h c c k o e a u n s t r g e e i n h . g o , l d w a s t e .
2
1 6 4
o n
o o f f n
o o f f n
o n
o o f f n
o n
A d o d n r e s s o n
B a u d
4 3
o n
o 8 f f
o o 7 f f f f
o o o o 6 f f f f f f f f
o o o o o 5 f f f f f f f f f f
o n
o o o o o 4 f f f f f f f f f f
o n
o o o o o 3 f f f f f f f f f f o n
o o f f n
o n
o n
o f f
3 8 .4 K
1 9 .2 K
9 6 0 0
N o d e a d d r e s s s w i t c h n u m b e r s a n d s e t t i n g s
o 2 n B f u a f m u b d e r o 1 r a f s t f a e n s 2 d w 4 i s t 0 e c 0 h t t i n g s
T h e c o p p e r n e t w o r k c a r d i s
f a c t o r y s e t f o r 3 8 .4 K b a u d w i t h n o d e a d d r e s s 4 .
O f f
C o p p e r N e t w o r k C a r d
7 6 5 4 3 2 1
8
S w i t c h s e t t i n O g n s
S W 1
L N I M L O C O C C O - C C C P N - - I L n n e p M o w a c - t i L o u a t o r O n l o k C C p C u o t o n n P a p r u t r d r t r t o o C l o c l l e a C e s r r d a s r C o d r a r C d a r d B a c k p l a n e
N C
I O C / N C
L O O P 4
L O O P 3
L O O P 2
L O O P 1
I O C / N C
P 8
P 7
P 6
P 5
P 4
P 3
P 2
C A R D 6
C A R D 5
C A R D 4
C A R D 3
C A R D 2
C A R D 1
C A R D 1 5
M C C / L C C P 1
b a c k p l a n e
C A R D 0
P 4
N e t w o r k C a r d
I n s t a l l a t i o n i n s t r u c t i o n s
T o D K C
c r 2 i 0 a b b b w l o e a n y
P 1
c r 4 i 0 a b b b w l o e a n y
C o p p e r N e t w o r k C a r d ( B S )
4 1 8 8 -7 9 0 i s s u e 4 _ 0 1 -1 0 _ f i b r e N e t w o r k C a r d ( E N & B S )
( S e n R t m t o e o l p n a r a t c i e g r o v e n e a u d h t r e e n u m s c i d i n t i g y ) u p t o 9 0 %
-1 0 C t o 5 5 C
1
p B a n S e l V i g i l o n
p E a n N e l V i g i l o n
o M r C l a C t e r V 3 . 9 0
o M r C l a C t e r V 4 . 0 0
V N I e G t - w N o C r k -F C O a r d
o M r C l a C t e r V 3 . 9 0
o M r C l a C t e r V 4 .1 6
V N I e G t - w N o C r k -D C O a r M d -F O
t O W e m p e i p e r g e h r a t t i a n t u g r e
0 C t o 4 5 C
8 2 g ( a p p r o x i m a t e )
( B M V i e C g f i l o C o r ) n e h C i n a o s s n t a c t r l l o o i n m l g p p a t a n h t i i e s b l ,l F e i b s e n r o s f u e t w e r N e a r t w h t e . e o p r k a C n e a r l ' d s M i n a e i n t i h C e o r n E t r N o l C o r a B r S d
F T i e b r r m e O i n a p t t i i o c n s s /
B a u d
F C S S i a T T b r b l s e o c o e 8 : c k n 2 M e n 0 u t e n l s c t m t i i o n o n w m t i a o h v d e s b e e N y l e n 6 2 e t m g . 5 w e t h / o a n 1 r k s 2 o 5 c a f µ r t m d h . e
1 9 .2 K , 3 8 .4 K , 1 1 5 .2 K & 2 3 0 .4 K
r a n g e
M C C c o m p a t i b i l i t y
N o d e a d d r e s s
O v e r a l l s i z e
1 t o 3 2
1 t o 6 4
( V I G N C -F O )
( V I G N C -D O M -F O )
1 4 4 m m h e i g h t x 1 0 0 m m w i d t h
S p e c i f i c a t i o n
n t p n T h c o a e h e e t n t w f n n e w e i f o b e l o b i r e r c o r k r r k e s n t . n . e d T n i o h e r t e t w e c d e t o y c w r l i n a o k r r t k d a o c a s d m c r o e u a d r d d s c k i s t a f e c o a b l l r t s t e o w s o e e n d p l s c s u f u t l g a h o g s r e t e . e t T d m E c h N a r e i n e 5 d t s f 4 . b i o s a t a T r h g n h e e e d e o r b p B e p a a S a t i c s r c k s V e c p i n i a t l g g w b a i l o e l n t o o n b s e o t u h f e i l t d h s e o f
N o t c h
h s d 6 U d s C U a m o 4 s i e o s s c n i v m s i n ( V t n a u t e a l m a g l i n e r o r g V f I c u e o I a t t p r n l G h h G r e o l e l p e n . e l t D b o a o e T N e p n F N h r w e n F 2 t i o i C b m C t w .T e 0 o F e b l r r 0 r e -F w e a -D e h s i t k b a O O p s O i n O e r o n e n r d a c e r p F k p b M p e n a O s t e n c N t i r i i c i -F a l p c c n a s d N g N b t e n e / r i a n b e c n w e e l b t O a e o u c b e t w ) F n e o w O d p a e t r e k d u p b c o i n p N o s t r r t b l o k k . o e i r o t e 2 d n c o o c c d d n K s a N i e a O e 2 e r r e m t s d c d p . K . a m c V t n t t w e V T c i I I o c F a h e d G n G e b t i b - r N b o -N k N r e e e f C e e c n t t w o c C w a t r O i o F r r e m D o p n O e d e O t r n i e s n a k c u y n s M c p c t s o e -F c a e t t a e d c O b d o r m e u d l i 3 r u e e n 1 c s p a o a f t n t o h e
t r w h u e h e s e c e o d o n m n r e w m e h p f r e e l o n n a E m e d c n e i s x n d R t r t g u S a r h c e p c a h a a t t i n i p r n t g a o t i n c s n s u t u h i t a m i t t h a i b p b e c f l e r p r o e c r a 4 m c r e 8 h d c a 0 t p i . - h I u 3 e e t t i 0 i o x s 0 c t n 5 a r s r . d a c a , t r s o e u r t c s i a h k e a n s
p B a n S e l V i g i l o n n s o u p e t w p i p t o o l n i a r e k d l c c f h a r o r p i d t h e
2 2 1 1 -1 4 0
n s o u p e t w p i p t o o l n i a r e k d l c c f a h r o r p i d t h e
2 2 1 1 -1 4 2
t h f e a c n t o e r t y w o f i r k t t e c d a t r o d t h f e a c n t o e r t y w o f i r k t t e c d a r t o d
p E a n N e l V i g i l o n 2 2 1 1 -1 3 9
V I G N C -F O
2 2 1 1 -1 4 1
V I G N C -D O M -F O
N O D E
D O M A I N
F i b r e N e t w o r k C a r d C h i p o p t i o n s
( V I G -N C -F O a n d V I G -N C -D O M -F O ) f o r V i g i l o n N e t w o r k
F I n i s b t a l r l e a t N oi n e t w o r k C a r d ( E N + B S )
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 -7 9 0 . 0 3 _ f i b r e N e t w o r k C a r d ( E N & B S )
R e g i s t e r e d o f f i c e : N o v a r H o u s e : 2 4 Q u e e n s R o a d , W e y b r i d g e , S u r r e y K T 1 3 9 U X
F a x ( U K ) : + 4 4 ( 0 ) 1 1 6 2 4 6 2 3 0 0
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
W e b s i t e : w w w . g e n t . c o . u k
o G b e l i n c a t b t i y o n H o t o n e n y o w t i f e l y l r a e n s y e p r v e e r s s o t h n e o r f g i s h u t c h t o r r e v e i v s i i s o n e s t h o s i f p c h u a b n l i g c e a t s i . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
F a c t o r y s e t t i n g s
6 3
4
o n
o f f
o n
o f f
o n
o f f
1
o n
o f f
o n
o n
o f f
o f f
2
o n
o n
o f f
o f f
o f f
o f f
3
o n
o f f
o f f
o f f
o f f
o f f
4
o n
o f f
o f f
o f f
o f f
o f f
5
o f f
o f f
o f f
o f f
o f f
6
o n
3
2
1
6 4
o n
o f f
o n
o f f
7
o n
o n
o f f
o f f
8
2 3 0 .4 K
1 1 5 .2 K
3 8 .4 K
1 9 .2 K
D D d p A W i o r t o o s h E n n p d t e E o o o u c t t s e E t b d e n u s i d a n d D r p o d n f o i r . o v b f e s i t e a a h c e t o a t t i e f s r i r v w u e i u e : i i s s t h t a s e f y b h u l o o e l u r u l i f r e d l e n c , o y b t h r e e m c l i n p a g l a h c c o e k a u n s t r g i e e n h . g o , l d w a s t e .
a v p A c a i o r t c o a d t h r s u e d c e a u t i a n n t c a n d e b l d o f w e b t r i a h t h e e c t t e i n y r r c a l e i u t i i n s s o e n g s u f a c h l l o l o e n u i f r t l e r d , l e o t c a b h e a n e l d d p l s i a e i n g p c i o k s a l s a e g t i d i n o g n o f , .
f o r 3 8 .4 K b a T u h d e w f i i b t r h e n o o p d t i e c a n d e d t r w e o s r s k 4 c . a r d s a r e f a c t o r y s e t
B a c k p l a n e
N S o w d t i e c h A e d s d f r o e s r s
S W 1 S w i t c h s e t t i n g s
C e l a n r d g t a h n . d T h p e E a l n t e c a s h d u p s r a c e n t h e o n e l . n e p c a t t c d h i r l e e c a t l d y s
t o a r e t h o e f F t h i e b r e c o N r r e e t w c o t r k
B S a w u t i d c h r e a t e s f o r
P 8
P 7
L O O P 4 P 6
L O O P 3 P 5
L O O P 2 P 4
L O O P 1 P 3
P P d N L i o i 3 2 s n r s s t m k e e a n a s t t P t i t i c l 2 e l n n g g e y a s s x t h n e d a a c r e r e P e l e i n 3 f o f d k a i o n s r r g r e E E a r b n n 7 e d d 5 0 n o 2 1 m o o t s t t h f i e r e t t l e i l n i n d k k ,h s s o . mw u e v s e t b r f e o f i r t t e d .
I O C P 2
L M C C C C - / P 1
P 4
P S r p o c a e c s e f s o o r r 3 s L o o p
L o o p P r o c e s s o r c a r d
P R P 2 x 7 T P x 4 C 8 7 6 5 4 3 2 1
R P x 6
B A C K P L A N E
P T P 3 x 5
I n p u t / O u t p u t c a r d
L o c 2 c a 0 a b l l w C e a o y n r t r i o b l b l e o r n c a r d
P 1
c 4 a 0 b w l a e y r i b b o n
F i b r e O p t i c N e t w o r k C a r d
I n s t a l l a t i o n
d 2
T x
T o D K C
N e t w o r k c a r d
C o n t r o l P a n e l o r N e t w o r k N o d e
C o n R n x e T x c t i n E g n P d 1 a n e l s a n d N o d E e n s
A B D U C 8 7 6 5 4 3 2 1
S S E R D DA
C 8 7 6 5 4 3 2 1
S W 1
R x
O n
O f f
B a c k p l a n e s l o t a n d s w i t c h l o c a t i o n
n e w F i b r e N e t w o r k C a r d ( E N )
n e w I O C a r d ( E N 5 4 ) 4 1 8 8 -7 7 7 i s s u e 3 _ 1 1 / 0 5
1
T h e e • x i s V t i n I g G I O I c O a C r d U s a N r I e n o l o n g e r a v a i l a b l e .
• • • V I G -I O C U F D
V I G -I O C -A S C O M
V I G -I O C -P R T
s r a o W e o q n t c d s h k u n e i o e t e n r t e i i t o d d n f f e s s D t t a a h u I n d e c l d P l r s i b t n i e w g a o s c n s i a k b a t n p e n c h a l f d e a n o t s d d r h S i e . e e W t i i n o r 1 o n s a t t a a t l o l r I l y t O i n h g s e w c t r a i e h c r d e t h q u t i c i S a r i r W e d d s m i 2 b i n a t o a u p o d r s t h r t p a e a a n r t e e t
e T x h i e s t i n n g e w I I O O c c a a r r d s d : c o m b i n e s t h e f u n c t i o n s o f a n d w i l l r e p l a c e t h e
n e w I O c a r d r e p l a c e s e x i s t i n g I O c a r d s
• V I G N O D E .
V i g i l o n N e t w o r k ( T e r m i n a l ) N o d e
• • • • • • • V I G 4 N E T
V I G 4
V I G 3 N E T
n u b O c C t p E S h o p a o n e n o o d t c s t s n e k e n i n b e u o n a t h a . f p e i e r t e o e d l c c o a d t c k n a o r u n i o t p l t r e t l t h a l b i r e i P e D a s o f n p r n n o 4 2 e r I y t o a 0 e P s r a l t o e t w I t w h O i w i n s e s h a s i t c e y t b o c t c a h c a k a I r l h S r O c l e i d i e b k t n W s b g p P c c a S l 7 a a t r o n h W 2 n o n d e 1 t e f b s c o e o a I a a s b O o t h f c l r i r c k e e e t e e q c k c t a e t f s r u o e d r e t o P d t i s n i 2 m r n . o t i r t o e n t d f o D o l s t h f h t K o t h e u e p c n a C k O c n e N e e t i e l t f o f t P n w a n . 2 o d r o k f
V I G 3
C h e c k s
V I G 2 N E T
T e r m i n a l c a r d
V I G 2
V I G 1 N E T
V I G 1
V i g i l o n F i r e P a n e l s
-v e 5 V + v e 0 V
T x C T S R x R T S
f d T i r e h e s s i i p g a n n n e e e d w l f I s n a o n r p d i n u t N s t O e a u l t l p t w a o t i u o t r k n ( I n i O o n ) d E c e N a : 5 d r 4 V ( p i a g r i t l o n n o a . n V a I l G o g - I u O e C a - d D d O r M e s ) s i a s b l e
p s T t I a t h e O n a n e r e d m c d l a i / n r a i a o d r g n d d I a r e O m a l i . s n c b a e s r l d R t o a S w w l 4 h l 8 a e s h 5 n o t i ( i w o P t o i s n s r t t i h n e a 1 s ) n t a a d l l s s e o a d c R s S i i n a s 2 t t 3 h e o d 2 e c ( t b e P i a a r o c m r t t k i e n p a 0 d l l ) a n s e o f o r f
( n I n V e s t I G w al l -I a t O I o i C O n -D C i n s t O a r M r u d c t i ) o
s R i m S 2 u 3 l 2 t a a n n e d o u R T s S h u 4 e r s 8 e e 5 i . p s o n r o t s n a e s e d t h o e t y s a w r t i e b c h o b t h e a t w v a e e i l n a b t h l e e f o r
( n R o e l n a t c i o v n e d h e n u m s c i i n d i t g y )
S t o r a g e t e m p e r a t u r e
u p t o 9 0 %
-1 0 C t o 5 5 C
O p e r a t i n g t e m p e r a t u r e 0 C t o 4 5 C
W R R S S e 4 2 i 8 g h 5 3 2 t ( ( P P o o r t r t 1 0 ) )
7 2 g ( a p p r o x i m a t e )
1 .2 K m c a b l e d i s t a n c e
1 0 m c a b l e d i s t a n c e
a W B d ( d h a i e u t i n d o n i n a l s I t a O l l e c d a r a d ) s a n
N o d e a d d r e s s r a n g e
O v e r a l l s i z e
4 1 8 2 0 0 0 0 , , 7 1 2 8 0 0 0 0 , , 9 2 6 4 0 0 0 0 , a n 3 d 6 1 0 9 0 2 , 0 0
1 t o 3 1
w 1 4 i 8 d t h m m h e i g h t x 1 0 0 m m
S p e c i f i c a t i o n
( E s n N 5 4 )
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
n e w I O C a r d ( E N 5 4 ) 4 1 8 8 -7 7 7 i s s u e 3 _ 1 1 / 0 5
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K .
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
O D u o T s n h F I e F P e d t h p s e V w i o i t o D g s t i s K o l i c t h e C i n o e t M n s a ,l C I o P o s S d c n O o W d r a e t t R t r 1 h s e o a o s d l T t n a o P A N t h t n n a n T e h d : y e b t h e l I a e m a O r u i a e c d n n k i a r e g e r a n d r o a t e d u s r . r I o e e e t o o d i r . A s f L i .T t h L m h e s p e D e o s t r w I P i n t a t i n c s t h t h w i e t h e t U a s c h P t a e r s h e o t r e
1 2 3
P 3
S W 1
P 2 I s F C 4 e t a c t o t o r 5 y
7
D D d p A W i o r t o o s t h E n n p d u e E o o o c t t s e E t b d e n u s i d a n d D o d r n p f o i r . o f e b t s v i e a a h c t e t o a t i e f s r i r v w u e i u e s : i t i s t h a s e f y b l h u o e l l u r o i f r e u l e n c d , o y b t h c r e m l e i n p a g l a h c c o e k a u n g s t r e e i n h g o . , l d w a s t e .
n e w I O C a r d
6 5
F - V U D a I n o G c i v m t -I e o O r r a i y n C s a s l e U H B r t i N a d t i n g I l ) f g -D e u F p u l l l -D e x u ( a p l s e x
4
B a c k p l a n e
P 8
P 7
L O O P 4 P 6
3
2 1 0 S l a v e I / O
3 2 1 7 H a l f / F u l l -D u p l e x
a R p 0 p S t e o w 1 p o r t o s i i t 2 e t f 7 t i c 0 a o o h 0 t r s n e b p t f a s a r n u e h o d l t i m . s
P S R o w o s t i t a . c r h y P S o t r a n t 0 d a ( R r S d 2 c 3 o 2 n ) n M e o c i d t e o n s ( R P S o r 4 t 8 1 5 m o d e
S W 2 S w i F t c a h c t o s y e r t s t e i n t i g t n s g
O n O n O n 1 9 2 0 0 b a u s d O O n f f O O n f f O O n n O | O n n O O n n 3 t u 7 1 o p
L O O P 2 P 4
L O O P 1 P 3
I O C P 2
L C C P 1
P 4
N e t w o r k c a r d
1
L O O P 3 P 5
T o D K C
P S r p o c a e c s e f s o o r r 3 s L o o p
S W 2
V A V U V R I s G I n G I e G c i v - m -I o -I e I o m O O r O e C P C s C t a -A a U - l -P P F i S g F u R r n C e T t r D l l -D ) e O ( ) r a M s ( u a p ) s l e x ( a s
a a o t S h 8 p t p t o w h s i t 9 p o s e i i 6 l i r p F t c i t 0 c o s o h 0 a r n t e i t b o t f f s a r o n o u s r m d .
S e t t i n g s w O i f t f c h e s O n S W 1 8 a 7 n 6 d 5 S 4 W 3 2 2
L o o p P r o c e s s o r c a r d
O n O n O f f 9 6 0 0 b a u d
O n O f f O n 7 2 0 0 b a u d
O n O f f O f f 4 8 0 0 b a u d
O f f O n O n 3 6 0 0 b a u d
O f f O n O f f 2 4 0 0 b a u d
O f f O f f O n 1 8 0 0 b a u d
O f f O f f O f f 1 2 0 0 b a u d
O f f O f f O n O n O f f
O f f O f f O n O f f O n
O f f O f f O n O f f O f f
O f f O f f O f f O n O n
O f f O f f O f f O n O f f
O f f O f f O f f O f f O n
O f f O f f O f f O f f O f f
6 5 4 3 2 1
I n p u t / O u t p u t c a r d
L o c a l C o n t r o l l e r c a r d
1 2 3
B a
| u d R a t e
4 5 | 6
N o 7 d e A 8 d d r e | s s
c 2 a 0 b w l a e y r i b b o n
P 1
c 4 a 0 b w l a e y r i b b o n
t h O e n C e n o e n w t r o I l O p c a a n r e d l i b s a n c o k p r l m a n a l e y l . f i t t e d a s C a r d 1 5 i n s o c k e t P 2 o f
w o r k w h e n u N s o e d d a o n s g s e l e c s i o n e r d q o u r i r a e d d d f i o t i r o n D I a P l I s O w c t i a c r h d e . s t o
I O c a r d l o c a t i o n
C T S h W a e r d s w w 1 h i S e t c n h w i i n p t s o c t s a i h t i l l o e n s d s a s e s h t t a o i n w n g n a d h s d e i e t i r o n a a e r l I a O p c p l a c i r a d . b l e f o r t h e n e w I O
I n s t a l l a t i o n i n s t r u c t i o n s
n e w I O C a r d
E N 5 4 ( V I G -I O C -D O M )
T h e e x i s t i n g I O c a r d s l i s t e d a b o v e a r e n o l o n g e r a v a i l a b l e .
n e w I O C a r d s V 3 + ( B S ) 4 1 8 8 -7 9 7 i s s u e 2 _ 7 / 0 5
f 3 o r 4 3 0 4 5 0 N 8 e / 3 t w 4 0 o 4 r k n o d e
3 4 0 8 C o n t r o l p a n e l
3 4 0 4 C o n t r o l p a n e l
P S S 5 K K 2 2
P T T 6 B B 6 9 / T B 1 0 1
3 N 2 0 e w 0 t 0 o r k n o d e f o r
3 2 0 0 0 C o n t r o l p a n e l
P I 6 O C
P P 8 2 -P 9
1 3 3 3 2 -1 3
1 3 4 3 2 0 3 V 3
V I G -I O C U N I V 3 +
V I G -I O C U F D V 3 +
V I G -I O C -A S C O M V 3 +
V I G -I O C -P R T V 3 +
3 3 3 3 3 2 4 4 4 4 0 K K K K 2 -I -I -I 3 O O O -2 I O C C C C 1 -P S U U L F R V N T D I - V - V V V 3 3 3 + + 3 + +
V N i e g t i l w o n o r k a n n d o 3 d 4 e f 0 o 0 r 0
3 4 0 0 0 C o n t r o l p a n e l
V i g i l o n C o n t r o l p a n e l P P P 2 2 2
N e t w o r k N o d e
C o n t r o l P a n e l o r
l p B o l a c u a g c k t i p o i l n n a n e
P P P R 1 4 4 S 5 2 3 2 / R S 4 8 5
t t A e e s r m r m s o i n i n c i a l a l a t s e c o d a r n d
c T a h r e d s n a e n w d I w O i l c l r a r e p d l c a c o e m b t h i n e e e t h x e i s t f i n u n g c I t O i o n c s a r o d f s a : l l t h e e x i s t i n g I O
T e r m i n a l c a r d
n e w I O c a r d s r e p l a c e s e x i s t i n g I O c a r d s
a a d a T d s e n h d t s d e i 3 n r h g e n 4 e s e s V e w d K a g i - b i f O I I n o l l e o r C p n u f i , i n - t r V e 3 s 3 O t 4 a p 0 + u l a 0 a t l h p n t a e 0 i v u , o t l s 3 n e ( I 2 O a 0 v ) n e n 0 i d 0 f c r a i r s N , e i r e 3 p o n d 4 t s a w 0 3 n o 0 e + p a r k a s l s t r n o ( o d t f n o t r 3 B w u m T S a e 3 r b e r 0 0 5 m . e 8 r T i n a h s n 3 9 e a a V : l P l y G ) o a a I n r r - o g u t I d e 4 e O e , C s s - . u V c 3 h +
-v e 5 V + v e 0 V
T x C T S R x R T S
I T O I O h c e i a d n r a i s d R w g r t a a S h 4 e m l l 8 n a 5 b i e t t ( P i l i o s o o r i t n w n 1 s s ) t h a a o n l l w d e R d s S i t h a 2 n e s 3 t 2 h a s e ( o P b s s o a o c r c c t i i a 0 k a ) p t t l e e a d d n e t e t o r f m e n r p i a a m n l f i e o n l r a / n s l o t s d a e n . d a r d
s R i m S 2 u 3 l 2 t a a n n e d o u R T s S h u 4 e r s 8 e e 5 i . p s o n r o t s n a e s e d t h o e t y s a w r t i e b c h o b t h e a t w v a e e i l n a b t h l e e f o r
( n R o e l n a t c i o v n e d h e n u m s i i n d g t i ) y
S t o r a g e t e m p e r a t u r e
O p e r a t i n g t e m p e r a t u r e
W e i g h t
R R S S 4 2 8 3 5 2 ( P ( P o o r t r t 1 0 ) )
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
7 2 g ( a p p r o x i m a t e )
1 .2 K m c a b l e d i s t a n c e
1 0 m c a b l e d i s t a n c e
a W B d ( d h a u i d t i e n o n i n a l s I t a O l l e c d a r d a ) s a n
N o d e a d d r e s s r a n g e
O v e r a l l s i z e
4 1 1 w 1 8 2 t i 4 0 0 o d 8 0 0 3 t m , , 1 h m 7 1 2 8 h 0 0 e 0 0 i , , g 9 2 h 6 4 t 0 0 x 0 0 1 , a 0 3 n 0 d 6 m 0 1 m 9 0 , 2 0 0
S p e c i f i c a t i o n
n I ( n V e s t I G w al l -I a t O I oi C O n -V C i n t 3 a s r + r u c d i / s t o 3 n 4 V s K 3 -I + O C ( -V B 3 S + ) )
b y H o n e y w e l l
2
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
n e w I O C a r d s V 3 + ( B S ) 4 1 8 8 -7 9 7 i s s u e 2 _ 7 / 0 5
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
3 3 3 3 0 0 0 3 0 2 M 0 M 3 V i 4 g a 0 a 3 0 i r r 4 0 o l 0 k k 0 0 2 & 1 0 , ,n 1 1 P P 2 3 2 3 3 3
a c p s s T r a a w w h e r n i i e t i d e t c g l c h h V i n a r s e g o e i s e s i t l r A i o e a o s d L r n n I . L i m e t a M n P s p u h d e o s e O t r e D 3 R d i 4 T n t a t K 0 n t 0 A h t o C s ,l 0 N e t T h e o U a t c C : P t a a o n d t t t o h d e r r e r d o O D e l s o P F I n s a F P n a t h p s n e e o w d l s s t i i n i c b n m t i h a e a o u n e k s d r e s S r d o W a o u t o s t h 1 e r e a o .F .T o t n o h f t r e t h h e t h t e h y e e D I s O I P e
O f f S W 1
P 2 I C F 4 s e a t c t o t o r 0 y
7 o r F
D D d p A W i o r t o o s t h E n n p d u e E o o o c t t s e E t b d e n u s i d a n d D o d r n p f o i r . o f e b t s v i e a a h c t e t o a t i e f s r i r v w u e i u e s : i t i s t h a s e f y b l h u o e l l u r o i f r e u l e n c d , o y b t h c r e m l e i n p a g l a h c c o e k a u n g s t r e e i n h g o . , l d w a s t e .
n e w I O C a r d
F a c t o r y s e t t i n g s
-
6 o r E
5 o r D
S W 2
4 o r C
3 o r B
2 o r A
V U D V A V U V R I n o G I s G I n G I e G i i v m - c v - m o -I e -I e I I o a m O r i O O r O n C P C s e C s C t a a - l B -A a U - l -P P U r H F r i S g N a d n u R i e F g C D T t l r l l e -I e O ( - -D -V r V -f D V a 3 u F M s 3 u 3 ( + u + a + p ) p V ) l ) s l l e -l e D 3 x x u + ( ( ) a a p l s s e x
9 a o t S h 8 p 6 p t o h s i t 0 p e o s w i i t 0 c l i r p F t i c o s o h b a r e n a t i t u o f f s t r o d n r o . s m a t
O n 8 7 6 5 4 3 2 1
P s R S 0 o w o W s i t 2 o . t c a r r S h y 8 w P S t S 3 i o t l 2 c a r a h v 1 n 7 t e 0 d s H a e I a / ( O l R r t t f S d i D n 2 c o g u 3 n p 2 s l ) n e M e x o c i d t e o n s 1 o r 9
a R p 0 p S m ( P t e o t o w o R o 1 p t r o s i d S r i t 2 4 t f 7 t e 8 i c 0 e 1 o o h ) 0 a 5 n t r s e b p f t r s o a a n u e h m d l t i . s
S e t t i n g s w i t c h e s S W 1 a n d S W 2
O n O n O n 1 9 2 0 0 b a u d O O n f f O O n f f O O n n O | O n n O O n n 3 t u 7 1 o p
s r n s W e o q o e c h d t k u i e t i a s e e n r t e D i o d d n I f f d s r P t t e a h u n s e c s s w l l i b t n i g i a t a n o c c d n h a k b t e n p e h s l f e S a a n o r W d d r o e i . e t 1 t a i i o r n y t n o a s t s a t w h l l I l i e O i n t r c g c e h q a t h S u d r e W i r i e c 2 d t a i r t s d o b a i m i n t h u p a e d o r a s r t p a e t a n r a e n t d t o
s c s O c A n o p E S o o o n o o f o n e c n c 2 d V s t s e n k t k i n 0 e u t t r e a e i o h e i e r e o w . g t d c s l t i n o t d l a r a o y o o p n o i b l t n e l t f a i r n t a r o P t D h o f i h e r n 4 b r o l e a e s r I P y 3 e b l a b s a o a 4 n a w s I s n c O d n 0 i n w i s k o d p 0 s c i t t c c 0 t t h a u l c a h c b i a p a r e l l a s h S l y t n e d i I e t e n W O o s e s d c t g o e o f o c 2 N o m t n n c f a a h f t u t n e r e S b o h e d e C t W w r I i a o O s c n e t o t V f n s 1 e r i o r t c t c k o g b i t r a q k e o a e r u n t h i d e r e l t l d i o e o i t w p i s e r d b n n P e a e / n n e t d o .2 e 3 t . a n c e t t u f k 4 t l h o D h p 0 n o e t e h c K l 0 r b a 0 e t s a N C n / i p c o e 3 e k O n 4 a t r f . w p 0 e f l 0 o a n r k e
O n O n O f f 9 6 0 0 b a u d
O n O f f O n 7 2 0 0 b a u d
O n O f f O f f 4 8 0 0 b a u d
O f f O n O n 3 6 0 0 b a u d
O f f O n O f f 2 4 0 0 b a u d
O f f O f f O n 1 8 0 0 b a u d
O 1 f f O 2 f f O 3 f f 1 2 0 0 | b a u d
O f f O f f O n O n O f f
O f f O f f O n O f f O n
O f f O f f O n O f f O f f
O f f O f f O f f O n O n
O f f O f f O f f O n O f f
O f f O f f O f f O f f O n
O f f O f f O f f O f f O f f
6 5 4 3 2 1
B a u d R a t e
4 5 | 6
N o 7 d e A 8 d d r e | s s
w o r k , w h e n N u o s e d d o a n s g l a e s s i e c e r o q n d u i r o e r d a f d o d r i t t i h o n e a D l I I P O s c w a t i r d c h . e s t o
C h e c k s
3 C T S 4 h 0 a r e W 0 d 0 w s w 1 p h t i S a e c n h w e n p i i l n o t o s s r a t i c h n l t i l o o e n s d d s e a e . s s t h t a o i n w n a n g d h s d e i e t i r o n a a e r l I a O p c p l a c i r a d b i n e l t h f e o r V t h i e g i l n o n e o w r O I
I n s t a l l a t i o n i n s t r u c t i o n s
n e w I O C a r d s v e r s i o n 3 + ( B S )
4 1 8 8 8 8 8 . 0 2 _ 1 / 0 7 _ C o p p e r N e t w o r k C a r d ( f o r V i g C o m p )
f i r n a o r s t e d t a a e l l n t a i n d i g l a s t s h d S e e d r e e N e t s o e t v t s h e w b e r o e b l e r o f a a k u r f . c e d a r d ,
L o o C p A C R a r D d ( L 2 o o p 2 )
i l h F l t i u t s e n t h t r e a e t w w e t d o i r . k r e i c l a n k r s d u a p n d p l i M e C d B b e a t w s e e n
l s o c i o n I f C o u n a r s a a p p a s r p t h d t l c e l i d l e n e a i e c r d M t o d o i d n n C s , a t i n n B o l h d s t l t o o d u t e t m n o a s h t f p l h e i i a n l r e n g r s c a k t a t n f t e f r i h d t i e t i d o t w t h e C ' t i n h s o e s e t A t r k s a n o n R e c e D t b c d a o e o w r n f d f 2 o . d s ' r k P B 1 A
c T o e n r n m e i n c a t i s l o n f s o r n e t w o r k
N e t w o r k C a r d
0 V L 2 L 2 +
P B 2 P B 1 B
1
0 V L 1 L 1 +
S t a n d o f f
L o o C p A C R a r D d L 1 ( o o p 1 )
a A h b s b T d b a o y e h d a s a s t i w s r n t d r t e e e c m s k e o s o r m M . e n p T p n f i n C e u d B h c e o m u a n r l o s f c t n b a r e a o e l -i t h r l t r n o t w e d p a -l a m a o n i r n c c p n k d e e a n u s e b s p e l c s a a w t l t u i e i b i r d t x n e n d c t i a s a p r h e a l e r u V u n d g t e s a i s e g e . o l d g i l d n n c i e o e a d n t t o h t i t C n e w e t d o o a l c o l m o a r s k l t h p w r w o d e a t d a i r ' M c i t a l n C l g a A a n t o e t w . R s e t w o D t s r p e 2 C o a t r t k s .' o e i n s T n g d h t r f o e o i f r l c e a r d
Mn a e s w t e r C o n t r o l B o a r d ( M C B )
W i r e l i n k t o N e t w o r k c a r d
C A R D 2 s l T o h t . e N e t w o r k c a r d m u s t b e p l u g g e d i n t o
t y p e .
2 S t a n d o f f s
1 1 - S W p i a e r d e l i n t a k g
1 p U .2 a s n i K e n m s l g t h c a c a e b n C l e b o d e p i c p s e t o a r n n n N c e e c e t w b t e e d o r t w i k e n c e a a n s d r p e a a c n u r m e e l n a s x d e i m e t w u p o e r m n o d k f l u e o n o p t p o , t n w o c t i 3 a h 1 b u C l p o e n t o t r o l
( n R o e l n a t c i o v n e d h e n u m s i d i n g t i ) y
S t o r a g e t e m p e r a t u r e
t O W e m p e i p e r g e h r a t t i a n t u g r e
u p t o 9 0 %
-1 0 C t o 5 5 C
0 C t o 4 5 C
C a b l e
1 B 0 e 8 l g d e ( a n p p 9 r 7 2 o x 9 ( i m e x a a t m e ) p l e )
T e r m i n a l b l o c k
O p e r a t i n g v o l t a g e
B a u d
N o d e a d d r e s s r a n g e
D i m e n s i o n s i n m m
2 2 1 2 1 . 5 5 4 t 5 5 m V 0 d 5 0 o e h , 3 m ( e 1 p R t i 2 S 9 h g 6 h 4 0 t 8 0 5 x ) ,1 9 1 .2 0 0 K w a i n d d t h 3 x 8 .4 K
T e c h n i c a l d a t a
( C P w p i a O a t n M r h e t P n s l h A u o f a C m t w v T b a i n e r g - N T h r : e a C e V v ) e n i C r e s N S s w c e t i - P o M o w m o S n U 4 C p r k . B a - c N 3 6 ( t i a ) P b r . o a l d r r e l t w ( P a n t i a e u t r r m h t a b V n n e g i u d r i m l b n : o e V n e w C C r : S P - o S M m U C p B a c - N t )
( C O M P A C T -N C ) f o r V i g i l o n C o m p a c t ( N e t w o r k a b l e )
C I n o s t p al l p a t e oi r ni N s n r e t u t c w t i o o s n r k C a r d
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 8 8 8 . 0 2 _ 1 / 0 7 _ C o p p e r N e t w o r k C a r d ( f o r V i g C o m p )
F a x ( U K ) : + 4 4 ( 0 ) 1 1 6 2 4 6 2 3 0 0
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
W e b s i t e : w w w . g e n t . c o . u k
o G b e l i n c a t b t i y o n H o t o n e n y o w t i f e l y l r a e n s y e p r v e e r s s o t h n e o r f g i s h u t c h t o r r e e v i v s i i s o n e s t h o s i f p c h u a b n l i g c e a t s i . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
f a c t o r y s e t t i n g s
6 3
4 3 2 1 6 4
o n
o f f o f f o n
o n A o d n d o r e s n s o n o n
a v p A c a i o r t c o a d t h r s u e d c u a i t e n n a t d c b a n e l d o w e b f r a t i e h t h c t t e i n y e r r a c i u e l t i s i n s e o n g s u f a c h l l e o o n u l i f r t l r d , e l e o c a b t h a n e e l d d p l s i e n p a g i c i o k s a l s a e g t i d i n o o g n f , .
B a u d
o f f o f f o f f o f f o n
o f f o f f o f f o f f o f f o o n n 3 8 .4 K
O n D D d p A W i o r t o o s h E n n p d t e E o o o u c e E t t s t n b d e d a d D u s i n o d r n p f o i r . o f e s v i b e a a t h c t e t o a t i i v f s e r r w u e i u e : i t i s s t e h a s f b y l h u o e o l u r u l i f r e l e n c d , o y b t h r c e e m l i n p a g l a h c c o e k a u n s t r g e e i n h . g o , l d w a s t e .
o f f o f f o f f
o o n f f o o n n
1
2
3
O f f
4
5
6
7
8
1 9 .2 K
N o d o o 8 e n f a f d o o 7 d r f f e f f s o o 6 s f f f f o o 5 f f f f o o 4 f f f f o o 3 f f f f o o 2 B n f a f u o o 1 d f r f f f a t e 9 2 6 4 0 0 0 0
3 8 .4 K b a u d T w h i e t h c n o o p d p e e r a n d e d t r w e o s s r k 4 c . a r d
D u a l i n l i n e ( D I L ) s w i t c h e s
i s f a c t o r y s e t f o r
D I L s w i t c h e C s l o o m c p a o t n i e o n n t o s i n d e t h e N e t w o r k c a r d
c ( u W o c s h n o r e n e d e r e s e e c w n t e i s a d t u h r m u t o e o u t t l i 0 t h c V s e i u o . g r n n e a u c l s a ) b a e l r d e e c s o i r b e s e i n g
a t b T s e r e h s m c e h i o c o n n a w a n b e l n l n c e . i s t e t h c r e d e t b o e a a n c n m k b e u o a s x r t , t h
C o n t r o l P a n e l
C o n t r o l P a n e l
M A S T E R C O N T R O L B O A R D
M A S T E R C O N T R O L B O A R D
C C a o r n d n 2 e c t i o n s f o r N e t w o r k c a r d
P B 1 A
P B 1 B
N / C = N o c o n n e c t i o n
0 V L 2 L 2 +
0 V L 1 L 1 +
N / C
C o n t r o l P a n e l
i n
C C a o r n d n 2 e c t i o n s f o r N e t w o r k c a r d i n
P B 1 A
P B 1 B
M A S T E R C O N T R O L B O A R D
0 V L 1 L 1 +
N / C
C o n t r o l P a n e l
N / C
P B 1 A
0 V L 2 L 2 +
P B 1 B
0 V L 1 L 1 +
i n C a b l e s c r e e n
C a b l e s c r e e n
0 V L 2 L 2 +
C C a o r n d n 2 e c t i o n s f o r N e t w o r k c a r d
W i r i n g a n e t w o r k o f V i g i l o n C o m p a c t p a n e l s
M A S T E R C O N T R O L B O A R D
C C a o r n d n 2 e c t i o n s f o r N e t w o r k c a r d i n
N / C P B 1 A
0 V L 2 L 2 +
P B 1 B
0 V L 1 L 1 +
I n s t a l l a t i o n i n s t r u c t i o n s
C o p p e r N e t w o r k C a r d ( f o r V i g C o m p a c t )
Vigilon 4/6 loops & Compact (VA) panels & network nodes
Appendix F - Spare parts The appendix has information on spare parts for the Vigilon panels.
s t r a p e r a p S F x i d n e p p A
4 1 8 8 9 1 3 . 0 1 _ 0 4 / 0 7 _ E N t o B S k i t s
s V t u I h p G e p - B c o o S n r t K v L I e o T r T o - N s i h p O o c D n e i k L r c ,E t i o u a V o p i t s I s G P . t h - r e B o S c N K e e I s t w T s o o b u r r k t C n n a r d o o d t i e w s i s d t o h u p e t h p s e l i n k e o i d t t w i t h
a N p o p e t l i : c a T h b e l e l o f o o r p N p e r o t w c o e r k s s n o o r d c e a r . d s a r e n o t
1
W a r n i n g
1 x ( ( N B N o S e t - t w s v o u e r p r k p s i C l i o e n a r d 3 d w ) ( N i C t h ) V I G -B S K I T )
P 8
P 7
P 6
P 5
P 4
P 3
P 2
P 1
C A R D 6
C A R D 5
C A R D 4
C A R D 3
C A R D 2
C A R D 1
C A R D 1 5
C A R D 0
1 x ( ( N B I n o S p t - u t s v / u O p e r u p s i p t l i o e n d 3 u t w ) C a i t r h d V ( I I O G C -B ) S K I T )
L N o L N o o e o e w p t w p t o P r P o r k o r r k o c o c o e r e r R s R s s s S S o 2 o 2 r 3 r 3 C 2 C 2 a o a o r r r r d d # #
L o o p P r o c e s s o r C a r d ( L P C )
L o o p P r o c e s s o r C a r d ( L P C )
L o o p P r o c e s s o r C a r d ( L P C )
L o o p P r o c e s s o r C a r d ( L P C )
N e t w o r k o r I O C a r d ( O p t i o n a l )
( M M C a n C i ) C o n t r o l l e r C a r d
P t M 1 o a C b e s e A f t i r R t t C D e d o 0 t n o o t r n s o l l o e b c a k r c e C k t a p r l d a n M e ( C C )
2 0 w a y r i b b o n
C o m m i s s i o n
1 x C o m m i s s i o n / W a r n i n g L E D l a b e l
2 0 w a y r i b b o n
B a c k p l a n e
# f o r V I G 1 -7 2 o n l y
1 x B l a n k l a b e l
1 x ( ( N B L o S o o t - p s v P u e r p r o p s i c l i o e n e d 3 s s w ) o r i C t h a r V d I ( G L -B P S C K ) I T -N O D E ) 4 0 w a y r i b b o n
C a r d g u i d e s 4 0 w a y r i b b o n
T h e k i t c o n s i s t s o f :
l c S o e c a a b l c u t e e r d s e o u n t h n d e t h e r t w e t h o b e a r i c c b k l b p a l m o a n n p e
B a c k p l a n e
1 x ( B M S a n - i v e C o r s n i t o r n o l 3 C ) a r d ( M C C )
t h e m a i n s F t e o r r m s i n a f a e l t b y l r o e c m k o i n v s e i t d h e e t h m e a p i n a s n f e u l s / n e o f d r e o . m
b .
t O o p a p t n e h e e l n n t p / h a o e n d e e o l a u / n n t e o d r d a e d n . s i d c i o n n n n e e r c d t o t h o e s r b o a f t t e t h r e y s u p p l y
a .
I s o l a t e t h e m a i n s s u p p l y t o t h e p a n e l / n o d e .
n V T o G h d I e e -N k t i o O t a D ( V I B E G - S 2 B N 4 S e t o K t w c I o o T r n -N k v O n e r D o t d t E e i ) . f r c o a mn a b n e E i n N s t a N l l e e t w d o i n r k a
R e p l a c e c a r d s
E V T N G I h e c 1 k o -7 i n 2 t t r c ( V o I l G p o n a t B n r S e o l K l t p I a T o n B e ) c S l a o n c t o c b n o e t r n i o n l v s p e t r a a t l n i e l e t f d r l . o i mn a V I n G 1 -2 4 o r
i n T h V e i s g 1 e / 2 c 4 o n / v 7 e 2 r C s i o o n n t r k o i l t p s a a n r e e l d s e a s i n g d n e N e d f t w o o r i r n k s n t a o l l d a e t i . o n
n sI
c m o u n s v e t r b s e i c o n o T h w m e o p m l r e k t a . e i l n y s i s s o u l p a p t e y l d b t o e t f h o r e e p c a o n m e l m / e n n o c d i n e g
t a l l a t i o n
f o r V i g 1 -2 4 / 7 2 p a n e l s & n o d e
E I n N s t a l t al o t i o B n S c o n v e r s i o n k i t s
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 9 1 3 . 0 1 _ 0 4 / 0 7 _ E N t o B S k i t s
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
a .
B e D t l C R h a n s S s i e b o e m e a c u b o l l m o o e r l c o m v m e a n s i e p t h m t i t o t l h s i e e h a i e n e n o n p t s n c a / t b T h o / s n o n W a y e e c w t s l s r a k t t L / i r e E D n o n n l m D e o a i g n v . s a l e n g o r d l f f a y i t n a t r L h d h e b e E e i e c D c o s a l r i r .T t o e n a c h t n i m d l s y e i l s s a m t b d b i c e o r k l n a l e e n t h d t e e f o o i n r
F i t l a b e l s e t
f .
b c c R a a a e c b b k l e l c p e o l s s n a a t n n r o e e e t c . s h t e e t c e r h u p e r l 2 e 0 d a c -w i n e m a t h e y e n a n c t a M d m C 4 p C 0 o a w n n a y t h d r i e e n b s b o u n r e t h e
p o l a o r p t n c u a m r b d e t h I r e f V n t h I G a e d c - L d o P i n C t i t o r - V n o l 3 a p + l . c a a n r d e l s i s m f i a t y t e b d e w a i c t q h u m i r o e r d e u t h s a i n n g o n e
c .
D D d p A W i o r t o o s t h E n n p d u e E o o o s c t t e t e E b d d a n u s i n d D o d r n p f o i r . o f e b s v i a t e a h c t e o a t t i i f s e r v r w u e i u e : i t i s s t e h a s u y b h f l o o e l u r u l i f r e d l e n c , o y b t h r e e m c l i n p a g l a h c c k o e a u n s t r g i e e n h . g o , l d w a s t e .
a v p A c a i o r t c h o a d t u r s d u c e a i t e n n t a d c a n e b d o l w e b f r a t i e h t h c t t e i n y e r r a c i u l e s t i i n s e o n g s f a c h u l o l o e n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i e n s a g i p c i o k s a l s a e g t i d i n o g o n f , .
n C o o l d s e e . t h e i n n e r a n d o u t e r d o o r s o f t h e p a n e l /
b .
o C p o e n r d a u t i n c g t e c t o s t r r s e o c t t l e y n . s u r e t h e p a n e l / n o d e i s
e .
b e r b B a p a e c l t f k t e o p a r r l c e y e a f n m i i n t e e s t i n u n a t l g n a t d c t i h a o e d r e n s n r s s e l p u s e r u e a l e p v c t e e h p l / m e i y e d d i e n a i s r n k t e . M t h F C s e e i C a k t h r t i t e t e e d i n m t c o o o v r r t h e e e t c h t l e y . a .
t P h b o e a t w p t e e a y r r n u e s p l u / p t h n p e o y l d a p e n a . d n e l s / w n i t c o h d e o b n y t h e c o mn n a e i n c t s i n p g o t w h e e r t o
P o w e r u p
d .
c .
a U n n d p l N u C g c t h a e r M d ( s C ) C f r a o mn d t h i f e a b p a p l c c k i p a b l a e n l e t h . e L P C , I O C
c D a s i b c l e s o n n f r e o c m t t t h h e e 2 M 0 C -w C a . y a n d 4 0 -w a y r i b b o n
b .
f d s R o t i e r o B n c k m S e t t h o v c o e e o h l t m d i a h p e b e e l i t l b a h a n i o v c t s k e s i n r i n y d g s i t h t e c e o m a f t f i S . o t h n o u e n B a d s e l i r a t i L n s k n E l a o D t .T b e a p h l i p s l i i c a s a n b d l e
1
S h i f t
A
Q
1 ! "
Z
S
W
2
X
D
E
3 #
C
F
R
4 $
V
G
T
5 %
B
H
Y
6 ^
N
J
U
7 &
M
K
I
8 *
L
. , S p a c e
U 4
M e n u O n / O f f
O
9 (
P
0
; ; :
-
S o u n d A l a r m s
D i s a b l e m e n t
T e s t
D e l a y
S y s t e m F a u l t
P o w e r F a u l t
F a u l t
V e r i f y
F i r e
F 1 S i l e n c e A l a r m s
R e s e t
F 2
P r e v i o u s
F 3
N e x t
I n s t a l l a t i o n
m a R n e e d m m o b s t v i e r a c n k b e t h a . e c l k a n b i e g l , t o a l i g n
C o n t r o l a n d i n d i c a t i o n m e m b r a n e
)
F 4 +
E n t e r
D e l e t e
I n s e r t
U 3
U 2
U 1
V e r i f y
C a n c e l B u z z e r
P o w e r
C B 2 5 4
C B 2 5 3
S o u n d e r
2
m a R n e e d m m o b s t v i e r c a n k b e t h a . e c l k a n b i e g l , t o a l i g n
E N t o B S c o n v e r s i o n k i t s
4 1 8 8 8 8 0 . 0 1 _ 0 1 / 0 7 _ 7 2 h r u p g r a d e
i T s h s w e p i t a c h n e e d l o w l n i l . o n l y p o w e r u p a f t e r t h e m a i n s s u p p l y 1
C o n t r o l P a n e l
B a t t e r y B o x
o B r a 8 t t x e r i 1 e 2 s V 4 2 x 1 1 A 2 h V 2 1 A h
B a t t e r y B o x
T H 1 P 1 P 2
P 6
P 4 P 3
s d V A t I d a e G n t e - d i d r 7 t m i 2 o b - n y n i B d e A a u t T l r h T b a e . a t i b T t t o e n a h r i e e . t t e b s r a - y t t 4 c e a r x p y 1 a l 2 c o V i o t y p 2 r o l 1 A e q a h d u a i r c r e a e d c l a f u v o l a r a l t i t h o a e r b l m e s y u o s s n t e t p m b a e r t u t o s n m e u e d m b e t t o e r t h e
T H - T H B + T 1 B T B 1 + T 2 - B T 2 +
B 1 + B 1 B 2 + B 2 T H + T H -
P P 2 3
P 1
C o n t r o l P a n e l x 1 I n s t r u c t i o n s
B 1 + B 1 B 2 + B 2 T H + T H -
x 1 B a t t e r y b o x
x 2 1 2 V 2 1 A h B a t t e r y
b c V V T h G o a I g i h x i i s . g r 1 o I i -7 l u t n n 2 p c p g o g p r n u a a n a s p d e i n e s t e ( l t s o l V k i t o 8 .T G f x h I ( p 2 e 1 V I a 1 k -2 G r A i 4 7 t s t h c ) 2 . U b o t n I a s P i t s t o t e i u G R t er i s s s ) . s i of e d s i n a t o d s e t c s a 7 i l 2 H o l n g e n v e d r e P i r d n S t f a U a o r m V r e i I n m o G s 1 t o d a t e u l -2 l l e b f 4 a i a o p t o t r a n t e n i r e n y l t o a
t h p f r o e o s m r s e i 2 q b l 4 u e h i r w o e i u T d t h r s s h y a t e s p o u t p e p r u g m o p r p t a l r o d o i a a 7 e d t . e 2 w n h i l l u o a m u c r h b s i e p e r l v o u e f s b 0 s a 5 a . t t n t e h r d r b i a y e l s a d r i n m u r t l a h o t i e a o b d n a . t o t T t e h b r s i e y i e b s x o t x m e a n f d o d e r e d
P P 2 3
P 1
x ( w 1 i B t h a 1 t t - e f r i x y i n T g e s m c r r i e n w a ) l C a r d
P 3
B1+ B1- B2+ B2- TH+ TH-
3 F A 1 S 2 5 Q B
x 1 B a t t e r y f i l t e r c a b l e
P 1
P 1 1 1 1 P
D L 2 D L 1 D L 5 D L 4 D L 3
( U V I p G g 7 2 r - a U d P G e R K ) f i o t r V I G 1 2 4 p a n e l
P 7 7 P
5 P
FS1
4 3 2 1
O N
S W 1 B 1 + B 1 B 2 +
B 2 T H + T H -
3 F A S 1 8 5 A S P 1
D A N G E R
c o R W v e l i A v e e r m R o p e x v N a a I r p t o l N s s o G e s f
x 1 7 2 H r P S U M o d u l e
L
N
P 2
P 2
b y H o n e y w e l l
I n s t a l l a t i o n
2
b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 8 8 0 . 0 1 _ 0 1 / 0 7 _ 7 2 h r u p g r a d e
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
D D d p A W i o r t o o s t h E n n p d E u e o o o s c t t e t e E b d d a n u s i o n d D r n p f d o i r . o v f e s i b e a a t h c t e o a t t i v f s e r i r w u e i u e : i i s s t e h t a f b s y h u l o o e l u r u l i f r e d n c l e o y b , t h c r e e m l i p n a g a l h o c e c k a u n g s t r i e n h e g o . , l d w a s t e .
a v p A c a i o r t c o a d t h u r s d u c e a i t e n n t a d c a n e b d o l w e b f r a t i e h t h c t e t e i n y r r a c i u l e s t i i n s e o n g s f a c h u l o l o e n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i e n s a g i p c i o k s a l s a e g t i d i n o g o n f , .
k )
j )
a C n l d o s t h e e t h o e u t e i n r n d e o r o a r n o d n o t h u e e t r b d a o t t e o r r s y b o f o t x h . e p a n e l
2 2 2 A < E m b C 7 7 7 s l 5 n o a a .1 3 . 5 . o b s r n t t r e y i u t V V V t t i s r t r o y h e @ @ @ e ( r e e t i c n h g i . a r s t 2 2 1 b g s c . . 5 0 5 a t u t B t i o e C h ( D D D t t f s d e e e r 1 e ) i g g g y s c - h a c f l B C C C o n o a T a r d n t 1 g mn v < e o r a e 5 c l t A i n t a ) i g . D s o e C s n u a s n p d h p o b a l u t r y l t e t e d r o c o b y n e A c h n D e a e b C c c o t i u s i k f o t a n : u o l f t
i )
g )
f )
e )
d )
c )
f r R i e x m e i n o m g v o s v e c e r t h t e w e h s P e P f S S o r U U l f a r m t e o r m o d u t h u s l e e e . b i a f x c i n k g b s o c x r . e K w e s e a p n t h d e
P U S n U p l . u g t h e
l a D e n i a d d s c o f r P 1 n o n m 1 e o c s n t p P R a i d S b e U b c o o , t h n n e n n c e a b c t u l n e o p r l s P u f r 5 g o m o t h n e c P 0 o S V n n U ( e . b c l a t o c k r P ) 7
r f r D e i q o u m s c o i r t e h n n d e e . p c a t n h e t ,l e k t w e e o p b t h a t e t m e r i e i n s a a n s a d r f e e p m l o a v c e e u t h n e t i l m
t h D i e s P c S o n U n e t c e t r m t h i n e a m l a b l i n o s c k L P i v 2 e . a n d
h )
t I b F o b n c o a l s n o o r t d x o l e h c r l o e r c b t e ,k t o w a p c t t m h l t a o e y t h e a t n i r k e n y e n m s n i e n .l e a t b t s c i o h t n a t s l l x r e a h .T c u n f t c e d u t o i h n o s b e s n n s a i e w e i t n n i t t c s e s c r h t o e i u r t i t o u O t n p p s c h l t N e i i i b e n o e d m t n t h a s i s w i e i d e n s m n e h e h t n t h o a s e t e w i t n e h b s r h e a m b o o p i t x w p t n e o a r w l . t a n y o e e r l
o f u p t o
B a t t e r y c a b l e
f r o m s o c k e t P 2 0 o n
a u b s a e d t t f e o r r 5 y t 6 b h E K o e n g x t s . i y u s p r e e t o o a b f d e c e m o q n u o s a u t t r e n u t e c f i x d t i t o u t n o r e s s s u u a p r f n p a o c d e f r i t o t a n t i n w t g e o s i w g a h h r i e t c h
N e u t r a l
w i r e s a t
m a i n s t e r m F i n o r a s l b a f l e o t c y k r i n e m s i o d v e e t h t h e e p m a n a e i n l . s f u s e f r o m t h e
g )
f )
e )
s t I h o n u p a a r s c n n i f t h e a n l 1 i a ,l 0 l t s w m s h t a M h / l e l B 1 e I e C n 5 a C u m d i n t t . s e c i n a y r g a b e r l m b 1 e . d o 5 x m s i o t e m t a o l n c u / 2 c . e a n 5 i d m a t o e w n r m a n y t h e f i a e r f e r n t h o c n t a m o h b t h m e l e e p , o a r n e e l
s R p c a b a d r a e c d c k o e t o p l n a n c n e o P n 7 e c t n t e o h n o t c e s t P o S o R r U c i P k b b 5 .P e t o o l P n n u 1 P g 1 c S i n o a U t n b l h P e m e s o 0 S f r d V U o u ( a n l b d m e . a l t t h e e c r k m ) l i n e a a d l t o
mR o e d c u o l n e n t e e c r m t t i n h a e l L i b v l e o c k a n P d 2 N . e u t r a l
w i r e s t o P S U
b )
a )
O s I p o e a l n t e t h h e t o e m u t e a i r n a s n s d u i n p n p l e y r o d t o t h o e r s p o a f n t h e l e . p a n e l . d )
b a t t e r i e s
H o w t o r e m o v e t h e e x i s t i n g P S U a n d
c )
oT
u c p o g m r a p l d e e t e w l o y T i h r s k o e . l m a a t e i d n s b s e u f o p r p e l c y o t m o m t h e e n p c a i n n g e l P m S u U s t b e
b )
U p g r a d e t h e P S U
a )
s F b B W t o C e t i a o a t i c c c t h u t t k o n h n e r n t b y e e h n e o r e c P i S t t x t t e u U e c a e t o n s n r m r i m o r e n m d s g o i e n n i s P n t a a h d e d l 3 c l b e u u o c o l l r n o e a f e r o r c t i h d h t g i k t e e i n i u t o a n s B B w a B i l a t n o a o f t a t g n r t i t x t e t e d t i h a t s y n e r r e o y g r s t y t b t c h h e i f s a r e e f l c r e i m t r c l e b e f w t k r r e i a w o n b r s n a c s s o a u e t c . l x , p o f c b a p f t b l a i a l n l r e i t e d e h t d h d . e e .
t o C o c o n n n e n e c t c t h t o e r o P t 1 h o e r n e P n S d U o . f
H o w t o f i t t h e P S U U p g r a d e K i t
I n s t a l l a t i o n
V i g i l o n P S U u p g r a d e k i t f o r V I G 1 2 4
1 b y H o n e y w e l l
T e l e p h o n e + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 8 7 6 . 0 1 _ i s s u e 2 _ 0 9 / 0 6 _ 7 2 h r b a t t . i n s t .
H a m i l t o n I n d u s t r i a l P a r ,k W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
w G i e t h n o t b u y t o H b o l n i e g a y t w i e o n l l t r o e n s e o r v t e i f s y a t n h y e r p g i e h r t s o t n o r o e f v s i u s e c h t h r s i e v p i s u i o b n l i s c o a f t i o c h n a f n r g o e m s . t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f
a v p A c a i o r t c o a d t h u r e d s c e a u t i a n n t c a n d e b d o e w l b f r a t i e h t h c t e t e i n y r r c a l e i u t i s s i n o e n g s f a c h u l o l o e n u l i f r t l e r d l e , o b t c a e h a n e l d d p l s i e n p a g i c i o k s a l s a g e t i d i n o o g n f , .
i T s h s e w i p t c a h n e e d l o w i n l l . o n l y p o w e r u p a f t e r t h e m a i n s s u p p l y
r s i o f W e l s h o h l e p t w r e a e c t t p r t i v h r e e e o q r c e u u e i p d d e r u p / r d e b l e , r a s c c a d o k d n e n l o t o f e a c d u r t i . b o s r d T a s h t i o e r t e n c e r o e i t t h y l n l s e y t o P c e o x C n c t h n e e B e . c p u t t p i e o p d n e t r o s t h h e e l ,f
B
D D d p A W i o r t o o s t h E n n p d u e E o o o c t t s e t e E b d d n D a d u s i n r p o d n f o i r . o v f e s i b t e a a h c t o a t t e i i f s e r v r u e w u e i : i t i s s t e h a s u y b h f l o o e l l u r u i f r e d l e n c , o y b t h c r e m l e i n p a g a l h c c o e k a u n s t r g e e i n h g o . , l d w a s t e .
I n -l i n e f u s e r a t e d 1 0 A Q B c e r a m i c 2 0 m m x 5 m m
W h i t e .
p A o l a R r d c n o o d u c d a t e t c t e d w d o e u o o n t h r m n n e e s o t e c b h t a r e e t o t t e t b t o o t r a p h y t e t r r . e r i e e r g d i e h s / b s t p l e a ' B s i c ' d c t k i t v l o e e e o t f c a h t d e h o t l e n o n h r w e n e c o e c u t r o o g l s s s r h h h e u r o l n o f e l . P e a n n C i d B s r h , e e p l e f a t
A
s L h o e w l f e r
A
B
T H 1
P 1 P 2
a R n d a i p s e u R s t h e h e d t t h w e o m b a B b t l a t a e c c k r i k i e n s t o t o t h e a n e u n c p r i l g o s h u t r p e o . s i t i o n
B s U a h e p p t t l e f e r r y B o x
P 6
P 4 P 3
T H - T H B + T 1 B T B 1 + T 2 - B T 2 +
f F u i s t e t h d e l e w a h d i t t o e l t n h i e k l b e a a t d t e a r n y d t e t r h m e i n n a f i l t s . t h e r e d / b l a c k
8 1 2 V 2 1 A h b a t t e r i e s
W h i t e .
R e d
B l a c k
B
w F h P i o a l a t r c s t z e h h i e e o n t r b t h t a e o o l l y l t e t , w a s w o c p i b h a t h a d b e t t a e t e t c r t m r e o i e r n i n y n a s t i e e l c s n r m t o a f t h r e i c , n l a w i n o l a g w a s o e s h u r s e t s r w h h o a a e w n r l f n d d a s s . n a p b r d o i l a v n e g y . t h e m
A
d a E r n o e n s u o b e r t i e c n t o g h m w e e i r b a i n e d t t t o .E e r i c n e o s s n u a t r r a e e c t t h h e w e l i b d t h a i n t h t t p e e r l m y a c e t e e t a r w l m h e i n i n a l e c l l s t o h s e u y r e .
I o t f i f s d r u e r c i n o g m b m a e t t n e r d e y d i n s t h t a a l l t t a h t i e o n m . a i n s s u p p l y i s s w i t c h e d
R e d B l a c k
s L h o e w l f e r
s U h e p p l f e r
T H 1
P 1 P 2
P 6
P 4 P 3
T H - T H B + T 1 B T B 1 + T 2 - B T 2 +
B a t t e r y B o x
4 1 2 V 2 1 A h b a t t e r i e s
b T a h t t e e s r i e e i s n s i n t r s u i c d e t i o t h n e s b c a o v t t e e r r h y o b w o x t o o f i n V s I t a G l 1 l -7 1 2 2 V p 2 a 1 n e A l . h
i n s i d e B a t t e r y b o x f o r V I G 1 7 2 p a n e l
B a t t e r y i n s t a l l a t i o n
b y H o n e y w e l l
I n s t a l l a t i o n
4 1 8 8 8 8 1 _ i s s u e 3 _ 0 2 / 1 0 _ R e p l a c e m e n t P S U B a c k C o m p .
P S a p r a t r s e
x 2 1 A F u s e Q B c e r a m i c 2 0 x 5 m m
x 1 3 A 1 5 F u s e Q B c e r a m i c 2 0 x 5 m m
x 1 3 A 1 5 F u s e A S g l a s s 2 0 x 5 m m
B B r B W W R l o h l h w u e a i t i d c e e k n e t
x 2 1 0 A F u s e Q B c e r a m i c 2 0 x 5 m m
x 2 2 2 K 0 . 5 W R e s i s t o r
x 1 T h e r m i s t o r l e a d
x 4 S t a n d o f f s
x 1 - B R a i c b k b p o l n a n C e a t b o l e T e r m i n a l C a r d
x 1 T - e R r i m b b i n o a n l C C a a r b d l e t o P S U
P T C E E - T r P a S n U s f C o r h m a e s r s E i a s E r h a t r t h
P S U C h a s s i s
S p a r e s p a c k 2
x 4 1 0 A F u s e Q B c e r a m i c
x 1 T c a e b r l m e i n a a s l s C e m a r b d l t y o P S U
2 0 x 5 m m
P C B
P S U C h a s s i s
B a t t e r y c a b l e a s s e m b l y
P C E L
N E L
E N N
P C E L
E N
L
F M i l a t e i n r s
N E L
P C B P S U C h a s s i s
F M i l a t e i n r s
T E P C E L
N
N L
F M i l a t e i n r s
T H 1
P 6
P 1 P 2
B o a r d
P 4 P 3
N E L
P S U
T H - T H B + T 1 B T 1 B + T 2 - B T 2 +
x 1 C B o a n t t n e r e y c t i o n
1 1 P
3 F A S 1 2 5 Q B
D L 5 D L 4 D L 3 D L 2 D L 1
7 P
5 P
FS1
4 3 2
N O
1
S W 1 B 1 + B 1 B 2 + B 2 -
3 F A S 1 8 5 A S
T H + T H -
P 1
D A N G E R
L
c o R W v l i v e e mA e r o R p e x v N a p r o a N l I t s s o G e f s
N
P 2
x 1
T E
N
1
x 4
s B x a 1 p a t t e T d r e e y r c m o L n i i n n n k a e l c a b t s l o s o r e c s m k b l y w i t h
T E
L
P C B
x 2
S p a r e s p a c k 1
r c e e x p o e l m t a p c l r n e e a m t l e c e y l h T n a h i r e t s w o g m o a l e r a r k t u e n . d n i i s b t e s s u f ( o w p r h p e l c e r y t o e m a o m p t h e e p l i p n c c a a i n n b l e g e l , ) P n S m o U u d s e t b a n e d
V V t h i a e g r i i m l o o a n u s n p P i a S s n F e U t e l m r o r s m s a i a i n f n a s l e t a b y n l , r d o c e f m i l k o t e i n v r s w i e d t i r h i n e e g t h m o e a f p i i a n n s n s t f a e l u l / l n s e d o e d f r e o . m
I n s t r u c t i o n s
c )
b )
a )
t h n O e o d p T e e n e a t r h n e m d i n r o a e u l m t e c a o r v a r e d n . t d D h e i i n s Mn c a e e r t r d a d t h l o e c o o r v s m e e r o f t a i f t h l f e i c t o t p e v d a e n r . o v e l e r /
d O i p s c o e n n t n h e e c t o b u a t e t r t e d r y o p o r o o w f e t r h t o e b t h a e t t e p y a r n b e o l x / n a n o d d e .
i n s s u p p l y t o t h e p a n e l / n o d e .
a p I a s n o e l l a t / e t h n e o m d a e
H o w t o r e m o v e t h e e x i s t i n g P S U f r o m
I O
V 3 . 7 4 / V 4 . 0 6 o r h i g h e r
n a c T e V a h n s t i w i b o g r i e e l r k o n u p l ( s a t e o r e c e r m 3 d t m i e n 4 o r n a 0 0 l 0 e ) p t n f l p o i a o e r c w d e e e a a r . a l s f u r m a u p l p c t l o y y n p u t o n r o w t i l e ( p r V a s n S -P e u l p p S o l r y U u -R n P i t L i n )
n h L M S t h s h a P e t t o a o e C C r l R C r d t l t e e d p c b c a e a l r i a r o l n d d w s a c e : w 3 m 4 i t h 0 e V V S n 0 t 3 3 o m f 0 P . 8 . 9 t i n o S 4 0 w i U m r / / a r V f V V e u g i o 4 4 v m .1 .2 e i l r V o r s 9 2 s n g o i i o o o f p i t r r n l w a o h h n a n n i g i g u r e h h m e / l c e v n a r e r
s s i T C
b e r
n e o o r d s n e i h y l o n a b a v e s i n g
o m p a t i b i l i t y
B R I n a e s c p t a k l l w l a t a a i o c r d e n C m o m e p n a t t i P b l S e U ( V f S o -P r S U V -R i g P i L l ) o
n
b y H o n e y w e l l
g )
f )
o D n s i t h c e o n B n a e c c k t r p i l b a n b o e n a c n d a b l u e n f c r l o a mm p c o t h n e n e c a c b t o l r e . a t P 1 2
f r R i l e t m e e m r . o o v i n v g e a t h n e d n d i u s t c a a n r d d b t h r e a c m k a e i t n t h s a f i l t t e s e r c u r , e b s y t h f i e s r t
2
B a t t r e r y b o x
B a c k p l a n e B u l l e t c o n n e c t i o n
4 1 8 8 8 8 1 _ i s s u e 3 _ 0 2 / 1 0 _ R e p l a c e m e n t P S U B a c k C o m p .
P a n e l / n o d e
t T R o e i b B r b a m o c i n n k p a l c l b a a n o b l e a e r : d
0 V l e a d
BR a b i c b k p o l n a n c e a b t l o e P : S U 3 P - S o U f f c s a e p c u t i v r e e d s c b r e y w s
c B O a a l d r t d t e n i r c y o ( T m h e p a r m t i b l i e s t o r )
c B a a r t d t e r y ( T h e r m i s t o r )
t T R o e i P r b S m b U i n o n a c l c a a b l r e d : f M o r o P u n S t U i n g s t u d s
0 V l e a d T H 1
P 6
P 1
P 4
P 2
P 3
T H - T H B + T 1 B - T B 1 T + 2 B - T 2 +
O l d P S U
R e p l a c e m e n t P S U
3 F A S 1 2 5 Q B
1 1 P
T e r m i n a l c a r d
D L 2 D L 1 D L 5 D L 4 D L 3
7 P
5 P
FS1
4 N O
3 2 1
S W 1 B 1 + B 1 B 2 + B 2 T H +
3 F A S 1 8 5 A S
T H -
P 1
D A N G E R
c o R W v l i v e e mA e r o R p e x v N a p I r o a l N t s s o G e f s
L
N
P 2
T e r m i n a l c o v e ,r i f f i t t e d r e m o v e a n d d i s c a r d
l )
e )
d )
D i s c o nn e f r c t o m t h e t h m e a m i n a s i n L s i v t e e , r m N i n e a u r l t a b l l a o c n k . d a l l E a r t h
w U h n e p r u l e a g p t h p e l i m c a a b i l n e ) s w L i i e v r e s a n d N f r e o m u t r t h a l e ( P a n S d U E . a r t h
w i r e s
k )
j )
i )
h )
c R l i f U a e n i b m t n s l e o g c r i e a e v t s u w p t s t e h h m e a e . b n t T l e d h y r h e a r m t e e n i n c n d a a r l o e p u c p a t t i v l r f a r d o e c m s e t c i o r t B t h e w a e w i t p s h c k . a t n H h p l e o e a n l d l o e n r / n t h e b i o e b d P e o . S n U
s o U n c k p l e u t s g t P h 3 e a b n a d t t P e r 5 y o a n n d P S t h U e . r m i s t o r c a b l e s f r o m
t h U n e p P u l S g U t . h e 0 V ( b l a c k ) l e a d b u l l e t c o n n e c t i o n a t
o D n s i t h c o e n T n e e r m c t i i n r a b b l o c a n r c d . a b l e f r o m c o n n e c t o r a t P 1 0
s u p p l i e d
I n s t a l l a t i o n
P S U b a c k w a r d c o m p a t i b l e f o r V i g i l o n
4 1 8 8 8 8 1 _ i s s u e 3 _ 0 2 / 1 0 _ R e p l a c e m e n t P S U B a c k C o m p .
3
h )
l F e i a t d t h . e b u l l e t c o n n e c t o r o f t h e 0 V ( b l a c k ) p r i n t e r
g )
C o n t o n e c o c n t n t h e e c P t o S r U P 1 t 0 o T o e n r t h m e i n T a l e c r m a r i n d a r i l b c a b o r n d . c a b l e
d I f W d c I n a f h b e t h e a c e u l e c a o r o r t r m g t f m e m a e t e m c a m r r e o i n d i t i h e s u t i e s s e s n o s i t i n a i r c o o o r e n , t e m n e d n s e h e d e b m d s t o . n y s i . u r r e t e t h s h e i t d o e h n n V e e i i n g i e c d t n e i h l 0 a c r f o l r a n 5 g o c s 2 1 e s e y 6 r u u s c i r n t h s e s e a i s t m r a h m g f e a u v i e l v i r y s a n t a w g a 3 a 0 l s 4 s 5 o 4 2 1 1 b 5 6 e
f )
t o C o c o n n n e n e c t c h t t o r e P P 1 S 2 U o t n o t h B e a c B k a p l c k a n p e l r a n i e b . b o n c a b l e
e )
d )
c )
t c a t / F t e t h t e C h W a h S n e n n o o o r r r e h d n d o m e m r e c n e n P t P i n e d e b o P i r n n e c 2 p e e o c u r 2 a S a t U l c , b o c a e t t l t o o t i o t p o h a b t b t h t n n m t e h n n e l o o l e i o t n v s f F e n e s i r c l c y r t i e p c L t k l e n e c e o t s p . a k . i e t t o r v r c c l d A e t r t h b n r a h y e e s c l a e n a o e b b e o e o w t o a l f n e d T r c e a e b s m r d t e d r x a . e m c o N e r t n n e t m .T c n i a t t l n n e t o r e e c n r i h b a e u P n r l e a y l c t a l S t r a n e u t l h c t a U e c n h l c m e d a a d t b p o b b o a e e t r a l y d l e k t o a r e n s . n E t e n t h i t e a e P s g e e i t n d t a t r m h h l S r i m t / t h e r o h a e n U e i n w e t n c t i c h h r i n x a o t i s n h y l e e e t l d g e s e a p m f r t s t o a P f n r h r s a o a 1 o s n e P e i l m i n m . 1 l s N s b u P t t W c b h o ) ) p a s C e h o a t i b n B t e n u W s s R r e g i n e e e r t e i e s e r r s n i 4 i u p d r a - i e p p s s r t t i a e - n a l p e n u n a l a u t a n p o l s t a i c n h e e d a f c s n l e x d o k e e d t w d . i n d s b h i a e g o i - u a f s n e t h t i t r ur , b a t t i c b e f e o n d r a t f t b a s h t a r g b t b p e y b l a n b h . u r e t t e c t o a t y l e e e d c s t i r r s t o l c p y r e m n t o i r s t o c r a u y i e n c r e s a a e i t n u o t t r l s c o i w s l t y t t i t a a o o n o l m s p o r n n r r d b P d w i i s a a o u a i a n c u C n w r k s i s g g d k r e i x e n e . r d B i I , b i g n e l f w o n t s a i h g n . t c c s u i e t a a t t a t p t h e h a n o l b t p r l d y c t l l l r e h e o e d i e e t e i e e s h s n n a d c c e c n o n s o n o c i e u l t n t n h o l n o h c p e h s n t e t s p h a i e l o l u l u e t m e r r i c n e r r e h e i d i t g s e a s , h i t o l t l r
b )
p t f i b s u A l t a i e a p l c t e d b k p g n . e o e l i a n x d n s d u .f I o h n o r t e t h o o i e t h k r b t u e t n a h s t t t o e p e b e r r e y t h c w p l i a n a o c d b f e i l t h e x i m n e a g e s n P s p t S e i P n m U S b s U c i l n h y a t h s e s i s i s a )
W i r b b C i n o a a g x r t e . t e f t r u h y l l e c y i r d b c i u s i c a t t t w o n e i r n r i y n e g c b i t a o n n x s i d d e d i t h s e c a r e d x i a s l t i n l i n g t b e a r n t t e a l r y
a )
P a n e l / n o d e
b E o n a s r u d r i e s t h w e i r f e i l d t c e r o b r r o e a c r t l d y .
Red Black Brown Blue
B 2 + B 2 -
White White
T H + T H -
u a s l l i n o w g e 1 d . b 5 m e m t w A m / e 2 e . n a x 5 m t m h i m e u m M c o I n c C r a C t b o l l e c p a b a d i n s l e t . e l a n a c n d e b o a f 1 t t e 0 r m y b / 1 o 5 x m w i h s e n
B 1 + B 1 -
e m F m T x t i u h t e o u t h s e r n n e t b w a t i r n t e i i l e n g w r g m d i o i n r b n i i n e e n t a g o w l c t . t h b e e l o r e o r b c e n a k c t t t t l h e y , e r y o t b p a b o n o t s e x h e r e / t v l n o t e h t o a e d e l e l r o m a w m r i n i s n c o t o a d b n r l m a n e c a a t t e c r r r t k i d y o i f n n o g b r o s o . x f
P 1
H o w t o f i t t h e r e p l a c e m e n t P S U i n t o t h e
e C d g o e n f i o g f u r t h e e t P h S e U d u f a S o w r -l i i B n t -l c S i h n e f o i r t t e E s d N w i t o n p c h a r l e n o t e r c o l a . f i t e t P d S o U n o t n h l e y t o p
S e t t i n g s f o r E N a n d B S p a n e l
c F t h F a s u c o p o e o r p n a n r r d n e t . p o p l l p a b i e o T e c / n e d t r n c e t t o o m l o i i a / n r m n d P a t n c o 1 e b l l o c e r a c 1 a d r o a e d e b n n m e n g l e n o t r o e e d e v y t c f n i e o o t t o t f s r r t h x t y b i e P e s a p o 1 c t t i n t 1 a g b f e ) r . b w t o b a h A y l c i n e e f r i t e a c t l e t P e d S t a a b h r r a U b b y l e s e s o s l c e s e T a f a h C r s b h d r e m o o a w s o r m i l n l m b n s t e l i c . s y s a i n o m t e t a n h i u d l s e t o t o n
P 1 1
P 3
p a n e l / n o d e
P 2
b e
E x t e r n a l w i r i n g
O N
O F F
P S U f o r E N P a n e l ( f a c t o r y s e t t i n g )
S w i t c h e s 2 , 3 a n d 4 a r e n o t u s e d .
1
O F F
O N
1
P S U f o r B S 5 8 3 9 P a n e l
4 3 3 F A S 1 2 5 Q B
1 1 P
5 D L 4 D L 3 D L 2 D L 1 D L
7 P
5 P
N O
FS1
4 N O
3 2 1
S W 1 B 1 + B 1 B 2 + B 2 T H + T H -
3 F A S 1 8 5 A S P 1
D A N G E R
c o R W v e l A i v e e r m R o p e x v N a p r o a N l I t s s o G e f s
L
N
P 2
2 1
P S U b a c k w a r d c o m p a t i b l e f o r V i g i l o n
I n s t a l l a t i o n
4
b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 8 8 1 _ i s s u e 3 _ 0 2 / 1 0 _ R e p l a c e m e n t P S U B a c k C o m p .
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
a v p A c a i o r t c o a d t h u r e d s c e a u t i a n n t c a n d e b l d o f w e b t r a h i e t h c t t e i n y e r r a c i u e l t i s i s n o g e n s f a c h u l e o l o n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i a e n s g i p c i o k s a s l a e g t i d i n o o g n f , .
B 1 + B 1 B 2 + B 2 T H + T H -
T h e r m i s t o r
d ) D D d p A W i o r t o o s h E n n p d t e E o o o u c t t s E t e b d e d n D a u s i o n d r n p f d o i r . o v f e s i b e a a t h c t e t o a t i i v f s e r r w u e i u e : i i s s t t e h a s f b h u y l o e o l u r u l i f r e d n c l e o y b , t h r e e m c l i n p a g l h c a c k o e a u n g s r e t i n h e o . g , l d w a s t e .
P 1
P 2
P 3
F i l t e r c a r d
b e t h o n e a d r s r m d i . t o s t t h o r e a t e s s r m e m i b n a y l l
R e m o v e t h e t e r m i n a s l b T l H o c + a n a d k f n r d t h o m T e H n t h - c e o o n l n n e a t h e d e c t e t f h d i l e t e r w i r e
d p t u e a r o s s c m e c t e d r i e w i c b t h e a l t d t h e r T h e e h h e e c p e l r u o b e e r . a r s d e s a i t e n b e d t l t r e y s t h t a a e n s c o r m d d n e n i a r s s e d t c o s c r r . b i t i W e o n h d b m e i o r n a e a y t t r h d b h s i i e s l f i e i s m t a t e n f l u d o e s a t t a t s n b d e
c )
b )
n C 2 2 2 A < E m c d C i o o 7 7 s i a l 5 n o c l 7 r s d s .1 3 . 5 . o b s r n u c r e e i u o V V V t t i i t s r o ( t n y a t @ @ @ h ( e o n s n h e e t r i e u n ) d e h g t . a a c 2 2 1 b a i 5 a g t n . . 0 5 i b t a l n t o d s B t n D D D e C t h m n t o e t e r e e e e y a t r 1 r h a g g g f - c a n y e n C C C o l B h i d n a o d a T a n r d r s e u o t 1 g c t < e s v u e u P o o 5 r p n S r e l ) A p n t d t a U . l r o d D y e g o o t e C t o c r o t i e s s o o r c h b h n t n s s o a e o , s t u t h o t c f l e f e t d r k b u h b y o f a c b e h a e A r t t e a t p D t a f s r e a a b C u y r n o y l u s i t b e l t : o / x .
m t o C a t o i h n n e n s e p m c o a t w i h n t e s r t e m t o e a r m t i n h i s e n s p a l u a b n l p p e o l l c k y / n a ,f i o n t d d t h e s e . w m i a t c h i n O s f N u s t h e e i n
a A ) t f
e r i N C a s o o l s l t n w e n t h i t e t e h c h e c i t n e p t h s d a e t O n b a l l N e a a t . l i w t o t e n i l r a l y p n o s w u d e p w r p l i r u y i p o t n a t g i f h s t e e r p c o m m a a n p i l n e l e s / t e s n u o : p d p e l . y
L e a d e d t h e r m i s t o r
P 1
B 1 + B 1 -
B
i T s h s w e p i t a c h n e e d l o w l n i l . o n l y p o w e r u p a f t e r t h e m a i n s s u p p l y
I n -l i n e f u s e r a t e d 1 0 A Q B c e r a m i c 2 0 m m x 5 m m
A
s h L e o w l f e r
P a n e l / n o d e
P 2
B o t t o m c a b l e e n t r y
P o w e r u p
P 3
B 2 + B 2 T H + T H -
P a n e T l e / r n m o i n d al e c a r d
A
B
T H 1 P 1 P 2
I n s t a l l a t i o n
F i l t e r c a r d
P 1 2 B1+
Battery 1 B1-
B2+
Battery 2 B2-
Thermistor TH+ TH-
s h U e p p l f e r
P 6
P 4 P 3
T o p c a b l e e n t r y
T H - T H B + T 1 B T B 1 + T 2 B - T 2 +
B a t t e r y B o x
U p t o 8 1 2 V 2 1 A h b a t t e r i e s
P S U b a c k w a r d c o m p a t i b l e f o r V i g i l o n
4 1 8 8 9 1 9 . 0 1 _ 0 9 / 0 7 _ R e p l a c e m e n t P S U f o r 3 4 0 8
h .
c b f O r r C b i c a a o o p b c m O m b e N l k e p n N o s p c n a t o . a l n 3 h r e t n n o c a m e e n b d . c t l e o n D t e e s t o r i o r r s m f c P i r o f a G n o r 1 a m a t h d n e t d C t i t h h o o e n n e d o i n s t h c c w t o c t o r n o e a r n n o d r n l i a e e b u b n c n o c o d t t t i r n t s h : e
g .
c t h t h U o e n m e s e c p a s x r a s i e r e s w t m m t i n e b g t h n y l 3 e t . f 4 f i v r 0 e o m 8 s P c t h S r e U e w P a s S n t h U d a r t e m s o e v c e u r e
f o r B a F t S t 1 1
B 1 B + 1 - B 2 B + 2 -
1
f F o r S B 3 a t t 2
L E N
e .
t h D i e s e c x o i n s n t i n e g c t 3 t h 4 e 0 p 8 r P i n S t U e r . 0 V l e a d f r o m
P R S e U p l f a o c r e 3 m 4 0 e n 8 t
d .
c f r D o o i n m s c n o e t h n c e n t o e e r s x c i t P s t h 5 t i n e a g t w n d 3 o P 4 r i 6 0 . 8 b b P o S n U c a b l e s
r 2 i 6 b b -w o a n y
3 F A S 1 2 5 Q B
1 1 P
0 V l e a d
D L D L 3 D L 2 D L 1 5 D L 4
B 1 + B 1 B 2 + B 2 -
7P
T H + T H -
l T e h a e d r m i s t o r
N O
3 F A S 1 8 5 A S
D A N G E R
L
c o R W v l i v e e A e r m R o p e x v N a p r o a N l I t s s o G e f s
B
1 2 3 4
S W 1
P 1
N
P 2
B
c c o r o o w D m m u t i i p p e r s e a a d s c r t r t o t n m m h f r r n e o e o N m e n n u o c t g t t h t e t h t t h e e h . a a e h m L n o b d a i l a v e i i n e n f t e r t s N t o o r e f m y t i u h l l e t t t e e r h a r a d b e l a a P s t a t n . d e S r r U e y E
a r t h
L o c a t i n g h o l e s
L o c a t i n g p i n s
b .
P c d O C o o o p B n n r e n . e a t n h c d t o d e r i P f r s c S o U m o n c n s e o o c m c t p k a e t h r t e b t m e o a n t n t e t t r h y e o P u S t e U r B A - f f i x x i i n n i g g s p c o r n i e w t s s
M a i n s F i l t e r
( R E x e s m i i o t v n e g e a a n r d t h d l i e s a c d a r d )
r 2 i 0 b b -w o a n y
F S 1 F S 3
c .
r a D e n s i q d u c d o i r i n e s d c n . a e r c d t i t h t a e s i f l i t t i e s r n e o a r l t o n h g e l e a r d
5 P
B
P 1
f .
a .
u 3 F n 4 i r i 0 s t . 8 t p c o o w n t r e r o l d p o a w n e n l m a a t i t h n e s f s u u s p e p d l s y p t u o r t h e
P S U C o m p a r t m e n t
A
T o r e m o v e t h e e x i s t i n g 3 4 0 8 P S U
c m o u m s m t e b n e c c i n o T h g m e P p l m S e U t e a n l i r y s e i s p s l o u a l p c a e t p m e y l e d t n b o t e t f h w o o e r e r k p a . n e l
C o m p a B r a t m t e t e n r t y
C o m p a r t m P e S n t U
C o C m o p n a t r r o t m l u e n n i t t
l e a 0 d V P 5
A
3
3
1
1
2
2
L
P 6
A
A
i n ( V T h t e h S e -P R 3 S e 4 U p 0 - a l 8 3 c 4 e C 0 o 8 m n ) e t n i t r s o l d P p e S a s U n i e g n f l . e o r d 3 f 4 o r 0 8 i n s t a l l a t i o n
E N
3 4 0 8 C o n t r o l p a n e l
E x i s t i n g 3 4 0 8 P S U
( R I n V e s t S p al -P l al t i o S a c U e n - m 3 4 e 0 n 8 t ) P S U f o r 3 4 0 8
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 9 1 9 . 0 1 _ 0 9 / 0 7 _ R e p l a c e m e n t P S U f o r 3 4 0 8
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
F a x ( U W K ) : e + b s i 4 t 4 e : ( w 0 w ) 1 w 1 6 g . 2 e 4 n 6 t . 2 c 3 o . 0 u 0 k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
g .
P r S e U p l a f c o r e 3 m 4 0 e n 8 t
L D 5
w P s i A i S g f t l h U i a v t h i e s n h e s i n M c o w g h i C m e n C m n d i c / u t n h L i e a t C c i o C a n t i n g D L D L 2 D L 1 D L 3 5 D L 4
5 P
D D d p A W i o r t o o s t h E n n p d u e E o o o c e E t t s e t b d d a n u s i n d D o d r n p f o i r . o f e b s v i a t e a h c e t o a t t i e f s r i r v w u e i u e : i i s s t h t a s e f y b l h u o e l l u r o u i f r e d l e n c , o y b t h r e e m c l i n p a g l a h c c o e k a u n s t r g i e e n h g o . , l d w a s t e .
c o n t h C t r e o o n n l n p c e a o c n n t e T h n h l e u e t n b c e t a t b i l t t t h a t h e e t r t e y m e m s r u a y a i i n p p n s l u s y s p s W u s p p u l p L I p y l L y p t N o s i l y t O . h c T o e p p n n o a e w e n c t r e e u l d p a . t n h d e
a v p A c a i o r t c o a d t h r s u e d c e a u t i a n n t c a n d e b l d o f w e b t r i a h t h e e c t t e n y r i r a c i u e l t i i n s s o e g s f n a c h u l o l o e n u l i f r t l e r d l e , o t c a b h e a n e l d d p l i s i a e g n p c i o k s a l s a e g t i d i n o o g n f , .
B a t t e r y C o m p a r t m e n t
f .
b C 2 t R h o a O 0 e n c N -w t o u k h t p N a c e o l 3 y n e a t t h t o n a r o r e n b i l p e t s d b u s i w o t o n d c h n t i e o k e r i c o b e o f b t 2 c a P 6 b m t h l p e o G -w e n 4 a t a P c r S . y o t a m c t e e U b l o r n c e n m t s . o n i m n t C e a p h c t r o i o n a t o o r u n t r n e m g h t o c a c t e n t r h t d h t e s e a h n o c d o l k i e n e t t o
+
-
-
+
B a t t 2
e .
U C n o i n t n c e o c m t p t h a e r t m p e r i n n t t e r 0 t o V l t h e e a d r f e r p o l m a c t e h m e e C n t o P n r S t U o l .
+
-
B a t t 1
+
c o t R n t h c o n o e m o u e c e t n e p t t s e m a e h d u r t p t r C h e m e c o e e r t t a e h r h c r e t n k e e u t c L t r r h e m t i l v e i i y . e t n a s , e s n t N r o i d e m e d r u i l l n t t h e e r a a a l e a v d l a m c e n a o t i d r m f k i l n E i p o n a g a a t o r s r t t t i t h m n h o w n e g e n t i b t o r t e h . m a s e t t a f o e i l r t r n y e e i t r o
P S U C o m p a r t m e n t
c .
f r C . om on n t h e e c t r t e h p e l L a c i v e e m e ,N n t e P u S t r U a l t o a n t h d e E m a r a t h i n s f i l w i t r e e r s
r
a e l E n x d a i d s d ( t i R i n s g c e a m e r o a d r v t ) e h
M a i n s F i l t e r
P 1 T h e r m i l e s a t d o r
d .
P R S e U p l a c e m e n t
P 1 1
0 P V r l i n e a t d e r
P 5
b .
f c c c P i x h o o o i m m s n a i g s p t s p i a o s s i r a r n c . t t r m m t e S h w e e e e n n s c r t t u e ' r a s B e p u l ' i l . t g c a h n h e w t c e h m a t a e s i s h t n t e t h t h e m e P b h p S l o i U y l n i u e n s s s ' i o A t n g o n ' t h t n e h P i e S t P h S f U e o u P U r S U
P S U f o r E N P a n e l
a S r w e i n t o c h t e u s s 1 e , d 2 . a n d 3
1
S W 1 o n 3 4 0 8 P S U
1
( N P o S U r m s a e l t s t i n e g t t i f n o g r f B o r S 3 5 4 8 3 0 9 8 P p a a n n e e l l )
4 3 N O
2 1
B a c k p l a n e
4 3 N O
2 1
P G 4
I n s t a l l a t i o n
e n t
P 7
S W 1
T o c P E f i o S n t n U s t f h i f u g r e e u o r r r e 3 t h e d 4 e p f 0 s o 8 w a l r B ( i c t r e S e c 5 p h m 8 a l e 3 c S 9 e W n 1 t p m o a e n P n n S e t t h U l . P e S r o f U e ) p r l 3 a c 4 i e 0 s m 8 a .
C O N N 3
C T a e r r m d i n a t i o n
C o n t r o l U n i t C o m p a r t m e n t
3 4 0 8 C o n t r o l p a n e l
R e p l a c e m e n t P S U f o r 3 4 0 8
4 1 8 8 9 6 7 _ i s s u e 3 _ 0 8 / 0 9 _ R e p l a c e m e n t d o o r k i t
S h i f t
A
Q
1 !
Z
S
W
2
X
D
E
3 #
C
F
R
4 $
V
G
T
5 %
B
H
N
J
M
K L
. ,
Y
"
6 ^
U
7 &
I
8 *
O
9 (
P
0
; ; :
-
m a R n e e d m m o b s t v i e r a c n k b e t h a . e c l k a n b i e g l , t o a l i g n
1
M e n u O n / O f f
S o u n d A l a r m s
D i s a b l e m e n t
T e s t
D e l a y
S y s t e m F a u l t
P o w e r F a u l t
F a u l t
1 8 2 1 9 3
F 1 S i l e n c e A l a r m s
2 0 4 2 5 1
F 2
P r e v i o u s
F 3
N e x t
2 6 2 2 3 7 2 8 4
R e s e t
2 5 9 2 1 6 0 2 1 7 1
)
F 4
E n t e r
D e l e t e
I n s e r t
U 4
U 3
U 2
U 1
V e r i f y
2 1 8 2
1 5 : 4 5
+
S p a c e
Z o n e s 1 1 7
C a n c e l B u z z e r
2 1 9 3 3 1 0 4
P o w e r
C B 2 5 4
C B 2 5 3
S o u n d e r
2
V e r i f y
F i r e
3 1 0 5 3 1 2 6
m a R n e e d m m o b s t v i e r c a n k b e t h . e a c l k a n b i e g l , t o a l i g n
N T h O e T Z a o p n p e l i i c n a d b i l c e a f t o o r s r B S a r p e a h i n d e d l e s n a u n n d t T i l l e t i r m b u i t n a a r l e ( N e t w o r k ) N o d e s .
t h o w i e n t h h p o a w t h n e t e l o M / f a n i i R n e o t d t f h e e e C o r . c n t o a t r r t d o h l e i n C i a t n o r s d t r h f t e o u r c b p t i a r o c o n k s p c l e d s a u n u p r p e e o s l i e f d
s C a l R B u b e S p o n e q p t l u T r s l i o i e r e l e d C s r m , a t i f i a n h n t r d t d e e d p e r a l i N p n a , r l t t b a o o c d n e t h u f e m e e m o r e ( e N b b n e a e i t c r t i i k V s w n t p G n o f i e l I t a t r r n - e e M d d k C o N t i n o o o s C r t i h t d d B e e e S o ) - b b t e h N a e O c m n D k o o - b d d U o i f e P x i . e b G A d a , s l w c n o k i b o h a t o t M x . a i n
1 x M a i n C o n t r o l C a r d
1 x C h i p 2 2 1 1 -1 4 4
f R E i C m e t N t e a r o d q d d u T i f i i i e r n p c e a s r t o a m r t i t o t t h n n h i n e e u s r a b m f l e i a b t t N c e e p l k d a o p r c d o l V a I n e m e n G o e ( e -M t N n e i h t n C t s C e i w n t i d n e -E b a e o r t h N c k r k e -N b d o N o o o n x r o O . d D a e d - A e U l s s ) b P s o u a G p c a p k , b n M e l i o o a d x t i . s n , u C w p o t i p n h l o i t r e u d o , l t a n y
i n 1 n x e E r d N o R o e r p l a c e m e n t
1 x B l a n k l a b e l
L 1 E x D C l o a b m e m l i s s i o n / W a r n i n g
i e r s a l R B s o b e S f c e q i p l t k t a l u V e e s i i d c t e r g e e d i n w d a s i l o t t c o i h n h n t e d t i h h p r p e t h o e a b e n , p l n a c t b a c h h e c e k i e f e l p p M o m l 2 e r a n 2 a i e n e 1 i n t t i i l 1 C s n o n c 1 o f i e a 4 n t t t e r e 4 t r d d d o l t o i n i C o o r s n a t h o t i t d r e d h e e s b b t u a e h k p m e t i p c k o p , b l i b d a e e o i n f d x f e o . i l e r m A e d b u s l w a t s o h c e t t i k t h h b c b o a e e x r . d
W a r n i n g
C o m m i s s i o n
t h S e t i c E k N o d n o a l o b r e t l o s a t B o S c o d n o v o e r r t
T h e V S -I D O O R k i t c o n s i s t s o f :
b C m R E a a o e N c r d q k d u V p a i f i i i r g l s c a e n s a s i t l e u o i t o h n l p n e o s c p l r p f a e i t e i p a t e d t n e l e d , d a w c l i n t t e i s h o m i o t d h e e u e n t t t h a b i n e n a n p y c k e a m b r n o o d e d x o . o l i f b c i A r a a l a c t s o s k o b i h s o ,n t u x f e p . t i M p l t i e a e d i n d , i n C w t o o i n t h t h t r o e o u l t a n y
o h V ( V T n a g h S e v i t i h i l -I r n o e g n D e O p b t l h p a e a O a c n R c k n e b i e m l ) o n s i e x e a s n . r n a t d d s i o p n o N a n r e r e h t w e r i n o p d a o g r r o e k t r f k p n o i i t r n o s d t h e l s e o c o l a d t e e r d
r o e l m d o s t v y e l d e f r d o W o m o h ,r e t h e n n e s f i b u t a r t i n c e g k t b h t o e h x t e . w r e o p m a l e c t a e l m D e z n u t s d P o a o n r e t x o r a e c p e a n p e t a l h c a l v e a i n r g e a n
( I n V R s e S t -I p a l l D l a O a t i O c o n R e ) m
f o r O l d e r V i g i l o n P a n e l s a n d N o d e s
e n t i n n e r d o o r k i t
b y H o n e y w e l l
2 b y H o n e y w e l l
T e l e p h o n e : + 4 4 ( 0 ) 1 1 6 2 4 6 2 0 0 0
4 1 8 8 9 6 7 _ i s s u e 3 _ 0 8 / 0 9 _ R e p l a c e m e n t d o o r k i t
F a x ( U K ) : + 4 4 ( 0 ) 1 1 6 2 4 6 2 3 0 0
H a m i l t o n I n d u s t r i a l P a r k , W a t e r s i d e R o a d , L e i c e s t e r L E 5 1 T N , U K
W e b s i t e : w w w . g e n t . c o . u k
o G b e l i n g a t b t i y o H n o t n o e n y o w t i f e l l y r a e n s y e p r v e e r s s o t h n e o r i f g s h u t c h t o r r e e v i v s i i s o e n s t h i o s f p c h u a b n l i g c e a t i s . o n f r o m t i m e t o t i m e a n d m a k e c h a n g e s t o t h e c o n t e n t h e r e o f w i t h o u t
w R a e s t h a i e n r i n g
b .
D D d p A W i o r t o o s t h E n n p d u e E o o o s c t t e t e E b d d a n u s i n d D o d r n p f o i r . o f e b s v i a t e a h c t e o a t t i i f s e r v r w u e i u e : i t i s s t e h a s u y b h f l o o e l u r u l i f r e d l e n c , o y b t h r e e m c l i n p a g l a h c c k o e a u n s t r g i e e n h . g o , l d w a s t e .
a v p A c a i o r t c h o a d t u r s d u c e a i t e n n t a d c a n e b d o l w e b f r a t i e h t h c t t e i n y e r r a c i u l e s t i i n s e o n g s f a c h u l o l o e n u l i f r t l e r d l e , o t c a b h a n e e l d d p l i e n s a g i p c i o k s a l s a e g t i d i n o g o n f , .
M F i a t i n t h C e r o e n p t r a l o l c C e a m r e d . n t c h i p 2 2 1 1 -1 4 4 i n t o t h e
D z u s P a n e x r e c e p t a c l e
t h w U s e a i n f s h g a s e a r t e o s n n u e e i r t a f r q u b o l e m a r s t e t c h r r e t e w b u a r n d c a r i k n v b t e r o c i x l t . o u c r k n w t h i e s e r a e n t a d i n p i n u g s h o u t a .
t l C R N h o e o e o a r m d c k i e n d o g l o o v t n h e e n a c e t a t h t o c t h e t r d e e o e i r o s n o c a o n c t t m t k a t t h e o i h e e p t n m e b o d o n o e d i c f t n h t t h o t i e e m s l f p i t o c . d h n h e a i o n t h p f d e b t e h s M f e d i o r c e a n e a , i r r w d h C e m w e o n o i n t t v r h o a l l .
d e r r T o m e h c e o e r o . v p o l e t a d d c s l t a e s s y l e f t i p h t t e a y e d n e a t l r o d e t h n e o o o t b r h r a a e q c v k e u b i r o t e x w d , o b t h D y e z s t h u s e e P r m a e p u s n l t e a x c b e e c m l i e p -i n n t
b t h T a e h c e k M r p a e l i p a n n l e C a c o o e f n m a t r e n B o l l t S e c r V C h i i a p g i r l d o n b p e 2 2 a o f n r 1 e e 1 l i -1 4 o t 4 n s l i m y i . n s u s t a t l l e b d e f i i n t t t o e d t h t e o
H o w t o r e p l a c e t h e c h i p o n M C C
T o r e m o v e t h e D z u s P a n e x r e c e p t a c l e
p t p h d o e o o w o w b r e a e a e r r n d u t t d p e r d A s y c o h s a r w l w o u d u p i n a y l p n b d l e s b y t h o f e e b e n r s d e e f p u o o a r n r n e r e e e m e l o t h i h / n t n v e o a a e p m d l r e o a e n . v a i e n F r e s f i t i l r r i s s s t s e u t i n o p p g c o r p o o m d l w f p e y e i r l . .T r n n e t h d e e l e o w r y n b .
L s R E t i e D c k m , t a h o v s e e s a l t h h b o e e w l b n t a . o c c k o i n v e g o r f t h f e t h S e o B u a n l d n e k r l t e a x b t e a l n d a n d
a .
a a l C R n o e d b e m m l m o L t E o v i e D s s c s t h , o i e v o a e s r n b / s t W a h h c k o e a i w D r n n g n s i i . a n o b g f l a l f e h m b t e e e n l t / T e a s n t / D d e s i l t c a y k t t h e e x t
u s e a n t i - s t a W t h i e c w n o h r k a n p d r l i o n c g e t d h u e r c e s a . d r a n d c h i p a l w a y s
V L t T h i E o g t e D h i l s e l o a n o r b e e p n p a t l s l n h a e e c l e / n i n m a o n e n d e n d e r t . d d o o s o o u r r p a t r o p l e i e c e d n o s i r n r u e r t h c e t e l t y h k l e t i a b p m e a u n s l l e e t d / l b n e f o o r d f i a e t t B e S d
H o w t o f i t l a b e l s t o c o n v e r t t o a B S D o o r
I n s t a l l a t i o n
R e p l a c e m e n t i n n e r d o o r k i t
Vigilon 4/6 loops & Compact (VA) panels & network nodes
To assemble the Parallel bracket
Beam sensor (Legacy)
Steps to . Fixing nuts
Fixed Plate
Angle bracket with base
Parallel bracket with base IP66 bracket with base
Spring washer Junction box
Base Adjustable Plate
Fixed Plate
Adjustable Plate
Adjustable Plate
Fixing nuts Beam Rx Beam Tx
Ensure nut is securely fitted to the plate Ensure plate is flush against the washer
Beam Sensor pair
To commission the beam sensor pair check the following: The beam transmitter and receiver heads are installed on the same loop circuit.
It is assumed that each beam sensor head is mounted on an angle bracket. Also the procedures for the IP rated beam and for beam sensor pairs mounted on parallel brackets are similar.
Ideally two people in communication with each other will help the setting up of the
Identification
beam sensor pair. While one person aligns the beam sensor head, another person operates the controls and reads measurements given at the control panel. The following procedures use the terms head, device and outstation interchangeably.
The beam sensor heads have a black plastic circular label surrounding the lens for
identification. The 2-way base has a black plastic cover fitted over the electronics.
Before aligning the sensor heads check to ensure all bracket and base fixing screws are securely fitted. After alignment ensure the pivot pins and adjusters are secure.
) y c a g e L ( r o s n e s m a e B
Commissioning instructions
Initial alignment
Gasket
cover plate
Using the adjuster on the bracket, roughly align one head to face the other head. To do this:
a.
Bracket fixing screws
Pivot for X adjuster
Pivot for Y adjuster
• slacken the locknuts to unscrew the Y- adjusters Beam sensor head
• to make a large adjustment remove the centre pin of the Y pivot • align the head in the Y-axis to face the opposite head
Movement
• secure the centre pin into the appropriate Y-pivot to enable adjustment
Galvanised Steel Junction box
• turn the adjusters to meet the centre pin and lock the axis adjusted using the lock
x
nuts.
y
• repeat procedure for the X-adjusters and then repeat the whole procedure for the
Angle bracket
opposite head.
Selecting gain
Centre pin for Y adjustment
Select a gain from the table for the required path. Set the gain of the receiver head, to do this press Menu On/Off button and select [Test/Eng] -> [Loop] Lock nut for the Y adjuster -> -> [Gain] -> [Beam] and enter a gain value followed by receiver [Device] and [Loop] numbers and then select [Enter]. Coarse adjustment
b.
Gain
) y c a g e L ( r o s n e s m a e B
6-9 29-33 56-60
Distance
c.
2m 10m 100m
On changing the gain of the beam receiver, do not:
or reset the Master Control Board (local controller)
or reallocate or reset the loop having beam sensors until gain changed acknowledge followed by the gain number is displayed. Otherwise a ‘Memory corrupt’ number will appear on the display.
To course align the beam sensor heads activate the alignment option at the panel. Press the Menu On/Off button and select [Test/Eng] -> [Loop], momentarily press and select [Align] type in the receiver address, select [Device] and type in the transmitter address, select [Loop] and enter loop address and then select [Enter]. Note the LEDs on the heads will flash once every 2 seconds:
• a 1.9 seconds LED flash will be seen for a large signal • a 100mS LED flash will be seen for a small signal.
power-down the control panel
Adjuster for Y direction
d.
Adjust the transmitter head in X and Y directions to obtain a long LED flash signal, allow at least 3 seconds for the flash rate to change. Then lock the adjusters using the lock nuts.
e.
Repeat d) for the receiver head, to obtain a maximum flash length.
Vigilon 4/6 loops & Compact (VA) panels & network nodes
Time averages f.
Check the time average of the receiver head is between 140-170. Press the
Fine adjustment g.
Menu On/Off button and -> [Usercode] -> [Time Avg] and type in the 2 for channel 2 and select [Device] and type in the receiver device address, select [Loop] and type in the loop number on which the receiver resides, select [Enter] and read the time averages on channel 2 of the receiver head, this should be between 140-170 bits . After each adjustment wait for
• stop on reaching a time average reading 5 bits below the peak value • while counting the number of turns, adjust in the opposite direction to reach 5 bits below the peak value
• finally turn the adjuster half the number of counted turns, towards the peak and
5 seconds for a change in the reading.
then stop
• secure the axis adjusted using the lock nuts
For time average reading above 200 bits carry out an autogain to minimise the need to fine adjust. To enter auto gain press Menu On/Off button and select [Test/Eng] -> h. [Usercode] -> [Loop] -> and momentarily press to select [AutoGain] and type in the i. receiver device number, select [Loop] and enter the loop on which the receiver reside and select [Enter].
Unlock the lock nuts to allow Y axis adjustment and using the adjusters move the transmitter head in Y direction, then:
Never [Autogain] a range of devices.
Repeat g) for adjustment in the X direction. Repeat g) and h) at the receiver head.
j.
Carry out a final [Autogain]. Then recheck the time average reading is within 140 to 170 band.
k.
Back up the appropriate loop processor card (LPC) (which holds the gain data) to the Non Volatile Memory using [Back Up] command in the [Set Up] menu. On completion you must write protect the Non Volatile Memory.
) y c a g e L ( r o s n e s m a e B